PPI Crane
PPI have wide range of cranes, jib cranes, monorails
& goods hoist coming from Germany, France,
Finland, Italy, United Kingdom and Taiwan. PPI can
assist customers to decide on which type of hoist is
the most suitable for them since we have wide range
of hoist depends on customer's budget.
Single Ginder Crane
PPI Single girder cranes are the most economical
purchase for capacities up to 10 tons and 30 m.
spans.
These advantages are:
It is the most economical solution in buildings with 30m width.
Much cheaper than a double girder model.
Type of Crane
Double Girder Crane
PPI Double Girder Cranes are frequently used in
capacities over 10 tons and or spans of 18 m. They
have extremely high hook lift because the hook can be
pulled up between the girders.
These advantages are:
Higher lifting, since the hook can be hoisted up between the main girders.
The box girder design suitable for heavy usage applications.
A Frame
PPI builds a complete range of A FRAME/gantry
cranes including single girder, double girder, double
leg and single leg.
Advantages A FRAME/Gantry Cranes are:
Can be used where runway beams are not able to be built.
Usually are used at outdoor due to space limitation and the capacity more than 5 tons.
JIB Crane
PPI builds a complete range of JIB CRANE for indoor or outdoor used.
Advantages JIB CRANE are:
Can be used in a very constrain space where there are a lot of machinery. Usually are used beside the machine where overhead cranes are not possible to reach.
Goods Hoist
PPI builds GOODSHOIST to hoist heavy goods
between two or more levels.
Advantages of GOODSHOIST are:
Can be used to transport heavy goods like raw material/material from ground floor to second or
third floor.
Usually are used at in shops such like restaurants, car spare parts dealers, light shops supplier and etc.
Our Services
Registration For The Certificate Of Fitness/ PMA For The Crane
Please be informed that all the hoist / cranes using electricity are needed to register with Department Of
Occupational Safety And Health [ DOSH ] OR Jabatan Keselamatan dan Kesihatan Pekerjaan (JKKP).
PPI assists customers to have their crane/cranes register. Once the crane/cranes are registered with
DOSH/JKKP.The Certificate Of Fitness[ PMA ] on the crane/ cranes will be issued to the customer.
The Certificate Of Fitness for the crane will expire every 15 months. Is the responsibility of the owner
the get their cranes serviced before the expiry.
If the machine is not in tip top condition DOSH/ JKKP will have the right not to renew the Certificate
Of Fitness [ PMA ] for the cranes.
Below are summary of the steps that are to be taken during the registration process:-
STEPS TO REGISTER THE JIB CRANE/CRANE/MONORAIL BELOW 4 TON. Prepare and submit full set of document for new PMA Licence registration. ( Jib-crane/crane/monorail)
Job scope:-
To prepare drawing and calculation for the jib crane/crane/monorail. To send the drawing and calculation for PE endorsement. To send the drawing and calculation to JKKP STATE OFFICE To arrange the JKKP officer to site and inspect the jib-crane/crane/monorail. To follow-up with JKKP officer for the PMA licence.
STEPS TO REGISTER THE JIB CRANE/CRANE/MONORAIL ABOVE 4 TON. Prepare and submit full set of document for new PMA Licence registration. ( Jib-
crane/crane/monorail)
Job scope:-
To prepare drawing and calculation for the jib crane/crane/monorail. To send the drawing and calculation to Putrajaya for design approval. To send the drawing and calculation to JKKP STATE OFFICE. To arrange the JKKP officer to site and inspect the jib crane/crane/monorail. To follow-up with JKKP officer for the PMA licence.
Renewal for PMA / PMT Licences
Sample of PMA Sample of PMT
Install Crane
PPI provides manpower to install new/old cranes for
customers in Malaysia including Sabah and Sarawak.
PPI with good network, PPI are able to repair most
of the brands of cranes. Example: DEMAG,
KONECRANE, STAHL, HITACHI, KITO,
MISIA and etc.
Modification & Relocation Crane
PPI provides service to do modification & relocation of
Cranes.PPI have the expertise to downgrade & upgrade
the capacity of the existing cranes with proper
modification in terms of the safety aspects. After the
modification, new sets of documents will be submitted to
JKKP/DOSH for new approval on the modified crane.
During the load test, the officer from JKKP/DOSH will
witness the test. After the load test, the new JKKP/ PMA
license will be issue to the crane owner.
Buy & Sell Recond Crane
PPI do buy & sell re-condition crane to customer who
has limited budget.PPI will make sure units we
purchase does have the hoists certificate from the
manufacturer as it is part of the document requires by
JKKP/DOSH for PMA registration.
Load Test
PPI provide load testing up to 100 ton. The steps in
the load test are equivalent to the requirement by
JKKP/ DOSH.
PPI was founded by Mr. Felix Low C.H. We already have more than 11 years in the cranes industry.
PPI main business activities are as followings :-
1. Manufacturing of cranes, jib cranes, monorails & goods hoist.
2. Assists customers to register the cranes , jib cranes , monorails & goods hoist.
3. Assists customers to renew their existing cranes , jib cranes, monorails & goods hoist.
4. We provide cranes services for hoist brand such like DEMAG,KONE,STAHL and others.
5. We provide load test in accordance to JKKP/DOSH requirements.
PPI have a team of qualified Professional Engineers that are looking after each crane coming from our
factory.PPI do recommends the most economical & reliable design to all of customers.
PPI have wide range of hoist coming from Germany, France, Finland, Italy, United Kingdom and Taiwan. PPI
can assist customers to decide on which type of hoist is the most suitable for them since we have wide range of
hoist depends on customer's budget.
PPI believe that business relationship with the customer is the most important factor in order to be successful as
such we are willing to provide best and speedy services to our customer so that they will be business deals in the
near future. When customer call for a quotation. We will always try to be the first to respond as we understand
the urgency as most of the tenders often close in a very short period of time.
Our commitment to customer service
We're constantly talking with our customers so we can improve our hoist /cranes design and our services.
No 74, Jalan Rodat 20/KU5, Bandar Bukit Raja, 41050, Klang, Selangor, Malaysia. www.ppicrane.com
