+ All Categories
Home > Documents > OWNER'S MANUAL - Miller Industriess manual ch-16 installation, ... 3 1 0302687 tool box, 120" c.a.,...

OWNER'S MANUAL - Miller Industriess manual ch-16 installation, ... 3 1 0302687 tool box, 120" c.a.,...

Date post: 22-May-2018
Category:
Upload: vuongnhan
View: 223 times
Download: 1 times
Share this document with a friend
44
OWNER'S MANUAL CH-16 INSTALLATION, OPERATION, MAINTENANCE & PARTS NOTE: MANUAL including SPECIFICATIONS, subject to change without notice All ratings specified are based on structural factors only, not vehicle capacities or capabilities. Miller Industries Towing Equipment Inc. 8503 Hilltop Drive Ooltewah, Tennessee 37363 FORM NO. 0500904 7 / 96 Phone (423) 238-4171 • FAX (423) 238-5371 PRICE $25.00
Transcript

OWNER'S MANUAL

CH-16

INSTALLATION, OPERATION, MAINTENANCE & PARTS

NOTE: MANUAL including SPECIFICATIONS, subject to change without noticeAll ratings specified are based on structural factors only,

not vehicle capacities or capabilities.

Miller Industries Towing Equipment Inc.

8503 Hilltop DriveOoltewah, Tennessee 37363 FORM NO. 0500904

7 / 96Phone (423) 238-4171 • FAX (423) 238-5371 PRICE $25.00

LIMITED WARRANTY

MILLER INDUSTRIES TOWING EQUIPMENT INC., hereinafter referred to as MILLER, warrants to theoriginal purchaser that each new MILLER wrecker or other MILLER products will be free from defects inmaterial and workmanship for a period of twelve (12) months from date placed in service, but in no eventshall such warranty period exceed twenty-four (24) months from date of manufacture by MILLER. Thepurchaser must promptly notify MILLER in writing of any failure in material or workmanship. In no eventshall MILLER accept such notification later than twenty-four (24) months from date of delivery or twelve(12) months from date placed in service, whichever is earlier.

MILLER's obligation under this warranty, statutory or otherwise, is limited to the repair or replacement atthe MILLER factory, or at a point designated by MILLER, of such part or parts as shall appear uponinspection by MILLER to be defective in material or workmanship. New or remanufactured parts will beused for any replacement at MILLER's option. This warranty is not transferable. This warranty does notobligate MILLER to bear the cost of labor or transportation charges in connection with the repair orreplacement of any parts found to be defective, nor shall it apply to a product upon which repairs oralterations have been made unless authorized by MILLER.

EXCEPT AS EXPRESSLY SET FORTH IN THIS WARRANTY, MILLER MAKES NO OTHERWARRANTY, EXPRESS OR IMPLIED, AND HEREBY DISCLAIMS ALL OTHER WARRANTIESINCLUDING, BUT NOT LIMITED TO, THE IMPLIED WARRANTIES OF MERCHANTABILITY ANDFITNESS FOR A PARTICULAR PURPOSE. MILLER shall in no event be liable for claimed downtime,claimed loss of profits or goodwill, or any other special, incidental, indirect, or consequential damagesconcerning or relating to any product or parts, whether based on negligence, strict liability, breach ofcontract, breach of warranty, misrepresentation or any other legal theory, regardless of whether the lossresulted from any general or particular requirement which MILLER knew or had reason to know about atthe time of sale.

MILLER MAKES NO WARRANTY, EXPRESS OR IMPLIED, AS TO THE FINISHED PRODUCTSMANUFACTURED OR SUPPLIED BY ANOTHER MANUFACTURER AND SUPPLIED BY MILLER TOPURCHASER, including, but not limited to, any vehicle to which a MILLER product may be affixed or anyaccessories or wire rope, and MILLER EXPRESSLY DISCLAIMS ANY IMPLIED WARRANTIES OFMERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE AS TO SUCH EQUIPMENT ORPRODUCTS. This language shall in no way affect or diminish the rights of the purchaser to rely on suchwarranties as are extended by such manufacturers or suppliers. MILLER shall, to the extent permittedunder applicable law, pass on to the purchaser such manufacturer's or seller's warranty.

MILLER, whose policy is one of continuous improvement, reserves the right to improve its productsthrough changes in design or materials as it may deem desirable without being obligated to incorporatesuch changes in products previously sold. This warranty is not intended to cover or include the followingitems, which are set forth by way of example and not limitation:

A. Normal deterioration of trim, paint, lettering, and appearance items due to wear or exposure toweather, road conditions, road treatments, etc.

B. Any damage or defect due to accident, misuse, abuse, improper or unauthorized repairs, failureto provide reasonable and necessary maintenance, or uses for which the equipment was notdesigned or intended.

C. Alterations or modifications that affect performance, operation or reliability.D. Normal maintenance parts including, but not limited to, wear pads, bushings, wire rope, mud

flaps, fenderettes, light bulbs, hydraulic oil, filters, and tow sling belts.

IT IS EXPRESSLY UNDERSTOOD THAT MILLER MAKES NO IMPLIED WARRANTY THAT MILLERPRODUCTS SHALL BE FIT FOR THE PURPOSE OF LIFTING OR MOVING PEOPLE OR FOR ANYOTHER IMPROPER USE.

SERIAL NUMBERMiller Industries Towing Equipment Inc.

8503 Hilltop DriveOoltewah, Tennessee 37363

Telephone (423) 238-4171

Section VI - PARTS

This Section is provided by the manufacturer for the purpose of orderingany component part of the CHALLENGER CH-16 Wrecker / IntegratedUnderlift that may be required when part replacement is necessary. Becertain to use only original equipment replacement parts for warrantypurposes as well as for keeping your CHALLENGER CH-16 Wrecker /Integrated Underlift in its original state and optimum operating capacities.When ordering replacement or spare parts be sure to provide the followinginformation to the manufacturer’s Parts Department.

1. Manual Number & Date of Publication2. Manual Page Number3. Page Title4. Reference Number of Part Desired5. Part Number6. Part Description7. Quantity of Part Desired

Providing this information will help ensure that the correct parts will bedelivered to you in an expedient manner without delay. Should additionalinformation be required for repair or replacement of certain components,contact your Wrecker Manufacturer Authorized Representative.

The Manufacturer reserves the right, without notice or obligation, to improveor modify their products, which may change the specifications, models andfeature availability.

VI-1

VI-2

Section VI - PARTS (cont'd)SUBFRAME ASSEMBLY

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

Section VI - PARTS (cont'd)SUBFRAME ASSEMBLY

1 6 0300113 GREASE FITTING2 8 0302540 CENTER BONDED MOUNT3 12. 0302541 SPECIAL WASHER4 2 0302616 SPADE CYLINDER5 2 0303091 BOOM LIFT CYLINDER6 2 0303140 RAMP PAD7 8 0400066 SCREW, 1/4"-20 X 3/4" HEX HD CAP8 10 0400128 SCREW, 3/8"-16 X 1-1/4" FL HD SKT9 2 0400130 SCREW, 3/8"-16 X 3-1/2" HEX HD CAP10 4 0400139 SCREW, 3/8"-16 X 1-1/2" HEX SKT SET11 2 0400181 SCREW, 1/2"-13 X 1-1/2" HEX HD CAP12 4 0400276 SCREW, 5/8"-11 X 4-1/2" HEX HD CAP13 4 0400281 SCREW, 3/4"-10 X 3-1/2" HEX HD CAP14 4 0400294 SCREW, 3/4"-10 X 6-1/2" HEX HD CAP15 16 0400392 NUT, 3/8"-16 NYLOK HEX16 4 0400408 NUT, 1/2"-13 NYLOK HEX17 4 0400430 NUT, 3/4"-10 NYLOK HEX18 8 0400452 LOCKWASHER, 1/4" HELICAL19 8 0400506 WASHER, 5/8" FLAT20 4 0400508 LOCKWASHER, 5/8" HELICAL21 8 0400510 WASHER, 3/4" FLAT22 2 0705500 SHAFT, LOWER SPADE23 2 0707341 PIN, LIFT CYLINDER24 2 0707377 COVER, SPADE TUBE25 2 0707394 SHAFT, UPPER SPADE26 -- 0707199 PIN, SPADE PAD-- 4 0301551 CABLE SLEEVE, 1/16"-- 4 0301553 CABLE ASSEMBLY, 1/16" X 17"-- 2 0302474 PIN, LYNCH-- 4 0400044 DRIVE SCREW, #10 X 1/2" RD HD-- 2 0400563 ROLL PIN, 3/16" X 1-3/4"-- 4 0702604 PROTECTIVE HOSE TUBE, 14"27 1 0802211 FRONT BODY MTG TUBE28 2 0802221 SPADE PAD29 2 0802240 PIVOT PIN, LIFT CYLINDER30 1 0802243 INNER SPADE, LEFT31 1 0802244 INNDER SPADE, RIGHT32 1 0802863 SUBFRAME WELDMENT33 -- 0903136 SAFETY CHAIN ASSEMBLY (NOT SHOWN)-- 2 0303086 SAFETY CHAIN-- 2 0400211 SCREW, 1/2"-13 X 1-34" HEX HD CAP-- 2 0400408 NUT, 1/2"-13 NYLOK HEX-- 2 0400492 WASHER, 1/2" FLAT

Section VI - PARTS (cont'd)BODY ASSEMBLY

VI-3

VI-4

Section VI - PARTS (cont'd)BODY ASSEMBLY

VI-5

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

Section VI - PARTS (cont'd)BODY ASSEMBLY

1 4 0301912 DOOR CHECK, 11"2 1 0302686 TOOL BOX, 120" C.A., LEFT3 1 0302687 TOOL BOX, 120" C.A., RIGHT4 1 0303061 BACKUP ALARM (NOT SHOWN)5 8 0400066 SCREW, 1/4"-20 X 3/4" HEX HD CAP6 8 0400122 SCREW, 3/8"-16 X 1-1/4" HEX HD CAP7 6 0400369 CLIP, 1/4" TINNERMAN8 8 0400392 NUT, 3/8"-16 NYLOK HEX9 6 0400451 WASHER, 1/4" FLAT10 8 0400452 LOCKWASHER, 1/4" HELICAL11 30 0400566 RIVET, 1/4"12 1 0705090 MUDFLAP MTG ANGLE, LEFT13 1 0705091 MUDFLAP MTG ANGLE, RIGHT14 2 0705092 BAR, MUDFLAP15 1 0711289 PANEL, SWITCH16 1 0711290 PANEL, CONTROL17 1 0711292 PANEL, CONTROL18 1 0711344 PANEL, GAUGE19 2 VA0452 FIBERGLASSFENDER20 2 VA0588 MUD FLAP

21 1 0902286 CHALLENGER NAMEPLATE KIT

-- -- 0902328 BODY MOUNTING KIT-- 28 0400288 SCREW, 3/4"-10 X 2-1/2" HEX HD CAP-- 28 0400431 NUT, 3/4"-10 NYLOK HEX-- 2 0707174 ANGLE, TAILGATE MOUNTING-- 2 0711256 MOUNTING PLATE

-- -- 124001727 LIGHT BAR, STANDARD-- 2 0301706 GASKET, LIGHT BAR-- 4 0400126 SCREW, 3/8"-16 X 1" HEX HD CAP-- 12 0400177 SCREW, 1/2"-13 X 1-1/4" HEX HD CAP-- 6 0400181 SCREW, 1/2"-13 X 1-1/2" HEX HD CAP-- 4 0400392 NUT, 3/8"-16 NYLOK HEX-- 18 0400408 NUT, 1/2"-13 NYLOCK HEX-- 12 0400492 WASHER, 1/2" FLAT22 2 0802254 MOUNTING ANGLE23 1 0802256 SUPPORT CHANNEL, LEFT24 1 0802257 SUPPORT CHANNEL, RIGHT25 1 0802260 TOP CHANNEL

VI-6

Section VI - PARTS (cont'd)BOOM ASSEMBLY

VI-7

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

Section VI - PARTS (cont'd)BOOM ASSEMBLY

1 6 0300113 GREASE FITTING2 2 0300626 SHEAVE, 8"3 2 0301224 WIRE ROPE, 6 X 37 IWRC, 1/2" X 175'4 2 0301895 GREASE FITTING, STR 1/8"5 2 0301923 SLIDE PAD, BOOM BOTTOM6 4 0301959 SNAP RING, 1-1/2" INTERNAL7 4 0302378 COMPRESSION SPRING8 1 0302614 EXTEND CYLINDER9 2 0302619 BUSHING, 2-1/4" OD X 2" ID X 1-1/2"10 2 0302628 SLIDE PAD, INNER BOOM11 4 0400066 SCREW, 1/4"-20 X 3/4" HEX HD CAP12 4 0400121 SCREW, 3/8"-16 X 3/4" HEX HD CAP13 4 0400122 SCREW, 3/8"-16 X 1-1/4" HEX HD CAP14 18 0400132 SCREW, 3/8"-16 X 1-1/2" HEX HD CAP15 2 0400133 SCREW, 3/8"-16 X 3" HEX HD CAP16 4 0400150 SCREW, 3/8"-16 X 2-1/2" HEX HD CAP17 2 0400176 SCREW, 1/2"-13 X 1" HEX HD CAP18 1 0400220 SCREW, 1/2"-13 X 5-1/2" HEX HD CAP19 4 0400248 SCREW, 5/8"-11 X 1" HEX HD CAP20 24 0400392 NUT, 3/8"-16 NYLOK HEX21 4 0400408 NUT, 1/2"-13 NYLOK HEX22 4 0400451 WASHER, 1/4" FLAT23 16 0400480 WASHER, 3/8" FLAT24 4 0400482 LOCKWASHER, 3/8" HELICAL25 2 0400491 LOCKWASHER, 1/2" HELICAL26 8 0400492 WASHER, 1/2" FLAT

27 4 0400506 WASHER, 5/8" FLAT28 4 0400508 LOCKWASHER, 5/8" HELICAL29 4 0400543 COTTER PIN, 1/8" X 3/4"30 6 0400554 ROLL PIN, 3/8" X 1"31 1 0400581 PIPE U-BOLT, 3/8"-18 X 3"32 2 0700778 TOP SPACER, OUTER BOOM33 4 0700801 CABLE GUIDE, BOTTOM34 2 0700888 SHAFT, SHEAVE35 2 0703442 SKID, FAIRLEAD ASSEMBLY36 1 0707343 EXTEND CYLINDER PIN, BASE37 1 0707344 EXTEND CYLINDER PIN, ROD38 1 0707342 PIVOT PIN, BOOM39 2 0709361 PIVOT ROD40 2 0709362 SPRING CHANNEL41 1 0710143 PIN, TILT CYLINDER BASE END42 1 0708645 PLATE, FLAPPER43 2 0800286 CABLE GUIDE44 1 0800509 SWIVEL WELDMENT, LEFT45 1 0800510 SWIVEL WELDMENT, RIGHT46 4 0802218 SPRING PIN47 1 0802246 CYLINDER SUPPORT48 2 0802365 PIN, TOWER PIVOT49 2 0802775 TENSIONER, MOUNTING BRACKET50 2 0802774 TENSIONER, BRACKET51 1 0802849 OUTER BOOM WELDMENT52 1 0802931 INNER BOOM WELDMENT

VI-8

Section VI - PARTS (cont'd)UNDERLIFT & TOWER ASSEMBLY

VI-9

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

Section VI - PARTS (cont'd)UNDERLIFT & TOWER ASSEMBLY

1 6 0300113 GREASE FITTING2 2 0301895 GREASE FITTING, 1/8" STR3 1 0301765 FOLD CYLINDER4 1 0302791 TILT CYLINDER5 1 0304246 PIN, FOLD CYLINDER CLEVIS6 1 0400121 SCREW, 3/8"-16 X 3/4" HEX HD CAP7 1 0400122 SCREW, 3/8"-16 X 1-1/4" HEX HD CAP8 4 0400167 SCREW, 3/8"-16 X 3-3/4" HEX HD CAP9 4 0400176 SCREW, 1/2"-13 X 1" HEX HD CAP10 3 0400392 NUT, 3/8"-16 NYLOK HEX11 7 0400482 LOCKWASHER, 3/8" HELICAL12 1 0400491 LOCKWASHER, 1/2" HELICAL13 3 0400548 COTTER PIN, 3/8" X 2"14 4 0710140 BUSHING, TILT CYLINDER15 1 0710143 PIN, TILT CYLINDER BASE END16 4 0710144 PIN, TILT CYLINDER ROD END17 1 0802220 PIN WELDMENT, FOLD CYLINDER18 1 0802237 PIVOT PIN, UNDERLIFT19 1 0802865 TOWER WELDMENT20 1 0802935 TOWER PIVOT PIN WELDMENT

-- -- 0901716 STOW KIT, WINCH CABLE21 2 0301691 MASTER LINK, OBLONG22 2 0302273 SPRING, WINCH CABLE TIE-BACK23 2 0400205 SCREW, 1/2"-13 X 3" HEX HD CAP24 2 0400408 NUT, 1/2"-13 NYLOK HEX

-- -- 0903059 HORIZONTAL BOOM ASSEMBLY25 6 0300113 GREASE FITTING, 1/8" STR26 7 0302561 SLIDE PAD27 2 0302619 SPRING BUSHING

-- -- 0903752 HORIZONTAL BOOM ASSEMBLY (con't)28 4 0303331 EXTEND CYLINDER29 8 0400107 SCREW, 5/16"-18 X 2-1/2" HEX HD CAP30 8 0400151 SCREW, 3/8"-24 X 5/8" BUTTON HD SKT31 5 0400228 SCREW, 3/8"-24 X 5/8" HEX HD CAP32 2 0400382 NUT, 5/16"-18 NYLOK HEX33 9 0400481 LOCKWASHER, 3/8" EXTERNAL TOOTH34 5 0707034 STOP PLATE35 1 0707271 EXTEND CYLINDER PIN, BASE END36 1 0707452 SPACER PAD37 1 0803231 OUTER BOOM WELDMENT38 2 0803232 2ND STAGE BOOM WELDMENT39 1 HD86 EXTEND CYLINDER PIN WELDMENT40 1 HD89 RETAINING RING

-- -- 0903175 CROSSBAR ASSEMBLY41 1 0301197 COMPRESSION SPRING, CROSS BAR42 1 0301398 DETENT BALL, 1-3/16"43 1 0303087 "O" RING, PIVOT PIN44 2 0303105 THRUST WASHER, 1/8"45 2 0303106 THRUST WASHER, 1/16"46 2 0400354 SCREW, 5/8"-11 X 4-1/2" SKT HD CAP47 2 0400508 LOCKWASHER, 5/8" HELICAL48 1 0710054 PIVOT PIN, TOP HALF49 1 0710055 PIVOT PIN, BOTTOM HALF50 1 0710195 SPACER, DETENT SPRING51 1 0802919 CROSSBAR WELDMENT

-- -- 0903751 INNER BOOM ASSEMBLY52 1 0302625 BUSHING, PIVOT PIN53 8 0803320 3RD STAGE BOOM WELDMENT

VI-10

Section VI - PARTS (cont'd)UNDERLIFT HYDRAULICS

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

VI-11

Section VI - PARTS (cont'd)UNDERLIFT HYDRAULICS

1 7 0300044 CONNECTOR, 6MJ-8MB2 1 0300142 ELBOW, 6MJ-4MP903 1 0300206 BRANCH TEE, 6MJ-6MJ-4MP4 1 0301424 CONNECTOR, 6MJ-4MP5 4 0301470 ELBOW, 6MJ-8MP906 2 0301473 HOSE ASSEMBLY, 18"7 2 0301485 HOSE ASSEMBLY, 81"8 3 0301522 CONNECTOR, 6MJ-6MB9 1 0301730 DOUBLE HOLDING VALVE10 1 0301731 HOLDING VALVE11 1 0301765 FOLD CYLINDER12 1 0301837 IN-LINE ORIFICE13 2 0301880 HOSE ASSEMBLY, 107"14 1 0302035 HOSE ASSEMBLY, 18"15 1 0302036 HOSE ASSEMBLY, 26"16 2 0302509 ELBOW, 6MJ-8MP9017 12 0302514 ADAPTER, 8MJ-6MJ18 4 0302548 CLAMPING UNIT19 12 0302549 SPLIT BUSHING, 1/2"20 4 0302551 STACKING NUT, SKT HD21 2 0302581 HOSE ASSEMBLY, 36"22 2 0302582 HOSE ASSEMBLY, 36"23 2 0302596 HOSE ASSEMBLY, 34"24 1 0302782 CONTROL VALVE25 1 0302791 TILT CYLINDER26 2 0302805 HOSE ASSEMBLY, 10"27 1 0302815 HOSE ASSEMBLY, 32"28 1 0303017 CONNECTOR, 8MB-6FB29 6 0303108 TUBE ASSEMBLY30 1 0303331 EXTEND CYLINDER31 2 0400064 SCREW, 1/4"-20 X 2" HEX HD CAP SLOTTED32 4 0400118 SCREW, 5/16-18 X 3/4 HEX HD CAP33 2 0400366 NUT, 1/4"-20 HEX34 2 0400451 WASHER, 1/4" FLAT35 2 0400452 LOCKWASHER, 1/4" HELICAL

VI-12

Section VI - PARTS (cont'd)BOOM ELEVATION HYDRAULICS

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

VI-13

Section VI - PARTS (cont'd)BOOM ELEVATION HYDRAULICS

1 1 0300011 CONTROL VALVE2 2 0300044 CONNECTOR, 6MJ-8MB3 4 0300113 GREASE FITTING4 2 0300147 ELBOW, STREET 4MP-4FP905 2 0300206 BRANCH TEE, 6MJ-6MJ-4MP6 2 0300710 CLAMP, CHECK VALVE RETAINING, 6-1/2"9 4 0301388 ELBOW, 8MJ-8MB908 2 0301425 CONNECTOR, 6MJ-6MB9 4 0301470 ELBOW, 6MJ-8MB9010 2 0301731 HOLDING VALVE16 1 0302035 HOSE ASSEMBLY, 18"11 2 0302051 ELBOW 8MJ-6MP9012 2 0302568 TUBING, HYDRAULIC13 4 0302569 WIRE TIE, 29-3/4"14 2 0302575 BULKHEAD RUN TEE W/NUT15 2 0302581 HOSE ASSEMBLY, 36"16 1 0302582 HOSE ASSEMBLY, 36"17 1 0302604 HOSE ASSEMBLY, 44"18 2 0302632 HOSE ASSEMBLY, 40"16 1 0303091 CYLINDER BOOM LIFT20 4 0400064 SCREW, 1/4"-20 X 2-1/4" RD HD SLOTTED21 4 0400366 NUT, 1/4"-20 HEX22 4 0400451 WASHER, 1/4" FLAT23 4 0400452 LOCKWASHER, 1/4" HELICAL24 2 0703001 BRACKET, CHECK VALVE MOUNTING

VI-14

Section VI - PARTS (cont'd)BOOM EXTENSION HYDRAULICS

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

Section VI - PARTS (cont'd)BOOM EXTENSION HYDRAULICS

1 1 0300011 CONTROL VALVE2 2 0300044 CONNECTOR, 6MJ-8MB3 1 0300209 ELBOW, 6MJ-6MP904 1 0301425 CONNECTOR, 6MJ-6MB5 2 0301620 ELBOW, 6MJ-6MB906 1 0301696 ELBOW, 6MJ-6FJX907 1 0301731 HOLDING VALVE8 1 0301782 MALE RUN TEE, 6MJ-4MP-6MJ9 1 0302000 HOSE ASSEMBLY, 24"10 5 0302062 WIRE TIE, 21" (NOT SHOWN)11 1 0302581 HOSE ASSEMBLY, 36"12 1 0302605 HOSE ASSEMBLY, 44"13 1 0302614 EXTEND CYLINDER14 1 0302635 HOSE ASSEMBLY, 131"15 2 0400122 SCREW, 3/8"-16 X 1-1/4" HAX HD CAP16 2 0400392 NUT, 3/8"-16 NYLOCK HEX17 2 0400480 WASHER, 3/8" FLAT

Section VI - PARTS (cont'd)PUMP, VALVE & FILTER HYDRAULICS

VI-15

VI-16

Section VI - PARTS (cont'd)PUMP, VALVE & FILTER HYDRAULICS

VI-17

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

Section VI - PARTS (cont'd)PUMP, VALVE & FILTER HYDRAULICS

1 2 0301485 HOSE ASSEMBLY, 81"2 1 0301507 PUMP, OPPOSITE ENGINE3 2 0302205 GAUGE, FLUSH MOUNT 6000 PSI4 2 0302577 CONNECTOR, 6MJ-4FP5 2 0303435 HOSE ASSEMBLY 58"6 6 0400021 SCREW, #8-32 X 1/2" RD HD PHIL MACH7 6 0400351 HEX NUT, & STAR WASHER, #8-32

-- -- 0903307 PUMP KIT8 2 0300364 CLAMP HOSE, 1" - 2-1/4"9 2 0300660 HOSE ASSEMBLY, 120"10 2 0300666 BARB, 24C4-24MP11 20 FT. 0300671 SUCTION HOSE, 1-1/2"12 2 0300891 PIPE NIPPLE, 1-1/2" X 3"13 2 0301547 ELBOW, 8MJ-12MB9014 2 0302088 BALL VALVE, BRONZE15 1 0302242 FLANGE FITTING, 24FL-24 HOSE 9016 2 0302983 STREET ELBOW, 45° 1-1/2"17 1 0303032 ELBOW, 24MJ-20MB9018 1 0303033 HOSE BARB, 24C4-24FJX19 6 0303290 CLAMP, 2-1/2" INSULATED20 2 0400188 SCREW, 1/2"-13 X 2 HEX HD CAP21 2 0400408 NUT, 1/2"-13 NYLOK HEX

-- -- 0903535 VALVE PAN ASSEMBLY22 1 0300011 CONTROL VALVE23 2 0300052 ELBOW, 8MJ-10MB9024 2 0301995 STRAIGHT ADAPTER, 8FJ-6MJ25 2 0302052 RUN TEE, 8MJ-8FJX-8MJ26 1 0302782 CONTROL VALVE27 6 0400135 SCREW, 3/8"-16 X 4-1/2" HEX HD CAP28 4 0400157 SCREW, 3/8"-16 X 1-3/4" HEX HD CAP

29 10 0400392 NUT, 3/8"-16 NYLOK HEX30 4 0400480 WASHER, 3/8" FLAT31 6 0704045 SPACER, CONTROL VALVE32 2 0711249 PLATE, CONTROL BULKHEAD (L.&R.S.C.)33 1 0711250 PLATE, CONTROL BULKHEAD (L.&R.S.C.)34 2 0711251 PLATE, CONTROL BULKHEAD (L.&R.S.C.)35 1 0711561 PLATE VALVE MOUNTING

-- -- 0902353 TANK KIT36 2 0300136 RETURN LINE FILTER ASSEMBLY37 1 0300446 PIPE PLUG, 3/4" NPT MALE38 2 0300615 ELL, 12MJ-12MP9039 2 0301545 ELBOW, 12MJ-12MP9040 4 0302227 CENTER BONDED MOUNT41 4 0302228 SPECIAL WASHER42 1 0302570 SIGHT GAUGE43 1 0305006 FILLER CAP44 6 0400036 SCREW, #10-32 X 1" RD HD MACH45 12 0400122 SCREW, 3/8"-16 X 1-1/4" HEX HD CAP46 4 0400146 SCREW, 3/8"-16 X 2-1/4" HEX HD CAP47 6 0400357 NUT, #10-32 NYLOK HEX48 4 0400392 NUT, 3/8"-16 NYLOK HEX49 12 0400482 LOCKWASHER, 3/8"HELICAL50 1 0705910 COVER PLATE51 1 0706114 GASKET, CLEAN OUT & FILLER COVER52 1 0803163 RESERVOIR WELDMENT

-- -- 0903696 COVER KIT53 4 0400121 SCREW, 3/8"-16 X 3/4" HEX HD CAP54 4 0400392 NUT, 3/8"-16 NYLOK HEX55 1 0711322 COVER, VALVE56 4 0711575 SUPPORT, COVER

VI-18

Section VI - PARTS (cont'd)WINCH HYDRAULICS & AIR FREE SPOOL

VI-19

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

Section VI - PARTS (cont'd)WINCH HYDRAULICS & AIR FREE SPOOL

1 1 0300011 CONTROL VALVE2 2 0300324 SOLENOID VALVE, AIR CONTROL3 4 0301376 CONNECTOR, 8MJ-10MB4 2 0301574 ELBOW, 4TB-4MP905 18 FT. 0301577 AIR HOSE, 1/4" O.D.6 2 0302055 AIR CYLINDER7 7 FT. 0302431 CONVOLUTED LOOM, 3/8"8 4 0302546 CLAMPING UNIT9 4 0302550 SPLIT BUSHING, 3/4"10 2 0302551 STACKING NUT, SKT HD11 1 0302607 TEE UNION, 4TB-4TB-4TB12 1 0302617 WINCH, H-600 LEFT13 1 0302618 WINCH, H-600 RIGHT14 2 0302627 HYDRAULIC MOTOR15 2 0302677 BREATHER VENT, 1/8" MP16 4 0302678 ELBOW, 4TB-2MP9017 1 0302782 CONTROL VALVE18 2 0302795 SPRING, COMPRESSION19 2 0302827 CONNECTOR, 10MJ-10MB20 2 0302828 CONNECTOR, 10MJ-10MBL21 2 0303131 HOSE ASSEMBLY, 80"22 2 0303391 HOSE ASSEMBLY, 96"23 4 0400034 SCREW, #10-32 X 1/2" RD HD PHIL24 2 0400118 SCREW, 5/16"-18 X 3/4" HEX HD CAP25 2 0400121 SCREW, 3/8"-16 X 3/4" HEX HD CAP26 4 0400122 SCREW, 3/8"-16 X 1-1/4" HEX HD CAP

27 2 0400132 SCREW, 3/8"-16 X 1-1/2" HEX HD CAP28 16 0400234 SCREW, 7/16"-14 X 1-1/4" HEX HD CAP29 4 0400238 SCREW, 1/2"-13 X 1-1/2" HEX HD CAP30 8 0400260 SCREW, 5/8"-11 X 2" HEX HD CAP31 4 0400356 NUT, #10-32 HEX32 8 0400367 NUT, 1/4"-20 HEX NYLOK33 8 0400392 NUT, 3/8"-16 HEX NYLOK34 2 0400412 NUT, 1/2"-20 HEX JAM35 8 0400421 NUT, 5/8"-11 HEX NYLOK36 8 0400480 WASHER, 3/8" FLAT37 16 0400487 LOCKWASHER, 7/16" HELICAL38 2 0400488 WASHER, 7/16" FLAT39 8 0400491 LOCKWASHER, 1/2" HELICAL40 16 0400504 WASHER, 5/8" SAE41 4 0400520 LOCKWASHER, #10 HELICAL42 2 0400530 CLEVIS PIN, 5/16" X 1-1/4"43 2 0400543 COTTER PIN, 1/8" X 3/4"44 2 0702382 MOUNTING ANGLE45 1 0707337 WINCH MOUNTING ANGLE, FRONT46 1 0707338 WINCH MOUNTING ANGLE, REAR47 1 0707416 FREESPOOL BRACKET, LEFT48 1 0707417 FREESPOOL BRACKET, RIGHT49 2 0707418 FREESPOOL COVER50 2 0800772 ADJUSTMENT YOKE51 4 RR809 BUSHING, CONTROL HANDLE

VI-20

Section VI - PARTS (cont'd)LEFT CONTROL ASSEMBLY

VI-21

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

Section VI - PARTS (cont'd)LEFT CONTROL ASSEMBLY REMOTE CONTROL ASSEMBLY

-- -- -- REMOTE CONTROL ASSEMBLY36 10 / 16 0300166 WIRE CONNECTOR, SPADE37 1 0301574 ELBOW, 4TB-4MP9038 15 / 25 0301577 AIR HOSE, 1/4" O.D. (FT.)39 2 / 4 0301610 CONNECTOR, 4TB-4MP40 2 / 3 0301618 BRASS PLUG, 4MP41 2 0302048 CABLE SEALING GRIP42 2 0302340 HEX PIPE BUSHING43 1 0302431 CONVOLUTED LOOM, 3/8" X 8"44 35 / 65 0302434 CABLE TIE, 4" 18 LB.45 1 / 2 0302677 BREATHER VENT, 2MP46 16 / 28 0302678 ELBOW, 4TB-2MP47 1 0302844 AIR SOLENOID VALVE (8)-- 1 0303479 AIR SOLENOID VALVE (14)48 1 0303226 CIRCUIT BREAKER, HI-AMP WATERPROOF49 1 / 2 0303235 TERMINAL BLOCK50 1 0303250 POWER PAL, 15 POSITION51 1 0303251 POWER PAL, 8 POSITION52 8 / 20 0303322 ELECTRICAL CABLE, 16/10 SO (FT.)53 4 / 7 0303335 AIR CYLINDER54 1 0303363 AIR FILTER/REGULATOR55 1 0303364 AIR LUBRICATOR56 1 0303365 MOUNTING BRACKET57 2 / 4 0400025 SCREW, #8-32 X 3/4" RD HD SLOTTED58 4 / 7 0400057 SCREW, 1/4"-20 X 1-1/4" HEX HD CAP59 2 / 4 0400078 SCREW, 1/4"-20 X 2" HEX HD CAP60 2 / 4 0400351 HEX NUT & STAR WASHER, #8-3261 6 / 11 0400367 NUT, 1/4"-20 HEX NYLOK62 4 / 7 0400401 NUT, 7/16"-20 HEX JAM63 2 / 4 0400451 WASHER, 1/4" FLAT64 4 / 7 0400527 CLEVIS PIN, 5/16" X 5/8" COTTERLESS65 1 0711277 SUPPORT, SOLENOID VALVE (8)-- 1 0711836 SUPPORT, SOLENOID VALVE (14)66 4 / 7 0803181 CLEVIS WELDMENT67 1 HA0132 GAUGE, 0-160 PSI

1 1 0300341 CONTROL KNOB, W/L (UP/DOWN)2 2 0300834 CONTROL KNOB, (IN/OUT)3 1 0300835 CONTROL KNOB, BOOM (UP/DOWN)4 2 0300836 CONTROL KNOB, JACK (UP/DOWN)5 1 0300837 CONTROL KNOB, BOOM (IN/OUT)6 1 0302453 CONTROL CABLE, 92"7 4 0302454 CONTROL CABLE, 67"8 4 0302455 CONTROL CABLE, 79"9 9 0302726 GREASE FITTING, 1/4"-28 X 45°10 1 0302856 CONTROL KNOB, TILT (UP/DOWN)11 1 0302917 CONTROL KNOB, W/L EXTEND (IN/OUT)12 12 0303008 ADJUSTABLE CLEVIS13 2 0400066 SCREW, 1/4"-20 X 3/4" HEX HD CAP14 9 0400103 SCREW, 5/16"-18 X 1-1/4" HEX HD CAP15 4 0400107 SCREW, 5/16"-18 X 2-1/2" HEX HD CAP16 4 0400122 SCREW, 3/8"-16 X 1-1/4" HEX HD CAP17 2 0400367 NUT, 1/4"-20 HEX NYLOK18 4 0400379 NUT, 5/16"-18 "J" TINNERMAN19 9 0400382 NUT, 5/16"-18 HEX NYLOK20 36 0400383 NUT, 5/16"-24 HEX21 10 0400392 NUT, 3/8"-16 HEX NYLOK22 9 0400393 NUT, 3/8"-16 HEX JAM23 4 0400451 WASHER, 1/4" FLAT24 24 0400466 WASHER, 5/16" INTERNAL TOOTH25 10 0400512 WASHER, 3/4" FLAT (SPECIAL)26 9 0400532 CLEVIS PIN, 5/16" X 1"27 9 0400541 COTTER PIN, 1/16" X 3/4"28 2 0711235 CLAMP, SHAFT CONTROL BOX29 1 0711245 PLATE, SHAFT SUPPORT30 1 0711246 PIN, CONTROL BOX31 1 0711284 SUPPORT, CONTROL (LEFT)32 1 0711285 SUPPORT, CONTROL (RIGHT)33 6 0801054 CONTROL CABLE CONNECTOR34 1 0803182 CONTROL FRAME WELDMENT35 9 0803294 CONTROL HANDLE WELDMENT

VI-22

Section VI - PARTS (cont'd)RIGHT CONTROL ASSEMBLY

VI-23

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

Section VI - PARTS (cont'd)RIGHT CONTROL ASSEMBLY

1 2 0300834 CONTROL KNOB, (IN/OUT)2 1 0300835 CONTROL KNOB, BOOM (UP/DOWN)3 2 0300836 CONTROL KNOB, JACK (UP/DOWN)4 1 0300837 CONTROL KNOB, BOOM (IN/OUT)5 3 0302453 CONTROL CABLE, 92"6 3 0302455 CONTROL CABLE, 79"7 6 0302726 GREASE FITTING, 1/4"-28 X 45°8 6 0303008 ADJUSTABLE CLEVIS9 6 0400103 SCREW, 5/16"-18 X 1-1/4" HEX HD CAP10 4 0400107 SCREW, 5/16"-18 X 2-1/2" HEX HD CAP11 4 0400122 SCREW, 3/8"-16 X 1-1/4" HEX HD CAP12 4 0400379 NUT, 5/16"-18 "J" TINNERMAN13 10 0400382 NUT, 5/16"-18 HEX NYLOK14 18 0400383 NUT, 5/16"-24 HEX15 4 0400392 NUT, 3/8"-16 HEX NYLOK16 6 0400393 NUT, 3/8"-16 HEX JAM17 18 0400466 WASHER, 5/16" INTERNAL TOOTH18 4 0400480 WASHER, 3/8" FLAT19 7 0400512 WASHER, 3/4" FLAT (SPECIAL)20 6 0400532 CLEVIS PIN, 5/16" X 1"21 6 0400541 COTTER PIN, 1/16" X 3/4"22 2 0711235 CLAMP, SHAFT CONTROL BOX23 1 0711247 PIN, CONTROL BOX24 1 0711284 SUPPORT, CONTROL (LEFT)25 1 0711285 SUPPORT, CONTROL (RIGHT)26 1 0803183 CONTROL FRAME WELDMENT27 6 0803294 CONTROL HANDLE WELDMENT

Section VI - PARTS (cont'd)H-600SC WINCH ASSEMBLY

VI-24

Section VI - PARTS (cont'd)H-600SC WINCH ASSEMBLY

VI-25

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

Section VI - PARTS (cont'd)H-600SC WINCH ASSEMBLY

1 1 300062 ADAPTER2 1 306036 SPRING, FLAT3 1 308046 BUSHING4 2 308048 BUSHING5 1 314003 CAM PLATE6 1 324163 CLUTCH, JAW7 1 328046 COVER, GEAR HOUSING8 1 328057 COVER, BRAKE9 2 330010 SHOE, DRAG BRAKE10 1 332140 DRUM11 2 334050 GEAR, R.H.12 1 338038 HOUSING, BRAKE13 1 338040 HOUSING, CLUTCH14 1 338270 HOUSING, GEAR15 1 340014 HUB, GEAR16 1 340024 HUB, BRAKE17 1 342024 KEY18 1 342032 KEY19 1 342051 KEY20 2 342120 KEY21 2 450017 KEY, BARTH22 1 352020 PLATE, RETAINER23 1 357466 SHAFT, DRUM24 1 356945 SHAFT, SHIFTER25 1 358001 SHIFTER HANDLE26 1 362007 SPACER, DRUM27 1 368195 WORM, R.H.28 1 370003 YOKE29 1 400003 BALL, POPPET30 1 400007 BALL31 1 402044 BEARING, BALL32 1 402107 BEARING, THRUST33 1 412005 BUSHING34 1 412006 BUSHING

35 4 414111 CAPSCREW, 5/16"-18 X 1" LG HEX HD36 1 414140 CAPSCREW, 5/16"-18 X 3/4" LG HEX HD NYLOK37 7 414141 CAPSCREW, 5/16"-18 X 1" LG HEX HD NYLOK38 6 414283 CAPSCREW, 3/8"-16 X 1-1/4" LG HEX HD39 2 414398 CAPSCREW, 3/8"-24 X 1" LG HEX HD NYLOK40 1 414603 CAPSCREW, 1/2"-20 X 1-3/4" LG HX HD ALL-THD41 6 414865 CAPSCREW, 5/16"-18 X 1" LG HEX SOC HD42 6 414887 CAPSCREW, 5/16"-18 X 1" LG BUTTON HD43 1 414971 SCREW, POPPET 1/2"-20 HD LESS DR SLOT44 1 416059 SETSCREW, 3/8"-16 X 1/2" LG HEX SOC HD45 1 416109 SETSCREW, 5/16"-18 X 1/2" LG SQ HD46 1 416112 SETSCREW, 5/16"-18 X 3/4" LG SQ HD47 1 418067 NUT, 1/2"-20 HEX JAM48 4 418163 LOCKWASHER, 5/16" MED SECT49 6 418176 LOCKWASHER, 3/8" MED SECT50 2 418184 WASHER, FLAT 3/8" ALUM.51 2 442182 GASKET52 1 442190 GASKET53 1 442191 GASKET54 3 456006 FITTING, LUBE55 1 456008 FITTING, RELIEF56 2 462003 QUAD, RING57 1 468002 REDUCER58 2 468011 PIPE PLUG59 1 474004 PLATE60 1 486076 THREAD SEAL61 1 486079 SEAL, PILOT62 1 494005 SPRING63 1 494010 SPRING64 2 494088 SPRING65 2 494089 SPRING66 2 518026 THRUST WASHER67 2 530094 SPACER, BRAKE

VI-26

Section VI - PARTS (cont'd)REAR SPADE HYDRAULICS

1 1 0300011 CONTROL VALVE2 2 0300044 CONNECTOR, 6MJ-6MB3 4 0300689 STREET ELBOW, STEEL, 8MJ-8FP904 2 0301522 CONNECTOR 6MJ-6MB5 4 0301819 NIPPLE, BLACK PIPE, 1/2" X 4-1/2"6 2 0302616 HYDRAULIC CYLINDER7 1 0302782 CONTROL VALVE8 2 0303017 CONNECTOR, 8MB-6FB9 2 0303175 HOSE ASSEMBLY, 102"

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

VI-27

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

Section VI - PARTS (cont'd)HYDRAULIC CYLINDERS

1 2 0303091 BOOM ELEVATION CYLINDER (COMPLETE)2 1 0304535 SEAL KIT, BOOM ELEVATION CYLINDER

1 1 0302614 BOOM EXTENSION CYLINDER (COMPLETE)2 1 0304503 SEAL KIT, BOOM EXTENSION CYLINDER

VI-28

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

Section VI - PARTS (cont'd)HYDRAULIC CYLINDERS

1 1 0302791 CYLINDER, UNDERLIFT TILT (COMPLETE)2 1 0304488 SEAL KIT, UNDERLIFT TILT CYLINDER

1 1 0303331 CYLINDER, UNDERLIFT EXTEND (COMPLETE)2 1 0304534 SEAL KIT, UNDERIFT EXTEND CYLINDER

VI-29

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

Section VI - PARTS (cont'd)HYDRAULIC CYLINDERS

1 1 0301765 CYLINDER, UNDERLIFT FOLD (COMPLETE)2 1 0304244 SEAL KIT, UNDERLIFT FOLD CYLINDER

1 2 0302616 CYLINDER, REAR SPADE (COMPLETE)2 1 0304244 SEAL KIT, REAR SPADE CYLINDER

VI-30

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

Section VI - PARTS (cont'd)GLAD HAND KIT

1 1 0301909 RECEPTACLE BOOT2 2 0301944 GLAD HAND COUPLING3 2 0301945 GLAD HAND PLUG4 2 0301946 BULKHEAD CONNECTOR5 2 0301947 ADAPTER, 1/4" NPM X 3/8" SYN. HOSE6 1 0301948 HD 7-WAY TRAILER CONNECTOR7 2 0400070 SCREW, 1/4"-20 X 1" HEX HD CAP8 2 0400367 NUT, 1/4"-20 HEX NYLOK9 2 0400451 WASHER, 1/4" FLAT10 2 0703795 AIR HOSE, 3/8" X 48" SYNFLEX

VI-31

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

Section VI - PARTS (cont'd)LIFT ADAPTERS

1 2 0200018 FORK, SHORT (3" OPENING)2 2 0200020 FORK, MEDIUM (3" OPENING)3 2 0200021 FORK, MEDIUM (4-1/2" OPENING)4 2 0200023 FORK, LONG (4-1/2" OPENING)5 2 0400585 HAIR PIN COTTER, 1-1/4"6 2 0711001 BOLT, MODIFIED 5/8"-11 X 5" WITH HOLE7 2 0800590 TEE HANDLE, FORK ADAPTER8 1 0802249 FORK ADAPTER, LT9 1 0802250 FORK ADAPTER, RT10 1 0802251 CHAIN HOOK ADAPTER, RT11 1 0802252 CHAIN HOOK ADAPTER, LT12 1 0803580 OFFSET FORK ADAPTER, LT13 1 0803581 OFFSET FORK ADAPTER, RT14 2 0902378 RETAINER PIN ASSEMBLY

VI-32

Section VI - PARTS (cont'd)OUTER CROSSTUBE ASSEMBLY

VI-33

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

Section VI - PARTS (cont'd)OUTER CROSSTUBE ASSEMBLY

1 1 0300113 GREASE FITTING2 2 0300341 KNOB, "L" BAR LOCK CONTROL3 2 0301417 SPRING, PLUNGER PIN4 2 0301681 EXTENSION, TIRE RESTRAINT5 2 0301682 TIRE RESTRAINT6 2 0400269 BOLT, 5/8"-11 X 4-1/2" CARRIAGE7 2 0400393 NUT, 3/8"-16 HEX JAM8 2 0400421 NUT, 5/8"-11 HEX NYLOK9 2 0400506 WASHER, 5/8" FLAT10 2 0400559 PIN, 3/16" X 1" ROLL11 2 0400560 PIN, 5/32" X 1" ROLL12 2 0706688 PIN, PLUNGER13 4 0800590 HANDLE, "T"14 2 0800839 BRACKET, RESTRAINT ASSEMBLY PIVOT15 1 0802069 HANDLE, L.H. PLUNGER PIN16 1 0802070 HANDLE, R.H. PLUNGER PIN17 1 0802231 CROSSBAR, LEFT OUTER18 1 0802232 CROSSBAR, RIGHT OUTER19 2 0802606 TIRE RESTRAINT, MEDIUM

VI-34

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

Section VI - PARTS (cont'd)KING PIN ADAPTER

1 1 0400188 SCREW, 1/2"-13 X 2" HEX HD CAP2 2 0400282 SCREW, 3/4"-10 X 2-3/4" HEX HD CAP3 2 0400316 SCREW, 7/8"-9 X 8" HEX HD CAP4 2 0400440 NUT, 3/4"-10 HEX JAM5 1 0400491 LOCKWASHER, 1/2" HELICAL6 2 0400515 LOCKWASHER, 7/8" HELICAL7 1 0706623 ADAPTER, TRAILER KING PIN (NOT SHOWN)8 1 0802961 BRACKET WELDMENT9 1 0802962 LOCK PLATE WELDMENT

-- -- 0902782 FIFTH WHEEL ADAPTER (COMPLETE)10 1 0400303 SCREW, 7/8"-9 X 2-1/2" HEX HD CAP11 1 0400555 ROLL PIN, 3/8" X 1-1/2"12 2 HD1259 PIN SNAPPER13 1 VA0660 FIFTH WHEEL PIVOT PLATE WELDMENT14 1 VA0661 PULL PIN WELDMENT15 1 VA0662 PIVOT PIN WELDMENT

VI-35

Section VI - PARTS (cont'd)LIGHT KIT

1 4 0302542 LIGHT, STOP & TURN ( COMPLETE)2 2 0302543 LIGHT, BACK-UP (COMPLETE)3 24 0400025 SCREW, #8-32 x 3/4" RD HD SLOTTED

REF. NO. PARTNO. REQ'D NUMBER DESCRIPTION

(A) STOP/TURN/BACKUP LIGHTS

VI-36

Section VI - PARTS (cont'd)LIGHT KIT

1 0300442 3-LIGHT BAR ASSEMBLY (COMPLETE)2 0300507 BULB, MARKER LIGHT3 0200511 LENS, 3-LIGHT BAR

1 0301390 LIGHT, TURN (COMPLETE)2 0304123 BEZEL MOUNTING SCREW3 0304124 CHROME BEZEL4 0304125 LENS & BULB ASSEMBLY5 0304126 GROMMET & PLUG KIT

REF. PARTNO. NUMBER DESCRIPTION

(B) 3-LIGHT BAR

REF. PARTNO. NUMBER DESCRIPTION

(C) STOP & TURN LIGHT

VI-37

REF. PARTNO. NUMBER DESCRIPTION

Section VI - PARTS (cont'd)LIGHT KIT

1 0302544 LIGHT, DOME (COMPLETE)

1 0302201 LIGHT, FLOOD (COMPLETE)

(D) FLOOD LIGHT

(E) DOME LIGHT

VI-38

REF. PARTNO. NUMBER DESCRIPTION

REF. PARTNO. NUMBER DESCRIPTION

Section VI - PARTS (cont'd)LIGHT KIT

1 0301740 GROMMET & PLUG, MARKER LIGHT2 0301741 SEALED MARKER LIGHT, RED3 0301742 SEALED MARKER LIGHT, AMBER

1 0300076 BRACKET, LICENSE PLATE2 0300273 LICENSE PLATE ILLUMINATOR (COMPLETE)3 0300512 BULB, LICENSE PLATE ILLUMINATOR

(F) MARKER LIGHTS

(G) LICENSE PLATE BRACKET & ILLUMINATOR

VI-39

Section VI - PARTS (cont'd)LIGHT KIT

1 0302611 LIGHT, AMBER MARKER (COMPLETE)

REF. PARTNO. NUMBER DESCRIPTION

(H) OVAL MARKER LIGHT

NOTES

NOTES

Miller Industries Towing Equipment Inc.8503 Hilltop Drive • Ooltewah, Tennessee 37363 • (423) 238-4171

www.millerind.com


Recommended