7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 1/87
Disclosure to Promote the Right To Information
Whereas the Parliament of India has set out to provide a practical regime of right to
information for citizens to secure access to information under the control of public authorities,in order to promote transparency and accountability in the working of every public authority,
and whereas the attached publication of the Bureau of Indian Standards is of particular interest
to the public, particularly disadvantaged communities and those engaged in the pursuit of
education and knowledge, the attached public safety standard is made available to promote the
timely dissemination of this information in an accurate manner to the public.
!"#$%&# '(%)
“ !"# $ %& #' (")* &" +#,-. ”Satyanarayan Gangaram Pitroda
“Invent a New India Using Knowledge”
“ /0 )"1 &2 324 #' 5 *)6 ” Jawaharlal Nehru
“Step Out From the Old to the New”
“ 7"#1 &" 8+9&") , 7:1 &" 8+9&") ”Mazdoor Kisan Shakti Sangathan
“The Right to Information, The Right to Live”
“ !"# %& ;<" =7"#" > 72 &(: ?0 )"@" #AB 7" <&*" A *”Bhart+hari—N,ti-atakam
“Knowledge is such a treasure which cannot be stolen”
IS 7622 (2001): Series 1 Freight Containers - Handling and
Securing [TED 12: Freight Containers and Pallets]
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 2/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 3/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 4/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 5/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 6/87
AMENDMENT
NO
4 JANUARY 2 1
TO
IS 7622 : 2 1 SERIES 1
FREIGHT
CONTAINERS HANDLING AND SECURING
SecondRevision
AMENDMENT 3: Double stack rail car operations
ge 28
Adda new9.3.5aftertheexisting 9.3.4as
follows:
9 3 5
Doublestack rail
car
operations
To
ensure
safe
operation
on doublestack rail car
vehicles
both the lower and the upper
containers
shallbe
supported by all four bottom ,comer fittings
only
The bottom container shall be
secured
to the rail vehicle
through the bottom comer fittings eftherby
twistlocks
or othermeanswhich will ensurecompliance with 9.1.
The
upper container shall be secured to the lower
container through
the
bottom
comer fittings either by
twisUcicks
or othermeanswhich will ensurecompliance
with
9.1. It is noted that these rail cars
should
always
be
shoved to
rest during operations l.e, shunting should not
be
allowed An
example of
a securing lifting
used for transport byrailandof a
double
stackrail
vehicle
is shownin Figure29.
Toensure safeoperation:
the posftion of the securing devices shall
be
readily
apparent:
before thevehide is
moved
the securement ofthe container shallbe checked:
before
thecontainers are lifted, all
locking
devices shallbe released
PriceGroup 7
1
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 7/87
Amendment No to IS 7622 :
2 I IS
874: 1997
ll
]
]
l. .- l
» I
• I
I
U
r
I
J
J
I
\
al
Overall v w of
a
typical double atack rail
car
b Detail of securing fitting
Figure 29- Example of double atack rail car with securing fittlnga in common uae
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 8/87
Amendment No 4 to IS 7622 : 2ool/lS0 3874: 1997
AMENDMENT 4: 45 ft containers
age
ReplaceTable 1 with the following:
Table 1 - Summary of specified lifting methods
SUbclause
Description
Containertypes Containertype E at Containertype Eat
A B CandD 40
It
position 45
It
position
6 2
Top lilt
±J
tb
preader
6 3
Toplilt
ling
6 4
ottom
lilt
ling
6 5 Side lilt:
1C:j]
ethod 1
6 6
Sidelift:
t
ethod
2
6 7 Sidelift:
Notapplicable to type E Notapplicable to
ty
E
method
3
45It)
containers
45 It)
containers
6
Endlift:
Notapplicable
ty E Notapplicable
type E
method 1
45 It) containers 45
II) containers
6 9
Endlilt:
Not
applicable
to type E Notapplicable
typeE
method
2
45 It)
containers
45 It)
containers
6 10
Fork·tilt
Notapplicable
type E
Notapplicable
typeE
45 It) containers 45It)
containers
3
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 9/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 10/87
Amendment No.4 to IS
7622
: IlIS 3874: 1997
age 7
able
Replace the existing Table3 bythe following,
which
includes containertypes EEEandEE.
DAl owed
Table
3 -
Applicability of top
lift
spreaders
Not
allowed or not
applicable
ee
etelllld be d ends PF
lIl d
fnM-standl
PF
complete.w folding endI
erected
PC
....-..
foldingfree-11IrIdln;
posts.erected
PC
. . .
and foIdlllllendI.taIded
PC
foIdinIl
fr8Ntltdng
posts folded
PC
. . .
P l l orTn bued with PO
ur
BK
PI.
P,\IN
TN,RT
TG
IlU
RE,RT
RS
n
G . •
Bulk:
non-
TMIt for IlquicSl
n
ps. .
Em contWner
1 Top liftpossible with extensions only.
age 7
6.3
Top
lift
sling
Makethe
existing
Figure3 intoFigure3a withthe caplion:
aj
Ufllng
containers otha than type
E
Adda new partb toFigure3:
40
ft
position 45
ft
position
b Lifting
type
E containers
Figure 3 - Lif ting by means of a top lift sling
5
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 11/87
AmendmentNo.4 to /S7622: 2 I SO 3874: /997
Replace
the
existing subclause
6.3.1 by the
following
to
include
intermediate :
6 3 The
container
is lifted byall four topcorneror
intermediate
fillings withforcesapplied otherthan
vertically.
age
8,
able
Replace the existing Table4 by the following,
which
includes container typesEEEandEE:
Table4 - Applicability of top slings
Key. 0
AHowed
. NotaIowed
I
not ~ p l i t l e t
Ce>ntelner type
epontop
Bulk:noo·pr urlHllbox
Tankfor llql lln QU
1 CenlRl
of
gravitymaybe eccentric.
2 For 10
and
lOX
c o o t i n o ~
tile lifting forcesshall be plied at ananglonolloss than
60 to
tho
horizontal, s
Figure4.
NOTE
centre
ofgravity may be mobile, e,g, liqUid, bulk orhanging loads.
age
6.4 Bottom ft sling
Make the existing Figure 5 intoFigure 5a withthe caption:
a Ufllng containers other than type E
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 12/87
Amendment No.4 to IS
7622
: 2001llS0 3874: 1997
Adda newpartb) to Figure 5:
40 ft
position
45ft position
b) Lifting type Econtainers
Figure 5- Lifting
by
means of a bottom lift sling
Replace theexisting subclause 6.4.1 bythe following to include intermediate :
6.4.1
The
container
is liftedfrom
side
apertures
of four
bottom
corneror
intermediate
fillings by
means
of
slings.
The bottom
sling
attachment
shall
bearon thecomeror intermediate fittings only and
should
be such to exertlifting
forces
notmore than 38mmawayfromthe outerface of thecornerfittings see
Figure 6).
Page
1
Table
Replace
the
existing Table
5 bythe following, which includes container typesEEEandEE:
0 ·-
Table 5 - Applicabili ty
of
bottom lift slings
~ Notaao d or rlOlappIiaIble)
Container
typII
G8nenJI purpose
GP.IIN
top UT
Bulk:non-pntIlUrtZIG box
U
T
RE,RT 1) 1) 1)
RS
,
,
T a n k ~ l i q d a m g a _
TN,RT
TG
Bulk: non-prnaurlzedlhopperpntSlUl1zed
OK
Pl
CCIllllell
net e n .
PF
fixed free.atlIndlngpam.
p
completeand fokIing tIndI erected
PC
condition
,
Pl8tkllm·tlIsed withcampi luperstuclure PS
1) centre of gravity
may
be
eccentric.
2) centre
of
gravitymaybe
mobile,
e.g.liquid,bulk
Of
hangingload.
7
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 13/87
Amendment No 4 to IS 7622 : 2001 lS0 3874 : 1997
ge
1 Table
Replace the existing Table 6 by the following, which includes container types 1EEE and 1EE:
Table 6 - Lifting angles fo r loaded containers
Container size designation l i ft ing angle, a, min.
l M lA l X lEEE lEE
30
lBBB lBB
lB lB X 37
lCC
lC lCX
45
10; lOX
60
Pages
10
and
6.5 SIde ft Method 1
Make the existing Figure7 intoFigure 7a) with the caption:
a) Uftlng containers other than type E
Add a new part b) to Figure 7:
40 ft position
45 ft position
b) Lifting
type
E containers
Figure7 -
lifting
by
mesns
of a
side
ft (method 1)
Replace the existing subclause 6.5.1 by the following (to include intermediate ):
6.5.1 The container is lifted by means of a side t frame designed to lift a container by the
two
botIom
comer or intermediate fittings of one side and to restrain II by the two top corner or Intermediate f t ngs
of the same side.
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 14/87
Amendment No 4 to IS 7622 : 2001llS0 3874: 1997
age
11
able
Replace
the
existing
Table7
by
the following
which includes
container typesEEEandEE:
Table 7 - Applicabi li ty
of
side li t lmethod i
[]I
No
IIIowed or
not
IIpplicable
EEE
EE.
AAA AAA AXB88 •
,,
-
Open
top UT
.s
Tankforllquidlltlldgaau TN,RT
TO
PL
compI. and
bed fInCSI
PF
f l l i d ~ n g p o l t l
PF
CIIll lJHIe
Mel
folding endI .edId
PC
.
I
Centre
01
gravity maybe eeeentri<:.
2 certnI
of
gravity
maybe mobil••• g. liquid.
bulk
or
hanging load
Pages 11 nd
8 6
Side 11ft: Method2
Make
theexisting Figure 8 into
Figure
8a withthe caption:
a Lifting containersother thsn
type
E
Add
a newpartb
to
Figure 8:
40 It
position
45 It position
b Wiling
type
E containers
Figure 8 - Lifting by means o a side
11ft
method 2
9
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 15/87
Amendment No.4 to IS7622: 200I/IS0 3874: 1997
Replace theexisting subclause 6.6.1 bythe following to include intermediate ):
6.6.1
The container is lifted by means of a side lift frame designed to lift a container by the two top
corner or. intermediate
fl tlings of one side and to take the reaction forces on the
bottom
corneror
intermediate fittings of the samesideor on suitable cornerpostareasabovethose cornerfillings see
Figure
9).
age 12 able 8
Repla<:e the
existing
Table8 bythe
following
which
includes
container typesEEEandEE:
,
Table 8 - Applicabil ity of side l t method 2)
~ N o t ~ o r n o t . a p p l c : a l : Q )
1)
centre
01
gravitymay
be tric.
2) centre o
gravity may
mobile,e.g. liquid,
bulk or
hanging loads.
on f lMr typ
Genaralpurpose
top
,,,
Platform based
withCOflllI_
IUper1lI UCtI.n
NOTE When
using
this
method. care should
be
taken
to
ensure
that
under dynamic conditions
the
container
is
not
subjected toundue
deflection
ordamage.
age
6.7 Side lift: Method 3
Inserta new
paragraph
in 6.7.1:
Sidelift method 3)is notallowed for EEandEEEcontainers.
10
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 16/87
Amendment No 4 to IS 7622 : 2 1115 3874: 1997
age 3
able
Replace the
existing
Table9 by the following which
includes
container types EEEandEE:
Table9 Applicability ofaide
ft
method
3
J
No aowed lor o t ~
Container
tv
l p
1 Centre of gnlVitymaybeeccentric.
Sidelift
molhod
3
is
notallowedfor EEandEEEcontainers.
NOTE The use of piggybackers has never been recognized by ISO and may cause damage due to excessive stressa to
containers operated insuch away
ge
6.8
End
ft Method 1
Insertanew
paragraph
in
6.8.1:
End lift method 1 is not allowed for EEandEEEcontainers.
11
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 17/87
AmendmentNo.4 to IS7622: 2001/lS0 3874:
1997
Page
4
e le
Replace theexisting
Table
10bythe
following
which
includes
container typesEEEandEE:
Table10- Applicability of end
lift
method 1
DNotallowed or notappIicMlle
t p
Tankfor l qu s n ga
Endlift
method 1 is not
allowed
for EEandEEEcontainers.
NOTE VVhen
usingthis method care
should
be takento ensure
that
under dynamic
c:onditions the
container
Is not
subjected
undue deflection or
damage.
Peges
4
and 5
6,9 End
l ift
Method2
lnserta new
paragraph
in 6.9.1:
Endlift method 2 is not allowed for EEandEEEcontainers.
2
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 18/87
Amendment No.4 to IS 7622: 2001/lS0
874:
1997
age 15
Table
Replace
theexisting Table 11 bythe following
which
indudescootainer typesEEEandEE:
loweG
Table 11- Applicability and 11ft method
o t ~
ornat appIIcII:lIe
-
ulk:
nO F zeciIbcoc
.. ..
End lilI melhod 2)
is not
alla.ved forEEandEEE
containers.
NOTE When using thismethod care
sholJd
be taken to ensure that
under
dynamic condittons the container
is
not
subjected to
undue _ ordamage
Pages15 and
6.10 Fork lifts
Inserta newparagraph in6.10.1 :
Theuseof fork liftsisnotallowed for EEandEEEcontainers.
13
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 19/87
Amendment No t IS 7622: 2 1115 3874: 1997
age 6 able
Replace the
existing
Table 12bythe folloWing which includes contaoer typesEEEandEE:
Table 12- Applicabil ity of fork lifts
o
Not l oWed ot notWiCllbll
-
U k n ~
~ -
P t am blNdtMlh
l l T l P e M i ~
and
1
Centro of
gravitymay
be
~
2 ntr ofgnlvitymaybe
mobile
e.g. liquid bulkor henging load•.
Fork
l to
are
not
allowed lor EE
end
EEE
containe
...
14
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 20/87
Amendment No 4 to IS 7622 : 200111503874: 1997
Addthe followingfigure beforeAnnex A:
Figure 30 45 It container with om r and Intennedlate fitllngs
TE
12
Reprogntphy
Unit
BIS NewDelhi India
15
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 21/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 22/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 23/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 24/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 25/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 26/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 27/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 28/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 29/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 30/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 31/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 32/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 33/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 34/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 35/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 36/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 37/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 38/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 39/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 40/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 41/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 42/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 43/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 44/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 45/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 46/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 47/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 48/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 49/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 50/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 51/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 52/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 53/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 54/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 55/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 56/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 57/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 58/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 59/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 60/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 61/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 62/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 63/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 64/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 65/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 66/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 67/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 68/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 69/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 70/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 71/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 72/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 73/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 74/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 75/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 76/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 77/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 78/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 79/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 80/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 81/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 82/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 83/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 84/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 85/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 86/87
7/25/2019 ISO_3874_1997
http://slidepdf.com/reader/full/iso38741997 87/87