40EnviroAmentalProtection Agency
John R. Kasich, GovernorMary Taylor, It. GovernorScott J. Nally, Director
I;J
OIi
Re Richland CountyM&D Real EstateNPDES Permit
August 23, 2011
Mrs. Shelly FisherM&D Real Estate Investments1862 Westover CourtMansfield, Ohio 44906
Dear Mrs. Fisher:
On August 3, 2011, an inspection was made of the wastewater treatment facilities serving your propertylocated at 4732 Lincoln Highway, Springfield Township, Richland County. At the time of the inspection,all major components of the treatment system appeared to be operating normally.
During the inspection, it was noted that the tablets in the chlorine feeder were not in contact with thewater. Several tablets at the bottom of the feeder tube had partially dissolved and become soft; however,they were preventing full tablets from failings down the tube to replace them. While performing checksat the treatment plant, the operator needs to be sure that the tablets are falling down the tube. Thisrequires the tube to be removed from the box and visually inspected. Please see the enclosed photograph.
The operator's log mentioned that the left sand filter dosing pump was malfunctioning beginning onJuly 18. It did not appear that this pump has been repaired. This should be done immediately if notalready completed.
Our office has received your discharge monitoring reports for the months of January through July 2011.A review of the data submitted revealed five violations of the limits contained In your NPDES permit.Four of the violations were for exceeding the pH limit; the other was for exceeding the total suspendedsolids limit.
A copy of our completed inspection report has been enclosed for your review. If you have any questions,please call me at 419-373-3070.
Sincerely,
Walter ̂ Jds S P. E.Environmental Specialist IIDivision of Surface Water
/jlmEnclosurespc: Lonnie McGhee, McGhee's Technical Water Service Inc.
çNWD0 File - ---
Northwest District Office
419 1352 8461347 North Dunbridge Road
419 1352 8468 (fax)
Bowling Green, OH 43402-9398
mw.epa.ohio.gov
OHIO ENVIRONMENTAL PROTECTION AGENCYOPERATION AND MAINTENANCE INSPECTION
WWTP'S LESS THAN 25,000 GPOoNPDES Permit No._________________
Facility Name 4t L) t47 Expiration Date____
Facility Address Z1712 2,2z/-r Date Time______
City -County 47L Township_________________
Name and Address of Owner S((y /7c4Person Contacted__________________ OwnerFlow: Design Q, (2)0 GPO Present (_I) GPD (metered _______Tub. Pop. - estimated) Weather at time of inspectiorc TempOEPA Personnel 47 //7r_'4-, _. District NWDO
Plant Effluent - Mark Severity No.
3.
Effect of effluent on Receiving Stream Name:
a. Plant has excellent good __________fair ________ poor operationb. Plant has __ excellent >c good fair poor maintenancec. Sand filters have _____ excellent good fair ' poor maintenance
d. Not operating at expected efficiency due to:
(1)hydraulic overload(2)organicf solids overload(3)___,,,,,personnel inefficiency4)equipment failure
wastes(6)
Disinfection: (Required May I thru Oct.31.)IN OUT
Chlorination Tablets -Dechlorination TabletsU.V.
Yes No
4• .Compliance with NPDES Permit,,
Periodic Violations
Chronic Violations
NParameters:'-
5. Adequate plant safety
6. Operation and Maintenance Service Name /4et$_,722TFrequency of visits _____________________________
Revised 6/05 RZ Page 1
Preliminary tirease irap
Bar Screen
Cornrninutor ........
Flow Equalization
Aeration Plant Timer _YNEquipment
Motor/ Blower UnitSecondaryTreatment Aeration Tank
Clarifier
Final Settling Sludge Return
/Surface Skimmer
Fixed Media Clarifier
TertiarySurface Sand Filter
____
Treatment Polishinq Pond
0 -I
Color c'2/ ./.çAdequate Aeration:
In -^5 Out — fcvvi
- Out
Chlorine Tube Feeder
Disinfection Dechlorination Tube F
Ultraviolet (UV)
' Elapsed Pump TimeFlow Metering -V---
Recorder (continuous
Raw Wastewater (typEPumps
Sand Filter Effluent Dc
Sludge -'' Aerated Storage TankSludge Drying Bed
Municipal P01WSludgeDisposal Landfill
Land Application
Post AerationAdvancedTreatment Spray Irrigation
Page 2
-
I
q.p-.
- - S-.- • - L - . -
- - -••- -
• - .- -- ---.-'.•• ----•-- •--- -
- - -
- - - --- ---;T
dj -_ •-4. -..--'- - -
- -- --- - '-
• •• I.• •,I..;,• -.
• - - ••- -k
-• sI - im
- A
•FC - I
,....'.l
l.l.
IIt
z. I 414 • -A -
• -• __ —' •.- - ,•. . •_.• :•.
A!•:
h - -
a- . .•• .- •.. - .•.- •: c: -r, : <j— g!ç -.
,r• •--,,_••- '•- •. -; ¼ - • - -• - -•-. -
• -'-*; •-- •' ,• '•- •'• - •---.:- - •.:'-'- •j1
I C,LL V 0 -Ali