McQuay Console Water Source Heat Pump - Daikin...

McQuay

Console Water Source Heat Pump

WMH, WCH, WMG, WMK007 - 019Vintage C

Last Manufactured: 1999

To find your Daikin Applied parts distributor, call 1-800-377-2787 or visit www.DaikinApplied.com

Replacement Parts List No. 057118400 Revision L 08/2017

WSHP; WMH,WCH,WMG,WMK 007-019 Vintage C Rev. L 08/17 RPL 0571184 / Page 2

ContentsParts List Revision History............................................................................................................................3 - 4

Nomenclature Serial Number Until February, 1999 ............................................................................................................ 5 Serial Number February, 1999 and later ..................................................................................................... 5 Model Number- Nameplate ......................................................................................................................... 5 Model Number- Complete ........................................................................................................................... 6

Field Installed Accessories ...........................................................................................................................7 - 9

Refrigeration Circuit Compressor Diagrams ................................................................................................................................................. 10 Unit Sizes 007 - 012 Components .......................................................................................................... 11 Unit Sizes 015, 019 Components ............................................................................................................ 12 Evaporator, Switches, Drain Pans, Plugs & Valves .................................................................................. 13 Condenser Coil and Tubing ....................................................................................................................... 14

Regulating Valve Dual Acting Water Regulating Valve .......................................................................................................... 15 Motorized Water Regulating Valve ............................................................................................................ 16

Fan and Housing Assembly Unit Sizes 007 - 012 Components ............................................................................................................ 17 Unit Sizes 015, 019 Components ............................................................................................................. 18

Control Box MicroTech 520 ....................................................................................................................................19 - 21 MicroTech Unit Control .......................................................................................................................22 - 24 Mark IV Control ..................................................................................................................................25 - 27 Disconnect Box ......................................................................................................................................... 28

Electric Heat .................................................................................................................................................... 29

Outside Air Damper Manual Damper ......................................................................................................................................... 30 Motorized Damper ..................................................................................................................................... 31

Flat Top Cabinet .......................................................................................................................................32 - 51Slope Top Cabinet ....................................................................................................................................52 - 60No Cabinet....................................................................................................................................................... 60Subbase, Finished Back Panel.................................................................................................................61 - 62Chassis Panels .........................................................................................................................................63 - 64

Critical Parts List......................................................................................................................................... CPL1


Parts List Revision History

12/97 Draft Copy. Not yet approved by engineering. --- 3/98 2nd Draft Copy. Changes made to: Page 5- Code string C10 and C22 changed from 'Y' to 'A', also Keylock description and Cleanable Filter descriptions revised; Page 11-Size 015 title changed from Panasonic to Tecumseh; Page 13-Fusible Plug # changed to 802025014; Pages 33 - 64-Changes made throughout these pages to reflect that code strings C10=A and C22=A. --- 4/98 3rd Draft Copy. Changes made to: Page 10- Added Capillary to 007 Panasonic and 009 Panasonic and Techumseh. Page 11- Added Capillary & Strainer to 012 Panasonic and Tecumseh. Page 12- Added Capillary & Strainer to 019 Panasonic and Tecumseh. Page 13- Added Reversing Valve 066533701 & 066533601. Page 24- Added diagrams. Page 27: Added diagrams and made changes to Overlay-Control Plate. NEW 6/98 Status change from Draft Copy to Final. A 1/99 Pages 10, 11, 12: Added compressor note to bottom of pages. Pages 56 thru 64: Added Screw and Button Head Dart Fastener to lists for Slope Top Cabinets. B 2/99 Page 10- Added part numbers for 115V Tecumseh Compressor and Capacitor (Ref.#101 and 102). C 10/99 Page 5- Added "J" to Code 5. Added "SB" to Code 7. Added "Y" to Code 22. Page 9- Updated pn's for Lock Nut-Panasonic Compr. (Ref.# 110), Mtg. Sleeve-PanasonicComp.(Ref.# 131), & Compr. Grommet. Page 11 - Updated p/n's for Capillary & Strainer on size 012 units. Added Capillary& Strainer on size 015. Page 13 - Updated part number for Fusible Plug. Page 14 - Added note to Tube-90 Deg. description (Ref.# 176). Page 16 - Updated part number for Water Reg. Valve Assy, N.O. for 208V and 230V (Ref.# 511). Page 24 - Added footnote to Transformer Assy, Circuit Breaker (Ref.# 265). Page 27 - Added note to Transformer Circuit Breaker description. Updated information for Top Panel- Flat Top Units (Ref.# 362), Top Panel- Slope Top (Ref.#362) and Plate/Bracket, T-stat (Ref.# 366). Page 28 - Added part number and description for Circuit Breaker, Mark IV. Page 43 - Removed the word "locking" from Door description (Ref.# 653). Page 53 - Added new pg for "Flat Top Cabinet, cont'd". Resulted in the re-num. of all pgs after pg 53. Pages 57, 58, 59, 60, 61, 62, 63, 64 & 65 - Updated part numbers for Blockoff (Ref.#663). Page 67 - Updated part numbers for Back Panels, Std. and XQ (Ref.# 605). Pages 68, 69 & 70 - Removed Back Panel and Condenser Access Panel. Added Back Panel Assembly. D 1/01 Page 5- Added E=Electromechanical Control to Control System (nomenclature #5). Page 11- Changed Strainer (Size 12) pn 060628808 to 06628802 and Size 15 pn to 060628806. Page 13- Added Rev. Valve Solenoid C04=C, M or E pn #066541901 & Rev. Valve C04= C, M or E pn 06653701. Added note #3 to components list. Page 17,18-Added Receptacle 6 ckt. pn 047934204 for each motor. Pages 22, 25 & 28-Added Receptacle 15 ckt. pn 034621900 & Plug 15 ckt. pn 034622000. Page 25- Added PC Board 3,4,5 & 22 ckt. Terminal Blocks to list. Page 27- Changed Bub. #385; 2-Button Sw. desc. to (C11=A** or RMC) & 4 button Sw desc.to (C11=M**). Page 53- Changed Bub #653, was listed as 061352802 and is now 061301302. Page 61- Corrected pn on Bub #652 - (unit Size 15-19) pn was 061355602, is now 061356602. Page 69- Fan Cover Panels; (C07=F*,C10=Y,C08=H) pn changed to 061353601, C07=F*,C10=Y,C08=L) pn changed to 061354601. Page 70- Fan Cover Panels; (C07=F*,C10=Y,C08=H) pn changed to 061353701, (C07=F*,C10=Y,C08=L) pn changed to 061354101. E 5/01 Page 13- Part No. 066540601 description changed from Limit Control w/bulb to Freezestat w/bulb. F 9/03 Reformatted to new standards. Added new art. Added notes regarding "phantom bills." Pages 5 thru 7- Added footnote 1 and added MUC Panel detail. Reformatted FIA. Page 4- Added serial number nomenclature for units built after 2/99. Page 10- Ref. # 10 size 009 208/230V Tecumseh p/n changed to 061086002. Added mfg. numbers. Page 12- Corrected p/n for all evap coils. Rev. Valve 066533701 for size 12 code changed to C. Page 13- Ref. # 173 corrected C06 for 061417901 and 061418101. Pages 18 thru 21- Removed ref. # 264. Added terminal blocks 073315201 & 061365602. Page 25- Ref. # 378 changed qty. to 5. Page 30- Ref. # 810 changed p/n for all voltages. Page 31- Ref. # 660 removed from drawing (not listed in tables). Page 61- Ref. # 711 added p/n for RH subbase panels. Pages 62, 63- Filter Support application changed to "Low Sill Only." 007, 009, 012 combined into one page.

Revision Date Description

McQuay International, 13600 Industrial Park Blvd., P.O. Box 1551, Minneapolis, MN 55440 (763) 553-5330

Continued on next page.


Parts List Revision HistoryContinued

G 05/2005 Page 12 - Reversing Valve description for pn 066533701 was changed to include "or M". H 06/2005 Page 12 - Reversing Valve- C04= C, M pn 066533701 - Size 012 has qty of 1. I 12/08 Pages 19, 22, 25, 29, 30, 61, 62, 63 - change note from SMG Parts Tech to McQuay Parts. J 5/09 Page 12- Add condensate drain tube p/n 061347201. K 12/12 Title Page- Add WMG. Update from PM6.5 to CS6. Page 4- Model Number- Add WMG= Console WSHP Cooling Only. Update Serial Number Nomenclature. Page 5- Code 1 Model Type- Add WMG= Console WSHP Cooling Only. CPL1- Add Critical Parts List. L 08/17 Add page for Parts List Revision History.Repaginate. Pages 19, 22, 25, 29-30, 61-63 Change note from "Please contact McQuay Parts" to "Please contact Daikin". CPL1- Change to Daikin format. Add compressors. Remove Damper Motor and Valves

Revision Date Description


WMH 007C M N L

Unit Size / Vintage007C= 7,000 Nominal Cooling Btuh009C= 9,000 Nominal Cooling Btuh012C= 12,000 Nominal Cooling Btuh015C= 15,000 Nominal Cooling Btuh019C= 19,000 Nominal Cooling Btuh

Model TypeWMH = Console Water Source Heat PumpWCH = Console Water Source Heat Pump Chassis Only WMG= Console Water Source Heat Pump Cooling OnlyWMK = Console Cabinet Only

Model Number- Nameplate

Control SystemM= Mark IV/AC Control SystemC= MicroTech Unit Controller L= MicroTech 520 Control

Piping HandL= Left HandR= Right Hand

VoltageG= 208-230/60/1 (wired for 208V)N= 265/60/1A= 115/60/1 V= 208/230/60/1 (wired for 230V)

7 6 A 00000 00

Nomenclature

Plant Identification Number7 = Auburn

Serial Number

Month Manufactured A = January B = February C = March D = April E = May F = June

Engineering Revision

Year ManufacturedY= 1993Z= 19945= 19956 = 19967 = 19978 = 19989 = 1999

Serial Number Until February, 1999

G = July I = August J = September K = October L = NovemberM = December

AUB U 99 05 04810

Plant Identification AbbreviationAUB = Auburn

Serial Number (build sequence)

U= Unit

Serial Number February, 1999 and later

Year of Manufacture99= 199900= 200001= 2001

Week of Manufacture


Code 01: Model TypeWMH = Console Heat Pump UnitWCH = Console Heat Pump Chassis OnlyWMG = Console Heat Pump Unit Cooling OnlyWMK = Console Cabinet Only

Code 02 & 03: Unit Size and Vintage007C = 7,000 BTU Cooling009C = 9,000 BTU Cooling012C = 12,000 BTU Cooling015C = 15,000 BTU Cooling019C = 19,000 BTU Cooling

Code 04: Control SystemM = Mark IV ControlC = Microtech Unit ControlL = MicroTech Control 520E = Electromechanical Control

Code 05: Unit VoltageA = 115/60/1 G = 208/230/60/1 (wired 208V) J = 230/50/1 V = 208/230/60/1 (wired 230V)N = 265/60/1

Code 06: Piping HandL= Left HandR= Right Hand

Code 07: Cabinet, Chassis Style & Discharge Grille TypeSP = Slope Top Cabinet with Modular Plastic GrilleSB = Slope Top with Steel Bar GrilleFS = Flat Top with One Piece Stamped GrilleFM = Flat Top with 5" X 5" Modular Discharge GrilleFB = Flat Top with Steel Bar GrilleDC = No Cabinet. Duct Collar for Custom Enclosure

Code 08: Cabinet HeightH = High Sill: 25" HighL = Low Sill: 22.5" High

Code 09: Thermostat ControlACC= Auto Changeover-Continuous Fan OperationStart/Stop and Hi Fan Fan/Low Fan SelectionMCC= ManualChangeover-Continuous Fan OperationStart/Stop and Hi Heat/Low Heat and Hi Fan/Low Fan SelectionACF= Auto Changeover-Cycle Fan with Compressor OperationStart/Stop and HiFan/Low Fan SelectionMCF= Manual Changeover-Cycle Fan with Compressor OperationStart/Stop and Hi Heat/Low Heat/Hi Cool/Low Cool SelectionRMC= Remote Thermostat or Slave Control Unit ControlRequires thermostat input from a field wall t-stat or a master/slave relay MTS=Unit Mounted MicroTechIncludes tenant setpoint adjustment knob. Also includes Start/Stop and Hi/Low FanMRT= Remote Wall Sensor MicroTechRequires field mounted wall sensor

Code 10: Extra Quiet ConstructionS = Extra Quiet ConstructionA = StandardX = Special

NomenclatureModel Number- Complete

Code 11: Mark IV Unit Night ControlsNSB = Night Setback OnlyNWR = Night Set back with Unit Mounted Pushbutton OverrideLLC = Low Limit Only or MicroTech Tenant Override MTR = Tenant Override

Code 12 - 13: Always YY

Code 14: Additional RelayAR = Auxiliary Relay (Mark IV only)MR = MicroTech Relay (MicroTech/520 only)

Code 15: Chassis Power ConnectionY = Std. Junction BoxP = Plug Cord (N/A on 115V)C = Conduit

Code 16: Electrical Connection to CabinetRFD = Fused Disconnect with ReceptacleRFY = Fuses and Receptacle ( no switch)RYY = Receptacle OnlyBDF = Fuses and Disconnect (no receptacleBDY = Disconnect Switch Only

Code 17: Always Y

Code 18: Water Control ValvesM = Motorized Valve- Fail Safe ClosedW = Dual Acting Water Regulating Valve

Code 19: Electric HeatA = .62KW @ 208V: Sizes 007- 012 .75KW @ 230V: Sizes 007- 012 1.0KW @ 265V: Sizes 007- 012 B = 1.23KW @ 208V: All Sizes 1.50KW @ 230V: All Sizes 2.00KW @ 265V: All Sizes C = 1.85KW @ 208V: Sizes 012- 019 2.25KW @ 230V: Sizes 012- 019 3.00KW @ 265V: Sizes 012- 019D = 3.0KW @ 208V: Sizes 015- 019

Code 19: Always Y

Code 20: Cleanable Filter T = ThrowawayC = Cleanable FilterY = None

Code 21: Outside Air DamperD= Manual Damper ControlM= Motorized Control

Code 22: KeylockY, A = StandardK = Keylock access to unit mounted controls

Code 23 - 24: Always YY

Code 25: Finished Back PanelF = Finished back panel when unit is mounted in front of glass

WMH 007C M V L SP H ACC S LLC YY AR PCode 01 02 & 03 04 05 06 07 08 09 10 11 12 - 13 14 15

RFD Y M A C D K YY FCode 16 17 18 19 20 21 22 23 - 24 25


For Mark IV/AC Control Units Description Thermostat Subbase Standard Manual Changeover Thermostat & Subbase. Honeywell T834C with no LED. Mounts vertically. 073319501 N/A System "Heat-Off-Cool" switch and fan "On-Auto" switch. (includes subbase) Standard Automatic Changeover Thermostat & Subbase. Honeywell T874/Q674. LED for "Service." Mounts horizontal. 073319001 073319701 System "Off-Auto" switch and fan "On-Auto" switch. Standard Manual & Auto. Changeover Thermostat & Subbase. Honeywell T874/Q674. LED for "Service." Mounts horizontal. 073319001 073319801 System "Off-Heat-Auto-Cool" switch and fan "On-Auto" switch. Deluxe Auto. Changeover T-stat & Subbase w/ Night Setback. Honeywell T874/Q674. LED for "Service." Mounts horizontal. Requires grounding of unit "U" terminal. 073318801 073320001 Night setback bulb set 12o F below day heating setpoint. System "Off-Auto" switch and fan "On-Auto" switch. Standard Auto. Changeover Thermostat & Subbase- For Operating Two Units. Honeywell T874/Q674. LED for "Service." Mounts horizontal. 073319101 073319601 System "Off-Auto". Programmable Electronic Thermostat & Subbase. 067114201 N/A Honeywell Chronotherm III (1 Stage Heat, 1 Stage Cool). N/A= Not Applicable.

Thermostat Accessories Description Part Number Universal Thermostat Guard- Honeywell TG512A. 066406601 Clear plastic with ring base, lock and keys. Programmable Thermostat Guard- Honeywell TG511A. 066406702 Clear plastic with ring base, lock and keys. Deluxe Locking Cover for T874/Q674 Thermostats.- Honeywell TG504A. Applies only to T874/Q674 stats. Replaces standard cover. Includes cover, lock & keys. 0733185011

Clear plastic with ring base, lock and keys. Adapter Plate for T874/Q674 Thermostats. 073319301 Allows for horizontal thermostat to be mounted on a vertical junction box. 7- Day Time Clock (not available for 50 cycle power). Includes spring carryover. 802005716 Override Timer- 1 Hour 802005717 Override Timer- 6 Hour 802005718 Locking Control Access Cover 0551452011 Do not use with Deluxe ACO Thermostat with override and Subbase 073318801, 073318901, 073320001.

Field Installed Accessories



Description Unit Size Specification Part No. Auxiliary Relay. 24 volt DC relay. All 803005073 Contact rating is 3 amp at 24 volts. Multiple Unit Control Panel.2 Allows master unit to be controlled by any t-stat. All Master + 1 Slave 803005159 Slave units "follow" C09 must = RMC. Subbase Kit- Unit Sizes 07- 12. 007- 012 High Sill/ Left Hand 061472601 For "Chassis-only" applications in custom 007- 012 High Sill/Right Hand 061472602 enclosures. Subbase supports the chassis 007- 012 Low Sill/ Left Hand 061472605 and permits entrance of return air on 007- 012 Low Sill/Right Hand 061472606 High Sill units. 015, 019 High Sill/ Left Hand 061472603 015, 019 High Sill/Right Hand 061472604 015, 019 Low Sill/ Left Hand 061472607 015, 019 Low Sill/Right Hand 061472608 Sill Grille and Duct Adapter Kit. 007- 012 Right Hand 055482001 C07 must be DC. 007- 012 Left Hand 055482002 Grille is 5" X 5" 015, 019 Right Hand 055482003 Modular Type 015, 019 Left Hand 055482004 Manual Fresh Air Damper Kit. All 0622416012 Components listed below.

Unit Accessories

Description Specification Part No. 1/2" MPT, 4- 10 GPM 061433102 3/4" MPT, 10- 20 GPM 061433103 1" MPT, 19- 32 GPM 061433104 1-1/4" MPT, 28- 48 GPM 061433105 1-1/2" MPT, 45- 70 GPM 061433106 Small Frame- Vertical 2" MPT, 65- 108 GPM 061433107 2-1/2" MPT, 95- 155 GPM 061433108 3" MPT, 148- 290 GPM 061433109 Mounting Bracket- 1/2" & 3/4" 802025658 Mounting Bracket- 1" & 1-1/2" 802025516 Mounting Bracket- 2" & 2-1/2" 802025517 4" Flanged, 275- 550 GPM 061433301 Large Frame- 22.5 Degree Low Profile 6" Flanged, 480- 880 GPM 061433302 6" Flanged, 720- 1200 GPM 061433303 8" Flanged, 1000- 1670 GPM 061433304 4" Flanged, 275- 550 GPM 061433201 Large Frame- Vertical 6" Flanged, 480- 880 GPM 061433202 6" Flanged, 720- 1200 GPM 061433203 8" Flanged, 1000- 1670 GPM 061433204 Manual Purge Valve- 3/4" Plastic 802025515 Manual Purge Valve- 3/4" Bronze 802026098 Manual Purge Valve- 1" Bronze 802026109 System Saver Purge Items Man. Purge Valve- 1-1/4" Bronze 802026109 Bag Strainer Kit 802025518 Replacement Bags (4) 802025519

System Savers & Accessories



Ref. Description Part Qty. No. Number 310 Cover- Control Box 106436101 1 311 Circuit Board 056794001 1 312 Stand Off- Circuit Board 802028090 6 313 Box 850007827 1

Multiple Unit Control Panel Components

310311

313

312

Description Unit Size Specification Part No. Throwaway Filter 007- 012 High Sill 061302501 007- 012 Low Sill 061302503 015, 019 High Sill 061302502 015, 019 Low Sill 061302504 Cleanable Filter 007- 012 High Sill 061364401 007- 012 Low Sill 061364403 015, 019 High Sill 061364402 015, 019 Low Sill 061364404

Filters

Hoses and Valves Description Specification Part No. Fire- Rated Rubber Supply/Return Hoses . Steel Braided 9" long, 1/2" I.D. 061269011 hose with one MPT and one MPT swivel fitting. 2 per unit. 12" long, 1/2" I.D. 061269007 18" long, 1/2" I.D. 061269008 Water Regulating Valve. Includes Refrigerant Service Tap. 1/2" NPT 802026158 3/4" NPT 802026162 Ball Valve. Combination shutoff and balancing valve with 1/2" FPT 802026097 memory stop. 2 per unit.


Refrigeration CircuitCompressor

Diagrams

Control Box

105

102

131

110

110

131

101

131

125


007 009 012 Ref Description Specification Part No. Number 101 Compressor- Panasonic 3 115/60/1 2R10S3R126A-6A 066531901 1 115/60/1 2P14S3R126B-1A 067281203 1 115/60/1 2P17S3R126B-1A 067281303 1 208/230/60/1 2R10S3R236A-6A 066531902 1 1 208/230/60/1 2P14S3R236A-1A 067281202 1 1 208/230/60/1 2P17S3R236A-1A 067281302 1 1 265/60/1 2R10S3R276A-6A 066531903 1 265/60/1 2P14S3R276A-1A 067281201 1 265/60/1 2P17S3R276A-1A 067281301 1 Compressor- Tecumseh 115/60/1 RK124AT-001 061086003 1 115/60/1 RK147AT-002 060907804 1 208/230/60/1 RK124ET-001 061086002 1 1 208/230/60/1 RK147ET-002 060907801 1 1 265/60/1 RK124JB-001 061086001 1 265/60/1 RK147JB-002 060907802 1 102 Capacitor- Panasonic Compressor 35MFD 370V 802007849 1 15MFD 370V 802007844 1 1 15MFD 440V 802007852 1 40MFD 370V 802007850 1 30MFD 370V 802007848 1 1 1 1 25MFD 370V 067291512 1 1 45MFD 370V 802007967 1 Capacitor- Tecumseh Compressor 25MFD 370V 067291512 1 1 1 1 1 1 1 25MFD 440V 802007855 1 105 Bracket- Capacitor 850010570 1 1 1 1 1 1 1 1 1 1 1 1 110 Locknut- Mounting Panasonic Compressors 032333302 3 3 3 3 3 3 3 3 3 3 3 3 Locknut- Mounting Tecumseh Compressors 802012035 3 3 3 3 3 3 3 3 125 Overload- Panasonic Compressor 115/60/1 066536701 1 115/60/1 057479601 1 115/60/1 057479401 1 208/230/60/1 066536801 1 1 208/230/60/1 067299501 1 1 208/230/60/1 057479501 1 1 265/60/1 066536901 1 265/60/1 067282701 1 265/60/1 067282801 1

131 Mounting Sleeve Panasonic Compressors 067281401 3 3 3 3 3 3 3 3 3 3 3 3 Mounting Sleeve Tecumseh Compressor 060623403 3 3 3 3 3 3 3 3 N/S Grommet- Compressor 060623301 3 3 3 3 3 3 3 3 3 3 3 3N/S= Not shown on diagram.3 Panasonic Compressor components: Gasket p/n 066536601; Nut p/n 066536501; Spring p/n 066536301; Gasket p/n 066537001; Terminal Cover p/n 067280501.

115/

60/1

208/

60/1

230/

60/1

265/

60/1

115/

60/1

208/

60/1

230/

60/1

265/

60/1

115/

60/1

208/

60/1

230/

60/1

265/

60/1

Refrigeration CircuitCompressor Unit Sizes 007 - 012

Components


015 019 Ref Description Specification Part No. Number 101 Compressor- Panasonic 3 208/230/60/1 2K25S3R236A-7A 067291402 1 1 265/60/1 2K25S3R276A-6A 067291401 1 Compressor- Tecumseh 208/230/60/1 RK222ET-009 061043401 1 1 208/230/60/1 RK233ET-009 066540301 1 1 265/60/1 RK222JB-009 061043402 1 265/60/1 RK233JB-009 066540302 1

102 Capacitor- Panasonic Compressor 35MFD 440V 067291515 1 1 1 Capacitor- Tecumseh Compressor 25MFD 370V 067291512 1 1 25MFD 440V 802007855 1 1 1 1

105 Bracket- Capacitor 850010570 1 1 1 1 1 1

110 Locknut- Mounting Panasonic Compressors 032333302 3 3 3 Locknut- Mounting Tecumseh Compressors 802012035 3 3 3 3 3 3

125 Overload- Panasonic Compressor 208/230/60/1 057458801 1 1 265/60/1 067293301 1

131 Mounting Sleeve Panasonic Compressors 067281401 3 3 3 Mounting Sleeve Tecumseh Compressor 060623403 3 3 3 3 3 3

N/S Grommet- Compressor 060623301 3 3 3 3 3 3N/S= Not shown on diagram.3 Panasonic Compressor components: Gasket p/n 066536601; Nut p/n 066536501; Spring p/n 066536301; Gasket p/n 066537001; Terminal Cover p/n 067280501.

208/

60/1

230/

60/1

265/

60/1

208/

60/1

230/

60/1

265/

60/1

Refrigeration CircuitCompressor Unit Sizes 015, 019

Components


Refrigeration CircuitEvaporator, Switches, Drain Pans, Plugs & Valves

Components Description Part 007 009 012 015 019 Number Evaporator Coil 056912202 1 Evaporator Coil 056912102 1 Evaporator Coil 056913503 1 Evaporator Coil 056912901 1 Evaporator Coil 056914101 1

Evaporator Coil Baffle 061397801 1 Evaporator Coil Baffle 061397803 1 1 Evaporator Coil Baffle 061397802 1 1

Strap- Evap. Coil (L.H. Units [C06=L] only) 056318801 1 1 1 Extension- Evaporator Header Plate 062578801 1 1

Drain Pan- Evaporator 056374501 1 Drain Pan- Evaporator 056374502 1 1 Drain Pan- Evaporator 056374503 1 1

Reversing Valve- C04= C, M 066533701 1 1 1 Reversing Valve- C04= C, M or L 6 066807701 1 1 Reversing Valve- C04= C or M 066533701 1 Reversing Valve- C04= L 067284101 1 Reversing Valve 7 066533601 1 1 Reversing Valve Solenoid- C04= C or M 062298701 4 1 1 Reversing Valve Solenoid- C04= C, M 066541901 1 1 1 Reversing Valve Solenoid- C04= L 062298702 5 1 1 Reversing Valve Solenoid- C04= L 067010001 1 1 1 Strainer 060628802 2 Strainer 060628808 2 Strainer 060628806 3 Capillary- Panasonic Compressor 067290602 1 Capillary- Panasonic Compressor 067290601 1 Capillary- Panasonic Compressor 060634706 1 Capillary- Panasonic Compressor 060634714 3 Capillary- Tecumseh Compressor 067290601 1 Capillary- Tecumseh Compressor 060634739 2 2 Capillary- Tecumseh Compressor 802001059 3 Freezestat w/bulb 066540601 1 1 1 1 1 Fusible Plug 106057401 1 1 1 1 1 H.P. Switch 802005813 1 1 1 1 1 Refrigerant Valve Assembly Units w/ Water Reg. Valve (C18=W) 802026161 3 3 3 3 3 Units w/o Water Reg. Valve (C18=Y) 802026161 2 2 2 2 2 Discharge Line Weight 060746901 1 1 Discharge Line Weight 067009101 1 1 1 Discharge Line Weight Clip 067009001 1 1 1 1 1 Condensate Drain Tube 061347201 1 1 1 1 14 Solenoid Assembly consists of Solenoid pn: 066807801 and (2) Terminal pin pn: 034247401.5 Solenoid Assembly consists of Solenoid pn: 066807802 and (2) Terminal pin pn: 034247401. 6 Use Solenoid pn: 062298701.7 Used on some early models. Replace with 066807701. Piping changes required.


Refrigeration CircuitCondenser Coil and Tubing

Ref. Description Specification Part 007 009 012 015 019 No. Number 171 Condenser Copper Inner Tube 073394401 1 Condenser Copper Inner Tube 073394501 1 Condenser Copper Inner Tube 073394601 1 Condenser Copper Inner Tube 073380301 1 1

172 Tube- Inlet: LH Unit C06= L 061417801 1 1 1 Tube- Inlet: LH Unit C06= L 061418201 1 1 Tube- Inlet: RH Unit C06= R 061418001 1 1 1 Tube- Inlet: RH Unit C06= R 061418401 1 1

173 Tube- Outlet: LH Unit C06= L 061417701 1 1 1 Tube- Outlet: LH Unit C06= R 061417901 1 1 1 Tube- Outlet: RH Unit C06= L 061418101 1 1 Tube- Outlet: RH Unit C06= R 061418301 1 1

174 Tube Coupling 041116508 2 2 2 176 Tube- 90 Degree 8 061435301 2 2 2 2 2

227 Tube- Condenser to Strainer 056353101 1 Tube- Condenser to Strainer 056373001 1 Tube- Condenser to Strainer 056387201 1

Left-hand Configuration

Right-hand Configuration

171

174

174

227

173 176

172

171

176

174

174 173172

227

8 Not used after 1/99.


Ref. Description Specification Part Code 6 = No. Number L R 511 Water Regulating Valve 1/2" 802026197 1 1 512 Adapter 041116114 1 1 514 Split Bushing 061377301 1 1 521 Elbow Fitting 041117104 1 1

Note: No longer offered as a factory installed option. Field installed only. See Field Installed Accessories page for part number(s) for adding to a unit.

514

512

521

511

Regulating ValveDual Acting Water Regulating Valve


9 Valves offered as standard when C18= M were normally open. Normally closed valves were available. The part numbers were as follows: 115V= 802026062; 208/230V= 061381001; 265V= 802026066.

Ref. Description Specification Part 115V 208V 230V 265V No. Number 511 Water Regulating Valve Ass'y N.O.9 802026063 1 Water Regulating Valve Ass'y N.O.9 802026061 1 1 Water Regulating Valve Ass'y N.O.9 802026067 1 515 Tube- Extension 061340302 1 1 1 1 517 Conduit 022003814 1 1 1 1 521 Elbow 041117104 1 1 1 1 524 Tube- Water 061340305 1 1 1 1 525 Adapter 041116213 1 1 1 1 526 Relay 120V 061019404 1 Relay 120V 061019401 1 1 Relay 120V 061019402 1

526517

521

515

511

524

525

Note: No longer offered as of November, 1996.

Regulating ValveMotorized Water Regulating Valve


007 009 012 Ref Description Specification Part No. Number N/S Motor 115/60/1 073388001 1 1 Motor 115/60/1 073384101 1 Motor 208/230/60/1 073388002 1 1 1 1 Motor 208/230/60/1 073384102 1 1 Motor 265/60/1 073388003 1 1 Motor 265/60/1 073384103 1

N/S Capacitor- Motor 4MFD 370V 067291502 1 1 Capacitor- Motor 2MFD 370V 802007008 1 1 1 1 1 1 1 1 1 Capacitor- Motor 5MFD 370V 067291503 1

N/S Plug- Motor 2 Ckt. Plug 038254701 1 1 1 1 Plug- Motor 6 Ckt. Housing 047934203 1 1 1 1 1 1 1 1 1 1 1 1 Plug- Motor 6 Ckt. Receptacle 047934204 1 1 1

N/S Fan Scroll 062550901 1 1 1 1 1 1 1 1 1 1 1 1 N/S Support- Fan Housing 056354301 1 1 1 1 1 1 1 1 1 1 1 1 N/S Mount- Motor 056354202 1 1 1 1 1 1 1 1 1 1 1 1 N/S Clip- Motor Mount 060900501 2 2 2 2 2 2 2 2 2 2 2 2 N/S Inlet Ring 062551001 1 1 1 1 1 1 1 1 1 1 1 1 Inlet Ring 062551101 1 1 1 1 1 1 1 1 1 1 1 1

N/S Fan Wheel 073383801 1 1 1 1 1 1 1 1 1 1 1 1

N/S Bracket- Capacitor 850010570 1 1 1 1 1 1 1 1 Boot- Capacitor 067291602 1 1 1 1N/S= Not shown on diagram.

115/

60/1

208/

60/1

230/

60/1

265/

60/1

115/

60/1

208/

60/1

230/

60/1

265/

60/1

115/

60/1

208/

60/1

230/

60/1

265/

60/1

Fan and Housing AssemblyUnit Sizes 007 - 012

Components


015 019 Ref Description Specification Part No. Number N/S Motor 067782202 1 1 1 1 Motor 067782203 1 1

N/S Capacitor- Motor 4MFD 370V 067291502 1 1 1 1 Capacitor- Motor 3MFD 370V 067291501 1 1 N/S Plug- Motor 2 Ckt. Plug 038254701 1 1 1 1 1 1 Plug- Motor 6 Ckt. Plug Housing 047934203 1 1 1 1 1 1 Plug- Motor 6 Ckt. Receptacle 047934204 1 1

N/S Fan Assembly 10 061389101 2 2 2 2 2 2 Housing- Discharge 11 022930900 2 2 2 2 2 2 Housing- Access 11 022931000 2 2 2 2 2 2 Hub Clamp 11 066534601 2 2 2 2 2 2 N/S Support- Motor 056312801 1 1 1 1 1 1 N/S Bracket- Capacitor 802009019 1 1 1 1 1 1

N/S Clip- Motor Mount 060900501 2 2 2 2 2 2N/S= Not shown on diagram.10 Includes housings, clamp, wheel, etc.11 Included in fan assembly 061389101.

208/

60/1

230/

60/1

265/

60/1

208/

60/1

230/

60/1

265/

60/1

Fan and Housing AssemblyUnit Sizes 015, 019

Components


Control BoxMicroTech 520

Diagrams

Transformer Detail

376

387

362 391

375

385

441442

373

367

369

370

416

429

226

435

377 226

227

227450


Control BoxMicroTech 520Components

Ref. Description Specification Part 115V 208V 230V 265V No. Number 226 Transformer 115V Units 060630801 1 208/230V Units 060614101 1 1 265V Units 060630701 1

227 Terminal- Quick Connect 803007156 3 3 3 3

362 Top Panel Flat Top Units 056919689 1 1 1 1 Top Panel Slope Top Units 056919789 1 1 1 1

367 End Panel- Flat Top Standard Enclosure C10= Y 061353399 1 1 1 1 Extra Quiet C10= S 056363401 1 1 1 1 End Panel- Slope Top Standard Enclosure C10= Y 061304099 1 1 1 1 Extra Quiet C10= S 056363402 1 1 1 1

369 Snap in Bushing 049751907 1 1 1 1

370 Terminal Board 802007090 1 1 1 1

373 Potentiometer 062596401 1 1 1 1

375 Rocker Switch 061321501 1 1 1 1

376 Knob 066544601 1 1 1 1

377 MicroTech 520 Control 073312502 1 1 1 1

385 Switch- 2 Button 061348801 1 1 1 1

387 Overlay- Control Plate C09= MTS/C11= YYY 061381601 1 1 1 1 C09= MTS/C11= MTR 061381801 1 1 1 1 C09= MRT/C11= YYY 061381901 1 1 1 1

391 Switch- Momentary N.O. 061377201 1 1 1 1

416 Relay- Auto Damper Units C21= M 802005209 1 1 1 1

429 Control Box Bottom Standard Enclosure C10= Y 061300299 1 1 1 1 Extra Quiet Enclosure C10= S 056372801 1 1 1 1

435 Split Bushing 061377301 1 1 1 1

441 Terminal Block 4 Terminals 065499804 1 1 1 1


Ref. Description Specification Part 115V 208V 230V 265V No. Number 442 Resistor- 1000 OHM 044690110 1 1 1 1

450 Relay 24V 047356506 1 1 1 1

N/S MicroTech Relay C14= M/ 24V 061019403 1 1 1 1

N/S Air Sensor 073305601 2 2 2 2

N/S Water Sensor 073305701 1 1 1 1

N/S Conduit Connection C15= C Conduit 061450218 1 1 1 1 90 Deg. Fitting 061377601 2 2 2 2 Fitting 047356402 2 2 2 2

N/S Receptacle 15 ckt. 034621900 1 1 1 1

N/S Plug 15 ckt. 034622000 1 1 1 1

N/S Receptacle for Sensors Air or Water 4EGA9159 3 3 3 3

N/S Suppressor PC Board 056799701 1 1 1 1

N/S Suppressor Ass'y- Damper C21=M 061073401 1 1 1 1 Suppressor Only- Damper 803007214 1 1 1 1 Diode Only- Damper 803007215 1 1 1 1

N/S Junction Box Connection C15= Y Junction Box 802007362 1 1 1 1 Junction Box Cover 000969300 1 1 1 1

N/S Cord Set C15= P 115V Units 062218107 1 208/230V Units- L.H. C06= L 062218101 1 1 208/230V Units- R.H. C06= R 061254701 1 1 265V Units- L.H. C06= L 062218103 1 265V Units- R.H. C06= R 062218104 1

N/S Terminal Block Low Voltage 073315201 1 1 1 1 N/S Terminal Block ELUPC 061365602 1 1 1 1

N/S Receptacle 15 ckt. 034621900 1 1 1 1 N/S Plug 15 ckt. 034622000 1 1 1 1N/S= Not shown on diagram.

Control BoxMicroTech 520

Components, Continued


Control BoxMicroTech Unit Control

Diagrams

Transformer Detail

226

227

227

376

387

362 391

375

385

441442

373

367

369

370424429

226

435

377

450

416

265

444

420

421

Ref# 387 Overlay Detail

061381601 061381801 061381901



Components

N/S= Not Shown on Diagram.12 Not used after 11/98.

Ref. Description Specification Part 115V 208V 230V 265V No. Number 226 Transformer 115V Units 060630801 1 Transformer 208/230V Units 060967020 1 1 Transformer 265V Units 060630701 1

227 Terminal- Quick Connect 060973601 1 1 1 1

265 Transformer 24V- 9V 060949301 1 1 1 1

N/S Circuit Breaker- Transformer 12 803007113 1 1 1 1 362 Top Panel Flat Top Units 056919689 1 1 1 1 Top Panel Slope Top Units 056919789 1 1 1 1

367 End Panel- Flat Top Std. Encl C10= Y 061353399 1 1 1 1 Ext. Quiet C10= S 056363401 1 1 1 1 End Panel- Slope Top Std. Encl C10= Y 061304099 1 1 1 1 Ext. Quiet C10= S 056363402 1 1 1 1

369 Snap in Bushing 023251700 1 1 1 1

370 Terminal Board 802007090 1 1 1 1

373 Potentiometer 062596401 1 1 1 1

375 Rocker Switch 061321501 1 1 1 1

376 Knob 066544601 1 1 1 1

377 MicroTech Unit Control (C04=C) 060959401 1 1 1 1

385 Switch 2 Button 061348801 1 1 1 1

387 Overlay- Control Plate C09= MTS/C11= YYY 061381601 1 1 1 1 C09= MTS/C11= MTR 061381801 1 1 1 1 C09= MRT/C11= YYY 061381901 1 1 1 1

391 Switch- Momentary N.O. 061377201 1 1 1 1

416 Relay- Auto Damper Units C21= M 802005209 1 1 1 1

420 Heater Relay 24V 2PDT 066803901 1 1 1 1




Components, Continued

Ref. Description Specification Part 115V 208V 230V 265V No. Number 424 Heater Relay 24V 1PDT 802005819 1 1 1 1

429 Control Box Bottom Standard Enclosure C10=Y 061300299 1 1 1 1 Extra Quiet Enclosure C10= S 056372801 1 1 1 1

435 Split Bushing 061377301 1 1 1 1

441 Terminal Block 4 Terminals 065499804 1 1 1 1

442 Resistor 1000 OHM 044690110 1 1 1 1

444 Terminal Block Housing 060949401 1 1 1 1

450 Relay 24V 047356506 1 1 1 1

N/S MicroTech Relay C14= M/ 24V 061019403 1 1 1 1

N/S Air Sensor 4EZS9158 2 2 2 2 N/S Water Sensor 4EZS9158 1 1 1 1

N/S Suppressor Ass'y- Damper C21=M 061073401 1 1 1 1 Suppressor Only- Damper 803007214 1 1 1 1 Diode Only- Damper 803007215 1 1 1 1

N/S Junction Box 802007362 1 1 1 1 Junction Box Cover 000969300 1 1 1 1

N/S Cord Set C15= P 115V Units 062218107 1 208/230V Units- L.H. C06= L 062218101 1 1 208/230V Units- R.H. C06= R 061254701 1 1 265V Units- L.H. C06= L 062218103 1 265V Units- R.H. C06= R 062218104 1

N/S Conduit Connection C15= C Conduit 061450218 1 1 1 1 90 Deg. Fitting 061377601 2 2 2 2 Fitting 047356402 2 2 2 2

N/S Receptacle 15 ckt. 034621900 1 1 1 1 N/S Plug 15 ckt. 034622000 1 1 1 1

N/S PC Board terminal block 3 Ckt. 049759001 1 1 1 1 N/S PC Board terminal block 4 Ckt. 049759002 1 1 1 1 N/S PC Board terminal block 5 Ckt. 049759003 1 1 1 1 N/S PC Board terminal block 25 Ckt. 060949401 1 1 1 1N/S= Not Shown on Diagram.


Control BoxMark IV Control

Diagrams

376 375 387391

366

373

385 398

401

399

403

367

430

432

426

389390

423

435

424

377

429 378

264

420421

369

370

362

435 415396

Ref# 387 Overlay Detail

061381601 061381801 061381901061381701061356901


Ref. Description Specification Part 115V 208V 230V 265V No. Number 264 Transformer 115V 060630801 1 Transformer 208/230V 060614101 1 1 Transformer 265V 060630701 1 N/S Circuit Breaker- Transformer 12 803007113 1 1 1 1

362 Top Panel- Flat Top until 5/99 061397089 1 1 1 1 Top Panel- Flat Top 5/99 and later 106056701 1 1 1 1 Top Panel- Slope Top until 5/99 061314789 1 1 1 1 Top Panel- Slope Top 5/99 and later 106056801 1 1 1 1

366 Plate- Thermostat until 5/99 061314601 1 1 1 1 Bracket, Thermostat 5/99 and later 106056401 1 1 1 1

367 End Panel- Flat Top Standard C10= Y 061353399 1 1 1 1 Extra Quiet C10= S 056363401 1 1 1 1 End Panel- Slope Top Standard C10= Y 061304099 1 1 1 1 Extra Quiet C10= S 056363402 1 1 1 1

369 Snap In Bushing 023251700 1 1 1 1 370 Terminal Board 802007090 1 1 1 1

373 Temp. Control straps on tube Auto Changeover Units 066540802 1 1 1 1 Manual Changeover Units 062278701 1 1 1 1

375 Rocker Switch 061321501 1 1 1 1 376 Knob 061334001 1 1 1 1

377 Mark IV Board (C04=M) 056792401 1 1 1 1 378 Stand Off 7/17" 802028115 5 5 5 5

385 Switch- 2 Button C11= A** or RMC 061348801 1 1 1 1 Switch- 4 Button C11= M** 061317701 1 1 1 1

387 Overlay- Control Plate C09=A**, MTS/ C11= LLC, YYY 061381601 1 1 1 1 C09=A**/ C11= NWR 061381801 1 1 1 1 C09=M**/ C11= NWR 061381701 1 1 1 1 C09=M**/ C11= NSB/LLC,YYY 061356901 1 1 1 1 A**, ACC, ACF 061356901 1 1 1 1 M**, MCC, MCF 061356901 1 1 1 1 RMC, MRT 061381901 1 1 1 1 389 Low Temp. Control- Night Control 061400701 1 1 1 1 390 Screw 048448102 2 2 2 2 391 Switch, Momentary C11= NWR 061377201 1 1 1 1 396 Circuit Board C14= A 803005073 1 1 1 1


Components

N/S= Not Shown on Diagram.12 Not used after 11/98.



Components, Continued Ref. Description Specification Part 115V 208V 230V 265V No. Number 398 Junction Box 802007362 1 1 1 1 399 Junction Box Cover 000127300 1 1 1 1

401 Snap In Bushing 023251700 1 1 1 1 403 Cup Washer 4WEA6586 1 1 1 1

415 Insulation C14= A 061343301 1 1 1 1



423 Bracket- Night Setback C11= N** 061397701 1 1 1 1


426 Receptacle 15 Circuits 034621900 1 1 1 1

429 Bottom Panel Standard C10= Y 061300299 1 1 1 1 Extra Quiet C10= S 056372801 1 1 1 1

430 Rocker Switch SPDT 047357307 1 1 1 1

432 Terminal Block 061365602 1 1 1 1 435 Bushing 061377301 1 1 1 1

N/S Low Temperature- Electric Heat SPDT 061350201 1 1 1 1

N/S Conduit Connection C15= C Conduit 061450218 1 1 1 1 90 Degree Fitting 061377601 2 2 2 2 Fitting 047356402 2 2 2 2

N/S Cord Set Connection C15= P 115V 062218107 1 1 1 1 208/230V- L.H. C06= L 062218101 1 1 1 1 208/230V- R.H. C06= R 061254701 1 1 1 1 265V- L.H. C06= L 062218103 1 1 1 1 265V- R.H. C06= R 062218104 1 1 1 1

N/S Circuit Breaker Mark IV 803007113 1 1 1 1

N/S Receptacle 15 ckt. 034621900 1 1 1 1

N/S Plug 15 ckt. 034622000 1 1 1 1N/S= Not Shown on Diagram.


Control BoxDisconnect Box

Ref. Description Specification Part C16= C16= C16= C16= C16= No. Number RFD RFY RYY BDF BDY 691 Disconnect Box 061360901 1 1 1 1 1 692 Bracket 061361201 1 1 1 1 1 693 Cover 061361101 1 1 1 1 1 694 Panel 061361001 1 1 1 1 1 698 Fuse Holder 15A Fuse 13 802007553 * * N/A * N/A Fuse Holder 20A Fuse 13 802007660 * * N/A * N/A 699 Fuse 15A 14 049128306 * * N/A * N/A Fuse 20A 14 049128307 * * N/A * N/A 700 Receptacle 047139805 1 1 1 N/A N/A 702 Switch 061350601 1 N/A N/A 1 N/AN/A= Not Applicable.13 All Units use 15A fuses EXCEPT 208V w/ 3KW Heaters (C19=D), or 265V units w/3KW Heaters (C19= C).14 Unit voltage determines quantity. 115V quantity= 1; 265V quantity= 1; 208/230V quantity= 2.

692 691700

694698

699

702693


Electric Heat Diagram & Components (C19 = A, B, C, or D)

To Control

Box

Ref. Description Specification Part 115V 208V 230V 265V No. Number 345 Heater 1.0 KW/ 265V 16 C19= A 061409701 17 1 1 1 2.0 KW/ 265V 16 C19= B 061409702 17 1 1 1 3.0 KW/ 265V 16 C19= C 061409703 17 1 1 1 346 Limit Switch 1.0 KW Heater C19= A 061402904 17 1 1 1 2.0 KW Heater C19= B 061402903 17 1 1 1 3.0 KW Heater C19= C 061402903 17 1 1 3.0 KW Heater C19= C 061402901 17 1 347 Screw 048440104 17 3 3 3 350 Bushing15 034248200 17 1 1 1

Components- Single Element- Unit Sizes 007, 009, 012

15 Bushing not used on units built after Dec. 15, 199716 Heater Voltage.17 Electric Heat is not available on 115V units.

Ref. Description Specification Part 208V 230V 265V No. Number 345 Heater 2.0 KW 265V 16 C19= B 061409802 1 1 1 3.0 KW 265V 16 C19= C 061409803 1 1 1 3.0 KW 208V 16 C19= D 061409804 1 1 1 346 Limit Switch 061402903 1 1 1 347 Screw 048440104 4 4 4 350 Bushing15 034248200 1 1 1

Components- Dual Element- Unit Sizes 015, 019

15 Bushing not used on units built after Dec. 15, 1997.16 Heater Voltage.

345346

347 350


Outside Air DamperManual Damper (C21 = D)

Ref. Description Part Qty. No. Number 803 Damper Box 061453189 1 805 Actuator 061450602 1 808 Damper Door 061442999 1 N/S Gasketing 107942501 2 N/S Gasketing 107942502 2

808

803

805

NOTE: All part numbers listed in italics are NOT set up WDSII (not orderable). Please contact Daikin.


Outside Air DamperMotorized Damper (C21 = M)

808

N/S= Not Shown on Diagram.NOTE: All part numbers listed in italics are NOT set up WDSII (not orderable). Please contact Daikin.

Ref. Description Specification Part 115V 208V 230V 265V No. Number 803 Damper Box 061453189 1 1 1 1 806 Wire Box 061443002 1 1 1 1 808 Damper Door 061442999 1 1 1 1 810 Damper Motor 115V Units 850003963 1 Damper Motor 208/230V Units 850003962 1 1 Damper Motor 265V Units 850003960 1 813 Operating Arm 062968001 1 1 1 1 814 Spring Hook 850006704 1 1 1 1 817 Spring- Extension 802017209 1 1 1 1 822 Bushing 045689300 1 1 1 1 825 Toggle Switch 802005045 1 1 1 1 829 Door Link 802023021 1 1 1 1 N/S Receptacle WMH Units only 038254801 1 1 1 1 N/S Plug WMH Units only 038254701 1 1 1 1 N/S Gasketing 107942501 2 2 2 2 N/S Gasketing 107942502 2 2 2 2

829

817

814

813

810803

806 822

825


Flat Top Cabinet Diagram & Components

(C01= WMH or WMK only) (C07= FS, FM, or FB)

Ref. Description Part Qty. No. Number 601 Front Panel 061327599 1 602 Left End Panel 061327990 1 603 Right End Panel 061328090 1 604 Tie Piece 061328199 1 651 Grille 062290989 6 652 Door Frame 061301402 1 653 Door- Locking 061352802 1 661 Lock w/Key 061334501 1 666 Grille Filler 061457002 1 N/S Grille Frame 061456802 1 N/S Retainer Strip 061464201 1 N/S Insulation 061398501 2

Unit Sizes- 007, 009, 012Flat Top/Modular Grille, High Sill 25", Locking Door, Std. Enclosure

C07= FM C08= H C22= K C10= A

653

652

603

601

651

604

666

602

Door oriented for left hand piping

unit.

Door oriented for right hand piping

unit.

N/S= Not Shown on Diagram.

661


Flat Top CabinetComponents, Continued



Unit Sizes- 007, 009, 012Flat Top/Modular Grille, High Sill 25", Locking Door, XQ Enclosure

C07= FM C08= H C22= K C10= S

Ref. Description Part Qty. No. Number 601 Front Panel 061327599 1 602 Left End Panel 061327990 1 603 Right End Panel 061328090 1 604 Tie Piece 061328199 1 651 Grille 062290989 6 652 Door Frame 061301402 1 653 Door 061301302 1 666 Grille Filler 061457002 1 N/S Grille Frame 061456802 1 N/S Retainer Strip 061464201 1 N/S Insulation 061398501 2

Unit Sizes- 007, 009, 012Flat Top/Modular Grille, High Sill 25", Std. Door, Std. Enclosure

C07= FM C08= H C22= A C10= A







Unit Sizes- 007, 009, 012Flat Top/Modular Grille, High Sill 25", Std. Door, XQ Enclosure

C07= FM C08= H C22=A C10= S


Unit Sizes- 007, 009, 012Flat Top/Modular Grille, Low Sill 22.5", Locking Door, Std. Enclosure

C07= FM C08= L C22= K C10= A







Unit Sizes- 007, 009, 012Flat Top/Modular Grille, Low Sill 22.5", Locking Door, XQ Enclosure

C07= FM C08= L C22= K C10= S


Unit Sizes- 007, 009, 012Flat Top/Modular Grille, Low Sill 22.5", Std. Door, Std. Enclosure

C07= FM C08= L C22= A C10= A







Unit Sizes- 007, 009, 012Flat Top/Modular Grille, Low Sill 22.5", Std. Door, XQ Enclosure

C07= FM C08= L C22= A C10= S

Ref. Description Part Qty. No. Number 601 Front Panel 061327599 1 602 Left End Panel 061327990 1 603 Right End Panel 061328090 1 604 Tie Piece 061328199 1 651 Grille 061335902 1 652 Door Frame 061301402 1 653 Door- Locking 061352802 1 661 Lock w/Key 061334501 1 N/S Insulation 061398501 2

Unit Sizes- 007, 009, 012Flat Top/Steel Bar Grille, High Sill 25", Locking Door, Std. Enclosure

C07= FB C08= H C22= K C10= A







Unit Sizes- 007, 009, 012Flat Top/Steel Bar Grille, High Sill 25", Locking Door, XQ Enclosure

C07= FB C08= H C22= K C10= S

Ref. Description Part Qty. No. Number 601 Front Panel 061327599 1 602 Left End Panel 061327990 1 603 Right End Panel 061328090 1 604 Tie Piece 061328199 1 651 Grille 061335902 1 652 Door Frame 061301402 1 653 Door 061301302 1 N/S Insulation 061398501 2

Unit Sizes- 007, 009, 012Flat Top/Steel Bar Grill, High Sill 25", Std. Door, Std. Enclosure

C07= FB C08= H C22= A C10= A


Unit Sizes- 007, 009, 012Flat Top/Steel Bar Grill, High Sill 25", Std. Door, XQ Enclosure

C07= FB C08= H C22= A C10= S






Unit Sizes- 007, 009, 012Flat Top/Steel Bar Grille, Low Sill 22.5", Locking Door, Std. Enclosure

C07= FB C08= L C22= K C10= A




Unit Sizes- 007, 009, 012Flat Top/Steel Bar Grille, Low Sill 22.5", Locking Door, XQ Enclosure

C07= FB C08= L C22= K C10= S


Unit Sizes- 007, 009, 012Flat Top/Steel Bar Grill, Low Sill 22.5", Std. Door, Std. Enclosure

C07= FB C08= L C22= A C10= A








Unit Sizes- 007, 009, 012Flat Top/Steel Bar Grill, Low Sill 22.5", Std. Door, XQ Enclosure

C07= FB C08= L C22= A C10= S

Ref. Description Part Qty. No. Number 601 Front Panel 061327599 1 602 Left End Panel 061327990 1 603 Right End Panel 061328090 1 604 Tie Piece 061328199 1 651 Grille 061301102 1 652 Door Frame 061301402 1 653 Door- Locking 061352802 1 661 Lock w/Key 061334501 1 663 Blockoff- L.H. Units Only (C06= L) 061363802 1 N/S Insulation 061398501 2

Unit Sizes- 007, 009, 012Flat Top/Stamped Steel Grille, High Sill 25", Locking Door, Std. Enclosure

C07= FS C08= H C22= K C10= A


Unit Sizes- 007, 009, 012Flat Top/Stamped Steel Grille, High Sill 25", Locking Door, XQ Enclosure

C07= FS C08= H C22= K C10= S







Ref. Description Part Qty. No. Number 601 Front Panel 061327599 1 602 Left End Panel 061327990 1 603 Right End Panel 061328090 1 604 Tie Piece 061328199 1 651 Grille 061301102 1 652 Door Frame 061301402 1 653 Door 061301302 1 663 Blockoff- L.H. Units Only (C06= L) 061363802 1 N/S Insulation 061398501 2

Unit Sizes- 007, 009, 012Flat Top/Stamped Steel Grille, High Sill 25", Std. Door, Std. Enclosure

C07= FS C08= H C22= A C10= A


Unit Sizes- 007, 009, 012Flat Top/Stamped Steel Grille, High Sill 25", Std. Door, XQ Enclosure

C07= FS C08= H C22= A C10= S


Unit Sizes- 007, 009, 012Flat Top/Stamped Steel Grille, Low Sill 22.5", Locking Door, Std. Enclosure

C07= FS C08= L C22= K C10= A








Unit Sizes- 007, 009, 012Flat Top/Stamped Steel Grille, Low Sill 22.5", Locking Door, XQ Enclosure

C07= FS C08= L C22= K C10= S


Unit Sizes- 007, 009, 012Flat Top/Stamped Steel Grille, Low Sill 22.5", Std. Door, Std. Enclosure

C07= FS C08= L C22= A C10= A


Unit Sizes- 007, 009, 012Flat Top/Stamped Steel Grille, Low Sill 22.5", Std. Door, XQ Enclosure

C07= FS C08= L C22= A C10= S








Unit Sizes- 015, 019Flat Top/Modular Grille, High Sill 25", Locking Door, Std. Enclosure

C07= FM C08= H C22= K C10= A


Unit Sizes- 015, 019Flat Top/Modular Grille, High Sill 25", Locking Door, XQ Enclosure

C07= FM C08= H C22= K C10= S







Unit Sizes- 015, 019Flat Top/Modular Grille, High Sill 25", Std. Door, Std. Enclosure

C07= FM C08= H C22=A C10= A


Unit Sizes- 015, 019Flat Top/Modular Grille, High Sill 25", Std. Door, XQ Enclosure

C07= FM C08= H C22= A C10= S







Unit Sizes- 015, 019Flat Top/Modular Grille, Low Sill 22.5", Locking Door, Std. Enclosure

C07= FM C08= L C22= K C10= A


Unit Sizes- 015, 019Flat Top/Modular Grille, Low Sill 22.5", Locking Door, XQ Enclosure

C07= FM C08= L C22= K C10= S







Unit Sizes- 015, 019Flat Top/Modular Grille, Low Sill 22.5", Std. Door, Std. Enclosure

C07= FM C08= L C22= A C10= A


Unit Sizes- 015, 019Flat Top/Modular Grille, Low Sill 22.5", Std. Door, XQ Enclosure

C07= FM C08= L C22= A C10= S







Unit Sizes- 015, 019Flat Top/Steel Bar Grille, High Sill 25", Locking Door, Std. Enclosure

C07= FB C08= H C22= K C10= A


Unit Sizes- 015, 019Flat Top/Steel Bar Grille, High Sill 25", Locking Door, XQ Enclosure

C07= FB C08= H C22= K C10= S


Unit Sizes- 015, 019Flat Top/Steel Bar Grille, High Sill 25", Std. Door, Std. Enclosure

C07= FB C08= H C22= A C10= A








Unit Sizes- 015, 019Flat Top/Steel Bar Grille, High Sill 25", Std. Door, XQ Enclosure

C07= FB C08= H C22=A C10= S


Unit Sizes- 015, 019Flat Top/Steel Bar Grille, Low Sill 22.5", Locking Door, Std. Enclosure

C07= FB C08= L C22= K C10= A


Unit Sizes- 015, 019Flat Top/Steel Bar Grille, Low Sill 22.5", Locking Door, XQ Enclosure

C07= FB C08= L C22= K C10= S








Unit Sizes- 015, 019Flat Top/Steel Bar Grille, Low Sill 22.5", Std. Door, Std. Enclosure

C07= FB C08= L C22= A C10= A


Unit Sizes- 015, 019Flat Top/Steel Bar Grille, Low Sill 22.5", Std. Door, XQ Enclosure

C07= FB C08= L C22= A C10= S

Ref. Description Part Qty. No. Number 601 Front Panel 061327699 1 602 Left End Panel 061327990 1 603 Right End Panel 061328090 1 604 Tie Piece 061328299 1 651 Grille 061301202 1 652 Door Frame 061301402 1 653 Door- Locking 061352802 1 661 Lock w/Key 061334501 1 663 Blockoff- L.H. Units only (C06= L) N/S Insulation 061398501 2

Unit Sizes- 015, 019Flat Top/Stamped Steel Grille, High Sill 25", Locking Door, Std. Enclosure

C07= FS C08= H C22= K C10=A








Unit Sizes- 015, 019Flat Top/Stamped Steel Grille, High Sill 25", Locking Door, XQ Enclosure

C07= FS C08= H C22= K C10= S

Ref. Description Part Qty. No. Number 601 Front Panel 061327699 1 602 Left End Panel 061327990 1 603 Right End Panel 061328090 1 604 Tie Piece 061328299 1 651 Grille 061301202 1 652 Door Frame 061301302 1 653 Door 061301302 1 661 Lock w/Key 061334501 1 N/S Insulation 061398501 2

Unit Sizes- 015, 019Flat Top/Stamped Steel Grille, High Sill 25", Locking Door, Std. Enclosure

C07= FS C08= H C22= A C10=A

Ref. Description Part Qty. No. Number 601 Front Panel 061327698 1 602 Left End Panel 061327999 1 603 Right End Panel 061328099 1 604 Tie Piece 061328299 1 651 Grille 061301202 1 652 Door Frame 061301302 1 653 Door 061301302 1 661 Lock w/Key 061334501 1 N/S Insulation 061398501 2

Unit Sizes- 015, 019Flat Top/Stamped Steel Grille, High Sill 25", Locking Door, XQ Enclosure

C07= FS C08= H C22= A C10= S







Ref. Description Part Qty. No. Number 601 Front Panel 061327699 1 602 Left End Panel 061327990 1 603 Right End Panel 061328090 1 604 Tie Piece 061328299 1 651 Grille 061301202 1 652 Door Frame 061301402 1 653 Door 061301302 1 663 Blockoff- L.H. Unit only (C06= L) 061302302 1 N/S Insulation 061398501 2

Unit Sizes- 015, 019Flat Top/Steel Bar Grille, High Sill 25", Std. Door, Std. Enclosure

C07= FB C08= H C22= A C10= A

Ref. Description Part Qty. No. Number 601 Front Panel 061327698 1 602 Left End Panel 061327999 1 603 Right End Panel 061328099 1 604 Tie Piece 061328299 1 651 Grille 061301202 1 652 Door Frame 061301402 1 653 Door 061301302 1 663 Blockoff- L.H. Unit only (C06= L) 061302302 1 N/S Insulation 061398501 2

Unit Sizes- 015, 019Flat Top/Steel Bar Grille, High Sill 25", Std. Door, XQ Enclosure

C07= FB C08= H C22=A C10= S

Ref. Description Part Qty. No. Number 601 Front Panel 061327899 1 602 Left End Panel 061327990 1 603 Right End Panel 061328090 1 604 Tie Piece 061328299 1 651 Grille 061301202 1 652 Door Frame 061301402 1 653 Door- Locking 061352802 1 661 Lock w/Key 061334501 1 663 Blockoff- L.H. Units only (C06= L) 061363802 1 N/S Insulation 061398501 2

Unit Sizes- 015, 019Flat Top/Stamped Steel Grille, Low Sill 22.5", Locking Door, Std. Enclosure

C07= FS C08= L C22= K C10= A







Ref. Description Part Qty. No. Number 601 Front Panel 061327898 1 602 Left End Panel 061327999 1 603 Right End Panel 061328099 1 604 Tie Piece 061328299 1 651 Grille 061301202 1 652 Door Frame 061301402 1 653 Door- Locking 061352802 1 661 Lock w/Key 061334501 1 663 Blockoff- L.H. Units only (C06= L) 061363802 1 N/S Insulation 061398501 2

Unit Sizes- 015, 019Flat Top/Steel Bar Grille, Low Sill 22.5", Locking Door, XQ Enclosure

C07= FB C08= L C22= K C10= S

Ref. Description Part Qty. No. Number 601 Front Panel 061327899 1 602 Left End Panel 061327990 1 603 Right End Panel 061328090 1 604 Tie Piece 061328299 1 651 Grille 061301202 1 652 Door Frame 061301402 1 653 Door 061301302 1 663 Blockoff- L.H. Units only (C06= L) 061363802 1 N/S Insulation 061398501 2

Unit Sizes- 015, 019Flat Top/Stamped Steel Grille, Low Sill 22.5", Std. Door, Std. Enclosure

C07= FS C08= L C22= A C10= A

Ref. Description Part Qty. No. Number 601 Front Panel 061327898 1 602 Left End Panel 061327999 1 603 Right End Panel 061328099 1 604 Tie Piece 061328299 1 651 Grille 061301202 1 652 Door Frame 061301402 1 653 Door 061301302 1 663 Blockoff- L.H. Units only (C06= L) 061363802 1 N/S Insulation 061398501 2

Unit Sizes- 015, 019Flat Top/Stamped Steel Grille, Low Sill 22.5", Std. Door, XQ Enclosure

C07= FS C08= L C22= A C10= S





Ref. Description Part Qty. No. Number 601 Front Panel 061300899 1 602 Left End Panel 061355102 1 603 Right End Panel 061355002 1 604 Tie Piece 061303799 1 651 Grille 061356402 4 652 Door Frame 061356602 1 653 Door 061356702 1 656 End Cap 061356502 1 661 Lock w/Key 802018114 1 663 Blockoff- L.H. Units only (C06= L) 106087201 1 N/S Access Door 055145308 1 N/S Screw 106084501 2 N/S Fastener, Button Head Dart 061461701 12

Slope Top CabinetDiagram & Components

(C01= WMH or WMK only) (C07= SP)

Unit Sizes- 007, 009, 012Slope Top/Plastic Grille, High Sill 25", Locking Door, Std. Enclosure

C07= SP C08= H C22= K C10= A

Door oriented for left hand piping

unit.

Door oriented for right hand piping

unit.

652653 661

603

651

663

602

656

601


604



Unit Sizes- 007, 009, 012Slope Top/Plastic Grille, High Sill 25", Locking Door, XQ Enclosure

C07= SP C08= H C22= K C10= S

Slope Top CabinetComponents, Continued


Ref. Description Part Qty. No. Number 601 Front Panel 061300899 1 602 Left End Panel 061355102 1 603 Right End Panel 061355002 1 604 Tie Piece 061303799 1 651 Grille 061356402 4 652 Door Frame 061356602 1 653 Door 061356702 1 656 End Cap 061356502 1 663 Blockoff- L.H. Units only (C06= L) 106087201 1 N/S Screw 106084501 2 N/S Fastener, Button Head Dart 061461701 12

Unit Sizes- 007, 009, 012Slope Top/Plastic Grille, High Sill 25", Std. Door, Std. Enclosure

C07= SP C08= H C22= A C10= A






Unit Sizes- 007, 009, 012Slope Top/Plastic Grille, High Sill 25", Std. Door, XQ Enclosure

C07= SP C08= H C22= A C10= S



Unit Sizes- 007, 009, 012Slope Top/Plastic Grille, Low Sill 22.5", Locking Door, Std. Enclosure

C07= SP C08= L C22= K C10= A





Unit Sizes- 007, 009, 012Slope Top/Plastic Grille, Low Sill 22.5", Locking Door, XQ Enclosure

C07= SP C08= L C22= K C10= S




Unit Sizes- 007, 009, 012Slope Top/Plastic Grille, Low Sill 22.5", Std. Door, Std. Enclosure

C07= SP C08= L C22= A C10= A





Unit Sizes- 007, 009, 012Slope Top/Plastic Grille, Low Sill 22.5", Std. Door, XQ Enclosure

C07= SP C08= L C22= A C10= S



Ref. Description Part Qty. No. Number 601 Front Panel 061312199 1 602 Left End Panel 061355102 1 603 Right End Panel 061355002 1 604 Tie Piece 061312099 1 651 Grille 061356402 5 652 Door Frame 061356602 1 653 Door 061356702 1 656 End Cap 061356502 1 661 Lock w/Key 802018114 663 Blockoff- L.H. Units only (C06= L) 106087201 1 N/S Screw 106084501 2 N/S Fastener, Button Head Dart 061461701 12

Unit Sizes- 015, 019Slope Top/Plastic Grille, High Sill 25", Locking Door, Std. Enclosure

C07= SP C08= H C22= K C10= A






Ref. Description Part Qty. No. Number 601 Front Panel 061312198 1 602 Left End Panel 061355102 1 603 Right End Panel 061355002 1 604 Tie Piece 061312099 1 651 Grille 061356402 5 652 Door Frame 061355602 1 653 Door 061356702 1 656 End Cap 061356502 1 661 Lock w/Key 802018114 1 663 Blockoff- L.H. Units only (C06= L) 106087201 1 N/S Screw 106084501 2 N/S Fastener, Button Head Dart 061461701 12

Unit Sizes- 015, 019Slope Top/Plastic Grille, High Sill 25", Locking Door, XQ Enclosure

C07= SP C08= H C22= K C10= S


Unit Sizes- 015, 019Slope Top/Plastic Grille, High Sill 25", Std. Door, Std. Enclosure

C07= SP C08= H C22= A C10= A







Unit Sizes- 015, 019Slope Top/Plastic Grille, High Sill 25", Std. Door, XQ Enclosure

C07= SP C08= H C22= A C10= S


Unit Sizes- 015, 019Slope Top/Plastic Grille, Low Sill 22.5", Locking Door, Std. Enclosure

C07= SP C08= L C22= K C10= A







Unit Sizes- 015, 019Slope Top/Plastic Grille, Low Sill 22.5", Locking Door, XQ Enclosure

C07= SP C08= L C22= K C10= S


Unit Sizes- 015, 019Slope Top/Plastic Grille, Low Sill 22.5", Std. Door, Std. Enclosure

C07= SP C08= L C22= A C10= A







Unit Sizes- 015, 019Slope Top/Plastic Grille, Low Sill 22.5", Std. Door, XQ Enclosure

C07= SP C08= L C22= A C10= S

No CabinetComponents

(C01= WCH) (C07= DC)

Ref. Description Part Qty. No. Number N/S Duct Flange Complete 061448801 1 Front Duct 061443201 1 Back Duct 061443301 1 N/S Tap Screw 048440103 4 N/S Gasket 061343960 1

Unit Sizes- 007, 009, 012C07= DC

Ref. Description Part Qty. No. Number N/S Duct Flange Complete 061448901 1 Front Duct 061443401 1 Back Duct 061443501 1 N/S Tap Screw 048440103 4 N/S Gasket 061343960 1

Unit Sizes- 015, 019C07= DC





Subbase, Finished Back PanelDiagram

Subbase frame shown in left hand piping position.

Subbase frame shown in right hand piping

position.

771605

711

712


Subbase, Finished Back PanelComponents

Ref. Description Part Qty. No. Number 605 Back Panel- Std. Const. (C10= Y) 106090090 1 Back Panel- XQ Const. (C10= S) 106090099 1 711 Subbase Frame 061312402 1 712 Subbase Panel 061312502 1 771 Finished Back Panel (C25= F) 061400402 1 N/S Throwaway Filter 061302502 1 N/S Cleanable Filter 061364402 1

Unit Sizes- 015, 019High Sill C08= H

Ref. Description Part Qty. No. Number 605 Back Panel- Std. Const. (C10= Y) 106090090 1 Back Panel- XQ Const. (C10= S) 106090099 1 711 Subbase Frame- LH Units (C06= L) 061328502 1 Subbase Frame- RH Units (C06=R) 061376602 1 771 Finished Back Panel (C25= F) 061400602 1 N/S Throwaway Filter 061302504 1 N/S Cleanable Filter 061364404 1

Unit Sizes- 015, 019Low Sill C08= L

Ref. Description Part Qty. No. Number 605 Back Panel- Std. Const. (C10= Y) 106089990 1 Back Panel- XQ Const. (C10= S) 106089999 1 711 Subbase Frame 061300502 1 712 Subbase Panel 061305202 1 771 Finished Back Panel (C25= F) 061400302 1 N/S Throwaway Filter 061302501 1 N/S Cleanable Filter 061364401 1

Unit Sizes- 007, 009, 012High Sill C08= H

Ref. Description Part Qty. No. Number 605 Back Panel- Std. Const. (C10= Y) 106089990 1 Back Panel- XQ Const. (C10= S) 106089999 1 711 Subbase Frame- LH Units (C06= L) 061328402 1 Subbase Frame- RH Units (C06= R) 062506301 1 771 Finished Back Panel (C25= F) 061400502 1 N/S Throwaway Filter 061302503 1 N/S Cleanable Filter 061364403 1

Unit Sizes- 007, 009, 012Low Sill C08= L



Ref. Description Part Qty. No. Number N/S Basepan 056360901 1 N/S Left Panel: Flat Top Units (C07= F*) 056360711 1 Left Panel: Slope Top Units (C07= SP) 056360712 1 N/S Right Panel: Standard Enclosure (C10= Y) 056361713 1 Right Panel: Extra Quiet Enclosure (C10= S) 056361711 1 N/S Center Panel: Flat Top/Std. Encl. (C07= F*/C10=Y) 056361513 1 Center Panel: Slope Top/Std. Encl. (C07=SP/C10=Y) 056361516 1 Center Panel: Flat Top/XQ Encl. (C07= F*/C10=S) 056361511 1 Center Panel: Slope Top/XQ Encl. (C07=SP/C10=S) 056361514 1 N/S Coil Mount 056371101 1 N/S Control Access: Flat Top/Std. Encl. (C07= F*/C10=Y) 056361813 1 Control Access: Slope Top/Std. Encl. (C07=SP/C10=Y) 056361814 1 Control Access: Flat Top/XQ Encl. (C07= F*/C10=S) 056361811 1 Control Access: Slope Top/XQ Encl. (C07=SP/C10=S) 056361812 1 N/S Fan Cover Panel: (C07= F*, C10=Y, C08= H) 056361915 1 Fan Cover Panel: (C07= SP, C10=Y, C08= H) 056361917 1 Fan Cover Panel: (C07= F*, C10=Y, C08= L) 056361916 1 Fan Cover Panel: (C07= SP, C10=Y, C08= L) 056361918 1 Fan Cover Panel: (C07= F*, C10=S, C08= H) 056361911 1 Fan Cover Panel: (C07= SP, C10=S, C08= H) 056361913 1 Fan Cover Panel: (C07= F*, C10=S, C08= L) 056361912 1 Fan Cover Panel: (C07= SP, C10=S, C08= L) 056361914 1 N/S Water Tube Retainer Clip 061304501 1 N/S Filter Support- Low Sill only (C08= L) 061300601 2 N/S Gasket- 1/8" X 3/8" X 156"- Low Sill only (C08= L) 062964001 1

N/S Back Panel Assembly 18

Extra Quiet Enclosure (C10= S) 056369201 1 Standard Enclosure (C10= Y) 058955801 1

Chassis PanelsComponents Sizes 007, 009, 012

C01= WMH or WCH only

N/S= Not Shown on Diagram.18 Includes condenser access and evaporator baffle.


Chassis PanelsComponents Sizes 015, 019

C01= WMH or WCH only

Ref. Description Part Qty. No. Number N/S Basepan 056360910 1 N/S Left Panel: Flat Top Units (C07= F*) 056360711 1 Left Panel: Slope Top Units (C07= SP) 056360712 1 N/S Right Panel: Standard Enclosure (C10= Y) 056361713 1 Right Panel: Extra Quiet Enclosure (C10= S) 056361711 1 N/S Center Panel: Flat Top/Std. Encl. (C07= F*/C10=Y) 056361513 1 Center Panel: Slope Top/Std. Encl. (C07=SP/C10=Y) 056361516 1 Center Panel: Flat Top/XQ Encl. (C07= F*/C10=S) 056361511 1 Center Panel: Slope Top/XQ Encl. (C07=SP/C10=S) 056361514 1 N/S Coil Mount 056371102 1 N/S Control Access: Flat Top/Std. Encl. (C07= F*/C10=Y) 056361813 1 Control Access: Slope Top/Std. Encl. (C07=SP/C10=Y) 056361814 1 Control Access: Flat Top/XQ Encl. (C07= F*/C10=S) 056361811 1 Control Access: Slope Top/XQ Encl. (C07=SP/C10=S) 056361812 1 N/S Fan Cover Panel: (C07= F*, C10=Y, C08= H) 056361905 1 Fan Cover Panel: (C07= SP, C10=Y, C08= H) 056361907 1 Fan Cover Panel: (C07= F*, C10=Y, C08= L) 056361906 1 Fan Cover Panel: (C07= SP, C10=Y, C08= L) 056361908 1 Fan Cover Panel: (C07= F*, C10=S, C08= H) 056361901 1 Fan Cover Panel: (C07= SP, C10=S, C08= H) 056361903 1 Fan Cover Panel: (C07= F*, C10=S, C08= L) 056361902 1 Fan Cover Panel: (C07= SP, C10=S, C08= L) 056361904 1 N/S Water Tube Retainer Clip 061304501 1 N/S Filter Support- Low Sill only (C08= L) 061300601 2 N/S Gasket- 1/8" X 3/8" X 156"- Low Sill only (C08= L) 062964001 1

N/S Back Panel Assembly 18

Extra Quiet Enclosure (C10= S) 056369203 1 Standard Enclosure (C10= Y) 061311699 1

N/S= Not Shown on Diagram.18 Includes condenser access and evaporator baffle.

Call Your Local Daikin Applied Parts Distributor For All Your Parts Needs.To Locate A Distributor, Go To www.DaikinApplied.com or Call 1-800-37PARTS

Critical Daikin Applied OEM PartsAre What Your HVAC Unit Needs!

0571184 Rev. L 08/2017 CPL Page 1 of 1

McQuay Console WSHPWMH, WCH, WMG, WMK

007 - 019 Vintage C

Critical Components Unit Sizes Voltage Part Number

ControlMicroTech Unit Control ALL N/A 060959401Mark IV ALL N/A 056792401MicroTech 520 ALL N/A 073312502

Compressor- PanasonicCompressor 007 115/60/1 066531901Compressor 007 208-230/60/1 066531902Compressor 007 265/60/1 066531903Compressor 009 115/60/1 067281203Compressor 009 208-230/60/1 067281202Compressor 009 265/60/1 067281201Compressor 012 115/60/1 067281303Compressor 012 208-230/60/1 067281302Compressor 012 265/60/1 067281301Compressor 019 208-230/60/1 067291402Compressor 019 265/60/1 067291401

Compressor- TecumsehCompressor 009 115/60/1 061086003Compressor 009 208-230/60/1 061086002Compressor 009 265/60/1 061086001Compressor 012 115/60/1 060907804Compressor 012 208-230/60/1 060907801Compressor 012 265/60/1 060907802Compressor 015 208-230/60/1 061043401Compressor 015 265/60/1 061043402Compressor 019 208-230/60/1 066540301Compressor 019 265/60/1 066540302

Fan Motor Motor, 1/60HP 007, 009 115/60/1 073388001Motor, 1/60HP 007, 009 208-230/60/1 073388002Motor, 1/60HP 007, 009 265/60/1 073388003Motor, 1/24HP 012 115/60/1 073384101Motor, 1/24HP 012 208-230/60/1 073384102Motor, 1/24HP 012 265/60/1 073384103Motor, 1/8HP 015, 019 208-230/60/1 067782202Motor, 1/8HP 015, 019 265/60/1 067782203

Fan Wheel Wheel ALL N/A 073383801

Sensor Air Temp Sensor (MicroTech 2000) ALL N/A 073305601Water Temp Sensor (MicroTech 2000) ALL N/A 073305701Air & Water Temp Sensor (MicroTech Unit Controller) ALL N/A 073305701

Date post:	17-Mar-2018
Category:	Documents
Upload:	haxuyen
View:	274 times
Download:	7 times

McQuay Console Water Source Heat Pump - Daikin...

Documents