Installation and Operation Instructions - Star Mfg Web · PDF filetable of contents. page...

®

ROLLER GRILLS

MODEL20C, 30C, 45C, 50C & 75C

Infinite and Electronic Controls

Installation and Operation

Instructions2M-Z9106 Rev. C 5/08/06

30SCBB

2 2

These symbols are intended to alert the user to the presence of important operating and maintenance instructions in the manual accompanying the appliance.

RETAIN THIS MANUAL FOR FUTURE REFERENCENOTICE

Using any part other than genuine Star factory supplied parts relieves the manufacturer of all liability.Star reserves the right to change specifi cations and product design without notice. Such revisions do not entitle the buyer to corresponding changes, improvements, additions or replacements for previously purchased equipment.Due to periodic changes in designs, methods, procedures, policies and regulations, the specifi cations contained in this sheet are subject to change without notice. While Star Manufacturing exercises good faith efforts to provide information that is accurate, we are not responsible for errors or omissions in information provided or conclusions reached as a result of using the specifi cations. By using the information provided, the user assumes all risks in connection with such use.

MAINTENANCE AND REPAIRSContact your local dealer for service or required maintenance. Please record the model number, serial number, voltage and purchase date in the area below and have it ready when you call to ensure a faster service.

SAFETY SYMBOL

Model No.

Serial No.

Voltage

Purchase Date

TABLE OF CONTENTS PAGE NUMBERCONNECTIONLOAD 3GENERALOPERATINGINSTRUCTIONS 4CLEANING 4ELECTRONICALLY CONTROLLED: START-UP,HEATING&PROGRAMING 5WARRANTY 6WIRINGDIAGRAM 7-10EXPLODEDVIEW 11,12PARTS LIST 20MODELSERIES 13 30MODELSERIES 14,15 45MODELSERIES 16,17 50MODELSERIES 18,19 75MODELSERIES 20,21

CAUTIONThis equipment is designed and sold for commercial use only by personnel trained andexperiencedinitsoperationandisnotsoldforconsumeruseinandaroundthehomenorforusedirectlybythegeneralpublicinfoodservicelocations.Forequipmenttobeusedbythegeneralpublic,pleasecontactthefactory.

INSTALLATIONThisgrillisequippedforthevoltageshownonthenameplate.Itwilloperateonalternatingcurrent only, however, the specified voltage must be applied. CAUTIONDO NOT CONNECT TO DIRECT CURRENT (DC).

CONNECTION LOAD:

INFINITE CONTROL MODEL SERIES WATTAGE

20C,20SC 93030C,30SC,30CF,30SCF,30CBB,30CBBC,30SCBB,30CDV 115045C,45SC,45CBB,45SCBB,45CDV 165050C,50SC,50CF,50SCF,50CBB,50CBBC,50SCBB,50CDV 153575C,75SC,75CBB,75SCBB,75FF,75SCF208/240V 1810/240075C,75SC,75CBB,75SCBB,75CDV230V 221075C,75CF,75SC,75SCF,75CBB,75SCBB,75CDV120V 1700

75CFV120V 2880

ELECTRONIC CONTROL MODEL SERIES WATTAGE20SCE 930

30CE,30SCE,30SCEX,30CBBE 30SCBBE 1150

45SCE,45SCRE 1650

50CE,50SCE,50SCEX50CBBE,50SCBBE,50CBBES 1535

75CE,75SCE,75CBBE,75CBBES,

75SCBBE,75SCRE208/240V,75SCFE 1810/2400

75CE,75SCE,75CBBE,75SCBBE,75SCRE120V 1730

INSTALLATION (CONTINUED)Thegrillshouldbeconnectedtoawalltypereceptacle,adirectlineorindividualbranchcircuit.Anindividualbranchcircuitispreferred.Ifconnectedtoanoverloadedcircuitthegrillwillnotoperateproperly.Theunitshouldbelevelwheninstalled.Modelsequippedwithbunboxesmustbeleveltoutilizetheself-closingfeatureofthebundrawer.Adjustable4-inchlegsarestandardonthe75seriesandavailableforallothermodels.

GENERAL OPERATING PROCEDURESThemainswitchlocatedonthecontrolpanelcontrolsallthepowertotheunit.Withthemainswitchon,therollerswill turn,butnoheatwillbesuppliedunlesstheheatcontrolsare turned on. For flexibility the heating section of the grill is divided into two individually controlledheatsections.Therightcontrolregulatestheheattotherearsectionandtheleftcontrolregulatestheheattothefrontsection.Theswitchislightedtoindicatewhentheunitis turned on. On Infinite control grills a signal light is provided above each heat control and indicateswhentheheatedsectionison.Anadditionallightisprovidedontheendhousingof the unit. This light indicates the position of the main power switch when either theoptional bun drawer front or merchandising door obstructs the control panel view. Bunboxequippedmodelsrequiretheremovalof thebundrawertoremovethebunpanandtoremovethedriptraywhenaccesstotherearoftheunit isobstructed.Toremovethebun drawer, grab the drawer by both sides and pull it out all the way. Lift the front tounhookthedrawerslidefromreardrawerroller.Pullthedrawertheremainderofthewayout.Usecautionnottodropthedrawerwhenreachingtheendofthedrawerslidetravel.Toreinsert the drawer, first hook the drawer slide over the front roller then the back roller. Do notoperatethegrillwithoutthedriptrayinplace.

CAUTIONUSE ONLY PLASTIC OR COATED UTENSILS FOR HANDLING THE FOOD PRODUCT. METAL COULD SCRATCH THE ROLLER COATING AND AFFECT THE CLEAN ABILITY OF THE ROLLERS.

CAUTIONDO NOT USE STEEL WOOL OR ABRASIVE CLEANERS ON THE ROLLERS. SCRAPES WILL VOID THE WARRANTY. USE CAUTION WHEN CLEANING A HOT GRILL TO PREVENT BURNS OR BODILY INJURY.

CLEANINGBefore cooking for the first time, wash the rollers with mild soap and water using a soft cloth. Donotusemetalutensilswhencooking.Scratchesandscrapeswillhampertheabilitytoeasilycleantherollers.Neverusesteelwoolorabrasivecleanersontherollers.Thiswilldamage the finish and the roller bearings. The rollers clean most easily when hot. Use caution whencleaningtopreventburnsandbodilyinjury.Cleantherollerswithacleanwetcloth.Wipefromtheendstothecentertopreventforcingdebrisintotherollerseals.Donotallowthefoodproducttobuildupandbakeontotherollersurface.Theexterioroftheunitshouldbecleanedusingamilddetergentornon-abrasivecleaner.Cleantheentireunitdailytoinsurelonglifeandsatisfactoryperformanceaswellastomaintainanattractiveappearance.Donotcleanwithwaterjetequipment.

3

START-UPWheninitiallyturningonpowertotheelectroniccontrolledgrill,itwillbeintheHOLDmode.Thedisplays will flash until the setpoint temperature is reached. Thegrillwillbeeponcewhen it isup to temperature. Infinite controlled grills have no notification when operating temperature is reached.

HEATINGThesize,content,andshapeoftheproductandtheinstallationofanysanitaryfoodshieldsorsneezeguardswilldeterminetheproperheatsetting.TheNationalSanitationFoundationrequiresthatallperishablefoodsbekeptat140°Foraboveduringservingperiods.The product should be kept refrigerated untilreadytouse.Heatingtimesvarydependingonthestartingtemperatureandthequalitiesoftheproduct. Forbestresults,useahotdogmadeforgrilling.Before cooking for the first time, wash the rollers withmildsoapandwaterusingasoftcloth.Whentheelectroniccontroledgrillsareinitiallyturnedon, the displays will flash the HOLD temperature untilthegrillreachesthatsetpoint.Withthegrillpreheatedtotheholdtemperature,loadwiththedesiredproductandpresstheHEATbutton.Thegrillwillthengointotheheatmodeandthe displays will flash until the HEAT temperature isreached.Aftertheheatingcycle,thegrillwillbeepfourtimesandthefoodproductwillbeattheservingtemperature.

NOTE: Basedontheproductbeingheated,someexperimentation is required to find the optimal HEAT temperatureandHEAT time tobring theproductuptotemperatureinanacceptableamountoftime.

PROGRAMMINGThe electronic controls provide programmableHEAT and HOLD settings for a variety of foodproductsandinstallationconditions.Toprogramtheelectronicrollergrill:

1. Withthegrillon,pushandholdthe and onthesideyouwishtoprogramtogetherforthreesecondsuntilthealarmbeepsonceandthedisplayblanks.

2. Tosettheheattemperatureand/orheattime,pushtheheatbutton.Thelastsavedheattimewillbedisplayed and the HEAT LED will flash and HEAT TIMEindicatorwillbeON.Usethe and buttonstoadjusttothedesiredtime,thenpresstheHEATbuttonagain. TheHEATTIMELEDindicatorwill turnoffandtheHEATTEMPLEDindicatorwillnowbelit.WhenprogrammingtheHEATtemperatureiscomplete,pushtheHEATbutton one more time to exit the programmingmode.

3. Tosettheholdtemperature,repeatstep1abovethenpushtheHOLDbutton.ThelastsavedholdtemperaturewillbedisplayedandHOLDLEDwillbeON.Usethe and buttonstoadjusttothedesired temperature, thenpress theHOLDbuttonagaintoexitprogrammingmode.

4. Toturntheheatofftothefrontorrearsection,pressandholdthe forthatsectionfor3seconds."OFF"willbedisplayed.Toturnthesectionbackon,presstheHEATorHOLDbutton.

PAT. # 6,782,802 PAT. # 6,707,015MADE IN

U.S.A.PAT. # 6,393,971

Seal-Max

DURATEC

PAT. # 6,782,802 PAT. # 6,707,015

Electronic Control Board5

OPERATING PROCEDURES FOR ELECTRONIC GRILLS

INTERNATIONAL ONE (1) YEAR EQUIPMENT WARRANTY

All workmanship and materials in “STAR” products are warranted for a period of one year from the date shipped from the factory or one year from the date shown on the proof of purchase of the end-user when purchased through an authorized “STAR” dealer/dis-tributor in a commercial foodservice location.

“STAR’s” obligation under this warranty is limited to the replacement of the defective part(s) only without charge. This warranty is void if damage occurs from improper installation, misuse or abuse, disassembly or tampering of unit for any purpose other than repair by a qualifi ed service agent, wrong voltage, incorrect or fl uctuating voltage conditions, wrong gas, improper gas or gas conditions, operated contrary to the installation and operating instructions, operated in an application for which the unit is not suited, or if the unit is not maintained and/or cleaned in a suitable manner.

Any expense in connection with installation, or any cost of making adjustments on a unit to conform to electric or gas service at the point of installation, are not covered by this warranty.

* The warranty period for the JetStar series six (6) ounce popcorn machines is two (2) years.

* The warranty period for the Chrome-Max Griddles is fi ve (5) years on the griddle surface. See detailed warranty provided with unit.

* The warranty period for Tefl on/Dura-Tec coatings is one year under normal use and reasonable care. This warranty does not apply if damage occurs to Tefl on/Dura-Tec coatings from improper cleaning, maintenance, use of metallic utensils, or abrasive cleaners. This warranty does not apply to the “non-stick” properties of such materials.* This warranty is not valid on Conveyor Ovens unless a “start-up/check-out has been performed by a Factory Authorized Technician.

In order to make a claim under this warranty; a warranty report must be fi led with Star Manufacturing International Inc. in St. Louis, Missouri, U.S.A. by the dealer/distibutor through which product was purchased. All details, including serial number and model num-ber of the defective unit, must be included. Failure to fi le a claim within a 120 Day time period may result in the claim being refused.

“STAR” may forego the necessity of returning the part for inspection dependent upon the expense involved. However, “STAR” requires defective parts to be held in the claimant’s possession for a period of ninety (90) days for possible inspection by a “STAR” representative or designated inspector .

The foregoing warranty is lieu of any and all other warranties, expressed or implied, and constitutes the entire warranty.

PARTS WARRANTY

Parts that are sold for out-of-warranty repair are warranted for a period of ninety days. The part only is warranted; no labor.

SERVICES NOT COVERED BY WARRANTY

1. Labor 2. Mileage and/or travel time 3. Installation and/or adjustment of equipment 4. Operation contrary to the installation and operating instructions5. Cleaning of equipment6. Seasoning of griddle plates7. Voltage conversions/adjustments8. Gas conversions9. Pilot light conversion/adjustments10. Thermostat calibration/adjustments11. Resetting of circuit breakers or safety controls12. Replacement of bulbs/lamps13. Replacement of fuses14. Damages due to improper installation15. Damages from abuse or misuse16. Damage created by acts of God, Acts of War, or Civil Disturbance

08-05 rms

PILO

T

H1

L1

H2

H2

PILO

T

H1

L1

77

L2

37

4

7

L2

1

1

2

REA

RFR

ON

T

F

RB

B

(AS

VIEW

ED F

RO

M R

EAR

OF

PAN

EL)

ALL

MO

DEL

S EX

CEP

T

20, 2

0S, 3

0D, 3

0SD

- 23

0V

PILO

TLI

GH

TPI

LOT

LIG

HT

MO

DEL:

RG

SER

IES,

INFI

NIT

E C

ON

TRO

LS

THIS

DRA

WIN

G CO

NTAI

NS IN

FORM

ATIO

N CO

NFID

ENTI

AL T

O ST

AR M

FG. I

NT'L.

INC.

NO

REP

RODU

CTIO

N OR

DIS

CLOS

URE

OF IT

S CO

NTEN

TS IS

PER

MIT

TED.

STA

R M

AN

UFA

CTU

RIN

G IN

TER

NAT

ION

AL

INC

. S

K16

46

R

ev D

8/07

/200

0

D

NE

UTR

AL

LIN

E

FRO

NT

GR

ILL

RE

AR

GR

ILL

RE

AR

FRO

NT

1

2

6

3

7

4

F

R

9

58

F

R

BLA

CK W

HIT

E

120V

AN

D 2

40V

MO

DE

LS

230V

MO

DE

LS

PIL

OT

LIG

HT

MO

TOR

CO

NTR

OL

BO

AR

D

PO

WE

R B

OA

RD

P

OW

ER

SW

ITC

H

SE

NS

OR

MO

DEL:

RG

E SE

RIE

S,EL

ECTR

ON

IC C

ON

TRO

LS

THIS

DRA

WIN

G CO

NTAI

NS IN

FORM

ATIO

N CO

NFID

ENTI

AL T

O ST

AR M

FG. I

NT'L.

INC.

NO

REP

RODU

CTIO

N OR

DIS

CLOS

URE

OF IT

S CO

NTEN

TS IS

PER

MIT

TED.

STA

R M

AN

UFA

CTU

RIN

G IN

TER

NAT

ION

AL

INC

. S

K19

13

R

ev -

9/

17/2

002

1

34

41

42

38

37

9

18

17

21

20

1013

MO

UN

T S

PR

ING

BE

TWE

EN

FR

AM

E &

AR

M H

OLE

S

14

5

35

2 8 1211

39

40

1110

1516

6

7

5

32

22

36

33 34

2331

30

24

INFI

NIT

E C

ON

TRO

LS

ELE

CTR

ON

IC C

ON

TRO

LS

19

NA

ME

PLA

TE

333130

28

17

RE

FER

TO

TH

E P

AR

TS L

IST

SP

EC

IFIC

TO

YO

UR

MO

DE

L FO

R M

OR

E D

ETA

IL IN

FOR

MAT

ION

.ST

AR

MA

NU

FAC

TUR

ING

INTE

RN

ATIO

NA

L IN

C.

SK

2109

Rev

. A12

/17/

10

2726

49

58

47

505159

60

6261

57

56 55

5253

54

44

4345

46

RE

FER

TO

TH

E P

AR

TS L

IST

SP

EC

IFIC

TO

Y

OU

R M

OD

EL

FOR

MO

RE

DE

TAIL

INFO

RM

ATIO

N.

STA

R M

AN

UFA

CTU

RIN

G IN

TER

NAT

ION

AL

INC

.S

K21

1001

-14-

05

48

PARTS LIST May8,2006,RevC

Some items are included for illustrative purposes only and in certain instances may not be available.

Star Manufacturing International, Inc.

MODEL

Grill-MaxRollerGrills 20 Series

IMPORTANT: WHEN ORDERING, SPECIFY VOLTAGE OR TYPE GAS DESIRED PAGE INCLUDE MODEL AND SERIAL NUMBER OF

11

1 A5-RG2028 1 BODYASSY 20CR/SCR1 A5-RG2027 1 BODYASSY 2OC/SC2 A5-Z2184 1 DRIPTRAY 20C/SC3 A5-Z8409 1 BACK-CHAINRETAINERSPACER 20C/SC4 A5-Z8410 1 ANGLECHAINRETAINERUPPER 20C/SC5 A5-Z2169 2 SIDEPANEL 20C/SC6 2N-Z2181 11 ELEMENT120V20 20C-120V6 2N-Z2611 11 ELEMENT230V20 20C-230V7 A5-Z6719 1 CHAINGUIDE 20C/SC8 2P-Z2242 1 CHAIN 20C/SC9 PS-RG2029 11 ROLLERASSYCHROME 20C9 PS-RG2030 11 ROLLERASSYPOLY 20SC10 2A-Z6614 3 IDLER ALL11 2A-Z8017 3 BUSHING,IDLER ALL12 A5-RG2042 1 ARMASSY-CHAINTENSIONER ALL13 2P-Z8074 1 SPRING ALL14 2P-Z2538 1 MOTORSPROCKET ALL15 2U-Z6485 1 MOTOR-120VOLT ALL120VMODELS15 2U-Z6487 1 MOTOR-230/240VOLT ALL230/240VMODELS16 A5-RG2046 1 MOTORMOUNTINGASSY 20C/SC17 A5-RG2036 1 CORDASSY120V 20C/SC(120VMODELSEXCEPTCSA)17 2E-Z0512 1 CORDSETEUR10AMP 20C/SC(230VMODELS)18 2K-Y3240 1 CORDBUSHING 20C/SC(120V&240VMODELS)19 2E-Y9227 1 CORDINLETIEC32010AMP 20C/SC(230VMODELS)20 A5-Z5335 1 BOTTOMCOVERPLATE ALL22 A5-Z9344 1 MOUNTINGBRACKET 20C/SC23 2J-Z2192 2 CONTROL230/240VOLT 20C/SC23 2J-Z2195 2 CONTROL120VOLT 20C/SC30 A5-Z7853 1 CONTROLPANEL 20C/SC30 A5-RG2047 1 CONTROLPANEL 20SCE31 2M-Z8323 1 CONTROLPANELLABEL 20C31 2M-Z8324 1 CONTROLPANELLABEL 20SC31 2M-Z9529 1 CONTROLPANELLABEL 20SCE32 2J-Z2329 3 PILOTLIGHTRED 20C/SC(120V&240VMODELS)32 2J-Z3157 3 PILOTLIGHTYELLOW 20C/SC(230VMODELS)33 2E-Z1858 1 SWITCH-REDLIGHTED 120V&240VMODELS33 2E-Z3156 1 SWITCH-YELLOWLIGHTED 230VMODELS34 2R-Z1854 2 KNOBW/SETSCREW 20C/SC35 A5-Z2509 4 PANEL-INSULATOR 20C/SC36 2P-Z6455 22 TUBESEAL,SOLID 20C/SC37 2I-Z2175 22 O-RINGSEAL 20C/SC38 2P-Z2174 22 TUBEGUIDE 20C/SC39 2R-Z5846 4 LEGS 20C/SC40 2K-Z2895 4 ANTISHORTBUSHING ALL41 A5-Z7650 1 ELEMENTRETAINER-UPPER 20C/SC42 A5-Z7656 1 ELEMENTRETAINER-LOWER 20C/SC58 2P-Z0584 1 TONGS ALLNOTSHOWN 2E-Z3619 1 WIRESET-230VNOTSHOWN 2E-Z8320 1 WIRESET-120V 20C/SCNOTSHOWN PS-Z3018 -- TUBEASSEMBLYSLEEVE

NumberPerUnit Description&ModelDesignation

PartNumber

KeyNumber




MODEL



12


PartNumber

KeyNumber

1 A5-RG3062 1 BODYASSY 30C/SC1 A5-RG3070 1 BODYASSY 30CBB/SCBB1 A5-RG3087 1 BODYASSY 30CBBC/SCBBC1 A5-RG3068 1 BODYASSY 30CF/SCF1 A5-RG3066 1 BODYASSY 30CR/SCR1 A5-RG3072 1 BODYASSY 30CRBB/SCRBB2 A5-Z2185 1 DRIPTRAY 30C/SC3 A5-Z8409 1 BACK-CHAINRETAINERSPACER 30C/SC4 A5-Z8410 1 ANGLECHAINRETAINERUPPER 30C/SC5 A5-Z2169 2 SIDEPANEL 30C/SC5 A5-Z5401 2 SIDEPANEL 30CF/SCF6 2N-Z2178 11 ELEMENT120V30/45 30C/SC-120V6 2N-Z2194 11 ELEMENT230V30/45 30C/SC-230V7 A5-Z6719 1 CHAINGUIDE 30C/SC8 2P-Z2242 1 CHAIN 30C/SC8 2P-Z5384 1 CHAIN 30CF/SCF9 PS-RG3077 11 ROLLERASSYCHROME 30C9 PS-RG3078 11 ROLLERASSYPOLY 30SC10 2A-Z6614 3 IDLER ALL11 2A-Z8017 3 BUSHING,IDLER ALL12 A5-RG2042 1 ARMASSY-CHAINTENSIONER ALL13 2P-Z8074 1 SPRING ALL14 2P-Z2538 1 MOTORSPROCKET ALL15 2U-Z6485 1 MOTOR-120VOLT ALL120VMODELS15 2U-Z6487 1 MOTOR-230/240VOLT ALL230/240VMODELS16 A5-RG2046 1 MOTORMOUNTINGASSY 30C/SC16 A5-RG5040 1 MOTORMOUNTINGASSY 30CF/SCF17 A5-RG2036 1 CORDASSY120V 30C/SC(120VMODELSEXCEPTCSA)17 2E-Z0512 1 CORDSETEUR10AMP 30C/SC(230VMODELS)18 2K-Y3240 1 CORDBUSHING 30C/SC(120V&240VMODELS)19 2E-Y9227 1 CORDINLETIEC32010AMP 30C/SC(230VMODELS)20 A5-Z5335 1 BOTTOMCOVERPLATE ALL21 2P-Z1540 2 HOLEPLUG ALLEXCEPTCLEARBUNBOXMODELS (CBBC,SCBBC)22 A5-Z9344 1 MOUNTINGBRACKET 30C/SC22 A5-RG4554 1 MOUNTINGBRACKETASSY 30CE/SCE23 2J-Z2192 2 CONTROL230/240VOLT 30C/SC23 2J-Z2195 2 CONTROL120VOLT 30C/SC23 PS-RG3091 1 ELECTRONICCONTROL120V 30CE/SCE23 A5-Z6002 1 ELECTRONICCONTROL230/240V 30CE/SCE24 2K-Z1971 9 SPACERS 30CE/SCE25 2E-Z5565-5 1 RIBBONCONNECTOR 30CE/SCE26 2E-Z5565-3 1 SENSORFRONT 30CE/SCE27 2E-Z5565-4 1 SENSORREAR 30CE/SCE28 2E-Z5565-2 1 POWERBOARD 30CE/SCE29 PS-RG3092 1 CONTROLBOARD 30CE/SCE30 A5-Z7651 1 CONTROLPANEL 30C/SC30 A5-Z7753 1 CONTROLPANEL 30CBB/SCBB30 A5-RG3069 1 CONTROLPANEL 30CE/SCE30 A5-RG3071 1 CONTROLPANEL 30CBBE/SCBBE31 2M-Z8325 1 CONTROLPANELLABEL 30C31 2M-Z8326 1 CONTROLPANELLABEL 30CBB




MODEL

Grill-MaxRollerGrills 30 Series con't


22


PartNumber

KeyNumber

31 2M-Z8328 1 CONTROLPANELLABEL 30CBBE31 2M-Z8327 1 CONTROLPANELLABEL 30CE31 2M-Z8329 1 CONTROLPANELLABEL 30SC31 2M-Z8330 1 CONTROLPANELLABEL 30SCBB31 2M-Z8331 1 CONTROLPANELLABEL 30SCBBE31 2M-Z8332 1 CONTROLPANELLABEL 30SCE32 2J-Z2329 3 PILOTLIGHTRED 30C/SC(120V&240VMODELS)32 2J-Z3157 3 PILOTLIGHTYELLOW 30C/SC(230VMODELS)32 2J-Z2329 1 PILOTLIGHTRED 30CE/SCE(120V&240VMODELS)32 2J-Z3157 1 PILOTLIGHTYELLOW 30CE/SCE(230VMODELS)33 2E-Z1858 1 SWITCH-REDLIGHTED 120V&240VMODELS33 2E-Z3156 1 SWITCH-YELLOWLIGHTED 230VMODELS34 2R-Z1854 2 KNOBW/SETSCREW 30C/SC35 A5-Z2509 4 PANEL-INSULATOR 30C/SC36 2P-Z6455 22 TUBESEAL,SOLID 30C/SC37 2I-Z2175 22 ORINGSEAL 30C/SC38 2P-Z2174 22 TUBEGUIDE 30C/SC39 2R-Z5846 4 LEGS 30C/SC40 2K-Z2895 4 ANTISHORTBUSHING ALL41 A5-Z7650 1 ELEMENTRETAINER-UPPER 30C/SC42 A5-Z7656 1 ELEMENTRETAINER-LOWER 30C/SC42 A5-RG3094 1 ELEMENTRETAINERASSY-LOW 30CE/SCE45 2P-Z5098 11 GREASESEAL 30CDV/SCDV46 A5-Z5158 1 GRILLDIVIDER 30CDV/SCDV47 2D-Z5898 1 PAN2/3X4”DEEP 30CBB/SCBB48 2P-Z0315 4 DRAWERROLLERW/SCREW ALLBUNBOX(CBB/SCBB)MODELS49 A5-RG3030 1 DRAWERASSY 30CBB/SCBB50 A5-RG3009 1 DRAWERFRONTASSEMBLY 30CBB/SCBB51 2M-Z2377 1 DRAWERLABEL 30CBB/SCBB52 2A-Z4667 1 SHAFT 30CBBC/SCBBC53 A5-Z4660 1 DOORBRACKET 30CBBC/SCBBC54 2C-Z4680 1 RETAINERRING 30CBBC/SCBBC55 A5-Z4661 1 SPRINGMOUNTBRACKET 30CBBC/SCBBC56 A5-Z4657 1 DOORARM 30CBBC/SCBBC57 2P-Z4683 1 EXTENSIONSPRING 30CBBC/SCBBC58 2P-Z0584 1 TONGS ALL59 2A-Z4333 1 RETAINERPIN 30CBBC/SCBBC60 2P-Z4337 1 COMPRESSIONSPRING 30CBBC/SCBBC61 2A-Z4332 1 SHOULDERSCREW 30CBBC/SCBBC62 A5-RG3037 1 FRONTDOOR 30CBBC/SCBBC62 A5-RG5016 1 FRONTDOOR-GLASS 30CBBC/SCBBCNOTSHOWN 2E-Z8320 1 WIRESET 30C/SC(INFINITECONTROLS)NOTSHOWN 2E-Z8414 1 WIRESET 30CE/SCE(ELECTRONICCONTROLS)NOTSHOWN PS-Z3018 -- TUBEASSEMBLYSLEEVE




MODEL



12


PartNumber

KeyNumber

1 A5-RG4533 1 BODYASSY 45C/SC1 A5-RG4536 1 BODYASSY 45CBB/SCBB1 A5-RG4534 1 BODYASSY 45CR/SCR1 A5-RG4537 1 BODYASSY 45CRBB/SCRBB2 A5-Z2186 1 DRIPTRAY 45C/SC3 A5-Z8411 1 BACK-CHAINRETAINERSPACER 45C/SC4 A5-Z8412 1 ANGLECHAINRETAINERUPPER 45C/SC5 A5-Z2265 2 SIDEPANEL 45C/SC5 A5-Z5347 2 SIDEPANEL 45CF/SCF6 2N-Z2178 16 ELEMENT120V30/45 45C/SC-120V6 2N-Z2194 16 ELEMENT230V30/45 45C/SC-230V7 A5-Z6615 1 CHAINGUIDE 45C/SC8 2P-Z2266 1 CHAIN 45C/SC8 2P-Z5336 1 CHAIN 45CF/SCF9 PS-RG3077 16 ROLLERASSYCHROME 45C9 PS-RG3078 16 ROLLERASSYPOLY 45SC10 2A-Z6614 3 IDLER ALL11 2A-Z8017 3 BUSHING,IDLER ALL12 A5-RG2042 1 ARMASSY-CHAINTENSIONER ALL13 2P-Z8074 1 SPRING ALL14 2P-Z2538 1 MOTORSPROCKET ALL15 2U-Z6485 1 MOTOR-120VOLT ALL120VMODELS15 2U-Z6487 1 MOTOR-230/240VOLT ALL230/240VMODELS16 A5-RG2046 1 MOTORMOUNTINGASSY 45C/SC16 A5-RG5040 1 MOTORMOUNTINGASSY 45CF/SCF17 A5-RG2036 1 CORDASSY120V 45C/SC(120VMODELSEXCEPTCSA)17 2E-Z0512 1 CORDSETEUR10AMP 45C/SC(230VMODELS)17 A5-RG2041 1 CORDASSY120V 45C/SC(120VCSAMODELS)18 2K-Y3240 1 CORDBUSHING 45C/SC(120V&240VMODELS)19 2E-Y9227 1 CORDINLETIEC32010AMP 45C/SC(230VMODELS)20 A5-Z5335 1 BOTTOMCOVERPLATE ALL21 2P-Z1540 2 HOLEPLUG ALLEXCEPTCLEARBUNBOXMODELS (CBBC,SCBBC)22 A5-Z9344 1 MOUNTINGBRACKET 45C/SC22 A5-RG4554 1 MOUNTINGBRACKETASSY 45CE/SCE23 2J-Z2192 2 CONTROL230/240VOLT 45C/SC23 2J-Z2195 2 CONTROL120VOLT 45C/SC23 PS-RG3091 1 ELECTRONICCONTROL120V 45CE/SCE23 A5-Z6002 1 ELECTRONICCONTROL230/240V 45CE/SCE24 2K-Z1971 9 SPACERS 45CE/SCE25 2E-Z5565-5 1 RIBBONCONNECTOR 45CE/SCE26 2E-Z5565-3 1 SENSORFRONT 45CE/SCE27 2E-Z5565-4 1 SENSORREAR 45CE/SCE28 2E-Z5565-2 1 POWERBOARD 45CE/SCE29 PS-RG3092 1 CONTROLBOARD 45CE/SCE30 A5-Z7651 1 CONTROLPANEL 45C/SC30 A5-Z7753 1 CONTROLPANELASSY 45CBB/SCBB30 A5-RG3069 1 CONTROLPANEL 45CE/SCE30 A5-RG3071 1 CONTROLPANEL 45CBBE/SCBBE31 2M-Z8325 1 CONTROLPANELLABEL 45C31 2M-Z8326 1 CONTROLPANELLABEL 45CBB




MODEL



22


PartNumber

KeyNumber

31 2M-Z8327 1 CONTROLPANELLABEL 45CE31 2M-Z8329 1 CONTROLPANELLABEL 45SC31 2M-Z8330 1 CONTROLPANELLABEL 45SCBB32 2J-Z2329 3 PILOTLIGHTRED 45C/SC(120V&240VMODELS)32 2J-Z3157 3 PILOTLIGHTYELLOW 45C/SC(230VMODELS)32 2J-Z2329 1 PILOTLIGHTRED 45CE/SCE(120V&240VMODELS)32 2J-Z3157 1 PILOTLIGHTYELLOW 45CE/SCE(230VMODELS)33 2E-Z1858 1 SWITCH-REDLIGHTED 120V&240VMODELS33 2E-Z3156 1 SWITCH-YELLOWLIGHTED 230VMODELS34 2R-Z1854 2 KNOBW/SETSCREW 45C/SC35 A5-Z2510 4 PANEL-INSULATOR 45C/SC36 2P-Z6455 32 TUBESEAL,SOLID 45C/SC37 2I-Z2175 32 ORINGSEAL 45C/SC38 2P-Z2174 32 TUBEGUIDE 45C/SC39 2R-Z5846 4 LEGS 45C/SC40 2K-Z2895 4 ANTISHORTBUSHING ALL41 A5-Z6619 1 ELEMENTRETAINER-UPPER 45C/SC42 A5-Z6622 1 ELEMENTRETAINER-LOWER 45C/SC42 A5-RG4549 1 ELEMENTRETAINERASSY-LOW 45CE/SCE45 2P-Z5098 16 GREASESEAL 45CDV/SCDV46 A5-Z5157 1 GRILLDIVIDER 45CDV/SCDV47 2D-Z5898 1 PAN2/3X4”DEEP 45CBB/SCBB48 2P-Z0315 4 DRAWERROLLERW/SCREW ALLBUNBOX(CBB/SCBB)MODELS49 A5-RG3030 1 DRAWERASSY 45CBB/SCBB50 A5-RG3009 1 DRAWERFRONTASSEMBLY 45CBB/SCBB51 2M-Z2377 1 DRAWERLABEL 45CBB/SCBB58 2P-Z0584 1 TONGS ALLNOTSHOWN 2E-Z8320 1 WIRESET 45C/SC(INFINITECONTROLS)NOTSHOWN 2E-Z8414 1 WIRESET 45CE/SCE(ELECTRONICCONTROLS)NOTSHOWN PS-Z3018 -- TUBEASSEMBLYSLEEVE




MODEL



12


PartNumber

KeyNumber

1 A5-RG5028 1 BODYASSY 50C/SC1 A5-RG5029 1 BODYASSY 50CR/SCR1 A5-RG5031 1 BODYASSY 50CBB/SCBB1 A5-RG5037 1 BODYASSY 50CBBC/SCBBC1 A5-RG5030 1 BODYASSY 50CF/50SCF1 A5-RG5032 1 BODYASSY 50CRBB/SCRBB2 A5-Z2305 1 DRIPTRAY 50C/SC2A A5-Z4273 1 DRIPTRAY 50SC-ST,50SCE-ST,50SC-STS2B A5-RG5012 1 DRIPTRAYASSY 50SC-ST,50SCE-ST,50SC-STS3 A5-Z8409 1 BACK-CHAINRETAINERSPACER 50C/SC4 A5-Z8410 1 ANGLECHAINRETAINERUPPER 50C/SC5 A5-Z2169 2 SIDEPANEL 50C/SC5 A5-Z5401 2 SIDEPANEL 50CF/SCF6 2N-Z2179 11 ELEMENT120V50 50C/SC-120V6 2N-Z2193 11 ELEMENT230V50/75 50C/SC-230V7 A5-Z6719 1 CHAINGUIDE 50C/SC8 2P-Z2242 1 CHAIN 50C/SC8 2P-Z5384 1 CHAIN 50CF/SCF9 PS-RG7562 11 ROLLERASSYCHROME 50C9 PS-RG7563 11 ROLLERASSYPOLY 50SC10 2A-Z6614 3 IDLER ALL11 2A-Z8017 3 BUSHING,IDLER ALL12 A5-RG2042 1 ARMASSY-CHAINTENSIONER ALL13 2P-Z8074 1 SPRING ALL14 2P-Z2538 1 MOTORSPROCKET ALL15 2U-Z6485 1 MOTOR-120VOLT ALL120VMODELS15 2U-Z6487 1 MOTOR-230/240VOLT ALL230/240VMODELS16 A5-RG2046 1 MOTORMOUNTINGASSY 50C/SC16 A5-RG5040 1 MOTORMOUNTINGASSY 50CF/SCF17 A5-RG2036 1 CORDASSY120V 50C/SC(120VMODELSEXCEPTCSA)17 2E-Z0512 1 CORDSETEUR10AMP 50C/SC(230VMODELS)18 2K-Y3240 1 CORDBUSHING 50C/SC(120V&240VMODELS)19 2E-Y9227 1 CORDINLETIEC32010AMP 50C/SC(230VMODELS)20 A5-Z5335 1 BOTTOMCOVERPLATE ALL21 2P-Z1540 2 HOLEPLUG ALLEXCEPTCLEARBUNBOX MODELS(CBBC,SCBBC)22 A5-Z9344 1 MOUNTINGBRACKET 50C/SC22 A5-RG4554 1 MOUNTINGBRACKETASSY 50CE/SC23 2J-Z2192 2 CONTROL230/240VOLT 50C/SC23 2J-Z2195 2 CONTROL120VOLT 50C/SC23 PS-RG3091 1 ELECTRONICCONTROL120V 50CE/SCE23 A5-Z6002 1 ELECTRONICCONTROL230/240V 50CE/SCE24 2K-Z1971 9 SPACERS 50CE/SCE25 2E-Z5565-5 1 RIBBONCONNECTOR 50CE/SCE26 2E-Z5565-3 1 SENSORFRONT 50CE/SCE27 2E-Z5565-4 1 SENSORREAR 50CE/SCE28 2E-Z5565-2 1 POWERBOARD 50CE/SCE29 PS-RG3092 1 CONTROLBOARD 50CE/SCE30 A5-Z7751 1 CONTROLPANEL 50C/SC30 A5-Z7850 1 CONTROLPANELASSY 50CBB/SCBB30 A5-RG7560 1 CONTROLPANEL 50CBBE/SCBBE30 A5-RG7561 1 CONTROLPANEL 50CE/SCE31 2M-Z8333 1 CONTROLPANELLABEL 50C




MODEL



22


PartNumber

KeyNumber

31 2M-Z8334 1 CONTROLPANELLABEL 50CBB31 2M-Z8336 1 CONTROLPANELLABEL 50CBBE31 2M-Z8335 1 CONTROLPANELLABEL 50CE31 2M-Z8337 1 CONTROLPANELLABEL 50SC31 2M-Z8338 1 CONTROLPANELLABEL 50SCBB31 2M-Z8340 1 CONTROLPANELLABEL 50SCBBE31 2M-Z8339 1 CONTROLPANELLABEL 50SCE32 2J-Z2329 3 PILOTLIGHTRED 50C/SC(120V&240VMODELS)32 2J-Z3157 3 PILOTLIGHTYELLOW 50C/SC(230VMODELS)32 2J-Z2329 1 PILOTLIGHTRED 50CE/SC(120V&240VMODELS)32 2J-Z3157 1 PILOTLIGHTYELLOW 50CE/SC(230VMODELS)33 2E-Z1858 1 SWITCH-REDLIGHTED 120V&240VMODELS33 2E-Z3156 1 SWITCH-YELLOWLIGHTED 230VMODELS34 2R-Z1854 2 KNOBW/SETSCREW 50C/SC35 A5-Z2509 4 PANEL-INSULATOR 50C/SC36 2P-Z6455 22 TUBESEAL,SOLID 50C/SC37 2I-Z2175 22 ORINGSEAL 50C/SC38 2P-Z2174 22 TUBEGUIDE 50C/SC39 2R-Z5846 4 LEGS 50C/SC40 2K-Z2895 4 ANTISHORTBUSHING ALL41 A5-Z7650 1 ELEMENTRETAINER-UPPER 50C/SC42 A5-RG3094 1 ELEMENTRETAINER-ASSY 50CE/SCE42 A5-Z7656 1 ELEMENTRETAINER-LOWER 50C/SC45 2P-Z5098 11 GREASESEAL 50CDV/SCDV46 A5-Z5158 1 GRILLDIVIDER 50CDV/SCDV47 2D-Z5899 1 PANFULLX4”DEEP 50CBB/SCBB48 2P-Z0315 4 DRAWERROLLERW/SCREW ALLBUNBOX(CBB/SCBB)MODELS49 A5-RG5011 1 DRAWERASSY 50CBB/SCBB50 A5-RG5004 1 DRAWERFRONTASSEMBLY 50CBB/SCBB51 2M-Z2380 1 DRAWERLABEL 50CBB/SCBB52 2A-Z4677 1 SHAFT 50CBBC/SCBBC53 A5-Z4660 1 DOORBRACKET 50CBBC/SCBBC54 2C-Z4680 1 RETAINERRING 50CBBC/SCBBC55 A5-Z4661 1 SPRINGMOUNTBRACKET 50CBBC/SCBBC56 A5-Z4657 1 DOORARM 50CBBC/SCBBC57 2P-Z4683 1 EXTENSIONSPRING 50CBBC/SCBBC58 2P-Z0584 1 TONGS ALL59 2A-Z4333 1 RETAINERPIN 50CBBC/SCBBC60 2P-Z4337 1 COMPRESSIONSPRING 50CBBC/SCBBC61 2A-Z4332 1 SHOULDERSCREW 50CBBC/SCBBC62 A5-RG5016 1 FRONTDOOR-GLASS 50CBBC/SCBBCNOTSHOWN 2E-Z8320 1 WIRESET 50C/SC(INFINITECONTROLS)NOTSHOWN 2E-Z8414 1 WIRESET 50CE/SCE(ELECTRONICCONTROLS)NOTSHOWN PS-Z3018 -- TUBEASSEMBLYSLEEVE




MODEL



12


PartNumber

KeyNumber

1 A5-RG7549 1 BODYASSY 75CRBB/SCRBB1 A5-RG7571 1 BODYASSY 75CFV1 A5-RG7547 1 BODYASSY 75CF/SCF1 A5-RG7548 1 BODYASSY 75CBB/SCBB1 A5-RG7546 1 BODYASSY 75CR/SCR1 A5-RG7545 1 BODYASSY 75C/SC2 A5-Z2306 1 DRIPTRAY 75C/SC3 A5-Z8411 1 BACK-CHAINRETAINERSPACER 75C/SC4 A5-Z8412 1 ANGLECHAINRETAINERUPPER 75C/SC5 A5-Z5347 2 SIDEPANEL 75CF/SCF5 A5-Z2265 2 SIDEPANEL 75C/SC6 2N-Z2193 16 ELEMENT230V50/75 75C/SC-230V6 2N-Z2982 16 ELEMENT120V105W 75C/SC-120V7 A5-Z6615 1 CHAINGUIDE 75C/SC8 2P-Z5336 1 CHAIN 75CF/SCF8 2P-Z2266 1 CHAIN 75C/SC9 PS-RG7563 16 ROLLERASSYPOLY 75SC9 PS-RG7562 16 ROLLERASSYCHROME 75C10 2A-Z6614 3 IDLER ALL11 2A-Z8017 3 BUSHING,IDLER ALL12 A5-RG2042 1 ARMASSY-CHAINTENSIONER ALL13 2P-Z8074 1 SPRING ALL14 2P-Z2538 1 MOTORSPROCKET ALL15 2U-Z6487 1 MOTOR-230/240VOLT ALL230/240VMODELS15 2U-Z6485 1 MOTOR-120VOLT ALL120VMODELS16 A5-RG5040 1 MOTORMOUNTINGASSY 75CF/SCF16 A5-RG2046 1 MOTORMOUNTINGASSY 75C/SC17 A5-RG2034 1 CORDSER240VW/TERMINALS 75C/SC(240VMODELS)17 2E-Y9251 1 CORDSETEUR16AMP 75C/SC(230VMODELS)17 A5-RG2041 1 CORDASSY120V 75C/SC(120VMODELS)18 2K-Y3240 1 CORDBUSHING 75C/SC(120V&240VMODELS)19 2E-Y9253 1 CORDINLETIEC32016AMP 75C/SC(230VMODELS)20 A5-Z5335 1 BOTTOMCOVERPLATE ALL21 2P-Z1540 2 HOLEPLUG ALLEXCEPTCLEARBUNBOX MODELS(CBBC,SCBBC)22 A5-RG4554 1 MOUNTINGBRACKETASSY 75CE/SCE22 A5-Z9344 1 MOUNTINGBRACKET 75C/SC23 A5-Z6002 1 ELECTRONICCONTROL230/240V 75CE/SCE23 PS-RG3091 1 ELECTRONICCONTROL120V 75CE/SCE23 2J-Z2192 2 CONTROL230/240VOLT 75C/SC23 2J-Z2195 2 CONTROL120VOLT 75C/SC24 2K-Z1971 9 SPACERS 75CE/SCE25 2E-Z5565-5 1 RIBBONCONNECTOR 75CE/SCE26 2E-Z5565-3 1 SENSORFRONT 75CE/SCE27 2E-Z5565-4 1 SENSORREAR 75CE/SCE28 2E-Z5565-2 1 POWERBOARD 75CE/SCE29 PS-RG3092 1 CONTROLBOARD 75CE/SCE30 A5-RG7560 1 CONTROLPANEL 75CE/SCE30 A5-RG7561 1 CONTROLPANEL 75CBBE/SCBBE30 A5-Z7850 1 CONTROLPANELASSY 75CBB/SCBB30 A5-Z7751 1 CONTROLPANEL 75C/SC31 2M-Z8339 1 CONTROLPANELLABEL 75SCE31 2M-Z8340 1 CONTROLPANELLABEL 75SCBBE




MODEL



22


PartNumber

KeyNumber

31 2M-Z8338 1 CONTROLPANELLABEL 75SCBB31 2M-Z8337 1 CONTROLPANELLABEL 75SC31 2M-Z8335 1 CONTROLPANELLABEL 75CE31 2M-Z8336 1 CONTROLPANELLABEL 75CBBE31 2M-Z8334 1 CONTROLPANELLABEL 75CBB31 2M-Z8333 1 CONTROLPANELLABEL 75C32 2J-Z3157 1 PILOTLIGHTYELLOW 75CE/SCE(230VMODELS)32 2J-Z2329 1 PILOTLIGHTRED 75CE/SCE(120V&240VMODELS)32 2J-Z3157 3 PILOTLIGHTYELLOW 75C/SC(230VMODELS)32 2J-Z2329 3 PILOTLIGHTRED 75C/SC(120V&240VMODELS)33 2E-Z3156 1 SWITCH-YELLOWLIGHTED 230VMODELS33 2E-Z1858 1 SWITCH-REDLIGHTED 120V&240VMODELS34 2R-Z1854 2 KNOBW/SETSCREW 75C/SC35 A5-Z2510 4 PANEL-INSULATOR 75C/SC36 2P-Z6455 32 TUBESEAL,SOLID 75C/SC37 2I-Z2175 32 ORINGSEAL 75C/SC38 2P-Z2174 32 TUBEGUIDE 75C/SC39 2R-Y5092 4 LEGS4” 75C/SC40 2K-Z2895 4 ANTISHORTBUSHING ALL41 A5-Z6619 1 ELEMENTRETAINER-UPPER 75C/SC42 A5-RG4549 1 ELEMENTRETAINERASSY-LOW 75CE/SCE42 A5-Z6622 1 ELEMENTRETAINER-LOWER 75C/SC43 2P-Y9176 2 SNAPBUTTON 75SCF-SA,75SCFE-SA44 A5-RG7516 1 CONTROLPANELCOVER 75SCF-SA,75SCFE-SA45 2P-Z5098 16 GREASESEAL 75CDV/SCDV46 A5-Z5157 1 GRILLDIVIDER 75CDV/SCDV47 2D-Z5899 1 PANFULLX4”DEEP 75CBB/SCBB48 2P-Z0315 4 DRAWERROLLERW/SCREW ALLBUNBOX(CBB/SCBB)MODELS49 A5-RG5011 1 DRAWERASSY 75CBB/SCBB50 A5-RG5004 1 DRAWERFRONTASSEMBLY 75CBB/SCBB51 2M-Z2380 1 DRAWERLABEL 75CBB/SCBB58 2P-Z0584 1 TONGS ALLNOTSHOWN 2E-Z8414 1 WIRESET 75CE/SCE(ELECTRONICCONTROLS)NOTSHOWN 2E-Z8320 1 WIRESET 75C/SC(INFINITECONTROLS)NOTSHOWN PS-Z3018 -- TUBEASSEMBLYSLEEVE

6

PROGRAMACIÓNLoscontroleselectrónicosproporcionanajustes

electrónicos para HEAT (Calentar) y HOLD (conservar-mantener)paraunavariedaddeproductoscomestiblesycondicionesdeinstalación.

Paraprogramarlaparrilleraelectrónicaderodillos:1. Con la parrillera encendida, oprima y mantenga

conjuntamentepor3segundoselydelladoquedeseeprogramarhastaqueseemitaunsonidodealarma(beep)ylapantallaseblanquee.

2.Paraprogramarlatemperaturadecalentamientoy/o el tiempo de calentamiento, oprima el botón de HEAT (calentar). El último tiempo decalentamientosalvadoserámostradoenla pantalla, la luz (LED) del HEAT (calentar) titilará y el HEAT TIME (indicador de tiempo decalentamiento)seencenderá(ON).Uselosbotones y para ajustar el tiempo deseado, luego oprima el botón de HEAT (calentar) de nuevo. La luz (LED) del HEAT TIME (indicador detiempodecalentamiento)seapagaráyla luz (LED) del HEAT TEMP (indicador de temperatura)seencenderá.Cuandohayaterminado de programar la temperatura, oprima el botón HEAT (calentar) una vez más para salir delmododeprogramación.

3.Paraprogramarlatemperaturadeconservación(hold temperature), repita el paso 1 de arriba, luego oprima el botón HOLD. La última temperaturadeconservaciónsalvadasemostrará en la pantalla y la luz (LED) del HOLD estaráencendida.Uselosbotonesyparaajustar la temperatura deseada, luego oprima el botón HOLD de nuevo para salir del modo de programación.

4.Paraquitarelcalordelasecciónfrontaloposterior, oprima y mantenga el botón de la sección específica durante 3 segundos. La palabra“OFF”apareceráenlapantalla.Paraencender la sección de nuevo, oprima los botones de HEAT o HOLD.

ArranqueElequipoconcontrolelectrónicoentraenelmodode conservación (HOLD) cuando se enciende porprimeravez.Lapantalla(display)titilaráhasta que la temperatura previamente fijada sea alcanzada.Elequipoemitiráunsonido(beep)unavezquelleguealatemperatura.Equiposconcontrol infinito no indican cuando la temperatura deoperaciónesalcanzada.

CalentamientoElajusteapropiadodelatemperaturadecalentamiento depende del tamaño, contenido, formadelproductoydelainstalacióndecualquierescudoprotectoropantalladeprotecciónsanitaria(proteccióncontraestornudos)LaFundaciónNacionaldeSanidad(NSF)requierequetodoslosproductoscomestiblesperecederosseanmantenidosa140ºFoporencimaduranteelperíododeservido.Losproductosdebensermantenidosrefrigeradoshastaqueesténlistosparaserutilizados.Lostiemposdecalentamientovaríandependiendodelatemperaturainicialydelacalidaddelproducto.Para mejores resultados, utilice salchichas elaboradasparaparrilleras.Antes de cocinar por primera vez, lave los rodillos conunpañosuavehúmedoconunasoluciónsuavedeaguajabonosa.Cuandolasparrillerascontroladasdeformaelectrónicasonencendidaspor primera vez, las pantallas titilarán, indicando la temperatura de HOLD (conservación) hasta que alcance la temperatura prefijada.

ConlaparrilleraprecalentadaalatemperaturadeHOLD (conservación), cárguela con el producto deseado y oprima el botón de HEAT (calentar). La parrillera entrará en la modalidad de HEAT (calentar)ylaspantallastitilaránhastaquesealcance la temperatura prefijada. Después del ciclo de calentamiento, la parrillera emitirá una alarmaosonido(beep)cuatrovecesyelproductoestaráalatemperaturadeservir.Nota: basado en el tipo de producto a calentar, esnecesarioexperimentardeformaquesealcance la temperatura de calentamiento HEAT yeltiempodecalentamientoparallevarelproductoalatemperaturaapropiadaenuntiempoaceptable.

5

PROCEDIMIENTOS OPERATIVOS PARA PARRILLERAS ELECTRONICAS

PAT. # 6,782,802PAT. # 6,707,015MADE IN

U.S.A. PAT. # 6,393,971

Seal-Max

DURATEC

PAT. # 6,782,802PAT. # 6,707,015

Tabla de Controles Electrónicos

INSTALACION CONTINUEDElequipodebeserconectadoenformadirectaeindividualalatomadealimentacióneléctricade la pared. Si se conecta a un circuito sobrecargado, el equipo no operará de forma correcta. Losmodelosequipadosconcajasparapanesdebenserniveladosparautilizarlacaracterísticade auto-cerrado en la gaveta de los panes. 4 patas ajustables están incluidas en la serie 75 yestándisponiblesdeformaopcionalparalosotrosmodelos.

PROCEDIMIENTOS OPERATIVOS GENERALESElinterruptorprincipalcontrolatodalaenergíadelequipo;ésteseencuentraubicadoenelpanel de controles. Cuando el interruptor principal está en la posición ON, los rodillos estarán encendidos, pero no suministrarán calor a menos que los controles de calor (HEAT) estén en la posición de ON. Para mayor flexibilidad de la sección de calentamiento (HEAT) la parrilla está divididaendosseccionescontroladasdeformaindividual.Elcontroldeladerechacontrolaelcalordelasecciónposterioryelcontroldelaizquierdaregulaelcalordelasecciónfrontal.Elinterruptorprincipalestáiluminadoparaindicarcuandoelequipoestáprendido.Enlasparrillerascon controlador infinito una luz (LED) ubicada arriba de cada control señala cuando la sección específica esta encendida (ON). También hay una luz (LED) adicional al final de la cubierta delequipo.Estaluz(LED)indicalaposiciónelinterruptorprincipalcuandolagavetaopcionalparalospanesolapuertadelcomercializadorobstruyenlavistadelpaneldecontrol.Enlosmodelosequipadosconlacajaparapanesserequiereremoverlagavetadelospanespararetirarlabandejadelospanesylabandejadedrenajecuandoelaccesoalaparteposteriordelequipoestáobstruida.Pararemoverlagavetadelospanestomelagavetaporambosladosyhálelahaciafuera.Levanteelfrenteparadesengancharlaruedadelriel-guíayretirela gaveta del equipo. Tenga precaución y evite que se caiga la gaveta cuando llegue al final del riel-guía. Para reinsertar la gaveta, primero deslice y enganche la guía de la gaveta en la ruedafrontalyluegolaruedatrasera.Noopereelequiposinlabandejadedrenaje.

PRECAUCIONSOLO UTILICE UTENSILIOS PLÁSTICOS O RECUBIERTOS CUANDO MANEJE PRODUCTOS COMESTIBLES. OBJETOS DE METAL PUEDEN DAÑAR LA CUBIERTA DE LOS RODILLOS Y AFECTAR LA CAPACIDAD SANITARIA DE LOS RODILLOS

PRECAUCIONNO UTILICE UTENSILIOS DE LANA DE ACERO O LIMPIADORES ABRASIVOS EN LOS RODILLOS. RASPADURAS INVALIDARÁN LA GARANTÍA. PARA EVITAR QUEMADURAS Y HERIDAS TOME LAS PRECAUCIONES NECESARIAS CUANDO LIMPIE LA PARRILLA Y ESTA ESTÉ CALIENTE.LimpiezaAntes de utilizar el equipo por primera vez, limpie los rodillos con un paño suave húmedo con unasoluciónsuavedeaguajabonosa.Noutiliceutensiliosdemetalcuandoestécocinando.Lasraspadurasyrayaslerestaránhabilidadparalimpiarlosrodillosdeformafácil.Nuncautilicelanillasoesponjasmetálicasolimpiadoresabrasivosenlosrodillos.Estodañaráelacabadoylossoportesdelosrodillos.Losrodillossonmásfácilesdelimpiarcuandoestáncalientes.Tomelasprecaucionesnecesariascuandolimpielaparrillayestécalientedeformaqueseeviteheridasyquemaduras.Limpielosrodillosconunpañohúmedo.Sequedesdelosextremoshaciaelcentroparaprevenirqueelsucioseaforzadodentrodelossellosdelosrodillos..Nopermita que los restos de la comida se adhieran y se quemen sobre la superficie del rodillo. El exteriordelequipodebeserlimpiadoconundetergentesuaveynoabrasivo.Limpietodoelequipo diariamente para garantizar la vida larga, buen funcionamiento y apariencia atractiva. Noutiliceequiposconchorrosdeaguaapresión(waterjet)paralimpiarlo.

4

PRECAUCIONEstaunidadhasidodiseñadaysevendeexclusivamenteparausoscomercialesyparaseroperadaporpersonaldebidamenteentrenadoyexperimentadoensuoperaciónynosevendeparausodelconsumidorenlacasaoalrededordeellaniparaserusadadirectamenteporlasociedadgeneraleninstalacionesdeserviciodecomidas.Favorcontactelafábricaparaequiposdeusoparapúblicoengeneral.

INSTALACIONEsteequipoestádiseñadoparaoperarconelvoltajeynúmerodevatiosindicadosenlaplacade identificación montada en el respaldo de la unidad, y ha sido diseñado para ser usado con corrienteeléctricaalterna(AC)únicamente.

PRECAUCIONNO CONECTE ESTA UNIDAD A UNA FUENTE DE CORRIENTE DIRECTA (DC)

CARGA DE CONEXIÓN:

3

TABLA DE CONTENIDO PAGINA NUMEROCARGADECONEXION3INSTRUCCIONESOPERATIVASGENERALES3LIMPIEZA4CONTROLDADOS ELECTRONICAMENTE:ARRANQUE, CALENTAMIENTOI & PROGRAMACION 5GARANTIA6DIAGRAMADECABLEADO7-10DESGLOSE DEL EQUIPO 11, 12LISTA DE PARTESMODELOSERIES2013 MODELO SERIES 30 14, 15 MODELO SERIES 45 16, 17 MODELO SERIES 50 18, 19 MODELO SERIES 75 20, 21

CONTROL INFINITO MODELO SERIE VATIAJE 20C, 20SC 93030C, 30SC, 30CF, 30SCF, 30CBB, 30CBBC, 30SCBB, 30CDV 115045C, 45SC, 45CBB, 45SCBB, 45CDV 165050C, 50SC, 50CF, 50SCF, 50CBB, 50CBBC, 50SCBB, 50CDV 153575C, 75SC, 75CBB, 75SCBB, 75FF, 75SCF 208/240V 1810/240075C, 75SC, 75CBB, 75SCBB, 75CDV 230V 221075C, 75CF, 75SC, 75SCF, 75CBB, 75SCBB, 75CDV 120V 1700

75CFV 120V 2880

CONTROL ELECTRONICOMODELO SERIE VATAJE20SCE 93030CE, 30SCE, 30SCEX, 30CBBE 30SCBBE 115045SCE, 45SCRE 165050CE, 50SCE, 50SCEX 50CBBE, 50SCBBE, 50CBBES 153575CE, 75SCE, 75CBBE, 75CBBES,75SCBBE, 75SCRE 208/240V,75SCFE 1810/240075CE, 75SCE, 75CBBE, 75SCBBE, 75SCRE 120V 1730

2

Este símbolo intenta alertar el usuario a la presencia de instrucciones de operación y mantenimiento importante en el manual que acompaña el aparato.

GUARDA ESTE MANUAL PARA REFERENCIA EN EL FUTURO.

AVISOEl uso de cualquier parte aparte de partes genuinos proveídos de la fabrica Star exime al fabricante de toda responsabilidad.Star reserva el derecho de cambiar las especifi caciones y el diseño del producto sin notifi cación. Estas revisiones no dan al comprador un derecho a estos cam-bios, mejoramientos, adiciones, o piezas de recambio correspondientes para equipo previamente comprado.Por los cambios periódicos del diseño, método, procedimiento, política, y regu-lación, las especifi caciones en este manual pueden cambiar sin aviso. Aunque Star Manufacturing hace todo que puede para asegurar que provee información correcta, no somos responsables por errores u omisiones en la información proveída ni por conclusiones formados como resulta de usar las especifi caciones. Cuando usa la información proveída, el usuario acepta todo el riesgo asociado con el uso de esta unidad.

MANTENIMIENTO Y REPARACIONESPóngase en contacto con su comerciante de quien usted compró la unidad para servicio y mantenimiento requerido. Por favor apunta en el área abajo el número de modelo, número serial, voltaje, y fecha de compra y tenga esta información lista cuando usted llama para asegurar servicio rápido.

Símbolo de seguridad

N° Modelo

N° Serial

Voltaje

Fecha de Compra

Para información sobre la garantía, póngase en contacto con su comerciante.

2

®

PARRILLERA ROLLER

MODEL20C, 30C, 45C, 50C & 75C

Controles Electrónico e Infinito

Instrucciones para instalación y

operación2M-Z9106 Rev. C 5/8/06

30SCBB

Date post:	06-Feb-2018
Category:	Documents
Upload:	buikhanh
View:	214 times
Download:	0 times

Installation and Operation Instructions - Star Mfg Web · PDF filetable of contents. page...

Documents