PARTS CATALOG
2002-2007 BEARCAT
Group 1 Accessories………………………………………………………….…..Page 3 1800 & 3600 Watt Power Inverter, Back-up Camera System, Cooper Sling, Elec-tric Power Winch, Explosive Gas Detection Package, Front Receiver Ram Pack-age, Go-Light Spot Light, Intercom System, Light-bars, Radiation Detection Package, Radio Prep Package, Thermal Camera System, Trailer Hitch & Wiring Harness, & Skip Round Shields.
Group 2 Front & Rear Suspension, Wheels & Emergency Brake…….....Page 11 Coil Springs, Emergency Brake Cable & Adjuster, Front & Rear Shock Absorb-ers, Jack & Jack Handle, Rear Leaf Springs, Run-flat Inserts & Tires, Spare Tire Mounting, Tire Valves, U-bolts & Hardware, Wheels.
Group 3 Electrical - Exterior & Interior, Windshield Wiper System……..Page 18 Exterior Lighting, Interior Lighting, Radio Speakers, Shoreline Parts, Siren P.A. System, Switches & Controls, Windshield Wiper Motors, Arms, Blades & Washer Nozzles & Wiring Harnesses.
Group 4 Exterior Body, Doors & Related Parts……………………………..Page 28 Exterior Mirrors, Front Bumper Parts, Fuel Door Lock, Gunports, Handles, Hood Pistons, Latches & Locks, Running Boards, Skip Round Shield Hooks, Toolbox Parts, Tow Hooks, Turret Parts.
Group 5 Body - Glass……………………………………………………………Page 40 Door Glass, Installation Materials, Sidewall Glass & Windshields.
Group 6 Interior Trim………………………………………………………….…Page 44 Fire Extinguisher, Floor Mats, Roof Insulation & Finish Panels, Seat Belts, & Seats.
Group 7 Heater & Air Conditioning……………………………………………Page 50 A/C Receiver/Dryer, Heater & A/C Controls, Hoses & Fittings, Rear Heater & Air Conditioning Unit.
Complete Index - Pages 53 - 55
Table of Contents
Lenco Armored Vehicles
Group 1
ACCESSORIES
To Order Call: 1-800-444-5362
Group 1 Index
Back-up Camera System ......................................................................................9 Cooper Sling .........................................................................................................5 Combustible Gas Monitoring System....................................................................5 Front Bumper Receiver .........................................................................................8 Front Ram Bar ......................................................................................................8 Go Light & Replacement Parts..............................................................................4 Intercom System ...................................................................................................5 Light Bars..............................................................................................................6 Power Inverter.......................................................................................................6 Radiation Detection Package................................................................................6 Radio Antenna ......................................................................................................8 Skip Round Shield & Brackets ..............................................................................7 Thermal Camera System ......................................................................................4 Trailer Hitch...........................................................................................................7 Trailer Wiring.........................................................................................................7 Winch ....................................................................................................................4
Lenco Armored Vehicles
Page 3
To Order Call: 1-800-444-5362 Lenco Armored Vehicles To Order Call: 1-800-444-5362
Page 4
Go-Light Searchlight The GoLight Model 2020 is designed to be permanently attached to the vehicle. The Searchlight with Directional Flexibility is operated by a dash-mount control, which gives the operator a full 370 degree horizontal turn and a 135 degree vertical tilt with fingertip control. The GoLight provides superior light penetration with Cr5 PentaBeam technology.
Part Number# 19-112-2032 Go-Light Part Number# 19-112RB Replacement Bulb Part Number# 19-2020-D Dash Control w/o Wireless Remote Part Number# 19-2067-D Dash Control with Wireless Remote
Thermal Camera System Vehicle mounted thermal imaging camera (FLIR) with BST (Bio Sensor Technology) sensor that operates in 7-14 micron band. EMX specially modifies an L3 Thermal-Eye 4000b and adds a color monitor. Standard system comes complete with pan/tilt housing, wiring harness, 7” monitor, joystick and electronics box.
Part Number# 19-199
Warn Winch 16.5 ti The 16.5 ti features the full diagnostic ability of WARN Thermometric technology, plus the extreme sealing, durability and reliability that the WARN ti-series of winches is known for. The new, more efficient design delivers faster line speeds and lower amp draw. Includes 90 feet of aircraft grade, 7/16” wire rope.
Part Number# 19-153
Lenco Armored Vehicles
Cooper Sling The Cooper Sling™ Gunner Seat & Restraint (patent pending) was engineered to substantially reduce stress and fatigue to Crew Weapon System Gunners, and can be adapted to fit any tactical or armored vehicle with a turret or hatch.
Part Number# 19-GPS-1161
Page 5
Intercom System The two way intercom system includes a master station with volume and Push-To-Talk (PTT) controls and a remote station that provides hands free operation.
Part Number# 19-179
Combustible Gas Monitoring System The Drager Polytron IR type 334 is an explosion proof gas detector with an infrared element for continuous monitoring of combustible gases and vapors in the ambient air. The transmitter is built for harsh environments (SS 316L enclosure) and features extreme reliability.*
Part Number# 19-190 *Part Number# 19-289 AC/DC transformer 24 VDC also required for installation. (not shown)
To Order Call: 1-800-444-5362
Whelen Light Bar The 9M strobe light bar features modular construction “snap-in/lock-in” components. Customized to your color pattern and layout. The Liberty LED features the next generation all Linear-LED technology in a warning package that rivals strobe in impact, but provides heavy-duty long life operation with low current draw. Customized to your color pattern and layout.
Part Number# 19-229 Edge Strobe Light Bar (top) Part Number# 19-240LED Liberty LED Light Bar (bottom)
Ludlum Radiation Detection Package The M375 Digital Wall Mount Area Monitor is designed for visibility and ease of operation. Featuring a wall mount chassis, the Model 375 has a four digit LED display that is readable from 30 feet away. Backlit indicators warn of low radiation alarm (yellow), high radiation alarm (red), instrument failure (red), and low battery (yellow). Green light status is a positive indication of instrument operation. A handheld, Pocket Survey Meter is included.
Part Number# 19-201
DC to AC Power Inverter Environmentally Friendly, Quiet Reliable, DC to AC power inverter with battery charge feature. Available in 1800 & 3600 watt power to start demanding loads.
Part Number# 19-168-18 1800 Watt Inverter (top) Part Number# 19-168-36 3600 Watt Inverter (bottom)
Page 6
Lenco Armored Vehicles
Page 7
Ballistic Skip Round Shield This composite shield can be quickly hung from the running boards on the side or rear of the vehicle. Its purpose is to help prevent “skip rounds” from being fired under the truck, skipping off the pavement and possibly striking team members or downed victims on the other side. The vehicle can be moved while deployed. The shield doubles as a stretcher, and measures 14” X 70”.
Part Number# 19-133
Ballistic Skip Round Shield Hooks Steel mounting hooks used to mount Ballistic Skip Round Shield on vehicle. 8 required per vehicle. Steel mounting brackets may be required.
Part Number# 15-207
Rear Trailer Hitch & 7 way connector Class 4 Trailer hitch with 2 inch receiver rated for up to 10,000 lbs. towing capacity.
Part Number# 27-SQCAT278 (Hitch) Part Number# 11-30602 (Wiring)
To Order Call: 1-800-444-5362
Page 8
Front Bumper Receiver 2” receiver size allows for a variety of attachments to be utilized.
Part Number# 27-SQCAT033
Front Ram Bar An 11 foot ram bar that attaches to the front bumper receiver. Includes the brackets and mounting hardware for easy storage above the driver door along the roof rail. Must be used with the Lenco Front Bumper Receiver, PN# 27-SQCAT033.
Part Number# 19-BCFRTRAM
Replacement Radio Antenna & Mounting
Hardware Direct replacement antenna and mounting hardware for Lenco’s Radio Prep Package.
Part Number# 19-222 (Antenna) Part Number# 19-229 (Antenna Mount)
Page 9
Back up Camera & Rear View Security Monitor
The Lenco rear view color security camera features a 150 degree wide angle lens and auto back light compensation. Rear view security color monitor features high definition, low reflection LCD, one touch dimmer, and a full function remote control.
Part Number# 19-281 Back up Camera Part Number# 19-188 Rear View Security Monitor
Lenco Armored Vehicles
Group 2
FRONT & REAR
SUSPENSION
WHEELS
EMERGENCY BRAKE
To Order Call: 1-800-444-5362
Page 11
Group 2 Index
Coil Springs.........................................................................................................12 Emergency Brake Parts ......................................................................................16 Jack.....................................................................................................................15 Leaf Springs........................................................................................................12 Lug Wrench.........................................................................................................15 Run-flat Inserts..............................................................................................13, 14 Shock Absorbers.................................................................................................12 Spare Tire Mounting Hardware ...........................................................................15 Tire & Wheel Assembly ................................................................................13, 14 Tire Valves ..........................................................................................................15 U-Bolts ................................................................................................................13 Wheels ..........................................................................................................13, 14
Lenco Armored Vehicles
To Order Call: 1-800-444-5362
Page 12
Front Shock Absorbers Heavy Duty, specially valved, gas charged front shock absorbers manufactured specifically for the Lenco BearCat by Monroe. Recommended to be replaced in pairs.
Part Number# 12-435
Front Coil Springs Heavy Duty Coil Springs. Recommended to be replaced in pairs.
Part Number# 12-429
Rear Shock Absorbers Heavy Duty, specially valved, gas charged rear shock absorbers manufactured specifically for the Lenco BearCat by Monroe. Recommended to be replaced in pairs.
Part Number# 12-436
Rear Leaf Springs Heavy Duty rear leaf spring with rear helper spring. Recommended to be replaced in pairs. Used on 2005 & newer Bearcats.
Part Number# 12-430
Lenco Armored Vehicles
Page 13
Lenco 22.5” Wheel, Run-flat & Tire Assembly Complete replacement wheels that include run-flat inserts and tires, mounted, balanced, and painted to match your vehicle.
Lenco 22.5” BearCat Wheel Specially designed 22.5” BearCat steel rims. Rear wheel shown.
Rear U-Bolts, Nuts & Washer Set Heavy Duty, Grade 8 U-Bolts, deep nuts and washers for Lenco heavy Duty rear suspension. Available individually or as a complete kit.
Lenco 22.5” BearCat Run-flat Insert A run-flat device provides continued mobility in the event of partial or complete loss of tire air pressure. Installation Tools available separately. (Not shown) 6 run-flats required per vehicle.
Part Number# 12-432 U-bolts 4 Req’d. Part Number# 12-433 Deep Nuts 8 Req’d. Part Number# 12-434 Washers 8 Req’d.
Part Number# 19-243F Front Part Number# 19-243R Rear
Part Number# 19-106 Run-flat Part Number# 19-106T Tools
Part Number# 19-BC225F Front Part Number# 19-BC225R Rear
To Order Call: 1-800-444-5362
Page 14
Lenco 19.5” BearCat Wheel 19.5” BearCat Wheel. Front wheel shown.
Part Number# 12-F550RIM
Lenco 19.5” Run-flat Insert A run-flat device provides continued mobility in the event of partial or complete loss of tire air pressure. Installation Tools available separately. (Not shown) 6 run-flats required per vehicle.
Part Number# 19-206 Run-flat Part Number# 19-206T Tools
Lenco 19.5” Wheel, Run-flat &Tire Assembly Complete replacement wheels that include run-flat inserts and tires, mounted, balanced, and painted to match your vehicle.
Part Number# 19-BC195WRT
Lenco Armored Vehicles
Tire Valves Brass tire valves with seals. Front (R) & rear (L) tire valves shown.
Part Number# 19-24149 Front Part Number# 19-24215 Rear
Page 15
Spare Tire Mounting Hardware
Hardware used to mount optional inside spare tire.
Replacement parts only, inside tire mounting option cannot be added.
Part Number# 19-SQCAT148 Mounting Bolt Part Number# 19-335 Retaining Ring Part Number# 19-65115K33 Nut
12 Ton Bottle Jack, Lug Wrench & Extension All parts except Bottle Jack Handle are available separately.
Part Number# 19-555-13989 Bottle Jack Part Number# 12-875 Lug Wrench Part Number# 12-876 Lug Wrench Extension
Emergency Brake Adjusting Cable Please specify the length of emergency brake intermediate cable and the style of the adjuster when ordering.
Part Number# 12-098 51” Cable 2004 BearCat Part Number# 12-098 36” Cable 2005-06 BearCat Part number# 12-BRAKE02 29 5/8” Cable 2007 BearCat
To Order Call: 1 800.000.0000
Page 16
To Order Call: 1-800-444-5362
Group 3
ELECTRICAL
EXTERIOR &
INTERIOR
WINDSHIELD WIPER
SYSTEM
To Order Call: 1-800-444-5362
Page 18
Group 3 Index
Accessory Power Point .......................................................................................... 23 Flasher, Headlight & Tail Light ............................................................................... 26 Flasher, Turn Signal ............................................................................................... 22 Flashers, L.E.D., Strobe & Halogen ....................................................................... 25 Light, Back-up ........................................................................................................ 21 Light, Clearance ..................................................................................................... 22 Light, Fog/Driving ................................................................................................... 20 Light, High Mounted 3rd Brake............................................................................... 20 Light, Interior Red/White......................................................................................... 22 Light, L.E.D. Emergency ....................................................................................... 19 Light, License Plate ............................................................................................... 21 Light, Strobe........................................................................................................... 20 Light, Tail................................................................................................................ 21 Shoreline Parts....................................................................................................... 23 Siren P.A. System .................................................................................................. 24 Speakers ................................................................................................................ 24 Switch, Heated Windshield..................................................................................... 23 Switch, Toggle........................................................................................................ 23 Timer, Heated Windshield ...................................................................................... 22 Windshield Wiper Parts .......................................................................................... 26
Lenco Armored Vehicles
To Order Call: 1-800-444-5362
Page 19
L.E.D. Emergency Lights L.E.D. lighting technology available in four colors. Comes with gasket and mounting hardware. Measures 3” X 7”.
Part Number# 19-70C02SCR Clear Part Number# 11-348A Amber Part Number# 11-348 Red Part Number# 11-349 Blue
Clear L.E.D. Emergency Lights Clear lenses with Red or Blue L.E.D. lights. Comes with gasket and mounting hardware. Measures 3” X 7”.
Part Number# 19-317 Clear/Red Part Number# 19-318 Clear/Blue
Red L.E.D. Steady Burn Emergency Light Red L.E.D. steady burn emergency light for California applications. Comes with gasket and mounting hardware. Measures 3” X 7”.
Part Number# 19-253
Mini L.E.D. Emergency Lights Mini L.E.D. lighting technology available in two colors. Comes with gasket and mounting hardware. Measures 1 5/8” X 5 1/8”.
Part Number# 19-315 Red Part number# 19-318 Blue
Lenco Armored Vehicles
Page 20
Strobe Emergency Lights Strobe lighting technology available in four colors. Comes with gasket and mounting hardware. Measures 3” X 7”. Flasher unit sold separately, see page 25.
Part Number# 19-329 Amber Part Number# 19-330 Clear Part Number# 19-149 Red Part Number# 19-148 Blue
Grille Guard Strobe Emergency Lights Strobe Emergency lights that mount to the LENCO front grille guard. Hardware included.
Part Number# 19-102 Blue Part Number# 19-102R Red
Fog/Driving Lamp 55W Plasma Ion fog lamp or extreme white driving lamp assembly with black powder coated housing.
Part Number# 19-119 Fog Lamp Part Number# 11-5402 Driving Lamp (Not shown)
L.E.D. High Mounted Rear Light Bar L.E.D. technology incorporating a high mounted 3rd brake light as well as turn signals and emergency 4 way flashers.
Part Number# 11-250-4400 Used after 1/04/06 Part Number# 11-258 Used before 1/04/06 (Not shown)
Page 21
License Plate Lamp Assembly
Part Number# 11-120
Part Number# 11-173 Lamp & gasket Part Number# 11-174 Aluminum Guard
Rear Clearance Lamp Red LED clearance lamp with aluminum guard and gasket.
L.E.D. Stop, Tail, & Turn Signal Lamp
w/ Grommet
Part Number# 11-170
Back-up Lamp Assembly w/ Grommet
Part Number# 11-122
To Order Call: 1-800-444-5362
Page 22
Red/Clear Interior Lamp This lamp uses a push/push lens on/off function. Replacement lenses are available.
Part Number# 11-127 Lamp Assembly Part Number# 11-127CL Clear Lens Part Number# 11-127RL Red Lens
BearCat Roof Clearance Lamp Mounted above the windshield roof area. 5 required per vehicle.
Part Number# 11-482
Heated Windshield Timer Heated windshield timer used in BearCats with heated windshields.
Part Number# 11-198
Turn Signal L.E.D. Flasher Turn signal flasher used with L.E.D. stop and turn lights.
Part Number# 11-298
Lenco Armored Vehicles
Page 23
Shoreline Power Inlet Parts Electrical power inlet and weather cover for shoreline power and battery charge feature. Used with power inverter, see page 8.
Part Number# 11-193 Inlet Connector Part Number# 11-194 Cover Assembly
12 volt accessory power point Provides 12 volt power for plug in accessories.
Part Number# 11-103
Euro Lighted Rocker Switch Used for a variety of electrical applications in the Lenco BearCat.
Part Number# 11-201
Heated Windshield Switch Single or Double throw momentary rocker switch used in BearCats with heated windshields.
Part Number# 11-197 Double Throw Switch (Fits May 2006 to 2007 Bearcats) Part Number# 11-200 Single Throw Switch (Fits 2005 to May 2006 Bearcats)
To Order Call: 1-800-444-5362
Siren P.A. Amplifier Features Hands free radio, alert, air horn, manual, wail, yelp, & lower case phaser modes. Powers up to two speakers at 200 watts.
Part Number# 19-136 Complete Assembly Part Number# 19-136CHD Replacement Control Head
Siren/P.A. Speaker 100 watt Siren P.A. speaker. 2 per vehicle.
Part Number# 19-137
Page 24
4” Radio Speakers 4” 2-way coaxial speaker system. 120 watts. Used on BearCats built after January 16, 2007.
Part Number# 11-PLX-42
6” X 9” Radio Speakers 6” X 9” single cone radio speakers. Used on BearCats built before January 16, 2007.
Part Number# 11-483
Lenco Armored Vehicles
Page 25
L.E.D. Light Flasher Unit Eight Outlet, Two Channel LED Flasher, 120 Watts (60 Watts per channel), Synchronize Feature, 4 Scan-Lock™ Flash Patterns with Phase 1 and Phase 2 for Alternate or Simultaneously Flashing LED Light heads and Sun/Snow/Fog Pattern
Part Number# 11-347
Strobe Light Flasher Unit 4 Channel, 90 watt strobe pack with user-selectable flash patterns: dual, quad or random flash patterns. Three wire, shielded heavy-duty strobe cable offers connectors installed and is available in various lengths.
Part Number# 19-110
L.E.D. & Halogen Flasher Unit Eight Outlet Halogen/LED Flasher, 60 Watts per outlet, 2x2x2x2 Switching, 17 Selectable Flash Patterns
Part Number# 19-UFM8
2 Outlet Strobe Flasher Unit The Optimax series of power supplies are quality power supplies built to last. The RP242 offers 6 high intensity flash patterns, and 2 outlets to run any strobe heads, 40 watts of power. These power supplies also include selectable Day/Night (High/Low power) modes.
Part Number# 19-RP242
To Order Call: 1-800-444-5362
Page 26
Windshield Wiper Arms and Wiper Blades
Part Number# 12-091-20BLADE 2 req’d Part Number# 12-091-ARM 2 req’d
Windshield Washer Nozzle Hood mounted windshield washer nozzle assembly.
Part Number# 12-118S Nozzle Assembly Part Number# 12-118SN Replacement Jet
Headlight & Tail Light Alternating Flasher
Part Number# 19-141 Headlight Flasher (Top) Part Number# 19-143 Tail Light Flasher (Bottom)
Windshield Wiper Motors &
Windshield Wiper Control Module
Part Number# 12-091L Left Motor Assembly Part Number# 12-091R Right Motor Assembly Part Number# 12-091-SYNCTERM Sync. Module Part Number# 11-195 #8 Wiper Harness with Control box (Not shown)
Lenco Armored Vehicles
Group 4
EXTERIOR BODY,
DOORS & RELATED
PARTS
To Order Call: 1-800-444-5362
Page 28
Group 4 Index
Arms, Exterior Mirror ...........................................................................................35 Bolt, Interior Slide................................................................................................30 Bolt, Tow Loop ....................................................................................................38 Bumper Stop, Door & Hood ................................................................................29 Bumpers, Front Rubber.......................................................................................36 Cover, Gun-port ..................................................................................................37 Door Holder.........................................................................................................31 Door Locking Lever Exterior................................................................................31 Gas Spring, Hood ...............................................................................................29 Gun-ports ............................................................................................................37 Handle, Exterior L ...............................................................................................30 Handle, Interior Web ...........................................................................................30 Handle, Tool Box ................................................................................................32 Hooks, Tow .........................................................................................................35 Latch & Striker, Inside Front & Rear Door Jaw Type .........................................31 Latch, Inside Front & Rear Door Rotary ..............................................................30 Latch, Rear Door Rotary & Spring Type..............................................................31 Lock, Fuel Door...................................................................................................37 Mirror, Exterior ....................................................................................................34 Mud Flaps ...........................................................................................................38 Prop Rod, Hood ..................................................................................................30 Running Boards ..................................................................................................36 Side Steps...........................................................................................................36 Striker, Door........................................................................................................32 Tow Loops, Rear.................................................................................................35 Turret Hand Wheel Assembly .............................................................................34 Turret Parts ...................................................................................................32, 33
Lenco Armored Vehicles
Page 29
Hood Center Gas Spring Gas spring used to raise hood to safety catch when hood release is pulled. Used in conjunction with Ball Stud Mount.
Part Number# 12-194 Gas Spring Part Number# 12-424 Ball Stud Mount
Hood Side Gas Springs Gas Springs used to keep hood fully open. Used in conjunction with Hood Safety Prop Rod. Replace in pairs.
Part Number# 12-193BC 2 per vehicle Part Number# 12-196 13mm Ball Studs (not shown)
Door & Hood Bumper Stops Prevents doors & hood from damaging body when opening or closing.
Part Number# 12-426 As required, 2006 Bearcats & newer
To Order Call: 1-800-444-5362
Page 30
Exterior Door L Handle Chrome plated exterior door handle with key. Spare keys available. Early keyless “spin when locked” type also available.
Part Number# 12-133 L Handle Part Number# 12-FS887 Spare Key
Front & Rear Door Rotary Latch, Web Handle &
Slide Bolt Inside front & rear door opening, latching and locking parts. Available separately.
Part Number# 14-156 Left Rotary Latch Part Number# 14-157 Right Rotary Latch Part Number# 12-168 Web Handle Part Number# 12-135 Slide Bolt Please specify front or rear hinged doors when ordering.
Hood Safety Prop Rod & Retainer
Part Number# 27-SQCAT106 Prop Rod Part Number# 12-220 Prop Rod Retainer
Lenco Armored Vehicles
Rear Inside Door Latch Inside rotary latch and release for rear door
Part Number# 16-408 Rotary Latch & Release Part Number# 12-8594K27 Vinyl Cap Part Number# 12-128 Rear Door Spring Latch (Used on Bearcats up to 2004)
Outside Door Holder Used with door locking levers in rear hinged front doors and all rear cargo doors.
Part Number# 12-281
Exterior Door Locking Lever Door Locking Levers used with rear hinged front doors and all rear cargo doors.
Part Number# 12-160 Left Side Part Number# 12-161 Right Side
Front & Rear Door Jaw Type Latch & Striker
Used on Bearcats up to 2004.
Part Number# 12-404 Right Latch & Striker Part Number# 12-408 Left Latch & Striker Part Number# 12-168 Web Handle
To Order Call: 1-800-444-5362
Page 31
Page 32
Tool Box Paddle Handle Lockable paddle handle and gasket used to open front bumper mounted toolbox. Spare keys available.
Part Number# 14-120 Handle & Key Part Number# 14-120X Molded Handle Gasket Part Number# 14-510CH Spare Key
Door Striker Striker used on all BearCat door and turret latches. 5 per BearCat
Part Number# 14-143
Turret Hatch Lock Open Handle
Part Number# 16-408 Hatch Lock Part Number# 12-8594K27 Vinyl Cap Used in BearCats built after May 2007
Turret Hatch Lock Open Handle
Part Number# 12-11972-16 Hatch Lock Part Number# 12-8594K27 Vinyl Cap Used in BearCats built before May 2007 Supersedes to 16-408
Lenco Armored Vehicles
Page 33
Turret Spring Plunger
Part Number# 12-T103P
Turret Gear Lock
Part Number# 12-DS604
Part Number# 12-144
Law Enforcement Turret Gear Lock
To Order Call: 1-800-444-5362
Turret Hatch Tee Handle
Part Number# 12-90222A116
Page 34
Military Turret Gear Lock
Part Number# 12-TL006
Law Enforcement Turret Gear Lock
Part Number# 12-TL-107
Outside Rear View Mirrors Black 71/2” x 10 1/2” mirror in flat and convex styles. Stick-on wedge convex mirror not shown.
Part Number# 12-888B Drivers Side Part Number# 12-888D Passenger Side Part Number# 12-CIP4902 Stick-on Wedge Convex
Internal Turret Hand Wheel Assembly w/keyway
Part Number# 12-T108 Turret Gear Part Number# 12-427 Spoke Hand Wheel Part Number# 19-176 Boston Gear (not shown) Part Number# 12-440 Folding Handle (not shown)
Lenco Armored Vehicles
Page 35
Front Tow Hooks
Mounts to the top of the front bumper.
Part Number# 12-206R Right Tow Hook Part Number# 12-206L Left Tow Hook
Rear Tow Loops & Mounting Bolts Mounts to the rear corners of the BearCat.
Part Number# 12-212 Rear Tow Loop (2 Req’d) Part Number# 12-301 Rear Tow Loop Bolt (2 bolts per Tow Loop)
To Order Call: 1-800-444-5362
Outside Rear View Mirror Arms Solid steel shaft arms to mount outside mirrors. Replaces hollow shaft arms installed on earlier years.
Part Number# 12-SQCAT261 Fender Mounted Mirrors Part Number# 12-SQCAT267 Door Mounted Mirrors Available individually or in pairs.
Page 36
Lenco “List B” Side Step Package Heavy-duty aluminum grip channel side & rear step package used on most government BearCats. Top picture shows side view, bottom picture shows rear door steps.
Part Number# 12-088 Complete set (Please indicate side mount or top mount when ordering.)
Front Rubber Bumpers Available individually or in pairs.
Part Number# 12-174
Lenco “List A” Running Board Package Heavy-duty aluminum grip channel running boards standard on most BearCats. Top picture shows side view, bottom picture shows rear door steps and rear quarter panel side steps.
Part Number# 12-089 Complete set (Please indicate side mount or top mount when ordering.)
Lenco Armored Vehicles
Page 37
LENCO Rectangular Gunport & Turret Gunport
Rain Cover
Part Number# 13-GPRT001 Gunport Part Number# 27-GPRT012 Gunport Cover Part Number# 13-108 Replacement Bushing
To Order Call: 1-800-444-5362
Fuel Door Lock Spare keys available. Non-locking version available.
Part Number# 14-127 Lock Assembly Part Number# 14-C390A Spare Key Part Number# 14-127NL Non-locking style
LENCO Round Gunport & Turret Gunport Rain
Cover Replacement bushings available.
Part Number# 13-105 Gunport Part Number# 13-100 Gunport Cover Part Number# 13-108 Replacement Bushing
LENCO Mud flaps Available individually or in pairs.
Part Number# 12-200
Page 38
Lenco Armored Vehicles
Group 5
BODY
GLASS
To Order Call: 1-800-444-5362
Page 40
Group 5 Index
Glass, Front Door................................................................................................41 Glass, Rear Door ................................................................................................42 Glass, Sidewall ...................................................................................................41 Glass Installation Supplies ..................................................................................42 Windshields.........................................................................................................41
Contact Technical Services
At
1-800-444-5362
For installation information
Lenco Armored Vehicles
Page 41
BearCat Windshield
Part Number# 17-046 Left Windshield w/ sun band, 66mm Low Spall Part Number# 17-047 Right Windshield w/ sun band, 66mm Low Spall Part Number# 17-046H Left Heated Windshield w/ sun band, 66mm Low Spall Part Number# 17-047H Right Heated Windshield w/ sun band, 66mm Low Spall
BearCat Side Door Glass
Part Number# 17-048 Driver’s Door Glass (66mm) Part Number# 17-049 Passenger Door Glass (66mm)
ALL GLASS SHOWN IS CURRENT PRODUCTION. CALL ON GLASS FOR PREVIOUS YEARS
To Order Call: 1-800-444-5362
BearCat Sidewall Glass
Part Number# 17-050 Rear Sidewall Glass (66mm) (4 req’d per BearCat)
Page 42
Glass Installation Supplies We have a variety of installation supplies available to install your replacement glass. Call us for details.
Contact Technical Services
At
1-800-444-5362
For installation information
Lenco Armored Vehicles
BearCat Rear Door Glass
Part Number# 17-051 Rear Door Glass (66mm) (2 req’d per BearCat)
Group 6
INTERIOR PARTS
& TRIM
To Order Call: 1-800-444-5362
Page 44
Group 6 Index
Boot, 4WD Shift ..................................................................................................47 Ceiling Headliner Kit............................................................................................46 Ceiling Insulation Kit............................................................................................46 Counter Balance, Turret Hatch ...........................................................................48 Fire Extinguisher .................................................................................................48 Floor Mats, Front.................................................................................................46 Floor Mats, Rear .................................................................................................46 Gunner Stand, Law Enforcement........................................................................47 Gunner Stand, Military ........................................................................................47 Retainer, 4WD Shift Boot ....................................................................................47 Seats, Front ........................................................................................................45 Seats, Rear Bench..............................................................................................45
Lenco Armored Vehicles
Page 45
BearCat Front Seats Sold individually or in pairs.
Part Number# 16-110
Rear Bench Seats Heavy-duty vinyl covered bench seats. Right side seat with optional seat belts shown.
Part Number# 16-101 Right side cushion 12.5” X 69” Part Number# 16-101L Left side cushion 12.5” X 96.5”
Part Number# 16-VCSQCAT04 10” X 53.5”
Center Rear Bench Seats Heavy-duty vinyl covered bench seats. Available individually or in pairs.
To Order Call: 1-800-444-5362
BearCat Carpeted Front Floor Mats
Part Number# 12-466 Drivers Mat Part Number# 12-467 Passenger Mat
BearCat Carpeted Rear Floor Mat
Part Number# 12-474 Standard Rear Mat Part Number# 12-478 With Gunner Stand Part Number# 12-SQCAT112NV Navy BearCat
Page 46
Lenco Armored Vehicles
BearCat Ceiling Panels & Insulation Replacement ceiling panels and insulation available. (BearCats built after 10/01/06)
Part Number# 12-483L Law Enforcement Insulation Kit Part Number# 12-483M Military Insulation kit Part Number# 12-439L Law Enforcement Headliner Kit Part Number# 12-439M Military Headliner Kit Part Number# 15-408 Black E-Coat Screws
Page 47
Law Enforcement Pull-out Gunner Stand
Part Number# 27-STBC267
To Order Call: 1-800-444-5362
Military Gunner Stand
Part Number# 19-GSTAND08
Part Number# 19-183 Boot Part Number# 27-SQCAT106 Retainer
4WD Shift Boot and Retainer
Page 48
Counter Balance Turret Hatch Counter Balance (Will not fit early models)
Part Number# 12-CB05 Law Enforcement Part Number# 12-CB25 Military
Lenco Armored Vehicles
Fire Extinguisher 5 lb. chemical fire extinguisher.
Part Number# 12-AMX500T
Group 7
HEATER
&
AIR CONDITIONING
To Order Call: 1-800-444-5362
Page 50
Group 7 Index
Fittings, Bubble Crimp.........................................................................................52 Knob, Fan ...........................................................................................................51 Line, A/C .............................................................................................................52 Motor, A/C Heater Blower ...................................................................................51 Rear A/C Heater Complete Units ........................................................................51 Receiver/Dryer A/C .............................................................................................52 Switch, Fan .........................................................................................................51 Switch, Toggle Selector ......................................................................................52 Wheel, Blower Motor...........................................................................................51
Lenco Armored Vehicles
Page 51
BearCat Floor Mounted Rear Heater Air
Conditioning Unit
Part Number# 10-4210235
BearCat Wall Mounted Rear Heater Air
Conditioning Unit
Part Number# 10-118
Fan Switch & Knob for Floor Mounted Heater
A/C Unit
Part Number# 10-4100066 Fan Switch Part Number# 10-4100038 Fan Switch Knob
Fan Motor for Floor Mounted Heater A/C Unit
Part Number# 10-4100010 Fan Motor Part Number# 10-4100000 Blower Wheel (Not shown)
To Order Call: 1-800-444-5362
Page 52
Toggle Switch for Floor Mounted Heater A/C Unit
Part Number# 11-202 Toggle switch
Lenco A/C Receiver/Dryer Modified A/C Receiver/Dryer to accommodate rear heating and air conditioning unit. Fits all years.
Part Number# 10-170
Lenco A/C Line Modified A/C line to accommodate rear heating and air conditioning unit.
Part Number# 10-176
Assorted Bubble Crimp A/C Line fittings (Bubble crimp tool required)
Part Number# 10-140 90* Female Fitting Part Number# 10-156 Straight Female Fitting Part Number# 10-168 Straight Male Fitting Part Number# 10-172 45* Female Fitting
Lenco Armored Vehicles
Page 53
Complete Index
Accessories Index............................................................................................................3 Accessory Power Point............................................................................................ …..23 Arms, Exterior Mirror................................................................................................. ….35 Back-up Camera..............................................................................................................9 Bolt, Interior Slide ..........................................................................................................30 Bolt, Tow Loop...............................................................................................................35 Boot, 4WD Shift .............................................................................................................47 Bumper Stop, Door & Hood ...........................................................................................29 Bumpers, Front Rubber .................................................................................................36 Ceiling Headliner Kit ......................................................................................................46 Ceiling Insulation Kit ......................................................................................................46 Coil Springs ...................................................................................................................12 Combustible Gas Monitor ................................................................................................5 Cooper Sling....................................................................................................................5 Counter Balance, Turret Hatch ......................................................................................48 Cover, Gunport ..............................................................................................................37 Door Holder ...................................................................................................................31 Door Locking Lever Exterior ..........................................................................................31 Emergency Brake Parts.................................................................................................16 Fire Extinguisher............................................................................................................48 Fittings, Bubble Crimp ...................................................................................................52 Flasher, Headlight & Tail Light.......................................................................................26 Flasher, Turn Signal ......................................................................................................22 Flashers, L.E.D. Strobe & Halogen................................................................................25 Floor Mats, Front ...........................................................................................................46 Floor Mats, Rear ............................................................................................................46 Front Bumper Receiver....................................................................................................8 Front Ram Bar .................................................................................................................8 Gas Spring, Hood ..........................................................................................................29 Glass, Front Door ..........................................................................................................41 Glass Installation Supplies.............................................................................................42 Glass, Rear Door ...........................................................................................................42 Glass, Sidewall ..............................................................................................................41 Go-Light & Replacement Parts ........................................................................................4 Gunner Stand, Law Enforcement ..................................................................................47
To Order Call: 1-800-444-5362
Page 54
Complete Index (cont’d) Gunner Stand, Military ...................................................................................................47 Gun-ports.......................................................................................................................37 Handle, Exterior L ..........................................................................................................30 Handle, Interior Web......................................................................................................30 Handle, Tool Box Paddle ...............................................................................................32 Hooks, Front Tow ..........................................................................................................35 Intercom System..............................................................................................................5 Jack ...............................................................................................................................15 Knob, Fan ......................................................................................................................51 Latch & Striker, Inside Front & Rear Door Jaw Type .....................................................31 Latch, Inside Front & Rear Door Rotary.........................................................................30 Latch, Rear Door Rotary & Spring Type ........................................................................31 Leaf Springs ..................................................................................................................12 Light, Back-up................................................................................................................21 Light Bars ........................................................................................................................6 Light, Clearance ......................................................................................................21, 22 Light, Fog/Driving...........................................................................................................20 Light, High Mounted 3rd Brake ......................................................................................20 Light, Interior Red/White ................................................................................................22 Light, L.E.D. Emergency................................................................................................19 Light, License Plate .......................................................................................................21 Light, Strobe ..................................................................................................................20 Light, Tail .......................................................................................................................21 Line, Air Conditioning.....................................................................................................52 Lock, Fuel Door .............................................................................................................37 Lug Wrench ...................................................................................................................15 Mirror, Exterior ...............................................................................................................34 Motor, A/C Heater Blower..............................................................................................51 Mud Flaps......................................................................................................................38 Power Inverter .................................................................................................................6 Prop Rod, Hood.............................................................................................................30 Radiation Detection Package ..........................................................................................6 Radio Antenna.................................................................................................................8 Rear A/C Heater Complete Units...................................................................................51
Lenco Armored Vehicles
Page 55
Complete Index (cont’d)
Receiver/Dryer A/C........................................................................................................52 Relay, Heated Windshield .............................................................................................22 Retainer, 4WD Shift Boot...............................................................................................47 Run-flat Inserts .........................................................................................................13,14 Running Boards.............................................................................................................36 Seats, Front ...................................................................................................................45 Seats, Rear Bench.........................................................................................................45 Shock Absorbers ...........................................................................................................12 Shoreline Parts ..............................................................................................................23 Side Steps .....................................................................................................................36 Siren P.A. System..........................................................................................................24 Skip Round Shield & Brackets.........................................................................................7 Spare Tire Mounting Hardware......................................................................................15 Speakers .......................................................................................................................23 Striker, Door ..................................................................................................................32 Switch, Fan....................................................................................................................51 Switch, Heated Windshield ............................................................................................23 Switch, Toggle ...............................................................................................................23 Switch, Toggle Selector .................................................................................................52 Thermal Camera System.................................................................................................4 Timer, Heated Windshield .............................................................................................22 Tire & Wheel Assembly ............................................................................................13,14 Tire Valves.....................................................................................................................15 Tow Loops, Rear ...........................................................................................................35 Trailer Hitch .....................................................................................................................7 Trailer Wiring ...................................................................................................................7 Turret Hand Wheel Assembly........................................................................................34 Turret Parts...............................................................................................................32,33 U-Bolts...........................................................................................................................13 Wheel, Blower Motor .....................................................................................................51 Wheels......................................................................................................................13,14 Winch...............................................................................................................................4 Windshields ...................................................................................................................41 Windshield Wiper Parts .................................................................................................26
Lenco Armored Vehicles To Order Call: 1-800-444-5362
10 Betnr Industrial Drive Pittsfield, MA 01201
Phone: 413-443-7359 Ext. 125 Toll Free: 800-444-5362 Ext. 125
Fax: 413-442-9612 E-mail: [email protected]
Lenco Armored Vehicles