Top fill indicator light on pump panel not working. Tank is full. Lights in cab OK. Swapped bulbs and still not working. SB1 AT STA26
Problem? Parts
1. TRAVELED TO STN 22. R/R PUMP PANEL LIGHT TEST- OK.
Task performed:
4Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V4811
Meter Reading:Close Date:
In Date:Quantity
10/09/200610/27/2006
SPARE BRUSH TRUCK, PUMP PACKING LEAKING WATER. PUMP HARD TO START, BATTERY B-17
Problem? Parts
1. TRAVELED TO STN 17. REPACK PUMP, TEST ADJUSTED CARB. TEST RUN OK.
Task performed:
Workorder: V5216
Meter Reading:Close Date:
In Date:Quantity
28,561.0011/02/200611/06/2006
A INSPECTION AND REPAIRS AS NEEDED S B BACK FROM 17
Problem? Parts
1. TRAVELED TO STN 17. WAIT FOR CREW TO CHANGE OUT VEHICLE. RETURN WITH SPARE BRUSH TO SHOP. 2. PERFORM "A" INSPECTION. 3. REPAIR L-1 COMPARTMENT LIGHTING. 4. INSTALL WIPER BLADES. 5. REPAIR ROOF WATER LEAK- REMOVE HEAD LINER ECT... 6. INSTALL NEW CAB DOOR WEATHER STRIPPING AROUND BOTH DOOR- NOTE: THESE DOORS ARE BENT AND TWISTED- CAN NOT BE STRAIGHTENED - REPLACE ONLY - (BOTH DOORS)- TRYED TO STRAIGHTEN -(NG).
Task performed:444058C2DOOR SEAL 2
91-14WIPER BLADE 2
9118-04SWITCH 1
A06-31083-000BATTERY CABLE POS 1
JEIBC207M2BWJEIBC207M2BWS CABLE BATT 1
5Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V4799
Meter Reading:Close Date:
In Date:Quantity
10/09/200611/07/2006
SPARE BRUSH-PUMP HARD TO START PUMP SEAL LEAKING WATER B-17
Problem? Parts
1. see wo# 4811, work completed under that wo
Task performed:
Workorder: V5842
Meter Reading:Close Date:
In Date:Quantity
2,543.0012/17/200612/18/2006
fire pump won't start B32
Problem? Parts
Task performed:24-60BATTERY GROUP 24 1
BATTERY EPA TAXBATTERY EPA TAX $1.50 PER BATTERY 1
Workorder: V5958
Meter Reading:Close Date:
In Date:Quantity
2,543.0012/26/200601/03/2007
brush truck won't start B32
Problem? Parts
Task performed:BATTERY EPA TAXBATTERY EPA TAX $1.50 PER BATTERY 2
HP-31DBATTERY 950CCA HP-31D 2
6Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V5937
Meter Reading:Close Date:
In Date:Quantity
2,543.0012/23/200601/05/2007
emergency light out on left side of lightbar mounted on the top of the truck SB AT 32
Problem? Parts
1. Repaired broken wire in light bar socket for bulb
Task performed:
Workorder: V6389
Meter Reading:Close Date:
In Date:Quantity
28,721.0001/21/200701/29/2007
pump leaking, hose reel not working, light bar needs a light this is for the brush truck the assest number will not work in computer SPARE BRUSH AT 32
Problem? Parts
1. TRAVELED TO STN 32. FOUND SUCTION HOSE NO GOOD. BC WILL ORDER NEW HOSE.
Task performed:
Workorder: V6433
Meter Reading:Close Date:
In Date:Quantity
2,551.0001/23/200701/29/2007
Spare brush truck won't hold a draft. Hard suction hose may be the problem. It is old and dry rotted. Truck pumps ok from the tank. Truck pulls the draft ok, but won't hold it. Thanks. sb at 32
Problem? Parts
1. TICKET CLOSED ON TICKET # 6389.
Task performed:
7Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V6434
Meter Reading:Close Date:
In Date:Quantity
2,551.0001/23/200701/29/2007
Float a Pump has several holes in the plastic and tends to sink. Also, very little water discharged by this pump. Seems to have a leak in the pump. Thanks. S B AT 32
Problem? Parts
1. TRAVEPED TO STN 32. REPAIRED FLOAT-O-PUMP.
Task performed:
Workorder: V7038
Meter Reading:Close Date:
In Date:Quantity
2,557.8003/02/200703/07/2007
float pump oil reservoir appears to have water in it (milky white color on dip stick)
Problem? Parts
Drained oil from truck and refilled
Task performed:
Workorder: V7027
Meter Reading:Close Date:
In Date:Quantity
28,765.0003/02/200703/08/2007
adjust pump packing sb at 32
Problem? Parts
Readjusted pump packing
Task performed:
8Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V7140
Meter Reading:Close Date:
In Date:Quantity
2,557.8003/10/200703/19/2007
Right rear tailight bulb out. one of the top beacon bulbs is also out. SB AT32
Problem? Parts
Replaced bulb in RR stop light
Task performed:
Workorder: V7274
Meter Reading:Close Date:
In Date:Quantity
2,579.0003/19/200703/23/2007
hose reel does not work sb at 32
Problem? Parts
1. Replaced hose reel motor 2. Replaced mirror
Task performed:99230015BRACKET HANNAY REEL MOTOR 1
P56AN227MOTOR HOSE REEL 1
Workorder: V7277
Meter Reading:Close Date:
In Date:Quantity
2,579.0003/19/200703/23/2007
oil leaking from front differential SB AT 32
Problem? Parts
Sent truck to shop
Task performed:
9Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V7367
Meter Reading:Close Date:
In Date:Quantity
28,984.0003/26/200704/04/2007
B inspection and repairs as needed SB back from 32
Problem? Parts
B-Inspection Corrosion on batry term; ness to rem term/clean/install felts on truck & pump btrys. Svc air dryer; install alt belt on pump motor. Rotate tires; rem frnt drums & inspect brakes. Rem rear drums; replc brakes & drums; adjust. Frnt diff leaking @ pinion seal; ness to rem drive shaft & flange to replc seal; top off fluid. Rear diff leaking at pinion seal; ness to rem driveshaft & flange to replc seal; top off fluid. Exh pipe band clmp brkn; ness to R/R/ clmp. Hose reel inop; fnd wiring @ swtich brkn; rep connections. Compt door shock weak; ness to replc. Svc coolant sys. Tighten air pump belt. Light bar rotator bulb 10-7. R/R bulb. Steering wheel not centered; pull wheel & test drive & center.
P1108WIX 33336 FUEL FILTER DO NOT USE LUBER-FINER 1
P1120FUEL FILTER 33239 WIX 1
P1654AWIX 51553 HYD. FILTER 1
PH7136WIX 51747 LFP2244 OIL FILTER 2
PR338324070 WIX FILTER WATER 1
RN60JDRYER KIT 1
S3240WIX 33582 FUEL FILTER SPARE BRUSH TRUCK 1
10Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V7864
Meter Reading:Close Date:
In Date:Quantity
29,099.0004/23/200704/26/2007
A inpection and repairs as needed
Problem? Parts
A-inspection
Task performed:
Workorder: V8402
Meter Reading:Close Date:
In Date:Quantity
29,099.0005/23/200705/31/2007
A inspection and related repairs (back from 16)
Problem? Parts
1. A-Inspection road test 2. Had to remove rear tires to check air pressure, tires mounted off set air valves. Change round off lugnouts 3. Transmission oil low - added 1.5 qts of oil 4. Pump will not start - found battery cells dead, removed to install new battery, start and chech charging system and run pump. system poeration normal
Task performed:24-60BATTERY GROUP 24 1
BATTERY EPA TAXBATTERY EPA TAX $1.50 PER BATTERY 1
E-5552-LNUT OUTER L/H R005977L 10
E-5552-RR005977R OUTER CAP NUT 10
Workorder: V8270
Meter Reading:Close Date:
In Date:Quantity
29,099.0005/15/200706/07/2007
Hose reel rewind innop, pump primer innop B16
Problem? Parts
1. Hose reel inop, solinoid bad - rewire, test OK 2. Primer inop, rebuild primer valve - test OK 3. Air horn inop, R/R air valves - test OK
Task performed:24076SOLENOID 1
EL360081760611 SOLENOID AIR HORN 1
11Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V9961
Meter Reading:Close Date:
In Date:Quantity
2,589.6008/16/200708/31/2007
won't start with battery problem sb1 at 16
Problem? Parts
Drive to Stn; chk alt; R/R btry; test system-ok
Task performed:
Workorder: V10244
Meter Reading:Close Date:
In Date:Quantity
29,099.0009/04/200709/20/2007
A inspection and related repairs(back from 16)
Problem? Parts
A-Inspection/road test 2. Tech meeting 3. Low volts; dia sys; fnd corroded terms & brkn grnd strap to chassis/eng; R/R/R all ness components; idle volts 13.5
Task performed:
12Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V11637
Meter Reading:Close Date:
In Date:Quantity
29,100.0011/16/200711/29/2007
b1 inspection and safety related items b34
Problem? Parts
1. Dash bulbs and comp light inop. switch and bulbs/ replaced door switch and blubs. 2. Exhaust bracket broken and modify eng oil skid palte. 3. Exhaust bracket broken and modify eng oil skid palte. 4. B-Insp 5. B-1 Inspection 6. B-1 Inspection 7. Oil leak L/R wheel/ flange gasket/ installed new gasket
Task performed:1615527C4BRACKET - EXH. BOLTS TO TRANS 1
1677004C9133232 FILTER SEPERATOR 0
24-60BATTERY GROUP 24 1
284358GOVERNOR D-2 1
35753EXHAUST CLAMP 3 1/2 1
895478R2GASKET AXEL 1
91-16USE 31-16 WIPER BLADE 2
9118-04SWITCH 1
BATTERY EPA TAXBATTERY EPA TAX $1.50 PER BATTERY 3
CA1596WIX 42253 L/F LAF9545 AIR FILTER 1
E-2436R002436 GASKET-REAR AXLE 1
HP-31DBATTERY 950CCA HP-31D 2
P1108WIX 33336 FUEL FILTER DO NOT USE LUBER-FINER 1
P1120FUEL FILTER 33239 WIX 1
P1654AWIX 51553 HYD. FILTER 1
PH21FILTER OIL 51110 1
PH7136WIX 51747 LFP2244 OIL FILTER 2
PL117GC001OBSOLETE LIGHT INDICATOR 1
13Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V12052
Meter Reading:Close Date:
In Date:Quantity
29,100.0012/13/200712/18/2007
b inspection and repairs as needed sb`1
Problem? Parts
1. "B" inspection 2. Drive engine won't start replace batteries. 3. Pump Engine won't start water in air cleaner. 4. Tune up pump engine, cap, rotor, plugs, wires. 5. Primer 10-7, test -replace solenoid. 6. repair front bumper plate fasteners all broken on deck. 7. Repair switch on pilot valve 10-7, test -replace switch. 8. Exhaust loose, repair exhaust. 9. Replace wiper blades. 10. Tank water putrid clean out and flush tank several times. 11. Front axle leaking, clean and sheck- tighten all fastners all fasteners on pumpkin-leaking from bolts.
Task performed:15W40BSYN OIL BULK QTS 32
1677004C9133232 FILTER SEPERATOR 1
2407124071 SOLENOID 1
35799FLAT CLAMP 4 IN 1
46977FILTER VW CRANKCASE BREATHER 1
7534-B6HSSPARK PLUG 4
91-14WIPER BLADE 2
9412SPARK PLUG WIRES VW 1
BATTERY EPA TAXBATTERY EPA TAX $1.50 PER BATTERY 2
CA140PLAIR FILTER 46094 1
G1FUEL FILTER 33001 1
GB324ROTOR VW 1
GB423CAP DIST. VW 1
HP-31DBATTERY 950CCA HP-31D 2
P1108WIX 33336 FUEL FILTER DO NOT USE LUBER-FINER 1
P1120FUEL FILTER 33239 WIX 1
PH7136WIX 51747 LFP2244 OIL FILTER 2
PR338324070 WIX FILTER WATER 1
S3240WIX 33582 FUEL FILTER SPARE BRUSH TRUCK 1
14Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V12112
Meter Reading:Close Date:
In Date:Quantity
29,100.0012/17/200712/18/2007
repair floatpump sb1
Problem? Parts
Repair float pump - Regan's Small Engine j
Task performed:
Vendor?: REGANS SMALL ENG
Workorder: V7304
Meter Reading:Close Date:
In Date:Quantity
2,579.0003/21/200701/14/2008
Booster Reel rewind motor not working. B32
Problem? Parts
Task performed:VML-S1414FILTER P/S 1
VML-T1264GASKET P/S COVER 1
VML-T1279WASHER P/S 1
Workorder: V15367
Meter Reading:Close Date:
In Date:Quantity
29,100.0005/28/200806/05/2008
A Inspection and repairs as needed
Problem? Parts
A-Inspection j
Task performed:
15Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V20194
Meter Reading:Close Date:
In Date:Quantity
29,100.0001/07/200902/17/2009
B INSPECTION AND REPAIRS AS NEEDED B54
Problem? Parts
16Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
B-Inspection 2. Rem frnt pinion yoke & seal; ordered parts; installed new seal, yoke & drive line; torqued pinion nut to proper torque; added fluid. 3. Chkd all frnt & rear spring hanger bolts for tightness. 4. Replcd exh flex pipe. 5. Replcd air horn swtch & rewired. 6. Adj eng idle & road tested to get warm; adj again-ok. 7. Ordered & installed new signal lens on hood. 8. Replcd holdopens on compt doors. 9. Rep connection to hose reel swtch. 10. Rem "21" from hood; removal put scratches in; clear coat buffed out hood w/light compound; better than it was but still slightly marred. 11. Made brkt & sec hose under body for frnt discharge. 12. Foam fill pump was locked up frm sitting; clnd out pump & pumped water thru several times; filled tank w/foam & flushed ok. 13. Svc cooling sys; replcd upper/lower hose; installed new clamps. 14. Rem F4 discharge elbow/swivel & ordered parts; installed new elbow & made new hose for front discharge. 15. Corners of lite bar inop; & (1) amber light in bar; had to diss bar & rewire all lights; installed new red corner light & test ok. 16. Reprogrammed RR LED light; flash pattern off. 17. Replcd pressure guage in dash. 18. Reroute & sec T-case vent. 19. Svc air dryer. 20. Turn fuel handle for pump motor. 21. Replcd wiper blades. 22. swtch for foam tank swtch; installed upside down. 24. Rep leaks in pump house. 25. Installed reflective stripping on rear of body; sanded/primed/paint rear bumper; added grit tape on step areas. 26. Assist w/reflective tape. 27. Installed decals & tested pump & foam sys. 28. Calibrated foam & water level gauges. 29. Assist Levy w/repairs & set up veh properly. 30. Replcd exh muffler back. j
Task performed:01-0263814-50USE 01-026B807-50 CORNER LED 4500 LIGHT BAR 1
101281021GSS1917UY 90# STRUT-LIFT 4
108-12FBEADED CHAIN W/CONN 12 1
117804HNUT-PINION 1
1647409C1HOSE 1
1647998C2MUFFLER INT BRUSH TK NS 1
1654267C2GRILL BR TK 1
1661761C93TURNSIGNAL LIGHT 1
1661762C93TURNSIGNAL LIGHT 1
1671734C1HOSE 1
20A-400CLAMP 4" 33969 2
20S-35033968 CLAMP EXHAUST LAP JOINT 3.5 2
25-1425-14 WIPER BLADE 2
3157TAIL LIGHT BULBS 2
35799FLAT CLAMP 4 IN 1
414724IN ELBOW 90 DEG 1
635SWIVEL ELBOW 2NPT-1.5NH AKRON 1
75908SWITCH BATTERY MASTER 300A 1
7605-666764-0023 SWITCH FOOT SIREN 1
CA1596WIX 42253 L/F LAF9545 AIR FILTER 1
FREIGHTSHIPPING CHARGES 1
P1108WIX 33336 FUEL FILTER DO NOT USE LUBER-FINER 1
P1120FUEL FILTER 33239 WIX 1
P1654AWIX 51553 HYD. FILTER 1
PH7136WIX 51747 LFP2244 OIL FILTER 2
PR338324070 WIX FILTER WATER 1
RN60JDRYER KIT 1
UMVS254411STRAP 46 IN 1
XE-WLPT1-S0CTANK SENSOR FOR TANK VISION 1
17Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V20690
Meter Reading:Close Date:
In Date:Quantity
29,100.0001/29/200902/19/2009
finish and paint grill (outside agency-Alvin matthews paint & body)
Problem? Parts
Finish & paint grill - Alvin Matthews Paint j
Task performed:
Vendor?: ALVIN MATTHEWS
Workorder: V20862
Meter Reading:Close Date:
In Date:Quantity
29,100.0002/04/200902/28/2009
replace srings total truck
Problem? Parts
Replace springs - Total Truck j
Task performed:
Vendor?: TOTAL TRUCK
18Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V16898
Meter Reading:Close Date:
In Date:Quantity
29,100.0008/07/200803/02/2009
C inspection and related repairs
Problem? Parts
Task performed:1677004C9133232 FILTER SEPERATOR 1
CA140PLAIR FILTER 46094 1
G1FUEL FILTER 33001 1
KN31400VALVE 1
P1108WIX 33336 FUEL FILTER DO NOT USE LUBER-FINER 1
P1120FUEL FILTER 33239 WIX 1
P1654AWIX 51553 HYD. FILTER 1
PH7136WIX 51747 LFP2244 OIL FILTER 2
PR338324070 WIX FILTER WATER 1
S3240WIX 33582 FUEL FILTER SPARE BRUSH TRUCK 1
Workorder: V21184
Meter Reading:Close Date:
In Date:Quantity
30,104.0002/18/200903/03/2009
REPAIR MISC ITEMS B54
Problem? Parts
1. Make up msng hose bed divider & weld onto hose bed; hose bed itself was left unsecured to body; secure hose bed to body. 2. Install hold nettting on equipt side of bed. 3. Travel time-back/forth to Stn54 training on operation of skid unit pump asy & changes made to veh itself; wait on change out. 4. Make up/install more labels (asked for by Stn personnel). 5. Make training video with video dept on operationn of new skid unit pump & foam sys. 6. Load hose in hose bed. 7. Unload eqmt not used on new referb & used for Training. j
Task performed:1684506C1SEAT BELT 1
19Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V21047
Meter Reading:Close Date:
In Date:Quantity
29,100.0002/11/200903/06/2009
replace tires at shop b54
Problem? Parts
Replace tires at shop B54 - Callaghan j
Task performed:
Vendor?: CALLAGHAN
Workorder: V21662
Meter Reading:Close Date:
In Date:Quantity
30,104.0003/09/200903/17/2009
B54 BLOWN HOSE LEADING TO FOAM DIAL OOS 3PM, REPORTED ALREADY
Problem? Parts
Blown hose-fitting bad to foam meter; replcd defective fitting. j
Task performed:
Workorder: V21764
Meter Reading:Close Date:
In Date:Quantity
30,104.0003/12/200903/23/2009
B54 IS LEAKING AIR , NEEDS TIME TO BUILD PSI
Problem? Parts
Chkd for air leaks & fnd none at this time. j
Task performed:
20Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V23541
Meter Reading:Close Date:
In Date:Quantity
2,679.3005/26/200906/19/2009
Needle on RPM gauge on pump is stuck at 6000 rpm. B54 is also leaking oil.
Problem? Parts
RPM gauge needs to be replaced; rep gauge & tested. j
Task performed:25216X30 STRAP 60000 LB 1
Workorder: V24800
Meter Reading:Close Date:
In Date:Quantity
30,408.4007/15/200907/24/2009
REPAIR leak on differental B54
Problem? Parts
1. Axle seal & rear end hsng leaks; rem wheel ends & axles; rem diff & resealed; replc wheel seals & inner/outer axle seals; installed axles & wheel ends. 2. Filled frt diff & road tested; chk for leaks; ok. 3. A-Inspection j
Task performed:1668454C1SEAL OIL SPINDEL 2
1668455C1BUSHING 4
1668458C1STUD 4
593119C91SEAL AXLE HOUS. 2
75W90GEAR OIL SYN QT 16
CR36364416125 NAT SEAL OIL BRUSH TRUCK 2
Workorder: V24761
Meter Reading:Close Date:
In Date:Quantity
30,408.4007/14/200907/28/2009
When we pulled B54 out of bay there was a clear oily puddle on the floor.
Problem? Parts
Oil leak; front input seal leaking; will send to shop. j
Task performed:
21Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V25417
Meter Reading:Close Date:
In Date:Quantity
30,408.4008/10/200908/27/2009
FUEL LEAK, B-54
Problem? Parts
1. Fuel leak; rep fuel filter. 2. Top light bar inop; fnd wires; pull out of light; rep & tested. 3. Pump motor slow starting; rep grnd cable. j
Task performed:
Workorder: V26490
Meter Reading:Close Date:
In Date:Quantity
30,408.4009/28/200910/14/2009
PUMP MOTOR WONT START B54
Problem? Parts
1. recharged rear pump btry. 2. Air leak; fnd fitting on main tank. j
Task performed:
22Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V26718
Meter Reading:Close Date:
In Date:Quantity
30,408.4010/06/200910/19/2009
C INSPECTION AND REPAIRS AS NEEDED B54
Problem? Parts
C-Service 2. "C" Electrical 3. Svc T-case; R/R lube. 4. Rem air dryer; diss/clnd; rebuilt dryer; reassembled/installed all parts; ck opn; ck ok. 5. Drained P/S sys; R/R filter; filled/ck opn; ck ok. 6. R/R alt & air compressor belts. 7. Rem old grip tape on step bars; replcd tape. 8. Rep damaged L-1 door; straightened hinge; drilled/tapped U remntd hinge; tightened other bolts; ck opn; ck ok. 9. Fnd hood spring damaged; rep cable; replcd msng clevis pin; ck ok. 10. Fnd u-bolts loose on axle; had to loosen u-bolts to retorque nuts; torqued all bolts. 11. Fnd door ajar light not working; rep connection at light; diss/greased rotator; ran/ck opn. 12. Steering wheel not aligned; rem wheel/repositioned. 13. Ck exh leak; reposition/tightened exh clamp; ck ok. 14. Ck brake adjustment; adj all brakes. 15. Ck for air leaks; R/R air compressor filter. j
Task performed:15W40BSYN OIL BULK QTS 38
1677004C9133232 FILTER SEPERATOR 1
1814927C1TR22770 BELT 1
5139451394 OIL FILTER MULE 1
9700BELT 2
CA32942714 AIR FILTER 1
P1108WIX 33336 FUEL FILTER DO NOT USE LUBER-FINER 1
P1120FUEL FILTER 33239 WIX 1
PH7136WIX 51747 LFP2244 OIL FILTER 2
PR338324070 WIX FILTER WATER 1
RN60JDRYER KIT 1
VML-S1414FILTER P/S 1
Workorder: V30123
Meter Reading:Close Date:
In Date:Quantity
30,408.4002/22/201003/17/2010
on call battery dead B54
Problem? Parts
Recharged btry & rep wire on alt. j
Task performed:
23Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V30574
Meter Reading:Close Date:
In Date:Quantity
30,408.4003/09/201003/17/2010
Brush 54 is leaking transmission fluid.
Problem? Parts
1 travel to sta 54 check for leak foundit to be coolant from water filter travel to south shopfor filter and coolant found filter over tightend and eas very hard to get off install new filter and recheck
Task performed:PR338324070 WIX FILTER WATER 1
Workorder: V29056
Meter Reading:Close Date:
In Date:Quantity
30,408.4001/12/201003/19/2010
brush 54 leaking pink liquid
Problem? Parts
Fnd no leaks for second time; fnd wtr coming frm soda machine. j
Task performed:
Workorder: V29659
Meter Reading:Close Date:
In Date:Quantity
30,408.4002/02/201003/19/2010
wont start b54
Problem? Parts
Recharged btrys & ran truck. j
Task performed:
24Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V31353
Meter Reading:Close Date:
In Date:Quantity
30,408.4004/07/201005/01/2010
B54 water meter on back of truck and in cab not working.
Problem? Parts
Recalibrated wtr gauges & tested. j
Task performed:WL2000WLA200-A00 WATER TANKVISION OLD FERR # 352000018 1
Workorder: V32456
Meter Reading:Close Date:
In Date:Quantity
30,408.4005/26/201006/11/2010
B INSPECTION out side vendor B54
Problem? Parts
B-Inspection B54 - Oil Change j
Task performed:
Vendor?: OIL CHANGE SVC
Workorder: V33254
Meter Reading:Close Date:
In Date:Quantity
30,408.4006/30/201007/01/2010
B54 has a blown water hose on the pump.
Problem? Parts
Rep brkn wtr line. j
Task performed:
25Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V35022
Meter Reading:Close Date:
In Date:Quantity
30,408.4009/17/201010/20/2010
Air brakes are leaking, take a long time to fill. B54
Problem? Parts
Air leak; fnd air horn solenoid leaking; replcd unit. 2. Belts making noise; adj all belts. 3. Wtr level & foam gauge inop; recalibrated gauges. j
Task performed:EL360081760611 SOLENOID AIR HORN 1
Workorder: V36377
Meter Reading:Close Date:
In Date:Quantity
30,408.4011/11/201011/18/2010
B54 OOS , pressure cupling not holding under pressure
Problem? Parts
5/8" line popping off of fitting at foam cntrl; replc fitting; test pump ovr 150 PSI line secure; btrys ovr 3-years old; replc btrys. j
Task performed:BATTERY EPA TAXBATTERY EPA TAX $1.50 PER BATTERY 2
HP-31DBATTERY 950CCA HP-31D 2
Workorder: V36358
Meter Reading:Close Date:
In Date:Quantity
30,408.4011/10/201012/16/2010
brush truck hesitates when trying to start b54
Problem? Parts
(1) TRAVELED TO ST54 FOR B54 HESITATING WHEN TRYING TO START ENGINE. CHECKED THE BATTERIES, RECHARGED ALL BATTERIES. OK. J.W.
Task performed:
26Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V37404
Meter Reading:Close Date:
In Date:Quantity
30,408.4012/25/201001/10/2011
dead batteries brush truck B54
Problem? Parts
Btrys dead; replc. j
Task performed:BATTERY EPA TAXBATTERY EPA TAX $1.50 PER BATTERY 2
HP-31DBATTERY 950CCA HP-31D 2
Workorder: V36895
Meter Reading:Close Date:
In Date:Quantity
30,408.4012/05/201001/11/2011
Water level gauge reads full at all times. Compass on dash not working. B54
Problem? Parts
Recaliberated wtr level guage. j
Task performed:
Workorder: V37218
Meter Reading:Close Date:
In Date:Quantity
30,408.4012/16/201001/11/2011
1. Water tank indicator light reads full all the time, even when tank is empty! 2. Water is leaking from the bottom of the water tank near the pump. B54
Problem? Parts
1. Recalibrated wtr level gauge. 2. Rep leak at pump will need to come to shop to have rep at B. j
Task performed:
27Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V37527
Meter Reading:Close Date:
In Date:Quantity
30,408.4012/31/201002/07/2011
Water gauge is not working properly and missing intake cap for main intake.
brush truck . water level needs calabration , does not show proper level of water in tank
Problem? Parts
Recalibrated wtr level gauge. j
Task performed:
28Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V39526
Meter Reading:Close Date:
In Date:Quantity
32,815.0003/29/201104/19/2011
C INSPECTION AND REPAIRS AS NEEDED B54
Problem? Parts
29Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
C-Inspection 2. Tank-to-pump plumbing leak. 3. Svc pump motor. 4. Finish tank-to-pump plumbing install; test opn & chk for leaks. 5. Cln corrosion in bulb socket for btry on indicator lite; R/R lens & bulb. 6. L-1 compt lite has no lens; parts dept doesn't stock it; R/R lite asy for new type; drill/tap (4) mtng holes; drill wire hole; extend length of pigtail; install term end & attach to switch. 7. Adj door striker bolt; lube door latch. 8. Tank-to-pump plumbing rep. 9. Continue rep on tank-to-pump plumbing. 10. Air compressor install; assemble ____. 11. Assist Mac w/T-case bushings. 12. Replc fuel line on pump motor. 13. Cooling svc on pump motor. 14. Dryer svc. 15. Trans svc. 16. Rear axle svc. 17. T-case svc. 18. Add washer fluid & concentrate. 19. Replc inner/outer air filters. 20. R/R wiper blades. 21. Test compt open warning sys; no audible alarm, only visual. 22. Frnt shock absorber; rem/install new shock absorber. 23. Frnt brakes good, has 85% material on shoe. 24. Defrost mode inop; dia fault - fnd cable stretched/fray; diss; ____ bad; rem cable asy; calibrate new blend door cntrl panel asy; install cable asy; reassem dash. 25. T-case bushing worn; jack up & support t-case; rem bushing, install new bushing & align t-case; secure t-case & rem supporting jack & lower unit. 26. Door open alarm inop; dia fault - fnd loose grnd & blown bulb; sec loose grnd & replc blown bulb. 27. Tank intake & direct fill caps (2.5) msng; install both caps. 28. Tank empty - fill wtr tank, ck for leaks; no leaks fnd. 29. No brake lite; dia fault - fnd corrosion on brake switch plug; cln plug & rechk; brake lite ok. 30. Chk trans fluid level when hot; fluid level within specs. 31. Replc eng belts. 32. Rem compressor, cooling hoses & oil hose to compressor. 33. Replc R-3 compt lite fixture; drill holes for new style fixture & splice wiring; test ok. j
Task performed:103385NDRAIN COCK 1
12258H1 EIK BULB 55W 1
15W40BSYN OIL BULK QTS 35
1664472C1CABLE DEFROST WHITE 1
1664769C92CONTROL DEFROST 1
1677004C9133232 FILTER SEPERATOR 1
1814927C1TR22770 BELT 1
1891BULB 1
236577GASKET D-2 GOV 1
286528XAIR COMPRESSOR 1
379919HOSE 1
379982FITTINGS 1
46449AIR FILTER GENERATOR LAF8388 ONAN 1
470031C2INSULATOR 4
66605SHOCK 2
7360BELT 1
80351DOME LIGHT 1
820311FUEL FILTER SKID PUMP 1
91-14WIPER BLADE 2
9700BELT 2
BATTERY EPA TAXBATTERY EPA TAX $1.50 PER BATTERY 2
CA1596WIX 42253 L/F LAF9545 AIR FILTER 1
CA1596ASYWIX 42254 1
HP-31DBATTERY 950CCA HP-31D 2
LED100-Q01COMPARTMENT LED LIGHT 1
P1108WIX 33336 FUEL FILTER DO NOT USE LUBER-FINER 1
P1120FUEL FILTER 33239 WIX 1
P1654AWIX 51553 HYD. FILTER 1
PH7136WIX 51747 LFP2244 OIL FILTER 2
PR338324070 WIX FILTER WATER 1
RN60JDRYER KIT 1
S775COUPLER 2
30Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V41402
Meter Reading:Close Date:
In Date:Quantity
33,090.0006/17/201106/20/2011
Broken hose on pump. Sta 16.
Problem? Parts
Travel to 16; fnd split plastic hose for foam sys; replc hose; travel home. j
Task performed:
Workorder: V41575
Meter Reading:Close Date:
In Date:Quantity
33,090.0006/24/201106/27/2011
Broken hose to pump foam system. Sta 54.
Problem? Parts
Travel to scene; fnd brkn hose end at foam regulating valve; cut off hose & installed new fitting; test ok; travel home. j
Task performed:
Workorder: V42287
Meter Reading:Close Date:
In Date:Quantity
33,090.0007/25/201107/26/2011
leak at pump panel.
Problem? Parts
Leak at pump panel; fitting at metering valve blocked; rep leak at pump panel. j
Task performed:
31Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V43856
Meter Reading:Close Date:
In Date:Quantity
33,651.5009/22/201110/14/2011
B54's light box not charging, B54.
Problem? Parts
REPAIRED LIGHT BOX CHARGERS
Task performed:
Workorder: V45679
Meter Reading:Close Date:
In Date:Quantity
33,651.5012/06/201112/27/2011
B INSPECTION OIL CHANGE SERVICES
Problem? Parts
B INSPECTION OIL CHANGE SERVICES
Task performed:
Vendor?: OIL CHANGE SERVICES
32Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V46138
Meter Reading:Close Date:
In Date:Quantity
33,758.0012/28/201101/04/2012
MAKE REPAIRS FROM B INSPECTION B 54
Problem? Parts
REPAIR LOOSE GROUND WIRE ON WINDSHIELD WIPER FLUID PUMP POST SERVICE CHECK COMPLETE AS PER INSTRUCTION TRAVEL TO STATION, REMOVE DAMAGE BRAKE CHAMBER HOSES, TRAVEL TO MACO HOSE AQUIRE SET OF HOSES TO RETURN TO STATION AND INSTALL NEW HOSE FOAM LEAK, DIAGNOSE FAULT, FOUND FOAM FLUSH SECTION VALVE LEAKING OPERATE SYSTEM FLUSH PROCEDURE AS DIRECTED BY PROCEDURES CLEAR LINE NO LEAK AT THIS TIME
Task performed:398705HOSE & FITTING ASSY 1
Workorder: V48676
Meter Reading:Close Date:
In Date:Quantity
33,758.0004/14/201205/11/2012
Driver side Back up light is out.
Problem? Parts
REPAIRED SHORTED WIRE TO BACK UP LIGHT.
Task performed:
33Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V49646
Meter Reading:Close Date:
In Date:Quantity
33,758.0005/26/201206/01/2012
Tried to pump test, passed vaccum test, draft test, but while testing capacity test, pump stoppped working, tempature lite came on. Stopped test, let pump cool down, unable to pump from draft from tank water. Barry. B54
Problem? Parts
RAN PUMP CHECKED OPERATION OF PUMP AND TESTED OK.
Task performed:
Workorder: V52030
Meter Reading:Close Date:
In Date:Quantity
33,758.0008/30/201209/06/2012
Check engine oil, transmission fluid, transfer case and differentials for contamination from high water caused by TS Isaac
Problem? Parts
1.went s54 & check track for water in drive train. 2.assist
Task performed:
Workorder: V52610
Meter Reading:Close Date:
In Date:Quantity
09/24/201210/16/2012
The left reverse light is not working. B 54
Problem? Parts
REPAIRED BULB.
Task performed:
34Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
J032784800 4X4 BRUSH TRUCK
Workorder: V53687
Meter Reading:Close Date:
In Date:Quantity
11/10/201211/13/2012
Requesting green wildland firefighting foam for the brush truck. Requesting a few buckets of the green foam for the brush truck due to Batallion wide training on the brush truck later this week. B54
Problem? Parts
TAKEN CARE OF BY WAREHOUSE.
Task performed:
Workorder: V53681
Meter Reading:Close Date:
In Date:Quantity
11/10/201211/14/2012
No discharge pressure from pump after turning up the throttle and increasing the RPM's. B54
Problem? Parts
PUMP NOT DISCHARGING WATER BOLT FOR TANK TO PUMP LOOSE NOT OPENING REPAIRED TANK TO PUMP LINKAGE TEST OK.
Task performed:1156BULB 10
Workorder: V53686
Meter Reading:Close Date:
In Date:Quantity
11/10/201212/07/2012
Light water panel gauge appears to be broken and possibly needs recalibration. The panel is reading full when the water tank is not full. E54
Problem? Parts
RECALABRATED FOAM GAUGE AND TESTED.
Task performed:
35Page
10/6/2015
Palm Beach County Fire RescueFleet Maintenance Asset History
