ECN CS-2432 AFTER INSTALLING THE DOOR PLEASE FORWARD TO H4409232 Rev J JAMISON DOOR COMPANY THE MAINTENANCE DEPARTMENT OR OWNER. P/N H4409232
MK IV OVERHEAD DOOR
REPLACEMENT PARTS BOOK
JAMISON DOOR COMPANY P.O. BOX 70
HAGERSTOWN, MARYLAND 21740 1-800-532-3667 301-733-3100
INTERNET: http://www.JamisonDoor.com E-MAIL: [email protected]
ECN CS-2432 2 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
2
THIS PAGE LEFT BLANK
ECN CS-2432 3 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
3
INDEX
SECTION TITLE PAGE 1. Instruction Sheet for Ordering Replacement Parts 4 2. Overhead 6 3. Torsion Shaft Assembly 8 4. Torque Operator for High Lift Door 9 5. Rollers and Brackets 10 6. Top Latch Assembly 12 7. Frame Gasket Assembly 14 8. Front Locking 16 9. Back Release and Cylinder Locking 17 10. Miscellaneous Door Parts 18 11. Pull Cord Switch 19 12. Control Panel (for Control Panels Shipped Prior to 1/1/06) 20 13. Control Panel (for Control Panels Shipped After 1/1/06) 22 14. Control Panel 575 Volt 24 15. Limit Switch Assembly 26 16. Power Unit Assembly 28 17. Standard Lift Power Operator Sub-Assembly 30 18. Pneumatic Edge Assembly 32
ECN CS-2432 4 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
4
1. INSTRUCTION SHEET FOR ORDERING REPLACEMENT PARTS A. GENERAL INSTRUCTIONS NOTES:
1. Sufficient information must be included with all orders so that we can give prompt and accurate service. The specific information needed includes: a. The stock number, drawing number and name of the part
I. If possible give the stock number or drawing number of the part to be replaced. b. The HIC and WIC of the door. c. State whether the door is a bi-parting or single. If the door is a single state which direction it opens. d. Finish
I. Galvanized (Galv), chrome (Chr), bright chrome (BChr), stainless steel (SST), or Tuffkote finish (similar to gray paint). Other coatings may be available see the applicable parts lists for information.
2. Parts highlighted in gray are no longer available.
B. MASTER LABEL PLATE FOUND ON CONTROL PANEL
ECN CS-2432 5 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
5
INSTRUCTION SHEET FOR ORDERING TORSION SPRINGS
NOTES:
1. When ordering a replacement torsion spring, the following information is required. a. The total length of the coiled spring. b. The inside diameter of the spring. c. The diameter of the spring wire. Measure the length of 10 coils and divide this by 10. d. Original job name to which the door was shipped. e. Specify either right hand (standard for single spring) or left hand wound spring.
ECN CS-2432 6 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
6
2. OVERHEAD
ECN CS-2432 7 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
7
Ref # Group Finish Offset Name of Part Stock No. Drawing No. 1* Vertical Track Section 3 Leaf (LH) 4409-005-03 4409-5 3 Leaf (RH) 4409-005-53 4409-5 4 Leaf (LH) 4409-006-04 4409-6 4 Leaf (RH) 4409-006-54 4409-6 5 Leaf (LH) 4409-007-05 4409-7 5 Leaf (RH) 4409-007-55 4409-7 2 Vertical Track Section High Lift Special Order 3* Horizontal Track Section with Radius (LH) 4409-009-01 4409-9 3* Horizontal Track Section with Radius (RH) 4409-009-51 4409-9 4* Rear Spreader Angle Special Order 5 Clip Angle 4409-011-01 4409-11 6 Horizontal Track Angle 4409-010-01 4409-10 Track Support Bracket (Counted From the Floor) 1
st W/ Heated Sill 4409-032-01 4409-32
1st and 2
nd 4409-004-01 4409-4
3rd
and 4th 4409-004-02 4409-4
5th and 6
th 4409-004-03 4409-4
8 Carriage Bolt 5/16”–18 x 1” 751-008 9 Heavy Hex Nut 5/16”–18 752-123 10 Shakeproof Lock Washer 5/16” 753-403 11 Flat Washer 11/16” x 11/32” x 16 GA 753-003 12 Machine Bolt 3/8”–16 x 1” 751-420 13 Lock Nut 3/8”–16 752-205 *When ordering specify the H.I.C. and W.I.C. and right or left hand.
Note: See instruction sheet for ordering parts.
ECN CS-2432 8 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
8
3. TORSION SHAFT ASSEMBLY
Ref # Group Finish Offset Name of Part Stock No. Drawing No. 1 5” Bearing Plate Assembly (W/ Bearing) 489-139 2 Standard Lift Cable Drum (LH) 489-130 2 Standard Lift Cable Drum (RH) 489-128 3 High Lift Drum (2’-0” to 4’6” High Lift) (LH) 489-125 3 High Lift Drum (2’-0” to 4’6” High Lift) (RH) 489-126 4 High lift Drum (4’7” to 10’0” High Lift) (LH) 489-127 4 High lift Drum (4’7” to 10’0” High Lift) (RH) 489-128 5* Torque Spring Shaft 311-301 6 3-3/4” Spring Winder Sleeve (LH) 489-134 6 3-3/4” Spring Winder Sleeve (RH) 489-133 7 5-1/4” Spring Winder Sleeve 4409-065-51 4409-65 8 3-3/4” Spring Bearing Retainer (LH) 489-132 8 3-3/4” Spring Bearing Retainer (RH) 489-131 9 5-1/4” Spring Bearing Retainer 489-135 10 Center Bearing Plate 489-124 11 End Bearing 481-065 12 Machine Bolt 3/8”-16 x 1-1/2” 751-420 13 Flat Washer 13/16” x 13/32” x 13 GA 753-006 14 Lock Nut 3/8”-16 752-205 15 Sleeve Nut 486-053 16 Cable with Terminal End and Button Stop Standard Lift Special Order High Lift Special Order 17 Spring Spacer (5-1/4” Springs Only) 4409-030-01 4409-30 18 Key 1/4” x 3-1/4” 4409-063-01 4409-63 19 Key 1/4” x 3” (5-1/4” Springs Only) 4409-064-01 4409-64 20 Center Bearing 481-068 *When ordering specify the H.I.C. and W.I.C. and right or left hand.
Note: See instruction sheet for ordering parts.
ECN CS-2432 9 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
9
4. TORQUE SHAFT OPERATOR FOR HIGH LIFT DOOR
Ref # Group Finish Offset Name of Part Stock No. Drawing No. 1* Torque Shaft Special Order 2 Drive Sprocket 4409-090-01 4409-90 3 Connecting Link #40 1/2” Pitch 202-005 4 Mounting Angle 4409-087-01 4409-87 5 Mounting Bracket 4409-086-01 4409-86 6 Manual Operator Assembly (Optional Equipment) Special Order 7 Clip Angle 4319-657-01 4319-657 8 Set Screw 5/16”-18 x 3/8” 764-104 9 Key 1/4” x 1” 4277-331-01 4277-331 10 Machine Bolt 3/8”–16 x 1-1/2” 751-422 11 Lock Nut 3/8”–16 752-205 12 Flat Washer 13/16” x13/32” x 13GA 753-006 13 Machine Screw Round Head 1/4”-20 x 2-1/4” 764-121 14 Hex Nut 1/4”-20 752-104 15 Roller Chain #40 1/2” Pitch 202-004
Note: See instruction sheet for ordering parts.
ECN CS-2432 10 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
10
5. ROLLERS AND BRACKETS
ECN CS-2432 11 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
11
Ref # Group Finish Offset Name of Part Stock No. Drawing No. 1 Galv Bottom Roller Bracket (LH) 4409-118-01 4409-118 1 Galv Bottom Roller Bracket (RH) 4409-118-51 4409-118 1 SST Bottom Roller Bracket (LH) 4409-118-02 4409-118 1 SST Bottom Roller Bracket (RH) 4409-118-52 4409-118 2 Galv Roller Bracket # 2 4409-119-01 4409-119 2 SST Roller Bracket # 2 4409-119-02 4409-119 3 Galv Roller Bracket # 3 (LH) 4409-120-01 4409-120 3 Galv Roller Bracket # 3 (RH) 4409-120-51 4409-120 3 SST Roller Bracket # 3 (LH) 4409-120-02 4409-120 3 SST Roller Bracket # 3 (RH) 4409-120-52 4409-120 4 Galv Roller Bracket # 4 (4 and 5 Leaf Doors Only) (LH) 4409-121-01 4409-121 4 Galv Roller Bracket # 4 (4 and 5 Leaf Doors Only) (RH) 4409-121-51 4409-121 4 SST Roller Bracket # 4 (4 and 5 Leaf Doors Only) (LH) 4409-121-02 4409-121 4 SST Roller Bracket # 4 (4 and 5 Leaf Doors Only) (RH) 4409-121-52 4409-121 5 Galv Top Roller Bracket (3 Leaf Doors Only) (LH) 4409-122-01 4409-122 5 Galv Top Roller Bracket (3 Leaf Doors Only) (RH) 4409-122-51 4409-122 5 SST Top Roller Bracket (3 Leaf Doors Only) (LH) 4409-122-02 4409-122 5 SST Top Roller Bracket (3 Leaf Doors Only) (RH) 4409-122-52 4409-122 6 Galv Top Roller Bracket (4 Leaf Doors Only) (LH) 4409-123-01 4409-123 6 Galv Top Roller Bracket (4 Leaf Doors Only) (RH) 4409-123-51 4409-123 6 SST Top Roller Bracket (4 Leaf Doors Only) (LH) 4409-123-02 4409-123 6 SST Top Roller Bracket (4 Leaf Doors Only) (RH) 4409-123-52 4409-123 7 Galv Roller Bracket #5 (5 Leaf Doors Only) (LH) 4409-134-01 4409-134 7 Galv Roller Bracket #5 (5 Leaf Doors Only) (RH) 4409-134-51 4409-134 7 SST Roller Bracket #5 (5 Leaf Doors Only) (LH) 4409-134-02 4409-134 7 SST Roller Bracket #5 (5 Leaf Doors Only) (RH) 4409-134-52 4409-134 8 Galv Top Roller Bracket (5 Leaf Doors Only) (LH) 4409-151-01 4409-151 8 Galv Top Roller Bracket (5 Leaf Doors Only) (RH) 4409-151-51 4409-151 8 SST Top Roller Bracket (5 Leaf Doors Only) (LH) 4409-151-02 4409-151 8 SST Top Roller Bracket (5 Leaf Doors Only) (RH) 4409-151-52 4409-151 9 Roller 481-062 10 Galv Lifting Angle (LH) 4319-047-01 4319-47 10 Galv Lifting Angle (RH) 4319-047-51 4319-47 10 SST Lifting Angle (LH) 4319-047-02 4319-47 10 SST Lifting Angle (RH) 4319-047-52 4319-47 11 Hex Washer Head Taptite 3/8”-16 x 1” 769-102 11 SST Hex Head Machine Bolt 3/8-16 x 1” 751-505 12 Hex Head Machine Bolt 3/8-16 x 1” 751-420 12 SST Hex Head Machine Bolt 3/8-16 x 1” 751-505 13 Lock Washer 3/8” 753-503 13 SST Lock Washer 3/8” 753-504 14 Lifting Angle Bushing 4319-048-01 4319-48 15 Flat Washer 753-006 15 SST Flat Washer 753-169 16 SST Spring Lock Washer 3/8” 753-504
Note: See instruction sheet for ordering parts.
ECN CS-2432 12 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
12
6. TOP LATCH ASSEMBLY
Ref # Group Finish Offset Name of Part Stock No. Drawing No. 1 Galv Latch Base 4319-018-01 4319-18 1 Chr Latch Base 4319-018-02 4319-18 2 Galv Latch Pawl (2” Door) 4319-730-03 4319-730 2 Chr Latch Pawl (2” Door) 4319-730-04 4319-730 2 Galv Latch Pawl (4” Door) 4319-730-01 4319-730 2 Chr Latch Pawl (4” Door) 4319-730-02 4319-730 2 Galv Latch Pawl (6” Door) 4319-019-01 4319-19 2 Chr Latch Pawl (6” Door) 4319-019-02 4319-19 3 Spring 482-032 4 SST Pivot Pin 754-221 5 Cotter Pin 1/8” x 1-1/4” Long 754-307 6 Eye Bolt with Nut 5/16 x1” 751-207 7 Sash Chain (No. 50) (H.I.C. minus 6’ 8”) 489-010 8 “S” Hook 3/16” x 1-1/2” Diameter 489-022 9 Pull Ring 5/16 x 3” Diameter 489-020 12 Tapetite Bolt 5/16” x 1-1/4” Long 759-105 13 Galv Latch Strike Plate 4406-250-01 4406-250 13 SST Latch Strike Plate 4406-250-02 4406-250 14 Galv Taptite Bolt 3/8”-16 x 1” 769-102 14 SST Taptite Bolt 3/8”-16 x 1” 751-505 15 SST Flat Washer 7/8” x 13/32” x .062 753-164 16 Galv Hex Head Type F Self Tapping Screw 1/4”-20 x 3/4” 765-402 16 SST Truss Head Machine Screw 1/4”-20 x 3/4” 764-601 17 Flat Washer 753-002 18 Eye Bolt with Nut 751-210
Note: See instruction sheet for ordering parts. Be sure to specify the door thickness and finish.
ECN CS-2432 13 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
13
THIS PAGE LEFT BLANK
ECN CS-2432 14 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
14
7. FRAME GASKET ASSEMBLY
ECN CS-2432 15 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
15
Ref # Group Finish Offset Name of Part Stock No. Drawing 1* Gasket Sub-Assembly Horiz. (White) 1* 5’0” 4404-010-01 4404-10 1* 6’0” 4404-010-02 4404-10 1* 7’0” 4404-010-03 4404-10 1* 8’0” 4404-010-04 4404-10 1* 9’0” 4404-010-05 4404-10 1* 10’0” 4404-010-06 4404-10 2* Gasket Sub-Assy. Vert. (White) (Specify Hand) 2* 6’0” 4404-010-11 4404-10 2* 7’0” 4404-010-12 4404-10 2* 8’0” 4404-010-13 4404-10 2* 9’0” 4404-010-14 4404-10 2* 10’0” 4404-010-15 4404-10 2* 12’0” 4404-010-16 4404-10 2* 14’0” 4404-010-17 4404-10 3* Gasket Retainer 3* SST 5’0” LH 4404-016-21 4404-16 3* SST 5’0” RH 4404-016-71 4404-16 3* SST 6’0” LH 4404-016-22 4404-16 3* SST 6’0” RH 4404-016-72 4404-16 3* SST 7’0” LH 4404-016-23 4404-16 3* SST 7’0” RH 4404-016-73 4404-16 3* SST 8’0” LH 4404-016-24 4404-16 3* SST 8’0” RH 4404-016-74 4404-16 3* SST 9’0” LH 4404-016-25 4404-16 3* SST 9’0” RH 4404-016-75 4404-16 3* SST 10’0” LH 4404-016-26 4404-16 3* SST 10’0” RH 4404-016-76 4404-16 3A Head Gasket Retainer (Order Reference 3, RH) 4 SST Pan Head Screw #14 x 2” 765-361 5* Gasket Outer Wrapper .04 x 5” 552-165 6* Flat Gasket Retainer for Doors w/Jambs (Not Shown) 4404-422-xx 4404-422 7 Screw (for Flat Gasket Retainer) 765-359 8 Gasket Heat Wire (Call Factory w/Serial Number) xxx-xxx *Please specify the HIC and WIC of the door that the item is to be used on.
Note: See instruction sheet for ordering parts.
ECN CS-2432 16 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
16
8. FRONT LOCKING
Ref # Group Finish Offset Name of Part Stock No. Drawing No. 1 Mounting Angle 4243-565-01 4243-565 2 Rivet 4243-266-01 4243-266 3 Switch with screws (Power Door Only) 113-001 4 Carriage Bolt (5/16”18 x 1”) 751-008 5 Hex Nut (5/16”-18) 752-123 6 Flat Washer (11/16” o.d. x 11/32” i.d. x 16GA.) 753-003 7 Hasp Blade (2” and 4” Door) 4243-572-01 4243-572 8 Hasp Blade (6” Door) 4243-568-01 4243-568 9 Staple (3/8” Hole) 4243-059-01 4243-59 10 Phenolic Washer 753-306 11 Staple Lock Plate 4243-060-01 4243-60 12 Pop Rivet (AD 54 BS) 755-365 13 Tee Handle Assy. (2” Door) 4243-664-02 4243-664 14 Tee Handle Assy. (4” Door) 4243-664-01 4243-664 Tee-Handle Assy. (6” Door) 4243-664-03 4243-664 15 Recessed Cup W/ Hole 4038-008-03 4038-8 16 Washer 753-017 17 Pop Rivet (AD 54 BS) 755-365 18 Staple 4243-028-01 4243-28 19 Lock Washer (5/16) 753-403
Note: See instruction sheet for ordering parts.
ECN CS-2432 17 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
17
9. BACK RELEASE AND CYLINDER LOCKING
Ref # Group Finish Offset Name of Part Stock No. Drawing No. 1* Front Handle Base Assy. 4406-247-01 4406-247 2 Shoulder Screw 5/16” x 1/2” 753-106 3 Washer 11/16” x 11/32” x 16 GA 753-003 4 Vinyl Coated Cable from Chain Lock 5 Set Screw 1/4”–20 x 1/4” 767-126 6 Washer 7 Pan Head Type “F” Screw #10-24 x 1/2” 765-310 8* Back Recessed Cup 4318-211-03 4318-211 9* Back Escutcheon 4318-052-01 4318-52 10 Thru Shaft (4” Door) 4406-245-01 4406-245 11 Back Handle 4318-547-01 4318-547 12 Roll Pin 5/16 x 7/8” 754-006 13 Screw, Truss Head Type “A” #8 x 3/4” 765-607 14 Screw, Pan Head Type “F” #8-32 x 1” 765-307 15* Dead Lock with Cylinder 483-049 16 Round Head Screw #10-24 x 1” 764-112 *Specify if hardware is Painted, Galvanized or Chrome Finish.
Note: See instruction sheet for ordering parts. Specify the door thickness, weather it is a cooler or freezer, and the door model and serial number.
ECN CS-2432 18 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
18
10. MISCELLANEOUS DOOR PARTS
Ref # Group Finish Offset Name of Part Stock No. Drawing No. 1 Rear Door Pull Cup 4038-008-01 4038-8 2 Rear Door Pull 4038-013-01 4038-13 3 Pop Rivet 755-365 4 Door Pull 251-010 5 Screw, Hex Head Taptite ( ¼”-20 x 1”) 769-103 6 Door Stop (4” and 6” Doors Only) 559-032 7 Gasket, Hollow Lo-Temp 512-006 8 Cord Attachment Bracket 4409-050-01 4409-50 9 Gasket Retainer 512-028 10 Gasket Insert 512-037 11 Screw #6 x1/2” Self Drilling 765-322 12 End Plug 559-037 13 Pop Rivet 755-366 14 Washer, Flat 5/8” x 9/32” x 16 GA 753-002 15 Eye Screw 1/4”–20 x 2-1/2” 751-210 16 Nylon Rope (5/16”) 999-021 17 Hex Nut 1/4”-20 752-104 18 Screw, Sheet Metal 763-439 18 SST Screw, Sheet Metal 765-322 19 SST Butt Hinge 439-016 20 Cord Connector 191-324 21 Lock Nut 191-400 22 Coiled Cord 18-2 121-020 22 Coiled Cord 18-3 121-021 22 Coiled Cord 18-4 121-022
Note: See instruction sheet for ordering parts.
ECN CS-2432 19 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
19
11. PULL CORD SWITCH
Ref # Group Finish Offset Name of Part Stock No. Drawing No. Assy. Complete WPS Switch (W/o Heat) 113-218 Assy. Complete WPS Switch (W/ Heat) 113-219 1 Pull Cord Rope W/ Tassel (Not Shown) 4285-059-02 4285-59 1 Pull Cord Rope Vinyl 60’ (Not Shown) 4285-049-01 4285-49
Note: See instruction sheet for ordering parts.
ECN CS-2432 20 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
20
12. CONTROL PANEL (FOR CONTROL PANELS SHIPPED PRIOR TO 1/1/2006)
Ref # Group Finish Offset Name of Part Stock No. Drawing No. Assy. Complete Control Panel Assy. (Give Model Number & Serial Numbers) (Specify NEMA 1, 3, 4, 4x or 12) 4390-238-xx 4390-238 *1 Housing – NEMA 3, 4 or 12 191-037 1 Housing – NEMA 1 486-117 1 Housing – NEMA 4x 191-040 2 Mounting Plate 4390-237-01 4390-237 3 Baffle 4390-122-01 4390-122 4 Transformer (240/480 Primary – 24 Volt Secondary) 115-106 5 Transformer (120/208/380 Primary – 24 Volt Secondary) 115-107 6 Fuse FNM-2 116-103 7 Reversing Contactor 111-037 8 Brass Cup Washer 753-905 9 Marker Strip 191-508 10 Terminal Strip 191-505 11 Stop Switch 113-108 12 Relay 111-029 13 Pilot Light (120V or 240V) 4290-073-01 4290-73 13 Pilot Light with Resister –(480V) 4290-073-03 4290-73 14 Time Delay 111-227 15 Termostst (80°) Optional 114-005 16 Heater (20 Watt) Optional 4369-044-01 4369-44 *17 Rubber Washer 11/16” x 9/32” x 1/16” 559-026 18 Self Tapping Screw #6-32 x 3/8” 765-303 19 Self Tapping Screw #6-32 x 1/2” 765-304 20 Self Tapping Screw #6-32 x 5/8” 765-305 21 Self Tapping Screw #8-32 x 3/8” 765-306 22 Round Head Machine Screw #10-32 x 3/8” 764-136 23 Self Tapping Screw #10-24 x 1/2” 765-310 24 Dual Speed Adder Block 111-040
Note: See instruction sheet for ordering parts.
ECN CS-2432 21 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
21
THIS PAGE LEFT BLANK
ECN CS-2432 22 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
22
13. CONTROL PANEL POWERTRON (FOR CONTROL PANELS SHIPPED AFTER 1/1/06)
ECN CS-2432 23 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
23
Ref # Group Finish Offset Name of Part Stock No. Drawing No. 1 DPDT Relay 111-029 4290-963 2 Rev. Contactor 60 Hz. 111-037 3 4 Floor Loop Socket 11-Pins, Octal Style 111-049 5 Time Delay 111-227 4390-216 6 Switch, Stop 113-108 4390-138 7 Thermostat 114-005 4290-69 8 Transformer Class 2 115-109 4390-434 9 Fuse 3AG, 1/4 Amp 116-107 10 Fuse, 3 Amp FNQ-R-3 600 VAC 116-108 11 Counter ENM #E4B74D 119-013 12 Floor Loop Unit 326SF24A-7, Harness 802A-4 119-014 13 Radio Control Multi-Code 1090 119-015 14 End Stop 170-004 15 Fuse Block 2 Poles 191-166 16 Fuse Block 1 Pole 191-167 17 Grounding Lug 191-355 18 Terminal Blocks 2-142 191-501 19 Marker, Number 191-508 4390-231 20 Enclosure, NEMA 4 191-514 4395-197 21 Enclosure, NEMA 4x 191-515 4395-197 22 Terminal Block 8 Rowes 191-518 23 24 25 Enclosure, NEMA 1 486-204 4390-416 26 Base Plate #16 GA. x 11” x 11” 486-205 4390-423 27 Din Rail 35mm x 5.25” 4390-406-02 4390-406 28 Bracket, Fuse Block #16 GA. 4390-417-01 4390-417 29 Baffle Plate #16 GA. 4390-418-01 4390-418 30 Bracket #16 GA. 4390-420-01 4390-420 31 Retainer #16 GA. 4390-422-01 4390-422 32 Heater Assy. 50W.120V. 4390-426-01 4390-426 33 Pilot Light Assy. NEMA 1 120V / 240V 4390-432-01 4390-432 34 Pilot Light Assy. NEMA 1 480V 4390-432-02 4390-432 35 Pilot Light Assy. NEMA 4 480V (STD) 4390-433-01 4390-433 36 Pilot Light Assy. NEMA 4 240V 199-016 37 Grounding Wire, Control Panel 14 AWG 13” Lg. 4390-470-02 4390-470 38 Ferrule 9/16 O.D. x 5/16 I.D. x 7/16 931-011 4277-359 39 Rnd Hd Mach Screw #10-32 x 3/8” lg 764-136
Note: See instruction sheet for ordering parts.
COMPLETE CONTROL PANEL ASSEMBLY (ACTIVE MODEL NUMBERS) (ALSO SPECIFY NEMA 1, 4, OR 4X) STANDARD SPEED…………………………………………… 4390-436-XX
OPTIONAL KITS AVAILABLE
CONTROL PANEL HEATER……………………………………439044401 H4390-444 GEARBOX AND MOTOR WITH HARDWARE………………..439504601 H4395-046 GEARBOX AND MOTOR NO HARDWARE…………………..439520401 H4395-204 TRAVEL LIMIT SWITCH HEATER……………………………..439511201 H4395-112 FLOOR LOOP………………………………………………….. H4390-425 RADIO CONTROL……………………………………………… H4390-424 TIME DELAY …………………………………………………….. H4390-227
ECN CS-2432 24 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
24
14. CONTROL PANEL POWERTRON 575 VOLT
ECN CS-2432 25 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
25
Ref # Group Finish Offset Name of Part Stock No. Drawing No. 1 DPDT Relay 111-029 4290-963 2 Rev. Contactor 60 Hz. 111-037 3 4 Floor Loop Socket 11-Pins, Octal Style 111-049 5 Time Delay 111-227 4390-216 6 Switch, Stop 113-108 4390-138 7 Thermostat 114-005 4290-69 8 Transformer 575 Volts 115-113 9 Fuse 3AG, 1/4 Amp 116-107 10 Fuse, 3 Amp FNQ-R-3 600 VAC 116-108 11 Counter ENM #E4B74D 119-013 12 Floor Loop Unit 326SF24A-7, Harness 802A-4 119-014 13 Radio Control Multi-Code 1090 119-015 14 End Stop 170-004 15 Fuse Block 2 Poles 191-166 16 Fuse Block 1 Pole 191-167 17 Grounding Lug 191-355 18 Terminal Blocks 2-142 191-501 19 Marker, Number 191-508 4390-231 20 Enclosure, NEMA 4 191-514 4395-197 21 Enclosure, NEMA 4x 191-515 4395-197 22 Terminal Block 8 Rowes 191-518 23 24 25 Enclosure, NEMA 1 486-204 4390-416 26 Base Plate #16 GA. x 11” x 11” 486-205 4390-423 27 Din Rail 35mm x 5.25” 4390-406-02 4390-406 28 Bracket, Fuse Block #16 GA. 4390-417-01 4390-417 29 Baffle Plate #16 GA. 4390-418-01 4390-418 30 Bracket #16 GA. 4390-420-01 4390-420 31 Retainer #16 GA. 4390-422-01 4390-422 32 Heater Assy. 50W.120V. 4390-426-01 4390-426 33 34 Pilot Light Assy. NEMA 1 480V 4390-432-02 4390-432 35 Pilot Light Assy. NEMA 4 575V (STD) 4390-433-03 4390-433 36 Grounding Wire, Control Panel 14 AWG 13” Lg 4390-470-02 4390-470 37 Fuse Holder Din Rail Mtg. 170-020 38 Fuse FNM-3 3 Amp 116-105
Note: See instruction sheet for ordering parts.
COMPLETE CONTROL PANEL ASSEMBLY (ACTIVE MODEL NUMBERS) (ALSO SPECIFY NEMA 1, 4, OR 4X) STANDARD SPEED 575 VOLT …………………………………………… 4390-457-XX
OPTIONAL KITS AVAILABLE
CONTROL PANEL HEATER……………………………………439044401 H4390-444 GEARBOX AND MOTOR WITH HARDWARE………………..439504601 H4395-046 GEARBOX AND MOTOR NO HARDWARE…………………..439520401 H4395-204 TRAVEL LIMIT SWITCH HEATER……………………………..439511201 H4395-112 FLOOR LOOP………………………………………………….. H4390-425 RADIO CONTROL……………………………………………… H4390-424 TIME DELAY …………………………………………………….. H4390-227
ECN CS-2432 26 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
26
15. LIMIT SWITCH ASSEMBLY
ECN CS-2432 27 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
27
Ref # Group Finish Offset Name of Part Stock No. Drawing No. Assy. Complete Limit Switch Assy. (Dual Speed) (NEMA1) 4395-026-04 4395-26 Assy. Complete Limit Switch Assy. (Dual Speed) (NEMA 4) 4395-026-05 4395-26 1 Housing (NEMA 4) 4395-199-01 4395-199 1 Housing (NEMA 1) 486-118 1 Housing (NEMA 4x) 4395-199-02 4395-199 2 Label 995-423 3 Base 4395-012-01 4395-12 4 Limit Switch Mounting Block 934-003 5A Actuator Block (Standard) 934-004 5B Actuator Block (Dual Speed) 934-014 6 Flange Bearing 481-018 7 Pillow Block Bearing 481-250 8A Shaft (Standard) 486-133 8B Shaft (Dual Speed) 486-157 9 Sprocket 4395-018-01 4395-18 10* Gasket (NEMA 3, 4, 4x or 12) 4395-019-01 4395-19 11* Gasket (NEMA 3, 4, 4x or 12) 4395-020-01 4395-20 12 Switch 113-009 13 Round Head Bolt 1/4”–20 x 6” 764-137 14 Round Head Bolt 1/4”–20 x 6” 764-137 15 Hex Head Bolt 1/4”–20 x 3/4” 751-402 16 Hex Lock Nut 1/4”–20 752-203 17 Self Tapping Screw #6–32 x 1” 765-102 18 Flat Washer 1/2” x 9/32” x 16 GA 753-151 19 Rubber Mounting Plate 4395-124-01 4395-124 20 Flat Washer 5/8” x 9/32” x 16 GA 753-002 22 Adapter Plate 4395-022-01 4395-22 23 Pedestrian Opening Switch Plate 4395-023-01 4395-23 24 Flat Head Self Tapping Screw #6–32 x 1” 765-209 25 Self Tapping Screw #10–24 x 3/8” 765-309 26 Split Lock Washer #10 753-401 27 Flat Washer 1/2” x 197 x 18 GA 753-100 28 Pedestrian Opening Assy. 4395-024-01 4395-24 *Use item 20 for items 10 and 11 with NEMA 1 housing.
Note: See instruction sheet for ordering parts.
ECN CS-2432 28 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
28
16. POWER UNIT ASSEMBLY
ECN CS-2432 29 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
29
Ref # Group Finish Offset Name of Part Stock No. Drawing No. 1 Gear Box 201-102 2 Collar 486-151 3 Roll Pin 3/16” x 2” 754-010 4 Friction Disc 991-200 5 Sprocket Assy. 4395-056-01 4395-56 6 Tongued Disc 4395-008-01 4395-8 7 Spring 753-908 8 Retainer 4395-009-01 4395-9 9 Lock Washer Split 1/2” 753-505 10 Machine Bolt W/ Locktite 1/2”-13 x 1-1/2” 751-440 11 Mounting Plate 4395-028-01 4395-28 12 Motor (115/230 Volt 1 Phase) 133-308 12 Motor (208-230/460 Volt 3 Phase) for Std. Lift 133-306 12 Motor (208-230/460 Volt 3 Phase) for High Lift 133-307 13 Key (1/8” x 1”) 4277-329-01 4277-329 14 Machine Bolt 3/8”-16 x 1” 751-420 15 Lock-washer Split 3/8” 753-503 16 Clip Angle 4395-027-01 4395-27 17 Rubber Grommet 559-029 18 Limit Switch Assembly See Limit Switch 19 Control Panel See Control Panel 20 Support Angle 4318-519-01 4318-519 21 Machine Bolt 3/8”-16 x 1-1/2” 751-422 22 Lock-nut, Hex 3/8”-16 752-205 24 Machine Bolt 3/8”-16 x 2” 751-422 25 Flat Washer 13/16” x 13/32” x 16 GA 753-006 26 Machine Bolt 3/8”-16 x 2” 751-424 27 Machine Bolt 1/4”-20 x 3/4” 751-402 28 Flat Washer 1-1/4” x 9/32 x 16 GA 753-015 29 Lock-nut, Hex 1/4”-20 752-203 30 Flat Washer 5/8” x 9/32” x 16 GA 753-002 31 Rubber Washer 11/16” x 9/32” x 1/16” 559-026 32 Limit Switch Chain (Specify Length) 202-004 33 Connecting Link #40 1/2” Pitch 202-005
Note: See instruction sheet for ordering parts.
ECN CS-2432 30 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
30
17. STANDARD LIFT POWER OPERATOR SUB-ASSEMBLY
ECN CS-2432 31 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
31
Ref # Group Finish Offset Name of Part Stock No. Drawing No. 1 Power Unit Support Plate 4319-673-01 4319-673 2 Hanger Angle 4319-675-01 4319-675 3 Rail Top Support Bracket 4319-674-01 4319-674 4 Rail Bottom Support Bracket 4319-675-01 4319-675 5* Drive Rail Special Order 6 Idler Bracket 4319-671-01 4319-671 7 Idler Sprocket 203-030 8 Oilite Bearing 481-004 9 Washer, Flat 1-3/4” x 13/32” x 1/8” 753-022 10 Washer, Spring Lock 3/8” 753-503 11 Machine Bolt 3/8”-16 x 1” 751-420 12 Brass Washer 2-1/4” x 1-1/16” x 1/8” 753-253 13 Machine Bolt 3/8”-16 x 1-1/2” 751-422 14 Washer, Flat 13/16” x 13/32” x 13 GA 753-006 15 Machine Bolt 3/8”-16 x 2-3/4” Full Thread 751-427 16 Pick-up Link 4370-255-01 4370-255 17 Drive Chain #40, 1/2” Pitch 202-004 18 Connecting Link (#2040) 202-011 19 Traveler Assembly 4319-532-01 4319-532 20 Washer, Flat 2” x 13/16” x 1/8” 753-108 21 Guide Roller 4319-520-01 4319-520 22 Lifting Link Std. Duty 4409-041-01 4409-41 23 Door Lifting Bracket 4319-039-01 4319-39 24 Roll Pin 1/8” x1” 754-003 25 Washer, Flat 1-3/4” x 13/16” x 14 GA 753-044 26 Machine Bolt 5/16”-18 x 2-1/4” 751-416 27 Machine Bolt 5/16”-18 x 4” 751-410 28 Lock Nut 5/16”-18 752-204 29 Lock Nut 3/8”-16 752-205 30 Sash Chain 489-010 * Specify door H.I.C.
Note: See instruction sheet for ordering parts.
ECN CS-2432 32 H4409232 Rev J
JAMISON DOOR COMPANY Phone: (USA & Canada) 1-800-532-3667 (Int.) 301-733-3100 P/N H4409232
32
18. PNEUMATIC EDGE ASSEMBLY
Ref # Group Finish Offset Name of Part Stock No. Drawing No. Assy. Pneumatic Reversing Edge Assy. Special 1 Gasket Insert (Width-in-Clear + 3-1/2”) 512-037 2 End Plugs H4409-237 4409-237 3 Hose (Width-in-Clear + 2”) 559-100 4 Vent Plug (Glue in Place) 4390-166-01 4390-166 5 End Plug (Glue in Place) 4390-167-01 4390-167 7 Air Duct 759-034 8 Hose (4” Long) 999-030 10 Gasket Retainer (Width-in-Clear +3-1/2”) 512-028 11 Screw, Truss Head (Type “A”) 765-307 12 Switch 113-113
Note: See instruction sheet for ordering parts.
