MANUAL NUMBER APX20-LP110618 · MANUAL NUMBER APX20-LP110618 EFFECTIVITY: 11-06-2018 APX20-LP...

LIFT-A-LOFT APX20-LP Diesel

MANUAL NUMBER APX20-LP110618 EFFECTIVITY: 11-06-2018

APX20-LP Scissor Lift Vehicle

PARTS MANUAL

APX20-LP1063 & Up

REV 04

LIFT-A-LOFT CORPORATION9501 SOUTH CENTER ROAD MUNCIE, IN 47302-9443

P.O. BOX 2645 MUNCIE, IN 47307-0645

Phone Number (765) 288-3691 Fax Number (765) 284-1023

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 CONTENTS

Page 1 11-06-2018

ILLUSTRATED PARTS LIST

CHAPTER 4 Section Page INTRODUCTION ........................................................................................ 1 .................. 1

1. Purpose ...................................................................................... 1 .................. 1 2. How to Use this Chapter ............................................................. 1 .................. 1

A. Figures/Drawings ............................................................. 1 .................. 1 3. How to Use the Part Number Listing Section .............................. 1 .................. 1

A. Find L-A-L Part Number................................................... 1 .................. 1 B. Superseded Parts ............................................................ 1 .................. 2 C. Ordering Procedure ......................................................... 1 .................. 2

UNIT I.D. STAMP & PLATE ....................................................................... 1 .................. 4 VENDOR IDENTIFICATION ....................................................................... 2 .................. 1

1. Vendor List Alphabetical ............................................................. 2 ................. 1 2. Vendor List Numerical ................................................................ 2 ................ 10

NUMERICAL PARTS LISTS ...................................................................... 3 .................. 1

1. Purpose ...................................................................................... 3 .................. 1 2. L-A-L Numerical Parts List ........................................................... 3 .................. 2

DETAILED PARTS LIST WITH FIGURES ................................................. 4 .................. 1

Fig 1. APX20-LP Scissor Lift .............................................................. 4 .................. 3 Fig 2. HCM129 Traversing Cylinder .................................................... 4 .................. 4 Fig 3. HCM122D Cylinder- Steering .................................................... 4 .................. 6 Fig 4. HCM212A Stabilizer Cylinder .................................................... 4 .................. 8

Fig 5. HV316-12VA-5.0 Main Holding Valve ....................................... 4 ................ 10 Fig 6. HCM211 Main Lift Cylinder ....................................................... 4 ................ 12

Fig 7. ST173-6 Brake Master Cylinder ................................................ 4 ................ 14 Fig 8. ST173-5 Brake Booster Assembly ............................................ 4 ................ 16 Fig 9. ESB703 Upper Control Pendant ............................................... 4 ................ 18 Fig 10. HP118 Compressor Hydraulic Motor ......................................... 4 ................ 20 Fig 11. PM11A Compressor .................................................................. 4 ................ 22

VEHICLE ASSEMBLY DRAWINGS .................................. END OF CHAPTER 4, SECT 4

ILLUSTRATED PARTS LIST

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 CONTENTS

Page 2 11-06-2018

VEHICLE ASSEMBLY DRAWINGS

DRAWING # TITLE REVISION

A37461GA MAGNETIC SWITCH ASSEMBLY 00B30172GA A/C HOSE KIT 00B39270GA UPPER PENDANT CONTROLLER ASSY 00B39373GA STABILIZER HARNESS 00B39374GA UPPER CONTROL STATION HARNESS 00B41994GA CHASSIS WIRE HARNESS 00B42852GA UPPER CONTROL STATION PENDANT 00C24774GA 110VAC JUNCTION BOX 01C24998 MIRROR OPTION KIT 00C39365GA-GB BRAKE LINE LAYOUT 00C44319GA ENGINE WIRE HARNESS 00D24997 WINDOW KIT 00D24999GA--GF DOOR KIT 05D26542GA FRONT AXLE ASSEMBLY 05D38190GA A/C OPTION KIT 01D39105GA SCISSOR ASSEMBLY 04D39126GA PLATFORM ASSEMBLY-TRAVERSING 05D39249GA LOWER ENCLOSURE ASSEMBLY-TRAVERSE 04D39258GA-GB UPPER CONTROL STATION 02D39262GA AIR FITTING LAYOUT 03D41600GA-GB STAGE 1 ASSEMBLY 04D41601GA-GB STAGE 2 ASSEMBLY 05D41602GA-GB STAGE 3 ASSEMBLY 04D41603GA-GB CAB ASSEMBLY 03D41604GA--GD DASH ASSEMBLY 05D41605GA--GG HYDRAULIC SCHEMATIC/FITTING LAYOUT 03D41606 WIRING DIAGRAM/SCHEMATIC 05D41607GA AIR FITTING LAYOUT 03D41608GA-GB DRESS KIT 03D42850GA AIR COMPRESSOR KIT 02D42854GA LOWER ENCLOSURE ASSEMBLY - FIXED 02D42855GA PLATFORM ASSEMBLY-FIXED 02D42981GA ENGINE KIT - DIESEL 03D44320GA ENGINE CARRIAGE ASSEMBLY-DIESEL 00D44321GA REAR AXLE ASSEMBLY 01UMA0266 MANIFOLD ASSEMBLY-FIXED PLATFORM 00UMA0271 MANIFOLD ASSEMBLY-TRAVERSING PLAT. 00

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 1

Page 1 11-06-2018

INTRODUCTION

1. PURPOSE The Illustrated Parts Chapter is intended to be used in provisioning, requisitioning, and in issuing replaceable parts. This listing is also useful for part identification and location.

2. HOW TO USE THIS CHAPTER

To find information on a part to be repaired, replaced, or serviced follow the information below: A. FIGURES/DRAWINGS:

(1) Begin by finding the part on a parts drawing (Section 4) or an included figure. More detailed information may be found on the figures with parts breakdowns.

(2) These drawings will picture the assemblies and will allow you to find the part

and the LIFT-A-LOFT Part Number. You may then choose to order the part from the LIFT-A-LOFT part number or reference it to a vendor part number.

3. HOW TO USE THE PART NUMBER (NUMERICAL) LISTING SECTION

A. FIND L-A-L PART NUMBER (OR SUB-ASSEMBLY PART NUMBER) (1) Find L-A-L number from drawing or figure.

(2) The L-A-L number is in the first column, the second column contains drawing

number or figure number, the third column contains item number as it appears on a drawing or figure, the fourth column gives a physical description of the part, the fifth column contains the quantity needed for this application, the sixth column contains the vendor part number, the seventh column contains the vendor number, and the eighth and last column contains a space for the airline number.

(3) Some vendor supplied parts breakdowns do not carry a L-A-L part number

and will only have a vendors part number only. (4) Some parts will have only a L-A-L part number, these items are created

entirely by Lift-A-Loft or are modified by Lift-A-Loft in such a way that the original identity is lost.

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 1

Page 2 11-06-2018

B. SUPERSEDED PARTS

Units in the field may contain older parts no longer used in the manufacturing of current units. Parts will be replaced (without notice) with current technology as replacements are required. This manual includes information on the standard APX-LP. When looking up part numbers consider which unit you have and the options which are included with your unit.

C. ORDERING PROCEDURE: (1) TO ORDER FROM LIFT-A-LOFT

Trace the part or assembly to the lowest, most specific level (e.g. drawing, figure, subfigure, sub-subfigure). It is advisable to have these drawings and/or figures available when talking with the factory. To order parts call, fax, or write Lift-A-Loft directly giving the parts department personnel the following information:

Your purchase order number.

Your complete shipping address.

Your complete invoicing address (if different.)

Specify the method of shipment, otherwise the least expensive method

will be used.

Correct part number and description as found in this manual.

Correct model and serial number of the unit from the Serial Number Plate (See Figure 2 for location).

NOTE: In the event that the serial number plate cannot be located or is damaged, locate

the permanent identification stamp (Figure 2) and immediately order a new serial number plate from your Lift-A-Loft representative. Serial # plate inside Lower Control Station - Name Plate inside cab on driver side tunnel.

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 1

Page 3 11-06-2018

(2) TO ORDER FROM A VENDOR:

The Manufacturer Identification section (Section 2), contains the names and address’s of the vendor suppliers for this unit.

To find the vendor for a part, follow the steps below: Numerical Index: Use the Index to determine vendor part number and the

vendor code number for the part. If no code number is referenced the part is manufactured by Lift-A-Loft and must be ordered from Lift-A-Loft.

Detailed Parts List: The vendor number will appear in the Vendor Number column.

Pursue the vendor from the lists in the Vendor/Mfg Identification section

(Section 2.)

Contact the vendor/mfg directly with the pertinent information for ordering.

NOTE: The figure contains a manufacturer I.D. number. This manufacturer I.D. number may differ from the Vendor I.D. number located in the parts list. This means the part may not be purchased directly from the manufacturer and will have to be purchased from Lift-A-Loft or from a distributor of that assembly.

NOTE: Some items contained within the vendor/manufacturer subassemblies (Figures) do not have an L-A-L part number.

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 1

Page 4 11-06-2018

UNIT IDENTIFICATIONFIGURE 2

Serial Number Plate

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 2

Page 1 11-06-2018

VENDOR IDENTIFICATION

GENERAL This section identifies the Vendors (Manufacturers or Distributors) of the parts utilized in building the APX-LP. The section is sorted into 2 lists for easy cross-referencing:

1) VENDORS - ALPHABETICAL (An alphabetical list of ALL of the vendors with included vendor I.D. Number and Federal I.D. number.)

2) VENDORS - NUMERICAL (A list of the vendors listed by vendor I.D. number.)

ALL VENDORS – ALPHABETICAL

VENDOR NAME and ADDRESS VENDOR ID FED. ID

ADVANCE AUTO PARTS 1301 W. MCGALLIARD MUNCIE, IN 47303

040757

ALL PHASE ELECTRIC CO 320 WEST WILLIARD MUNCIE, IN 47302

002028

ALLEGIS CORPORATION 8001 CENTRAL AV. N.E MINNEAPOLIS, WI 55432

040350

ALLIED ELECTRONICS 12400 N. MERIDIAN STREET STE 195 CARMEL, IN 46032

041407 0DS47

ALRO STEEL 2301 S WALNUT ST MUNCIE, IN 47302

000195

ARROW ELECTRONICS 155 CHAIN LAKE DRIVE SUITE 27 HALIFAX, NOVASCOTIA B3S 1B3

041857

AURORA BEARING CO. 901 AUCUTT ROAD MONTGOMERY,IL 60538

040569 56644 Pro

perty

of A

mer

ican

Airline

s



CHAPTER 4 SECTION 2

Page 2 11-06-2018

AUSTIN HARDWARE & SUPPLY 52900 HARMAN DRIVE ELKHART, IN 46516

040447

BAILEY INTERNATIONAL 2527 WESTCOTT BLVD. KNOXVILLE, TN 37931

041866

BATTERY MASTERS 1619 N. WALNUT MUNCIE, IN 47303

000672

CABLESCIENCE 9211 GREENLEAF AVENUE SANTA FE SPRINGS, CA 90670

041874 50FJ5

CAL-WEST MACHINING INC. 1933 NORTH MAIN STREET ORANGE, CA 92865

040491 0NM27

CAPITAL ENGINE CO. 97 CYPRESS STREET SW REYNOLDSBURG, OH 43068

041184 0FGM0

CAPLUG DIVISION 2150 ELMWOOD AVE BUFFALO, NY 14207

001078 99017

CARLTON BATES 2256 CITY GATE DRIVE COLUMBUS, OH 43219

041420

CARRIER-OEHLER PO BOX 40 S. HOLLAND, IL 60473

039802 3V702

CENTURY SPRING CORP. P.O. BOX 15287 222 EAST 16TH ST LOS ANGELES, CA 90015

040208 56988

COXREELS 6720 S. CLEMENTINE CT. TEMPE, AZ 85283

040697

DIGI-KEY CORPORATION 701 BROOKS AVENUE SOUTH THIEF RIVER FALLS, WI 56701

041319

Prope

rty o

f Am

erica

n Airli

nes



CHAPTER 4 SECTION 2

Page 3 11-06-2018

ECCO 8727 NORTH PIONEEER ROAD PEORIA, IL 61615

009760

EDWARD DANIEL CO 11700 HARVARD AVE P.O. BOX 94628 CLEVELAND, OH 44101

000953 73634

FASTENAL COMPANY 1360 NORTH WHEELING AVENUE MUNCIE, IN 47304

039850

FLEETPRIDE 1140 S. WEST ST. P.O.BOX 2933 INDIANAPOLIS, IN 46225

040772

GE ELECTRIC SUPPLY CUSTOMER SERVICE CENTER 1250 STADIUM DRIVE INDIANAPOLIS, IN 46202

003103

GENELCO INDUSTRIES 90 13TH AVE RONKONKOMA, NY 11779

041445 8G055

GLEASON REEL CORP. C/O HK INDUSTRIAL SALES 11715 FOX RD. SUITE 400-120 INDIANAPOLIS, IN 46236

003214

GRAYBAR 9222 ORLY ROAD INDIANAPOLIS, IN 46241

040837 1F174

GREAT LAKES POWER – CINCINNATI 4740 DEVITT DRIVE CINCINNATI, OH 45246

041297 3M970

GROTE MANUFACTURING PO BOX 766 MADISON, IN 46202

003445

GUARDIAN PACKAGING INDUSTRIES 3615 SECURITY STREET GARLAND, TX 75042

042086 6E0Z4 Pro

perty

of A

mer

ican

Airline

s



CHAPTER 4 SECTION 2

Page 4 11-06-2018

HARLAN GLOBAL MANUFACTURING 27 STANLEY ROAD KANSAS CITY, KS 66115

041382 60905

HAYES BRAKE, INC 5800 WEST DONGES BAY ROAD MEQUON, WI 53092

040326 22075

HYDRA AIR INC 8208 INDY LANE INDIANAPOLIS, IN 46224

003947 2S415

ILLINOIS AUTO ELECTRIC COMPANY 700 ENTERPRISE STREET AURORA, IL 60504

041584

INDIANAPOLIS WIRE & TERMINAL, INC. 350 CHURCHMAN AVENUE BEECH GROVE, IN 46107

041285

INDUSTRIAL BRAKE COMPANY 300 CLAY AVENUE P.O. BOX 670 MARS, PA 16046

041524 44S86

J & N AUTO ELECTRIC 10995 CANAL ROAD CINCINNATI, OH 45241

004585 5H980

J W SPEAKER CORPORATION N120 W19434 FREISTADT ROA GERMANTOWN, WI 53022

009330

JENNY PRODUCTS INC. 850 N. PLEASANT AVE. SOMERSET, PA 15501

041317 29215

JLG INDUSTRIES, INC 1 JLG DRIVE MCCONNELLSBURG, PA 17233

041159 51905

KAMAN INDUSTRIAL TECHNOLOGIES 14295 WEST COMMERCE ROAD DALEVILLE, IN 47334

005040

KNAPP SUPPLY COMPANY PO BOX2488 420 SOUTH OHIO AVE. MUNCIE, IN 47302

005452 Pro

perty

of A

mer

ican

Airline

s



CHAPTER 4 SECTION 2

Page 5 11-06-2018

KOORSEN PROTECTION SERVS 401 WEST ONTARIO DRIVE MUNCIE, IN 47303

005454

KRAFT FLUID SYSTEMS, INC. 14300 FOLTZ INDUSTRIAL PKWY STRONGSVILLE, OH 44149

005517 7N474

LADD INDUSTRIES 144 WEST PARK ROAD CENTERVILLE, OH 45459

039835 0EXP8

LOWE'S OF MUNCIE 4401 W. CLARA LANE MUNCIE, IN 47304

040098

MANCHESTER TANK & EQPT. CO. 1749 MALLORY LANE SUITE 400 BRENTWOOD, TN 37027

040709

MARADYNE MOBIL/DREISON INT'L 4540 W. 160TH STREET CLEVELAND, OH 44135

040385 0DBY7

MARION ENGINEERING TECHNOLOGY, INC. 1309 WEST NELSON ST PO BOX 924 MARION, IN 46952

003401

MCMASTER CARR SUPPLY CO PO BOX 7690 CHICAGO, IL 60680

006043 6K495

MEDALIST/LEITZKE PO BOX 305 HUNTISFORD, WI 53034

008689 96652

MORRELL INC 7402 EAST 90’TH STREET PO BOX 501610 INDIANAPOLIS, IN 46250

003962

MOSIER FLUID POWER 9851 PARK DAVIS DRIVE INDIANAPOLIS, IN 46236

006309 4P280

MSC INDUSTRIAL SUPPLY COMPANY 31800 INDUSTRIAL DRIVE LIVONIA, MI 48151

004588

Prope

rty o

f Am

erica

n Airli

nes



CHAPTER 4 SECTION 2

Page 6 11-06-2018

NAPA AUTO PARTS 1009 W. CENTENNIAL MUNCIE, IN 47303

006354

NEFF ENGINEERING 9325 UPTOWN DRIVE SUITE 100 INDIANAPOLIS, IN 46256

042055 21314

NEWARK ELECTRONICS 50 EAST 91’ST STREET INDIANAPOLIS, IN 46240

006840 1FX31

NIXON’S CARQUEST AUTO FINISHES 701 WEST 8’TH ST. MUNCIE, IN 47302

006855

NORTHERN HYDRAULICS P.O. BOX 1499 BURNVILLE, MN 55337

006910 2Z432

ORR & ORR 3520 S. MORGAN ST. CHICAGO, IL 60609

007357 2K900

PDI GROUND SUPPORT SYSTEMS, INC. 6225 COCHRAN ROAD SOLON, OH 44139

040623 0W357

PG TRIONIC, INC. 234 WESTERN AVENUE ESSEX, MA 01929

041893

PHOENIX METAL PRODUCTS 3000 INDUSTRIAL AVENUE 3 FT. PIERCE, FL 34946

040798 084Y3

PIVOT POINT 761 INDUSTRIAL P.O. BOX 488 HUSTISFORD, WI 53034

040779 0CUJ4

POLYGON COMPANY 103 INDUSTRIAL PARK P.O. BOX 176 WALKERTON, IN 46574

039808 4R363

POMP'S TIRE SERVICE US 24 W P.O. BOX 743 MONTICELLO, IN 47960

006013

Prope

rty o

f Am

erica

n Airli

nes



CHAPTER 4 SECTION 2

Page 7 11-06-2018

POWERTRAIN CONTROL SOLUTIONS 10511 OLD RIDGE ROAD ASHLAND, VA 23005

042231 4WR67

PRM NEWAGE LIMITED BARLOW ROAD ALDERMANS GREEN INDUSTRIAL ESTATE COVENTRY, ENGLAND

042099

PROGRESSIVE POWER 7751 EAST 89TH STREET INDIANAPOLIS, IN 46256

007938 0FNW9

R. S. HUGHES CO., INC. 5058 WEST 79TH STREET INDIANAPOLIS, IN 46268

041581

RIDOUT PLASTICS 5535 RUFFIN ROAD SAN DIEGO, CA 92123

041974 3L244

RUBBER PRODUCTS DISTRIBUTORS 2725 TOBEY DRIVE INDIANAPOLIS, IN 46219

039960

SAGE PARTS PLUS 30 HUB DRIVE MELVILLE, NY 11747

040640 1HZX1

SCOTT INDUSTRIAL SYSTEMS 2655 TOBEY DRIVE INDIANAPOLIS, IN 46219

009080 6H328

SEALCON 14853 E. HINSDALE AVE., SUITE D CENTENNIAL, CO 80112

041199 0UE11

SKF LINEAR MOTION & PRECISION TECH 7781 COLLECTION CENTER DRIVE CHICAGO, IL 60693

041325

STANLEY NATIONAL P.O. BOX 577 STERLING, IL 61081

006693

SUNSOURCE – FAUVER 5757 WEST 73’RD STREET INDIANAPOLIS, IN 46278

002540

Prope

rty o

f Am

erica

n Airli

nes



CHAPTER 4 SECTION 2

Page 8 11-06-2018

T.P.I. 4125 NORTH CLINTON FORT WAYNE, IN 46805

009844 5PFE9

TAYLOR-DUNN CORPORATION 2114 WEST BALL ROAD ANAHEIM, CA 92804

041126 08786

TECH PRODUCTS CORPORATION 2215 LYONS ROAD MIAMISBURG, OH 45342

041782 5P059

TECH SALES & MARKETING, INC 8333 MASTERS ROAD INDIANAPOLIS, IN 46250

041703 4F9D2

TERMINAL SUPPLY 1800 THUNDERBIRD TROY, MI 48084

009664 1W654

THE WISE COMPANY, INC. 79 SOUTH SECOND STREET MEMPHIS, TN 38103

040384

THERMO KING MIDWEST P.O. BOX 42388 817 SOUTH TIBBS AVENUE INDIANAPOLIS, IN 46241

040394 1JRT1

THERUSTSTORE.COM INTERNET ORDERS

041886

TRAILER PARTS SUPERSTORE 931 SOUTH CHAPEL STREET NEWARK, DE 19713

042050

TRANSMISSION FLUID EQUIPMENT 6912 TRAFALGAR DRIVE FT WAYNE, IN 46803

009831 68108

TRI LITE, INC. 1642 BESLY CT CHICAGO, IL 60622

009894 001Y1

TRIM-LOK, INC 6855 HERMOSA CIRCLE BUENA PARK, CA 90620

039509 57137 Pro

perty

of A

mer

ican

Airline

s



CHAPTER 4 SECTION 2

Page 9 11-06-2018

TRUCKPRO – INDIANAPOLIS 1405 WEST THOMPSON ROAD INDIANAPOLIS, IN 46217

041082

TUG AFTERMARKET 815 ALLGOOD ROAD MARIETTA, GA 30062

040741 345K3

ULINE SHIPPING SUPPLY 2200 S. LAKESIDE DRIVE WAUKEGAN, IL 60085

040547

VAN’S CARBURETOR & ELECTRIC 2541 KENTUCKY AVE INDIANAPOLIS, IN 46241

040062 1CJ84

VEHICLE IMPROVEMENT PRODUCTS 151 S. RAM RD. ANTIOCH, IL 60002

040419 0KAW7

VEHICLE SPECIALTIES, LLC. 615 W. 9TH STREET MUNCIE, IN 47302

011148

W.W. GRANGER 924 WEST WILLIARD MUNCIE, IN 47302

040240

W.W. WILLIAMS 14056 BRITTON PARK ROAD FISHERS, IN 46038

041746

WAGO CORPORATION N120 W19129 FREISTADT ROAD GERMANTOWN, WI 53022

042091 65996

WES-GARDE COMPONENTS GROUP 300 ENTERPRISES DRIVE WESTERVILLE, OH 43081

041835 6S553

WHITNEY BLAKE COMPANY 20 INDUSTRIAL DRIVE BELLOWSFALLS, VT 05101

041279 79566

ZENITH SPRINGS CO. 3116 W. MICHIGAN ST. DULUTH, MN 55806

040324 6H829 Pro

perty

of A

mer

ican

Airline

s


VENDOR ID VENDOR NAME and ADDRESS FED. ID

CHAPTER 4 SECTION 2

Page 10 11-06-2018

LISTING BY VENDOR ID. NUMBER

VENDOR ID. VENDOR NAME and ADDRESS FED. ID

000195 ALRO STEEL 2301 S WALNUT ST MUNCIE, IN 47302

000672 BATTERY MASTERS 1619 N. WALNUT MUNCIE, IN 47303

000953 EDWARD DANIEL CO 11700 HARVARD AVE P.O. BOX 94628 CLEVELAND, OH 44101

73634

001078 CAPLUG DIVISION 2150 ELMWOOD AVE BUFFALO, NY 14207

99017

002028 ALL PHASE ELECTRIC CO 320 WEST WILLIARD MUNCIE, IN 47302

002540 SUNSOURCE – FAUVER 5757 WEST 73’RD STREET INDIANAPOLIS, IN 46278

003103 GE ELECTRIC SUPPLY CUSTOMER SERVICE CENTER 1250 STADIUM DRIVE INDIANAPOLIS, IN 46202

003214 GLEASON REEL CORP. C/O HK INDUSTRIAL SALES 11715 FOX RD. SUITE 400-120 INDIANAPOLIS, IN 46236

003401 MARION ENGINEERING TECHNOLOGY, INC. 1309 WEST NELSON ST PO BOX 924 MARION, IN 46952

Pro

perty

of A

mer

ican

Airline

s



CHAPTER 4 SECTION 2

Page 11 11-06-2018

003445 GROTE MANUFACTURING PO BOX 766 MADISON, IN 46202

003947 HYDRA AIR INC 8208 INDY LANE INDIANAPOLIS, IN 46224

2S415

003962 MORRELL INC 7402 EAST 90’TH STREET PO BOX 501610 INDIANAPOLIS, IN 46250

004585 J & N AUTO ELECTRIC 10995 CANAL ROAD CINCINNATI, OH 45241

5H980

004588 MSC INDUSTRIAL SUPPLY COMPANY 31800 INDUSTRIAL DRIVE LIVONIA, MI 48151

005040 KAMAN INDUSTRIAL TECHNOLOGIES 14295 WEST COMMERCE ROAD DALEVILLE, IN 47334

005452 KNAPP SUPPLY COMPANY PO BOX2488 420 SOUTH OHIO AVE. MUNCIE, IN 47302

005454 KOORSEN PROTECTION SERVS 401 WEST ONTARIO DRIVE MUNCIE, IN 47303

005517 KRAFT FLUID SYSTEMS, INC. 14300 FOLTZ INDUSTRIAL PKWY STRONGSVILLE, OH 44149

7N474

006013 POMP'S TIRE SERVICE US 24 W P.O. BOX 743 MONTICELLO, IN 47960

006043 MCMASTER CARR SUPPLY CO PO BOX 7690 CHICAGO, IL 60680

6K495 Prope

rty o

f Am

erica

n Airli

nes



CHAPTER 4 SECTION 2

Page 12 11-06-2018

006309 MOSIER FLUID POWER 9851 PARK DAVIS DRIVE INDIANAPOLIS, IN 46236

4P280

006354 NAPA AUTO PARTS 1009 W. CENTENNIAL MUNCIE, IN 47303

006693 STANLEY NATIONAL P.O. BOX 577 STERLING, IL 61081

006840 NEWARK ELECTRONICS 50 EAST 91’ST STREET INDIANAPOLIS, IN 46240

1FX31

006855 NIXON’S CARQUEST AUTO FINISHES 701 WEST 8’TH ST. MUNCIE, IN 47302

006910 NORTHERN HYDRAULICS P.O. BOX 1499 BURNVILLE, MN 55337

2Z432

007357 ORR & ORR 3520 S. MORGAN ST. CHICAGO, IL 60609

2K900

007938 PROGRESSIVE POWER 7751 EAST 89TH STREET INDIANAPOLIS, IN 46256

0FNW9

008689 MEDALIST/LEITZKE PO BOX 305 HUNTISFORD, WI 53034

96652

009080 SCOTT INDUSTRIAL SYSTEMS 2655 TOBEY DRIVE INDIANAPOLIS, IN 46219

6H328

009330 J W SPEAKER CORPORATION N120 W19434 FREISTADT ROA GERMANTOWN, WI 53022

009664 TERMINAL SUPPLY 1800 THUNDERBIRD TROY, MI 48084

1W654 Prope

rty o

f Am

erica

n Airli

nes



CHAPTER 4 SECTION 2

Page 13 11-06-2018

009760 ECCO 8727 NORTH PIONEEER ROAD PEORIA, IL 61615

009831 TRANSMISSION FLUID EQUIPMENT 6912 TRAFALGAR DRIVE FT WAYNE, IN 46803

68108

009844 T.P.I. 4125 NORTH CLINTON FORT WAYNE, IN 46805

5PFE9

009894 TRI LITE, INC. 1642 BESLY CT CHICAGO, IL 60622

001Y1

011148 VEHICLE SPECIALTIES, LLC. 615 W. 9TH STREET MUNCIE, IN 47302

039509 TRIM-LOK, INC 6855 HERMOSA CIRCLE BUENA PARK, CA 90620

57137

039802 CARRIER-OEHLER PO BOX 40 S. HOLLAND, IL 60473

3V702

039808 POLYGON COMPANY 103 INDUSTRIAL PARK P.O. BOX 176 WALKERTON, IN 46574

4R363

039835 LADD INDUSTRIES 144 WEST PARK ROAD CENTERVILLE, OH 45459

0EXP8

039850 FASTENAL COMPANY 1360 NORTH WHEELING AVENUE MUNCIE, IN 47304

039960 RUBBER PRODUCTS DISTRIBUTORS 2725 TOBEY DRIVE INDIANAPOLIS, IN 46219

040062 VAN’S CARBURETOR & ELECTRIC 2541 KENTUCKY AVE INDIANAPOLIS, IN 46241

1CJ84 Prope

rty o

f Am

erica

n Airli

nes



CHAPTER 4 SECTION 2

Page 14 11-06-2018

040098 LOWE'S OF MUNCIE 4401 W. CLARA LANE MUNCIE, IN 47304

040208 CENTURY SPRING CORP. P.O. BOX 15287 222 EAST 16TH ST LOS ANGELES, CA 90015

56988

040240 W.W. GRANGER 924 WEST WILLIARD MUNCIE, IN 47302

040324 ZENITH SPRINGS CO. 3116 W. MICHIGAN ST. DULUTH, MN 55806

6H829

040326 HAYES BRAKE, INC 5800 WEST DONGES BAY ROAD MEQUON, WI 53092

22075

040350 ALLEGIS CORPORATION 8001 CENTRAL AV. N.E MINNEAPOLIS, WI 55432

040384 THE WISE COMPANY, INC. 79 SOUTH SECOND STREET MEMPHIS, TN 38103

040385 MARADYNE MOBIL/DREISON INT'L 4540 W. 160TH STREET CLEVELAND, OH 44135

0DBY7

040394 THERMO KING MIDWEST P.O. BOX 42388 817 SOUTH TIBBS AVENUE INDIANAPOLIS, IN 46241

1JRT1

040419 VEHICLE IMPROVEMENT PRODUCTS 151 S. RAM RD. ANTIOCH, IL 60002

0KAW7

040447 AUSTIN HARDWARE & SUPPLY 52900 HARMAN DRIVE ELKHART, IN 46516

Prope

rty o

f Am

erica

n Airli

nes



CHAPTER 4 SECTION 2

Page 15 11-06-2018

040491 CAL-WEST MACHINING INC. 1933 NORTH MAIN STREET ORANGE, CA 92865

0NM27

040547 ULINE SHIPPING SUPPLY 2200 S. LAKESIDE DRIVE WAUKEGAN, IL 60085

040569 AURORA BEARING CO. 901 AUCUTT ROAD MONTGOMERY,IL 60538

56644

040623 PDI GROUND SUPPORT SYSTEMS, INC. 6225 COCHRAN ROAD SOLON, OH 44139

0W357

040640 SAGE PARTS PLUS 30 HUB DRIVE MELVILLE, NY 11747

1HZX1

040697 COXREELS 6720 S. CLEMENTINE CT. TEMPE, AZ 85283

040709 MANCHESTER TANK & EQPT. CO. 1749 MALLORY LANE SUITE 400 BRENTWOOD, TN 37027

040741 TUG AFTERMARKET 815 ALLGOOD ROAD MARIETTA, GA 30062

345K3

040757 ADVANCE AUTO PARTS 1301 W. MCGALLIARD MUNCIE, IN 47303

040772 FLEETPRIDE 1140 S. WEST ST. P.O.BOX 2933 INDIANAPOLIS, IN 46225

040779 PIVOT POINT 761 INDUSTRIAL P.O. BOX 488 HUSTISFORD, WI 53034

0CUJ4

040798 PHOENIX METAL PRODUCTS 3000 INDUSTRIAL AVENUE 3 FT. PIERCE, FL 34946

084Y3 Pro

perty

of A

mer

ican

Airline

s



CHAPTER 4 SECTION 2

Page 16 11-06-2018

040837 GRAYBAR 9222 ORLY ROAD INDIANAPOLIS, IN 46241

1F174

041082 TRUCKPRO – INDIANAPOLIS 1405 WEST THOMPSON ROAD INDIANAPOLIS, IN 46217

041126 TAYLOR-DUNN CORPORATION 2114 WEST BALL ROAD ANAHEIM, CA 92804

08786

041159 JLG INDUSTRIES, INC 1 JLG DRIVE MCCONNELLSBURG, PA 17233

51905

041184 CAPITAL ENGINE CO. 97 CYPRESS STREET SW REYNOLDSBURG, OH 43068

0FGM0

041199 SEALCON 14853 E. HINSDALE AVE., SUITE D CENTENNIAL, CO 80112

0UE11

041279 WHITNEY BLAKE COMPANY 20 INDUSTRIAL DRIVE BELLOWSFALLS, VT 05101

79566

041285 INDIANAPOLIS WIRE & TERMINAL, INC. 350 CHURCHMAN AVENUE BEECH GROVE, IN 46107

041297 GREAT LAKES POWER – CINCINNATI 4740 DEVITT DRIVE CINCINNATI, OH 45246

3M970

041317 JENNY PRODUCTS INC. 850 N. PLEASANT AVE. SOMERSET, PA 15501

29215

041319 DIGI-KEY CORPORATION 701 BROOKS AVENUE SOUTH THIEF RIVER FALLS, WI 56701

041325 SKF LINEAR MOTION & PRECISION TECH 7781 COLLECTION CENTER DRIVE CHICAGO, IL 60693

Prope

rty o

f Am

erica

n Airli

nes



CHAPTER 4 SECTION 2

Page 17 11-06-2018

041382 HARLAN GLOBAL MANUFACTURING 27 STANLEY ROAD KANSAS CITY, KS 66115

60905

041407 ALLIED ELECTRONICS 12400 N. MERIDIAN STREET STE 195 CARMEL, IN 46032

0DS47

041420 CARLTON BATES 2256 CITY GATE DRIVE COLUMBUS, OH 43219

041445 GENELCO INDUSTRIES 90 13TH AVE RONKONKOMA, NY 11779

8G055

041524 INDUSTRIAL BRAKE COMPANY 300 CLAY AVENUE P.O. BOX 670 MARS, PA 16046

44S86

041581 R. S. HUGHES CO., INC. 5058 WEST 79TH STREET INDIANAPOLIS, IN 46268

041584 ILLINOIS AUTO ELECTRIC COMPANY 700 ENTERPRISE STREET AURORA, IL 60504

041703 TECH SALES & MARKETING, INC 8333 MASTERS ROAD INDIANAPOLIS, IN 46250

4F9D2

041746 W.W. WILLIAMS 14056 BRITTON PARK ROAD FISHERS, IN 46038

041782 TECH PRODUCTS CORPORATION 2215 LYONS ROAD MIAMISBURG, OH 45342

5P059

041835 WES-GARDE COMPONENTS GROUP 300 ENTERPRISES DRIVE WESTERVILLE, OH 43081

6S553

041857 ARROW ELECTRONICS 155 CHAIN LAKE DRIVE SUITE 27 HALIFAX, NOVASCOTIA B3S 1B3

Prope

rty o

f Am

erica

n Airli

nes



CHAPTER 4 SECTION 2

Page 18 11-06-2018

041866 BAILEY INTERNATIONAL 2527 WESTCOTT BLVD. KNOXVILLE, TN 37931

041874 CABLESCIENCE 9211 GREENLEAF AVENUE SANTA FE SPRINGS, CA 90670

50FJ5

041886 THERUSTSTORE.COM INTERNET ORDERS

041893 PG TRIONIC, INC. 234 WESTERN AVENUE ESSEX, MA 01929

041974 RIDOUT PLASTICS 5535 RUFFIN ROAD SAN DIEGO, CA 92123

3L244

042050 TRAILER PARTS SUPERSTORE 931 SOUTH CHAPEL STREET NEWARK, DE 19713

042055 NEFF ENGINEERING 9325 UPTOWN DRIVE SUITE 100 INDIANAPOLIS, IN 46256

21314

042086 GUARDIAN PACKAGING INDUSTRIES 3615 SECURITY STREET GARLAND, TX 75042

6E0Z4

042091 WAGO CORPORATION N120 W19129 FREISTADT ROAD GERMANTOWN, WI 53022

65996

042099 PRM NEWAGE LIMITED BARLOW ROAD ALDERMANS GREEN INDUSTRIAL ESTATE COVENTRY, ENGLAND

042231 POWERTRAIN CONTROL SOLUTIONS 10511 OLD RIDGE ROAD ASHLAND, VA 23005

4WR67

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 1 11-06-2018

NUMERICAL PARTS LIST

1. PURPOSE The following Numerical Indexes are useful for finding parts and for cross-referencing between part numbers, figures, and drawings.

2. MANUFACTURER PARTS

This Index has been created from all parts on the L-A-L vehicle assembly drawings and figures. The list is then sorted in an alpha-numeric fashion by the L-A-L part number.

3. VENDOR PARTS

Vendor supplied parts breakdowns have the vendor code and the vendor part number identified with the listing. The vendor code may then be found in the vendor code listing to identify the vendor and the address of the vendor.

Reminder: See manufacturing drawings for part lengths and additional assembly information.

Prope

rty o

f Am

erica

n Airli

nes

LIFT-A-LOFT APX20-LP Diesel LAL# DRAWING ITEM DESCRIPTION QTY VENDOR PART# VENDOR AIRLINE#

CHAPTER 4 SECTION 3

Page 20 11-06-2018

L-A-L NUMERICAL PARTS LISTING

LAL# DRAWING ITEM DESCRIPTION QTY VENDOR PART#VENDO

R AIRLINE #03T03204G04G D39262GA 41 HOSE ASSEMBLY 1 04T02004G04E D41605GF 3 HOSE ASSEMBLY 1 04T02004G04E D41605GG 3 HOSE ASSEMBLY 1 04T02306G06G D41605GF 7 HOSE ASSEMBLY 2 04T05906G06G D39126GA 1 HOSE ASSEMBLY REF 04T05906G06G D41605GF 10 HOSE ASSEMBLY 1 04T09404G04G D41605GE 8 HOSE ASSEMBLY 1 06R01606G06E D41605GD 2 HOSE ASSEMBLY 1 06R01706G06G D41600GA 1 HOSE ASSEMBLY X 17" LG 2 06R01706G06G D41600GB 1 HOSE ASSEMBLY X 17" LG 2 06R02906G06G D41605GD 2 HOSE ASSEMBLY 4 06T02706G06G D41605GF 4 HOSE ASSEMBLY 2 06T05706G06G D41605GE 1 HOSE ASSEMBLY 2 06T07006G06G D41605GF 14 HOSE ASSEMBLY 2 06T10006G06G D41605GE 3 HOSE ASSEMBLY 2 06T16006G06G D41605GE 16 HOSE ASSEMBLY 2 06T24008G06G D41605GB 2 HOSE ASSEMBLY 1 08T03108G08G D41605GD 2 HOSE ASSEMBLY 8 08T04908G08E D41605GE 18 HOSE ASSEMBLY 1 08T05008G08E D41605GE 19 HOSE ASSEMBLY 1 08T07008G08E D41605GF 2 HOSE ASSEMBLY 2 08T07008G08E D41605GG 2 HOSE ASSEMBLY 2

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 21 11-06-2018

08T12408G08E D41605GE 20 HOSE ASSEMBLY 1 08T20608G08E D41605GB 7 HOSE ASSEMBLY 1 08T27808G08G D41605GE 2 HOSE ASSEMBLY 1 08T31008G08G D41605GA 1 HOSE ASSEMBLY 1 12B08712G12G D41605GA 5 HOSE ASSEMBLY 1 12S19212G12G D41605GE 22 HOSE ASSEMBLY 1 70R20725 B30172GA 7 SERVICE PORT -1 70R20785 B30172GA 10 SERVICE PORT -1 70R44025 B30172GA 8 HOSE END -1 70R44085 B30172GA 11 HOSE END -1 70R44925 B30172GA 6 HOSE END -1 70R44985 B30172GA 9 HOSE END -1 A17487-1 D39126GA 2 ADJUSTER SCREW 4 A17494-1 D39126GA 3 WEAR PAD BUTTON 4 A23959-1 D24999GD 1 DOOR LATCH MTG PLATE 1 A24025-1 C39365GA 15 BRAKE HOSE -1 A24026-1 C39365GA 16 BRAKE HOSE -1 A24172GA D41603GA 1 MODIFIED LIGHT 1

A24176GA D44320GA 1 WIRE HARNESS (BAT TO STARTER/ALTERNATOR) 2

A24177GA D44320GA 2 WIRE HARNESS (ENG BLOCK TO CARRIAGE) 1

A24229-1 D41603GA 2 HINGE 2 A24229-1 D41603GB 1 HINGE 2 A24281-1 D41603GA 3 FAN GUARD 1 A24301GA D41603GA 4 WIRE HARNESS 1 A24301GA D41603GB 2 WIRE HARNESS 1 A24302GA D41603GA 5 WIRE HARNESS 1

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 22 11-06-2018

A24302GA D41603GB 3 WIRE HARNESS 1 A24350-1 D39105GA 1 CYLINDER PIN 1 A24351-1 D39105GA 2 CYLINDER PIN 2 A24364-1 D41602GA 1 ECCENTRIC HOLD DOWN 5 A24364-1 D41602GB 1 ECCENTRIC HOLD DOWN 5 A24413-1 D41600GA 2 PINTLE HOOK MOUNT -1 A24413-1 D41600GB 2 PINTLE HOOK MOUNT -1 A24446GA D26542GA 7 FRONT SPRING PLATE 2 A24725-1 D41601GA 1 RETAINER 3 A24725-1 D41601GB 1 RETAINER 3 A25317-1 D39105GA 3 APX SCISSOR END/ CYLINDER PIN 8 A25331-1 UMA0266 1 MOUNTING ANGLE 2 A25331-1 UMA0271 1 MOUNTING ANGLE 2 A25877GA D41603GA 6 BRAKE PEDAL PIVOT 1 A25877GA D41603GB 4 BRAKE PEDAL PIVOT 1 A26002-1 D41603GB 5 OUTLET COVER PLATE 1

A36607GA D44320GA 3 WIRE HARNESS (ENG BLOCK TO BAT NEG) 1

A39138-1 D39105GA 4 SCISSOR PIN - CENTER 4 A39157-1 D39126GA 4 CYLINDER MOUNT 1 A39188-1 D39126GA 5 BUMPER 4 A39188-1 D42855GA 1 BUMPER 4 A39189-1 D39126GA 6 BUMPER STRAP 4 A39189-1 D42855GA 2 BUMPER STRAP 4 A39193-1 D39126GA 7 GATE STOP 4 A39193-1 D42855GA 3 GATE STOP 4 A39195-1 D39126GA 8 RETAINER 2 A39256-1 D41600GA 3 MODIFIED FUEL LEVEL SENDER 1

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 23 11-06-2018

A39256-1 D41600GB 3 MODIFIED FUEL LEVEL SENDER 1 A44318GA D39126GA 9 TRAVERSE SWITCH ASSEMBLY 1 A44734GA D44321GA 1 SPRING SPACER 2 A44737-1 D44321GA 2 BRAKE LINE MOUNT 2 B23690GA D42850GA 1 ANGLE WELD - AIR 1 B23958GA D24999GA 45 LATCH PLATE WELDMENT 1 B23958GA D24999GC 45 LATCH PLATE WELDMENT 1 B23958GB D24999GB 46 LATCH PLATE WELDMENT 1 B23958GB D24999GD 46 LATCH PLATE WELDMENT 1 B24055-1 D24999GD 3 DOOR SPACER 1 B24244GA D41603GA 7 BRAKE PEDAL MOUNT 1 B24244GA D41603GB 6 BRAKE PEDAL MOUNT 1 B24322-4 D44321GA 3 U-BOLT 4 B24369GA D41602GA 2 SCISSOR SPREADER 1 B24369GA D41602GB 2 SCISSOR SPREADER 1 B24445-1 D26542GA 4 U-BOLT 4 B24450GA D42850GA 2 COMPRESSOR MOTOR MOUNT 1 B24609GA D41603GA 8 TUNNEL INSULATION KIT 1 B24609GA D41603GB 7 TUNNEL INSULATION KIT 1 B24710GB D41603GA 9 KNEE GUARD ASSEMBLY 1 B24710GB D41603GB 8 KNEE GUARD ASSEMBLY 1 B24739GA C39365GA 23 TUBING DETAIL -1 B24740GA C39365GA 17 TUBING DETAIL -1 B24742GA D41605GC 5 TUBING ASSEMBLY 1 B24773-1 C24774GA 1 MODIFIED ENCLOSURE 1 B24804GA C39365GB 21 TUBING DETAIL 1 B24805-1 D41601GA 2 HOSE COVER 2 B24805-1 D41601GB 2 HOSE COVER 1

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 24 11-06-2018

B24916GA D41601GA 3 PARKING BRAKE LEVER 1 B24916GA D41601GB 3 PARKING BRAKE LEVER 1 B24923GA D41601GA 4 BRAKE LEVER ROD 1 B24923GA D41601GB 4 BRAKE LEVER ROD 1 B25120-1 D41603GA 10 BATTERY HOLD DOWN 1 B25120-1 D41603GB 9 BATTERY HOLD DOWN 1 B25175-1 D24999GC 4 HINGE 2 B25175-1 D24999GD 4 HINGE 2 B25175-1 D41601GA 5 MODIFIED HINGE 1 B25175-1 D41601GB 5 MODIFIED HINGE 1 B25175-1 D41603GA 11 MODIFIED HINGE 2 B25175-1 D41603GB 10 MODIFIED HINGE 2 B25234GA C39365GB 19 TUBING DETAIL 1 B25371GA C39365GB 4 TUBING DETAIL 1 B25409-1 D24999GA 5 LATCH COVER 1 B25409-1 D24999GB 5 LATCH COVER 1 B25409-1 D24999GC 5 LATCH COVER 1 B25409-1 D24999GD 5 LATCH COVER 1 B25410GA D24999GA 6 DOOR LATCH 1 B25410GA D24999GC 6 DOOR LATCH 1 B25410GB D24999GB 7 DOOR LATCH 1 B25410GB D24999GD 7 DOOR LATCH 1 B25547-1 D41603GA 12 COMPARTMENT COVER 2 B25547-1 D41603GB 11 COMPARTMENT COVER 2 B25554-1 D24999GA 8 HINGE 1 B25554-1 D24999GB 8 HINGE 1 B25628GA D44321GA 4 REAR SHACKLE 2 B25631GA D26542GA 6 FRONT SHACKLE 2

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 25 11-06-2018

B25635GA C24998GA 2 MIRROR MOUNT 1 B25897GA D41603GA 13 TUBING ASSEMBLY 1 B25897GA D41603GB 12 TUBING ASSEMBLY 1 B25898GA C39365GB 24 TUBING DETAIL 1 B25899GA C39365GB 25 TUBING DETAIL 1 B30172GA D38190GA 12 A/C HOSE KIT 1 B31752GA D39258GA 1 LIGHT MOUNT WELDMENT 1 B31752GA D39258GB 1 LIGHT MOUNT WELDMENT 1 B34673GA D41603GA 14 DEFROST ADAPTER 1 B35755-1 D26542GA 12 BRAKE HOSE 2 B35755-1 D44321GA 5 BRAKE HOSE - CALIPER 2 B36499-1 D44320GA 4 RADIATOR SUPPORT 1 B37370-1 D44320GA 5 BRAKE ROTOR 1 B37405GA D41603GB 13 SEAT BELT MOUNT 2 B37416GA D41601GA 6 GRILL 1 B37416GA D41601GB 6 GRILL 1 B37523-1 D41601GA 7 BRAKE CABLE MOUNT 1 B37523-1 D41601GB 7 BRAKE CABLE MOUNT 1 B37938GA D44320GA 6 EXHAUST SUPPORT WELD 1 B38182-1 D38190GA 10 SWING ARM 2 B39049-1 D41602GA 3 MODIFIED ROUND 2 B39049-1 D41602GB 3 MODIFIED ROUND 2 B39110GA D39105GA 5 ADJUSTABLE PLATFORM MOUNT 1 B39177-1 D39126GA 10 BUMPER 4 B39178-1 D39126GA 11 BUMPER 1 B39187-1 D39126GA 12 BUMPER 2 B39187-1 D42855GA 4 BUMPER 2 B39190-1 D39126GA 13 BUMPER STRAP 2

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 26 11-06-2018

B39190-1 D42855GA 5 BUMPER STRAP 2 B39191-1 D39126GA 14 BUMPER STRAP 1 B39192-1 D39126GA 15 BUMPER STRAP 4 B39196GA D39126GA 16 PENDANT HOLDER WELDMENT 1 B39196GA D42855GA 6 PENDANT HOLDER WELDMENT 1 B39259-1 D41602GA 4 FORMED TUBE 2 B39259-1 D41602GB 4 FORMED TUBE 2 B39263GA D39262GB 36 TUBING ASSEMBLY -2 B39263GA D41605GF 17 TUBING ASSEMBLY 3 B39263GA D41607GA 6 TUBING ASSEMBLY -2 B39267-1 D41603GB 14 TOE KICK 1 B39270GA D41602GA 5 UCS PENDANT ASSEMBLY 1 B39273-1 D39126GA 17 BUMPER 2 B39273-1 D42855GA 7 BUMPER 2 B39275GA D41601GA 8 DRIVESHAFT SUPPORT 1 B39275GA D41601GB 8 DRIVESHAFT SUPPORT 1 B39364GA C39365GA 22 TUBING DETAIL 1 B39368GA D41604GA 1 HARNESS - DASH TO LCS 1 B39368GA D41604GD 1 HARNESS - DASH TO LCS 1 B39372GA D41601GA 9 PROP ROD ASSEMBLY 1 B39372GA D41601GB 9 PROP ROD ASSEMBLY 1 B39373GA D41601GA 10 STABILIZER HARNESS 1 B39373GA D41601GB 10 STABILIZER HARNESS 1 B39374GA D41602GA 6 UCS HARNESS 1 B39374GA D41602GB 6 UCS HARNESS 1 B39388GA D41605GF 18 TUBING ASSEMBLY 1 B40310GA D44320GA 7 ENGINE BRACKET WELDMENT 1 B41994GA D41600GA 4 CHASSIS HARNESS 1

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 27 11-06-2018

B41994GA D41600GB 4 CHASSIS HARNESS 1 B42852GA D41602GB 7 UCS PENDANT ASSEMBLY 1 B42864-1 D42855GA 8 BUMPER 1 B42865-1 D42855GA 9 BUMPER STRAP 1 B42966-1 D42855GA 10 BUMPER 2 B42967-1 D42855GA 11 BUMPER STRAP 2 B43222GA D41600GA 5 STABILIZER FOOT WELDMENT 2 B43222GA D41600GB 5 STABILIZER FOOT WELDMENT 2 B44736GA D44321GA 6 BRAKE LINE 1 B44738-1 D44321GA 7 BRAKE LINE MOUNT 1 B44739GA D44321GA 8 BRAKE LINE 1 B44774-1 D41603GB 15 DASH SHIELD 1 B45030-1 D44321GA 9 SPRING PLATE 2 B45193-1 D44320GA 8 TPS LINK BAR 1 BA21 D41603GA 15 12VDC BATTERY 1 31P 000672BA21 D41603GB 16 12VDC BATTERY 1 31P 000672BA24 D41603GA 16 BATTERY HEATER -1 78051 006855BM136 D39105GA 6 BUSHING - 1-1/2 ID X 1-3/4 OD X 5" LG 2 MRP24F28-80 039808

BM137 D39105GA 7 BUSHING - 1-1/2 ID X 1-3/4 OD X 2-3/4" LG 2 PF2428-44 039808

BM141 D41603GA 17 ROD END - 3/4, FEMALE 2 CW-12Z 040569BM141 D41603GB 17 ROD END - 3/4, FEMALE 2 CW-12Z 040569C24191GA D24997GG 1 VINYL WINDOW (BLUE) - DRIVER SIDE 1 C24191GA-BLK D24997GJ 2 VINYL WINDOW (BLACK) - DRIVER SIDE 1

C24191GB D24997GF 3 VINYL WINDOW (BLUE) - PASSENGER SIDE 1

C24191GB-BLK D24997GH 4 VINYL WINDOW (BLACK) - PASSENGER SIDE 1

C24225GA D41603GA 18 BRAKE PEDAL WELDMENT 1

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 28 11-06-2018

C24225GA D41603GB 18 BRAKE PEDAL WELDMENT 1 C24491-1 D41603GB 19 SEAT ADAPTER PLATE 2 C24717 D41608GA 29 CUP HOLDER KIT 2 C24717 D41608GB 29 CUP HOLDER KIT 2 C24774GA D41603GA 19 COLD WEATHER JUNCTION BOX -1 C24917GA D41601GA 11 BRAKE LEVER MOUNT 1 C24917GA D41601GB 11 BRAKE LEVER MOUNT 1 C24998GD D41608GA 35 DRIVERS SIDE MIRROR 1 C24998GD D41608GB 36 DRIVERS SIDE MIRROR 1 C25104GA D24999GG 9 VINYL DOOR 1 C26649-1 D41602GA 8 LIGHT MOUNT -1 C26649-1 D41602GB 8 LIGHT MOUNT -1

C37570-1 D44320GA 9 TRANSMISSION DRIVESHAFT ADAPTER GEN II 1

C38180GA D38190GA 5 COMPRESSOR MOUNT 1 C38188-1 D38190GA 15 PULLEY 1 C38525GA D44320GA 10 LH ENGINE MOUNT 1 C38528GA D44320GA 11 RH ENGINE MOUNT 1 C39235GA D39126GA 18 GUARDRAIL WELDMENT 8 C39235GA D42855GA 12 GUARDRAIL WELDMENT 8 C39363-1 D39249GA 1 MONITOR MOUNT 1 C39363-1 D42854GA 1 MONITOR MOUNT 1 C39365GA D41600GA 6 BRAKE LINE KIT 1 C39365GA D41600GB 6 BRAKE LINE KIT 1 C39365GB D41601GA 12 BRAKE LINE KIT 1 C39365GB D41601GB 12 BRAKE LINE KIT 1 C43219-1 D41608GA 36 LCS COVER 1 C43219-1 D41608GB 37 LCS COVER 1

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 29 11-06-2018

C44319GA D44320GA 12 WIRE HARNESS - ENGINE 1 C44489-1 D41600GA 7 FUEL TANK STRAP 2 C44489-1 D41600GB 7 FUEL TANK STRAP 2 C44490-1 D41603GA 20 HEADLIGHT MOUNT 4 C44490-1 D41603GB 20 HEADLIGHT MOUNT 4 CF47 D39105GA 8 CAMFOLLOWER - V GROOVE 4 VTR-4.50 009831CF9 D39126GA 19 1-3/4 DIA CAMFOLLOWER 6 CF-1 3/4-SB 009844D24494GA D39126GA 20 PEDESTAL WELDMENT 1 D24494GA D42855GA 13 PEDESTAL WELDMENT 1 D24518GA D41603GA 21 2 PASSENGER CAB WELDMENT 1 D24519 D41603GA 22 TUNNEL COVER 1 D24997 D41602GA 9 DRIVER DOOR WINDOW KIT 1 D24997 D41602GA 10 PASSENGER DOOR WINDOW KIT 1 D24997 D41602GB 9 DRIVER DOOR WINDOW KIT 1 D24997 D41602GB 10 PASSENGER DOOR WINDOW KIT 1

D24997GA D24999GB 10 GLASS WINDOW OPTION - DRIVER SIDE (STEEL DOOR) -1

D24997GB D24999GA 11 GLASS WINDOW OPTION - PASSENGER SIDE (STEEL DOOR) -1

D24997GE D24999GC 12 GLASS WINDOW OPTION - 3RD/4TH OR CREW VAN DOOR (STEEL) -1

D24997GE D24999GD 12 GLASS WINDOW OPTION - 3RD/4TH OR CREW VAN DOOR (STEEL) -1

D24997GF D24999GA 13 VINYL WINDOW OPTION (BLUE) - PASSENGER SIDE STEEL DOOR -1

D24997GG D24999GB 14 VINYL WINDOW OPTION (BLUE) - DRIVER SIDE STEEL DOOR -1

D24997GH D24999GA 15 VINYL WINDOW OPTION (BLACK) - PASSENGER SIDE STEEL DOOR -1

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 30 11-06-2018

D24997GJ D24999GB 16 VINYL WINDOW OPTION (BLACK) - DRIVER SIDE STEEL DOOR -1

D24999 D41602GA 11 DRIVERS DOOR KIT 1 D24999 D41602GA 12 PASSENGER DOOR KIT 1 D24999 D41602GB 11 DRIVERS DOOR KIT 1 D24999 D41602GB 12 PASSENGER DOOR KIT 1 D25475GA D24999GC 17 3RD DOOR 1 D25475GB D24999GD 18 4TH DOOR 1 D25556GA D24999GB 19 DOOR - DRIVER SIDE (STEEL) 1 D25556GB D24999GA 20 DOOR - PASSENGER SIDE (STEEL) 1 D25557GA D24999GF 21 DOOR - DRIVER SIDE (VINYL) 1 D25557GB D24999GE 22 DOOR - PASSENGER SIDE (VINYL) 1 D26542GA D41600GA 8 FRONT AXLE ASSEMBLY 1 D26542GA D41600GB 8 FRONT AXLE ASSEMBLY 1 D34881GA D41603GA 23 DEFROSTER RAIL 1 D36515-1 D44320GA 13 FAN SHOURD 1 D37565GA D44320GA 14 ENGINE CARRIAGE WELDMENT 1 D38190GA D41602GA 13 A/C OPTION KIT -1 D38190GA D41602GB 13 A/C OPTION KIT -1 D39104GA D41600GA 9 FRAME WELDMENT 1 D39104GA D41600GB 9 FRAME WELDMENT 1 D39105GA D41602GA 14 SCISSOR ASSEMBLY - 20FT 1 D39105GA D41602GB 14 SCISSOR ASSEMBLY - 20FT 1 D39106GA D39105GA 9 1ST INSIDE SCISSOR WELD 1 D39107GA D39105GA 10 1ST OUTSIDE SCISSOR WELDMENT 1 D39108GA D39105GA 11 2ND INSIDE SCISSOR WELDMENT 1 D39126GA D41602GA 15 PLATFORM ASSEMBLY - TRAVERSE 1 D39127GA D39126GA 21 PLATFORM WELDMENT 1

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 31 11-06-2018

D39128GA D39126GA 22 PLATFORM CARRIAGE WELDMENT 1 D39145GA D39105GA 12 LOWER SCISSOR MOUNT 1 D39170GA D39105GA 13 2ND OUTSIDE SCISSOR WELD 1 D39170GB D39105GA 14 2ND OUTSIDE SCISSOR WELD 1 D39171GA D39126GA 23 END GUARDRAIL WELDMENT 2 D39171GB D39126GA 24 END GUARDRAIL WELDMENT 2 D39172GA D41600GA 10 HYDRAULIC TANK - 20 GAL 1 D39172GA D41600GB 10 HYDRAULIC TANK - 20 GAL 1 D39173GA D39126GA 25 GATE WELDMENT 2 D39173GA D42855GA 14 GATE WELDMENT 2 D39180GA D41603GB 21 CAB WELDMENT 1 D39245GA D41604GA 4 DASH WELDMENT 1 D39245GA D41604GD 4 DASH WELDMENT 1 D39246 B39270GA 9 WIRING DIAGRAM REF D39246 B39373GA 1 WIRING DIAGRAM REF D39246 B39374GA 10 WIRING DIAGRAM REF

D39246 B41994GA 11 WIRING DIAGRAM(REF

) D39246 D39258GA 2 WIRING DIAGRAM REF D39246 D39258GB 2 WIRING DIAGRAM REF D39246/D41606 D39249GA 2 WIRING DIAGRAM REF D39247-1 D39249GA 3 MODIFIED ENCLOSURE 1 D39248GC D39249GA 4 HYDRAULIC FITTING KIT 1 D39249GA D41600GA 11 LOWER ENCLOSURE ASSEMBLY 1 D39251 D41600GA 12 FUEL TANK ASSEMBLY - DIESEL 1 D39251 D41600GB 12 FUEL TANK ASSEMBLY - DIESEL 1 D39257-1 D39258GA 3 MODIFIED ENCLOSURE 1 D39258GA D41602GA 16 UPPER CONTROL STATION 1

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 32 11-06-2018

D39258GA D41602GB 16 UPPER CONTROL STATION 1 D39260GA D41603GB 22 TUNNEL COVER 1 D39261GA D42850GA 3 COMPRESSOR COVER 1 D39262GA D42850GA 4 AIR FITTING KIT 1 D39262GB D42850GA 5 AIR FITTING KIT 1 D39508GA D44320GA 15 PARKING BRAKE MOUNT 1 D41600GA D41601GA 13 STAGE 1 ASSEMBLY 1 D41600GA D41601GB 13 STAGE 1 ASSEMBLY - D41600GB D41601GA 14 STAGE 1 ASSEMBLY - D41600GB D41601GB 14 STAGE 1 ASSEMBLY 1 D41601GA D41602GA 17 STAGE 2 ASSEMBLY 1 D41601GB D41602GB 18 STAGE 2 ASSEMBLY 1 D41602GA D41608GA 1 STAGE 3 ASSEMBLY 1 D41602GB D41608GB 31 STAGE 3 ASSEMBLY 1 D41603 D41601GA 15 CAB ASSEMBLY 1 D41603 D41601GB 15 CAB ASSEMBLY 1 D41604 D41603GA 24 DASH ASSEMBLY 1 D41604 D41603GB 23 DASH ASSEMBLY 1 D41604GB D41604GA 5 INDICATOR LIGHT KIT -1 D41604GB D41604GD 5 INDICATOR LIGHT KIT -1

D41604GC D41604GA 6 SHUT DOWN KIT (LOW OIL, HIGH TEMP) -1

D41604GC D41604GD 6 SHUT DOWN KIT (LOW OIL, HIGH TEMP) -1

D41605GA D44320GA 16 FITTING LAYOUT KIT 1 D41605GB D42850GA 6 HYDRAULIC FITTING KIT 1 D41605GC D42854GA 2 HYDRAULIC FITTING KIT 1 D41605GD D41603GA 25 HYDRAULIC FITTING KIT 1

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 33 11-06-2018

D41605GD D41603GB 24 HYDRAULIC FITTING LAYOUT KIT 1 D41605GE D41601GA 16 HYDRAULIC FITTING KIT 1 D41605GE D41601GB 16 HYDRAULIC FITTING KIT 1 D41605GF D41602GA 19 HYDRAULIC FITTING KIT 1 D41605GG D41602GB 20 HYDRAULIC FITTING KIT 1 D41606 B42852GA 9 WIRING DIAGRAM REF D41606 D41600GA 13 WIRING DIAGRAM REF D41606 D41600GB 13 WIRING DIAGRAM REF D41606 D41601GA 17 WIRING DIAGRAM REF D41606 D41601GB 17 WIRING DIAGRAM REF D41606 D41602GA 21 WIRING DIAGRAM REF D41606 D41602GB 21 WIRING DIAGRAM REF D41606 D41603GA 26 WIRING DIAGRAM REF D41606 D41603GB 25 WIRING DIAGRAM/SCHEMATIC REF D41606 D41604GA 7 WIRING DIAGRAM REF D41606 D41604GB 7 WIRING DIAGRAM REF D41606 D41604GC 7 WIRING DIAGRAM REF D41606 D41604GD 7 WIRING DIAGRAM REF D41606 D42854GA 3 WIRING DIAGRAM REF D41606 D44319GA 10 WIRING DIAGRAM REF D41606 D44320GA 17 WIRING DIAGRAM REF

D41607GA D41602GA 22 AIR LINE KIT (DO NOT NEED WITH COMPRESSOR) -1

D41607GA D41602GB 22 AIR LINE KIT (DO NOT NEED WITH COMPRESSOR) -1

D42850GA D41602GA 23 AIR COMPRESSOR KIT -1 D42850GA D41602GB 23 AIR COMPRESSOR KIT -1 D42851-1 D42854GA 4 MODIFIED ENCLOSURE 1

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 34 11-06-2018

D42854GA D41600GB 14 LOWER ENCLOSURE ASSEMBLY - FIXED 1

D42855GA D41602GB 24 PLATFORM ASSEMBLY - FIXED 1 D42856GA D42855GA 15 PLATFORM WELDMENT - FIXED 1 D42861GA D41608GA 43 GUARDRAIL BUMPER KIT -1 D42861GA D41608GB 44 GUARDRAIL BUMPER KIT -1 D42866GA D42855GA 16 END GUARDRAIL WELDMENT 2 D42866GB D42855GA 17 END GUARDRAIL WELDMENT 2 D42981 D41601GA 18 ENGINE KIT 1 D42981 D41601GB 18 ENGINE KIT 1 D44321GA D41600GA 15 REAR AXLE ASSEMBLY 1 D44321GA D41600GB 15 REAR AXLE ASSEMBLY 1 D45168GA D41601GA 19 GRILL 1 D45168GA D41601GB 19 GRILL 1 D45169-1 D41601GA 20 HOOD TOP 1 D45169-1 D41601GB 20 HOOD TOP 1 EAP0014R D41603GB 26 DOUBLE SPADE QD 4 MMRC 041285EAP1614 B39374GA 6 SPADE CONNECTOR 4 B272X 039960EAP1614 B41994GA 12 SPADE CONNECTOR 2 B272X 041285EAP1614W B39373GA 8 SPADE CONNECTOR 4 B-972 041285EAP1614W D44319GA 5 FEMALE SPADE 6 B-972 041285EAR1610 B41994GA 10 RING TERMINAL WIRE END 1 B-539-10 041285EAR1610 D44319GA 8 WIRE END 2 B-539-10 041285EBR0856 D44319GA 14 WIRE END 2 D-351-56 041285EC155 B39373GA 7 DIN CONNECTOR - 10 AMP 250V 2 GDM 003962EC158 D41604GA 8 CONNECTOR BODY 1 12052978 009664EC158 D41604GD 8 CONNECTOR BODY 1 12052978 009664EC158-1 D41604GA 9 WIRE END 4 2962572 009664

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 35 11-06-2018

EC158-1 D41604GD 9 WIRE END 4 2962572 009664EC179 D41603GA 27 12VDC HEAVY DUTY RELAY 1 70101959 041407EC179 D41603GB 27 12VDC HEAVY DUTY RELAY 1 70101959 041407EC180 D41600GA 16 4 PIN RECEPTACLE 1 DT04-4P 039835EC180 D41600GB 16 4 PIN RECEPTACLE 1 DT04-4P 039835EC180-1 D41600GA 17 WEDGE LOCK 1 W4P 039835EC180-1 D41600GB 17 WEDGE LOCK 1 W4P 039835EC181 B41994GA 6 4 PIN PLUG 1 DT06-4S 039835EC181-1 B41994GA 7 4 PIN WEDGE LOCK 1 W4S-ZZ 039835EC182 B39270GA 7 WIRE TERMINAL 12 1062-14-0122 039835EC182 B39373GA 6 SOCKET 12 1062-14-0122 039835EC182 B39374GA 3 SOCKET 12 1062-14-0122 039835EC182 B41994GA 3 SOCKET 17 1062-14-0122 039835EC182 B42852GA 7 WIRE TERMINAL 12 1062-14-0122 039835EC182 D41604GA 10 WIRE END 27 1062-14-0122 039835EC182 D41604GD 10 WIRE END 27 1062-14-0122 039835EC183 A37461GA 1 WIRE TERMINAL 3 1060-14-0122 039835EC183 D41604GA 11 WIRE END 9 1060-14-0123 039835EC183 D41604GD 11 WIRE END 9 1060-14-0124 039835EC183 D44319GA 2 WIRE END 16 1060-14-0125 039835EC184 D41604GA 12 12 PIN RECEPTACLE - GRAY 1 DT04-12PA 039835EC184 D41604GD 12 12 PIN RECEPTACLE - GRAY 1 DT04-12PA 039835EC184 D44319GA 15 12 PIN GRAY RECEPTACLE 1 DT04-12PA 039835EC184-1 D39249GA 5 12 PIN WEDGE LOCK 3 W12P 039835EC184-1 D39258GA 4 12 PIN WEDGE LOCK 1 W12P 039835EC184-1 D41604GA 13 12 PIN WEDGE LOCK 1 W12P 039835EC184-1 D41604GD 13 12 PIN WEDGE LOCK 1 W12P 039835EC184-1 D42854GA 5 12 PIN WEDGE LOCK 3 W12P 039835

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 36 11-06-2018

EC184-1 D44319GA 3 WEDGE LOCK 2 W12P 039835EC184B D44319GA 1 12 PIN BLACK RECEPTACLE 1 DT04-12PB 039835EC185 B39373GA 4 PLUG - 12 PIN KEY A 1 DT06-12SA 039835EC185 B41994GA 1 12 PIN PLUG 1 DT06-12SA 039835EC185-1 B39270GA 4 WEDGE LOCK 1 W12S 039835EC185-1 B39373GA 5 WEDGELOCK FOR EC185 QD PLUG 1 W12S 039835EC185-1 B39374GA 2 12 PIN WEDGE LOCK 1 W12S 039835EC185-1 B41994GA 2 12 PIN WEDGE LOCK 1 W12S 039835EC185-1 B42852GA 4 WEDGE LOCK 1 W12S 039835EC185-1 D41604GA 14 WEDGE LOCK 1 W12S 039835EC185-1 D41604GD 14 WEDGE LOCK 1 W12S 039835EC185B B39374GA 1 12 PIN PLUG 1 DT06-12SB 039835EC185B D41604GA 15 12 PIN PLUG - BLACK 1 DT06-12SB 039835EC185B D41604GD 15 12 PIN PLUG - BLACK 1 DT06-12SB 039835EC185C B39270GA 3 12 PIN PLUG (GREEN) 1 DT06-12SC 039835EC185C B42852GA 3 12 PIN PLUG (GREEN) 1 DT06-12SC 039835EC195 D41600GA 18 6 PIN RECEPTACLE 1 DT04-6P 039835EC195 D41600GB 18 6 PIN RECEPTACLE 1 DT04-6P 039835EC195-1 D41600GA 19 WEDGE LOCK 1 W6P 039835EC195-1 D41600GB 19 WEDGE LOCK 1 W6P 039835EC196 B41994GA 4 6 PIN PLUG 1 DT06-6S 039835EC196 B41994GA 4 6 PIN PLUG 1 DT06-6S 039835EC196 B41994GA 4 6 PIN PLUG 1 DT06-6S 039835EC196 D41604GA 16 6 PIN PLUG 1 DT06-6S 039835EC196 D41604GD 16 6 PIN PLUG 1 DT06-6S 039835EC196-1 B41994GA 5 6 PIN WEDGE LOCK 1 W6S 039835EC196-1 D41604GA 17 6 PIN WEDGE LOCK 1 W6S 039835EC196-1 D41604GD 17 6 PIN WEDGE LOCK 1 W6S 039835

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 37 11-06-2018

EC197 D39249GA 6 12 PIN BULKHEAD RECEPTACLE GRAY 1 DT04-12PA-LEO1 039835EC197 D42854GA 6 12 PIN BULKHEAD RECEPTACLE GRAY 1 DT04-12PA-LEO1 039835

EC197B D39249GA 7 12 PIN BULKHEAD RECEPTACLE BLACK 1 DT04-12PB-LE01 039835

EC197B D42854GA 7 12 PIN BULKHEAD RECEPTACLE BLACK 1 DT04-12PB-LE01 039835

EC197C D39249GA 8 12 PIN BULKHEAD RECEPTACLE GREEN 1 DT04-12PC-LE01 039835



EC199 B41994GA 14 QD HOLE PLUG 3 114017 039835EC199 D41600GA 20 HOLE PLUG 4 114017 039835EC199 D41600GB 20 HOLE PLUG 4 114017 039835EC199 D41604GA 18 HOLE PLUG 10 114017 039835EC199 D41604GD 18 HOLE PLUG 10 114017 039835EC199 D44319GA 12 HOLE PLUG 8 114017 039835EC217 D38190GA 13 12 VDC RELAY 1 HE87414 009664EC217 D41604GA 19 12VDC RELAY 3 HE87414 009664EC217 D41604GC 19 12VDC RELAY 1 HE87414 009664EC217 D41604GD 19 12VDC RELAY 3 HE87414 009664EC219 B41994GA 17 PLASTISOL BOOT - 4 PIN PLUG 1 DT4S-BT 039835EC221 B41994GA 16 PLASTISOL BOOT - 6 PIN PLUG 1 DT6S-BT 039835EC222 D44319GA 4 BOOT 2 DT12P-BT 039835EC223 B39270GA 5 BOOT 1 DT12S-BT 039835EC223 B39373GA 10 BOOT 1 DT12S-BT 039835EC223 B39374GA 11 BOOT 1 DT12S-BT 039835EC223 B41994GA 15 PLASTISOL BOOT - 12 PIN PLUG 1 DT12S-BT 039835

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 38 11-06-2018

EC223 B42852GA 5 BOOT 1 DT12S-BT 039835EC280-10 D41604GA 20 10 AMP FUSE 7 70128980 041407EC280-10 D41604GD 20 10 AMP FUSE 7 70128980 041407EC280-15 D39249GA 9 15 AMP FUSE 1 1610-21-15A 041319EC280-15 D41604GA 21 15 AMP FUSE 1 1610-21-15A 041319EC280-15 D41604GD 21 15 AMP FUSE 1 1610-21-15A 041319EC280-15 D42854GA 9 15 AMP FUSE 1 1610-21-15A 041319EC424 A37461GA 2 3 PIN RECEPTACLE 1 DT04-3P 039835EC424-1 A37461GA 3 WEDGELOCK 1 W3P 039835EC425 A37461GA 4 BOOT 1 DT3P-BT 039835EC426 D39258GA 6 PLUG - 3 PIN, TRIANGLE 1 DT06-3S 039835EC426-1 D39258GA 7 WEDGE LOCK 1 W3S 039835EC430A D39249GA 10 DISPLAY - DIAGONSTIC 1 21 500 230 041893EC430A D42854GA 10 DISPLAY - DIAGONSTIC 1 21 500 230 041319EC439 B39374GA 4 PLUG - 3 CIRCUIT AMP M-N-L 1 1-480700-0 041319EC439 D39249GA 11 PLUG - 3 PIN 1 1-480700-0 041319EC439 D39258GA 8 PLUG - 3 PIN 1 1-480700-0 041319EC439 D42854GA 11 PLUG - 3 PIN 1 1-480700-0 041319EC440 D39249GA 12 PLUG - 4 PIN 2 1-480702-0 041319EC440 D42854GA 12 PLUG - 4 PIN 2 1-480702-0 041319EC442 D39249GA 13 PLUG - 12 PIN 1 1-480708-0 041319EC442 D42854GA 13 PLUG - 12 PIN 1 1-480708-0 041319EC443 D39249GA 14 PLUG - 15 PIN 4 1-480710-0 041319EC443 D39258GA 9 PLUG - 15 PIN 2 1-480710-0 041319EC443 D42854GA 14 PLUG - 15 PIN 4 1-480710-0 041319EC444 B39374GA 5 SOCKET - AMP M-N-L PLUGS 14-20 GA 3 350550-1 041319EC444 D39249GA 15 WIRE TERMINAL 50 350550-1 041319EC444 D39258GA 10 WIRE END 22 350550-1 041319

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 39 11-06-2018

EC444 D42854GA 15 WIRE TERMINAL 50 350550-1 041319EC448 D39249GA 16 CONTROLLER 1 21-510-481 041319EC448 D42854GA 16 CONTROLLER 1 21-510-481 041319EC449 D39258GA 11 REMOTE I/O 1 21-450-001 041319EC451 D39258GA 12 PLUG - 6 PIN 1 1-480704-0 041319EC499 D41604GC 22 RELAY - TIMER, 12V 1 VCM-03-60SA 040062EC508 D39249GA 17 TERMINAL BLOCK MODULE 1 21-500-340 041893EC508 D42854GA 17 TERMINAL BLOCK MODULE 1 21-500-340 041893EF13 D38190GA 7 FUSE HOLDER 2 TA-215 10-12 GA 006855EF24 D38190GA 14 5 AMP FUSE 1 AGC5 002028EF27 D38190GA 8 30AMP FUSE 1 1BX45 040240EH17 D39249GA 18 ALARM 1 505 009760EH17 D42854GA 18 ALARM 1 505 009760EH24 D41600GA 21 ALARM 102 db 1 530 009760EH24 D41600GB 21 ALARM 102 db 1 530 009760EH27 D44320GA 18 HORN 1 72100-5 003445EK8 B39270GA 2 COIL CORD 1 PCE1612-CL 041874EK8 B42852GA 2 COIL CORD 1 PCE1612-CL 041874EM58A D41603GA 28 WIPER MOTOR 2 4R1.12.R110 041584EO29 D41602GA 25 OUTLET BOX - WEATHERPROOF 1 5320-0 002028EO29 D41602GB 25 OUTLET BOX - WEATHERPROOF 1 5320-0 002028EO31 D41602GA 26 OUTLET COVER 1 238249 040098EO31 D41602GB 26 OUTLET COVER 1 238249 040098EO32 D41602GA 27 110 VAC GFI OUTLET 1 25191332 040837EO32 D41602GB 27 110 VAC GFI OUTLET 1 25191332 040837EO33 D39249GA 19 110V INLET 1 88127370 040837EO33 D42854GA 19 110V INLET 1 88127370 040837

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 40 11-06-2018

ESB113 D41608GA 13 DISCONNECT POWER DECAL (LOCATE ON ALL ENCLOSURES) 6

ESB113 D41608GB 13 DISCONNECT POWER DECAL (LOCATE ON ALL ENCLOSURES) 6

ESB148 D41608GA 20 CRUSHING DECAL (LOCATE ON SCISSOR AND WHEEL WELLS) 9

ESB148 D41608GB 20 CRUSHING DECAL (LOCATE ON SCISSOR AND WHEEL WELLS) 9

ESB149 D41608GA 5 SCISSOR SPREADER DECAL 2 ESB149 D41608GB 5 SCISSOR SPREADER DECAL 2 ESB164 D39258GA 13 TOGGLE SWITCH - 2 POS MOMENTARY 1 1TL1-6 041420ESB165-4 D39258GA 14 TOGGLE SWITCH - 2 POS MAINTAINED 2 70120169 041407ESB192 D41608GA 6 MOVING PARTS DECAL 2 ESB192 D41608GB 6 MOVING PARTS DECAL 2

ESB202 D41608GA 15 EMERGENCY CONTROLS DECAL (LOCATE ON LOWER ENCLOSURE) 1

ESB202 D41608GB 15 EMERGENCY CONTROLS DECAL (LOCATE ON LOWER ENCLOSURE) 1

ESB208 D41608GA 23 110VAC DECAL (LOCATE NEXT TO ALL OUTLETS) 2

ESB208 D41608GB 23 110VAC DECAL (LOCATE NEXT TO ALL OUTLETS) 2

ESB297 D41608GA 18 STABILIZER DECAL 2 ESB297 D41608GB 18 STABILIZER DECAL 2 ESB351 D41608GA 3 MAX NUMBER OF DECAL 2 ESB351 D41608GB 3 MAX NUMBER OF DECAL 2 ESB362 D41608GA 2 NUMBER 4 DECAL 2 ESB362 D41608GB 2 NUMBER 4 DECAL 2 ESB383 D41608GA 16 FLUID TYPE LEGEND PLATE 1 ESB383 D41608GB 16 FLUID TYPE LEGEND PLATE 1

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 41 11-06-2018

ESB387 D41608GA 21 CAUTION FAN LEGEND PLATE 1 ESB387 D41608GB 21 CAUTION FAN LEGEND PLATE 1 ESB389 D41608GA 7 DECAL - NAME PLATE 1 ESB389 D41608GB 7 DECAL - NAME PLATE 1 ESB403 D41608GA 45 PARKING BRAKE LEGEND PLATE 1 ESB403 D41608GB 45 PARKING BRAKE LEGEND PLATE 1 ESB404 D41608GA 25 REDUCED CAPACITY DECAL 2 ESB404 D41608GB 25 REDUCED CAPACITY DECAL 2 ESB434 D41608GA 27 PLATFORM CAPACITY 4 ESB434 D41608GB 27 PLATFORM CAPACITY 4 ESB460 D41604GA 23 DASH LEGEND PLATE 1 ESB460 D41604GD 23 DASH LEGEND PLATE 1 ESB463 D41608GA 26 TRAVERSE CAPACITY DECAL 4

ESB472 D41608GA 24 OPERATING INSTRUCTIONS LEGEND PLATE 3

ESB472 D41608GB 24 OPERATING INSTRUCTIONS LEGEND PLATE 3

ESB474 D41608GA 9 IGNITION SWITCH DECAL 1 ESB474 D41608GB 9 IGNITION SWITCH DECAL 1 ESB475 D41608GA 30 DECAL - FOOT CRUSHING 2 ESB475 D41608GB 30 DECAL - FOOT CRUSHING 2

ESB523 D39249GA 20 TOGGLE SWITCH - 3 POSITION MOMENTARY 3 2TL1-7 041407



ESB567 D39249GA 21 PUSH/ PULL OPERATOR 1 P9SET4RN1 003103ESB567 D42854GA 21 PUSH/ PULL OPERATOR 1 P9SET4RN1 003103

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 42 11-06-2018

ESB570 D39249GA 22 CONTACT BLOCK N/O 1 P9B1OVN 003103ESB570 D42854GA 22 CONTACT BLOCK N/O 1 P9B1OVN 003103ESB571 D39249GA 23 CONTACT BLOCK N/C 1 P9BO1VN 003103ESB571 D42854GA 23 CONTACT BLOCK N/C 1 P9BO1VN 003103ESB575 D41604GA 24 TOGGLE SWITCH - 2 POS MAINTAINED 3 P9BO1VN 003103ESB577 D39249GA 24 PANEL SEAL - TOGGLE O'RING - 7/16 ID 3 15PA87 041420ESB577 D39258GA 16 PANEL SEAL 4 15PA87 041420ESB577 D42854GA 24 PANEL SEAL - TOGGLE O'RING - 7/16 ID 2 15PA87 041420ESB588 D39258GA 17 IGNITION SWITCH 1 956-3124 009664ESB588 D41604GA 25 IGNITION SWITCH 1 956-3124 009664ESB588 D41604GD 25 IGNITION SWITCH 1 956-3124 009664

ESB590 D39249GA 25 PUSH BUTTON OPERATOR 1

P9SPL0S0 BASE WITH P9ASB3G YELLOW CAP 003103

ESB590 D42854GA 25 PUSH BUTTON OPERATOR 1

P9SPL0S0 BASE WITH P9ASB3G YELLOW CAP 003103

ESB592A D41604GA 26 TURN SIGNAL SWITCH WIRING HARNESS 1 TL-905 009664

ESB592A D41604GD 26 TURN SIGNAL SWITCH WIRING HARNESS 1 TL-905 009664

ESB593 D41604GA 27 TOGGLE SWITCH - 3 POS MAINTAINED 1 32NT392-12-C08 041420ESB593 D41604GD 27 TOGGLE SWITCH - 3 POS MAINTAINED 1 32NT392-12-C08 041420ESB597 D41604GA 28 KEYED IGNITION SWITCH -1 956-3122 004585ESB597 D41604GB 28 KEYED IGNITION SWITCH -1 956-3122 004585ESB597 D41604GC 28 KEYED IGNITION SWITCH -1 956-3122 004585ESB597 D41604GD 28 KEYED IGNITION SWITCH -1 956-3122 004585ESB63 C39365GB 8 BRAKE LIGHT SWITCH 1 SL134 006354ESB703 B39270GA 1 PENDANT ASSEMBLY 1 25649573 040837

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 43 11-06-2018

ESB719 D41608GA 11 EMERGENCY PROCEDURES DECAL 1 ESB719 D41608GB 11 EMERGENCY PROCEDURES DECAL 1

ESB761 B42852GA 1 PENDANT ASSEMBLY 1 99980632 040837

ESB90 D39258GA 18 LIGHTS LEGEND PLATE 1 ESB98 D41608GA 4 ELECTROCUTION DECAL 2 ESB98 D41608GB 4 ELECTROCUTION DECAL 2 ESB99B D41608GA 28 FOR YOUR SAFETY DECAL 2 ESB99B D41608GB 28 FOR YOUR SAFETY DECAL 2 ESL33 D41601GA 21 LIMIT SWITCH 1 E1092-B3111E-6C 041445ESL33 D41601GB 21 LIMIT SWITCH 1 E1092-B3111E-6C 041445ESL33-1 B41994GA 13 QUICK DISCONNECT 1 K1041X 041445ESL51 A37461GA 5 MAGNETIC LIMIT SWITCH 1 59135030 041857ESL57 D41602GA 28 ANGLE SENSOR 1 21-500-301 041893ESL57 D41602GB 28 ANGLE SENSOR 1 21-500-301 041893ESL58-1 B39373GA 9 CONNECTOR - M12X1 - 5 METER 2 BCC030L 042055ET21 D39249GA 26 2-CONDUCTOR TERMINAL BLOCK 1 280-901 042091ET21 D39258GA 19 2-CONDUCTOR TERMINAL BLOCK 2 280-901 042091ET21 D41604GA 29 2-CONDUCTOR TERMINAL BLOCK 19 280-901 042091ET21 D41604GD 29 2-CONDUCTOR TERMINAL BLOCK 19 280-901 042091ET21 D42854GA 26 2-CONDUCTOR TERMINAL BLOCK 1 280-901 042091ET22 D39258GA 20 3-CONDUCTOR TERMINAL BLOCK 1 280-681 042091ET22 D41604GA 30 3-CONDUCTOR TERMINAL BLOCK 6 280-681 042091ET22 D41604GD 30 3-CONDUCTOR TERMINAL BLOCK 6 280-681 042091ET22-1 D41604GA 31 3-CONDUCTOR BLOCK SPACER 1 280-324 042091ET22-1 D41604GD 31 3-CONDUCTOR BLOCK SPACER 1 280-324 042091

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 44 11-06-2018

ET23 C24774GA 5 CONDUCTOR BLOCK 3 280-633 042091ET23 D39249GA 27 4-CONDUCTOR TERMINAL BLOCK 6 280-633 042091ET23 D39258GA 21 4-CONDUCTOR TERMINAL BLOCK 2 280-633 042091ET23 D41604GA 32 4-CONDUCTOR TERMINAL BLOCK 4 280-633 042091ET23 D41604GD 32 4-CONDUCTOR TERMINAL BLOCK 4 280-633 042091ET23 D42854GA 27 4-CONDUCTOR TERMINAL BLOCK 6 280-633 042091ET23-1 C24774GA 6 SPACER 1 280-314 006309ET23-1 D39249GA 28 4-CONDUCTOR BLOCK SPACER 1 280-314 006309ET23-1 D39258GA 22 4-CONDUCTOR BLOCK SPACER 1 280-314 006309ET23-1 D41604GA 33 4-CONDUCTOR BLOCK SPACER 1 280-314 006309ET23-1 D41604GD 33 4-CONDUCTOR BLOCK SPACER 1 280-314 006309ET23-1 D42854GA 28 4-CONDUCTOR BLOCK SPACER 1 280-314 006309ET24 D39249GA 29 TERMINAL BLOCK JUMPER 2 280-402 006840ET24 D41604GA 34 TERMINAL BLOCK JUMPER 3 280-402 006840ET24 D41604GD 34 TERMINAL BLOCK JUMPER 3 280-402 006840ET24 D42854GA 29 TERMINAL BLOCK JUMPER 3 280-402 006840ET25-003.000 C24774GA 2 DIN RAIL X 3" LG 1 210-112 (X 3") 006840ET25-003.000 D39249GA 30 DIN RAIL X 3" LG 1 210-112 (X 3") 006840ET25-003.000 D39258GA 23 DIN RAIL X 3" LG 1 210-112 (X 3") 006840ET25-003.000 D42854GA 30 DIN RAIL X 3" LG 1 210-112 (X 3") 006840ET25-004.500 D41604GA 35 DIN RAIL X 4-1/2" LG 1 210-112 (X 4.5") 006840ET25-004.500 D41604GD 35 DIN RAIL X 4-1/2" LG 1 210-112 (X 4.5") 006840ET25-007.250 D41604GA 36 DIN RAIL X 7-1/4" LG 1 210-112 (X 7.25") 006840ET25-007.250 D41604GD 36 DIN RAIL X 7-1/4" LG 1 210-112 (X 7.25") 006840ET26 C24774GA 7 END BRACKET 2 249-116 042091ET26 D39249GA 31 END BRACKET 2 249-116 042091ET26 D39258GA 24 END BRACKET 2 249-116 042091ET26 D41604GA 37 END BRACKET 4 249-116 042091

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 45 11-06-2018

ET26 D41604GD 37 END BRACKET 4 249-116 042091ET26 D42854GA 31 END BRACKET 2 249-116 042091

ET27 D39249GA 32 FUSE HOLDER - AUTOMOTIVE TYPE FUSE 1 282-696 042091


ET27 D41604GD 38 FUSE HOLDER - AUTOMOTIVE TYPE FUSE 8 282-696 042091


ET28 D39249GA 33 END BKT FOR TERMINAL BLOCK 1 282-334 006309ET28 D41604GA 39 END BKT FOR TERMINAL BLOCK 1 282-334 006309ET28 D41604GD 39 END BKT FOR TERMINAL BLOCK 1 282-334 006309ET28 D42854GA 33 END BKT FOR TERMINAL BLOCK 1 282-334 006309ET29 D41604GA 40 FUSE BLOCK JUMPER 4 282-402 042091ET29 D41604GD 40 FUSE BLOCK JUMPER 4 282-402 042091EW114 D39258GA 25 12VDC LIGHT - LED 1 HD47554WL 040062EW114 D39258GB 25 12VDC LIGHT - LED 1 HD47554WL 040062EW117 D41600GA 22 LIGHT 12VDC RED LENS 2 53292 003445EW117 D41600GB 22 LIGHT 12VDC RED LENS 2 53292 003445EW117-1 D41600GA 23 LIGHT CONNECTOR 2 67005 003445EW117-1 D41600GB 23 LIGHT CONNECTOR 2 67005 003445EW118 D41600GA 24 LIGHT 12VDC WHITE LENS 2 62811 003445EW118 D41600GB 24 LIGHT 12VDC WHITE LENS 2 62811 003445EW123 D41603GA 29 LAMP - LED W/BLUNT CUT - YELLOW 2 6050A 006354EW123 D41603GB 28 LAMP - LED W/BLUNT CUT - YELLOW 2 6050A 006354EW123-1 D41603GA 30 CONNECTOR 2 94993 006354EW123-1 D41603GB 29 CONNECTOR 2 94993 006354EW154 D41604GA 41 FLASHER- SS, HD 1 275 040757

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 46 11-06-2018

EW154 D41604GD 41 FLASHER- SS, HD 1 275 040757EW24-2 D39258GA 26 GREEN INDICATOR LIGHT 2 3035-3-13-37640 041835EW24-2 D41604GA 42 GREEN INDICATOR LIGHT 1 3035-3-13-37640 041835EW24-2 D41604GB 42 GREEN INDICATOR LIGHT 1 3035-3-13-37640 041835EW24-2 D41604GD 42 GREEN INDICATOR LIGHT 1 3035-3-13-37640 041835EW24-3 D39258GA 27 RED INDICATOR LIGHT 1 3035-3-13-37610 041835EW24-3 D41604GA 43 RED INDICATOR LIGHT 2 3035-3-13-37610 041835EW24-3 D41604GB 43 RED INDICATOR LIGHT 1 3035-3-13-37610 041835EW24-3 D41604GD 43 RED INDICATOR LIGHT 2 3035-3-13-37610 041835EW24-5 D41604GA 44 YELLOW INDICATOR LIGHT 1 090-0192 041835EW24-5 D41604GD 44 YELLOW INDICATOR LIGHT 1 090-0192 041835EW55A-12 D41602GA 29 12 VDC AMBER FLASHING LIGHT 1 FF3-12P/A 009894EW55A-12 D41602GB 29 12 VDC AMBER FLASHING LIGHT 1 FF3-12P/A 009894EW58A D41603GA 31 HEADLIGHT - LED 2 1300392 009330EW58A D41603GB 30 HEADLIGHT - LED 2 1300392 009330EW63 D39258GA 28 LAMP 1 DL-13 W/#67 040062EW64L D39258GA 29 BULB - 12V, LED 1 AUT67-0CW-014V 040837EW72R D41608GA 34 REFLECTOR - RED 2 UAL984R 040640EW72R D41608GB 35 REFLECTOR - RED 2 UAL984R 040640EW72Y D41608GA 33 REFLECTOR - AMBER 6 58714 040640EW72Y D41608GB 34 REFLECTOR - AMBER 6 58714 040640F511 D41601GA 22 BRAKE LEVER - OVERCENTER 1 1213400 009831F511 D41601GB 22 BRAKE LEVER - OVERCENTER 1 1213400 009831F513 C39365GA 5 BRAKE HOSE -2 36722 009831F515 C39365GA 2 BRAKE HOSE -1 F515 009831F515 D44321GA 10 BRAKE HOSE - DROP 1 F515 009831FD115 D44321GA 11 AXLE - PLANETARY, 10K 1 415B12L062 042099FD26 D44321GA 12 LEAF SPRING - REAR STD 2 8 LEAF H.D 040324

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 47 11-06-2018

FD31 D26542GA 2 LEAF SPRING 2 6 LEAF-SHALLOW 040324FD47 D26542GA 1 FRONT AXLE 1 S1-30539 040623FD59 D44320GA 19 BRAKE - MECHANICAL 1 00-13011 040326FW105B D41600GA 25 TIRE ASSEMBLY - HEAVY DUTY 4 FW105B 006013FW105B D41600GB 25 TIRE ASSEMBLY - HEAVY DUTY 4 FW105B 006013GA04 D41600GA 26 SIGHT GAGE 1 FSA-127-1.1-T-12 003962GA04 D41600GB 26 SIGHT GAGE 1 FSA-127-1.1-T-12 003962GA13 D41604GA 45 FUEL GAUGE 1 104246 040062GA13 D41604GD 45 FUEL GAUGE 1 104246 040062GA22 D39262GA 16 GAGE -2 4FLU3 040240

GA22 D42850GA 7 GAUGE - AIR PRESSURE W/PORT ON SIDE 1 4FLU3 040240

GA40 D41604GA 46 GAUGE - ANNUNCIATOR 1 EN204-SG-12 041184GA40 D41604GD 46 GAUGE - ANNUNCIATOR 1 EN204-SG-12 041184GE122-26 D44320GA 20 REAR TRANSMISSION MOUNT 1 02045-0014 041382GE154-1A D44319GA 13 GLOW PLUG RELAY PLUG 1 421-7705 041746GE154A D44319GA 6 GLOW PLUG RELAY 1 421-9374 041746GE182 D44320GA 21 DIESEL ENGINE - 67HP 1 V3600LFE-2-TPEM 041184GE182-13 D38190GA 1 DUAL SHEAVE PULLEY 1 3A851-72351 041184GE182-3A D44320GA 22 FUEL PUMP 1 610-1050 POSI-FLO 006354GE185 D44320GA 23 ISOLATOR 2 52545-1 041782GW10 D24997GC 5 WINDOW - REAR 1 9-DIG-00236 041325GW10 D41603GA 32 REAR WINDOW - SLIDING 1 9-DIG-00236 041325GW11 D41603GA 33 WINDSHIELD 1 9-DIG-00336 041325GW12 D24997GD 6 WINDOW - SIDE (SMALL) 1 9-DIG-00343 041325GW12 D41603GA 34 WINDOW - 8 X 24-1/2 STATIC 2 9-DIG-00343 041325GW13 D24997GA 7 WINDOW SEAL 1 051135-08612 041581GW13 D24997GB 7 WINDOW SEAL 1 051135-08612 041581

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 48 11-06-2018

GW13 D24997GC 7 WINDOW SEAL 1 051135-08612 041581GW13 D24997GD 7 WINDOW SEAL 1 051135-08612 041581GW1L D24997GA 8 WINDOW - DRIVER SIDE 1 #9-DIG-00027 041325GW1R D24997GB 9 WINDOW - PASSENGER SIDE 1 9-DIG-00028 041325GW7 D41603GA 35 WIPER ARM 2 TTI-500-610 041126GW8 D41603GA 36 WIPER BLADE - 14" 2 TTI500611 041126HCM122D D26542GA 3 STEERING CYLINDER 1 321-109 041866HCM129 D39126GA 26 HYDRAULIC CYLINDER 2 X 1 X 54" 1 HCM129 003401HCM211 D39105GA 15 LIFT CYLINDER - TELESCOPIC 2 D10302 040491HCM212A D41600GA 27 CYLINDER - 3 X 2 X 10 STABILIZER 2 320-803 041866HCM212A D41600GB 27 CYLINDER - 3 X 2 X 10 STABILIZER 2 320-803 041866HF10 D41600GA 28 FILTER 1 10048 007938HF10 D41600GB 28 FILTER 1 10048 007938HF10-1 D41608GA 32 FILTER 1 10049 007938HF10-1 D41608GB 33 FILTER 1 10049 007938HF27A D41600GA 29 FILTER/BREATHER 1 LHA #ABB-10N 005040HF27A D41600GB 29 FILTER/BREATHER 1 LHA #ABB-10N 005040HF9 D41601GA 23 3/4" NPT SUCTION STRAINER 1 105-504 005452HF9 D41601GB 23 3/4" NPT SUCTION STRAINER 1 105-504 005452HHF104 D44320GA 24 FITTING 1 C3359 X 2 009831HHF160 C39365GB 1 NPT PLUG 1 5406-HP-2 009831HHF160 D41603GA 37 NPT PLUG 1 5406-HP-2 009831HHF160 D41603GB 31 NPT PLUG 1 5406-HP-2 009831HHF201 D39262GA 13 NPT NIPPLE 2 5404-4-4- MP-MP HEX 009831HHF201 D41605GC 8 NPT NIPPLE 1 5404-4-4- MP-MP HEX 009831HHF201 D41605GD 1 NPT NIPPLE 13 5404-4-4- MP-MP HEX 009831HHF201 D42850GA 8 1/4" HEX NIPPLE 1 5404-4-4- MP-MP HEX 009831HHF203 D39262GA 45 ELBOW - 90 DG STREET 1 5502-4-4 009831

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 49 11-06-2018

HHF203 D42850GA 9 NPT STREET ELBOW 1 5502-4-4 009831HHF225 D41605GC 7 SWIVEL ADAPTER 1 1826308 009831HHF225 D41605GD 1 SWIVEL ADAPTER 12 1826308 009831HHF229 D39262GA 7 ADAPTER 1 C5205 X 4 009831HHF230 D41605GF 13 MALE CONNECTOR 2 C5315 X 4 009831HHF230 D41605GG 5 MALE CONNECTOR 2 C5315 X 4 009831HHF2303 D41605GC 3 MALE CONNECTOR 1 6400-4-6-0 009831HHF234 D39262GA 43 ELBOW - 90 DG MALE 1 C5405X4 009831HHF244 D41605GF 1 TEE - SWIVEL NUT BRANCH 1 6600-4-4-4 009831HHF244 D41605GG 1 TEE - SWIVEL NUT BRANCH 1 6600-4-4-4 009831HHF260 D41602GA 30 PLUG - 1/4 NPT HEX SOCKET 2 5406-HP04 009831HHF260 D41602GB 30 PLUG - 1/4 NPT HEX SOCKET 2 5406-HP04 009831HHF301 D39126GA 27 3/8" HEX NIPPLE REF C3069 X 6 009831HHF301 D41605GF 9 NPT NIPPLE 1 C3069 X 6 009831HHF31003 D41600GA 30 MALE TO MALE CONNECTOR 2 3474-06-06-NWO 009831HHF31003 D41600GB 30 MALE TO MALE CONNECTOR 2 3474-06-06-NWO 009831

HHF31113 D41600GA 31 RUN TEE - MALE TO FEMALE ORB 2 6835-06-06-06-NWO-FG 009831

HHF31113 D41600GB 31 RUN TEE - MALE TO FEMALE ORB 2 6835-06-06-06-NWO-FG 009831

HHF3171 D44320GA 25 FITTING 1 C3109X6X2 009831

HHF325 D39126GA 28 ADAPTER - STRAIGHT THD O-RING SWIVL REF 900-6-6-0 009831

HHF325 D41605GF 11 SWIVEL ADAPTER 1 900-6-6-0 009831HHF329 D39262GA 25 MALE ADAPTER 1 C5205X6 009831HHF329 D41607GA 1 MALE ADAPTER 1 C5205X6 009831HHF3294 D42850GA 10 MALE ADAPTER 3/8-1/2 1 C5205X6X8 009831

HHF330 D41600GA 32 O-RING CONNECTOR - STRAIGHT THREAD 2 C5315 X 6 009831

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 50 11-06-2018

HHF330 D41600GB 32 O-RING CONNECTOR - STRAIGHT THREAD 2 C5315 X 6 009831

HHF330 D41605GB 1 MALE CONNECTOR 1 C5315 X 6 009831HHF330 D41605GC 2 MALE CONNECTOR 4 C5315 X 6 009831HHF330 D41605GD 6 MALE CONNECTOR 3 C5315 X 6 009831HHF330 D41605GF 19 MALE CONNECTOR 2 C5315 X 6 009831

HHF330 D44320GA 26 O-RING CONNECTOR - STRAIGHT THREAD 2 C5315 X 6 009831

HHF3304 D41605GD 3 MALE CONNECTOR 6 C5315 X 6 X 8 009831HHF333 D41605GD 1 45° SWIVEL ELBOW 5 C5356X6 009831HHF333 D41605GF 6 45° SWIVEL ELBOW 1 C5356X6 009831HHF3343 D39126GA 29 90° MALE ELBOW 3/8-3/8 REF 219669 009831HHF3343 D41605GF 8 90° MALE ELBOW 1 219669 009831HHF3344 D39262GB 30 90° MALE ELBOW 1 (2) 2024-8-6S 009831HHF3344 D41607GA 2 90° MALE ELBOW 1 2024-8-6S 009831HHF336 D39262GA 29 90° SWIVEL ELBOW 1 1680274 009831HHF336 D41605GC 4 90° SWIVEL ELBOW 2 1680274 009831HHF336 D41605GC 12 ELBOW - 90 DG SWIVEL NUT 2 1680274 009831HHF336 D41605GD 3 90° SWIVEL ELBOW 16 1680274 009831HHF337 D39126GA 30 90° MALE CONNECTOR REF 2062-6-6S 009831HHF337 D41600GA 33 90° MALE CONNECTOR 6 2062-6-6S 009831HHF337 D41600GB 33 90° MALE CONNECTOR 6 2062-6-6S 009831HHF337 D41603GA 38 90° MALE CONNECTOR 1 2062-6-6S 009831HHF337 D41603GB 32 90° MALE CONNECTOR 1 2062-6-6S 009831HHF337 D41605GE 21 90° MALE ELBOW 6 2062-6-6S 009831HHF337 D41605GF 5 90° MALE ELBOW 3 2062-6-6S 009831HHF3374 D41605GD 1 90° MALE ELBOW 2 C5515X6X8 009831HHF343 D39262GA 28 SWIVEL NUT TEE 1 6602-6-6-6 009831

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 51 11-06-2018

HHF343 D41605GC 13 TEE - SWIVEL NUT RUN 2 6602-6-6-6 009831HHF3541 D41600GA 34 ADAPTER - 3/8 STRAIGHT TO 1/8 NPT 2 6405-06-02-0 009831HHF3541 D41600GB 34 ADAPTER - 3/8 STRAIGHT TO 1/8 NPT 2 6405-06-02-0 009831HHF357 D41605GC 14 PLUG 1(3) 6408-6 009831HHF369 D44320GA 27 UNION - HEX 2 2403-06-06 009831HHF371 D39262GB 34 NUT 4 306-6 009831HHF371 D41605GF 15 NUT 8 306-6 009831HHF371 D41607GA 5 NUT 4 306-6 009831HHF372 D39262GB 38 BULKHEAD 4 292351 009831HHF372 D41605GF 16 BULKHEAD 8 292352 009831HHF372 D41607GA 8 BULKHEAD 4 292352 009831HHF401 D39262GA 22 NPT NIPPLE 2 C3069X8 009831

HHF401 D41603GA 39 NPT NIPPLE (ASSEMBLE TO ENGINE FOR HEATER HOSE) 1 C3069X8 009831

HHF401 D42850GA 11 HEX NIPPLE 1/2" NPT 2 C3069X8 009831HHF403 D39262GA 5 90° STREET ELBOW 3 5502-8-8 009831HHF403 D42850GA 12 ELBOW - 90 DG STREET - 1/2" NPT 1 5502-8-8 009831HHF404 D39262GA 44 ELBOW - 45 DG STREET 1 C3359X8 009844HHF406 D39262GA 3 NPT TEE 1 C3709X8 009831

HHF407-15 D41603GA 40 HOSE END (ASSEMBLE TO ENGINE FOR HEATER HOSE) 2 4738-8-8B 009831

HHF409 D39262GA 11 NPT STRAIGHT SWIVEL 2 1404-8-8 009831HHF4101 D39262GA 33 1/2 ID HOSE X 66" LG 1 8LOLA 009831HHF4101 D39262GB 35 1/2 ID HOSE X 36" LG 1 8LOLA 009831HHF4101 D39262GB 37 1/2 ID HOSE X 27" LG 1 8LOLA 009831HHF4101 D39262GB 39 1/2 ID HOSE X 190" LG 1 8LOLA 009831HHF4101 D41607GA 4 1/2 ID HOSE X 96" LG 1 8LOLA 009831HHF4101 D41607GA 7 1/2 ID HOSE X 27" LG 1 8LOLA 009831

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 52 11-06-2018

HHF4101 D41607GA 9 1/2 ID HOSE X 190" LG 1 8LOLA 009831HHF4101-1 D39262GA 32 HOSE END 2 288-0809 009831HHF4101-1 D39262GB 32 HOSE END 6 (2) 288-0809 009831HHF4101-1 D41607GA 3 HOSE END 6 288-0809 009831

HHF4133 D41603GA 41 NPT ADAPTER (ASSEMBLE TO ENGINE FOR HEATER HOSE) 1 2040-6-8S 009831

HHF4172 D39262GA 6 NPT REDUCER 3 C3109 X 8 X 4 009831HHF429 D41600GA 35 MALE ADAPTER 3 2021-6-8S 009831HHF429 D41600GB 35 MALE ADAPTER 3 2021-6-8S 009831HHF430 D41605GD 2 MALE CONNECTOR 10 6400-8-8-0 009831HHF430 D41605GE 14 MALE CONNECTOR 4 6400-8-8-0 009831HHF4303 D41605GC 1 MALE CONNECTOR 2 1643811 009831HHF4306 D41605GB 8 MALE CONNECTOR 1 C5315X8X12 009831HHF4306 D41605GD 2 MALE CONNECTOR 11 C5315X8X12 009831HHF433 D41605GB 3 45° SWIVEL ELBOW 2 1681067 009831HHF433 D41605GC 11 45° SWIVEL ELBOW 1 1681067 009831HHF433 D41605GD 2 45° SWIVEL ELBOW 9 1681067 009831HHF436 D41600GA 36 ELBOW - 90 DG SWIVEL NUT 1 1680337 009831HHF436 D41600GB 36 ELBOW - 90 DG SWIVEL NUT 1 1680337 009831HHF436 D41605GA 6 90° SWIVEL ELBOW 1 1680337 009831HHF436 D41605GB 4 90° SWIVEL ELBOW 1 1680337 009831HHF4373 D41605GC 6 90° MALE ELBOW 2 C5515X8X6 009831HHF4373 D41605GF 12 90° MALE ELBOW 2 C5515X8X6 009831HHF4373 D41605GG 4 90° MALE ELBOW 2 C5515X8X6 009831HHF4375 D41605GA 2 90° MALE ELBOW 1 C5515X8X10 009831HHF4375 D41605GB 6 MALE ELBOW 1 C5515X8X10 009831HHF4375 D41605GD 2 90° MALE ELBOW 7 C5515X8X10 009831HHF443 D41605GB 5 TEE 1 6602-8-8-8-8 009831

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 53 11-06-2018

HHF467 D41600GA 37 AN CAP 1 304-C-8 009831HHF467 D41600GB 37 AN CAP 1 304-C-8 009831HHF601 D41600GA 38 HEX NIPPLE 3/4" NPT 1 C3069 X 12 009831HHF601 D41600GB 38 HEX NIPPLE 3/4" NPT 1 C3069 X 12 009831HHF601 D41601GA 24 HEX NIPPLE 3/4" NPT 2 C3069 X 12 009831HHF601 D41601GB 24 HEX NIPPLE 3/4" NPT 2 C3069 X 12 009831HHF6264 D41605GE 25 REDUCER 1 C5015 X 12 X 8 009831HHF633 D41605GE 4 45DEG SWIVEL ELBOW 1 6502-12-12 009831HHF634 D41605GE 24 90ｰ MALE ELBOW 2 C5405 X 12 009831HHF636 D41605GA 4 90° SWIVEL ELBOW 1 1680463 009831HHF636 D41605GE 5 90° SWIVEL ELBOW 1 1680463 009831HHF637 D41605GA 3 MALE CONNECTOR 1 C5515X12 009831HHF637 D41605GE 15 90° MALE ELBOW 1 C5515X12 009831HHF643 D41605GE 23 SWIVEL TEE 1 C5706X12 009831HHF8176 D41600GA 39 NPT REDUCER BUSHING 1 C3109X16X12 009831HHF8176 D41600GB 39 NPT REDUCER BUSHING 1 C3109X16X12 009831HHF8176 D41605GE 17 NPT REDUCER 1 C3109X16X12 009831HHF859 D41601GA 25 1" HEX HEAD PLUG 1 5406-P-16 009831HHF859 D41601GB 25 1" HEX HEAD PLUG 1 5406-P-16 009831HHFM2260 D41601GA 26 METRIC PLUG 2 8555-H22 009831HHFM2260 D41601GB 26 METRIC PLUG 2 8555-H22 009831HOSE A B30172GA 2 HOSE ASSEMBLY -1 HOSE B B30172GA 3 HOSE ASSEMBLY -1 HP118 D42850GA 13 GEAR PUMP 1 SNP2-17DCI-06 002540

HP184 D44320GA 28 GEAR PUMP 1 SNP2NN/019LN06SAP1E6E5NNNN/NNNNN 005517

HR9 D39126GA 31 HOSE REEL - AIR -1 P-LP-425 040697HR9 D42850GA 14 HOSE REEL 1 P-LP-425 040697

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 54 11-06-2018

HR9 D42855GA 18 HOSE REEL - AIR (1) P-LP-425 040697HTR19A D38190GA 3 COMPRESSOR 1 75R8542 040394HTR23A D44320GA 29 OIL PAN HEATER -1 OLT221515 041746HTR3 D41603GA 42 HEATER HOSE X 75" LG 1 CQ1726 040757HTR37 D38190GA 9 ROOFTOP AIR CONITIONER UNIT 1 R-6100-4P 040394HTR37-1 B30172GA 1 INSTALLATION KIT 1 78R1505 040394

HTR37-2 D38190GA 11 A/C SYSTEM CHARGE (R134A) 1

HOSE INSTALL/SYSTEM CHARGE (LABOR) 040394

HTR47 D41603GA 43 HEATER ASSEMBLY - 12 VDC 1 R-2020-0P 040394HTR48 D41603GA 44 ELBOW - 90°, 5/8 HOSE 2 70R7650 040394HTR51 D44320GA 30 LOWER RADIATOR HOSE 1 20584 040757HTR53 D44320GA 31 COOLER - TRANSMISSION 1 240516 040757HV194 D41601GA 27 3/4" NPT GATE VALVE 1 438 3/4 011148HV194 D41601GB 27 3/4" NPT GATE VALVE 1 438 3/4 011148HV258 UMA0266 23 HAND PUMP SECTION 1 CP11629 005517HV258 UMA0271 23 HAND PUMP SECTION 1 CP11629 005517HV258-02 UMA0266 23A HAND PUMP CARTRIDGE -1 CP602-A01-B-O 002540HV258-02 UMA0271 23A HAND PUMP CARTRIDGE -1 CP602-A01-B-O 002540HV267 UMA0266 2 O'RING 12 2-115 BUNA N 70 005040HV267 UMA0271 2 O'RING 12 2-115 BUNA N 70 005040HV269A UMA0266 6 SPOOL SHIFTER 1 BY DESCRIPTION 007938HV269A UMA0271 6 SPOOL SHIFTER 1 BY DESCRIPTION 007938HV280-HP D41600GA 40 PRESSURE SWITCH 2 W57174 041703HV280-HP D41600GB 40 PRESSURE SWITCH 2 W57174 041703HV282 D39126GA 32 CHECK VALVE - DOUBLE PILOT 1 CP410-1-B-6S-0 002540HV300-13 UMA0266 3 SAE 2 PLUG 6 22S-S03 007938HV300-13 UMA0271 3 SAE 2 PLUG 8 22S-S02 007938

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 55 11-06-2018

HV300-14 UMA0266 4 SAE 4 PLUG 14 22S-S04 007938HV300-14 UMA0271 4 SAE 4 PLUG 18 22S-S04 007938HV300-15 UMA0266 5 SAE 6 PLUG 3 22S-S06 007938HV300-15 UMA0271 5 SAE 6 PLUG 3 22S-S06 007938HV316-12VA-5.0 D41602GA 31 HOLDING VALVE - 12VDC, 5 GPM 2 HV316-12VA-5.0 007938HV316-12VA-5.0 D41602GB 31 HOLDING VALVE - 12VDC, 5 GPM 2 HV316-12VA-5.0 007938HV320 D41603GA 45 VALVE - STEERING 1 HV320 007938HV320 D41603GB 33 VALVE - STEERING 1 HV320 007938HV323 D41601GA 28 DUAL CYLINDER CONTROL VALVE 1 HV323 007938HV323 D41601GB 28 DUAL CYLINDER CONTROL VALVE 1 HV323 007938HV620 D41600GA 41 VALVE - DUAL PO CHECK 2 CKCS XCN YEI 007938HV620 D41600GB 41 VALVE - DUAL PO CHECK 2 CKCS XCN YEI 007938

LAL10673 D41608GA 14 LANYARD DECAL (LOCATE NEXT TO LANYARDS ON TOEBOARDS) 8

LAL10673 D41608GB 14 LANYARD DECAL (LOCATE NEXT TO LANYARDS ON TOEBOARDS) 8

LD0013 D39258GA 30 UCS LEGEND PLATE 1

LD0056 D39249GA 34 LOWER CONTROL STATION LEGEND PLATE 1

LD0056 D42854GA 34 LOWER CONTROL STATION LEGEND PLATE 1

LD0095 D41608GA 17 135PSI DECAL 4 LD0095 D41608GB 17 135PSI DECAL 4 LD0355 D41608GA 44 APPROACH DISTANCE DECAL 1 LD0355 D41608GB 44 APPROACH DISTANCE DECAL 1 LD0500 D41608GA 40 LAL LOGO 2 LD0500 D41608GB 41 LAL LOGO 2 LD0537 D41604GD 48 LEGEND PLATE - DASH, OPEN 1

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 56 11-06-2018

LD0545 D41608GA 38 ANSI DECAL 1 LD0545 D41608GB 39 ANSI DECAL 1 LD0547 D41608GA 10 DECAL - HOOD PROP 1 LD0547 D41608GB 10 DECAL - HOOD PROP 1 LD0556 D41608GA 41 DECAL - ANNUAL NSPECTION 1 LD0556 D41608GB 42 DECAL - ANNUAL NSPECTION 1 LD0568 D41608GA 8 DECAL - SERIAL # 1 LD0568 D41608GB 8 DECAL - SERIAL # 1 LD0590 D41604GA 49 LEGEND PLATE - DASH, CLOSED 1 LD0652 D41604GB 50 LEGEND PLATE - IND LTS 1 M1012 D41608GA 12 REFLECTIVE TAPE 2 X 10" 12 S-6736 040547M1027 D39249GA 35 STRAIN RELIEF WITH WIRE HOLES 1 CD13N9-BK 041199M1027 D42854GA 35 STRAIN RELIEF WITH WIRE HOLES 1 CD13N9-BK 041199M1070 D41601GA 29 HANDLE 1 4PE15 040240M1070 D41601GB 29 HANDLE 1 4PE15 040240M1109 D39258GA 31 COIL CORD 1 4-8094-00-91W 041279M1109 D39258GB 31 COIL CORD 1 4-8094-00-91W 041279M1195 D41602GA 32 1/2" HITCH PIN X 3.5 2 98485A515 006043M1195 D41602GB 32 1/2" HITCH PIN X 3.5 2 98485A515 006043M1245 D41602GA 33 WIRE CLIP - 1/2 1 RBC-1/2-50 009664M1245 D41602GB 33 WIRE CLIP - 1/2 1 RBC-1/2-50 009664M1247 D41608GA 46 HOLE PLUG 34 99190819 001078M1247 D41608GB 46 HOLE PLUG 34 99190819 001078M1300 D41608GA 42 CORROSION INHIBITOR 3 VPCI-101 041886M1300 D41608GB 43 CORROSION INHIBITOR 3 VPCI-101 041886

M1311 (1309-17) D41602GA 34 WEARSTRIP-ADHESIVE 0.050 X 2-1/2" UHMW X 8" LG 4 AV6640AFB X 0.050 041974

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 57 11-06-2018

M1311 (1309-17) D41602GB 34 WEARSTRIP-ADHESIVE 0.050 X 2-1/2" UHMW X 8" LG 4 AV6640AFB X 0.050 041974

M1323 D41608GA 39 REFLECTIVE TAPE X 12" LG (RED SECTION+WHITE SECTION) 2 4TDP8 040240

M1343 D41600GA 42 MUD FLAP (PAIR) 1 B2014LSP 042050M1343 D41600GB 42 MUD FLAP (PAIR) 1 B2014LSP 042050M1344 D41608GA 19 MANUAL ENCLOSURE 1 01-473 042086M1344 D41608GB 19 MANUAL ENCLOSURE 1 01-473 042086M1573 C24998GD 8 ADJUSTABLE ARM MOUNT 1 10433 003445M19 D39249GA 36 CHAIN X 16" LG 1 3599T48 (X 16") 006043M19 D42854GA 36 CHAIN X 16" LG 1 3599T48 (X 16") 006043M510 D39126GA 33 WIRE CLIP - 1/4 4 RBC 1/4 009664M510 D39258GA 32 WIRE CLIP - 1/4 1 RBC 1/4 009664M510 D39258GB 32 WIRE CLIP - 1/4 1 RBC 1/4 009664M529 D41603GB 34 STEP TAPE - 6 X 24 3 6970T34 006043M530AWF-025 D39126GA 34 CABLE CARRIER X 25 LINKS 1 162P-II-1.9 X 25 003214M533 D39258GA 33 SNAP PLUG - 1/2" 1 1042 002028M625 UMA0266 22 ROPE X 20" LG 1 3838T531 006043M625 UMA0271 15 ROPE X 22" LG 1 3838T531 006043M640C D39126GA 35 SPRING HINGE 4 N184-580 006693M640C D42855GA 19 SPRING HINGE 4 N184-580 006693M654 D41603GB 35 LATCH 1 S62-40-151-3 040447M68 D41601GA 30 HOSE CLAMP 3 5236 040757M68 D41601GB 30 HOSE CLAMP 3 5236 040757M710 D41603GA 46 EDGE PROTECTOR X 36" LG 1 100 B3 X 1/8 040350M710 D41603GB 36 EDGE PROTECTOR X 36" LG 1 100 B3 X 1/8 040350M725 D41603GA 47 QD PORT 1 PD342 003947M725 D41603GB 37 QD PORT 1 PD342 003947

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 58 11-06-2018

M725 D41605GC 9 QD -1 PD342 003947M725 D41605GD -1 QD 14 PD342 003947M726 D41603GA 48 QD CAP 1 PD6-285 009831M726 D41603GB 38 QD CAP 1 PD6-285 009831M726 D41605GC 10 QD CAP -1 PD6-285 009831M726 D41605GD -1 QD CAP 15 PD6-285 009831M732 D39126GA 36 LANYARD 2 87900551 004588M732 D41602GA 35 LANYARD 2 87900551 004588M732 D41602GB 35 LANYARD 2 87900551 004588M738 D39126GA 37 HITCH PIN - 3/8 X 2 2 DRI-53X 040779

M745 D24999GE 51 1/4" TK RUBBER SHEET X 4 X 37-1/2" LG 1 6893T37 006043

M745 D24999GF 51 1/4" TK RUBBER SHEET X 4 X 37-1/2" LG 1 6893T37 006043

M745 D41603GA 49 RUBBER MAT X 7-1/4 X 12" 1 6893T37 006043M745 D41603GB 39 1/4" TK RUBBER SHEET X 4 X 37-1/2" 2 6893T37 006043M745 D41603GB 40 1/4" RUBBER MAT X 7-1/4 X 12" 1 6893T37 006043M777 D41600GA 43 TWIN CLAMP 8 2160/160-DPP 039802M777 D41600GB 43 TWIN CLAMP 8 2160/160-DPP 039802M782F D24999GA 41 CHAIN SLEEVE X 12" LG 1 NHS-114 009831M782F D24999GB 41 CHAIN SLEEVE X 12" LG 1 NHS-114 009831M782F D24999GC 41 CHAIN SLEEVE X 12" LG 1 NHS-114 009831M782F D24999GD 41 CHAIN SLEEVE X 12" LG 1 NHS-114 009831M849 D26542GA 15 CABLE CLAMP 2 RBC-3/8 009664M860 D39249GA 37 THUMB GUARD 3 4060802 041159M860 D39258GA 34 THUMB GUARD 4 4060802 041159M860 D41604GA 51 THUMB GUARD 4 4060802 041159M860 D41604GD 51 THUMB GUARD 1 4060802 041159

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 59 11-06-2018

M860 D42854GA 37 THUMB GUARD 2 4060802 041159M871 C24774GA 3 STRAIN RELIEF 2 3234 039960

M871 D39249GA 38 STRAIN RELIEF - 3/4 NPT BLACK NYLON 1 3234 039960



M872 D39258GB 35 STRAIN RELIEF - 1/2 NPT BLACK NYLON 1 3231 039960

M873 C24774GA 11 STRAIN RELIEF 2 3200 039960


M873 D41602GB 36 STRAIN RELIEF - 1/2 NPT BLACK NYLON 1 3200 039960

M874 C24774GA 12 NUT 2 8463 039960M874 D39249GA 39 LOCKNUT - 1/2" NPT BLACK NYLON 1 8463 039960M874 D39258GA 36 LOCKNUT - 1/2" NPT BLACK NYLON 3 8463 039960M874 D39258GB 36 LOCKNUT - 1/2" NPT BLACK NYLON 1 8463 039960M874 D42854GA 39 LOCKNUT - 1/2" NPT BLACK NYLON 1 8463 039960M875 C24774GA 2 NUT 4 8465 039960M875 D39249GA 40 LOCKNUT - 3/4" NPT BLACK NYLON 1 8465 039960M875 D42854GA 40 LOCKNUT - 3/4" NPT BLACK NYLON 1 8465 039960M876 A37461GA 6 SPLIT TUBING X 10" LG 1 1636 039960M876 B39373GA 3 5/16 SPLIT TUBING X 310" LG 1 1636 039960M876 B39374GA 7 5/16 SPLIT TUBING X 24" LG 1 1636 039960M876 B41994GA 9 TUBING X 160" LG 1 1636 039960M876 D44319GA 11 5/16" SPLIT TUBING X 310" LG 1 1636 039960M877 B39373GA 2 1/2 SPLIT TUBING X 30" LG 1 1639 039960

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 60 11-06-2018

M877 B39374GA 9 1/2 SPLIT TUBING X 444" LG 1 1639 039960M877 B41994GA 8 TUBING X 333" LG 1 1638 039960M877 D44319GA 9 1/2" SPLIT TUBING X 28" LG 1 1638 039960M878 B39374GA 8 3/4 SPLIT TUBING X 36" LG 1 1642 039960M880 D41603GA 50 SEAT BELT KIT 2 M7206 007357M880 D41603GB 41 SEAT BELT 2 M7206 007357M882 D41603GA 51 MIRROR - REAR VIEW 1 7618 009664M883 D41603GA 52 SEAT - VINYL WITH SLIDERS 2 WM682 040384M883-1 D41603GB 42 SEAT SLIDER 2 WM1250 040384M899 D41603GA 53 FAN - 12VDC, 2 SPEED 1 200112 040385M903 C24998GA 3 MIRROR (STANDARD) 1 TL-97654 009664M903 C24998GD 3 MIRROR (STANDARD) 1 TL-97654 009664M911 D24999GA 40 CHAIN X 11 LINKS 1 3592T32 006043M911 D24999GB 40 CHAIN X 11 LINKS 1 3592T32 006043M911 D24999GC 40 CHAIN X 11 LINKS 1 3592T32 006043M911 D24999GD 40 CHAIN X 11 LINKS 1 3592T32 006043M916 D24999GA 2 DOOR SEAL X 137" LG 1 62000S 039509M916 D24999GB 2 DOOR SEAL X 137" LG 1 62000S 039509M916 D24999GC 49 DOOR SEAL X 100" LG 1 62000S 039509M916 D24999GD 49 DOOR SEAL X 100" LG 1 62000S 039509M939 D41603GB 43 SEAT 2 102720 040798M942 B39270GA 6 HEAT SHRINK X 4" LG 1 TSC-221-1/2 009664M942 B41994GA 18 HEAT SHRINK X 4" LG 4 TSC-221-1/2 009664M942 B42852GA 6 HEAT SHRINK X 4" LG 1 TSC-221-1/2 009664M942 D41604GA 52 HEAT SHRINK X 4" LG 4 TSC-221-1/2 009664M942 D41604GD 52 HEAT SHRINK X 4" LG 4 TSC-221-1/2 009664M942 D44319GA 7 HEAT SHRINK X 4" LG 1 TSC-221-1/2 009664M947 D41608GA 31 FIRE EXTINGUISHER 1 A460 005454

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 61 11-06-2018

M947 D41608GB 32 FIRE EXTINGUISHER 1 A460 005454M948 D41608GA 22 BRACKET 1 A862 005454M948 D41608GB 22 BRACKET 1 A862 005454M958 C24998GB 4 MIRROR (LOW MOUNT) 1 3661 040757M958 C24998GC 4 MIRROR (LOW MOUNT) 1 3661 040757MAN-A92.7-2014 D41608GA 37 ANSI MANUAL 1 PH-30RP41 041082MAN-A92.7-2014 D41608GB 38 ANSI MANUAL 1 PH-30RP41 041082MH107 D44320GA 32 U-BOLT 2 63651 041297MH130 D24999GA 23 GRAB HANDLE 1 H-9051 007357MH130 D24999GB 23 GRAB HANDLE 1 H-9051 007357MH130 D24999GC 23 GRAB HANDLE 1 H-9051 007357MH130 D24999GD 23 GRAB HANDLE 1 H-9051 007357MH130 D41603GA 54 GRAB HANDLE 2 H-9051 007357MH130 D41603GB 44 GRAB HANDLE 2 H-9051 007357MH137A D41600GA 44 PINTLE HOOK - RIGID TYPE -1 PH-30RP41 041082MH137A D41600GB 44 PINTLE HOOK - RIGID TYPE -1 PH-30RP41 041082MH138 D41603GA 55 LATCH - QUARTER TURN 2 AH520B-NI 040350MH138 D41603GB 45 LATCH - QUARTER TURN 2 AH520B-NI 040350MH144 D41603GA 56 CLEVIS PIN - 5/8 DIA 1 97245A555 006043MH144 D41603GB 46 CLEVIS PIN - 5/8 DIA 1 97245A555 006043MH159 D41600GA 45 TOW HOOK 4 14160-C131 006910MH159 D41600GB 45 TOW HOOK 4 14160-C131 006910MH160 D24999GD 24 STEP 1 1-585809 040741MH237 B39270GA 8 CABLE GRIP 2 69675K25 006043MH237 B42852GA 8 CABLE GRIP 2 69675K25 006043MH268 D41603GA 57 GROMMET 2 50607003 006354MH268 D41603GB 47 GROMMET 2 50607003 006354MH38 D41602GA 37 U-BOLT 1 3043T13 006043

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 62 11-06-2018

MH38 D41602GB 37 U-BOLT 1 3043T13 006043MH50 D39249GA 41 GROMMET - 3/8" ID 1 G3035 039960MH50 D42854GA 41 GROMMET - 3/8" ID 1 G3035 039960MH50 D44320GA 33 GROMMET - 3/8" ID 10 G3035 039960MH53 D42850GA 15 U-BOLT - 1/4 X 2-3/4 2 BY DESCRIPTION 039850MH6 D41601GA 31 CLEVIS PIN - 5/16" 2 98310 000953MH6 D41601GB 31 CLEVIS PIN - 5/16" 2 98310 000953MH65 D39105GA 16 SPACER 28 37-07 008689MH70 D39105GA 17 SPACER 32 35-10 008689MH80 D26542GA 11 SPACER 2 37-01 008689MH93 D39105GA 18 1-3/4" ID SPACER 4 37-09 008689PAA11758 D41601GA 32 INTAKE HOSE 1 PAA11758 009831PAA11758 D41601GB 32 INTAKE HOSE 1 PAA11758 009831PB104 D38190GA 2 IDLER PULLEY 1 FA2003 009831PB81 D38190GA 4 V-BELT 1 4L470 006354PB83-1 D42850GA 16 5/8 SHAFT PULLEY BUSHING 1 H X 5/8 009831PB90 D42850GA 17 V-BELT 1 A82 009831PB91 D42850GA 18 SINGLE SHEAVE PULLEY 1 AK154H 009831PF101 D39262GA 42 NPT COLLAR 1 BY DESCRIPTION 011148PF1205 D39262GA 14 NPT PLUG 2 234623 011148PF804 D41600GA 46 1" STREET ELBOW 1 BY DESCRIPTION 011148PF804 D41600GB 46 1" STREET ELBOW 1 BY DESCRIPTION 011148PM10 D42850GA 19 20 GAL AIR TANK 1 302466 040709PM11A D42850GA 20 AIR COMPRESSOR 1 421-1502 041317PM7 D39262GA 24 AIR FILTER -1 F74G-4AN-QD3 009080PM7 D42850GA 21 AIR FILTER 1 F74G-4AN-QD3 009080PR5 D39262GA 23 REGULATOR -1 4ZM22 040240PR5 D42850GA 22 AIR PRESSURE REGULATOR 1 4ZM22 040240

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 63 11-06-2018

PV25 D39262GA 15 POP OFF VALVE -1 5A709 040240PV25 D42850GA 23 VALVE - AIR TANK POP OFF 1 5A709 040240PV27 D39262GA 8 UNLOADER VALVE -1 3X818 040240PV28 D39262GA 12 DRAIN VALVE -1 4KT04 040240PV28 D42850GA 24 AUTOMATIC DRAIN VALVE 1 4KT04 040240PV36 D39262GA 17 CHECK VALVE -1 6X208 040240PV36 D42850GA 25 AIR CHECK VALVE FOR COMPRESSOR 1 6X208 040240

PV45 D39262GA 4 HOSE ASSEMBLY - BRAIDED, STAINLESS X 210" LG 1

UC3-S321-SHM-CS-1/2X210" 009831

PV46 D39262GA 19 HOSE ASSEMBLY X 96" LG 1 UC3-S321-SHM-CS-1/2X96" 009831

RD-5-5008-0 B30172GA 5 #8 A/C HOSE X AS NEEDED N/A RD-5-5012-0 B30172GA 4 #12 A/C HOSE X AS NEEDED N/A SA1 D41600GA 47 SHOCK ABSORBER, HEAVY DUTY 4 66828 040772SA1 D41600GB 47 SHOCK ABSORBER, HEAVY DUTY 4 66828 040772SP48 D44320GA 34 SPRING 1 208 040208ST171 D41601GA 33 STEERING WHEEL - 14" 1 14353BP 040419ST171 D41601GB 33 STEERING WHEEL - 14" 1 14353BP 040419ST172 D41601GA 34 HORN BUTTON KIT 1 HB10T 040419ST172 D41601GB 34 HORN BUTTON KIT 1 HB10T 040419ST173 D41603GA 58 MASTER CYLINDER W/HYD ASSIST 1 02-461-404 005517ST173 D41603GB 48 MASTER CYLINDER W/HYD ASSIST 1 02-461-404 005517ST174 D41603GA 59 RESERVOIR - BRAKE FLUID W/MT 2 20-920-505 005517ST174 D41603GB 49 RESERVOIR - BRAKE FLUID W/MT 2 20-920-505 005517ST179 D41604GA 53 HYDROSTATIC STEERING UNIT 1 RR60801 007938ST179 D41604GD 53 HYDROSTATIC STEERING UNIT 1 RR60801 007938ST180 D41604GA 54 STEERING COLUMN 1 KK150V-01/2 007938ST180 D41604GD 54 STEERING COLUMN 1 KK150V-01/2 007938

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 64 11-06-2018

T2-1 D41601GA 35 SHIFTER CABLE 1 100-4333-96 009831T2-1 D41601GB 35 SHIFTER CABLE 1 100-4333-96 009831T28 D44320GA 35 INSTALL KIT - TRANSMISSION 1 02045-0331 009831T30 D41604GA 55 SHIFTER - LIGHTED, 2" TRAVEL 1 62475900 009831T30 D41604GD 55 SHIFTER - LIGHTED, 2" TRAVEL 1 62475900 009831T33 D44320GA 36 TRANSMISSION - ELE, GM C6 REPT 1 TRN4265 042231T33-1 D44320GA 37 REAR HOUSING - C6 1 TRN8630 042231T34 D44320GA 38 CABLE MOUNT - TRANSMISSION 1 T34 009831T4 D44320GA 39 BALL JOINT 1 031126 041297T44 D44320GA 40 THROTTLE POSITION SENSOR 1 TCM6040 042231T45 D44320GA 41 RPM SENSOR 1 SNS1025 042231T47 D44320GA 42 WIRE HARNESS - TRANSMISSION 1 TCM4666 042231T5 D44320GA 43 CABLE RETAINING CLIP 1 36174 041297T50-2 D44320GA 44 TRANSMISSION CONTROL UNIT 1 A-TCM2600 042231T50-4 D44320GA 45 VENT TUBE KIT 1 TRN7006-REV2 042231T50-5 D44320GA 46 DIPSTICK ASSEMBLY 1 TRN7011 042231TF005 C39365GB 7 TEE 1 3700X2 009831TF200 D41603GA 60 CLEAR TUBING X 25" LG 1 PT24044 009831TF200 D41603GB 50 CLEAR TUBING X 25" LG 1 PT24044 009831TF205 C39365GB 9 ELBOW 1 202-2 009831TF210 C39365GB 6 ADAPTER 2 202 X 4 009831TF213 C39365GA 10 ADAPTER 2 7828 009831TF213 D44321GA 13 ADAPTER 2 7828 009831TF217 C39365GB 18 TEE 2 7898 009831TF218 C39365GB 20 PLUG 2 131 X 4 009831TF304 C39365GB 3 UNION 1 302 X 4 009831TF413 C39365GA 14 BRAKE SEALING WASHER -4 WAG F5795 041524TF413 D26542GA 13 COPPER WASHER 4 WAG F5795 041524

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 65 11-06-2018

TF413 D44321GA 14 COPPER WASHER 4 WAG F5795 041524TF415 C39365GB 11 TEE 1 702 X 4 009831TF416 C39365GA 12 HOSE CLIP 3 (2) 3015906RY 040757TF416 D44321GA 15 HOSE CLIP 2 3015906RY 040757TF417 C39365GA 13 BRAKE SEALING BOLT -2 BANJO BOLT M10 009831TF417 D26542GA 14 BANJO BOLT 2 BANJO BOLT M10 009831TF417 D44321GA 16 BANJO BOLT 2 BANJO BOLT M10 009831TF433 D39262GA 9 COMPRESSION FITTING 1 68X4 009831TF434 D39262GA 10 1/4 OD RND COPPER TUBING X 20" LG 1 BY DESCRIPTION 009831TF477 D41600GA 48 AN ADAPTER 2 28756 009831TF477 D41600GB 48 AN ADAPTER 2 28756 009831TF478 D41600GA 49 NPT TO BARB ADAPTER 2 32320 009831TF478 D41600GB 49 NPT TO BARB ADAPTER 2 32320 009831UMA0266 D42854GA 42 MANIFOLD - 6 SEC - 12VDC 1 UMA0266 007938UMA0271 D39249GA 42 MANIFOLD - 7 SEC - 12VDC 1 UMA0271 007938

UMB1001 UMA0266 7 VALVE BLOCK - DIRECTIONAL W/RELIEF 3 ZC50297 007938

UMB1001 UMA0271 7 VALVE BLOCK - DIRECTIONAL W/RELIEF 4 ZC50297 007938

UMB2000 UMA0266 8 VALVE BLOCK - UNLOADER 1 UMB2000 007938UMB2000 UMA0271 8 VALVE BLOCK - UNLOADER 1 UMB2000 007938UMB4004 UMA0266 9 VALVE BLOCK - HEADER W/RELIEF 1 UMB4004 007938UMB4004 UMA0271 9 VALVE BLOCK - HEADER W/RELIEF 1 UMB4004 007938UMC1243-12 UMA0266 10 SOLENOID VALVE 1 DSL101NTN 007938UMC1243-12 UMA0271 10 SOLENOID VALVE 1 DSL101NTN 007938UMC1243-NC UMA0266 10B SOLENOID VALVE CARTRIDGE -1 UMC1243-NC 007938UMC1243-NC UMA0271 10B SOLENOID VALVE CARTRIDGE -1 UMC1243-NC 007938UMC2332 UMA0266 11 DIRECTIONAL VALVE 3 AL10504 007938

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 66 11-06-2018

UMC2332 UMA0271 11 DIRECTIONAL VALVE 4 AL10504 007938UMC4400-2800 UMA0266 13 RELIEF VALVE 1 CP2001BOEC280 007938UMC4400-2800 UMA0271 13 RELIEF VALVE 1 CP2001BOEC280 007938UMC4401-0500 UMA0271 12 RELIEF VALVE 2 UMC4401-0500 007938UMC4401-1000 UMA0266 16 RELIEF VALVE 2 CP2081BOEC100 007938UMC4401-1000 UMA0271 16 RELIEF VALVE 2 CP2081BOEC100 007938UMC4401-2000 UMA0266 14 RELIEF VALVE 4 CP2081B0EC200 007938UMC4401-2000 UMA0271 14 RELIEF VALVE 4 CP2081B0EC200 007938UMC7410 UMA0266 17 CHECK VALVE 1 CV10NP0.3B00 002540UMC7410 UMA0271 17 CHECK VALVE 1 CV10NP0.3B00 002540UMC9123 UMA0266 10A SOLENOID COIL -1 CAP012D 007938UMC9123 UMA0271 10A SOLENOID COIL -1 CAP012D 007938UMC9320 UMA0266 11A COIL -6 CSD112N70 007938UMC9320 UMA0271 11A COIL -8 CSD112N70 007938WV12 D39262GA 20 SHUT OFF VALVE -1 174072 011148WV12 D42850GA 26 1/2" NPT BALL VALVE 1 174072 011148

WV5 D41603GA 61 GATE VALVE (ASSEMBLE TO ENGINE FOR HEATER HOSE) 1 BB2 011148

X13002 D24999GE 25 1/8 X 1-1/4 HR FLAT X 20" LG 1 BY DESCRIPTION 000195X13002 D24999GE 27 1/8 X 1-1/4 HR FLAT X 26" LG 2 BY DESCRIPTION 000195X13002 D24999GE 28 1/8 X 1-1/4 FLAT X 38" LG 1 BY DESCRIPTION 000195X13002 D24999GF 25 1/8 X 1-1/4 HR FLAT X 20" LG 1 BY DESCRIPTION 000195X13002 D24999GF 27 1/8 X 1-1/4 HR FLAT X 26" LG 2 BY DESCRIPTION 000195X13002 D24999GF 28 1/8 X 1-1/4 FLAT X 38" LG 1 BY DESCRIPTION 000195X13002 D24999GG 26 1/8 X 1-1/4 HR FLAT X 22-1/2" LG 1 BY DESCRIPTION 000195X13002 D24999GG 29 1/8 X 1-1/4 HR FLAT X 44" LG 2 BY DESCRIPTION 000195X35017 D24999GA 30 3/8 THREADED ROD X 7" LG 1 47474 039850X35017 D24999GB 30 3/8 THREADED ROD X 7" LG 1 47474 039850

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 67 11-06-2018

X35017 D24999GC 30 3/8 THREADED ROD X 7" LG 1 47474 039850X35017 D24999GD 30 3/8 THREADED ROD X 7" LG 1 47474 039850X35019-017.000 UMA0266 20 5/16-18 THREADED ROD X 14-3/4" LG 2 0123459 039850X35019-017.000 UMA0271 20 5/16-18 THREADED ROD X 17-3/4" LG 2 0123459 039850X35019-017.500 UMA0266 21 5/16-18 THREADED ROD X 15-1/8" LG 2 0123459 039850X35019-017.500 UMA0271 21 5/16-18 THREADED ROD X 18-1/8" LG 2 0123459 039850X42010-004.00X036.00 D41600GA 50 1/4" NEOPRENE X 4 X 36" 2 BY DESCRIPTION 000195X42010-004.00X036.00 D41600GB 50 1/4" NEOPRENE X 4 X 36" 2 BY DESCRIPTION 000195X42158-002.00X018.00 D41600GA 51 3/8 TK NEOPRENE X 2 X 18" 2 BY DESCRIPTION 000195X42158-002.00X018.00 D41600GB 51 3/8 TK NEOPRENE X 2 X 18" 2 BY DESCRIPTION 000195X44001 D24997GF 11 3/16 FIBERGLASS SHEET 1 X 13-1/2 2 8549K85 006043X44001 D24997GF 12 3/16 FIBERGLASS SHEET 1 X 14 2 8549K86 006043X44001 D24997GF 13 3/16 FIBERGLASS SHEET 1 X 18-1/4 2 8549K87 006043X44001 D24997GF 14 3/16 FIBERGLASS SHEET 1 X 23-1/2 2 8549K88 006043X44001 D24997GF 15 3/16 FIBERGLASS SHEET 1 X 25 2 8549K89 006043X44001 D24997GG 11 3/16 FIBERGLASS SHEET 1 X 13-1/2 2 8549K90 006043X44001 D24997GG 12 3/16 FIBERGLASS SHEET 1 X 14 2 8549K91 006043X44001 D24997GG 13 3/16 FIBERGLASS SHEET 1 X 18-1/4 2 8549K92 006043X44001 D24997GG 14 3/16 FIBERGLASS SHEET 1 X 23-1/2 2 8549K93 006043X44001 D24997GG 15 3/16 FIBERGLASS SHEET 1 X 25 2 8549K94 006043X44001 D24997GH 11 3/16 FIBERGLASS SHEET 1 X 13-1/2 2 8549K95 006043X44001 D24997GH 12 3/16 FIBERGLASS SHEET 1 X 14 2 8549K96 006043X44001 D24997GH 13 3/16 FIBERGLASS SHEET 1 X 18-1/4 2 8549K97 006043X44001 D24997GH 14 3/16 FIBERGLASS SHEET 1 X 23-1/2 2 8549K98 006043X44001 D24997GH 15 3/16 FIBERGLASS SHEET 1 X 25 2 8549K99 006043

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 68 11-06-2018

X44001 D24997GJ 11 3/16 FIBERGLASS SHEET 1 X 13-1/2 2 8549K100 006043X44001 D24997GJ 12 3/16 FIBERGLASS SHEET 1 X 14 2 8549K101 006043X44001 D24997GJ 13 3/16 FIBERGLASS SHEET 1 X 18-1/4 2 8549K102 006043X44001 D24997GJ 14 3/16 FIBERGLASS SHEET 1 X 23-1/2 2 8549K103 006043X44001 D24997GJ 15 3/16 FIBERGLASS SHEET 1 X 25 2 8549K104 006043X45003 D41603GA 62 1/2" TK FOAM RUBBER X 34 X 77-1/2" 1 APR12040 009332YC103373 D41601GA 36 3/32 X 3/4 COTTER PIN 2 65034 039850YC103373 D41601GB 36 3/32 X 3/4 COTTER PIN 2 65034 039850YC103386 D41603GA 63 COTTER PIN 1/8 X 1-1/4" 1 65077 039850YC103386 D41603GB 51 COTTER PIN 1/8 X 1-1/4" 1 65077 039850YD436665 D41604GA 56 PPHMS ZN - 6-32 X 1/2" LG 2 27304 039850YD436665 D41604GD 56 PPHMS ZN - 6-32 X 1/2" LG 2 27304 039850YD436730 D39249GA 43 PPHMS ZN - 10-24 X 3/8" LG 3 27448 039850YD436730 D42854GA 43 PPHMS ZN - 10-24 X 3/8" LG 3 27448 039850YD436732 C24774GA 8 #10-24 P.H.M.S. X 1/2" LG 2 27457 039850YD436732 D39249GA 44 PPHMS ZN - 10-24 X 1/2" LG 6 27457 039850YD436732 D39258GA 37 PPHMS ZN - 10-24 X 1/2" LG 2 27457 039850YD436732 D41600GA 52 PPHMS ZN - 10-24 X 1/2" LG 18 27457 039850YD436732 D41600GB 52 PPHMS ZN - 10-24 X 1/2" LG 18 27457 039850YD436732 D41601GA 37 PPHMS ZN - 10-24 X 1/2" LG 2 27457 039850YD436732 D41601GB 37 PPHMS ZN - 10-24 X 1/2" LG 2 27457 039850YD436732 D41603GB 52 PPHMS ZN - 10-24 X 1/2" LG 4 27457 039850YD436732 D41604GA 57 PPHMS ZN - 10-24 X 1/2" LG 4 27457 039850YD436732 D41604GD 57 PPHMS ZN - 10-24 X 1/2" LG 4 27457 039850YD436732 D42854GA 44 PPHMS ZN - 10-24 X 1/2" LG 6 27457 039850YD436733 D39126GA 38 PPHMS ZN -10-24 X 5/8" LG 6 27463 039850YD436733 D41603GA 64 PPHMS ZN -10-24 X 5/8" LG 8 27463 039850YD436733 D41603GB 53 PPHMS ZN -10-24 X 5/8" LG 8 27463 039850

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 69 11-06-2018

YD436734 D39249GA 45 PPHMS ZN - 10-24 X 3/4" LG 4 27469 039850YD436734 D42854GA 45 PPHMS ZN - 10-24 X 3/4" LG 4 27469 039850YD436734 D44320GA 47 PPHMS ZN - 10-24 X 3/4" LG 2 27469 039850YD436736 D39249GA 46 PPHMS ZN 10-24 X 1" LG 2 1128981 039850YD436736 D39258GA 38 PPHMS ZN 10-24 X 1" LG 4 1128981 039850YD436736 D42854GA 46 PPHMS ZN 10-24 X 1" LG 2 1128981 039850YE108188 D41600GA 53 1/2-13 HHCS X 2-3/4" LG -4 13214 039850YE108188 D41600GB 53 1/2-13 HHCS X 2-3/4" LG -4 13214 039850YE180016 D39126GA 39 1/4-20 HHCS X 1/2" LG 24 13001 039850YE180016 D39249GA 47 1/4-20 HHCS X 1/2" LG 2 13001 039850YE180016 D41600GA 54 1/4-20 HHCS X 1/2" LG 14 13001 039850YE180016 D41600GB 54 1/4-20 HHCS X 1/2" LG 14 13001 039850YE180016 D41601GA 38 1/4-20 HHCS X 1/2" LG 12 13001 039850YE180016 D41601GB 38 1/4-20 HHCS X 1/2" LG 12 13001 039850YE180016 D41602GA 38 1/4-20 HHCS X 1/2" LG 1 13001 039850YE180016 D41602GB 38 1/4-20 HHCS X 1/2" LG 1 13001 039850YE180016 D41603GA 65 1/4-20 HHCS X 1/2" LG 5 13001 039850YE180016 D41603GB 54 1/4-20 HHCS X 1/2" LG 15 13001 039850YE180016 D41604GA 58 1/4-20 HHCS X 1/2" LG 4 13001 039850YE180016 D41604GD 58 1/4-20 HHCS X 1/2" LG 4 13001 039850YE180016 D42854GA 47 1/4-20 HHCS X 1/2" LG 2 13001 039850YE180016 D42855GA 20 1/4-20 HHCS X 1/2" LG 24 13001 039850YE180018 C24998GA 5 1/4-20 H.H.C.S. X 5/8" LG 2 13002 039850YE180018 C24998GB 5 1/4-20 H.H.C.S. X 5/8" LG 4 13002 039850YE180018 C24998GC 5 1/4-20 H.H.C.S. X 5/8" LG 4 13002 039850YE180018 D39126GA 40 1/4-20 HHCS X 5/8" LG 6 13002 039850YE180018 D41603GA 66 1/4-20 HHCS X 5/8" LG 8 13002 039850YE180018 D41603GB 55 1/4-20 HHCS X 5/8" LG 16 13002 039850

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 70 11-06-2018

YE180018 D42850GA 27 1/4-20 HHCS X 5/8" LG 7 13002 039850YE180018 D42855GA 21 1/4-20 HHCS X 5/8" LG 2 13002 039850YE180020 D24999GA 31 1/4-20 H.H.C.S. X 3/4" LG 4 13003 039850YE180020 D24999GB 31 1/4-20 H.H.C.S. X 3/4" LG 4 13003 039850YE180020 D24999GC 31 1/4-20 H.H.C.S. X 3/4" LG 10 13003 039850YE180020 D24999GD 31 1/4-20 H.H.C.S. X 3/4" LG 14 13003 039850YE180020 D39126GA 41 1/4-20 HHCS X 3/4" LG 4 13003 039850YE180020 D41601GA 39 1/4-20 HHCS X 3/4" LG 9 13003 039850YE180020 D41601GB 39 1/4-20 HHCS X 3/4" LG 9 13003 039850YE180020 D41602GA 39 1/4-20 HHCS X 3/4" LG 4 13003 039850YE180020 D41602GB 39 1/4-20 HHCS X 3/4" LG 4 13003 039850YE180020 D41603GA 67 1/4-20 HHCS X 3/4" LG 22 13003 039850YE180020 D41603GB 56 1/4-20 HHCS X 3/4" LG 22 13003 039850YE180020 D42855GA 22 1/4-20 HHCS X 3/4" LG 4 13003 039850YE180042 D44320GA 48 1/4-20 HHCS X 1-3/4" LG 4 110120307 039850YE180048 D41602GA 40 1/4-20 HHCS X 2-1/2" LG 4 110120310 039850YE180048 D41602GB 40 1/4-20 HHCS X 2-1/2" LG 4 110120310 039850YE180050 D41601GA 40 1/4-20 HHCS X 2-3/4" LG 2 13014 039850YE180050 D41601GB 40 1/4-20 HHCS X 2-3/4" LG 2 13014 039850YE180052 D41602GA 41 1/4-20 HHCS X 3" LG 8 110120312 039850YE180052 D41602GB 41 1/4-20 HHCS X 3" LG 8 110120312 039850YE180075 D24999GA 43 HHCS - 5/16-18 X 5/8" 4 13052 039850YE180075 D24999GB 43 HHCS - 5/16-18 X 5/8" 4 13052 039850YE180075 D24999GC 43 HHCS - 5/16-18 X 5/8" 4 13052 039850YE180075 D24999GD 43 HHCS - 5/16-18 X 5/8" 4 13052 039850YE180079 D39249GA 48 5/16-18 HHCS X 1" LG 4 110120325 039850YE180079 D41601GA 41 5/16-18 HHCS X 1" LG 2 110120325 039850YE180079 D41601GB 41 5/16-18 HHCS X 1" LG 2 110120325 039850

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 71 11-06-2018

YE180079 D41603GA 68 5/16-18 HHCS X 1" LG 3 110120325 039850YE180079 D41603GB 57 5/16-18 HHCS X 1" LG 11 110120325 039850YE180079 D42854GA 48 5/16-18 HHCS X 1" LG 4 110120325 039850YE180081 D41601GA 42 5/16-18 HHCS X 1-1/4" LG 1 110120326 039850YE180081 D41601GB 42 5/16-18 HHCS X 1-1/4" LG 1 110120326 039850YE180081 D42850GA 28 5/16-18 HHCS X 1-1/4" LG 4 110120326 039850YE180120 D39126GA 42 3/8-16 HHCS X 3/4" LG 8 13103 039850YE180120 D41600GA 55 3/8-16 HHCS X 3/4" LG 4 13103 039850YE180120 D41600GB 55 3/8-16 HHCS X 3/4" LG 4 13103 039850YE180120 D41604GA 59 3/8-16 HHCS X 3/4" LG 4 13103 039850YE180120 D41604GD 59 3/8-16 HHCS X 3/4" LG 4 13103 039850YE180120 D42855GA 23 3/8-16 HHCS X 3/4" LG 4 13103 039850YE180122 D41600GA 56 3/8-16 HHCS X 1" LG 4 13105 039850YE180122 D41600GB 56 3/8-16 HHCS X 1" LG 4 13105 039850YE180122 D42850GA 29 3/8-16 HHCS X 1" LG 6 13105 039850YE180124 D44320GA 49 3/8-16 HHCS X 1-1/4" LG 8 110120345 039850YE180126 D38190GA 24 3/8-16 HHCS X 1-3/4" LG 2 13110 039850YE180128 D44320GA 50 3/8-16 HHCS X 1-1/2" LG 1 13109 039850YE180130 D39126GA 43 3/8-16 HHCS X 2" LG 2 110120348 039850YE180145 D41601GA 43 7/16-14 HHCS X 1" LG 4 110120361 039850YE180145 D41601GB 43 7/16-14 HHCS X 1" LG 4 110120361 039850YE180145 D41603GA 69 7/16-14 HHCS X 1" LG 4 110120361 039850YE180145 D41603GB 58 7/16-14 HHCS X 1" LG 4 110120361 039850YE180153 D44320GA 51 7/16-14 HHCS X 2" LG 4 BY DESCRIPTION 039850YE180171 D41603GA 70 HHCS GR5 ZN - 1/2-13 X 3/4 4 110131301 039850YE180171 D41603GB 59 HHCS GR5 ZN - 1/2-13 X 3/4 4 110131301 039850YE180175 D41600GA 57 1/2-13 HHCS X 1-1/4" LG 4 13207 039850YE180175 D41600GB 57 1/2-13 HHCS X 1-1/4" LG 4 13207 039850

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 72 11-06-2018

YE180193 D41602GA 42 1/2-13 HHCS X 3-3/4" LG 2 13218 039850YE180193 D41602GB 42 1/2-13 HHCS X 3-3/4" LG 2 13218 039850YE181591 D41601GA 44 5/16-24 HHCS X 1/2" LG 2 17051 039850YE181591 D41601GB 44 5/16-24 HHCS X 1/2" LG 2 17051 039850YE181651 D38190GA 19 3/8-24 HHCS X 5" LG 1 BY DESCRIPTION 039850YE181696 D44320GA 52 1/2-20 HHCS X 1" LG 4 17205 039850YE181698 D44320GA 53 1/2-20 HHCS X 1-1/4" LG 2 17207 039850YE181700 D41600GA 58 1/2-20 HHCS X 1-1/2" LG 12 17209 039850YE181700 D41600GB 58 1/2-20 HHCS X 1-1/2" LG 12 17209 039850YE181700 D44320GA 54 1/2-20 HHCS X 1-1/2" LG 4 17209 039850YE213546 D24997GF 16 1/4-20 H.H.C.S. X 1" LG 12 0115005 039850YE213546 D24997GG 16 1/4-20 H.H.C.S. X 1" LG 12 0115005 039850YE213546 D24997GH 16 1/4-20 H.H.C.S. X 1" LG 12 0115005 039850YE213546 D24997GJ 16 1/4-20 H.H.C.S. X 1" LG 12 0115005 039850YE213546 D24999GA 32 1/4-20 H.H.C.S. X 1" LG 6 0115005 039850YE213546 D24999GB 32 1/4-20 H.H.C.S. X 1" LG 6 0115005 039850YE213546 D24999GC 32 1/4-20 H.H.C.S. X 1" LG 5 0115005 039850YE213546 D24999GD 32 1/4-20 H.H.C.S. X 1" LG 10 0115005 039850YE213546 D39126GA 44 1/4-20 HHCS X 1" LG 8 0115005 039850YE213546 D41601GA 45 1/4-20 HHCS X 1" LG 2 0115005 039850YE213546 D41601GB 45 1/4-20 HHCS X 1" LG 2 0115005 039850YE213546 D41603GA 71 1/4-20 HHCS X 1" LG 5 0115005 039850YE213546 D41603GB 60 1/4-20 HHCS X 1" LG 5 0115005 039850YE213546 D42855GA 24 1/4-20 HHCS X 1" LG 8 0115005 039850YE223530 D41600GA 59 3/4-10 HHCS X 3" LG 6 0115365 039850YE223530 D41600GB 59 3/4-10 HHCS X 3" LG 6 0115365 039850YE223810 D41602GA 43 5/8-18 HHCS X 1-3/4" LG 3 18959 039850YE223810 D41602GB 43 5/8-18 HHCS X 1-3/4" LG 3 18959 039850

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 73 11-06-2018

YE223811 D41602GA 44 5/8-18 HHCS X 2" LG 2 18960 039850YE223811 D41602GB 44 5/8-18 HHCS X 2" LG 2 18960 039850YE223823 D41601GA 46 3/4-16 HHCS X 1-1/2" LG 4 18988 039850YE223823 D41601GB 46 3/4-16 HHCS X 1-1/2" LG 4 18988 039850YE271756 D44320GA 55 5/8-18 HHCS X 4" LG 2 BY DESCRIPTION 039850YE271793 D41601GA 47 3/4-16 HHCS X 2" LG 6 17361 039850YE271793 D41601GB 47 3/4-16 HHCS X 2" LG 6 17361 039850YE271793 D41603GA 72 3/4-16 HHCS X 2" LG 2 17361 039850YE271793 D41603GB 61 3/4-16 HHCS X 2" LG 2 17361 039850YE272506 D41600GA 60 3/4-16 HHCS X 6-1/2" LG 2 17376 039850YE272506 D41600GB 60 3/4-16 HHCS X 6-1/2" LG 2 17376 039850YE427565 D41602GA 45 1/2-13 HHCS X 1-3/4" LG 2 0115210 039850YE427565 D41602GB 45 1/2-13 HHCS X 1-3/4" LG 2 0115210 039850YE427587 D24999GA 33 1/4-20 H.H.C.S. X 1-1/4" LG 6 15007 039850YE427587 D24999GB 33 1/4-20 H.H.C.S. X 1-1/4" LG 6 15007 039850YE427587 D39126GA 45 1/4-20 HHCS X 1-1/4" LG 40 15007 039850YE427587 D42855GA 25 1/4-20 HHCS X 1-1/4" LG 38 15007 039850YE454906 D24999GD 47 3/8-16 HHCS X 1-1/2" LG 2 15109 039850YE454998 D41601GA 48 1/2-13 HHCS X 1" LG 4 0115205 039850YE454998 D41601GB 48 1/2-13 HHCS X 1" LG 4 0115205 039850YE9414506 D41600GA 61 9/16-18 HHCS GR8 X 6-1/2" LG 4 10365-01866 039850YE9414506 D41600GB 61 9/16-18 HHCS GR8 X 6-1/2" LG 4 10365-01866 039850YE9418633 D38190GA 18 3/8-16 HHCS X 4-1/2" LG 1 BY DESCRIPTION 039850YE9430539 D26542GA 8 9/16-18 H.H.C.S. X 5" LG 2 18953 039850YE9430539 D44321GA 17 9/16-18 HHCS GR8 X 5" LG 2 18953 039850YE9430568 D41600GA 62 3/4-10 HHCS X 6" LG 2 15375 039850YE9430568 D41600GB 62 3/4-10 HHCS X 6" LG 2 15375 039850YEMETRIC004 D41602GA 46 M6 X 1 HHCS X 50mm LG 2 0121798 039850

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 74 11-06-2018

YEMETRIC004 D41602GB 46 M6 X 1 HHCS X 50mm LG 2 0121798 039850YEMETRIC010 D39249GA 49 M6 X 1 HHCS X 12mm LG 6 1138564 039850YEMETRIC010 D39258GA 39 M6 X 1 HHCS X 12mm LG 2 1138564 039850YEMETRIC010 D42854GA 49 M6 X 1 HHCS X 12mm LG 6 1138564 039850YEMETRIC033 D38190GA 16 M12X1.25 HHCS X 30mm LG 3 38727 039850YEMETRIC033 D44320GA 56 M12 X 1.25 HHCS X 30mm LG 8 38727 039850YF102572L D39105GA 19 1/4-20 KCSS X 5/8" LG 4 85383 039850YF139069 D42850GA 30 KCSS SCREW LOC-WEL - 3/8-16 X 3" LG 2 BY DESCRIPTION 039850YG138202 D41600GA 63 1/4-20 SHCS X 1" LG 8 BY DESCRIPTION 039850YG138202 D41600GB 63 1/4-20 SHCS X 1" LG 8 BY DESCRIPTION 039850YG138243 D44320GA 57 3/8-16 SHCS X 1-1/4" LG ZN 9 93307 039850YG138246 D39105GA 20 3/8-16 SHCS X 3" LG 8 93315 039850YG147126 D39105GA 21 3/8-16 SHCS X 3-3/4" LG 4 93318 039850YG427191 D39105GA 22 3/8-16 SHCS X 2-1/2" LG 3 93313 039850YG9421662 D38190GA 6 5/8-11 LHCS X 1-1/2" LG 1 BY DESCRIPTION 039850YGMETRIC008 D44320GA 58 M10 X 1.25 SHCS X 25mm LG 2 0142070 039850YH1304L D42850GA 31 3/8-16 FHSC X 1-1/2" LG 2 BY DESCRIPTION 039850YH1504L D24999GA 34 FHSC SCREW LOC-WEL - 1/4-20 X 3/4 4 FC04C0024PFDMPT 039850YH1504L D24999GB 34 FHSC SCREW LOC-WEL - 1/4-20 X 3/4 4 FC04C0024PFDMPT 039850YH1504L D24999GC 34 FHSC SCREW LOC-WEL - 1/4-20 X 3/4 4 FC04C0024PFDMPT 039850YH1504L D24999GD 34 FHSC SCREW LOC-WEL - 1/4-20 X 3/4 4 FC04C0024PFDMPT 039850YH1505 D41603GB 62 1/4-20 FHSC X 1" LG 4 94225 039850YH2200L D41603GA 73 #10-24 FHSC X 5/8" LG 8 10365-04853 039850YH2200L D41603GB 63 #10-24 FHSC X 5/8" LG 4 10365-04853 039850YH2201 D41601GA 49 FHC SCREW #10-24 X 1/2" ZN 4 91263A533 006043YH2201 D41601GB 49 FHC SCREW #10-24 X 1/2" ZN 4 91263A533 006043YH2400L D41601GA 50 5/16-24 FHSC X 3/4" LG 1 10365-04853 039850YH2400L D41601GB 50 5/16-24 FHSC X 3/4" LG 1 10365-04853 039850

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 75 11-06-2018

YKE0002 D41603GB 64 #1/4-14 TEK SCREW X 5/8" LG 1 32045 039850YKE0003 D24997GA 17 #10-18 TEK SCREW X 5/8" LG 25 KHW010D00062HSZI 039850YKE0003 D24997GB 17 #10-18 TEK SCREW X 5/8" LG 25 KHW010D00062HSZI 039850YKE0003 D24997GC 17 #10-18 TEK SCREW X 5/8" LG 30 KHW010D00062HSZI 039850YKE0003 D24997GD 17 #10-18 TEK SCREW X 5/8" LG 15 KHW010D00062HSZI 039850YKE0003 D24999GA 35 TEK SCREW 2 1132036 039850YKE0003 D24999GB 35 TEK SCREW 2 1132036 039850YKE0003 D24999GC 35 TEK SCREW 2 1132036 039850YKE0003 D24999GD 35 TEK SCREW 2 1132036 039850YKE0003 D41603GA 74 #10 TEK SCREW X 5/8" LG 100 1132036 039850YM120214 D24999GA 44 SPLIT LOCK WASHER ZN - 5/16 4 33620 039850YM120214 D24999GB 44 SPLIT LOCK WASHER ZN - 5/16 4 33620 039850YM120214 D24999GC 44 SPLIT LOCK WASHER ZN - 5/16 4 33620 039850YM120214 D24999GD 44 SPLIT LOCK WASHER ZN - 5/16 4 33620 039850YM120214 D39249GA 50 5/16" LOCK WASHER 4 33620 039850YM120214 D41601GA 51 5/16" LOCK WASHER 4 33620 039850YM120214 D41601GB 51 5/16" LOCK WASHER 4 33620 039850YM120214 D41603GA 75 5/16" LOCK WASHER 3 33620 039850YM120214 D41603GB 65 5/16" LOCK WASHER 3 33620 039850YM120214 D42850GA 32 5/16" LOCK WASHER 4 33620 039850YM120214 D42854GA 50 5/16" LOCK WASHER 4 33620 039850YM120214 UMA0266 18 5/16 LOCK WASHER 8 33620 039850YM120214 UMA0271 18 5/16 LOCK WASHER 8 33620 039850YM120217 C24774GA 9 #10 LOCK WASHER 2 33614 039850YM120217 D39126GA 46 #10 LOCK WASHER 6 33614 039850YM120217 D39249GA 51 #10 LOCK WASHER 15 33614 039850YM120217 D39258GA 40 #10 LOCK WASHER 6 33614 039850YM120217 D41600GA 64 #10 LOCK WASHER 23 33614 039850

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 76 11-06-2018

YM120217 D41600GB 64 #10 LOCK WASHER 23 33614 039850YM120217 D41601GA 52 #10 LOCK WASHER 2 33614 039850YM120217 D41601GB 52 #10 LOCK WASHER 2 33614 039850YM120217 D41603GA 76 #10 LOCK WASHER 8 33614 039850YM120217 D41603GB 66 #10 LOCK WASHER 12 33614 039850YM120217 D41604GA 60 #10 LOCK WASHER 4 33614 039850YM120217 D41604GD 60 #10 LOCK WASHER 4 33614 039850YM120217 D42854GA 51 #10 LOCK WASHER 15 33614 039850YM120217 D44320GA 59 #10 LOCK WASHER 2 33614 039850YM120380 C24998GA 6 1/4 LOCK WASHER 2 1133618 039850YM120380 C24998GB 6 1/4 LOCK WASHER 4 1133618 039850YM120380 C24998GC 6 1/4 LOCK WASHER 4 1133618 039850YM120380 D24999GA 36 1/4 LOCK WASHER 10 1133618 039850YM120380 D24999GB 36 1/4 LOCK WASHER 10 1133618 039850YM120380 D24999GC 36 1/4 LOCK WASHER 10 1133618 039850YM120380 D24999GD 36 1/4 LOCK WASHER 12 1133618 039850YM120380 D39126GA 47 1/4" LOCK WASHER 80 1133618 039850YM120380 D39249GA 52 1/4" LOCK WASHER 2 1133618 039850YM120380 D41600GA 65 1/4" LOCK WASHER 22 1133618 039850YM120380 D41600GB 65 1/4" LOCK WASHER 22 1133618 039850YM120380 D41601GA 53 1/4" LOCK WASHER 14 1133618 039850YM120380 D41601GB 53 1/4" LOCK WASHER 14 1133618 039850YM120380 D41602GA 47 1/4" LOCK WASHER 15 1133618 039850YM120380 D41602GB 47 1/4" LOCK WASHER 15 1133618 039850YM120380 D41603GA 77 1/4" LOCK WASHER 20 1133618 039850YM120380 D41603GB 67 1/4" LOCK WASHER 38 1133618 039850YM120380 D41604GA 61 1/4" LOCK WASHER 4 1133618 039850YM120380 D41604GD 61 1/4" LOCK WASHER 4 1133618 039850

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 77 11-06-2018

YM120380 D42850GA 33 1/4" LOCK WASHER 11 1133618 039850YM120380 D42854GA 52 1/4" LOCK WASHER 2 1133618 039850YM120380 D42855GA 26 1/4" LOCK WASHER 76 1133618 039850YM120380 D44320GA 60 1/4" LOCK WASHER 4 1133618 039850YM120382 D38190GA 21 3/8 LOCK WASHER 4 33622 039850YM120382 D39126GA 48 3/8" LOCK WASHER 8 33622 039850YM120382 D41600GA 66 3/8" LOCK WASHER 4 33622 039850YM120382 D41600GB 66 3/8" LOCK WASHER 4 33622 039850YM120382 D41603GB 68 3/8" LOCK WASHER 1 33622 039850YM120382 D41604GA 62 3/8" LOCK WASHER 4 33622 039850YM120382 D41604GD 62 3/8" LOCK WASHER 4 33622 039850YM120382 D42850GA 34 3/8" LOCK WASHER 4 33622 039850YM120382 D42855GA 27 3/8" LOCK WASHER 4 33622 039850YM120382 D44320GA 61 3/8" LOCK WASHER 17 33622 039850YM120383 D41601GA 54 7/16" LOCK WASHER 2 1133624 039850YM120383 D41601GB 54 7/16" LOCK WASHER 2 1133624 039850YM120383 D41603GA 78 7/16" LOCK WASHER 4 1133624 039850YM120383 D41603GB 69 7/16" LOCK WASHER 4 1133624 039850YM120384 D41600GA 67 1/2" LOCK WASHER 16 1133626 039850YM120384 D41600GB 67 1/2" LOCK WASHER 16 1133626 039850YM120384 D41601GA 55 1/2" LOCK WASHER 4 1133626 039850YM120384 D41601GB 55 1/2" LOCK WASHER 4 1133626 039850YM120384 D44320GA 62 1/2" LOCK WASHER 4 1133626 039850YM121574 D26542GA 17 5/8 LOCK WASHER 8 33630 039850YM121574 D41602GA 48 5/8" LOCK WASHER 5 33630 039850YM121574 D41602GB 48 5/8" LOCK WASHER 5 33630 039850YM131044 D41604GA 63 #6 LOCK WASHER 2 1133610 039850YM131044 D41604GD 63 #6 LOCK WASHER 2 1133610 039850

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 78 11-06-2018

YM131046 D39126GA 49 3/4" LOCK WASHER 6 33632 039850YM131046 D41603GA 79 3/4" LOCK WASHER 2 33632 039850YM131046 D41603GB 70 3/4" LOCK WASHER 2 33632 039850YMMETRIC001 D38190GA 17 M12 LOCK WASHER 3 M12 HELICAL 039850YMMETRIC001 D44320GA 63 M12 LOCK WASHER 8 M12 HELICAL 039850YMMETRIC003 D44320GA 64 M10 LOCK WASHER 6 40384 039850YMMETRIC004 D39249GA 53 M6 LOCK WASHER 6 1140381 039850YMMETRIC004 D39258GA 41 M6 LOCK WASHER 2 1140381 039850YMMETRIC004 D42854GA 53 M6 LOCK WASHER 6 1140381 039850YN001 D24999GA 42 FENDER WASHER 2 1133209 039850YN001 D24999GB 42 FENDER WASHER 2 1133209 039850YN001 D24999GC 42 FENDER WASHER 2 1133209 039850YN001 D24999GD 42 FENDER WASHER 2 1133209 039850YN001 D41603GB 71 1/4" FENDER WASHER 1 1133209 039850YN120386 D24997GF 18 1/4 FLAT WASHER 24 1133078 039850YN120386 D24997GG 18 1/4 FLAT WASHER 24 1133078 039850YN120386 D24997GH 18 1/4 FLAT WASHER 24 1133078 039850YN120386 D24997GJ 18 1/4 FLAT WASHER 24 1133078 039850YN120386 D24999GA 37 1/4 FLAT WASHER 12 1133078 039850YN120386 D24999GB 37 1/4 FLAT WASHER 12 1133078 039850YN120386 D24999GC 37 1/4 FLAT WASHER 10 1133078 039850YN120386 D24999GD 37 1/4 FLAT WASHER 20 1133078 039850YN120386 D39126GA 50 1/4" FLAT WASHER 8 1133078 039850YN120386 D39249GA 54 1/4" FLAT WASHER 2 1133078 039850YN120386 D41600GA 68 1/4" FLAT WASHER 14 1133078 039850YN120386 D41600GB 68 1/4" FLAT WASHER 14 1133078 039850YN120386 D41601GA 56 1/4" FLAT WASHER 14 1133078 039850YN120386 D41601GB 56 1/4" FLAT WASHER 14 1133078 039850

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 79 11-06-2018

YN120386 D41602GA 49 1/4" FLAT WASHER 9 1133078 039850YN120386 D41602GB 49 1/4" FLAT WASHER 9 1133078 039850YN120386 D41603GA 80 1/4" FLAT WASHER 32 1133078 039850YN120386 D41603GB 72 1/4" FLAT WASHER 39 1133078 039850YN120386 D41604GA 64 1/4" FLAT WASHER 4 1133078 039850YN120386 D41604GD 64 1/4" FLAT WASHER 4 1133078 039850YN120386 D42850GA 35 1/4" FLAT WASHER 4 1133078 039850YN120386 D42854GA 54 1/4" FLAT WASHER 2 1133078 039850YN120386 D42855GA 28 1/4" FLAT WASHER 4 1133078 039850YN120386 D44320GA 65 1/4" FLAT WASHER 4 1133078 039850YN120391 C24774GA 10 #10 FLAT WASHER 2 33074 039850YN120391 D39126GA 51 #10 FLAT WASHER 4 33074 039850YN120391 D39249GA 55 #10 FLAT WASHER 4 33074 039850YN120391 D39258GA 42 #10 FLAT WASHER 10 33074 039850YN120391 D41601GA 57 #10 FLAT WASHER 2 33074 039850YN120391 D41601GB 57 #10 FLAT WASHER 2 33074 039850YN120391 D41604GA 65 #10 FLAT WASHER 4 33074 039850YN120391 D41604GD 65 #10 FLAT WASHER 4 33074 039850YN120391 D42854GA 55 #10 FLAT WASHER 4 33074 039850YN120394 D38190GA 20 3/8 FLAT WASHER 20 33082 039850YN120394 D39126GA 52 3/8" FLAT WASHER 8 33082 039850YN120394 D41600GA 69 3/8" FLAT WASHER 8 33082 039850YN120394 D41600GB 69 3/8" FLAT WASHER 8 33082 039850YN120394 D42850GA 36 3/8" FLAT WASHER 8 33082 039850YN120394 D42855GA 29 3/8" FLAT WASHER 4 33082 039850YN120394 D44320GA 66 3/8" FLAT WASHER 13 33082 039850YN120396 D44320GA 67 1/2 FLAT WASHER 4 33086 039850YN121458 D41600GA 70 9/16" FLAT WASHER 4 1133088 039850

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 80 11-06-2018

YN121458 D41600GB 70 9/16" FLAT WASHER 4 1133088 039850YN131016 D44320GA 68 5/8 FLAT WASHER 4 33090 039850YN131016 D44321GA 18 5/8 FLAT WASHER 8 33090 039850YN131017 D41600GA 71 3/4 FLAT WASHER 12 33092 039850YN131017 D41600GB 71 3/4 FLAT WASHER 12 33092 039850YN131017 D41601GA 58 3/4 FLAT WASHER 6 33092 039850YN131017 D41601GB 58 3/4 FLAT WASHER 6 33092 039850YN446362 D41601GA 59 5/16 FLAT WASHER 7 1133006 039850YN446362 D41601GB 59 5/16 FLAT WASHER 7 1133006 039850YS120361 D39249GA 56 #10-24 HEX NUT 2 1136028 039850YS120361 D39258GA 43 #10-24 HEX NUT 4 1136028 039850YS120361 D41600GA 72 #10-24 HEX NUT 5 1136028 039850YS120361 D41600GB 72 #10-24 HEX NUT 5 1136028 039850YS120361 D42854GA 56 #10-24 HEX NUT 5 1136028 039850YS120361 D44320GA 69 #10-24 HEX NUT 2 1136028 039850YT120369 D38190GA 23 3/8-24 HEX NUT 1 36356 039850YT120375 C24998GA 7 1/4-20 HEX NUT 2 36302 039850YT120375 C24998GB 7 1/4-20 HEX NUT 4 36302 039850YT120375 C24998GC 7 1/4-20 HEX NUT 4 36302 039850YT120375 D41602GA 50 1/4-20 HEX NUT 12 36302 039850YT120375 D41602GB 50 1/4-20 HEX NUT 12 36302 039850YT120375 D41603GB 73 1/4-20 HEX NUT 2 36302 039850YT120375 D42850GA 37 1/4-20 HEX NUT 4 36302 039850YT120376 D39249GA 57 5/16-18 HEX NUT 4 1136304 039850YT120376 D42854GA 57 5/16-18 HEX NUT 4 1136304 039850YT120376 UMA0266 19 5/16-18 HEX NUT 8 1136304 039850YT120376 UMA0271 19 5/16-18 HEX NUT 8 1136304 039850YT124829 D41603GB 74 3/8-16 JAM NUT 1 BY DESCRIPTION 039850

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 81 11-06-2018

YT124829 D42850GA 38 3/8-16 JAM NUT 4 BY DESCRIPTION 039850YT219770 D39126GA 53 3/4-16 HEX NUT 6 36466 039850YT9418738 D38190GA 22 3/8-16 HEX NUT 3 36406 039850YT9418738 D42850GA 39 3/8-16 GR8 HEX NUT 2 36406 039850YT9418755 D44321GA 19 5/8-18 HEX LONG NUT 8 1137892 039850YTMETRIC008 D44320GA 70 M10 X 1.25 HEX NUT 4 BY DESCRIPTION 039850YU024A D26542GA 5 5/8-18 LOCK NUT 8 37587 039850YU273767 D41601GA 60 5/16-24 LOCK NUT 1 22UTB5162 039850YU273767 D41601GB 60 5/16-24 LOCK NUT 1 22UTB5162 039850YU273924 D24997GF 19 1/4-20 UNITORQUE 12 10365-01240 039850YU273924 D24997GG 19 1/4-20 UNITORQUE 12 10365-01240 039850YU273924 D24997GH 19 1/4-20 UNITORQUE 12 10365-01240 039850YU273924 D24997GJ 19 1/4-20 UNITORQUE 12 10365-01240 039850YU273924 D24999GA 38 1/4-20 UNITORQ 10 10365-01240 039850YU273924 D24999GB 38 1/4-20 UNITORQ 10 10365-01240 039850YU273924 D24999GC 38 1/4-20 UNITORQ 4 10365-01240 039850YU273924 D24999GD 38 1/4-20 UNITORQ 4 10365-01240 039850YU273924 D39126GA 54 1/4-20 LOCK NUT 2 10365-01240 039850YU273924 D41601GA 61 1/4-20 LOCK NUT 11 10365-01240 039850YU273924 D41601GB 61 1/4-20 LOCK NUT 11 10365-01240 039850YU273924 D41602GA 51 1/4-20 LOCK NUT 8 10365-01240 039850YU273924 D41602GB 51 1/4-20 LOCK NUT 8 10365-01240 039850YU273924 D41603GA 81 1/4-20 LOCK NUT 24 10365-01240 039850YU273924 D41603GB 75 1/4-20 LOCK NUT 24 10365-01240 039850YU274638 D26542GA 9 9/16-18 UNITORQUE NUT 2 37310 039850YU274638 D41600GA 73 9/16-18 LOCK NUT 4 37310 039850YU274638 D41600GB 73 9/16-18 LOCK NUT 4 37310 039850YU274638 D44321GA 20 9/16-18 LOCK NUT 2 37310 039850

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 82 11-06-2018

YU274993 D24999GD 48 3/8-16 LOCK NUT 2 37264 039850YU274993 D39105GA 23 3/8-16 LOCK NUT 12 37264 039850YU274993 D39126GA 55 3/8-16 LOCK NUT 2 37264 039850YU274993 D41600GA 74 3/8-16 LOCK NUT 4 37264 039850YU274993 D41600GB 74 3/8-16 LOCK NUT 4 37264 039850YU274993 D42850GA 40 3/8-16 LOCK NUT 4 37264 039850YU9411638 D41601GA 62 5/16-18 LOCK NUT 1 37262 039850YU9411638 D41601GB 62 5/16-18 LOCK NUT 1 37262 039850YU9411638 D41603GB 76 5/16-18 LOCK NUT 12 37262 039850YU9411638 D42850GA 41 5/16-18 LOCK NUT 4 37262 039850YU9411727 D41600GA 75 1/2-13 LOCK NUT -4 37268 039850YU9411727 D41600GB 75 1/2-13 LOCK NUT -4 37268 039850YU9411727 D41601GA 63 1/2-13 LOCK NUT 1 37268 039850YU9411727 D41601GB 63 1/2-13 LOCK NUT 1 37268 039850YU9411727 D41602GA 52 1/2-13 LOCK NUT 4 37268 039850YU9411727 D41602GB 52 1/2-13 LOCK NUT 4 37268 039850YU9411727 D41603GA 82 1/2-13 LOCK NUT 4 37268 039850YU9411727 D41603GB 77 1/2-13 LOCK NUT 4 37268 039850YU9411818 D44320GA 71 1/2-20 LOCK NUT 6 51UTC-1220 039850YU9413947 D41601GA 64 7/16-14 LOCK NUT 2 1137266 039850YU9413947 D41601GB 64 7/16-14 LOCK NUT 2 1137266 039850YU9413970 D44320GA 72 5/8-18 LOCK NUT 2 10365-01267 039850YU9413971 D41600GA 76 3/4-10 LOCK NUT 8 37274 039850YU9413971 D41600GB 76 3/4-10 LOCK NUT 8 37274 039850YU9413972 D26542GA 10 3/4-16 LOCK NUT 2 37314 039850YU9413972 D41600GA 77 3/4-16 LOCK NUT 2 37314 039850YU9413972 D41600GB 77 3/4-16 LOCK NUT 2 37314 039850YU9413972 D41601GA 65 3/4-16 LOCK NUT 10 37314 039850

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 83 11-06-2018

YU9413972 D41601GB 65 3/4-16 LOCK NUT 10 37314 039850YUMETRIC002 D41602GA 53 M6 X 1 LOCK NUT 2 1140155 039850YUMETRIC002 D41602GB 53 M6 X 1 LOCK NUT 2 1140155 039850YW0010A D41600GA 78 3/4-16 SERRATED FLANGE NUT 24 94831A745 006043YW0010A D41600GB 78 3/4-16 SERRATED FLANGE NUT 24 94831A745 006043YZ0004 D24999GA 50 1/8" POP RIVET 30 41209 039850YZ0004 D24999GB 50 1/8" POP RIVET 30 41209 039850YZ0004 D24999GC 50 1/8" POP RIVET 25 41209 039850YZ0004 D24999GD 50 1/8" POP RIVET 25 41209 039850YZ0005 D24999GE 39 POP RIVET 25 41229 039850YZ0005 D24999GF 39 POP RIVET 25 41229 039850YZ0005 D24999GG 39 POP RIVET 25 41229 039850YZ0021 D39258GA 44 THUMB SCREW ZN - 1/4-20 X 1 1 32781 039850YZ0021 D39258GB 44 THUMB SCREW ZN - 1/4-20 X 1 1 32781 039850YZ0021 D41603GA 83 THUMB SCREW ZN - 1/4-20 X 1 2 32781 039850YZ0021 D41603GB 78 THUMB SCREW ZN - 1/4-20 X 1 2 32781 039850

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 3

Page 84 11-06-2018

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 1 11-06-2018

DETAILED PARTS LIST

GENERAL The following information has been provided to help explain the content of the detailed parts list. This section identifies and illustrates serviceable parts that were “VENDOR SUPPLIED” or produced by Lift-A-Loft. Vendor supplied parts are pictured and then identified by the actual vendor part number. Vendor parts breakdowns are shown where available. Items fabricated by Lift-A-Loft or vendor assemblies that are modified by Lift-A-Loft are identified by a Lift-A-Loft part number. An attempt has been made to show parts broken-down to the component level. See the key below for definition of abbreviations. Only the basic unit is covered for the more major components such as transmissions, engines and so on. Chapter 5 contains the engine and drive train parts breakdown, which is the largest portion of the vendor supplied parts. Items are permanently joined to other parts, and items that are fabricated in such a way

that causes the component to lose its original identity, will be listed with a L-A-L number only.

The most complete listing of the major parts and their locations may be found on the drawings included at the end of this chapter.

The most complete vendor supplied parts breakdown and service information for the major components will be found in Chapter 5.

NOTE: Vendor part numbers and illustrations were current at the time that this manual was released. When repairing and/or replacing items, keep in mind that parts are subject to change (without notice). QTY = Quantity per assembly.

-* = No L-A-L number REF = See additional reference figure. REQ = As required. VENDOR = Vendor & Mfg are the same.

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 2 11-06-2018

THIS PAGE LEFT

BLANK

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 3 11-06-2018

APX20-LP SCISSOR LIFTFIGURE 1

D41601GA-GBSTAGE 2

D41602GA-GBSTAGE 3

D41606 WIRING DIAGRAM/SCHEMATICD41605GA--GG

HYDRAULIC LAYOUT/SCHEMATIC

C39365GA-GB BRAKE LINE

LAYOUT

B30172GA A/C HOSE KIT

C24774GA 110VAC

JUNCTION BOX

D41608GA-GBDRESS KIT

B41994GA CHASSIS WIRE

HARNESS

A37461GA MAGNETIC SWITCH

ASSEMBLY

D39105GA SCISSOR ASSY

D26542GA FRONT AXLE

D39126GA PLATFORM ASSEMBLY

(TRAVERSING)

D44320GB ENGINE

CARRIAGE ASSY

D39258GA-GB UPPER CONTROL

STATION

D39249GA LOWER ENCLOSURE

B39373GA STABILIZER HARNESS

D41600GA-GBSTAGE 1

(CHASSIS)

D41603GA-GB CAB ASSEMBLY UMA0271

MANIFOLD ASEMBLY(inside enclosure)

C38177GA ENGINE WIRE HARNESS

D41604GA--GD DASH ASSY

D38190GA A/C OPTION KIT

D39262GA AIR FITTING

LAYOUT

D44321GA REAR AXLE

C24998GA-GB-GC MIRROR OPTION KIT

D24999GA-GB DOOR KIT

B39270GA UPPER

PENDANT CONTROLLER

B39374GA UPPER CONTROL

STATION HARNESS

B42852GA UPPER

PENDANT CONTROLLER

D24997 WINDOW KIT

D41607GA AIR FITTING

LAYOUT

D42850GA AIR

COMPRESSOR KIT

D42854GA LOWER ENCLOSURE

D39126GA PLATFORM

ASSEMBLY (FIXED)

UMA02666 MANIFOLD ASEMBLY

(inside enclosure)

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 4 11-06-2018

FIGURE 2

HCM129 TRAVERSING CYLINDER

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 5 11-06-2018

FIGURE 2

HCM129 TRAVERSING CYLINDER

PART NUMBER

ITEM NOMENCLATURE QTY VENDOR PART # VENDOR/MFG

AIRLINE NO.

HCM129 - TRAVERSING CYLINDER REF MC0200020060-L25 006099 * 1 BARREL ASSY 1 MC-20-600L25-8 006099 * 1A BARREL 1 MC-20B-600-8 006099 * 1B END CAP 1 MC-20-8E 006099 * 1C PORT SPUD 2 WPS-15D-8 006099 * 2 PISTON NUT 1 WC-2-2 006099 * 3 PISTON WEAR RING 2 STM-20-1 006099 * 4 PISTON 1 DD-20-2 006099 * 5 PISTON SEAL 1 STM-20-3 006099 * 6 PISTON SEAL EXPANDER 1 CD-15-8 006099 * 7 PISTON & ROD SEAL 1 MC-20-6 006099 * 8 PISTON ROD 1 MC-20A-600-10 006099 * 9 ROD SEAL 1 MC-20-13 006099 * 10 GLAND SEAL 1 MMSC-30-9 006099 * 11 GLAND SEAL BACKUP 1 WC-2-10 006099 * 12 GLAND 1 MC-20A-11 006099 * 13 BARREL COLLAR 1 MC-20-15 006099 * 14 ROD WIPER 1 MC-20-16 006099 * 15 PIN 1 MC-25-17A 006099 * 16 ROD CLEVIS 1 DC-20A-17 006099 * 17 CLEVIS PIN 2 MC-20-27 006099 * 18 COTTER PIN 2 MC-20-24 006099 * 19 STOP TUBE 1 MC-20A-060-7 006099

HCM129-1 - PACKING KIT 1 MC-20A-PK 006099

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 6 11-06-2018

FIGURE 4 HCM122D STEERING CYLINDER

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 7 11-06-2018

FIG 4

HCM122D STEERING CYLINDER

PART NUMBER


AIRLINE NO.

HCM122D - Cylinder- Steering REF 321-109 041866 HCM122D-1 * Packing Kit 1 783555 041866

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 8 11-06-2018

FIGURE 5 HCM212A Stabilizer Cylinder

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 9 11-06-2018

FIG 5 HCM212A Stabilizer Cylinder

PART

NUMBER ITEM NOMENCLATURE QTY VENDOR PART # VENDOR/

MFG AIRLINE

NO. HCM212A - STABILIZER CYLINDER REF 320-803 041866

HCM212-1* 1 PACKING KIT 1 783-109 041866

*AVAILABLE UPON REQUEST

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 10 11-06-2018

FIG 5 HV316-12VA-5.0-A MAIN HOLDING VALVE

1

2

3

4

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 11 11-06-2018

FIG 5 HV316-12VA-5.0-A MAIN HOLDING VALVE

PART NUMBER ITEM NOMENCLATURE QTY VENDOR PART # VENDOR AIRLINE NO.

HV316-12VA-5.0 - HOLDING VALVE REF HV316-12VA-5.0 007938 HV316 1 COUNTERBALANCE 1 CBCA-LHN 003962 HV316-06 2 FLOW CONTROL 1 FR101S260-20 003947 HV316-02A 3 SOLENOID CARTRIDGE 1 DSL101C 003947 HV316-07A 4 COIL –HIGH WATT 1 S10LPD012 003947

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 12 11-06-2018

FIGURE 6 HCM211 MAIN LIFT CYLINDER

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 13 11-06-2018

FIG 6

HCM211 Main Lift Cylinder

PART NUMBER


AIRLINE NO.

HCM211 - MAIN LIFT CYLINDER REF D3658B 040491 * 1 BLEEDER 1 480705 040491 * 2 3” ROD WIPER 1 31029H 040491 * 3 3” GLAND 1 503658 040491 * 4 3” ROD SEAL 1 26330U 040491 * 5 4” ROD WIPER 1 31037H 040491 * 6 4” GLAND 1 503657 040491 * 7 4” ROD SEAL 1 21340U 040491 * 8 BACKUP 1 18236T 040491 * 9 O-RING 1 12236U 040491 * 10 BACKUP 1 18244T 040491 * 11 O-RING 1 12244U 040491 * 12 RETAINER 1 410450 040491 * 13 RETAINER 2 410350 040491 * 14 ROD ASSY 1 8010302 040491 * 15 ROD ASSY 1 8310302 040491 * 16 4.5” WEAR RING 1 38051G 040491 * 17 3.5” WEAR RING 1 38033G 040491 * 18 BODY ASSY 1 8610302 040491

HCM211-1 19 SEAL KIT 040491

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 14 11-06-2018

FIG 7 ST173-6 BRAKE MASTER CYLINDER

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 15 11-06-2018

PART NUMBER

ITEM NOMENCLATURE QTY VENDOR PART # MFG AIRLINE NO.

ST173-6 - BRAKE MASTER CYLINDER REF 02-461-404 006178 ST173-1 * SEAL KIT (Marked with Dot 1 02-400-185 006178

FIG 7 ST173-6 BRAKE MASTER CYLINDER

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 16 11-06-2018

FIG 8 ST173-5 BRAKE MASTER CYLINDER BOOSTER

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 17 11-06-2018

PART NUMBER


ST173-5 - BRAKE MASTER CYLINDER BOOSTER

REF 02-461-404 006178

ST173-2 * SEAL KIT FOR BOOSTER 1 02-400-016 006178

FIG 8 ST173-5 BRAKE MASTER CYLINDER BOOSTER

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 18 11-06-2018

FIG 9

ESB703 UPPER CONTROL PENDANT

1

2

3

4

4

4

4

5

8

9

10

7

6

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 19 11-06-2018

PART NUMBER


ESB703 - UPPER CONTROL STATION REF ESB703 040837 ESB703-1 1 HOUSING 1 25407580 040837 ESB703-2 2 E-STOP BUTTON 98306116 040837 ESB703-3 3 GREEN MOMENTARY

BUTTON 1 92100898 040837

ESB703-4 4 BLACK MOMENTARY BUTTON

4 92100897 040837

ESB703-8 5 E-STOP LEGEND PLATE 1 ZB2BY2330 040837 ESB703-9 6 ON LEGEND PLATE 1 ZB2BY2311 040837 ESB703-10 7 RAISE LEGEND PLATE 1 ZB2BY2335 040837 ESB703-11 8 LOWER LEGEND PLATE 1 ZB2BY2337 040837 ESB703-12 9 OUT LEGEND PLATE 1 ZB2BY2339 040837 ESB703-13 10 IN LEGEND PLATE 1 ZB2BY2503 040837 ESB703-5 * 11 NORMALLY CLOSED

CONTACT 92102449 040837

ESB703-6 * 12 NORMALLY OPEN CONTACT

92102450 040837

ESB703-7 * 13 MECHANICAL INTERLOCK 92103573 040837 * NOT SHOWN

FIG 9 ESB703 UPPER CONTROL PENDANT

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 20 11-06-2018

FIG 10 HP118 HYDRAULIC MOTOR

1 4

3

38 5

26

7

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 21 11-06-2018

FIG 10

HP118 HYDRAULIC MOTOR

ITEM

PART NUMBER

NOMENCLATURE QTY VENDOR PART # MFG # AIRLINE #

- HP118 GEAR HYDRAULIC MOTOR REF SNP2-17DCI-06 040874 1 - REAR COVER 1 B30800-21000 040874 2 - SNAP RING 1 B57252-22975 040874 3 - DOWEL PIN 4 B57310-21290 040874 4 - SCREW 4 B57121-02644 040874 5 - IDLER GEAR 1 B31114-02000 040874 6 - FLANGE 1 B30700-39000 040874 7 - DRIVE GEAR-STRAIGHT KEY 1 B31116-52000 040874 8 - SHAFT COVER 1 B33000-12000 040874

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 22 11-06-2018

KU181

KU85

KU81

KU82

KU83

KU84

LU86

LU80

LU87

WU88 EQ80

W66

EQ77

EQ56

W63

EQ50

W63 W65

W62

W78

G154

G54E K52 W67

W18

L5

L50 W62

L51

L40 K146

K145

L41

W30

K31

W18

L7

W78

EQ76

EQ748EQ74AK8

EQ74DEQ72

EQ174

W175

W170

W2 EQ73 EQ70

EQ70EQ71

EQ72

W10

W3 W13

F15

W14

K8

K43

K44

K46

K47

K47

K45

K43

K44

K133

K33

K33

K34

K32

K132

K32W

L41

W40

EQ51

K36A

K35

W22 EQ38

EQ35

EQ37

W21W

W30

K31

W21 W25

W11 W9

W20

W23A W23

K36A

K36AW21 W21

K32

K32

W1

L55

L54

L54E

L53

FIG 11 Air

Compressor

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 23 11-06-2018

FIGURE 11 AIR COMPRESSOR

PART

NUMBER ITEM NOMENCLATURE QTY VENDOR PART # MFG # AIRLINE NO.

PM11A - AIR COMPRESSOR REF EMGLO MODEL WU 040847 * - CRANKCASE 1 W1 040847 * - BEARING CAP 1 W2 040847 * - BEARING CAP GASKET (.031) 1 W3 040847 * - USE 121-1032 1/4X1/8 TUBE EL CONN. 1 L5 040847 * - USE 120-1002 BEARING CAP BOLT 1/4-20 X

5/8 (15 FT-LB) 4 K6 040847

* - USE 121-1025 1/4X1/8 TUBE CONN 1 L7 040847 * - USE 120-1017 CRANKCASE BOLT 5/16-18 X

3/4 (15FT-LB) 12 K8 040847

* - BEARING-FLYWHEEL END 1 W9 040847 * - BEARING W/OUTBOARD SHIELD 1 W10 040847 * - OIL SEAL 1 W11 040847 * - USE 122-1046

OIL DRAIN PLUG 3/8 NPT 1 W13 040847

* - FILL CAP (INCLUDES F15) 1 W14 040847 * - FILL CAP GASKET 1 F15 040847 * - BREATHER TUBE 1 W18 040847

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 24 11-06-2018

PART NUMBER

ITEM NOMENCLATURE QTY VENDOR PART # MFG # AIRLINE NO.

* - CRANKSHAFT 1 W20 040847 * - CONNECTING ROD W/DIPPER ASSY 3 W21 040847 * - CONNECTING ROD HP ASSY W/EQ38

BEARING 1 W21W 040847

* - ROD BOLT W/LOCK WASHER 5/16-18X1 1/2 (15 FT-LB)

8 W22 040847

* - FLYWHEEL –15"OD W/W25 KEY

1 W23 040847

* - FLYWHEEL-16"OD (FOR ALL PUMPS W SERIAL NO. BEGINNING WITH "B"

1 W23A 040847

* - FLYWHEEL SPIROL PIN KEY 1 W25 040847 * - CYLINDER 2 W30 040847 * - CYLINDER GASKET 2 K31 040847 * - PISTON LP 3 K32 040847 * - PISTON HP 1 K32W 040847 * - COMPRESSION RING (CHAMFER/PIP MARK

ON TOP SIDE) 8 K33 040847

* - OIL CONTROL RING ASSY 4 K34 040847 * - PISTON PIN LP 3 K35 040847 * - PISTON PIN HP 1 EQ35 040847

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 25 11-06-2018

PART NUMBER


* - BEARING 1 EQ38 040847 * - PIN RETAINER LP 6 K36A 040847 * - ROLL PIN 1 EQ37 040847 * - VALVE PLATE 1 L40 040847 * - VALVE PLATE 1 W40 040847 * - VALVE PLATE GASKET 2 L41 040847 * - VALVE RETAINER 9 K43 040847 * - VALVE BUMPER 9 K44 040847 * - VALVE SPRING-LIGHT 3 K45 040847 * - VALVE SPRING-HEAVY 6 K46 040847 * - VALVE DISC 9 K47 040847 * - LEFT HEAD (START-STOP TYPE) 1 L50 040847 * - RIGHT HEAD (START-STOP TYPE) 1 EQ50 040847 * - LEFT HEAD GASKET 1 L51 040847 * - RIGHT HEAD GASKET 1 EQ51 040847 * - HEAD BOLT 5/16-18X2 1/4 (22FT-LB) 12 K52 040847 * - FILTER MOUNT 2 L53 040847 * - FILTER COVER 2 L54 040847 * - FILTER ELEMENT 2 L54E 040847 * - FILTER ELEMENT 2 G54E 040847

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 26 11-06-2018

PART NUMBER


* - FINNED INTERCOOLER W/FLARE NUTS 5/8" 1 W62 040847 * - PACKAGE OF (4) FILTER ELEMENTS 1 G54EP 040847 * - FILTER NUT 2 L55 040847 * - USE SV65 SAFETY VALVE (65PSIG) 1 EQ56 040847 * - USE 121-1012 1/2X3/8 FLARE EL 2 W63 040847 * - FINNED INTERCOOLER W/FLARE NUTS 1/2" 1 W65 040847 * - USE 121-1014 5/8X3/8 FLARE EL 1 W66 040847 * - USE 121-1020 5/8X3/8 FLARE 45 EL 1 W67 040847 * - WEIGHT PAIR 1 EQ70 040847 * - OPERATING TUBE 1 EQ71 040847 * - SPRING 1 EQ72 040847 * - PIVOT PIN W/COTTER PIN 1 EQ73 040847 * - COTTER PIN 1 EQ73B 040847 * - AIR VALVE 1 EQ74A 040847 * - UNLOADER BODY 1 WQ74B 040847 * - HEX NUT 1 EQ74C 040847 * - OPERATING PIN 1 EQ74D 040847 * - USE 121-1025 1/4X1/8 TUBE CONN. 1 EQ76 040847 * - USE 121-1032 1/4X1/8 TUBE EL 1 EQ77 040847 * - CENTRIFUGAL UNLOADER TUBE 1 W78 040847

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 27 11-06-2018

PART NUMBER


* - UNLOADER SPRING 4 KU83 040847 * - LEFT HEAD UNLOADING TYPE 1 LU80 040847 * - RIGHT HEAD UNLOADING TYPE 1 EQ80 040847 * - UNLOADER PISTON 4 KU81 040847 * - 0-RING 4 KU82 040847 * - UNLOADER WASHER 4 KU84 040847 * - UNLOADER RETAINER 4 KU85 040847 * - USE 121-1032 1/4X1/8 TUBE EL CONN. 1 LU86 040847 * - USE 121-1039 1/4X1/8 TUBE TEE 1 LU87 040847 * - UNLOADER MANIFOLD TUBE 1 WU88 040847 * - GASKET SET (W3, 2 OFK31, 2 OF L41, L51,

EQ51) 1 W100 040847

* - BASIC REPAIR KIT-MODEL W (W100, 2 OF K133, 3 OF K145, 6 OF K146, 2 OF L54E)

1 W101 040847

* - BASIC REPAIR KIT-MODEL WU (W101 PLUS 4 OF KU181)

1 WU101 040847

* - PISTON, PIN, RINGS LP 3 K132 040847 * - PISTON, PIN, RINGS HP 1 EQ132 040847 * - PISTON RING SET FOR TWO PISTONS 2 K133 040847 * - LEFT VALVE PLATE, W/VALVES INSTALLED

W/L41,L51 GASKETS) 1 L140 040847

Prope

rty o

f Am

erica

n Airli

nes


CHAPTER 4 SECTION 4

Page 28 11-06-2018

PART NUMBER


* - CENTER UNLOADER WEIGHT ASSY W/GASKET (EQ70, 71, 72, 73, W3)

1 W170 040847

* - RIGHT VALVE PLATE, W/VALVES INSTALLED W/L41,EQ51 GASKETS)

1 W140 040847

* - VALVE ASSY – LIGHT 3 K145 040847 * - VALVE ASSY - HEAVY 6 K146 040847 * - FILTER ASSY 2 G154 040847 * - CENTER UNLOADER VALVE ASSY (EQ74A,

B,C,D, EQ76) 1 EQ174 040847

* - CENTER UNLOADER COMPLETE ASSY W/BEARING CAP, TUBING, AND GASKET

1 W175 040847

* - LEFT UNLOADING HEAD W/UNLOADERS 1 LU180 040847 * - RIGHT UNLOADING HEAD W/UNLOADERS 1 EQ180 040847 * - UNLOADER ASSY (KU81, 82, 83, 84, 85) 1 KU181 040847 * - OIL LEVEL SIGHT GAGE, FACTORY INST. 1 LOW 040847

Prope

rty o

f Am

erica

n Airli

nes

Date post:	09-Jan-2020
Category:	Documents
Upload:	others
View:	0 times
Download:	0 times

MANUAL NUMBER APX20-LP110618 · MANUAL NUMBER APX20-LP110618 EFFECTIVITY: 11-06-2018 APX20-LP...

Documents