of 53
7/30/2019 Para Evaluar Un Candidato de Operador
1/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.2013ii
Mobile Crane Operator
Candidate Handbook
Effective January 1, 2008
Updated 03.18.2013
7/30/2019 Para Evaluar Un Candidato de Operador
2/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.2013ii
7/30/2019 Para Evaluar Un Candidato de Operador
3/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.2013iii
Table of Contents
Welcome ......................................................................................................................................... 5CIC Leadership ............................................................................................................................... 6Introduction ..................................................................................................................................... 8Non-Discrimination Policy ........................................................................................................... 10Accommodations for Disabilities ................................................................................................. 10Eligibility for Certification ........................................................................................................... 11Registration Procedures ................................................................................................................ 12
Overall Process ......................................................................................................................... 12Scheduling Exams ..................................................................................................................... 13Fees ........................................................................................................................................... 14
Written Exams ...................................................................................................................... 14Practical Exams ..................................................................................................................... 15
Rush Registration ...................................................................................................................... 15Rescheduling ............................................................................................................................. 15Credit for Exam Fees: ............................................................................................................... 16Other Service Fees .................................................................................................................... 16Special Requirements for Practical Exams ............................................................................... 17
Examination Administration Procedures ...................................................................................... 17Certification Policy ....................................................................................................................... 18
Exam Programs ......................................................................................................................... 18Supplements .............................................................................................................................. 18Practical Exams Associated with Supplements ........................................................................ 18Certification Cards .................................................................................................................... 18
Confidentiality of Candidate Information ..................................................................................... 19Determination of Passing Scores .................................................................................................. 20Scoring Your Examination ....................................................................................................... 20Eligibility Requirement Policies ................................................................................................... 27
Medical Verification Form ....................................................................................................... 27Code of Ethics Policy................................................................................................................ 29Code of Ethics Agreement ........................................................................................................ 29Substance Abuse Policy ............................................................................................................ 30
Disciplinary Policy........................................................................................................................ 31Appeals Policy and Procedures ..................................................................................................... 32
Appealing Eligibility Determination or Certification Status .................................................... 32Request for Scoring Review ..................................................................................................... 32Disciplinary Appeal .................................................................................................................. 32
Ethics Committee ...................................................................................................................... 33
Content Outline for Written Exams .............................................................................................. 34General Knowledge Exam ........................................................................................................ 34Supplemental Exams ................................................................................................................. 36Sample Exam Questions ........................................................................................................... 38References for Exam Questions.39
Content Outline for Practical Exam .............................................................................................. 41
7/30/2019 Para Evaluar Un Candidato de Operador
4/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.2013iv
Skills Tested Crane Types ..................................................................................................... 41Scoring ...................................................................................................................................... 41Reporting................................................................................................................................... 41Exam Check-in.......................................................................................................................... 42Description of Challenge .......................................................................................................... 42
Crane Familiarization............................................................................................................ 42
Challenge One Measures Accuracy and Depth Perception .................................................. 43Challenge Two Measures Hand-Signals ............................................................................... 43Challenge Three Measures the Ability to Control a Load .................................................... 43
Safety ........................................................................................................................................ 44Exam Delays Due to Weather or Equipment Problems ............................................................ 44
Security Procedures ...................................................................................................................... 45Candidate Security .................................................................................................................... 45Exam Security ........................................................................................................................... 45Exam Security Agreement ........................................................................................................ 46
Recertification Procedures ............................................................................................................ 47Multiple Certifications .............................................................................................................. 47
Notice of Time to Recertify ...................................................................................................... 47Less than 1,000 Hours or Expired Certifications ...................................................................... 48
Appendix ....................................................................................................................................... 49Extension Request Form ........................................................................................................... 51
7/30/2019 Para Evaluar Un Candidato de Operador
5/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.20135
Welcome
Welcome! Your decision to certify through Crane Institute Certification is appreciated. CIC isbacked by over 1,000 years of combined industry expertise and support. CIC is governed bycrane and rigging leaders, manufacturers, crane operators, crane managers, riggers, and safetypersonnel. A list of the CIC leadership follows and is available at
http://www.craneinstitutecertification.com/directors_advisors.php
The CIC support team in Atlanta is here to assist you. If you have questions, requests or ideas onhow we can improve, please contact us.
Email [email protected]
Customer Service - 770.783.9262 for registration, exam or site questions
Thank you,
Debbie Dickinson, CIC Executive Director
http://www.craneinstitutecertification.com/directors_advisors.phphttp://www.craneinstitutecertification.com/directors_advisors.phpmailto:[email protected]:[email protected]:[email protected]://www.craneinstitutecertification.com/directors_advisors.php7/30/2019 Para Evaluar Un Candidato de Operador
6/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.20136
CIC Leadership
The CIC Governing Committee, Advisory Board and Certification Committee members includethe following notable leaders and companies:
Governing Committee
Name CIC Committee & Subject Matter Expertise
(SME)
Company
Anthony Brown Public Awareness, OSHA & Legislative; ASMEB30 Main
A.D. BrownConsulting
Peter Cooke Rigging Committee, Rigging Manufacturing Columbus McKinnon
Robert Cooper Practical Exam Committee, Crane Certifier SE Crane Inspections
William C.Dickinson, Jr.
President, CIC Governing; Co-Chair, PracticalExams; Rigging Committee; Crane & Rigging;
ASME B30 Main Alternate
Crane IndustryServices
Jeff Dudley Item Writing Committee, Contractor; Rigging &Crane Safety
Archer Western
Tim Edwards Public Member; Practical Examiner, CraneOperator Over 75 Tons, CertifiedRigger/Signalperson
Tim EdwardsMachinery MoversLLC, Mid StateEquipment LLC
James Headley Chair, Inspector; Crane Operations & Safety, ASMEB30 Main-retired
Crane Institute ofAmerica &Certification
Dave McElrath Public Awareness, Crane Insurance Provider McElrath Insurance
Keith Morical Testing & Co-Chair Practical Exam CommitteeMember, President of Testing Partner, 4ROI
4ROI
Mike Parnell Secretary/Treasurer, CIC Governing; Chair RiggingCommittee; Co-Chair ASME B30 Main Crane &Rigging Expert;
Industrial TrainingInternational, Inc.
Ron Scott Public Awareness, Safety Inspections, Certification,Legislative
Black Jack Cranes
Paul Zorich Vice President, CIC Governing; Retired ASME B30Main, Operating Engineer
RPZ International
7/30/2019 Para Evaluar Un Candidato de Operador
7/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.20137
Advisory Board
Name CIC Committee & SME Expertise Company
Neil Andrews Lead Technical Specialist; Crane Expert ThyssenKrupp Steel
Paul Boeckman Rigging Committee; Engineering, Rigging
Manufacturer, ASME B30
The Crosby Group
James Cahill Rigging Committee; Engineer Skanska Energy
Robert Cook Public Awareness; Crane Operations Director Pinnacle Refinery
Brian Hope Item Writing Committee; Corporate Safety Manager Caldwell Tanks
Bill Jordan Item Writing Committee; Crane Manufacturing Altec, Inc.
Jerry Klinke Rigging Committee; Crane & Rigging ACRA Enterprises
Henry Lopez Crane Operations Manager; Spanish Chairman Florida CraneInspections, LLC
Jerry Lopez Practical Exam Committee; Trainer Laguna CraneServices, LLC
Wade Pierce Inspector Committee; Maintenance Supervisor Alabama Power
CompanyJeff Roach Practical Exam Committee; Crane Learning
CoordinatorAmerican Elec. Power
Brent Robinson Item Committee; Senior Crane Specialist Alabama PowerCompany
William BillRussell
Practical Exam Committee; Fleet Test Specialist Southern CompanyGeorgia Power
Bill Schofield Practical Exam Committee; Crane OperationsConsultant
Schofield Consulting
Doug Smith Item Writing Committee; Global Director HSETraining and Education
STI Group
Dave Steffens Practical Exam Committee; Construction Industry Lane ConstructionJay Sturm Inspection Committee; Crane Inspections, Safety Crane Aerial Truck
Service
Paul Sweeney Rigging Committee; Crane & Rigging Safety;ASME B30 Main
General Dynamics
Mike Tillery Item Committee; Senior Crane Specialist Southern Company
Matt Trefz Item Writing Committee; Crane Manufacturing Altec, Inc.
Matt Turner Item Committee; Terminal Manager Black Hawk Cranes
Cliff Warren Practical Exam Committee; Crane SafetySuperintendent
Webber LLC
CIC Executive Director
DebbieDickinson
Leadership, Crane Industry Certification Expert Crane InstituteCertification
7/30/2019 Para Evaluar Un Candidato de Operador
8/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.20138
Crane Institute Certification
The Standard in Certification
Introduction
Thank you for choosing Crane Institute Certification (CIC) as your certifying organization. CICcertifies personnel in the crane and rigging industry including:
Certified Crane Operator, Small Telescoping Boom, Under 21 Tons
Certified Crane Operator, Medium Telescoping Boom, 21-75 Tons
Certified Crane Operator, Large Telescoping Boom, Over 75 Tons
Certified Crane Operator, Small Lattice Boom Crawler/Truck, 1-300 Tons Certified Crane Operator, Large Lattice Boom Crawler/Truck, Over 300 Tons
Qualified Rigger and Signalperson Certification
This Candidate Handbook and the CIC website links will:
Guide you through the registration process
Provide the forms you need to complete and submit
Describe your options for certification(s) through CIC
CIC provides NCCA accredited, OSHA recognized certifications.
Crane Operators must pass a General Knowledge Exam, a Supplemental Exam and a PracticalExam for each crane type of certification being requested. Recertification, with documentationof hours of operation, requires a written exam and no practical. Some states or cities havespecific requirements for crane operator licenses. Visit the CIC website atwww.CICert.comfor alist of requirements. Visit the state of city website for most current regulations.
Please read this Candidate Handbook thoroughly and keep it for reference throughout thecertification process.
About CIC and Its PurposeCrane Institute Certification (CIC) is an independent certifying organization. CICs nationallyaccredited crane operator, rigger and signalperson programs are the result of the experience andinput of experts from a broad range of crane-related companies, industry groups, and assessmentexperts. CIC subject matter experts include crane managers for power, construction, and generalindustry; crane operators and supervisors; inspectors; manufacturers; and training professionals.The crane operating experience and wisdom represented by these experts totaling over 1,000years is unparalleled.
http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/7/30/2019 Para Evaluar Un Candidato de Operador
9/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.20139
The purpose of CIC is to save lives, promote safety and to provide the crane industry with moreoptions to obtain accredited certification.
Furthermore, CIC has joined its expertise in the crane industry with the assessment expertise of
4ROI, based in Minneapolis, Minnesota. This ensures the ongoing validity and reliability of itswritten and practical exams as well as a flexible and user-friendly exam administration process.CIC is committed to your success and satisfaction.
If you have further questions after you read the Candidate Handbook, please call CIC at770.783.9262 or e-mail us [email protected]. CIC will be pleased to provide furtherinformation about our certification programs.
mailto:[email protected]:[email protected]:[email protected]:[email protected]7/30/2019 Para Evaluar Un Candidato de Operador
10/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201310
Non-Discrimination Policy
Crane Institute Certification does not discriminate on the basis of race, age, gender, disability,religion, or national origin.
Accommodations for DisabilitiesCrane Institute Certification provides reasonable accommodation to its testing process toindividuals requesting such an accommodation in compliance with the Americans withDisabilities Act (ADA).
It is the responsibility of the candidate seeking an accommodation to complete theRequest forAccommodation Form provided in this handbook and on the CIC website and send it to theaddress provided on the form. Please wait to hear if your accommodation has been grantedbefore registering for the exam(s). Requests may take up to a month to review. The candidatewill have to do the following:
List the exam types for which he is requesting an accommodation Name the disability and when it was first diagnosed
List any previous accommodations provided for the disability
Describe the specific accommodation he is requesting
Provide documentation from a licensed care provider about the history of his disabilityand any past accommodation.
Crane Institute Certification will not grant any accommodation that limits its ability to measurethe ability of an individual to safely operate a crane as defined by the ASME Standards forMobile and Locomotive Cranes, B30.5-2004 or the OSHA regulatory requirements listed in1926.1400.
7/30/2019 Para Evaluar Un Candidato de Operador
11/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201311
Eligibility for Certification
Eligibility for Crane Institute Certification as a Certified Crane Operator includes the following:
Requirement Required Documentation
Be 18 years of age or older Provide government-issued photo ID (i.e., driverslicense, passport) at exam site; CDL licenses may bemandatory in some areas.
Be physically able to operate a crane,per ASME guidelines
Complete and sign theMedical Verification Form
Pass the General Knowledge Examand one Supplemental Exam perdesired crane type
Earn a passing score on written exam(s)
Pass a Practical Exam appropriatefor the crane selected
Earn a passing score on the practical exam
Honor the Crane InstituteCertification Code of Ethics
Read and sign theCode of Ethics Agreement
Adhere to the Crane InstituteCertification Substance Abuse Policy
Read theSubstance Abuse Policyand sign the Codeof Ethic Agreement
Important: Immediately prior to taking the Written Exam, candidates are required to sign theiracceptance ofConfidentiality Policyand theExam Security Agreement. Candidates shouldreview these forms in advance, since they must be signed by the candidate at the time of theWritten Exam to take the written exam.
http://www.craneinstitutecertification.com/pdf_files/physicians_medical_verification_form.pdfhttp://www.craneinstitutecertification.com/pdf_files/physicians_medical_verification_form.pdfhttp://www.craneinstitutecertification.com/pdf_files/physicians_medical_verification_form.pdfhttp://www.craneinstitutecertification.com/code_of_ethics_policy.phphttp://www.craneinstitutecertification.com/code_of_ethics_policy.phphttp://www.craneinstitutecertification.com/code_of_ethics_policy.phphttp://www.craneinstitutecertification.com/substance_abuse_policy.phphttp://www.craneinstitutecertification.com/substance_abuse_policy.phphttp://www.craneinstitutecertification.com/substance_abuse_policy.phphttp://www.craneinstitutecertification.com/confidentiality_policy.phphttp://www.craneinstitutecertification.com/confidentiality_policy.phphttp://www.craneinstitutecertification.com/confidentiality_policy.phphttp://www.craneinstitutecertification.com/exam_security_agreement.phphttp://www.craneinstitutecertification.com/exam_security_agreement.phphttp://www.craneinstitutecertification.com/exam_security_agreement.phphttp://www.craneinstitutecertification.com/exam_security_agreement.phphttp://www.craneinstitutecertification.com/confidentiality_policy.phphttp://www.craneinstitutecertification.com/substance_abuse_policy.phphttp://www.craneinstitutecertification.com/code_of_ethics_policy.phphttp://www.craneinstitutecertification.com/pdf_files/physicians_medical_verification_form.pdf7/30/2019 Para Evaluar Un Candidato de Operador
12/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201312
Registration Procedures
Overall Process
Candidates must complete the following overall process to register for Crane OperatorCertification:
Go towww.CICert.comto find information on the certifications offered.
Select Registration and walk through the registration steps online.
o Set up profile including user name and password.o Register the candidates desired certification.o Select the desired exam location, date, and time.o Purchase the exam using a credit card.
The candidate will then receive a confirmation email that includes the following:
o Location and time for the examo The candidates IDo Instructions for what to bring and what not to bring to the exam siteo Address and map to the siteo Copies of the Confidentiality Policy, Medical Verification Form, and Code of
Ethics Agreement including the Substance Abuse Policy that the candidate will berequired to sign to qualify
o Instructions for emailing a digital photograph for Certification Card
Arrive at chosen exam location.
o Provide government issued photo ID (i.e., drivers license, passport).o Read and sign the Medical Verification Form and Code of Ethics Agreement
(which among other things incorporates the Substance Abuse Policy).
Complete appropriate exam(s).
Review certification status and update contact information atwww.CICert.com. Thesystem also provides updates through emails after every exam.
Receive the CIC Certified Crane Operator card.
Registration is available atwww.CICert.com.
http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.craneinstitutecertification.com/http://www.craneinstitutecertification.com/http://www.craneinstitutecertification.com/http://www.craneinstitutecertification.com/http://www.cicert.com/http://www.cicert.com/7/30/2019 Para Evaluar Un Candidato de Operador
13/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201313
Scheduling Exams
CIC recommends that candidates schedule exams at least 4 weeks in advance. However,candidates may register in as little as 7 days in advance without a rush fee. Registration orrescheduling in less than 7 days incurs a $50 fee per candidate and is not confirmed until the site
approves availability. The registration system that is set up online will show the closest examlocations to the candidate along with the available dates for the exams. Call 770.783.9262 [email protected] assistance.
Technical registration support is available from CIC by telephone and emails Monday-Friday,excluding holidays.
The candidate or the individual registering the candidate (i.e. employer) is responsible formaking sure registration is completed accurately. Be sure to follow directions and read all emailcommunication carefully when registering.
CIC offers certification exams. CIC does not require or provide training for accreditation foreducational programs nor does it provide a course of study that leads to certification. CIC has nolegal or financial or other obligation to organizations it recognizes for training options.
The websitewww.CICert.com, does provide references for gaining knowledge and skills for safecrane operation.
mailto:[email protected]:[email protected]:[email protected]://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/mailto:[email protected]7/30/2019 Para Evaluar Un Candidato de Operador
14/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201314
Fees
The following fees are due during the online registration process and prior to confirmation ofcandidates exam schedule:
Written Exams
PriceInitial Certification or Retest
General Knowledge Exam + 1 Supplement $155General Knowledge Exam + 2 Supplements $165General Knowledge Exam + 3 Supplements $175General Knowledge Exam + 4 Supplements $185General Knowledge Exam + 5 Supplements $195
General Knowledge Exam Only $155
1 Supplement Only $652 Supplements Only $753 Supplements Only $854 Supplements Only $955 Supplements Only $105
Recertification Price
1 Recertification Exam $145
2 Recertification Exams $1503 Recertification Exams $1554 Recertification Exams $1605 Recertification Exams $165
Exam registration fees are not refundable.Candidates have up to a year to take their exam. Candidates, who must reschedule, forany reason, even after the test, do not forfeit exam fees with CIC.
Pricing is for all written tests that are registered at one time and taken on the same day, ifa candidate wants to take tests on different days they will need to register on subsequent
days restarting at the top price category. Certain sites may have a 5 person minimum.
Beginning Spring 2013 requests for paper exams at electronic sites incur a $12.50/examhandling fee.
Written exam site and examiner fees are collected at time of registration for convenience.
If testing site schedule allows for this many exams in one day.
7/30/2019 Para Evaluar Un Candidato de Operador
15/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201315
Practical Exams
The Practical Exam requires the operator to perform tasks similar to those required on the job.
The CIC exam courses are set with the boom at a length appropriate for the capacity and type ofcrane.
CIC allows operators to take one (1) Practical Exam for up to five (5) certifications.However some states and cities have additional requirements. Please check your locationsrequirements or visithttp://www.craneinstitutecertification.com/co_state_or_city_licenses.phpfor more information.
CIC Practical Exam Scoring Fees
One (1) Practical Exam (Crane Operator or Advanced Rigger) $55Operators may retake the Practical Exam up to (3) times/same day.
2nd attempt/same day $653rd attempt/same day $75
Practical Examiner and Site Fees
CIC scoring fees for Practical Exams also include reporting and maintaining records foreach candidate.
Practical Exam Sites and Practical Examiners set their own fees for administering
Practical Exams. Check price with your site and selected examiner when scheduling. Site and examiner fees are charged separately, per the exam site.
Rush Registration
CIC exams can be registered with only 7 days advance notice of the exam date for noadditional fee.
Requests for a rush registrations 6 or fewer days prior to the exam, are made directly withRush Exam Sites.
o Seehttp://www.craneinstitutecertification.com/exam_locations.phpfor a list ofRush Exam Sites.
CIC charges $50/candidate to process rush registrations. Same day scoring requests will incur a fee of $30
CIC cannot guarantee site availability.
Rescheduling
Exams may be rescheduled anytime up to 1 year from the initial registration invoice date.
Exams may be rescheduled at any available exam site.
http://www.craneinstitutecertification.com/co_state_or_city_licenses.phphttp://www.craneinstitutecertification.com/co_state_or_city_licenses.phphttp://www.craneinstitutecertification.com/co_state_or_city_licenses.phphttp://www.craneinstitutecertification.com/exam_sites.phphttp://www.craneinstitutecertification.com/exam_locations.phphttp://www.craneinstitutecertification.com/exam_locations.phphttp://www.craneinstitutecertification.com/exam_locations.phphttp://www.craneinstitutecertification.com/exam_locations.phphttp://www.craneinstitutecertification.com/exam_sites.phphttp://www.craneinstitutecertification.com/co_state_or_city_licenses.php7/30/2019 Para Evaluar Un Candidato de Operador
16/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201316
To reschedule an exam, the buyer simply logs in towww.CICert.com, clicks on theCandidate Exam Site tab, selects the new location, date, and completes payment.
If you need help [email protected] call Customer Service at 770.783.9262
Fees for Rescheduling
If rescheduled 7 or more days in advance the reschedule fee is $25/candidate.
If rescheduled 6 or fewer days in advance of exam, or after the exam, the reschedule feeis $50/candidate plus the written site fee.
No fee is charged when an exam is cancelled or rescheduled by the exam site.
Credit for Exam Fees
An employer may receive credit for CIC processing fees for unused exams if the employee hasleft the company or is deceased. To obtain the credit, the employer must:
1. Notify employee of test and payment cancellation2. Provide employment termination and test cancellation letters [email protected]. Apply for credit at least 7 days prior to the unused test dates [email protected]
770.783.92624. Call 770.783.9262, at least 7 days prior to test date to register new candidate(s) using the
credits5. Pay a $50 change fee plus the written or practical exam site fees6. Use the credit within 12 months of original candidate's test date
A terminated employee may pay or have their new company pay fees for certification andcomplete their certification by calling 770.783.9262
Other Service Fees
Other fees may include Proctor fee for Written Exam or Site/Examiner fee for Practical Exam.Other service fees, if applicable, include:
Type FeeReturned checks, incomplete or late payments (corporate clients only) $30Paper Written Exam fee per exam for electronic sites $12.50Phone registration fee No Charge
Rush Shipment (Paper exams only) $50Duplicate/replacement certification card or request for confirmation ofcertification
$25
http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/mailto:[email protected]:[email protected]:[email protected]:[email protected]:[email protected]:[email protected]:[email protected]:[email protected]:[email protected]:[email protected]:[email protected]:[email protected]://www.cicert.com/7/30/2019 Para Evaluar Un Candidato de Operador
17/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201317
Special Requirements for Practical Exams
The Practical Exam requires the operator to perform tasks similar to those required on the job.The CIC exam courses are set with the boom at a length appropriate for the size and type ofcrane.
Practical Exam Crane Size & Type
Small Telescoping Boom, Under 21 Tons
Medium Telescoping Boom, 21 to 75 Tons
Large Telescoping Boom Over 75 Tons
Small Lattice Boom Crawler/Truck 1-300 Tons
Large Lattice Boom Crawler/Truck Over 300 TonsQualified Rigger & Signalperson
Examination Administration Procedures
When the registration has been successfully completed and payment has been received, CIC willsend an admission email to the candidates registered email address.
The Candidate must provide the Exam Confirmation email to the exam center representative.The Exam Confirmation email includes the address, reporting date and time, the examination(s)registered for, candidate ID, and items the candidate needs to bring:
Exam Confirmation email Government issued photo identification (passport, drivers license) Personal Protective Equipment (such as hardhat and hard sole shoes/boots) to the
Practical Exam only.
No other materials are allowed in an exam site.
The email also provides copies of the forms that the candidate will need to sign at the exam site:
Confidentiality Policy Security Agreement Code of Ethics Policy and Substance Abuse Policy Medical Verification Form (physician statement not required)
The exam location will provide and collect the following:
Blank scratch paper or worksheets and pencils Computer and workstation (if online)
Exam(s) to be taken
Calculator (only those provided by and bearing the Crane Institute Certification logo,which only performs basic math functions. Note: the General Knowledge portion testarithmetic skills without the use of a calculator; the calculator may be used during theSupplemental exam only).
7/30/2019 Para Evaluar Un Candidato de Operador
18/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201318
Exam timeframes are as follows:
90 minutes to complete the 75-item General Knowledge Exam
60 minutes to complete each 30-item Supplemental Exam
45 minutes to complete the Practical Exam.
Candidates are invited to provide feedback on any aspect of the CIC offering (registration,exams, examiners, support, process and pricing) at any time by calling 770.783.9262
Certification Policy
Exam Programs
Crane Institute Certification certifies candidates who pass each of the following:
The General Knowledge Exam One (or more) Supplemental Exam(s)
Practical Exam(s) associated with the selected Supplement(s).
Supplements
Candidates receive load charts from an approved list of load charts relevant to their exam typeand capacity.
Some locations require licenses, in addition to accredited certification. Seehttp://www.craneinstitutecertification.com/news/special-notice-pennsylvania-license-
requirements-for-crane-operators/or contact CIC for assistance or questions in meeting thoserequirements.
Practical Exams Associated with Supplements
In addition to passing the written exams, operators must successfully complete a Practical Examwithin 12 months of passing the Written Exam. Extensions beyond the 12 months are rare andgranted only in extreme cases. To request an extension, read and complete theExtensionRequest Form at the end of this Handbook.
Certification Cards
Candidates earning a passing score on the General Knowledge, Supplemental and PracticalExams required for their selected certification and completing administrative requirements,receive a Certification Card from Crane Institute of America Certification. This card states thatthe NCCA accredited Crane Institute Certification recognizes that operator as a Certified CraneOperator.
http://www.craneinstitutecertification.com/news/special-notice-pennsylvania-license-requirements-for-crane-operators/http://www.craneinstitutecertification.com/news/special-notice-pennsylvania-license-requirements-for-crane-operators/http://www.craneinstitutecertification.com/news/special-notice-pennsylvania-license-requirements-for-crane-operators/http://www.craneinstitutecertification.com/news/special-notice-pennsylvania-license-requirements-for-crane-operators/http://www.craneinstitutecertification.com/news/special-notice-pennsylvania-license-requirements-for-crane-operators/7/30/2019 Para Evaluar Un Candidato de Operador
19/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201319
Confidentiality of Candidate Information
Confidentiality Policy
CIC candidates individual information and results are held strictly confidential by CIC.Candidates maintain this confidentiality by registering their own contact information through theCIC website. A candidate that registers their own certification control access to theircertification status, score results, and Certification Card.
Candidates may choose to give their results to others by:
1. Physically giving their results to another person or party2. Registering contact information different than their own to receive results3. By having an employer or other party, register them for the exam
If candidates want the convenience of having an employers representative register for theirexam, that employer will have access to their exam status, results and Certification Card.
Further, employers, potential employers, regulatory agencies and other interested parties mayrequest the names of operators who are currently certified by Crane Institute Certification.Names of certified operators may be published or provided in response to a written onlinerequest; however, Crane Institute Certification keeps actual scores confidential.
At any time, Candidates may request and receive a duplicate Certification Card. A smallshipping and handling fee will apply for duplicate cards.
Confidentiality Agreement
By signing below, I acknowledge that I have read and agree to this Confidentiality Policy.
Signature: _____________________________ Date: _______ Candidate ID ___________
7/30/2019 Para Evaluar Un Candidato de Operador
20/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201320
Determination of Passing Scores
CIC exams are criterion-referenced exams. This means that pre-determined cut-off scoresmust be reached or exceeded in order for an examinee to pass. This pre-determined score isestablished by experts in the crane industry.
The passing scores for each exam are found in the chart below. Scoring has no relation to theperformance of other examinees; therefore everyone who takes the exam may pass based on theirown performance.
Scoring Your Examination
Our testing partner, 4ROI, scores and records all exams, written and practical. 4ROI sends anemail, with exam score, within 10 business days and immediately for online written exams.Candidates, or the coordinator who registered them on their behalf, may also log in to theiraccount on CICs website and check the status of exams taken.
Crane Type Passing Score Top Possible Score
General Knowledge Exam 50 80
Small Telescoping Boom, Under 21 Tons 50 80
Medium Telescoping Boom, 21 to 75 Tons 50 80
Large Telescoping Boom Over 75 Tons 50 80
Small Lattice Boom Crawler/Truck 1-300Tons
50 80
Large Lattice Boom Crawler/Truck Over300 Tons
50 80
Qualified Rigger and Signalperson 50 80
Once a candidate successfully passes the requirements for certification, 4ROI will mail theCertification Card.
7/30/2019 Para Evaluar Un Candidato de Operador
21/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201321
Sample Score Report for Passing a Written Exam
From: Crane Institute Certification [mail to: [email protected]]Posted At: Thursday, January 24, 2013 10:15 AMPosted To: CICBCC ArchiveConversation: CIC Exam Results for First Last
Subject: CIC Exam Results for First Last
Candidate: First, Middle Initial, Last
Candidate ID: ZZ-99999
Date: 01/24/2013
Site: Site Name
Exam Location: City State Zip
Congratulations, Crane Institute Certification is pleased to inform you that you have PASSED your
Telescoping Boom, Under 21 Tons. This is a major step towards achieving your certification.
CIC will send your Crane Operator Certification Card within two weeks of completing all requirements.If you need to check whether you have fulfilled all requirements you can do one of the following:
If you registered yourself, go directly towww.CICert.comand login using the username andpassword you set up at the time of registration.
If someone else registered you, ask them to checkwww.CICert.com.
Below is a status of your certification. CIC will send your certification card within two weeks ofcompleting all requirements.
Status Requirement
Completed Provide payment
Incomplete Provide photo
Completed Meet age requirement
Completed Sign CIC Medical Verification Form
Completed Sign the Ethics Policy
Completed Sign Confidentiality Form
Completed Sign Exam Security Form
Completed Pass General Knowledge exam
Completed Pass Telescoping Boom Under 21 Tons Exam
Exam Confirmed Pass Small - Telescoping Under 21 Tons Practical
If you have questions go towww.CICert.com, see the CIC Candidate Handbook, or email CIC [email protected], or call 770.783.9262
mailto:mail%20to:%[email protected]:mail%20to:%[email protected]:mail%20to:%[email protected]://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/mailto:[email protected]:[email protected]:[email protected]://www.cicert.com/http://www.cicert.com/http://www.cicert.com/mailto:mail%20to:%[email protected]7/30/2019 Para Evaluar Un Candidato de Operador
22/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201322
Sample Score Report for Failing a Written Exam
From: Crane Institute Certification [mail to: [email protected]]Posted At: Thursday, January 24, 2013 10:20 AMPosted To: CICBCC ArchiveConversation: CIC Exam Results for First Last
Subject: CIC Exam Results for First Last
Candidate: First, Middle Initial, Last
Candidate ID: ZZ-99999
Date: 01/24/2013
Site: Site Name
Exam Location: City State Zip
We regret to inform you that you have NOT passed yourGeneral Knowledge.
Your overall score is 42 and the passing score is 50.
To support your efforts to pass the certification exam in the future the percent of correct responses foreach content area is shown below. Anything less than 100% correct shows room for improvement. Whenstudying to re-take your exam, make sure to focus on the content areas of the exam in which you have alower percentage correct and that make up the largest percentage of the exam. Please use this informationand the resources provided in the Candidate Handbook and atwww.CICert.comto improve yourperformance.
Content Area % Correct % Exam
Setup 82% 25%
Technical 62% 25%
Load Charts 40% 25%
Operation 62% 25%
CIC will send your Crane Operator Certification Card within two weeks of completing all requirements.If you need to check whether you have fulfilled all requirements you can do one of the following:
If you registered yourself, go directly towww.CICert.comand login using the username and password you set up at the time of registration.
If someone else registered you, ask them to checkwww.CICert.com.
When reregistering for an exam please use your existing CIC ID. This will ensure that you receive yourcertification card as soon as all criteria are met.
mailto:mail%20to:%[email protected]:mail%20to:%[email protected]:mail%20to:%[email protected]://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/mailto:mail%20to:%[email protected]7/30/2019 Para Evaluar Un Candidato de Operador
23/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201323
Below is a status of your certification. CIC will send your certification card within two weeks ofcompleting all requirements.
Status Requirement
Invoiced Provide payment
Completed Provide photo
Completed Meet age requirement
Completed Sign CIC Medical Verification Form
If you have questions go towww.CICert.com, see the CIC Candidate Handbook, email CIC [email protected], or call 770.783.9262
http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/mailto:[email protected]:[email protected]:[email protected]://www.cicert.com/7/30/2019 Para Evaluar Un Candidato de Operador
24/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201324
Sample Score Report for Passing a Practical Exam
From: Crane Institute Certification [mail to: [email protected]]Posted At: Thursday, January 24, 2013 8:08 AMPosted To: CICBCC ArchiveConversation: CIC Exam Results for First Last
Subject: CIC Exam Results for First Last
Candidate: First, Middle Initial, Last
Candidate ID: ZZ-99999
Date: 01/24/2013
Site: Site Name
Exam Location: City State Zip
Congratulations, Crane Institute Certification is pleased to inform you that you have PASSED your
Medium Practical. This is a major step towards achieving your certification.
The following crane was used in this examination.
Crane Type: Telescoping Boom 21- 75 Tons
Manufacturer: Altec
Model: AC-38
Max Capacity (tons): 38
Boom Length: 103
Cab Type: Rotating
CIC will send your Crane Operator Certification Card within two weeks of completing all requirements.
If you need to check whether you have fulfilled all requirements you can do one of the following: If you registered yourself, go directly towww.CICert.com and login using the username and
password you set up at the time of registration. If someone else registered you, ask them to checkwww.CICert.com
Below is a status of your certification. CIC will send your certification card within two weeks ofcompleting all requirements.
Status Requirement
Completed Provide payment
Completed Provide photo
Completed Meet age requirement
Completed Sign CIC Medical Verification Form
Completed Sign the Ethics Policy
Completed Sign Confidentiality Form
mailto:mail%20to:%[email protected]:mail%20to:%[email protected]:mail%20to:%[email protected]://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/mailto:mail%20to:%[email protected]7/30/2019 Para Evaluar Un Candidato de Operador
25/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201325
Completed Sign Exam Security Form
Completed Pass General Knowledge exam
Completed Pass Telescoping Boom Under 21 Tons Exam
Completed Pass Telescoping Boom 21-75 Tons Exam
Completed Pass Medium - Telescoping 21-75 Tons Practical
If you have questions go towww.CICert.com, see the CIC Candidate Handbook, email CIC [email protected], or call 770.783.9262.
Sample Score Report for Failing a Practical Exam
From: Crane Institute Certification [mail to: [email protected]]Posted At: Thursday, January 24, 2013 8:08 AM
Posted To: CICBCC ArchiveConversation: CIC Exam Results for First LastSubject: CIC Exam Results for First Last
Candidate: First, Middle Initial, Last
Candidate ID: ZZ-99999
Date: 01/24/2013
Site: Site Name
Exam Location: City State Zip
We regret to inform you that you have NOT passed yourMedium Practical. Your overall score is 65andthe passing score is 70.To support your efforts to pass the test in the future, please use this information and the resourcesprovided in the Candidate Handbook and atwww.CICcert.com to improve your performance. Additionalcrane operation practice and instruction may be helpful. This exam measures the following content areas.
Content Areas % of Test
Ability to Control a Load 50Accuracy and Depth Perception 30Hand Signals 16Crane Safety 4
The first two content areas are also measured in terms of time to complete. The less time it takes tocomplete the challenges the better your score. If you feel that you moved swiftly through the challenges,then you may want to improve your control of the crane. If you feel that you had good control of the craneand load on the challenges, then you may want to work being able to complete the challenges in less time.
http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.craneinstitutecertification.com/pdf_files/candidate_handbook.pdfmailto:[email protected]:[email protected]:mail%20to:%[email protected]:mail%20to:%[email protected]:mail%20to:%[email protected]://www.ciccert.com/http://www.ciccert.com/http://www.ciccert.com/http://www.ciccert.com/mailto:mail%20to:%[email protected]:[email protected]://www.craneinstitutecertification.com/pdf_files/candidate_handbook.pdfhttp://www.cicert.com/7/30/2019 Para Evaluar Un Candidato de Operador
26/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201326
The following crane was used in this examination.
Crane Type: Telescoping Boom 21- 75 Tons
Manufacturer: Altec
Model: AC-38
Max Capacity (tons): 38Boom Length: 103
Cab Type: Rotating
CIC will send your Crane Operator Certification Card within two weeks of completing all requirements.If you need to check whether you have fulfilled all requirements you can do one of the following:
If you registered yourself, go directly towww.CICert.comand login using the username andpassword you set up at the time of registration.
If someone else registered you, ask them to checkwww.CICert.com.
Below is a status of your certification. CIC will send your certification card within two weeks of
completing all requirements.
Status Requirement
Completed Provide payment
Completed Provide photo
Completed Meet age requirement
Completed Sign CIC Medical Verification Form
Completed Sign the Ethics Policy
Completed Sign Confidentiality Form
Completed Sign Exam Security Form
Completed Pass General Knowledge exam
Completed Pass Telescoping Boom Under 21 Tons Exam
Completed Pass Telescoping Boom 21-75 Tons Exam
Failed Pass Medium - Telescoping 21-75 Tons Practical
If you have questions go towww.CICert.com, see the CIC Candidate Handbook, email CIC [email protected], or call 770.783.9262.
http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.cicert.com/http://www.craneinstitutecertification.com/pdf_files/candidate_handbook.pdfmailto:[email protected]:[email protected]:[email protected]://www.craneinstitutecertification.com/pdf_files/candidate_handbook.pdfhttp://www.cicert.com/http://www.cicert.com/http://www.cicert.com/7/30/2019 Para Evaluar Un Candidato de Operador
27/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201327
Eligibility Requirement Policies
Medical Verification Form
Carefully read the ASME B30.5-3.1.2 physical requirements listed below.
1. I have a vision of at least 20/30 Snellen in one eye and 20/50 in the other, with or withoutcorrective lenses.
2. I have the ability to distinguish colors, regardless of position, if color differentiation isrequired.
3. I have adequate hearing to meet operational demands, with or without a hearing aid.4. I have sufficient strength, endurance, agility, coordination, and speed of reaction to meet
crane operation demands.5. I have normal depth perception, field of vision, reaction time, manual dexterity,
coordination, and no tendencies to dizziness or similar undesirable characteristics.6. I have negative results for a substance abuse test. The level of testing determined by the
standard practice for the industry where the operator is employed and confirmed by arecognized laboratory service.
7. I have no physical defects or emotional instability that could render a hazard to myself orothers, or which, in the opinion of the examiner, could interfere with the operatorsperformance. If evidence of this nature is found, it may be sufficient cause fordisqualification.
8. I am not subject to seizures or loss of physical control; such evidence shall be sufficientreason for disqualification. Specialized medical tests may be required to determine theseconditions.
If you do NOT meet any of the eight (8) requirements listed above, but believe that failure tomeet the qualification will not affect your ability to operate cranes:
Select B below
Get a copy of the Physicians Medical Verification Form from CIC
Have it completed by the appropriate physician and returned to CIC
Check A OR B.
A. Passed Physical - By checking this box and signing below, I state that I have passed aphysical exam by a licensed physician within the last three (3) years that affirms my
compliance with the ASME B30.5-3.1.2 (a) medical requirements, and confirm that theabove eight (8) statements are true at this time. Furthermore, I swear that I will have aphysical at least every three (3) years during the period of my CIC certification and if Ido not meet any of the ASME B30.5-3.1.2 requirements that I will stop operatingcranes and notify CIC immediately.
OR
7/30/2019 Para Evaluar Un Candidato de Operador
28/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201328
B. Did Not Pass Physical - By checking this box and signing below, I state that I have notmet the ASME B30.5-3.1.2 (a) medical requirements. I am aware that I must provide aPhysicians Medical Verification form in order to be considered for Crane OperatorCertification. I am also aware that providing a Physicians Medical Verification formdoes not guarantee that I will meet Medical Verification Policy requirements for
certification.
Signature: ____________________________ Date: _______ Candidate ID ____________
Note: CIC will make reasonable accommodations in accordance with ADA guidelines andlimits. Read and complete the Request for Accommodations form in the appendix, if needed.
7/30/2019 Para Evaluar Un Candidato de Operador
29/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201329
Code of Ethics Policy
Code of Ethics Agreement
I agree to uphold a Code of Ethics that includes the following:
1. Using my knowledge and skill to accomplish my work in the manner that best safeguardsmyself, co-workers, employers, the public and the workplace
2. Being honest with employers, the public and co-workers and not willingly misleadinganyone with regard to work experience, skill, experience or capability in operating acrane or the status of certification
3. Promoting competence and prestige of the craning industry by following applicableOSHA Regulations, ASME Standards and Operating Guidelines provided by cranemanufacturers to operate cranes safely and efficiently
4. Working with integrity and without bias regarding race, color, creed, religion, age,gender, national origin, physical ability or ethnicity
Abiding by the Substance Abuse Policy including: Never reporting to work under theinfluence of alcohol, an illegal drug or substance
Never using alcohol or illegal drugs while at work or on any work/job site
Never working while under the influence of alcohol or an illegal drug or substance
Never engaging in the unlawful manufacture, distribution, sale, or possession ofillegal drugs in the workplace
Never abusing prescription drugs
Never operating cranes if taking a prescription drug, if the label, or attendingphysician, recommends not driving or operating machinery. However, I may operate
a crane and take the prescribed medication without an adverse effect on maintainingcertification, when, and if, an attending physician advises that the drug or substancewill not adversely affect my ability to safely perform duties as a crane operator.
For purposes of the Substance Abuse Policy, under the influence means thedetectable presence of any drug or substance in the operators body that impairs theoperators ability to operate the crane safely.
5. Reporting safety and other violations of the Code of Ethics to appropriate personnelwithin their organization.
By signing below, I acknowledge that I have read and agree to comply with the previous six (6)statements.
Signature: ________________________________ Date: _______ Candidate ID __________
7/30/2019 Para Evaluar Un Candidato de Operador
30/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201330
Substance Abuse Policy
Operators seeking certification who sign the Code of Ethics Policy also agree to avoid substanceabuse. In doing so, operators agree to the following:
Never using alcohol or illegal drugs while at work or on any work/job site
Never working while under the influence of alcohol or an illegal drug or substance
Never engaging in the unlawful manufacture, distribution, sale, or possession of illegaldrugs in the workplace
Never abusing prescription drugs
Never operating cranes if taking a prescription drug, if the label, or attending physician,recommends not driving or operating machinery. However, operators may operate acrane and take the prescribed medication without an adverse effect on maintainingcertification, when, and if, an attending physician advises that the drug or substance willnot adversely affect my ability to safely perform duties as a crane operator.
For purposes of the Substance Abuse Policy, under the influence means the detectablepresence of any drug or substance in the operators body that impairs the operators ability tooperate the crane safely.
Violation of the Substance Abuse Policy may result in disciplinary action up to and includingrevoking the operator's certification. Operators should expect their certification to be suspendedor revoked for engaging in the unlawful or unauthorized manufacture, distribution, sale, use orpossession of illegal drugs and use of alcohol in the workplace.
At the sole discretion of the Ethics Committee, an operators certification that was revoked due
to violation of the Substance Abuse Policy may be reinstated under certain conditions.Conditions for reinstatement include, but are not limited to, the following:
Proof of participation in and successful completion of a treatment, counseling orrehabilitation substance abuse program that is professionally run and operated
No other incidents of Substance Abuse Policy violations
Taking the General Knowledge, Supplemental and Practical Exams for newcertification(s).
7/30/2019 Para Evaluar Un Candidato de Operador
31/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201331
Disciplinary Policy
Grounds for disciplinary action may include, but are not limited to the following:Misrepresentation of any information provided to CIC or its representatives
1. Non-compliance with medical requirements2. Non-compliance with Code of Ethics3. Non-compliance with Substance Abuse Policy4. Any infringement of exam security.
Disciplinary action may include one or more of the following: reprimand, revocation ofcertification or potentially civil sanctions. In the event that disciplinary action is taken or decidedupon by the Ethics Committee, an operator may appeal the decision to the Governing Committeewithin 30 days of written notification of the decision.
A written appeal must be sent by traceable courier or certified mail, return receipt requested, tothe Executive Director, at the following address. Specific grounds as to why the appeal should beconsidered must be stated.
Debbie Dickinson, Executive DirectorCrane Institute of America Certification, Inc.P.O. Box 2049Villa Rica, GA 30180
For complete appeals process seeAppeals Policies and Procedures.
http://www.craneinstitutecertification.com/appeals_policy.phphttp://www.craneinstitutecertification.com/appeals_policy.phphttp://www.craneinstitutecertification.com/appeals_policy.phphttp://www.craneinstitutecertification.com/appeals_policy.php7/30/2019 Para Evaluar Un Candidato de Operador
32/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201332
Appeals Policy and Procedures
Appealing Eligibility Determination or Certification Status
Candidates may question their eligibility determination or certification status by writing oremailing the CIC Executive Director who will provide additional explanation. If desired, theCandidate or the Director may refer the matter to the Governing Committee for review andreconsideration, as appropriate. The Governing Committee will make a final determinationwithin thirty (30) day or receipt of the request and provide that decision in writing to theCandidate.
Request for Scoring Review
Multiple safeguards are in place to prevent scoring errors. Candidates who do not pass an exammay request that their exam(s) be reviewed and re-scored by completing an online form titled
Request for Exam Score Review. Requests must be submitted within ninety (90) days of theoriginal result date and a re-scoring fee of $50 per exam requested will be applied for scoringreview
Disciplinary Appeal
An operator may appeal a disciplinary decision by the Ethics Committee to the GoverningCommittee within thirty (30) days of written notification of the decision.
A written appeal must be sent by traceable courier orcertified mail, return receipt requested, to the Governing
Committee c/o the Executive Director Specific groundsas to why the appeal should be considered must bestated.
Candidates may appeal to the Governing Committee ifthey are in disagreement with how a policy is enforcedin their individual case. The Governing Committee shallonly overrule the Ethics Committees recommendationsand conclusions in the event of the following:
The Code of Ethics was incorrectly applied
The findings of facts by the Ethics Committee were clearly erroneous, arbitrary orcapricious and/or disproportionate to the facts surrounding the violation
The disciplinary sanctions imposed by Ethics Committee were grossly disproportionate tothe facts surrounding the violation
New information, relevant and not available at the time of the original decision, isprovided
7/30/2019 Para Evaluar Un Candidato de Operador
33/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201333
In the event that an appeal is timely and properly prepared, the Governing Committee shallconstitute and serve as an Appeals Panel and shall notify the operator of the date and location ofthe appeal hearing. The appeal hearing will be scheduled as soon as possible after receipt of thenotification of appeal. The hearing shall be conducted at the Crane Institute CertificationHeadquarters or another location designated by the Governing Committee. The operator is
responsible for their expenses. The operator has the right to have representation at the hearingbut in no event will counsel be allowed to provide testimony in lieu of, or on behalf of, theoperator.
The hearing is closed to third parties with the exception of witnesses, experts, consultants andlegal counsel. The Governing Committee will consider all evidence provided, including the basisfor the original decision reached by the Ethics Committee.
Ethics Committee
Alleged ethics violations are reviewed by a three member panel of the Ethic Committee. Appeals
are heard by the Governing Committee
Name Expertise CompanyDave McElrath Insurance for Commercial
Crane AccountsMcElrath & Parrish
Anthony (Tony) D. Brown Retired OSHA Crane Work ConsultantPaul Zorich Retired, ASME B30 Main,
Operating EngineerRPZ International
Bill Schofield* Schofield Consulting, Inc. Crane Operations Consultant
* Alternate
Executive Director Address:
Debbie Dickinson, Executive DirectorCrane Institute of America Certification, Inc.P.O. Box 2049Villa Rica, GA 30180Email:[email protected]
mailto:[email protected]:[email protected]:[email protected]:[email protected]7/30/2019 Para Evaluar Un Candidato de Operador
34/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201334
Content Outline for Written Exams
General Knowledge Exam
The General Knowledge Exam tests the knowledge of the candidate in the following areas:
Site Evaluation & Crane Setup 25%
Technical Information 25%
Load Charts 25%
Crane Operation 25%
The exam candidate should be familiar with the following:
Site Evaluation & Crane Setup
1. Roles and responsibilities of all persons involved with the lift2. Factors that impact the lift such as tail swing, load path and clearances3. Impact of various weather conditions4. How to deal with unstable ground and setup on soft surfaces5. Hazards such as overhead obstructions, power lines and underground hazards6. Standards and guidelines regarding various risks and hazards7. ASME standards and OSHA regulations8. Requirements of crane setup such as radii, clearances, crane dimensions and load
dimensions9. Crane setup procedures such as use of outriggers, lifting on rubber and leveling the
crane
10.Site requirements for blocking
Technical Information
11.Crane inspection procedures12.Crane components including the following:
o Engine, air, electrical & hydraulic systemso Chassis & running gear componentso Outriggers and counterweightso Boom components
o Hoisting systemso Operating controlso Operational aids
13.Basic load rigging procedures14.Knowledge of sling and hardware capacity15.Impact of deformities in slings and hardware
7/30/2019 Para Evaluar Un Candidato de Operador
35/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201335
Load Charts
16.Using/Interpreting capacity charts17.Determining lifting capacity, including the following:
o
Configuration of crane mountingo Areas of operation for different types of mobile craneso Boom lengtho Load radiuso Boom angleo Gross capacityo Capacity deductionso Net capacityo Parts of line
18.Conditions that reduce capacities, including the following:
o Crane not to specificationo Crane conditiono Crane levelo Windo Side loadingo Increase in load radiuso Dynamic loadingo Shock loadingo Eccentric reevingo Duty cycle operations
Crane Operation
19.How to enter and exit the cab of the crane in a safe manner20.Procedures for setup and usage of operational aids21.Hand signals or voice signals used to direct crane operator22.Handling loads out of operators sight (operating in the blind)23.How to handle loads submerged in water24.How to move loads from an elevated position25.Duty cycle considerations (i.e., steel erection, concrete bucket operations)26.Traveling the crane27.Heavy lift operations, procedures and types of heavy lift attachments28.Attachments for luffing jibs29.Hoisting procedures and personnel hoisting equipment30.Procedures for securing the crane under standard and emergency conditions.
7/30/2019 Para Evaluar Un Candidato de Operador
36/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201336
Supplemental Exams
The Supplemental Exams test the candidates knowledge with respect to the following cranes:
Small Telescoping Boom, Under 21 TonsMedium Telescoping Boom, 21 75 TonsLarge Telescoping Boom Over 75 Tons, 75-300 and 300+Lattice Boom Carrier, 1-350 Tons and over 350 tonsLattice Boom Crawler, 1-350 Tons and over 350 tons
Supplemental Exams cover the following areas:
Site Evaluation & Crane Setup 5%
Technical Information 15%
Load Charts 40%
Crane Operation 40%
The exam candidate should be familiar with the following pertaining to the particular crane typefor the certification requested:
Site Evaluation & Crane Setup
1. Factors that impact the lift such as tail swing, load path and clearances for a particularcrane type
2. How to deal with unstable ground and setup on soft surfaces3. Standards and guidelines regarding various risks and hazards
4. ASME standards, OSHA regulations and manufacturers guidelines regarding variousrisks, hazards and crane setup
5. Requirements of crane setup such as radii, clearances, crane dimensions and loaddimensions
6. Crane setup procedures such as use of outriggers, lifting on rubber and leveling thecrane
7. Site requirements for blocking
Technical Information
8. Crane components including the following:
o Engine, air, electrical & hydraulic systemso Chassis & running gear componentso Outriggers and counterweightso Boom componentso Hoisting systemso Operating controlso Operational aids9. Basic load rigging procedures
7/30/2019 Para Evaluar Un Candidato de Operador
37/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201337
10.Knowledge of sling and hardware capacity11.Impact of deformities in slings and hardware
Load Charts
12.Using/Interpreting capacity charts13.Calculating lifting capacity, including the following:
o Configuration of crane mountingo Areas of operation for different types of mobile craneso Boom lengtho Load radiuso Boom angleo Gross capacityo Capacity deductionso Net capacityo
Parts of line
14.Conditions that reduce capacities, including the following:
o Crane not to specificationo Crane conditiono Crane levelo Windo Side loadingo Increase in load radiuso Dynamic loadingo Shock loadingo Eccentric reevingo Duty cycle operations
Crane Operation
15.Procedures for setup and usage of operational aids16.Power flows and power transmission for lattice boom cranes17.Basic hydraulic systems for telescoping boom cranes18.Characteristics of Rough Terrain cranes and All Terrain cranes19.Characteristics of All Terrain cranes such as maneuverability and setup20.Duty cycle considerations (i.e., steel erection, concrete bucket operations)21.Traveling the crane22.Heavy lift operations, procedures and types of heavy lift attachments23.Attachments for luffing jibs24.Hoisting procedures and personnel hoisting equipment25.Procedures for securing the crane under standard and emergency conditions.
7/30/2019 Para Evaluar Un Candidato de Operador
38/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201338
Sample Exam Questions
The following sample questions are representative of the type of questions you will encounter onthe CIC written exams:
1. What is the proper procedure when raising long loads from a horizontal position to avertical position?
a. Lift loads away from the crane.b. Lift loads toward the crane.c. Long loads cannot be lifted.d. There is no correct procedure.
2. Boom trucks normally do not have capacities in which operating area?
a. over the sideb. over the frontc. over the reard. Capacity in any operating area is never restricted.
3. If the extension and jib are removed from the crane, what is the deduction?
a. There is no deduction.b. 640 lbs.c. 1,063 lbs.
d. 9,396 lbs.
4. What action can cause the lattice boom to topple backwards?
a. Stopping the boom suddenly while booming downb. Starting a swing suddenly at a low boom anglec. Swinging from the downhill side to the uphill sided. No action will cause the boom to topple backwards.
5. Lifting over the front of a truck crane is not usually allowed unless a front stabilizeris used.
a. Trueb. False
7/30/2019 Para Evaluar Un Candidato de Operador
39/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201339
References for Exam Questions
American Society of Mechanical Engineers. B30.5 - MOBILE AND LOCOMOTIVE CRANES.Publisher: American Society of Mechanical Engineers (ASME).
American Society of Mechanical Engineers P.O. Box 2300Fairfield, NJ 07007-2300
800-843-2763 (U.S/Canada) Fax: [email protected]
American Society of Mechanical Engineers. B30.23 - PERSONNEL LIFTING SYSTEMS.Publisher: American Society of Mechanical Engineers (ASME).
American Society of Mechanical EngineersP.O. Box 2300Fairfield, NJ 07007-2300800-843-2763 (U.S/Canada)Fax: 973-882-1717
Campbell, Douglas. MOBILE CRANING TODAY. Publisher: Operating Engineers TrainingInstitute of Ontario (OETIO).
Operating Engineers Training Institute of Ontario (OETIO)2245 Speers Rd.Oakville, OntarioCanada L6L 6X8(905) 469-9299 or 1-877-793-4863www.oetio.com
Dickie, Donald & Campbell, Douglas. MOBILE CRANE MANUAL. Publisher: ConstructionSafety Association of Ontario.
Construction Safety Association of Ontario21 Voyager Court SouthEtobicoke, Ontario M9W 5M7 CanadaPhone: 800-781-2726; Fax: 416-674-8866www.csao.org
Dickie, Donald. HOISTING AND RIGGING SAFETY MANUAL. Publisher: ConstructionSafety Association of Ontario.
Construction Safety Association of Ontario21 Voyager Court SouthEtobicoke, Ontario M9W 5M7 CanadaPhone: 800-781-2726; Fax: 416-674-8866www.csao.org
mailto:[email protected]:[email protected]:[email protected]://www.oetio.com/http://www.oetio.com/http://www.csao.org/http://www.csao.org/http://www.csao.org/http://www.csao.org/http://www.csao.org/http://www.csao.org/http://www.oetio.com/mailto:[email protected]:[email protected]7/30/2019 Para Evaluar Un Candidato de Operador
40/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201340
Garby, Ronald. IPT'S CRANE AND RIGGING HANDBOOK. Publisher: IPT Publishing andTraining Ltd.
IPT Publishing and Training Ltd.P.O. Box 9590
Edmonton, Alberta, T6E 5X2 CanadaPhone: 780-962-4548; Fax: 780-962-4819www.iptbooks.com
Headley, James. MOBILE CRANES. Publisher: Crane Institute of America Publishing &Products, Inc.
Crane Institute of America3880 St. Johns ParkwaySanford, Florida 32771Phone: 800-832-2726www.craneinstitute.com
Headley, James. RIGGING. Publisher: Crane Institute of America Publishing & Products, Inc.
Crane Institute of America3880 St. Johns ParkwaySanford, Florida 32771Phone: 800-832-2726www.craneinstitute.com
Occupational Health and Safety Administration (OSHA). PART 1926.550 - CRANES ANDDERRICKS. Publisher: US DEPT. OF LABOR.
U.S. Department of LaborOccupational Safety & Health Administration200 Constitution AvenueWashington, D.C. 202101-800-321-OSHA (6742)
www.osha.gov
Occupational Health and Safety Administration (OSHA). PART 1910.180 - CRAWLERLOCOMOTIVE AND TRUCK CRANES. Publisher: US DEPT. OF LABOR.
U.S. Department of LaborOccupational Safety & Health Administration200 Constitution AvenueWashington, D.C. 202101-800-321-OSHA (6742)
www.osha.gov
http://www.iptbooks.com/http://www.iptbooks.com/http://www.craneinstitute.com/http://www.craneinstitute.com/http://www.craneinstitute.com/http://www.craneinstitute.com/http://www.osha.gov/http://www.osha.gov/http://www.osha.gov/http://www.osha.gov/http://www.osha.gov/http://www.osha.gov/http://www.craneinstitute.com/http://www.craneinstitute.com/http://www.iptbooks.com/7/30/2019 Para Evaluar Un Candidato de Operador
41/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201341
Content Outline for Practical Exam
Skills Tested Crane Types
The Practical Exam measures the basic skills needed to safely operate a crane in a controlled
fashion. It does not indicate the ability to operate any crane in any situation.
Practical Exams may be conducted using a crane capable of achieving the specified boom length.The primary concern is that the crane has the appropriate boom length for a typical crane of thattype.
The practical exam measures the following skills:
Operating controls to raise and lower the load
Operating controls to swing boom
Operating controls to raise and lower the boom
Controlling the load Picking and carrying load
Communicating with signaler
Securing the crane
Scoring
Scoring takes into consideration control, time to complete tasks, and knowledge required whileoperating a crane. The particular tasks measured and the proportions of the exam they compriseare as follows:
Accuracy and depth perception 35%
Hand signals 16%
Ability to control a load 50%
Securing the crane 4%
Some challenges are timed. The less time it takes to complete the timed challenges the betteryour score.
Reporting
Practical Exams are scored on a straight Pass/Fail basis by 4ROI. The examiner will not be ableto provide feedback on your performance. However, your result will be sent to you via emailwithin 10 days of completing the exam
7/30/2019 Para Evaluar Un Candidato de Operador
42/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201342
Exam Check-in
When the candidate arrives for the Practical Exam, the examiner will do the following:
Introduce himself Check the candidates government issued ID to verify candidate is person registered for
exam
Verify that the candidate has appropriate PPE (Personal Safety Equipment such as hardhat, hard sole shoes/boots and any PPE specified by a particular exam site)
Give the candidate needed materials (forms to sign, instructions, etc.).
Candidates wait in a waiting area until called to the exam site.
In this waiting area, candidates are provided a minimum of 10 minutes with the following:
Full copy of the crane user manual, OEM specs, and load chart for crane used Practical Exam Course Layout
Task Description.
When the examiner is ready for the candidate, the candidate is:
Escorted to the exam site
Given 15 minutes to become familiar with the crane
Read instructions and provide clarity as needed.
Description of Challenge
Crane Familiarization
You will be given 15 minutes to familiarize yourself with the crane used for the exam.
You may view any component of the crane or operate the crane to obtain the feel of itsoperation, with the following exceptions:
o Do not travel the crane or adjust outriggers, if any.o Do not telescope the boom.
The brakes and LMI are set according to OEM standards. At the end of the familiarization period, you will be asked to sign your examination form
and indicate whether the crane is operating satisfactorily and you wish to take your exam.If you are not ready to take the exam at the end of the 15-minute time, the exam will becancelled and you will not pass.
7/30/2019 Para Evaluar Un Candidato de Operador
43/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201343
Challenge One Measures Accuracy and Depth Perception
The first task requires you to place the headache ball into a 55-gallon drum markedwith a 1.
This is a timed task.
The task is to move the headache ball from the Start Point and place the entire headacheball to the wedge socket, under control, into drum 1.
You do not want to hit or move any part of the course with any part of the hook or ball.
The second task is similar, requiring you to place the headache ball into a different drummarked with a 2.
This is also a timed task.
The task is to move the headache ball from Drum 1 and to place the entire headache ball
to the wedge socket, under control, into Drum 2. You do not want to hit or move any part of the course with any part of the hook or ball.
Challenge Two Measures Hand-Signals
This task requires you to follow the examiners hand signals. You will be given 12 hand signals,and you are required follow them while keeping the headache ball under control at all times.
Challenge Three Measures the Ability to Control a Load
This task requires you to pick-up a load and move it through an obstacle course in a specifiedpattern and place it in a designated spot.
This is a timed activity.
The load must be controlled in terms of height off the ground and clearance of obstacles.
To finish, the load needs to be placed at the designated spot.
7/30/2019 Para Evaluar Un Candidato de Operador
44/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201344
Safety
A candidate will be automatically disqualified if, at the judgment of the examiner, the candidateoperates the crane in an unsafe manner during familiarization or the exam. Examples of unsafeoperation include the following:
Two blocking the crane
Hit crane with any part of the load
Uncontrolled or reckless operation
Action dangerous to personnel or equipment.
Exam Delays Due to Weather or Equipment Problems
If the anemometer indicates that wind speeds exceed 20 mph immediately before or during aPractical Exam, the examiner delays the exam until wind speeds are below 20 mph.
Exams may not start until 30 minutes past official local sunrise at the exam location. Exam stepsmust be completed 30 minutes prior to official local sunset.
Exams will not start, or will immediately stop, if thunder is heard within 30 seconds of lightning.In the event of a thunderstorm, exams may start, or resume, a minimum of 30 minutes after thelast audible thunder.
Exams will not start, or will immediately stop, if precipitation is strong enough to obstruct thecandidates ability to see all materials within the course.
If any weather conditions require the examiner to stop the exam before the candidate completesit but the exam can be completed on the same day, the examiner
Restarts the candidate at the beginning of the task that was in-progress when theexaminer stopped the exam
Allows the candidate the same amount of time, 15 minutes, to become familiar again withthe crane and tasks before restarting the exam.
If weather conditions dictate that the candidate will not be able to start or safely complete theexam on the day registered, the candidate and Exam Site Coordinator reschedule the exam at theearliest convenience at no additional fee. If the Exam Site Coordinator cannot reasonably
accommodate the candidate, the coordinator must contact CIC. At that point, the candidate mayreschedule a new exam on the CIC web site with no additional fee. On the new exam day, thecandidate will start the testing process from the beginning.
7/30/2019 Para Evaluar Un Candidato de Operador
45/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201345
Security Procedures
Candidate Security
Security procedures are mandatory to preserve and protect personal civil rights, business
property rights, and the public trust. Candidates must bring the confirmation email that confirmsthe candidates exam date, location, and Candidate ID on the day of the exam, In addition, thecandidate must provide required identification and meet the requirements forEligibility forCertification
Exam Security
Candidates should not bring, or expect to store, bags and personal items not permitted in theexam area. Items not permitted include cameras, scan or transmitting equipment, cell phones,pagers, beepers, books and paper.
Candidates may not use or bring their own calculators to the exam area. Crane Institute
Certification provides calculators that perform only basic math functions and are used only forsupplemental exams. Since other types of calculators may pose a security risk, only thecalculators provided, at no charge, by Crane Institute Certification are permissible.
Candidates are required to sign theExam Security Agreementbefore taking any Written Exam.
http://www.craneinstitutecertification.com/co_eligibility.phphttp://www.craneinstitutecertification.com/co_eligibility.phphttp://www.craneinstitutecertification.com/co_eligibility.phphttp://www.craneinstitutecertification.com/co_eligibility.phphttp://www.craneinstitutecertification.com/exam_security_agreement.phphttp://www.craneinstitutecertification.com/exam_security_agreement.phphttp://www.craneinstitutecertification.com/exam_security_agreement.phphttp://www.craneinstitutecertification.com/exam_security_agreement.phphttp://www.craneinstitutecertification.com/co_eligibility.phphttp://www.craneinstitutecertification.com/co_eligibility.php7/30/2019 Para Evaluar Un Candidato de Operador
46/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201346
Exam Security Agreement
As a candidate taking a CIC Certification Exam, I, the undersigned, accept responsibility formaintaining the strict confidentiality of all examination-related materials.
I will NOT:
Destroy or deface any exam materials
Take exam materials from the exam room
Make copies, photographs, or notes of exam questions
Discuss, reproduce or communicate exam questions in any form to any other person orentity before, during or after the exam
Use any unauthorized notes or aids during the exam
Cheat in any way, including receiving or giving assistance or copying from anotherpersons exam materials
I have read and understand the terms of this CIC Exam Security Agreement. My signature belowsignifies that I agree to the terms of this agreement without reservation. I understand also thatany violation of this agreement may result in disqualification of my exam(s), revocation of myCIC Certification and civil action.
Signature: ________________________________ Date: _______ Candidate ID _____________
7/30/2019 Para Evaluar Un Candidato de Operador
47/53
2008-2013 Crane Institute of America Certification, Inc. Updated 03.20.201347
Recertification Procedures
Crane Institute Certification certifies mobile crane operators for a period of five years. CraneInstitute Certification welcomes and offers recertification to individuals who have validcertifications. Operators seeking recertification must meet all recertification requirements in the
12 months before the expiration of their current certification. Recertification is valid for five (