MM--11®® CCoott FFaasstteenneerr

MMaaiinntteennaannccee MMaannuuaall

637363766381

EN

6373-009-002 Rev E.0 2020/04

SSyymmbboollss

Operating instructions/Consult instructions for use

General warning

Caution

CE mark

Authorized representative in the European Community

European medical device

Catalogue number

Lot (batch) code

Serial number

For US patents see www.stryker.com/patents

Manufacturer

Date of manufacture

Safe working load

6373-009-002 Rev E.0 EN

TTaabbllee ooff CCoonntteennttss

Warning/Caution/Note Definition ..............................................................................................................................2Summary of safety precautions ................................................................................................................................2

Introduction ...............................................................................................................................................................3Product description .................................................................................................................................................3Indications for use...................................................................................................................................................3Expected service life ...............................................................................................................................................3Disposal/recycle .....................................................................................................................................................3Contraindications ....................................................................................................................................................3Specifications .........................................................................................................................................................3Product illustration ..................................................................................................................................................4Contact information.................................................................................................................................................5Serial number location.............................................................................................................................................6Date of manufacture................................................................................................................................................6Cot compatibility .....................................................................................................................................................6

Center mount cot fastener, DIN guides ....................................................................................................................7Center mount cot fastener, straight guide without belts ...........................................................................................8Center mount cot fastener, narrow guide .................................................................................................................9Foot end latch assembly.........................................................................................................................................10Head end hook assembly, right ..............................................................................................................................11Head end hook assembly, left ................................................................................................................................12Pull pin assembly ....................................................................................................................................................13

6373-009-002 Rev E.0 1 EN

WWaarrnniinngg//CCaauuttiioonn//NNoottee DDeeffiinniittiioonnThe words WWAARRNNIINNGG, CCAAUUTTIIOONN, and NNOOTTEE carry special meanings and should be carefully reviewed.

WWAARRNNIINNGG

Alerts the reader about a situation which, if not avoided, could result in death or serious injury. It may also describepotential serious adverse reactions and safety hazards.

CCAAUUTTIIOONN

Alerts the reader of a potentially hazardous situation which, if not avoided, may result in minor or moderate injury to theuser or patient or damage to the product or other property. This includes special care necessary for the safe and effectiveuse of the device and the care necessary to avoid damage to a device that may occur as a result of use or misuse.

NNoottee -- Provides special information to make maintenance easier or important instructions clearer.

SSuummmmaarryy ooff ssaaffeettyy pprreeccaauuttiioonnss

Always read and strictly follow the warnings and cautions listed on this page. Service only by qualified personnel.

WWAARRNNIINNGG• Install the cot fastener by qualified personnel only. Improper installation could result in injury to the patient or operator.• Always make sure that all cots meet the installation specifications for the Stryker cot fastener system.• Always replace the cot fastener if it has been involved in an accident to avoid the risk of injury due to product damage.

CCAAUUTTIIOONN• Improper usage of the product can cause injury to the patient or operator. Operate the product only as described in this

manual.• Do not modify the product or any components of the product. Modifying the product can cause unpredictable operation

resulting in injury to patient or operator. Modifying the product also voids its warranty.

EN 2 6373-009-002 Rev E.0

IInnttrroodduuccttiioonnThis manual assists you with the operation or maintenance of your Stryker product. Read this manual before operating ormaintaining this product. Set methods and procedures to educate and train your staff on the safe operation or maintenanceof this product.

CCAAUUTTIIOONN• Improper usage of the product can cause injury to the patient or operator. Operate the product only as described in this

manual.• Do not modify the product or any components of the product. Modifying the product can cause unpredictable operation

resulting in injury to patient or operator. Modifying the product also voids its warranty.

NNoottee• This manual is a permanent part of the product and should remain with the product even if the product is sold.• Stryker continually seeks advancements in product design and quality. This manual contains the most current product

information available at the time of printing. There may be minor discrepancies between your product and this manual. Ifyou have any questions, contact Stryker Customer Service or Technical Support at 1-800-327-0770.

PPrroodduucctt ddeessccrriippttiioonn

The Stryker Model 6373/6376/6381 MM--11® Cot Fastener holds a compatible ambulance cot in an emergency vehicle forpatient transport purposes. The cot fastener performs this function after the user manually loads the compatible cot into theemergency vehicle and guides it into the cot fastener.

IInnddiiccaattiioonnss ffoorr uussee

The Stryker Model 6373/6376/6381 is a manual, ambulance cot fastener that secures a compatible ambulance cot duringtransport. The cot fastener is intended to be used in pre-hospital environments, in emergency and non-emergencyapplications. Operate the product by trained professionals only. This includes emergency medical service and medical firstresponders.

EExxppeecctteedd sseerrvviiccee lliiffee

Cot fasteners have a seven year expected service life under normal use conditions and with appropriate periodicmaintenance.

DDiissppoossaall//rreeccyyccllee

Always follow the current local recommendations and/or regulations governing environmental protection and the risksassociated with recycling or disposing of the equipment at the end of its useful life.

CCoonnttrraaiinnddiiccaattiioonnss

None known.

SSppeecciiffiiccaattiioonnss

Model 6373 - tray mounted cot fastener (6373-000-000)

6376 - floor mounted cot fastener (6376-000-000)

6373-009-002 Rev E.0 3 EN

6381 - floor mounted cot fastener (6381-000-000)

Compatibility See Cot compatibility (page 6)

The Model 6100 MM--11® Roll-In System cot, in combination with a Model 6373/6376/6381 MM--11 Cot Fastener System, isdesigned in accordance to BS EN 1789, Medical Vehicles and their Equipment - Road Ambulances. The cot fastenersystem must be installed by qualified personnel to be in conformance to this standard. 1/4 in. steel backing plates (orequivalent) are required beneath the mounting surface (ambulance floor or tray system) at all mounting points. Beforeputting the system into service, test the installation using BS EN 1789 as a minimum.

The Model 6100 MM--11 Roll-In System cot, equipped with the AS/NZS 4535 upgrade, in combination with a Model 6373/6376/6381 MM--11 Cot Fastener System, is designed in accordance to AS/NZS 4535 Australian/New Zealand Standard -Ambulance Restraint Systems. The cot fastener system must be installed by qualified personnel to be in conformance tothis standard. 1/4 in. steel backing plates (or equivalent) are required beneath the mounting surface (ambulance floor ortray system) at all mounting points. Before putting the system into service, test the installation using AS/NZS 4535 as aminimum.

Side restraint belts are required to conform to BS EN 1789 Medical Vehicles and their Equipment - Road Ambulances. Siderestraint belts are not required for applications where this standard does not apply.

EEnnvviirroonnmmeennttaall ccoonnddiittiioonnss OOppeerraattiioonn SSttoorraaggee aanndd ttrraannssppoorrttaattiioonn

Temperature 130 °F(54 °C)

-30 °F (-34 °C)

130 °F(54 °C)

-30 °F (-34 °C)

Relative humidity 93%

0%

93%

0%

Atmospheric pressure 1060 hPa

700

1060 hPa

700

PPrroodduucctt iilllluussttrraattiioonn

AB C

E

F G

B

D

A

FFiigguurree 11 –– MM--11® CCoott FFaasstteenneerr

A Guide railB Front hookC BumperD Head end

EN 4 6373-009-002 Rev E.0

E Foot endF Red release buttonG Latch housing

CCoonnttaacctt iinnffoorrmmaattiioonn

Contact Stryker Customer Service or Technical Support at: 1-800-327-0770.

Stryker Medical3800 E. Centre AvenuePortage, MI 49002USA

NNoottee -- The user and/or the patient should report any serious product-related incident to both the manufacturer and theCompetent authority of the European Member State where the user and/or patient is established.

To view your operations or maintenance manual online, see https://techweb.stryker.com/.

Have the serial number (A) of your Stryker product available when calling Stryker Customer Service or Technical Support.Include the serial number in all written communication.

6373-009-002 Rev E.0 5 EN

SSeerriiaall nnuummbbeerr llooccaattiioonn

A

FFiigguurree 22 –– SSeerriiaall nnuummbbeerr llooccaattiioonn

DDaattee ooff mmaannuuffaaccttuurree

The year of manufacture is the first 2 digits of the serial number.

CCoott ccoommppaattiibbiilliittyy

The Stryker Model 6373, 6376, and 6381 MM--11 Cot Fastener systems are compatible only with cots that conform to theinstallation specifications.

WWAARRNNIINNGG• Install the cot fastener by qualified personnel only. Improper installation could result in injury to the patient or operator.• Always make sure that all cots meet the installation specifications for the Stryker cot fastener system.• Always replace the cot fastener if it has been involved in an accident to avoid the risk of injury due to product damage.

Stryker

• Model 6100 MM--11 Roll-In System

Ferno-Washington

• Model X-2*

NNoottee -- * 2000 model year or earlier. Stryker is not responsible for changes in specifications to other manufacturer’s cots.

EN 6 6373-009-002 Rev E.0

CCeenntteerr mmoouunntt ccoott ffaasstteenneerr,, DDIINN gguuiiddeess6373-010-010 Rev AB (Reference only)

IItteemm NNuummbbeerr NNaammee QQuuaannttiittyyA 0007-086-000 Truss head torx screw 4C 0037-235-000 Square plug 2D 6372-010-011 Foot end latch assembly (page 10) 1E 6372-010-014 Head end hook assembly, right (page

11)1

F 6372-010-015 Head end hook assembly, left (page 12) 1G 637300010926 6373 tag, serial number 1H 0025-079-000 Blind rivet 4K 6372-090-002 Label, housing 1L 6373-090-001 Label, specification 1M 6373-010-051 DIN rail weldment 1T 6372-010-020 MM--11 fastener spacer 1V 639000010901 Label, EAR 1W 637300010902 Label, translation 1

6373-009-002 Rev E.0 7 EN

CCeenntteerr mmoouunntt ccoott ffaasstteenneerr,, ssttrraaiigghhtt gguuiiddee wwiitthhoouutt bbeellttss6376-010-010 Rev AB (Reference only)

IItteemm NNuummbbeerr NNaammee QQuuaannttiittyyA 0007-086-000 Truss head torx screw 4B 0037-235-000 Square plug 2C 6372-010-011 Foot end latch assembly (page 10) 1D 6372-010-014 Head end hook assembly, right (page

11)1

E 6372-010-015 Head end hook assembly, left (page 12) 1F 6372-010-051 Straight rail weldment 1G 6373-090-001 Label, specification 1H 6372-090-002 Label, housing 1M 637600010926 6376 tag, serial number 1N 0025-079-000 Blind rivet 6P 6372-010-020 MM--11 fastener spacer 2S 639000010901 Label, EAR 1T 639000010902 Label, translation 1

EN 8 6373-009-002 Rev E.0

CCeenntteerr mmoouunntt ccoott ffaasstteenneerr,, nnaarrrrooww gguuiiddee6381-010-010 Rev AB (Reference only)

IItteemm NNuummbbeerr NNaammee QQuuaannttiittyyA 0007-086-000 Truss head torx screw 4B 0037-235-000 Square plug 2C 6372-010-011 Foot end latch assembly (page 10) 1D 6372-010-014 Head end hook assembly, right (page

11)1

E 6372-010-015 Head end hook assembly, left (page 12) 1F 6381-010-051 DIN rail weldment 1G 6373-090-001 Label, specification 1H 6372-090-002 Label, housing 1M 638100010926 6381 tag, serial number 1N 0025-079-000 Blind rivet 6P 6372-010-020 MM--11 fastener spacer 2S 639000010901 Label, EAR 1T 639000010902 Label, translation 1

6373-009-002 Rev E.0 9 EN

FFoooott eenndd llaattcchh aasssseemmbbllyy6372-010-011 Rev B (Reference only)

IItteemm NNuummbbeerr NNaammee QQuuaannttiittyyA 0001-030-000 Flat head cap screw 4B 0001-140-000 Flat head cap screw 2C 0011-065-000 Washer 1E 0028-303-000 Truarc ring 1G 6372-010-012 Rotary latch assembly, right 1H 6372-010-050 Bottom plate weldment 1J 6372-110-066 Casting foot latch housing 1K 6372-010-077 Release button 1M 6372-010-080 Clevis pin 1N 6372-010-081 Wear block 2

EN 10 6373-009-002 Rev E.0

HHeeaadd eenndd hhooookk aasssseemmbbllyy,, rriigghhtt6372-010-014 Rev C (Reference only)

IItteemm NNuummbbeerr NNaammee QQuuaannttiittyyA 0004-460-000 Button head cap screw 1B 0014-020-000 Washer 1C 0014-021-000 Nylon washer 2D 0028-181-000 Truarc ring 1E 0056-026-000 Bumper 1F 6372-010-016 Pull pin assembly (page 13) 1G 6372-010-087 Flip-up hook 1H 6372-010-091 Clevis pin 1J 6372-210-065 Casting head retaining hook 1

6373-009-002 Rev E.0 11 EN

HHeeaadd eenndd hhooookk aasssseemmbbllyy,, lleefftt6372-010-015 Rev C (Reference only)

IItteemm NNuummbbeerr NNaammee QQuuaannttiittyyA 0004-460-000 Button head cap screw 1B 0014-020-000 Washer 1C 0014-021-000 Nylon washer 2D 0028-181-000 Truarc ring 1E 0056-026-000 Bumper 1F 6372-010-016 Pull pin assembly (page 13) 1G 6372-010-087 Flip-up hook 1H 6372-010-091 Clevis pin 1J 6372-210-066 Casting head retaining hook 1

EN 12 6373-009-002 Rev E.0

PPuullll ppiinn aasssseemmbbllyy6372-010-016 Rev A (Reference only)

IItteemm NNuummbbeerr NNaammee QQuuaannttiittyyA 0038-469-000 Compression spring 1B 6372-010-088 Pull pin housing 1C 6372-010-089 Ball knob 1D 6372-010-090 Pin 1

6373-009-002 Rev E.0 13 EN

Stryker Medical3800 E. Centre AvenuePortage, MI 49002USA

6373-009-002 Rev E.0WCR: AC.3

2020/04