Date post: | 27-Jul-2015 |
Category: |
Documents |
Upload: | julio-a-hernandez |
View: | 500 times |
Download: | 4 times |
• Design specifications are subject to change without notice.
MITSUBISHI DIGITAL ELECTRONICS AMERICA, INC.9351 Jeronimo Road, Irvine, CA 92618-1904
Copyright © 2005 Mitsubishi Digital Electronics America, Inc.All Rights Reserved
CAUTION:Before servicing this chassis, it is important that the service person read the "SAFETY PRECAUTIONS" and"PRODUCT SAFETY NOTICE" contained in this manual.
SerSerSerSerServiceviceviceviceviceManualManualManualManualManual
20052005200520052005
MITSUBISHI ELECTRIC
DLP PROJECTION HDTVV29 / V30 / V30+ / V31 CHASSIS
SPECIFICATIONS• Power Input : AC 120V, 60Hz• Power Usage : See table on page 5• Light Engine : DLPTM (1920 x 1080 pixels)• Light Source : 120W [V29,V30(52"&62")]
: 150W [V30(73"),V30+,V31]• Channel Range : Air VHF - 2~13, UHF - 14~69
Analog Cable - 1~25Digital Cable - 1~35
• Antenna Input : 2 RF 75Ω unbalanced• Tuning (V29,V30) : 1 NTSC/ATSC/QAM
1 Out of Band for CableCARDTM
1 NTSC for PIP• Tuning (V30+, V31) : 2 NTSC/ATSC/QAM
1 Out of Band for CableCARDTM
2 NTSC for PIP
• Cabinet Dimensions : See Table on page 5
• Weight : See table on page 5
• Speakers (8 Ohms 10W): Two 1.5" Round
Two 5.5"x2.2" Oval
• Input Level : VIDEO IN JACK (RCA Type) 1.0Vp-p 75Ω unbalanced
: AUDIO IN JACK (RCA Type) -4.7dBm 43kΩ unbalanced
: S-VIDEO IN JACK(Y/C separate type)Y:1.0 Vp-p C:0.286Vp-p(BURST)75Ω unbalanced
: COMP / Y, Cr, Cb (RCA Type)Y: 1.0 Vp-p Cr, Cb: 700mVp-p
• Output Level : VIDEO OUT JACK (RCA Type)1.0Vp-p 75Ω unbalanced
: AUDIO OUT JACK (RCA Type)-4.7dBm 4.7kΩ unbalanced
• Digital : IEEE-1394 I/O Jacks: Digital Audio Output
(RCA Type): HDMITM
: MonitorLinkTM RS-232 Control: Memory Card Reader
: Lead-Free solder PWBs
WD-52327
V29 ChassisWD-52627WD-62627
V30 ChassisWD-52628WD-62628WD-73727WD-52527
Pb Solder
Pb Solder
WD-62827
V30+ ChassisWD-62827WD-73827
V31 ChassisWD-62927WD-73927
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 3
INTRODUCTION ................................................................................................................................ 5Model Dimensions and Weight Specifiations ................................................................................... 5
PRODUCT SAFETY NOTICE ............................................................................................................. 5
SAFETY PRECAUTIONS ................................................................................................................. 6
DISASSEMBLY ................................................................................................................................. 7Front Disassembly (WD-52627 / WD-52628 / WD-62627 / WD-62628............................................. 7Front Disassembly (WD-62827) ...................................................................................................... 8Front DisassembLY (WD-62927) ................................................................................................... 11Front Disassembly (WD-73727 / WD-73827) ................................................................................. 15Front Disassembly (WD-73927) .................................................................................................... 17Rear Disassembly ........................................................................................................................ 19Chassis Disassembly & Accessing PWBs ................................................................................... 20Out of Cabinet Chassis Operation ................................................................................................. 26Optical Engine Replacement ......................................................................................................... 29
DIAMOND SHIELDTM Removal ........................................................................................................ 34
SERVICING THE LENTICULAR LENS AND FRESNEL SCREEN ..................................................... 35Removal of the Lenticular Screen and Fresnel Lens ...................................................................... 35Installation of the Lenticular Screen and Fresnel Lens ................................................................... 36
ADJUSTMENTS ............................................................................................................................... 37Option Menu & Defaults ................................................................................................................ 37LED Indicator Diagnostics ............................................................................................................. 38Error Codes Operational Check ..................................................................................................... 39Remote Operational Mode ............................................................................................................ 40Service Adjustment Mode ............................................................................................................. 40
Service Adjustment Mode Operation .................................................................................... 40Resetting Data to factory values and Transferring data ......................................................... 41
Optical Engine Adjustment ............................................................................................................ 42Test Signal activation ........................................................................................................... 42Preliminary .......................................................................................................................... 42Locking Screw ..................................................................................................................... 42Trapezodial Distortion Adjustment ........................................................................................ 43Rotation Adjustment............................................................................................................. 43Hortizontal & Vertical Position.............................................................................................. 44
USING LEAD FREE SOLDER .......................................................................................................... 45
CHIP PARTS REPLACEMENT ......................................................................................................... 46
REPLACEMENT PARTS .................................................................................................................. 47Parts Ordering .............................................................................................................................. 47Critical and Warranty Parts Designation........................................................................................ 47Parts Tolerance Codes .................................................................................................................. 47Quick Reference List .................................................................................................................... 48
SERVICE PARTS LIST .................................................................................................................... 49
SCREEN ASSEMBLY PARTS LIST.................................................................................................. 60WD-52627 / WD-52628 / WD-62627 / WD-62628 .......................................................................... 60WD-62827 / WD-62927 ................................................................................................................. 71WD-73727 / WD-73827 / WD-73927 ............................................................................................. 62
CONTENTS
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 4
CIRCUITRY BLOCK DIAGRAMS ..................................................................................................... 63Main Power Supply ....................................................................................................................... 63Lamp Ballast DC Supply ............................................................................................................... 64Fans Power Supply ....................................................................................................................... 64Optical Engine Power Supply ........................................................................................................ 65HDD Power Supply ((V30+ & V31 Only)........................................................................................ 65Analog Video Signal Path ............................................................................................................. 66Digital Video Signal Path .............................................................................................................. 67HDD Record Signal Path ............................................................................................................... 68Sound Signal Path ........................................................................................................................ 69Command Input Circuitry ............................................................................................................... 70Serial Data Control Lines .............................................................................................................. 70Lamp Control Circuitry .................................................................................................................. 71Lamp, Engine and Fan’s Protect circuitry ..................................................................................... 72TV Guide On Screen®................................................................................................................... 72
SCHEMATIC DIAGRAMS .....................................................................................................................
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 5
This service manual includes:1. Assembly and disassembly instructions for the front and rear cabinet components.2. Servicing of the Lenticular Screen and Fresnel Lens.3. Servicing down to major components, chassis, PWBs, Light Engine, Lamp Ballast, etc..4. Electrical adjustments.5. Optical Adjustments.6. Lead Free Soldering.7. Chip parts replacement procedures.8. Simplified circuit path diagrams.
The parts list section of this service manual includes:1. Cabinet and screen parts.2. Electrical parts.
Block diagrams of the above listed models are included in this service manual for better understanding of the circuitry.
PRODUCT SAFETY NOTICE
Many electrical and mechanical parts in television receivers have special safety related characteristics. These charac-teristics are often not evident from visual inspection nor can the protection afforded by them necessarily be obtained byusing replacement components rated for higher voltage, wattage, etc.
Replacement parts which have special safety characteristics are identified in this service manual.
Electrical components having such features are identified by shading on the schematic diagram and by bold type inthe parts list of this service manual. Therefore, the replacement for any safety part should be identical in valueand characteristics.
Pb SolderThe PWBs used in the V29, V30, V30+ and V31 chassis are constructed using Lead-Free solder.When servicing use only recommended Lead-Free solder (refer to page 45).
CableCARD is a trademark of Cable Television Laboratories, Inc.TV Guide On Screen is a registered trademark of Gemstar Development Corp.HDMI is a trademark of HDMI Licensing, LLC.Digital Light Processing, Digital Micromirror Device and DLP are trademarks of Texas Instruments.
MODEL CHASSIS HEIGHT WIDTH DEPTH WEIGHT POWER USAGE
WD-52627 V29 34 in. 49.6 in. 18.6 in. 121 lbs. 295WWD-52628 V30 " " " " "WD-62627 V29 40.5 in. 58.3 in. 20.3 in 133 lbs. "WD-62628 V30 " " " " "WD-62827 V30+ " 60.3 in. " " 310WWD-62927 V31 " " " " 330WWD-73727 V30 44.8 in. 69.9 in. 21.5 in. 165 lbs. 335WWD-73827 V30+ " " " " 350WWD-73927 V31 " 69.8 in. " " "
Dimensions/Weight
INTRODUCTION
This service manual provides service instructions for DLP Projection TV Models and Chassis:
Page 6
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
SAFETY PRECAUTIONSNOTICE: Observe all cautions and safety related notes located inside the receiver cabinet and on the
receiver chassis.
WARNING:1. Operation of this receiver outside the cabinet or with the cover removed presents a shock hazard
from the receiver's power supplies. Work on the receiver should not be attempted by anyone who isnot thoroughly familiar with the precautions necessary when working on high voltage equipment.
2. When service is required, observe the original lead dress. Extra precaution should be taken toassure correct lead dress in the high voltage area. Where a short-circuit has occurred, replace thosecomponents that indicate evidence of overheating.
Leakage current checkBefore returning the receiver to the customer, it is recommended that leakage current be measured according to thefollowing methods.
1. Cold CheckWith the alternating current (AC) plug removed from the AC source, place a jumper across the two AC plugprongs. Connect one lead of an ohm meter to the AC plug and touch the other lead to each exposed metal part(i.e. antennas, handle bracket, metal cabinet, screw heads, metal overlay, control shafts, etc.), particularly anyexposed metal part that has a return path to the chassis. The resistance of the exposed metal parts having areturn path to the chassis should be a minimum of 1Meg Ohm. Any resistance below this value indicates anabnormal condition and requires corrective action.
2. Hot Check ...Use the circuit shown below to perform the hot check test.1. Keep switch S1 open and connect the receiver to the measuring circuit. Immediately after
connection, and with the switching devices of the receiver in their operating positions, measure the leakage current for both positions of switch S2.2. Close switch S1, energizing the receiver. Immediately after closing switch S1, and with the
switching devices of the receiver in their operating positions, measure the leakage current for both positions of switch S2. Repeat the current measurements of items 1 and 2 after the receiver has
reached thermal stabilization. The leakage current must not exceed 0.5 milliampere (mA).
WARNING ... RISK OF EYE INJURYDo not look into the light source, lens or mirror when operating the TV
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 7
SPEAKER GRILLE & BEZEL Removal1) Pull the SPEAKER-GRILLE away from the cabinet to remove.2) Pull the BEZEL from the cabinet.
SCREEN-ASSY Removal1) Remove 10 screws (a) from the upper cabinet rear cover (3 screws on each side and 4 screws across the
top).2) Remove screws (b) along the bottom of the SCREEN-ASSY (8 screws on 52 inch models, and 10 screws
on 62 inch models),3) Unplug the LL connector to the front CONTROL-PANEL.4) Lift the SCREEN-ASSY up slightly and then pull away from the cabinet.
CABINET FRONT DISASSEMBLY(WD-52627 / WD-52628 / WD-62627 / WD-62628)
CARD READER Removal1) Remove two screws (c) securing the Card
Reader.2) Pull the Card Reader from the cabinet.3) Disconnect the ground lead, USB and 1394
connectors to the Card Reader.
Page 8
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
WD-62827 Front Disassembly
FRONT PANEL CAPS RemovalPull the FRONT PANEL CAPS from the unit.
TOP TRIM and FRONT ESCUTCHEON Removal1) Remove screw (a) to remove the TOP
TRIM.2) Pull off the FRONT-ESCUTCHEONS.
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 9
SIDE-TRIM Removal1) Remove screws (a) and (b) on each
side of the unit.2) Pull off the SIDE-TRIM on each side.
BEZEL and Card Reader/Contol Assy. Removal1) Remove screws (c) to remove the BEZEL.2) Remove screws (d), pull the Card Reader/
Control Assy. out the front of the unit.3) Unplug the LL, CE1, J8202 and 1394
connectors to remove the Assembly completely.
WD-62827 Front Disassembly (continued)
Page 10
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
SCREEN ASSY Removal1) Remove screws (e) from the top and sides of the upper rear cover.2) Remove screws (d) from the bottom of the SCREEN ASSY.3) Lift the SCREEN ASSY up slightly and pull away from the cabinet.
WD-62827 Front Disassembly (continued)
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 11
FRONT ESCUTCHEONS, CARD READER/CONTROL Assy and PEDESTAL COVER Removal1) Pull the Right and Left Front Escutcheons from the cabinet.2) Pull the Pedestal Cover forward to remove.3) Remove screw (a) to remove the Card Reader/Control Assembly from the front.
(To remove the assembly completely unplug the LL, CE1 J8202 and 1394 connectors.)
WD-62927 Front Disassembly
Page 12
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
TOP, BOTTOM and SIDES TRIM Removal1) Remove screws (b) to remove the Top Trim.2) Remove screws (c) to remove the Bottom Trim.3) Remove screws (d) on both sides to remove the Side Trim
WD-62927 Front Disassembly (continued)
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 13
FRONT BEZEL Removal1) Remove screws (e) from the FRONT-BEZEL.2) Pull the FRONT-BEZEL from the cabinet.
WD-62927 Front Disassembly (continued)
Page 14
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
WD-62927 Front Disassembly (continued)
SCREEN ASSEMBLY Removal1) Remove screws (f) from the upper rear cover (3 at each side and 4 acrross the ).2) Remove screws (g) at the bottom of the screen.3) Lift the Screen Assembly slighly and pull away from the unit.
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 15
WD-73727 / WD-73827 Front Disassembly
CARD READER REMOVAL1) Pull the two PANEL-FRONTs from the cabinet.2) Remove screws ((a) from the Card Reader.3) Slide the Card Reader and Control Assembly out the front of the TV.
(To remove the Card Reader completely unplut the connectore LL, CE1, J8202 and 1394.)
Page 16
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
WD-73727 / WD-73827 Front Disassembly (continued)
GRILLE-SIDE REMOVAL1) Remove screw (b) in the GRILLE-SIDE
LEFT and GRILL-SIDE RIGHT2) Pull the two GRILLE-SIDEs from the unit.
SCREEN-ASSY REMOVAL1) Remove screw (c) along the top and sides
of the upper rear cover. (4 across the topand 3 on each side).
2) Remove two screw (d) on the bottom on theSCREEN-ASSY.
3) Lift the SCREEN-ASY slightly and pull itaway from the TV.
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 17
WD-73927 Front Disassembly
CARD READER REMOVAL1) Pull of the right and left GRILLE-SIDEs.2) Remove screws (a) to remove the FRONT-BOARDS.3) Remove screws (b) and pull the Card Reader and Control Assembly out the front of the TV.
Page 18
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
WD-73927 Front Disassembly (continued)
SCREEN-ASSY Removal1) Remove screws (f) along the top and sides of the upper rear cover. (4 across the top and 3 on each side).2) Remove two screw (g) on the bottom on the SCREEN-ASSY.3) Lift the SCREEN-ASY slightly and pull it away from the TV.
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 19
Cabinet Rear Disassembly
BACK-COVER Removal1) Remove screws (a) and (b) from the the BACK-COVER.2) Pull the BACK-COVER from the set.
Accessing the MIRROR from the rear (52 and 62 inch models ONLY)1) Remove screws (c).2) Pull the Rear Mirror Access panel from the unit.
Page 20
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Chassis Disassembly / Accessing PWBsNote: Although not individually indicated, unplug the required connectors in each
disassembly step.
REMOVEChassis Top Cover
(Fig. 1)
REMOVEPWB-POWER
(Fig. 3)
REMOVEAssy PWB-TERMINAL
(Fig. 2)
REMOVEChassis Top Shield
(Fig. 3)
REMOVEChassis Rear Shield
(Fig. 6)
REMOVEPWBs MICRO / FMT/ RISER
(Figs. 4 & 5)
REMOVEPWB-DM(Fig. 7)
Chassis Sequence of Disassembly
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 21
Chassis Removal from the cabinetAfter removing the Rear Cover:
1) Remove screw (a), (b) and (c) to remove theback terminal board cover. (Figure A)
2) Remove screw (d) to remove the support bracketon each side of the chassis. (Figure B)
3) Remove the chassis mounting screws (e) oneach side of the chassis. (Figure (C)
4) Unplug all connectors to the chassis andcarefully slide the chassis from the cabinet.
Figure A
Figure B
Figure C
Page 22
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Assy PWB- TERMINAL Removal (Figure 2)1) Remove 7 screws (b) to remove
the TERMINAL-INLAY.2) Remove 3 screws (c) to remove
the Assy PWB-TERMINAL.
Figure 1: Chassis Cover Removal
Chassis Cover Removal (Figure 1)1) Remove the 3 screws (a).2) Lift the Cover from the chassis.
Figure 2: ASSY PWB-TERMINAL Removal
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 23
PWB-POWER Removal (Figure 3)1) Remove four screws (d).2) Disconnect all connectors to PWB-POWER.3) Lift PWB-POWER from the chassis.
Figure 3: PWB-POWER and Chassis Upper Shield
Chassis Upper Shield Removal (Figure 3)1) Remove seven screws (e).2) Lift the Shield from the chassis.
Page 24
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Figure 4: HDMI Socket Screws
PWB-MICRO RemovalReferring to Figures 4 & 5 .
1) Remove the 2 HDMI socket screws (f).2) Remove 3 mounting screws (g) from PWB-MICRO.2) Unplug PWB-MICRO from PWB-RISER
and remove it from the chassis.
Figure 5: PWB-MICRO Mounting Screws
PWB-FORMAT & PWB=RISER RemovalReferring to Figures 6After removing PWB-MICRO:
1) Remove screw (h).2) Unplug the PWB-FORMAT and
PWB-RISER from PWB-DM.
Figure 6: PWB-FORMAT & RISER Removal
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 25
Figure 8: PWB-DM Removal
PWB-DM RemovalChassis Rear Shield Removal (Figure 7)
1) Remove 7 screw ( j )2) Remove 2 nuts ( j1 )3) Pull off Chassis Rear Shield.
PWB-DM Removal (Figures 8)1) Remove 3 screws (k) holding the PWB-MICRO
Support Bracket.2) Remove the Support Bracket.3) Remove the five screws (m).4) Remove the PWB-DM from the chassis.
Figure 7: Chassis Rear Shield
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 26
OPERATING CHASSIS OUTSIDE OF CABINET
1) Remove screws from back terminal board.Screws A = (7), B = (2), C = (2)
2) Remove support bracket screws D = (4), andmounting screw E = (1)
4) Remove mounting screw F = (1) on right sideof chassis behind bracket
5) Disconnect AC cord from connector PS anddisconnect connector CE1
F
3) Support bracket has latch that must be openedbefore removing from unit
latch
support bracket
6) Pull chassis from cabinet. Rotate to side aspictured below and remove screws G = (2)
PS
CE1
G
D
E
A
B
C
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 27
7) Pictured below is proper wire routing, pleaseverify during re-assembly
8) Disconnect connector PL and remove screwH = (1)
PL
9) Remove connectors PC, PA1, PB, PD andDVI cable
10) Remove cover shield for Power PWB. Dis-connect connectors FB, ES, KA, PD, PC, J7T01
PL
H
PCPA1
PBPD
DVI
11) Remove screws from side and front ofchassis I =(4)
12) Remove screws from side of chassis J = (3)and from terminal K = (3)
FBKAPD
PC
J7T01
ES
I J KFront Back
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 28
13) Pull Terminal PWB from chassis assemblyand remove fan connector JD from Micro PWB
14) Setup power section next to remainingchassis section as pictured below.
NOTE: Unit can be operated without TerminalPWB or Chassis Fan installed. Without Fanconnected, TV will shutdown if Micro PWB(Bottom side) temperature becomes too hot.
NOTE: It is recommened to use a separate ACcord. You can purchase one from the partsdepartment: P/N 246C351070
Screw Size: 3x12Used @: A / C
Screw Size: 3x8Used @: B / G / H / I / J / K
Screw Size: 4x16Used @: D / E / F
Bolt Table:
AC Cord
JD
3
12
3
8
4
16
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 29
OPTICAL ENGINE REPLACEMENT
(View from back)Ballast Fan
Ballast Cover
Lamp Cartridge
Interface PWB
Engine PWR PWB
Ballast Plate
Lamp Duct Lens Cushion(View from front)
Engine Plate
Bottom Plate
Pull engine from base and remove all the listed parts on this page and transfer them to newengine. Then transfer EEPROM data and realign mechanical.(See following pages for details)
LAMP DUCT ENGINE-PWR-PWBLENS CUSHION BALLAST PLATEENGINE PLATE INTERFACE PWBBOTTOM PLATE LAMP CARTRIDGELAMP FAN
Lamp Fan(120W Version) (note on 150W version
Lamp Fan is in front)
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 30
OPTICAL ENGINE REPLACEMENT (Details)1) Remove screws (3) 2) Remove mounting screw
3) Disconnect JA, JF, LT connectors 4) Disconnect JC and CD connectors
5) Remove DVI cable and disconnectJE and DT connectors
6) Remove wire tie near support post
JA
JF
LT JC
CD
JE
DT
DVI
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 31
10) Route wiring so that it does not snagon support post.
12) Pull Optical Engine from cabinet. (Note:Slight twisting motion may be required)
11) Disconnect PA1 and J3 connectorsand remove Engine-PWR-PWB
8) Remove CJ3 connector from Inter-face PWB
OPTICAL ENGINE REPLACEMENT (Details)7) Remove (3) screws from Interface PWB
CJ3
9) Remove (2) screws from Side Lock
PA1J3
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 32
14) Remove (2) screws from LampCartridge - and remove Lamp Cartridge
13) Remove (3) screws from Lamp Duct
16) Remove Bottom Plate from Engine Plate.Remove (5) screws A - B - C
15) Remove (4) screws from Ballast Plate
OPTICAL ENGINE REPLACEMENT (Details)
A
B C
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 33
OPTICAL ENGINE REPLACEMENT (Details)
Reassembly:
1) Attach LENS CUSHION BASE to Engine
Follow above steps in reverse order
Mechanical Alignment: Adjustment is required after engine has been removed. Please follow stepsin the adjustment section of this manual.
Data: Index Delay Data needs to be transfered from Engine to E2P PWB:< MENU + 2457 + 0 >Select -> COPY LIGHT ENGINE EEPROM TO DMPRESS ENTER
19) Transfer LENS COVER fromservice part to defective part
17) Be sure not to misplace spring 18) Remove (1) screw from plate(A), (4) screws from fan (B), (2)screws from side lock (C) and (2)grounding strap screws (D)
Lens Cushion Base
Spring
A B
CD
TIP: Lift and group wiring on leftside of engine when installing
MODEL: WD-52525 / WD-52725 / WD-52825 / WD-62525 / WD-62725 / WD-62825
Page 17
DIAMOND SHIELD REPLACEMENT
92
To Remove the Diamond Shield:
1. While wearing soft cotton gloves, loosen thesides of the Diamond Shield by pressing a smallplastic card (the size of a standard credit card or aclean, plastic, putty knife) into the middle of theside slot. The Diamond Shield side will snap outof the top middle and bottom clips. Loosen bothsides before proceeding to step 2.
2. After the sides are free, gently push down on thetop of the Diamond Shield. It will slide out of thetop channel.
3 Carefully pull the screen up to remove it from thebottom channel. Store the Diamond Shield in a clean,dust free area, where it will not be scratched.
To Install the Diamond Shield:
4. Slide the Diamond Shield into the bottom channel,making sure it fits securely.
5. Press gently on the top of the Diamond Shield toslightly bow the screen towards you. Insert thetop of the Diamond Shield into the top channel. Itshould fit securely.
6. At each side, gently press the top, middle andbottom of the Diamond Shield to snap it back intoplace.
WARNING
Sharp edges! Always wear gloves tohandle, lift, install and remove theDiamond Shield.
1b1a
1 1
2
3
6 6
5
4
6
6
6
6
1
1
1
1
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 35
SERVICING THE LENTICULAR SCREEN AND FRESNEL LENS
CAUTION: Wear gloves when handling the Lenticular Screen and Fresnel Lens.This prevents cuts and finger prints. Do not place Fresnel Lens in the sun.This may cause fire and heat related injuries.
Lenticular Screen and Fresnel Lens Removal1. Remove the screen assembly as shown in the Cabinet Disassembly procedure.2. Remove the four screws (a) to remove the bottom of the SCREEN-FRAME-BOTTOM . (Figure 1)3. From the rear of the screen assembly, carefully slide the Lenticular Screen and Fresnel Lens combination
from the Screen Frame. (Figure 2)Note: When separating the Lenticular Screen from the Fresnel Lens, use caution
while prying the Screen and Lens apart. Use a slot type screw driver, andremove the pressure sensitive double sided tape.
Figure 1
Page 36
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
SERVICING THE LENTICULAR SCREEN AND FRESNEL LENS
Lenticular Screen and Fresnel Lens InstallationNote: Store the Lenticular Screen and Fresnel Lens in a cool dry place. High humidity may
deform the Lenticular Screen and Fresnel Lens.
1. Apply double coated tape (Part #LENS-TAPE) along the top rear edge of the Lenticular Screen, as shownbelow. Refer to the table below for the tape length.
2. Sandwich the Fresnal Lens and Lenticular Screen together. The Lenticular Screen label must be towardsthe front and the Fresnel Lens label towards the rear. (Figure 2)
3. Apply pressure at the top edge to bond the screens together.4. Reverse the Screen Removal procedure and insert the screens in the Screen Fame Assembly.
Figure 1
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 37
OPTION MENU1. Press the “MENU” button on the remote hand unit.2. Press the buttons “2”, “4”, “7” and “0” in order. (The screen will change to the option menu.)
Setup Menu L-Adult Language EnableLanguage English S-Sexual Situationss EnableCombine Channel View -- V-Violence EnableClock Programs Not Rated EnableClock Setting Manual Movie Rating PGTime 12:00pm V-Chip TimeDate -- Start 12:00pmTime Zone -- Stop 12:00pmDaylight Savings Time -- Lock by TimeTimer -- Lock by Time OnLamp Reminder Lock Time 12:00pmSoftware Version Unlock Time 12:00pmNetCommand Menu Front Button Lock OffEdit -- Audio/VideoIcon Order -- A/V Memory Reset Ant-1Transport Menu On SettingsFixed Channel for Cable Box 3 (gray out) AudioRecord Bass 50%Record Treble 50% Channel 2 Balance 50% Record to -- Surround Off Duration 1 hr Listen to (Analog Only) Stereo Start Time -- Level Sount (Analog Only) On Day -- Language (Digital Only) EnglishRecord List -- VideoDefault Record Device Gray out Contrast 100%Analog Recordings Anamorphic Brightnes 50%Channel Sharpness 50%Antenna 1 Color 50%
Tint 50%Prefer Digital -- Color Temp HighChannel 2 Video Noise StandardMemory Added Film Mode (Auto) OnName -- Define Edge OnSQV -- Color BalaneSignal Strength -- Video Mute OnCaptions Menu black Enhancement OnAnalog Captions On if Mute TV Speakers OnBackground Gray TV Volune 30%Digital Caption On if Mute PIP Source Ant 1 003Appearance Default PIP Position Lower RightDigitalSettings POP Position Right Half
Font Font 3 PIP/POP Format Double WindowSize Large FormatColor White Ant-1,2 (480i/480p) StretchBackground Black Ant -1,2 (HD Digital) StandardOpacity Translucent Input 1,2,3 StandardBackground Opacity Translucent Comp-1,2,3 Standard
V-Chip Lock Menu HDMI-1,2 (Video) StandardV-Chip Off HDMI-2(PC) StandardTV Rating TV-PG Card Reader Video StandardFV-Fantasy Violence Enable Analog PC (v31 ONLY) StandardD-Sexual Dialog Enable
Initial Main Menu Defaults
Page 38
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
A. A/V MemoryEach of the external inputs has its’ own Audio/Video Memory. A change in an A/V setting at a specific input isstored in memory for that specific input.
B. A/V Reset1. Press the GUIDE and FORMAT buttons on the front panel to reset all A/V Memories to the default settings.2. The AV Reset in the user’s menu resets only the selected input’s A/V Memory.
LED Indicator DiagnosticsThe front panel LEDs provide an indication of the sets opera-tion, and the possible cause of a malfunction. There are threefront panel LEDs, “Power”, “Status” and “Lamp”. Which LED islit, the color and whether it is blinking or steady indicate thecurrent status, or a possible malfunction.
A/V Memory Ant 1/2 INPUTS 1/2/3
Component 1/2/DTV
1394 when connected
HDMI 1/2 (Video)
HDMI-2 (PC) Analog PC* Card 1~4
Bright/Natural Bright Bright Bright Bright Bright N/A BrightBright Contrast MAX MAX MAX MAX MAX MAX MAX
Bright Brightness Center Center Center Center Center Center CenterColor Center Center Center Center Center N/A CenterTint Center Center Center Center Center N/A Center
Sharpness Center Center Center Center Center N/A CenterColor Temp. High High High High High High High
Perfect Color Manual/ Center
Manual/ Center
Manual/ Center
Manual/ Center
Manual/ Center N/A
Manual/ Center
Deep Field Imager (V30-V31) On On On On On N/A On
Video Noise Standard Standard Standard N/A Standard N/A N/ATV Film Mode (Auto) On On On N/A On N/A N/ASharpEdge (V30-V31) On On On On On N/A On
Bass Center Center Center Center Center Center CenterTreble Center Center Center Center Center Center Center
Balance Center Center Center Center Center Center CenterSurround OFF OFF OFF OFF OFF OFF OFFListen To Stereo N/A N/A N/A N/A N/A N/A
Level Sound On On On On On On On Language (Digital Only) English N/A N/A English N/A N/A English
Vertical Position N/A N/A N/A N/A N/A Center N/AHorizontal Position N/A N/A N/A N/A N/A Center N/A
Fine Detail N/A N/A N/A N/A N/A Center N/A*Analog PC mode is only available on V31 models
A/V RESET DEFAULT SETTINGS (By Input)
POWER LED
STATUS LED
LAMP LED
Power Status Condition
Off Off Off Stby OffGreen Off Off P-0N Power On
Off Off Blinks Green
After Turn Off Lamp Fan On for 1 minute
Blinks Green Off Off Stby Booting after AC applied
Slo Blinks Green Off Off Stby On Timer is set
Normal LED Indications
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 39
3. Error Code Operational CheckNote: The TV must be in “Shut Down” and not have been switched Off, to perform the Error Code Opera-
tional Check. When the TV is switched Off, the code automatically resets to “12” No Error.
Pressing the front panel “DEVICE” and “MENU” buttons at the same time, and holding for 5 seconds,activates the Error Code Mode. The LED flashes denoting a two digit Error Code, or indicating no problemhas occured since the last Initalization.
Note: The front panel buttons must be used, NOT those on the Remote Control.
• The number of flashes indicates the value of the MSD (tens digit) of the Error Code.• The flashing then pauses for approximately 1/2 second.• The LED then flashes indicating the value of the LSD (ones digit) of the Error Code.• The Error Code is repeated a total of 5 times.
Example: If the Error Code is “23”, the LED will flash two times, pause, and then flash three times.
4. Error CodesThe Error Code designations indicating malfunction, or no malfunction, are listed below:
Error Codes "DEVICE" & "MENU"Error Codes Description
12 No error detected22 Recovery from Reset32 Lamp cover is Open34 Lamp abnormality35 DM Fan failed (Chassis Fan)36 Exhaust or Lamp Ballast Fan failed37 DMD Engine Fan failed38 Lamp temperature abnormally high39 DMD temperature abnormally high41 Short is detected (Standby Power Supplies)42 Lamp Fan failed44 DVI cable between Format and Engine disconnected46 DMD Fan failed (JC connector disconnected)47 DM Temperature too high48 Engine power supply short detected51 Speaker Drive circuit short detected52 HDD excess temperature (V30+ & V31 only)55 HDD Fan Stopped (V30+ & V31 onlyt)
POWER LED
STATUS LED
LAMP LED
Power Status Condition
Off Yellow Off Low Power Excess Temperature
Off or On Off Yellow No change
120w usage time over 7000 Hrs. 150W usage time over 3500 Hrs.
Off Off Blinks Yellow
Low Power Lamp Cover open
Off Blinks Yellow Off " Filter Cover Open
Off Off Red Stby Lamp did not turn On
Off Blinks Red Off Low
Power Fan Stopped
Off Red Off " Circuit failure (short or DVI connector unplugged)
Abnormal LED Indications
Page 40
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
SERVICE ADJUSTMENTSThere are only 5 Service Adjustments required in these models:
Two Electrical Adjustments• Horizontal Centering• Vertical Centering
Three Mechanical Adjustment• Picture Rotation• Horizontal Keystone Distortion• Vertical Keystone Distortion
Measuring equipment and Jigs• No additional Test Equipment is required.• Conventional Electrical Hand Tools.
Test signalAn internally generated Test Signal is used, no additional external signals arerequired.
Remote Control Operational ModesThere are two Remote Hand Unit Operational Modes, “Standard” and “NetCommand”. The Remote is initiallyin the “Standard” mode. The “NetCommand” mode is used when controlling Home Theater devices usingNetCommand. To change the Remote Operational Mode:
• Set the Remote to the TV Layer• Point the Remote away from the TV.• To change to “Netcommand” ... Hold the “Power” button and press “9-3-5” in sequence.• To change to “Standard” ... Hold the “Power” button and press “0-0-0” in sequence.
Circuit Adjustment ModeOn these models, the Cirduit Adjustment Mode is used only for:
• Test Signal activation• Horizontal Centering• Vertical Centering the following adjustments may only
be performed using the remote hand unit.
1. Activating the adjustment mode1. Press the “MENU” button on a remote hand unit. (The “MENU” display will appear.)2. Press the buttons “2”, “4”, “5” and “7” in that order. (The screen will change to the adjustment mode.) If not changed to the adjustment mode, repeat steps 1 and 2.
2. Test Signal ActivationWhen in the Circuit Adjustment mode, press “REWIND” on the remote control to activate the test pattern. Thispattern is used for both electrical and mechanical adjustments.
3. Adjustment Function SelectionUse the “AUDIO” button to select a specific Adjustment Function.
Doubler fmtFunctions
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 41
3. Adjustment SelectionUse the “VIDEO” button to select a specific electrical ajustment, “1 HPOS” or “2 VPOS”.
4. Adjusting DataAfter selecting an adjustment item, use the “UP” and “DN” buttons to change adjustment data.
ª If the “UP” button is pressed, the adjustment data increases.ª If the “DN” button is pressed, the adjustment data decreases.
5. Saving data Press “ENTER” to save the adjustment data in memory.The display characters go red for approx. one second in this step.
Note: If the circuit adjustment mode is terminated without pressing “ENTER”, changes in adjustment data are not saved.
6. Terminating the circuit adjustment modePress the “MENU” button on the remote hand unit twice to terminate the adjustment mode.
Note: The adjustment mode can be also terminated by turning thepower off.
Resetting Data to Factory Values1) Enter the Service Adjustment Mode ... Press “MENU-2-4-5-7”2) Press “0” when in the Service Mode ... Three choices appear at the top of the screen.
3) User UP & DN keys to highlight the desired choice, the Press “ENTER”
Data Transfer MENU-2-4-5-7-0Display Description
Copy Engine E2PROM to DM Transfers Engine data to DM E2PROMRestore Backup Restores data to factory valuesUPLOAD TERMINAL BOARD DATA DO NOT USEDownload WB Alignment to FMT Transfers Engine data to FMT
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 42
PrelminaryMechanical Optical Engine Adjustments are made using the UNIT-ADJUSTER shown in Figure 1. The UNIT-ADJUSTERis mounted under the Light Engine on the Engine Plate. It is accessed from the front of the set through the opening forthe Card Reader. Refer to the model specific Disassembly Instructions and remove the:
• Back Cover• Speaker Grille• Card Reader
Optical Engine AdjustmentsTest Signal Activation
1) Press “MENU-2-4-5-7” (Service Mode)2) Press “REW” (Test Pattern).
Red = 4% overscanWhite = 5% overscanGreen = 6% overscanCyan = 7% overscanYellow = 10% overscan
Required Tools• 4mm Hex Wrench (10 inches long minimum )• 5mm Allen Wrench ( 10 inches long minimum)• 10mm Hex or Phillips driver.
Figure 1: Unit-Adjuster
[A-1]VERT. KEYSTONE
4mm Hex
[B-1]LOCKING SCREW
5mm Allen Wrench
[A-3]HORIZ. KEYSTONE
4mm Hex
[A-2]ROTATION4mm Hex
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 43
ADJUSTMENT PROCEDURESAdjustment LocationsThe Mechanical Adjustements are accessedthough the opening for the Card Reader.Locations of the Adjustmentts ar shown InFigure 3.
CAUTION: Do Not force an adjust-ment past the end of it’s range,UNIT-ADJUSTER damage mayresult.
[A-1]
[B-1]
[A-3]
[A-2]
Figure 4: Adjustment
Locking Screws and Wedge RemovalBefore mechanical adjustments can be made, locking screw [B-1]and [B-2] must be loosened.
• [B-1] is located on the front of the UNIT-ADJUSTER.(Figure 1)
• [B-2] is accessible from the rear of the unit on theright side of the Optical Engine (from the rear).(Figure 2)
• Remove the rubber wedge shown in Figure 3. (52inch and 62 inch models Only)
[B-2]
Figure 2: Side Locking Screw
Figure 3: Rubber Wedge (52 and 62 inch models only)
WEDGE
WARNING: DO NOT loosen [B-2] toofar. The nut on the other side may dropoff. Then the Optical Engine must beremoved to re-install the nut.
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 44
Rotation AdjustmentAdjust [A-2] to remove any picture rotation
Horizontal Keystone AdjustmentAdjust [A-3] to remove horizontal keystone distortion.
NOTE: Vertical Positioning may shift
Vertical Keystone AdjustmentAdjust [A-1- To remove vertical keystone distortion.[A-1] can only be accessed by the front access holeshown above.
NOTE: Horizontal Positioning may shift.
After Adjustment1) Slide the rubber wedge under the Engine slowly
until it makes solid contact. (See Figures 3 & 6)2) Tighten side Locking Screw [B-2]. (Figure 2)3) Check the Picture, re-adjustment may be required
(usually rotation).4) Tighten front Locking screw [B-1]. (Figure 3)
Purpose:
MeasuringInstrumentTest Point
MeasuringRangeInput Signal
Ext. Trigger
Input Terminal
Symptom:[Format Circuit]
----
------
------
Internal Test Patern.
Video
To center the picture on the screen.
Picture is off center.
1. Press “MENU-2-4-5-7”, activates the Service Mode..2. Select the “FORMAT” function (AUDIO button).3. Press “REWIND”, activates the Overscan Test Pattern4. Select “Item 1” HPOS (VIDEO button).5. Use the ADJUST buttons to center the picture horizontally.6. Press ENTER to save the new setting.7. Select “Item 2” VPOS (VIDEO button).8. Use the ADJUST buttons to center the picture vertically.9. Press ENTER to save the new setting.
10. Press MENU to exit the Service Mode.
Horizont/Vertical Positi0n Adjust-ment
Figure 5: Adjustments
Electrical Adjustments
RUBBERWEDGE
Figure 6: Wedge Insertion
PAGE 45
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Using Lead Free SolderPb Solder
The above symbol indicates Lead (Pb) Free solder wasused during the construction of PWBs. Only LeadFree solder should be used when servicing thesePWBs.
Solder must be compatible with that used by themanufacturer. Leaded solder can not be used onPWBs manufactured with Pb-free solder. The Mitsub-ishi standard for service requires the use of Tin-Silver-Copper (Sn-96.5, Ag-3.0, Cu-0.5). It can be obtainedthrough the Parts Department.Order part number: PB FREE SOLDER
Lead Free solder has a higher melting point, and doesnot “wet” as well as leaded solder. This means it doesnot adhere as readily to the solder iron tip, and thesurface to be soldered. To counteract this, the fluxused is more corrosive.
The following cautions must be taken when using PbFree solder.
• Higher temperatures can cause the PWB towarp, detaching surface mountcomponents.
• Higher temperatures maycause thermal damage tocomponents.
• Higher temperatures can causeplastics, such as connectors,relays, LEDs electrolyticcapacitors, etc. to melt orwarp.
• Higher temperatures can causesurface oxidation resulting inpoor solder spread-ability andwet-ability.
• The flux is more corrosive.• The time required for a good solder connection may
take longer.• Poor wet-ability can cause solder balls.• Higher temperatures can cause flux spattering.• Soldering iron tip life is shortened.• Dull finish solder joints (not shiny) can appear to be
a “cold” solder joint.
In general a tip temperature of 700° F will usually providegood results.
Displays used to indicate Pb-freePCBs will be marked, indicating the level of Pb-free con-struction. Table 1 defines the levels by phase and showsthe different symbols that will be displayed on the PCB.Additionally, a PCB constructed using Pb-free solder maybe simply marked LFS.
When possible, the indication will be placed close to thepart number that is screened onto the PCB (not the partlabel). Figure 1 is an example of a PCB showing thedisplay and its location.
Pb-Free Phase Definition Display
Short Display (When the area is too small)
Phase-1 PCB's constructed using Pb-free solder.
Phase-2 Solder, PCB surface finishing and component lead plating is Pb-free. Components may have internal Pb.
Phase-3 Solder, PCB surface finishing and components are Pb-free. (100% Pb-free)
Table 1: Pb-Free Phases and Symbols
Pb PCA
Pb Joints
Pb S
Pb J
Pb P
Pb Solder
Pb-FreeDisplay
Figure 2: Pb-Free display on PWB
PAGE 46
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
CHIP PARTS REPLACEMENTSome resistors, shorting jumpers (0 Ohm resistors),ceramic capacitors, transistors and diodes are chip parts.The following precautions should be taken when replacingthese parts.
Cautions:1. Use a fine tipped, well insulated soldering iron
and tweezers.2. Melt the solder and remove the chip parts
carefully so as not to tear the copper foil fromthe printed circuit board.
3. Discard removed chips; do not reuse them.4. Do not apply heat for more than 3 (three)
seconds to new chip parts.5. Avoid using a rubbing stroke when soldering.6. Take care not to scratch, or damage the chip
parts when soldering.7. Supplementary cementing is not required.
Chip Parts Removal (Resistors, Capacitors, etc.)1. Grasp the part with tweezers. Melt the solder
at both sides alternately, and remove one sideof the part with a twisting motion.
2. Melt the solder at the other side and removethe part.
Chip Parts Removal (Transistors)1. Melt the solder of one lead and lift the side of
that lead upward.2. Simultaneously melt the solder of the other
two leads and lift the part from the PCB.
Replacement1. Presolder the contact points on the circuit
pattern.2. Press the part downward with tweezers and
apply the soldering iron as shown.
PAGE 47
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Parts OrderingTo expedite delivery of replacement parts orders, specify the following:1. Model Number/Serial Number2. Part Number and description3. Quantity
Note: Unless complete information is supplied, delay in processing of orders will result.
Critical and Warranty Parts Designation
Critical Electrical Components are indicated by Bold Type in the Parts List, and in the schematicdiagrams by shading.
Warranty Return Parts are indicated in the Parts List with an (*).
Parts Tolerance CodesRefer to the following chart for tolerance characteristics of electrical components.
MARK B C D F G J K
Tolerance % ± 0.1 ± 0.25 ± 0.5 ± 1 ± 2 ± 5 ± 10
MARK M N V X Z P Q
Tolerance % ± 20 ± 30 ± 10 + 40 + 80 + 100 + 30
-20 -20 - 0 -10
MARK M N V X Z
Tolerance (pF) ± 0.1 ± 0.25 ± 0.5 ± 1 ± 2
REPLACEMENT PARTS
PAGE 48
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
QUICK REFERENCE FOR COMMON PARTS
PART NO. MODELSASSY-PW B-POW ER2 934C159001 W D-52627 / 52628 / 62627 / 62628 / 73727
934C159002 W D-62827 / 62927 / 73827 / 73927ASSY-PW B-TERMINAL 934C150005 W D-52627 / 52628 / 62627 / 62628 / 73727
934C150006 W D-62827 / 62927 / 73827 / 73927ASSY-PW B-MICRO 934C151005 W D-52627 / 52628 / 62627 / 62628 / 73727
934C151006 W D-62827 / 62927 / 73827 / 73927ASSY-PW B-DM 934C152005 W D-52627 / 62627
934C152006 W D-52628 / 62628 / 72727934C152007 W D-62827 / 62927 / 73827 / 73927
ASSY-PW B-V29FMT 934C160001 W D-52627 / 52628 / 62627 / 62628 / 62827 / 73727 / 73827934C160002 W D-62927 / 73927
ASSY-PW B-RISER 934C154002 W D-52627 / 52628 / 62627 / 62628 / 73727934C154005 W D-62827 / 62927 / 73827 / 73927
ASSY-PW B-DEMOD1 935D819001 All modelsASSY-PW B-DEMOD2 935D839001 W D-62827 / 62927 / 73827 / 73927ASSY-ENG-POW ER 955C283001 All models
PW BsMajor PWB Assemblies
Component Part No. ModelsLIGHT ENGINE 938P017010 WD-52627 / 52628
938P017020 WD-62627 / 62628938P019020 WD-62827 / 62927938P019010 WD-73727 / 73827 / 73927
PW B-BALLAST 938P018010 WD-62827 / 62927 / 73727 / 73827 / 73927939P978020 WS-52627 / 52628 / 62627 / 62628
LAMP CARTRIDGE 915P026010 WS-52627 / 52628 / 62627 / 62628915P027010 WD-62827 / 62927 / 73727 / 73827 / 73927
OPTICAL COMPONENTS
MODEL MIRROR LENTICULAR SCREEN
FRESNEL LENS
DIAMOND SHIELD
WD-52627 767D079010 491P178040 491P177040 -WD-52628 " " " -WD-62627 767D079020 492P178030 491P177030 -WD-62628 " " " -WD-62827 " " " 760D656010WD-62927 " " " 760D656030WD-73727 767D079030 491P176050 491P175050 -WD-73827 " " " -WD-73927 " " " 760D656040
MIRROR & SCREEN PARTS
CHASSIS Chassis Fan Lamp Fan DMD Fan Ballast FanRem ote Control
V29 299P288010 299P298010 299P299010 299P278020 290P122020V30 / V30+ / V31 " " " " 290P123020
MISCELLANEOUS PARTS
PAGE 49
Ref # Part # Part Name & Description [#]
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927[#] Model Legend: (a) WD-52627, (b) WD-52628, (c) WD-62627, (d) WD-62628, (e) WD-62827, (f) WD-62927, (g) WD-73727,
(h) WD-73827, (i) WD-73927Ref # Part # Part Name & Description [#]
INTEGRATED CIRCUITSIC101 266P419040 IC - M5223AFPIC102 266P419040 IC - M5223AFPIC105 276P089010 IC-C-MOS - TC7W66FU efhiIC106 276P089010 IC-C-MOS - TC7W66FUIC107 261P839010 TR-CHIP - TPCP8J01IC1501 276P212010 IC-C-MOS - UPC3221GVIC1505 271P130010 IC-C-MOS - T313R100-CG0521IC1506 271P156010 IC - MIC49150WR TRIC1507 271P072040 IC - LD29150DT18RIC1601 276P212010 IC-C-MOS - UPC3221GV efhiIC1606 271P156010 IC - MIC49150WR TR efhiIC1607 271P072040 IC - LD29150DT18R efhiIC2000 276P203010 IC-C-MOS - SiI9021CTU144IC2001 275P981010 IC-C-MOS - 24LCS22AT/SNIC2002 271P172010 IC - CM1213-04MSIC2003 271P172010 IC - CM1213-04MSIC2101 275P981010 IC-C-MOS - 24LCS22AT/SNIC2102 271P172010 IC - CM1213-04MSIC2103 271P172010 IC - CM1213-04MSIC2401 276P109010 IC-C-MOS - CS4334-KSIC2600 271P152010 IC-C-MOS - MAX7454UUP+IC2C01 276P020010 IC-C-MOS - SN74LVC2G14DBVR efhiIC2C02 276P064010 IC-C-MOS - SN74LVC1G125DBVIC2C03 276P064010 IC-C-MOS - SN74LVC1G125DBVIC2C04 275P989010 IC-C-MOS - MAX3223ECAP efhiIC2K01 271P139010 IC - AN15865AIC2K02 271P139010 IC - AN15865AIC2K03 272P951010 IC - BA7046FIC2K04 276P237010 IC-C-MOS - SN74HC4066PWRIC3E00 271P080010 IC - TDA8922JIC3E01 271P138010 IC - LV1115IC3J01 271P140010 IC - MM1631XJBEIC3J02 270P838010 IC-C-MOS - NJM2520MIC3J03 270P838010 IC-C-MOS - NJM2520MIC3J04 271P078010 IC - MM1566AJBEIC7A00 276P244030 IC-C-MOS - M306V7FGFP#U0-V281IC7A01 271P023010 IC - SN74CBTD1G125DBVRIC7A02 270P706020 IC - MAX823REUKIC7A03 275P786010 IC-C-MOS - TC7SA08FUIC7A29 271P023010 IC - SN74CBTD1G125DBVRIC7C81 271P081010 IC - BA00CC0WFPIC7E00 276P238010 IC-C-MOS - SN74LVC14APWRIC7E01 276P197010 IC-C-MOS - AD9981KST-80IC7E03 270P992010 IC - BA18BC0FPIC7E05 270P992030 IC - BA33BC0FP-E2IC7E06 276P237010 IC-C-MOS - SN74HC4066PWRIC7EA1 267P176020 HIC - AF-1477IC7EB0 276P146010 IC-C-MOS - CS5340-CZRIC7EB1 270P938010 IC - MC33202DIC7G01 275P982020 IC-C-MOS - MT48LC2M32B2P-7IC7G02 270P348010 IC - TLC2932IPWIC7G03 270P992030 IC - BA33BC0FP-E2IC7G04 275P236020 IC-C-MOS - TC74LVX244FTIC7G05 274P901010 IC-C-MOS - TC74HCT7007AFIC7G06 270P879030 IC - SC1566I5M-2.5TRIC7G07 275P982020 IC-C-MOS - MT48LC2M32B2P-7IC7G08 276P194010 IC-C-MOS - MB87S1270PB-ESIC7K21 270P831010 IC-C-MOS - OPA2350PA
IC7P01 276P204020 IC-C-MOS - PIC18F2510I/SOIC7P02 276P064010 IC-C-MOS - SN74LVC1G125DBVIC7P03 263P154010 IC-C-MOS - SN74HC132DBIC7P04 271P023010 IC - SN74CBTD1G125DBVRIC7P05 276P064010 IC-C-MOS - SN74LVC1G125DBVIC7R01 276P281010 IC-C-MOS - SN74LVC2GU04DBVRIC7R02 275P443010 IC-C-MOS - TC7SET08HIC7R03 270P706010 IC - MAX823IC7R04 271P023010 IC - SN74CBTD1G125DBVRIC7R05 276P108030 IC-C-MOS - M306H2FCFP-V261IC7R06 271P023010 IC - SN74CBTD1G125DBVRIC7R07 271P023010 IC - SN74CBTD1G125DBVRIC7R08 276P064010 IC-C-MOS - SN74LVC1G125DBVIC7R09 276P064010 IC-C-MOS - SN74LVC1G125DBVIC8001 276P030030 IC-C-MOS - 215H31AGA12HIC8002 270P706020 IC - MAX823REUKIC8003 276P064010 IC-C-MOS - SN74LVC1G125DBVIC8004 276P064010 IC-C-MOS - SN74LVC1G125DBVIC8006 270P880010 IC - 24LC64I/SNIC8008 276P214010 IC-C-MOS - SN74LVC2G125DCURIC8009 276P064010 IC-C-MOS - SN74LVC1G125DBVIC80E1 275P657050 IC-C-MOS - 24LC256T-I/SNIC80E2 271P150010 IC - 24LC512T-I/SMIC80E3 270P880010 IC - 24LC64I/SNIC8101 271P033010 IC - LP2996MRXIC8102 276P029030 IC-C-MOS - NT5DS16M16CS-5T acIC8103 276P029030 IC-C-MOS - NT5DS16M16CS-5T acIC8104 276P029030 IC-C-MOS - NT5DS16M16CS-5T acIC8105 276P029030 IC-C-MOS - NT5DS16M16CS-5T acIC8205 276P042010 IC-C-MOS - MIC2544-1BMIC8211 276P029030 IC-C-MOS - NT5DS16M16CS-5T acIC8212 276P029030 IC-C-MOS - NT5DS16M16CS-5T acIC8280 276P215010 IC-C-MOS - DS1337U+T&RIC8301 275P677010 IC-C-MOS - SN74LVC573APWRIC8303 275P677010 IC-C-MOS - SN74LVC573APWRIC8304 275P956030 IC-C-MOS - MD5811-D256-V3Q18-PIC8305 275P677010 IC-C-MOS - SN74LVC573APWRIC8306 276P198010 IC-C-MOS - MAS3507D-QGIC8307 276P199010 IC-C-MOS - ST16C654CQ64TR-FIC8308 275P677010 IC-C-MOS - SN74LVC573APWRIC8309 275P464010 IC-C-MOS - TC7WH14FKIC8310 276P064010 IC-C-MOS - SN74LVC1G125DBVIC8311 275P913010 IC-C-MOS - SN74LVC257APWRIC8312 276P148030 IC-C-MOS - LC4128V-75TN100CS3248IC8313 276P200010 IC-C-MOS - CS4344-CZZIC8314 276P200010 IC-C-MOS - CS4344-CZZIC8315 270P938010 IC - MC33202DIC8316 270P938010 IC - MC33202DIC8317 276P239010 IC-C-MOS - SN74LVC74APWRIC8401 276P193010 IC-C-MOS - MN864620 acIC8402 276P246010 IC-C-MOS - M12L16161A-7TIC8403 275P686010 IC-C-MOS - TSB41AB3PFPIC8403 275P686010 IC-C-MOS - TSB41AB3PFP acIC8404 271P155010 IC - MM1661FTRE acIC8501 276P202020 IC-C-MOS - ICS443M-20LFTIC8502 275P124040 IC-C-MOS - SN74LVC245APWRIC8503 275P677010 IC-C-MOS - SN74LVC573APWRIC8505 275P677010 IC-C-MOS - SN74LVC573APWRIC8506 276P065030 IC-C-MOS - CIMAX SP2 PBFIC8507 275P913010 IC-C-MOS - SN74LVC257APWR
Ref # Part # Part Name & Description [#]
PAGE 50
Ref # Part # Part Name & Description [#]
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927[#] Model Legend: (a) WD-52627, (b) WD-52628, (c) WD-62627, (d) WD-62628, (e) WD-62827, (f) WD-62927, (g) WD-73727,
(h) WD-73827, (i) WD-73927
IC8508 275P675010 IC-C-MOS - SN74LV125APWRIC8510 275P464010 IC-C-MOS - TC7WH14FKIC8511 271P171010 IC - MIC2040-1YMMIC8512 271P171010 IC - MIC2040-1YMMIC8513 271P171010 IC - MIC2040-1YMMIC8600 275P980010 IC-C-MOS - SAA7115HL efhiIC8601 275P982020 IC-C-MOS - MT48LC2M32B2P-7 efhiIC8602 276P111010 IC-C-MOS - AK5353VT efhiIC8603 276P112010 IC-C-MOS - BCM7040 KQL efhiIC8604 270P992010 IC - BA18BC0FP efhiIC8A00 271P131010 IC - AD9888KSZ-100 abcdeghIC8A00 271P131030 IC - AD9888KSZ-170 fiIC8A01 276P018020 IC-C-MOS - SN74LVC157APWRIC8A02 276P217010 IC-C-MOS - SN74LVT245BPWRIC8A03 275P981010 IC-C-MOS - 24LCS22AT/SN fiIC8E01 271P133010 IC - MB8751340PB-ESIC8E03 276P251010 IC-C-MOS - EDS6432AFTA-6BEIC8F01 271P148010 IC - Sil116OCTUIC8G01 276P210030 IC-C-MOS - M30833FJFP#U5-V291IC8G02 275P657050 IC-C-MOS - 24LC256T-I/SNIC8G05 271P149010 IC-C-MOS - M62368GP#CFOJIC8G07 276P064010 IC-C-MOS - SN74LVC1G125DBVIC8G08 276P214010 IC-C-MOS - SN74LVC2G125DCURIC8G09 276P213010 IC-C-MOS - SN74LVC1G17-DCKRIC8K01 271P132010 IC - MB87S1330PB-GE1IC8K02 275P982030 IC-C-MOS - MT48LC2M32B2P-5 fiIC8K02 276P251010 IC-C-MOS - EDS6432AFTA-6BE abcdeghIC8K03 275P982030 IC-C-MOS - MT48LC2M32B2P-5 fiIC8K03 276P251010 IC-C-MOS - EDS6432AFTA-6BE abcdeghIC9A10 267P175010 HIC - STR-W6735
IC9A22 271P147010 IC - NJM2374AMIC9A23 271P145010 IC - BD9702T-V5IC9A25 271P081010 IC - BA00CC0WFP efhiIC9C00 271P071020 IC - BA09SFPIC9C10 271P071020 IC - BA09SFPIC9C20 270P677020 IC - BA05FPIC9C51 271P072020 IC - LD29150DT33IC9C71 271P071010 IC - BA033SFPIC9C81 271P072040 IC - LD29150DT18RIC9F00 271P141010 IC - TPS40071PWPRIC9G01 271P141010 IC - TPS40071PWPRIC9G21 271P141010 IC - TPS40071PWPRIC9G22 270P879030 IC - SC1566I5M-2.5TRIC9G23 271P072040 IC - LD29150DT18RIC9G24 270P879030 IC - SC1566I5M-2.5TRIC9G41 271P141010 IC - TPS40071PWPRIC9G70 270P992050 IC - BA90BC0FP-E2IC9H01 270P992010 IC - BA18BC0FPIC9H02 270P992030 IC - BA33BC0FP-E2IC9H03 270P879020 IC - SC1566I5M-1.8.TRIC9H04 270P992030 IC - BA33BC0FP-E2IC9H05 270P992030 IC - BA33BC0FP-E2IC9J01 276P238010 IC-C-MOS - SN74LVC14APWRIC9J02 276P238010 IC-C-MOS - SN74LVC14APWRIC9J03 270P884010 IC - SI-8050JDIC9J04 270P884010 IC - SI-8050JDIC9J05 270P884010 IC - SI-8050JD
TRANSISTORSCHIP Type Transistors (Listed by Part No.)Part No. Description261P837010 UPA672T261P839010 TPCP8J01261P842020 2SC3052-T112-1F261P842030 2SC3052-T112-1G abcdg261P842080 2SC3052-T112-1E;F261P843010 2SA1235A-T112-1E261P843020 2SA1235-T112-1F261P843080 2SA1235-T112-1E;F261P844010 RT1N436C-T112-1 efhi261P845010 RT1P241C-T1112-1261P846010 TPCP8402261P851010 Si78720PT1E3261P852010 Si7336ADPT1E3261P853010 Si7390DPT1E3
TRANSISTORSConventional Transistors (By Ref #)
Ref # Part # Part Name & Description [#]Q1501 261P026020 TR - 2SC3356-T1B-AQ1502 261P026020 TR - 2SC3356-T1B-AQ1503 261P026020 TR - 2SC3356-T1B-AQ1601 261P026020 TR - 2SC3356-T1B-A efhiQ1602 261P026020 TR - 2SC3356-T1B-A efhiQ1603 261P026020 TR - 2SC3356-T1B-A efhiQ2E01 261P114010 TR - 2SA1585STPR
DIODES
D1501 262P071070 DIODE-LE - SML-210FTD1601 262P832010 D-LE-CHIP - CL-270F-CD-TS efhiD2001 262P828010 D-CHIP - MC2838-T112-1D2002 262P828010 D-CHIP - MC2838-T112-1D2003 262P828010 D-CHIP - MC2838-T112-1D2021 262P805050 D-CHIP - UDZS5.1BD2101 262P828010 D-CHIP - MC2838-T112-1D2102 262P828010 D-CHIP - MC2838-T112-1D2103 262P828010 D-CHIP - MC2838-T112-1D2121 262P805050 D-CHIP - UDZS5.1BD2E00 262P075010 DIODE - RSB6.8SD2E01 262P075010 DIODE - RSB6.8SD2J01 262P075010 DIODE - RSB6.8SD2J02 262P075010 DIODE - RSB6.8SD2J03 264P828010 D-CHIP - DAN202U/MA142WKD2J04 262P075010 DIODE - RSB6.8SD2J05 262P075010 DIODE - RSB6.8SD2J06 262P075010 DIODE - RSB6.8SD2J07 262P075010 DIODE - RSB6.8SD2J91 262P075010 DIODE - RSB6.8SD2J92 262P075010 DIODE - RSB6.8SD2J93 262P075010 DIODE - RSB6.8SD3E00 262P828010 D-CHIP - MC2838-T112-1D3E01 262P828010 D-CHIP - MC2838-T112-1D7A44 262P828010 D-CHIP - MC2838-T112-1D7A73 262P828010 D-CHIP - MC2838-T112-1D7K21 268P100010 DIODE-PHOTO - SFH235FAD7K22 262P828010 D-CHIP - MC2838-T112-1
PAGE 51
Ref # Part # Part Name & Description [#]
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927[#] Model Legend: (a) WD-52627, (b) WD-52628, (c) WD-62627, (d) WD-62628, (e) WD-62827, (f) WD-62927, (g) WD-73727,
(h) WD-73827, (i) WD-73927Ref # Part # Part Name & Description [#]
D7L20 262P075010 DIODE - RSB6.8S abcdD7L21 264P212020 D-LED - LN31GPH abcdD7L22 264P584020 DIODE-LE - SML1216W-C,D abcdD7L23 264P584020 DIODE-LE - SML1216W-C,D abcdD7L70 262P075010 DIODE - RSB6.8S efghiD7L71 264P212020 D-LED - LN31GPH efghiD7L72 264P584020 DIODE-LE - SML1216W-C,D efghiD7L73 264P584020 DIODE-LE - SML1216W-C,D efghiD8280 262P828010 D-CHIP - MC2838-T112-1D8701 264P846010 D-CHIP - MA732D8702 264P846010 D-CHIP - MA732D8703 264P846010 D-CHIP - MA732D8704 264P846010 D-CHIP - MA732D8A01 264P882010 D-CHIP - HSB123 fiD8A02 264P882010 D-CHIP - HSB123 fiD8A03 264P882010 D-CHIP - HSB123 fiD8A04 264P878020 D-CHIP - HZM6.2ZWA fiD8A05 264P878020 D-CHIP - HZM6.2ZWA fiD8G05 262P830010 D-CHIP - MC2850-T111-1D8G07 262P830010 D-CHIP - MC2850-T111-1D8G08 262P830010 D-CHIP - MC2850-T111-1D8G09 262P828010 D-CHIP - MC2838-T112-1D9A00 262P031010 DIODE - D6SB80D9A01 262P031010 DIODE - D6SB80D9A02 264P045080 DIODE - 1S2076A/1S2471OMD9A03 262P805060 D-CHIP - UDZS5.6BD9A04 264P045080 DIODE - 1S2076A/1S2471OMD9A18 264P045080 DIODE - 1S2076A/1S2471OMD9A19 264P045080 DIODE - 1S2076A/1S2471OMD9A20 264P045080 DIODE - 1S2076A/1S2471OMD9A22 262P805080 D-CHIP - UDZS6.8BD9A23 264P622010 DIODE - AL01ZD9A24 264P622010 DIODE - AL01ZD9A25 264P622010 DIODE - AL01ZD9A26 264P919010 DIODE - FCH20A10D9A31 262P129010 DIODE - 30PRA20-FC5D9A32 262P129010 DIODE - 30PRA20-FC5D9A33 264P045080 DIODE - 1S2076A/1S2471OMD9A35 264P045080 DIODE - 1S2076A/1S2471OMD9A36 264P045080 DIODE - 1S2076A/1S2471OMD9A37 264P045080 DIODE - 1S2076A/1S2471OMD9A38 262P087010 D-CHIP - EC21QS04-TE12LD9A39 262P805060 D-CHIP - UDZS5.6BD9A40 262P087010 D-CHIP - EC21QS04-TE12LD9A41 262P805020 D-CHIP - UDZS3.9BD9A42 264P045080 DIODE - 1S2076A/1S2471OMD9A43 264P045080 DIODE - 1S2076A/1S2471OMD9A44 264P846010 D-CHIP - MA732D9A45 264P045080 DIODE - 1S2076A/1S2471OMD9A47 262P805060 D-CHIP - UDZS5.6BD9E50 264P846010 D-CHIP - MA732 0efhiD9E52 262P806060 D-CHIP - UDZS13BD9E53 264P846010 D-CHIP - MA732D9E54 264P846010 D-CHIP - MA732D9F00 264P846010 D-CHIP - MA732D9F02 262P805020 D-CHIP - UDZS3.9BD9F03 262P828010 D-CHIP - MC2838-T112-1D9F04 264P846010 D-CHIP - MA732D9G01 262P090010 DIODE - M1FP3D9G02 262P805020 D-CHIP - UDZS3.9B
D9G04 262P090010 DIODE - M1FP3D9G21 262P090010 DIODE - M1FP3D9G22 262P805020 D-CHIP - UDZS3.9BD9G24 262P090010 DIODE - M1FP3D9G41 262P090010 DIODE - M1FP3D9G42 262P805020 D-CHIP - UDZS3.9BD9G44 262P090010 DIODE - M1FP3D9G70 262P828010 D-CHIP - MC2838-T112-1D9G71 262P828010 D-CHIP - MC2838-T112-1D9G72 262P806070 D-CHIP - UDZS15BD9G73 262P806080 D-CHIP - UDZS16BD9J01 264P828010 D-CHIP - DAN202U/MA142WKD9J02 264P828010 D-CHIP - DAN202U/MA142WKD9J03 264P828010 D-CHIP - DAN202U/MA142WKD9J04 264P878010 D-CHIP - HZM27WAD9J05 264P878010 D-CHIP - HZM27WAD9J06 264P878010 D-CHIP - HZM27WAD9J07 262P087010 D-CHIP - EC21QS04-TE12LD9J08 262P087010 D-CHIP - EC21QS04-TE12LD9J09 262P087010 D-CHIP - EC21QS04-TE12LD9J10 264P878010 D-CHIP - HZM27WAD9J11 264P828010 D-CHIP - DAN202U/MA142WKD9J12 264P878010 D-CHIP - HZM27WAD9J13 264P828010 D-CHIP - DAN202U/MA142WK
COILSL101 409P865080 EMI-F-CHIP - BLM18PG6 abcdgL102 409P923060 EMI-F-CHIP - BLM21B272S efhiL103 409P923060 EMI-F-CHIP - BLM21B272SL104 409P923060 EMI-F-CHIP - BLM21B272SL105 409P923060 EMI-F-CHIP - BLM21B272SL106 409P923060 EMI-F-CHIP - BLM21B272SL107 409P923060 EMI-F-CHIP - BLM21B272SL108 325C420030 COIL-CHIP - 2.2MH-ML109 409P923060 EMI-F-CHIP - BLM21B272SL110 409P923060 EMI-F-CHIP - BLM21B272SL111 409P865070 EMI-F-CHIP - BLM11P300SL112 409P865070 EMI-F-CHIP - BLM11P300SL113 409P923060 EMI-F-CHIP - BLM21B272SL114 409P865080 EMI-F-CHIP - BLM18PG6 efhiL1501 409P777080 EMI-F-CHIP - BLM21P221SL1503 325C410050 COIL-CHIP - 2.2MH-JL1508 409P865070 EMI-F-CHIP - BLM11P300SL1509 409P865070 EMI-F-CHIP - BLM11P300SL1510 409P865070 EMI-F-CHIP - BLM11P300SL1511 409P865070 EMI-F-CHIP - BLM11P300SL1512 409P865070 EMI-F-CHIP - BLM11P300SL1513 409P865070 EMI-F-CHIP - BLM11P300SL1514 409P865070 EMI-F-CHIP - BLM11P300SL1515 409P865070 EMI-F-CHIP - BLM11P300SL1516 409P865070 EMI-F-CHIP - BLM11P300SL1517 409P777080 EMI-F-CHIP - BLM21P221SL1519 409P865070 EMI-F-CHIP - BLM11P300SL1520 409P865070 EMI-F-CHIP - BLM11P300SL1521 409P865070 EMI-F-CHIP - BLM11P300SL1522 409P777080 EMI-F-CHIP - BLM21P221SL1601 409P777080 EMI-F-CHIP - BLM21P221S efhiL1603 325C410050 COIL-CHIP - 2.2MH-J efhi
Ref # Part # Part Name & Description [#]
PAGE 52
Ref # Part # Part Name & Description [#]
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927[#] Model Legend: (a) WD-52627, (b) WD-52628, (c) WD-62627, (d) WD-62628, (e) WD-62827, (f) WD-62927, (g) WD-73727,
(h) WD-73827, (i) WD-73927
L1604 409P777080 EMI-F-CHIP - BLM21P221S efhiL1608 409P865070 EMI-F-CHIP - BLM11P300S efhiL1609 409P865070 EMI-F-CHIP - BLM11P300S efhiL1612 409P865070 EMI-F-CHIP - BLM11P300S efhiL1613 409P865070 EMI-F-CHIP - BLM11P300S efhiL1615 409P865070 EMI-F-CHIP - BLM11P300S efhiL1616 409P865070 EMI-F-CHIP - BLM11P300S efhiL1617 409P777080 EMI-F-CHIP - BLM21P221S efhiL1619 409P865070 EMI-F-CHIP - BLM11P300S efhiL1620 409P865070 EMI-F-CHIP - BLM11P300S efhiL2018 409P777080 EMI-F-CHIP - BLM21P221SL2118 409P777080 EMI-F-CHIP - BLM21P221SL2201 409P777080 EMI-F-CHIP - BLM21P221SL2202 409P865020 EMI-F-CHIP - BLM11A601SL2203 409P865020 EMI-F-CHIP - BLM11A601SL2207 409P777080 EMI-F-CHIP - BLM21P221SL2213 409P777080 EMI-F-CHIP - BLM21P221SL2216 409P777080 EMI-F-CHIP - BLM21P221SL2219 409P777080 EMI-F-CHIP - BLM21P221SL2222 409P777080 EMI-F-CHIP - BLM21P221SL2235 409P777080 EMI-F-CHIP - BLM21P221SL2237 409P777080 EMI-F-CHIP - BLM21P221SL2238 409P777080 EMI-F-CHIP - BLM21P221SL2255 409P777080 EMI-F-CHIP - BLM21P221SL2287 409P777080 EMI-F-CHIP - BLM21P221SL2289 409P777080 EMI-F-CHIP - BLM21P221SL2294 409P777080 EMI-F-CHIP - BLM21P221SL2295 409P865020 EMI-F-CHIP - BLM11A601SL2296 409P865020 EMI-F-CHIP - BLM11A601SL2334 409P777080 EMI-F-CHIP - BLM21P221SL2337 409P777080 EMI-F-CHIP - BLM21P221SL2401 409P865020 EMI-F-CHIP - BLM11A601SL2402 409P865020 EMI-F-CHIP - BLM11A601SL2403 409P865020 EMI-F-CHIP - BLM11A601SL2404 409P865020 EMI-F-CHIP - BLM11A601SL2600 409P777080 EMI-F-CHIP - BLM21P221SL2C01 325C411090 COIL-CHIP - 33MH-J efhiL2C02 409P876020 EMI-F-CHIP - CNF20C470S/CKD510JB1H470SefhiL2C03 409P876020 EMI-F-CHIP - CNF20C470S/CKD510JB1H470SefhiL2C04 409P876020 EMI-F-CHIP - CNF20C470S/CKD510JB1H470SefhiL2C11 409P777080 EMI-F-CHIP - BLM21P221S acL2C11 409P777080 EMI-F-CHIP - BLM21P221SL2E00 409P876040 EMI-F-CHIP - CNF20C221S/CKD510JB1H221SL2E01 409P876040 EMI-F-CHIP - CNF20C221S/CKD510JB1H221SL2J01 409P923060 EMI-F-CHIP - BLM21B272SL2J02 409P777080 EMI-F-CHIP - BLM21P221SL2J03 409P923060 EMI-F-CHIP - BLM21B272SL2J04 409P923060 EMI-F-CHIP - BLM21B272SL2J05 409P923060 EMI-F-CHIP - BLM21B272SL2J06 409P923060 EMI-F-CHIP - BLM21B272SL2J07 409P923060 EMI-F-CHIP - BLM21B272SL2J08 409P923060 EMI-F-CHIP - BLM21B272SL2J09 409P777080 EMI-F-CHIP - BLM21P221SL2K01 409P777080 EMI-F-CHIP - BLM21P221SL2K02 409P777080 EMI-F-CHIP - BLM21P221SL2K03 409P777080 EMI-F-CHIP - BLM21P221SL2K04 409P777080 EMI-F-CHIP - BLM21P221SL2K05 325C420070 COIL-CHIP - 10MH-KL2K06 409P777080 EMI-F-CHIP - BLM21P221S
L2K07 409P777080 EMI-F-CHIP - BLM21P221SL2K08 409P777080 EMI-F-CHIP - BLM21P221SL2K09 409P777080 EMI-F-CHIP - BLM21P221SL2K10 325C420070 COIL-CHIP - 10MH-KL2K11 325C411030 COIL-CHIP - 10MH-JL2K12 325C411030 COIL-CHIP - 10MH-JL2K13 325C411030 COIL-CHIP - 10MH-JL2K14 325C411030 COIL-CHIP - 10MH-JL2K15 325C421040 COIL-CHIP - 150MH-K LOW-RL2K16 325C421040 COIL-CHIP - 150MH-K LOW-RL2M00 321C114010 COIL-RF - 2200MH-JL2M01 325C411030 COIL-CHIP - 10MH-JL2M20 325C411030 COIL-CHIP - 10MH-JL2M21 321C114010 COIL-RF - 2200MH-JL3E25 325C502010 COIL-CHIP - SLF12575T-330M3R2-HL3E26 325C502010 COIL-CHIP - SLF12575T-330M3R2-HL3E51 411D009020 CORE-FERRITE - ZBF503D-01L3E52 411D009020 CORE-FERRITE - ZBF503D-01L3E60 409P865080 EMI-F-CHIP - BLM18PG6L7A16 409P777050 EMI-F-CHIP - BLM21B201SL7A73 409P865060 EMI-F-CHIP - BLM11B141SL7A89 409P777050 EMI-F-CHIP - BLM21B201SL7A99 409P777050 EMI-F-CHIP - BLM21B201SL7C84 409P865080 EMI-F-CHIP - BLM18PG6L7E00 325C420070 COIL-CHIP - 10MH-KL7E01 325C420070 COIL-CHIP - 10MH-KL7E02 409P777080 EMI-F-CHIP - BLM21P221SL7E03 409P865090 EMI-F-CHIP - BLM11A121SL7E04 409P865090 EMI-F-CHIP - BLM11A121SL7E05 409P865090 EMI-F-CHIP - BLM11A121SL7E06 409P865090 EMI-F-CHIP - BLM11A121SL7E13 409P865080 EMI-F-CHIP - BLM18PG6L7E17 409P777080 EMI-F-CHIP - BLM21P221SL7E18 409P777080 EMI-F-CHIP - BLM21P221SL7E19 409P777080 EMI-F-CHIP - BLM21P221SL7EA0 325C420070 COIL-CHIP - 10MH-KL7EB0 325C420070 COIL-CHIP - 10MH-KL7EB1 409P777080 EMI-F-CHIP - BLM21P221SL7EB2 409P777080 EMI-F-CHIP - BLM21P221SL7G01 325C420070 COIL-CHIP - 10MH-KL7G02 409P865080 EMI-F-CHIP - BLM18PG6L7G03 409P777080 EMI-F-CHIP - BLM21P221SL7G04 409P865080 EMI-F-CHIP - BLM18PG6L7G05 409P777080 EMI-F-CHIP - BLM21P221SL7G06 409P777080 EMI-F-CHIP - BLM21P221SL7G07 409P865080 EMI-F-CHIP - BLM18PG6L7G08 409P865080 EMI-F-CHIP - BLM18PG6L7G09 409P865080 EMI-F-CHIP - BLM18PG6L7G10 409P777080 EMI-F-CHIP - BLM21P221SL7G11 409P865080 EMI-F-CHIP - BLM18PG6L7G12 409P865020 EMI-F-CHIP - BLM11A601SL7G13 409P865080 EMI-F-CHIP - BLM18PG6L7K01 409P777080 EMI-F-CHIP - BLM21P221SL7P00 409P923060 EMI-F-CHIP - BLM21B272SL7P14 409P777050 EMI-F-CHIP - BLM21B201SL7P20 409P777050 EMI-F-CHIP - BLM21B201SL7R01 409P777080 EMI-F-CHIP - BLM21P221SL7R02 409P777080 EMI-F-CHIP - BLM21P221SL7T01 409P777080 EMI-F-CHIP - BLM21P221S acL7T01 409P777080 EMI-F-CHIP - BLM21P221S
PAGE 53
Ref # Part # Part Name & Description [#]
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927[#] Model Legend: (a) WD-52627, (b) WD-52628, (c) WD-62627, (d) WD-62628, (e) WD-62827, (f) WD-62927, (g) WD-73727,
(h) WD-73827, (i) WD-73927Ref # Part # Part Name & Description [#]
L7T02 351P265010 COIL-CHOKE-CHIP - ACM2012 acL7T02 351P265010 COIL-CHOKE-CHIP - ACM2012L7T03 409P777080 EMI-F-CHIP - BLM21P221S acL7T03 409P777080 EMI-F-CHIP - BLM21P221SL7T04 409P777080 EMI-F-CHIP - BLM21P221S acL7T05 351P265010 COIL-CHOKE-CHIP - ACM2012 acL7T06 409P777080 EMI-F-CHIP - BLM21P221S acL7T07 409P865060 EMI-F-CHIP - BLM11B141S abcdgL7T07 409P865060 EMI-F-CHIP - BLM11B141S acefhiL7T08 409P865060 EMI-F-CHIP - BLM11B141S abcdgL7T08 409P865060 EMI-F-CHIP - BLM11B141S acefhiL7T09 409P865060 EMI-F-CHIP - BLM11B141S abcdgL7T09 409P865060 EMI-F-CHIP - BLM11B141S acefhiL7T10 409P865060 EMI-F-CHIP - BLM11B141S abcdgL7T10 409P865060 EMI-F-CHIP - BLM11B141S acefhiL7T11 409P865060 EMI-F-CHIP - BLM11B141S abcdgL7T11 409P865060 EMI-F-CHIP - BLM11B141S acefhiL7T12 409P865060 EMI-F-CHIP - BLM11B141S abcdgL7T12 409P865060 EMI-F-CHIP - BLM11B141S acefhiL7T13 409P865060 EMI-F-CHIP - BLM11B141S abcdgL7T13 409P865060 EMI-F-CHIP - BLM11B141S acefhiL7T14 409P865060 EMI-F-CHIP - BLM11B141S abcdgL7T14 409P865060 EMI-F-CHIP - BLM11B141S acefhiL7T15 409P865060 EMI-F-CHIP - BLM11B141S abcdgL7T15 409P865060 EMI-F-CHIP - BLM11B141S acefhiL7T16 409P865060 EMI-F-CHIP - BLM11B141S abcdgL7T16 409P865060 EMI-F-CHIP - BLM11B141S acefhiL7T17 409P865060 EMI-F-CHIP - BLM11B141S abcdgL7T17 409P865060 EMI-F-CHIP - BLM11B141S acefhiL7T18 409P865060 EMI-F-CHIP - BLM11B141S abcdgL7T18 409P865060 EMI-F-CHIP - BLM11B141S acefhiL7T19 409P865060 EMI-F-CHIP - BLM11B141S abcdgL7T19 409P865060 EMI-F-CHIP - BLM11B141S acefhiL7T20 409P865060 EMI-F-CHIP - BLM11B141S acL7T21 409P865060 EMI-F-CHIP - BLM11B141S abcdgL7T21 409P865060 EMI-F-CHIP - BLM11B141S acefhiL7T22 409P865060 EMI-F-CHIP - BLM11B141S abcdgL7T22 409P865060 EMI-F-CHIP - BLM11B141S acefhiL7T23 409P865060 EMI-F-CHIP - BLM11B141S abcdgL7T23 409P865060 EMI-F-CHIP - BLM11B141S acefhiL7T24 409P865060 EMI-F-CHIP - BLM11B141S abcdgL7T24 409P865060 EMI-F-CHIP - BLM11B141S acefhiL7T26 409P865060 EMI-F-CHIP - BLM11B141S abcdgL7T26 409P865060 EMI-F-CHIP - BLM11B141S acefhiL7T27 409P865060 EMI-F-CHIP - BLM11B141S abcdgL7T27 409P865060 EMI-F-CHIP - BLM11B141S acefhiL7T28 409P865060 EMI-F-CHIP - BLM11B141S abcdgL7T28 409P865060 EMI-F-CHIP - BLM11B141S acefhiL7T29 409P865060 EMI-F-CHIP - BLM11B141S efhiL7T30 409P865060 EMI-F-CHIP - BLM11B141S abcdgL7T30 409P865060 EMI-F-CHIP - BLM11B141S acefhiL8001 409P865080 EMI-F-CHIP - BLM18PG6L8002 409P865080 EMI-F-CHIP - BLM18PG6L8003 409P865080 EMI-F-CHIP - BLM18PG6L8004 409P865080 EMI-F-CHIP - BLM18PG6L8005 409P865080 EMI-F-CHIP - BLM18PG6L8006 409P865080 EMI-F-CHIP - BLM18PG6L8007 409P865080 EMI-F-CHIP - BLM18PG6L8008 409P865080 EMI-F-CHIP - BLM18PG6L8009 409P777080 EMI-F-CHIP - BLM21P221S
L8011 409P865080 EMI-F-CHIP - BLM18PG6L8012 409P865080 EMI-F-CHIP - BLM18PG6L8013 409P865080 EMI-F-CHIP - BLM18PG6L8280 409P865080 EMI-F-CHIP - BLM18PG6L8301 409P865080 EMI-F-CHIP - BLM18PG6L8306 409P865080 EMI-F-CHIP - BLM18PG6L8307 409P865080 EMI-F-CHIP - BLM18PG6L8308 409P865080 EMI-F-CHIP - BLM18PG6L8309 409P865080 EMI-F-CHIP - BLM18PG6L8310 409P865080 EMI-F-CHIP - BLM18PG6L8311 409P865080 EMI-F-CHIP - BLM18PG6L8312 409P865080 EMI-F-CHIP - BLM18PG6L8313 409P865080 EMI-F-CHIP - BLM18PG6L8314 409P865080 EMI-F-CHIP - BLM18PG6L8315 409P865080 EMI-F-CHIP - BLM18PG6L8317 409P865080 EMI-F-CHIP - BLM18PG6L8318 409P865080 EMI-F-CHIP - BLM18PG6L8319 409P865080 EMI-F-CHIP - BLM18PG6L8320 409P865080 EMI-F-CHIP - BLM18PG6L8321 409P865080 EMI-F-CHIP - BLM18PG6L8322 409P865090 EMI-F-CHIP - BLM11A121SL83A1 409P865080 EMI-F-CHIP - BLM18PG6L83B3 325C501010 COIL-CHIP - ALQM21NNR47K10L8401 351P265020 COIL-CHIP - ACM2012-201-2P 0acL8402 351P265020 COIL-CHIP - ACM2012-201-2P 0acL8403 409P777080 EMI-F-CHIP - BLM21P221S acL8404 409P777080 EMI-F-CHIP - BLM21P221S acL8405 351P284010 COIL-CHOKE-CHIP - TCM1210-201-2P-T000L8406 351P284010 COIL-CHOKE-CHIP - TCM1210-201-2P-T000L8413 351P265020 COIL-CHIP - ACM2012-201-2P 0acL8414 351P265020 COIL-CHIP - ACM2012-201-2P 0acL8415 351P265020 COIL-CHIP - ACM2012-201-2P 0acL8416 351P265020 COIL-CHIP - ACM2012-201-2P 0acL8501 409P865080 EMI-F-CHIP - BLM18PG6L8502 409P777080 EMI-F-CHIP - BLM21P221SL8503 409P865080 EMI-F-CHIP - BLM18PG6L8504 409P865090 EMI-F-CHIP - BLM11A121SL8505 409P865080 EMI-F-CHIP - BLM18PG6L8507 409P865080 EMI-F-CHIP - BLM18PG6L8508 409P865080 EMI-F-CHIP - BLM18PG6L8509 409P865080 EMI-F-CHIP - BLM18PG6L8510 409P865090 EMI-F-CHIP - BLM11A121SL8511 409P865090 EMI-F-CHIP - BLM11A121SL8512 409P865090 EMI-F-CHIP - BLM11A121SL8600 409P777080 EMI-F-CHIP - BLM21P221S efhiL8601 409P777080 EMI-F-CHIP - BLM21P221S efhiL8602 409P777080 EMI-F-CHIP - BLM21P221S efhiL8603 409P777080 EMI-F-CHIP - BLM21P221S efhiL8604 409P777080 EMI-F-CHIP - BLM21P221S efhiL8605 409P777080 EMI-F-CHIP - BLM21P221S efhiL8606 409P777080 EMI-F-CHIP - BLM21P221S efhiL8607 409P777080 EMI-F-CHIP - BLM21P221S efhiL8608 409P777080 EMI-F-CHIP - BLM21P221S efhiL8609 325C420070 COIL-CHIP - 10MH-K efhiL8610 409P777080 EMI-F-CHIP - BLM21P221S efhiL8611 409P777080 EMI-F-CHIP - BLM21P221S efhiL8A01 409P777080 EMI-F-CHIP - BLM21P221SL8A02 409P777080 EMI-F-CHIP - BLM21P221SL8A03 409P777080 EMI-F-CHIP - BLM21P221SL8A07 409P865040 EMI-F-CHIP - BLM11B050SA fi
Ref # Part # Part Name & Description [#]
PAGE 54
Ref # Part # Part Name & Description [#]
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927[#] Model Legend: (a) WD-52627, (b) WD-52628, (c) WD-62627, (d) WD-62628, (e) WD-62827, (f) WD-62927, (g) WD-73727,
(h) WD-73827, (i) WD-73927
L8A08 409P865040 EMI-F-CHIP - BLM11B050SA fiL8A09 409P865040 EMI-F-CHIP - BLM11B050SA fiL8A10 409P865040 EMI-F-CHIP - BLM11B050SA fiL8A11 409P865040 EMI-F-CHIP - BLM11B050SA fiL8A12 409P865060 EMI-F-CHIP - BLM11B141S fiL8A13 409P865060 EMI-F-CHIP - BLM11B141S fiL8A16 409P865040 EMI-F-CHIP - BLM11B050SAL8A17 409P865040 EMI-F-CHIP - BLM11B050SAL8A18 409P865040 EMI-F-CHIP - BLM11B050SAL8A19 409P865040 EMI-F-CHIP - BLM11B050SAL8A20 409P865040 EMI-F-CHIP - BLM11B050SAL8A21 409P777080 EMI-F-CHIP - BLM21P221SL8E01 409P777080 EMI-F-CHIP - BLM21P221SL8E05 409P777080 EMI-F-CHIP - BLM21P221SL8F01 409P777080 EMI-F-CHIP - BLM21P221SL8F02 409P777080 EMI-F-CHIP - BLM21P221SL8F03 409P777080 EMI-F-CHIP - BLM21P221SL8F04 409P777080 EMI-F-CHIP - BLM21P221SL8F05 409P777080 EMI-F-CHIP - BLM21P221SL8F06 409P865060 EMI-F-CHIP - BLM11B141SL8F07 409P865060 EMI-F-CHIP - BLM11B141SL8F08 409P865060 EMI-F-CHIP - BLM11B141SL8F09 409P865060 EMI-F-CHIP - BLM11B141SL8F10 409P865060 EMI-F-CHIP - BLM11B141SL8F11 409P865060 EMI-F-CHIP - BLM11B141SL8F12 409P865060 EMI-F-CHIP - BLM11B141SL8G01 409P777080 EMI-F-CHIP - BLM21P221SL8G02 409P777080 EMI-F-CHIP - BLM21P221SL8G05 409P777080 EMI-F-CHIP - BLM21P221SL8G06 409P777080 EMI-F-CHIP - BLM21P221SL8G10 409P865060 EMI-F-CHIP - BLM11B141SL8G11 409P865060 EMI-F-CHIP - BLM11B141SL8G12 409P865060 EMI-F-CHIP - BLM11B141SL8G13 409P865060 EMI-F-CHIP - BLM11B141SL8G14 409P865060 EMI-F-CHIP - BLM11B141SL8G15 409P865060 EMI-F-CHIP - BLM11B141SL8G16 409P865060 EMI-F-CHIP - BLM11B141SL8G17 409P865060 EMI-F-CHIP - BLM11B141SL8G18 409P865060 EMI-F-CHIP - BLM11B141SL8G19 409P865060 EMI-F-CHIP - BLM11B141SL8G30 409P865060 EMI-F-CHIP - BLM11B141SL8G32 409P865060 EMI-F-CHIP - BLM11B141SL8G33 409P865060 EMI-F-CHIP - BLM11B141SL8K00 409P777080 EMI-F-CHIP - BLM21P221SL8K01 409P777080 EMI-F-CHIP - BLM21P221SL8K02 409P777080 EMI-F-CHIP - BLM21P221SL8K03 409P777080 EMI-F-CHIP - BLM21P221SL9A10 321C151070 COIL-RF - 22MH-KL9A19 321C141010 COIL-RF - 6.8MH-ML9A20 321C141030 COIL-RF - 10MH-KL9A21 321C141030 COIL-RF - 10MH-KL9A30 321C141010 COIL-RF - 6.8MH-ML9A31 321C140060 COIL-RF - 2.7MH-ML9A32 321C140060 COIL-RF - 2.7MH-ML9A33 351P276040 COIL-CHOKE-CHIP - GSRH125-4R0ML9A34 321C141070 COIL-RF - 22MH-KL9A35 321C141010 COIL-RF - 6.8MH-ML9A36 321C141070 COIL-RF - 22MH-KL9A37 351P277090 COIL-CHOKE-CHIP - GSRH127-221ML9A38 321C141070 COIL-RF - 22MH-K
L9A39 351P277060 COIL-CHOKE-CHIP - GSRH127-470ML9A40 321C141030 COIL-RF - 10MH-KL9A43 321C141070 COIL-RF - 22MH-KL9A50 321C141070 COIL-RF - 22MH-KL9A51 321C141070 COIL-RF - 22MH-K efhiL9A52 321C141070 COIL-RF - 22MH-K efhiL9A53 321C141070 COIL-RF - 22MH-KL9A54 321C141070 COIL-RF - 22MH-KL9A55 321C141030 COIL-RF - 10MH-K 0efhiL9A56 321C141030 COIL-RF - 10MH-K 0efhiL9A60 321C141030 COIL-RF - 10MH-K 0efhiL9A61 321C141030 COIL-RF - 10MH-K 0efhiL9A62 351P277030 COIL-CHOKE-CHIP - GSRH127-7R6ML9A63 321C140060 COIL-RF - 2.7MH-M 0efhiL9A64 321C140060 COIL-RF - 2.7MH-M 0efhiL9C51 409P777080 EMI-F-CHIP - BLM21P221SL9C81 409P777080 EMI-F-CHIP - BLM21P221SL9D00 351P268010 LINE-FILTER - HF3545-502Y5R0-TXXBHL9D02 351P266020 LINE-FILTER - ELF22V025AL9D03 351P286010 LINE-FILTER - HF2836-353Y1R0-T01L9E20 409P865080 EMI-F-CHIP - BLM18PG6 efhiL9F00 321C140060 COIL-RF - 2.7MH-ML9F01 351P282040 COIL-CHOKE-CHIP - GSRH129-4R0M01L9F02 321C140030 COIL-RF - 1.5MH-ML9F03 321C140030 COIL-RF - 1.5MH-ML9F04 321C140030 COIL-RF - 1.5MH-ML9G01 321C141070 COIL-RF - 22MH-K abcdeghL9G01 321C141070 COIL-RF - 22MH-K fiL9G02 351P276040 COIL-CHOKE-CHIP - GSRH125-4R0ML9G03 321C140060 COIL-RF - 2.7MH-M abcdeghL9G03 321C140060 COIL-RF - 2.7MH-M fiL9G04 321C140060 COIL-RF - 2.7MH-M abcdeghL9G04 321C140060 COIL-RF - 2.7MH-M fiL9G21 321C141030 COIL-RF - 10MH-K abcdeghL9G21 321C141030 COIL-RF - 10MH-K fiL9G22 351P276040 COIL-CHOKE-CHIP - GSRH125-4R0ML9G23 321C141010 COIL-RF - 6.8MH-M abcdeghL9G23 321C141010 COIL-RF - 6.8MH-M fiL9G24 321C141010 COIL-RF - 6.8MH-M abcdeghL9G24 321C141010 COIL-RF - 6.8MH-M fiL9G25 321C141010 COIL-RF - 6.8MH-M abcdeghL9G25 321C141010 COIL-RF - 6.8MH-M fiL9G41 321C141070 COIL-RF - 22MH-K abcdeghL9G41 321C141070 COIL-RF - 22MH-K fiL9G42 351P277030 COIL-CHOKE-CHIP - GSRH127-7R6ML9G43 321C140060 COIL-RF - 2.7MH-M abcdeghL9G43 321C140060 COIL-RF - 2.7MH-M fiL9G44 321C140060 COIL-RF - 2.7MH-M abcdeghL9G44 321C140060 COIL-RF - 2.7MH-M fiL9G70 409P777080 EMI-F-CHIP - BLM21P221SL9H01 409P777080 EMI-F-CHIP - BLM21P221SL9H02 409P777080 EMI-F-CHIP - BLM21P221SL9J01 351P244010 COIL-CHOKE - CD-C-1010-101L9J02 351P244010 COIL-CHOKE - CD-C-1010-101L9J03 351P244010 COIL-CHOKE - CD-C-1010-101L9J04 321C142030 COIL-RF - 68MH-KL9J05 321C142030 COIL-RF - 68MH-KL9J06 321C142030 COIL-RF - 68MH-KLC8701 409P945010 EMI-F-CHIP - NFL21SP506X13CDLC8702 409P945010 EMI-F-CHIP - NFL21SP506X13CD
PAGE 55
Ref # Part # Part Name & Description [#]
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927[#] Model Legend: (a) WD-52627, (b) WD-52628, (c) WD-62627, (d) WD-62628, (e) WD-62827, (f) WD-62927, (g) WD-73727,
(h) WD-73827, (i) WD-73927Ref # Part # Part Name & Description [#]
LC8703 409P944010 EMI-F-CHIP - NFL21SP107X1LC8704 409P944010 EMI-F-CHIP - NFL21SP107X1LC8705 409P944010 EMI-F-CHIP - NFL21SP107X1LC8706 409P944010 EMI-F-CHIP - NFL21SP107X1LC8707 409P945010 EMI-F-CHIP - NFL21SP506X13CDLC8708 409P945010 EMI-F-CHIP - NFL21SP506X13CDLC8709 409P945010 EMI-F-CHIP - NFL21SP506X13CDLC8710 409P945010 EMI-F-CHIP - NFL21SP506X13CDLC8711 409P945010 EMI-F-CHIP - NFL21SP506X13CDLC8712 409P945010 EMI-F-CHIP - NFL21SP506X13CDLC8713 409P944010 EMI-F-CHIP - NFL21SP107X1LC8714 409P945010 EMI-F-CHIP - NFL21SP506X13CDLC8715 409P945010 EMI-F-CHIP - NFL21SP506X13CDLC8716 409P944010 EMI-F-CHIP - NFL21SP107X1LC8717 409P944010 EMI-F-CHIP - NFL21SP107X1LC8718 409P944010 EMI-F-CHIP - NFL21SP107X1LC8719 409P944010 EMI-F-CHIP - NFL21SP107X1LC8720 409P945010 EMI-F-CHIP - NFL21SP506X13CDLC8721 409P945010 EMI-F-CHIP - NFL21SP506X13CDLC8722 409P945010 EMI-F-CHIP - NFL21SP506X13CDLC8723 409P945010 EMI-F-CHIP - NFL21SP506X13CDLC8724 409P945010 EMI-F-CHIP - NFL21SP506X13CDLC8725 409P945010 EMI-F-CHIP - NFL21SP506X13CDT2001 409P961010 CHIP-FILTER - ACM2012D-9002PT2002 409P961010 CHIP-FILTER - ACM2012D-9002PT2003 409P961010 CHIP-FILTER - ACM2012D-9002PT2004 409P961010 CHIP-FILTER - ACM2012D-9002PT2101 409P961010 CHIP-FILTER - ACM2012D-9002PT2102 409P961010 CHIP-FILTER - ACM2012D-9002PT2103 409P961010 CHIP-FILTER - ACM2012D-9002PT2104 409P961010 CHIP-FILTER - ACM2012D-9002P
TRANSFORMERST9A10 350P833010 TRANS-PWR - SRW42EC-U15V117
VARIABLE RESISTORSRV9D00 265P100020 VAR - ERZV10D271CSRV9D01 265P100020 VAR - ERZV10D271CS
RESISTORSCHIP Type Resistors (Listed by Value)
Part No. Value Part No. Value103P509050 1/16W 0OHM 103P502050 1/16W 1K-J103P409050 1/8W 0OHM 103P504090 1/16W 100K-J103P408040 1/10W 2.2-J 103P497050 1/16W 120K-F103P508040 1/16W 2.2-J 103P505000 1/16W 120K-J103P488080 1/4W 4.7-J 103P497080 1/16W 160K-F103P409000 1/10W 6.8-J 103P497090 1/16W 180K-F103P500010 1/16W 10-J 103P505020 1/16W 180K-J103P400020 1/10W 12-J 103P505030 1/16W 220K-J103P400050 1/10W 22-J 103P498020 1/16W 240K-F103P500050 1/16W 22-J 103P498050 1/16W 330K-F103P910050 1/16W 22-Jx4 103P505060 1/16W 390K-J103P500060 1/16W 27-J 103P505070 1/16W 470K-J103P500070 1/16W 33-J 103P499010 1/16W 560K-F103P910070 1/16W 33-Jx4 103P506000 1/16W 820K-J103P793080 1/16W 36F 103P506010 1/16W 1M-J103P500080 1/16W 39-J 103P813020 1/16W 2K-D103P910090 1/16W 47-J 103P493020 1/16W 2K-F
Part No. Value Part No. Value103P400090 1/10W 47-J 103P493030 1/16W 2.2K-F103P794010 1/16W 47-F 103P502090 1/16W 2.2K-J103P500090 1/16W 47-J 103P493050 1/16W 2.7K-F103P401000 1/10W 56-J 103P503000 1/16W 2.7K-J103P844030 1/16W 56-D 103P493060 1/16W 3K-F103P501000 1/16W 56-J 103P493070 1/16W 3.3K-F103P911000 1/16W 56-Jx4 103P503010 1/16W 3.3K-J103P501010 1/16W 68-J 103P493080 1/16W 3.6K-F103P794060 1/16W 75-F 103P493090 1/16W 3.9K-F103P509090 1/16W 75-J 103P503020 1/16W 3.9K-J103P489090 1/4W 75-J 103P494000 1/16W 4.3K-F103P794070 1/16W 82-F 103P494010 1/16W 4.7K-F103P501020 1/16W 82-J 103P503030 1/16W 4.7K-J103P490010 1/16W 100F 103P494020 1/16W 5.1K-F103P501030 1/16W 100-J 103P494030 1/16W 5.6K-F103P401030 1/10W 100-J 103P503040 1/16W 5.6K-J103P401050 1/10W 150-J 103P814040 1/16W 6.2K-D103P810050 1/16W 150-D 103P494050 1/16W 6.8K-F103P501050 1/16W 150-J 103P494070 1/16W 8.2K-F103P490080 1/16W 200-F 103P503060 1/16W 8.2K-J103P490090 1/16W 220-F 103P494080 1/16W 9.1K-F103P501070 1/16W 220-J 103P474060 1/10W 7.5K-F103P911070 1/16W 220-Jx4 103P494090 1/16W 10K-F103P481070 1/4W 220-J 103P503070 1/16W 10K-J103P491010 1/16W 270-F 103P913070 1/16W 10K-Jx4103P501080 1/16W 270-J 103P495000 1/16W 11K-F103P491020 1/16W 300-F 103P495010 1/16W 12K-F103P501090 1/16W 330-J 103P503080 1/16W 12K-J103P491050 1/16W 390-F 103P495020 1/16W 13K-F103P502000 1/16W 390-J 103P495030 1/16W 15K-F103P491060 1/16W 430-F 103P475030 1/8W 15K-F103P502010 1/16W 470-J 103P503090 1/16W 15K-J103P471070 1/8W 470-F 103P495050 1/16W 18K-F103P491080 1/16W 510-F 103P504000 1/16W 18K-J103P491090 1/16W 560-F 103P495070 1/16W 22K-F103P502020 1/16W 560-J 103P504010 1/16W 22K-J103P471090 1/8W 560-F 103P495090 1/16W 27K-F103P492000 1/16W 620-F 103P504020 1/16W 27K-J103P492010 1/16W 680-F 103P496000 1/16W 30K-F103P502030 1/16W 680-J 103P496010 1/16W 33K-F103P492030 1/16W 820-F 103P504030 1/16W 33K-J103P502040 1/16W 820-J 103P504040 1/16W 39K-J103P492040 1/16W 910-F 103P496040 1/16W 43K-F103P492060 1/16W 1.1K-F 103P496050 1/16W 47K-F103P492070 1/16W 1.2K-F 103P504050 1/16W 47K-J103P502060 1/16W 1.2K-J 103P496070 1/16W 56K-F103P492080 1/16W 1.3K-F 103P504060 1/16W 56K-J103P492090 1/16W 1.5K-F 103P497000 1/16W 68K-F103P502070 1/16W 1.5K-J 103P496090 1/16W 68K-F103P493010 1/16W 1.8K-F 103P504070 1/16W 68K-J103P502080 1/16W 1.8K-J 103P504080 1/16W 82K-J103P492050 1/16W 1K-F
RESISTORSConventional Resistors (By Ref #)
Ref # Part # Part Name & Description [#]R3E28 103C170050 R-METAL - 1W 22-JR3E32 103C170050 R-METAL - 1W 22-J
Ref # Part # Part Name & Description [#]
PAGE 56
Ref # Part # Part Name & Description [#]
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927[#] Model Legend: (a) WD-52627, (b) WD-52628, (c) WD-62627, (d) WD-62628, (e) WD-62827, (f) WD-62927, (g) WD-73727,
(h) WD-73827, (i) WD-73927
R7A89 265P809010 THRM-CHIPNCP18XH103F03RBR9A01 109P179010 R-CEMENT-PLATE - 6.8-JR9A02 109P179010 R-CEMENT-PLATE - 6.8-JR9A03 109C010010 R-COMP - 1/2W 1M-KR9A05 109C010010 R-COMP - 1/2W 1M-KR9A06 109C010010 R-COMP - 1/2W 1M-KR9A09 103P145030 R-CARBON - 1/2W 220K-JR9A11 103P145030 R-CARBON - 1/2W 220K-JR9A13 103C184090 R-METAL - 2W 100K-JR9A14 103C184090 R-METAL - 2W 100K-JR9A16 103P145020 R-CARBON - 1/2W 180K-JR9A17 103P145020 R-CARBON - 1/2W 180K-JR9A19 103P144070 R-CARBON - 1/2W 68K-JR9A20 103P144070 R-CARBON - 1/2W 68K-JR9A21 103C187030 R-METAL - 2W 0.27-JR9A22 103C187030 R-METAL - 2W 0.27-JR9A25 103P142050 R-CARBON - 1/2W 1K-JR9A29 109D151080 R-CARBON - 1/4W 220-J 0efhiR9A30 109D151060 R-CARBON - 1/4W 68-JR9A36 109D151080 R-CARBON - 1/4W 220-J 0efhiR9A52 109D151080 R-CARBON - 1/4W 220-JR9A54 109D151080 R-CARBON - 1/4W 220-JR9A55 109D151080 R-CARBON - 1/4W 220-JR9A56 109D151080 R-CARBON - 1/4W 220-J 0efhiR9A64 103P331080 R-CARBON-25 - 1/4W 270-JR9A65 103P331080 R-CARBON-25 - 1/4W 270-JR9A77 103C392050 R-METAL-P - 3W 1K-JR9A78 103C392050 R-METAL-P - 3W 1K-JR9A91 103P331080 R-CARBON-25 - 1/4W 270-JR9C00 103C398070 R-METAL-P - 3W 3.9-KR9C10 103C398070 R-METAL-P - 3W 3.9-KR9C20 103C399000 R-METAL-P - 3W 6.8KR9C71 103C398010 R-METAL-P - 3W 1.2-KR9D00 109D036020 R-COMP - 1/2W 4.7M-KR9F16 109D151080 R-CARBON - 1/4W 220-J
CAPACITORSCHIP Type Capacitors (Listed by Value)
Part No. Value Part No. Value154P340060 CK50V 5P-C 189P245010 0.1M 25V154P340070 CH50V 6P-C 141P143030 B16V 0.1M-K154P341010 CH50V 10P-C 141P139030 B25V 0.1M-K154P351020 SL50V 10P-J 141P146080 B10V 0.47M-K154P341030 CH50V 12P-J 141P139090 B16V 0.47M-K154P341050 CH50V 15P-J 141P144010 F50V 0.047M-Z154P344010 CH50V 180P-J 141P134090 F50V 0.1M-Z154P341070 CH50V 18P-J 141P144020 F25V 0.1M-Z154P341090 CH50V 22P-J 141P135000 F25V 0.22M-Z154P342010 CH50V 27P-J 141P138080 B25V 0.33M-K154P342030 CH50V 33P-J 141P144040 F25V/16V 0.33M-Z154P352040 SL50V 33P-J 141P144050 F16V 0.47M-Z154P342070 CH50V 47P-J 141P135020 F25V 0.47M-Z154P342090 CH50V 56P-J 141P135070 F16V 1M-Z154P343010 CH50V 68P-J 141P134070 B16V 1M-K154P343030 CH50V 82P-J 141P144060 F25V 1M-Z154P343050 CH50V 100P-J 141P147020 B10V/6.3V 1M-K154P353060 SL50V 100P-J 181P826010 50V 1M-M 105C141P140010 B50V 220P-K 181P802040 16V 2.2M-M
Part No. Value Part No. Value154P354040 SL50V 220P-J 181P806020 50V 2.2M-M154P344030 CH50V 220P-J 181P806030 50V 3.3M-M154P344050 CH50V 270P-J 181P808070 16V 4.7M-M154P344070 CH50V 330P-J 181P824090 35V 4.7M-M 105C154P345010 CH50V 470P-J 189P243010 10M 6.3V141P140050 B50V 470P-K 189P243020 10M 25V141P140060 B50V 560P-K 181P808080 16V 10M-M141P140070 B50V 680P-K 181P802030 16V 10M-M154P345050 CH25V 680P-J 181P822030 16V 10M-M 105C154P345090 CH25V 1000P-J 181P810070 10V 10M-M BP141P140090 B50V 1000P-K 181P826050 50V 10M-M 105C141P141010 B50V 1500P-K 181P825000 35V 10M-M 105C141P141030 B50V 2200P-K 181P820010 6.3V 22M-M 105C141P141040 B50V 2700P-K 181P822040 16V 22M-M 105C141P141050 B50V 3300P-K 181P832030 16V 33M-M BP
105C141P141070 B50V 4700P-K 181P802060 16V 47M-M141P141080 B50V 5600P-K 181P820030 6.3V 47M-M 105C141P142000 B50V 8200P-K 181P800030 6.3V 47M-M172P391030 16V 0.01M-J 181P822060 16V 47M-M 105C141P142010 B50V 0.01M-K 181P800040 6.3V 100M-M141P133080 B50V 0.01M-Z 181P802070 16V 100M-M141P143080 F50V 0.01M-Z 181P822070 16V 100M-M 105C141P132030 B50V 0.015M-K 181P824010 25V 100M-M 105C141P142040 B50/25/16V 181P828000 4V 100M-M 105C
0.018M-K141P137040 B50V 0.022M-K 181P820040 6.3V 100M-M 105C141P142070 B25V 0.033M-K 181P800060 6.3V 220M-M141P142090 B25V 0.047M-K 181P828010 4V 220M-M 105C172P392030 16V 0.068M-J 181P820050 6.3V 220M-M 105C
CAPACITORS AND TRIMMERSConventional Capacitors (By Ref #)
Ref # Part # Part Name & Description [#]C112 181P181000 C-ELEC - 10V 330M-M 105CC117 181P181000 C-ELEC - 10V 330M-M 105CC2E01 181P352050 C-ELEC - 16V 220M-MC2L05 181P355050 C-ELEC - 50V 10M-MC2L06 181P352010 C-ELEC - 16V 22M-MC2L07 181P355050 C-ELEC - 50V 10M-MC2L08 181P122070 C-ELEC-NP - 25V 10M-MC2L09 181P355050 C-ELEC - 50V 10M-MC2L10 181P122070 C-ELEC-NP - 25V 10M-MC2L11 181P355050 C-ELEC - 50V 10M-MC2L12 181P122070 C-ELEC-NP - 25V 10M-MC2L13 181P355050 C-ELEC - 50V 10M-MC2L14 181P122070 C-ELEC-NP - 25V 10M-MC2L17 181P352040 C-ELEC - 16V 100M-MC2L18 181P352010 C-ELEC - 16V 22M-MC2L19 181P212060 C-ELEC - 16V 47M-MC3E50 181P358070 C-ELEC - 63V 22M-MC3E51 181P354090 C-ELEC - 35V 470M-MC3E52 181P354090 C-ELEC - 35V 470M-MC3E53 181P354090 C-ELEC - 35V 470M-MC3E54 181P354090 C-ELEC - 35V 470M-MC3J23 181P352030 C-ELEC - 16V 47M-MC3J25 181P355060 C-ELEC - 50V 22M-MC3J26 181P212060 C-ELEC - 16V 47M-M
PAGE 57
Ref # Part # Part Name & Description [#]
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927[#] Model Legend: (a) WD-52627, (b) WD-52628, (c) WD-62627, (d) WD-62628, (e) WD-62827, (f) WD-62927, (g) WD-73727,
(h) WD-73827, (i) WD-73927Ref # Part # Part Name & Description [#]
C7E01 181P350060 C-ELEC - 3V 1000M-MC7K01 181P352030 C-ELEC - 16V 47M-MC7K21 181P355050 C-ELEC - 50V 10M-MC7K23 181P352030 C-ELEC - 16V 47M-MC7K28 181P355050 C-ELEC - 50V 10M-MC8281 189P197020 C-ELE-DBL-LA - FM0H473Z/EECS5R5T473ZC9A00 189P185090 C-CER - AC250V E2200P-MC9A01 189P185090 C-CER - AC250V E2200P-MC9A02 185D122050 C-ELEC - H200V 1000M-MC9A03 185D122050 C-ELEC - H200V 1000M-MC9A04 185D127040 C-ELEC - H450V 150M-M 105CC9A05 189P185090 C-CER - AC250V E2200P-MC9A06 189P185090 C-CER - AC250V E2200P-MC9A08 189P185090 C-CER - AC250V E2200P-MC9A09 189P185090 C-CER - AC250V E2200P-MC9A10 189P185090 C-CER - AC250V E2200P-MC9A11 189P185090 C-CER - AC250V E2200P-MC9A13 189P152080 C-M-POLY - AC125/250V 0.015M-MC9A14 189P152080 C-M-POLY - AC125/250V 0.015M-MC9A15 189P185070 C-CER - AC250V E1000P-MC9A16 189P185070 C-CER - AC250V E1000P-MC9A19 154P400060 C-CER - B1KV 1500P-KC9A21 181P185060 C-ELEC - 50V 10M-M 105CC9A25 172P138050 C-POLY - 50V 0.01M-JC9A26 185D122050 C-ELEC - H200V 1000M-MC9A27 185D122050 C-ELEC - H200V 1000M-MC9A28 154P400060 C-CER - B1KV 1500P-KC9A30 154P400050 C-CER - B1KV 1000P-KC9A31 142P010090 C-CER - B500V 470P-KC9A32 181P735020 C-ELEC - 25V 1000M-M 105CC9A33 181P735020 C-ELEC - 25V 1000M-M 105CC9A35 181P735010 C-ELEC - 25V 470M-MC9A36 181P735020 C-ELEC - 25V 1000M-M 105CC9A37 181P735020 C-ELEC - 25V 1000M-M 105CC9A38 181P735020 C-ELEC - 25V 1000M-M 105CC9A39 181P184070 C-ELEC - 35V 2200M-MC9A40 181P184070 C-ELEC - 35V 2200M-MC9A43 172P166070 C-TF - 50V 0.22M-JC9A45 181P182030 C-ELEC - 16V 1000M-M 105CC9A46 142P010090 C-CER - B500V 470P-KC9A47 142P010090 C-CER - B500V 470P-KC9A48 181P355010 C-ELEC - 50V 1M-MC9A53 181P735020 C-ELEC - 25V 1000M-M 105CC9A65 181P732000 C-ELEC - 10V 680M-M 105CC9A66 181P732000 C-ELEC - 10V 680M-M 105CC9A68 181P734070 C-ELEC - 25V 100M-M 105C LOW-RC9A70 181P734070 C-ELEC - 25V 100M-M 105C LOW-RC9A71 181P352070 C-ELEC - 16V 470M-MC9A72 181P735020 C-ELEC - 25V 1000M-M 105CC9A74 181P733080 C-ELEC - 16V 1000M-H 105C LOWRC9A75 181P352070 C-ELEC - 16V 470M-MC9A82 181P352070 C-ELEC - 16V 470M-M 0efhiC9A90 154P400060 C-CER - B1KV 1500P-KC9A98 181P352070 C-ELEC - 16V 470M-M efhiC9A99 181P352070 C-ELEC - 16V 470M-M efhiC9C51 181P351070 C-ELEC - 10V 470M-MC9D00 189P153040 C-M-POLY - 250VAC 0.1M-MC9D01 189P153040 C-M-POLY - 250VAC 0.1M-MC9D02 189P153040 C-M-POLY - 250VAC 0.1M-MC9D03 189P153040 C-M-POLY - 250VAC 0.1M-M
C9E22 181P354050 C-ELEC - 35V 47M-M efhiC9E45 181P735020 C-ELEC - 25V 1000M-M 105CC9E60 181P735020 C-ELEC - 25V 1000M-M 105CC9E64 181P733060 C-ELEC - 16V 470M-H 105C LOWRC9E65 181P733060 C-ELEC - 16V 470M-H 105C LOWRC9F12 181P735020 C-ELEC - 25V 1000M-M 105CC9F17 181P732000 C-ELEC - 10V 680M-M 105CC9F18 181P732000 C-ELEC - 10V 680M-M 105CC9G04 181P735020 C-ELEC - 25V 1000M-M 105CC9G17 181P732000 C-ELEC - 10V 680M-M 105CC9G18 181P732000 C-ELEC - 10V 680M-M 105CC9G24 181P735020 C-ELEC - 25V 1000M-M 105CC9G37 181P732000 C-ELEC - 10V 680M-M 105CC9G38 181P732000 C-ELEC - 10V 680M-M 105CC9G44 181P735020 C-ELEC - 25V 1000M-M 105CC9G57 181P732000 C-ELEC - 10V 680M-M 105CC9G58 181P732000 C-ELEC - 10V 680M-M 105CC9J01 181P356020 C-ELEC - 50V 470M-MC9J02 181P738010 C-ELEC - 50V 220M-M 105C LOW-RC9J04 181P356020 C-ELEC - 50V 470M-MC9J05 181P738010 C-ELEC - 50V 220M-M 105C LOW-RC9J07 181P356020 C-ELEC - 50V 470M-MC9J08 181P738010 C-ELEC - 50V 220M-M 105C LOW-RC9J15 181P355050 C-ELEC - 50V 10M-MC9J16 181P355050 C-ELEC - 50V 10M-M
SWITCHESS7F01 434P004010 SW-LEVERS7L20 432P109010 SW-KEY BOARD - KSHS611BT abcdS7L21 432P109010 SW-KEY BOARD - KSHS611BT abcdS7L22 432P109010 SW-KEY BOARD - KSHS611BT abcdS7L23 432P109010 SW-KEY BOARD - KSHS611BT abcdS7L24 432P109010 SW-KEY BOARD - KSHS611BT abcdS7L25 432P109010 SW-KEY BOARD - KSHS611BT abcdS7L26 432P109010 SW-KEY BOARD - KSHS611BT abcdS7L27 432P109010 SW-KEY BOARD - KSHS611BT abcdS7L28 432P109010 SW-KEY BOARD - KSHS611BT abcdS7L29 432P109010 SW-KEY BOARD - KSHS611BT abcdS7L70 432P109010 SW-KEY BOARD - KSHS611BT efghiS7L71 432P109010 SW-KEY BOARD - KSHS611BT efghiS7L72 432P109010 SW-KEY BOARD - KSHS611BT efghiS7L73 432P109010 SW-KEY BOARD - KSHS611BT efghiS7L74 432P109010 SW-KEY BOARD - KSHS611BT efghiS7L75 432P109010 SW-KEY BOARD - KSHS611BT efghiS7L76 432P109010 SW-KEY BOARD - KSHS611BT efghiS7L77 432P109010 SW-KEY BOARD - KSHS611BT efghiS7L78 432P109010 SW-KEY BOARD - KSHS611BT efghiS7L79 432P109010 SW-KEY BOARD - KSHS611BT efghi
MISCELLANEOUS096Z465030 TAPE-LENS ghi096Z465080 TAPE-LENS abcdef242D536010 CABLE-MEMORY - USB/5P-JS i242D535010 CABLE-EXTENSION - 1394 ghi242D536040 CABLE - USB to 5P abcdefgh242D540070 CABLE-RF - 150mm242D543020 CABLE - 1394 L-L 700mm ef242D544030 CABLE - 1394 700mm ef242D544040 CABLE - 1394 780mm bd
Ref # Part # Part Name & Description [#]
PAGE 58
Ref # Part # Part Name & Description [#]
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927[#] Model Legend: (a) WD-52627, (b) WD-52628, (c) WD-62627, (d) WD-62628, (e) WD-62827, (f) WD-62927, (g) WD-73727,
(h) WD-73827, (i) WD-73927
246C524020 CABLE-DVI ghi299P254020 IR-EMITTER, 4-HEAD - T-IR-02
W/FERRITE CO bdefghi299P278020 FAN-COOLING - Ballast abcdef299P288010 FAN-COOLING - Chassis299P298010 FAN-COOLING-LAMP299P299010 FAN-COOLING-DMD299P300010 THERMISTOR-DMD299P285020 SENSOR-THERMAL-LAMP299P290010 THERM - DTN-C223H3UAMD101B ef305P703020 2RF-SWITCH abcdg305P705010 SWITCH-RF-TYPE 5 efhi411D024010 CORE-FERRITE - CAT2035 abcdef411D044020 CORE-FERRITE - ZCAT2032-0930 abcdef411D063010 CORE-FERRITE - ZCAT2132-1130 abcdef411P026010 CORE-FERRITE - ZCAT2017 abcdef411P026020 CORE-FERRITE - ZCAT2436 abcdef411P029010 CORE-FERRITE - ZCAT3513S480P080010 SPEAKER - 10W480P081010 SPEAKER efghi480P081020 SPEAKER abcd598D417020 PLATE - RF-SWITCH622C289010 CUSHION-LENS ghi635B114010 MIRROR - BRACKET - TOP ab635B114020 MIRROR - BRACKET - TOP cdef704B205010 KNOB - CONTROL abcd704B207010 BUTTON - RESET abcd704B215010 CONTROL BUTTONS f704B219010 CONTROL BUTTONS gh704B223010 CONTROL BUTTONS e767D079010 MIRROR ab767D079020 MIRROR cdef767D079030 MIRROR ghi915P026010 LAMP-CARTRIDGE - 120W abcd915P027010 LAMP-CARTRIDGE - 150W efghi938P017010 OPTICAL-ENGINE ab938P017020 OPTICAL-ENGINE cd938P019020 OPTICAL-ENGINE ef938P019010 OPTICAL-ENGINE ghi938P026010 HDD UNIT eh938P026020 HDD UNIT fi938P027010 CARD READER UNIT abcdghi938P027020 CARD READER UNIT ef955P002010 UNIT ADJUSTER abcdef
AG9D00 299P220020 SURGE-SUPPRESSOR - DSS-302MF9A01 283P144080 FUSE - 125V 5AF9A02 283D158010 FUSE - 125V 25AF9A03 283P144080 FUSE - 125V 5AF9A04 283P144080 FUSE - 125V 5AF9A05 283P144060 FUSE - 125V 7AF9A06 283P144080 FUSE - 125V 5AF9A07 283P144080 FUSE - 125V 5AF9A08 283P144060 FUSE - 125V 7AF9A09 283P075090 FUSE-CHIP - FCC20252ADTPF9A10 283P075090 FUSE-CHIP - FCC20252ADTPF9D00 283D131040 FUSE - S10A 125AF9G01 283P163050 FUSE-WIRE-CHIP - 125V 6.3AF9G21 283P163050 FUSE-WIRE-CHIP - 125V 6.3AF9G41 283P163050 FUSE-WIRE-CHIP - 125V 6.3ASF1501 296P171010 SAW-FILTER - X6892D
SF1503 296P173010 SAW-FILTER - MKT47.3MC110PSF1601 296P171010 SAW-FILTER - X6892D efhiSF1603 296P173010 SAW-FILTER - MKT47.3MC110P efhiJ2001 452C410010 CONNECTOR-HDMIJ2101 452C410010 CONNECTOR-HDMIJ2C01 452C388010 CONNECTOR-DSUB-9P efhiJ7T01 452C401010 CONNECTOR-USBJ7T02 452C401010 CONNECTOR-USB acJ8301 440C393030 PIN-JACK-BOARD-1PJ8401 451P246010 JACK-1394 - MINIJ8401 451P246010 JACK-1394 - MINI acJ8402 451P246010 JACK-1394 - MINIJ8402 451P246010 JACK-1394 - MINI acJ8403 451P246010 JACK-1394 - MINIJ8A01 452C300010 CONNECTOR-DSUB-15P fiK9A10 287P111030 RELAY-POWER - LKS1AF-12VK9A20 287P111030 RELAY-POWER - LKS1AF-12VK9A21 287P111030 RELAY-POWER - LKS1AF-12VPB 452C411020 CONNECTOR PCCARDPC9A10 268P115010 PHOTO-COUPLIER - SHF2505FAPC9A21 268P115010 PHOTO-COUPLIER - SHF2505FAPJ2E00 451C268010 JACK MICROPHONE 1PPJ2E01 451C268010 JACK MICROPHONE 1PPJ2J01 440P108010 PIN-JACK-BOARD-5P abcdgPJ2J01 440P112010 PIN-JACK-BOARD-5P efhiPJ2J02 440P110010 PIN-JACK-BOARD-2P abcdgPJ2J02 440P114010 PIN-JACK-BOARD-2P efhiPJ2J03 440P110010 PIN-JACK-BOARD-2P abcdgPJ2J03 440P114010 PIN-JACK-BOARD-2P efhiPJ2J04 440P107010 PIN-JACK-BOARD-5P abcdgPJ2J04 440P111010 PIN-JACK-BOARD-5P efhiPJ2J05 440P107010 PIN-JACK-BOARD-5P abcdgPJ2J05 440P111010 PIN-JACK-BOARD-5P efhiPJ2J06 440P107010 PIN-JACK-BOARD-5P abcdgPJ2J06 440P111010 PIN-JACK-BOARD-5P efhiPJ2J07 440P109010 PIN-JACK-BOARD-5P abcdgPJ2J07 440P113010 PIN-JACK-BOARD-6P efhiPJ2J11 440C412030 PIN-JACK-BOARD-3P-1S abcdgPJ2J11 440C412050 PIN-JACK-BOARD-3P-1S efghiTU100 295P523030 TUNER-NTSC/ATSCTU101 295P523030 TUNER-NTSC/ATSCTU102 295P524020 TUNER-OOBX1501 285P459070 QTZ-CRYST - 25.14MHZX1601 285P459070 QTZ-CRYST - 25.14MHZ efhiX2296 285P459090 QTZ-CRYST - 28.322MHZX7A13 285P459040 QTZ-CRYST - 16MHZX7G01 285P431030 QTZ-CRYST - 81MHZX7P09 285P459020 QTZ-CRYST - 8MHZX7R01 285P459010 QTZ-CRYST - 3.579545MHZX7R02 285P459030 QTZ-CRYST - 10MHZX8001 285P441040 QTZ-CRYST - 26.1621MHZ bdgX8001 285P455040 QTZ-CRYST - 26.1521MHZ acefhiX8201 285P403020 QTZ-CRYST - 32.768MHZX8301 285P464010 QTZ-CRYST - 7.3728MHZX8402 285P455030 QTZ-CRYST - 24.576MHZ acX8403 285P455030 QTZ-CRYST - 24.576MHZ acX8501 285P455010 QTZ-CRYST - 18.24MHZX8600 285P455030 QTZ-CRYST - 24.576MHZ efhiX8601 285P446010 QTZ-CRYST - 83.33MHZ efhiX8G01 299P284010 CER-OSC - CSTCE20M0V51-R0
PAGE 59
Ref # Part # Part Name & Description [#]
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927[#] Model Legend: (a) WD-52627, (b) WD-52628, (c) WD-62627, (d) WD-62628, (e) WD-62827, (f) WD-62927, (g) WD-73727,
(h) WD-73827, (i) WD-73927Ref # Part # Part Name & Description [#]
X8K45 285P391030 OSC - 74.175824MHZZ7K01 938P005010 UNIT-PREAMP - GP1UM283QK
PRINTED CIRCUIT BOARDS934C150005 ASSY-PWB-TERMINAL abcdg934C150006 ASSY-PWB-TERMINAL efhi934C151005 ASSY-PWB-MICRO abcdg934C151006 ASSY-PWB-MICRO efhi934C152005 ASSY-PWB-DM ac934C152006 ASSY-PWB-DM bdg934C152007 ASSY-PWB-DM efhi934C154002 ASSY-PWB-RISER abcdg934C154005 ASSY-PWB-RISER efhi934C155005 ASSY-PWB-INTERFACE934C159001 ASSY-PWB-POWER2 abcdg934C159002 ASSY-PWB-POWER2 efhi934C160001 ASSY-PWB-V29FMT abcdegh934C160002 ASSY-PWB-V29FMT fi935D818001 ASSY-PWB-PREAMP935D819001 ASSY-PWB-DEMOD1935D820001 ASSY-PWB-E2P935D822001 ASSY-PWB-FRONT abcdg935D822002 ASSY-PWB-FRONT efhi935D824001 ASSY-PWB-CONTROL abcd935D824002 ASSY-PWB-CONTROL2 efghi935D839001 ASSY-PWB-DEMOD2 efhi935D849001 ASSY-PWB-SW-LAMP938P018010 ASSY-PWB-BALLAST efghi939P978020 ASSY-PWB-BALLAST abcd955B313001 ASSY-CHASSIS ac955B313002 ASSY-CHASSIS bdg955B313004 ASSY-CHASSIS fi955B313006 ASSY-CHASSIS eh955C283001 ASSY-PWB-ENG-PWR
COSMETIC PARTS702A464010 BOARD TERMINAL702A465010 FRONT PANEL CAP - LEFT e702A465020 FRONT PANEL CAP - RIGHT e703C072010 ORNAMENT-T ghi703C073010 ORNAMENT-S ghi703C074010 ORNAMENT-B ghi711D014010 M-CARD DOOR COVER f711D015010 CONTROL PANEL PLATE f712C718010 TOP TRIM ef712C719010 SIDE TRIM - LEFT f712C720010 BOTTOM TRIM f712C721010 BOTTOM TRIM e712C722010 SIDE TRIM - LEFT e712C722020 SIDE TRIM - RIGHT e716C044020 BADGE BRAND i716C046010 BADGE DIAMOND e752B162010 COVER - LAMP-ACCESS752C310010 CAP POD abcdef752C311010 CAP RG abcdef760A018010 INLAY TERMINAL abcdg760A018020 INLAY TERMINAL eh760A018030 INLAY TERMINAL fi761A252010 BEZEL - FRONT ab
761A253010 BEZEL - FRONT cd761A271010 COVER PEDESTAL a761A271020 COVER PEDESTAL b761A276010 GRILLE SPEAKER a761A276020 GRILLE SPEAKER b761A278010 GRILLE SPEAKER c761A278020 GRILLE SPEAKER d761A279010 COVER PEDESTAL c761A279020 COVER PEDESTAL d761A286010 COVER PEDESTAL f761A287010 FRONT BEZEL f761A305010 GRILL-SIDE - LEFT ab761A305020 GRILL-SIDE - RIGHT g761A305030 GRILL-SIDE - LEFT h761A305040 GRILL-SIDE - RIGHT h761A312010 FRONT ESCUSHION - LEFT f761A312020 FRONT ESCUSHION - RIGHT f761A313010 BACK ESCUSHION - LEFT f761A313020 BACK ESCUSHION - RIGHT f761A314010 FRONT ESCUSHION - LEFT e761A314020 FRONT ESCUSHION - RIGHT e761A316010 GRILL-REAR g761A316020 GRILL-REAR h761A320010 CONTROL PANEL PLATE e761A321010 FRONT BEZEL e761C754010 M-CARD READER DOOR f761C759010 M-CARD READER DOOR e761A281010 PEDESTAL i761A306010 GRILL-SIDE i761A306020 GRILL-SIDE i761A317010 GRILL-REAR i
ACCESSORIES242D483020 IR-MOUSE ac242D525010 CABLE - AUDIO - AC3 abdefghi242D527010 CABLE - IR aefghi246C351070 AC POWER CORD ghi290P122020 REMOTE-CONTROL - V29 ac290P123020 REMOTE-CONTROL - V30/V30+/V31 bdefghi622C284010 COSMETIC CLIP SIDE ef622C284020 COSMETIC CLIP SIDE ef622C285010 COSMETIC CLIP BOTTOM efI/TV WD-52627 GUIDE: TVI/QR WD-52627 GUIDE: QR acI/QR WD-52628 GUIDE: QR bdgI/QR WD-62827 GUIDE: QR efhiI/B WD-52627 GUIDE: OWNERS acI/B WD-52628 GUIDE: OWNERS bdgI/B WD-62827 GUIDE: OWNERS efhi
PAGE 60
Ref # Part # Part Name & Description [#] Ref # Part # Part Name & Description [#]
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927[#] Model Legend: (a) WD-52627, (b) WD-52628, (c) WD-62627, (d) WD-62628, (e) WD-62827, (f) WD-62927, (g) WD-73727,
(h) WD-73827, (i) WD-73927
SCREEN ASSEMBLY PARTSWD-52627& WD-52628 Screen Parts (Figure 1)
(1) 491P177040 LENS-FRESNEL(2) 491P178040 SCREEN-LENTICULAR(3) 623D253020 SCREEN - HOLDER(4) 701B525030 FRAME TOP(5) 701B534010 FRAME SIDE(6) 761A232050 SCREEN-FRAME - BOTTOM(7) 761A238050 SCREEN-FRAME - COVER-TOP(8) 768C082010 SCREEN-CAP-CORNER - LEFT(9) 768C082020 SCREEN-CAP-CORNER - RIGHT(11) 623D209010 SCREEN - SHEET - BOTTOM(12) 704B238010 FRAME-TRIM - BTM LEFT(13) 704B238020 FRAME-TRIM - BTM RIGHT
598D822010 SCREEN - BRACKET623D224010 SCREEN-FRAME - SPACER
WD-62627& WD-62628Screen Parts (Figure 1)(1) 491P177030 LENS-FRESNEL(2) 491P178030 SCREEN-LENTICULAR(3) 623D253010 SCREEN - HOLDER(4) 701B525040 FRAME TOP(5) 701B534020 FRAME SIDE(6) 761A242050 SCREEN - FRAME - BOTTOM(7) 761A244050 SCREEN-FRAME - COVER-TOP(8) 768C082010 SCREEN-CAP-CORNER - LEFT(9) 768C082020 SCREEN-CAP-CORNER - RIGHT(11) 623D209020 SCREEN-SHEET - BOTTOM(14) 704B217010 FRAME-TRIM - BTM LEFT(15) 704B217020 FRAME-TRIM - BTM RIGHT
598D683010 SCREEN - BRACKET623D224010 SCREEN-FRAME - SPACER
Figure 1
PAGE 61
Ref # Part # Part Name & Description [#] Ref # Part # Part Name & Description [#]
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927[#] Model Legend: (a) WD-52627, (b) WD-52628, (c) WD-62627, (d) WD-62628, (e) WD-62827, (f) WD-62927, (g) WD-73727,
(h) WD-73827, (i) WD-73927
Figure 2:
WD-62827 Screen Parts (Figure 2)(1) 491P177030 LENS-FRESNEL(2) 491P178030 SCREEN-LENTICULAR(3) 701B519010 FRAME TOP(4) 701B520010 FRAME SIDE - RIGHT(5) 701B520020 FRAME SIDE - LEFT(6) 701B532010 FRAME BOTTOM(7) 768C083010 CAP-CORNER - TOP RIGHT(8) 768C083020 CAP-CORNER - TOP LEFT(9) 768C086010 CAP-CORNER - BTM RIGHT(10) 768C086020 CAP-CORNER - BTM LEFT(11) 622C137010 CLIP-DS - SIDE(12) 760D656010 AR-DIAMOND-SHIELD
598D683010 SCREEN - BRACKET
WD-62927 Screen Parts (Figure 2)(1) 491P177030 LENS-FRESNEL(2) 491P178030 SCREEN-LENTICULAR(3) 701B519010 FRAME TOP(4) 701B520010 FRAME SIDE - RIGHT(5) 701B520020 FRAME SIDE - LEFT(6) 701B532010 FRAME BOTTOM(7) 768C083010 CAP-CORNER - TOP RIGHT(8) 768C083020 CAP-CORNER - TOP LEFT(9) 768C086010 CAP-CORNER - BTM RIGHT(10) 768C086020 CAP-CORNER - BTM LEFT(11) 622C137010 CLIP-DS - SIDE(12) 760D656030 AR-DIAMOND-SHIELD
598D683010 SCREEN - BRACKET
PAGE 62
Ref # Part # Part Name & Description [#] Ref # Part # Part Name & Description [#]
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927[#] Model Legend: (a) WD-52627, (b) WD-52628, (c) WD-62627, (d) WD-62628, (e) WD-62827, (f) WD-62927, (g) WD-73727,
(h) WD-73827, (i) WD-73927
WD-73727 Screen Parts (Figure 3)(1) 491P175050 LENS-FRESNEL(2) 491P176050 SCREEN-LENTICULAR(3) 595C114010 PLATE-SCREEN(4) 711C061010 FRAME-SCREEN-T(5) 711C062010 FRAME-SCREEN-B(6) 711C063020 FRAME-SCREEN-S(7) 711C065020 COVER-FRAME-TOP(8) 768C084030 CAP-CORNER - TOP LEFT(9) 768C084040 CAP-CORNER - TOP RIGHT(10) 768C087030 CAP-CORNER - BTM LEFT(11) 768C087040 CAP-CORNER - BTM RIGHT
WD-73827 Screen Parts (Figure 3)(1) 491P175050 LENS-FRESNEL(2) 491P176050 SCREEN-LENTICULAR(3) 595C114010 PLATE-SCREEN(4) 711C061010 FRAME-SCREEN-T(5) 711C062020 FRAME-SCREEN-B(6) 711C063020 FRAME-SCREEN-S(7) 711C065020 COVER-FRAME-TOP(8) 768C084030 CAP-CORNER - TOP LEFT(9) 768C084040 CAP-CORNER - TOP RIGHT(10) 768C087030 CAP-CORNER - BTM LEFT(11) 768C087040 CAP-CORNER - BTM RIGHT
Figure 3
WD- 73927 Screen Parts (Figure 3)(1) 491P175050 LENS-FRESNEL(2) 491P176050 SCREEN-LENTICULAR(3) 595C114010 PLATE-SCREEN(4) 711C061010 FRAME-SCREEN-T(5) 711C064010 FRAME-SCREEN-B(6) 711C063020 FRAME-SCREEN-S(7) 711C065020 COVER-FRAME-TOP(8) 768C084030 CAP-CORNER - TOP LEFT(9) 768C084040 CAP-CORNER - TOP RIGHT(12) 622C137010 CLIP-DS - SIDE(13) 622C211030 CLIP DS BOTTOM(14) 760D656040 AR-DIAMOND-SHIELD
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 63
Main Pow
er Supply
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 64
Lamp Ballast DC Supply
Fans Power Supply
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 65
Light Engine Power Supply
HDD Power Supply & Fan Control(V30+ and V31 Only)
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 66
Analog Video Signal Path
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 67
Digital Video Signal Path
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 68
HD
D R
ecor
d Si
gnal
Pat
h(V
30+
and
V31
Onl
y)
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 69
Sound Signal Path
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 70
CommandInput Circuitry
Serial Control Lines
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 71
Lamp C
ontrol Circuitry
MODELS: WD-52627 / 52628 / 62627 / 62628 / 62827 / 62927 / 73727 / 73827 / 73927
Page 72
Lamp, Engine & Fan Protect Circuitry
TV Guide On® Screen Block Diagram
BOSS
BOSS
1 2 3 4 5 6 7 8 9 10 11
4 5 6 7 8 91 2 3
1 2 3
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
41 2 3
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
1 2 3 4 5 6 7 8
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
1
2
3
4
1 2 3
1
2
3
4
5
6
7
8
9
1 2 3 4
1
2
3
2
3
4
5
6
7
8
1
1 2 3
1234
1 2 3 4 5 6 7 8 9 10 11
1
2
3
4
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
1 2 3 4
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22
12345678910111213141516171819202122
1 2 3 4 5 6 7 8 9
1 2 3 4
1234
1 2 3 4 5 6 7 8 9
1
2
3
1 2 3 4 5 6 7 8
21
1234
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
2 3 41
2
3
4
5
6
7
8
9
10
1
2
3
4
1
12
34
56
78
12
34
56
78
1 2 3 4
1 2 3 4
SHADED COMPONENTS HAVE SPECIAL CHARACTERISTICS
IMPORTANT TO SAFETY. BEFORE REPLACING ANY OF
THESE COMPONENTS, READ CAREFULLY THE PRODUCT
SAFETY NOTICE IN THE SERVICE MANUAL. DON’T
DEGRADE THE SAFETY OF THE RECEIVERS THROUGH
IMPROPER SERVICING.
CE
LE
CJ1
MC
CD
MB
PC
MC
J8202
RB
PB
CJ3
RB
PH
JD
ES
CE1
PL
MB
MA
J8202
J8F01
JPS1
MD
1394
1394
MD
PS
PC
1394
MA
PB
CJ3
EP
EP
10 11
5
5
5
5
5
23 24 25 26 27 28 29
23242526272829
11
AN
LE
AN
A15V
5V
5V-T
5VS
-15VS
9V-T
5VS
+15VS
12VS
18VS
18VS
A15V
12VS
5VS
-15VS
5VSL
12V
5VS
-15VS
18VS
5VSL
12VS
5VSL
5V
5VR
18VS
12V
18VS
+15VS
-A15V
A15V
A15V
-A15V
A15V
5V
5VS
5VS
A15V
5VS
A15V
5VSL
-A15V
3.3VSL
12VS
3.3VSL
-A15V
5VS
5VS
-A15V
5VS
5VS
18VS
5V-T
18VS
3.3VS
3.3V
5VS
18VF
3.3V
18VS
5VS
18VS
3.3V
12VS
340V
3.3VS
18VS18VS
5VSB
18VS
A15V
5VS
-A15V
5VS
12VS
340V
5VS
18VS
5VSL
3.3V
5V
3.3VSE
12VS
3.3V
5VS
5VS5VS
3.3VSL
3.3V
5VSL3.3VSL
5VS
5VSL
-15VS
3.3V
+15VS
12VS
3.3V
5VS
3.3V
18VS
5VSL
3.3V
PWR-ON
3.3V
5VS
-A15V
5VSB
9V-T
5VR
5VS
-A15V
5VS
3.3VSE
3.3V
+15VS
18VF
18VSB
3.3V
5V
18VSB
12V
18VSA
3.3V
5V
18VSA
12V
3.3V
5V
2.5V
12V
2.5V
2.5V
2.5V
2.5V
5V
2.5V
2.5V
2.5V
3.3V
12V
3.3VSL
3.3VSL
5VSL
108
5
3
53
95
75
27
43
48
10
68
46
110
10
4
68
81
50
65
51
6
116
105
61
107
5
9
5
24
98
28
16
74
72
4
13
103
22
109
6
8
7
89
36
42
43
42
31
54
60
119
6
61
100
30
77
15
8
68
85
81
103
7
29
85
75
48
79
34
12
89
99
112
15
78
93
59
67
65
55
106
108
55
115
8
13
39
99
45
39
40
21
93
112
48
120
9
53
94
71
31
13
2
119
72
41
114
1
12
64
96
75
25
76
118
38
75
106
10
41
88
71
50
5
64
107
61
32
102
16
19
83
78
44
11
28
86
77
23
101
11
3
86
43
34
238
6
11
113
119
105
8
14
31
97
22
44
62
34
20
101
49
84
116
23
56
72
3
55
17
15
43
27
117
27
15
33
21
21
8
102
83
6
104
3
2
21
7
18
66
2
21
1
109
6
111
6
15
30
57
19
58
76
24
75
16
57
118
7
10
25
36
68
33
11
2
114
66
72
113
1
21
17
74
50
77
3
19
9
70
29
4
23
20
31
47
6
59
14
74
57
92
11
28
45
9
53
71
11
87
110
94
9
9
18
78
56
78
9
37
71
105
8
38
24
49
30
66
12
14
66
21
10
16
57
19
5
68
43
4
52
84
7
14
26
22
26
74
14
22
18
117
100
60
9
5937
31
62
26
72
5
4242
50
5
18
14 62
22
3232
33
10
50
37
79
2
5
22
51
32
79
2
18
3
5
14
26
19
3016
29
63
38
6
7
87
67
90
13
13 35
58
24
37
53
22
97
5
115
4
58
6452
12
73
56
16
23
65 65
20
45
17
61
9
18
30
23
4
98
53
7
20
23
39
47
48
68
1
80
67
TMDS
17
19 55
43
28
7
47
15
59
58
20
22
23 4962
51
45
5
13
47
58
33
12
4
72
60
54 54
74
34
69
36
6
73
37
66
25
37
95
90
78
3
75
62
46
27
15
62
55
96
27
24
12 60
41
73
4
32
26
2
91
1
48
58
57
60
10
79
35
45
85
17
50
42
50
29
7963
7
113
8
10
42
33
71
36
76
24
47
53
73
20
14
63
32
19
70
7
8
28
4
8
26
36
68
40
58
45
97
63
39
7
20
44
52
12
46
9
102
17
74
3
21
49
9
5
46
54
110
92
18
55
55
8
6
25
38
13
23
1
34
66
64
67
15
62
56
22
33
56
34
25
40
51
10
40
21
32
54
12
43
17
58
1
29
9
73
40
69
65
13
73
45
104
19
69
35
27
80
52
46
103
111
77
42
80
44
35
60
28
18
14
59
59
50
23
63
29
120
19
12
4
47
10
26
11
36
100
94
6
1051
33
17
61
19
120
88
2
2864
78
10
14
12
6118
108
13
2
38
3
41
4
40
12
81
76
5
18
48
29
74
52
17
11
48
54
16
65
47
34
41
53
13
7
32
39
1
79
61
100
6045
64
3
63
36
4
8
54
86
53
76
14
15
59
24
24
38
75
85
39
68
4
5
910
11
46
49
84
35
65
52
8
112
82
15
7056
91
1
66
80
4
64
16
80
4840
96
80
69
41
16
111
30
95
106
47 77
81
1
77
44
2
99
17
69
116
52
21
92
24
71
23
9
15
114
33
114
37
28
90
3
75
26
3
56
46
117
35
16
94
57
72
10
1
79
19
70
118
18
63
88
69
79
35
13
24
40
101
105
2
76
2
93
70
70
1
10
71
88
43
101
6 66
87
61
67
38
14
51
83
73
108
1
76
5
97
57
78
15
2
86
116
96
119
4
2
63
39
99
20
74
22
8
98
109
93
115
6
25
89
29
73
16
9
51
64
34
104
70
72
83
56
80
13
2
115
18
112
60
27
98
31
69
11
11
25
52
113
9
7
67
54
95
42
69
49
7
20
35
106
109
6
4
67
82
7
38
17
27
5
78
30
31
102
51
84
59
70
71
65
15
25
12
62
120
80
90
20
61
30
13
3
89
41
107
111
3
46
92
77
57
41
16
14
22
91
44
110
3
1
82
67
20
8
44
16
21
104
82
107
7
1
24
91
39
11
37
12
76
117
49
103
8
10
2
11
87
31
49
36
55
1
44
3
77
9
78
3
2
6
11
10
4
5
12
1
9 7
8
3
26
11
10 4
5
12
1
9
78
3
2
6
11
10
4
5
12
1
14
1312
10
1
5
14
2
43
13
8
6
11
7
9
1331
862 12 14
119
104
75
146
95
124
1331
2
11
108
7
+
or
+
TV-Rxd
LAMP-EN
GND
GND
MN-L
GND
TV-RESET
A-GND
3.3V-ENG-SCL
GND
SUB-Pr
STU-V
ENG-PWR-ON
GND
GND
CARD-DETECT
A-GND
GND
CRIN(0)
PIC-Rxd
MAIN-V
LAMP-LITZ
HDMI-R
DVI-SW
GND
GOS-Rxd
YIN(2)
A-GND
GND
LAMP-RELAY
HDMI-V
GND
BUSREQ
SUB-Pr
FMTRST
R-SPKR(+)
GND
ENG-PROTECT
HDD-TEMP
CMP2-Pr
HDMI-L
FMTRTS
A-GND
GND
CRIN(4)
RELAY NC
GND(POWER)
FAN-STOP
DM-R
IN1-C
GND
AVR-R
A-GND
3.3V-ENG-SDA
PON-SHORT
A-GND
BUSREQ
LAMP-FAN-CONT(DLP)
GND
MT-MONA
GND
GND
GND
GND
A-GND
MAN-RST
GND
GND
PWR-ON
HDDFANPWR
GND(BALLAST)
GND
YIN(4)
GLINK-Rxd
GND
TEMP
CMP2-Pb
STU-L
GND
TV-RESET
A-GND
FAN-DET
GND
GND
KSCO
GND
GND
GND
GND
LAMP-PROTECT
ENG-FAN-ON
SUB-Y
GND
GND
GND
GND
FAN-STOP
IN3-C
GND
STBY
DLP-FAN-CONT(DLP)
FMTRST
USBNB
GND
CBIN(3)
LED
ENC-R
TEMP
HDMI-V
GND
GND
CMP2-Y
GND
GND
FMT-PGOOD
GND
FAN-VCC-BALAST
GND
HIN
L-SPKR(-)
MTU-L
HDMI-R
FAN-VCC
ENC-L
S3
MAIN-Y
PON-SHORT
GND
GND
STU-L
R-SPKR(+)
HDD-RST
MT-MONV
GND
PWR-ON
GND
FSTP-BALAST
GND
GND
SUB-Pb
MN-R
HDMI-B
GND
DVI-SW
DM-L
GND
A-GND
PON-SHORT
GOS-CTS
GND
SUB-H
USB5V
HDMI-G
GND
GMD
L-SPKR(-)
GND
DIM
GND
PIC-RTS
DM-R
GND
GND
GND
ASIC-MTOD
STBY-SHORT
PON-SHORT
MAN-RST
TX1+
GND
STU-V
STU-R
GND
GND
MTU-R
HDD-RST
MTU-L
TX1-
CRIN(5)
GND
USBPA
GND
GND
R-SPKR(+)
STBY
DM-RESET
GND
MD(LCD/DMD)_FAN
TXC+
CBIN(7)
LAMP-R
PC-RXD
GND
AVR-R
AC-OFF
HDDFANPWR
PC-TXD
NC
ENC-R
LAMP-FAN
TX0+
GND
KSC1
NC
GND
S1
IN3-Y
MAIN-V
DM-R
GND
TX2+
PWR-ON
MAN-RST
GND
CMP3-Y
GND
MT-MONA
GND
HDD-TEMP
STBY
PIC-Txd
LENS
GND(5V&H/V-SYNC:AGND)
GND
MAIN-H
MTU-R
HDMI-H
5VSCL
GND
TV-CTS
USB5V
TXC-
FMT-PGOOD
A-GND
GND
GND
GND
MT-MONV
L-SPKR(-)
GND
GND
3.3V_ENG_SCL(DLP)
PC-TxD
GND
R-SPKR(+)
GND
GND
MTU-L
AC-OFF
ASIC-MTOD
TX0-
PC-RxD
L-SPKR(-)
MTU-R
GND
5VSDA
STBY-SHORT
MAIN-RELAY
MAIN-Pr
PC-RXD
CRIN(3)
L-SPKR(-)R-SPKR(+)
3.3V-ENG-SCL
STU-L
CMP1-Y
DM-VID
HDDFANSTP
GND
GND
GND
GND
GND
GND
GND
NC
DM-VID
PWR-ON
GND
GND
MTU-V
A-GND
PIC-Rxd
GND
IN3-C
ASIC-CLK
GND
GND
GND
VIN
A-GNDGND
AVR-R
GND
GND
NC
PIC-Rxd
HDD-RST
IR-IN
GND
GND
NC
SUB-Pr
GND
GND
AVR-L
MAIN-Pr
TV-RTS
DM-L
RMC
GND
SUB-V
NC
ENC-L
GND
TX2-
ENC-L
A-GND
GND
GND
L
GND
SUB-Y
L-SPKR(-)
GND
GND
LED
IN1-V
GND
GND
N
GND
PIC-CTS
KSCO
GND
IN1-C
CMP2-PbTV-Rxd
TV-Txd
PIC-RTS
DMD
GND
GND
PIC-CTS
GND
S3
KSC1
MON-VID
GND
TV-RESET
ENC-L
LAMP
YIN(3)
AVR-L
GND
MLINK-Rxd
5VSDA
LAMP-G
STU-R
DM-RESET
GND
GND
CBIN(6)
GND
GND
GND
MANRST
GND
GND
PWR-GOOD
ASIC-BANK
RELAY
GOS-Txd
DM-L
GND
GND
HDDFAMSTP
MLINK-Rxd
FSTP-PBS(LCD)
GND
R-SPKR(+)
GND
SUB-Y
GND
STATUS-R
CMP1-Pb
FMT-PGOOD
RST-TVGOS
AC-OFF
FAN-VCC-LAMP
YIN(1)
RS232-EN
GND
USBPB
KSC0
S2
MN-R
STU-V
MTU-V
GND
PCLK
NC
MN-L
RST-TVGOS
GND
LAMP-R
GND
TV-Txd
PIC-CTS
USBPB
GND
GND
CRIN(6)
GND
GND
GND
MT-AVR
STATUS-G
GND
HDD-TEMP
GND
TV-Rxd
GND
GND
GND
HDDFANPWR
LED
GND
GND
GND
GND
GND
DM-R
NC
FMT-PGOOD
COVER-DET
GND
GND
PIC-RTS
FMT-PGOOD
TX2_SHIELD(AGND)
YOUT(4)
GND
PWR-ON
MAIN-Y
GND
MAIN-Pb
GND
GND
GND
HDDFANSTP
PIC-Txd
PIC-CTS
STU-R
VOUT
GND
MAIN-Pb
GND
TX1_SHIELD(AGND)
GND
GND
FAN-VCC-PBS(LCD)
PON-SHORT
KSC1
GND
CMP2-Y
GND
GNDA-GND
GND
GND
TX0_SHIELD(AGND)
LAMP-RELAY
CRIN(1)
STU-L
RMC
GOS-CTS
FILTER-DET
IN3-V
GND
IN2-C
ASIC-DTOM
MAIN-H
USBNA
TXC_SHIELD(AGND)
GND
GND
GND
GLINK-Txd STU-L
GND
S3
YOUT(6)
GND
GND
GND
USB5V
GND
LAMP-EN
ENG-PWR-ON
TX2+
LAMP-DET(V29)
DM-L
MAIN-Pb
RS232-EN
GND
GND
GND
ENC-R
GNDMAIN-Pr
MN-L
LAMP-RELAY
BLP-ASIC-READY(DLP)
CBIN(1)
LAMP-RST(V28)
GND
MTU-V
GND
IN3-V
CBOUT(3)
GND
ENC-R
MAIN-Pb
BLP-ASIC-READY(DLP)
GND(BALLAST)
LAMP GND
5V(DLP ONLY)
GND(V28)
RMC
GND
PON-SHORT
TX1+
GND
GND
CMP3-PrPWR-GOOD
GND
AVR-L
RESETZ-DVI(DLP)
NC
3.3V_ENG_SCL(DLP)
GND
FSTP-MD(DLP/LCD)
NC
SUB-V
MN-L
IN3-Y
GND
GND
MTU-R
STU-R
POWERGOOD-DVI(DLP)
GND(ENGINE)
NC
FMTCTS
L-SPKR(-)
USBNA
GND
TXC_SHIELD(AGND)
GND
GND
HOUT
CMP1-Pr
GND
GND
ENG-PROTECT
NC
LAMPEN-DVI(DLP)
MN-L
GND
GND
GND
FAN-VCC-MD(DLP/LCD)
IN3-C
YOUT(3)
DM-R
TV-CTS
GND
SDA_DOC_2(LCD)
LAMP GND
GND
FAN-DET
LAMPLIT-DVI(DLP)
YIN(6)
NC
ASIC-CS
SUB-Pb
GND
LAMPLIT-DVI(DLP)
GND
GND
S2
STU-R
FSTP-LAMP
GND
DIM(DLP)
GND
FMTRxDGND
GND
GND
DM-RESET
YSOUT
IN3-R
CBOUT(2)
CMP1-Pb
ASIC-CS
SENSOR-DET
MAIN-V
GND-1
GND(5V&H/V-SYNC:AGND)
ENG-PWR-ON
LAMPEN
GND
GND
L-SPKR(-)
PON-SHORT
PIC-Rxd
GND
GND
ENC-R
ASIC-BANK
GND
GND GND
TX0_SHIELD(AGND)
GND(POWER)
LAMPLITZ
GND
GND
USB5V
LAMP-G
GND
IN3-L
CBOUT(6)
GND
MAIN-H
MD-TEMP
ENC-R
RMC
MTU-R
ENG-FAN-ON
RESETZ-DVI(DLP)
GND
GND
GND
GND
STU-V
IN3-L
YOUT(0)
AVR-L
R-SPKR(+)
GND
AVR-R
IR-IN
MAIN-Y
TX2-
FMTTxD
PCLK
MTU-L
PIC-Txd
LAMP-R
STBY
IN3-C
GMD
DM-R
GND
GND
GND
SUB-Pb
TX0-
LAMP-LITZ
YIN(5)
GND
PIC-Txd
PC-TXD
DM-L
GND
IN3-V
GND
TV-RTS
YOUT(1)
LAMP-R
GND
3.3V_ENG_SDA(DLP)
LAMP-FAN-CONT(DLP)
BUSREQ
GND
GND
AVR-L
ENC-L
GOS-RTS
GND
HDMI-L
IN1-Y
YOUT(7)
MN-R
LED
SUB-V
TX2_SHIELD(AGND)
GND
STAT-R
DLP-FAN-CONT(DLP)
GND
GND
GND
GND
CMP3-Pb
CBOUT(5)
STU-R
LAMP-G
AVR-R
YSIN
YOUT(5)
GND
ASIC-MTOD
GND
POWERGOOD-DVI(DLP)
MD-TEMP
GND
MN-L
MN-R
CROUT(6)
GND
STATUS-R
GND
YIN(7)
YOUT(2)
ENC-L
TV-CTS
SUB-Y
GND
TX1-
IN3-R
IN1-V
GND
CROUT(0)
DM-VID
STATUS-G
SUB-H
CBIN(4)
CBOUT(7)
R-SPKR(+)
GND
GNDGND
LAMP-TEMP
TX0+
IN3-Y
CMP3-Pr
CMP3-Y
GND
ASIC-BANK
CARD-DETECT
CRIN(7)
CBOUT(4)
GND
GLINK-Txd
HDD-RST
LAMP-DET(V28)
TXC-
S3
GND
IN2-Y
PON-SHORT
MANRST
GOS-Txd
GND
GND
PWR-ON
STAT-R
DM-VID
TXC+
GND
GND
IN3-V
CROUT(7)
GND
KSC0
GND
CBOUT(1)
MAIN-Pr
STAT-G
MAIN-Y
TX1_SHIELD(AGND)
GND
IN2-V
GND
PWR-ON
GND
GND
NC
GND
GND
GND
MTU-L
MT-AVR
CROUT(1)
CARD-DETECT
KSC1
SCL_DOC_2(LCD)
MAIN-V
CROUT(5)
MLINK-Txd
STU-L
GND
LAMPEN-DVI(DLP)
MN-R
GND
ASIC-MTOD
GND
CROUT(2)
DM-L
MAN-RST
TV-RTS
HDMI-H
IN2-Y
GND
CROUT(4)
TV-Rxd
HDD-TEMP
GND
3.3V-ENG-SDA
GND
MTU-L
SUB-V
HDD
IN2-C
MTU-R
CROUT(3)
ASIC-DTOM
BUSREQ
PC-RxD
SUB-Pb
AVR-L
GND
GND
MON-VID
S1
A-GND
LOUT(+)
GND
PC-TxD
GOS-Rxd
GND
GND
TEMP
CMP1-Pr
GND
FSTP-DM
CBOUT(0)
AC-OFF
STBY-SHORT
LOUT(-)
ASIC-CS
PIC-RTS
SUB-Pr
TV-Txd
GND
GND
FAN-VCC
GND
DM-RESET
MAIN-RELAY
ROUT(-)
GND
SUB-H
SUB-HGND
GND
CMP3-Pb
CMP2-Pr
GND
GND
PWR-GOOD
HDDFANSTP
ROUT(+)
GND
CRIN(2)GND
AVR-R
HDMI-G
FAN-VCC
CMP1-Y
HDMI-R
5V(DLP ONLY)
TV-RTS
GND
GND
CBIN(0)
IR-IN
AC-OFF
3.3V-ENG-SDA
GND
GND
IN1-Y
GND
STBY
GND
MN-R
SCL_DOC_2(LCD)
GLINK-Rxd
PWR-GOOD
ASIC-BANK
GND
GND
GND
AC-OFF
LAMPEN
GND
SDA_DOC_2(LCD)
NC
LAMP-G
TV-RESETGND
GND
FMTCTS
FMT-PGOOD
HDDFANPWR
LAMPLITZ
GND
3.3V_ENG_SDA(DLP)
GND
CARD-DETECT
HDMI-R
GND
GND
IN2-V
DIM
GND
TV-CTS
GND
USBPA
GND
HDD-TEMP
GND
GND(LCD) GND
HDD-RST
GND
FMTRxD
LAMP-PROTECT
STBY
GOS-RTS
CBIN(2)
IR-IN
MTU-V
GND(LCD)
DIM(DLP)
HDMI-B
GND
GND
GND
STBY-SHORT
GND
GND
5VSCL
GND
TV-Txd
HDD-RST
MAIN-H
DM FAN
YIN(0)
GND
GND
MD-TEMP
GND
IN3-Y
GND
3.3V-ENG-SCL
ASIC-CS
GND
FMTRTS
STAT-G
USBNB
GND(ENGINE)
GND GND
FMTTxD
ASIC-CLK
A-GND
MLINK-Txd
CBIN(5)
NC
ENG-PWR-ON
GND
LAMP-RELAY
GND
GND
ENG-PWR-ONPON-SHORT
GND
GNDGND
GND
GND
GND
GND
ENG-PWR-ON
PON-SHORT
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
NC
NC
NC
IR-IN
PWR-LED
MAN-RST
GND
KSC1
STATUS-G
LAMP-PROTECT
RMC
LAMP-G
STATUS-R
5VSL
KSCO
LAMP-R
KSCO
LAMP-PROTECT
LAMP-R
RMC
GND
PWR-LED
KSC1
LAMP-G
IR-IN
MAN-RST
STATUS-G
STATUS-R
Tolerance
Not indicated = +/-5%
G=+/-2%
: Tantalum capacitor
5. RESITOR
: Semiconductor Ceramic capacitor
Q=+30%
: Aluminus electrolytic capacitor
Not indicated : F or B (high dielrctric percentage)
Not indicated : 50V
Parts
except
for
chips
uF, for numbers less than 1
: Cemented resistor
J=+/-5%
: Carbon resistor
TF
MMF
: Styrol capacitor
Not indicated = +/- 10%
: chip resistor
: Metalized paper
Tolerance
4. CAPACITOR
MP
SC
Value Not indicated
: Metal film resistor
D=+/-2PF
No tolerance is indicated
for electrolytic capacitor
and +/- 20%
1. DC voltages were measured from points indicated to the circuit
: Ceramic capacitor chip
Not indicated
: Polyester polypropylene film capacitor
F = +/-1%
II
MF
K = 1,000 Ohm
M
ground with a high-Z voltmeter
Chips
ML
Not indicated
W
MB
Value
-20%
: Non polarized electrolytic capacitor
TAN
J = +/-5%
Not indicated
K=+/-10%
-0%
: Metal liner resistor
I
: Twin film capacitor
F=+/-1PF
K = +/-10%
: Metalized plastic film capacitor
C=+/-0.25PF
Not indicated = 1/4W or 1/6W
TANT
-0%
6. This is a basic schematic diagram. Some sets may be subject
to modification according to engineering improvement
Type
Dielectricstrength
P=+100%
NP
D = +/-0.5%
: Electrolytic capacitor
: Wire wound resistor
PP
-10%
Parts exceptfor chips
Not indicated = 1/10W
Type
D=+/-0.5PF
Not indicated = Ohm
Not indicated
PS
Z=+80%
MP
: Electrolytic capacitor
: Metalized polyester capacitor
chips
3. TP13.etc. show test points.
M=+/-20%
ALM
2. Wave form were taken with standard color bar signal.
CE
II
S
Wattage
M = 1,000,000 Ohm
PF, for numbers more than 1
: Fixed composition resistor
: Polypropylene film capacitor
T=+200%
: Non polarized electrolytic capacitor chip
CH, SL, etc. : Temperature compensaing types
MPP
MF,PP
NP
I
: Polyester capacitor
: Metal plate cement resistor
Parts
except
for
chips
chips
: Ceramic capacitor
: Metal oxide film resistor(Type B)
DA
FA
FB
FD
J8A01
J8A01
RA
FD
PD
DA
KB
FA
PD
FB
PH
RA
TATA
PA1
PA1
J3 J3
KA
KA
D-SUB 15PIN D-SUB 15PIN
(V31 ONLY)
JE
DT
JCJA
LT
JD
CD
CE1
LL
BALLAST FAN
V30+/V31 ONLY
Front 1394
PT
V30+/V31
JF
V29/V30
Front 1394
PG 25....DEMOD2
PG 24....DEMOD1
PG 14....DM3 [DMCORE]
PG 20....DM9 [MPEG ENCODER]
PG 12....DM1 [ATSC/NTSC TUNER]
PG 4.....FMT1 [SUITE / DVI]
PG 15....DM4 [DMMEMA/DC]
PG 3.....INTERFACE
PG 19....DM8 [DMPOD]
PG 22....DM11 [DMDPM7]
PG 1.....BLOCK
PG 23....TERMINAL
PG 2.....POWER
PG 10....MICRO3 [TV uP]
PG 11....MICRO4 [HDMI]
PG 21....DM10 [DMADC]
PG 18....DM7 [1394/DV I/F]
PG 8.....MICRO1 [VID-SW]
PG 16....DM5 [DMMEMB/USB]
PG 9.....MICRO2 [AUD-PIC]
PG 17....DM6 [DMROM/AV]
PG 5.....FMT2 [MICRO]
PG 13....DM2 [DMDDCDC]
SERVICE TECHNICIAN WARNING;
PG 28....E2P/FRONT/CONTROL/PREAMP
PG 27....RISER2
PG 26....RISER1
ENGINE-POWER
ATSC/NTSC TUNER
ATSC/NTSC TUNERATSC/NTSC TUNER
DMCORE
DMDPM7
DVI
MICRO
DVI
DMDCDCRISER
RISER
RISER
RISER
RISER
RISER
TVuPVID-SW
TVuP
ATSC/NTSC TUNER ATSC/NTSC TUNER
HDMI
PG 7.....FMT4 [PRELUDE]
PG 6.....FMT3 [ADC / XGA]
ES1
3.3V-ENG-SCL
L_OUT+
L_OUT-
R_OUT-
R_OUT+
L_SP
R_SP
3.3V-ENG-SDA
L_TWEETER
L_OUT+
L_OUT-
L_OUT-
L_OUT+
R_TWEETER
Characteristic(Only ceramiccapacitor)
PWB-MICRO
PWB-RISER
PWB-INTERFACE
ENGINE
PWB-POWER
PWB-DM
PWB-FMT
PWB-TERMINAL
FRONT
AVHDD
PWBENG-PWR
PWB-DEMOD1
PWB-DEMOD2
FRONTCARD
READER
E2P
861 122 4 9 1453 7 131110 15 16
L
M
N
17 18
H
A
J
E
B
K
F
C
G
I
D
LAMP
PWB-SW-LAMP
ANT
PREAMP
CONTROL
RELAY
LAMP BALLAST
WD-52627 V29
PAGE 1
WD-62628 V30
CONTENTS
WD-62627 V29
WD-52628 V30
* NOTES
WD-73827 V30+
WD-62927 V31
WD-62827 V30+
WD-73727 V30
WD-73927 V31
THIS PRODUCT INCLUES CRITICAL ELECTRICAL AND MECHANICAL PARTS ESSENTIAL FOR X-RADIATION PROTECTION
TO AVOID POSSIBLE TO X-RADIATION TAKE RADIATION PROTECTIVE
MEASURE FOR PERSONNEL DURING SERVICING.
SEE SERVICE INSTRUCTION FOR SPECIFIED REPLACEMENT
PARTS AND SERVICE ADJUSTMENTS.
X-RADIATION PRECAUTION
3 92 5 6 8 101 743 9 14 202 165 116 138 1810 19151 1774 12 21 22 23 24
1110 123 92 5 6 81 74
A-GND
18VS
5VS
5VS
LAMP-RELAY
ENG-PWR-ON
5VSL
A-GND
-15VS
+15VS
A-GND
+15VS
5VSL
STBY
STBY-SHORT
A-GND
-15VS
12VS
A-GND
AC-OFF
PON-SHORT
18VS
18VS
5VSL
MAIN-RELAY
MAIN-RELAY
5VR
PWR-ON
STBY-SHORT
18VS
STBY
18VSA
18VSA
12V
5VR
5V
+15VSA
12VS
5VS
5V
12V
-15VSA
PWR-ON
18VS
12VS
HDDFANPWR
FAN-STOP
HDDFANSTP
18VSA
5V
5VS12VS
HDD-RST
HDD-TEMP
HDDFANPWR
HDDFANSTP
FAN-VCC
FAN-STOP
HDD-TEMP
FAN-VCC
HDD-RST
LAMP-RELAY
ENG-PWR-ON
18VF
18VSA
PON-SHORT
ENG-PWR-ON
STBY
18VSB
18VS
18VSC
3.3V
PON-SHORT
3.3V
12V
3.3V
12VS
5VS
ENG-PWR-ON
ENG-PWR-ON
PWR-ON
+15VSA
+15VS
-15VSA
-15VS
+15VSA
-15VSA
A-GND1 2 3 4
5678
BD9702T-V5
GND
STBY
OUT
INV
VCC
T9A10
SRW42EC-U15V117
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
STR-W6735
S/GND
SS/OLP
N/C
VCC
D FB
OCP/BD
1
EMITTER
2
DRAIN
3DRAIN
4
DRAIN
5
SOURCE
6
GATE
7
BASE
8COLLECTOR
1 2 3 4
5678
21 22 23 24
1 KFF
2 RT
3 BP5
4 SYNC
5 SGND
6 SS/SD
7 VFB
8 COMP 9PGND
10LDRV
11BP10
12SW
13HDRV
14BOOST
15VIN
16ILIM
1
EMITTER
2
DRAIN
3
DRAIN
4
DRAIN
5
SOURCE
6
GATE
7
BASE
8
COLLECTOR
CD
V+
IN+
SI
GND
Cs
Es
CT
5 6 7 8
1 KFF
2 RT
3 BP5
4 SYNC
5 SGND
6 SS/SD
7 VFB
8 COMP 9PGND
10LDRV
11BP10
12SW
13HDRV
14BOOST
15VIN
16ILIM
1
SOURCE1
2 GATE1
3
SOURCE2
4 GATE2 5
DRAIN2
6DRAIN2
7
DRAIN1
8DRAIN1
125V 5A
K
REF
A
1
EMITTER
2
DRAIN
3
DRAIN
4
DRAIN
5
SOURCE
6
GATE
7
BASE
8
COLLECTOR
NC CVCC
OUT
CTL6
GND
1S2076A/1S2471OM
1S2076A/1S2471OM
1
23
AC-OFF
10uFC9E63
25V
1K1/16W
R9E35
47K1/16W
R9A48
50V
C9A481U
2SC3052-T112-1E,F
Q9A11
L9A642.7MH
1/16W
R9E6013K
1/2W
R9A11220K
470C9A81
25V/50V
D9A39
UDZS5.6B
0.22
C9A43
50V
25V
C9A32680U
1/2W
R9A031M (UL)
22K1/16W
R9A38
1/16W
R9E58220
12K1/16W
R9A98
56K1/16W
R9E03
PC9A21
SFH6156-T1-E3
1
2 3
4
L9A34
22MH 9X9.5
1/16W
R9E36270
2SC3052-T112-1E,F
Q9A1710V
C9A65680U
0.1C9A29
50V
1/16W
R9E59910
4.7M1/2W
R9D00
470C9A46
500V
1K1/16W
R9A94
1/16W
R9A9727K
1/16W
R9A413.3K
35V
C9E2247U
D9A41
UDZS3.9B
120K1/16W
R9E54
L9A43
22MH 9X9.5
1000C9A16
AC250V
3 52 41
L9A1022MH
0.1C9A54
50V
2SC3052-T112-1E,F
Q9A01
1/2W
R9A09220K
1/16W
R9A872.2K
0.1C9D02
AC125V/250V
2SC3052-T112-1E,F
Q9A10
0.015C9A14
AC125V/250V
1K1/16W
R9E68
1UFC9A77
V25
L9D03
HF2836-353Y1R0-T01
1
23
4
1/16W
R9A572.2
L9A62GSRH127-7R6M
450V
C9A04150U
25V
C9A35470U
1 2 3 4 5 6 7 8 9 10
1/4W
R9A91270
1K3W
R9A77
0.1
C9A83
50V
1/16W
R9E211.3K
3K1/16W
R9A93
25V
C9A36680U
0.01C9A49
50V
2200C9A08
AC250V
L9A51
22MH 9X9.5
L9D02
ELF22V025A
1
23
4
2201/4W
R9A54
0.272W
R9A21
25V
C9A37680U
10uFC9A73
25V
0.1C9A61
50V
82C9E56
50V
1/2W
R9A251K
F9A06125V 5A
25V
C9A68100U
3300C9E32
50V
L9A33GSRH125-4ROM
L9A6010MH
25V
C9A38680U
1/2W
R9A17180K
1/2W
R9A2068K
HOTGND
22K1/16W
R9A46
1500C9A28
1KV
1/10W
R9E630
0.1C9E01
50V
4.7K1/16W
R9A35
1UFC9E15
V25
39K1/16W
R9E05
2200C9A09
AC250V
2SC3052-T112-1E,F
Q9E51
180K1/16W
R9E52
2SC3052-T112-1E,F
Q9E01
0.1C9E13
50V
1/16W
R9E55160K
0.1C9A67
50V
J2
8200C9A58
25V/50V
1/16W
R9A602.2
4 5 6 7 8 91 2 3
1/16W
R9E0022K
1UFC9E02
V25
D9A22
UDZS6.8B
L9A32
2.7MH
16V
C9E64470U
F9A02125V 25A
2200C9A11
AC250V
25V
C9A72680U
L9E20
BLM18PG600SN1
33K1/16W
R9E62
PC9A10
SFH6156-T1-E3
1
23
4
1/16W
R9E23100
1UFC9A18
V25
1M (UL)1/2W
R9A06
680C9E62
50V
0.01C9A44
25V/50V
L9A53
22MH 9X9.5
8200C9E54
25V/50V
1UFC9E58
V25
0.015C9A13
AC125V/250V
200V
C9A27
1000U
1 3
D9E52
UDZS13B
J1
3 52 41 6 7
16V
C9A82470U
470C9A23
25V/50V
2201/4W
R9A29
0.1C9E21
25V/16V
8200C9A57
25V/50V
1UFC9A17
V25
1/16W
R9E206.8K
01/16W
R9E34
0.1
C9E00
50V
2200C9A06
AC250V
1 3 5
47K1/16W
R9E51
1UC9A22
16V
F9A04125V 5A
1K1/16W
R9A37
1/16W
R9E2210K
1001/16W
R9A63
1/16W
R9A393.3K
10uFC9A52
25V
2W
R9A13100K
25V
C9A33680U
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
1/16W
R9E611.8K
HOTGND
56K1/16W
R9E06
1 2 3 4 5 6 7 8 9 10 11 12
0.1C9A69
25V
IC9A21
TPS40055PWPR
1/16W
R9A89680
100K1/16W
R9A27
1K1/16W
R9E69
25V
C9A53680U
L9A56
10MH
0.022C9A55
50V
33K1/16W
R9A90
L9D00
HF3545-502Y5R0-T01BH
1
23
4
56
L9A2010MH
L9A61
10MH
2W
R9A14100K
1/10W
R9E650
0.1C9E36
25V
3300C9E33
50V
12
3
8 6 57
41 2 3
1 2 3 4
1500C9A19
1KV
0.1C9D01
AC125V/250V
2SC3052-T112-1E,F
Q9A08
L9A2110MH
F9A10FCC20252ADTP
2201/4W
R9A36
50V
C9A2110U
2701/4W
R9A64
6.810W
R9A01
D9A47
UDZS5.6B
22K1/16W
R9A44
16V
C9A75470U
33K1/16W
R9E01
1K1/16W
R9A95
470C9A31
500V
10uFC9A64
6.3V
1/10W
R9E320
1UFC9A78
V25
2201/4W
R9A52
22K1/16W
R9A45
25V
C9E45
680U
L9A632.7MH
2.21/10W
R9E43
25V
C9A70100U
0.1C9E50
50V
1001/10W
R9A24
L9A35
6.8MH 9X9.5
35V
C9A402200U
1/16W
R9E642.2
0.1C9E66
50V
16V
C9A71470U
16V
C9A99470U
1K3W
R9A78
1/2W
R9A16
180K
1/4W
R9A3068
0.1C9E12
50V
4700C9E53
50V
1K1/16W
R9A32
2201/4W
R9A56
HOTGND
47K1/16W
R9A26
L9A31
2.7MH
2SC3052-T112-1E,F
Q9E50
15K1/16W
R9A10
1/16W
R9A592.2
2201/16W
R9A31
0.1C9E57
50V
0.1C9A41
50V
L9A37GSRH127-221M
120K1/16W
R9A82
200V
C9A021000U
1/16W
R9E412.2
2SA1235A-T112-1E,F
Q9E02
L9A55
10MH
2200C9A05
AC250V
F9A07125V 5A
1/16W
R9A5327K
1/16W
R9E672.2
2SC3052-T112-1E,F
Q9A02
1000C9A15
AC250V
F9A03125V 5A
221/10W
R9A79
1/16W
R9A082.2K
2SC3052-T112-1E,F
Q9A16
L9A3822MH 9X9.5
1/16W
R9A582.2
22K1/16W
R9A07
L9A40
10MH
2701/4W
R9A65
L9A50
22MH 9X9.5
1K1/16W
R9A92
IC9E50
TPS40055PWPR
F9D00
S10A 125V
D9A03
UDZS5.6B
680C9A63
50V
F9A01
1/2W
R9A1968K
2200C9A00
AC250V
1/16W
R9E5027K
180K1/16W
R9A49
L9A39GSRH127-470M
0.272W
R9A22
39K1/16W
R9E02
1M (UL)
1/2W
R9A05
0.1C9D03
AC125V/250V
AG9D00DSS-302M
1K1/16W
R9E37
16V
C9A741000U
0.1C9A24
25V
16V
C9E65470U
1 2 3
200V
C9A031000U
1/16W
R9A1210K
1UFC9A50
V25
25V
C9E60680U
22K1/16W
R9A40
200V
C9A261000U
L9A30
6.8MH 9X9.5
F9A08
125V 7A
10V
C9A66680U
1/16W
R9E422.2
82K1/16W
R9E04
10uFC9E59
25V
L9A36
22MH 9X9.5
1K1/16W
R9A23
1UC9A42
16V
1UFC9A62
V25
0.01C9A25
50V
1/16W
R9A86220
1/16W
R9A501K
1/16W
R9A83160K
2.2K1/16W
R9A96
1/16W
R9A8813K
F9A09FCC20252ADTP
16V
C9A451000
L9A54
22MH 9X9.5
L9A196.8MH 9X9.5
22K1/16W
R9A42
2201/4W
R9A55
0.1C9A60
50V
82C9A59
50V
16V
C9A98470U
2SC3052-T112-1E,F
Q9A09
L9A52
22MH 9X9.5
27K1/16W
R9A34
0.1C9D00
AC125V/250V
F9A05125V 7A
2200C9A10
AC250V
220K1/16W
R9A62100K1/16W
R9A61
6.810W
R9A02
2200C9A01
AC250V
35V
C9A392200U
2.21/10W
R9E66
0.1C9E61
50V
0.01C9A80
50V
1/10W
R9E330
1/16W
R9E531K
2.7K1/16W
R9A33
470C9A47
500V
0.1C9E20
25V/16V
10uFC9E35
6.3V
0.022C9E51
50V
1500C9A90
1KV
3 52 41
2SC3052-T112-1E,F
Q9E20
K9A20LKS1AF-12V
1S1
2S23
C1
4C2
K9A21LKS1AF-12V
1S1
2S23
C1
4C2
K9A10LKS1AF-12V
1S1
2S23
C1
4C2
1S2471OM
D9A451S2076A/
EC21QS04-TE12LD9A38
1S2076A/1S2471OMD9A02
1S2471OM
D9A431S2076A/
MA732D9E53
1S2471OM
D9A331S2076A/
1S2471OM
D9A371S2076A/
1S2076A/1S2471OMD9A04
1S2471OM
D9A351S2076A/
D9A18
AL01ZD9A25
EC21QS04-TE12L
D9A40
D9A19
1S2471OM
D9A421S2076A/
1S2471OM
D9A361S2076A/
MA732D9E54
AL01Z
D9A24
30PRA20-FC5
D9A31
MA732D9A44
30PRA20-FC5
D9A32
D9A201S2076A/1S2471OM
AL01ZD9A23
MA732D9E50
D9A00D6SB80
1
2 3
4
D9A01D6SB80
1
2 3
4
D9A26FCH20A10
NC
R9A16 connected to
HOT GND
HOT GND
HOT GND
PWP GND
340V
R9A17 connected to D9A00 heatsink.
18V, 0.32A MAX
5V (To DLP Engine) (To Riser PWB)(PA connector) (PD connector)
(To DLP Engine)(PA connector)
NC
D9A01 heatsink.
D9A26 heatsinkconnected to gnd.
NC
IC9A23 heatsinkconnected to gnd.
NC NC
5V
ENG-PWR-ON
12VS
PWP GND
7.6V
7.6V
Q9A12
Si7872DPT1E3
RV9D01
PB
PS
IC9A10
PL
Q9A15TPCP8J01(te85lf,f)
Q9E52
Si7872DPT1E3
Q9A13
TPCP8J01(te85lf,f)
IC9A22NJM2374AM
PC
RV9D00
Q9E00TPCP8402 (TE85LF,F)
IC9A20RT9H301C
Q9A14TPCP8J01(te85lf,f)
IC9A25BA00CC0WFP
12VS SUPPLY SWITCH.
5V SUPPLYSWITCH
PG 25....DEMOD2
PG 26....RISER1PG 12....DM1 [ATSC/NTSC TUNER]
PG 18....DM7 [1394/DV I/F]
PG 10....MICRO3 [TV uP]
PG 22....DM11 [DMDPM7]
PG 15....DM4 [DMMEMA/DC]
PG 2.....POWER
PG 11....MICRO4 [HDMI]
PG 9.....MICRO2 [AUD-PIC]
PG 19....DM8 [DMPOD]
PG 28....E2P/FRONT/CONTROL/PREAMP
PG 4.....FMT [SUITE / DVI]
PG 8.....MICRO1 [VID-SW]
PG 7.....FMT [PRELUDE]
PG 1.....BLOCK
PG 13....DM2 [DMDDCDC]
ENGINE-POWER
PG 24....DEMOD1
PG 16....DM5 [DMMEMB/USB]
PG 23....TERMINAL
PG 27....RISER2
PG 3.....INTERFACE
PG 20....DM9 [MPEG ENCODER]
PG 21....DM10 [DMADC]
PG 17....DM6 [DMROM/AV]
PG 5.....FMT [MICRO]
PG 14....DM3 [DMCORE]
PG 6.....FMT [ADC / XGA]
IC9A23
PHPA1
PD
ET9A02
ET9A01
(TO LAMP BALLAST)
(TO RISER PWB: CHASSIS) (TO RISER PWB: CHASSIS)(TO ENG-PWR) (TO INTERFACE PWB)
NL
(TO AC POWER CORD)
(TO AVHDD)
(ALL V30+ AND V31)
5VR SUPPLYSWITCH
COLDLIVE
COLDLIVE
* *
*
* *
*
53 127 111082 13 14961 4 15 16
B
J
K
H
E
F
A
C
G
D
I
AC-OFF DETECT.
MODELS CHASSIS
VCC SHORT DETECT.
5VSL NJR BUCK CONVERTER
3.3V ROHM BUCK CONVERTER
AC-OFF BUFFER
C9A98, C9A99, L9A51, L9A52, C9E20
AUDIO SUPPLY SWITCH
Q9E20, C9E21, C9E22, R9E20, R9E21,
R9E22, R9E23, L9E20, IC9A25, PH
ROHM FAN VCC AND FAN CONTROL
AVHDD VCC AND FAN CONNECTOR
AVHDD
LAMP BALLAST SWITCHAND IN-RUSH RELAYS.
IC9A10 IN-RUSH RELAY.
IC9A10
(18VS ANDAUDIO VCC)
12VS TI BUCK CONVERTER
MAIN POWER SUPPLY
WD-73727 V30
WD-52628 V30
WD-62628 V30
WD-73927 V31
WD-73827 V30+
WD-52627 V29CONTENTS
WD-62927 V31
WD-62627 V29
PAGE 2
WD-62827 V30+WD-52627, WD-62627
WD-52628, WD-62628,V30
V29
LAMP BALLAST POWER SUPPLY.
DOUBLER CIRCUIT.
WD-73727
V31
V30+WD-62827, WD-73827
WD-62927, WD-73927 O
O
X
X
5V, 6.5A MAX.
12V
12VS
5VS TI BUCK CONVERTER
3 9 14 202 165 116 138 1810 19151 1774 12 21 22 23 24
3914 2511 613 810 17 412
BOSS
3
9
14
2
16
5
11
6
13
8
10
15
1
7
4
12
3 9 14 202 165 116 138 1810 19151 1774 12
L9J04
68MH 9X9.5
L9J05
68MH 9X9.5L9J06
68MH 9X9.5
2K1/16W
R9J03
1K1/16W
R9J04
2K1/16W
R9J20
2K1/16W
R9J21
2K1/16W
R9J22
2K1/16W
R9J23
1K1/16W
R9J24
1K1/16W
R9J25
1001/16W
R9J05
1K1/16W
R9J26
2K1/16W
R9J27
1K1/16W
R9J28
2K1/16W
R9J29
2K1/16W
R9J30
2K1/16W
R9J32
2K1/16W
R9J34
1K1/16W
R9J35
2K1/16W
R9J37
2K1/16W
R9J38
1K1/16W
R9J39
2K1/16W
R9J40
0.1C9J13
25V/16V
0.1C9J14
25V
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
RT1N436C-T112-1Q9J01
3
BC
2201/10W
R9J41
2201/10W
R9J42
0R9J09
0R9J10
0R9J43
0R9J44
01/16W
R9J45
01/16W
R9J46
1K1/16W
R9J06
0R9J47
01/16W
R9J48
01/16W
R9J49
50V
C9J15
10U
50V
C9J16
10U
4.7K1/16W
R9J36
4.7K1/16W
R9J50
2201/16W
R8P27
2201/16W
R8P28
1001/16W
R9J01
100R9J02
100R9J31
1001/16W
R9J33
1001/16W
R9J51
100R9J52
100R9J53
100
1/16W
R9J54
4.7K1/16W
R9J55
4.7K1/16W
R9J56 4.7K1/16W
R9J57
4.7K1/16W
R9J58
4.7K1/16W
R9J59
4.7K1/16W
R9J60
4.7K1/16W
R9J61
2
3
4
5
6
7
8
9
1
0
1/16W
R9J64
01/16W
R9J65
01/16W
R9J66
01/16W
R9J67
01/16W
R9J68
1 2 3 4 5 6 7
891011121314
1 2 3 4 5 6 7
891011121314
0R9J69
0R9J75
1K1/16W
R9J12
1K1/16W
R9J14 1K1/16W
R9J78
0.01C9J23
50V
0.01C9J24
50V
1234567891011121314
2SC3052-T112-1E,F
Q9J03
50V
C9J02220U
0.1C9J03
50V0.1
C9J06
50V
0.1C9J09
50V
L9J01
CD-1010-101
50V
C9J01470U
0.1C9J10
50V
2SA1235A-T112-1E,F
Q9J02
10K1/16W
R9J80
2SC3052-T112-1E,F
Q9J05
1K1/16W
R9J07
50V
C9J110.1
50V
C9J04470U
L9J02
CD-1010-101
50V
C9J05220U
2SC3052-T112-1E,F
Q9J07
Q9J06
10K1/16W
R9J82
1001/16W
R9J76
1001/16W
R9J79
50V
C9J120.1
50V
C9J07470U
L9J03
CD-1010-101
50V
C9J08220U
0R9J63
01/16W
R9J70
390R9J77
390
R9J11
1.2K1/16W
R9J18
360
R9J13
180R9J16
1.2K1/16W
R9J19
SI-8050JD
SI-8050JDSI-8050JD
2 3 4 5 6 7 8 9 101 11 12 13 14
2 3 4 5 6 7 81
4
5
6
7
8
1
2
3
2 3 4 5 6 7 8 9 101 112 3 41
1K1/16W
R9J15
22K1/16W
R9J83
EC21QS04-TE12LD9J09
EC21QS04-TE12LD9J08
EC21QS04-TE12LD9J07
DAN202UD9J02
DAN202UD9J03DAN202U
D9J01
DAN202U
D9J11
DAN202UD9J13
D9J04
HZM27WA
D9J05
HZM27WA
D9J06
HZM27WA
D9J10
HZM27WAD9J12
HZM27WA
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
3.3VSL
STATUS-G
STATUS-R
LAMP-G
LAMP-R
PWR-LED
MAN-RST
KSC1
KSC0
STATUS-G
STATUS-R
LAMP-G
LAMP-R
MAN-RST
KSC1
KSC0
BALLAST-FAN-CONT
PBS/LAMP-FAN-CONT
LCD/DLP-FAN-CONT
PWR-LED
ENG-SDA
ENG-SCL
CLRN
BUSYX
DDAN
ENG-SCL
CLRN
BUSYX
DDAN
ENG-SDA
LAMPLITZ
LAMPEN
LAMPLITZ
FSTP-LAMP
FILTER-DET
COVER-DET
MD-TEMP
MD-TEMP
FAN-DET
FAN-DET
ENG-PROTECT
ENG-PROTECT
MOTOR-CLK
MOTOR-SET
MOTOR-ST
MOTOR-DAT
ENG-FAN-ON
SENS-OP
SENS-CLMOTOR-CLK
MOTOR-DAT
MOTOR-SET
MOTOR-ST
SENS-OP
SENS-CL
PBS/LAMP-FAN-CONT
LAMP-PROTECT
LAMP-PROTECT
ENG-PWR-ON
DIM
LCD/DLP-FAN-CONT
DIM
FSTP-PBS(LCD)
FSTP-MD(LCD/DLP)
IR-IN
AMC
IR-IN
AMC
FSTP-MD(LCD/DLP)
FSTP-BALST
LAMP-DET
SENSOR-DET
LAMP-TEMP
LAMP-TEMP
SENSOR-DET
COVER-DET
FSTP-LAMP
LAMP-DET
FAN-VCC-BALLAST
FAN-VCC-MD
FAN-VCC-MD
FSTP-PBS(LCD)
3.3VSL
18V-ON
FSTP-BALST
FAN-VCC-PBS/LAMP
FAN-VCC-PBS/LAMP
PBS/LAMP-FAN-CONT
ENG-FAN-ON
LAMPENFILTER-DET
LCD/DLP-FAN-CONTBALLAST-FAN-CONT
21 22 23 24
1VCC
2OUT
3GND
4INV
5STBY
1VCC
2OUT
3GND
4INV
5STBY
1VCC
2OUT
3GND
4INV
5STBY
3.3VSL
5VS
5VS
5VSL
5VSL
3.3VS
3.3VS
3.3VSL
3.3V
18V
KB
KA
KD
PB
LEAN
KC
CJ3
IC9J01
SN74LVC14APWR
IC9J02
SN74LVC14APWR
FB
FC
1A
1Y
2A
2Y
3A
3Y
GND
4Y
4A
5Y
5A
6Y
6A
VCC
1A
1Y
2A
2Y
3A
3Y
GND
4Y
4A
5Y
5A
6Y
6A
VCC
IC9J05
IC9J04IC9J03
2SA1235A-T112-1E,F
TO/FROM RISER TO CONTROL TO PREAMP
TO POWER
TO FMT - MICRO
TO FMT - MICRO TO SHUTTER CONTROL
TO ENGINE
TO BALLASTTO SENSORS & FANS
390
0
R9J13 R9J66
0
0
V30,V30+,31
R9J47CHASSIS R9J16
390
0
560
R9J67
0
220
0
R9J48R9J09
180
390
0
560
R9J68
220
0
R9J49R9J10
390
R9J70
360 0
0
0
V28
R9J41
390
R9J11
0
R9J64
0
0V29
R9J42 R9J69
0
390
390
0
0
WD-73727 V30
WD-52628 V30
WD-62628 V30
WD-73927 V31
WD-73827 V30+
WD-52627 V29CONTENTS
WD-62927 V31
WD-62627 V29
PAGE 3
WD-62827 V30+
V28 ONLY
V28 ONLY
V28 ONLY
V28 ONLY
V29 ONLY
V28 ONLY
PWB ID
V29 ONLY
V29 ONLY
FAN-VCC-BALLAST
PBS/LAMP-FAN-CONT
LCD/DLP-FAN-CONT
(V28 ONLY)
SEE NOTE
V29,30,30+,31 ONLY
V29 ONLY
B
J
K
H
E
F
A
C
G
D
I
21 1512118 161410 137 95 643
PG 25....DEMOD2
PG 26....RISER1PG 12....DM1 [ATSC/NTSC TUNER]
PG 18....DM7 [1394/DV I/F]
PG 10....MICRO3 [TV uP]
PG 22....DM11 [DMDPM7]
PG 15....DM4 [DMMEMA/DC]
PG 2.....POWER
PG 11....MICRO4 [HDMI]
PG 9.....MICRO2 [AUD-PIC]
PG 19....DM8 [DMPOD]
PG 28....E2P/FRONT/CONTROL/PREAMP
PG 4.....FMT [SUITE / DVI]
PG 8.....MICRO1 [VID-SW]
PG 7.....FMT [PRELUDE]
PG 1.....BLOCK
PG 13....DM2 [DMDDCDC]
ENGINE-POWER
PG 24....DEMOD1
PG 16....DM5 [DMMEMB/USB]
PG 23....TERMINAL
PG 27....RISER2
PG 3.....INTERFACE
PG 20....DM9 [MPEG ENCODER]
PG 21....DM10 [DMADC]
PG 17....DM6 [DMROM/AV]
PG 5.....FMT [MICRO]
PG 14....DM3 [DMCORE]
PG 6.....FMT [ADC / XGA]
BOSS
BOSS
BOSS BOSS
11
10
12
3
9
14
2
5
11
6
13
8
10
1
7
4
12
1/16W
R7L27F-2.2K
50V
C7K2810U
Z-0.1C80E2
25V/16V
1/16W
R7L32F-56K
Z-.1C80E3
25V/16V
GND
12K1/16W
R7K25
16V
C7K0147U
1/16W
R7K324.7K
GND
GND
Z-.1C80E1
25V/16V
2.7K1/16W
R7K34
GND
1/16W
R7L28F-3.3K
3.3K1/16W
R7K02
K-0.1C7K25
16V
GND
N11
N77
N55
N66
N22
N44
N33
N8 8
GND
12K1/16W
R7K23
GND
1/16W
R7K291.2K
1
2
3
4
GND
8
6
5
7
4
1
2
3
1/16W
R7K35100
Z-1UC7K27
16V
3301/16W
R7L21
50V
C7K2110U
1/16W
R7L29F-5.6K
1/16W
R7K011K
1/16W
R7K21270
GND
K-0.01C7K30
25V/50V
10K1/16W
R7K27
8
2
63
54
7
1
220K1/16W
R7K31
GND
GND
1/16W
R7L30F-12K
12K1/16W
R7K24
GND
K-0.1C7K26
16V
1501/16W
R7K28
16V
C7K2347U
3301/16W
R7L24
1/16W
R7L26F-1.5K
1/16W
R7L31F-33K
K-.1
C7L21
16V
47K1/16W
R7K22
L7K01221 OHM
3301/16W
R7L23
1/16W
R7K26220K
3301/16W
R7L22
10K1/16W
R7K30
GND
220C7K20
50V
GND
10K1/16W
R80E1
01/16W
R7L1201/16W
R7L1401/16W
R7L1301/16W
R7L11
8
6
5
7
4
1
2
3
2
3
4
1
10 456789 123
10 456789 123
3 7 10
14
11
138654 9 1212
1/16W
R7K36100
1/16W
R7K37100
Z7K01GP1UM283QK
1 2 3
2SC3052-T112-1E,FQ7K21
123
S7F00
SSCF210100
12345
4 123
S7F01
SSCF210100
12345
D7L21LN31GPH
D7L20RSB6.8S
D2J91RSB6.8S
D2J92RSB6.8S
D2J93RSB6.8S
D7L22SML1216W-C,D
1
2
3
D7L23SML1216W-C,D
1
2
3
SFH235FA
D7K21
MC2838-T112-1
D7K22
680C9F13
50V
10uFC9F15
6.3V
0.1C9F08
50V
180K1/16W
R9F02
0.1C9F19
50V
IC9F00
TPS40071PWPR
0.1C9F02
25V
33C9F07
50V
1/16W
R9F031K
10V
C9F17680U
10uFC9F11
25V
1UFC9F09
V25
0.1C9F00
50V
10K1/16W
R9F06
0.1C9F10
50V
0.1C9F01
50V
8200C9F04
25V/50V47K1/16W
R9F01
D9F02
UDZS3.9B
10V
C9F18680U
2.21/10W
R9F15
L9F041.5MH-M
1/16W
R9F0027K
2201/4W
R9F16
10uFC9F16
6.3V
330K1/16W
R9F04
1/16W
R9F05160K
25V
C9F12680U
1/16W
R9F182.2
2SC3052-T112-1E,F
Q9F00
01/10W
R9F17
1/16W
R9F122.2K
1/16W
R9F142.2
L9F01GSRH129-4R0M01
1/16W
R9F1013K
L9F002.7MH
1/16W
R9F095.6K
2SC3052-T112-1E,F
Q9F01
10uFC9F14
25V
1.3K1/16W
R9F13
1/16W
R9F08220
L9F021.5MH-M
8200C9F05
25V/50V
L9F031.5MH-M
MC2838-T112-1
D9F03
MA732D9F04
MA732D9F00
1
2
3
4
5
6
7
8
9
10
11
12
1
2
3
4
5
6
7
8
9
10
11
12
13
14
REMOCONPRE-AMPUNIT
AN
PJ2J11
S7L21KSHS611BT
S7L29
KSHS611BT
S7L25KSHS611BT
IC7K21OPA2350PA
S7L26KSHS611BT
S7L27KSHS611BT
EP
IC80E1AT24C256N-10SC/SI-2.7
IC80E324LC64I/SN
S7L24
KSHS611BT
S7L20KSHS611BT
S7L22KSHS611BT
S7L28
KSHS611BT
S7L23
KSHS611BT
IC80E224LC512T-I/SM
LE
CE1
CF CD
Q9F02
Si7390DPT1E3
Q9F03
Si7336ADPT1E3
3
9
2
5
6
8
1
7
4
PA1
J3
FRNT-R
FRNT-L
FRNT-V
LED
MANRST
KSC1
KSC0
GND
GND
GND
GND
GND
GND
GND
STATUS-R
LAMP-G
LAMP-R
RMC
IR-IN
FRNT-S
FRNT-Y
FRNT-C
STATUS-G
18VS
PON-SHORT
ENG-PWR-ON
2.5V
2.5V
12V
3.3V
3.3V
OUTA
OUTB
+INB
-INB
-INA
V-
+INA
V+
VCC
SCL
SDA
WC
VSS
E0
E1
E2
VCC
A1
SCLA2
SDAVSS
WP
A0
VCC
SCL
SDA
WP
VSS
A0
A1
A2
S11B-PASK-2
11
S11B-PASK-2
11
1 KFF
2 RT
3 LVBP
4 PGD
5 SGND
6 SS
7 VFB
8 COMP 9PGND
10LDRV
11DBP
12SW
13HDRV
14BOOST
15VDD
16ILIM
1
SOURCE
2
SOURCE
3
SOURCE
4
GATE
5
DRAIN
6
DRAIN
7
DRAIN
8
DRAIN
1
SOURCE
2
SOURCE
3
SOURCE
4
GATE
5
DRAIN
6
DRAIN
7
DRAIN
8
DRAIN
5VSL
3.3VS
LAMP
DEVICE
STATUS
MAN-RESET
ADJ-DOWN
MENU
ADJ-UPADJ-LEFT CANCEL GUIDE
ENTER
POWER/TIMER
VOL-UP/ POWER
FORMAT/
ADJ-RIGHTVOL-DOWN/ CH-UP/CH-DOWN/
(TO DLP ENGINE)
(TO POWER)
(R) (G) (G)(R)
SDAE
GND
SCLE
GND-1
440C412-30
PWP GND
GND
12V
GND
3.3V
GND5V
GND
12V
GND
2.5V
GNDGND
2.5V
GND
GND2.5V
2.5V
GND
GND5V
PWB-CONTROL
PWB-FRONT
PWB-PREAMPPWB-E2P
TO DM PWB
PWB-SWFILTER PWB-SWLAMP
B
J
K
H
E
F
A
C
G
D
I
21 1512118 161410 137 95 643
PWB-ENG-PWR
TO PWB-TERMINAL
2.5VS BUCK CONVERTER
WD-73827 V30+
WD-52627 V29CONTENTS
WD-62927 V31
WD-62627 V29
PAGE 28
WD-62827 V30+
WD-73727 V30
WD-52628 V30
WD-73927 V31
WD-62628 V30
PWB-INTERFACE AN
TO PWB-INTERFACE
TO PWB-INTERFACE TO PWB-INTERFACE
3.3V
18V. 4.7A MAX.
PG 28....E2P/FRONT/CONTROL/PREAMP
PG 19....DM8 [DMPOD]
PG 4.....FMT1 [SUITE / DVI]
PG 8.....MICRO1 [VID-SW]
PG 6.....FMT3 [ADC / XGA]
ENGINE-POWER
PG 1.....BLOCK
PG 13....DM2 [DMDDCDC]
PG 24....DEMOD1
PG 16....DM5 [DMMEMB/USB]
PG 23....TERMINAL
PG 27....RISER2
PG 3.....INTERFACE
PG 20....DM9 [MPEG ENCODER]
PG 21....DM10 [DMADC]
PG 17....DM6 [DMROM/AV]
PG 5.....FMT2 [MICRO]
PG 14....DM3 [DMCORE]
PG 26....RISER1PG 12....DM1 [ATSC/NTSC TUNER]
PG 18....DM7 [1394/DV I/F]
PG 25....DEMOD2
PG 7.....FMT4 [PRELUDE]
PG 10....MICRO3 [TV uP]
PG 22....DM11 [DMDPM7]
PG 15....DM4 [DMMEMA/DC]
PG 2.....POWER
PG 11....MICRO4 [HDMI]
PG 9.....MICRO2 [AUD-PIC]