Date post: | 22-Mar-2017 |
Category: |
Documents |
Upload: | faiz-ahmed |
View: | 106 times |
Download: | 0 times |
Welcome
HEALTH, SAFETY & ENVIRONMENTAL
INDUCTION(738-C02)
Client : ROYAL COMMISSION Principle Contractor : KIFAH CONTRACTING COMPANYSite Reference : 738-C02Location : JUBAIL INDUSTRIAL CITYProject Manager : Mr. AMR Mahmoud NaguibEH&S Manager : Mr. Shamim Ahmad Siddique
SITE INFORMATION
Organization objectiveThe main objective of our department is to have ZERO accident at site. Create Safe working Environment. Implement safety culture. To complete the project with ZERO accident.
Policy
About Us……
HSE Manager Shamim Ahmad Siddique
HSE Engineer Faiz Ahmed
Safety OfficerMd Irshad Ali
Shaikh Aashiq Ali
Shaik Mohammad
Masood ShaikPrajith K. R.Manu M. P.
Tank Area Telecommunication Building
PROJECT?
WHY ACCIDENT ? Safety Procedure not followed. Proper PPEs missing. Shortcuts at work. SLIP & Trip due to obstruction & wet surface.
Incompetency.
Basic Reason……..
Color CodeJANUARY - MARCHv
APRIL - JUNE
JULY - SEPTEMBER
OCTOBER - DECEMBER
Signage
Warning Sign giving warning of a hazard or danger.
Prohibited A sign prohibiting behavior likely to increase or cause danger.
Mandatory A sign prescribing specific behavior to followed.
Emergency Sign giving information on emergency exits, first aid, or rescue facilities
Red-man & Green-man
Persons operating within 02 - 10 meters
Persons operating beyond 10 meters
Dead man - Person operating within 0-2 meters
Personal Protective Equipment (PPEs)
Mandatory PPEs
PPEs Related To Work
Hot Work
Working at Height
Unsafe Act
Unsafe Condition
Electrical SafetyOnly qualified electricians shall perform
the job. Never use defective electrical
equipment's, defective extension cords or shop made equipment's.
All electrical conductors shall be considered energized unless notified.
Use 110 V for all portable electrical tools.
No work on exposed live conductors. Metal ladders shall not be used.
DIFFERENCES IN TOOLS
110 VOLT 220 VOLT
Do Not Use…….
Bad Practice
XX
ScaffoldAll Scaffolding must be inspected by Trained Competent
Scaffolding Inspector before they can be used.
Complete guardrails and other fall protection arrangements shall be made for platforms above 1.8 m.
It must contain Guard-rail, Mid-rail & Toe-board.
Use ladder for access & egress while using scaffold.
Always check for SCAF-TAG before using.
Use Body Harness above 1.8 m.
XAccepted Not Accepted
Safe for UseBody Harness Required Do Not Use
Scaf-Tag
Welfare Facilities
Drinking Water.Rest Area.
Smoking Area.Toilet & Ablution.
Water Station
Cool & Sweet drinking water provided at site.
Rest Area
Toilet & Ablution.
Smoking Area
Recycle Area
Separate Skip for• Wood• Steel• Polythene
Ladder Aluminum and steel ladder
always maintain three points of contact
Don’t carry tools, equipment, or material in your hands while climbing
If more than 3 metres or 10 feet up, wear a safety harness.
Unsafe use of Ladder
Wooden ladder is strictly prohibited at site.
X
EMERGENCY CONTACTCall 0580290327 OR Ext. 9601 (PROJECT MANAGER) 0599748039 OR Ext. 9606 0592760385 (SAFETY DEPARTMENT) 0597391457 OR Ext. 9611 (MALE NURSE/ FIRST AID) 0597391457 (AMBAULANCE DRIVER)
From phone/mobile call. Say, “This is an EMERGENCY”. Describe the incident location. Describe the incident. Report injuries, if any. Give your name and other details. Stay on line until further instructed.
EMERGENCY PROCEDURE
Know the Assembly Areas. In case of emergency, stop your
work and rush to the assembly area.
Be there until advised to move. Participate in Roll Call / Head
count. Look for your co-workers.
ASSEMBLY AREA
DRIVING AT SITE
Speed Limit (Km/Hr) Seat Belt
It is the responsibility of the driver to ensure his vehicle is safe to operate.
Only Valid Saudi Government driving license. The driver is responsible for transporting the
materials properly and ensuring that a load does not exceed the manufacturer’s design load capacity.
Follows the traffic rule at site. Watch for the people moving in pedestrian and
crossing point. Park your vehicle in parking area ONLY. Do not leave vehicle in start condition.
Rules……...
Observe
Identify the Hazards
Tie-Back GateHarness Leg Straps
Improper Tie-Off Location
Proper Tie-Off LocationStanding on Scaffold Tube
Sitting on Railing Not Allowed
Knot in Lanyard
No Tie-Off
Extinguisher Not Secured
Housekeeping
Thank you.
Prepared By,
Faiz Ahmed(HSE ENGINEER)