MT 6034 T - midtnequipment.com

MT 6034 TTelescopic Handler

Parts ManualCatalog 50960090 Rev. ABeginning with S/N 16251

Introduction MT6034T Telescopic Handler

MT6034T J F 00 00000

Model

Year (F=14, G=15, etc.) Month

Unit NumberEngine

When ordering service parts, specify the correct part num-ber, full description, quantity required, the machine modelnumber, and serial number. For your safety, and continuedproper operation, use only genuine Manitou service parts.

“Right” and “left” are determined from a position sitting onthe seat inside the cab and facing forward.

Manitou North America, Inc. reserves the right to makechanges or improvements in the design or construction ofany part of the machine without incurring the obligation toinstall such changes on previously delivered machines.

NOTE: This parts manual identifies both standard andoptional features for this model. Depending on the featuresof your machine, some of the items identified in the partslists may, or may not, be included with your machine.

Operator's Manual: P/N 50960089Engine Parts Manual: P/N 50960088

SERIAL NUMBER

RELATED MANUALS

A1Represents a port designation onhydraulic components (e.g., valves,cylinders, etc.)

Serial number breaks are indicated as follows:

• (SN 999 and before) - indicates serial numbers up to and including 999.

• (SN 1000 - 2000) - indicates serial numbers from 1000 to 2000.

• (SN 999 and up) - indicates serial numbers including 999 and after.

NOTE: When ordering parts, be sure to identify the last fivedigits of the machine's serial number.

HYDRAULIC AND ELECTRICAL SCHEMATICSHydraulic and electrical schematics can be found in theOperator’s and Service Manuals for this machine; pleaserefer to the information at the right for the correct manual.

SOME ABBREVIATIONS LISTED IN THIS MANUALASSY AssemblyAR As RequiredCFPD Contact Factory Parts DepartmentEU European Union (standards)HYD HydraulicIN Inch(es)INC/INCL Included or includesLN Lock NutMM/mm MillimeterNA Not Applicable or Not AvailableNPT National Pipe ThreadNSS Not Sold SeparatelyORB O-Ring BossREF ReferenceSN Serial NumberW/ WithW/O Without

TiltCylinderparts are

on page 247.

Interior CabOptions areon page 18.

Refer to page126 for the

warningdecal.

Identifies whereadditional pagesfor component

parts, seals, andkits can be found.

Identifies whereadditional

information canbe found.

Alerts and directsuser to investigatemore information.

The following icons shown on various pages provideimportant information or identify where additionalinformation can be found.

NOTE:Hydraulicbulkhead

fitting.

Identifies missing,hidden parts, or

adds informationalcomments.

Warning or Important

Information

Important information to

follow

Seal Kit Repair Kit

PRINTED IN U.S.A. 1 50960090/AP0914

PageINTRODUCTIONTable of Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1Filters and Belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4

CABCab and Covers (Standard) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6Cab Mounts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8Front Work Lights and Strobe Light (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9Glass - Front and Rear Window Group (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10Wipers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12Glass - Top and Left Window (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16Instruments, Switches and Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18Fuses, Relays, and Modules . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .20Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22Steering Column and Shifter Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .24Steer Motor and Steer Select Valve Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .26Brake and Accelerator Pedals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .28Brake Valve Hydraulic Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .30Cab Components - Tri-Function Controls (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .32Heater (Option) - (No A/C) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .34A/C - Heater - (A/C - Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .36A/C Circuit (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .38Heater Circuit (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .40A/C Condenser - (A/C Equipped - Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .42

CHASSISHoods - Front . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .44Hoods - Center . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46Hoods and Covers - Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .48Hydraulic Tank Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .50Fuel Tank Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .52Battery Group and ECU . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .54Frame Level Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .56

PERSONNEL WORK PLATFORMBoom Components - (Standard PWP) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .58Level Sensor, Module, Chains, and Manifold (for Standard and Radio Remote) . . . . . . . . . . . . . . . . . . . .59PWP Radio Remote (Option) - Transmitter and Receiver . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .60

ENGINEExternal Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .62A/C Compressor Group - (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .64Fuel Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .66Radiator and Cooler Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .68Radiator and Cooler Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .70Air Intake Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .72Exhaust Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .74

MT6034T Telescopic Handler Table of Contents

50960090/AP0914 2 PRINTED IN U.S.A.

PageTRANSMISSIONExternal Components (including driveshafts) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76Drive (Flex) Plate Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .78Converter Housing Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .79Case and Plate Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80Torque Converter Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .82Gear Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .84Drive Pump Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .86Charge Pump Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .87Output Shaft Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .88Reverse Idler Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .89Forward and Reverse Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90Third Shaft Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .92First and Second Shaft Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .94Modulation Valve Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .96Control Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .97

AXLEExternal Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .98Brake and Steering Circuit - Front Axle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .100Brake and Steering Circuit - Rear Axle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .102Front Axle - Steer Cylinder and Tie Rods Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .104Rear Axle - Steer Cylinder and Tie Rods Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .105Front Axle - Differential Housing Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .106Rear Axle - Differential Housing Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .107Front Axle - Brake Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .108Rear Axle - Brake Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .109Front Axle - Outer End Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .110Front Axle - Differential Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .112Rear Axle - Outer End Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .114Rear Axle - Differential Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .116

BOOMOuter Boom Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .118Intermediate Boom Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .120Inner Boom Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .122Dynattach Bracket Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .124

BOOM HYDRAULICSLift Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .126Tilt / Slave Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .128Boom Extend Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .130Auxiliary Hydraulics Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .132

HYDRAULIC SYSTEMSHydraulic Pump Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .134Hydraulic Control Valve and Hoses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .136Dual Controls Circuit (Standard) Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .138Tri-Function Control (Option) - Standard Hydraulics Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .140Tri-Function Control (Option) and Auxiliary Hydraulics Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .142

Table of Contents MT6034T Telescopic Handler


Page

Radio Remote (Option) Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .144Dual Controls - Standard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .146Dual Controls with only Auxiliary Hydraulics (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .148Dual Controls with only PWP (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .150Dual Controls with PWP and Auxiliary Hydraulics (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .152Dual Controls with Radio Remote (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .154Dual Controls with Radio Remote and Auxiliary Hydraulics (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . .156Tri-Function Control (Option) with only PWP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .158Tri-Function Control (Option) with PWP and Auxiliary Hydraulics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .160Tri-Function Control (Option) with Radio Remote . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .162Tri-Function Control (Option) with Radio Remote and Auxiliary Hydraulics . . . . . . . . . . . . . . . . . . . . . . .164

HYDRAULIC COMPONENTSHydraulic Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .166Joystick Relief - Flow Divider . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .167Hydraulic Control Valve (including auxiliary hydraulics work section) . . . . . . . . . . . . . . . . . . . . . . . . . . .168PWP Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .170Steer Select Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .171Steer Motor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .172Brake Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .173Pilot Apply Manifold - Tri-Function Controller (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .174Radio Remote (Option) Manifold . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .175Controller - Tilt/Frame Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .176Controller - Lift/Extend . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .178Controller - Tri-Function (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .180Controller - Auxiliary Hydraulics (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .182Frame Level Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .184Lift Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .186Slave Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .188Tilt Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .190Boom-Extend Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .192Fork-Shift Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .194Rotating-Carriage Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .195

ATTACHMENTSCarriage Forks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .196Standard Carriage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .198Fork-Shift Carriage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .200Rotating Carriage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .202Truss Booms and Bucket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .204

DECALSGeneral Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .208New Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .208Decal Locations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .209

INDEXESNumeric Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .212Subject Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .220

MT6034T Telescopic Handler Table of Contents


Maintenance MT6034T Telescopic HandlerFilters and Belts

1

2

34

5

67

9

1011

1312

PrimaryAir

SecondaryAir

SecondaryFuel

Fuel/WaterSeparator

EngineOil

HydraulicStrainer

(In Hydraulic Tank)

EngineBelt

A/C Compressor Belt(A/C Option)

Cab Air(Heater or A/C Option)

Transmission

8


Item Part Description Qty. Item Part Description Qty.No. No. Req. No. No. Req.

01 132023 FILTER, ENGINE OIL . . . . . . . . . . . 102 50303847 FILTER, WATER SEPARATOR . . . . 103 50220612 WATER SENSOR (includes #4) . . . 104 50220613 SEALING RING . . . . . . . . . . . . . . . . 105 50302441 FILTER, FUEL (secondary) . . . . . . . 106 50352454 FILTER, ENGINE AIR (main). . . . . . 107 50352455 FILTER, ENGINE AIR (secondary) . 108 L99184 FILTER, TRANSMISSION . . . . . . . . 1

09 211146 FILTER, RECIRCULATING . . . . . . . 1(cab air; located in HVAC unit)

10 L97489 FILTER, HYDRAULIC OIL. . . . . . . . 111 L49327 STRAINER, OIL SUCTION . . . . . . . 1

(located in hydraulic tank)12 50220511 BELT, ENGINE. . . . . . . . . . . . . . . . . 113 271491 BELT, A/C COMPRESSOR (option) 1

MT6034T Telescopic Handler MaintenanceFilters and Belts


Cab MT6034T Telescopic HandlerCab and Covers (Standard)

LOWER SUPPORT

UPPER SUPPORT

SKID PLATE

23

22

21

20

19

1110 12

18

171615

14

413

33

33

32

31

21

30

6

29

2135

28

27

26

25

18

15161714

24

21

32

4

1

InstrumentPanel and

switches areon page 18.

Load Chartsare listed onpage 210.

5

INSTRUMENT PANELAND LOAD CHARTS

6

987

34

LEFT MIRROR(OPTIONAL)

36

26

25

37



01 50380734 CAB (frame only) . . . . . . . . . . . . . . . 102 L69297 PLATE, INCLMT MOUNT . . . . . . . . 103 L66011 INDICATOR/FRAME LEVEL . . . . . . 1

L50417 #8-32X1” SCREW . . . . . . . . . . . . . . 204 651640 5/16”-18X3/4” BUTT. HD BOLT . . . . 205 L50051 1/4”-20 WHIZ LOCK NUT. . . . . . . AR06 102692 COVER, FUSE PANEL . . . . . . . . . . 107 105636 PANEL, DASH . . . . . . . . . . . . . . . . . 1

L50202 BHSCS 1/4"x5/8" (not shown) . . . . . 608a L63634 LOAD CHART PLATE (metal) . . . . . 2

L69402 LOAD CHART PLATE (plastic). . . AR09 L63887 1/4”-20 U-BOLT . . . . . . . . . . . . . . . . 110 103022 BULB SEAL, RIGHT WINDOW. . . . 111 103021 GLASS, RIGHT HAND . . . . . . . . . . 1

103675 SCREEN (option - not shown)12 L500057 CLIP, WINDOW . . . . . . . . . . . . . . . . 213 102880 MOUNT, REAR GLASS UPPER . . . 214 L50051 1/4”-20 WHIZ NUT. . . . . . . . . . . . . . 315 L500022 WASHER, FLAT (BLACK) . . . . . . . . 316 L500020 BUSHING, NYLON . . . . . . . . . . . . . 317 L500021 GROMMET, 1/2”ID X 1/4”GROOVE 318 L52024 1/4”-20X1” BUTT. HD BOLT . . . . . . 319 103023 GLASS, REAR. . . . . . . . . . . . . . . . . 120 103024 BULB SEAL, REAR WINDOW . . . . 121 L50202 1/4”-20X5/8” BUTTON HD . . . . . . AR22 L50139 1/4” LOCK WASHER. . . . . . . . . . . . 223 102881 MOUNT, REAR GLASS LOWER . . 124 067847 HLN INST 3/8 CZY . . . . . . . . . . . . . 2

25 210-19470 LN FL SERR 5/16 CZY . . . . . . . . . . 226 650486 CS 5/16" X 3/4" C5ZY . . . . . . . . . . . 227 50380737 SKID PLATE . . . . . . . . . . . . . . . . . . 128 102778 MASTER CYLINDER COVER. . . . . 129 102769 COVER, HYD. CONTROLLERS . . . 130 101550 1/4”-20 SELF THREADING BOLT. . 431b 102728 PANEL, HEATER. . . . . . . . . . . . . . . 132b 102727 PANEL, DASH COVER . . . . . . . . . . 133 L63813 HOLE PLUG, 2-1/2” DIA. . . . . . . . AR34 219274 MIRROR (optional) . . . . . . . . . . . . . 1

L50202 1/4"-20x5/8" BUTT. HD. BOLT . . . ARL50051 1/4"-20 FLANGE LOCK NUT . . . . AR

35 651640 BHSCS 5/16X3/4 C8 OCG . . . . . . . 236 210-19470 LN FL SERR 5/16 CZY . . . . . . . . . . 237 50302119 SCREW, ST #1032x1-1/2 ZB . . . . . 4

-- ITEMS NOT SHOWN---- L54002 TREAD STRIP, 6” WIDE (4 FT.) . . AR-- L71305 PLUG (top of cab) . . . . . . . . . . . . . . 2-- 104688 PLUG, BLACK 5/8” . . . . . . . . . . . . AR

a Refer to decal section (page 210) for load chart decals.

b Used when not equipped with a heater or A/C.

MT6034T Telescopic Handler CabCab and Covers (Standard)


2

7

24

4

2

7

4

2

7

65

43

1

Cab MT6034T Telescopic HandlerCab Mounts


01 102780 1”-8X3” GR8 BOLT . . . . . . . . . . . . . 102 651151 1” SAE FLAT WASHER. . . . . . . . . . 703 102741 RETAINER, CANOPY NUT . . . . . . . 104 102781 1”-8 CLASS C LOCK NUT . . . . . . . 405 101667 WASHER, CANOPY NUT . . . . . . . 106 650491 3/8”-16X1-1/4” BOLT . . . . . . . . . . . . 2

07 102780 1”-8X3” GR8 BOLT . . . . . . . . . . . . . 3

-- ITEMS NOT SHOWN---- L63813 HOLE PLUG, 2-1/2” DIA . . . . . . . . . 1

(plugs hole in cab where side boltattaches)

Lockable storage

shown onpage 22.


MT6034T Telescopic Handler CabFront Work Lights and Strobe Light (Option)

Item Part Description Qty.No. No. Req.

01 L70039 HEAD LIGHT . . . . . . . . . . . . . . . . . . 202 654006 3/8” FLAT WASHER . . . . . . . . . . . . 203 067847 HLN INST 3/8 CZY . . . . . . . . . . . . . 204 101712 GROMMET, 5/8” . . . . . . . . . . . . . . . 2

-- ITEMS NOT SHOWN ----- 103192 GROMMET 13/16”. . . . . . . . . . . . . . 2

(under dash for head light harness)-- L70241 WIRE HARNESS, HEAD LIGHT . . . 2

(from light switch behind dash, through cab frame posts, up to work light)

43

2

1

Front Work Lights(option)

Boom lightsand harness

are on page 119.

Rear lightsare on

page 48.

Strobe Light(option)


05 104952 STROBE LIGHT . . . . . . . . . . . . . . . 1

-- ITEMS NOT SHOWN ----- L63876 GROMMET 9/32" ID x 3/8” OD . . . . 1

(under stobe light on top of cab)-- 104950 HARNESS, STROBE (upper) . . . . . 1-- 104951 HARNESS, STROBE (in dash) . . . . 1-- 653002 #8-32 HEX NUT . . . . . . . . . . . . . . AR-- 650936 #8-32x1/2" MACHINE SCREW . . AR

5

50960090/AP0914 10 PRINTED IN U.S.A.

20

16

19

16

16

1714 14

1318

12 10

9

3

2

84561

11

3

64

15

1

7

2

15

FRONT WINDOW HINGE

REAR WINDOW HINGE

Cab MT6034T Telescopic HandlerGlass - Front and Rear Window Group (Option)

PRINTED IN U.S.A. 11 50960090/AP0914


01 L500038 5/16”-18 ACORN NUT . . . . . . . . . AR02 651639 5/16”-18X1” BUTTON HD BOLT . . . 403 651640 5/16”-18X3/4” BUTTON HD BOLT . 804 L500042 BUSHING, STEEL . . . . . . . . . . . . . . 405 L500021 GROMMET, 1/2”IDX1/4”GROOVE . 606 651641 5/16” FLAT WASHER (BLACK). . . . 407 L500111 HINGE, FRONT WINDOW . . . . . . . 208 L500024 HINGE, PLASTIC (rear window) . . . 109 103023 GLASS, REAR. . . . . . . . . . . . . . . . . 110 103024 BULB SEAL, REAR GLASS . . . . . . 111 103022 BULB SEAL, FRONT GLASS . . . . . 112 103019 GLASS, FRONT . . . . . . . . . . . . . . . 113 101727 HOLD OPEN, T-STYLE. . . . . . . . . . 114 L500025 PIN, QUICK DETACH . . . . . . . . . . . 4

15a 104846 MOUNT, REAR WINDOW LATCH . 116 L500019 PIN, ROLL - 3/16”x1/2” . . . . . . . . . . 317 L500028 HOLD OPEN, L-STYLE. . . . . . . . . . 118 L500027 HOLD OPEN, L-STYLE. . . . . . . . . . 119a 103029 MOUNT, WIND. HOLD OPEN (RH) 120a 102722 MOUNT, WIND. HOLD OPEN (LH). 1

a Use the parts listed below to fasten mount to frame:-- 650863 1/4” FLAT WASHER . . . . . . . . . . AR-- 654002 1/4” LOCK WASHER. . . . . . . . . . AR-- L50202 1/4”-20X5/8” BUTTON HD BOLT AR

MT6034T Telescopic Handler CabGlass - Front and Rear Window Group (Option)

50960090/AP0914 12 PRINTED IN U.S.A.

Cab MT6034T Telescopic HandlerWipers — Front and Top (with Enclosed Cab)

1

3

45

6

2313

1415

17

22

2120

19

18

16

2

Hole not used

PRINTED IN U.S.A. 13 50960090/AP0914

MT6034T Telescopic Handler CabWipers — Front and Top (with Enclosed Cab)


01 50380577 WIPER BLADE, 16". . . . . . . . . . . . . 102 WIPER ARM, PANTOGRAPH . . . . . 1

50380576 Front Window50380682 Top Window

03 50380579 PLATE, PANTO ARM MOUNT . . . . 104 50380583 PIN, PANTO ARM MOUNT . . . . . . . 105 L500706 M5, ACORN NUT . . . . . . . . . . . . . . 106 L500700 M8, ACORN NUT . . . . . . . . . . . . . . 113 L500696 COVER WIPER MOTOR. . . . . . . . . 114 L500718 BOLT / 10-24x1.25 HEX GR5 . . . . . 115 L500001 WASHER/BLK NYLON . . . . . . . . . . 116 139170 WASHER, #10 WEATHERTITE . . . 217 L500004 NUT/ACORN #10-24 BLK . . . . . . . . 118 L500709 RAIN SHIELD . . . . . . . . . . . . . . . . . 119 L500697 M18, NUT . . . . . . . . . . . . . . . . . . . . 1

20 L500701 GASKET, PANTO ADAPTER . . . . . 121 L500708 TOWER SEAL, TRICO WIPER. . . . 122 L500695 WIPER MOTOR, TRICO . . . . . . . . . 123 L500099 ADAPTER/WET ARM . . . . . . . . . . . 124 101495 BOTTLE, DUAL -PUMP WASHER . 125 243063 CAP, WASHER BOTTLE . . . . . . . . 1

(included with item #24)

-- ITEMS NOT SHOWN --(Windshield Wiper Harness)

-- 103179 HARNESS, TOP WIPER . . . . . . . . . 1-- 103180 HARNESS, FRONT WIPER . . . . . . 1

(Windshield Washer System)-- 102925 HARNESS, WASHER BOTTLE . . . 1-- 103013 TUBING, WASHER (15-1/2’) . . . . . . 1

24

WASHER SYSTEM RESERVOIRLOCATED OUTSIDE CAB -

UNDER RIGHT SIDE WINDOW

25

50960090/AP0914 14 PRINTED IN U.S.A.

9

8

4

3

1

10

2

3

56

7

10

Cab MT6034T Telescopic HandlerGlass - Top and Left Window (Option)

PRINTED IN U.S.A. 15 50960090/AP0914


01a 103027 GLASS, TOP . . . . . . . . . . . . . . . . . . 102 L500038 5/16”-18 ACORN NUT . . . . . . . . . AR03 102711 WINDOW MOUNT. . . . . . . . . . . . . . 204 L500021 GROMMET, 1/2”IDX1/4”GROOVE . 405 L500042 BUSHING, STEEL . . . . . . . . . . . . . . 406 651641 5/16” FLAT WASHER (BLACK). . . . 407 651639 5/16”-18X1” BUTTON HD BOLT . . . 4

08 103025 GLASS, LEFT REAR. . . . . . . . . . . . 109 103026 BULB SEAL, LEFT GLASS . . . . . . . 110 102712 WINDOW MOUNT. . . . . . . . . . . . . . 2

a Use P/N L500607 Adhesive Kit to attach top glass to cab.

MT6034T Telescopic Handler CabGlass - Top and Left Window (Option)

50960090/AP0914 16 PRINTED IN U.S.A.

21

20

16

10

14

127

11

8

156

78

9

4

3

21

5

5678

1718

19

22

9

Cab MT6034T Telescopic HandlerDoor (Option)

32

PRINTED IN U.S.A. 17 50960090/AP0914


-- 103014 CAB DOOR . . . . . . . . . . . . . . . . . . 1(includes items 1-10, 12 and 15)

01 102874 WELDMENT, CAB DOOR FRAME . 102 102705 BULB SEAL, DOOR FRAME . . . . . 103 102680 GLASS, UPPER DOOR . . . . . . . . . 104 102681 GLASS, LOWER DOOR . . . . . . . . . 105 651638 5/16”-18X1-3/4” BUTTN HD BOLT . 506 651641 5/16” FLAT WASHER (BLACK). . . . 507 L500042 BUSHING, STEEL . . . . . . . . . . . . . . 808 L500021 GROMMET, 1/2”IDX1/4”GROOVE . 809 L500038 5/16”-18 ACORN NUT (BLACK) . . . 710 651643 5/16”-18X2” BUTTON HD BOLT . . . 311 650730 3/8”X5” BOLT. . . . . . . . . . . . . . . . . . 312 102901 WELDMENT, DOOR HINGE . . . . . . 314 067847 HLN INST 3/8 CZY . . . . . . . . . . . . . 315 102928 BUMPER, DOOR . . . . . . . . . . . . . . 116 L500036 HOLD OPEN/DOOR (SET) . . . . . . . 1

(includes item #18—mounts to cab)17 650588 1/4”-20x1-1/2” BOLT . . . . . . . . . . . . 118 NSS HOLD OPEN/DOOR STUD. . . . . . . 1

(included with item #16, as a set)19 101719 GLASS MOUNT . . . . . . . . . . . . . . . 1

20 102948 HANDLE, EXT. DOOR LOCKING . . 1101792 KEY ONLY . . . . . . . . . . . . . . . . . . . 1

21 102886 LATCH RELEASE, INTERIOR . . . . 1651635 1/4-20X1-1/4” FLAT HD SCREW . . 2L50202 1/4-20X5/8” BUTTON HD BOLT . . 1651636 M6-1X12 8.8 BOLT. . . . . . . . . . . . . 2L500022 FLAT WASHER (BLACK) . . . . . . . . 1L520003 1/4”-20 NYLON INSERT NUT . . . . 2L70069 1/2” HOLE PLUG . . . . . . . . . . . . . . 2

22 101436 STRIKER . . . . . . . . . . . . . . . . . . . . . 1654028 7/16” LOCK WASHER . . . . . . . . . . 1654046 7/16” FLAT WASHER . . . . . . . . . . . 1L50979 7/16”-14 NUT . . . . . . . . . . . . . . . . . 1

32 101746 COVER (included with #21) . . . . . . 1

-- ITEMS NOT SHOWN ---- L70069 1/2” PLUG . . . . . . . . . . . . . . . . . . . . 1

(access hole for door handle)

MT6034T Telescopic Handler CabDoor (Option)

50960090/AP0914 18 PRINTED IN U.S.A.

Cab MT6034T Telescopic HandlerInstrument Panel and Dash Switches

2

11 12 14

1

8 9 107

3 4 5 6

13

16

18

15

IGNITIONSWITCH

17

12 VOLTPOWERPORT

19 20

PRINTED IN U.S.A. 19 50960090/AP0914

MT6034T Telescopic Handler CabInstrument Panel and Dash Switches


NOTE: Switches shown in the Illustration or listedon this page are for reference purposes only, yourmachine may be configured differently than shownhere.

01 50380306 PANEL, DASH . . . . . . . . . . . . . . . . . 1(does not include switches or display)

02 50305161 DISPLAY, CAN & INSTRUMENTS . 103 L71075 SWITCH, STEER MODE. . . . . . . . . 104 L71086 SWITCH, CLUTCH CUT-OUT. . . . . 105 101278 SWITCH, ENGINE FAULT. . . . . . . . 106 L71074 SWITCH, PARK BRAKE . . . . . . . . . 107 L71082 SWITCH, LIGHTS . . . . . . . . . . . . . . 108 L71084 SWITCH, TURN SIGNALS . . . . . . . 109 L71077 SWITCH, HAZARD LIGHTS . . . . . . 110 L71083 SWITCH, STROBE . . . . . . . . . . . . . 111 L71076 SWITCH, WIPER/WASHER . . . . . . 1

(front window)12 L71076 SWITCH, WIPER/WASHER . . . . . . 1

(top window)

13 L71691 SWITCH, WORK PLATFORM. . . . . 114 L71088 HOLE PLUG, SWITCH . . . . . . . . . AR

(used to plug empty switch hole)15 272578 SWITCH, IGNITION w/KEY. . . . . . . 1

(includes items #16 and #17, doesnot include item #18)

16 50280186 KEY (included with item #15) . . . . . 117 50280187 KEY COVER, RUBBER. . . . . . . . . . 1

(included with item #15)18 50304708 SPACER, KEY SWITCH . . . . . . . . . 119 137602 CONNECTOR, 12V PWR. PORT . . 120 137603 COVER, 12V POWER PORT . . . . . 1

50960090/AP0914 20 PRINTED IN U.S.A.

12

5

6

7

8

5

11

CAN-Terminate

8

9

13

10

Cab MT6034T Telescopic HandlerFuses, Relays, and Modules

103104 DIODE PACK

LOCATED UNDERTRANS. HOOD

1

2

2

3 4

(Fuses and relays are locatedinside the cab under the load

chart panel on the dash.)

(Shift and brake modules arelocated inside the cab under theload chart panel on the dash.)

Turn SignalFlasher

(Diode wires for park brake; located on the park brake switch

behind the switch panel.)

CATHODESIDE

CATHODESIDE

14

15

PRINTED IN U.S.A. 21 50960090/AP0914

01 NSS FUSE/RELAY BOX . . . . . . . . . . . . . 1(included with canopy wire harness)

02 50380753 LATCH, FUSE/RELAY COVER . . . . 403 272648 COVER, RELAY BOX . . . . . . . . . . . 104 50380751 COVER, FUSE BOX . . . . . . . . . . . . 105 L50491 #8-32X5/8” SCREW . . . . . . . . . . . . 406 101877 MODULE, F-N-R SHIFTER. . . . . . . 107 210797 BRACKET, BRAKE MODULE . . . . . 108 L50538 #8-32 NUT . . . . . . . . . . . . . . . . . . . . 409 210614 MODULE, BRAKE WARNING. . . . . 110 L63894 TURN SIGNAL FLASHER. . . . . . . . 1

(Located inside joystick access cover)11 106001 CAN, TERMINATE RECEPTACLE . 1

(Included with wire harness.)12 103104 DIODE PACK, 4 DIODES . . . . . . . . 1

(Included with chassis wire harness.)13 L500747 CLEAR COVER, DIODE PACK. . . . 114a 50220757 DIODE WIRE (---->|--) . . . . . . . . . . 115a 105960 DIODE WIRE (--|<----) . . . . . . . . . . 1------------------------------------------------------------------------------20 L70075 RELAY, 40A (ignition) . . . . . . . . . . . 121 L70075 RELAY, 40A (ignition) . . . . . . . . . . . 122 103100 RELAY, 20A (park brake). . . . . . . . . 123 103100 RELAY, 20A (front wiper). . . . . . . . . 124 103100 RELAY, 20A (lights) . . . . . . . . . . . . . 125 103100 RELAY, 20A (top wiper) . . . . . . . . . . 1


26 103099 MINI FUSE, 15A . . . . . . . . . . . . . . . 1(ignition, horn, brake light, clutch-cut out)

27 104769 MINI FUSE, 20A . . . . . . . . . . . . . . . 1(transmission, park brake, PWP, steer-select, and backup alarm)

28 103099 MINI FUSE, 15A (lights) . . . . . . . . . 129 103221 MINI FUSE, 25A . . . . . . . . . . . . . . . 1

(heater and display)30 103221 MINI FUSE, 25A (top wiper motor) . 131 103221 MINI FUSE, 25A (frnt wiper motor) . 1

-- WIRE HARNESS (NOT SHOWN)---- 50304281 WIRE HARNESS, CANOPY . . . . . . 1

(includes fuse/relay boxes withfuses and relays)

-- 50304028 WIRE HARNESS, CHASSIS. . . . . . 1

a Located under the dash; attaches to the park brake switch. Be aware there are two different diode wires (50220757 and 105960).Refer to the illustration on the facing page before ordering.

MT6034T Telescopic Handler CabFuses, Relays, and Modules

26 27

2928

313025

24

22 23

21

20

Fuses andRelays

50960090/AP0914 22 PRINTED IN U.S.A.

Cab MT6034T Telescopic HandlerSeat

7

4

65

4

3

2

3

54

4

4

3

5

3

2

98

11

8

6

5

1

9

1514

17

16

12

5

4

9

8

9

2119

20

811

1819

20

22 9

SUSPENSIONSEAT

(OPTION)

13

PRINTED IN U.S.A. 23 50960090/AP0914

MT6034T Telescopic Handler CabSeat

01 210170 SEAT, OPERATOR’S (wo/armrest) . 102 L70634 SEAT BELT (includes tethers) . . . . . 103 650630 7/16”-20X1” BOLT . . . . . . . . . . . . AR04 L50196 7/16” FLAT WASHER . . . . . . . . . . AR05 L50517 7/16”-20 NYLON INSERT NUT . . AR06 L70212 BRACKET, TETHER . . . . . . . . . . . . 207a L70201 MOUNT, SEAT BELT. . . . . . . . . . . . 108 654004 5/16” FLAT WASHER . . . . . . . . . . AR09 L50056 5/6”-18 NYLON INSERT NUT . . . AR11 L50823 5/16”-18X1” BOLT . . . . . . . . . . . . AR12a 10071 SEAT RISER . . . . . . . . . . . . . . . . . . 113 50380852 SEAT RISER/TOOL BOX . . . . . . . . 114 50380853 DOOR/TOOL BOX. . . . . . . . . . . . . . 115 271869 CAM LOCK (includes two keys) . . . 1

50290081 KEY (only) . . . . . . . . . . . . . . . . . . . . 116 651640 BHSCS 5/16" x 3/4" C8 OCG . . . . . 217 210-19470 LN FL SERR 5/16 CZY . . . . . . . . . . 2

18 650490 CS 3/8" x 1" C5ZY. . . . . . . . . . . . . . 219 654006 FW 3/8" AWZY. . . . . . . . . . . . . . . . . 420 067847 HLN INST 3/8" CZY. . . . . . . . . . . . . 421 650533 CS 3/8" x 1-1/2" C5ZY. . . . . . . . . . . 222b L68496 BELLOWS, SUSPENSION SEAT . . 1

(includes seat belt tether bracket, and items 22, 23, and 24.)

23b 210403 BELLOWS, SEAT (boot only) . . . . . 124b 210405 ADJUSTMENT KNOB . . . . . . . . . . . 125b 210404 SHOCK, SUSP. SEAT . . . . . . . . . . . 1

a Used only for standard seat—not used with suspension seat option.

b Used only for suspension seat.


23

25

24

SUSPENSIONSEAT

(OPTION)

50960090/AP0914 24 PRINTED IN U.S.A.

STEER MOTORPORTS

RL

P

T LS

10

7

6

4

3

2

1

8

9

Cab MT6034T Telescopic HandlerSteering Column and Shifter Group

5

Shiftermodule is

on page 20.

Axle hydrauliccircuit is onpage 100.

11

PRINTED IN U.S.A. 25 50960090/AP0914


01 L69596 CAP W/HORN BUTTON . . . . . . . . . 102 L41261 NUT, STEERING WHEEL . . . . . . . . 103 L69595 STEERING WHEEL . . . . . . . . . . . . 104 L68772 F-N-R/1-2-3 SHIFTER . . . . . . . . . . 1

(includes items 5-7)05 L99425 BOOT (included with item 4) . . . . . . 106 L50101 M5X.8X35mm HX SKTHD BOLT . . 2

(included with item 4)

07 105236 CLAMP, SHIFTER . . . . . . . . . . . . . 1(included with item 4)

08 50380779 COLUMN, STEERING. . . . . . . . . . . 109 651625 3/8”-16X1-1/4” BUTTON HD BOLT . 410 101882 MOTOR, STEER . . . . . . . . . . . . . . . 111 L63876 GROMMET 0.28 ID x 0.38" OD . . . 1

(used to protect horn wire)

MT6034T Telescopic Handler CabSteering Column and Shifter Group

50960090/AP0914 26 PRINTED IN U.S.A.

15

6

7

9

10

11

12

6

5

16

1412

13

17

32

1

Steer Motor

LS

T

B

A

P

Cab MT6034T Telescopic HandlerSteer Motor and Steer Select Valve Group

Steer Selectvalve parts

are onpage 171.

R

L

PT

17



PRINTED IN U.S.A. 27 50960090/AP0914


01 101882 STEER MOTOR . . . . . . . . . . . . . . . 102 137784 ADAP., -4ORM -6JICM 90º . . . . . . . 103 L63402 HOSE, -4 A6/A6 48” . . . . . . . . . . . . 105 L69747 VALVE, STEER SELECT . . . . . . . . 1

651089 CS 1/4 X3 C5ZY (not shown) . . . . . 2L520003 NUT/.25-20 NYLON (not shown) . . 2

06 079026 ADAP., -6ORM -6JICM 45º . . . . . . . 207 103319 HOSE, -6 A8/A6 22” . . . . . . . . . . . . 109 054994 ADAP., -6ORM -6JICM STR . . . . . . 2

HOSE LOCATOR

03 STEER MOTOR PORT “LS” HYDRAULIC PUMP07 STEER SELECT VALVE PORT “T” STEER CYLINDER, FRONT AXLE RIGHT SIDE10 STEER SELECT VALVE PORT “B” STEER CYLINDER, REAR AXLE RIGHT SIDE11 STEER SELECT VALVE PORT “A” STEER CYLINDER, REAR AXLE LEFT SIDE12 STEER MOTOR PORT “R” STEER SELECT VALVE PORT “P”13 STEER MOTOR PORT “L” STEER CYLINDER, FRONT AXLE LEFT SIDE14 STEER MOTOR PORT “P” HYDRAULIC PUMP15 STEER MOTOR PORT “T” HYDRAULIC TANK RETURN MANIFOLD

10 50304898 HOSE, -6 X115". . . . . . . . . . . . . . . . 111 50304898 HOSE, -6 X115". . . . . . . . . . . . . . . . 112 L63383 HOSE, -6 A6/DS8 52” . . . . . . . . . . . 113 L63387 HOSE, -6 A8/DS8 67” . . . . . . . . . . . 114 L68808 HOSE, -6 A8/DS8 48” . . . . . . . . . . . 115 L68805 HOSE, -6 A6/DS6 70” . . . . . . . . . . . 116 L64524 VALVE, CHECK, -8ORM . . . . . . . . . 117 054626 ADAP., -8ORM -8JICM STR . . . . . . 3

MT6034T Telescopic Handler CabSteer Motor and Steer Select Valve Group

50960090/AP0914 28 PRINTED IN U.S.A.

Cab MT6034T Telescopic HandlerBrake and Accelerator Pedals

1 2

3

23

5

4

4

7

6

8

8

10

9

12

9

15

13

14

18

17

11

16

20 19

25

19

21

22

24

26

23

27

PRINTED IN U.S.A. 29 50960090/AP0914


01 50381115 THROTTLE PEDAL. . . . . . . . . . . . . 102 654004 FW 5/16 AWZY . . . . . . . . . . . . . . . . 203 650485 CS 5/16" x 5/8" C5ZY . . . . . . . . . . . 204 L50202 BHSCS 1/4X5/8 C SS . . . . . . . . . . . 205 105287 COVER, THROTTLE PEDAL . . . . . 106 50380743 BRAKE CYL., SINGLE TANDEM . . 107 656009 CS M10-1.5X35 C8.8 ZY. . . . . . . . . 208 650491 CS 3/8X1-1/4 C5ZY. . . . . . . . . . . . . 409 067847 HLN INST 3/8 CZY . . . . . . . . . . . . . 410 50380894 BRACKET, BRAKE VLV. MOUNT . . 111 651707 LN INST FL M10-1.5 C8.8. . . . . . . . 212 653010 HN 3/8 C2ZY . . . . . . . . . . . . . . . . . . 113 50380841 LINKAGE . . . . . . . . . . . . . . . . . . . . . 114 656049 HN M10-1.50 C8 . . . . . . . . . . . . . . . 115 210328 YOKE, CLEVIS M10X1.5 . . . . . . . . 1

16 L44859 PIN, CLEVIS 1/2"X27/64" . . . . . . . . 117 655006 CP EPSC 1/8"XX1" Z . . . . . . . . . . . 118 L561004 SPRING, EXT. 13 GA. 73X6 . . . . . . 119 654009 FW 1/2 AWZY . . . . . . . . . . . . . . . . . 220 210608 BUSHING, BRONZE . . . . . . . . . . . . 1

(included with item 25)21 102529 PIN, BRAKE LEVER PIVOT . . . . . . 122 L50628 ROLL PIN, 3/16"X1" . . . . . . . . . . . . 123 570019 GREASE ZERK 1/4" TAPER. . . . . . 124 650545 CS 5/16”-18X1-1/4” C5ZY . . . . . . . . 225 210609 BRAKE LEVER ASSEMBLY . . . . . . 1

(includes item 20)26 210-19470 LN FL SERR 5/16 CZY . . . . . . . . . . 227 L63230 PAD, BRAKE PEDAL . . . . . . . . . . . 1

MT6034T Telescopic Handler CabBrake and Accelerator Pedals

50960090/AP0914 30 PRINTED IN U.S.A.

Cab MT6034T Telescopic HandlerBrake Valve Hydraulic Circuit

Front AxleService Brake

(Right-Side Tee)

Rear AxleService Brake(Left-Side Tee)

Located behindjoystick access

panel.

1

2 4

7 5 4

2

6

2

2

12

13 11

14

8

9

10

7

Located undercab floor

3

PRINTED IN U.S.A. 31 50960090/AP0914


MT6034T Telescopic Handler CabBrake Valve Hydraulic Circuit

01 102842 HOSE, -4 A4/A4 66" . . . . . . . . . . . . 102 230-32195 ST MJ04-MORB04 . . . . . . . . . . . . . 403 210828 PRESSURE SWITCH 150 P.S.I . . . 204 210-19469 LN FL SERR 1/4" CZY . . . . . . . . . . 405 230-32364 PLUG, MORB04 . . . . . . . . . . . . . . . 206 102840 HOSE, -4 A4/A6 90” . . . . . . . . . . . . 107 L70428 MANIFOLD, BRAKE LINE. . . . . . . . 2

08 104111 HOSE, -4 A4/A4 18" . . . . . . . . . . . . 209 50381095 ST MJ04-M12X1 DIN FL 74235 . . . 210 50380743 BRAKE CYL. SINGLE TANDEM . . . 111 50380754 MOUNT, BRAKE SWITCHES . . . . . 112 064260 HLN INST 5/16 CZY . . . . . . . . . . . . 213 650486 CS 5/16X3/4 C5ZY . . . . . . . . . . . . . 214 650706 CS 1/4X2 C5ZY. . . . . . . . . . . . . . . . 2

50960090/AP0914 32 PRINTED IN U.S.A.

1

5

7

6

5

8

11

109

5

4

2

12

3

Cab MT6034T Telescopic HandlerCab Components - Tri-Function Controls (Option)

Controllerparts on arepage 180.

Controllerparts are onpage 182.

PRINTED IN U.S.A. 33 50960090/AP0914

01 L71346 CONTROLLER, 4 BTN/W TRIG . . . 102 104304 BEZEL, JOYSTICK . . . . . . . . . . . . . 1

(included with item 1)03 L50202 1/4”-20X5/8” BTN HD BOLT. . . . . AR04 103582 JOYSTICK MOUNT. . . . . . . . . . . . . 105 L50051 1/4”-20 FLANGE LOCK NUT . . . . AR06 104214 SPACER, LEVEL CONTROLLER . . 207 103264 CONTROLLER, LEVEL. . . . . . . . . . 1

08 104219 1/4”-20X2-1/2” BTN HD BOLT. . . . . 209 L52024 1/4”-20X1” BTN HD BOLT. . . . . . . . 210 L52022 1/4”-20X5/8” BTN HD BOLT . . . . . . 211 103708 BRACKET, ARM REST . . . . . . . . . . 112 L69756 PAD, ARM REST . . . . . . . . . . . . . . . 1

-- ITEMS NOT SHOWN ---- 105580 TRI-FUNCTION WIRE HARNESS . 1


MT6034T Telescopic Handler CabCab Components - Tri-Function Controls (Option)

50960090/AP0914 34 PRINTED IN U.S.A.

1

7

8

6

5432

Cab MT6034T Telescopic HandlerHeater (Option) - (No A/C)

2

9

1810

11

12

17

1612

15

13

14

19

18

PRINTED IN U.S.A. 35 50960090/AP0914

MT6034T Telescopic Handler CabHeater (Option) - (No A/C)


01 102907 HEATER ASSEMBLY . . . . . . . . . . . 1(Includes items 5-11; 13-19)

02 L63545 GRILL, DEFROSTER . . . . . . . . . . . 203 102944 INSTRUMENT PANEL. . . . . . . . . . . 104 102945 DECAL, HEAT CONTROL. . . . . . . . 105 187841 CONTROL, TEMPERATURE . . . . . 1

(does not include knob)06 273968 KNOB (not included with item 5) . . . 107 136305 SWITCH, VARIABLE SPEED . . . . . 1

50300066 PANEL MOUNT NUT (included) . . . 2(NOTE: switch includes knob; knob not sold separately)

08 L500163 VALVE, WATER. . . . . . . . . . . . . . . . 1

09 NSS HOSE, 5/8" - FORMED . . . . . . . . . . 110 50380847 HEATER CORE. . . . . . . . . . . . . . . . 111 103033 BLOWER MOTOR. . . . . . . . . . . . . . 1

(does not include fan/cage)12 L50202 1/4”-20X5/8” BUTTN HD BOLT . . . 1013 136310 RESISTOR BLOCK . . . . . . . . . . . . . 114 NSS GROMMET 5/8" OD X 3/8" ID. . . . . 215 NSS HOUSING . . . . . . . . . . . . . . . . . . . . 116 137503 LOUVER . . . . . . . . . . . . . . . . . . . . . 117 NSS HOSE, 5/8" - FORMED . . . . . . . . . . 118 NSS GROMMET 1-3/8" OD X 1" ID . . . . 219 NSS HOSE COUPLER . . . . . . . . . . . . . . 1

50960090/AP0914 36 PRINTED IN U.S.A.

Cab MT6034T Telescopic HandlerA/C - Heater - (A/C - Option)

15

16

17

13 12

14

11

9 8

10

7

65

18

4

3

2

16

1

PRINTED IN U.S.A. 37 50960090/AP0914

MT6034T Telescopic Handler CabA/C - Heater - (A/C - Option)


01 210796 HVAC ASSEMBLY. . . . . . . . . . . . . . 1(Includes items 2-9)

211147 FAN ASSEMBLY (only) . . . . . . . . . . 102 211145 FILTER COVER. . . . . . . . . . . . . . . . 103 211146 FILTER, CAB AIR . . . . . . . . . . . . . . 104 211149 EVAPORATOR/HEATER COIL . . . . 105 137503 LOUVER . . . . . . . . . . . . . . . . . . . . . 106 211148 EXPANSION VALVE . . . . . . . . . . . . 107 138623 COLD CONTROL SWITCH. . . . . . . 108 242145 RELAY . . . . . . . . . . . . . . . . . . . . . . . 109 242875 RECTIFIER PACK . . . . . . . . . . . . . . 1

10 420-36290 LOUVER . . . . . . . . . . . . . . . . . . . . . 111 189049 DECAL, A/C HEATER CONTROL. . 112 136305 SWITCH, VARIABLE SPEED . . . . . 1

50300066 PANEL MOUNT NUT (included) . . . 213 139279 KNOB. . . . . . . . . . . . . . . . . . . . . . . . 214 189033 MODULE, A/C CONTROL. . . . . . . . 115 L63545 GRILL, VENT. . . . . . . . . . . . . . . . . . 216 L50202 1/4”-20X5/8” BUTTN HD BOLT . . . 1017 211023 PANEL, HVAC CONTROL. . . . . . . . 118 201179 HOSE, OVERFLOW . . . . . . . . . . . . 1

50960090/AP0914 38 PRINTED IN U.S.A.

Cab MT6034T Telescopic HandlerA/C Circuit (Option)

Condenser(located inside the housingon the top-rear of the cab)

Evaporator / Heater Coil(located inside the cab)

A/C compressormounting ison page 64.

1

2

3

4

5

5

3

6

7

8

102

2

11

13

12

9

16

158

9

17

7

2

14

4

A/C Dryer(located under the cab)

Condenserassembly is on

page 42

PRINTED IN U.S.A. 39 50960090/AP0914

Ref. Part Description Qty. Ref. Part Description Qty.No. No. Req. No. No. Req.

01 L500595 CONDENSER . . . . . . . . . . . . . . . . . 102 138777 O-RING . . . . . . . . . . . . . . . . . . . . . . 403 138778 O-RING . . . . . . . . . . . . . . . . . . . . . . 204 211010 HOSE, #6 COND./DRYER . . . . . . . 105 50305209 HOSE, #8 COND./COMP. . . . . . . . . 106 50352428 COMPRESSOR, A/C. . . . . . . . . . . . 107 138779 O-RING . . . . . . . . . . . . . . . . . . . . . . 208 50305208 HOSE, #10 w/SERVICE PORT. . . . 109 50305598 HOSE, #6 DRYER/EVAPORATOR . 110 138714 SWITCH, BINARY . . . . . . . . . . . . . . 1

11 138649 A/C DRYER . . . . . . . . . . . . . . . . . . . 112 650450 CS 3/8 x 5/8 C5ZY . . . . . . . . . . . . . 113 650491 CS 3/8 x 1-1/4 C5ZY . . . . . . . . . . . . 114 138651 CLAMP, DRYER . . . . . . . . . . . . . . . 115 090666 HN FL SLOC 3/8 CZY . . . . . . . . . . . 216 50305578 MOUNT, DRYER . . . . . . . . . . . . . . . 117 210796 HVAC UNIT (Evaporator/Heater). . . 1

-- ITEMS NOT SHOWN ---- 50305621 WIRE HARNESS, A/C. . . . . . . . . . . 1

(Attaches to starter, A/C compressor,A/C condenser, and HVAC unit inthe cab.)

MT6034T Telescopic Handler CabA/C Circuit (Option)

50960090/AP0914 40 PRINTED IN U.S.A.

Cab MT6034T Telescopic HandlerHeater Circuit (Option)

A/C and Heater Equipped4

3

21

5

27

6

86

ENGINE

9

10

12

11

2

14

212

1

313

HVAC(located inside

the cab)

2 7

86

16

6

2

2

17

15 Heater Only EquippedENGINE

Heater Unit(located inside the cab)

24

20

23

21

22

Bracket fastens to enginenear heater hose ports

24

20

23

21

22

Bracket fastens to enginenear heater hose ports

PRINTED IN U.S.A. 41 50960090/AP0914

MT6034T Telescopic Handler CabHeater Circuit (Option)


01 210796 HVAC UNIT . . . . . . . . . . . . . . . . . . . 102 095955 CLAMP, HOSE #10 . . . . . . . . . . . AR03 138459 HOSE, HEATER 5/8" x 50" . . . . . . . 104 272546 WIRE GUARD (for heater hose) . . . 205 50305830 HOSE, HEATER 5/8" x 113" . . . . . . 106 50303155 ST MJ10-MM22 SP . . . . . . . . . . . . . 207 50302496 90 HB10-FJS10 . . . . . . . . . . . . . . . . 208 065415 90 MJ10-FJS10 . . . . . . . . . . . . . . . . 109 138459 HOSE, HEATER 5/8" x 50" . . . . . . . 110 L50051 HLN SERR 1/4"-20 . . . . . . . . . . . . . 211 650512 CS 1/4" x 3/4" C5 . . . . . . . . . . . . . . 2

12 186193 ST HB10-MP08 . . . . . . . . . . . . . . . . 213 50305570 BRACKET, HEATER VALVE . . . . . . 114 186703 VALVE, HEATER-A/C SOLENOID . 115 102907 HEATER UNIT. . . . . . . . . . . . . . . . . 116 243008 HOSE, HEATER 5/8" x 71" . . . . . . . 117 230209 HOSE, HEATER 5/8" x 60" . . . . . . . 1------------------------------------------------------------------------------20 50306490 BRACKET, HEATER HOSE . . . . . . 121 L50206 CLAMP, HOSE 0.875" DBL . . . . . . . 122 651695 CS FL M8-1.25x25 8.8 . . . . . . . . . . 123 651706 LN INST FL M8-1.25 C8 ZY . . . . . . 124 651732 CS FL M10-1.5x20 8.8 ZY. . . . . . . . 2

50960090/AP0914 42 PRINTED IN U.S.A.

Cab MT6034T Telescopic HandlerA/C Condenser - (A/C Equipped - Option)

1

2

3

3 4

6

7

11

12

13

10

3

93

8

5

Condenser Assembly(located on the

top-rear of the cab)

14

16

15

A/C HoseCovers

(located on theright rear

corner of the cab)

18

17

PRINTED IN U.S.A. 43 50960090/AP0914


01 211052 CONDENSER ASSEMBLY . . . . . . . 1(includes items 1-10)

02 211039 COVER, CONDENSER HOUSING. 103 089888 BHSCS 1/4” x 1/2” . . . . . . . . . . . . 1704 L50051 FLANGE LN 1/4”-20 . . . . . . . . . . . . 205 L500596 SELF-TAP SCREW 3/16” x 5/8” . . . 606 211035 MOUNT, CONDENSER COIL . . . . . 107 L500595 CONDENSER COIL . . . . . . . . . . . . 108 211045 CONDENSER HOUSING . . . . . . . . 109 420-35602 RELAY . . . . . . . . . . . . . . . . . . . . . . . 1

10 L500594 CONDENSER FAN ASSEMBLY . . . 211 651640 BHSCS 5/16” x 3/4” . . . . . . . . . . . . 412 210765 FW 5/16” ZY SEALING . . . . . . . . . . 413 070648 LN LG FL SERR 5/16 CZ . . . . . . . . 414 210833 COVER, A/C HOSES (upper) . . . . . 115 50305607 COVER, A/C HOSES (lower) . . . . . 116 650315 SELF-TAP SCREW 1/4” x 1/2” . . . . 317 L50051 FLANGE LN 1/4”-20 . . . . . . . . . . . . 318 650512 CS 1/4" x 3/4" C5ZY . . . . . . . . . . . . 3

MT6034T Telescopic Handler CabA/C Condenser - (A/C Equipped - Option)

50960090/AP0914 44 PRINTED IN U.S.A.

Chassis MT6034T Telescopic HandlerHoods - Front

1

11

11

14

12

1313

9 810

9

84

98

4

984

5

4

6

7

4

4 5

3

2

PRINTED IN U.S.A. 45 50960090/AP0914


01 50381236 COVER, ACCESS . . . . . . . . . . . . . . 102 50381229 HOOD, FRONT . . . . . . . . . . . . . . . . 103 L68866 COVER, FRAME FRONT . . . . . . . . 104 L530004 FASTENER RETAINED NUT . . . . . 905 651640 BHSCS 5/16”-18X3/4” C8 OCG . . . 406 650484 CS 5/16”-18X1/2”. . . . . . . . . . . . . . . 107 L70045 HORN W/GROUND (12V). . . . . . . . 1

08 654004 FW 5/16” AWZY. . . . . . . . . . . . . . . . 609 650486 CS 5/16”-18X3/4” C5ZY . . . . . . . . . 610 210-19470 LN FL SERR 5/16 CZY . . . . . . . . . . 111 104222 LATCH, COMPRESSION . . . . . . . . 212 650648 HN MS #10-32 FZY. . . . . . . . . . . . . 213 650387 RHMS SLT #10-32 x 1/2" FZY . . . . 214 L64673 HANDLE, HOOD . . . . . . . . . . . . . . . 1

MT6034T Telescopic Handler ChassisHoods - Front

50960090/AP0914 46 PRINTED IN U.S.A.

Chassis MT6034T Telescopic HandlerHoods - Center

1

25

4

3

2

3

32

64 7

33

2

4

8

93 2

4

3

210

11

12

1314

15

2 3

2 34

2 32

3

2

4

2

3

11

4

23

2 3

2 3

4

4

4

PRINTED IN U.S.A. 47 50960090/AP0914


01 50304907 COVER, ENGINE . . . . . . . . . . . . . . 102 650486 CS 5/16”-18X3/4” C5ZY . . . . . . . . AR03 654004 FW 5/16” AWZY . . . . . . . . . . . . . . AR04 L530004 FASTENER RETAINED NUT . . . . AR05 50304791 COVER, REAR . . . . . . . . . . . . . . . . 106 50304788 MOUNT, HOOD (LH) . . . . . . . . . . . . 107 50304759 PANEL, REAR LEFT SIDE . . . . . . . 108 50304821 HOOD, MAIN (CENTER). . . . . . . . . 1

09 210-19470 LN FL SERR 5/16" CZY . . . . . . . . . 310 651457 LN INST M6-1 C8 ZY . . . . . . . . . . . 811 103873 HINGE, ACCESS COVER. . . . . . . . 212 50381241 DOOR, ENGINE ACCESS . . . . . . . 113 104222 LATCH, COMPRESSION . . . . . . . . 114 50304797 PANEL, REAR RIGHT SIDE . . . . . . 115 50304798 MOUNT, HOOD (RH) . . . . . . . . . . . 1

MT6034T Telescopic Handler ChassisHoods - Center

CENTER HOOD ASSEMBLED

50960090/AP0914 48 PRINTED IN U.S.A.

1

Chassis MT6034T Telescopic HandlerHoods and Covers - Rear

DOC Guard(Under the Frame -

Right Side)

Hose Guard(Under/Inside theFrame -Left Side)

1

2

3

153

2

12

31

2

2

141

23

3 2 1

5

4

4

67

1 2

2

8

9

11

12

1 3

2

13

10

8 11

9

12

Counterweight

1617

NOTE: The counterweight is a non-serviceableitem.

PRINTED IN U.S.A. 49 50960090/AP0914

MT6034T Telescopic Handler ChassisHoods and Covers - Rear


01 650486 CS 5/16”-18X3/4” C5ZY . . . . . . . . AR02 654004 FW 5/16” AWZY . . . . . . . . . . . . . . AR03 L530004 FASTENER RETAINED NUT . . . . AR04 L70701 LIGHT, TAIL (includes bezel) . . . . . . 2

L500339 RUBBER BEZEL . . . . . . . . . . . . . . . 205 L71595 LIGHT, BACKUP (includes bezel) . . 1

L500606 RUBBER BEZEL . . . . . . . . . . . . . . . 1100102 JUMPER WIRE (not included) . . . . 1

06 210-19470 LN FL SERR 5/16 CZY . . . . . . . . . . 207 L70200 BACKUP ALARM. . . . . . . . . . . . . . . 1

L47847 ELEC. TERM. FEMALE (not incl.). . 1L60956 ELEC. TERM. MALE (not included) 1

08 650489 CS 3/8" X 7/8" C5Z . . . . . . . . . . . . . 409 654049 FW 3/8" ANZY . . . . . . . . . . . . . . . . . 410 50304736 GUARD, HOSE . . . . . . . . . . . . . . . . 111 090666 LN FL SERR 3/8" CZY . . . . . . . . . . 412 L50442 CS 3/8"-16 x 1-1/4" SELF-TAP . . . . 413 50381217 GUARD, DOC . . . . . . . . . . . . . . . . . 114 50304812 HOOD, REAR . . . . . . . . . . . . . . . . . 115 50304811 COVER, REAR . . . . . . . . . . . . . . . . 116 L50333 CS 3/4"-10X3" GR5HX . . . . . . . . . . 417 079209 HLN INST 3/4" CZY. . . . . . . . . . . . . 418a L60587 3 AMP/800PIV (in-line diode) . . . . . 2

(rear of machine inside the wire loom between diode pack (103101) and back-up alarm wires)

19a 103101 DIODE PACK . . . . . . . . . . . . . . . . . 120a L500748 DIODE PACK . . . . . . . . . . . . . . . . . 121a L500747 CLEAR COVER, DIODE PACK . . . 2

-- ITEMS NOT SHOWN ---- 102647 WIRE HARNESS, REAR HOOD. . . 1

(Standard) Connects to chassis wire harness and to the backup alarm, rear backuplight, and the right and left stop lights—not used when equippedwith the optional light package; therear section of the optional light package wire harness PN 102572replaces this standard wire harness.

-- 102572 WIRE HARNESS, LIGHT PACKAGE 1(Option)Connects to canopy wire harness for the light switch, hazard switch, and turn signal switch. Also connects tothe boom light wire harness and theframe harness at the rear of themachine. The rear section of this wire harness replaces the standardrear hood wire harness (PN 102647)and connects to the backup alarm, rear backup light, and the right and left stop lights.

The rear section of this harnessreplaces the standard rear hoodwire harness (102647).

This harness also includes items18-21.

a Included with light package wire harness 102572.

103101 DIODE PACK

LOCATED NEARREAR LIGHTS

L500748DIODE PACK

LOCATED UNDER DASHNEAR SWITCHES

L500747DIODE PACK

CLEAR COVER

L60587IN-LINE DIODE

18

19 2021

50960090/AP0914 50 PRINTED IN U.S.A.

25

16

17

18

21

22 23

29

2827

26

30

19

20

31

24

10

8

15

14

97

6

4

5

3

2

11

12

13

1

2

Chassis MT6034T Telescopic HandlerHydraulic Tank Group

Hydraulic OilTank Heater

(Option)

32

HydraulicPump andcircuit is onpage 134.

PRINTED IN U.S.A. 51 50960090/AP0914


01 101879 ASSEMBLY, IN-TANK FILTER. . . . . 1(includes items 1-3)

02 50380450 SEAL KIT (three o-rings) . . . . . . . . . 103 L97489 HYDRAULIC FILTER ELEMENT. . . 104 650489 CS 3/8”-16X 7/8” C5Z . . . . . . . . . . . 405 654006 3/8” FLAT WASHER . . . . . . . . . . . . 406 L277944 ADAP., -20ORM -12JICM . . . . . . . . 107 L63406 HOSE, -12 A12/DS12 114” . . . . . . . 108 50306017 CAP ASSEMBLY, HYDRAULIC. . . . 1

(includes item 9)09 L99163 GASKET, FILLER NECK . . . . . . . . . 210 L63756 MIRROR, CONVEX 6-1/2”X10”. . . . 111 103991 BRACKET, MIRROR . . . . . . . . . . . . 112 L520003 1/4”-20 NYLON INSERT NUT . . . . . 113 081379 5/16”x1/2” LOCK BOLT . . . . . . . . . . 414 650488 5/16”-18x3/4” BOLT . . . . . . . . . . . . 1015 654004 5/16” FLAT WASHER . . . . . . . . . . 1016 L65142 PLATE, HYDRAULIC TANK COVR. 117 L65144 GASKET, RUBBER . . . . . . . . . . . . . 1

18 50380516 HYDRAULIC TANK WELDMENT . . 1(includes items 22 and 23)

19 650569 1/2”-13X1-3/4” BOLT . . . . . . . . . . . . 420 068034 HLN INST 1/2 CZY . . . . . . . . . . . . . 421 131529 PLUG, -8ORM SAE . . . . . . . . . . . . . 122 L49327 STRAINER, HYD. OIL . . . . . . . . . . . 123 L61620 1-1/2” THREADED PIPE . . . . . . . . . 124 L441010 ADAP., -24NPTM -24JICM . . . . . . . 125 L63309 HOSE, -24 A24/A24 35” . . . . . . . . . 126 103315 HOSE, -4 A6/DS6 60” . . . . . . . . . . . 127a 103318 HOSE, -6 A6/DS6 52” . . . . . . . . . . . 128 L68805 HOSE, -6 A6/DS8 70” . . . . . . . . . . . 129 103368 HOSE, -6 A6/DS6 52” . . . . . . . . . . . 130 054994 ADAP., -6ORM -6JICM . . . . . . . . . AR31b 122778 PLUG, -6ORM SAE . . . . . . . . . . . . . 132c 50381156 HEATER/500W (option). . . . . . . . . . 1

a Used on units equipped with PWP.

b Used on units not equipped with PWP.

c Optional tank heater attaches to the bottom of thehydraulic tank. Used for operating in cold climates.

HOSE LOCATOR

07 HYDRAULIC FILTER HYDRAULIC CONTROL VALVE “OUT”25 HYDRAULIC TANK HYDRAULIC PUMP “IN”26 HYDRAULIC TANK RETURN JOYSTICK27a HYDRAULIC TANK RETURN PWP VALVE “T”28 HYDRAULIC TANK RETURN STEER MOTOR “T”29 HYDRAULIC TANK RETURN FLOW DIVIDER “T”

MT6034T Telescopic Handler ChassisHydraulic Tank Group

50960090/AP0914 52 PRINTED IN U.S.A.

Chassis MT6034T Telescopic HandlerFuel Tank Group

1

25

4

3

6

7

15

11 109

8

1013

1214

FUEL SUPPLY

FUEL RETURN

Fuel circuit isshown onpage 66.

PRINTED IN U.S.A. 53 50960090/AP0914


01 50381061 FUEL TANK WELDMENT . . . . . . . . 102 210722 CAP, FUEL (vented) . . . . . . . . . . . . 103 L61867 SENDER, FUEL LEVEL . . . . . . . . . 1

(includes gasket; item #4)04 L41854 GASKET, FUEL SENDER . . . . . . . . 105 650387 #10-32X1/2” RD MACH SCREW . . 506 068034 HLN INST 1/2 CZY . . . . . . . . . . . . . 407 650569 1/2”-13X1-3/4” BOLT . . . . . . . . . . . . 408 110227 ADAP., -8ORM -6JICM 90º . . . . . . . 1

09 50300449 ST HB06-FJS06 BRASS . . . . . . . . . 110 087852 CLAMP, HOSE #06 . . . . . . . . . . . . . 211 50304972 HOSE, FUEL -6 x 120" . . . . . . . . . . 112 054816 90 MJ08-MAORB08 . . . . . . . . . . . . 113 50300462 ST HB08-FJS08 BRASS . . . . . . . . . 114 50304958 HOSE, FUEL -8 x 25" . . . . . . . . . . . 115 131529 PLUG, -8ORM SAE . . . . . . . . . . . . . 1

MT6034T Telescopic Handler ChassisFuel Tank Group

50960090/AP0914 54 PRINTED IN U.S.A.

Chassis MT6034T Telescopic HandlerBattery Group and ECU

12

3

4

8

7

5

7

6

3

228

109

11

12

13

23

24

24

2215

16

17

21

18

19

19

18

18

20

17

16

15

26

2725 14

14

19Battery ThermalWrap (Option)

29

Engine isshown onpage 62.

Connects toalternator

and starter

Secures chassis wire harnessto the top left-side of theengine flywheel housing.

Located at the frontof the machine

under the front panel

Located undercenter hood

PRINTED IN U.S.A. 55 50960090/AP0914


01 50301134 ALTERNATOR CABLE . . . . . . . . . . 102 651668 CS M12-1.75x16 C8.8 . . . . . . . . . . . 203 191352 CLAMP 0.88" X 0.53" . . . . . . . . . . . 204 055648 TIE, CABLE 0.19x7.50 IN. . . . . . . AR05a L500225 FUSE, MAXI 60 AMP (not shown) . 106 210-19469 LN FL SERR 1/4" CZY . . . . . . . . . . 107 650863 FW 1/4" ANZY . . . . . . . . . . . . . . . . . 408 650347 CS 1/4x1-3/4 C2 . . . . . . . . . . . . . . . 109 191192 FUSE HOLDER . . . . . . . . . . . . . . . . 110 50301357 FUSE, 100A AMG . . . . . . . . . . . . . . 111 650542 CS 1/4" x 1/2" C5ZY . . . . . . . . . . . . 212 193856 SOLENOID (does not include #13) . 113 195740 COVER (not included with #12) . . . 114 651269 SHCS HS 1/4"x7/8" C5 OCG . . . . . 215 653098 WING NUT 3/8" . . . . . . . . . . . . . . . . 216 L70146 ROD, BATTERY HOLD DOWN. . . . 217 090666 3/8”-16 FLANGE NUT . . . . . . . . . . . 418 651759 CS FL M6-1.0x30 8.8 ZY. . . . . . . . . 419 651705 LN INST FL M6-1.00 C8 ZY . . . . . . 420b NA ECU (Engine Control Unit) . . . . . . . 121c NSS BATTERY, 12V 4DLT TYPE . . . . . . 122 L63334 BAR, BATTERY HOLD-DOWN . . . . 1

23 243319 CABLE END (includes item 24-25) . 1(cover is not sold separately)

24 071244 LN INST M6-1.0 C9. . . . . . . . . . . . . 225 071245 LN INST M8-1.25 C9. . . . . . . . . . . . 126 101954 CABLE, BATTERY NEG. . . . . . . . . . 127 L630004 GROUND STRAP, 14GA.X14” . . . . 128 50304354 CABLE, BATTERY POS. . . . . . . . . . 129d 50381167 WRAP, BATTERY THERMAL 56" . . 1

(Option)

a The fuse holder (shown as item #5) is part of the canopy wire harness and is not sold separately.

b The ECU is a special order item that requires factory programming. Please provide the enginemodel and serial number (located on a plate on top of the valve cover) when ordering this part. Beaware that due to the programming requirements there may be a delay in obtaining this part.

c The battery is not sold separately or is it available from the parts department; please obtain locally.

d Thermal battery wrap is an option; is included withthe Arctic Weather Kit option (PN 50860109).

MT6034T Telescopic Handler ChassisBattery Group and ECU

50960090/AP0914 56 PRINTED IN U.S.A.

HydraulicControl Valve

FRONT AXLE

7

15

17

4

5

3

21

14

16

13

12

8

910

11

7

66

Chassis MT6034T Telescopic HandlerFrame Level Circuit

Frame LevelCylinder parts

are on page 184.

HydraulicControl Valveparts are onpage 168.

PRINTED IN U.S.A. 57 50960090/AP0914


01 L63015 LEVEL CYLINDER . . . . . . . . . . . . . 102 L64367 BRONZE BEARING . . . . . . . . . . . . 103 650731 3/8”-16X3-1/2” BOLT . . . . . . . . . . . . 104 L63276 PIN, CYLINDER (BASE END). . . . . 105 067847 HLN INST 3/8 CZY . . . . . . . . . . . . . 106 L68794 ADAP., W/ORIFICE -8ORM -6JICM 207 L68809 HOSE, -4 A6/DS6 136” . . . . . . . . . . 208 650487 5/16”X1” BOLT. . . . . . . . . . . . . . . . . 209 L63715 PLATE . . . . . . . . . . . . . . . . . . . . . . . 110 210447 PIVOT PIN (ROD END). . . . . . . . . . 1

11 L63016 BRONZE BEARING . . . . . . . . . . . . 112 210569 FRAME LEVEL MOUNT . . . . . . . . . 113 210572 PLATE, FRAME LEVEL. . . . . . . . . . 114 L50712 3/4”-10X9” GR8 BOLT . . . . . . . . . . . 415 654014 3/4” FLAT WASHER . . . . . . . . . . . . 416 L50084 3/4”-10 STOVER NUT . . . . . . . . . . . 417 L60253 ADAP., -10ORM -6JICM . . . . . . . . . 2

.

MT6034T Telescopic Handler ChassisFrame Level Circuit

50960090/AP0914 58 PRINTED IN U.S.A.

651'-0"

9'-2“

(Attached to PersonnelWork Platform)

2


01 L71729 REMOTE SWITCH W/CABLE. . . . . 1(Includes item 2-4)

02 102408 CABLE ASSEMBLY. . . . . . . . . . . . . 103 L71726 REMOTE STOP SWITCH . . . . . . . . 104 L71725 REMOTE SWITCH ENCLOSURE. . 1

5

4

3

05 L71750 REMOTE SWITCH POUCH . . . . . . 106 L71732 REMOTE SWITCH HARNESS . . . . 1

(consists of two cables)420-19671 CLAMP, 3/8" (not shown) . . . . . . . . 1650484 CS 5/16x1/2 C5ZY (not shown). . . . 1L51143 ZIP TIE 0.171 x 11" (not shown) . . 15

Personnel Work Platform MT6034T Telescopic HandlerBoom Components - (Standard PWP)

1

PRINTED IN U.S.A. 59 50960090/AP0914

01 50380789 LEVEL SENSOR/PWP 1-AXIS . . . . 1650835 CS 1/4" x 1" C5ZY (not shown) . . . . 2L50051 HLN SERR 1/4" (not shown) . . . . . . 2

02 102321 MANIFOLD, PWP JOYSTICK . . . . . 1650706 CS 1/4" x 2" C5ZY (not shown) . . . . 2654002 FW 1/4" AWZY (not shown). . . . . . . 2L50139 LW 1/4" (not shown) . . . . . . . . . . . . 2

03 104078 MODULE, PWP CONTROL . . . . . . 1L50655 MS #10-24x1/2" RND (not shown) . 2650550 HN MS #10-24 CZY (not shown) . . 2

04a L71752 5/16” CHAIN SHACKLE . . . . . . . . . 105a L71751 5/16” CHAIN GR40 16 LINKS . . . . 1

-- ITEMS NOT SHOWN ---- L71691 SWITCH, PWP (located on dash) . . 1-- 104064 WIRE HARNESS, PWP. . . . . . . . . . 1

(under dash)

a Chain shackle and chain are used to secure the personnel work platform.


Chain and Shackle(Used to secure personnel work platform)

54

2

1

3Located under thejoysticks—behind

access cover.

Located undertransmission

hood—attached toinner frame

MT6034T Telescopic Handler Personnel Work PlatformLevel Sensor, Module, Chains, and Manifold

PWP circuit isshown onpage 154and 158.

50960090/AP0914 60 PRINTED IN U.S.A.

Personnel Work Platform MT6034T Telescopic HandlerPWP Radio Remote (Option) - Transmitter and Receiver

14

2

5

4

6

7

8

9

12

3

10

11

13

Bracket (#10) bolts to the bracketthat is welded to the frame under

the transmission access hood.

1

15

16

Not shown to scale. Not shown to scale.

PRINTED IN U.S.A. 61 50960090/AP0914

MT6034T Telescopic Handler Personnel Work PlatformPWP Radio Remote (Option) - Transmitter and Receiver

01 50380274 RADIO REMOTE, SYSTEM . . . . . . 1(Includes items 2 and 3)

02a 50220629 REMOTE TRANSMITTER. . . . . . . . 103 50220630 RECEIVER, RADIO REMOTE . . . . 104 NSS HOUSING . . . . . . . . . . . . . . . . . . . . 105 50220628 SWITCH, TOGGLE 2-POS.. . . . . . . 106 50220627 SWITCH, TOGGLE 3-POS.. . . . . . . 407 50220626 BUTTON, RADIO E-STOP . . . . . . . 108 103475 LANYARD (wire cable) . . . . . . . . . . 109 103476 SNAP RING, LANYARD . . . . . . . . . 110 50380826 BRACKET, RECEIVER MOUNT . . . 111 L50051 HLN SERR 1/4" . . . . . . . . . . . . . . . . 212 650426 CS 1/4”X1-1/4” C5ZY . . . . . . . . . . . 2

13 50380789 LEVEL SENSOR/PWP 1-AXIS . . . . 1650835 CS 1/4" x 1" C5ZY (not shown) . . . . 2L50051 HLN SERR 1/4" (not shown) . . . . . . 2

14 50380825 DECAL, REMOTE TRANSMITTER. 1(not included with item 1)

15 50380836 HARNESS, CERVIS RADIO . . . . . . 116 50305606 HARNESS, RADIO REMOTE . . . . . 1

a Requires programming—refer to Radio RemoteOperator’s Manual / Parts Manual (50960060), included with the Radio Remote Control at the time of purchase.


50960090/AP0914 62 PRINTED IN U.S.A.

Engine MT6034T Telescopic HandlerExternal Components

1

2

3

45

6

7

8

9

10

11

12

12

11

10

9

8

713

1716

14

15

19

18

18

20Oil PanHeater(Option)

LEFT

RIGHT

21

PRINTED IN U.S.A. 63 50960090/AP0914


01 50380587 ENGINE, DEUTZ TD 3.6 L4 . . . . . . 102 TBD DIPSTICK, ENGINE OIL LEVEL . . . 103 132023 FILTER, ENGINE OIL . . . . . . . . . . . 104 133444 CAP, ENGINE OIL FILL. . . . . . . . . . 105 50220553 SENSOR, PRESSURE . . . . . . . . . . 106 50220515 ALTERNATOR . . . . . . . . . . . . . . . . . 107 50301039 CS FLH M12-1.75x25 10.9ZY . . . . . 808 271601 CS 5/8" x 4" C8OCG SP . . . . . . . . . 209 135425 MOUNT, ENGINE CUSHION . . . . . 210 L64197 WASHER . . . . . . . . . . . . . . . . . . . . . 211 067826 HLN INST 5/8" CZY. . . . . . . . . . . . . 2

12 50380592 MOUNT, ENGINE . . . . . . . . . . . . . . 213 50220511 BELT, FAN/ALTERNATOR. . . . . . . . 114 L69264 FAN, ENGINE 20" . . . . . . . . . . . . . . 115 651695 CS FL M8-1.25x25 8.8 ZY. . . . . . . . 416 50300466 CS M8-1.25x65 c8.8 ZY SP . . . . . . 417 50381171 SPACER, FAN . . . . . . . . . . . . . . . . . 118 105910 CS FL M10 x 30m . . . . . . . . . . . . . . 319 TBD STARTER . . . . . . . . . . . . . . . . . . . . 120 50302785 HEATER, OIL PAN 250W (option). . 121 50304956 WRAP, REFLECTIVE HEAT . . . . . . 1

(wraps around EGR coolant hose)

MT6034T Telescopic Handler EngineExternal Components

50960090/AP0914 64 PRINTED IN U.S.A.

Engine MT6034T Telescopic HandlerA/C Compressor Group - (Option)

2

6

7869

4

32

2

5

10

15

14

1112

16

13

18

17

19

A/C hoses areshown onpage 38.

PRINTED IN U.S.A. 65 50960090/AP0914


01 50305581 MOUNT, A/C COMPRESSOR. . . . . 102 651702 CS FLH M16-2.00x50 8.8 ZY . . . . . 403 50302216 PULLEY, A/C (crankshaft) . . . . . . . . 104 50301159 CS M10-1.5x45 C8.8 ZY . . . . . . . . . 605 650579 CS 3.8"x1-3.4" C5ZY. . . . . . . . . . . . 106 654049 FW 3/8 ANZY. . . . . . . . . . . . . . . . . . 207 139952 PULLEY W/BEARING . . . . . . . . . . . 108 241385 SPACER, PULLEY . . . . . . . . . . . . . 109 071703 LN 3/8" CBZY . . . . . . . . . . . . . . . . . 110a 241010 BELT TENSIONER . . . . . . . . . . . . . 1

11a 656103 LW M10 ZY . . . . . . . . . . . . . . . . . . . 112a 651395 CS M10-1.5x30 C10.9 ZY . . . . . . . . 113 071043 LN SER FL M10-1.50 C10 ZY. . . . . 414 651706 LN INST FL M8-1.25 C8 ZY . . . . . . 115 651517 SHCS M8-1.25x30 C8.8 OCG. . . . . 116 271491 V-BELT /Ax43 . . . . . . . . . . . . . . . . . 117 50352428 COMPRESSOR, A/C. . . . . . . . . . . . 118 656133 FW M10 ZY . . . . . . . . . . . . . . . . . . . 419 651796 CS M10-1.50x110 C10.9 ZY . . . . . . 4

a Belt tensioner includes items #11 and 12

RS-634 Telescopic Handler EngineA/C Compressor Group - (Option)

50960090/AP0914 66 PRINTED IN U.S.A.

Engine MT6034T Telescopic HandlerFuel Circuit

1

23

4

15 15

31

32

6

15

5

78924

1011

12

1314

15

23

16

15

25

26

15

22

272826

25

1525

29

17

18

15

15

19

21

20

151430

SUPPLYRETURN

RETURN

SUPPLY

FUELTANK

ENGINE

RADIATOR

7

6

5

Fuel tank ison shown on

page 52.

Radiatorshow on

next page

PRINTED IN U.S.A. 67 50960090/AP0914

MT6034T Telescopic Handler EngineFuel Circuit


01 650542 CS 1/4"x1/2" C5ZY . . . . . . . . . . . . . 202 50351523 COOLER, FUEL . . . . . . . . . . . . . . . 103 50304911 MOUNT, FUEL COOLER . . . . . . . . 104 071401 HLN INST 1/4" C5ZY. . . . . . . . . . . . 205 50303802 HOSE ASSEMBLY, FUEL . . . . . . . . 1

(includes items 6 and 7)06 50303801 CLAMP, COMPRESSION . . . . . . . . 207 50303794 FITTING, ST 1/2" QD FEMALE . . . . 208 50303791 FITTING, ST QD FUEL . . . . . . . . . . 109 50303793 WASHER, SEALING . . . . . . . . . . . . 110 651698 CS FL M10-1.50x35 8.8 ZY. . . . . . . 211 50302437 FUEL FILTER ASY. (secondary) . . . 112 50302441 FUEL FILTER (only - incld. w/#11) . 113 50302203 ST MJ06-MM16 . . . . . . . . . . . . . . . . 114 50300449 ST HB06-FJS06 BRASS . . . . . . . . . 215 087852 CLAMP, HOSE #06 . . . . . . . . . . . AR16 50304962 HOSE, FUEL -6 x 10" . . . . . . . . . . . 117 50288223 FUEL PUMP (w/fitting). . . . . . . . . . . 1

18 NSS FITTING (included with #17) . . . . . . 119 50381223 HOSE, FUEL -8 x 18" . . . . . . . . . . . 120 650584 FW #10 AZY . . . . . . . . . . . . . . . . . . 421 651195 SHCS HS #10-24x1/2 C . . . . . . . . . 422 50304958 HOSE, FUEL -8 x 25" . . . . . . . . . . . 123 50302438 SENSOR, PRESSURE . . . . . . . . . . 124 651707 LN INST FL M10-1.50 C8 . . . . . . . . 225 50300462 ST HB08-FJS08 BRASS . . . . . . . . . 326 50300327 90 MJ08-MMA16 . . . . . . . . . . . . . . . 227 650489 CS 3/8"x7/8" C5Z . . . . . . . . . . . . . . 228 50303845 WATER SEPARATOR ASSEMBLY . 1

(Refer to filter section at beginning ofthis manual for more information.)

29 054816 90 MJ08-MAORB08 . . . . . . . . . . . . 130 110227 90 MJ06-MAORB08 . . . . . . . . . . . . 131 50304972 HOSE, FUEL -6 x 120" . . . . . . . . . . 132 50304965 HOSE, FUEL -6 x 58" . . . . . . . . . . . 1

50960090/AP0914 68 PRINTED IN U.S.A.

Engine MT6034T Telescopic HandlerRadiator and Cooler Group

Transmission(Left Side)

Transmission(Top-Right Side)

1

2

3

4

5

7

6

9

8

12

10

11

7

6

10

19

10

20

18

19

10

23

21

17

22

21

1412

16

16

15

12

14

1214

12

14

12

13

Radiator andcooler parts

shown on thenext page.

Transmissionis shown on

page 76.

24

25

25

PRINTED IN U.S.A. 69 50960090/AP0914


01 50380595 COOLER ASSEMBLY . . . . . . . . . . . 1(refer to next page for components)

02 50302457 SENSOR, COOLANT LEVEL . . . . . 103 055005 90 MJ12-MAORB12 . . . . . . . . . . . . 104 L67455 HOSE, -12 A12/DS12 105" . . . . . . . 105 210-19470 LN FL SERR 5/16" CZY . . . . . . . . . 606 210148 STUD 3/8"-16 x 2" . . . . . . . . . . . . . . 607 090666 LN FL SERR 3/8" CZY . . . . . . . . . . 608 50301444 HOSE, MP -12 x 68" . . . . . . . . . . . . 109 055064 45 MJ12-MAORB12 . . . . . . . . . . . . 110 055030 CLAMP, HOSE #28 . . . . . . . . . . . . . 411 50381160 HOSE, RADIATOR BOTTOM . . . . . 112 654004 FW 5/16 AWZY . . . . . . . . . . . . . . . 12

13 650486 CS 5/16" x 3/4" C5ZY . . . . . . . . . . . 2(used on in the center hole on both sides of shroud)

14 650484 CS 5/16" x 1/2" C5ZY . . . . . . . . . . . 615 420-19671 CLAMP, HOSE 3/8" . . . . . . . . . . . . . 116 210329 FAN GUARD . . . . . . . . . . . . . . . . . . 217 50381224 FAN SHROUD . . . . . . . . . . . . . . . . . 118 50381161 HOSE, COOLANT . . . . . . . . . . . . . . 119 L75990 CLAMP, HOSE #16 . . . . . . . . . . . . . 220 50380594 HOSE, RADIATOR TOP . . . . . . . . . 121 062023 CLAMP, HOSE #05 M . . . . . . . . . . . 222 50381259 HOSE, HEATER -5 x 16". . . . . . . . . 123 133074 ST HB05-MP04 . . . . . . . . . . . . . . . . 124 102262 HOSE, OVERFLOW 42" . . . . . . . . . 125 650487 CS 5/16" x 1" C5ZY. . . . . . . . . . . . . 4

(used on the yop and bottom on both sides of shroud)

MT6034T Telescopic Handler EngineRadiator and Cooler Group

50960090/AP0914 70 PRINTED IN U.S.A.

Engine MT6034T Telescopic HandlerRadiator and Cooler Components

2

1

4

3

756

6

8

9

Cooler Groupshown onprevious

page.

PRINTED IN U.S.A. 71 50960090/AP0914


01 50380595 COOLER/RAD/TOC/SURGE ASY. . 1(includes all items shown)

02 50220759 RADIATOR SECTION . . . . . . . . . . . 103 104932 CAP, RADIATOR 16PSI. . . . . . . . . . 104 50220227 SIGHT GLASS. . . . . . . . . . . . . . . . . 105 081377 CS FL LOCK 3/8 x 1-1/4" C5ZY . . . 6

06 654006 FW 3/8" AWZY. . . . . . . . . . . . . . . . 1207 50220761 COOLER SECTION, TRANS. . . . . . 108 067847 HLN INST 3/8 CZY . . . . . . . . . . . . . 609 L40805 VALVE, COOLANT DRAIN . . . . . . . 1

MT6034T Telescopic Handler EngineRadiator and Cooler Components

50960090/AP0914 72 PRINTED IN U.S.A.

Engine MT6034T Telescopic HandlerAir Intake Group

1

2 1

3

1

4

8

5

7 6

6

9

76

12

13

14

11

10

PRINTED IN U.S.A. 73 50960090/AP0914


01 190091 CLAMP, T-BOLT 3-3/4" . . . . . . . . . . 302 50304225 HOSE, AIR INTAKE. . . . . . . . . . . . . 103 50381224 FAN SHROUD . . . . . . . . . . . . . . . . . 104 50304231 HOSE, AIR INTAKE. . . . . . . . . . . . . 105 272299 INDICATOR, SERVICE . . . . . . . . . . 106 651720 CS FL M8-1.25x35 8.8 ZY. . . . . . . . 307 651706 LN INST FL M8-1.25 C8 ZY . . . . . . 308 50302313 CLAMP, T-BOLT 4-1/4" . . . . . . . . . . 1

09 50351477 AIR CLEANER ASSEMBLY. . . . . . . 1(includes items 10-14)

10 50220719 DUST EVACUATOR . . . . . . . . . . . . 111 NSS END CAP (not sold separately) . . . . 112 50352454 FILTER, AIR (PRIMARY). . . . . . . . . 113 50352455 FILTER, AIR (SECONDARY) . . . . . 114 NSS HOUSING (not sold separately) . . . 1

MT6034T Telescopic Handler EngineAir Intake Group

50960090/AP0914 74 PRINTED IN U.S.A.

Engine MT6034T Telescopic HandlerExhaust Group

1

5

4

3

2 6

1213

78

10

911

8

7

15

16

14

9

Attaches toengine

Attaches toturbocharger

PRINTED IN U.S.A. 75 50960090/AP0914


01 131951 CLAMP, MUFFLER 3" . . . . . . . . . . . 102 L64764 HANGER, TAILPIPE . . . . . . . . . . . . 103 067847 HLN INST 3/8" CZY. . . . . . . . . . . . . 104 654006 FW 3/8" AWZY. . . . . . . . . . . . . . . . . 205 650490 CS 3/8" x 1" C5ZY. . . . . . . . . . . . . . 106 50381174 TAILPIPE . . . . . . . . . . . . . . . . . . . . . 107 50220574 CLAMP, EXHAUST . . . . . . . . . . . . . 208 50220575 GASKET, EXHAUST . . . . . . . . . . . . 209 651706 LN INST FL M8-1.25 C8 ZY . . . . . . 810 50302200 CLAMP, DOC MOUNT . . . . . . . . . . 211a NSS DOC . . . . . . . . . . . . . . . . . . . . . . . . 1

12 651695 CS FL M8-1.25x25 8.8 ZY. . . . . . . . 813 50381198 MOUNT, DOC . . . . . . . . . . . . . . . . . 114 651699 CS FLH M12-1.75x25 8.8ZY . . . . . . 415 50381150 COUPLER, EXHAUST PIPE . . . . . . 116 50220500 CLAMP, EXHAUST (3-1/2"). . . . . . . 1

50220501 NUT (not included with clamp) . . . . 1

a The DOC is not sold separately; please consult theengine parts manual PN 50960088, or contact thefactory parts department for assistance.

MT6034T Telescopic Handler EngineExhaust Group

50960090/AP0914 76 PRINTED IN U.S.A.

Transmission MT6034T Telescopic HandlerExternal Components

17

18

19

24

23

20

18

21

20

21

17

20 LEFT

RIGHT

1

2

3

4

5

8

7

6

12

9

10

11

11

10

9

13

6

8

14

16

15 Transmissioncooler shownon page 70.

Transmission Cooler

Top Port

Transmission Cooler

Bottom Port

Drive/Flexplate shown

on next page.

PRINTED IN U.S.A. 77 50960090/AP0914


01 50305017 TRANSMISSION/1102 T12000 . . . . 102a 656007 CS M10-1.5X25 C8.8. . . . . . . . . . . 1103b 50302228 CS FLH M10-1.5x40 10.90 CGSP . 804 188973 ST-L MJ12-MORB12 . . . . . . . . . . . . 105 50301444 HOSE, MP -12 x 68" . . . . . . . . . . . . 106 271601 CS 5/8x4 C8OCG SP . . . . . . . . . . . 207 50380901 MOUNT, TRANSMISSION (LH) . . . 108 L50704 CS M12-1.75x40 GR8 . . . . . . . . . . . 509 135425 MOUNT CUSHION . . . . . . . . . . . . . 210 L64197 WASHER . . . . . . . . . . . . . . . . . . . . . 211 067823 HLN INST 5.8 CZY . . . . . . . . . . . . . 212 L66965 SENDER, TEMPERATURE. . . . . . . 113 50304852 MOUNT, TRANSMISSION (RH) . . . 114 054819 ST MJ12-MORB10 . . . . . . . . . . . . . 115 L99184 TRANSMISSION FILTER . . . . . . . . 1

16 L67455 HOSE, -12 A12/DS12 105" . . . . . . . 117 L99182 UNIVERSAL JOINT (includes bolts) 418c L50468 3/8”-24X1-3/4” GR8 BOLT. . . . . . . 1619 50381202 DRIVESHAFT, REAR . . . . . . . . . . . 123d 650965 3/8”-24X1-1/4” GR 8 BOLT . . . . . . . 8

654026 3/8” LOCK WASHER. . . . . . . . . . . . 824 50381201 DRIVESHAFT, FRONT . . . . . . . . . . 1

a Fastens flex plate to flywheel.b Fastens transmission to engine.c Fastens u-joint to transmission and axle yokes.d Fastens u-joint to driveshaft.

MT6034T Telescopic Handler TransmissionExternal Components Group

50960090/AP0914 78 PRINTED IN U.S.A.

1

5

4

3

2

2

2


01 50220762 KIT, DRIVE PLATE . . . . . . . . . . . . . 1(includes all items shown above)

02 NSS DRIVE PLATE . . . . . . . . . . . . . . . . . 3(included with item 1)

03 L98316 RING/DRIVE PLATE BACKING . . . 1

04 L99785 BOLT . . . . . . . . . . . . . . . . . . . . . . . . 605 L99030 LOCKWASHER . . . . . . . . . . . . . . . . 606 L98317 KIT/DRIVE PLATE ASSY . . . . . . . . 1

(includes items 1 thru 5)

Transmission MT6034T Telescopic HandlerDrive (Flex) Plate Group

PRINTED IN U.S.A. 79 50960090/AP0914

14

1110

3

2

158

11

12

13

12

9

11

13

32

1

56

74


01 L99286 HOUSING/CONVERTER . . . . . . . . 102 NSS PLUG (includes item 3) . . . . . . . . . . 403 L99284 O-RING/PLUG (part of item 2) . . . . 404 L99246 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 105 NSS PLUG (includes item 6) . . . . . . . . . . 106 L99284 O-RING/PLUG (part of item 5) . . . . 107 L99262 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 108 L99285 SCREW . . . . . . . . . . . . . . . . . . . . . . 6

09 L99260 SCREW . . . . . . . . . . . . . . . . . . . . . . 310 L99261 SCREW . . . . . . . . . . . . . . . . . . . . . . 111 L99029 WASHER/LOCK . . . . . . . . . . . . . . 1012 L99260 SCREW . . . . . . . . . . . . . . . . . . . . . 1313 L99029 WASHER/LOCK . . . . . . . . . . . . . . 1314 L98938 GASKET/HSG. TO PLATE. . . . . . . . 115 L99249 PLUG/TEMP PICKUP . . . . . . . . . . . 1

MT6034T Telescopic Handler TransmissionConverter Housing Group

50960090/AP0914 80 PRINTED IN U.S.A.

28

1415 21

20

19

1

6

26

33

32

835

349

22

5

34

18

17

3029

31

2316

2

18

17

7

36

2713

12

25

241030

29

31

2119

11

Transmission MT6034T Telescopic HandlerCase and Plate Group

PRINTED IN U.S.A. 81 50960090/AP0914


01 NSS CASE, TRANSMISSION . . . . . . . . . 102 L94824 BREATHER/AIR . . . . . . . . . . . . . . . 103 L99251 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 2

(includes item 4)04 L99013 O-RING/PLUG. . . . . . . . . . . . . . . . . 2

(part of item item 3)05 L99253 PLUG/MAGNETIC DRAIN. . . . . . . . 106 L98927 PIN/DOWEL PLATE TO CASE . . . . 207 L98926 GASKET/PLATE TO CASE . . . . . . . 108 L98185 RING/TUBE SEAL. . . . . . . . . . . . . . 109 L98176 CLIP/OIL TUBE RETAINER . . . . . . 110 102949 PLATE, SPACER. . . . . . . . . . . . . . . 111 L98935 SEAT/SAFETY VALVE . . . . . . . . . . 112 L98932 SNAP RING. . . . . . . . . . . . . . . . . . . 113 L98226 POPPET/SAFETY VALVE . . . . . . . . 114 L98218 SPRING. . . . . . . . . . . . . . . . . . . . . . 115 L98217 WASHER/POPPET . . . . . . . . . . . . . 116 L99246 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 117 NSS PLUG. . . . . . . . . . . . . . . . . . . . . . . . 3

18 L99284 O-RING/PLUG. . . . . . . . . . . . . . . . . 319 L99018 SCREW . . . . . . . . . . . . . . . . . . . . . . 720 L99045 SCREW . . . . . . . . . . . . . . . . . . . . . . 221 L99029 WASHER/LOCK . . . . . . . . . . . . . . . 922 L98184 ASSY/TUBE & SCREEN. . . . . . . . . 123 L99274 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 124 L99246 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 125 L99262 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 126 106175 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 127 L98734 TUBE/TRANS DIPSTICK . . . . . . . . 128 L98735 TRANS DIPSTICK TUBE . . . . . . . . 129 L99287 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 230 L99312 O-RING . . . . . . . . . . . . . . . . . . . . . . 231 L99288 SCREW . . . . . . . . . . . . . . . . . . . . . . 232 L99285 SCREW . . . . . . . . . . . . . . . . . . . . . . 133 L99294 WASHER/SEAL. . . . . . . . . . . . . . . . 134 L99295 WASHER/SCREW. . . . . . . . . . . . . . 135 L99296 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 1

MT6034T Telescopic Handler TransmissionCase and Plate Group

50960090/AP0914 82 PRINTED IN U.S.A.

10

11

13

9

8

13

16

6

14

3

2

1

5

4

6

12

15

7

Transmission MT6034T Telescopic HandlerTorque Converter Group

PRINTED IN U.S.A. 83 50960090/AP0914


01 L98203 ASSY/STATOR SUPPORT . . . . . . . 102 L98204 BUSHING . . . . . . . . . . . . . . . . . . . . 103 L98197 BEARING/FRONT . . . . . . . . . . . . . . 104 L98201 RING/PISTON . . . . . . . . . . . . . . . . . 105 L98202 EXPANDER/RING . . . . . . . . . . . . . . 106 L98200 RING/SNAP. . . . . . . . . . . . . . . . . . . 207 L98194 SEAL/OIL CONV. HSG. . . . . . . . . . . 108 L500294 ASSY/TORQUE CONVERTER . . . . 1

09 L98189 PLUG/BORE . . . . . . . . . . . . . . . . . . 110 L97525 O-RING/BORE PLUG . . . . . . . . . . . 111 L97526 RING/RET. BORE PLUG. . . . . . . . . 112 L98199 IMPELLER/HUB GEAR . . . . . . . . . . 113 L98191 SNAP RING/IMPELLER HUB . . . . . 214 L98205 WASHER/HUB GEAR . . . . . . . . . . . 115 L98198 BEARING/TORQUE CONVERTER. 116 L98196 RING/OIL DISTRIBUTOR . . . . . . . . 1

MT6034T Telescopic Handler TransmissionTorque Converter Group

50960090/AP0914 84 PRINTED IN U.S.A.

13

12

11

9

104 6

5

13

2

15

148

7

16

Transmission MT6034T Telescopic HandlerGear Group

PRINTED IN U.S.A. 85 50960090/AP0914


01 NSS ASSY/REV. GEAR & BEARING . . . 1(includes items 2 and 3)

02 L98253 BEARING/NEEDLE . . . . . . . . . . . . . 2(part of item 1)

03 L98254 SPACER/CLUTCH GEAR . . . . . . . . 1(part of item 1)

04 NSS ASSY/FOR. GEAR & BEARING . . . 1(includes items 5 and 6)


06 L98254 SPACER/CLUTCH GEAR . . . . . . . . 1(part of item 4)

07 L500407 ASY. 3RD CLUTCH GEAR . . . . . . . 1(includes item 8)

08 L500408 BEARING-3RD CLUTCH GEAR . . . 2(part of item 7)

09 L98968 1st CLUTCH GEAR/BRG. ASSY . . . 1(includes item 9)


11 L98276 2nd CLUTCH GEAR/BRG. ASSY . . 1(includes item 12)


13 L98277 GEAR/THIRD DRIVEN - 18T . . . . . 114 L98284 GEAR/OUTPUT SHAFT - 40T . . . . 115 L98955 GEAR/REVERSE IDLER - 28T . . . . 116 L500409 GEAR/FIRST DRIVEN - 27T. . . . . . 1

MT6034T Telescopic Handler TransmissionGear Group

50960090/AP0914 86 PRINTED IN U.S.A.


01 L98945 IDLER/SHAFT & PIN. . . . . . . . . . . . 1(includes item 2)

02 L98947 ROLL PIN . . . . . . . . . . . . . . . . . . . . 1(part of item1)

03 L98944 GEAR/IDLER,PUMP DRIVE . . . . . . 1

04 L98943 BEARING/IDLER GEAR . . . . . . . . . 105 L98211 GEAR/DRIVE. . . . . . . . . . . . . . . . . . 106 L98942 WASHER/THRUST . . . . . . . . . . . . . 207 L98212 RING/SNAP. . . . . . . . . . . . . . . . . . . 1

5

1

6

7

6

4

3

2

Transmission MT6034T Telescopic HandlerDrive Pump Group

PRINTED IN U.S.A. 87 50960090/AP0914


01 L98220 PUMP/T12000 CHARGE. . . . . . . . . 102 L99184 ASSY/ HYDRAULIC SPIN FILTER . 103 L98953 SLEEVE. . . . . . . . . . . . . . . . . . . . . . 104 L98950 PISTON . . . . . . . . . . . . . . . . . . . . . . 105 L98951 SPRING. . . . . . . . . . . . . . . . . . . . . . 106 L98224 PIN/CLARK TRANS. . . . . . . . . . . . . 107 L98949 ASSY/BALL CHECK VALVE . . . . . . 1

(includes items 8 thru 11)08 L98215 BALL . . . . . . . . . . . . . . . . . . . . . . . . 109 L98216 SPRING. . . . . . . . . . . . . . . . . . . . . . 110 L98214 PIN. . . . . . . . . . . . . . . . . . . . . . . . . . 1

11 L98948 O-RING . . . . . . . . . . . . . . . . . . . . . . 112 L98219 GASKET/CHARGE PUMP . . . . . . . 113 L99025 SCREW . . . . . . . . . . . . . . . . . . . . . . 414 L99023 SCREW . . . . . . . . . . . . . . . . . . . . . . 115 L99020 WASHER/LOCK . . . . . . . . . . . . . . . 516 L99027 SCREW . . . . . . . . . . . . . . . . . . . . . . 117 L99029 WASHER/LOCK . . . . . . . . . . . . . . . 1

--ITEMS NOT SHOWN---- L98954 ASSY/FILTER MOUNT . . . . . . . . . . 1

(includes items 3-6)

3

6

54

2

17

16

131415

1

12

10

9

8

7

11

MT6034T Telescopic Handler TransmissionCharge Pump Group

Transmission Charge Pump;not to be confused with the

hydraulic system pump

50960090/AP0914 88 PRINTED IN U.S.A.

Transmission MT6034T Telescopic HandlerOutput Shaft Group

1

6

45

32

6

7

62

35

46

8

9


01 L500274 SHAFT/OUTPUT . . . . . . . . . . . . . . . 102 L98282 BEARING/SHAFT . . . . . . . . . . . . . . 203 L98281 SLEEVE/OIL SEAL . . . . . . . . . . . . . 204 L98268 O-RING/SLEEVE. . . . . . . . . . . . . . . 205 L96053 SEAL/OUTPUT SHAFT OIL . . . . . . 2

06 L98264 RING/SNAP. . . . . . . . . . . . . . . . . . . 407 L98266 RING/SNAP. . . . . . . . . . . . . . . . . . . 208 L98279 FLANGE/OUTPUT & PLUG ASSY . 109 L98278 PLUG/FLANGE . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A. 89 50960090/AP0914

2

95

7

6

4

8

3

1


01 L98229 SHAFT IDLER & PILOT . . . . . . . . . 102 L98228 RING/SNAP. . . . . . . . . . . . . . . . . . . 103 L98231 BEARING/REV IDLR GEAR . . . . . . 104 L98230 WASHER/THRUST . . . . . . . . . . . . . 1

05 L98232 END PLATE. . . . . . . . . . . . . . . . . . . 106 L99031 CAPSCREW . . . . . . . . . . . . . . . . . . 107 L99032 WASHER . . . . . . . . . . . . . . . . . . . . . 108 L98233 END PLATE. . . . . . . . . . . . . . . . . . . 1

MT6034T Telescopic Handler TransmissionReverse Idler Group

50960090/AP0914 90 PRINTED IN U.S.A.

16

17

18

19

20

17

16

17

17

19

3

2

4

9

8

151413

12

1

7

6

5

10

17

1617

9

8

15

1413

12

11

1716

1719

2019

21

22

7

11

105

6

Transmission MT6034T Telescopic HandlerForward and Reverse Group

PRINTED IN U.S.A. 91 50960090/AP0914


01 L98248 ASY/TURB SHFT DRUM & PLUG . 102 L98251 SLEEVE/OIL DISTRIBUTOR. . . . . . 103 L98252 SCREW . . . . . . . . . . . . . . . . . . . . . . 104 L98250 RING/PISTON . . . . . . . . . . . . . . . . . 305 L99278 ASY/PISTON . . . . . . . . . . . . . . . . . . 2

(includes items 6 and 7)06 L98246 SEAL/OUTER PISTON . . . . . . . . . . 2

(part of item 5)07 L98247 SEAL/INNER PISTON. . . . . . . . . . . 2

(part of item 5) 08 L98238 PLATE/END . . . . . . . . . . . . . . . . . . . 209 L98237 RING/SNAP. . . . . . . . . . . . . . . . . . . 210 L98244 PLATE/WEAR . . . . . . . . . . . . . . . . . 211 L98961 ASY/DISC SPRING Pkg 5. . . . . . . . 2

12 L98242 RETAINER. . . . . . . . . . . . . . . . . . . . 213 L98241 RETAINER/SNAP RING . . . . . . . . . 214 L98240 CLUTCH/OUTER FWD . . . . . . . . . 1215 L98239 CLUTCH/INNER FWD. . . . . . . . . . 1216 L98236 BEARING. . . . . . . . . . . . . . . . . . . . . 417 L98235 WASHER/THRUST . . . . . . . . . . . . . 818 L98249 BEARING/REAR . . . . . . . . . . . . . . . 119 L98253 BEARING/CLUTCH GEAR . . . . . . . 420 L98254 SPACER/CLUTCH GEAR . . . . . . . . 221 L98962 ASSY/REV. AND BRG. . . . . . . . . . . 1

(includes items 19 and 20)22 L98255 ASSY/FOR. GEAR AND BRG. . . . . 1

(includes items 19 and 20)

MT6034T Telescopic Handler TransmissionForward and Reverse Group

50960090/AP0914 92 PRINTED IN U.S.A.

7

34

2421

1

10

5

1920

2222

23

2019

2021

1413

12

11

1817

16

15

8

9

6

20

221

Transmission MT6034T Telescopic HandlerThird Shaft Group

PRINTED IN U.S.A. 93 50960090/AP0914


01 L500410 ASY-3RD SHAFT, DRUM & PLUG . 102 L500411 BEARING-ROLLER. . . . . . . . . . . . . 103 L500273 ASSY/BEARING & SEAL . . . . . . . . 104 L500412 WASHER-BEARING SUPPORT . . . 105 L98258 SLEEVE/OIL DISTRIBUTOR. . . . . . 106 L98257 SCREW/SLEEVE LOCK . . . . . . . . . 107 L98250 RING/PISTON . . . . . . . . . . . . . . . . . 208 L99279 ASSY/CLTCH PISTON & BALL. . . . 109 L98246 SEAL/OUTER PISTON . . . . . . . . . . 110 L98247 SEAL/INNER PISTON. . . . . . . . . . . 111 L98240 CLUTCH/OUTER FWD . . . . . . . . . . 512 L98239 CLUTCH/INNER FWD. . . . . . . . . . . 5

13 L98238 PLATE/END . . . . . . . . . . . . . . . . . . . 114 L98237 RING/SNAP. . . . . . . . . . . . . . . . . . . 115 L98244 RING/SNAP. . . . . . . . . . . . . . . . . . . 116 L98961 ASY/DISC SPRG PKG 5. . . . . . . . . 117 L98242 RETAINER. . . . . . . . . . . . . . . . . . . . 118 L98241 RETAINER/SNAP RING . . . . . . . . . 119 L500413 BEARING-THRUST NEEDLE . . . . . 220 L500414 WASHER/CLTCH GEAR THRUST . 421 L99696 RING/SNAP. . . . . . . . . . . . . . . . . . . 322 L500408 BEARING-3RD CLUTCH GEAR . . . 223 L500407 ASY. 3RD CLUTCH GEAR . . . . . . . 124 L500408 GEAR-FIRST DRIVEN . . . . . . . . . . 1

MT6034T Telescopic Handler TransmissionThird Shaft Group

50960090/AP0914 94 PRINTED IN U.S.A.

65

10

12

1314

20

218

915

16

25

24

15

16

3

418

19

17

15

16

24

26

15

16

98

2322

14

11

13

10

5

6

71

7

27

2

Transmission MT6034T Telescopic HandlerFirst and Second Shaft Group

PRINTED IN U.S.A. 95 50960090/AP0914


01 L98274 ASY-1ST 2ND SHAFT. . . . . . . . . . . 102 L98275 BEARING/REAR . . . . . . . . . . . . . . . 103 L500273 ASSY/BEARING & SEAL . . . . . . . . 104 L98250 RING/PISTON . . . . . . . . . . . . . . . . . 205 L99038 PISTON/CLUTCH & SEALS . . . . . . 206 L98246 SEAL/OUTER PISTON . . . . . . . . . . 207 L98247 SEAL/INNER PISTON. . . . . . . . . . . 208 L98238 PLATE/END . . . . . . . . . . . . . . . . . . . 209 L98237 RING/SNAP. . . . . . . . . . . . . . . . . . . 210 L98244 PLATE/WEAR . . . . . . . . . . . . . . . . . 211 L98961 ASSY/DISC SPRG PKG 5 . . . . . . . 112 L98967 SPRING/DISC ASSY PKG (7). . . . . 113 L98242 RETAINER. . . . . . . . . . . . . . . . . . . . 214 L98241 RETAINER/SNAP RING . . . . . . . . . 215 L98236 BEARING. . . . . . . . . . . . . . . . . . . . . 4

16 L98235 WASHER/THRUST . . . . . . . . . . . . . 817 L98260 RING/SNAP. . . . . . . . . . . . . . . . . . . 218 L98272 SLEEVE/OIL DISTRIBUTOR. . . . . . 119 L98257 SCREW/SLEEVE LOCK . . . . . . . . . 120 L98240 CLUTCH/OUTER FWD . . . . . . . . . 1021 L98239 CLUTCH/INNER FWD. . . . . . . . . . 1022 L98240 CLUTCH/OUTER FWD . . . . . . . . . . 523 L98239 CLUTCH/INNER FWD. . . . . . . . . . . 524 L98253 BEARING/CLUTCH GEAR . . . . . . . 425 L98968 1ST CLUTCH GEAR/BRG ASSY . . 1

(includes item 24)26 L98276 2ND CLUTCH GEAR/BRG ASSY . . 1

(includes item 24)27 L98277 GEAR/3RD DRIVEN . . . . . . . . . . . . 1

MT6034T Telescopic Handler TransmissionFirst and Second Shaft Group

50960090/AP0914 96 PRINTED IN U.S.A.

1

14

7

6

10

11

13

12

9

5

4

3

8

2

15


01 L98291 HOUSING MODULATOR VALVE . . 102 L98292 O-RING . . . . . . . . . . . . . . . . . . . . . . 103 L98294 SPRING INNER. . . . . . . . . . . . . . . . 104 L98295 SPRING MIDDLE . . . . . . . . . . . . . . 105 L98304 SPRING OUTER . . . . . . . . . . . . . . . 106 L98298 SLEEVE-MODULATION VALVE . . . 107 L98307 O-RING . . . . . . . . . . . . . . . . . . . . . . 108 L98293 PIN STOP . . . . . . . . . . . . . . . . . . . . 1

09 L98303 SPOOL ACCUMULATOR . . . . . . . . 110 L98958 SPOOL . . . . . . . . . . . . . . . . . . . . . . 111 L98300 SPRING. . . . . . . . . . . . . . . . . . . . . . 112 L98302 RETAINER. . . . . . . . . . . . . . . . . . . . 113 L98301 SPACER . . . . . . . . . . . . . . . . . . . . . 114 L98956 PIN-UPPER . . . . . . . . . . . . . . . . . . . 115 L98957 PIN-LOWER . . . . . . . . . . . . . . . . . . 1

Transmission MT6034T Telescopic HandlerModulation Valve Group

PRINTED IN U.S.A. 97 50960090/AP0914

12

11

1

10

9 87

2

6

54 3


01 102950 SOLENOID, W / DEUTSCH CON. . 4(includes items 2 thru 5)

02 102951 O-RING, 21.5 X 1.5MM . . . . . . . . . . 4(included with item 1)

03 102952 O-RING, 15.1 X 1.60MM . . . . . . . . . 4(included with item 1)



06 102955 PLUG, SOLENOID BORE . . . . . . . . 1(includes items 7, 8 and 9)




10 102957 CLAMP, SOLENOID . . . . . . . . . . . . 611 106259 CAPSCREW . . . . . . . . . . . . . . . . . 1212 102959 WASHER, PLAIN. . . . . . . . . . . . . . 12

MT6034T Telescopic Handler TransmissionControl Group

50960090/AP0914 98 PRINTED IN U.S.A.

1

1213

14

15

11

10

9

7

4

32

17

18

19

16

20

22

Front axle (shown)

LEFT

RIGHT

AXLE MODEL ANDSERIAL NUMBER PLATE

Axle MT6034T Telescopic HandlerExternal Components

Driveshaftsare on

page 76.

PRINTED IN U.S.A. 99 50960090/AP0914


01 NSS TIRE AND WHEEL ASY . . . . . . . . AR809528 VALVE STEM . . . . . . . . . . . . . . . . ARNSS TIRE, 15.00X19.5 12 PLY809610 WHEEL ONLY (for above tire) . . . ARNSS TIRE, 9.00R 20XMINE D2809558 WHEEL ONLY (for above tire) . . . AR

02a L50253 3/8”-16 BUTTON HD BOLT. . . . . . . 603a L99951 FENDER . . . . . . . . . . . . . . . . . . . . . 104a 105857 FENDER MOUNT . . . . . . . . . . . . . . 107a 102587 M12-1.5 NUT . . . . . . . . . . . . . . . . . . 409 L50201 M20-2.5 CLASS 10 LOCK NUT . . . 8

(four per axle)10 L50712 3/4”-10X9” GR8 BOLT . . . . . . . . . . . 411 210569 FRAME LEVEL MNT (front axle). . . 112 L69734 M22-1.5 WHEEL NUT . . . . . . . . . . 32

(eight per wheel)13 L50084 3/4”-10 GR8 LOCK NUT . . . . . . . . . 8

(four per axle)14 210572 PLATE, FRAME LEVEL. . . . . . . . . . 115 651543 M20-2.50X130 C10.9 BOLT . . . . . . 8

(four per axle)

16 L500543 THRUST BUSHING. . . . . . . . . . . . . 217 L500544 SUPPORT . . . . . . . . . . . . . . . . . . . . 218 L98355 GREASE FITTING. . . . . . . . . . . . . . 219 L500496 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 220 L500542 REDUCTION BUSING . . . . . . . . . . 421 NA . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 022b AXLE ASSEMBLY, 212

102668 FRONT (with internal park brake) . . 150380746 FRONT (remanufactured) (note c)L68849 REAR. . . . . . . . . . . . . . . . . . . . . . . . 150380745 REAR (remanufactured) (note c)

a Available only on the front axle left side.

b Axle assembly only, does not include any otheritems shown in the illustration.

c Call the factory parts department for moreinformation regarding remanufactured axles.

MT6034T Telescopic Handler AxleExternal Components

50960090/AP0914 100 PRINTED IN U.S.A.

Axle MT6034T Telescopic HandlerBrake and Steering Circuit - Front Axle

615

4

2

37

47

45

4

9

9

10

11

19

2

10

11

12

14

18

15

1617

20

21

22

8

13T

L

Steer motoralso shown

on page 172

Brake valvecircuit

shown onpage 30

Steer selectalso shownon page 26.

PBPARK

BRAKE

SERVICEBRAKE

Flow Dividerparts are onpage 167.

PRINTED IN U.S.A. 101 50960090/AP0914


01 102313 MANIFOLD, FLOW DIVIDER . . . . . 102 079026 45 MJ06-MAORB06 . . . . . . . . . . . . 203 103317 HOSE, -6 A6/A6 28" . . . . . . . . . . . . 104 L66139 ST MJ06-MM14 . . . . . . . . . . . . . . . . 405 095457 TE MJ06 MJ06 FJS06. . . . . . . . . . . 206 L69928 HOSE, -4 A6/A6 25" . . . . . . . . . . . . 107 091039 90 MJ06 FJS06 . . . . . . . . . . . . . . . . 208 L69928 HOSE, -4 A6/A6 25" . . . . . . . . . . . . 109 102842 HOSE, -4 A4/A4 66" . . . . . . . . . . . . 110 100011 ST MJ08-MM18 . . . . . . . . . . . . . . . . 211 088442 90 MJ08-FJS08 . . . . . . . . . . . . . . . . 2

12 103319 HOSE, -6 A6/A8 22" . . . . . . . . . . . . 113 L69747 VALVE, STEER SELECT . . . . . . . . 114 230-32195 ST MJ04-MORB04 . . . . . . . . . . . . . 215 104111 HOSE, -4 A4/A4 18" . . . . . . . . . . . . 116 50381095 ST MJ04-M12x1 DIN FL 74235. . . . 117 50380743 BRAKE CYL. SINGLE TANDEM . . . 118 L70428 MANIFOLD, BRAKE LINE. . . . . . . . 119 210828 SWITCH, PRESSURE 150 PSI. . . . 120 L63387 HOSE, -6 A8/DS8 67" . . . . . . . . . . . 121 054626 ST MJ08-MORB08 . . . . . . . . . . . . . 122 101882 STEER MOTOR/17.9 DYNAMIC. . . 1

MT6034T Telescopic Handler AxleBrake and Steering Circuit - Front Axle

50960090/AP0914 102 PRINTED IN U.S.A.

Axle MT6034T Telescopic HandlerBrake and Steering Circuit - Rear Axle

12

19

18

20

1716

21

3

34 5

6

6

7

815

7

810

9

10

9

11

1213

14

11

B

A

P

R

SERVICEBRAKE

Steer selectalso shownon page 26.

Brake valvecircuit

shown onpage 30.

Steer motoralso shownon page 26.

PRINTED IN U.S.A. 103 50960090/AP0914


01 101882 STEER MOTOR/17.9 DYNAMIC. . . 102 054626 ST MJ08-MORB08 . . . . . . . . . . . . . 103 L63387 HOSE, -6 A8/DS8 67" . . . . . . . . . . . 104 079026 45 MJ06-MAORB06 . . . . . . . . . . . . 105 L69747 VALVE, STEER SELECT . . . . . . . . 106 054994 ST MJ06-MORBO6 . . . . . . . . . . . . . 207 50304898 HOSE, -6 x 115" . . . . . . . . . . . . . . . 108 50304898 HOSE, -6 x 115" . . . . . . . . . . . . . . . 109 088442 90 MJ08-FJS08 . . . . . . . . . . . . . . . . 210 100011 ST MJ08-MM18 . . . . . . . . . . . . . . . . 211 L66139 ST MJ06-MM14 . . . . . . . . . . . . . . . . 2

12 091039 90 MJ06 FJS06 . . . . . . . . . . . . . . . . 113 L69928 HOSE, -4 A6/A6 25" . . . . . . . . . . . . 114 095457 TE MJ06 MJ06 FJS06. . . . . . . . . . . 115 102840 HOSE, -4 A4/A6 90" . . . . . . . . . . . . 116 50381095 ST MJ04-M12x1 DIN FL 74235. . . . 117 104111 HOSE, -4 A4/A4 18" . . . . . . . . . . . . 118 L70428 MANIFOLD, BRAKE LINE. . . . . . . . 119 210828 SWITCH, PRESSURE 150 PSI. . . . 120 230-32195 ST MJ04-MORB04 . . . . . . . . . . . . . 221 50380743 BRAKE CYL. SINGLE TANDEM . . . 1

MT6034T Telescopic Handler AxleBrake and Steering Circuit - Rear Axle

50960090/AP0914 104 PRINTED IN U.S.A.


01 50220265 ARTICULATED TIE ROD . . . . . . . . 1(includes tie rod nut)(Right [Front Axle], Left [Rear Axle])

02 50220264 STEER CYLINDER . . . . . . . . . . . . . 150220267 SEAL KIT (not shown) . . . . . . . . . . . 1L500539 STEER CYLINDER BOLT . . . . . . . 4

(not shown)03 50220266 ARTICULATED TIE ROD . . . . . . . . 1

(includes tie rod nut)(Left [Front Axle], Right [Rear Axle])

LEFT

RIGHT

3

1

2

Axle MT6034T Telescopic HandlerFront Axle - Steer Cylinder and Tie Rods Group

50220268

TIE ROD NUT

PRINTED IN U.S.A. 105 50960090/AP0914

LEFT

RIGHT

3

1

2

MT6034T Telescopic Handler AxleRear Axle - Steer Cylinder and Tie Rods Group

50220268

TIE ROD NUT


01 50220265 ARTICULATED TIE ROD . . . . . . . . 1(includes tie rod nut)(Right [Front Axle], Left [Rear Axle])

02 50220264 STEER CYLINDER . . . . . . . . . . . . . 150220267 SEAL KIT (not shown) . . . . . . . . . . . 1L500539 STEER CYLINDER BOLT . . . . . . . 4

(not shown)03 50220266 ARTICULATED TIE ROD . . . . . . . . 1

(includes tie rod nut)(Left [Front Axle], Right [Rear Axle])

50960090/AP0914 106 PRINTED IN U.S.A.


01 L98417 O-RING . . . . . . . . . . . . . . . . . . . . . . 302 L500451 INTERMEDIATE COVER . . . . . . . . 103 102573 HOUSING . . . . . . . . . . . . . . . . . . . . 104 104518 COVER . . . . . . . . . . . . . . . . . . . . . . 105 L500454 VENT . . . . . . . . . . . . . . . . . . . . . . . . 1

06 NA . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 007 102575 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 108 102576 MAGNETIC PLUG. . . . . . . . . . . . . . 109 L98373 SNAP RING. . . . . . . . . . . . . . . . . . . 1

Axle MT6034T Telescopic HandlerFront Axle - Differential Housing Group

PRINTED IN U.S.A. 107 50960090/AP0914

01 L98417 O-RING . . . . . . . . . . . . . . . . . . . . . . 302 L500451 INTERMEDIATE COVER . . . . . . . . 103 L500452 HOUSING . . . . . . . . . . . . . . . . . . . . 104 L500453 COVER . . . . . . . . . . . . . . . . . . . . . . 1

05 L500454 VENT . . . . . . . . . . . . . . . . . . . . . . . . 106 L500455 SEAL WASHER. . . . . . . . . . . . . . . . 207 L98318 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 108 102576 MAGNETIC PLUG. . . . . . . . . . . . . . 1

6

4

8

7

653

1

2

1

1


MT6034T Telescopic Handler AxleRear Axle - Differential Housing Group

50960090/AP0914 108 PRINTED IN U.S.A.


01 102617 SPACER . . . . . . . . . . . . . . . . . . . . . 202 102618 SPRING. . . . . . . . . . . . . . . . . . . . . . 403 102619 PISTON . . . . . . . . . . . . . . . . . . . . . . 204 102620 O-RING . . . . . . . . . . . . . . . . . . . . . . 205 102621 O-RING . . . . . . . . . . . . . . . . . . . . . . 406 102622 BACKUP RING . . . . . . . . . . . . . . . . 407 102623 COVER . . . . . . . . . . . . . . . . . . . . . . 208 L98368 O-RING . . . . . . . . . . . . . . . . . . . . . . 209 102624 BACKUP RING . . . . . . . . . . . . . . . . 210 102625 PISTON . . . . . . . . . . . . . . . . . . . . . . 211 102626 INTERMEDIATE BRAKE DISC . . . . 212 102627 SPRING. . . . . . . . . . . . . . . . . . . . . . 613 102628 ADJUSTING BOLT . . . . . . . . . . . . . 614 L500527 BRAKE DISC. . . . . . . . . . . . . . . . . . 6

15 L500536 INTERMEDIATE BRAKE DISC . . . . 616 103390 SPACER . . . . . . . . . . . . . . . . . . . . . 217 103391 BOLT . . . . . . . . . . . . . . . . . . . . . . . . 418 103392 ADJUSTING BOLT . . . . . . . . . . . . . 619 102632 SPRING. . . . . . . . . . . . . . . . . . . . . . 620 102633 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 421 102634 LOCK WASHER . . . . . . . . . . . . . . . 422 104655 BLEEDING BOLT . . . . . . . . . . . . . . 423 L500496 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 424 102635 SHIM (2mm) . . . . . . . . . . . . . . . . . . 2

102636 SHIM (3mm) . . . . . . . . . . . . . . . . . . 2102637 SHIM (5mm) . . . . . . . . . . . . . . . . . . 2

25 104621 BOLT . . . . . . . . . . . . . . . . . . . . . . . . 426 104607 SEAL WASHER. . . . . . . . . . . . . . . . 4

1

2

3

4

5

6

2322

25

26

7 89

10

11

1213

19

18

14

1516

24

21 2017

Axle MT6034T Telescopic HandlerFront Axle - Brake Group

10

1

14

23

45

6

7

12

11

9

8

13

PRINTED IN U.S.A. 109 50960090/AP0914


01 L500527 BRAKE DISC. . . . . . . . . . . . . . . . . . 602 L500528 ADJUSTING BOLT . . . . . . . . . . . . . 603 L500529 SPRING. . . . . . . . . . . . . . . . . . . . . . 604 NSS PISTON . . . . . . . . . . . . . . . . . . . . . . 205 L500531 SPRING. . . . . . . . . . . . . . . . . . . . . . 606 L500532 BACK-UP RING. . . . . . . . . . . . . . . . 207 L500533 O-RING . . . . . . . . . . . . . . . . . . . . . . 208 L500534 BACK-UP RING. . . . . . . . . . . . . . . . 2

09 L500535 O-RING . . . . . . . . . . . . . . . . . . . . . . 210 L500536 INTERMEDIATE BRAKE DISC . . . . 811 104655 BLEEDING BOLT . . . . . . . . . . . . . . 212 L500496 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 213 L500537 DOWEL . . . . . . . . . . . . . . . . . . . . . . 214 L500538 PISTON . . . . . . . . . . . . . . . . . . . . . . 2

(includes items 3,4, 6-9)

MT6034T Telescopic Handler AxleRear Axle - Brake Group

50960090/AP0914 110 PRINTED IN U.S.A.

26

25

24

2321

20

16

1514

1312

11

8

54

5

36

12

9

23

24

29

27

33

4544

43

42

41

36

3938

3635

19

18

30, 31

28 29

27

10

46

51

40

34

5049 848

47

7

22

32

3717

Axle MT6034T Telescopic HandlerFront Axle - Outer End Group

FRONT

31

30FRONT AXLE

PRINTED IN U.S.A. 111 50960090/AP0914


01 L500483 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 202 L500484 BOLT . . . . . . . . . . . . . . . . . . . . . . . . 203 103394 BOLT . . . . . . . . . . . . . . . . . . . . . . . 2404 102614 STUD. . . . . . . . . . . . . . . . . . . . . . . . 805 L500487 WASHER . . . . . . . . . . . . . . . . . . . . 3206 102615 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 807 103393 AXLE CASE. . . . . . . . . . . . . . . . . . . 208 102575 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 409 102576 MAGNET PLUG. . . . . . . . . . . . . . . . 210 L500488 REDUCTION BUSHING (set) . . . . . 211 L98372 SNAP RING. . . . . . . . . . . . . . . . . . . 212 L98373 SNAP RING. . . . . . . . . . . . . . . . . . . 213 L98371 BALL BEARING. . . . . . . . . . . . . . . . 214 L500489 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 215 L500490 O-RING . . . . . . . . . . . . . . . . . . . . . . 216 103395 JOINT . . . . . . . . . . . . . . . . . . . . . . . 217 NSS (included as part of item 18) . . . . . . 018 105958 SEAL/DUST EXCLUDER . . . . . . . . 219 L500492 THRUST BUSHING. . . . . . . . . . . . . 220 102587 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 521 102583 WASHER . . . . . . . . . . . . . . . . . . . . . 822 102893 STUD. . . . . . . . . . . . . . . . . . . . . . . . 823 L500496 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 424 L98355 GREASE FITTING. . . . . . . . . . . . . . 425 103398 PIVOT PIN. . . . . . . . . . . . . . . . . . . . 226 L500523 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 2

L500524 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 2L500525 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 2

27 NSS (not used on this axle) . . . . . . . . . . . 028 103396 BUSHING . . . . . . . . . . . . . . . . . . . . 229 L500499 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 430 L500501 STEERING CASE . . . . . . . . . . . . . . 1

(includes item 19)31 L500504 STEERING CASE . . . . . . . . . . . . . . 1

(includes item 19)32 L500498 PIVOT PIN (set). . . . . . . . . . . . . . . . 233 L500500 BEARING. . . . . . . . . . . . . . . . . . . . . 234 L500494 BOLT . . . . . . . . . . . . . . . . . . . . . . . 1235 L500505 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 236 104604 BEARING. . . . . . . . . . . . . . . . . . . . . 437 102601 WHEEL STUD . . . . . . . . . . . . . . . . 1638 L500508 WHEEL HUB . . . . . . . . . . . . . . . . . . 239 L98417 O-RING . . . . . . . . . . . . . . . . . . . . . . 240 L500519 SNAP RING. . . . . . . . . . . . . . . . . . . 241 L500509 RING GEAR . . . . . . . . . . . . . . . . . . 242 L500510 RING GEAR SUPPORT . . . . . . . . . 243 L500522 LOCKING PLATE . . . . . . . . . . . . . . 244 104600 SNAP RING. . . . . . . . . . . . . . . . . . . 845 104641 PLANET GEAR . . . . . . . . . . . . . . . . 846 104642 BEARING. . . . . . . . . . . . . . . . . . . . . 847 103399 PLANET GEAR CARRIER . . . . . . . 248 104504 COUNTERSUNK BOLT. . . . . . . . . . 449 103401 PLANET GEAR CARRIER . . . . . . . 2

(includes items 41-48)50 L500518 NUT . . . . . . . . . . . . . . . . . . . . . . . . 1651 L500517 STUD. . . . . . . . . . . . . . . . . . . . . . . 16

MT6034T Telescopic Handler AxleFront Axle - Outer End Group

50960090/AP0914 112 PRINTED IN U.S.A.

Axle MT6034T Telescopic HandlerFront Axle - Differential Group

PRINTED IN U.S.A. 113 50960090/AP0914


01 L500457 O-RING . . . . . . . . . . . . . . . . . . . . . . 102 L500459 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1

L500460 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1L500461 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1L98414 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1

03 L500463 BEVEL GEAR SET . . . . . . . . . . . . . 104 L98380 TAPER ROLLER BEARING . . . . . . 205 L500464 RING NUT . . . . . . . . . . . . . . . . . . . . 206 L500465 CYLINDER BOLT . . . . . . . . . . . . . . 407 L500466 CYLINDER BOLT . . . . . . . . . . . . . . 208 L500467 BOLT . . . . . . . . . . . . . . . . . . . . . . . 1209 L500468 FRICTION WASHER. . . . . . . . . . . . 210a 105266 DIFFERENTIAL PINION GEAR . . . 1

(DIFFERENTIAL SIDE GEAR KIT)11 103402 PIN. . . . . . . . . . . . . . . . . . . . . . . . . . 412 L500471 SNAP RING. . . . . . . . . . . . . . . . . . . 4

13 L500472 FRICTION WASHER. . . . . . . . . . . . 414b 105266 DIFFERENTIAL PINION GEAR . . . 1

(DIFFERENTIAL SIDE GEAR KIT)15 L500474 DIFFERENTIAL CARRIER . . . . . . . 116 L500475 TAPER ROLLER BEARING . . . . . . 217 L98404 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1


18 L500478 SPACER . . . . . . . . . . . . . . . . . . . . . 119 L98396 RING NUT . . . . . . . . . . . . . . . . . . . . 120 L98395 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 122 102863 FLANGE . . . . . . . . . . . . . . . . . . . . . 123 L500480 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 124 L500481 SNAP RING. . . . . . . . . . . . . . . . . . . 4

a Differential gear kit #105266 includes 2 of item#10 (L500469) and 4 of item #14 (L500473).

MT6034T Telescopic Handler AxleFront Axle - Differential Group

50960090/AP0914 114 PRINTED IN U.S.A.

46

2728

29

3031

2832

43

33 3435

3650 37

38

4142

40 3925

25

44 48

2019

1318

16

15

24

2

1 45

3

15161749

1921,26

12

2

1

4

1122

10

5

96

7814

13

FRONT

47

Axle MT6034T Telescopic HandlerRear Axle - Outer End Group

FRONT 21

26

REAR AXLE

PRINTED IN U.S.A. 115 50960090/AP0914


01 L500483 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 202 L500484 STEERING ADJUST BOLT . . . . . . . 203 L500485 AXLE CASE. . . . . . . . . . . . . . . . . . . 204 L500486 BOLT . . . . . . . . . . . . . . . . . . . . . . . 3205 L500488 REDUCTION BUSHING . . . . . . . . . 2

(includes items 6-9, and 47)06 L500489 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 207 L98371 BALL BEARING. . . . . . . . . . . . . . . . 207 L98372 SNAP RING. . . . . . . . . . . . . . . . . . . 209 L500490 O-RING . . . . . . . . . . . . . . . . . . . . . . 210 L500491 JOINT . . . . . . . . . . . . . . . . . . . . . . . 211 L500492 THRUST BUSHING. . . . . . . . . . . . . 2

(included with items 21 and 26)12 L500493 OUTER RACE . . . . . . . . . . . . . . . . . 213 L500494 BOLT . . . . . . . . . . . . . . . . . . . . . . . 2014 L500495 COVER . . . . . . . . . . . . . . . . . . . . . . 215 L500496 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 416 L98355 GREASE FITTING. . . . . . . . . . . . . . 217 L500497 PIVOT PIN. . . . . . . . . . . . . . . . . . . . 2

(includes item 16)18 L500498 PIVOT PIN. . . . . . . . . . . . . . . . . . . . 2

(includes items 16, 19 and 20)19 L500499 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 220 L500500 ARTICULATION. . . . . . . . . . . . . . . . 221 L500501 STEERING CASE . . . . . . . . . . . . . . 1

(includes item 11)22 105958 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 224 102576 MAGNETIC PLUG. . . . . . . . . . . . . . 225 L98318 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 4

26 L500504 STEERING CASE . . . . . . . . . . . . . . 1(includes item 11)

27 L500505 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 228 104604 BEARING. . . . . . . . . . . . . . . . . . . . . 429 L500507 WHEEL STUD . . . . . . . . . . . . . . . . 1630 L500508 WHEEL HUB . . . . . . . . . . . . . . . . . . 231 L98417 O-RING . . . . . . . . . . . . . . . . . . . . . . 232 L500509 RING GEAR . . . . . . . . . . . . . . . . . . 233 L500510 RING GEAR SUPPORT . . . . . . . . . 234 104600 SNAP RING. . . . . . . . . . . . . . . . . . . 835 104641 PLANET GEAR . . . . . . . . . . . . . . . . 836 104642 BEARING. . . . . . . . . . . . . . . . . . . . . 837 L69734 WHEEL NUT . . . . . . . . . . . . . . . . . 1638 L500455 SEAL WASHER. . . . . . . . . . . . . . . . 639 104504 COUNTERSUNK BOLT. . . . . . . . . . 440 L500516 PLANET GEAR CARRIER . . . . . . . 241 L500517 STUD. . . . . . . . . . . . . . . . . . . . . . . 1642 L500518 NUT . . . . . . . . . . . . . . . . . . . . . . . . 1643 L500519 SNAP RING. . . . . . . . . . . . . . . . . . . 244 104546 ADJUSTING BOLT (includes #45) . 445 NSS NUT (included with item #44) . . . . . 446 L500522 LOCKING PLATE . . . . . . . . . . . . . . 247 L98373 SNAP RING. . . . . . . . . . . . . . . . . . . 248 L500555 SPACER . . . . . . . . . . . . . . . . . . . . . 249 L500523 SHIM - .15mm . . . . . . . . . . . . . . . . . 2

L500524 SHIM - .20mm . . . . . . . . . . . . . . . . . 2L500525 SHIM - .50mm . . . . . . . . . . . . . . . . . 2

50 103401 PLANET GEAR CARRIER . . . . . . . 2(includes items 32-36, 40-41)

MT6034T Telescopic Handler AxleRear Axle - Outer End Group

50960090/AP0914 116 PRINTED IN U.S.A.

12

15

4

7

5

924

3

17

1618

2

16

20

21

19

22

1

23

1411

65

413

1313

14

12

24

11

24

1310

12

11

7 8

11912

24

Axle MT6034T Telescopic HandlerRear Axle - Differential Group

PRINTED IN U.S.A. 117 50960090/AP0914

01 L500457 O-RING . . . . . . . . . . . . . . . . . . . . . . 102 L98415 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1

L500459 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1L500460 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1L500461 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1L98414 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1

03 L500463 BEVEL GEAR SET . . . . . . . . . . . . . 104 L98380 TAPER ROLLER BEARING . . . . . . 205 L500464 RING NUT . . . . . . . . . . . . . . . . . . . . 206 L500465 CYLINDER BOLT . . . . . . . . . . . . . . 407 L500466 CYLINDER BOLT . . . . . . . . . . . . . . 208 L500467 BOLT . . . . . . . . . . . . . . . . . . . . . . . 1209 L500468 FRICTION WASHER. . . . . . . . . . . . 210a 105266 DIFFERENTIAL PINION GEAR . . . 1

(DIFFERENTIAL SIDE GEAR KIT)11 L500470 PIN W/CLIP (includes item 12) . . . . 412 L500471 SNAP RING. . . . . . . . . . . . . . . . . . . 4

13 L500472 FRICTION WASHER. . . . . . . . . . . . 414a 105266 DIFFERENTIAL PINION GEAR . . . 1

(DIFFERENTIAL SIDE GEAR KIT)15 L500474 DIFFERENTIAL CARRIER . . . . . . . 116 L500771 TAPER ROLLER BEARING . . . . . . 217 L98404 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1


18 L500478 SPACER . . . . . . . . . . . . . . . . . . . . . 119 L98396 RING NUT . . . . . . . . . . . . . . . . . . . . 120 L98395 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 121 L98394 COVERPLATE. . . . . . . . . . . . . . . . . 122 102863 FLANGE . . . . . . . . . . . . . . . . . . . . . 123 L500480 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 124 L500481 SNAP RING. . . . . . . . . . . . . . . . . . . 4

a Differential Gear Kit #105266 includes 2 of item#10 (L500469) and 4 of item #14 (L500473).


MT6034T Telescopic Handler AxleRear Axle - Differential Group

50960090/AP0914 118 PRINTED IN U.S.A.

FRONT

REAR

26

4

32

22

23

24

25

27

282927

1

33

353410

32

27

3130

15

16

1413

15

21

7

6

5

25

10

89

1211

43B

36

42

Boom MT6034T Telescopic HandlerOuter Boom Section

45

44

Boom chainsare on

page 122.

Boom hosesbegin on

page 128.

B

PRINTED IN U.S.A. 119 50960090/AP0914


01 L68350 BOOM, OUTER . . . . . . . . . . . . . . . . 102 L70242 5/16”-18 NUTSERT . . . . . . . . . . . . . 203 L65640 PLATE, BOOM ANGLE IND.. . . . . . 104 654004 5/16” FLAT WASHER . . . . . . . . . . . 205 L52048 BUTTON HD 5/16”-18X1” SS . . . . . 206 L65638 INCLINOMETER-ANGLE IND. . . . . 107 651271 #8-32X3/8” HHM USL CZY . . . . . . . 2

650549 #10 FW (not shown) . . . . . . . . . . . . 208 L50380 1/2”-20X1-1/4” BOLT . . . . . . . . . . . . 209 654030 1/2” LOCK WASHER. . . . . . . . . . . . 210 655001 PIN, COTTER 1/16”X3/4” . . . . . . . . 611 L63169 PIN, OUTER BOOM CLEVIS . . . . . 112 L63173 CLEVIS, OUTER BOOM . . . . . . . . . 113 L63131 REAR OUTER COVER . . . . . . . . . . 114 L50226 5/16”-18X1” SELF TAP SCREW . . . 415 L68006 BUSHING 2.5IDX2.75ODX4” . . . . . 216 L68003 LIFT CYLINDER PIVOT BUSHING. 221 L63099 PIN, PIVOT PIN. . . . . . . . . . . . . . . . 1

L50462 1/2”-13X5 BOLT (not shown) . . . . . 1068034 HLN INST 1/2 CZY (not shown) . . . 1

22 L63694 EXTEND CYLINDER BRACKET. . . 1650490 3/8”-16X1” BOLT (not shown) . . . . 2654026 3/8” LOCK WASHER (not shown) . 2

23 L61708 SLIDE PAD 5/8”X4”X6” . . . . . . . . . . 224 L62715 FLAT-BOLT LOCK . . . . . . . . . . . . . . 2

25 650488 3/8”-16X3/4” BOLT . . . . . . . . . . . . . 626 650490 3/8”-16X1” BOLT . . . . . . . . . . . . . . . 227 654026 3/8” LOCK WASHER. . . . . . . . . . . 1228 L61709 SLIDE PAD 5/8”X3”X4” . . . . . . . . . . 429 L62733 SHIM .06”X3”X4” . . . . . . . . . . . . . . . 230 650491 3/8”-16X1-1/4” BOLT . . . . . . . . . . . . 431 L64143 SHIM 1/2”X3”X4” . . . . . . . . . . . . . . . 232 650533 3/8”-16X1-1/2” BOLT . . . . . . . . . . . . 433 L63167 PIN, CLEVIS ADJUSTMENT. . . . . . 234a L63166 CLEVIS, CHAIN ADJUSTMENT . . . 235 L50086 3/4”-10 NUT. . . . . . . . . . . . . . . . . . . 436 L71748 TOP CLAMP PLATE . . . . . . . . . . . . 137b 103333 BRACKET, LIGHT MOUNT . . . . . . . 138b L70040 WORK LIGHT . . . . . . . . . . . . . . . . . 239b 654006 3/8” FLAT WASHER . . . . . . . . . . . . 440b 090666 3/8”-16 WHIZ LOCK NUT . . . . . . . . 441b 650491 3/8”-16X1-1/4” BOLT . . . . . . . . . . . . 242 103330 CLAMP, BOOM HOSES . . . . . . . . AR43 103331 CLAMP, BOOM W/INSERT . . . . . AR44 L50056 5/16” FLANGE LOCK NUT. . . . . . AR45 L51035 5/16”X2” BOLT . . . . . . . . . . . . . . . AR

--- ITEMS NOT SHOWN ---00b L70462 WIRE HARNESS, WORK LIGHT . . 1

a Refer to page 122 for boom chains.b When equipped with Optional Boom Work Lights.

(Refer to illustration below.)

38

37

40

3941

40

39

Boom Work Lights(Option)

(mounts to front of boom;reference B on facing page)

MT6034T Telescopic Handler BoomOuter Boom Section

B

50960090/AP0914 120 PRINTED IN U.S.A.

FRONT

REAR

20

16

29

28

27

9108

118

12

19

16

17

16

18

19

14

15

21

21

54

3

6

7

891011

812

13

1721 19

223

22

26

252413

16

19

16

211719

211

17

Boom MT6034T Telescopic HandlerIntermediate Boom Section

Boom chainsare on page

122.

PRINTED IN U.S.A. 121 50960090/AP0914


01 L68744 INTERMEDIATE SECT WLDMNT. . 102 L63006 TRAY, INTERMEDIATE . . . . . . . . . . 103 650484 5/16”-18X1/2” BOLT . . . . . . . . . . . . 104 L50207 CLAMP, VINYL .69 DBL . . . . . . . . . 105 L520004 5/16”X18 NYLON INSERT NUT . . . 106 067847 HLN INST 3/8 CZY . . . . . . . . . . . . . 207 651625 3/8”-16X1-1/4” BOLT . . . . . . . . . . . . 208 L68697 WASHER, CHAIN SHEAVE . . . . . . 609 L63158 RING, BEARING-INNER . . . . . . . . . 310 L63157 BEARING, BOOM SHEAVE . . . . . . 311 L63153 SHEAVE, CHAIN . . . . . . . . . . . . . . . 312 650493 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 213 067847 HLN INST 3/8 CZY . . . . . . . . . . . . . 214 L68695 PIN, FRONT SHEAVE. . . . . . . . . . . 115 650490 3/8”-16X1” BOLT . . . . . . . . . . . . . . . 4

16 L62715 FLAT-BOLT LOCK . . . . . . . . . . . . . 1217 L62734 SHIM, .105”X3”X4” . . . . . . . . . . . . . 818 L62733 SHIM, .06”X3”X4” . . . . . . . . . . . . . . 219 650488 3/8”-16X3/4” BOLT . . . . . . . . . . . . 2820 654026 3/8” LOCK WASHER. . . . . . . . . . . . 821 L61709 SLIDE PAD, 5/8”X3”X4”. . . . . . . . . 1222 650533 3/8”-16X1-1/2” BOLT . . . . . . . . . . . . 123 654026 3/8” LOCK WASHER. . . . . . . . . . . . 124 L68696 PIN, REAR SHEAVE . . . . . . . . . . . . 125 L63239 SPACER, TRAY BRACKET. . . . . . . 126 L61699 SLIDE PAD, 2”X3” . . . . . . . . . . . . . . 127 L61708 SLIDE PAD, 5/8”X4”X6”. . . . . . . . . . 228 L62731 SHIM, .06”X4”X6” . . . . . . . . . . . . . . 229 L62732 SHIM, .105”X4”X6” . . . . . . . . . . . . . 2

NOTE: Refer to page 122 for boom chains.

MT6034T Telescopic Handler BoomIntermediate Boom Section

50960090/AP0914 122 PRINTED IN U.S.A.

REAR

FRONT

22

28

27

2524 23

9

11

7 9

10

20

19

21

171615

1413

12

7

111098

7

21

22

3

4

18

5

6

Boom MT6034T Telescopic HandlerInner Boom Section

30

29

26

Refer to note c on

facing page.

Boom hosesbegin on

page 128.

PRINTED IN U.S.A. 123 50960090/AP0914


01 L68762 INNER BOOM WELDMENT . . . . . . 102 L63005 HOSE TRAY, INNER BOOM . . . . . . 103 L71748 TOP PLATE, HOSE CLAMP . . . . . . 104 L61699 SLIDE PAD 2”X3” . . . . . . . . . . . . . . 105 103330 CLAMP, BOOM HOSES . . . . . . . . . 106 103331 CLAMP, BOOM W/INSERT . . . . . . 107 650488 3/8”-16X3/4” BOLT . . . . . . . . . . . . 1708 654026 3/8” LOCK WASHER. . . . . . . . . . . . 109 L61709 SLIDE PAD 5/8”X3”X4” . . . . . . . . . . 410 L62734 SHIM .105”X3”X4” . . . . . . . . . . . . . . 211 L62715 FLAT-BOLT LOCK . . . . . . . . . . . . . . 812 L66783 SHIM .105”X3”X8” . . . . . . . . . . . . . . 213 L66782 SHIM .06”X3”X8” . . . . . . . . . . . . . . . 214 L66780 SLIDE PAD 3”x8”. . . . . . . . . . . . . . . 215a L63156 CHAIN, BOOM LEAF . . . . . . . . . . . 216 655001 PIN, COTTER 1/16”X3/4” . . . . . . . . 417 L63168 PIN, INNER BOOM CLEVIS . . . . . . 118b L63156 CHAIN, BOOM LEAF . . . . . . . . . . . 119 L63166 CLEVIS, CHAIN ADJUSTMENT . . . 120 L63167 PIN, CLEVIS ADJUSTMENT. . . . . . 121 L50086 3/4”-10 NUT. . . . . . . . . . . . . . . . . . . 222 L68003 BUSHING . . . . . . . . . . . . . . . . . . . . 2

23c L50877 5/16”-18X2-1/4” STUD. . . . . . . . . . . 224c L63716 CUSHION, HOSE-TWIN .68 . . . . . . 225 L63715 PLATE, TWIN CUSHION TOP . . . . 126c L520004 HLN INST 5/16" . . . . . . . . . . . . . . . . 227 067847 HLN INST 3/8 CZY . . . . . . . . . . . . . 228 651625 BH CS 3/8”-1-1/4” . . . . . . . . . . . . . . 229 L50056 5/16” FLANGE LOCK NUT. . . . . . AR30 L51035 5/16”X2” BOLT . . . . . . . . . . . . . . . AR

a Attaches from the rear of the inner boom to the chain adjustment clevis’ located on the front of theouter boom section. (Refer to Outer Boom Section, item #34, chain adjustment clevis.)

b Attaches from item #19 (chain adjustment clevis) toouter boom clevis. (Refer to Outer Boom Section,item #12, outer boom clevis.)

c If the machine is equipped with optional auxiliaryhydraulics, items #23 and #26 are not used; instead there will be (2) 650784 5/16" x 2-3/4" bolts, (2) 654024 5/16" lock washers, and two additional hose cushions (#24).

MT6034T Telescopic Handler BoomInner Boom Section

50960090/AP0914 124 PRINTED IN U.S.A.

2

76

212

11

109

9

1314

3

54

3

1

Tilt Cylinder

15

Boom MT6034T Telescopic HandlerDynattach® Bracket Assembly

TiltCylinderparts are

on page 190.

PRINTED IN U.S.A. 125 50960090/AP0914


01 L98700 DYNATTACH WELDMENT . . . . . . . 1(includes items 9, and 12-15)

02 067847 HLN INST 3/8 CZY . . . . . . . . . . . . . 303 650493 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 304 L63274 PIN, TAPPED 1-1/2” DIA . . . . . . . . . 205 L68003 BUSHING . . . . . . . . . . . . . . . . . . . . 206 L63272 PIN, TILT CYL.(ROD END) . . . . . . . 107 L63018 BUSHING, TILT CYL (ROD END) . . 109 L66456 BUSHING, LOCK PIN . . . . . . . . . . . 210a NSS PIN, DYNATTACH LOCK . . . . . . . . 1

11a NSS DYNATTACH LOCK WLDMNT . . . . 112 L50646 3/16”X1-3/4” ROLL PIN . . . . . . . . . . 113 L65097 LOCK SPRING . . . . . . . . . . . . . . . . 114 L65098 SPRING MOUNT. . . . . . . . . . . . . . . 115 L63957 LOCK AND PIN ASSEMBLY . . . . . . 1

(includes items 10-11)

-- ITEMS NOT SHOWN ---- L66613 DECAL, DYNATTACH UNLOCKED 1

(adheres to item #11)

a Not sold separately; order item #15.

MT6034T Telescopic Handler BoomDynattach® Bracket Assembly

50960090/AP0914 126 PRINTED IN U.S.A.

Boom Hydraulics MT6034T Telescopic HandlerLift Circuit

2 14

5

3

1

23

4

5

6

6

7

9

8

71

4

5

3

2

137

12

9

1011

8

13

1210 11

13

7

5

4

BOOM LIFT

RETRACT

EXTEND

Lift cylinderparts are on page 186.

Valve circuitis on

page 136.

EXTENDRETRACT

RETRACT

EXTEND

Hydraulicvalve parts

are on page 168.

PRINTED IN U.S.A. 127 50960090/AP0914


01 L10057 ZERK, GREASE . . . . . . . . . . . . . . . 402 L68003 BRONZE BUSHING . . . . . . . . . . . . 403 L63274 PIN, LIFT CYLINDER . . . . . . . . . . . 404 650493 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 405 067847 HLN INST 3/8 CZY . . . . . . . . . . . . . 406 L63199 CYLINDER, LIFT . . . . . . . . . . . . . . . 207 054816 90 MJ08-MAORB08 . . . . . . . . . . . . 4

08 L63407 HOSE, -6 A8/A8 48” . . . . . . . . . . . . 109 L63407 HOSE, -6 A8/A8 48” . . . . . . . . . . . . 110 076143 ADAP -8JICFS -8JICM RUN TEE . . 211 076031 90 MJ08-MAORB10 . . . . . . . . . . . . 212 L63407 HOSE, -6 A8/A8 48” . . . . . . . . . . . . 113 L63407 HOSE, -6 A8/A8 48” . . . . . . . . . . . . 1

MT6034T Telescopic Handler Boom HydraulicsLift Circuit

50960090/AP0914 128 PRINTED IN U.S.A.

Boom Hydraulics MT6034T Telescopic HandlerTilt / Slave Circuit

16

1

7

1213

14

15

26

20

3

56

25

2424

2125

26

723

5

22

27

17

18

18

19

8

8 9 10

11

1213

1615

14

7523 3

4

3

1

2

2

5

7 6

Slave cylinderparts are onpage 188.

Tilt cylinderparts are onpage 190.

Extend RetractExtend

FORKTILT

Retract

28

Hydraulicvalve partsare on page

168.

PRINTED IN U.S.A. 129 50960090/AP0914


01a L68374 HOSE, -6 A8/H10 322” . . . . . . . . . . 102a L68374 HOSE, -6 A8/H10 322” . . . . . . . . . . 103 054816 ADAP., -8ORM -8JICM 90º . . . . . . . 304 L63013 CYLINDER, TILT . . . . . . . . . . . . . . . 105 650493 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 406 L63272 PIN, CYLINDER (rod end). . . . . . . . 207 067847 HLN INST 3/8 CZY . . . . . . . . . . . . . 408 L520004 5/16”-18 NYLON INSERT NUT . . . 1009 L63715 PLATE, TWIN CUSHION. . . . . . . . . 110 L63716 CUSHION, HOSE 0.6875 TWIN . . . 211b L50877 5/16”-18X2-1/4” STUD. . . . . . . . . . . 212 L50056 FLN SERR 5/16" . . . . . . . . . . . . . . . 213 103331 CLAMP, HOSE 0.625 W/INSRT . . . 214 103330 CLAMP, BOOM HOSE 0.625 . . . . . 215 L71748 PLATE, CLAMP TOP. . . . . . . . . . . . 216 L51035 CS 5/16" x 2" . . . . . . . . . . . . . . . . . . 217 L50877 5/16”-18X2-1/4” STUD. . . . . . . . . . . 818 L68039 CUSHION, TUBE 0.625 TWIN . . . . 819 L63715 PLATE, TWIN CUSHION. . . . . . . . . 4

20 L63407 HOSE, -6 A8/A8 48" . . . . . . . . . . . . 121 L68817 HOSE, -6 A8/A8 28” . . . . . . . . . . . . 122 076880 45 MJ08 MAORB08. . . . . . . . . . . . . 123 L63273 PIN, CYLINDER (base end) . . . . . . 224 121387 TEE MJ08-MAORB10-MJ08 . . . . . . 225 50380757 HOSE, -8 x 52" . . . . . . . . . . . . . . . . 126 50380757 HOSE, -8 x 52" . . . . . . . . . . . . . . . . 127 L63014 CYLINDER, SLAVE . . . . . . . . . . . . . 128 L68351 TUBE, TILT/AUX . . . . . . . . . . . . . . . 2

a Both hoses fit inside the protective hose sleeve PN L500784.

b If the machine is equipped with optional auxiliaryhydraulics, items #11 and two of the item #8 are notused; instead there will be (2) 650784 5/16" x 2-3/4" bolts, (2) 654024 5/16" lock washers, and two additional hose cushions (#10). Refer to the auxiliary hydraulics circuit pages for moreinformation.

MT6034T Telescopic Handler Boom HydraulicsTilt / Slave Circuit

50960090/AP0914 130 PRINTED IN U.S.A.

Boom Hydraulics MT6034T Telescopic HandlerBoom Extend Circuit

1

2

3

4

5

6

10

9

8

7

7

68

10

9

1112

4

2

13

1415

16

5

Hose cushion mounts arewelded to the undersideof the outer boom and are not a service part.

Boom Extendcylinder parts

are on page 192.

BOOMEXTEND

Hydraulicvalve partsare on page

168.

PRINTED IN U.S.A. 131 50960090/AP0914


01 L63012 CYLINDER, BOOM EXTEND . . . . . 102 067847 HLN INST 3/8 CZY . . . . . . . . . . . . . 203 L63273 PIN, CYLINDER (base end) . . . . . . 104 650493 CS 3/8”-16x2-3/4” C5ZY . . . . . . . . . 205 126862 90-LL MJ08-MAORB08 . . . . . . . . . . 206 50380756 HOSE, -8 x 70" . . . . . . . . . . . . . . . . 207 650784 CS 5/16" x 2-3/4" C5ZY. . . . . . . . . . 408 L68358 CUSHION, TOP PLATE. . . . . . . . . . 2

09 L68348 CUSHION, HOSE 0.875" . . . . . . . . 410 L520004 HLN INST 5/16"-18 . . . . . . . . . . . . . 411 50302155 ST-L MJ08-MORB10 . . . . . . . . . . . . 212 L63272 PIN, CYLINDER (rod end). . . . . . . . 113 654026 LW 3/8" RZY . . . . . . . . . . . . . . . . . . 214 650490 CS 3/8" x 1" C5ZY. . . . . . . . . . . . . . 215 L63694 BRACKET, CYLINDER STOP. . . . . 116 570019 FITTING, GREASE 1/4". . . . . . . . . . 2

MT6034T Telescopic Handler Boom HydraulicsBoom Extend Circuit

50960090/AP0914 132 PRINTED IN U.S.A.

Boom Hydraulics MT6034T Telescopic HandlerAuxiliary Hydraulics Circuit

1

2

6

65

3

4

9

7

810

11

7

8

17

18

19

20

21

24

23

22

16

15

14

1312

1314 15

16

12

2

1

AUXILIARYHYDRAULIC

(Option)

Hydraulic valve is shownwith the optional auxiliaryhydraulics work section.

Hose cushions andclamps fasten to the

front-right side ofinner boom.

Hydraulic valveparts (including

auxiliary section)are on page 168.

Inner boom ison page 122.

PRINTED IN U.S.A. 133 50960090/AP0914


01a L68376 HOSE, -6 A8/H10 352” . . . . . . . . . . 102a L68376 HOSE, -6 A8/H10 352” . . . . . . . . . . 103 654024 LW 5/16 RZY . . . . . . . . . . . . . . . . . . 204 650784 CS 5/16”-18X2-3/4” C5ZY . . . . . . . . 205 L63715 PLATE, TOP 2.50" . . . . . . . . . . . . . . 106 L63716 CUSHION, HOSE 0.69" TWIN . . . . 4

(two for the tilt hoses and two for theauxiliary hydraulics hoses)

07 076147 CLAMP, HOSE 0.50 x 0.41 . . . . . . . 408 054626 ST MJ08-MORB08 . . . . . . . . . . . . . 209 L65273 QUICK COUPLER SET. . . . . . . . . . 110 650448 CS 1/4 x 3/4 C5ZY . . . . . . . . . . . . . 211 654002 FW 1/4 AWZY . . . . . . . . . . . . . . . . . 212 L50056 FLN SERR 5/16" . . . . . . . . . . . . . . . 2

13 103331 CLAMP, HOSE 0.625 W/INSRT . . . 214 103330 CLAMP, BOOM HOSE 0.625 . . . . . 215 L71748 PLATE, CLAMP TOP. . . . . . . . . . . . 216 L51035 CS 5/16" x 2" . . . . . . . . . . . . . . . . . . 217 L50877 5/16”-18X2-1/4” STUD. . . . . . . . . . . 818 L68039 CUSHION, TUBE 0.625 TWIN . . . . 819 L63715 PLATE, TWIN CUSHION. . . . . . . . . 420 L520004 5/16”-18 NYLON INSERT NUT . . . . 821 L68351 TUBE, BOOM TILT/AUX . . . . . . . . . 222 50302155 ST-L MJ08-MORB10 . . . . . . . . . . . . 223 50380757 HOSE, -8 X 52" . . . . . . . . . . . . . . . . 124 50380757 HOSE, -8 X 52" . . . . . . . . . . . . . . . . 1

a Used with protective fabric sleeve PN L500784.

MT6034T Telescopic Handler Boom HydraulicsAuxiliary Hydraulics Circuit

50960090/AP0914 134 PRINTED IN U.S.A.

Hydraulics MT6034T Telescopic HandlerHydraulic Pump Group

Front AxlePark Brake

(left side)

Joysticks(Note a)

PWP Manifold"P" Port(Note b)

HydraulicControl Valve(right-front port)

TPB

EP

J

INS

LS

P

HydraulicTank

(return)

HydraulicTank

(supply)


HydraulicPump parts

are on page 166.

2928

27

30

26

25

22

2123

24

19 17

11

18

1615

11

10

14

13

20

1

12

6

119 8

7

5

4

5

33

6

12

13

32

31

2

1

3

HydraulicTank is onpage 50.

PRINTED IN U.S.A. 135 50960090/AP0914

MT6034T Telescopic Handler HydraulicsHydraulic Pump Group

01 L63402 HOSE, -4 A4/A6 48" . . . . . . . . . . . . 102 137784 90 MJ06-MAORB04 . . . . . . . . . . . . 103 101882 STEER MOTOR 17.9 DYNAMIC. . . 104 L64524 CHECK VALVE FITTING. . . . . . . . . 105 L68808 HOSE, -6 A8/DS8 48" . . . . . . . . . . . 106 50381079 HOSE, -6 X 23" . . . . . . . . . . . . . . . . 107 654002 FW 1/4" AWZY . . . . . . . . . . . . . . . . 208 L50139 LW 1/4" . . . . . . . . . . . . . . . . . . . . . . 209 L50217 CS 1/4"x3-1/2" (one not shown) . . . 210 102313 FLOW DIVIDER. . . . . . . . . . . . . . . . 111 054994 ADAP., -6ORM -6JICM STR . . . . . . 312 L66563 HOSE, -12 A12/A12 26" . . . . . . . . . 113 055005 90 MJ12-MAORB12 . . . . . . . . . . . . 214 055064 45 MJ12-MAORB12 . . . . . . . . . . . . 115a 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 116b L63381 HOSE, -4 A6/A6 15” . . . . . . . . . . . . 117 103317 HOSE, -6 A6/A6 28” . . . . . . . . . . . . 118 079026 45 JM06-MAORB06 . . . . . . . . . . . . 1

19 103368 HOSE, -6 A6/DS6 52” . . . . . . . . . . . 120 L67455 HOSE, -12 A12/DS12 105" . . . . . . . 121 650488 CS 3/8" x 3/4" C5ZY . . . . . . . . . . . . 122 090666 LN FL SERR 3/8" CZY . . . . . . . . . . 123 L570017 CLAMP, HOSE 1.19 x 0.41 . . . . . . . 124 L63309 HOSE, -24 A24/A24 35” . . . . . . . . . 125 100012 90 MJ04-FJS04 . . . . . . . . . . . . . . . . 126 L445014 90 MJ24-MAORB20 . . . . . . . . . . . . 127 L46865 GASKET, HYD PUMP . . . . . . . . . . . 128 651148 FW 1/2” . . . . . . . . . . . . . . . . . . . . . . 229 650495 CS 1/2”-13 x 1-1/4” . . . . . . . . . . . . . 230 50380843 HYDRAULIC PUMP, 47cc . . . . . . . 131 054626 ST MJ08-MORB08 . . . . . . . . . . . . . 132 088442 90 MJ08-FJS08 . . . . . . . . . . . . . . . . 133 076143 TEE MJ08-FJS08-MJ08 . . . . . . . . . 1

a Standard (units not equipped with PWP).b Option (units equipped with PWP).


50960090/AP0914 136 PRINTED IN U.S.A.

Hydraulics MT6034T Telescopic HandlerHydraulic Control Valve and Hoses

26

25

16

18

17

1

18

17

2

3

4 5

620

19

2115

19 22 7

8

923

1023

112212

13

21

20

14

24

Hydraulicvalve parts

are onpage 168.

A

B

PRINTED IN U.S.A. 137 50960090/AP0914


01 L68809 HOSE, -4 A6/DS6 136” . . . . . . . . . . 102 L67455 HOSE, -12 A12/DS12 105" . . . . . . . 103 L68809 HOSE, -4 A6/DS6 136” . . . . . . . . . . 104 L63407 HOSE, -6 A8/A8 48” . . . . . . . . . . . . 105 L63407 HOSE, -6 A8/A8 48” . . . . . . . . . . . . 106 50380756 HOSE, -8 X 70" . . . . . . . . . . . . . . . . 107 50380757 HOSE, -8 X 52" . . . . . . . . . . . . . . . . 108 L68817 HOSE, -6 A8/A8 26” . . . . . . . . . . . . 109 50380757 HOSE, -8 X 52" (hydraulic option) . 110 50380757 HOSE, -8 X 52" (hydraulic option). . 111 50380757 HOSE, -8 X 52" . . . . . . . . . . . . . . . . 112 L63407 HOSE, -6 A8/A8 48” . . . . . . . . . . . . 113 50380756 HOSE, -8 X 70" . . . . . . . . . . . . . . . . 114 L63407 HOSE, -6 A8/A8 48” . . . . . . . . . . . . 115 L63407 HOSE, -6 A8/A8 48” . . . . . . . . . . . . 116 L63406 HOSE, -12 A12/DS12 114” . . . . . . . 117 L60253 ST MJ06-MORB10 . . . . . . . . . . . . . 218 072587 ST MJ12-MORB12 . . . . . . . . . . . . . 2

HOSE LOCATOR

01 HYDRAULIC CONTROL VALVE SECTION 1 PORT “A” LEVEL CYLINDER (INSIDE-EXTEND)02 HYDRAULIC CONTROL VALVE “IN” FLOW DIVIDER PORT “EF”03 HYDRAULIC CONTROL VALVE SECTION 1 PORT “B” LEVEL CYLINDER (OUTSIDE-RETRACT)04 HYDRAULIC CONTROL VALVE SECTION 2 PORT “B” LIFT CYLINDER (LEFT) (OUTSIDE-RETRACT)05 HYDRAULIC CONTROL VALVE SECTION 2 PORT “B” LIFT CYLINDER (RIGHT) (INSIDE-RETRACT)06 HYDRAULIC CONTROL VALVE SECTION 3 PORT “B” BOOM EXTEND CYLINDER (BOOM RETRACT)07 HYDRAULIC CONTROL VALVE SECTION 4 PORT “B” TILT CYLINDER (RETRACT)08 HYDRAULIC CONTROL VALVE SECTION 4 PORT “B” SLAVE CYLINDER (BOTTOM-RETRACT)09 OPTIONAL HYD. SECTION PORT “B” HYDRAULIC OPTION (RETRACT)10 OPTIONAL HYD. SECTION PORT “A” HYDRAULIC OPTION ( EXTEND)11 HYDRAULIC CONTROL VALVE SECTION 4 PORT “A” TILT CYLINDER (EXTEND)12 HYDRAULIC CONTROL VALVE SECTION 4 PORT “A” SLAVE CYLINDER (TOP-EXTEND)13 HYDRAULIC CONTROL VALVE SECTION 3 PORT “A” BOOM EXTEND CYLINDER (BOOM EXTEND)14 HYDRAULIC CONTROL VALVE SECTION 2 PORT “A” LIFT CYLINDER (LEFT) (INSIDE-EXTEND)15 HYDRAULIC CONTROL VALVE SECTION 2 PORT “A” LIFT CYLINDER (RIGHT) (OUTSIDE-EXTEND)16 HYDRAULIC CONTROL VALVE “OUT” HYDRAULIC TANK (FILTER COVER FITTING)

19 076031 90 MJ08-MAORB10 . . . . . . . . . . . . 220 076143 TEE MJ08-FJS08-MJ08 . . . . . . . . . 221 50302155 ST-L MJ08-MORB10 . . . . . . . . . . . . 222 121387 TEE MJ08-MAORB10-MJ08 . . . . . . 223 50302155 ST-L MJ08-MORB10 (hyd. option) . 224a L68694 VALVE, HYDRAULIC CONTROL . . 1

(refer to note a)25 650833 CS 5/16" X 3" C5ZY . . . . . . . . . . . . 326 L520004 LN INST 5/16" . . . . . . . . . . . . . . . . 3

a The illustration on the facing page shows the hydraulic valve with the optional auxiliary hydraulicswork section. Be aware that the standard four-section valve, PN L68694, does not include the auxiliary hydraulics work section. The kit for the optional auxiliary hydraulics work section is PN L68778.

MT6034T Telescopic Handler HydraulicsHydraulic Control Valve and Hoses

HoseLayout

FRAME LEVEL

BOOM LIFT

BOOM EXTEND

FORK TILT

AUX. HYD. (OPTION)

RETRACTEXTEND

ValveFunctions

A

B

50960090/AP0914 138 PRINTED IN U.S.A.

TILT “FORWARD” (R)

TILT “BACK”(E)

LEVEL “LEFT” (E)

LEVEL “RIGHT” (R)BOOM “DOWN”(R)

EXTEND

RETRACT

LEVEL (RIGHT)BOOM (OUT)

BOOM (DOWN)

TILT (FORWARD)HYDRAULIC OPTION

TILT (BACK)HYDRAULIC OPTION

BOOM (UP)BOOM (IN)

LEVEL (LEFT)

7 7

49

5

9

5

6

66

6

3

4

2

1

4

(R) = retract(E) = extend

TILTLEVEL

LIFTEXTEND

HYDRAULICOPTION

8Hydraulic Control Valve shownwith Auxiliary Hydraulics Option 8

BOOM “UP”(E)

BOOM “IN” (R)

BOOM “OUT” (E)

OUT

DOWNUP

IN

RIGHTLEFT

FORWARDBACK

FRONT

Hydraulics MT6034T Telescopic HandlerDual Controls (Standard) Circuit

Controllersare on pages

176-182.

PRINTED IN U.S.A. 139 50960090/AP0914


01 103264 CONTROLLER, AUX. HYD . . . . . . . 102 103263 CONTROLLER, LIFT/EXTEND . . . . 103 103262 CONTROLLER, TILT/LEVEL. . . . . . 104 054994 ADAP., -6ORM -6JICM STR. . . . . AR05 L68811 HOSE, -4 A6/A6 108” . . . . . . . . . . . 206 L68810 HOSE, -4 A6/A6 96” . . . . . . . . . . . . 407 L68810 HOSE, -4 A6/A6 96” . . . . . . . . . . . . 2

08a L68694 HYDRAULIC CONTROL VALVE . . . 109 L64275 HOSE, -4 A6/A6 102” . . . . . . . . . . . 2

a The illustration on the facing page shows the (optional) auxiliary hydraulic work section with thehydraulic control valve. Be aware the auxiliary hydraulic work section is not included with the hydraulic control valve (PN L68694), but must be ordered separately as a kit (PN L68778). Refer to page 168 for more information

MT6034T Telescopic Handler HydraulicsDual Controls (Standard) Circuit

50960090/AP0914 140 PRINTED IN U.S.A.

P 4

3

1

2

T

B

TA

P

FLOW DIVIDERPORT “J”

HYDRAULICTANK MANIFOLD

LEGEND

BOOM IN/OUTBOOM UP/DOWNFRAME LEVEL

6

78

4

3

7

3

8

3

2

4

12

1011

7

4

10

3

14

13

7

3

14

64

3

9

5

7

1

16

15

17

3

P

T

7

Hydraulics MT6034T Telescopic HandlerTri-Function Control (Option) - Standard Hydraulics Circuit


176-182.

PRINTED IN U.S.A. 141 50960090/AP0914

01 L71346 CONTROLLER, TRI-FUNCTION. . . 102 103264 CONTROLLER, FRAME LEVEL . . . 103 054994 ADAP., -6ORM -6JICM STR . . . . . 1404 068938 ADAP., -6ORM -6JICM 90º . . . . . . . 905 054820 ADAP., -6ORM -6JICM RUN TEE . . 106 091039 ADAP., -6JICM -6JICFS 90º . . . . . . 207 L68810 HOSE, -6 A6/A6 96” . . . . . . . . . . . . 608 L69903 HOSE, -4 A6/DS6 17” . . . . . . . . . . . 209 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 110 102831 HOSE, -4 A6/DS6 102” . . . . . . . . . . 2

11 072806 ADAP., -6JICM -6JICFS RUN TEE . 112 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 113 L69904 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 114 102843 HOSE, -4 A6/DS6 35” . . . . . . . . . . . 115 106898 PILOT APPLY MANIFOLD. . . . . . . . 116 L50741 STUD, 1/4”X3-1/4”. . . . . . . . . . . . . . 217 L50051 NUT, 1/4”-20 WHIZ NUT . . . . . . . . . 2

-- ITEMS NOT SHOWN ---- 105580 TRI-FUNCTION WIRE HARNESS . 1-- L62761 1/4” MALE ELEC. CONNECTOR . . 8


MT6034T Telescopic Handler HydraulicsTri-Function Control (Option) - Standard Hydraulics Circuit

50960090/AP0914 142 PRINTED IN U.S.A.

P

P 4

3

1

2

A

T

B

TA

P

B

T

FLOW DIVIDERPORT “J” HYDRAULIC

TANK MANIFOLD

LEGEND

BOOM IN/OUTBOOM UP/DOWNFRAME LEVEL

6

78

4

3

7

3

8

3

2

15

18

13

19 16

12

1011

7

4

7

10

11 3 415

13

18

3

7

3

14

4

14

9

5

7

1

3

17

P

T

3

Hydraulics MT6034T Telescopic HandlerTri-Function Control (Option) with Auxiliary Hydraulics Circuit


176-182.

PRINTED IN U.S.A. 143 50960090/AP0914

01 L71346 CONTROLLER, TRI-FUNCTION. . . 102 103264 CONTROLLER, FRAME LEVEL . . . 103 054994 ADAP., -6ORM -6JICM STR . . . . . 1904 068938 ADAP., -6ORM -6JICM 90º . . . . . . 1005 054820 ADAP., -6ORM -6JICM RUN TEE . . 106 091039 ADAP., -6JICM -6JICFS 90º . . . . . . 107 L68810 HOSE, -6 A6/A6 96” . . . . . . . . . . . . 608 L69903 HOSE, -4 A6/DS6 17” . . . . . . . . . . . 209 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 110 102831 HOSE, -4 A6/DS6 102” . . . . . . . . . . 211 072806 ADAP., -6JICM -6JICFS RUN TEE . 212 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 1

13 L69904 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 214 102843 HOSE, -4 A6/DS6 35” . . . . . . . . . . . 215 106898 PILOT APPLY MANIFOLD. . . . . . . . 216 L50745 STUD, 1/4”X5-3/4”. . . . . . . . . . . . . . 217 L50051 NUT, 1/4”-20 WHIZ NUT . . . . . . . . . 218 105593 HOSE, -4 A6/DS6 12” . . . . . . . . . . . 219 L51762 ADAP., -6ORM -6JICM B TEE . . . . 1



MT6034T Telescopic Handler HydraulicsTri-Function Control (Option) with Auxiliary Hydraulics Circuit

50960090/AP0914 144 PRINTED IN U.S.A.

Boom Up

Boom Down

Boom Out

Boom In

T

J1

J2

P

JS

E1

E2

E3

E4

J4

J3

UP

INL

DN

Boom Up

Boom In

Boom Out

Boom Down

3

8

4

1

8

1

2

5

6

7

5

9

9

AA

BB

CC

NOTE: Hose reference AA, BB, and CC attach to joysticks and manifolds.Refer to “Hydraulic Controls - Radio Remote” section for more information.

TILT (FORWARD)BOOM (UP)

BOOM (IN)

LEVEL (LEFT)

Hydraulics MT6034T Telescopic HandlerRadio Remote (Option) Circuit

Radio RemoteManifold partsare on page

175.

EXTRET

PRINTED IN U.S.A. 145 50960090/AP0914


01 L68804 HOSE, -4 A6/DS6 26” . . . . . . . . . . . 402 L69905 HOSE, -4 A6/A6 130” . . . . . . . . . . . 203 103505 HOSE, -4 H6/DS6 109” . . . . . . . . . . 104 137784 ADAP., -4ORM -6JICM 90º . . . . . . . 605 129124 ADAP., -4ORM -6JICM STR . . . . . . 5

06 50380273 MANIFOLD, RADIO REMOTE . . . . 107 103425 MOUNT, RADIO REMOTE . . . . . . . 108 L69902 HOSE, -4 A6/H6 20” . . . . . . . . . . . . 409 L68810 HOSE, -4 A6/A6 96” . . . . . . . . . . . . 4

MT6034T Telescopic Handler HydraulicsRadio Remote (Option) Circuit

50960090/AP0914 146 PRINTED IN U.S.A.

P

P

T

T

J

HYDRAULICTANK

FRONT

TILTLEVEL

LIFTEXTEND

FLOW DIVIDER

7

5

6

4

3

5

5

5

3

2

1

8

Hydraulics MT6034T Telescopic HandlerDual Controls - Standard



176-182.

PRINTED IN U.S.A. 147 50960090/AP0914

01 103262 CONTROLLER, TILT/LEVEL. . . . . . 102 103263 CONTROLLER, LIFT/EXTEND . . . . 103 054994 ADAP., -6ORM -6JICM STR . . . . . . 404 072806 ADAP., -6 SWVL RUN TEE . . . . . AR

05 L69903 HOSE, -4 A6/DS6 17”. . . . . . . . . . AR06 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 107 102313 MANIFOLD, JOYSTICK RELIEF. . . 108 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 1


MT6034T Telescopic Handler HydraulicsDual Controls - Standard

50960090/AP0914 148 PRINTED IN U.S.A.

P

P

P

T

T

T

HYDRAULICTANK

TILTLEVEL

LIFTEXTEND

HYDRAULICOPTION

2

1

12

11

13

7

96

53

4

12

10

9

8

7

4

3

8

103

J

FLOW DIVIDER

Hydraulics MT6034T Telescopic HandlerDual Controls with only Auxiliary Hydraulics (Option)



176-182.

PRINTED IN U.S.A. 149 50960090/AP0914

01 103262 CONTROLLER, TILT/LEVEL. . . . . . 102 103263 CONTROLLER, LIFT/EXTEND . . . . 103 054994 ADAP., -6ORM -6JICM STR. . . . . AR04 072806 ADAP., -6 SWIVEL RUN TEE. . . . AR05 091039 ADAP., -6JICM -6JICFS 90º . . . . . AR06 068938 ADAP., -6ORM -6JICM 90º. . . . . . AR07 L69904 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 1

08 L69903 HOSE, -4 A6/DS6 17” . . . . . . . . . . . 109 L69904 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 110 L69903 HOSE, -4 A6/DS6 17” . . . . . . . . . . . 111 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 112 103264 CONTROLLER, AUX. HYD . . . . . . . 113 102313 MANIFOLD, JOYSTICK RELIEF. . . 1


MT6034T Telescopic Handler HydraulicsDual Controls with only Auxiliary Hydraulics (Option)

50960090/AP0914 150 PRINTED IN U.S.A.

P

P

T

HYDRAULICTANK

TILTLEVEL

LIFTEXTEND

1

6

4

35

7

7

8

3

2

J2

J1

T

8

5

12

9

11

10PWP VALVEFLOW DIVIDER

J

p

Hydraulics MT6034T Telescopic HandlerDual Controls with only PWP (Option)


176-182.


PWP valveparts are onpage 170.

PRINTED IN U.S.A. 151 50960090/AP0914

01 103262 CONTROLLER, TILT/LEVEL. . . . . . 102 103263 CONTROLLER, LIFT/EXTEND . . . . 103 054994 ADAP., -6ORM -6JICM STR. . . . . AR04 072806 ADAP., -6 SWIVEL RUN TEE. . . . AR05 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 106 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 107 L69903 HOSE, -4 A6/DS6 17” . . . . . . . . . . . 1

08 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 109 102313 MANIFOLD, JOYSTICK RELIEF. . . 110 102321 MANIFOLD, PWP JOYSTICK . . . . . 111 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 1

(to hydraulic tank)12 L63381 HOSE, -4 A6/DS6 15” . . . . . . . . . . . 1


MT6034T Telescopic Handler HydraulicsDual Controls with only PWP (Option)

50960090/AP0914 152 PRINTED IN U.S.A.

P

P

P

T

T

T

HYDRAULICTANK

TILTLEVEL

LIFTEXTEND

HYDRAULICOPTION

7

96

5

3

12

10 8

7

4

3 11

4

3

16

1

2

9

8

11

13

14

15

17

J2J1

FLOW DIVIDER

PWP VALVE

p

Hydraulics MT6034T Telescopic HandlerDual Controls with PWP and Auxiliary Hydraulics (Option)


176-182.



PRINTED IN U.S.A. 153 50960090/AP0914

01 103262 CONTROLLER, TILT/LEVEL. . . . . . 102 103263 CONTROLLER, LIFT/EXTEND . . . . 103 054994 ADAP., -6ORM -6JICM STR. . . . . AR04 072806 ADAP., -6 SWIVEL RUN TEE. . . . AR05 091039 ADAP., -6JICM -6JICFS 90º . . . . . AR06 068938 ADAP., -6ORM -6JICM 90º. . . . . . AR07 L69904 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 108 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 109 L69904 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 1

10 L69903 HOSE, -4 A6/DS6 17” . . . . . . . . . . . 111 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 112 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 113 102313 MANIFOLD, JOYSTICK RELIEF. . . 114 102321 MANIFOLD, PWP JOYSTICK . . . . . 115 L63381 HOSE, -4 A6/A6 15” . . . . . . . . . . . . 116 103264 CONTROLLER, AUX. HYD . . . . . . . 117 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 1

(to hydraulic tank)


MT6034T Telescopic Handler HydraulicsDual Controls with PWP and Auxiliary Hydraulics (Option)

50960090/AP0914 154 PRINTED IN U.S.A.

P

P

T

TILTLEVEL

LIFTEXTEND

1

4

3 87

8

32

T

J

P

T

T

AA

BB CC

11

8

10

13

12

4

3

9

10

NOTE: Hose reference AA, BB, and CC attach to radio remote manifold.Refer to the “Hydraulic Control Valve - Radio Remote” section for moreinformation.

5

J1 J2

8

6 6HYDRAULIC

TANK MANIFOLD

3

JS

T P

14

Hydraulics MT6034T Telescopic HandlerDual Controls with Radio Remote (Option)


176-182.



PRINTED IN U.S.A. 155 50960090/AP0914

01 103262 CONTROLLER, TILT/LEVEL. . . . . . 102 103263 CONTROLLER, LIFT/EXTEND . . . . 103 054994 ADAP., -6ORM -6JICM STR . . . . . . 804 072806 ADAP., -6 SWIVEL RUN TEE . . . . . 205 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 106 L69905 HOSE, -4 A6/DS6 130” . . . . . . . . . . 207 L69904 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 1

08 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 309 102321 MANIFOLD, PWP JOYSTICK . . . . . 110 068938 ADAP., -6ORM -6JICM 90º . . . . . . . 211 L63381 HOSE, -4 A6/A6 15” . . . . . . . . . . . . 112 103368 HOSE, -6 A6/DS6 52” . . . . . . . . . . . 113 102313 MANIFOLD, JOYSTICK RELIEF. . . 114 103505 HOSE, -4 H6/DS6 109” . . . . . . . . . . 1

MT6034T Telescopic Handler HydraulicsDual Controls with Radio Remote (Option)


50960090/AP0914 156 PRINTED IN U.S.A.

P

P

T

TILTLEVELLIFT

EXTEND

1

4

9

11

8

3

2

T

P

T

T

AABB

12

11

6

10

15

13

4

3

14

6

J

T

P

58

6

8

8

37

8

CCNOTE: Hose reference AA, BB, and CC attach to radio remote mani-fold. Refer to the “Radio Remote” section for more information.

J2J1

HYDRAULICTANK MANIFOLD

3

3

10

11

JS

TP

11

16

Hydraulics MT6034T Telescopic HandlerDual Controls with Radio Remote and Auxiliary Hydraulics (Option)


176-182.

PRINTED IN U.S.A. 157 50960090/AP0914

01 103262 CONTROLLER, TILT/LEVEL. . . . . . 102 103263 CONTROLLER, LIFT/EXTEND . . . . 103 054994 ADAP., -6ORM -6JICM STR . . . . . . 904 072806 ADAP., -6 SWIVEL RUN TEE . . . . . 205 103264 CONTROLLER, AUX. HYD . . . . . . . 106 068938 ADAP., -6ORM -6JICM 90º . . . . . . . 307 091039 ADAP., -6ORM -6JICFS 90º . . . . . . 108 L69904 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 309 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 1

10 L69905 HOSE, -4 A6/A6 130” . . . . . . . . . . . 211 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 312 L63381 HOSE, -4 A6/A6 15” . . . . . . . . . . . . 113 103368 HOSE, -6 A6/DS6 52” . . . . . . . . . . . 114 102321 MANIFOLD, PWP JOYSTICK . . . . . 115 102313 MANIFOLD, JOYSTICK RELIEF. . . 116 103505 HOSE, H6/DS6 109” . . . . . . . . . . . . 1

MT6034T Telescopic Handler HydraulicsDual Controls with Radio Remote and Auxiliary Hydraulics (Option)




50960090/AP0914 158 PRINTED IN U.S.A.

P

T

T

P

2

J2J1

TP

T

J

PILOT APPLY VALVE(REAR OF MACHINE)

T

P

T

P

14

9

6

5

1

3

9

10

4

13

3

10

10 8

4

4

3

3

9

11

7

3

4

15

12

9

9HYDRAULIC TANKRETURN MANIFOLD

Hydraulics MT6034T Telescopic HandlerTri-Function Control (Option) with only PWP


176-182.

PRINTED IN U.S.A. 159 50960090/AP0914

01 L71346 CONTROLLER, TRI-FUNCTION. . . 102 103264 CONTROLLER, FRAME LEVEL . . . 103 054994 ADAP., -6ORM -6JICM STR . . . . . . 804 068938 ADAP., -6ORM -6JICM 90º . . . . . . . 505 054820 ADAP., -6ORM -6JICM RUN TEE . . 106 091039 ADAP., -6JICM -6JICFS 90º . . . . . . 107 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 108 L69903 HOSE, -4 A6/DS6 17” . . . . . . . . . . . 109 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 3

10 102831 HOSE, -4 A6/DS6 102” . . . . . . . . . . 211 L63381 HOSE, -4 A6/DS6 15” . . . . . . . . . . . 112 102313 MANIFOLD, JOYSTICK RELIEF. . . 113 106898 PILOT APPLY MANIFOLD. . . . . . . . 114 102321 MANIFOLD, PWP JOYSTICK . . . . . 115 103368 HOSE, -6 A6/DS6 52”



MT6034T Telescopic Handler HydraulicsTri-Function Control (Option) with only PWP



Pilot Applyvalve parts

are on page 174.

50960090/AP0914 160 PRINTED IN U.S.A.

P

T

T

P

2

J2J1

TP

T

J


T

P

T

P

12

10

16

13

16

15

10

4

10

7

6

5

3

9

9

4

8

1

3

3

3

17

9

3

4

11

9

14

9

HYDRAULIC TANKRETURN MANIFOLD

Hydraulics MT6034T Telescopic HandlerTri-Function Control (Option) with PWP and Auxiliary Hydraulics


176-182.

PRINTED IN U.S.A. 161 50960090/AP0914

01 L71346 CONTROLLER, TRI-FUNCTION. . . 102 103264 CONTROLLER, FRAME LEVEL . . . 103 054994 ADAP., -6ORM -6JICM STR . . . . . . 804 068938 ADAP., -6ORM -6JICM 90º . . . . . . . 505 054820 ADAP., -6ORM -6JICM RUN TEE . . 106 091039 ADAP., -6JICM -6JICFS 90º . . . . . . 107 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 108 L69903 HOSE, -4 A6/DS6 17” . . . . . . . . . . . 109 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 310 102831 HOSE, -4 A6/DS6 102” . . . . . . . . . . 2

11 L63381 HOSE, -4 A6/DS6 15” . . . . . . . . . . . 112 102313 MANIFOLD, JOYSTICK RELIEF. . . 113 106898 PILOT APPLY MANIFOLD. . . . . . . . 114 102321 MANIFOLD, PWP JOYSTICK . . . . . 115 L51762 ADAP., -6ORM -6JICM B TEE . . . . 116 105593 HOSE, -4 A6/DS6 12” . . . . . . . . . . . 217 103368 HOSE, -6 A6/DS6 52” . . . . . . . . . . . 1



MT6034T Telescopic Handler HydraulicsTri-Function Control (Option) with PWP and Auxiliary Hydraulics




are on page 174.

50960090/AP0914 162 PRINTED IN U.S.A.

P

T

T

P

2

AA BB CC

J2J1

P

T

J

NOTE: Hose reference AA, BB, and CC attach to radio remote manifold.Refer to the “Hydraulic Control Valve - Radio Remote” section for moreinformation.

JST P

T

P

PILOT APPLY VALVE(REAR OF MACHINE) T


3

14

4

9

43

11

15

3

312

10

3

10

10

4

9

4

3

8

7

6

59

3

1

17 17

916

T

P

4

13

3

189

Hydraulics MT6034T Telescopic HandlerTri-Function Control (Option) with Radio Remote


176-182.

PRINTED IN U.S.A. 163 50960090/AP0914

01 L71346 CONTROLLER, TRI-FUNCTION. . . 102 103264 CONTROLLER, FRAME LEVEL . . . 103 054994 ADAP., -6ORM -6JICM STR . . . . . . 704 068938 ADAP., -6ORM -6JICM 90º . . . . . . . 405 054820 ADAP., -6ORM -6JICM RUN TEE . . 106 091039 ADAP., -6JICM -6JICFS 90º . . . . . . 107 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 108 L69903 HOSE, -4 A6/DS6 17” . . . . . . . . . . . 109 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 310 102831 HOSE, -4 A6/DS6 102” . . . . . . . . . . 211 L63381 HOSE, -4 A6/DS6 15” . . . . . . . . . . . 1

12 102313 MANIFOLD, JOYSTICK RELIEF. . . 113 106898 PILOT APPLY MANIFOLD. . . . . . . . 214 102321 MANIFOLD, PWP JOYSTICK . . . . . 115 103368 HOSE, -6 A6/DS6 52” . . . . . . . . . . . 116 072806 ADAP., -6JICM -6JICFS R TEE. . . . 117 L69905 HOSE, -4 A6/A6 130” . . . . . . . . . . . 218 103505 HOSE, -4 H6/DS6 109” . . . . . . . . . . 1


MT6034T Telescopic Handler HydraulicsTri-Function Control (Option) with Radio Remote





are on page 174.

50960090/AP0914 164 PRINTED IN U.S.A.

P

T

T

P

2

AA BB CC

J2J1

P

T

J

NOTE: Hose reference AA, BB, and CC attach to radio remote manifold.Refer to the “Radio Remote” section for more information.

JST P

T

P


T

P

T


3

14

4

9

43

11

17

3

312

16

13

15

16

10

3

10

10

4

9

4

3

8

7

6

59

3

1

19 19

918

209

Hydraulics MT6034T Telescopic HandlerTri-Function Control (Option) with Radio Remote and Auxiliary Hydraulics


176-182.

PRINTED IN U.S.A. 165 50960090/AP0914

01 L71346 CONTROLLER, TRI-FUNCTION. . . 102 103264 CONTROLLER, FRAME LEVEL . . . 103 054994 ADAP., -6ORM -6JICM STR . . . . . . 704 068938 ADAP., -6ORM -6JICM 90º . . . . . . . 405 054820 ADAP., -6ORM -6JICM RUN TEE . . 106 091039 ADAP., -6JICM -6JICFS 90º . . . . . . 107 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 108 L69903 HOSE, -4 A6/DS6 17” . . . . . . . . . . . 109 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 310 102831 HOSE, -4 A6/DS6 102” . . . . . . . . . . 211 L63381 HOSE, -4 A6/DS6 15” . . . . . . . . . . . 112 102313 MANIFOLD, JOYSTICK RELIEF. . . 1

13 106898 PILOT APPLY MANIFOLD. . . . . . . . 214 102321 MANIFOLD, PWP JOYSTICK . . . . . 115 L51762 ADAP., -6ORM -6JICM B TEE . . . . 116 105593 HOSE, -4 A6/DS6 12” . . . . . . . . . . . 217 103368 HOSE, -6 A6/DS6 52” . . . . . . . . . . . 118 072806 ADAP., -6JICM -6JICFS R TEE. . . . 119 L69905 HOSE, -4 A6/A6 130” . . . . . . . . . . . 220 103505 HOSE, -4 H6/DS6 109” . . . . . . . . . . 1



MT6034T Telescopic Handler HydraulicsTri-Function Control (Option) with Radio Remote and Auxiliary Hydraulics




are on page 174.

50960090/AP0914 166 PRINTED IN U.S.A.


Hydraulic Components MT6034T Telescopic HandlerHydraulic Pump

01 50380843 HYDRAULIC PUMP, 47CC . . . . . . . 1(Cast Iron Body)

02 L46865 GASKET . . . . . . . . . . . . . . . . . . . . . 1

NOTE: The pump is not a serviceable item;order complete pump.

1

2

PRINTED IN U.S.A. 167 50960090/AP0914


5

6

4

7

3

2

8

01 102313 FLOW DIVIDER . . . . . . . . . . . . . . . .102 103017 PILOTED SPOOL LOGIC ELEM.. . .103 L99927 RELIEF VALVE . . . . . . . . . . . . . . . .1

L99925 SEAL KIT . . . . . . . . . . . . . . . . . . . .104 105087 DEBRIS SCREEN . . . . . . . . . . . . . .105 NSS NUT, SOLENOID VALVE . . . . . . . . .1

(included with item 6)06 L99908 12 VDC WEATHER PACK COIL . . .1

(includes item 5)07 L99910 SOLENOID VALVE . . . . . . . . . . . . .1

L99911 SEAL KIT . . . . . . . . . . . . . . . . . . . .1

08 P471997 TEST PORT . . . . . . . . . . . . . . . . . . .3L62840 CAP, DUST COVER (not shown) . .3

09 NSS MANIFOLD BLOCK . . . . . . . . . . . . .1

-- ITEMS NOT SHOWN --(Mounting Hardware)

-- L50217 1/4”-20X3-1/2” BOLT . . . . . . . . . . . .2-- L50139 1/4” LOCK WASHER . . . . . . . . . . . .2-- 654002 1/4” FLAT WASHER . . . . . . . . . . . .2

NOTE: Items included in seal kits are not shown.

PARKINGBRAKEVALVE

MT6034T Telescopic Handler Hydraulic ComponentsJoystick Relief - Flow Divider

9

1

50960090/AP0914 168 PRINTED IN U.S.A.

2

15

5

20

54

19

1813

17

15 16

5

15

5

7

15

15

10

14

132

1211104

95

4

87

46

54

3

21

Auxiliary HydraulicsWork Section

(Option)

SEAL KITS

LEVEL

TILT

BOOM

LIFT

‘B’ PORT

‘A’ PORT

OUTIN

22

22

Hydraulic Components MT6034T Telescopic HandlerHydraulic Control Valve

1

PRINTED IN U.S.A. 169 50960090/AP0914


01 L68694 HYDRAULIC CONTROL VALVE . . . 1(does not include items 20 and 21)

02 L98891 STUD KIT (3 tie bolts and 3 nuts) . . 103 L500954 INLET COVER. . . . . . . . . . . . . . . . . 104 L500134 HRO ACTUATOR “B” END . . . . . . . 405 L500132 NO RELIEF-NO ANTI-CAV.PLUG . . 4

L500130 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 106 L98895 WORK SECTION 1 (Frame Level) . 1

(includes items 4, 5, 15 & 16)07 L500952 NO RELIEF - ANTI-CAV PLUG. . . . 108 L500953 WORK SECTION 2 (Boom Lift). . . . 1

(includes items 4, 5, 7, 15 & 16)09 L500956 WORK SECTION 3 (Boom Extend) 1

(includes items 4, 5, 7, 15 & 16)10 L98896 RELIEF CARTRIDGE . . . . . . . . . . . 2

L98897 SERVICE KIT (less seals) . . . . . . . . 2L98898 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 2

11 L98899 WORK SECTION 4 (Fork Tilt). . . . . 1(includes items 4, 10, 15 & 16)

12 L500955 OUTLET COVER. . . . . . . . . . . . . . . 113 L500957 PLUG SAE-12 . . . . . . . . . . . . . . . . . 114 L500959 PLUG SAE 12 (socket head). . . . . . 1

15 L500135 HRO ACTUATOR “A” END . . . . . . . 416 L500961 SCREW . . . . . . . . . . . . . . . . . . . . 32

654022 LOCK WASHER . . . . . . . . . . . . . . 3217 L500129 RELIEF CARTRIDGE (RP51-A) . . . 1

L96580 RELIEF SEAL KIT . . . . . . . . . . . . . . 118 L500958 PLUG WITH TEST PLUG . . . . . . . . 119 SEAL KITS FOR WORK SECTIONS

L500127 SECTION SEAL KIT . . . . . . . . . . 1ea(used with items 6-8 & 10)

L98887 SPOOL SEAL KIT . . . . . . . . . . . . 1ea(used with items 4 & 15)

20 L98895 WORK SECTION (Aux. Hyd.) . . . . . 121 L500960 STUD ASSEMBLY KIT (Aux. Hyd.) . 1

(used with item 21)22 L500300 DUST BOOT. . . . . . . . . . . . . . . . . AR

-- ITEMS NOT SHOWN ---- L68778 KIT, VALVE SECTION (AUX.) . . . . . 1

(includes all items shown on facingpage in the “Auxiliary HydraulicsWork Section” window, plus item 21)

MT6034T Telescopic Handler Hydraulic ComponentsHydraulic Control Valve

50960090/AP0914 170 PRINTED IN U.S.A.


04 102321 MANIFOLD, PWP JOYSTICK . . . . . 1(complete assembly)

02 NSS NUT, SOLENOID VALVE. . . . . . . . . 2(included with item 4 and 5)

03 L99908 12 VDC WEATHER PACK COIL . . . 204 L99909 SOLENOID VALVE . . . . . . . . . . . . . 1

L99911 SEAL KIT . . . . . . . . . . . . . . . . . . . . 1(Items included are not shown.)

05 L99910 SOLENOID VALVE . . . . . . . . . . . . . 1L99911 SEAL KIT . . . . . . . . . . . . . . . . . . . . 1

(Items included are not shown)06 NSS MANIFOLD . . . . . . . . . . . . . . . . . . . 1

6

3

45

2

Hydraulic Components MT6034T Telescopic HandlerPWP Valve

1

PRINTED IN U.S.A. 171 50960090/AP0914


01 L69747 STEER SELECT VALVE.. . . . . . . . . 1(Includes items 1-5)

02 210018 WEATHER PAK VALVE. . . . . . . . . . 103 NSS SHCS #10-24 x 1-3/4" . . . . . . . . . . . 4

(included with item #1)

04 107000 SEAL KIT . . . . . . . . . . . . . . . . . . . . 1(consists of the o-rings shown)

05 NSS MANIFOLD . . . . . . . . . . . . . . . . . . . 1

MT6034T Telescopic Handler Hydraulic ComponentsSteer Select Valve

1

4

3

2

5

50960090/AP0914 172 PRINTED IN U.S.A.


01 101882 STEERING CONTROL UNIT . . . . . 1

1

T

R

L

P

LS

2

02 L500968 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1(Items included are not shown.)

NOTE: Field service is limited to seals replacement.

Hydraulic Components MT6034T Telescopic HandlerSteer Motor

PRINTED IN U.S.A. 173 50960090/AP0914

MT6034T Telescopic Handler Hydraulic ComponentsBrake Valve


01 50380743 BRAKE VALVE . . . . . . . . . . . . . . . . 1

NOTE: At the time of publication, the OEM supplierwas unable to provide individual serviceable items.Contact the factory parts department for additionalinformation.

1

50960090/AP0914 174 PRINTED IN U.S.A.

Hydraulic Components MT6034T Telescopic HandlerPilot Apply Manifold - Tri-Function (Option)


01a 106898 PILOT APPLY MANIFOLD. . . . . . . . a(includes all items except item 9)

02 L500745 PRESSURE CONTROL . . . . . . . . . 2L99911 SEAL KIT . . . . . . . . . . . . . . . . . . . . 2

03 244655 CARTRIDGE, 3-WAY/2-POSITION . 2240202 SEAL KIT (for one cartridge) . . . . AR

04 106893 SCHS M5-.08X10MM . . . . . . . . . . . 405 NSS COIL NUT (included with item 7). . . 106 106892 COIL, 12VDC. . . . . . . . . . . . . . . . . . 1

07 L500746 VALVE, 2-WAY . . . . . . . . . . . . . . . . 1(includes item 5)

L99924 SEAL KIT, 2-WAY VALVE . . . . . . . . 108 L99917 PLUG -4 NWD STYLE . . . . . . . . . . 109 211161 WIRE HARNESS, TILT CONTROL . 1

a Units equipped with Auxiliary Hydraulics use(2) 106898 Pilot Apply Manifolds.

B

6

2

T

3

7

8

54

1

9

PRINTED IN U.S.A. 175 50960090/AP0914

MT6034T Telescopic Handler Hydraulic ComponentsRadio Remote Manifold — (Option)


01 50380273 MANIFOLD, RADIO REMOTE . . . . 1(includes all items shown and listed)

02 50220634 2/4 WAY SOLENOID VALVE . . . . . . 150220635 SEAL KIT FOR VALVE . . . . . . . . . . 1

03 104736 12 VDC COIL (WEATHERPAK). . . . 104 50220631 PROPORTIONAL PRESS. VALVE . 4

50220632 SEAL KIT (one per valve) . . . . . . . . 450220633 SCREWS, M4-0.7x12mm . . . . . . . . 8

(not shown)05 NSS MANIFOLD . . . . . . . . . . . . . . . . . . . 1

23

4

1

5

50960090/AP0914 176 PRINTED IN U.S.A.

11

9

7

6

5

4

3

10

8

2

Hydraulic Components MT6034T Telescopic HandlerController - Tilt/Frame Level

1

PRINTED IN U.S.A. 177 50960090/AP0914


01 103262 HYDRAULIC CONTROLLER . . . . . 102 103122 KNOB. . . . . . . . . . . . . . . . . . . . . . . . 103 103112 LEVER ROD (as shown) . . . . . . . . . 104 103113 BOOT. . . . . . . . . . . . . . . . . . . . . . . . 105 102674 LOCK GATE . . . . . . . . . . . . . . . . . . 106 103114 SELECTOR DISC . . . . . . . . . . . . . . 1

07 103115 PIVOT/ BALL JOINT . . . . . . . . . . . . 108 103116 PLATE / BOOT MOUNT . . . . . . . . . 109 103403 METERING CURVE (as shown) . . . 410 103404 RETURN SPRING. . . . . . . . . . . . . . 411a 103117 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1

a Items included in seal kit are not shown.

MT6034T Telescopic Handler Hydraulic ComponentsController - Tilt/Frame Level

50960090/AP0914 178 PRINTED IN U.S.A.

10

8

6

5

4

3

9

7

2

Hydraulic Components MT6034T Telescopic HandlerController - Lift/Extend

1

PRINTED IN U.S.A. 179 50960090/AP0914


01 103263 HYDRAULIC CONTROLLER . . . . . 102 103122 KNOB. . . . . . . . . . . . . . . . . . . . . . . . 103 103112 LEVER ROD (as shown) . . . . . . . . . 104 103113 BOOT. . . . . . . . . . . . . . . . . . . . . . . . 105 103114 SELECTOR DISC . . . . . . . . . . . . . . 106 103115 PIVOT/ BALL JOINT . . . . . . . . . . . . 1

07 103116 PLATE /BOOT MOUNT . . . . . . . . . . 108 103403 METERING CURVE (as shown) . . . 409 103404 RETURN SPRING. . . . . . . . . . . . . . 410a 103117 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1


MT6034T Telescopic Handler Hydraulic ComponentsController - Lift/Extend

50960090/AP0914 180 PRINTED IN U.S.A.

12

11

7

10

8

5

6

4

3

2

4

9

13

Hydraulic Components MT6034T Telescopic HandlerController - Tri-Function (Option)

1

PRINTED IN U.S.A. 181 50960090/AP0914


01 L71346 JOYSTICK 4BUTTN/TRIGGER . . . 102 L500371 HANDLE W/4 BUTTONS . . . . . . . . 103 L62761 WIRE CONNECTOR . . . . . . . . . . . . 804 L500688 NUT M10 UNI . . . . . . . . . . . . . . . . . 205 L500656 RUBBER BOOT . . . . . . . . . . . . . . . 106 L500689 SELECTOR DISC . . . . . . . . . . . . . . 107 L500652 UNIVERSAL JOINT. . . . . . . . . . . . . 1

08 L500692 SPINDLE GUIDE ASSEMBLY. . . . . 409 L500690 HPV SPINDLE 10mm . . . . . . . . . . . 410 L500691 PILOT SPRING PACK C094 . . . . . . 411 NSS BODY ASSEMBLY. . . . . . . . . . . . . . 112a L500653 SEAL REPAIR KIT . . . . . . . . . . . . . 113 104304 BEZEL, JOYSTICK . . . . . . . . . . . . . 1

a Items included in the seal kit are not shown.

MT6034T Telescopic Handler Hydraulic ComponentsController - Tri-Function (Option)

50960090/AP0914 182 PRINTED IN U.S.A.

7

6

5

4

3

2

Hydraulic Components MT6034T Telescopic HandlerController - Auxiliary Hydraulics (Option) (Tri-Function - Level Valve)

1

PRINTED IN U.S.A. 183 50960090/AP0914


01 103264 HYDRAULIC CONTROLLER. . . . . . 102 103077 LEVER ROD (as shown) . . . . . . . . . 103 103084 BOOT (included with item #4) . . . . . 104 103078 CONTROL KIT. . . . . . . . . . . . . . . . . 1

(includes item #3 Boot)

05 103403 METERING CURVE (as shown) . . . 206 103404 RETURN SPRING. . . . . . . . . . . . . . 207a 103083 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1


MT6034T Telescopic Handler Hydraulic Components(Tri-Function - Level Valve) Controller - Auxiliary Hydraulics

50960090/AP0914 184 PRINTED IN U.S.A.

Hydraulic Components MT6034T Telescopic HandlerFrame Level Cylinder

11

10

12

9

5

4

6

78

3

2

CylinderPart Number

Stamped Here

ExternalThreads

13

1

PRINTED IN U.S.A. 185 50960090/AP0914

MT6034T Telescopic Handler Hydraulic ComponentsFrame Level Cylinder


01 L63015 CYLINDER, FRAME LEVEL . . . . . . 102 L98503 ROD (includes #3) . . . . . . . . . . . . . . 103 L63016 BUSHING . . . . . . . . . . . . . . . . . . . . 104 L98547 HEAD GLAND CAP. . . . . . . . . . . . . 105 L99857 5/16”-18x1/4” SET SCREW. . . . . . . 106 L98507 HEAD GLAND . . . . . . . . . . . . . . . . . 107 L98550 PISTON . . . . . . . . . . . . . . . . . . . . . . 1

08 L99405 1-1/4”-12 UNF LOCKNUT . . . . . . . . 109 L64367 BUSHING 2.0X2.25X2.0” . . . . . . . . 110 NSS TUBE WELDMENT . . . . . . . . . . . . . 111 L98509 OIL LINE TUBE ASSEMBLY . . . . . . 112 L70495 COUNTER-BALANCE VALVE. . . . . 2

L97889 SEAL KIT (CBV) . . . . . . . . . . . . . . . 113 L98506 CYLINDER SEAL KIT . . . . . . . . . . . 1

(Items included are not shown.)

50960090/AP0914 186 PRINTED IN U.S.A.

Hydraulic Components MT6034T Telescopic HandlerLift Cylinder

2

10

9

8

4

76

5

3

11

ExternalThreads

CylinderPart Number

Stamped Here

1

PRINTED IN U.S.A. 187 50960090/AP0914

MT6034T Telescopic Handler Hydraulic ComponentsLift Cylinder


01 L63199 CYLINDER, LIFT . . . . . . . . . . . . . . 2

Note: Quantities shown are for one cylinder.02 L98518 ROD WELDMENT . . . . . . . . . . . . . . 103 L98520 HEAD GLAND CAP. . . . . . . . . . . . . 104 L99857 5/16”-18X1/4” SET SCREW . . . . . . 105 L98522 HEAD GLAND . . . . . . . . . . . . . . . . . 106 L98523 PISTON . . . . . . . . . . . . . . . . . . . . . . 1

07 L99405 1-1/4”-12 UNF LOCKNUT . . . . . . . . 108 NSS TUBE WELDMENT . . . . . . . . . . . . . 109 L98519 OIL LINE TUBE ASSEMBLY . . . . . . 1

(includes nuts and ferrules) 10 L64175 COUNTER-BALANCE VALVE. . . . . 1

L97889 SEAL KIT (CBV) . . . . . . . . . . . . . . . 111 L98521 CYLINDER SEAL KIT . . . . . . . . . . . 1


50960090/AP0914 188 PRINTED IN U.S.A.

Hydraulic Components MT6034T Telescopic HandlerSlave Cylinder

109

45

6

7

8

32

11

ExternalThreads

CylinderPart Number

Stamped Here

1

PRINTED IN U.S.A. 189 50960090/AP0914

MT6034T Telescopic Handler Hydraulic ComponentsSlave Cylinder


01 L63014 CYLINDER, SLAVE . . . . . . . . . . . . 102 L98524 ROD WELDMENT (includes #3) . . . 103 L63018 BUSHING . . . . . . . . . . . . . . . . . . . . 104 L99857 5/16”-18X1/4” SET SCREW . . . . . . 105 L98513 HEAD GLAND CAP. . . . . . . . . . . . . 106 L98528 HEAD GLAND . . . . . . . . . . . . . . . . . 1

07 L98516 PISTON . . . . . . . . . . . . . . . . . . . . . . 108 L500668 1-1/8”-12 UN LOCKNUT . . . . . . . . . 109 L68003 BUSHING . . . . . . . . . . . . . . . . . . . . 110 NSS TUBE WELDMENT . . . . . . . . . . . . . 111 L98527 CYLINDER SEAL KIT . . . . . . . . . . . 1


50960090/AP0914 190 PRINTED IN U.S.A.

Hydraulic Components MT6034T Telescopic HandlerTilt Cylinder

9

13

11

10

4

5

6

78

3

2

12

ExternalThreads

CylinderPart Number

Stamped Here

1

PRINTED IN U.S.A. 191 50960090/AP0914

MT6034T Telescopic Handler Hydraulic ComponentsTilt Cylinder


01 L63013 CYLINDER, TILT . . . . . . . . . . . . . . 102 L98545 ROD WELDMENT (includes #3) . . . 103 L63018 BUSHING . . . . . . . . . . . . . . . . . . . . 104 L99857 5/16”-18X1/4” SET SCREW . . . . . . 105 L98547 HEAD GLAND CAP. . . . . . . . . . . . . 106 L99866 HEAD GLAND . . . . . . . . . . . . . . . . . 107 L98550 PISTON . . . . . . . . . . . . . . . . . . . . . . 108 L99405 1-1/4”-12 UN LOCKNUT . . . . . . . . . 1

09 NSS TUBE WELDMENT . . . . . . . . . . . . . 110 L68003 BUSHING . . . . . . . . . . . . . . . . . . . . 111 L70495 COUNTER-BALANCE VALVE. . . . . 1

L97889 SEAL KIT (CBV)12 L98548 CYLINDER SEAL KIT . . . . . . . . . . . 1

(Items included are not shown.)13 L98551 HYDRAULIC LINE ASSEMBLY. . . . 1

50960090/AP0914 192 PRINTED IN U.S.A.

Hydraulic Components MT6034T Telescopic HandlerBoom-Extend Cylinder

2

45

3

6

12

11

10

9

8

7

13

ExternalThreads

CylinderPart Number

Stamped Here

1

PRINTED IN U.S.A. 193 50960090/AP0914

MT6034T Telescopic Handler Hydraulic ComponentsBoom-Extend Cylinder


01 L63012 CYLINDER, BOOM EXTEND . . . . . 102 L98511 ROD WELDMENT (includes #3) . . . 103 L63018 BUSHING . . . . . . . . . . . . . . . . . . . . 104 L99857 5/16”-18X1/4” SET SCREW . . . . . . 105 L98513 HEAD GLAND CAP. . . . . . . . . . . . . 106 L98515 HEAD GLAND . . . . . . . . . . . . . . . . . 107 L98516 PISTON . . . . . . . . . . . . . . . . . . . . . . 108 L500668 1-1/8”-12 UN LOCKNUT . . . . . . . . . 1

09 L68003 BUSHING . . . . . . . . . . . . . . . . . . . . 110 NSS TUBE WELDMENT . . . . . . . . . . . . . 111 L48868A COUNTER-BALANCE VALVE. . . . . 1

L96838 SEAL KIT (CBV)12 L98517 HYDRAULIC LINE ASSY. . . . . . . . . 113 L98558 CYLINDER SEAL KIT . . . . . . . . . . . 1


50960090/AP0914 194 PRINTED IN U.S.A.


01 L68337 CYLINDER, FORK-SHIFT . . . . . . . 102 L500763 ROD WELDMENT . . . . . . . . . . . . . . 103 L500762 HEAD GLAND . . . . . . . . . . . . . . . . . 104 L500761 PISTON . . . . . . . . . . . . . . . . . . . . . . 1

05 L500367 3/4”-16 UNF LOCKNUT. . . . . . . . . . 106 NSS TUBE WELDMENT . . . . . . . . . . . . . 107 L500370 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1


Hydraulic Components MT6034T Telescopic HandlerFork-Shift Cylinder

2

6

54

3

7

1

PRINTED IN U.S.A. 195 50960090/AP0914


01 L63594 CYLINDER, ROTATING . . . . . . . . . 102 L99168 ROD WELDMENT (includes #3) . . . 103 L63593 BUSHING . . . . . . . . . . . . . . . . . . . . 104 121554 HEAD GLAND CAP. . . . . . . . . . . . . 105 L99857 5/16”-18X1/4” SET SCREW . . . . . . 106 121554 HEAD GLAND . . . . . . . . . . . . . . . . . 107 L99174 SPACER, ROD . . . . . . . . . . . . . . . . 108 L99175 SUPPORT WASHER. . . . . . . . . . . . 1

2

13

12

11

5

4

6

7

38

910

09 121552 PISTON . . . . . . . . . . . . . . . . . . . . . . 110 L500367 3/4”-16 UN LOCKNUT. . . . . . . . . . . 111 L64175 COUNTER-BALANCE VALVE. . . . . 2

L97889 SEAL KIT (CBV)12 NSS TUBE WELDMENT . . . . . . . . . . . . . 113 L99170 CYLINDER SEAL KIT . . . . . . . . . . . 1


MT6034T Telescopic Handler Hydraulic ComponentsRotating-Carriage Cylinder

1

50960090/AP0914 196 PRINTED IN U.S.A.

Attachments MT6034T Telescopic HandlerCarriage Forks

5

9

8

3

7

6

4

2

1

72” Long

42” Long

60” Long

48” Long

Forks with 2”Shaft Bore

PRINTED IN U.S.A. 197 50960090/AP0914

MT6034T Telescopic Handler AttachmentsCarriage Forks


01 CFSD * FORK, 42”X4”X2” (8,400 lbs.) . . . . . 202a CFSD * FORK, 48”X2”X2” (4,200 lbs.) . . . . . 403 CFSD * FORK, 48”X4”X2” (8,400 lbs.) . . . . . 204 CFSD * FORK, 48”X4”X2-1/4” (12,000 lbs.) . 205 CFSD * FORK, 48”X5”X1-3/4” (8,500 lbs.) . . 206 CFSD * FORK, 48”X5”X2” (10,500 lbs.) . . . . 2

07 CFSD * FORK, 60”X5”X2” (10,500 lbs.) . . . . 208 CFSD * FORK, 60”X6”X2-1/4” (12,500 lbs.) . 209 CFSD * FORK, 72”X5”X2” (10,500 lbs.) . . . . 2

a Requires 2 sets (4 forks).

NOTE: Ratings are based on two forks with theload at 24” on center, except for item 2, for which four forks are required.

* CFSD - Call Factory Sales Department to order forks.

WARNINGWhen ordering forks, select forks with a rat-ing capacity that meets or exceeds the liftingcapacity of the machine; failure to use thecorrect forks could result in injury or death.For more information contact dealer (or man-ufacturer).

50960090/AP0914 198 PRINTED IN U.S.A.

1

4

5

32

Attachments MT6034T Telescopic HandlerStandard Carriage

PRINTED IN U.S.A. 199 50960090/AP0914


01 CARRIAGE, WELDMENT . . . . . . . . 1L99192 48” CarriageL99193 66” Carriage

02 FORK SHAFT BAR . . . . . . . . . . . . . 1L63319 48” Carriage (50-1/2”)L63320 66” Carriage (68-1/2”)

03 L400425 WASHER, FORK SHAFT . . . . . . . . 204 067847 HLN INST 3/8 CZY . . . . . . . . . . . . . 205 650493 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 2

MT6034T Telescopic Handler AttachmentsStandard Carriage

50960090/AP0914 200 PRINTED IN U.S.A.

32

67

8

910

16

152

11 9 12

1

13

18

20

19

1715

5

4

Attachments MT6034T Telescopic HandlerFork-Shift Carriage

PRINTED IN U.S.A. 201 50960090/AP0914


01 L500215 FORK SHIFT CARRIAGE FRAME . 102 L50519 3/4”-10 NYLON INSERT NUT . . . . . 303 L400425 FORK SHAFT WASHER . . . . . . . . . 104 L50333 3/4”-10X3” BOLT . . . . . . . . . . . . . . 105 L66919 FORK SHAFT, 50” . . . . . . . . . . . . . . 106 L66931 FORK SLIDE PLATE . . . . . . . . . . . . 207 650500 3/4”-10X1-1/2” BOLT . . . . . . . . . . . . 108 FORK SLIDE COUPLER. . . . . . . . . 1

L66921 Used with 4” wide forksL66948 Used with 5” wide forks

09 L63715 TWIN CUSHION TOP PLATE . . . . . 2

10 L50242 5/16”-18X2-1/4” BOLT . . . . . . . . . . . 211 L63716 TWIN HOSE CUSHION. . . . . . . . . . 112 L520004 5/16”-18 NYLON INSERT NUT . . . . 213 L65273 QUICK COUPLER SET. . . . . . . . . . 115 L66918 CYLINDER MOUNT . . . . . . . . . . . . 216 L68337 FORK SHIFT CYLINDER . . . . . . . . 117 L50562 3/4”-10X4” BOLT . . . . . . . . . . . . . . . 218 L63143 ADAP -8ORM -6JICM W/.06 ORF . 219 L66950 HOSE -6 A6/A6 59” . . . . . . . . . . . . . 120 L66949 HOSE -6 A6/A6 56” . . . . . . . . . . . . . 1

MT6034T Telescopic Handler AttachmentsFork-Shift Carriage

50960090/AP0914 202 PRINTED IN U.S.A.

1

5

43

129

1110

87

5

4

32

15

16

17

18

19

20

12

11

10

6

13

13

14

21

Attachments MT6034T Telescopic HandlerRotating Carriage

PRINTED IN U.S.A. 203 50960090/AP0914


01 ROTATE CARRIAGE, FRAME . . . . 1L99225 48” CarriageL99224 66” Carriage

02 FORK SHAFT BAR . . . . . . . . . . . . . 1L63319 48” Carriage (50-1/2” long)L63320 66” Carriage (68-1/2” long)

03 650493 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 204 L400425 RETAINER. . . . . . . . . . . . . . . . . . . . 205 067847 HLN INST 3/8 CZY . . . . . . . . . . . . . 206 L50205 2”-12 CASTELLATED NUT . . . . . . . 1

L61287 WASHER (not shown) . . . . . . . . . . 107 651625 3/8”-16X1-1/4” BOLT” . . . . . . . . . . . 608 654026 3/8” LOCK WASHER. . . . . . . . . . . . 609 L61709 SLIDE PAD 3”X4” . . . . . . . . . . . . . . 310 L65273 QUICK COUPLER SET. . . . . . . . . . 1

(includes both couplers)

11 L63143 ADAP., -8ORM -6JICM STR.. . . . . . 2(with orifice)

12 L63344 HOSE, -6 A8/A6 20” . . . . . . . . . . . . 213 L51968 ADAP., -6ORM -6JICM 90º . . . . . . . 214 067847 HLN INST 3/8 CZY . . . . . . . . . . . . . 115a L63968 BASE END PIVOT PIN . . . . . . . . . . 116 650493 3/8”-16X2-3/4” BOLT . . . . . . . . . . AR17 L63594 ROTATE CYLINDER . . . . . . . . . . . . 118a L63969 ROD END PIVOT PIN . . . . . . . . . . . 1

650650 1/2”-13X3-1/2” BOLT . . . . . . . . . . . 1068034 HLN INST 1/2 CZY . . . . . . . . . . . . . 1

19 NSS ROTATE PIN (welded to #20). . . . . 120 L63952 ROTATE, PLATE (includes #19). . . 121 L64367 BUSHING (not shown) . . . . . . . . . . 1

MT6034T Telescopic Handler AttachmentsRotating Carriage

50960090/AP0914 204 PRINTED IN U.S.A.

17 1623

2221

20

19 18

8’ Truss Boom

15

27

14

11

13

12

910

4

9

5

6

3

7

1

2

24

25

26

5’ Truss Boom

Hydraulic WinchWith Brake

Attachments MT6034T Telescopic HandlerTruss Booms and Bucket

PRINTED IN U.S.A. 205 50960090/AP0914

01 L99237 8’ TRUSS BOOM WELDMENT . . . . 102 104835 5’ TRUSS BOOM WELDMENT . . . . 103 L64294 HOSE -8 A8/A8 53” . . . . . . . . . . . . . 204 114742 ADAP -8ORM -8JICM RUN TEE. . . 105 650706 1/4-20”X2” BOLT . . . . . . . . . . . . . . . 2

L520003 1/4”-20 NYLON INSERT NUT . . . . 206 054626 ADAP -8ORM -8JICM STR . . . . . . . 207 L65273 QUICK COUPLER SET. . . . . . . . . . 109 054816 ADAP -8ORM -8JICM 90º . . . . . . . . 210 L82358 RELIEF VALVE . . . . . . . . . . . . . . . . 111a 100963 HYDRAULIC WINCH. . . . . . . . . . . . 112 650569 1/2”-13X1-3/4” GR 8 BOLT . . . . . . . 613 068034 HLN INST 1/2 CZY . . . . . . . . . . . . . 614 089099 ADAP -10ORM -8JICM . . . . . . . . . . 215 L400398 HOSE -6 A8/A8 18.5” . . . . . . . . . . . 216 650733 5/16”X2-1/2” BOLT . . . . . . . . . . . . . 217 100076 PIN, TRUSS WINCH . . . . . . . . . . . . 118 L520004 5/16”-18 NYLON INSERT NUT . . . . 219 L65338 WINCH SHEAVE . . . . . . . . . . . . . . . 120b L66946 3/8”X60’ WINCH CABLE . . . . . . . . . 1

(Includes hook and swivel)21 650492 3/8”X2-1/2” BOLT . . . . . . . . . . . . . . 2


22 654026 3/8” LOCK WASHER. . . . . . . . . . . . 223 L60451 WINCH BALL. . . . . . . . . . . . . . . . . . 124 L61411 PINTLE HOOK . . . . . . . . . . . . . . . . 125 L50380 1/2”-20X1-1/4” GR 8 BOLT . . . . . . . 426 654030 1/2” LOCK WASHER. . . . . . . . . . . . 427c 088442 ADAP -8JICFS -8JICM 90º . . . . . . . 228 L500373 1.3 CU. YD. BUCKET WELDMNT . 1

L68831 CUTTING EDGE 98” (weld on) . . . . 1

-- ITEMS NOT SHOWN --00 L500222 ADAPTER PLATE. . . . . . . . . . . . . . 1

a Used with 5’ truss booms after attachmentserial number 11182. The winch on 5’ trussbooms before attachment serial number 11183have been discontinued; you must purchase aboom and a winch.

b Used with 5’ truss booms with winch.

c Not used on some attachments.

MT6034T Telescopic Handler AttachmentsTruss Booms and Bucket

28

50960090/AP0914 206 PRINTED IN U.S.A.

Decals MT6034T Telescopic HandlerGeneral Information and Application Instructions

GENERAL INFORMATION

Decal location information is provided to assist inthe proper selection and application of newdecals, in the event original decals become dam-aged or the machine is repainted.

For correct replacement of decals, compare thelocation illustrations to your machine beforestarting to refinish the unit. Check off eachrequired decal using the illustration referencenumber to find the part number, description andquantity in the list. Refer to the appropriate illus-tration for replacement locations.

If there is a decal on a part that is to be replaced,be sure that a new decal is applied to thereplaced part.

NEW DECAL APPLICATIONBefore applying the new decals, surfaces mustbe free from dirt, dust, grease and other foreignmaterial. To apply a solid-formed decal, removethe smaller portion of the decal backing paperand apply this part of the exposed adhesivebacking to the clean surface while maintainingproper position and alignment. Slowly peel offthe other portion of the backing paper whileapplying hand pressure to smooth-out decal sur-face. To apply a die-cut decal, first remove thebacking paper. Then, properly orient and positionthe decal onto the clean mounting surface. Afterthe decal is firmly applied and smoothly presseddown, remove the front covering paper.

PAINT FINISH

Use this list to order paint for refinishing:

808020 One Gallon Red808021 6 (12 oz. Spray Cans) Red808043 One Gallon Gun-Metal Gray808044 6 (12 oz. Spray Cans) Gun-Metal Gray

DECAL KITS

51200699 MT6034T Telescopic Handler w/o PWP

51200700 MT6034T Telescopic Handler w/ PWP

CAUTIONALWAYS follow the safety precautions ondecals. Replace decals if they are damaged,or if the unit is repainted. If repainting, besure that all applicable decals are affixed intheir proper locations.

Boom Attachment Decals

808033 WARNING - PINCH POINT51200486 WARNING - WINCH51200487 WARNING - TRUSS BOOM TILT

PRINTED IN U.S.A. 207 50960090/AP0914

MT6034T Telescopic Handler DecalsFrame and Boom


01 808036 DANGER - HANDS OUT . . . . . . . AR02 808033 WARNING - PINCH POINT . . . . . AR03 51200619 MANISCOPIC . . . . . . . . . . . . . . . . . 104 808057 HYDRAULIC OIL FILL . . . . . . . . . AR05 808035 WARNING - NO RIDERS. . . . . . . AR06 50380379 MANITOU LOGO (SMALL) . . . . . AR

07 808031 DANGER - PERSONAL INJURY . AR(units without PWP)

08 808038 DYNATTACH UNLOCKED . . . . . . AR09 50301416 DIESEL FUEL. . . . . . . . . . . . . . . . AR10 51200618 MT 6034 T . . . . . . . . . . . . . . . . . . AR11 809291 HOT SURFACE . . . . . . . . . . . . . . AR

8

11

2

5

1

3

7

4

2

2

96

10

50960090/AP0914 208 PRINTED IN U.S.A.

Decals MT6034T Telescopic HandlerFrame and Boom

69

8

4

2

1

3


01 808036 DANGER - HANDS OUT . . . . . . . AR02 808033 WARNING - PINCH POINT . . . . . AR03 808034 WARNING - JUMP START. . . . . . AR04 50380379 MANITOU LOGO, SMALL . . . . . . AR05 808046 DYNATTACH DIAGRAM . . . . . . . AR06 806320 MANITOU LOGO, LARGE . . . . . . . 107 808047 ANTI-FREEZE . . . . . . . . . . . . . . . AR08 808048 HALF ZONE MARKER . . . . . . . . . . 509 809561 NO. “0” EXTENSION MARKER . . . 1

808049 NO. “1” EXTENSION MARKER . . . 1808050 NO. “2” EXTENSION MARKER . . . 1808051 NO. “3” EXTENSION MARKER . . . 1808052 NO. “4” EXTENSION MARKER . . . 1808053 NO. “5” EXTENSION MARKER . . . 1

10 808054 COOLANT UNDER PRESSURE. . . 111 808035 WARNING - NO RIDERS. . . . . . . AR12 808055 BRAKE FLUID . . . . . . . . . . . . . . . AR13 808032 OPERATOR MANUAL WARNING. . 114 808031 DANGER - PERSONAL INJURY . AR

(units without PWP)16 50305007 LUBE CHART . . . . . . . . . . . . . . . . . 117 51200618 MT 6034 T . . . . . . . . . . . . . . . . . . . . 1

2

5

2

2

4

11 1613

14

12

1710

7

PRINTED IN U.S.A. 209 50960090/AP0914

MT6034T Telescopic Handler DecalsFrame and Boom

11

2

1

57

3

2

2

95

4

8

6

10


01 808036 DANGER - HANDS OUT . . . . . . . AR02 808033 WARNING - PINCH POINT . . . . . AR03 51200619 MANISCOPIC . . . . . . . . . . . . . . . . . 104 808057 HYDRAULIC OIL FILL. . . . . . . . . . . 105 808035 WARNING - NO RIDERS. . . . . . . AR06 50380379 MANITOU LOGO, SMALL. . . . . . . . 1

07 808037 WARNING - CARRY LOAD. . . . . . . 108 808038 QUICK-ATTACH UNLOCKED . . . . . 109 50301416 DIESEL FUEL . . . . . . . . . . . . . . . . . 110 51200618 MT 6034 T . . . . . . . . . . . . . . . . . . . . 111 809291 HOT SURFACE . . . . . . . . . . . . . . . . 1

50960090/AP0914 210 PRINTED IN U.S.A.

Decals MT6034T Telescopic HandlerCab

DECAL LOCATIONS - OPERATOR STATIONItem Part Description Qty. Item Part Description Qty.No. No. Req. No. No. Req.

01 808027 WARNING - TILT HAZARD . . . . . . . 1/GENERAL OPERATOR

02 808037 WARNING - CARRY LOAD LOW . . 103 808059 F-N-R SHIFT . . . . . . . . . . . . . . . . . . 104 808060 MADE IN U.S.A. . . . . . . . . . . . . . . . 105 808030 WARNING - PARK BRAKE . . . . . . . 1

/SEAT BELT-- LOAD CHARTS--

06 REFER TO OPERATOR'S MANUAL 50960089 FORLOAD CHARTS

07 808061 ATTACHMENT TILT/FRAME LVL . . 108 808062 BOOM CONTROL . . . . . . . . . . . . . . 1

09 808064 AUX. HYD. CONTROL (optional) . . 110 50304691 IGNITION SWITCH . . . . . . . . . . . . . 111 808029 DANGER-HIGH VOLTAGE . . . . . . . 112 51200536 JOYSTICK CONTROL . . . . . . . . . . 113 809307 FRAME LEVEL . . . . . . . . . . . . . . . . 114 808035 WARNING - NO RIDERS. . . . . . . AR

-- OPTIONAL TRI-FUNCTION CONTROLLER --00 51202269 VALVE ADJUSTMENT. . . . . . . . . . . 1

(not shown - attaches to pilot valve)

1

Tri-function Hydraulic Controllers (Option)Dual Hydraulic Controllers (Standard)

12

13

6

97 86

5

11

2

4

14

3

10

PRINTED IN U.S.A. 211 50960090/AP0914

MT6034T Telescopic Handler DecalsPWP Equipped Units

DECAL LOCATIONS - PWP EQUIPPED UNITS

4


01 808039 WARNING - PERSONNEL LIFT. . AR02 808040 WARNING - WORK PLATFORM . AR

/RULES03 808041 PERSONNEL LIFT SAFETY . . . . AR

/RULES

04 809304 PWP LOAD CHART . . . . . . . . . . . AR05 808042 PWP SWITCH . . . . . . . . . . . . . . . AR

51

2

3

1

50960090/AP0914 212 PRINTED IN U.S.A.

054626 101 21054626 103 02054816 127 07054816 129 03054819 77 14054820 141 05054820 143 05054994 103 06054994 135 11055005 69 03055005 135 13055030 69 10055064 69 09055064 135 14055648 55 04062023 69 21064260 31 12065415 41 08067823 77 11067826 63 11067847 07 24067847 09 03068034 51 20068034 53 06068034 119 21068034 203 18068034 205 13068938 141 04068938 143 04070648 43 13071043 65 13071244 55 24071245 55 25071401 67 04071703 65 09072587 137 18072806 141 11072806 143 11072806 147 04076031 127 11076031 137 19076143 127 10076143 135 33076143 137 20076147 133 07076880 129 22079026 101 02079026 103 04079209 49 17081377 71 05081379 51 13087852 53 10087852 67 15088442 101 11088442 103 09088442 135 32088442 205 27089099 205 14089888 43 03090666 119 40

090666 135 22091039 101 07091039 103 12095457 101 05095457 103 14095955 41 02100011 101 10100011 103 10100012 135 25100076 205 1710071 23 12100963 205 11101278 19 05101436 17 22101495 13 24101550 07 30101667 08 05101712 09 04101719 17 19101727 11 13101746 17 32101792 17 20101877 21 06101879 51 01101882 25 10101882 27 01101882 101 22101882 103 01101882 135 03101882 172 01101954 55 26102262 69 24102313 101 01102313 147 07102313 149 13102313 151 09102313 165 12102313 167 01102313 135 10102321 59 02102321 151 10102321 153 14102321 170 04102408 58 02102529 29 21102572 49 —102573 106 03102575 106 07102575 111 08102576 106 08102576 107 08102576 111 09102576 115 24102583 111 21102587 99 07102587 111 20102601 111 37102614 111 04102615 111 06102617 108 01

102618 108 02102619 108 03102620 108 04102621 108 05102622 108 06102623 108 07102624 108 09102625 108 10102626 108 11102627 108 12102628 108 13102632 108 19102633 108 20102634 108 21102635 108 24102636 108 24102637 108 24102647 49 —102668 99 22102674 177 05102680 17 03102681 17 04102692 07 06102705 17 02102711 15 03102712 15 10102722 11 20102727 07 32102728 07 31102741 08 03102769 07 29102778 07 28102780 08 01102780 08 07102781 08 04102831 141 10102831 143 10102840 31 06102840 103 15102842 31 01102842 101 09102843 141 14102843 143 14102863 113 22102863 117 22102874 17 01102880 07 13102881 07 23102886 17 21102893 111 22102901 17 12102907 35 01102907 41 15102925 13 —102928 17 15102944 35 03102945 35 04102948 17 20102949 81 10102950 97 01

102951 97 02102952 97 03102952 97 08102953 97 04102954 97 05102954 97 09102955 97 06102956 97 07102957 97 10102959 97 12103013 13 —103014 17 —103017 167 02103019 11 12103021 07 11103022 07 10103022 11 11103023 07 19103023 11 09103024 07 20103024 11 10103025 15 08103026 15 09103027 15 01103029 11 19103033 35 11103077 183 02103078 183 04103083 183 07103084 183 03103099 21 26103099 21 28103100 21 22103100 21 23103100 21 24103100 21 25103101 49 19103104 21 12103112 177 03103112 179 03103113 177 04103113 179 04103114 177 06103114 179 05103115 177 07103115 179 06103116 177 08103116 179 07103117 177 11103117 179 10103122 177 02103122 179 02103179 13 —103180 13 —103192 09 —-103221 21 29103221 21 30103221 21 31103262 139 03103262 147 01

Part Page ItemNo. No. No.




Numerical Index MT6034T Telescopic HandlerN

UM

ERIC

AL

IND

EX

PRINTED IN U.S.A. 213 50960090/AP0914

103262 149 01103262 151 01103262 153 01103262 155 01103262 157 01103262 177 01103263 139 02103263 147 02103263 149 02103263 151 02103263 153 02103263 155 02103263 157 02103263 179 01103264 33 07103264 139 01103264 141 02103264 143 02103264 149 12103264 153 16103264 157 05103264 159 02103264 161 02103264 163 02103264 165 02103264 183 01103315 51 26103315 141 09103315 143 09103315 147 06103317 101 03103317 135 17103318 51 27103318 135 15103318 141 12103318 143 12103318 147 08103318 149 11103318 151 05103318 165 09103319 27 07103319 101 12103330 119 42103330 123 05103330 129 14103330 133 14103331 119 43103331 123 06103331 129 13103331 133 13103333 119 37103368 51 29103368 135 19103390 108 16103391 108 17103392 108 18103393 111 07103394 111 03103395 111 16103396 111 28

103398 111 25103399 111 47103401 111 49103401 115 50103402 113 11103403 177 09103403 179 08103403 183 05103404 177 10103404 179 09103404 183 06103425 145 07103475 61 08103476 61 09103505 145 03103505 155 14103505 157 16103505 163 18103505 165 20103582 33 04103675 07 11103708 33 11103873 47 11103991 51 11104064 59 —104078 59 03104111 31 08104111 101 15104111 103 17104214 33 06104219 33 08104222 45 11104222 47 13104304 33 02104304 181 13104504 111 48104504 115 39104518 106 04104546 115 44104600 111 44104600 115 34104604 111 36104604 115 28104607 108 26104621 108 25104641 111 45104641 115 35104642 111 46104642 115 36104655 108 22104655 109 11104688 07 —104736 175 03104769 21 27104835 205 02104846 11 15104932 71 03104950 09 —104951 09 —104952 09 05

105087 167 04105236 25 07105266 113 10105266 113 14105266 117 10105266 117 14105287 29 05105580 33 —105580 141 —105580 143 —105593 143 18105593 161 16105593 165 16105636 07 07105857 99 04105910 63 18105958 111 18105958 115 22105960 21 15106001 21 11106175 81 26106259 97 11106892 174 06106893 174 04106898 141 15106898 143 15107000 171 04110227 53 08110227 67 30114742 205 04121387 129 24121387 137 22121552 195 09121554 195 04121554 195 06122778 51 31126862 131 05129124 145 05131529 51 21131529 53 15131951 75 01132023 05 01132023 63 03133074 69 23133444 63 04135425 63 09135425 77 09136305 35 07136305 37 12136310 35 13137503 35 16137503 37 05137602 19 19137603 19 20137784 27 02137784 135 02137784 145 04138459 41 03138459 41 09138623 37 07

138649 39 11138651 39 14138714 39 10138777 39 02138778 39 03138779 39 07139170 13 16139279 37 13139952 65 07184605 73 01186193 41 12186703 41 14187841 35 05188973 77 04189033 37 14189049 37 11191192 55 09191352 55 03193856 55 12195740 55 13201179 37 18210018 171 02210148 69 06210170 23 01210-19469 31 04210-19469 55 06210-19470 07 25210-19470 07 36210328 29 15210329 69 16210403 23 23210404 23 25210405 23 24210447 57 10210569 57 12210569 99 11210572 57 13210572 99 14210608 29 20210609 29 25210614 21 09210722 53 02210765 43 12210796 37 01210796 39 17210796 41 01210797 21 07210828 31 03210828 101 19210828 103 19210833 43 14211010 39 04211023 37 17211035 43 06211039 43 02211045 43 08211052 43 01211145 37 02211146 05 09211146 37 03





MT6034T Telescopic Handler Numerical IndexN

UM

ERIC

AL

IND

EX

50960090/AP0914 214 PRINTED IN U.S.A.

211147 37 01211148 37 06211149 37 04211161 174 09219274 07 34230209 41 17230-32195 31 02230-32195 101 14230-32195 103 20230-32364 31 05240202 174 03241010 65 10241385 65 08242145 37 08242875 37 09243008 41 16243063 13 25243319 55 23244655 174 03271491 05 13271491 65 16271601 63 08271601 77 06271869 23 15272299 73 05272546 41 04272578 19 15272648 21 03273968 35 06420-19671 58 06420-19671 69 15420-35602 43 09420-36290 37 1050220227 71 0450220264 104 0250220264 105 0250220265 104 0150220265 105 0150220266 104 0350220266 105 0350220267 104 0250220267 105 0250220500 75 1650220501 75 1650220511 05 1250220511 63 1350220515 63 0650220553 63 0550220574 75 0750220575 75 0850220612 05 0350220613 05 0450220626 61 0750220627 61 0650220628 61 0550220629 61 0250220630 61 0350220631 175 0450220632 175 0450220633 175 04

50220634 175 0250220635 175 0250220719 73 1050220757 21 1450220759 71 0250220761 71 0750220762 78 0150280186 19 1650280187 19 1750288223 67 1750290081 23 1550300066 35 0750300066 37 1250300327 67 2650300449 53 0950300449 67 1450300462 53 1350300462 67 2550300466 63 1650301039 63 0750301134 55 0150301159 65 0450301357 55 1050301416 207 0950301416 209 0950301444 69 0850301444 77 0550302119 07 3750302155 131 1150302155 133 2250302155 137 2150302155 137 2350302200 75 1050302203 67 1350302216 65 0350302228 77 0350302437 67 1150302438 67 2350302441 05 0550302441 67 1250302457 69 0250302496 41 0750302785 63 2050303155 41 0650303791 67 0850303793 67 0950303794 67 0750303801 67 0650303802 67 0550303845 67 2850303847 05 0250304028 21 —50304225 73 0250304231 73 0450304281 21 —50304354 55 2850304691 210 1050304708 19 1850304736 49 1050304759 47 07

50304788 47 0650304791 47 0550304797 47 1450304798 47 1550304811 49 1550304812 49 1450304821 47 0850304852 77 1350304898 27 1050304898 27 1150304898 103 0750304898 103 0850304907 47 0150304911 67 0350304956 63 2150304958 53 1450304958 67 2250304962 67 1650304965 67 3250304972 53 1150304972 67 3150305007 208 1650305017 77 0150305161 19 0250305208 39 0850305209 39 0550305570 41 1350305578 39 1650305581 65 0150305598 39 0950305606 61 1650305607 43 1550305621 39 —50305830 41 0550306490 41 2050351477 73 0950351523 67 0250352428 39 0650352428 65 1750352454 05 0650352454 73 1250352455 05 0750352455 73 1350380273 145 0650380273 175 0150380274 61 0150380306 19 0150380379 207 0650380379 208 0450380379 209 0650380450 51 0250380516 51 1850380576 13 0250380577 13 0150380583 13 0450380587 63 0150380592 63 1250380594 69 2050380595 69 0150380595 71 01

50380682 13 0250380734 07 0150380737 07 2750380743 29 0650380743 31 1050380743 101 1750380743 103 2150380743 173 0150380745 99 2250380746 99 2250380751 21 0450380753 21 0250380754 31 1150380756 131 0650380756 137 0650380756 137 1350380757 129 2550380757 129 2650380757 133 2350380757 133 2450380757 137 0750380757 137 0950380757 137 1050380757 137 1150380779 25 0850380789 59 0150380789 61 1350380825 61 1450380826 61 1050380836 61 1550380841 29 1350380843 135 3050380843 166 0150380847 35 1050380852 23 1350380853 23 1450380894 29 1050380901 77 0750381061 53 0150381079 135 0650381095 31 0950381095 101 1650381095 103 1650381115 29 0150381150 75 1550381156 51 3250381160 69 1150381161 69 1850381167 55 2950381171 63 1750381174 75 0650381198 75 1350381201 77 2450381202 77 1950381217 49 1350381223 67 1950381224 69 1750381224 73 0350381229 45 0250381236 45 01






UM

ERIC

AL

IND

EX

PRINTED IN U.S.A. 215 50960090/AP0914





50381241 47 1250381259 69 2251200486 206 0051200487 206 0051200536 210 1251200618 207 1051200618 208 1751200618 209 1051200619 207 0351200619 209 0351200699 206 0051200700 206 0051202269 210 00570019 29 23570019 131 16650315 43 16650347 55 08650387 45 13650387 53 05650426 61 12650448 133 10650450 39 12650484 45 06650484 58 06650484 69 14650484 121 03650485 29 03650486 07 26650486 31 13650486 45 09650486 47 02650486 49 01650486 69 13650487 57 08650487 69 25650488 51 14650488 119 25650488 121 19650488 123 07650488 135 21650489 49 08650489 51 04650489 67 27650490 119 26650490 121 15650491 08 06650491 119 30650492 205 21650493 121 12650493 125 03650493 127 04650493 129 05650495 135 29650500 201 07650512 41 11650512 43 18650533 23 21650533 119 32650533 121 22650542 55 11

650542 67 01650545 29 24650549 119 07650550 59 03650569 51 19650569 53 07650569 205 12650579 65 05650584 67 20650588 17 17650630 23 03650648 45 12650650 203 18650706 31 14650706 59 02650706 205 05650730 17 11650731 57 03650733 205 16650784 131 07650784 133 04650833 137 25650835 59 01650835 61 13650863 11 —650863 55 07650936 09 —650965 77 23651089 27 05651148 135 28651151 08 02651195 67 21651269 55 14651271 119 07651395 65 12651457 47 10651517 65 15651543 99 15651625 25 09651625 121 07651625 123 28651625 203 07651635 17 21651636 17 21651638 17 05651639 11 02651639 15 07651640 07 04651640 07 35651640 11 03651640 23 16651640 43 11651640 45 05651641 11 06651641 15 06651641 17 06651643 17 10651668 55 02651695 41 22651695 63 15

651695 75 12651698 67 10651699 75 14651702 65 02651705 55 19651706 41 23651706 65 14651706 73 07651706 75 09651707 29 11651707 67 24651720 73 06651732 41 24651759 55 18651796 65 19653002 09 —653010 29 12653098 55 15654002 11 —654002 133 11654004 23 08654004 119 04654006 09 02654006 119 39654009 29 19654014 57 15654022 169 16654024 133 03654026 119 22654026 119 27654028 17 22654030 119 09654030 205 26654046 17 22654049 49 09654049 65 06655001 119 10655001 123 16655006 29 17656007 77 02656009 29 07656049 29 14656103 65 11656133 65 18806320 208 06808020 206 00808021 206 00808027 210 01808029 210 11808030 210 05808031 207 07808031 208 14808032 208 13808033 206 00808033 207 02808033 208 02808033 209 02808034 208 03808035 207 05808035 208 11

808035 209 05808035 210 14808036 207 01808036 208 01808036 209 01808037 209 07808037 210 02808038 207 08808038 209 08808039 211 01808040 211 02808041 211 03808042 211 05808043 206 00808044 206 00808046 208 05808047 208 07808048 208 08808049 208 09808050 208 09808051 208 09808052 208 09808053 208 09808054 208 10808055 208 12808057 207 04808057 209 04808059 210 03808060 210 04808061 210 07808062 210 08808064 210 09809291 207 11809291 209 11809304 211 04809307 210 13809558 99 01809561 208 09809610 99 01L10057 127 01L277944 51 06L400398 205 15L400425 199 03L400425 201 03L400425 203 04L400929 197 05L40805 71 09L41261 25 02L41854 53 04L441010 51 24L445014 135 26L44859 29 16L46865 135 27L46865 166 02L47263 197 06L47265 197 07L48868A 193 11L49327 05 11L49327 51 22L500001 13 15


UM

ERIC

AL

IND

EX

50960090/AP0914 216 PRINTED IN U.S.A.





L500004 13 17L500019 11 16L500020 07 16L500021 07 17L500021 11 05L500021 15 04L500021 17 08L500022 07 15L500022 17 21L500024 11 08L500025 11 14L500027 11 18L500028 11 17L500036 17 16L500038 11 01L500038 15 02L500038 17 09L500042 11 04L500042 15 05L500042 17 07L500057 07 12L500099 13 23L500111 11 07L500127 169 19L500129 169 17L500130 169 05L500132 169 05L500134 169 04L500135 169 15L500163 35 08L500215 201 01L500222 205 00L500225 55 05L500273 93 03L500273 95 03L500274 88 01L500294 83 08L500300 169 22L500367 194 05L500367 195 10L500370 194 07L500371 181 02L500373 205 28L500407 85 07L500407 93 23L500408 85 08L500408 93 22L500408 93 24L500409 85 16L500410 93 01L500411 93 02L500412 93 04L500413 93 19L500414 93 20L500451 106 02L500451 107 02L500452 107 03L500453 107 04L500454 106 05L500454 107 05





UM

ERIC

AL

IND

EX

PRINTED IN U.S.A. 217 50960090/AP0914





L500959 169 14L500960 169 21L500961 169 16L500968 172 02L50101 25 06L50139 07 22L50139 59 02L50139 135 08L50139 167 —L50196 23 04L50201 99 09L50202 07 07L50202 07 21L50202 07 34L50202 11 —L50202 17 21L50202 29 04L50202 33 03L50202 35 12L50202 37 16L50205 203 06L50206 41 21L50207 121 04L50217 135 09L50217 167 —L50226 119 14L50242 201 10L50253 99 02L50333 49 16L50333 201 04L50380 119 08L50380 205 25L50417 07 03L50442 49 12L50462 119 21L50468 77 18L50491 21 05L50517 23 05L50519 201 02L50538 21 08L50562 201 17L50628 29 22L50646 125 12L50655 59 03L50704 77 08L50712 57 14L50712 99 10L50741 141 16L50745 143 16L50823 23 11L50877 123 23L50877 129 11L50877 129 17L50877 133 17L50979 17 22L51035 119 45L51035 123 30L51035 129 16L51035 133 16L51143 58 06

L51762 143 19L51762 161 15L51762 165 15L51968 203 13L520003 17 21L520003 27 05L520003 51 12L520003 205 05L520004 121 05L520004 123 26L520004 129 08L520004 131 10L520004 133 20L520004 137 26L520004 201 12L520004 205 18L52022 33 10L52024 07 18L52024 33 09L52048 119 05L530004 45 04L530004 47 04L530004 49 03L54002 07 —L561004 29 18L570017 135 23L60253 57 17L60253 137 17L60451 205 23L60587 49 18L60961 197 08L61001 197 02L61017 197 03L61287 203 06L61411 205 24L61620 51 23L61699 121 26L61699 123 04L61708 119 23L61708 121 27L61709 119 28L61709 121 21L61709 123 09L61709 203 09L61867 53 03L62715 119 24L62715 121 16L62715 123 11L62731 121 28L62732 121 29L62733 119 29L62733 121 18L62734 121 17L62734 123 10L62761 141 —L62761 181 03L62840 167 08L630004 55 27L63005 123 02L63006 121 02


L63381 165 11L63383 27 12L63387 27 13L63387 101 20L63387 103 03L63402 27 03L63402 135 01L63406 51 07L63406 137 16L63407 127 08L63407 127 09L63407 127 12L63407 127 13L63407 129 20L63407 137 04L63407 137 05L63407 137 12L63407 137 14L63407 137 15L63545 35 02L63545 37 15L63593 195 03L63594 195 01L63594 203 17L63634 07 08L63694 119 22L63694 131 15L63715 57 09L63715 123 25L63715 129 09L63715 129 19L63715 133 05L63715 133 19L63715 201 09L63716 123 24L63716 129 10L63716 133 06L63716 201 11L63756 51 10L63813 07 33L63813 08 —L63876 09 —-L63876 25 11L63887 07 09L63894 21 10L63952 203 20L63957 125 15L63968 203 15L63969 203 18L64143 119 31L64175 187 10L64175 195 11L64197 63 10L64197 77 10L64275 139 09L64294 205 03L64367 57 02L64367 185 09L64367 203 21L64524 27 16


UM

ERIC

AL

IND

EX

50960090/AP0914 218 PRINTED IN U.S.A.

L64524 135 04L64673 45 14L64764 75 02L65097 125 13L65098 125 14L65142 51 16L65144 51 17L65273 133 09L65273 201 13L65273 203 10L65273 205 07L65338 205 19L65638 119 06L65640 119 03L66011 07 03L66139 101 04L66139 103 11L66406 197 04L66456 125 09L66563 135 12L66613 125 —L66780 123 14L66782 123 13L66783 123 12L66918 201 15L66919 201 05L66921 201 08L66931 201 06L66946 205 20L66948 201 08L66949 201 20L66950 201 19L66965 77 12L67455 69 04L67455 77 16L67455 135 20L67455 137 02L68003 119 16L68003 123 22L68003 125 05L68003 127 02L68003 189 09L68003 191 10L68003 193 09L68006 119 15L68039 129 18L68039 133 18L68331 197 09L68337 194 01L68337 201 16L68348 131 09L68350 119 01L68351 129 28L68351 133 21L68358 131 08L68374 129 01L68374 129 02L68376 133 01L68376 133 02L68496 23 22

L68694 137 24L68694 139 08L68694 169 01L68695 121 14L68696 121 24L68697 121 08L68744 121 01L68762 123 01L68772 25 04L68778 169 —L68794 57 06L68804 145 01L68805 27 15L68805 51 28L68808 27 14L68808 135 05L68809 57 07L68809 137 01L68809 137 03L68810 139 06L68810 139 07L68811 139 05L68817 129 21L68817 137 08L68831 205 28L68849 99 22L68866 45 03L69264 63 14L69297 07 02L69402 07 08L69595 25 03L69596 25 01L69734 99 12L69734 115 37L69747 27 05L69747 101 13L69747 103 05L69747 171 01L69756 33 12L69902 145 08L69903 141 08L69903 143 08L69904 141 13L69904 143 13L69905 145 02L69905 157 10L69928 101 06L69928 101 08L69928 103 13L70039 09 01L70040 119 38L70045 45 07L70069 17 21L70069 17 —L70075 21 20L70075 21 21L70146 55 16L70200 49 07L70201 23 07L70212 23 06

L70241 09 —L70242 119 02L70428 31 07L70428 101 18L70428 103 18L70462 119 00L70468 73 08L70495 185 12L70495 191 11L70634 23 02L70701 49 04L71074 19 06L71075 19 03 L71076 19 11L71076 19 12L71077 19 09L71082 19 07L71083 19 10L71084 19 08L71086 19 04L71088 19 14L71305 07 —L71346 33 01L71346 141 01L71346 143 01L71346 159 01L71346 161 01L71346 163 01L71346 165 01L71346 181 01L71350 197 01L71595 49 05L71691 19 13L71691 59 —L71725 58 04L71726 58 03L71729 58 01L71732 58 06L71748 119 36L71748 123 03L71748 129 15L71748 133 15L71750 58 05L71751 59 05L71752 59 04L75990 69 19L82358 205 10L94824 81 02L96053 88 05L96580 169 17L96838 193 11L97489 05 10L97489 51 03L97525 83 10L97526 83 11L97889 185 12L97889 187 10L97889 191 11L97889 195 11L98176 81 09







UM

ERIC

AL

IND

EX

PRINTED IN U.S.A. 219 50960090/AP0914





MT6034T Telescopic Handler Numerical Index



NU

MER

ICA

LIN

DEX

L98895 169 20L98896 169 10L98897 169 10L98898 169 10L98899 169 11L98926 81 07L98927 81 06L98932 81 12L98935 81 11L98938 79 14L98942 86 06L98943 86 04L98944 86 03L98945 86 01L98947 86 02L98948 87 11L98949 87 07L98950 87 04L98951 87 05L98953 87 03L98954 87 —L98955 85 15L98956 96 14L98957 96 15L98958 96 10L98961 91 11L98961 93 16L98961 95 11L98962 91 21L98967 95 12L98968 85 09L98968 95 25L99013 81 04L99018 81 19L99020 87 15L99023 87 14L99025 87 13L99027 87 16L99029 79 11L99029 79 13L99029 81 21L99029 87 17L99030 78 05L99031 89 06L99032 89 07L99038 95 05L99045 81 20L99163 51 09L99168 195 02L99170 195 13L99174 195 07L99175 195 08L99182 77 17L99184 05 08L99184 77 15L99184 87 02L99192 199 01L99193 199 01L99224 203 01

L99225 203 01L99237 205 01L99246 79 04L99246 81 16L99246 81 24L99249 79 15L99251 81 03L99253 81 05L99260 79 09L99260 79 12L99261 79 10L99262 79 07L99262 81 25L99274 81 23L99278 91 05L99279 93 08L99284 79 03L99284 79 06L99284 81 18L99285 79 08L99285 81 32L99286 79 01L99287 81 29L99288 81 31L99294 81 33L99295 81 34L99296 81 35L99312 81 30L99405 185 08L99405 187 07L99405 191 08L99425 25 05L99696 93 21L99785 78 04L99857 185 05L99857 187 04L99857 189 04L99857 191 04L99857 193 04L99857 195 05L99866 191 06L99908 167 06L99908 170 03L99909 170 04L99910 167 07L99910 170 05L99911 167 07L99911 170 04L99911 170 05L99911 174 02L99917 174 08L99924 174 07L99925 167 03L99927 167 03L99951 99 03P471997 167 08

50960090/AP0914 220 PRINTED IN U.S.A.

AA/C Dryer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39Adapter Plate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .205Adhesive Kit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15Air Cleaner Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .73Alternator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .63Alternator Cable . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .55Axle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .99, 111, 115

BBackup Alarm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .49Bellows, Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23Belt Tensioner . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .65Belt, A/C Compressor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .05, 65Belt, Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .05, 63Bevel Gear Set . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .113, 117Bleed Screw . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .108, 109Blower Motor, Hvac . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .35Boom Chain . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .123Boom Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .210Boom Extend Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .131, 193Boom, Outer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .119Bottle, Dual -Pump Washer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13Brake Cylinder Single Tandem . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .29, 31, 101, 103Brake Disc . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .108, 109Brake Disc . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .109Brake Lever Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .29Brake Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .173Breather, Air . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .81Bucket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .205Bumper, Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17Button, Radio E-Stop . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .61

CCab Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .07, 17Cable, Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .55Cam Lock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23Can, Terminate Receptacle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21Cap, Oil Fill . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .63Cap, Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .53Cap, Hydraulic . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .51Cap, Radiator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .71Cap, Steering Wheel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25Cap, Washer Bottle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13Carriage, Standard Fork . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .199Chain, Boom Leaf . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .123Charge Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .87

PAGE

Subject Index MT6034T Telescopic HandlerSU

BJE

CT

IND

EX

PRINTED IN U.S.A. 221 50960090/AP0914

MT6034T Telescopic Handler Subject Index

PAGECold Control Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37Column, Steering . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25Compressor, A/C . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39, 43, 65Connector, 12v Power Port . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19Control, Temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .35Controller, Auxiliary Hydraulics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .139, 149, 153, 157, 183Controller, Frame Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .141, 143, 159, 161, 163, 165Controller, Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .33Controller, Lift/Extend . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .139, 147, 149, 151, 153, 157Controller, Tilt/Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .139, 147, 149, 151, 153, 155, 157Controller, Tri-Function . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .141, 143, 159, 161, 163, 165Cooler Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .69Cooler Section, Transmission . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .71Cooler, Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .67Coupler, Exhaust Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .75Cover Wiper Motor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13Cover, 12v Power Port . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19Cover, A/C Hoses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .43Cover, Access . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45Cover, Condenser Housing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .43Cover, Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .47Cover, Frame Front . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45Cover, Fuse Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .07, 21Cover, Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .47, 49Cover, Relay Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21Cover, Throttle Pedal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .29Cutting Edge, Bucket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .205Cylinder, Boom Extend . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .131, 193Cylinder, Fork-Shift . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .194, 201Cylinder, Frame Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .185Cylinder, Lift . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .127, 187Cylinder, Rotating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .195, 203Cylinder, Slave . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .129, 189Cylinder, Tilt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .129, 191

DDecals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .206Differential Carrier . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .113, 117Diodes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21, 49, 61Dipstick, Engine Oil Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .63Display, Can & Instruments . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19Door, Engine Access . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .47Door Tool Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23Driveshaft . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77Dust Boot . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .169Dust Evacuator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .73Dynattach Weldment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .125

SUB

JECT IN

DEX

50960090/AP0914 222 PRINTED IN U.S.A.

PAGE

Subject Index MT6034T Telescopic Handler

EEngine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .63Evaporator, Heater Coil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37Expansion Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37

FFan Assembly, Hvac . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37Fan Shroud . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .69, 73Fan, Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .63Fender . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .99Fender Mount . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .99Filter, Air . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .05, 73Filter, Cab Air . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37Filter, Engine Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .05, 63Filter, Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .05, 67Filter, Hydraulic Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .05, 51Filter, Recirculating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .05, 37Filter, Transmission . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .05, 77, 87Filter, Water Separator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .05, 67Flow Divider . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .135, 167Fork Shaft Bar . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .199, 203Fork, Attachment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .197Fork-Shift Carriage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .201Fork-Shift Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .201Frame Level Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .57Frame Level Mount . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .57, 99Fuel Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .67Fuel Tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .53Fuse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21, 55Fuse Holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .55

GGlass, Front . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11Glass, Left Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15Glass, Lower Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17Glass, Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .07, 11Glass, Right Hand . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .07Glass, Top . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15Glass, Upper Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17Grill, Defroster . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .35Grill, Vent . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37Ground Strap . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .55Guard, Exhaust Doc . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .49

HHandle, Hood . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45Head Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .09

SUB

JEC

T IN

DEX

PRINTED IN U.S.A. 223 50960090/AP0914


PAGEHeater Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .35Heater Core . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .35Heater Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .41Heater, Hydraulic Tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .51Heater, Oil Pan . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .63Hood, Front . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45Hood, Main . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .47Hood, Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .49Horn W/Ground . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45Hose Assembly, Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .67Hose Tray, Inner Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .123Hose, A/C . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39Hose, Heater . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .41, 69Hose, Overflow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37, 69Hose, Radiator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .69HVAC Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37, 39, 41Hydraulic Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .139, 169, 177, 179, 183Hydraulic Filter Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .51Hydraulic Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .135, 166Hydraulic Tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .51Hydraulic Winch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .205

IInclinometer-Angle Indicator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .119Indicator, Frame Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .07Indicator, Service . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .73Inner Boom Weldment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .123Instrument Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .35

KKey . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17, 19, 23Kit, Valve Section (Auxiliary . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .169

LLanyard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .61Level Sensor, Pwp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .59, 61Lift Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .127, 187Light, Backup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .49Light, Tail . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .49Lube Chart . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .209

MMagnetic Plug . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .106, 111, 115Manifold, Brake Line . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .31, 101, 103Manifold, Flow Divider . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .101Manifold, Joystick Relief . . . . . . . . . . . . . . . . . . . . . .147, 149, 151, 153, 155, 157, 159, 161, 163, 165

SUB

JECT IN

DEX

50960090/AP0914 224 PRINTED IN U.S.A.

PAGE


Manifold, Pilot Apply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .141, 143, 159, 161, 163, 165, 174 Manifold, Pwp Joystick . . . . . . . . . . . . . . . . . . . . . . . .59, 151, 153, 155, 157, 159 161, 163, 165, 170Manifold, Radio Remote . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .145, 147Mirror . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .07, 51Module, A/C Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37Module, Brake Warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21Module, F-N-R Shifter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21Module, Pwp Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .59Motor, Steer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25Mount, A/C Compressor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .65Mount, Brake Switches . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .31Mount, Condenser Coil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .43Mount, Doc . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .75Mount, Dryer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39Mount, Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .63Mount, Engine Cushion . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .63Mount, Fuel Cooler . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .67Mount, Hood . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .47Mount, Radio Remote . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .145Mount, Seat Belt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23Mount, Transmission . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77

OOuter Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .119

PPad, Arm Rest . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .33Pad, Brake Pedal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .29Paint . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .206Panel, Dash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .07, 19 Panel, Hvac Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37Pilot Apply Manifold . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .141, 143, 159, 161, 163, 165, 174 Pintle Hook . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .205Poppet, Safety Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .81Pressure Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .174Pressure Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .31Proportional Pressure Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .175Pulley, A/C . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .65Pump, T12000 Charge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .87

QQuick Coupler Set . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .133

RRadiator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .71Radio Remote, System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .61SU

BJE

CT

IND

EX

PRINTED IN U.S.A. 225 50960090/AP0914


PAGE

Receiver, Radio Remote . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .61Rectifier Pack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37Relay . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21, 37, 43Remote Stop Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .58Remote Transmitter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .61Resistor Block . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .35Rotate Carriage, Frame . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .203Rotate Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .203

SSeat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23Seat Belt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23Seat Riser . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23Sender, Fuel Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .53Sender, Temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77Sensor, Coolant Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .69Sensor, Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .63, 67Shifter, Fnr . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25Shock, Suspension Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23Sight Glass . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .71Skid Plate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .07Starter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .63Steer Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .104, 105Steer Motor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27, 101, 103, 135, 172Steer Select Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .171Steering Wheel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25Strainer, Hydraulic Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .51Strainer, Oil Suction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .05Striker . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17Strobe Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .09Switch, Binary . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39Switch, Clutch Cut-Out . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19Switch, Engine Fault . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19Switch, Hazard Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19Switch, Ignition . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19Switch, Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19Switch, Park Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19Switch, Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .101, 103Switch, PWP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .59Switch, Steer Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19Switch, Strobe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19Switch, Toggle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .61Switch, Turn Signals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19Switch, Variable Speed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .35, 37Switch, Wiper/Washer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19Switch, Work Platform . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19

SUB

JECT IN

DEX

50960090/AP0914 226 PRINTED IN U.S.A.

PAGE


TTailpipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .75Test Port . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .167Throttle Pedal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .29Tie Rod . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .104, 105Transmission . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77Transmission Dipstick . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .81Transmission Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77Tray, Intermediate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .121Tri-Function Wire Harness . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .33, 141, 143, 159, 161, 163, 165Turn Signal Flasher . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21

UUniversal Joint . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77

VValve Stem . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .99Valve, 2-Way . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .174Valve, Check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27Valve, Coolant Drain . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .71Valve, Heater-A/C Solenoid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .41Valve, Hydraulic Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .137Valve, Steer Select . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27, 101, 103Valve, Water . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .35Vent, Axle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .106, 107

WWater Sensor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .05Water Separator Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .67Wheel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .99Wheel Hub . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .111, 115Wiper Arm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13Wire Harness, A/C . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39Wire Harness, Canopy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21Wire Harness, Cervis Radio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .61Wire Harness, Chassis . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21Wire Harness, Front Wiper . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13Wire Harness, Head Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .09Wire Harness, Light Package . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .49Wire Harness, Pwp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .59Wire Harness, Radio Remote . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .61Wire Harness, Rear Hood . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .49Wire Harness, Strobe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .09Wire Harness, Tilt Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .174Wire Harness, Top Wiper . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13Wire Harness, Washer Bottle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13Wire Harness, Work Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .119

SUB

JEC

T IN

DEX

PRINTED IN U.S.A. 227 50960090/AP0914


PAGEWork Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .119Work Section (Auxiliary Hydraulic) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .169Work Section 1 (Frame Level) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .169Work Section 2 (Boom Lift) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .169Work Section 3 (Boom Extend) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .169Work Section 4 (Fork Tilt) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .169Wrap, Battery Thermal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .55Wrap, Reflective Heat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .63

SUB

JECT IN

DEX

50960090/AP0914 228 PRINTED IN U.S.A.

REFERENCEMETRIC BOLT TORQUE GUIDE

Grade 10.9 Grade 12.9

M5 4.1 (5.5) 6 (8) 7 (10) 4 (5) 5 (7)M6 7 (10) 10 (14) 13 (17) 6.3 (8.5) 9 (12)M8 18 ( 25) 26 (35) 31 (42) 15 (20) 22 (30)M10 33 (45) 48 (65) 59 (80) 30 (40) 44 (59)M12 64 (87) 81 (110) 108 (147) 51 (69) 74 (100)M14 100 (135) 133 (180) 170 (230) 81 (110) 118 (160)M16 155 (210) 203 (275) 258 (350) 125 (170) 184 (250)M18 207 (280) 302 (410) 354 (480) 181 (245) 254 (345)M20 302 (410) 420 (570) 509 (690) 251 (340) 361 (490)M22 406 (550) 575 (780) 686 (930) 339 (460) 487 (660)M24 524 (710) 738 (1000) 878 (1190) 435 (590) 620 (840)M27 767 (1040) 1092 (1480) 1305 (1770) 642 (870) 922 (1250)M30 1047 (1420) 1482 (2010) 1770 (2400) 885 (1200) 1254 (1700)

MetricCoarse-Pitch

Thread 8.8 10.9 12.9 8.8 10.9

DIN 912, DIN 931, DIN 933, etc... DIN 7984All torque values are in Foot-Pounds and Newton Meters (Nm).

M8X1.0 18 (25) 27 (37) 32 (43) 16 (22) 24 (32)M10X1.0 37 (50) 55 (75) 65 (88) 32 (43) 48 (65)M10X1.25 36 (49) 52 (71) 61 (83) 31 (42) 46 (62)M12X1.25 64 (87) 96 (130) 111 (150) 55 (75) 81 (110)M12X1.5 61 (83) 92 (125) 107 (145) 53 (72) 77 (105)M14X1.5 100 (135) 148 (200) 173 (235) 89 (120) 129 (175)M16X1.5 155 (210) 229 (310) 266 (360) 133 (180) 195 (265)M18X1.5 232 (315) 332 (450) 391 (530) 199 (270) 284 (385)M20X1.5 325 (440) 465 (630) 538 (730) 277 (375) 391 (530)M22X1.5 435 (590) 620 (840) 723 (980) 369 (500) 524 (710)M24X2.0 546 (740) 789 (1070) 922 (1250) 465 (630) 664 (900)M27X2.0 811 (1100) 1143 (1550) 1328 (1800) 679 (920) 959 (1300)M30X2.0 1106 (1500) 1586 (2150) 1844 (2500) 959 (1300) 1364 (1850)

MetricFine-Pitch

Thread 8.8 10.9 12.9 8.8 10.9

DIN 912, DIN 931, DIN 933, etc... DIN 7984All torque values are in Foot-Pounds and Newton Meters (Nm).

Grade 8.8

Use these torque values when tightening hardware—excluding: lock nuts, thread-forming, self-tap-ping, and metal screws—unless otherwise specified.

PRINTED IN U.S.A. 229 50960090/AP0914

REFERENCESAE BOLT TORQUE GUIDE

Use these torque values when tightening hardware—excluding: lock nuts, thread-forming, self-tap-ping, and metal screws—unless otherwise specified.

NOTE: All torque values are in foot-pounds (lb.-ft.), except those marked with asterisks (*), whichare in inch-pounds (lb.-in.). To convert lb.-ft. to Newton Meter (Nm)—metric—torque values, multi-ply the lb.-ft. value by 1.355, or for inch pounds, multiply the lb.-in. value by 0.113.

* Value shown is in pound-force inch (lb.-in.)—inch pounds.

8-32 19* 14* 30* 22* 41* 31*8-36 20* 15* 31* 23* 43* 32*10-24 27* 21* 43* 32* 60* 45*10-32 31* 23* 49* 36* 68* 51*1/4-20 66* 50* 9 75* 12 91/4-28 76* 56* 10 86* 14 105/16-18 11 9 17 13 25 185/16/24 12 9 19 14 25 203/8-16 20 15 30 23 45 353/8-24 23 17 35 25 50 357/16-14 32 24 50 35 70 557/16-20 36 27 55 40 80 601/2-13 35 35 75 55 110 801/2-20 40 40 90 65 120 909/16-12 55 55 110 80 150 1109/16-18 60 60 120 90 170 1305/8-11 75 75 150 110 220 1705/8-18 85 85 180 130 240 1803/4-10 130 130 260 200 380 2803/4-16 150 150 300 220 420 3207/8-9 125 125 430 320 600 4607/8-14 140 140 470 630 660 5001-8 190 190 640 480 900 6801-14 210 210 710 530 1000 740

Grade 2

Dry Oiled

UnifiedNationalThread

Grade 5

Dry Oiled

Grade 8

Dry Oiled

50960090/AP0914 © 2014 Manitou Americas, Inc. All rights reserved. PRINTED IN U.S.A.

Manitou Americas, Inc.One Gehl WayP. O. Box 179

West Bend, WI 53095-0179 U.S.A

For parts orders contact your Manitou Americas Dealer or call:Factory Parts Department (262) 334-6653.

Websites: www.us.manitou.com / www.manitouamericasdealer.com

Date post:	08-Apr-2022
Category:	Documents
Upload:	others
View:	4 times
Download:	0 times

MT 6034 T - midtnequipment.com

Documents