Parts Cat 177RG 1971-1978

Cessna

Illustrated Parts Catalog

1971thru1978

MODEL 177RGSERIES

Member of GAMA

THIS CATALOG IS A REISSUE AND SUPERSEDES AND REPLACES ALL 177RGSERIES PARTS CATALOGS, DATED: 1 NOVEMBER 1970 THRU 15 NOVEMBER1978, AND TEMPORARY REVISION 1, DATED 1 MARCH 1995.

COPYRIGHT © 1978CESSNA AIRCRAFT COMPANY

WICHITA, KANSAS, USA 3 MARCH 1997P700-12(RGI-50-11/00)

177RG Parts CatalogINSERT LATEST REVISED PAGES. DESTROY SUPERSEDED PAGES

LIST OF EFFECTIVE PAGES

Dates of Issue for original and revised pages are:

Original ..... 0 ... 3 MARCH 1997

TOTAL NUMBER OF PAGES IN THIS PUBLICATION IS 696 CONSISTING OF THE FOLLOWING:

Page Revision Page Revision Page RevisionNo. No. No. No. No. No.

Title ......... 0 156 thru 166 . 0 318 thru 328 .. 0A .......... 0 167 blank ..... 0 329 blank ..... 0ithruxliii ..... 0 168 thru 208 .. 0 330 thru 332 .. 0xliv blank ..... 0 209 blank ..... 0 333 blank ..... 01 thru 8 ...... 0 210 thru 237 .. 0 334 thru 338 .. 09 blank ...... 0 238 blank ..... 0 339 blank ..... 010 thru 20 .... 0 239 thru 241 .. 0 340 thru 343 .. 021 blank ...... 0 242 blank ..... 0 344 blank ..... 022 thru 40 .... 0 243 thru 248 .. 0 345 thru 352 .. 041 blank ...... 0 249 blank ..... 0 353 blank ..... 042 thru 63 .... 0 250 thru 263 .. 0 354 thru 356 .. 064 blank ...... 0 264 blank 264 blank ..... 0 357 blank ..... 065 thru 88 .... 0 265 thru 274 .. 0 358 thru 363 .. 089 blank ...... 0 275 blank ..... 0 364blank ..... 090 thru 104 ... 0 276 thru 282 .. 0 365 thru 400 .. 0105 blank ..... 0 283 blank ..... 0 401 blank ..... 0106 thru 112 .. 0 284 thru 296 . 0 402 thru 412 .. 0113 blank ..... 0 297 blank ..... 0 413 blank ..... 0114 thru 120 .. 0 298 thru 301 . 0 414 thru 427 .. 0121 blank ..... 0 302 blank ..... 0 428 blank ..... 0122 thru 150 .. 0 303 thru 308 .. 0 429 thru 475 . 0151 blank ..... 0 309 blank ..... 0 476 blank ..... 0152 thru 154 .. 0 310 thru 316 .. 0155 blank ..... 0 317 blank ..... 0

Page A

177RG Parts Catalog

INTRODUCTION. er of the STC. Since STC installations may changesystems interface, operating characteristics and

The information in this publication is based on data component loads or stresses on adjacent structures,available at the time of publication and is updated, Cessna provided inspection criteria may not be val-supplemented, and automaicallly amended by all id for airplanes with STC installations.information issued in Service Newsletters, ServiceBulletins, Supplier Service Notices, Publication This illustrated parts catalog has been prepared toChanges, Revisions, Reissues and Temporary Revi- aid you in easily and quickly identifying parts ofsions. All such amendments become part of and are the models covered herein. The information in thisspecifically incorporated within this publication. catalog is based on data available at the time ofUsers are urged to keep abreast of the latest publication.amendments to this publication through informa-tion available at authorized Cessna service stations This catalog features an index system consisting of:or through the Cessna Product Support subscrip- 1. An alphabetical index located in the fronttion services. Cessna service stations have also of the catalog.been supplied with a group of supplier publications 2. A numerical index located in the back ofwhich provide disassembly, overhaul, and parts the catalog, which lists all parts and fig-breakdowns for some of the various supplier issued ures in which they appear.revisions and service information which may be re-issued by Cessna thereby automatically amending AEROFICHE .. .This catalog has been designedthis publication and are communicated to the field for Aerofiche presentation. To facilitate the use ofthrough authorized Cessna's service stations and/or the catalog for Aerofiche, fiche and frame numbersthrough Cessna's subscription services. have been added to the alphabetical and numerical

indexes. Frame numbers appear at the bottom cen-WARNING: ter of each page. Refer to the header of the applica-

ble fiche for location of various indexing informa-ALL INSPECTION INTERVALS, RE- tion.PLACEMENT TIME LIMITS, OVER-HAUL TIME LIMITS, THE METHOD OF STANDARD PARTS.INSPECTION, LIFE LIMITS, CYCLELIMITS, ETC., RECOMMENDED BY Many parts having standard usage have been incor-CESSNA ARE SOLELY BASED ON THE porated into the Cessna Standard System. Parts inUSE OF NEW, REMANUFACTURED, OR this group are designated with the part numberOVERHAULED CESSNA APPROVED prefix "S".PARTS. IF PARTS ARE DESIGNED,MANUFACTURED, REMANUFAC- For standard hardware items such as TinnermanTURED, OVERHAULED, PURCHASED, nuts, clamps, etc. "AN" and "NAS" numbers haveAND/OR APPROVED BY ENTITIES been used.OTHER THAN CESSNA, THEN THE DA-TA IN CESSNA'S MAINTEN- USABLE ON CODES .... Serial listings in thisANCE/SERVICE MANUAL AND PARTS catalog are noted by a letter code located in the US-CATALOGS ARE NO LONGER APPLI- ABLE ON code column which is the extreme rightCABLE AND THE PURCHASER IS hand column of the parts list page. USABLE ONWARNED NOT TO RELY ON SUCH DA- codes are applicable only to the figure on whichTA FOR NON-CESSNA PARTS. ALL IN- they appear. The code letters and the serials toSPECTION INTERVALS, REPLACE- which they apply are listed at the end of the figure.MENT TIME LIMITS, OVERHAUL TIMELIMITS, THE METHOD OF INSPEC- If no USABLE ON code appears opposite a first col-TION, LIFE LIMTTS, CYCLE LIMITS, umn listing of the figure, the usage is applicable toETC., FOR SUCH NON-CESSNA PARTS all models and serials covered by this catalog. If noMUST BE OBTAINED FROM THE MAN- USABLE ON code appears opposite any indentedUFACTURER AND/OR SELLER OF listing, the usage is applicable to all models and se-SUCH NON-CESSNA PARTS. rials covered by the figure on which it appears.

Inspection, maintenance and parts requirements Bold face type serials appearing on certain figuresfor STC installations are not included in this man- are for quick reference to large blocks of airplanes.ual. When an STC installation is incorporated onthe airplane, those portions of the airplane affectedby the installation must be inspected in accordancewith the inspection program published by the own-

i

177RG Parts Catalog

Reims Aviation serial usage is listed together with A blank entry in the part number column appearsthe Cessna Aircraft Company serial usage imme- before an unprocurable part or installation which isdiately following the parts listing on each individ- also denoted in the "Units Per Assembly" columnual figure where applicable. by the use of the symbol "NP".

NON-INTERCHANGEABLE PARTS.. .. When GROUP ASSEMBLY PARTS LISTparts are not interchangeable with earlier models, ARRANGEMENT.all parts applicable to the particular usage are list-ed. The letter code for the individual part usage is This section lists all replaceable items in the air-listed in the USABLE ON column opposite each plane and these items are detailed on illustrationspart. Care should be exercised in determining prop- throughout the section. The index numbers on theer serial when ordering to insure receipt of correct illustration are keyed to each accompanying partspart. list. The purpose of the index numbers is to provide

complete and positive identificatinn of the article,INTERCHANGEABLE PARTS. .. .When a later but should not be used for procurement purposes.

design part is completely interchangeable with thepart it replaces, both parts will be serialized and the a. The figure and index number column ofnotation "when exhausted use__", or the abbrevia- the parts list shows the figure numbertion, "WEU_" will be entered following the listing once at the beginning of the list. The fig-of the earlier design part. This means that the ear- ure number is followed by a dash and thelier design part should be used on airplanes to indexed number. The remaining indexwhich they apply until the supply of these parts is numbers are preceded by dash only.exhausted- after which time the later design partmust be used. This is done to simplify stocking of b. The part number column identifies theparts by our distributors and authorized Cessna item by part number.service stations. The earlier part is as good phys-ically and functionally, as the later design part- c. In the description column, relationship ofthe difference being the later design part can be items covered is shown by the degree of in-used on more than one block of airplane serials. dention of each item, for example: The

wing assembly (Figure 3) is listed in col-SYMBOLS & PART NUMBER TERMS. (1) of the description column. The

wing structure, is the next lower assemblyNP - The symbol "NP" appearing in the units per and is therefore listed in column (2).

assembly column denotes that the item it appearsopposite is not procurable. d. If two or more assemblies contain a major-

ity of identical parts or the assemblies areAR - The symbol "AR" appearing in the units per left or right hand, the assemblies are list-assembly column denotes "As Required" and is used ed together and the next lower assembliesto indicate bulk quantity where an indefinite or detail parts are listed as common foramount is used. both assemblies, with the differing parts

coded for usage on the correct major as-The following is a list of abbreviations that may ap- sembly.pear in the description nomenclature:

e. Attaching parts are listed immediately be-ALT Alternate Part LH Left Hand neath the item to be attached and preced-ASSY Assembly M/G Main Gear ing any detail parts of the item. They areBHD Bulkhead N/G Nose Gear listed in the same column as the item theyBKI Bulk item PNL Panel attach and are preceded by the captionCOMP Component PRESS Pressure "Attaching Parts". The end of the attach-FSO For spares order RH Right Hand ing parts listing is followed by a separat-FWD Forward SECT Section ing symbol-*-.IND Indicatnr UPR UpperINSTL Installation WEU When Ex. f. The quantity listed in the "Units Per As-

Use sembly" column for attaching parts de-notes the quantity necessary to attach on-

Other key letter symbols spaced apart from and fol- ly one part. Total quantity neccessary tolowing the part nomenclature are for cataloging attach more than one part is obtained byand manufacturing purposes only and are not to be multiplying the attaching parts quantityconsidered by the customer. by the number of parts attached.

ii

177RG Parts Catalog

g. Component parts of the complete airplane RETAIL ORDERS.which are not included in any assembly,but which are used in conjunction with, or Retail orders will not be honored by the factory.attach to certain assemblies, are listed They are to be placed with the Cessna Service Sta-either preceding the first detail or follow- tion or Distributor in the owner's territory anding the last detail of the assembly or in- when received directly by the factory will be for-stallation, and in the same column as the warded to the Distributor from whose territory itmajor assembly or installation. was received. Considerable savings in time will re-

sult for the owner's orders if placed with a Serviceh. The quantities listed in the "Units Per Station or Distributor.

Assembly" column are the quantity usedper figure.

ADDITIONAL PUBLICATIONS.ACCESSORY KITS.

In addition to the information in this Parts Catalog,For accessory kit listings, refer to separate a group of supplier publications is available fromAccessory Kit and Service Kit Index. Cessna Parts Distribution, which describe complete

disassembly, overhaul and parts breakdown ofBULK ITEMS. some of the various supplier equipment items. A

listing of these publications is issued periodically inCertain items such as flexible air hose, rubber the "Customer Care Supplies Catalog" which in-moldings and channels, windshield sealing strips, cludes listings of Autopilots, Avionics Communica-etc., are noted in the catalog listings as bulk items. tions, and Navigation Equipment which are notThese listings also note the cut length of these ma- covered in this manual. These publications areterials for one installation. When an item is listed available from Cessna Parts Distribution, Cessnaas a bulk item, it will be supplied to the service Aircraft Company, 5800 East Pawnee, Box 1521,stations in the most convenient bulk length or Wichita, Kansas 67218 USA.quantity. Reference to the cut length or quantityper installation provides for the most satisfactorydisbursement to the customer.

HOW TO ORDER. Cessna Aircraft Company reserves theright to cancel, add or change the parts

USE YOUR CATALOG TO ORDER PARTS. Use and assemblies described in the catalogthe Parts and Accessories Order Form, which will without notice.be supplied by Cessna on request. Give completeinformatinn on addresses and make sure the partnumber and part name are as shown in the catalog.Be sure to specify quantities. Specify how the orderis to be shipped, otherwise it will be sent out in themanner that seems best to the shipper.

SERIAL, COLOR, & CORROSIONPROOFING.

Be sure to indicate. model and serial number of theairplane. Serial number is very important to prop-erly identify parts used on each airplane. When col-or is involved, refer to "Upholstery & Interior Trim"section for example. If corrosion proofing is desired,add the letters "CO" following the part number.

DISTRIBUTOR ORDERS.

Distributors will send all orders to the factory withinstructions as to the shipping destination. The fac-tory prefers not to make C.O.D. shipments for thedistributor, and all billing will be made to the dis-tributor in the case of direct shipments.

iii

177RG Parts Catalog

IMPORTANT INFORMATION CONCERNINGKEEPING CESSNA PUBLICATIONS CURRENT

This Publication is kept current in two ways:

1. REVISIONS/CHANGES.

Revisions/changes are issued for this publication as required and in-clude only pages that require updating.

2. REISSUE.

A reissue is issued as required, and is a complete manual incorporat-ing all the latest information and outstanding revisions/changes. Itsupersedes and replaces previous issue(s).

REVISIONS/CHANGES and REISSUES can be purchased from an authorizedCessna Service Station or directly from Cessna Parts Distribution, Cessna Air-craft Company, 5800 East Pawnee, Box 1521, Wichita, Kansas 67201 USA.

The Cessna Customer Care Supplies and Publications Catalog is also availablefrom an authorized Cessna Service Station or directly from Cessna Parts Dis-tribution, Cessna Aircraft Company, 5800 East Pawnee, Box 1521, Wichita,Kansas 67201 USA. This catalog lists all publications and Customer Care Sup-plies available from Cessna for prior year models as well as new products.

CUSTOMER COMMENTS ON MANUAL

Cessna Aircraft Company has endeavored to furnish you with an accurate, use-ful, up-to-date manual. This manual can be improved with your help. Pleaseuse the return cards, provided with your manual, to report any errors, discrep-ancies, and omissions in this manual as well as any general comments you wishto make.

iv

177RG Parts Catalog

"All aircraft, regardless of manufacturer, are certificated under model number designations. However,popular names are often used for marketing purposes. To provide a consistent method of referring to thevarious aircraft, model numbers will be used in this publication unless names are required to differentiatebetween versions of the same basic model. The following table provides a cross reference listing of popularname vs. model numbers."

SERIALSNAME MODEL YEAR MODEL

BEGINNING ENDING

1972 177RG 177RG0213 177RG0282CARDINAL RGII 1973 177RG 177RG0283 177RG0432

1974 177RG 177RG0433 177RG05921975 177RG 177RG0593 177RG07871976 177RG 177RG0788 177RG10511977 177RG 177RG1052 177RG12661978 177RG 177RG1267 177RG1366

1971 F177RG F177RG0001 F177RG00421972 F177RG F177RG0043 F177RG0062

CARDINAL RG 1973 F177RG F177RG0063 F177RG0092

1975 F177RG F177RG0123 F177RG01381976 F177RG F177RG0139 F177RG01601977 F177RG F177RG0161 F177RG0177

MODEL 177RG

FINISH & TRIM PLATE1971 THRU 1977

177RG0001 THRU 177RG1266

The "FINISH AND TRIM" plate is located on the left side of the airplane on the forward doorjamb directly above the aircraft identification nameplate.

This plate indicates the model year, interior color scheme and the exterior paint combination.

The following diagram is an example showing the sequence and definition of each code symbolon the "FINISH AND TRIM" plate.

Interpretation of information stamped on the Finish and Trim Plate is obtained by use of theColor Code Chart for the respective year.

COMBINATION CODE *YEAR CODE

OPTIONAL CARPET (BLACK)

INTERIOR COLOR CODE

FINISH AND TRIM NUMBER1 = 1971 Model Year

AF = Clove Brown Interior Scheme (Fabric)AV = Clove Brown Interior Scheme (Vinyl)

B = Black Carpet (Optional)171V = Vestal White, Butterscotch & Italian Gold Exterior171L = Luster White, Butterscotch & Italian Gold Exterior

*Standardized arctic color reversal is designated by theprefix "R" on the exterior color combination code.

vi

FINISH & TRIM PLATE1978 & ON

177RG1267 & ONThe "FINISH AND TRIM" plate is located on the left side of the airplane

on the forward door jamb directly above the aircraft identification nameplate.

This plate indicates model year, interior color scheme and the exteriorcolor combination.

Interpretation of information stamped on the Finish and Trim Plate isobtained by use of the Color Code Chart for the respective year.

Color Code Charts for yearly models appear on pages immediately followingthis page.

The Finish and Trim Plate is explained below. Explanatory remarks arekeyed to the illustrated example.

First column number indicates year.

Second column letter or letters indicate interior color code of aircraft.

The letter B following the interior code indicates optional black carpet.

Fourth column letter indicates overall exterior color.The letter "A" indicates bare aluminum for overall color.

First letter following hyphen indicates major stripe color.

Second letter following hyphen indicates accent color.

* Special exterior and/or interior is denoted by the letters "SP" in lieuof the standard codes.

Interpretation of the example Finish & Trim code 8 AF B W-FJthat is obtained from the 1978 Color Code Chart is:

8 = 1978 model yearAF = Chestnut Brown interior scheme

B = Optional Black CarpetW = Vestal White overall exterior paintF = Pecan Brown major stripe paintJ = Jaguar Yellow accent area paint

vii

MODEL 177RG

MODEL 177RG PAINT CODE CHART MODEL77RG

BLACK BLACK BLACKSEMI-GLOSS SEMI-GLOSS SEMI-GLOSS SEMI-GLOSS VESTAL WHITE BUTTERSCOTCH ITALIAN GOLD

AF Clove Brown (LAQUER) (LAQUER)

CLOUD GRAY CLOUD GRAY CLOUD GRAY CLOUD GRAY(LACQUER) (LAQUER) (LAQUER) (LACQUER)

VESTAL WHITE

BF LIGHT GRAY LIGHT GRAY LIGHT GRAY LIGHT GRAY(VINYL) (VINYL)

CE17SV

BV176V

.CF CV I DF I DVBLACK BLACK BLACK BLACK VESTAL WHITE GLODENRODCF

CV Picnic Green9

LIGHT GRAY

GREEN GREEN REDDV (LAQUER) (LACQUER) (LACQUER) (LACQUER)

EL FL DL HL

C

DUL BLACK DULL BLACK DULL BLACK DULL BLACK

FL

CLOUD GRAY CLOUD GRAY CLOUD GRAY CLOUD GRAY -(LACQUER) (LACQUER) (LACQUER) (LACQUER)

DL

NOTE WHEN ORDERING PAINT SPECIFY CES054 DASH NUMBER. EXAMPLE CES054-156 * NOTE-LACQUER PAINT USED ON FRENCH MODELS

viii

MODEL 177RG PAINT CODE CHART MODEL 177RG

YEAR INTERIOR INTERIOR PAINT SERIAL EXTERIOR PAINTCODECODE COLOR AF & A V B CF & AV C DF & DV LISTING CODE COLOR

BLACK BLACK BLACK BLACK VESTAL WHITEAF JAVA GOLD

(LACQUER) (LACQUER) (LACQUER) (LACQUER)

C(LACQUER) (LACQUER) (LACQUER) (LACQUER)

CF

C(LACQUER) (LACQUER) (LACQUER) (LACQUER)

CLOUD GRAY (LACQUER) (LACQUER) (LACQUER) (LACQUER) THRU

CLOUD GRAY CLOUD GRAY CLOUDRAY CLOUD GRAY

INTERIOR PAINT

2HL PALOMINO TAN SEMI-GLOSS SEMI-GLOSS

LEATHER(LACQUER) (LACQUER) (LACQUER) (LACQUER)

AV JAVA GOLD CLOUD CRAY CLOUD CRAY CLOUD CRAY CLOUD GRAYVINYL


BV BOGATA BLUEBV

DULL BLACK DULL BLACK DULL BLAC DULL BLACK


CV CYPRUS GREEN

CLOUD GRAY CLOUD GRAY CLOUD GRAY CLOUD GRAY

ix

MODEL 177RG3


YEAR INTERIOR PAINT SERIAL EXTERIOR PAINTCOLOR

FL

3HL PALIMINO TAN EL 2

CLOUD GRAY

BV

DV


DULL BLACK

4 CVBLACK

DV

AL

EL Cloud Gray

FL

-x


YEAR INTERIOR INTERIOR PAINT SERIAL EXTERIOR PAINTYEAR COLOR

CFG SAME AS CF EXCEPT SEATS ARE OLD GOLDDFA SAME AS DF EXCEPT SEATS ARE CHESTNUT BROWNGFC SAME AS GF EXCEPT SEATS ARE OLIVE GREEN

xi

MODEL 177RG


YEAR INTERIOR INTERIOR PAINT SERIA EXTERIOR PAINTCOLOR

AF

CF

AL

TOPAZ GOLD

EL

TOPAZ GOLD

NOTE: WHEN ORDERING PAINT SPECIFY CES1054 DASH NUMBER. EXAMPLE: CE1054-

xii


YEAR INTERIOR PAINT SERIAL EXTERIOR PAINTCOLOR INTERIOR COLOR CODE LISTING

DULL BLACK DULL BLACK DULL BLACK DULL BLACKCFCF

VESTAL WHITE SPANISH BRONZE TROPICAL ORANGE719 CES1054-

DF(VINYL)

GF Topaz GoldGF

HF F---- (LACQUER) (LACQUER) 724

AV VinylCHESTNUT SAPPHIRE

BV

Vinyl BLACK BLACK BLACK BLACK VESTAL WHITE TROPICAL ORANGE

7

CLOUD GRAY CLOUD GRAY CLOUD GRAY CLOUD GRAY

AL

DL

(LACQUER)EL Cloud Gray

TOPAZ GOLD POPPY RED

FL

MODEL 177RG

177R1267 & ON 1978 PAINT CODE CHARTINTERIOR COLOR & PAINT EXTERIOR PAINT

CODE COLOR LACQUER VINYL CODE MODIFIED URETHANE

AF CHESTNUT BROWN CHESTNUT BROWN VESTAL WHITEVINYL & FABRIC CES1054-B41 CES1054-B42 W CES1054-C53

BF DUTCH BLUE DUTCH BLUE DUTCH BLUE FLAG REDVINYL & FABRIC CES1054-C22 CES1054-C23 CES1054-C43

CF COLONIAL GREY COLONIAL GREY COLONIAL GREY SATIN BLUEVINYL & FABRIC CES1054-C26 CES1054-C27 C CES1054-C44

GF MAIZE MAIZE FLEET BLUEVINYL & FABRIC CES1054-C34 CES1054-C35 CES1054-C45

HF HUNTER RED HUNTER RED HUNTER RED E VILLA GREENVINYL & FABRIC CES1054-A85 CES1054-A86 CES1054-C46

AV CHESTNUT BROWN CHESTNUT BROWN PECAN BROWNVINYL CES1054-B41 CES1054-B42 F CES1054-C47

BV DUTCH BLUE DUTCH BLUE DUTCH BLUE AVANT ORANGEVINYL CES1054-C22 CES054-C23 G CES1054-C48

COLONIAL GREY COLONIAL GREY COLONIAL GREY SPRINGBOCKVINYL CES1054-C26 CES1054-C27 CES1054-C49

EV CLOUD GRAY CLOUD GRAY CLOUD GRAY JAGUAR YELLOWV VINYL CES1054-531 CES1054-533 J CES1054-C50

GV MAIZE MAIZE MAIZE CARNIVAL YELLOWVINYL CES1054-C34 CES1054-C35 CES1054-C54

HUNTER RED HUNTER RED HUNTER RED M ANCIANO BLUEHV VINYL CES1054-A85 CES1054-A86 CES1054-C51

AL CHESTNUT CHESTNUT BROWN CHESTNUT BROWN VELVET BLACKLEATHER CES1054-B41 CES1054-B42 N CES1054-C52

EL CLOUD GRAY CLOUD GRAY CLOUD GRAYLEATHER CES1054-531 CES1054-533

FL EBONY BLACK BLACKLEATHER CES1054-151

HUNTER RED HUNTER RED HUNTER REDHL LEATHER CES1054-A85 CES1054-A86

JFL RED HUNTER RED HUNTER REDJL FABRIC & LEATHER CES1054-A85 CES1054-A86

KFL BEIGE COLONIAL GREY COLONIAL GREYKF FABRIC & LEATHER CES1054-C26 CES1054-C27

LFL GOLD CHESTNUT BROWN CHESTNUT BROWNFABRIC & LEATHER CES1054-B41 CES1054-B42

MFL ,GREEN ORO GREEN ORO GREENMFLFABRIC & LEATHER CES1054-B77 CES1054-B78

INTERIOR PAINT COMMON TO ALL INTERIORSBLACK

(LACQUER) (LACQUER) PART NUMBER. EXAMPLE: CES1054-531CES1054-156 CES1054-193

CLOUD GREY CLOUD GREY(LACQUER) (VINYL)

CES1054-531 CES1054-533

xiv

MODEL 177RG

UPHOLSTERED PARTS - HOW TO ORDER

PARTS MARKED WITH A # FOLLOWING PART NUMBER REQUIRE A SECOND DASH NUMBER FOR COLOR & MATERIAL

(SPECIFY SERIAL NUMBER OF AIRCRAFT WHEN ORDERING)

HOW TO DETERMINE 2nD DASH NUMBER

1. Find part number of desired part in catalog.

2. Refer to "FINISH & TRIM" plate, in the airplane, for your "Year Code" and "Interior Color Code."

3. Add the "Year Code" and "Interior Color Code," to the part number from catalog.

EXAMPLE OF COMPLETE NUMBER

2015001-5-1 AF

Part NumberFrom Catalog From Finish & Trim Plate

-Year CodeFrom Finish & Trim Plate

xvi

INTERIOR PAINTED OR PLASTIC PARTSHOW TO ORDER

PARTS MARKED WITH A a FOLLOWING PART NUMBER REQUIRE A SECOND DASH NUMBER FOR PROPER COLOR

(SPECIFY SERIAL NUMBER OF AIRCRAFT WHEN ORDERING)

To obtain second dash number use of correct table, for your model year, is required.

To use table,

1. Find part number of desired part in catalog.

2. Refer to the "Finish and Trim" plate, in the airplane, for your "Interior Color Code."

FINISH AND TRIM1 AF 171V

3. Locate part number from catalog in table.

4. Add dash number for color that appears under your "Interior Color Code."

INTERIOR PAINTED OR PLASTIC PARTS

1971 MODEL YEAR

EXAMPLES OF COMPLETE NUMBER

0514017-2 -532

Part Number 2nd Dash NumberFrom Catalog From Table

(Interior Color Code BF)

xvii

MODEL 177RG

INTERIOR PAINTED OR PLASTIC PARTS INTERIOR COLOR CODE

1971 MODEL YEAR(FromFinishandTrimPlate)

177RG0001 THRU 177RG0212AF BF CF DF

PART NUMBER PART NAME AV BV CV DV EL FL DL HL

0514017-1 TRIM - CHAIR BOTTOM LH ....... .. 532 532 532 532 532 532 532 5320514017-2 TRIM - CHAIR BOTTOM RH .............. 532 532 532 532 532 532 532 5320514017-3 TRIM - CHAIR BOTTOM FWD ............. 532 532 532 532 532 532 532 5320514018-3 POCKET ASSEMBLY - MAGAZINE .......... 532 532 532 532 532 532 532 5320514018-15 TRIM ASSEMBLY - SEAT BACK............. 532 532 532 532 532 532 532 5320514055-3 POCKET ASSEMBLY - MAGAZINE .......... 532 532 532 532 532 532 532 5320514055-11 TRIM ASSEMBLY - SEAT BACK ............. 532 532 532 532 532 532 532 5320514058-1 RETAINER - SEAT BOTTOM .......... . 532 532 532 532 532 532 532 5321706044-1 COVER - CABIN TOP CONSOLE ............ 532 532 532 532 532 532 532 5321706054-1 COVER- CABIN AIR OUTLET REAR. ......... 532 532 532 532 532 532 532 5321713080-6 GLARE SHIELD ................... 710 10 710 710 710 710710 7101713081-1 COVER - DECK SKIN ................. 825 825 825 825 825 825 825 8251713262-12 COVER ASSEMBLY - UPPER LH INSTRUMENT PANEL 989 989 989 989 989 989 989 9891713262-14 COVER ASSEMBLY - UPPER LH INSTRUMENT PANEL 989 989 989 989 989 989 989 9891713270-7 COVER - INSTRUMENT PANEL LOWER LH ...... 978 A24 A30 A27 279 279A27 2791713274-2 COVER - INSTRUMENT PANEL UPPER RH ...... 989 989 989 989 989 989 989 9891713275-10 COVER - SWITCH PANEL LB ............. 279 279 279 279 279 279 279 2791713279-3 COVER - RADIO CUTOUT UPPER ........... 279 279 279 279 279 279 279 2791713279-4 COVER - RADIO CUTOUT LOWER .......... 978 A24 ASO A27 279 279 A27 2791713355-1 DOOR ASSEMBLY - GLOVE BOX ............ 978 A24 A30 A27 279 279 A27 2791714027-3 COVER - SEAT SUPPORT LH ............. 532 532 532 532 532 532 532 5321714027-4 COVER - SEAT SUPPORT RH ............. 532 532 532 532 532 532 532 5321715013-1 ESCUTCHEON - HEADLINER ACCESS ......... 532 532 532 532 532 532 532 5321715014-1 ESCUTCHEON - DOOR STOP ............. 978 A24 A30 A27 532 279 A27 5321715017-8 PANEL ASSEMBLY - AFT WALL ........... 978 A24 A30 A27 532 279 A27 5321715018-7 TRIM PANEL ASSEMBLY - RH FORWARD ....... 978 A24 A30 A27 532 279 A27 5321715018-9 TRIM PANEL ASSEMBLY - LH FORWARD ....... 978 A24 A30 A27 532 279 A275321715019-6 MOULDING - REAR WINDOW ............. 532 532 532 532 532 532 532 5321715019-17 MOULDING ASSEMBLY - WINDOW LH DOOR ...... 532 532 532 532 532 532 532 5321715019-18 MOULDING ASSEMBLY - WINDOW RH DOOR ...... 532 532 532 532 532 532 532 5321715027-3 RETAINER- LH ................... 532 532 532 532 532 532 532 5321715027-4 RETAINER - RH ................... 532 532 532 532 532 532 532 5321715033-1 TRIM - LOWER LH DOOR. .. ............ 978 A24 A30 A27 532 279 A27 5321715033-2 TRIM - LOWERRH DOOR..... .......... 978 A24 A30 A27 532 279 A27 5321715034-1 MOULDING- LH ................... 978 A24 A30 A27 532 279 A27 5321715034-2 MOULDING -RH ................... 978A24 A30 A27 532 279 A27 5321715037-1 RETAINER - SEAT BOTTOM. .......... 532 532 532 532 532 532 532 5321715038-1 TRIM ASSEMBLY - REAR SEAT ............ 532 532 532 532 532 532 532 5321715039-1 TRIM ASSEMBLY - REAR SEAT LH .......... 532 532 532 532 532 532 532 5321715039-2 TRIM ASSEMBLY - REAR SEAT RH .......... 532 532 532 532 532 532 532 5321715040-2 MOULDING - RH WINDOW . ......... . 532 532 532 532 532 532 532 5321715040-5 MOULDING - LH DOORPOST ............. 532 532 532 532 532 532 532 5321715040-6 MOULDING - RH DOORPOST ............. 532 532 532 532 532 532 532 5321715040-7 MOULDING - DOOR & WINDSHIELD LH UPPER ...... 532 532 532 532 532 532 532 5321715040-8 MOULDING - DOOR & WINDSHIELD RH UPPER.....532 532 532 532 532 532 532 5321715040-9 MOULDING -LH ................... 532 532 532 532 532 532 532 5321715040-9 MOULDING - RH ................... 532 532 532 532 532 532 532 5321715040-14 MOULDING - RH WINDOW FORWARD .32 532 532 532 532 532 532 5321715040-15 MOULDING - LH WINDOW FORWARD ......... 532 532 532 532 532 532 532 5321715040-16 MOULDING - LH WINDOW ...... .... .. 532 532 532 532 532 532 532 5321715040-17 MOULDING - L WINDOW WITH COURTESY LIGHT. . . 532 532 532 532 532 532 532 5322013020-14 COVER ASSEMBLY - HAND PUMP............. 279 279 279 279 279 279 279 2792013057-2 COVER-SWITCH PANEL RH ............. 978 A24 A30 A27 532 279A27 5322013065-1 COVER ASSEMBLY - PEDESTAL WITH COURTESY LIGHT 978 A24 A30 A27 279 279 A27 2792013065-3 COVER ASSEMBLY - PEDESTAL...........978 A24 A30 A27 279 279 A27 2792013078-1 COVER - INSTRUMENT PANEL FLAP POSITION . . . 978A24 A30 A27 279 279 A27 2792013080-1 COVER - INSTRUMENT PANEL LOWERRH ...... 978 A24 A30 A27 532 279 A27 5322015000-5 TRIM PANEL RH AFT BAGGAGE COMPARTMENT . . . 978 A24 A30 A27 532 279 A27 5322015002-1 COVER - BAGGAGE DOOR .............. 978A24 A30A27279 A27 5322015003-1 COVER - REAR BAGGAGE DOORPOST ......... 279 279 279 279 279 279 279 2792015005-1 MOULDING - BAGGAGE DOOR JAM .......... 978 A24 A30 A27 532 279 A27 5322015006-1 MOULDING - BAGGAGE DOOR JAM .......... 978 A24 A30 A27 532 279 A27 5322015008-1 COVER - BAGGAGE DOOR BALANCE .978 A24 A30 A27 532 279 A27 5322016019-2 COVER - DRAIN CONTROL ............. 978 A24 A30 A27 532 279 A27 532

xviii


1972 MODEL YEAR177RG0213 THRU 177RG0282

AF BF CF DFPART NUMBER PART NAME AV BY CV DV EL FL DL HL

0514017-3 TRIM - CHAIR BOTTOM FWD........... 978 A44 A48 A52 532 279 A52 5320514058-1 RETAINER - SEAT BOTTOM ............. 978 A44 A48 A52 532 279 A52 5320514076-1 TRIM ASSY - SEAT BACK .............. 978 A44 A48 A52 532 279 A52 5320514076-2 TRIM ASSY - SEAT BACK .............. 978 A44 A48 A52 532 279 A52 5320714010-5 TRIM - CHAIR BOTTOM RH ............. 978 A44 A48 A52 532 279 A52 5320714010-6 TRIM - CHAIR BOTTOM LH ............. 978 A44 A48 A52 532 279 A52 5321706044-3 COVER - CABIN TOP CONSOLE ............ 532 532 532 532 532 532 532 5321706054-1 COVER - CABIN AIR OUTLET REAR .......... 532 532 532 532 532 532 5325321713080-6 GLARE SHIELD ................... 710 710 710 710 710 710 710 7101713081-1 COVER - DECK SKIN ................. 825 825 825 825 825 825 825 8251713262-15 COVER ASSY - UPPER LH INSTRUMENT PANEL .... A59 A59 A59 A59 A59 A59 A59A591713262-17 COVER ASSY - UPPER LH INSTRUMENT PANEL .... A59A59 A59 A59A59 A59 A59 A59 A591713270-11 COVER - INSTRUMENT PANEL LOWER LH....... A59 A59 A59 A59 A59 A59 A59 A591713274-3 COVER - INSTRUMENT PANEL UPPER RH ...... A A59 A59 A59 A59 A59 A59 A59 A591713275-9 COVER - SWITCH PANEL LH ............. 978 A44 A48 A52 532 279 A52 5321713279-9 COVER - RADIO CUTOUT UPPER ......... A59 A59 A59 A59 A59 A59 A591713279-10 COVER - RADIO CUTOUT LOWER ........... A59 A59 A5A59 A59 A59 A59 A A591713355-1 DOOR ASSY - GLOVE BOX .............. A59 A59A59 A59 A59 A59 A59 A591714027-5 COVER - SEAT SUPPORT LH ............. 978 A44 A48 A52 532 279 A525321714027-6 COVER - SEAT SUPPORT RH ............. 978 A44 A48 A52 532 279 A525321715013-1 ESCUTCHEON - HEADLINER ACCESS ......... 532 532 532 532 532 532 532 5321715014-1 ESCUTCHEON - DOOR STOP ............. 978 A44 A48 A52 532 279 A525321715017-8 PANEL ASSY - AFT WALL ............. 978 A44 A48 A52 532 279 A52 5321715018-7 TRIM PANEL ASSY - RH FWD ............ 978 A44 A48 A52 532 279 A52 5321715018-9 TRIM PANEL ASSY - LH FWD ............ 978 A44 A48 A52 532 279 A52 5321715019-6 MOULDING - REAR WINDOW ............. 532 532 532 532 532 532 5325321715019-17 MOULDING ASSY - WINDOW LH DOOR......... 532 532 532 532 532 532 532 5321715019-18 MOULDING ASSY - WINDOW RH DOOR ......... 532 532 532 532 532 532 532 5321715027-3 RETAINER- L .................. 531 531 531 531 531 531 531 5311115021-4 RETAINER-RH .................. 531 531 531 531 531 531 531 5311715033-1 TRIM - LOWER HOOR . ....... .. .... 978 A44 A48 A52 532 279 A52 5321715033-2 TRIM - LOWER RH DOOR ............... 978A44 A48 A52532 279 A525321715034-1 MOULDING -LH .................. 978 A44 A48 A52 532 279 A52 5321715034-2 MOULDING - RH .................. 978 A44 A48 A52 532 279 A525321715037-1 RETAINER - SEAT BOTTOM .. ......... 978 A44 A48 A52 532 279 A52 5321715038-1 TRIM ASSY - REAR SEAT............... 978A44 A48 A52 532 279 A525321715039-1 TRIM ASSY - REAR SEAT LH ............. 978 A44 A48 A52 532 279 A52 5321715039-2 TRIM ASSY - REAR SEAT RH ............. 978 A44 A48 A52 532 279 A525321715040-5 MOULDING - LH DOORPOST ............. 532 532 532 532 532 532 532 5321715040-6 MOULDING - RH DOORPOST ............ 532 532 532 532 532 532 5325321715040-7 MOULDING - DOOR & WINDSHIELD LH UPPER ..... 5532 532 532 532 532 532 532 5321715040-8 MOULDING - DOOR & WINDSHIELD RH UPPER ..... 532 532 532 532 532 532 532 5321715040-9 MOULDING - LBH .. ............. 532 532 532 532 532 532 5325321715040-10 MOULDING - RH ................... 532 532 532 532 532 532 532 5321715040-21 MOULDING - LH WINDOW ............. 532 532 532 32 532 32 532 5321715040-22 MOULDING - R WINDOW .............. 532532 532 532 532 532 532 5321715040-24 MOULDING - LH WINDOW WITH COURTESY LIGHT . . 532 532 532 532 532 532 532 5321715040-25 MOULDING - LB WINDOW FWD ............ 532 532 532 532 532 532 532 5321715040-26 MOULDING - RH WINDOW FWD ............ 532 532 532 532532 532 532 5322013020-14 COVER ASSY - HAND PUMP ............. 1978 A44 A48 A52 532 279 A52 5322013057-2 COVER - wi;n PANEL RH ............. 978 A44 A48 A52 532 279 A52 5322013065-1 COVER ASSY - PEDESTAL WITH COURTESY LIGHT . .978 A44 A48 A52 279 279 A52 2792013065-3 COVER ASSY - PEDESTAL .............. 978 A44 A48 A52 279 279 A52 2792013078-1 COVER - INSTRUMENT PANEL FLAP POSITION . . . . A59 A59 A59 A59 A59 A59 A59 A592013080-2 COVER -2015000-5 TRIM PANEL - RH AFT BAGGAGE COMPARTMENT . .978 A44 A48 A52 532 279 A52 5322015002-1 COVER - BAGGAGE DOOR .............. 978 A44 A48 A52 532 279 A52 5322015003-1 COVER - REAR BAGGAGE DOORPOST ......... 978 A44 A48 A52 532 279 A52 5322015005-1 MOULDING - BAGGAGE DOOR JAM ......... 978 A44 A48 A52 532 279 A52 5322015006-1 MOULDING - BAGGAGE DOOR JAM ......... 978 A44 A48 A52532 279 A52 5322015008-1 COVER - BAGGAGE DOOR BALANCE .... . 978 A44 A48 A52 532 279 A52 5322016019-2 COVER - DRAIN CONTROL .............. 978 A44 A48 A52 532 279 A52 532

xix

MODEL 177RG


1973 MODEL YEAR (From Finish and Trim Plate.)177RG0283 THRU 177RG0432

AF BF CF DF

0514017-3 TRIM - CHAIR BOTTOM FWD .......... 978 A80 A88 A84 532 279 5320514058-1 RETAINER - SEAT BOTTOM ............. 97 8 A80 A A84 532 279 5320514076-1 TRIM ASSY - SEATBACK .............. 978 A80 A88 A84 532 279 5320514083-1 TRIM ASSY - SEAT BACK ............. 78 A80 A88 A84 532 279 5320714010-5 TRIM - CHAIR BOTTOM . ........... 978 A80 A88 A84 532 279 5320714010-6 TRIM- CHAIR BOTTOM LH. .............. 978 A80 A88 A84 532 279 5321706044-3 COVER - CABIN TOP CONSOLE ............ 532 532 532 532 532 532 5321706054-1 COVER - CABIN AIR OUTLET REAR ......... 532 532 532 532 532 532 5321713080-6 GLARE SHIELD ................... 710 710 710 710 710 710 7101713081-1 COVER- DECK SKIN. ................ 825 825 825 825 825 825 8251713262-19 COVER ASSY - UPPER LH INSTRUMENT PANEL .. A59 A59 A59 A59 A59 A59 A591713270-11 COVER - INSTRUMENT PANEL LOWER LH .... . A59 A59 A59 A59 A59 A59 A591713274-3 COVER - INSTRUMENT PANEL UPPER RH ...... A59 A59 A59 A59 A59 A59 A591713275-9 COVER - SWITCH PANEL LH . ........ 978 A80 A88 A84 279 279 2791713279-9 COVER - RADIO CUTOUT UPPER .. .......... A59 A59A59 A59 A59 A59 A591713279-10 COVER - RADIO CUTOUT LOWER. . ......... A A59A A59 A59 A59 A591713355-1 DOOR ASSY - GLOVE BOX .............. A59 A59 A59 A59 A59 A59 A591714027-5 COVER - SEAT SUPPORT LH .............. 978 A80 A88 A84 532 279 5321714027-6 COVER - SEAT SUPPORT RH ... ........ 978 A80A88 A84 532 279 5321715013-1 ESCUTCHEON - HEADLINER ACCESS ......... 532 532 532 532 532 532 5321715014-1 ESCUTCHEON - DOOR STOP ............. 978 A80 A88 A84 532 279 5321715017-8 PANEL ASSY - AFT WALL .............. 978 A80 A88 A84 532 279 5321715018-11 TRIM PANEL ASSY - RH FWD. . .......... 978A80 A8S A84 532 279 5321715018-12 TRIM PANEL ASSY - LH FWD. .. ........... 978 A80A88 A84 532 279 5321715019-6 MOULDING - REAR WINDOW .. ........... 532 532 532 532 532 532 5321715027-3 RETAINER - LH ................... 531 531 531 531 531 531 5311715027-4 RETAINER- RH ................... 531 531 531 531 531 531 5311715033-1 TRIM - LOWER LH DOOR . .. 978 A80 A88 A84 532 279 5321715033-2 TRIM - LOWER RH DOOR .............. 978 A80 A88 A84 532 279 5321715034-1 MOULDING - LH .................. . 978 A88 A84 532 279 5321715034-2 MOULDING - RH . ................. 978 A80 A88 A84 532 279 5321715037-1 RETAINER - SEAT BOTTOM . ........ .... 978 A88 A84 532 279 5321715038-1 TRIM ASSY - REAR SEAT .............. A0978 A80 A84 532 279 5321715039-1 TRIM ASSY - REAR SEAT LH . ........ 978 A80 A88 A84 532 279 5321715039-2 TRIM ASSY - REAR SEAT RH ............. 978 A80 A88 A84 532 279 5321715040-5 MOULDING - LH DOORPOST ............. 532 532 532 532 532 532 5321715040-6 MOULDING- RH DOORPOST ..........R. . . 532 532 532 632 532 532 5321715040-7 MOULDING - DOOR & WINDSHIELD LH UPPER .... 532 532 532 532 532 532 5321715040-8 MOULDING - DOOR & WINDSHIELD RH UPPER ...... 532 532 532 532 532 532 5321715040-9 MOULDING - LH . ................. 532 532 532 532 532 532 5321715040-10 MOULDING - RH ................... 532532 532 532 532 532 5321715043-3 MOULDING - L WINDOW .............. 532 532 532 532 532 532 5321715043-4 MOULDING - RH WINDOW .............. 532 532 532 532 532 532 5321715043-7 MOULDING - LH WINDOW FWD ............ 532 532 532 532 532 532 5321715043-8 MOULDING - RH WINDOW FWD ............ 532 532 532 532 532 532 5321715043-15 MOULDING - LH WINDOW WITH COURTESY LIGHT... 532 532 532 532 532 532 5322013020-14 COVER ASSY - HAND PUMP ............. 978A808 A80 A A84 279 279 9782013057-2 COVER - SWITCH PANEL RH ............. 978 A80 A88 A84 279 279 2792013065-1 COVER ASSY - PEDESTAL WITH COURTESY LIGHT . 978 A80A88 A84 279 279 2792013065-3 COVER ASSY - PEDESTAL .............. 978 A80 A88 A84 279 279 2792013078-1 COVER - INSTRUMENT PANEL FLAP POSITION .... A59 A59A59 A59 A59 A59 A592013080-2 COVER - INSTRUMENT PANEL LOWER RH ..... A59 A59 A59 A59 A59 A59 A592015000-5 TRIM PANEL - RH AFT BAGGAGE COMPARTMENT . . 978 A80 A88 A84 532 279 5322015002-1 COVER - BAGGAGE DOOR .............. 978 A80 A88 A84 532 279 5322015003-1 COVER - REAR BAGGAGE DOORPOST. ........ 978A80A88 A84 532 279 5322015005-1 MOULDING - BAGGAGE DOOR JAM .......... 978 A80 A88 A84 532 279 5322015006-2 MOULDING - BAGGAGE DOOR JAM ......... .978 A80 A88 A84 532 279 5322015008-1 COVER - BAGGAGE DOOR BALANCE . .... 978A80 A88 A84 532279 5322016034-1 COVER - DRAIN CONTROL ............. 978 A80A88 A84 532 279 5322016035-2 COVER - FUEL SELECTOR VALVE . ........ 978 A80 A88 A4 532 279 532

xx

INTERIOR PAINTED OR PLASTIC PARTS INTERIOR COLORCODE

1974 MODEL YEAR177RG0433THRU177RG0592 AF GF

AV BF CF DF GVPART NUMBER PART NAME AL BV CV DV GL EL FL

0514017-3 TRIM - CHAIR BOTTOM FWD . . ....... 40 B28 B32 B36 B24 532 2790514017-4 TRIM - CHAIR BOTTOM RH ............. .B40 B28 B32 B36 B24 532 2790514017-7 TRIM - CHAIR BOTTOM LH .............. B40 B28 B32 B36 B24 532 2790514058-1 RETAINER - SEAT BOTTOM .............. B40 B28 B32 B36 B24 532 2790514076-1 TRIM ASSY - SEAT BACK . . ...... B40 B28 B32 B36 B24 532 2790514083-1 TRIM ASSY - SEAT BACK ............... B40 B28 B3 B360515010-6 TRAY ASSY - SHOUT1706044-3 COVER - CABIN TOP CONSOLE ........1706054-1 COVER - CABIN AIR OUTLET REAR .......... 532 532 532 532 532 532 5321713080-6 CLARE SHIELD ................... 710 710 710 710 710 710 7101713081-1 COVER- DECK SKIN .............. .825 825 825 825 825 825 8251713262-21 COVER ASSY - UPPER LH INSTRUMENT PANEL .... A59 A59 A59 A59 A59 A59 A591713270-13 COVER - INSTRUMENT PANEL LOWER LH ....... A59 A59 A59 A59 A59 A59 A591713274-5 COVER - INSTRUMENT PANEL LOWER RH ...... A59 A59 A59 A59 A59 A59 A591713215-12 COVER - SWITCH PANEL ............. B40 B28 B32 B36 B24 532 2791713279-9 COVER - RADIO CUTOUT UPPER ........... A59 A59 A59 A59 A59 A59 A591713279-10 COVER - RADIO CUTOUT LOWER ........... A59 A59 A59 A59 A59 A59 A591713355-1 DOOR ASSY - GLOVE BOX . . ............ A59 A59 A59 A59 A59 A59 A591714027-5 COVER - SEAT SUPPORT LH ............. 40 B28 B32 B36 B24 532 2791714027-6 COVER - SEAT SUPPORT RH . . .......... B40 B28 B22 B36 B24 532 2791715013-1 ESCUTCHEON - HEADLINER ACCESS ........ 32 532 532 532 532 532 2791715017-8 PANEL ASSY - AFT WALL . . ........ B40B28 B32 B36 B24532 2791715027-3 RETAINER - LH ................... 532 532 532 532 532 532 5321715027-4 RETAINER-RH . . ................. 532 532 532 532 532 532 5321715034-1 MOULDING - LH ................... B40B28 B32 B36 B24 532 2791715034-2 MOULDING -RH . . ................. B40B28 B32 B36 B245322791715037-1 RETAINER - SEAT BOTTOM .............. B40B28 B32 B36 B24 532 2791715038-1 TRIM ASSY - REAR SEAT ............... B40 3B28 3B32 3B36 B24 279 2791715039-1 TRIM ASSY - REAR SEAT LH ............. 40 B28 B32 B36 B24 532 2791715039-2 TRIM ASSY - REAR SEAT ............. B40 B28 B32 B36 B24 532 2791715040-5 MOULDING- LH1715040-6 MOULDING - RH DOORPOST ............. 532 532 532 532 532 532 5321715040-7 MOULDING - DOOR & WI1715040-8 MOULDING- DOOR&1715040-9 MOULDING - LH ................... 532 532 532 532 532 532 5321715040-10 MOULDING- RH ................... 532 532 532 532 532 532 5321715041-1 MOULDING - REAR WINDOW FWD ........... 532 532 532 532 532 532 5321715041-2 MOULDING - REAR WINDOW AFT ........... 532 532 532 532 532 532 5321715042-23 TRIM - LOWER LH DOOR . . ............. B4028 28 B32 B36 B24 532 2791715042-24 TRIM - LOWER RH DOOR .............. .B40 B28 B32 B36 B24532 2791715043-3 MOULDING - LH WINDOW ................ 532 532 532 532 532 532 5321715043-4 MOULDING - RH WINDOW . .............. 532 532 532 532 2 532 532 5321715043-7 MOULDING - LH WINDOW FWD BELOW BELTLINE . B41 B29 B33 B37 B25 NA 151

ABOVE BELTLINE . .532 532532 532 532 532 5321715043-8 MOULDING - RH WINDOW AFT BELOW BELTLINE . B41 B29 B33 B37 B25 NA 151

ABOVE BELTLINE . .532 532 532 532 532 532 5321715043-15 MOULDING - LH WINDOW BELOW BELTLINE . B41 B29 B33 B37 B25 NA 151

ABOVE BELTLINE . .532 532 532 532 532 532 5321715047-1 ESCUTCHEON - LH .................. B40 B28 B32 B36 B24 532 2791715047-2 ESCUTCHEON - RH .................. B40B28 B32 B36 B24 532 2791715049-1 TRAY ASSY - SHOULDER HARNESS FWD ......... 532 532 532 532 532 532 5321715050-1 MOULDING - LH .......... ....... 532 532 532 532 5325325321715050-2 MOULDING - RH .......... ......... 532 532 532 532 532 532 5322013020-14 COVER ASSY - HAND PUMP .............. B40B28 B32 B36 B24 B32 2792013057-4 COVER - SWITCH PANEL ......... . ... 28 B32 B36 B24 532 279

CONTINUED ON NEXT PAGE

xxi

MODEL 177RG


1974 MODEL YEAR177RG0433 THRU 177RG0592 AF GF

AV BF CF DF GVPART NUMBER PAT NAME AL BV CV DV L EL FL

2013065-1 COVER ASSY - PEDESTAL WITH COURTESY LIGHT . . . B40 B28 B32 B36 B24 532 2792013065-3 COVER ASSY - PEDESTAL . .............. B40 B28 B32 B36 B24 532 2792013078-1 COVER- INSTRUMENT PANEL FLAP POSITION .... A5 A59 A59 A59 A59 A59 A592013080-4 COVER - LWR RH2013080-7 COVER - LWR RH INSTRUMENT PANEL ........ A59 A59 A59 A59 A59 A59 A592015002-1 COVER- BAGGAGE DOOR .............. .B40 B32 B36 B24 532 2792015003-1 COVER - REAR BAGGAGE2015005-1 MOULDING - BAGGAGE DOOR JAM ......... . B40 B28 B32 B36 B24 2792015006-2 MOULDING - BAGGAGE DOOR JAM BELOW BELTLINE B41 B29 B33 B37 B25 NA 151

ABOVE BELTLINE 532 532 532 532 532 532 5322015008-1 COVER - BAGGAGE DOOR BALANCE .-....... .B40 B28 B32 B36 B24 532 2792015014-7 TRIM PANEL - RH AFT BAGGAGE COMPARTMENT . . . B40 B28 B32 B36 B24 532 2792015015-1 TRIM PANEL ASSY - LB WD ............ .B40 B28 B32 B36 B24 532 2792015015-2 TRIM PANEL ASSY - RH FWD ............. B40 B28 B32 B36 B24 532 2792016034-1 COVER - DRAIN CONTROL .............. B40 B28 B32 B36 B24 532 2792016035-2 COVER - FUEL

xxii


1975 MODEL YEAR

177RG0593THRU 177RG0787 AF CFGAV BF CF DF GV

PART NUMBER PART NAME

0514112-1 TRIM ASS - SEAT BACK. .............. 532 532 532 52 532 532 5320515010-6 TRAY ASSY - SHOULDER HARNESS .. . . . ..... A59 A59 A59 A59 A59 A59 A590714010-1 TRIM - CHAIR BOTTOM LH ..... B40 B28 B32 B36 B24 532 279

B36* B24* B40* B32*0714010-2 TRIM - CHAIR BOTTOM RH ............. B40 B28 B32 B6 B24 532 279

B36* B24* B40* B32*1214098-1 TRIM - SEAT . .............. .. B40 B28 B32 B36 B24 532 279

B36* B24* B40* B32*1706044-3 COVER - CABIN TOP CONSOLE. ............ 532 532 532 532 532 532 5321706044-5 COVER - CABIN TOP CONSOLE WITH POST LIGHTS . 532 532 532 532 532 532 5321706054-1 COVER - CABIN AIR OUTLET REAR ...... . 532 52 532 532 532 532 532

1713081-1 COVER - DECK S ................ 825 825 825 825 825 825 8251713262-23 COVER ASSY - UPR LH INSTRUMENT PANEL ..... A59 A59 A59 A59 A59 A59 A591713270-17 COVER - INSTRUMENT PANEL LWR L ........ . . A59 A59 A59 A59 A59 A59 A591713274-5 COVER - INSTRUMENT PANEL UPR RH ........ A59 A59 A59 A59 A59 A59 A591713275-19 COVER - SWITCH PANEL LH ............. B40 B28 B32 B36 B24 532 2791713279-10 COVER - RADIO CUTOUT UPR . ........ . .. A59 A59 A59 A59 A59 A59 A591713279-15 COVER - RADIO CUTOUT LWR ............. .A59 A A59 A59 A59 A59 A591713355-1 DOORASSY-GLOVEBOX . ............. A59 A59 A59 A59 A59 A591713362-2 COVER - INSTRUMENT PANEL FLAP POSITION .... A59 A59 A59 A59 A59 A A591714027-5 COVER - SEAT SUPPORT LH . ............... 532 .. 532 532 532 532 532 5321714027-6 COVER - SEAT SUPPORT RH . ........ . . . . 532 532 532 532 532 532 5321714088-1 PANEL - SEAT BACK LH. ............... B40 B28 B32 B36 B24 532 279

B36* B24* B40* B32*1714088-2 PANEL - SEAT BACK RH. ............. B40 B28 B32 B6 B24 52 279

B36* B24* B40* B32*1714089-1 PANEL -SEAT BACK ............... . B40 28 B32 B36 B24 532 279

B36* B24* B40* B32*1715013-1 ESCUTCHEON - HEADLINER ACCESS ...... . .. 532 532 532 532 532 532 5321715027-3 RETAINER - LH ......... . . ......... 532 532 532 532 532 532 5321715027-4 RETAINER - RH ........... ... . .. 532 532 532 532 532 532 5321715034-1 MOULDING- L ...................... B40 B28 B32 B36 B24 52 2791715034-2 MOULDING-RH. .................. B40 B28 B32 B36 B24 532 2791715040-5 MOULDING - LH DOORPOST ............ .532 532 532 532 532 532 532 5321715040-6 MOULDING - RH DOORPOST ... ........... 532 532 532 532 532 532 5321715040-7 MOULDING - DOOR & WINDSHIELDLH UPR . . . . . . 532 532 532 532 532 532 5321715040-8 MOULDING - DOOR & WINDSHIELD. ....... 532 532 532 532 532 532 5321715040-9 MOULDING- LH ............ ... . . . .. 532 532 53 532 532 532 5321715040-10 MOULDING - R. ............ ... . 532 532 532 532 532 532 5321715041-1 MOULDING -REAR WINDOW FWD. . ......... . 532 532 532 532532 5321715041-2 MOULDING-REAR WINDOW AFT. ......... 532 532 532 532 532 532 5321715042-23 TRIM-LOWER DOOR LH. . . .. .B40 B28 B32 B36 B24 532 2791715042-24 TRIM- LOWER DOOR R. ............... B40 B28 B32 B36 B24 532 2791715043-3 MOULDING - LH WINDOW. ............. 532 532 532 532 532 5321715043-4 MOULDING -RH WINDOW. .............. 532 532 532 2 532 532 5321715043-7 MOULDING - LH WINDOW FWD BELOW BELTLINE . B41 B29 B33 B37 B25 N/A 151

ABOVE BELTLINE . 532 532 532 532 532 532 5321715043-8 MOULDING - RH WINDOW AFT BELOW BELTLINE . B41 B29 B33 B37 B25 N/A 151

ABOVE BELTLINE . 532 532532 532 532 532 5321715043-15 MOULDING - LH WINDOW BELOW BELTLINE .... B41 B29 B33 B37 B25 N/A 151

ABOVE BELTLINE .... 532 532 532 532 532 532 5321715047-1 ESCUTCHEON - LH . .. . . . . . ..... . B40 B28 B32 B36 B24 532 2791715047-2 ESCUTCHEON ............ ....... B40 B28 B32 B36 B24 532 2791715049-1 TRAY ASSY - SHOULDER HARNESS . ......... 532 532. 532 532 532 532 532


xxii

MODEL 177RG

INTERIOR PAINTED OR PLASTIC PARTS INTERIOR COLORCODE

1975 MODEL YEAR AFD

177RG0593THRU 177RG0787 AF CFG DFA- GFAV F CF DF GV

PART NUMBER PART NAME AL BV CV DV GL EL FL

1715050-1 MOULDING - LH ................... 532 532 532 52 52 532 5321715050-2 MOULDING - RE .................. 532 53532 532 532 532 5321715054-12001016-5 COVER - POST2013020-142013057-5 COVER - SWITCH PANEL. .............. B40B28 B2 B36 B24 532 2792013057-6 COVE - CIRCUIT BREAKER ........... . .B40 B28 B32 B36 B24 532 2792013065-10 uv ASSY - PEDESTAL .................. B40 28 B2 B36 B24 532 2792013065-12 COVER ASSY -2013080-10 COVER - LWR RH INSTRUMENT PANEL ........ B40 B28 32 B36 B24 532 2792013080-11 COVER - LWR RH INSTRUMENT PANEL ........ B40 B28 B32 B36 24 532 2792013154-4 COVER - R POST LIGHTED ............. A5A59 A59 A59 A59 A59 A592013154-5 COVER- LWR LH POST LIGHTED ........... A 9 A59 A 59 A 59 A59 A52013154-7 COVER - UPPER LH POST LIGHTED . .......... A59 A59 A59 A AA59A92015002-1 COVER- BAGGAGE DOOR .............. B40B28 B32 B36 B24 532 2792015003-1 COVER - REAR BAGGAGE DOORPOST ......... 40B28 B32 B36 B24 532 2792015005-1 MOULDING - BAGGAGE DOOR JAM .......... B40 B28 B2 B36 B24 532 2792015006-2 MOULDING - BAGGAGE DOOR JAM BELOW BELTLINE B41 B29 B33 B37 B25 N/A 151

ABOVE BELTLINE 532 5322 252 53 532 5322015008-1 COVER - BAGGAGE DOOR BALANCE .......... B40 B28 B32 B36 B24 532 2792015014-7 TRIM PANEL - RH AFT BAGGAGE COMPARTMENT . . B40 28 B32 B36 B24 532 2792015015-1 TRIM PANEL - LH FWD ............... B4028 B32 B36 B24 532 2792015015-2 TRIM PANEL - R FWD ............... B40B28 B32 B36 B24 532 2792016034-1 COVER - DRAIN CONTROL .................... 40 28 B2 36 24 532 2792016035-2 COVER - FUEL SELECTOR VALVE .......... B40 B28 B32 B36 24 532 279

1976 MODEL YEAR177RG0788 THRU 177RG1051 AF DF

AV BFCF DV GFPART NUMBER PART NAME AL BV DL GV EL FL

0614112-1 TRIM ASSY - SEAT BACK ............... B40 B72 B76 B80 B84 532 2790515010-6 TRAY ASSY - SHOULDER HARNESS .......... 532 532 532 532 532 532 5320715049-1 SPLICE - WINDLACE ................. B40 B72 B76 B80 B84 532 2791214098-1 TRIM - SEAT ..................... B40 B72 B76 B80 B84 532 2791701030-3 COVER ASSY - UPR RH POST LIGHTED ......... A59 A59 A59 A59 A59 A59 A591701030-4 COVER ASSY - UPR RH POST LIGHTED W/RH CONTROLS A59 A59 A59 A59 A59 A59 A591701030-6 COVER - UPR LH POST LIGHTED ........... A59 A59 A59 A59 A59 A59 A591706044-7 COVER - CABIN TOP CONSOLE ........... 32 532 532 532 532 532 5321706044-9 COVER - CABIN TOP CONSOLE WITH POST LIGHTS. 532 532 532 532 532 532 5321706054-1 COVER - CABIN AIR OUTLET REAR .......... 532 532 532 532 532 532 5321713279-18 COVER - RADIO CUTOUT ............... A59 A59 A59 A59 A59 A59 A591713362-4 COVER - INSTRUMENT PANEL FLAP POSITION .... A59 A59 A59 A59 A59 A59 A591713377-1 DOOR ASSY - GLOVE BOX ............... A59 A59 A59 A59 A59 A59 A591713380-2 COVER ASSY - UPR LH INSTRUMENT PANEL ...... A59 A59 A59 A59 A59 A59 A591713382-3 COVER- UPR RH INSTRUMENT PANEL. ........ A59 A59 A59 A59 A59 A59 A591714027-5 COVER - SEAT SUPPORT LH5 532...... 532532532532 532 532 5321714027-6 COVER - SEAT SUUPPORT RH .............. 32 532 532 532 532 532 5321714088-1 PANEL - SEAT BACK LH ............... 532 532 532 532 532 532 5321714088-2 PANEL - SEAT BACK RH ............... 532 532 532 532 532 532 5321714089-1 PANEL - SEAT BACK ................. 532 532 532 532 532 532 5321715013-1 ESCUTCHEON - HEADLINER ACCESS .......... 532 532 532 532 532 532 5321715027-3 RETAINER - LH .................... 532 532 532 532 532 532 5321715027-4 RETAINER - RH. .................. 532 532 532 532 532 5321715041-1 MOULDING - REAR WINDOW FWD ........... 532 532 532 532 532 532 5321715041-2 MOULDING- REAR WINDOW AFT. ........... 532 532 532 532 532 532 5321715042-23 TRIM - LOWER DOOR LH ............... B40 B72 B76 B80 B84 532 2791715042-24 TRIM - LOWER DOOR RH ............... B40 B72 B76 B80 B84 532 2791715047-1 ESCUTCHEON - LH ................... B40 B72 B76 B80 B84 532 2791715047-21715049-1 TRAY ASSY - SHOULDER HARNESS ........... 532 532 532 532 532 532 5321715050-1 MOLDING - LH . . . ........... .. 532 532 532 532 532 532 5321715050-2 MOLDING -RH .................... 532 532 532 532 532 532 5321715054-1 COVER - INERTIA REEL ............... 532532 532 532 532 532 5321715058-1 MOLDING - UPR DOOR LH .............. 532 532 532 532 532 532 5321715058-2 MOLDING - UPR DOOR R .532 532 532 532 532 532 5321715058-3 MOLDING - DOORPOST LH............... 532 532 532 532 532 532 5321715058-4 MOLDING - DOORPOST RH. .............. 532 532 532 532 532 532 5321715058-5 MOLDING - WINDSHIELD LH ........... .. 532 532 532 532 532 532 5321715058-6 MOLDING - WINDSHIELD RH .............. 532 532 532 532 532 532 5321715058-11 MOLDING - LH WINDOW BELOW BELTLINE ..... B41 B73 B77 B81 B85 532 151

ABOVE BELTLINE ...... 532 532 532 532 532 532 5321715058-12 MOLDING - RH WINDOW BELOW BELTLINE ..... B41 B73 B77 B81B85 532 151

ABOVE BELTLINE ..... 532 532 532 532 532 532 5321715058-14 MOLDING - LH WINDOW BELOW BELTLINE ..... B41 B73 77 B81B85 532 151

ABOVE BELTLINE..... 532 532 532 532 532 532 5321715058-15 SPLICE - UPR DOOR FWD ............... 532 532 532 532 532 532 5321715058-16 SPLICE - UPR DOOR AFT ............... 532 532 532 532 532 532 5321715058-17 CAP - DOORPOST L............... . 279 279 279 279 279 279 2791715058-18 CAP - DOORPOST RH ................ .279 279 279 279 279 279 2791715060-6 GLARE SHIELD ................... .710 710 710 710 710 710 7101715062-1 COVER - DECK SKIN ................. 825 825 825 825 825 8258251715054-3 HOUSING - GLARE SHIELD LIGHT . .... ... 279 792 279 279 279 279 2791715064-4 HOUSING - GLARE SHIELD LIGHT ........... 79 279 279 279 279 279 2791715066-1 SPLICE - WINDLACE . . .... .. B40 B72 B76 B80 B84 532 2791715066-2 SPLICE - WINDLACE ................. B40 B72 B76 B80 B84 532 279


xxv

MODEL 177RG

INTERIOR PAINTED OR PLASTIC PARTS INTERIOR COLOR CODE

1976 MODEL YEAR177RG0788 THRU 177RG1051 AF DF

AV BF CF DV GFPARTNUMBR PART NAME AL BV CV DL GV EL FL

2013020-14 COVER ASSY - HAND PUMP .............. B472 B76 B80 B84 532 2792013065-10 COVER ASSY- PEDESTAL. .............. 40 B72 B76 B80 B84 532 2792013065-12 COVER ASSY - PEDESTAL ............... 4 B0 2 B76 B80 B84 532 2792013161-1 COVER - SWITCH PANEL LH .............. B40 B72 B76 B80 B84 532 2792013161-2 COVER - LWR RH SWITCH PANEL ........... B40 B2 B76 B80 B84 532 2792015002-1 COVER - BAGGAGE DOOR ...............2015003-1 COVER - REAR BAGGAGE DOORPOST .. ........ B40 B72 B76 B80 84 532 2792015005-1 MOLDING - BAGGAGE DOOR JAMB ........... 40 B72 B76 80 B84 532 2792015006-2 MOLDING - BAGGAGE DOOR JAMB BELOW BELTLINE B41 B73 B77 B81 B85 532 151

ABOVE BELTLINE 532 532 532 532 532 532 5322015008-1 COVER - BAGGAGE DOOR BALANCE .......... B40 72 76 B80 B84 532 2792015014-7 TRIM PANEL - RH AFT BAGGAGE COMPARTMENT . . .B40 B72 B76 B80 B84 532 2792015015-1 TRIM PANEL - L WD ................ B40 72 B76 B80 B84 532 2792015015-2 TRIM PANEL - RH FWD ............... . 40 B72 B76 B80 B84 532 2792015017-1 PANEL ASSY - AFT WALL .............. . B40 B72 B76 B80 B84 532 2792016034-1 COVER - DRAIN CONTROL. ............... . B40 B72 B76 B80 B84 532 2792016035-2 COVER - FUEL SELECTOR VALVE .......... . 40 B72 B76 B80 B84 532 279

xxvi


1977 MODEL YEAR

AV BF CF DV EVGF HFPART NUMBER PART NAME AL BV DL GV HV FL

0514112-1 TRIM - SEAT ..................... B40 B72 B76 B80 532 B84 A84 2790715049-1 SPLICE - CABIN DOOR AFT .......... ... 40 B72 B76 B80 279 B84 A84 2791706054-1 COVER - CABIN AIR OUTLET REAR . .......... 532 532 532 532 5 32 5321713362-4 COVER ASSY- FLAP INDICATOR . . . . . . . . . . . A59 A59 A59 A59 A59 A59 A591714088-1 PANEL - SEAT BACK L ......... 2 532 532 532 532 532 5325321714088-2 PANEL - SEAT BACK RH .............. 532 532 532 52 532 532 532 5321714089-1 PANEL - SEAT BACK ... . 532 532 532 532 532 532 532 5321715013-1 ESCUTCHEON - HEADLINER ACCESS ......... 532 532 532 532 532 532 5321715027-3 RETAINER - L .................. 532 532 532 532 532 532 532 5321715027-4 RETAINER- RH ................... 532 532 532 532 532 532 532 5321715034-1 MOLDING - LH ................... B40 B72 B76 B80 279 B84 A84 2791715034-2 MOLDING - ................... B40 B72 B76 B80 279 84 84 2791715041-1 MOLDING - REAR WINDOW UPR ........... 532 532 532 532 532 532 532 5321715041-2 MOLDING - REAR WINDOW LWR ........... 532 532 532 532 532 532532 5321715042-23 TRIM - LWR LH DOOR .............. B40 B72 B76 B80 532 B84 A84 2791715042-24 TRIM - LWR RH DOOR ................ B40 B72B76 B80 532B84 A842791715047-1 ESCUTCHEON - LH ................. B40 B72 B76 B80 532 B84 A4 2791715047-2 ESCUTCHEON - RH .......... B40 B72 76 B80 532 B84 A84 2791715050-1 MOLDING - VENT WINDOW RETAINER LH.... . . 532 532 532 532 532 532 5321715050-2 MOLDING - VENT WINDOW RETAINER R . . . . . . . 532 532 532 532 532 532 532 5321715062-1 COVER- DECK SIN .................. 825 825 825 825 825 825 825 8251715066-1 SPLICE - CABIN DOOR LH FWD ............ B40 B72 B76 B80 279 B84 2791715066-2 SPLICE - CABIN DOOR RH FWD ........... B40 B72 76 B80 279B84 A84 2792013020-14 COVER - HAND PUMP ......... B40 B72 76 B80 279 B84 A84 2792013065-10 COVER ASSY - PEDESTAL USED WITH COURTESYLIGHT B40 B72 B76 B80 279 B84 A84 2792013065-12 COVER ASSY - PEDESTAL .. ......... . .B40 B72 B76 B80 279 B84A84 2792013161-5 COVER - LWR LH SWITCH PAEL. .......... B40 B76 B80 279 B84 A84 2792013161-6 COVER - LWR LH SWITCH PANEL. .......... B40 B72 B76 B80 279 B84 A84 2792015002-1 COVER - BAGGAGE DOOR .............. B40 B72 B76 B80 532 B84 2792015003-1 COVER - REAR BAGGAGE DOORPOST ...... . B40 B72 B76 B80 532 B84 A84 2792015005-1 MOLDING - BAGGAGE DOOR JAMB . B40 B72 B76 B80 532 B84 A84 2792015006-2 MOLDING - BAGGAGE DOOR JAMB ABOVE BELTLINE 532 532 532 532 532 532 532 532

BELOW BELTLINE B41 B73 B77 B81 NA B85 A85 1512015008-1 COVER - BAGGAGE DOOR BALANCE ....... B40 B72 B76 B80 532B84 84 2792015014-7 TRIM PANEL - RH AFT BAGGAGE COMPARTMENT .. B40 B72 B76 B80 532B84 A84 2792015015-1 TRIM PANEL ASSY - L FWD ........... B40 72 B76 B80 532B84 A84 2792015015-2 TRIM PANEL ASSY - RHFWD .......... . B40 B72 76 B80 532 B84 A84 2792015017-1 PANEL ASSY - AFT WALL ......... ... B40 B72 B76 B80 532 B84 A84 2792016034-1 COVER - DRAIN CONTROL .. ....... 40 B72 B76 B80 279 B84 A4 2792016035-2 COVER- FUEL SELECTOR VALVE . ...... B40 B72 B76 B80 279 B84 A84 279

xxvii

MODEL 177RG


1978 MODEL YEARAF HF

177RG1267 & ON AV CF HVAC BF CV EV GF HL

PART NUMBER PART NAME

0514112-1 TRIM - SEAT . .................... B40 C21 C25 532 279 C33 A84 B760715049-1 SPLICE - CABIN DOOR AFT . ............ . B40 C21C25 532 279 C33 A84 B761706054-1 COVER - CABIN AIR OUTLET REAR . ........ 532 532 532532532532 532 5321713362-4 COVER ASSY - FLAP INDICATOR ............ A59 A59 A59 A59 A59 AS A59 A591714088-1 PANEL - SEAT BACK LH. .............. B40 21 C25 532 279 C33 A84 B761714088-2 PANEL - SEAT BACK R ........... B40C2 C25532279 C33 A84 B761714089-1 PANEL - SEATBACK ................. B40 C21 C25c25 532 279 C33 A84 B761715013-1 ESCUTCHEON - HEADLINER ACCESS .......... 532 532 532 532 532 532 532 5321715027-3 RETAINER- LH........ ............. 532 532 532 532 532 532 532 5321715027-4 RETAINER - B ....... ............ 532 532 532 532 532 532 532 5321715034-1 MOLDING - LH ....... B4. . B40 C21 C25 279 279 C33 A84 B761715034-2 MOLDING-RH . ................. ... B40C21C25 279 279C33 A84 B761715041-1 MOLDING -- READ WINDOW UPR ........ 532532 532 532 532 532 532 5321715041-2 MOLDING - REAR WINDOW LWR ............ 532 532 532 532 532 532 532 5321715042-23 TRIM - LWR L DOOR ................. B40 C21 C25 532 279 C33 A84 B761715042-24 TRIM - LWR RH DOOR ................ .. B40C2C553 .01 C33 A8 B761715047-1 ESCUTCHEON- LH ................. .B40 C21 C25 532 279 C33 A84 B761715047-2 ESCUTCHEON- RH ................. B40 C21 C25 532 279 C33 A84 B761715050-1 MOLDING - VENT WINDOW RETAINER LB ...... 532 532 532 532 532 532 532 5321715050-2 MOLDING - VENT WINDOW RETAINER RH........ 532 532 532 532 532 532 532 5321715062-1 COVER - DECK SKIN .................. 825 825 825 825 825 825 825 8251715066-1 SPLICE - CABIN DOOR LH FWD. ............ B40 C21 C25 532 279 C33 A84 B761715066-2 SPLICE - CABIN DOOR RE FWD. ............ B40 C21 C25 532 279 C33 A84 B762013020-14 COVER - HAND PUMP ................ B40 C21 C25 532 279 C33 A84 B762013065-10 COVER ASSY - PEDESTAL WITH COURTESY LIGHT . B40 C21 C25 279 279 C33 A84 B762013065-12 COVER ASSY - PEDASTAL .............. B40 C21 C25 279 279 C33 A84 B762013161-7 COVER - LWR LH SWITCH PANEL. ........ B40 C21 C25 279 279 C33 A84 B762013161-8 COVER - LWR RH SWITCH PANEL. ........... B40 C21 C25 279 279 C33 A84 B762015002-1 COVER - BAGGAGE DOOR . ............. B40 C21 C25 279 279 C3 A84 B762015003-1 COVER - REAR BAGGAGE DOORPOST . ....... .. B40 C21 C25279 279 C33 A4 B762015005-1 MOLDING - BAGGAGE DOOR JAMB .. .. B40 C21 C25 279 279 C33 A84 B762015006-2 MOLDING - BAGGAGE DOOR JAMB ABOVE BELTLINE 532 532 532 532 532 532 532 532

BELOW BELTLINE - B41 C22C26 532 151 C34 A85 B772015008-1 COVER - BAGGAGE DOOR BALANCE ....... .. B40 C21 C25 532279 C33 A84 762015014-7 TRIM PANEL - RH AFT BAGGAGE COMPARTMENT. ... B40 C21 C25 532 279 C33 A84 B762015015-1 TRIM PANEL ASSY - LH FWD . ............ B40C21 25 532 279 C33 A84 B762015015-2 TRIM PANEL ASSY - RH FWD. ............ . B40 C21 C25 532 279 C33 A84 B762015017-1 PANEL ASSY - AFT WALL . ............. B40 C21 C25 532 279 C33 A84 B762016034-1 COVER - DRAIN CONTROL .............. . B40C21 C25 532279 C33 A84 762016035-2 COVER - FUEL SELECTOR VALVE .......... . B40C21 C25532 279 A84 B76

xxix

MODEL 177RG

ALPHABETICAL INDEXNOMENCLATURE FIGURE NOMENCLATURE FIGURE

A A(Cont)

ACCESSORY KITS-SEE ACCY KIT CATALOG . AMMETER GAGE . ........... 49CACTUATOR & MOTOR FLAP ....... 7h3 ANTENNA VHF ..... .... . 5ACTUATOR MAIN GEAR. ....... 88A ANTENNA VHF .......... 5AACTUATOR MAIN GEAR. ......... 88F ARMREST . ............ 41ACTUATOR MAIN GEAR DOWNLOCK ..... 88F ARMREST ............. .. 43ACTUATOR MAIN GEAR UNLOCK & SEQUENCE. 88A ARMREST BRACKET .......... 18ACTUATOR MAIN LANDING GEAR .... . 88 ARMREST BRACKET . ... . . . . . . . 38ACTUATOR NOSE GEAR . ....... 37 ARMREST BRACKET ........ . . . 38AACTUATOR NOSE GEAR. ....... 87 ASH RECEIVER.. ..... ..45ACTUATOR NOSE GEAR DOOR .. .. 37 ASH RECEIVER . .... . ... 46ACTUATOR STABILATOR TRIM.. .... 75 ASH TRAY ........... . .43ACTUATOR SWITCH ... ........ 73 ASH TRAY. ....... ..... 49ADAPTER OIL COOLER .. ...... 57 ASH TRAY. .............. 49AADAPTER OIL FILTER ..... . . . . 62 ASH TRAY .............. 49BADHESIVE GASKET . .......... ASH TRAY. ............. 49CAFT CABIN WINDOWS ... ...... 22 ASSIST HANDLE ........... 42AFT CARPET ... .... .... 43 ASSIST HANDLE .... . ...... 42AAFT FLOORBOARD ..... .... 18 AUTO PILOT-SEE ELECTRONICS MANUAL .AILERON ............. 8 AXLE. ............ ... 33AILERON BELLCRANK .......... 70AILERON CABLE .......... 69AILERON CABLE . ...... ...AILERON CONTROL SYSTE. ........ 70AILERON CONTROL TUBE. .. .... .69AILERON PULLEY ........ .. . 70 BAFFLE OIL COOLER .......... 56AILERON PULLEY BRACKET ..... .. 5 BAFFLE SEAL ............. 57AILERON PULLEY BRACKET. . ..... 5A BAFFLE SFAL ....... .... 61AILERON PULLEY BRACKET .... . . .15 BAFFLE SEAL . ........ . 61AAILERON PULLEY BRACKET ........ 15A BAFFLES ENGINE. ......... 61AILERON PULLEY BRACKET ...... 72 BAFFLES ENGINE. . . . . 61AAILERON RIB ........... 4 BAGGAGE DOOR. . .. . . . . . . . 18AILERON RIB ............. 8 BAGGAGE DOOR ....... .40AILERON SERVO ...... .2 BAGGAGE DOOR FUSELAGE ... . 40AILERON SERVO BRACKET ... 72 BAGGAGE DOOR HANLE ......... 40AILERON TRIM TAB. ......... 8 BAGGAGE DOOR JAMB . ... . . ... 21AIR FILTER. .... ...... .57 BAGGAGE DOOR LATCH ......... 40AIR FILTER. ............. 82BAGGAGE DOOR LOCK ... .... .40AIR OUTLET .... ...... 17 BAGGAGE DOOR STRIKER PLATE ... . 40AIR SCOOP ... .......... 54 BAGGAGE NET . ........... 50AIR SCOOP ............ 54A BAGGAGE PLACARD ........... 2AIR TEMP GAGE OUTSIDE ......... 51A BALANCE WEIGHT AILERON ....... 8AIR TEMP OUTSIDE . ......... 51. BARREL TURNBUCKLE ..... 70AIR TEMPERATURE GAGE OUTSIDE ..... 51A BARREL TURNBUCKLE .......... 73AIR VENTILATION SYSTEM CABIN . .... 63 BARREL TURNBUCKLE ......... 75AIRBOX.. ............. . 63 BARREL TURNBUCKLE ......... 76AIRCRAFT IDENTIFICATION NAMEPLATE . .13 BATTERY. ..... ....... .. 89AIRSPEED INDICATOR. ........ 49 BATTERY ..... .......... 89AAIRSPEED INDICATOR . ....... 49A BATTERY BOX . .......... .26AIRSPEED INDICATOR ......... 49B BATTERY BOX ............ 26AAIRSPEED INDICATOR. ..... . . . . 49C BATTERY BOX BASE . ......... 26AIRSPEED INDICATOR. ......... 78A BATTERY BOX LID .......... 26AAIRSPEED INDICATOR TRUE. ...... 49 BATTERY BOX SUPPORT .. ....... 6AAIRSPEED INDICATOR TRUE. ...... 49A BATTERY CABLE . .. . . . . . 89AIRSPEED INDICATOR TRUE . ..... 498 BATTERY CABLE . ... ... . 89AAIRSPEED INDICATOR TRUE ....... 49C BATTERY CONTACTOR ......... 89ALTERNATOR. ... . ...... 58 BATTERY CONTACTOR .......... 89AALTERNATOR. ... ......... 89 BEACON FLASHER. ...... . . . . . 89ALTERNATOR BELT ....... . . . 89 BEACON FLASHER. ........ .89AALTERNATOR BELT ........... 89A BEACON FLASHING . . . . . . . . . . . 93ALTERNATOR DRIVE BELT ........ 57 BEACON LIGHT FLASHER. ....... 93ALTERNATOR 60 AMP . . . . . . . . . . 89A BELLCRANK AILERON .... .70ALTIMETER . ... . ....... 78 BELLCRANK PARKING BRAKE .... .68ALTIMETER ............. 78A BELLCRANK STABILATOR TRIM TAB ... 75ALTIMETER DUAL. .......... 78 BELT ALTERNATOR ....... . . . . 89ALTIMETER ENCODING .... .... 78A BELT ALTERNATOR ............ 89AALTIMETER SENSITIVE ........ 49 BELT ALTERNATOR DRIVE ........ 57AMMETER GAGE ............. 49 BELT FRONT SEAT .... ..... 50AAMMETER GAGE. ... .... . . . . 49A BELT REAR SEAT . .......... 50A

XXX


B(Cont) C(Cont)BELT SEAT .............. 50A CABIN HEAT CONTROL......... . 49BLIND ENCODER ...... ...... 788 CABIN HEAT CONTROL .... . . 49CBOTTOM SEAT ............. 4A CABIN SECTION CENTER.. ....... 18BOWL FUEL STRAINER. .... .. 80 CABIN SECTION LOWER CENTER. 18BOX BATTERY ............. 26 CABIN SIDE & FLOORBOARD UPHOLSTERY. 43BOX BATTERY ....... ... 26A CABIN SOUNDPROOFING ......... 44BOX GLOVE . . ............ 15 CABIN STEP. .... ......... 13BOX GLOVE ............ 15A CABIN TOP ............. 14BRAKE ...... ...... 36 CABIN TOP ............. 15BRAKE ................ 36 CABIN TOP . ............ 15ABRAKE .......... ..... 66 CABIN TOP . ..... ....... 42ABRAKE & RUDDER PEDALS ........ 66 CABIN TOP & FIREWALL UPHOLSTERY . .. 42BRAKE CYLINDER.......... 36B CABIN TOP & FIREWALL UPHOLSTERY . .42ABRAKE DISC .............. 36 CABIN TOP UPHOLSTERY........ 42BRAKE DISC .. . . ........ 36B CABIN WINDOWS AFT ........ .22BRAKE LINE. .......... 65 CABLES-CONTROL-SEE APPLICABLE SYSTEM.BRAKE LINING. .......... . 36 CAM DOOR LOCK .......... 38BRAKE LINING. ............ 36A CAM DOOR LOCK .......... 38ABRAKE LINING. ............. 36B CAP FUEL .. ............ 3BRAKE MAIN GEAR ........... 36B CAP HUB ............ 27BRAKE PARKING ........ .. 68 CAP HUB . . .33BRAKE SYSTEM. .......... .65CAP LOWER NOSE. .......... 54BREAKER CIGAR LIGHTER CIRCUIT ... 49B CAP LOWER NOSE .. ........ .54ABREAKER CIGAR LIGHTER CIRCUIT . .. 49C CAP NOSE WHEEL HUB. ........ 27BULB ALSO SEE LIGHTS. ....... .CAP UPPER NOSE. ........... 54BULB COMPASS . .......... 51A CAP UPPER NOSE. ........ .54ABULB COURTESY LIGHT ......... 92 CAPACITOR . ........... 89BULB DONE LIGHT ........... 89 CARPET. ... ............. 43BULB DOME LIGHT . .......... 89A CARPET AFT. ............. 43BULB FLASHING BEACON.. ....... 93 CATALOG-HOW TO USE-SEE INTRODUCTION .BULB GEAR INDICATOR ........ 49 CATCH MAGNETIC. . ..... ... .49BULB GEAR INDICATOR . . .. 49A CATCH MAGNETIC............ 49ABULB GEAR INDICATOR ......... 49B CATCH MAGNETIC ............ 49BBULB GEAR INDICATOR ........ 49C CATCH MAGNETIC... . ...... 49CBULB GLARE SHIELD LIGHT ...... 90 CATCH MAGNETIC. ........... 83BULB INSTRUMENT CLUSTER .... .. 49B CENTER BELLY SECTION FUSELAGE ... 19BULB INSTRUMENT CLUSTER ...... 49C CENTER CABIN SECTION. ....... 18BULB INSTRUMENT CLUSTER ...... 490 CENTER CABIN SECTION LOWER ..... 18BULB INSTRUMENT PANEL ........ 90 CENTER FLOORBOARD .......... 18BULB INSTRUMENT PANEL LIGHT ..... 90 CESSNA NAMEPLATE. .......... 2BULB PEDESTAL LIGHT ........ 92 CHAIN RUDDER TRIM ......... 77BULB POST LIGHT. .......... 490 CHAIN STABILATOR TRIM . ..... 75BULB POST LIGHT . .......... 49E CHECK LIST PILOTS ... 2..BULB POST LIGHT . ....... 49F CHECK VALVE ............. 84ABULB WING POSITION LIGHT. ...... 3 CHECK VALVE ............ 88CBULK ITEMS-LIST OF . .... .... CIGAR LIGHTER ............ 49BUNGEE NOSE GEAR STEERING ...... 28 CIGAR LIGHTER ........... 49A

CIGAR LIGHTER ........... 49BCIGAR LIGHTER .. 49CC CIGAR LIGHTER FUSE. ......... 49ACIGAR LIGHTER KNOB... .49CIGAR LIGHTER KNOB. ......... 49A

CABIN AIR CONTROL .......... 49 CIGAR LIGHTER KNOB .......... 49BCABIN AIR CONTROL .......... 49A CIGAR LIGHTER KNOB. .......... 49CCABIN AIR CONTROL ....... 49B CIGAR LIGHTER RESISTOR. ....... 49CCABIN AIR CONTROL ........ 49C CIGAR LIGHTER RESISTOR. ...... 89ACABIN AIR VENTILATION SYSTEM. .... 63 CIRCUIT BREAKER . .......... 49CABIN DOOR. ........... 38 CIRCUIT BREAKER ........... 49ACABIN DOOR. ........... 38A CIRCUIT BREAKER . ..... ...... 49BCABIN DOOR. ........... 43 CIRCUIT BREAKER ........... 49CCABIN DOOR LATCH. . ......... 39 CIRCUIT BREAKER CIGAR LIGHTER .. . 49BCABIN DOOR STOP ........... 38 CIRCUIT BREAKER CIGAR LIGHTER .. . 49CCABIN DOOR STOP ........... 38A CLIP DOOR HANDLE........... 38CABIN DOOR STRUCTURE. ....... 38 CLIP DOOR HANDLE. ........... 38ACABIN DOOR STRUCTURE. ...... 38A CLOCK ELECTRIC ............ 49CABIN DOOR UPHOLSTERY ....... 41 CLOCK ELECTRIC. ........... 49ACABIN HEAT CONTROL. .......... 49 CLOCK ELECTRIC........... 49BCABIN HEAT CONTROL . ........ 49A CLOCK ELECTRIC .......... .. 49C

MODEL 177RG


C(Cont) DCLOCK FUSE.... ......... 89 DAMPENER SHIMMY ........... 32CLOCK FUSE ............. 89A DEADENER SOUND .. .... . .....CLUSTER INSTRUMENT ........ 49 DECALS-SEE PLACARDS . ........CLUSTER INSTRUMENT. ......... 49A DECK SKIN .............. 15CLUSTER INSTRUMENT. ........ 49B DECK SKIN ............. 15ACLUSTER INSTRUENT. ........ 49C DEFLECTOR .............. 42COAT HANGER HOOK.... .. 42 DEFLECTOR ......... .... 42ACOLLAR CONTROL TUBE ..... . .. 69 DEFLECTOR .. .. ......... 56COMPASS ............... 51A DEFLECTOR ...... ........ 91COMPASS & OUTSIDE AIR TEMPERATURE . 51A DEFLECTOR DEFROST ......... 42COMPASS BULB.. .......... 51A DEFROST DEFLECTOR .......... 42COMPASS CORRECTION PLACARD 2 ..... DEFROST NOZZLE. .......... 15COMPASS CORRECTION PLACARD ...... 51A DEFROST NOZZLE. ............ 64COMPONENTS & ACCESSORIES ENGINE . . 58 DEFROST VALVE . ........... 64COMPONENTS ENGINE ......... 58 DEFROST VALVE .. ....... 64ACONNECTOR PITOT TUBE. ....... 78 DEFROSTER CONTROL ......... 49CONTACTOR .............. 89 DEFROSTER CONTROL ......... 49ACONTACTOR .............. 89A DEFROSTER CONTROL ..... ..... 49BCONTACTOR BATTERY .......... 39 DEFROSTER CONTROL ......... 49CCONTACTOR BATTERY ......... 89A DETECTOR NAVIGATION LIGHT ..... 3CONTACTOR EXTERNAL POWER. ...... 89 DETECTOR STALL WARNING. ....... 89CONTACTOR EXTERNAL POWER. ...... 89A DETECTOR STALL WARNING. .. ..... 89ACONTACTOR STARTER ........ 89 DIMMER TRANSISTORIZED . . ...... 89CONTACTOR STARTER .......... 89A DIMMER TRANSISTORIZED ...... 89ACONTROL CABLES-SEE INDIVIDUAL SYSTEM. DIODE ................ 49CONTROL SYSTEMS-SEE INDIVID SYSTEMS . DIODE .............. .49ACONTROL WHEEL SEE WHEEL-CONTROL . . .DIODE ................ 89CONTROL-PUSHPULL-SEE ENGINE INSTL.. DIODE ......... ...... 89ACONTROL-PUSHPULL-SEE INSTRUMENT PANEL DIODE EXTERNAL POWER. ....... 89COOLER OIL .............. 57 IODE EXTERNAL POWER. ...... 89ACOORDINATOR TURN. .......... 49 DIPSTICK ....... . ...... 84ACOORDINATOR TURN . ........ 49A DIRECTIONAL GYRO. ......... .49COORDINATOR TURN ........... 72 DIRECTIONAL GYRO .......... 49ACOURTESY LIGHT BULB ..... .... 92 DIRECTIONAL GYRO.... ...... 49BCOURTESY LIGHT SHIELD .... ... . 92 DIRECTIONAL GYRO . ....... . 49CCOURTESY LIGHT SOCKET ........ 92 DIRECTIONAL GYRO. ......... 82COURTESY LIGHTS ........... 92 DISC BRAKE. ............. 36COWL ENGINE ............ 54 DISC BRAKE ..... ........ 36BCOWL ENGINE .......... D.. 54A DISCHARGER STATIC ..........COWL FLAP . ............. 54 DISCHARGER STATIC ......... 11COWL FLAP ............. 54A DISCHARGER STATIC ... . ...... 12COWL FLAP CONTROL . ........ 55 DOME LIGHT BULB ........... 89COWL FLAP CONTROL BRACKET .... DOME LIGHT BULB ........... 89ACOWL FLAP CONTROL BRACKET ...... 54 DOME LIGHT LENS . ......... 89COWL FLAP CONTROL BRACKET ...... 54A DOME LIGHT LENS .. ........ 89ACOWL FLAP CONTROLS.. ....... 55 DOME LIGHT SOCKET .......... 89ACOWL FLAP POSITION BRACKET..... 17 DOME LIGHT SWITCH ... . ..... 89COWL LOWER.. ........... .54 DOME LIGHT SWITCH .......... 89ACOWL LOWER. ........... . 54A DOME SPINNER. ......... 52COWL UPPER. 54 DOOR BAGGAGE. ............. 18COWL UPPER. .............. 4A DOOR BAGGAGE. . .......... 40CRANK VENT WINDOW ......... 39 DOOR CABIN. ............. 38CRANK VENT WINDOW .......... 38A DOOR CABIN. ........... 38ACUP FUEL SAMPLER. .......... 6 DOOR CABIN. . . ....... .43CUP HOLDER. .............. 50 DOOR CLOSE LOCK VALVE . ... .88CCYLINDER BRAKE. ........... 368 DOOR EXTERNAL POWER . ........ 89ACYLINDER HEAD TEMP GAGE ....... 49B DOOR FUEL FILLER. .......... 3CYLINDER HEAD TEMP GAGE ....... 49C DOOR FUSELAGE BAGGAGE . ...... 40CYLINDER HEAD TEMP TRANSDUCER .. . 49A DOOR GLASS. ...... ....... 38CYLINDER HEAD TEMP TRANSDUCER . 57 DOOR GLASS ............. 38ACYLINDER HEAD TEMPERATURE GAGE. . 49 DOOR GLOVE BOX ........... 49CYLINDER HEAD TEMPERATURE GAGE.... 49A DOOR GLOVE BOX. .......... 49ACYLINDER HEAD TEMPERATURE GAGE.... 49B DOOR GLOVE BOX .. ......... 49CYLINDER MASTER BRAKE ........ 67 DOOR GLOVE BOX. .......... 49C

DOOR HANDLE ............ 38DOOR HANDLE ............. 38ADOOR HANDLE ............. 39DOOR HANDLE CLIP .......... 38

xxxii


D(Cont) E(Cont)

DOOR HANDLE CLIP .......... 38A ENGINE BAFFLES .......... . 61ADOOR HANDLE PLACARD . ........ ENGINE COMPONENTS .......... 58DOOR HANDLE PLACARD ... .... 38 ENGINE COMPONENTS & ACCESSORIES . .- .58

DOOR HANDLE PLACARD ......... 38A ENGINE COWL ............ 54DOOR HINGE. ............ 38 ENGINE COWL ........... 54A

DOOR HINGE .... ......... 38A ENGINE MOUNT . ...... 57DOOR JAMB BAGGAGE . .... 21 ENGINE OIL PLACARD.......... 2DOOR LATCH.. ........... 54 EQUIPMENT ELECTRICAL ........ 89

DOOR LATCH . ............ 54A EQUIPMENT ELECTRICAL . ....... 89ADOOR LATCH CABIN ........... 39 EQUIPENT FUSELAGE ......... 50DOOR LOCK ........... 38 EQUIPMENT WINTERIZATION ..... 56DOOR LOCK ............. 38A EQUIPMENT 24 VOLT ELECTRICAL .... 89ADOOR MOULDING ............ 42 ESCUTCHEON DOOR STOP. .... .. 41DOOR NOSE GEAR ........... 37 ESCUTCHEON HEADLINER ACCESS .... 42DOOR SEAL .............. 40 ESCUTCHEON HEADLINER ACCESS ..... 42A

DOOR STOP ESCUTCHEON. ........ 41 EXHAUST SYSTEM ........ 63DOOR UPHOLSTERY CABIN ..... .. . 41 EXTENSION SEAT BELT .. ..... 51DOOR UPPER COL ........... 54 EXTENSION VALVE ... ....... 27

DOOR UPPER COWL .......... 54A EXTERNAL POWER CABLE ... 89ADOOR WINDOW MOULDING ........ 41 EXTERNAL POWER CONTACTOR ...... 89

DOORPOST. ............. 15 EXTERNAL POWER CONTACTOR. ...... 89ADOORPOST ............ 15A EXTERNAL POWER DIODE. ........ 89DOORPOST. ............... 16 EXTERNAL POWER DIODE ......... 89ADOORPOST. . .. ......... 42A EXTERNAL POWER DOOR .. ..... 89ADOORPOST BULKHEAD FRONT ....... 16 EXTERNAL POWER FUSE ........ 89DOORPOST MOULDING .......... 42 EXTERNAL POWER FUSE ......... 9ADOORPOST REAR ............ 14 EXTERNAL POWER RECEPTACLE ...... 89

DOORPOST REAR ............ EXTERNAL POWER RECEPTACLE ..... 9ADORSAL FIN. .......... ... 10 EXTINGUISHER FIRE ......... 50DORSAL TIP. ...........10 EYEBOLT ............... 24DOWEL PIN WING ATTACH ........ 3 EYEBOLT .. ............ 24ADRAG LINK .... ....... . 27 EYEBOLT .......... ... 37DRAIN VALVE ...... 6 . ... EYEBOLT .............. 43DUAL ALTIMETER.. ... ..... 78 EYEBOLT HOISTING. .......... 50DUAL WARNING UNIT .......... 89DUAL WARNING UNIT .. .. ...... 89ADUCT HEATER ..... ........ 17

E FAIRING FUSELAGE. ......... 3FAIRING WING............. 3FAIRING WING. ............ 14

ECONOMY POWER INDICATOR ... .... 49 FELT GREASE SEAL. ........ 36ECONOMY POWER INDICATOR ..... . 49A FIBERGLASS SOUNDPROOFING ...... 44ECONOMY POWER INDICATOR ..... .. 49B FILTER ............... 80ECONOMY POWER INDICATOR . ...... 49C FILTER. .............. .84AECONOMY POWER INDICATOR PROBE .... 57 FILTER. . . .......... 89ECONOMY POWER PROBE ... .. 57 FILTER AIR ............. 57ELECTRIC CLOCK ..... ...... 49 FILTER AIR. ............. 82ELECTRIC CLOCK . . . ........ 49A FILTER ELEMENT. .......... 82ELECTRIC CLOCK . ........... 98 FILTER ELEMENT KIT .......... 62ELECTRIC CLOCK . ......... 49C FILTER OIL . ..... .62ELECTRICAL EQUIPMENT. .... ... 89 FILTER VACUUM ............ 82ELECTRICAL EQUIPMENT ........ 89A FIN DORSAL ............ 10ELECTRICAL EQUIPMENT 24 VOLT ..... 89A FIN TIP . ... ........... 93ELECTROLUMINESCENT PANEL. ...... 490 FIN VERTICAL. . ............ 10ELECTROLUMINESCENT PANEL. . . .... 49E FINISH & TRIM PLACARD ..... .. 2ELECTROLUMINESCENT PANEL ....... 49F FINISH TRIM-HOW TO READ-PAGE IV .ELECTRONIC EQUIP-SEE ELECT MANUAL .. FIRE EXTINGUISHER .. ... .. 50ELEMENT FILTER . ........... 82 FIRE EXTINGUISHER BRACKET ..... 50ELEMENT KIT FILTER .......... 62 FIREWALL ............ 15ELEVATOR TRIM TAB .......... 75A FIREWALL ............. 15AELEVATOR TRIM TAB ACTUATOR ...... 75A FIREWALL ............. 17EMERGENCY HAND PUMP ....... . 6 FIREWALL COVER ........... 42ENCODER BLIND ... ........ 788 FIREWALL COVER. ........... 2AENCODING ALTIMETER. . .... 78A FIREWALL LOWER ............ 17ENGINE ................ 57 FIREWALL UPPER. .......... 15ENGINE BAFFLES. .......... 61 FIREWALL UPPER .......... 15A

MODEL 177RG


F(Cont) F(Cont)

FLANGE STATIC SOURCE. . .... FUEL PUMP SWITCH.. .......... 49AFLANGE STATIC SOURCE. ....... ISA FUEL PUMP SWITCH. ...... .. 49BFLANGE STATIC SOURCE. ....... 78 FUEL PUMP SWITCH. ...... . 49C-FLAP ............ .... 9 FUEL SAMPLER CUP. . .. ..... 6FLAP BELLCRANK BRACKET. ....... 4 FUEL SELECTOR VALVE ........ 81AFLAP CABLE .... ....... 73 FUEL SELECTOR VALVE . . ...... 81BFLAP CONTROL BRACKET. ........ 9 FUEL SELECTOR VALVE COVER ...... 81AFLAP CONTROL BRACKET ........ 73 FUEL SHUT OFF VALVE . . ... . 81FLAP CONTROL SYSTEM ....... . FUEL STRAINER . ....... .. .FLAP CONTROLS COL. ......... 55 FUEL STRAINER BOWL... . ... .. 80FLAP COWL ....... ...... 54 FUEL STRAINER PLUNGER ... .. . . 80FLAP COWL . .... .. 54A FUEL STRAINER TOP .......... 80FLAP INDICATOR. ........... 73 FUEL SYSTE ... .......... 79FLAP INDICATOR & SWITCH .... 73 FUEL SYSTEM ....... . . . . . . 79AFLAP KNOB .......... . .73 FUEL TANK ............. 6FLAP LEVER. ............ 73 FUEL TANK DRAIN VALVE ........ 6FLAP LIMIT SWITCH ......... 73 FUEL TRANSMITTER .......... 3FLAP TRACK . ........... FUEL VALVE. ............ 810FLAP ,ING ............ . 9 FUEL VALVE HANDLE ..... .. .79FLASHER BEACON ..... ...... 89 FUEL VENT LINE. ........ . 3FLASHER BEACON. 89A FUSE . . . . . . . . . . . . . . . 49FLASHER BEACON LIGHT ..... 93 FUSE. ..... ......... 94FLASHING BEACON .......... 93 FUSE CIGAR LIGHTER .......... 49AFLASHING BEACON BULB. ........ 93 FUSE CLOCK ............. 89FLASHING BEACON LIGHT ..... .93 FUSE CLOCK ..... . . . . . .. . 89AFLASHING BEACON RESISTOR. ... .. .9 FUSE EXTERNAL POWER . ....... 89FLASHING BEACON RESISTOR. ...... 89A FUSE EXTERNAL POWER .... .. . . 89AFLOORBOARD .. .... .. . . . . .. 17 FUSEHLOER. ............. 89FLOORBOARD ............. 18 FUSEHOLDER ..... . ... . 89AFLOORBOARD AFT ........... 18 FUSELAGE. ......... ...... 13FLOORBOARD CENTER ....... .. .18 FUSELAGE. .............. 19FOOTREST. .......... .. 45 FUSELAGE CENTER BELLY SECTION ... 19FOOTREST. ........... ... 45A FUSELAGE EQUIPMENT. ........ 50FORK HAND PUMP. ........... 86 FUSELAGE FAIRING .......... 3FORWARD FUSELAGE STRUCTURE ...... 15 FUSELAGE STRUCTURE FORWARD . . ... 15FORWARD FUSELAGE STRUCTURE. .. . .SA FUSELAGE STRUCTURE FORWARD . ... 15AFORWARD SECTION FUSELAGE LOWER. . . 17FRONT & CENTER CABIN SECTION .... .14FRONT CARRY THRU SPAR ........ 16 GFRONT DOORPOST BULKHEAD ....... 16FRONT SEAT ............. 45FRONT SEAT ............. 45A GAGE-SEE INDIVIDUAL LISTING ..FRONT SEAT. .......... 46 GAS CAP-SEE FUEL CAP ........FRONT SEAT . ............. 46A GAS GAGE-SEE INSTRUMENT PANEL ....FRONT SEAT ............. 46B GASKET ADHESIVE . .........FRONT SEAT BELT ........ .50A GEAR ACTUATOR NOSE. ........ 87FRONT SPAR .............. 16 GEAR DOWN LIGHT .... ...... 49AFUEL CAP. . ....... ..3 GEAR DOWN LIGHT .... ...... 49BFUEL DRAIN CONTROL. ......... 79 GEAR DOWN LIGHT ....... .. 49CFUEL DRAIN VALVE. .......... 79 GEAR DOWN SWITCH. . . ....... 29FUEL FILLER DOOR. ......... 3 GEAR INDICATOR BULB ... ... 49FUEL FLOW GAGE .. . ....... 49 GEAR INDICATOR BULB ......... 49AFUEL FLOW GAGE. ....... 49A GEAR INDICATOR BULB . .. ... 498FUEL FLOW INDICATOR ......... 49B GEAR INDICATOR BULB .. . . . . 49CFUEL FLOW INDICATOR ......... 49C GEAR MAIN LANDING .......... 34FUEL FLOW LINE ............ 49 GEAR SELECTOR LANDING ... .... 88BFUEL FLOW LINE ............ 49A GEAR UP LIGHT .... ..... 49AFUEL FLOW LINE. .. . .. .. .49B GEAR UP LIGHT ........... .. 49FUEL FLOW LINE. ........... 49C GEAR UP LIGHT ..... . . . . 49CFUEL HOSE . ............ . GEAR UP LINE. ........ . .83FUEL HOSE . ........... . 57 GEAR UP LINE . ...... . . .3AFUEL LINE ............. 57 GEAR UP LINE . ....... ... 83BFUEL LINE ..... . . . .... 9 GEAR UP LINE ........... 83CFUEL LINE .............. 79A GEAR UP LINE .... ....... 830FUEL PRESSURE HOSE... ....... 57 GEAR UP LINE . ............ 83EFUEL PUMP . ............ GEAR UP LINE. . ............ 83GFUEL PUMP .............. 79A GEAR UP SWITCH . ........... 29FUEL PUMP SWITCH........... 49 GEAR UPLOCK NOSE. . ... . . . . 29

xxxiv

ALPHABETICAL INDEXNOMENCLATURE FIGURE NOMENCLATURE IFIGURE

G(cont) H(cont)

GEAR WARNING HORN .......... 89 HEADLINER ACCESS ESCUTCHEON ..... 42GLARE SHIELD......... 49A HEADLINER ACCESS ESCUTCHEON ..... 42AGLARE SHIELD......... .... 49B HEADREST. .............. 45GLARE SHIELD. ............ 49C HEADREST ............. 45AGLARE SHIELD LIGHT .... ...... 90 HEADREST ..............GLARE SHIELD LIGHT BULS ....... 90 HEADREST .............. 46AGLARESHIELD ............. 49 HEADREST. ........... 46BGLOVE BOX .. ............ 15 HEADREST. ............. 47GLOVE BOX ............ 15A HEADREST .............. 47AGLOVE BOX 000D ... ... ...... 49 HEADREST .............. 48GLOVE BOX DOOR ............ 49A HEADREST .............. 48AGLOVE BOX DOOR. ........... 49B HEATER DUCT ............. 17-LOVE BOX DOOR . ........... 49C HEATER PITOT. ........... 78

GOVERNO. ............. 59 HEATING DEFROSTING. ...... . 64GOVERNOR BASE .......... 59A HEATING C DEFROSTING ........ 64AGOVERNOR BODY ... ......... 59 HEATING & DEFROSTING. ........ 64BGOVERNOR BODY ............ 59A HEATING PLUG.......... 49GOVERNOR COVER. ........... 59A HINGE DOOR ............. 38GOVERNOR PROPELLER ... ...... 59A HINGE DOOR. 38AGREASE SEAL FELT........... 31 HINGE HALF TAB ... .. 12GREASE SEAL FELT. .......... 31A HOISTING EYEBOLT . ...... . 50GREASE SEAL FELT. .......... 31B HOLDER CUP ............ 50GREASE SEAL FELT.......... 36 HOOK COAT HANGER .......... 42GREASE SEAL FELT........... 36A HORIZON GYRO. .......... 49GREASE SEAL FELT........... 36B HORIZON GYRO............ 49AGRILL VNT .............. 42A HORIZON GYRO ............ .49BGROUND STRAP. ........... 8 HORIZON GYRO............ 49CGROUND STRAP . ............ 57 HORIZON GYRO ............ 82GROUND STRAP .......... 89 HORN GEAR WARNING .......... 89GROUND STRAP ......... .... 89A HORN STALL WARNING ......... 89GYRO DIRECTIONAL ........ 49 HOSE FUEL ..........GYRO DIRECTIONAL. ......... 49A HOSE' FUEL .............. 7GYRO DIRECTIONAL .......... 498 HOSE FUEL PRESSURE ......... 57GYRO DIRECTIONAL. ......... .49C HOSE OIL PRESSURE ...... ... 49AGYRO DIRECTIONAL. .... 82 HOSE OIL PRESSURE .......... 49BGYRO HORIZON............. 49 HOSE OIL PRESSURE ......... 57GYRO HORIZON. ............ 49A HOSES-SEE APPLICABLE SYSTEM ...GYRO HORIZON . ......... 498 HOURMETER .............. 49BGYRO HORIZON .......... . 49C HOUR.ETER . ..... ....... 49CGYRO HORIZON ............ 82 HOW TO ORDER PARTS-SEE INTRODUCTION .

HOW TO ORDER UPHOL PARTS-PAGE XIV . .HOW TO READ FINISH & TRIM-PAGE IV .

HUB CAP .............. . 27HUB CAP ............... 33

HAND PUMP BODY............ 86 HUB CAP NOSE WHEEL ......... 27HAND PUMP EMERGENCY ......... 86 HYDRAULIC POWER PACK ........ 84HAND PUMP FORK . ........... 86 HYDRAULIC POWER PACK.. ..... . 84AHAND PUMP HANDLE ....... .. . 86 HYDRAULIC POWER PACK BODY . .... 84AHANDLE ASSIST ........ . 42 HYDRAULIC PRESSURE SWITCH ...... 83CHANDLE ASSIS .. .......... 42A HYDRAULIC SELECTOR VALVE. . ... 83GHANDLE BAGGAGE DOOR ......... 40 HYDRAULIC SELECTOR VALVE. ..... 88BHANDLE DOOR .... ........ 38 HYDRAULIC SELECTOR VALVE. . . 88DHANDLE DOOR . ........... 38A HYDRAULIC SELECTOR VALVE.. ...... 88EHANDLE DOOR ....... ........ 39HANDLE FUEL VALVE .......... 79HANDLE HAND PUMP........... 86HANDLE INTERIOR DOOR ........ 38HANDLE INTERIOR DOOR ......... 38AHANDLE LIFT ............ 50 IDLER SPROCKET. ........... 77HANDLE PARKING BRAKE. ........ 68 IGNITION HARNESS .......... 58HANDLE SEAT .......... ... 46 IGNITION SIITCH KIT .... .... 49HANDLE SEAT ... .......... 46A IGNITION SWITCH KIT ......... 49AHANDLE SEAT .... ...... ..... 46 IGNITION SWITCH KIT .... ... . 49BHARNESS IGNITION .. ....... 58 IGNITION SWITCH KIT ......... 49CHARNESS SHOULDER . .......... 50A INDICATOR-SEE INSTRUMENT PANEL . .HEADLINER .............. 42 INERTIA REEL ....... 50A... 50AHEADLINER ........ ... . . 42A INSTRUMENT CLUSTER. ........ 49

XXXV

MODEL 177RG


I(Cont) L(Cont)

INSTRUMENT CLUSTER ....... .. 49A LANDING GEAR ACTUATING SYSTEM MAIN. .34INSTRUMENT CLUSTER. ....... 49B LANDING GEAR BULKHEAD MAIN. ..... 20INSTRUMENT CLUSTER. ........ . . 49C LANDING GEAR DOWNLOCK MAIN .... . 35INSTRUMENT CLUSTER BULB ....... 49B LANDING GEAR DOWNLOCK MAIN. .... . 35AINSTRUMENT CLUSTER BULB ....... 49C LANDING GEAR DOWNLOCK MAIN ...... 35BINSTRUMENT CLUSTER BULB ....... 49D LANDING GEAR HYDRAULIC SYSTEM ... 83INSTRUMENT CLUSTER LIGHT. ...... 49B LANDING GEAR HYDRAULIC SYSTEM ... .83AINSTRUMENT CLUSTER LIGHT. ...... 49C LANDING GEAR HYDRAULIC SYSTEM ... 838INSTRUMENT CLUSTER LIGHT. ...... 49D LANDING GEAR HYDRAULIC SYSTEM ... .83CINSTRUMENT PANEL BULB ........ 90 LANDING GEAR MAIN ... ...... 18INSTRUMENT PANEL COVER. ....... 49 LANDING GEAR MAIN ......... 20INSTRUMENT PANEL EQUIPMENT. ..... 49 LANDING GEAR MAIN . . ...... 21INSTRUMENT PANEL EQUIPMENT. ..... 49A LANDING GEAR MAIN .......... 33INSTRUMENT PANEL EQUIPMENT. ..... 498 LANDING GEAR MAIN ......... 34INSTRUMENT PANEL EQUIPMENT ...... 49C LANDING EAR MAIN .......... 35INSTRUMENT PANEL LIGHT. ....... 90 LANDING GEAR MAIN .......... 35AINSTRUMENT PANEL LIGHT BULB ..... 90 LANDING GEAR MAIN ........ . 35BINSTRUMENT PANEL LIGHTS ....... 90 LANDING GEAR SELECTOR . ..... 88BINSTRUMENT-SEE INDIVIDUAL LISTINGS. . LANDING LAMP... ....... .. . 91INTERIOR DOOR HANDLE. ........ 38 LANDING LIGHT BRACKET ....... 91INTERIOR DOOR HANDLE ....... . 38A LANDING LIGHT COVER ......... 5INVERTER. ............ . . 72 LANDING LIGHT COWL. ..... . .. 91

LANDING LIGHT LENS. ........ 91LANDING LIGHTS. ...... .. . . 91J LATCH .............. . 26LATCH ................ 26ALATCH . . . . . . . . . 35

JACK MICROPHONE-SEE ELECT MANUAL. . . LATCH ............... 35AJACK POINT WING ........... 50 LATCH ..... .......... 35BJACK-HEADSET-SEE ELECT MANUAL .... LATCH BAGGAGE DOOR ......... 40JA BAGGAGE DOOR .......... 21 LATCH DOOR ..... ...... 54

LATCH DOOR. . ........... 54ALEADING-EDGE SKIN .... .. .. 5K LEADING EDGE SKIN .......... 5ALEADING EDGE SKIN ... ...... 12LEADING EDGE WING .......... 5

KIT IGNITION SWITCH ......... 49 LEADING EDGE WING .. ...... . 5AKIT IGNITION SWITCH ........ 49A LENS DONE LIGHT .......... 89KIT IGNITION SWITCH ......... 498 LENS DOME LIGHT .. . ... . . 89AKIT IGNITION SWITCH ......... 49C LENS LANDING LIGHT .... ...... 91KIT SEAT ROLLER ........... 45 LENS PEDESTAL LIGHT ...... 92KIT SEAT ROLLER ....... .... . 45A LENS STROBE LIGHT .. ......... 3KIT SEAT ROLLER ........... 46 LENS TAIL LIGHT .......... 11KITS-SEE ACCESSORY KIT CATALOG. ... LENS TAIL LIGHT CLEAR ..... 11KNOB CIGAR LIGHTER .......... 49 LENS WING POSITION LIGHT GREEN ... 3KNOB CIGAR LIGHTER .......... 49A LENS WING POSITION LIGHT RED .... 3KNOB CIGAR LIGHTER ......... 498 LEVELER WING .. ....... . 72KNOB CIGAR LIGHTER .......... 49C LEVER FLAP . ............ 73KNOB FLAP .... .......... 73 LEVER SPEED ADJUSTMENT.. .... ... 59AKNOB RHEOSTAT ............ 49D LID BATTERY BOX .......... . .26AKNOB SEAT ADJUST. .......... 46 LIFT HANDLE ............ . .. 50KNOB SEAT ADJUSTMENT. ........ 45 LIFT HANDLE TAILCONE. ..... 50KNOE SEAT ADJUSTMENT. ........ 45A LIGHT COWL LANDING.......... 91KNOE SEAT ADJUSTMENT. .... 47 LIGHT FLASHING BEACON . .. . . . .. 93KNOB SEAT ADJUSTMENT ........ . 47A LIGHT GEAR DOWN ... ........ 49AKNOB SEAT ADJUSTMENT ... ..... 48 LIGHT GEAR DOWN . ...... . ... 49KNOE SEAT ADJUSTMENT ........ 48A LIGHT GEAR DOWN . ...... .. 49CKNOB VALVE. .. ......... .. 72 LIGHT GEAR UP........ 49AKNOBS-SEE INDIVIDUAL APPLICATIONS . LIGHT GEAR UP . . . ....... 49B

LIGHT GEAR UP ...... ...... 49CLIGHT GLARE SHIELD ......... 90

L LIGHT INSTRUMENT CLUSTEk- . .. . 49BLIGHT INSTRUMENT CLUSTER ....... 49CLIGHT INSTRUMENT CLUSTER ....... 490

LAMP LANDING. ............ 91 LIGHT INSTRUMENT PANEL ...... 90LAMP TAIL LIGHT .. ....... . 11 LIGHT OVERVOLT. ... ....... . 49LAMPS-SEE BULBS ........... LIGHT OVERVOLT ..... ...... 49ALAMPS-SEE LIGHTS. .......... . LIGHT OVERVOLTAGE ... .... - . 49B

xxxvi


L(Cont) M(ont)LIGHT OVERVOLTAGE ....... 49C MAIN LANDING GEAR DOWNLOCK .... 35ALIGHT POST. ..... ..... 49D MAIN LANDING GEAR DOWNLOCK . ... 35BLIGHT POST. .......... 49E MAIN LANDING GEAR PIVOT ...... 34LIGHT POST. ............. 49F MANIFOLD PRESSURE LINE ... ... 49LIGHT RUDDER. ........... 11 MANIFOLD PRESSURE LINE ....... 49ALIGHT STROBE. ........... 3 MANIFOLD PRESSURE LINE. .... . 49BLIGHTER CIGAR ............ 49 MANIFOLD PRESSURE LINE. .. .... 57LIGHTER CIGAR ........... 49A PLIGHT CONTROL WHEEL ........ 94LIGHTER CIGAR ........... 49B MARKER BEACON PLACARD ........ 2LIGHTER CIGAR ..... ..... 49C MASTER BRAKE CYLINDER ....... 67LIGHTS COURTESY ........... 92 MASTER SWITCH . ... ..... .49LIGHTS LANDING. ........ . . . 91 ASTER SWITCH ............ 49ALIMIT SWITCHES-SEE SWITCHES ..... MASTER SWITCH ........... 49BLINES-SEE INDIVIDUAL SYSTE ..... MASTER SWITCH ........... 49CLINING BRAKE ............ 36 MCAULEY PROPELLELINING BRAKE .......... . 36A MCCAULEY PROPELLER. ........ 53LINING BRAKE . .......... 368 METERING PIN ........... 30LINK DRAG . ............. 27 MIKE SWITCH . ............ 94LINK LOWER TORQUE ........ 30 MIRROR & COVER ....... . .. 50LINK TORQUELINK UPPER TORQUE .......... 30 MIXTURE CONTROL ......... .49ALOCK BAGGAGE DOOR ... .... .. 4 MIXTURE CONTROL .... ..... 498LOCK CONTROL. ............ 50 MIXTURE CONTROL ......... 49CLOCK DOOR ...... ..... . 38 MOORING RING. ............ 3LOCK DOOR ...... ....... 38A MOORING RING . ........... 7LOCK NOSE EAR .. ......... 27 MOTOR POWER PACK........... 84ALOWER COWL. ............. MOULDING DOOR ........... 42LOWER COWL. ............. 54A MOULDING DOOR WINDO ........ 41LOWER FIREWALL ........... 17 MOULDING DOORPOST ......... 42LOWER FORWARD SECTION FUSELAGE ... 17 MOULDING REAR WINDOW . ....... 42LUBRICATION FITTING ... . . . . . 20 MOULDING WINDOW ........ 2LUBRICATION FITTING ......... 34 MOULDING WINDOW ........ 42

MOULDING WINDOW .......... 42AMOUNT COWL SHOCK. ......... 15

M MOUNT COWL SHOCK ........... 15AMOUNT ENGINE ........ .... 57MOUNT SHOCK ............. LSA

MAGAZINE POCKET ........... 45 MOUNT SHOCK ........... 54MAGAZINE POCKET ........... 46 MOUNT SHOCK ............. 54AMAGAZINE POCKET ........... 46A MUFFLER . ...... . . . . . . 60MAGAZINE POCKET .. ....... . 468 MUFFLER SHROUD. . ..... . . . 60MAGNETIC CATCH.. ......... 49MAGNETIC CATCH.. .. ...... 49AMAGNETIC CATCH.. ......... .49BMAGNETIC CATCH. 49CMAGNETIC CATCH. ........ 83MAGNETO ............. 58 NAMEPLATE .............. 2MAIN GEAR ACTUATOR. ........ 88A NAMEPLATE .......... . .59AMAIN GEAR ACTUATOR ......... 88F NAMEPLATE ........ 83MAIN GEAR BRAKE .. ...... .368 NAMEPLATE . ........... .88CMAIN GEAR DOWNLOCK . . ..... 83D NAMEPLATE . ..... ..... . 88FMAIN GEAR DOWNLOCK ACTUATOR ..... 88F NAMEPLATE AIRCRAFT IDENTIFICATION . .13MAIN GEAR UNLOCK & SEQUENCE ACTUATOR. 88A NAMEPLATE CESSNA ......... 2MAIN GEAR WHEEL ... ..... 36 NAMEPLATE CONTROL WHEEL .. . . 2MAIN GEAR WHEEL ........... 36A NAMEPLATES. ............ 2MAIN GEAR WHEEL ...... .... 36B NAMEPLATES & EXTERIOR MARKINGS. . . 2MAIN LANDING GEAR .......... 18 NAVIGATION LIGHT DETECTOR ..... 3MAIN LANDING GEAR ..... ... 20 NAVOMATIC-SEE ELECTRONICS MANUAL. .MAIN LANDING GEAR ........ 21 NET BAGGAGE ............ 5MAIN LANDING GEAR ..... . . . . . 33 NOSE CAP LOWER ............ 54MAIN LANDING GEAR ......... 34 NOSE CAP LOWER. ........... 54AMAIN LANDING GEAR ......... 35 NOSE CAP UPPER ............ 54MAIN LANDING GEAR ......... 35A NOSE CAP UPPER ............ 54AMAIN LANDING GEAR ... ....... 358 NOSE GEAR ........ .... .17MAIN LANDING GEAR ACTUATING SYSTEM.. 34 NOSE GEAR . ............ . 27MAIN LANDING GEAR ACTUATOR. ..... 88 NOSE GEAR ............ 37MAIN LANDING GEAR BULKHEAD ..... 20 NOSE GEAR ACTUATOR .......... 37MAIN LANDING GEAR DOWNLOCK ..... 35 NOSE GEAR ACTUATOR ......... 87

xxxvii

MODEL l77RG

ALPHABETICAL INDEXNOMENCLATURE FIGURE NOMENCLATURE IFIGUR

N(Cont) P

NOSE GEAR DOOR .... . ...... 37 PAD CONTROL WHEEL ......... 69NOSE GEAR DOOR ACTUATOR ....... 37 PAINT-SEE FINISH & TRIM PLATE-PAGE IVNOSE GEAR DOORS & ACTUATOR... .. 37 PAINTED PARTS-HOW TO ORDER-PAGE XV .NOSE GEAR LOCK. ..... ... .. 27 PANEL & RADIO LIGHTS RHEOSTAT . .. 49BNOSE GEAR SHOCK STRUT PLACARD ... 2 PANEL & RADIO LIGHTS RHEOSTAT .... 49NOSE GEAR STEERING. ....... 28 PANEL DOOR TRIM ..... ..... 41NOSE GEAR STEERING BUNGEE ...... 28 PANEL ELECTROLUMINESCENT ..... 49DNOSE GEAR STEERING SYSTEM ..... 28 PANEL ELECTROLUMINESCENT. ...... - 49ENOSE GEAR SUPPORT ........ 15 PANEL ELECTROLUMINESCENT. ...... 49FNOSE GEAR SUPPRT .......... 15A PANEL EQUIPMENT INSTRUMENT. ..... 49NOSE GEAR SUPPORT ......... 54 PANEL EQUIPMENT INSTRUMENT ...... 49ANOSE GEAR SUPPORT .... ... .. 54A PANEL EQUIPMENT INSTRUMENT. ..... 49BNOSE GEAR TRUNNION .......... 30 PANEL EQUIPMENT INSTRUMENT. .... 49CNOSE GEAR UPLOCK. .......... 29 PANEL LIGHTS INSTRUMENT .. ..... 90NOS E GEAR WHEEL ........... 31 PANEL REMOVABLE .. ......... 49NOSE GEAR WHEEL ........... 31A PANEL REMOVABLE .......... 49ANOSE GEAR WHEEL ........... 31B PANEL REMOVABLE ........... 49BNOZZLE DEFOST ............ 15 PANEL REMOVABLE ........... 49CNOZZLE DEFROST. .......... 64 PANEL STATIONARY. ...... .. 49

PANEL STATIONARY. ......... 49APANEL STATIONARY ........... 49BO PANEL STATIONARY .......... 49CPANEL TRIM ............. 41PANEL TRIM. . . ........ 43

OIL COOLER ............. 57 PARKING BRAKE .. ......... 68OIL COOLER ADAPTER ......... 57 PARKING BRAKE BELLCRANK ....... 68OIL COOLER BAFFLE .......... 56 PARKING BRAKE HANDLE ......... 68OIL FILTER. .......... 62 PARKING BRAKE SUPPORT ........ 17OIL FILTER ADAPTER. ......... 62 PARKING BRAKE SUPPORT ....... 68OIL FILTER PLACARD. ......... 2 PAWL SEAT BACK . .. ..... 45OIL FILTER PLACARD, ......... 62 PAWL SEAT BACK. .......... .45AOIL GAGE.... .......... 49B PAWL SEAT BACK. ........ .47

OIL GAGE............... PAWL SEAT BACK. . ........... 47AOIL LINE.. ........ .... 49C PAWL SEAT BACK ADJUSTMENT ..... 45OIL LINE. ............. 57 PAWL SEAT BACK ADJUSTMENT ...... 45AOIL PLACARD .. .......... .2 PEDESTAL.. ........... ..17OIL PRESSURE GAGE .......... 49 PEDESTAL. .............. 46OIL PRESSURE GAGE . ........ 49A PEDESTAL ............... 46AOIL PRESSURE HOSE ......... 49A PEDESTAL. . .......... 468OIL PRESSURE HOSE ..... ... .. 49B PEDESTAL COVER........... .43OIL PRESSURE HOSE .......... 57 PEDESTAL LIGHT BULB ....... 92OIL PRESSURE LINE ........ 49 PEDESTAL LIGHT LENS ......... 92OIL PRESSURE LINE . ......... 49A PEDESTAL SEAT ............ 46OIL PRESSURE LINE ......... 49B PEDESTAL SEAT ........... 46AOIL PRESSURE SWITCH.........57 PEDESTAL SEAT ............ 46BOIL PRESSURE TRANSDUCER .. , .... 57 PILOTS CHECK LIST ......... 2OIL QUICK DRAIN VALVE ........ 57 PIN BASE PLUG .. ......... 30OIL TEMP GAGE . ........... 49A PIN METERING. .......... 30OIL TEMP GAGE . ......... 49B PIN SEAT STOP .. ......... .45OIL TEMP GAGE . . ........ 49C PIN SEAT STOP ........... 45AOPERATIONAL LIMITATIONS PLACARD . . 2 PIN WING ATTACH DOWEL .......OUTLET AIR............. 17 PISTON MASTER CYLINDER ........ 67OUTSIDE AIR TEMP. .......... A PITOT HEATER............. 78OUTSIDE AIR TEMP GAGE . ....... 51A PITOT SYSTEM. ........... 78OUTSIDE AIR TEMPERATURE GAGE... . 51A PITOT TUBE ............. 78OVERVOLT LIGHT. ....... 49 PITOT TUBE CONNECTOR......... 78OVERVOLT LIGHT. ....... .... 49A PITOT TUBE NOSE FITTING ....... 78OVERVOLTAGE LIGHT .. ..... .. 49B PIVOT MAIN LANDING GEAR ....... 34OVERVOLTAGE LIGHT .......... 49C PLACARDS SEE FIG 2........OVERVOLTAGE SENSOR. ........ 49 PLATE BAGGAGE DOOR STRIKER ...... 40OVERVOLTAGE SENSOR . ......... 49A PLATE DOORPOST COVER. ......... 16OVERVOLTAGE SENSOR . ........ 49B PLATE PRESSURE ............ 36OVERVOLTAGE SENSOR. . .. .... . 49C PLATE PRESSURE ........... 36AOVERVOLTAGE SENSOR. ........ .89 PLATE PRESSURE. ........... 36BOVERVOLTAGE SENSOR. .... .. .. 89A PLATE STINGER COVER ......... 25

PLATE STRIKER ........... 49BPLATE STRIKER . ... .... 49CPLATE STRIKER .. ......... 73

NOMENCLATURE FIGURE NOMENCLATURE FIGURE

P(Cont)R

PLENUM CHAMBER ........... 57 RADIO COVER ............ 49PLUG HEATING .... . .... 49 RADIO COVER .... ........ 49APLUG PIN BASE ............ 30 RADIO COVER. ............. 49PLUG SPARK ........... 58 RADIO COVER ........... 49CPLUNGER FUEL STRAINER ........ 80RADIO SHELF ........ .... 24POCKET MAGAZINE .......... 45 RADIO SHELF ............ 24APOCKET MAGAZINE .......... 46 RADIOS-SEE CESSNA ELECTRONICS MANUAL.POCKET MAGAZINE ........... 46A RAIL SEAT. ............. 13POCKET MAGAZINE .. . ..... . 468 REAR DOORPOST .......... .14POINT WING JACK ........ . .50 REAR DOORPOST ......... . 20POST LIGHT ............ 490 REAR SEAT .......... . . . . 18POST LIGHT ............ 49E REAR SEAT .............. 47POST LIGHT............. 49F REAR SEAT .............. 47APOST LIGHT BULB ........... 49D REAR SEAT ............ .. 48POST LIGHT BULB .......... .49E REAR SEAT ............. 48APOST LIGHT BULB .......... 49F REAR SEAT BELT .......... .50APOWER PACK ...... ..... . 85 REAR SPAR .............. 9POWER PACK CONTROL VALVE . . ... 85 REAR SPAR ............. 10POWER PACK HYDRAULIC ......... .84 REAR WINDOW ........... 22POWER PACK HYDRAULIC ......... 84A REAR WINDOW. .... ........ 42APOWER PACK MOTOR. .......... 84A REAR WINDOW MOULDING ........ 42POWER PACK PUP .... . . . . . . . 84A RECEIVER ASH . ........ 45POWER PACK RESERVOIR. ........ 84A RECEIVER ASH ............. 46POWER SUPPLY ELECTROLUMINESCENT . . 49D RECEPTACLE EXTERNAL POWER ..... 89POWER SUPPLY ELECTROLUMINESCENT .. . 49E RECEPTACLE EXTERNAL POWER ..... 89APOWER SUPPLY ELECTROLUMINESCENT .. 49F REEL INERTIA. ..... ....... 50APOWER SUPPLY ELECTROLUMINESCENT PANEL 490 REGULATOR VOLTAGE . ....... 58POWER SUPPLY ELECTROLUMINESCENT PANEL 49F REGULATOR VOLTAGE . ...... 89POWER SUPPLY STROBE LIGHT ... 89 REGULATOR VOLTAGE ......... 89APOWER SUPPLY STROBE LIGHT ...... 89A RELAY SPLIT BUS BAR ........ 89PRESSURE PLATE ..... .. ... 36 RELIEF VALVE. .... ...... .84APRESSURE PLATE ... ...... .36A REMOVABLE PANEL ... ...... 49PRESSURE PLATE . ......... 36B REMOVABLE PANEL .......... 49APRESSURE SWITCH HYDRAULIC . .. . . 83C REMOVABLE PANEL . ........ .. 49BPRESSURE SWITCH HYDRAULIC ...... 83E REMOVABLE PANEL ......... 49CPRIMER ............ 1 RESERVOIR DRAIN CONTROL ...... 81CPRIMER ZINC CHROMATE......... 1 RESERVOIR POWER PACK. .. ...... 84APROBE ECONOMY POWER ....... 57 RESISTOR. ... . . . . . . . . . . . 49PROBE ECONOMY POWER INDICATOR ... 57 RESISTOR. . ............. 49CPROPELLER & SPINNER ......... 52 RESISTOR. ............. 49FPROPELLER GOVERNOR. ....... 59A RESISTOR .............. 89PROPELLER MCCAULEY ........ RESISTOR. ............. 89APROPELLER MCCAULEY. .. .. ... 53 RESISTOR CIGAR LIGHTER. . ... . 49CPROPELLER-PITCH CONTROL ....... .49 RESISTOR CIGAR LIGHTER ........ 9APROPELLER PITCH CONTROL ...... 49A RESISTOR FLASHING BEACON ...... 89PULL BAR DOOR HANDLE. .. .... 39 RESISTOR FLASHING BEACON. ... .. 89APULLEY AILERON . ....... . .70 RESTRICTOR VALVE ... ... .. . 72PULLEY RUDDER . ......... . 76 RESTRICTOR VALVE ........... 83PULLEYS-SEE APPLICABLE SYSTEM .... RESTRICTOR VALVE. ........ . 83APUMP FUEL ............ . 79 RESTRICTOR VALVE . ......... 838PUMP FUEL ........... 79A RETAINER SEAT BOTTOM. .. .... .45PUMP POWER PACK ........... 84A RETAINER SEAT BOTTOM. ....... 47PUMP VACUUM . .......... 58 RETAINER SEAT BOTTOM ........ 48PUMP VACUUM . . ........ 82 RETAINER TRUE AIRSPEED. . .... 49PUSH ROD DOOR LATCH ......... 38 RETAINER TRUE AIRSPEED . ..... .49APUSH ROD DOOR LATCH ........ 38A RETAINER INDO ..... . . . . 38PUSH ROD FLAP ............ 73 RETAINER WINDOW .......... 38A

RETAINER WINDSHIELD ........ 16RETAINER WINDSHIELD ......... 23Q RETAINER WINDSHIELD TOP ....... 23RHEOSTAT. ....... 49RHEOSTAT ...... .... . 49A

QUADRANT. ..... ... 69 RHEOSTAT. .... . . . . . . . . 49QUADRANT. .......... . . . 74 RHEOSTAT. ...... ...... .9C

RHEOSTAT. ........... 49DRHEOSTAT ............ 49ERHEOSTAT KNOB ... .... .. . 49DRHEOSTAT PANEL & RADIO LIGHTS ... 49B

xxxix

MODEL 177RG


R(Cont) S(Cont)RHEOSTAT PANEL & RADIO LIGHTS .... 49C SEAT REAR ........... 48RIBS-SEE APPLICABLE STRUCTURE.... SEAT REAR ..... ...... 48ARING MOORING. ............ 3 SEAT ROLLER KIT ........... 45 -RING MOORING. .......... . 7 SEAT ROLLER KIT ........... 45ARING TRUE AIRSPEED .... ..... 49 SEAT STOP ............. 45RING TRUE AIRSPEED. .... ... 49A SEAT STOP .... ....... 45ARIVET SET KIT .......... 36A SEAT STOP ...... ........ 46RIVET SET KIT .......... 36B SEAT STOP . ............ 46AROD DOOR LATCH PUSH .. ..... 38 SEAT STOP ............ . 46BROD DOOR LATCH PUSH . ....... 38ASEAT STOP PIN ............ 45ROD FLAP PUSH ........ 73 SEAT STOP PIN ............ 45AROLLER KIT SEAT ........... 46 SELECTOR VALVE FUEL ......... 81ARUDDER. .............. 11 SELECTOR VALVE FUEL ........ 81BRUDDER...... ......... 71 SELECTOR VALVE HYDRAULIC. ...... 83GRUDDER BAR.............. 66 SELECTOR VALVE HYDRAULIC. ...... 88DRUDDER BAR BEARING. .......... 15 SELECTOR VALVE HYDRAULIC. ..... 88ERUDDER BAR BEARING ......... 15A SENDING UNIT CYLINDER HEAD TEMP ... 49RUDDER BAR SUPPORT. ......... 15 SENDING UNIT CYLINDER HEAD TEMP . . 57RUDDER BAR SUPPORT ......... 15A SENSITIVE ALTIMETER ..... . ..49RUDDER CONTROL SYSTEM ....... 76 SENSOR OVERVOLTAGE. ........ 49RUDDER LIGHT . ........... 11 SENSOR OVERVOLTAGE. ........ 49ARUDDER PULLEY ........... .6 SENSOR OVERVOLTAGE. 49BRUDDER RIB............ .. 11SENSOR OVERVOLTAGE. 49CRUDDER SERVO. . .......... 72 SENSOR OVERVOLTAGE. .... .. 89RUDDER TIP. . ........ 11 SENSOR OVERVOLTAGE. ......... 89ARUDDER TRIM CHAIN .......... 77 SEPARATOR ..... .. .. 64RUDDER TRIM CONTROL ......... 28 SEPARATOR .. .... . . . 64ARUDDER TRIM CONTROL ........ 77 SEPARATOR ............. , 64BRUDDER TRIM CONTROL SYSTEM ...... 77 SERVO AILERON ........... .72RUDDER TRIM INDICATOR ........ 77 SERVO RUDDER. .......... 72RUDDER TRIM WHEEL. ....... .77 SET KIT RIVET ......... .. 36A

SET KIT RIVET ........... 368SHAFT DOOR HANDLE ...... ... 38S SHAFT DOOR HANDLE .. .. . . . . . 38ASHAFT STEERING BUNGEE ........ 17SHAFT STEERING BUNGEE ..... . . 28

SAFETY BELT-ALSO SEE SEAT BELTS . . SHAFT TACHOMETER . ......... 49SCOOP AIR ..... 54....... . .SHAFT TACHOMETER. .......... 49ASCOOP AIR .............. 54A SHAFT TACHOMETER. ........ 49BSCOOP STALL WARNING ........ 5 SHAFT TACHOMETER. ........ 49CSEAL BAFFLE ............ 57 SHELF RADIO ............. 24SEAL BAFFLE ............. 61 SHELF RADIO ............. 24ASEAL BAFFLE . ............ 61A SHIELD COURTESY LIGHT ........ 92SEAL DOOR ... ......... 40 SHIELD GLARE . ......... .. 49ASEAL FELT GREASE........... 31 SHIELD GLARE. ............. 498SEAL FELT GREASE. ........ . 31A SHIELD GLARE. . ........... 49CSEAL FELT GREASE........... 31B SHIMMY DAMPENER ........... 32SEAL FELT GREASE .......... 36A SHOCK MOUNT ....... .... 15ASEAL FELT GREASE. ........ 36B SHOCK MOUNT ..... .. .... 54SEALANT ............... 1 SHOCK MOUNT ............ 54ASEAT BACK PAWL. .......... 45 SHOCK MOUNT COWL.. ...... 15SEAT BACK PAL. ....... ... 45A SHOCK MOUNT COWL.. ........ .15ASEAT BACK PAWL. ............ 47 SHOCK STRUT LOWER ........ 30SEAT BACK PAWL........... 47A SHOCK STRUT NOSE GEAR .... .. 30SEAT BELT ............. 50A SHOULDER HARNESS. . ....... 50ASEAT BELT EXTENSION ........ 51 SHROUD................ 60SEAT FRONT. ............. 45 SHROUD................ 61ASEAT FRONT. ......... .... 45A SHROUD MUFFLER............ 60SEAT FRONT. ....... ....... 46 SHUT OFF VALVE FUEL ......... 81SEAT FRONT. .............. 46A SIDE FLOORBOARD UPHOLSTERY CABIN. .43SEAT FRONT..... ......... 468 SIDE WINDOW ...... . .... .. 22SEAT PEDESTAL ............ 46 SKINS-SEE APPLICABLE STRUCTURE ...SEAT PEDESTAL ............ 46A SOCKET COURTESY LIGHT ........ 92SEAT PEDESTAL ............ 468 SOCKET DOME LIGHT ......... . 89ASEAT RAIL ............ .13 SOUND DEADENER.... .. . .... 1SEAT REAR ...... ...... 18 SOUNDPROOFING CABIN. ........ 44SEAT REAR .............. 47 SOUNDPROOFING FIBERGLASS. ...... 44SEAT REAR ............. 47A SPAR FRONT . .......... .. 16

Xi


S(Cont) S(cont)

SPAR FRONT CARRY THRU .... .. STRAP GROUND. ......... 89SPAR MAIN WING. ............ 7 STRAP GROUND ........... 89ASPAR REAR ............. 9 STRETCHER... ...... 51SPAR REAR ............. 10 STRIKER PLATE ..... 49BSPAR WING ............. 7 STRIKER PLATE ............ 49CSPAR WING .... ......... 14 STRIKER PLATE .......... 73SPAR WING CARRY THRU ........ 14 STROBE LIGHT.............3SPARK PLUG. .......... 58 STRUT LOWER SHOCK ......... 30SPEAKER .............. 89 STRUT NOSE GEAR SHOCK ...... 30SPEAKER ............... 89A SUCTION GAGE ...... ..... 49SPEAKER-RADIO-SEE ELECTRONICS MANUAL. SUCTION GAGE. .... ....... 49ASPINNER DOME............. 52 SUCTION GAGE. .... ... 49BSPLIT BUS BAR RELAY ........ 89 SUCTION GAGE. ........... 49CSPROCKET IDLER ........... 77 SUCTION GAGE. ........ .. 82STABILATOR. ............. 12 SUN VISOR ............. 50STABILATOR. ........... 17 SWITCH ACTUATOR ........... 73STABILATOR. .... ....... 24 SWITCH COVER. ........... 49STABILATOR. ............. 24A SWITCH COVER ............ 49ASTABILATOR. ........... 74 SWITCH DOME LIGHT .......... 89STABILATOR TIP ........... 12 SWITCH DOME LIGHT ........ 89ASTABILATOR TRIM ACTUATOR ..... 75 SWITCH FLAP LIMIT ......... 73STABILATOR TRIM CHAIN ........ 75 SWITCH FUEL PUMP.. ......... 49STABILATOR TRIM TAB ......... 75 SWITCH FUEL PUMP. .......... 49ASTABILATOR TRIM TAB BELLCRANK .... 75 SWITCH FUEL PUMP. ......... 498STAINLESS CABLES-SEE SPECIFIC SYSTEM. SWITCH FUEL PUMP.. ........ 49CSTALL WARNING DETECTOR ....... 89 SWITCH GEAR DOWN. ......... 29STALL WARNING DETECTOR. ....... 89A SWITCH GEAR UP. .......... 29STALL WARNING HOR. .......... 89 SWITCH HYDRAULIC PRESSURE .... .. 83ESTALL WARNING SCOOP . . ....... 5 SWITCH MASTER ............ 49STARTER ........ 58 SWITCH MASTER ....... 4.... 49ASTARTER CABLE ............ 89 SWITCH MASTER ............ 49B

STARTER CONTACTOR . .. ......... 89 SWITCH MIKE ............ 94STARTER CONTACTOR ......... 89A SWITCH OIL PRESSURE . ........ 94STARTER CONTACTOR . ..... 89A SWITCH OIL PRESSURE ......... 57STARTER CONTACTOR CABLE .. .... .89 SWITCH PANEL COVER. .......... 49STARTER CONTACTOR CABLE ....... 89A SWITCH PANEL COVER ......... 49ASTATIC DISCHARGER .......... 8 SWITCH THROTTLE ...... . .57STATIC DISCHARGER .......... 11 SWITCH THROTTLE ... ....... 89STATIC DISCHARGER . . ..... 12 SWITCH THROTTLE ......... 89ASTATIC SOURCE ALTERNATE . .. 78 SWITCHES-SEE INSTRUMENT PANEL . ...STATIC SOURCE FLANGE ....... .15 SYSTEMS-SEE INDIVIDUAL LISTINGS . .STATIC SOURCE FLANGE. ........ 15ASTATIC SOURCE FLANGE. . ...... 78STATIONARY PANEL. .......... 49STATIONARY PANEL. 49ASTATIONARY PANEL ...... 49BSTATIONARY PANEL. .......... 49C TAB AILERON TRIM. .......... 8STEERING BUNGEE SHAFT ....... 17 TACHOMETER. .. . ....... 49STEERING BUNGEE SHAFT ........ 28 TACHOMETER ............ .. 49ASTEERING SUPPORT..... ..... 17 TACHOMETER. ........ 49BSTEERING SUPPORT. .......... 28 TACHOMETER. ............. 49CSTEP. ................ 33 TACHOMETER SHAFT. . .... .. .49STEP CABIN. ............. 13 TACHOMETER SHAFT. ......... 49ASTINGER ............... 25 TACHOMETER SHAFT. .......... 49BSTINGER COVER PLATE ....... 25 TACHOMETER SHAFT........... 49CSTOP CABIN DOOR ........... 38 TAIL LIGHT LAMP ........- 11STOP CABIN DOOR ........... 38A TAILCONE. ..... ...... ... 24STOP DOOR ............ 17 TAILCONE. 24A............ 24STOP DOOR .............. 38 TAILCONE LIFT HANDLE. ....... 50STOP DOOR ............. 38A TANK DRAIN VALVE FUEL .. .. 6STOP SEAT .......... .45 TANK FUEL ..... ...... . 6STOP SEAT .............. 45A THROTTLE CONTROL ... .... 49STOP SEAT .............. 6 THROTTLE CONTROL .......... 49ASTOP SEAT ............ .. 46A THROTTLE CONTROL . - ...... .49BSTOP SEAT ............. 468 THROTTLE CONTROL .. ...... ... 49CSTRAINER FUEL ............ 80 THROTTLE SWITCH ........... 57STRAP GROUND. .......... . .8 THROTTLE SWITCH ......... .. 89STRAP GROUND. ............ 57 THROTTLE SWITCH .......... 89A

xii

MODEL 177RG


T(Cont) VTIP DORSAL. ........ .. . 10 VACUUM FILTER . ........... 82TIP FIN .............. 93 VACUUM PUMP ............ 58TIP RUDDER. ............ 11 VACUUM PUMP . ........... 82TIP STABILATOR ... ........ 12 VACUUM RELIEF VALVE ........ 82TIP VERTICAL FIN. .......... 10 VACUUM SYSTEM ............ 82TIP WING . ....... .... 3 VALVE CHECK ............ 84ATIRE. ....... .. .... 31 VALVE CHECK .......... . 88CTIRE . .......... ... 31A VALVE DEFROST ......... . .64TIRE ............... . 31B VALVE DEFROST. ......... . 64ATIRE. ............. 36 VALVE DOOR CLOSE LOCK ....... 89CTIRE ............... 36A VALVE DRAIN ........... . 6TIRE. ............ .. 36B VALVE EXTENSION ........... 27TOP & FIREWALL UPHOLSTERY CABIN .. .42A VALVE FUEL ...... ..... 81DTOP CABIN ... ...... 14 VALVE FUEL DRAIN. .. ..... . .79TOP CABIN ............. 15 VALVE FUEL SELECTOR ....... .81ATGP CABIN ... ......... . 15A VALVE HYDRAULIC SELECTOR..... . 88BTOP CABIN ............. 42A VALVE KNOB ............. 72TOP FUEL STRAINER ......... 80 VALVE OIL QUICK DRAIN . ....... 57TOROUE LINK ... 30 VALVE RELIEF .. . . . ... . 84ATOROUE LINK LOWER ....... .. 30 VALVE RESTRICTOR.7 ........ .72TORQUE LINK UPPER ..... . . . 30 VALVE RESTRICTOR. . ....... 83TOW BR .... . . . . . . . . . . 50 VALVE RESTRICTOR. .......... 83ATRACK FLAP ............ . 4 VALVE RESTRICTOR ....... 838TRANSDUCER CYLINDER HEAD TEMP . . .49A VALVE VACUUM RELIEF .. . . .. 82TRANSDUCER CYLINDER HEAD TEMP ... 57 VENT GRILL. ... ........ 42ATRANSDUCER OIL PRESSURE .... .. 57 VENT LINE. .. . ........ . .. 79TRANSISTORIZED DIMMER . ..... 89 VENT LINE ........... .. 79ATRANSISTORIZED DIMMER ..... . 89A VENT WINDOW . .. ........ 38TRANSMITTER FUEL. ........ 3 VENT WINDOW . ........... 38ATRIP CONTROL RUDDER ........ 77 VENT WINDOW CRANK ....... . 38TRIM CONTROL SYSTEM RUDDER. .. . . . 77 VENT WINDOW CRANK ......... 38ATRIM TAB ACTUATOR ELEVATOR . ... 75A VERTICAL FIN. ......... .. 10TRIM TAB ELEVATOR . ........ . A VERTICAL FIN TIP. ......... 10TRIM TAB STABILATOR .. . . . . .75 VERTICAL SPEED INDICATOR. ..... 49TRUE AIRSPEED INDICATOR ....... 49 VERTICAL SPEED INDICATOR ..... .49ATRUE AIRSPEED INDICATOR ...... 49A VERTICAL SPEED INDICATOR ....... 49BTRUE AIRSPEED INDICATOR ....... 49B VERTICAL SPEED INDICATOR ..... .49CTRUE AIRSPEED INDICATOR . ..... 49C VERTICAL SPEED INDICATOR .... .. 78ATRUE AIRSPEED RETAINER ...... 49 VHF ANTENNA ......... . . . 5TRUE AIRSPEED RETAINER ...... . 49A VHF ANTENNA . . ...... ... 5ATRUE AIRSPEED RING. .. .... .. 49 VISOR SUN . ............ 50TRUE AIRSPEED RING .......... 49A VOLTAGE REGULATOR ....... .. 58TRUNNION NOSE GEAR ......... 30 VOLTAGE REGULATOR ...... . . 89TUBE AILERON CONTROL. .... . . 69 VOLTAGE REGULATOR .......... 89ATUBE PITOT ... ...... . .78TUBE POLYETHYLENE ...... 1TUNNEL WALL .... . .. ... 17 WTURN COORDINATOR. . .. .. .. 49TURN COORDINATOR. .. . .. 49ATURN COORDINATOR. . . . . .. 72 HALL TUNNEL . ..... . . . . 17TURN COORDINATOR INDICATOR .. . . 49A WARNING UNIT DUAL . .. . ... 89TURN COORDINATOR INDICATOR. . .. .49B WARNING UNIT DUAL . .... .. 89ATURN COORDINATOR INDICATOR. . . . 49C WARNING UNIT STALL. . . .. . . .. . 89TWIN PACK BEVERAGE. . . . ... .50 WARNING UNIT STALL & GEAR ... .. 89

WEIGHT AILERON BALANCE. ....... 8WELL WHEEL. ... . .... 17

U WELL WHEEL. ............. 21WHEEL & BRAKE . . . . . . . . . . . . 36WHEEL & BRAKE .. 36A

UPHOLSTERY CABIN TOP ......... 42 WHEEL & BRAKE ..... ...... 36BUPHOLSTERY CABIN TOP & FIREWALL . . 42 WHEEL & BRAKE MAIN GEAR ..... . 36BUPPER COWL ..... ... ... . 54 WHEEL & BRAKE MAIN LANDING GEAR . . 36UPPER COWL ... . ......... 54A WHEEL & BRAKE MAIN LANDING GEAR . .. 36AJPPER COWL DOOR .... ...... 54 WHEEL CONTROL. .......... . 69UPPER COWL DOOR ......... . 54A WHEEL CONTROL . . . . . . . . . . . 94UPPER FIREWALL. ..... ...... WHEEL MAIN GEAR . ........ 36UPPER FIREWALL ....... ... 15A WHEEL MAIN GEAR ... .. .... 36A

WHEEL MAIN GEAR . ......... .36B

xiii

NOMENCLATURE FIGURE NOMENCLATURE FIGUR

W(Cont)

WHEEL NOSE GEAR .......... 31HHEEL NOSE GEAR ........... 31A

WHEEL NOSE GEAR ......... 31BWHEEL RUDDER TRIM .77WHEEL WELL. . . .......... 17WHEEL WELL. ..... ... 21WINDOW MOULDING ...... 20WINDOW MOULDING .......... .42WINDOW MOULDING .. ....... 42AWINDOW REAR ............ 22WINDOW REAR .... ........ 42AWINDOW SIDE .......... 22WINDOW VENT . ...... ... . 38WINDOW VENT ......... 38AWINDSHIELD. ............. 23WINDSHIELD . ...... 42AWINDSHIELD RETAINER ......... 16WINDSHIELD RETAINER ........ 23WINDSHIELD TOP RETAINER .... ... 23WING CARRY THRU SPAR. ........ 14WING COMPLETE ...... 3...... 3WING FAIRING ............ 3WING FAIRIN. ............ 14WING FLAP ............. 9WING LEADING EDGE .......... 5WING LEADING EDGE ...WING LEVELER. ........ 72WING POSITION LIGHT BULB ... 3WING POSITION LIGHT GREEN LENS ... 3WING POSITION LIGHT RED LENS . ... 3WING ROOT RIB ........... 4WING SPAR ...........WING SPAR ........ 14WING SPAR MAIN.... ...... 7WING STRUCTURE .........WING TIP .............. 3WINTERIZATION EQUIPMENT ....... 56WINTERIZATION PLACARD ....... 2WINTERIZATION PLACARD ..... . 56

177RG Parts CatalogFIGURE

AND UNITSPART NUMBER PERNO-. 2 3 4 5 6 7

-3 1024A-B CEMENT PARTS A & B

- 4 1007 PRIMER

-5 576.1

- 6 579.6 SEALANT-EXTRUDED WEATHER SEALING

- 7 S1078-1 SEALANT WINDSHIELD SEALING

- 8 S1078-2 S

-9 S1078-3

-10 EC1239AB SEALANT-CATALYTIC

AND AREAS

-11 700 SEALANT-FIREALLAND OPENINGS.

WITHSTAND 2000FOR 5 MINUTES.

-12 EC776

-13 550

-14 MIL-P8585A PRIMER-ZINC CORROSION PROOFING -

-14A EC1675A-B S


2

177RG Parts Catalog

FIGURE

NO. 1 2 3 4 5 6 7 ASSY

-14D EC2216B/A ADHESIVE -PARTS A & B METAL TO METAL

-14E

-15

S5-12S5-16

-17

.- AR-11

-18-19

-22 -1


3

MODEL 177RG

Bulk Items (Cont)

\ /- / -----20

31 32 33

38

Figure 1. Miscellaneous Bulk Items

4

177RG Parts Catalog

FIGURE UNITSAND PART NUMBER DESCRIPTION ON

NO. ASSY CODE

1--24

-25-26

-27AR

-28 389- BY AR

-29-30-31-32 S 441-1

-33 495-4

-34-35 S 635-1 -

-36 S1636-1 2-18 ARS1636-2S1636-3

-37 637-1 PIN ARS1637-2 AR

-41 S16406 AR

-12 PINS1640-15 PIN-15 CAR

-42 S641-6 ARS1641-9

-43

-4

-47-48

S1050-3-49 S1817-1-

-51

5

MODEL 177RG

Registration Markings

ABCDFFFFH/JKLMN

LEFT HAND SLANT(LEFT SIDE OF AIRPLANE)

RIGHT HAND SLANT(RIGHT SIDE OF AIRPLANE)

ABCDEFGHIJKLMNOPQRSTUVWXYZ-1234567890

Figure 1A. (Sheet 1 of 3) Registration Markings

6

Registration Markings (Cont)

S1500 TYPE STENCILS *

FOR SLANT GOTHIC LETTERS & NUMERALSLETTERS AND NUMERALS ARE AVAILABLE IN 10 INCH AND12 INCH HEIGHTS IN EITHER LEFT HAND OR RIGHT HANDSLANT.

LETTERS AVAILABLE ARE A THRU Z.NUMERALS AVAILABLE ARE 0 THRU 9.

TO ORDER:EACH LETTER OR NUMERAL WANTED MUST BE ORDERED BYGIVING BASIC PART NUMBER, FOLLOWED BY HEIGHT DESIRED,FOLLOWED BY SPECIFIC LETTER OR NUMERAL AND THEDESIGNATOR L OR R TO INDICATE LEFT OR RIGHT HANDSLANT.

EXAMPLE: S1500 - 10 - M L

BASIC PART NO. L DIRECTION OF SLANT

HEIGHTWANTED

S1600 TYPE STENCILS *FOR VERTICAL GOTHIC LETTERS & NUMERALS

LETTERS AND NUMERALS ARE AVAILABLE IN 6 INCH, 12 INCHAND 20 INCH HEIGHTS. LETTERS AVAILABLE ARE A THRU Z.NUMERALS AVAILABLE ARE 0 THRU 9.

TO ORDER:EACH LETTER OR NUMERAL WANTED MUST BE ORDERED BYGIVING BASIC PART NUMBER, FOLLOWED BY HEIGHT DESIRED,FOLLOWED BY SPECIFIC LETTER OR NUMERAL WANTED.

EXAMPLE: S1600 - 20 - N

BASIC PART NO.HEIGHT WANTED

* EACH STENCIL PROVIDES FOR EITHER

BACKGROUND OR CENTER MASK.


7

MODEL 177RG

Registration Markings (Cont)

ABCDEFGHIJKLMNOPQRSTUVWXYZ

1234567890

S2400 TYPE DECALS*3 INCH VERTICAL GOTHIC LETTERS & NUMERALS

LETTERS & NUMERALS ARE 3 INCHES IN HEIGHT AND AVAILABLEIN WHITE (W), GOLD (G) OR BRONZE (B) LETTERS AVAILABLE APEA THRU Z. NUMERALS AVAIABLE ARE 0 THRU 9.

TO ORDER:EACH LETTER OR NUMERAL WANTED MUST BE ORDERED GIVINGTHE BASIC PART NUMBER, FOLLOWED BY THE COLOR, FOLLOWEDBY THE HEGHT(3), FOLLOWED BY THE SPECIFIC LETTER OR NUMERALWANTED.

EXAMPLES2400

BASIC PART NO. LETTER WANTEDCOLOR WANTED HEIGHT

PRESSURE SENSITIVE ADHESIVE BACKED VINYL FILM


8

MODEL 177RG

Placards (Cont)

9 10

WICHITA, KANSAS

14

18

.Figure 2. (Sheet 1 of 2) Placards, Nameplates & Exterior Markings

9 blank/10

Placards (Cont) 3730 --

32

51

54 55

6 dS3^ / *10- 1

CARDINAL RGFigure 2. (Sheet 2 of 2) Placards, Nameplates & Exterior Markings

11

177RG Parts Catalog

NO. 1 2 3 4 5 6 7 ASSY

2 -

-

-4-

- 7-

-

-

-

--23---

-24-23

-24

-25

-26-27

-33

-36 N


12


AND UNITSINDEX PART NUMBER DESCRIPTION PER ON

NO. 1234567ASSY CODE

2-38-39 050530-2 2-40 1005006-1 2-41 205074-1 2-42-43-44 70-45 70-46 -1---49

-51-52--54

-55 4-3 2

-56

-57

-58 38-1 2-59 38-3 2-60 5-3 2-61 5-4 2-62-63-64

-1 ALASKAN COLOR REVERSAL 2-65 -6 2-66 1-1 2

11-3 ALASKAN COLOR REVERSAL 2-67 11-2 2

-6817

-69AR

-70

-7172 -2

NOTE.


13

177RG Parts Catalog

FIGURE UNITSAND PART NUMBER DESCRIPTION

NO. 123467 ASSY CODE

2 -

14


AND PART NUMBER DECRIPTION PER

NO. 1 2 3 4 5 6 7

3 - WING ASSEMBLIES

--2- 3 71-4-9-6-7 rA-

-


MODEL 177RG

62

THRU

Figure 3. Wing Assembly Complete

16

16

177RG Parts Catalog

FIGURE UNITS USABLEAND PART NUMBER DESCRIPTION PER ON


3 -12-13 #2

#3#3

-14

-15A

-16-16A

AN507-1032R7 SCREW 16

-17

ATTACHING PARTSAN507-1032R7 SCREW 6

-18 1221091-4 DOOR-AILERON ACCESS 1ATTACHING PARTS

AN507-1032R7 SCREW 6

-191221093-3

AN507-1032R7 SCREW 6*

-20 1221096-3 DOOR-ACCESS 2ATTACHING PARTS

AN507-632R8 SCREW 6

-21 122116-3

AN507-1032R7 SCREW 8

-22 S225-4 PLATE-INSPECTION

S1022Z8-6 SCREW 6

-22A 1222012-1 COVER 1ATTACHING PARTS

S1022Z8-6 SCREW 6

-22BATTACHING PARTS

AN507-832R8 SCREW 6

-23-24

-26-27-28

-29


17

177RG Parts Catalog

FIGURE

NO. 1 2 3 4 567 CODE

3 -30 C62201-0201

-31 LIGHT 3

-32

-33-34-35

-36-37

-38

-39

-44-45 AN507-

-46

-48-50-52-53-54

-56

-57 PROCURABLE-58 MS35489-12S-59 1200406-85 ASSY-FUEL VENT-59A AN74206

S1021Z8-6-60-61


18

177RG Parts Catalog


NO. 1 2 3 45 6 7ASSY

3 -62A

#6

-

-65-65

ATTACHING PARTS

NOTE. #2 THIS PART IS CONTAINED IN SK177-39.

NOTE. #3 THIS PART IS CONTAINED IN SK177-40.

NOTE. #4 THIS PART IS CONTAINED IN SK177-39 AND SKIN-40.

NOTE. #5 AIRPLANES

INCORPORATING

NOTE. #6 AIRPLANES

INCORPORATINGNOTE. #7

IN

NOTE.


I 77RG Parts Catalog

FIGURE

INDEX PART NUMBER DESCRIPTION PER ONN 1 2 3 4 5 6 7 ASSY

MODEL 177RG

Wing (Cont)

18 16 14

53

67

Figure 4. Wing Structure Assembly21 blank/22


NO.

-

-4-5-6-7-8

- --

--

-25-26-27

-28

-29

-30

-31

-32

-33

-

-35 221


23

177RG Parts Catalog

FIGURE

INDEX PART NUMBER DESCRIPTION PER ONNO. 1 2 3 4 5 6 7

4 -36

--

--45

-

---4-50

-51-52-53

-57

-

-

.

-


177RG Parts Catalog

FIGURE UNITS USABLEPART NUMBER DESCRIPTION PER ON

NO. 1 2 3 4 5 6 7 ASSY CODE

4-76 1221050-4

-77

-

-83 7

-88-87-89

-90-91 NAS43001-42-92 AN515-6R26-93 1722084-5 S ASSEMBLY-SWITCH

NAS698A06L PLATE-94 AN515-6R25 SCREW-95 NAS43001-47-96 1722084-1-97 AN515-6R6-98 AN960-6-99 E33-10K SWITCH B

S1906-1 SW A

-99A AN515-4R10AN936B4 2

-99B MS21044N04 2

-99C 1722083-1 PLUG 4-99D 1722079-7 SU ASSY-IR AI H |I -P

1722079-3 SA-

B-77R

C- -7R

E-

25

MODEL 177RG

9A Wing (Cont)

26 9B 36

·

26

177RG Parts Catalog

FIGURE UNITS USABLE

-

-

-1 . RIBRIB

- 6 1221047-7

- 9B-9B

* ~ ~* 22 ' 0-1248r LAASSY-

-14

-14A


27

177RG Parts Catalog

AND PART NUMBER

NO. 1234567

-23-24-25-26

-27

-31

-3 *

-

-48

SEE FIG 6


28


INDEX PART NUMBER DESCRIPTIONNO. 1234567 ASSY CODE

5 -58 S226-2S1860-2A

-59 SEE FIG 63

-61 A

-67-63

64

-65

-68

-69

NAS-70-71 1221042-60 R LY STA. 206.00 RH ONLY

S1860-2A .

-72

-73

-76-74

-80-81-

-76

-77-78-79

-

-8

-

A---

B--

29

MODEL 177RG

30

62 77

177RG Parts Catalog

FIGUREINDEX PART NUMBER DESCRIPTON PER ON

--4

-5 AN3-3A 4

-

CONTINUED ON NEXT PA- 9D

-

2


31

177RG Parts Catalog

5A-23-24

-25--2

-3-

-

--

-37

-38-38- - ---

-4

-

-51

-

177RG Parts Catalog

FIGURE

AND INDEX PART NUMBER DESCRIPTION PER ON

NO. 1 2 3 4 5 6 7 ASSY CODE

5A-60 17

-61-62

-63

FIGSEE FIG -

-66--67 SEE FIG 63

-

-7

-71

-72

-

.

-74

-75

-76

-77

-78

-79

-80

NOTE. #1 THESE ARE LISTED ONLY FOR MAKING

NOTE. #2 FOR SPARES ORDER 1221049-1 DOUBLER AND1221049-9 SPACER ASSEMBLY.

NOTE. #3 THIS PART CONTAINED IN FUEL TANK

A-

33

MODEL 177RG

Wing (Cont)

2

Figure 6. Fuel Tank Drain Valve Installation

FIGURE UNITS USABLEAND PART NUMBER DESRIPTION PER ON

6 -

MS29513- 14S2020-2

- 2 S2107-1

NOTE. #l THESE PARTS & INSTALLATION

NOTE. #2

34

177RG Parts Catalog

FIGURE UNITSAND PART NUMBER DESCRIPTION ON

1234567 ASSY CODE

7 -

-1-

-2

-3

-4-5- 6-7

-8

-9

-

-12

-13-14-


35

MODEL 177RG

Wing (Cont)

Figure 7. Wing Main Spar Assembly

36

177RG Parts Catalog

FIGURE

-19 S

-22

-24

-26

37

MODEL 177RG

Wing (Cont)

7

Figure 8. Aileron Installation14 10

25

42

2 44 443

52

Figure 8. Aileron Installation

38

177RG Parts Catalog

FIGURE

NO. 1 2 3 4 5 6 7 CODE

8 -

- 2 AN960-416 3

-3

-

-

--

-1

-14

-15-16

- 1

-25-24 1221068-8-25 1221072-1-26

28-29

-33--

-34


39


AND UNITS USABLEINDEX PART NUMBER DESCRIPTION PER ON

NO. 1 2 4 5 67 ASSY CODE

-36

-39 S

-40-

-4

-43-44

-45

-46S1093-1 2 B

-472 D

-48 AN515-6R6 2AN936A6 2S1648-06K75 NUT 2

-49 1570102-1 STRAP ASSY-GROUND 1ATTACHING PARTS

-50-51-52

40

MODEL 177RG

Wing (Cont)

3

41

28 2311

Figure 9. Flap Installation

177RG Parts Catalog

FIGURE

9 - FLAP

-6-

--

-13

-

-16

-17

-18

-19

--21-22-23-24-25-26-27

-32-33-32

-36

---41

43

MODEL 177RG

Empennage

33 32

30 5

29

Figure 10. Vertical Fin & Dorsal Installation

44

177RG Parts Catalog

AND UNIT USABLEINDEX PART NUMBER DESCRIPTION PER

NO. 1 2 3 4 5 6 7ASSY CODE

10 - VERTICAL FIN & DORSAL INSTALLATION NP1731000-201 FIN LY 1

-2--3-4-5

- 6-7- 8--10

RIB--

-

--19

-24-25 6-26

-27 1731020-2 FIN ASSEMBLY-DORSAL 1ATTACHING PARTS

-28 S102128-6

-29 0731605-4 TIP-DORSAL 1ATTACHING PARTS

-30 S102128-6 SCREW 3

-30 1731009-4 .-

-32 AN515-8R8 SCREW 5-33

A--F

45

MODEL 177RG

Empennage (Cont)

2930

27

26

Detail A

24

9

4

18 23

Figure 11. Rudder Installation

46

177RG Parts Catalog

FIGURE UNITS

INDEX

11 -1733000-1-1 3

-2 0532104

-3-4- 5 7-6

---

-

-AN515-6R6 2 A

2 A

-32-33

-34 AN515-8R6 SCREW B

47

MODEL 177RG

Empennage (Cont)

4822

3350

53

12

Figure 12. Stabilator Installation

48

177RG Parts Catalog

FIGURE UNITS USABLEAND PART NUMBER DESRIPTION PER

INDEXNO. 1 2 3 4 5 6 7 CODE

12-

- 1-2A MS24665-283 PIN 2

- 3A

-

-10 1732043-4--14

--

-17 1732025--1

-20

--26

-- -4

-

-33 AN5156R10

--

-37

-43


49

177RG Parts Catalog

FIGURE UNITS

12-44-45-46-47 --48

---5-54

--

.

---6-64

-67ATTACHING PARTS

-68 S102128-6 SCREW 2-

-70

NAS

-71

-73-74

NOTE.

NOTE. INITIALLY ORDER THIS PART FOR

77

50

177RG Parts Catalog

FIGURE

AND PART NUMBER DESCRIPTION PERNO. 1 2 3 4 5 6 ASSY CODE

13---2- 3- 4

- 5-6

CR763-5-8

NAS221-12-10

-14 1212031-11 COVER-ACCESS 2ATTACHING PARTS

NAS220-7 SCREW 6ATTACHING PARTSS1021Z8-6 SCREW 6


51

MODEL 177RG

Fuselage

SHOULDER HARNESS ATTACH

177RG Parts Catalog

FIGURE UNITS USABLE

INDEINDEX PART NUMBERNO. 1 2 3 4 5 6 7NO. 1234567 ASSY CODE

13 -15ATTACHING PARTS

S102128-6 SCREW 6

-16

-17

-18 -

-1A

-

-21 .

-22 A-

-24-25

-26

--

-

-3

-31

-32

-33

NOTE. #1 WHEN ORDERING THIS PART. REFER TOSEB 89-2 ,TO ORDER APPROPRIATE SERVICE KIT.

A

C-

E-

F-

H- .

.

53

MODEL 177RG

Fuselage (Cont)

41

Figure 14. Front & Center Cabin Section AssemblyFigure 14. Front & Center Cabin Section Assembly

54

177RG Parts Catalog

FIGURE USABLEINDEX PART NUMBER DESCRIPTION PER

14 -

-

-24-25-26

-27

-30-31-32-33-34

-36

-38

-39 AN6-10A 8-40-41-42 AN60-616 WASHER 16-43 MS21042L6

55

MODEL 1773RG

74A Fuselage (Cont)

53 Detail A

177RG SERIAL 177RG0001 THRU 177RG0787Figure 15. Forward Fuselage Structure Assembly67 69 7670 18B

1

177RG SERIAL 177RG0001 THRU 177RG0787Figure 15. Forward Fuselage Stucture Assembly

56

177RG Parts Catalog

PART NUMBER DESCRIPTIONNO.1 2 3 4 5 ASSY CODE

-2

-3 -2-

-6-7 1

-24

-31-32

-36

-

-41-42


57

177RG Parts Catalog

AND PARTNUMBER DESCRIPTIONNO. 1 2 3 4 5 6 7 ASSY CODE

15 -45

-50

-48--49 -

-

--55

-

-

-

-73-7

--77-78-79-80-8 1713292-2-82 171000-11--83 1711023-2


58

177RG Parts Catalog

FIGURE UNITS USABLEAND PART NUMBER

15 -

-85

A-B-

D-

59

MODEL 177RG

Fuselage (Cont)

177RG SERIAL 177RG0788 & ONFigure 15A. Forward Fuselage Structure Assembly1

177RG Parts Catalog

-56

- 6

72-2

AN960-10L 1MS20365-1032CNAS222-10 2AN960-416L 2MS21042L4 INBD 2

-33-34

-35

-36

-37

-38

-39

-41

-42

-43

-44

-45

-46


61

177RG Parts Catalog

ANDAND PART NUMB DESCRIPTION PERNO. 1 2 3 4 5 6 7 A CO

-50-

-

-

-

---

-6

-68

-70--72

-74-75-76

62

177RG Parts CatalogFIGURE UNITS

AND PART NUMBER DESCRIPTION PER ONNO. 1 2 3 4 5 6 7

15A-77 1713247-1-78 7-79--81-82-83-84

ATTACHING PARTSAN3-4 BOLT 2NAS221-9 SCREW 4

-85 1713036-11713036-2

D-

63/64 blank

177RG Parts Catalog

FIGURE

AND PART NUMBER DESCRIPTION UNIT

NO. 12 3 4 567 ASSY CODE

16 - FRONT BULKHEAD ASSEMBLY-1-2

- 3

- 5-6

-


65

MODEL 177RG

Fuselage (Cont)

27

66

Figure 16. Front Doorpost Bulkhead Assembly66


AND PART NUMBER DESCRIPTION PER ONN 1 2 3 4 5 6 7 ASSY CO

16-

-22

67

MODEL 177RG

Fuselage (Cont)

68

65 77 55 33

Figure 17. Fuselage Lower Forward Section

68

177RG Parts Catalog


INDEX 1234567 ASSY CODE

---5-6

-

-8

-12

-

-16

-

-19

-20

-23-24-25

314--26

-26A -

-27-28-29-30-31 - --32-33-34

-35


69

177RG Parts Catalog

PART NUMBER DESCRIPTIONNO. 1 2 3 4 5 6

17-36--37

-38

-40

-41

-50-50

-55

-70--68-70

177RG Parts Catalog

FIGURE UNITSAND PART NUMBER DESCRIPTION PERINDEX ASSYNO. 1 2 3 4 5 6 71234567 CODE

17 -74

-76

--7

---82--83A

-84

--

--92 AN4-6A BOLT 2

AN960-416L WASHER - 2MS21042L4 ----- 2

-93 AN3-4A BOLT 5

-94 AN3-5A 2

NOTE.

D--E-

L--

MODEL 177RG

Fuselage ICont)

46 41

1921

71

Figure 18. Center Cabin Section - Lower

72

177RG Parts Catalog

AND PART NUMBER DESCRIPTIONNO. 2 3 4 5 6 ASSY CODE

18- 1 SEE FIG 19- 2 SEE FIG- 3-3-4 2- 4A-5A-6

- 6A-7 2012035-5

-7

-13 AN525-10R8 2

-14 1712063-1 GUIDE 2ATTACHING PARTS

-15 AN525-10R14 SCREW 2

-16

-19 17

-20-21-21A-22-23-24

NAS220-8 12

-25 2012023-1

NAS221-8 SCREW 19NAS221-7 . 3

-26-27-28-29

-3

NUTPLATE


73

177RG Parts Catalog

1234567

18-33

-35

-37

-38

-44

5ATTACHING PARTS

74

177RG Parts Catalog

FIGUREINDEX PART NUMBER DESCRIPTION PER

1 2 3 4 5 6 7 ASSY CODENO. 1234567

18 64 ASSY-DRAIN CONTROL-65-

-67 AN515-8R8 SCREW 19 F

-68 2016029-2

-69-70-71

A-- -

B-

C-

D-

177RG SERIAL

75

MODEL 177RG

Fuselage (Cont)

20

Figure 19. Fuselage Center Belly Section76 49

76

177RG Parts Catalog

FIGURE UNITSAND PART NUMBER DESCRIPTION

NO. 2 3 45 6 7 ASSYCODE

19-

-2 A

- 3-4

- 6

-- 8

-10

-

-20 A4

-24

-25-26 6-1

-27-28 2

-29 2 3-1 ASSRENBLY-_R~E PUL[[ | 13-2

-30 1 1-1-31

-32

-33

-34

-35 1

-37


77

177RG Parts Catalog

AND PART NUMBER DESCRIPTION PERINDEX ASSYNO. 1234567

19 -38

-43

-50

-51

-54-55-56-57

78

177RG Parts Catalog

FIGURE

INDEXNO. 1234567 ASSY CODE

No. 1234587- 1

- 2

-5

-9-----

-14-

- -- 1-

-2

-

--2

-38--3-3-3--


79

MODEL 177RG

Fuselage (Cont)

40

80

177RG Parts Catalog

FIGUREAND UNITS USABLEPARTNUMBER DESCRIPTION PER ON

-40

-41

NAS 450-9

-42

-43-

-44

-47-48 20

-49-50

-51-53 2

-55-56

81-64-65

-66 2011009-1

-67 AN743-12 BRACKET 2-68 NAS464P

MS2104214 4-69

81

MODEL 177RG

Fuselage (COnt)

Figure 21. Wheel Well Details - Main Landisg Gear37,.

1

21 26

Figure 21. Wheel Well Details-Main

82

177RG Parts Catalog

FIGURE UNITSINDEX PARTNUMBER DESCRIPTION PER ON

NO. 1 23 ASSY 3 4 6

21 - DETAILS- LANDING GEAR

-17-18

ATTACHING PARTS

CR762-4-3 RIVET CY 2

-21

-23

-

-30

-32 a2 M228U<ANGLE-SPLICE-33-34

-36-37-38-

83

MODEL 177RG

Fuselage (Cont)

12

Figure 22. Aft Cabin Windows Installation

FIGURE UNITS USABLEAND PART NUMBERS DESCRIPTION PER ON

NO. 1234567

22 - AFT CABIN WINDOWS INSTALLATION NP- 1 1712000-7 WINDOW-REAR --- 1

1712000-10 WINDOW-REAR TINTED 1ATTACHING PARTS

- 2 1712055-1 RETAINER-LH FWD 1 A1712055-5 RETAINER-LH FWD 1 B

- 3 1712055-2 RETAINER-RH FWD -- --- 1 A1712055-6 RETAINER-RH FWD 1 B

- 4 1712056-1 RETAINER-LH AFT 1 A1712056-5 RETAINER-LH AFT 1 B

- 5 1712056-2 RETAINER-RH AFT 1 A1712056-6 RETAINER-RH AFT - --- 1 B

- 6 S1166-1 SEAL-CHANNEL BULK ITEM 1- 7 1712000-5 WINDOW-SIDE LH 1

1712000-8 WINDOW-SIDE LH TINTED 1- 8 1712000-6 WINDOW-SIDE RH ----- --- - 1

1712000-9 WINDOW-SIDE RH TINTED 1ATTACHING PARTS

- 9 1712076-5 RETAINER ASSEMBLY-LH UPPER FWD 11712076-6 RETAINER ASSEMBLY-RH UPPER FWD 1

-10 1712057-5 RETAINER ASSEMBLY-LH UPPER AFT -1712057-6 RETAINER ASSEMBLY-RH UPPER AFT 1

-11 1712058-5 RETAINER ASSEMBLY-LOWER LH -- 11712058-6 RETAINER ASSEMBLY-LOWER RH 1

-12 S1166-1 SEAL-CHANNEL BULK ITEM ----- - 2

A--177RG SERIAL 177RG0001 THRU 177RG0019B--177RG SERIAL 177RG0020 & ON

F177RG SERIAL F177RG0001 & ON

84

Fuselage (Cont)

10

Figure 23. WindshieldFigure 23. Windshield Installation

FIGURE UNITS USABLE

AND X PART NUMBER DESCRIPTIOn NINDEX ASSY CODE

NO. 1234567

23 - WINDSHIELD INSTALLATION NP- 1 1710000-9 WINDSHIELD ASSEMBLY - 1

1710000-10 WINDSHIELD ASSEMBLY TINTED 1- 2 S1389-3 SEAL-FELT BULK ITEM - ------ - --- 3 51389-1 SEAL-FELT BULK ITEM 1- 4 S1389-1 SEAL-FELT BULK ITEM- 5 1713051-1 RETAINER-WINDSHIELD TOP LH -

1713051-2 RETAINER-WINDSHIELD TOP RH 1- 6 S1389-8 SEAL-FELT BULK ITEM - -- --- 7 1713147-1 RETAINER-WINDSHIELD SIDE LH 1

1713147-2 RETAINER-WINDSHIELD SIDE RH 1- 8 1713043-5 RETAINER-WINDSHIELD LOWER - 1- 9 S1389-1 SEAL-FELT BULK ITEM 2-10 AN507-832R12 SCREW -- ---

AN960-8L WASHER - 2NAS1022N08 NUT 2

85

MODEL 177RG

Fuselage (Cont)

177RG SERIAL 177RG0001 THRU 177RG1266Figure 24. Fuselage Tailcone AssemblyFigure 24. Fuselage Tailcone Assembly

86

177RG Parts Catalog

INDEX ....NO. 1234567 ASSY

24 -

-3

-4- 6

- 6A

-11- 3-

--22-23-24-25

-30-31-32-33-34 -8A-35-36 1

-37

-37A-38-39-40-41-42-43

-43A

NAS696A08 2

-44

-45

-47


87

177RG Parts Catalog

AND PARTNUMBER DESCRIPTION

24 -51

-54

-57

--

-

66

-75-76 20

-77

-

-

88

MODEL 177RG

Fuselage (Cont)

69

72

70

Detail A

68

85

13 66

21

53

177RG SERIAL 177RG1267 & ONFigure 24A. Fuselage Tailcone Assembly

8 blank/ 90

177RG Parts Catalog

AND UNITSINDEX PART NUMBER DESCRIPTION ON

NO. 1 2 3 4 5 6 7 A

24A-

-6

- 8---3

-

--

-33-34-35-36-37 ,

-39 BULKHEAD-40-41-42-43-44-45

-48

-49

-50

-52-53-54


91

177RG Parts Catalog

AND PART NUMBER DESCRIPTION UNITS ONASSY CODENO 2 3 4 5 67 ASSY CODE

24A-55 2012118-1 RETAINER-TAILSKID-5--

ATTACHING PARTS

NUT 6

-67 1712155-1-68-69 1712128-12

-73-74-75-76-77-78

AN515-8R8 SCREW 2-79-80-81

92

Fuselage (Cont)

3

Figure 25. Stinger Installation

FIGURE UNITS USABLE

AND PART NUMBER DESCRIPTION PER ONINDEX ASSY CODE

NO. 1234567

25 - STINGER INSTALLATION NP

- 1 1712136-1 STINGER ASSEMBLY-TAILCONE 1ATTACHING PARTS

-2 S102128-6 SCREW- 3 AN509-R12 SCREW

- 4 NAS681A08 NUTPLATE- 5 NAS395-14-3 NUT-6 NAS683A08 NUTPLATE 1

AN515-8R5 SCREW -

7 S1021Z8-6 SCREW 7- 8 1712137-1 BULKHEAD 1

ATTACHING PARTS-9 S1021Z8-6 SCREW 6

NAS395-14-3 NUT --- -

-10 1712072-1 PLATE-STINGER COVER LH 11712072-2 PLATE-STINGER COVER RH 1

ATTACHING PARTS-11 S1021Z8-6 SCREW -- .-12 AN507-832R6 SCREW

93

MODEL 177RG

Fuselage (Cont)

13

177RG SERIAL 177RG0001 THRU 177RG1266Figure 26. Battery Box & Hydraulic Pump Mount Installation

94

177RG Parts Catalog

FIGUREAND UNITS USABLE

INDEX PART NUMBER DESCRIPTION PER ONNO. 1 2 3 4 5 6 7 ASSY CODE

26 - BATTER BOX & HYDRAULIC PUMP MOUNT INSTALLATION

---3

-

---7 PIN- 8

ATTACHING PARTS-9 NAS397-8 CLAMP 1 C

-152

-

-

95

MODEL 177RG

Fuselage (Cont)

177RG SERIAL 177RG1267 & ONFigure 26A. Battery Box & Mount Installation - 24 Volt

FIGURE

INDEX PART NUMBER DESCRIPTIONNO. 1234567

26A- BATTERY BOX MOUNT INSTALLATION -24 VOLT NP A- 1 1670039-10 LID ASSY-BATTERY BOX 1

ATTACHING PARTS- 2 AN415-2 PIN-LOCK 2

- 3 0413307-13 CATCH 20512167-16 BACKING PLATE-CATCH 2

- 4 1670039-5 BOX ASSY-BATTERY 1- 5 0512167-10 LATCH SPRING 2- 6 0512167-17 BACKING PLATE-LATCH 2- 7 1712168-1 SUPPORT-BATTERY BOX 2- 8 1670032-1 BACKING PLATE-SUPPORT 2- 9 S1071-4 TUBE 7.50 IN LG BKI REF S1071-4-7.50 1

ATTACHING PARTS-10 S1494-8 CLAMP 1

MS35489-14 GROMMET 1

-11 2012092-1 SUPPORT PLATE-AFT 1-12 2012089-1 BULKHEAD SEGMENT-FORWARD 1-13 2012090-1 BULKHEAD 1-14 2012091-1 BULKHEAD 1-15 2012112-1 SHIM-ULKHEAD 1

A- 177RG SERIAL 177RG1267 ON

96

177RG Parts Catalog

RGUREAND PART NUMBER DESCRIPTION PER ON

N. 12345 CODE

27 - NOSE GEAR INSTALLATION-1 SEE FIG 30 GEAR STRUT ASSEMBLY

- 2 NAS464-6lA33- 3 S1450-6H14-063 WASHER- 4 RA6- 5 AN960-616 WASHER- 6 MS21042L65- 7 2043015-5 BOLT ASSEMBLY

AN320-5-10 MS24665-132 PIN-COTTER

-11 SEE FIG 32 ASSEMBLY-SHIMMY 1

-12 MS20392-3C17AN960-416L

-13NAS75-3-013

-14 2043009-1 RING-ASSEMBLY GIMBAL 1-15-15 NAS464-4A5 2

AN960-416L2

-

-18 AN515-8R6 SCREW 2-19 MS21045

-20 SEE 83 GEAR SYSTEM-21 SEE FIG 28

-23 2043015-6

MS24665-132 PIN-COTTER

-24 NAS75-5-010 BUSHING 2NAS77-5-34 2

-25 2043007-1 ASSEMBLY-AFT 1ATTACHING

-26 NAS464-5-33 2-27 AN960-516 ER 4-28 AN320-5 2-29 MS24665-132 PIN-COTTER 2

-30 NAS77-5-24 BUSHINGNAS75-. . BUSHING

-31 NAS428H4-12AN316-4 NUTAN960-416 WASHERMS21209F4-15-32 NAS75-5-102MS21209F5-152043006-22

-32A 2043006-23-32B 2043073-5

-33-34 WASHER-35 S14-36-37-38 5A15 BOLT-39 516L WASHER

-40 2043073-6 WELD ASSEMBLY-LOCK


97

MODEL 177RG

Alighting Gear

98 43 32

53C

98

177RG Parts Catalog

FIGURE UNITS USABLEAND PARTNUMBER DESCRIPTION PER ONNO. 1234567 ASSY CODE

27 -41 CR841A 2043006-11-41A-42-43 2043006-24

-

-44 S2049P4FG ROD END-45

-46 2043006-3

-48-49 2043048-1 A

-50-51 WASHER A-52

-52A 2070029-2

-52B--52D

-5-53--53B

-53C-530-53E-53F-536

-54 SEE FIG 31

-55-56-5-

-62

-63 A

-64 A

6241M EXTENSION-VALVE DL 1

A--

.C--

D-- -

99

MODEL 177RG

Alighting Gear (Cont)

22

26

33

Figure 28. Nose Gear Steering System

100

177RG Parts Catalog

FIGURE

PART NUMBER DESCRIPTION PER ONN 1 2 34567 ASSY CODE

28- NOSE SYSTEM NP-1 2060003-1

ATTACHING PARTS-2-4

-5 MS20392-

PIN-COTTER

- 8- 9 2067009-2 SUPPORT ASSEMBLY-STEERING SHAFT RH

-10 S1004-46A BEARING11 2067009-1 SUPPORT ASSEMBLY-STEERING SHAFT LH12 S1044-59A

-13 2067010-1 ROD ASSEMBLYATTACHING PARTS

-14 MS20392-3C13

-18 2060004-1

-19 AN4-7A-20 AN960-416-21-22 AN4-11A BOLT .

-23 2060004-10-24 S1896--25 2067006-1 BE ASSEMBLY .

-26 AN4-11A-27-28

-29--31-

-33 NAS220-9 2-34 AN960-8 2 REQD ON OUTBD SCREWS ONLY 4-35

101

MODEL 177RG


30 3332

25

Figure 29. Nose Gear Uplock Installation35A2

4 39

37

39 34B - 34C

177RG001 THRU 177RG0282 177RG0283 THRU 177RG787

Figure 29. Nose Gear Uplock Installation

102

177RG Parts Catalog

FIGUREAND UNITS

INDEX PART NUMBER DESCRIPTION PER ONNO. 1234567 ASSY CODE

29- 1- 2 2043036-1

ATTACHING PARTS-3 MS20392-2C7 PIN- 4 MS24665-132 COTTER PIN-5- 6- 7

.

-20 AN4-15A--

-23

-24 AN4-20A BOLT-25 2043035-2 SPACER-26 AN960-4161 WASHER-27 MS20365-428C NUT

-28 MS20392-2C51-29-30 2043030-1-31 NAS220-7 SCREW-32 AN960-8 WASHER 6-33 MS20365-832C 6

-34 S1377-1 2 A-34A 1 & E ASSY-GEAR UP B-34B

-35-35A

-37A

-38


103


NO. 1234 5 6 7

29 -39 S1693-1

NOTE. *WHEN INITIALLY ODERING THIS

NOTE.

104

MODEL 177RG


75

177RG0001 THRU 177RG0787F177RG0001 THRU F177RG0138

Figure 30. Nose Gear Shock Strut Assembly

105 blank/ 106

177RG Parts Catalog

FIGUREUNITSAND PART NUMBE DESCRIPTION

1 234567 ASSY CODE

30 -

-3 --4

- 6

-7

-10

- .4-. 5-

-25

-27 S2014-9 .030 - .035 IN THICK-28 S2013-4-29 S2014-4-30 2043002-12-30A 2043071- *-31 S1997-9G12-32 S1997-4 2-33 S1997-44G16-34 NAS77-5-40-35 1542009-2-36 2043013-1

-37 AN5-31A-38-39 MS21025.

-40 2043024-1 SPINDLE BOLT-STEERING COLLAR 2ATTACHING PARTS

-41 AN960-616-42 AN310-6 NUT-43 MS24665-283 PIN-COTTER

-44 MS15002-1 FITTING-LUBE 2-45 NAS77-8-15-46

-47 AN960-10L-48 MS21042-3

-49 S1827-1 VALVE ASSEMBLY 1


107

177RG Parts Catalog

FIGURE


30 -50

-53

-60

-69 --70

-74

-76

NOTE.TO& 2043003-4.

108


6

12 7

9

Figure 31. Nose Gear Wheel Assembly

FIGURE UNITSAND PART NUMBER

INDEX ASSY CODENO. 1234567

31 - WHEEL ASSEMBLY-NOSE GEAR NP- 1 C262003-0102 TIRE-BLACKMALL 5.00X5 4 PLY RATED 1

C262001-0102 TIRE-WHITEWALL 5.00X5 4 PLY RATED 1- 2 C262023-0101 TUBE-5.00X5 1

1241156-12 WHEEL ASSEMBLY CFP 1- 3 155-00200 RING CFP 2- 4 153-00800 RING-GREASE SEAL CFP 4- 5 154-00600 GREASE SEAL-FELT CFP 2- 6 214-00400 BEARING CFP 2- 7 161-03100 WHEEL HALF-MALE CFP 1- 8 162-02800 WHEEL HALF-FEMALE CFP 1- 9 214-00300 CUP-BEARING CFP 1-10 217-00100 GROMMET CFP 1-11 AN4-22A BOLT 3-12 AN960-416 WASHER 3-13 MS20365-428 NUT 3

109

MODEL 177RG


13

177RG SERIAL 177RG0274 THRU 177RG0911(ALTERNATE)

Figure 31A. Nose Gear Wheel Assembly

110

177RG Parts Catalog

FIGUREAND PART NUMBER DESCRPTION PER ONINDEX ASSY

31A--1

- 3-3 D

-6,--

--7

NOTE

MODEL 177RG

177RG SERIAL 177RG0912 & ON(ALTERNATE)

Figure 31B. Nose Gear Wheel & Tire Assembly - McCauley

FIGURE UNITS

NO. 1234567

31B- WHEEL ASSEMBLY-NOSE GEAR ALTERNATE NP A- 1 C262003-0102 TIRE 5.00X5 4 PLY RATED 1- 2 C262023-0101 TUBE 5.00X5 1

C163005-0201 WHEEL ASSY 1- 3 A1636-23 RING-RETAINING MCL 2- 4 A30048 RETAINER-SEAL MCL 4- 5 A30047 GREASE SEAL-FELT MCL 2- 6 A30078-2 CONE-BEARING MCL 2- 7 C30598 WHEEL HALF ASSY MCL 2- 8 A30078-1 CUP-BEARING MCL 1- 9 AN5-22A BOLT 3-10 AN960-516 WASHER 6-11 AN365-524A NUT 3

A-177RG SERIAL 177RG0912 & ONF177RG SERIAL F177RG0154 & ON

112

MODEL 177RG


Figure 32. Shimmy Dampener Assembly57A

8 12

Figure 32. Shimmy Dampener Assembly

FIGURE UNITS USABLE

AND PART NUMBER DESCRIPTION PERINDEX ASSYCODENO. 1234567

32 - SHIMMY DAMPENER ASSEMBLY USE 2043014-10 1 A2043014-10 SHIMMY DAMPENER ASSEMBLY 1 B

- 1 2043014-8 BARREL ASSEMBLY WEU 2043014-10 1 A2043014-14 BARREL ASSEMBLY 1 B

- 2 MS21209F1-15 INSERT 2- 3 600-015-100S STAT-O-SEAL 1- 4 NAS563-11 BOLT 1- 5 AN6227B10 O-RING 2- 5A MS2B775-112 PACKING 2 B- 5B S1628-112 RING 2 B- 6 2043014-6 HEAD BEARING WEU 2043014-12 1

2043014-12 * HEAD BEARING B- 7 AN6227B18 O-RING USED WITH 2043014-6 ONLY 1- 7A MS28775-023 ** PACKING 1 B- 7B S1628-023 ** RING 1 B- 8 MS16625-118 SNAP RING 2- 9 2043014-9 ROD ASSEMBLY 1-10 2043014-5 PISTON WEU 2043014-11 1 A

2043014-11 PISTON 1 BATTACHING PARTS

-11 NAS561P4-15 PIN

-11A MS28775-213 PACKING 1-12 0743623-4 PISTON-FLOATING 1-13 AN6227B3 O-RING-14 0743623-3 SPRING 1-15 0743623-6 SETSCREW 1

NOTE. *WHEN ORDERING THIS PART FOR AIRPLANESPRIOR TO SERIAL 177RG0252 ALSO ORDER PARTSMARKED **.

A-177RG SERIAL 177RG0001 THRU 177RG0251F177RG SERIAL F177RG0001 THRU F177RG0072

B--177RG SERIAL 177RG0252 & ONF177RG SERIAL F177RG0073 & ON

113 blank/114

177RG Parts Catalog

FIGURE

AND PART NUMBER DESCRIPTION

- 1 0741048-8

-2-3 3

- 4-5- 6

516L


115

MODEL 177RG


116


AND PART NUMBER DESCRIPTIONNO. 1 2 3 4 5 6 7

-33

-18

--

-2---2

-26 MS21042L6-27 1241606-9

-

--36 AN960-10 4

-37 2041030-14

NOTE. **REFER TO NOTE ON FIGURE 34.

A-177RG SERIAL 177RSG0001 THRU 177RG0067

B-

117

MODEL

24

118

177RG Parts Catalog

INDEX PART NUMBER DESCRIPTION UNITS

NO. 1234567ASSY CODE

34- MAIN LANDING GEAR ACTUATING SYSTEM

--

-4.

------12

2

-

-

-24 -

-

ATTACHING PARTS-

-30-

-31 S2394-2S2394-4S2394-6 AR

-33 S2394-5 2-34 2041013-1

--36 AN960-41G-

-38-39


119119

177RG Parts Catalog

AND PART NUMBER DESRIPTION PERINDEX ASSY

34 -40

-44

NOTE. *WHEN ORDERING THIS PART FOR AIRCRAFT PRIOR TO

NOTE.

77

120

MODEL 177RG


2429

30

REFER TOFOR MODIFICATIONS TO 177RG0001 THRU 16177RG0212 & F177RG0001 THRU F177RG0042.

177RG SERIAL 177RG0001 THRU 177RG0282Figure 35. Main Landing Gear Downlock Installation

121 blank/122

177RG Parts Catalog

FIGURE

PART NUMBER DESCRIPTION PERNO. 1234567 ASSY CODE

35 -

-5-5-6-7

-11

--

-----21-

-22--24-25-26 18-27-28-29-30-31

-33

-3-34-36

-37 . SWITCH .-38 S2112-1 ATTACHING PARTS 1-39 AN515-2RB 2-40 AN936A2 2-41 AN340B2 NUT 2-42 NAS430D5-9 A

NAS43005-5 B-43 MS16624-1031 RETAINER RING B

F

E-1

123

MODEL 177RG

Alightng Gear (Cont)

28 25

17

177RG SERIAL 177RG0283 THRU 177RG0787Figure 35A. Main Landing Gear Downlock Installation177RG SERIAL 177RG0283 THRU 177RG0787Figure 35A. Main Landing Gear Downlock Installation

124

177RG Parts CatalogFIGURE UNITS USABLE

AND PART NUMBER DESCRIPTION PER ON1234567ASSY CODE

35- MAIN LANDING GEAR DOWNLOCK INSTALLATION NP A- 1 SEE FIG 88A

- 5

- 6

- 7 AN4-7A BOLT

-17

-1-19-20-21

-22-24-25-26

-27

-28

125

MODEL 177RG


27

177RG SERIAL 177RG0788 & ONFigure 35B. Main Landing Gear Downlock Installation

126

177RG Parts Catalog

FIGURE

INDEX PART NUMBER DESCRIPTIONNO 1234567

35B-- 1 SEE FIG 88F

- 2 MS20392-1C15 PIN- 3 AN960-6L WASHER- 4 S24665-132- 5- 6 AN

- 7

-8

-13

-1

-20 AN4-7A-21-21A

-22-23-24--26-27

-31 NAS1352-06LE6 2-32 AN936-

-33

ATTACHING PARTS-34 AN504-6R6-35 AN936-A6 WASHER 2-36 MS35649-262 NUT 2

A-177RG SERIALF

127

MODEL 177RG


9

22

24

22

128

177RG Parts Catalog


ASSY CODE

C163001-0104 ASSY-MAIN GEAR-1- 2 162--3-4 155

-6

-

CFP

CFP

-24 CFP-25 MS21042-4-27

-28-29-30

-31

NOTE. **BRAKE ASSEMBLIES DESRIBED AREH NORMALLY

MODEL 177RG


14

15 35

27

31 34

177RG SERIAL 177RG0788 THRU 177RG1108Figure 36A. Main Landing Gear Wheel & Brake Assembly (Alternate)

130

177RG Parts Catalog

FIGURE UNITS USABLEAND PART NUMBER DESCRIPTION PER ONINDEX 1234567 ASSY CODE

36A--- 2

-3 3-4-5- 6 30163-6-6A-7- 7A-8- 9-10-11 4

-13

-16

-17-18

-19 C30041-20-20-21-22 T-23 PLATE ASSY-24

-25-26-27 ASSY MCL

-29-3

-33-34-35

NOTE. BRAKE ASSEMBLIES DESCRIBED ARE NORMALLY

FOR INSTALLATION

NOTE. %THIS BRAKE ASSY MUST BE USED WITH C163003-0102OR C163004-0104 WHEEL ASS ONLY.

NOTE. **THESE WHEELS MUST BE USED ONLY ON

C-

131

MODEL 177RG


22

177RG SERIAL 177RG1109 & ONFigure 36B. Main Landing Gear Wheel & Brake Assembly (Alternate)

132

177RG Parts Catalog

PART NUMBER DESCRIPTIONNO. 1 2 3 4 5 6 7

36B---2

-3- 4

-

- 7- 8- 9-

-

--18-19 416L-20-2-22-23-24

--26 AN960-416L-2-28 B30026

A30087

NOTE. **THIS

B-

133

MODEL 177RG

Nose Gear Doors

17

9

Figure 37. Nose Gear Doors & Actuator Installation

134


INDEX

37 -

-3 204322-1

-5-6- 7

-8 2043042-- 9

-

-

-20

-22-23-24-24A-25-26-27-28-29

-3-32-33

-

-ATTACHING PARTS

-43 S1693-2 STRAP 2

Door & Window

136

177RG Parts Catalog

AND PART NUMBER DESCRIPTION PER ONINDEX

NO. 1 2 3 4 5 6 7

38 - CABIN DOOR ASSEMBLY

-2-3

- 5 1713123-11713123-2

-6 1211249-2-7-8

-12-13 NAS561-3-10 1

-

-27-24--

-2-25 A

-

-32

-33 S1631-8 RING-RETAINER


137

177RG Parts Catalog

FIGURE USABLEPART NUMBER DESCRIPTION PER ON

2 4

38 -34-35-37

-38

--41

-42

-44-46

-49

-50-47-51

-53 ASSEMBLY

-54 AN515-8R4 2-55 MS21044N08 NUT 2

-59 1717077-1

ATTACHING PARTS

-66 MS2092-1C7 PIN


138

177RG Parts Catalog

FIGURE UNITSAND PART NUMBER DESCRIPTION PER ON

INDEX ASSY CODE

-70-71

-72

-73 1717052-1

-74-75-76-77-78

NOTE. *FOR BREAKDOWN REFER TO FIG 38A.

C-- . 17

139

Door & Window

177RG Parts Catalog

FIGURE UNITS USABLEAND PART NUMBER DESCRIPTIONNO. 1234567 ASSY CODE

38A- CABIN DOOR ASSEMBLY-LH NP A

-

-

-

---25

-

-


141

177RG Parts Catalog

38A-31

-32 S1631-8

ATTACHING PARTS-3 LH-37

-40

-43

-44

-45-46

-47 AN3-3A-48 1717088-1

-49 1717091-1 ROD ASSEMBLY-UPPER DOOR LATCH 1

-51 MS24665-132 PIN-COTTER

-52 1717084-5 SLEEVE ASSY- ATTACHING S

-53 AAN

-54

--55

-5

. 7-

142

177RG Parts Catalog

FIGURE UNITSINDEX PART NUMBER . DESCRIPTION PER ON

NO. 1234567 ASSY

38A-61

-62 AN515-8R5 SCREW 2

-64

-65-66

-67 AN515-8R4-68

*

-69 1717077-8-73 7

-77-76 1717080-2

-80 MS24665-132 PIN

-8-

-84-85

MS21044N3 NUT 2

-86 1717052-1 ARM-DOOR STOP 1

-87

--9

-92 1717070-2

B- 177RG SERIAL THRU 177RG0592

C-

177R6 SERIAL F177RG0139 & ON

143

MODEL 177RG

Door & Window (Cont)

23

Figure 39. Cabin Door Latch Assembly

144144

177RG Parts CatalogFIGURE UNITS USABLEIND PART NUMBER DESCRIPTION PER ON

NO. 123456ASSY CODE

39 -

-

-8

PARTS-12

-14 1511209-12

--21-22

-23-

145

MODEL

177RG Parts Catalog

AND PART NUMBER DESCRIPTION PERINDEX

40 --1

- 2

-20-3-4--

- 8

-- 9A

- 9E- 9F NAS620-5 WASHER AR B

- 9G 1217043-1

- 9H NAS561C3-8 PIN 1 B

-17

-1-

-

-25 AN515-8R6

-26 SEE FIG 43 SEAL-BAGGAGE DOOR

A-

147

MODEL 177RG

Upholstery

12

177RG0433 & ON

Figure 41. Cabin Door Upholstery Installation

148

177RG Parts Catalog

FIGURE UNITS USABLE

41 - DOOR INSTALLATION

--3 1715014-1 <

-S1023A4-6C SCREW ARS1066C1

- AN520-10R20 SCREW 2#-- AR M

2015015-3 #

-8 -23 F1715042-24 < F

AR

-10 S1021Z4-6 SCREW 2

-12 S1023A4-6C S


149


NO. 1234567ASY

41 -NOTE.

A-- -

150

MODEL 177RG

Upholstery (Cont)

13

3

1TRG0283 & ON

177RG SERIAL 177RG0001 THRU 177RG0787Figure 42. Cabin Top & Firewall Upholstery Installation

151 blank/152


INDEX PART NUMBER PER ON

1 2 3 4 5 6 7 ASSY

-2

- 4 1715027-7

-5-5A

-6-

-8 1715040-16- 8A 1715043-7 < -

1715040-17 <

- 9-12--

-11

--- . 7

7

-20 0713253-1 DEFLECTOR-DEFROST AIR 1

S1021Z4-6NAS446-1-3 NUT 4

-21

-22


177RG Parts Catalog

NO. 1234 6 7 CODE

42 -23 1713136-3 RETAINER 1S1022Z4-5C

-24 2013140-2 BRACKET 2ATTACHING PARTS

S1021Z6-8 SCREW 3-25 2013136-1

-26 2013140-1 BRACKET 2ATTACHING PARTS

S1021Z6-8 SCRE 3

-29S1021A4-6 2

-30

NOTE. <THIS PART MUST HAVE A SECOND DASH NUMBER

F-

77

154

MODEL 177RG

Upholstery (Cont)

177RG SERIAL 177RG0788 & ONFigure 42A. Cabin Top & Firewall Upholstery Installation

155 blank/156


AND UNITS USABLEINDEX PART NUMBER DESCRIPTION PER

NO. 1234567 ASSYCODE

S1023A4- 6C AR

-

S1021Z4-8 2

- 5 1715013-1 <

S1950-1

-6 -7

S1950-1 AR

-17 S1362-6

AN507-1032R10 SCREW 2

-21-22


157

177RG Parts Catalog

FIGUREINDEX PART NUMBER DESCRIPTIONQ PER

NO. 1 2 3 4 5 6 7

42A-23

-24 -

-25

-27 AN525-10R12 SCREW 2

S1021A4-6 SCREW 2

NOTE. #THIS PART NUMBER MUST HAVE A SECOND DASH

NOTE. <THIS PART NUMBER MUST HAVE A SECOND DASH

158

177RG Parts Catalog

FIGURE UNITS USABLE

AND PART NUMBER PER ONINDEX ASSY CODE

43 -

WASHER AR

-3 2015002-1 1

AR

- 4

-5

-6

-7 #

- 8-

AN520-10R12

S1542-1 WASHER 2


159

MODEL 177RG

Upholstery (Cont)

8 25

177RG0213 & ON

Figure 43. Cabin Side & Floorboard Upholstery Installation

160

177RG Parts Catalog

FIGUREINDEX PART NUMBER DESCRIPTION PER ON

1234567

43 -18 1715029-117

-19

-20

-21

-24 --

-23

ATTACHING PARTS-24-25

AR

A--

B--

C-

D-

E-

161

P--

161

MODEL 177RG

. 8i

CES 1109 1B

Figure 44. Cabin Soundproofing Installation

162

177RG Parts Catalog

FIGURE

INDEX PARTNUMBER DESCRIPTION PER ONNO. 1234567 CODE

44 - CABIN INSTALLATION- 1

NOTE. *GIVE DIMENSIONS WHEN ORDERING

163

MODEL 177RG

177RG0283 & ON

38

31

177RG SERIAL 177RG0001 THRU 177RG0592Figure 45. Front Seat Installation

164

177RG Parts Catalog

RGUREAND UNITS USABLEINDEX PART NUMBER DESRIPTION PER ON

NO. 1 2 3 4 5 6 7 ASSY CODE

45 - FRONT SEAT INSTALLTION NP

2 SEAT ASSEMBLY-FRONT 2

ATTACHING- 1

- 2

- 3 2014001-201 #2 BACK ASSEMBLY-UPHOLSTERY SEAT . AASSEMBLY SEA B

-4 2-5 BUSHING 2-6-7 SPRING 2-8

-9 -6 2 SEAT 1 A

-10

#1-11 ATTACHING-12 S1021A4-6 SCREW 5

-13 0514055-3 #1

0514055-12 CABLE1414045-2

1214062-5 #2-14

-16

-

----20 S1021A4-6 SCREW 2-21 0514058-1 #1 RETAINER-SEAT BOTTOM 1

S1021A4-6 SCREW 5

-22 1714000-33 HOUSING ASSEMBLY 4ATTACHING PARTS-23 NAS220-11 SCREW 2-24 AN960-8 2 2-25 MS21044N08 2

-26 1714000K200

-27

-29 S1914-8


165

177RG Parts Catalog

ANDINDEX PART NUMBER DESCRIPTION PER ON

1 2 3 4 5 6 7 ASSY CODE

45 -30

-34

ATTACHING PARTS-41

-45-46-47-48-49

-51-52

NOTE. #1 THIS PART NUMBER MUST HAVE A SECOND DASH

NOTE. #2 THIS PART NUMBER MUST HAVE A SECIND DASH

NOTE. #3 WHEN INITIALLY ORDERING THIS PART, REFER TOSEB 89-2 TO ORDER APPROPRIATE SERVICE KIT.

-

166

MODEL 177RG

Seat (Cont)

47

177RG SERIAL 177RG05932

26 33

26 27 32

177RG SERIAL 177RG0593 & ONFigure 45A. Front Seat Installation

167 blank/168

177RG Parts Catalog

FIGURE

INDEXAND PART NUMBER DESCRIPTION

45A-

-

- 2

-

-4

-1-12 0514099-3 CLIP 2

- 1

S1021A4-6 SCREW 2

--

S1021A4-6 SCREW 3

-

-20 --21

S1021A4-6 SCREW 2

-22 1714000-33

-23 NAS220-11 SCREW 2-24-25

-26

-28-29 S1914-8

-30


169

177RG Parts Catalog

NO. 12 3 4 5 6 7 ASSY CODE

45A-31 1714007-1 BE

-39 1714068-1

-40-41

-42 1714009-1 PIN-SEAT STOP 2ATTACHING PARTS

-43 MS20392-1C13AN960-4LMS24665-132

-44 1714061-1 GUIDE-PIN 2

-45 2-46

-47

-49-50

-51

-52-53-54

-55

170

177RG Parts Catalog

FIGUREAND PART NUMBER DESCRIPTION PER ON

46 -

--

- 2

- 3 2014002-200 #2

- 4-5

0514029-2 SPACER

- 6- 7- 8 MS24665-132 PIN-COTTER 2

-9

-10

-11

-12 S1021A4-6 SCREW 3

-13 0514018-3 #1

-14-15 2014002-201 #2 A

-16-17 MS20392-3C17 P 2- 8 AN960-416L-19 MS24665- 1 3 4

-20 2014002-2

-21

-22 0514101-10514101-2

-

-26 S1021A4-6-24

-28 MAS561P4-12

-27

-33


171

MODEL 177RG

Seat (Cont)

2

39 36

84

68 47

99

66

177RG SERIAL 177RG0001 THRU 177RG0282Figure 46. Infinitely Adjustable Front Seat Installation

172

177RG Parts Catalog

FIGURE

INDEX PART NUMBER DESCRIPTION

NO. 2 3 4 5 6 7

46 -34 0514036-1 HANDLE ASSEMBLY-SEAT BACK ADJUST 1ATTACHING PARTS

-35 NAS561P4-12 ROLL PIN 1

-36 0514033-1 BLOCK BEARINGATTACHING PARTS

-39

-40 NAS561P4-12 ROLL PIN

-40A4-2

-41

-42-43

-44-45

-51 NAS561P6-28 1

-52 0514028-6 BELLCRANK ASSEMBLY-REAR TORQUE TUBE LH 1ATTACHING PARTS


-54 0514028-5 BELLCRANK ASSEMBLY-REAR TORQUE TUBE 1

-55 NAS561P6-18

-56 0514026-5-57

-58

-59 1200136-1 COLLAR-FRONT TORQUE TUBE 3


-61 0514028-5 BELLCRANK ASSEMBLY-FRONT TORQUE TUBE 1


-63 0514032-1

-65 MS24665-132 PIN-COTTER 2

-66 1200159-3 HANDLE ASSEMBLY-VERTICAL ADJUSTMENT 1ATTACHING PARTS


-68 0514033-2 BEARING 1


173

177RG Parts Catalog

FIGURE UNITS USABLE

NO. 1 2 3 4 5 6 7

46 -70A

-n-72

-73-74-75 .

-7-7-78 MS24665-132-79 070113-1

-80 S102Z6-8

-81 0514047-2 ARM ASSEMBLY-SEAT ADJUST 1-82 PIN-83 10L WASHER

-85 1414104-56 CLAMP 1ATTACHING PARTS

-87

-91-94

-95

-96 1714000K200

-

-99 S1914-8 NUT

-99A 0514048-1 #2 HEADREST Y 2-99B

NOTE. #1 THIS PART NUMBER MUST HAVE A SECOND DASHNUMBER ADDED COLOR. REFER TOHOW TO ORDER INTERIOR PARTS PAGE XVII.

NOTE-. #2 THIS PART NUMBER MUST HAVE A SECOND DASH

HOW TO ORDER UPHOLSTERED PARTS-PAGE XVI.NOTE. #3 WHEN ORDERING THIS PART FOR AIRCRAFT

BEARING & TWO S2014-2

B

174

177RG Parts Catalog

INDEX PART NUMBER DESCRIPTION PER ON1234567ASS CODENO. 1 2 3 4 5 6 7

46A- NP A4006-8 #2 2 B

-1

ASSEMBLY-UPHOLSTERED SEAT NP

-2-3

-6

-7 #2

-8 #1-9

-10 1214062-5 2 PICKET ASSEMBLY-MAGAZINE 1

-11

-21-22-23

ATTACHING PARTS-24 NAS561P6-12 PIN 4

-25 0514030-4 BELL

-26 NAS561P4-12 PIN 2

-27 0514060-5 ASSEMBLY-SEAT PILOT-28

-29 NAS561P4-15 PIN 2

-30 0514036-1 H

-31 NAS561P4-12 PIN 1

-32 0514033-1 BEARING BLOCK 1175-33 AN520-10R8 SCREW 1

-34 1200138-2 COLLAR 2ATTACHING PARTS

-35 NAS561P4-12 PIN 1


175

MODEL 177RG

Seat (Cont)

26

2229

3236

30

54 48

177RG Parts Catalog


INDEX PART NUMBER DESCRIPTION PER ON

NO. 1 2 3 4 5 6 7 ASSY CODE

46A-36 S2013-2

-37

-38-39

-40 NAS561P6-28 PIN 1

-41 0514028-6 B

-42 NAS561P8-18 PIN 2

-43 0514028-5ATTACHING PARTS

-44 NAS561P6-18 PIN 1

-45 0514026-5 TORQUE TUBE-FWD 1-46 1200136-1 COLLAR-FRONT TOQUE TUBE 3

-47 NAS561P6-18 PIN 1

-48 0700633-5 BELLCRANK ASSEMBLY-VERTICAL ADJUSTMENT FRONT 2

-49 NAS561P6-22


-51 NAS561P6-18 PIN 2

-52 0514032-1

-53

-54

-55 1200159-3 HANDLEATTACHING PARTS

-56 NAS561P4-12 PIN 2

-57 0514033-2 BEARING BLOCK 1

-58 AN520-10R8 SCREW 1

-60 1200138-2 COLLAR 2ATTACHING PARTS

-61 NAS561P4-12 PIN 1

-63 0514027-19 ASSEMBLY-VERTICAL ADJUSTMENT 1-64

-65-66-67 AN960--68 MS24665-132 PIN-COTTER 169 1714087-3 HANDLE ASSEMBLY-SEAT LATCH RELEASE 1

-70 MS20392-2C59 PIN 2-70A NAS43003-18 2-71 AN960-10 2-72 MS24665-132 2

-73 1714061-1 GUIDE 2

-75 MS21044N08

CONTINUED ON NEXT PAE

177

1 77RG Parts Catalog

NO. 12345 67

46A-76 1714067-6 PIN-SEAT ADJUST 2-77

-77A

-81

-83---

---

NOTE

NOTE.

SEB 89-2 TO

178

177RG Parts Catalog

FIGURE UNITS

INDEX PART NUMBER DESCRIPTIONINDEX

46B-

- 2

-

-4

-6

-10

-12 0514099-3

S1021A4-6 SCREW 2

-16

-19

-20-21-22 4-23

-24-25

-26-

ATTACHING PARTS 2-27 S1021A4-6 2

-28ATTACHING PARTS

S1021A4-6

-28A

-28B S1021A4-6 SCREW 5 C

-31ATTACHING PARTS

-32 NAS561P6-12 PIN 4


179

MODEL 177RG

Seat (Cont)

17

28A

34 33 44 36

177RG788 & ON 37

4041

99B

2439 42

82

84 85 82 . .....Detail B

177RG SERIAL 177RG0593 & ONFigure 46B. Infinitely Adjustable Front Seat Installation

180180

177RG Parts Catalog

FIGURE

AND PART NUMBER DESCRIPTIONNO. 1 2 3 4 5 6 7ASSY

46B-33 0514030-4 BELLCRANK ASSY-SEAT BACK ADJUST 2ATTACHING PARTS

-34 NAS561P4-12 PIN 2

-35-36

-37

-38

-39

-40 0514033-1 BEARING BLOCK 1-41ATTACHING PARTS

-42 NAS561P4-12 PIN 1

-43

-45

-46-47

-48 NAS561P6-28 PIN 1


-50 NAS561P8-18 PIN 2

-51 0514028-5 BELLCRANK ASSY-REAR TORQUE TUBE RH 1ATTACHING PARTS

-52 NAS561P6-18 PIN 1

-53 0514026-5 TORQUE TUBE-FWD 1-54 1200136-1 COLLAR-FRONT TORQUE TUBE 3

-55 NAS561P6-18 PIN 1

-56 0700633-5 BELLCRANK ASSY-VERTICAL ADJUSTMENT FRONT 2

-57 NAS561P6-22 PIN 1

-58 0514028-5 BELLCRANK ASSY-FRONT TORQUE TUBE 1

-59 NAS561P6-18 PIN 2

-60 0514032-1 CHANNEL TORQUE TUBE INTERCONNECT 1

-61 MS20392-2C17 PIN 2AN960-10L WASHER 2

-62 MS24665-132 COTTER PIN 2

-63 1200159-3 HANDLE ASSY- B0514121-1

-64

-65 0514033-2 BEARING BLOCK 1-66-67

-68 1200138-2 COLLAR - 2ATTACHING PARTS

-69 NAS561P4-12 PIN 1


181

177RG Parts Catalog

FIGURE

1234S67CODE

46-70 BEARING

-71 -19 SCREW ASSY-VERTCAL ADJUSTMENT-72

-74-75-76-77

-78

-81

-82

-83-84-85 1714067-6 PIN-SEAT

ATTACHING PARTS

-87

PARTS-91 NAS220-11 2-92 AN960-8 2-93 MS21044N08 UT 2-94 S1704-1 ROLLER 4-95 1714000-22 8

-97 AN23-20A BOLT-98-99-99A

-

-99D 121 73- 2-99E

NOTE. #1 THIS PART NUMBER MUST HAVE A SECOND DASH

NOTE. #4

A---. SERIAL F

D--

E-

182

177RG Parts Catalog

FIGUREANDFIGURE UNITS USABLE

NO. 12 3 4 5 6 7CODE

47- REAR SEAT

# SEAT ASSEMBLY

- 1

--2

2A-2B

-3 2014003-201 #

-4-5-6 -- 7-8


183

MODEL 177RG

Seat (Cont)30

177RG SERIAL 177RG0001 THRU 1771RG0592Figure 47. Rear Seat Installation

184

177RG Parts Catalog

FIGUREAND UNITS USABLEINDEX PART NUMBER DESCRIPTION PER ONINDEXNO. 1234567

47 -10

-13-13

-16

-17 S1021A4-6 SCREW AR

-18 1714005-1

-19 1714033-1 BELLCRANKPARTS

-20

-2-23-24 1714095-1 LINK-SEAT BACK ADJUST 1

-25 MS20392-1C7 PIN-26 AN960-4L-27 MS24665-132 PIN-COTTER 2

-31

NOTE. <THIS PART NUMBER MUST A SECOND DASH

NOTE. THIS PART

MODEL 177RG

Seat (Cont)

24 20 2523

419 28 - 21

Detail B Detail A

177RG SERIAL 177RG0593 & ONFigure 47A. Rear Seat Installation

186

177RG Parts Catalog


- 1 7A

- 3

-

-12-13

-14

S1021Z6-4 SCREW 14

-6

-17

ATTACHING PARTS-20 1714033-1-21 AN24-31A BOLT 1-22-23-24


-26 MS20392-1C7 PIN 2-27 A960-4L WASHER 2-28 MS24665-132 COTTER PIN 2

NOTE. <THIS PART NUMBER

187

MODEL 177RG

Seat (Cont)

12

177RG SERIAL 177RG0001 THRU 177RG0592Figure 48. Rear Seat Installation-Individually Reclining Back

188

177RG Parts Catalog

FIGURE UNITS

NO. 1234567 ASSY

48 - REAR SEAT -INDIVIDUALLY RECLINING BACK NP

# SEAT ASSEMBLY REAR

- 2B

-3 2014004-201ASSEMBLY

2014004-202 #

-4 2

-6-7-8

-9

--5

-

------12-S1021A4-6-13 2014004-200

ASS

ASSEMBLY

CONTINUED ON NEXT PAGE-17 S1021A4-6

-18 1714005-1 KNOB SEAT

NAS561P3-6


189

177RG Parts Catalog

PART NUMBER DESCRIPTIONNO. 12345ASSYNO. 1 2 3 4 5 6 7

48 -19 1714033-1 2-20 AN23-12A BOLT-21 1714036-2-22 S1450-3-10-032-23 MS2

-24 1714095-1 LINK-SEAT BACK ADJUST 2-25-26-27 MS24665-132 PIN-COTTER 2

-28 1714001-19 PAWL ASSEMBLY 4-29 NAS561P3-8 ROLL PIN 1

-32

-33-34 .

190

77RG Parts Catalog

FIGURE UNITSAND PART NUMBER DESCRIPTION PER ONINDEXNO. 1 2 3 4 5 6 7 ASSY CODE

48A-

---4-5

-6

2


191

MODEL 177RG

Seat (Cont)

41

38 19

Detail C

22

20

36

33

Detil A

177RG SERIAL 177RG0593 & ONFigure 48A. Rear Seat Installation - Individually Reclining Back

192

177RG Parts Catalog

FIGUREAND UNITS

NO. 1 2 3 45 7 ASS CODE

48A-13

-14

-15

ATTACHING

-27-22-23-24-25NAS561P3-6

-26 1714033-1 BELLCRANK 2

ATTACHING PARTS-27 AN23-12A-28 1714036-2-29 S1450-3-10-032

-32 MS20392-1C7 2-33 AN960-4L-34 MS24665-132 COTTER PIN 2-35 1714001-19


-37

NOTE. <THIS PART NUMBER MUST HAVE A SECOND DASH

NOTE

193

MODEL 177RG

Instruments177RG0001

61A

45

177RG SERIAL 177RG0001 THRU 177RG0432Figure 49. Instrument Panel Equipment Installation

177RG Parts Catalog

FIGURE

AND PARTNUMBER DESCRIPTIONNO. 1 2 3 4 5 6 7

49 - INSTALLATION

-2ATTACHING PARTS

-3WASHER 4

4-

-6

-9

-

-18-19-20-21-22-23-24-24A-25

-26 0513351-1 2 A-27-28-29-29A

-30 1-30

-32 l713080-6 #3 PARTSATTACHING PARTS.

#3 B


195

177RG Parts Catalog

PART NUMBER DESCRIPTION

-33

-35 171355-1 #3

-36

-36A

-37

-38-39

-39A

-40

-41B A

-42

-43

A

SEE FIG 72

AN515B6R16

AN936A6B WASHER


196

177RG Parts Catalog

FIGURE UNITS

AND PART NUMBER DESCRIPTION PER ON


49 -46 S1317N2C664508-0102

-47

USE WITH NAV-O-MATIC

-48

-49

AN936A6B 3AN340B6 .- 3

-50

AN515B6R16 3

-51 C6685-0101-52-53

AN515B6R16 4

-54

ATTACHING PARTSAN515B6R12 SCREW

-55

AN515B6R10 4AN936A6 4AN340B6


197


UNITS USABLEPART NUMBER DESCRIPTION ON

-56

2000010-51

-57-

-58A 440451 FSO 6246-00109 NP6246-00109 1

-58B 4428746246-00618 #5

C486050 WIRE-CY

-59 C669504-0103 INSTRUMENT NP

-59A 441347 #6

-60 2000010-52 LINE-OIL GAGE TO FIREWALLATTACHING PARTS

AN520-10R8

-61 C

A515

AN34086 NUT 2


198

177RG Parts Catalog

FIGUREAND PART NUMBER DESCRIPTION PER ON

49 -61A 441346 SW FS0 6246-00675

-61B 442792 #12

-62 S1994-1-1

S1843-1

-63 ,845-1-2

843-1

-64-65

S1980-3780-5

-66 845-1-2 PITOT HEAT-67 S1846-2-3-68

S1843-1 1

-69 880- RHEOSTAT RADIO LIGHTS

-70-7

-71 SEE FIG 75

-72 0861233-2AN56508458857K44

-73-75-7-76

-79-80-81-81-82

-85 SE FIGQ 73-86 SEE FIG 77 --87 SEE FIG 55-88 0513019-7

-89ATTACHING PARTS

S1021A6-8 -

-90C593001-0101

NOTE. THESE ARE


199

177RG Parts Catalog

INDEX PART NUMBER DESCRIPTIONINDEX 1 2 3 4 5 6 7 ASSY

49 -

NOTE.

SK177-57.NOTE. #6 AIRPLANES

PART ORDER

NOTE.

S

NOTE.


200

177RG Parts Catalog

FIGURE UNITS USABLEINDEX PART NUMBER DESCRIPTION PER ON

NO. 1234567 ASSY CODENO. 2 3 4 5 6 7

49 -

201

MODEL 177RG

Instruments (Cont)

Detail A Detail B

Detail C177RG SERIA 177RG43 3 THRU 177RG0787

Figure 49A. Instrument Panel Equipment installation

202

177RG Parts Catalog

FIGUREAND PART NUMBER DESCRIPTION PER ONINDEX PART NUMBER DESCRIPTION

NO. 2 3 4 5 6 7 ASSY CODE

49A-

-2 1713200-4

-6

-

---

-

-

-25B AN515-6R3 SCREW 6

-26 1713262-21 COVER PANEL

--28 -

-35-33-34-36 ATTACHING PAR

S1895-1


203

177RG Parts Catalog

123467 ASSY CODE

-38

-39 S

-

-43

-44

-45 2015010-2 PAD-LOWER INSTRUMENT PANEL RH SIDE 1S1898-2 FASTENER 3

-46-47 C661060-01071

AN515B6R16

TRUE AIRSPEED INDICATOR INSTALLATION NP-48 C661061-0105 INDICATOR-TRUE 1

AN515B6R16 SCREW 4

-49-50-5

-53 C664508-0102 CLOCK ASSEMBLY-ELECTRIC 1

AN515B6R10 SCREW 2

-54

AN515-6R6 5' 4AN515-6R6 PARTS 4-55

#2

AN515B6R16 3


204

177RG Parts Catalog

FIGURE UNITS

INDEXNO. 12 3 4 5 6 7 ASSY CODE

-59

PARTSAN515B6R12 SCREW 4

S1605-22 1

-62 C662037-0106

AN515B6R16

AN924-3DSEE FIG 57

AN960PD6LAN340B6 2 2

-65 44045136365

4404516246-00109

-66 4428746246-00618

442874 #7S1372-1 #6110691C486050 WIRE-

#6S1372-1 #6S2334-1 #7


205

177RG Parts Catalog

FIGURE

INDEX PART NUMBER DESCRIPTIONNO. 1 2 3 4 5 6 7

49A-67

-68

4413479

444678 #1 GAGE- 78385

NUT

-70

AN515-6R22 2NAS43

-71

441346

-72 4427926246-00620

S1843-1 BEZEL 1

S1843-1 - BEZEL

-75 C292501-0104-76 S1880-2 1S1904-3


206

177RG Parts Catalog

FIGURE UNITS

2 3 ASSY CODE

49A- S1980-3

-89 S160-5L-89-91-92-93-94

-95-96 S-97-98 S-98A-99

NAS395-2-3NAS395-9-3

-99B.

NOTE. #1 THESE GYROS ARE PHYSICALLY &

NOTE. #2 THESE GYROS ARE PHYSICALLY &

NOTE. #3 FOR DUAL ALTIMETER INSTALLATION-20 FT

AN515B6R12 SCREW,

NOTE. 6

NOTE.

207

177RG Parts CatalogFIGUREAND

AND PART NUMBER DESCRIPTION PER ONNO- 12 3 4 5 67 ASSY CODE

49A NOTE.

NOTE. #9 AIRPLANES 177RG0433 THRU 177RG0787 AND

NOTE.

NOTE.

SK177-53.

NOTE. #14 AIRPLANES 177RG0433

ORDER SK177-54.

NOTE- #15 AIRPLANES 177RG0433 THRU 177R078T ANDF177RG0093 THRU F177RG0138 INCORPORATINGSK177-54.

E-

F--177Rg SERIALEXCEPT AIRCRAFT MODIFIED BYSK177-36C

208

MODEL 177RG

Instruments (Cont)

42A

177RG1052 THRU 177RG1266TRUE AIRSPEED INDICATOR

DetailA

32A 3 2 25 30 18 20 26 21 16 30 28 27 22 32B

177RG SERIAL 177RG0788 THRU 177RG1266Figure 49B. Instrument Panel Equipment Installation

209blank/210

177RG Parts Catalog

FIGURE


49B-

-3-

- 4 1713264-8 PANEL ASSTAT

-5

-15

-16 1713351-2 BRACKET-7

-9

--32A-33-23-24-25-26

-30-31-32

-32A 1862-1-36 1713279-18-33 1713380-2-34 1713381-1

S1389-12

.513839-3 1-35 1713382-3

-36 .713279-18 ASSY-RADIO-37 1713362-4 #1

-38 S1021A4-6B 4

-39 1713377-1

CONTINUED ON NEXT PAGE 211173378-2 CONTINUED ON NEXT PAGE

211

177RG Parts Catalog

FIGURE UNITSAND PART NUMBER DESCRIPTION PER

NO. 1234567

49B-

-41 1715060-6

SCREW

ASHER

AN515-8R14 SCREW 1

-45 C664508-0102

-46-47AN515B6R16 SCREW 4

TRUE INDICATOR INSTALLATION NP-48 C661065-02

-49

-50

-51-52

AN515-6R6 SCREW 4

-54

AN515B6R16 SCREW 3

-55

A515B6R12 4


212

177RG Parts Catalog


NO. 1 2 3 4 5 6 7 ASSY CODE

49B-56 #6

AN515-6R7 SCREW 4

-57 C661080-0101 INDICATOR-VERTICAL SPEED 1ATTACHING PARTS

AN515B6R16 SCREW 3

-58 C668501-0211 INDICATOR-EGT (ECONOMY POWER) 1

AN936A6B WASHER 4

C668501-0206SEE FIG 57

-59 C662037-0106 MANIFOLD PRESSURE

AN515B6R16 4

2000010-51 GAGE TO FIREWALLS1167-4-0130

2000010-90 FUEL FIREWALL

SEE FIG 57-

ATTACHING PARTSAN515B6R12 SCREW 4

S150-2

36365 NPC669509-0103

AN515-6R22 SCREW 2NAS43003-64 SPACER 2

AN341-6

#74428746246-00618 #8

-62

6246-00109 GAGE

36365C669504-0103

-63 441347 GAGE 363656246-00675 #10 GAGE-LH FUEL 09393 1


213

177RG Parts Catalog

FIGURE UNITS USABLEAND PART NUMBER DESCRIPTION PER ONNO. 1 2 34567 ASSY CODe

AN815-3D ASSY TO HOSE ASSY 136365 NP

C669505-0101

AN515-6R22 2NAS43003-64 2AN960PD6L 2AN341-6 NUT 2

-65 #1344

6246-00675

S1894-1

-67ATTACHING PARTS

AN5156R6 SCREW 2

-S1450-19A16-050 ELEC

-7-PARTS

S1450-19A16-050 WASHER USED WITH ELECTR

S1450-196-050 ELECTROLUMINESCENT 1 B

-74A

-75-76 S1994-1-1

S1843-1 BEZEL-MOUNTING 1

-77 S2160-1 SWITCH-FUEL PUMPATTACHING PARTS 1

S1843-1 BEZEL-MOUNTING 1

-78 S1980-1 KNOB-PANEL & RADIO LIGHTS 2S1904-3

S2160-1 SWITCH SINGLE


214

177RG Parts Catalog

FIGURE

1 2 3 4 5 6 7 ASSY CODE

49B--82

-83-84-85

-87

-

-90

-91ATTACHING PARTS

S1982-2

-93 2015010-4

-94

-98-99-99A SEE FIG 49D-99B

NOTE. #1 THIS PART MUST HAVE

NOTE. #2 LENGTH TO BE ADDED LATER.

NOTE. #3 FOR DUAL ALTIMETER INSTL-50 FT INCREMENTS,

USE 2

NOTE. #5 THESE GYROS ARE PHYSICALLY & FUNCTIONALLY


215

177RG Parts Catalog

FIGURE UNITS

49B- NOTE. #6 THESE GYROS ARE PHYSICALLY & FUNCTIONALLY

NOTE. #7 AIRPLANES 177RG0788 THRU 177RG266 ANDF177RG0139 THRU

NOTE. #8 AIRPLANES

S

SK177-53.

F177SK177-54.

A-177RG SERIALB-

F177R6 SELF77RBO:3 « r7a60

216

177RG Parts Catalog

FIGURE


NO. 1 2 3 4 5 6 7 ASSY CODENO. 1234567 ASSY CODE

49B-

217

MODEL 177RG

Instruments (Cont)

TRUE SPEED INDICATOR

53 95 57 54 65 66 59 44 60 97 4447

45 37

Detail A

177RG SERIAL 177RG1267 & ONFigure 49C. Instrument Panel Equipment Installation

218


ANDINDEX PART NUMBER DESCRIPTION PER


49C- INSTALLATION NP A-1 1713370-20 1

-5 AN515-8R7 SCREW 7

-3A

-25-26

-30

-32B S1863-2

-33

-35

-36-37 1713362-4 #1

-38 S1021A4-6B SCREW 4-39 1713377-1 DOORS

AN960XC4L


219

177RG Parts Catalog

INDEX PART NUMBER DESRIPTION PER ONNO. 1 23234567 ASSY CODE

49C- S1895-1

AN507-632R6 SCREW 2AN936B6 WASHER 2AN340-6 2

-40 1713379-1

-41 1715060-6 GLARE

-43 2013161-8 #1 COVER-LWR RH SWITCH PANEL 1ATTACHING PARTS

AN515-8R14 SCREW 1-44-45 C664508-0102

AN515B6R10 SCREW 2

AN515B6R16 SCREW 4

TRUE AIRSPEED INDICATOR INSTL NP-48 C661065-0202 INDICATOR

-49 AN515B6R16 SCREW 4

-50

-52

-55AN515B6R12 4


220

177RG Parts Catalog

FIGUREAND

NO. 1 2 3 4 5 6

49C-56 -SEHGI I: I

-57 C661080-0101A

-58 C668501-0211

-59

AN924-3DSEE FIG 57

-60 C668020-0110

AN341-6 NUT 2

-61C669532-0101

AN341-6 2AN832-2D

-63 6246-00111-64 2646-00024 GAGE-

2000010-52 LINE A

A

AN341-6

S1902-


221

177RG Parts Catalog

AND PART NUMBER DESCRIPTION PERNO. 123457

49C-67 C664503-0101 1

-68-69 55-70

-72-73-74

-76 S19941-1

-77

-81

-82-83

MS25237-327-84 S1360-L-85-86-87-88 S1707-

-

-90

-91ATTACHING PARTS

-92 0513292-13

S1021Z6-6 SCREW 3

-93 0513292-14

S1021Z6-6 SCREW 3


222

177RG Parts Catalog

FIGURE

INDEX PART PERNO. 12 3 4 5 6 7 ASSY

49C-94 -5 S

-96-97-99-99A-99B 2

NOTE. #2 FOR DUAL ALTIMETER INSTL-50 FT INCREMEMTS,USE 2 CAN515B6R12 SCREW, A

NOTE. #3 FOR DUAL ALTIMETER INSTL-20 FT INCREMENTS,USE 2

NOTE. #4 THESE GYROS ARE PHYSICALLY & FUNCTIONALLY

NOTE.

A-177RG SERIAL 177R1267 & ON

223

MODEL 177RG

Instruments (Cont)

16 21

24

177RG SERIAL 177RG0593 THRU 177RG0787Figure 49D. Post Lighted & Electroluminescent Panel Covers

224

177RG Parts Catalog

FIGURE

AND PART NUMBER DESCRIPTON UNITSINDEX ASSYNO. 123456 7

49D-

-4 -

- 8

-330-15-16

S1023A4-8B SCREW 3-17 2013151-1

S1021Z4-10B SCREW 4

-22 C613001-0201 SUPPLY-ELECTROLUMINESCENT PANELS 1

-23-24

-25 S1843-2 *AN936B616 * WASHER 2 WITH CABIN AIR & 1 WITH DEFROST CONTROLS 3

NOTE.

NOTE.

A-177RG SERIAL 177RG0593 THRU 177RG07 87

F177RG SERIAL

225

MODEL 177RG

3

13

POWER SUPPLY

177RG SERIAL 177RG0788 THRU 177RG1266Figure 49E. Post Lighted & Electroluminescent Panel Covers

226

177RG Parts Catalog


NO. 12 3 4567 ASSY CODE

49E- POST INSTRUMENT PAEL COVERS A

-2

- 7

ATTACHING PARTS

S1021Z4-10B SCREW 4

-11 2013162-2 PANEL ASSY-ELECTROLUMINESCENT 1ATTACHING PARTS

-

S1022A4-8B SCREW 3

NOTE.

A -177RG SERIAL

227

MODEL 177RG

Instruments (Cont)

11

POWER SUPPLY

177RG SERIAL 177RG1267 & ONFigure 49F. Post Lighted & Electroluminescent Panel Covers Installation

228


AND PART NUMBER DESCRIPTION PERNO. 1234567ASSYNO. 1 2 3 4 5 6 7

49F- POST LIGHT-1 171030- 14

-2

--4--6

--

-11 20

-1

-13 2013162-2

-14 2013162-9 PANEL ASSY-ELETROLUMINESCENT 1

ATTACHING PARTS-15 S2091-3 VARIABLE RESISTOR-

-17 AN515-8R7 SCREW 2S1450-2-10-032 WASHER 2

A-177RG SERIAL 177RG1267 & ON

229

MODEL 177RG

Fuselage Equipment

BA

Detail E

CUP HOLDER

35 Detail D Tw~iiCTWIN PACK

Figure 50. Fuselage Equipment Installation

230

177RG Parts Catalog

AND DESAND PART NUMBER DESCRIPTION

NO. 1 2 3 4 5 6 7ASSY C

50 - FUSELAGE EQUIPMENT INSTALLATION- 1 0541115-3 EYEBOLT

- 2 MS35489-17

- 4- 5 AN970-5 WASHER 2- 6 AN960-616 WASHER ON 2-7 AN960PD616 ASHER ON 2-8 MS2104215 NUT 4

- 9 1712093-1 ATTACH

-10 AN6-17A 2

-11 C421001-0101 FIRE EXTINGUISHER 1

-23 0500310-1 BRACKET ASSY 1ATTACHING PARTS-24-25-26-28-22 ATTACHING PARTS

-28 SEE FIG 51A COMPASS & OUTSIDE AIR TEMPERATURE INSTALLATION NP-29 1414087-10 SUN VISOR ASSEMBLY 2

-30 1414087-5 CLAMP 1-31 NAS603-8 SCREW 2

-32-33 7

-34-35-36-37 33001-0103-38

-43-44

PARTS-45 AN515-8R10 SCREW 1-46


231

177RG Parts Catalog


50 -47 0501022-1

-51-52-53

-54-55 SEE FIG 50A SE

A-

D-

232

177RG Parts CatalogFIGUREINDEX PART NUMBER DESCRIPTION

#2

#2 2#2 2

#2

#2 2

#2#2

#2 2#2 .

S227

S227

NAS464P4A10NAS464P4A13

-3- 4- 5- 6


233

MODEL 177RG

177RG0001 THRU 177RG0432

2

19 22

Detail E Detail

Figure 50A. Seat Belts & Shoulder Harness Installation

234

177RG Parts Catalog

FIGUREAND PART NUMBER DESCRIPTION PER

INDEX567ASSYNO. 1 2 3 4 5 6 7

ATTACHING PARTS

-14

2SZ7511 fl BEtJASS'T -! 2

S2

S

S

AN4-4A 22

201

-20 AN525-10R10 4

-21

S2275F

S227

SS2275S22


235

177RG Parts Catalog

FIGUREAND

INDEX PART NUMBER DESCRIPTIONNO. 1234567 ASSY

50A-

-24- -- -

-25-26

ATTACHING PARTS-36 4-36 AN4-10A 2

177RG Parts Catalog


NO. 1 2 3 4 5 6 7 ASSY CODE

50A-A-

B-1

F77

F.77R

237/238 blank

Fuselage Equipment (Cont)

Figure 51. Stretcher Installation

FIGUREFIGURE UNITS USABLEAND


51 - STRETCHER INSTALLATION NP- 1 070016- 7 STRETCHER --------- 2 S1809-1 EXTENSION-SEAT BELT -- -

239

MODEL 177RG

Fuselage Equipment (Cont)

10

4

177RG0001 THRU 177RG0282

Figure 51A. Compass & Outside Air Temperature Installation

240

177RG Parts Catalog


NO. 1 2 3 4 5 6 7

51A- COMPASS & OUTSIDE AIR TEMPERATURE INSTALLATION A-1 C660501-0101 COMPASS 1

ATTACHING PARTS-2

-3

- 5- 6 1713142-1-7 S1570-6 I-8 S1570-8-12 SCREW

-9 0400210-1 PLACARD-COMPASS CORRECTION 1

COMPASS & OUTSIDE AIR TEMPERATURE INSTALLATION B1 C668507-0101

ATTACHING PARTS-16 AN510B4R8 SCREW 2

-17

ATTACHING PARTS-18 AN507B832R14 SCREW 1

MS25237-330

-19 0413517-5 CUP-

-20 D366 SCREW-21-22

-23BASE ASSY PART

-24 AN500B8-7 SCREW 3-25 1713234-1 TUBE 1

A--177RG SERIAL

C-

D-

F--

241/242 blank

Propeller

10

/

4

Figure 52. Propeller & Spinner Installation

FIGUREAND UNITS USABLEINDEX PART NUMBER DESCRIPTION PER ONNO. 1 2 3 4 5 6 7 ASSY CODE

5- I SEE FIG 53 PROPELLER ASSY ------

P2014392-01 PROPELLER ASSY-MCCAULEY MODEL B20378 IN 01A REF C161008-0103

- 2 0752637-16 DOME ASSEMBLY-SPINNER -- --------ATTACHING PARTS

- 3 NAS221-8 SCREW --------------------- - 10---*--

- S1050-1 GROMMET BULK ITEM --- - --5 1750051-1 BULKHEAD ASSEMBLY-PROPELLER -- -- 1

ATTACHING PARTS6 AN4-10A BOLT 12

- 7 1750042-1 SHIM -------- 8 AN960-416L WASHER ---- ---- MS21042L4 NUT --------------- 12

-10 NAS680A3 NUTPLATE ------------------------ 10

NOTE. *FOR DETAIL PARTS OF THIS PROPELLER REFERTO APPLICABLE MCCAULEY MANUAL.

A--177RG SERIAL 177RG0001 THRU 177RG0212F177RG SERIAL F177RG0001 THRU F177RG0042

B---177RG SERIAL 177RG0213 . ONFL77RG SERIAL F177RG0043 & ON

243

MODEL 177RG

Propeller (Cont)

34

16

12 39

177RG SERIAL 177RG0001 THRU 177RG0212Figure 53. McCauley Propeller Assembly

244

177RG Parts Catalog

FIGUREAND

53 - PROPELLER ASSEMBLY-MCCAULEY MODEL

--3-4 3150-

-5-6--8

-9A

-10

-11 B3908-12-13

-

-17 A2356-18 B3526-19 A1636-7-20 A2108-21 A1633-12-22 C3418-23 B3414-24 A3150-5-25 A3902-26 B3905

ATTACHING PARTS-27 A1635-66

-28

-33-34-35-36-37-38 3411-2-39-40-41-42-43-44 78TA-0

NOTE.

A--

245

MODEL 177RG

Cowl

177RG0213 & ON

177RG SERIAL 177RG0001 THRU 177RG0282Figure 54. Engine Cowl Assembly1723

23D

246

177RG Parts Catalog


1234567 ASSY CODENO. 1 2 3 4 5 6 7

54 - COWL ASSEMBLY ENGINE-

- 2 AN520-8R7 SCREW 14

- 3 S1115-32S1115-9

-

-

---22 1-22

-23A-23B-23C

-25 S1115-29PARTS

0752058-3 SPACER AR

-26 LOWER

-29 NAS221-10 SCREW 12

AN960-10 WASHER 2

-30-31-32-33 2-34-35

-36-37


247

177RG Parts Catalog

FIGURE UNITSAND PART NUMBER DESCRIPTION PER ONNO. 1 2 ASSY CODE

54 -43

-43A

-43B-43C

-43D

-45

-47

248

MODEL 177RG

Cowl (Cont)

177RG SERIAL 177RG0283 & ONFigure 54A. Engine Cowl Assembly

249 blank250

177RG Parts Catalog

FIGURES USABLE

INDEX PART NUMBER DESCRIPTION PER ONNO. 1 2 3 4 5 6 7 ASSY CODE

54A--1 2052001-4

-2 AN520-8R7 14

-

-

-

-28-29

-30-

-32-33-34-35-36

-39---42-43-44-43-45

-46

-47

251

MODEL 177RG

Cowl Flap Controls

1 18

9

Figure 55. Cowl Flap Controls Installation

252

177RG Parts Catalog

FIGURE UNITS USABLE

INDEX PART NUMBER DESCRIPTION PER

NO. 1 2 3 4 5 6 7

55 - COWL FLAP CONTROLS INSTALLATION NP- 1 S1391-27

-4 .

- 8 MS2

- 9 S2087-1

-13-14

-15 1713323-2 CLAMP 1ATTACHING PARTS

-18 713701-3 CLEVIS 1ATTACHING PARTS

-19 AN24-11-20-21 AN320D4-22 MS24665-134

-23 2013027-1 LEVER ASSEMBLY 1

-24 AN3-14A BOLT-25 NAS75-3- 107-26 MS21044N3

-27 S1249-2 KNOB 1ATTACHING PARTS

-28 AN507-1032R8 SCREW 1

-29 AN525-1032R12 SCREW 2-30 NAS

MODEL 177RG

Winterization

14

177RG0001 THRU 177RG0282

19

254254

177RG Parts Catalog

FIGURE UNITS

AND PART NUMBER DESRIPTION PER ONINDEX ASSY CODENO. 1 2 3 4 5 6 7

56 -1 A

-

- 4

- 8

-

-17 AN52-10R10 SCREW-18 NAS680A3

-19 1752107-2 CLIP-20-21 2052049-1

-22 AN

-23

-24

-25-26 B-27

NOTE.

255

177RG Parts Catalog

FIGURE UNITS USABLE

NO. 1 2 3 4 5 6 7 CODE

57 - ENGINE INSTALLATION- 1

- 2

- 4 AN960-616

- 7-6-

-

-

-21 2


256

177RG Parts Catalog


NO. 12 3 4 5 6 7 ASSY CODE

NAS446-5 NUT 2

-28 1700121-52 LINE-ASSEMBLY-FUEL UPPER 1

NAS397--28-29 S1495-4 HOSE-FUEL PUMP VENT 6.0 IN LG BULK ITEM 1

NAS397-8 CLAMP ATTACHING PARTS 2

-33 AN3-7AS

S1236C6-0120 HOSE ASSEMBLY FUEL STRAINER TO FUEL PUMPATTACHING PARTS

-33

AN924-3 NUT

69336STD1410 NUT 4STD475 LY 4


257

MODEL 177RG

Engine

25 1422

LWR SHOCK MOUNT UPR SHOCK MOUNT

Figure 57. Engine Installation (Sheet 1 of 2)

258

35

26

4441

44H

A4470 67

43B 43C 44A 64

Figure 57. Engine Installation (Sheet 2 of 2)

259259

177RG Parts Catalog



0750139

-36

-38 S1372-1-

-43A

-43B

-43C-43D


260

177RG Parts Catalog

FIGUREINDEX PART NUMBER DESCRIPTION PER ON

57 -44 2052031-7 BASE ASSY-PLENUM CHAMBER 1ATTACHING PARTS

-44A AN520-1017 SCREW 6-44B WASHER 6

-44C 1-44D-44E-44F--44H

2013086-1

AN515-2R10 SCREW 2 NAN960-2 ASHER 2 N

-45A S1856-1

2013083-1

-46

-47

-48 S1664-3 CLAMP ATTACH BRACKET ASSEMBLY 1 F-49 0412007

AN4-11A BOLT

--

-51 SEE FIG 49ATTACHING PARTS

-52 S1104-3 END-53 AN3-11A-54-55-56 AN315-3R

AN970-3 WASHER 1-57 0450191-3-58 AN3-6A

-


261

177RG Parts Catalog

FIGURE UNITS USABLEAND PART NUMBER DESCRIPTION PER

1234567

S11D4-3 ROD END

1032C NUT

66 AN520-10R4

-68

-72 SEE FIG

-74

NOTE. *MUST BE USED WITH 2054000-43 MUFFLER ASSY

A-

E-

F-

H-

J-

77


262

177RG Parts Catalog

FIGUREINDEX PART NUMBER DESCRIPTION PER ONNO. 1 2 3 4567 ASSY CODE

57 -

AC-

263/264 blank

177RG Parts Catalog

FIGURE


58 - * ENGINE COMPONENTS & ASSOCIATED ACCESSORIES I0360A1B6 NP A

- 1 75896 .75897

-

-- 1

SR86*

265

MODEL 177RG

Engine (Cont)

7

6

11

Figure 59. Governor Assembly

266266

177RG Parts Catalog

FIGURE

NO. 1 2 3 4 5 6 7

59 -

C16

- 1-2-3- 4

-6--7

-

-22-

-3-25-26-20-21

-22-23-24


-27 A20022 GASKET-COVER-28-29-30

-35 A20027-36

72053

NOTE.

NOTE.

NOTE.

A-

B-

C---

267

MODEL 177RG

Engine (Cont)

20

35

177RG SERIAL 177RG0001 THRU 177RG0282Figure 59A. Propeller Governor Assembly (Alternate)

268

177RG Parts Catalog


NO. 1 234567 ASSY CODE

59A- C161040-0110 PROPELLER GOVERNOR ASSY ALTERNATE-- 2

- 3 189744-4 218547-5 206336 GASKET-BASE

-6 213231-7 210036-8 204864--9

- -

-

ATTACHING PARTS-18 189574 DRIVE PIN WGV 2

-19 MS100009 GASKET-MOUNTING FS0 MS9144-01MS9144-01A

-12347 PLATE-GOVERNOR PAD

-20

-21 1-22-23 206337 GASKET-COVER WGV ---- 1

-24 4451-064 ASSY-SPEEADJUSTMENT 1

-25 .88434-26 188141-27-28-2-30-31 3460-022 S-32--34 1410-626 VALVE WGV-35 3246-050-36 1-37 218446 RELIEF VALVE WGV --38 186320

-40

NOTE. #1 REFERENCE LYCOMING-TEXTRON

A--

269

MODEL 177RG

Engine (Cont)

19

177RG1202&

Detail A

177RG0788 THRU 177RG1201

Figure 60. Exhaust System Assembly

270

177RG Parts Catalog

FIGURE UNIT USABLEAND PART NUMBER DESCRIPTION PER ON

NO. 127 ASSY CODE

60 - SYSTEM ASSEMBLYASSY-

--3 0750161-25-4- 5-6 MS20365-1032C 4

--7B

- 8 SCREW 4 A

,PARTS-23 2054020-1 4 HALF 4-25 AN960- -ER 4-26

-27 2054025-9 SHIELD ASSY-EXHAUST CROSSOVER 1

NOTE. #1 REFER TO SE 77-35 (REWORK OF LH SUPPORT BRACKETS).

C--

271

MODEL 177RG

177RG SERIAL 177RG0001 THRU 177RG0592

177RG Parts Catalog


61 -BAFFLES- 1-3

-4- 5 AN

-6 2055003-6 BAFFLE-7

-

REAR A

-

-16 AN500-416-10 SCREW 2

-20-21 NAS463W416SHIM-ANCHOR NUT 2-22 2055007-1 BAFFLE - CYLINDER 1

-23 AN500-416-10 SCRE 2-24 AN36A416 LOCKWASHER-25-26

-27 205-28-29

-30 AN500-416-10-31-32 A-33 S1021-34

-35-36

-37 2055006-12055006-5

-

-42 2055006-3-43


177RG Parts Catalog

NO. 123456ASSY CODENO. 1 2 3 4 5 6 7 ASSY

-53

-57-58

-60-61-62

-63 -

-66-67-68

274

MODEL 177RG

Baffles (Cont)

27

29

14

30

42

41

177RG SERIAL 177RG0593 & ON52 177RG0593

275 blank/276F

177RG Parts Catalog

FIGURE UNITSAND PART NUMBER DESCRIPTION UNITS ON


61A--

-5

-12 2055014-4 S -BAFFLE-

----

ATTACHING PARTS

-25--27-28

-

- ATTACHING PARTS-32 AN500-416-10 SCREW-

-35--------

-34


277

177RG Parts Catalog

FIGURE


61A-48 2055015-3

-54 2055015-6 BAFFLE ASSY 1-55 S1021Z8-4 SCREW 2

-56 1755043- SHROUD-57

-59

278

Oil Filter

OIL TEMPERATURE

9

177RG0001 THRU 177RG0432

Figure 62. Oil Filter Installation


INDEX PART NUMBER DESCRIPTION PER ONNO. 12 3 4 5 6 7 ASSY CODE

62 - OIL FILTER INSTALLATION - -----------C294505-0101 OIL FILTER ASSEMBLY - --- -----

- 1 C294505-0102 FILTER ELEMENT KIT ---------------------------- --- 2 6436637 GASKET AC --------- 3 6436635 GASKET AC ------- --- 4 5579654 METAL GASKET AC - -------- 5 6436916 STUD-CENTER AC --- -- 6 6436989 LID-OIL FILTER AC ---------------------- ---- -- 7 1250410-5 PLACARD-OIL FILTER ----- ----- --- 8 755288 ADAPTER ASSEMBLY-OIL FILTER LY- 9 74904 GASKET-ADAPTER LY ------------------

A--177RG SERIAL 177RG0001 THRU 177RG0432

279

MODEL

177RG Parts Catalog



63 - CABIN AIR VENTILATION NP

ATTAING PARTS-2- 3-- 4-5

-7 1706048-

-9 1706024-3 2-

-14 S1

-15

-16 AN507-832R6 SCREW 4

-

-18 S1021Z6-12 SCREW 8

-19 1706017-3

-23 NAS397-34-24 AN742D32 CLAMP 1

-26

-27 AN515-8R8 SCREW PARTS 8

-28 17-29

-30 NAS398-50 CLAMP 2

-30A--31

ATTACHING PARTS-32 NAS397-34 CLAMP 2

-33-34

-35-36

-37 NAS514P832-8 SCREW 4MS21044N08 NUT 4


281

177RG Parts Catalog

NO. 1234567 CODE

63 -38 1706054-1 < COVER-CABIN AIR OUTLET REAR 2ATTACHING PARTS

-39

NOTE. <THIS PART MUST HAVE A

282

MODEL 177RG

Heating System

Detail A

177RG SERIAL 177RG0001 THRU 177RG0432 177RG0213 & ON

Figure 64. Heating & Defrosting System

283 blank/284

177RG Parts CatalogFIGURE UNITS USABLEINDEX PART NUMBER DESCRIPTION

NO. 1 2 3 4 5 6 7 ASSY

64-

- 2 NAS398- CLAMP 1

- 4 2050010-1-3

-7 NAS398-502050016-1AN3-3A

MS20365-1032C

- 8

- 9 NAS398-50 CLAMP 2

-10 S1053K16T ATTACHING PARTS-11 NAS397-32 CLAMP 2

-

-

-13A

-15 S10268G 20513238-1

-16 S1053E16T

-17 NAS397-34 CLAMP PARTS 2

-20-18 2-19-21-22-23

-24 AN960-10 -2-25 MS35489-6-26 MS24665-134 COTTER PIN 1

-27 2013124-4 1ATTACHING PARTS

-28 MS20392-2C7 PIN-29 AN960-10 WASHER-30 MS24665-134 COTTER PIN

-31 MS20392-2C7 PIN - 2-32 AN960-10L WASHER-33 MS24665-134 PIN-34 1413519-4 ARM 2

ATTACHING PARTS-35 MS24665-136 COTTER PIN 1


285

177RG Parts Catalog


N 12345 ASSYPART NUMBER 1 2 3 4 5 6 7

64 -36 SEE FIG 49ATTACHING PARTS

-49

-42

-46

12

-

286

177RG Parts Catalog

INDEX PART NUMBER DESCRIPTIONNO. 1 2 3 4 5 6 7

64A-

-2- 3

- 4

- 5

- 6

- 8ATTACHING PARTS

- 9 NAS397-32 CLAP 2

-

-

-25 S1053E16TATTACHING PARTS

-26S1485

-36 2013124-4

-37 MS20392-2C7-38 AN960-10-39 MS24665-134 PIN

-40 MS20392--

-


287

MODEL 177RG

Heating System (Cont) 72

30 29 31 27

Detail A

288

177RG Parts Catalog

FIGUREAND UNITS USABLEPART NUMBER DESCRIPTION PER ON

NO. 1234567 ASSY

64A-43 1413519-4 ARM ASSY 2ATTACHING PARTS

-44 MS24665-136

-45 SEE FIG 49A

-47-

-

-52-53

-54 1250116-1

-55-

1250115-5 LEVER ASSY-VLVE 1 DATTACHING PARTS

-57 MS16562-17 ROLL PIN 1

-58 1250115-4 SHAFT-59 0713119-24 ARM ASSY-60 52-018-078-0562 PIN ES-61-62-63

2013155-1---64 1713368-1-65 1

-66 AN515-6R10 SCREW - 2

-67 1250115-4 SHAFT

-68 MS16562-17 PIN 1

-69-7

ATTACHING PARTS-71 MS16562-17 PIN 1

-72 S-73-74-75

-75B

-76 SEE FIG 49 CONTROL ASSY-DEFROS 1ATTACHING PARTS

-77 AN742D4 CLAMP 1AN515-6R4 SCREWMS21044N06 NUT -


289

177RG Parts Catalog


64A-78 SEE FIG 49ATTACHING PARTS

-79

ATTACHING PARTS

177RG Parts Catalog



64B- HEATING & DEFROSTING nP A-1 S1053K24T

-2- 3

- 4 250010-1 SEPARATOR ASSY 1ATTACHING PARTS

-5 1891-48 CLAMP . 1

- 6 S1053K24TATTACHING PARTS

-8

S1053K16TATTACHING PARTS

-10 NAS397-32 CLAMP 2

---

ATTACHING PARTS-23 NAS397-34 CLAMP 2

DEFROSTER INSTL NP2013155-1 DEFROSTER ASSY 1

AN960PD2 WASHER 6

-26 AN515-6R10 SCREW 2

-27 1250115-4 SHAFT-CONTROL 1

-28 MS16562-17 PIN 1

-30 1713019-24 ARM ASSY 1

-31 MS16562-17 PIN 1

-32 S2323-5 CLAMP .

-34-35 2013156-1 BRAKET-NOZZLE

-36 S1485D32U CLAMP 1-37

-38-

-41-42

20


291

MODEL 177RG

35

177RG SERIAL 177RG0788 &


AND

NO. 1 2 3 4 5 6 7

64B-43

-44 AN4-11A BOLT I-45-46-47 SPACER-48

-49 2013125-17 LINK 2ATTACHING PARTS

-50 MS20392-2C7 PIN 2-51-52 MS24665-134 PIN-COTTER 2

-53 SEE FIG 49B

-56-57-59

PARTS-62-65

-67-68

ATTACHING PARTS-71

-72 2017005-13

-73 S1357-3 WASHER 1-74-75

-76 2017005-14 VALVE 1ATTACHING PARTS

-77 M24665-132 SCREW 2

-78 S2204-1 KNOB-VENT 1

-80 SEE FIG 49B

-83

293

MODEL 177RG

Brake System

10

45Figure 65. Brake System

294

177RG Parts Catalog

FIGURE USABLEANDINDEX PART NUMBER DESCRIPTION PER ON

NO. 1 2 3

65 - BRAKE SYSTEM- 1 SEE FIG 67- 2 S1810-1525 CYLINDER- 3-4 1782001-1 NIPPLE- 5 MS28778-4 RING- 6 AN916-1D

-8

9

-20-2

-26 CLAMP-

-

-

--

--2-2- 2

-

MS2104213

-29 AN832-30-30-31

-33-34

295

177RG Parts Catalog

FIGURE UNITSAND PART NUMBER

INDEX ASSYNO. 123 4 5 6 7

65 -40 11-1 ASSY LY 2-41-42 SEE FIG 33-43 2-44-45-46-47

177RG SERIAL F177RG0161 & ON

296

MODEL 177RG

Control Pedal

34

33

Figure 66. Brake & Rudder Pedals Installation

Figure 66. Brake & Rudder Pedals Installation

297 blank/298

177RG Parts Catalog


INDEX PART NUMBER DESCRIPTIONPER ONNO. 1234567 ASSY CODE

66 - BRAKE & RUDDER NP NP- 1 460320-1

- 6-7-

-

-

-20---23

-24 AN3-16A 2

-30A

---26 A3-10A

-27 AN960-1016 WASHER INBOARD ENDS --- 2-

-30A 2067004-7 ASSEMBLY 1ATTACHING PARTS


-33 S1674-1 BEARING HALF ORDER PAIR ---------- 4ATTACHING PARTS

-34 AN3-16A

- 299-40 MS20392-2029 PIN

-42 MS24665-132 PIN-COTTER 1

-43 1560504-3 SUPPORT 2ATTACHING PARTS

-45 A-46

299

MODEL 177RG

Brake Cylinder

17

18

Figure 67. Master Brake Cylinder Assembly

300

177RG Parts Catalog

FIGUREAND PART NUMBER DESCRIPTION

--2- 4

-6

-9

-

-

-

301/302 blank

177RG Parts Catalog

FIGUREANDINDEX PART NUMBER DESCRIPTION

68-- 1 2013062-2

AN3-7ANAS43003-32

- 3 AN3-4A- 4 MS21044N3

-7

-14-

-16 NAS561-5-12 ROLL PIN 1


303

MODEL 177RG

Brake System (Cont)

15

3837

Figure 68. Parking Brake Installation

304

177RG Parts Catalog

FIGURE UNITS USABLEAND PART NUMBER DESCRIPTION PER ONINDEX ASSY CODENO. 1 2 3 4 5 6 7

68 -17

-18A

-24-2-23 MS20392-2C7 PIN-24--27 2-28 S1052-1

-39 AN3-5A-40

-41 MS24665-132 COTTER PIN

MODEL 177RG

Flight Controls

47

306 37

30

177RG0213 & ON

Figure 69. Control Column Installation

306

177RG Parts Catalog

FIGURE


69-1

-2 SLEEVE WELD ASSEMBLY B3 BEARING

- 4 RACE-BEARING TOR-5 BEARING TOR- 6 S16624-1137 RI-RETAING- 7 760646-2 RETAINER ASSEMBLY-CONTROL ROLLERS- 8 K7200-3 NUT-STAKE

1260664-1 BEARING ASSEMBLY-CONTROL WHEEL

-12 1260148-1 STUD 2

--18

-21 NAS561P6-18 PIN 1

-27

-28 0760633-1 BEARING

--31 MS21044N08 2

-32 0760633-1 BEARING BLOCK ASSEMBLY SINGLE CONTROLS ONLY 1

-33 NAS220-9 SCREW 2

-34 1713266-1 PLATE AASEMBLY-AILERON IDLER SINGLE CONTROLS ONLY - - 1

-35 NAS220-9 SCREW-36

-39

-40

-41 1

307

177RG Parts Catalog

--46-47

ATTACHING PARTS-48

-

-

-53

-54

-54A

-55-56 156319-2 CCUR

--

-59 AN507-632R8 2 B

-60 1713343-3 BRACKET ASSY 2 B-61 AN525-832R8 SCREW 3 B

-63

308

309 blank/310

177RG Parts Catalog



70 -1 1760006-4

1760006-104

- 3 1760009-1

AN310-3AN960-10LMS24665-132 COTTER PIN

- 5-6 AN23-11

1760006-107

- 9 AN155B32S

-12 MS24565-134 PIN

-13 1221087-11221087-2

-14 AN4-40A BO-15 AN960-416

-16 S1450-7B12-032

-17 1221113-4 ROD ASSEMBLY-AILERON 2

-

MS21042L4

-21-22-23-24

-25 AN5-17A

-27-2

-31

-32 AN4-13A

1713048-1 GUARD-AILERON DIRECT CABLE 1

-34 2-35

-36 NAS222-19 SCREW-37-38-39 MS20220-2

-40

-41 1

311

MODEL 177RG

Flight Controls (Cont)

312312

177RG Parts Catalog

FIGURE UNITS

NO.1 2 3 4 5 6 7

71--1

-

-

-

-

-

-21-22 201-23

-24 0411523-1 PARTS 2

-25-26

-27 0411524 BUSHING 2

313

MODEL 177RG


Figure 72. Wing Leveler Installation314 Figure 72. Wing Leveler Installation

314

177RG Parts Catalog


INDEXNO. 1 2 3 4 5 6 7 ASSY CODE

-1 20351-4

-2 ** INVERTER- 3 **-4--6--8

- --

-

--

ATTACHING PARTS-24 S1592-2A 2

S1021Z6-8 SCREW 2

-25-26-27 IN BULK ITEM R S1071R3-* ---28

-29

-30 NAS220-7 SCREW 6

-31-32

-33-35

-36-37 ATTACHING PARTS-38 AN3-5A 1

-39 SEE FIG 70 BELLCRANK ASSEMBLY-LH WING

-40 AN23-11

-41 1100-0-0

-42-43 S1450-5A15-050 4


315

177RG Parts Catalog

FIGURE UNITS USABLE


-

-54-55-56

-

F.77R

316

MODEL 177RG


Figure 73. Flap Control System

177RG Parts Catalog

FIGURE USABLE

N 1 2 3 4 5 6 7 ASSY CODE

73- -- 1 1260128-1

-2 AN3-6A-3 AN3-11A-4 AN960-10L

S1819-3 END 2AN316-4R 2

- 6

- 7 AN3-6A8 AN960-10L 2

S1106-3

-111260125-2

-12 AN4-

-12A

-13

- AN3-6A 1

- 18 MS21044N3 2

S1819-3

-19

-20

-21

-22

-23

-24

-25-26-27-28

COTTER PIN-29-30

ATTACHING PARTS

-31

-32-33 2-34


319

177RG Parts Catalog

AND PART NUMBER DESCRIPTION PERINDEX ASSYNO. 1 2 3 4 5 6 7ASSYCODE

73-35

-4124V

-44

-46

-47 1722088-5 GUIDE ASSEMBLY-ACTUATOR 1

-48 1

-51 1512280-34-52 S1771-3-53 1562033-7 ARM ASSEMBLY-FLAP CONTROL A

1562033-18-54 S1906-1

-55 AN515-4-12 2

-56 NAS75-3-018-

-59 1713215-6

-61 S2202-4-62-63

-64A


320

177RG Parts Catalog

FIGURE UNITS USABLEAND PART NUMBER DESCRIPTION PER ONNO. 1 2 3 4 5 6 7 ASSY CODE

73 -65 1398-1-66

-66A

-67 42-

-71

-72-73-73A-74

-7-77

-AN960-416

-82 MS21042L4

-83 1722082-7

-84 AN3-6A-85 NAS43

-88-84-89 S1450-3-8-032-90 MS21044N3 2

-91 1713352-1 SPRING-

F 77R

321

MODEL 177RG


32241

177RG Parts Catalog


NO. 1 2 3 4 5 6 7 ASSY CODE

74 --

-PARTS-2-3 17

- 6- 7 17

-

-

--

-25-26

-

-32

-34 AN5-16AAN960-516LMS21042L5 1

-35 MS24665-140 1-36

-37 AN5-15A

-38 MS24665-142-39 S378-3L

-40 AN4-10A BOLT 1

-41-42

-43 AN4-10A


323

177RG Parts Catalog

AND PART NUMBER DESCRIPTIONINDEX CODE

74 -45

-46

-47

-49

-50 S378-4--52-53

-54-55-56-57

-

-83

-86

-9192

324

177RG Parts Catalog

FIGUREAND PART NUM

75 -

-2

- TRIM B

-14ATTACHING PARTS

-15 AN3-10A

-17

-18-19

-20

-21-22

ATTACHING PARTS

-35

-39 S378-4 2

-41-42


325

MODEL 177RG


60 59 57

Figure 75. Stabilator Trim Control System

326

177RG Parts Catalog

FIGURE UNITS USABLEAND PART NUMBER DESCRIPTION UNITS

INDEX

75 -43 1760005-2 PIN-CABLE GUARD 1

-44 MS24665-132 COTTER PIN 2

-45 0411523

-4647

-48-49-50

-51-52

-53-54-55-56

-62 04-63 1260074-5

-65

-67 0310332ATTACHING PART

ATTACHING PARTS-68-69 AN3-7A

--71-72 ASSEMBLY-ACTUATOR SUPPORT 1-73

-74 AN3-6-75 AN310-3

-78 AN960-10-79 AN3-10-80 AN960-10 WASHER-81 AN310-3-82 MS24665-134 COTTER PIN FWD END-82A MS24665-132 PIN AFT END 1

-83

D---

327

MODEL 177RG


Figure 75A. Elevator Trim Tab Actuator Assembly

RGURE

AND PART NUMBER DESCRIPTION PERINDEX ASSY CODE

NO. 1 234567

75A- 1260074-5 ELEVATOR TRIM TAB ACTUATOR ASSEMBLY 1- I MS16624-1081 RING-RETAINER OUTSIDE 2- 2 1/16X.62 TYPE 3 GROOV-PIN 4- 3 0310332 SPROCKET-ROLL CHAIN 1

ATTACHING PARTS- 4 3132X.38 TYPE 3 GROOV-PIN 2

- 5 0310297-1 BEARING-ACTUATOR 1- 6 0310295 COLLAR-ACTUATOR 2- 7 1260049-1 SCREW-INTERNAL THREADS 1-8 AN6227B5 PACKING-ACTUATOR 1- 9 0310298-1 BEARING-ACTUATOR 1-10 0310362-5 SCREW ASSEMBLY-ACTUATOR 1-11 PN3A BEARING TOR 1

328

MODEL 177RG


24 3924 28 38

4

329 blank/330

177RG Parts Catalog


NO. 1 234567 CODE

76 - RUDDER CONTROL SYSTEM-1

-3 AN23-15-4- 5

-6-7 S-8

-9 AN4-10A

-10 NAS427K10 2-11 MS24665-134 2

-12 S378-4 2

-13 AN4-10A

-14 MS24665-134 4-15 S378-4 2

-16 AN4-10A

-19 AN4--20-21

-22 1760005-2

-23 MS24665-132 COTTER 2

-25 AN4-33A-24

-28 S378-4S378-4S

-31

-32 1760005-2 PIN-CABLE 1ATTACHING PARTS

-33 MS24665-132 COTTER PIN 2-34 S378-4

-35 AN4-53-36 AN-37-38-39-40-41-42-43 176000-1

-44 1760005-1

-45 MS24665-132


331

177RG Parts Catalog

FIGUREUNITS USABLEAND

NO. 1234 5 6 7 ASSY

76 -46-47

-48

-

A-B-

332

MODEL 177RG


Figure 77. Rudder Trim System



77 - RUDDER CONTROL SYSTEM NP- 1 2013014-1

- 2 AN507-632R5-3

-4 S1896-4LI5 1713269-6 ASSBEMBLY-RUDDER TRIM

-7- 8

ATTACHING PARTS

-17-18

ATTACHING PARTS

-20 SEE FIG 28

-22-23

335

MODEL 177RG

Pitot System

24

Figure 78. Pitot System Installation

336

336


AND PART NUMBER DESCRIPTION PER ONNO. 1 2 3 4 5 6 7 ASSY CODE

78 -

--6 S1071-1 BULK 1

ATTACHING-7 S1592-1A

-8 S1130-1-

-

-2

-

-22 S-23

-25

-26-27-28

-37 SEE FIG 49


-32

-34

-35

-37 SEE FIG 49

-38 S2116-1 VALVE-ALTERNATE2013142-1 VALVE-ALTERNATE STATIC SOURCE

-42 MS21044N08 2


337

177RG Parts Catalog

FIGURE UNITS USABLEINDEX PART NUMBER DESCRIPTION PER

NO.1 2 3 4 5 6 7 ASSYCODE

7843 2 1 -- EXTENSION ASSY-44 SET SCREW

-46

-54

-55-56

-57

-59 BULK

-61

B-

C-

D-

338

MODEL 177RG

Pitot System (Cont)

15

F177RG0139 & ON

177RG SERIAL 177RG 0593F

Figure 78A. Encoding Altimeter Installation

339 blank/340

177RG Parts Catalog

FIGURE

AND PART NUMBERNO. 1234567 ASSY

-

- 9 AN515-8R6 SCREW 2--10 .

-

NOTE. *LENGTH TO BE DETERMINED LATER

341

MODEL 177RG

Blind Encoder

10

177RG SERIAL 177RG1088 & ONFigure 78B. Blind Encoder Installation

342

177RG Parts Catalog

FIGURE UNITS USABLEAND PART NUMBER DESCRIPTION PER ONNO. 1234567 ASSY CODENO.

788-- 1 C744001-0101

- 2 AN520-10R12 SCREW 4

-

-5- 6-7

-


A-177RG SERIAL 177RG1088 & ONF177RG SERIAL

343/344 blank

177RG Parts CatalogFIGURE UNITSINDEX PART NUBER DESCRIPTION PER ONINDEX

79 - FUEL

-2-3

-5-6-6A

-8-9

-10ATTACHING PARTS

S1021Z10-8 SCREW 1

-

-36

-37 SEE FIG 81-39-33-

CONTINUED ON NEXT PAGE 345

-33 AN525-832R6-34 AN936A8

-35 2013081-1 < COVER FUEL VALVE

-36 S1021Z8-8 SCREW

-37 SEE FIG 81 VALVE ASSEMBLY-FUEL SHUT OFF 1

-38 AN507-10R8 SCREW 2-39 MS21044N3 NUT 2

-40 2000010-29 LINE ASSEMBLY-FUEL 1


345

MODEL 177RG

177RG SERIAL 177RG0001 THRU 177RG0282Figure 79. Fuel System

346

177RG Parts Catalog

FIGURE UNITS

AND PART NUMBER PER ON

NO. 1234567 ASSY CODE4 5 6 7

ATTACHING PARTS

-45

-47

-49

-51-52-53-54-55-56

-57

-60A

-63

-65 S51-6-66-67

-73

-76

347

177RG Parts CatalogFIGUREAND PART NUMBER DESCRIPTION

NO. 2 3 4 5 6 7

-83

-86

ATTACHING PARTSMS24665-132 PIN 1

NOTE. <THIS PART NUMBER MUST HAVE A SECONDDASH

348

177RG Parts Catalog

FIGURE UNITS USABLE

PART NUMBER DESCRIPTION

-

--4

--7-23-49 ATTACHING PARTS

---- -

-

-

--26

-2---31-32

-33

-34-35-362-37-38

-39 2026001-4AN3-11A


349

MODEL 177RG

Fuel System (Cont) 41B

42A

177RG0593 THRU 177RG1051

177RG1052 & ON

Detail Detail C

177RG SERIAL 177RG0283 & ONFigure 79A. Fuel System

350

177RG Parts Catalog

FIGUREAND UNITSINDEX PART NUMBER DESCRIPTION PER ONNO. 1 2 3 4 5 6 7

79A-40 \

-41

--43A

--4-44A

--49 DRAIN 1-50

-5 2016-53

MS24665-132

-54 SEE FIG 81C

-55MS20365-428C NUT 2

-56-57

-58 2016017-1 1

-66

--

--

-70 AN737TW91 CLAMP - --


351

177RG Parts Catalog

AND PART NUMBER DESCRIPTIONNO ASSY CODE

79A-71-72

-74

--7

352

MODEL 177RG

Fuel System (Cont)

18

Figure 80. Fuel Strainer Assembly

353 blank/354

177RG Parts Catalog

FIGUREAND UNITS USABLEPART NUMBER DESCRIPTION

NO. 12 3 4 5 67 ASSY CODE

80 - 0756005-10

-0756008-1 BOWL-FUEL STRAINER 1ATTACHING PARTS

-4 S1573-3 NUT5 0756015-1

-6 MS29513- 111

- 8 0756011-1 STANDPIPE- 9

-

--

-

355

MODEL 177RG illustrated parts catalog

Fuel System (Cont)

1011

177RG SERIAL 177RG0001 THRU 177RG0282Figure 81. Fuel Shut Off Valve Assembly

FIGURE UNITSUSABLEAND PART NUMBER DESCRIPTION PER ONINDEX

NO.

81 - S1903-2 FUEL SHUT OFF VALVE ASSEMBLY-

ATTACHING PARTS- 2 AN507-1032-6R SCREW 2

- 3 HE2100 * ROTOR HEAC 1- 4 79-022-094-37.5 ROLL PIN HEAC - 1- 5 S272-204 BALL-STEEL 1- 6 HE107 * SPRING HEAC -- 7 MS29513-18 O SPRING 1- 8 HE1372-2 * SEAL HEAC- 9 MS29513-13 O RING-10 HE1373 * WASHER HEAC-11 HE1251 * SPRING

NOTE. WHEN THESE PARTS ARE EXHAUSTEDVALVE ASSY MUST BE ORDERED

A-177RG SERIAL 177RG0001 THRU 177RG0282F177RG SERIAL F177RG0001 THRU F177RG0062

356

MODEL 177RG

Fuel System (Cont)

3

177RG SERIAL 177RG0283 & ONFigure 81A. Fuel Selector Valve Installation

357 blank/358

177RG Parts Catalog

FIGURE UNITSINDE PART NUMBER DESCRIPTION PER ONNO. 1234567 ASSY CODE

81A- FUEL SELECTOR VALVE INSTALLATION NP A- 1 075137-1 -SE VALVE 1 B

0716623-2 HANDLE-SELECTOR VALVE 1 C

- 2 0716624-1 COVER- 3 AN525-832R6- 4

- 5 2016035-2 < COVER-FUEL SELECTOR VALVE 1- 6 S1021Z8-8 SCREW 3

- 7SEE FIG 81B VALVE ASSY-FUEL SELECTOR

ATTACHING PARTS- 8

B-

C-D-

E-

77RG

359

MODEL 177RG

Fuel System (Cont)

177RG SERIAL 177RG1052 & ONFigure 81B. Fuel Selector Valve Assembly

360

177RG Parts Catalog

AND PART NUMBER DESCRIPTION PERONDESCRIPTION

NO. 2 3 4 5 6 7

81B-

-2

- 3 9851068-3

_

A-1T7RG SERIAL 177RGCIt2 6 ON

361

MODEL 177RG

Fuel System (Cont)

177RG SERIAL 177RG0283 & ONFigure 81C. Reservoir Drain Control Installation

362


AND PART NUMBER DESCRIPTION PER ONINDEX CODE

NO. 1 2 3 4 5 6 7

81C-- 1 2016034-1

- 2 AN507-1032R8 SCREW 2

- 3 2016032-6

- 4 AN520-8R7 SCREW 1

-5 *

- 6A

-

PARTS-8 AN520-10R7 SCREW 3

-9 2016032-2

-5 SEE FIG 19 BRACKET 1

NOTE.

A---F

363/364 blank

Fuel System (Cont)

2

Figure 81D. Fuel Reservoir Drain Valve Assembly


NO. 12345 7ASS CODE

81D- 2016021-9 VALVE ASSY-FUEL RESERVOIR DRAIN ---------------------- I 201602 1- 5 CAP-VALVE ----------------------------------- 2 NAS1593-010 PACKING ----------------------------- -- 3 NAS1596-6 PACKING --- -- -- ----- --------- 4 2016021-10 SPRING --------- 5 S2391-3 WASHER ---------------------------------- 6 5103-25MF RETAINING RING K -------- ------------ 7 2016021-4 PLUNGER ASSY ----- - --- ---------

365

MODEL 177RG

Vacuum System

11

Detail A

Figure 82. Vacuum System

366

177RG Parts Catalog

FIGUREAND

INDEX PART NUMBER DESCRIPTIONNO.

82-

-3

- 4 AN515-6R6 SCREW 4

- 5 MS20913-1- MS20913-2

- 6- 7

- 8 C668509-0101

S1450-16-24-100 WASHER 1

- 9 S 497-4

1201075-2 . B

-16 NAS603-7 SCREW . 2

-17 C294501-0102

-18

-19A AN3--19B

ATTACHING PARTS-22 AN924- 10D NUT 2-23 AN960D1416 WASHER 2

-23A C482001-0202 FILTER-VACUUM RELIEF VALVE-24 S51-10 HOSE

ATTACHIING PARTS

-26-27

-28-29

367

MODEL 177RG

Hydraulics

22

30 4

177RG SERIAL 177RG0001 THRU 177RG0282

177RG Parts Catalog

INDEX PART NUMBER DESCRIPTION PER ONNO. 12 3 4 567 ASSY CODE

83- LANDING GEAR HYDRAULIC SYSTEM NP C

2043037-1

- 2

- 3- 3A

-3B 2080117-28 ** - ASSEMBLY-GEAR UP- 3C 2043039-1 CLAMP ASSEMBLY

-3D AN3-4AA960-10LMS20364-1032C

-4 AN815-4D

-6 -

- 6-

- 2080

- 2-23A 1580015-1-24 1580012-9 ASSEMBLY-RESTRICTOR-25 AC105H4609E-4 --26 MS28778-4-27 AN815-4D-

-31-32 2080100-8 LINE ASSEMBLY-GEAR DOWN

-34 2080100-6GEAR ASSEMBLY-GEAR DOWN-35 AN815-4D-36 2080100-3 LINE ASSEMBLY-GEAR UP


369

177RG Parts Catalog

NO. 1234567

83 -37

AN5-10A 4AN960-516 WASHER 8MS21042L5 4

-42 AN816-4D

-45 SEE FIG 85-45-46

-48-49-50-51

-53-54

-56-57-58-59

-62

-64

-66-67-68

-6

-70 S

-71 SEE FIG 86 PUMP ASSY 1

-72 AN4-17A-73-74

-75 208000-27 LINE ASSEMBLY-SUCTION

-

-81 AN565B8H4

-82 AN924-3D NUT .1


370

177RG Parts Catalog

FIGURE UNITS USABLE


83-83-84 S2019-22-85-86-87-88-89-90-91-92-93-94-95-96-97


NOTE.

NOTE.

NOTE. **WHEN INITIALLY REPLACING THISPART ALSO ORDER INDEX 2, AN837-4D.

371

MODEL 177RG

Hydraulics (Cont) .

3232

Figure 83A. Landing Gear Hydraulic System

372

177RG Parts Catalog

FIGURE

AND PART NUMBER DESCRIPTIONNO. 2 3 4 5 6 ASSY CODE

83A-- 1 SEE FIG 87 GEAR

-32


373

177RG Parts Catalog

FIGUREPART NUMBER DESCRIPTION

NO.1 2 3 4 5 6 7 ASSY

83A-39 ASSY-GEAR UP-40 ASSY-GEAR UP-42-43-44

-47

-51 AN815-4D

-53-54 SEE FIG 85 VALVE ASSY

PARTS-55 NAS144DH12

-56-57

-63-64

-68

-71

-76

-77 S1021Z8-10SCREW 10-78 SEE FIG 86

-81

- ASSY-SUCTION


374

177RG Parts Catalog

FIGURE UNITS USABLEAND PART NUMBER DESCRIPTION PER ONINDEX ASSY CODENO. 1 2 3 4 5 6 7

83A-86 VALVE ASSY-HAND PUMP RELIEF-87

ATTACHING PARTS-88 AN565

-89-90-91-92 PACKING-93-94-95 ER-96-97-98-99

99A

SEE FIG 49 LANDING GEAR-99E SEE FIG 83B

NOTE. <THIS PART MUST HAVE A S SECOND

NOTE.

A--

375

MODEL 177RG

Hydraulics (Cont)

7

12376

""' -.- ~~ .... ... :. ,~.~~7

177RG Parts Catalog

FIGUREINDEX PART NUMBER DESCRIPTION PER ONNO. 12345 7 ASSY CODE

83B- GEAR SYSTEM NP A- 1 SEE FIG 87

2043037-1NAS464P4A10 BOLT UPPER

S2390-1 WASHER

-2

- 3

- 5

-

-7

--

-25

-26-28

-29-30

-31 2080100-9 LINE ASSY-GEAR UP/GEAR DOWN-32

-33-34-35-36 2080100-3-37 A-38 2080 67 ASSY-GEAR UP/GEAR DOWN


377


PART NUMBER DESCRIPTION PERNO. 1 2 3 4 5 6 7

-41-42-43-45 1580012-9 1-46-47

-50-52-53-54-55 SEE FIG 86 ASSY

ATTACHING PARTS-56 AN4-17A 2-57 AN960-416L 2-58 MS21042L4

- 2080100-71

-61-62-63-64-65

-70

-72 NAS144-12-73 AN936-A416 4-74 AN919-6D .

-75 AN919-7D

-82 2013020-14 <-83 S1021Z8-10

ALSO ORDER INDEX 2, AN837-4D.

F177RG SERIAL- F177RG0093 THRU F177R0138

378


IND PART NUMBERNO. 1 2 3 4 5 6 CODE

2043037-1 1- 2

- 3 2080117-28- 4

-6

MS20364-1032C


379

MODEL 177RG

Hydraulics (Cont)

Detail A 23

Detail A Detail B

,

78

177RG SERIAL 177RG0788 & ON

177RG Parts Catalog

FIGUREAND PART NUMBER DESCRIPTIONINDEX

NO2 3 4 5 6 7 ASSY CODE

83C- 7

-

-

-27

-22-23

-24 SEE FIG 86

-26-27

-28 2013020-14

-29 S

-30-31-32-33-34

-39

-41-42

CONTINUED ON NEXT PAGE-47


381

177RG Parts Catalog

AND PART NUMBER DESCRIPTION PER ONNO. 1 2 3 4 5 6 7 ASSY CODE

83C-48

-

-51-52-53

-54-55

-56

-57A

-58-59 AN936A416

-60 SEE FIG 84-61 AN5-10A-62 AN960-516

-64

-5 2080117-27

--68-69

-70--72-73

-74-75 SEE

-76-77

-78 2080117-31 ASSY

-81-82 2080117-30-83-84 A-85-86 2080117-29

NOTE.

382

Hydraulics (Cont)

177RG0433 THRU 177RG0787 21

177RG SERIAL 177RG0283 THRU 177RG0787Figure 83D. Main Gear Downlock Lines Installation

FIGURE UNITS USABLE

INDEX PAT NUMBER DESCRIPTION PER ONNO. 1234567 ASSY CODE

830- MAIN GEAR DOWNLOCK LINES INSTALLATION ---- --------------- NP A- 1 2080100-36 LINE ASSY-GEAR UP -------------------- --------- I B- 2 AN815-40 UNION --------------- -- 1 B

- 3 AN824-40 TEE----------------- 4 2080100-38 LINE ASSY-GEAR UP --------------------------5 AN815-40 UNION ---- -------------------- --------

MS28778-4 PACKING ---- --------- --- ------ 6 AN921-40 ELBO --------------- ---------

MS28778-4 PACKING -- --------- ------- ---- 1AN924-40 NUT ------------------------

- 7 2080100-40 LINE ASSY-GEAR UP -------------- ------------- I-8 2080100-45 LINE ASSY-GEAR UP ----- -------- ---- 9 AN824-40 TEE ------------------------------

-10 2080100-47 LINE ASSY-GEAR UP ----------------------------11 AN815- -4D UNION----------------------------------

MS28778-4 PACKING ----- ------------------12 2080100-46 LINE ASSY-GEAR UP --- ----------13 AN921-40 ELBO ----- ------------------- -----

MS28778-4 PACKING ---------- -----------AN924-40 NUT ----- ---------- -- 1

-14 2080100-40 LINE ASSY-GEAR UP --- -----------------------15 AN515-40 UNION ------------ ---------------------16 2080100-42 LINE ASSY-GEAR UP -------------------------------------17 2080100-37 LINE ASSY-GEAR DON -------- ----- ------18 AN824-40 TEE --------- -- --------19 2080100-39 LINE ASSY-GEAR DOWN - ---- ------20 2080100-44 LINE ASSY-GEAR DOWN ------ -----------------21 S1999-1 FITTING ---------------------------

MS28778-3 PACKING -------- -- ------------- 2AN924-3D NUT --- -- ---------------- 2


B--177RG SERIAL 177RG0283 THRU 177RG0432F177RG SERIAL F177RG0063 THRU F177RG092

383

MODEL 177RG

Hydraulics (Cont)

384

177RG Parts Catalog


INDEX ASSY CODENO. 1 2 3 4 5 6 7 ASSY CODE

83E-

--

-----

-

-28

-34

A--177RG SERIAL 177RG0433 THRU 177RG0787

385

MODEL 177RG

Hydraulics (Cont)

2

7

39

41

42

177RG SERIAL 177RG0433 THRU 177RG0787Figure 83F. Selector Valve and Handle Installation

386

177RG Parts Catalog

FIGURE UNITS USABLEAND PART NUMBER DESCRIPTION PER ONNO. 12345 7 ASSY CODE

83F- SELECTOR VALVE AND HANDLE INSTALLATION NP A

-

-34-35 A-36 AN960-10L WASHER 1-37 MS21044- NUT 1

-39 SEE FIG 88B

A-177RG SERIAL 177RG0433 THRUF177RG SERIAL

387

MODEL 177RG

Hydraulics (Cont)

12

177RG SERIAL 177RG0788 & ONFigure 83G. Hydraulic Selector Valve and Lines Installation

388

177RG Parts Catalog

FIGURE UNITS

INDEX PART NUMBER DESCRIPTION PER ONNO. 1 2 3 4 5 6 ASSY CODE

836- HYDRAULIC SELECTOR VALVE & LINES INSTALLATION NP A-1 SEE FIG 88D 1 B

SEE FIG 88E ASSY 1 C

- 2 AN507-1032R7 3

- 3 AN921-AN924-

MS28778-5 PACKING- 4 2080117-21 ASSY-RETURN

AN960PD816AN924-5D

- 6 AN815-4D

- 7- 8

F177RG SERIALB-

389

MODEL 177RG

Hydraulics (Cont)

177RG SERIAL 177RG0001 THRU. 177RG1266Figure 84. Hydraulic Power Pack Assembly

390

177RG Parts Catalog


NO. 1 2 3 4 5 6 ASSY CODE

84- -

-2

-4-5-6

PRST

PARTS

-13

-15-

-3 960P 716L S|ER-- --

NOTE. *DISCARD FILLER PLUG HARDWARE SUPPLIED.

NOTE. **CONTAINS ADDITIONAL PARTS TO SERVICEOTHER APPLICANTS.

391

MODEL 177RG

Hydraulics (Cont)

.

15 50 38

9

177RG SERIAL 177RG1267 & ONFigure 84A. Hydraulic Power Pack Assembly

392

177RG Parts Catalog


NO. 123456 7 ASSY CODE

84A-

- 2 AN3- 6 A- 3

-4 1- 5- 6

S1628-129-

-8-

-

-

-

-34-

--35-36-37

-41-42

-43

-46

-41

-53-54

A-177RG SERIAL 177RG1267 & ON

393

MODEL 177RG

Hydraulics (Cont)

10

12

17

1519

17

THREAD TEE.15

11

177RG SERIAL 177RG0001 THRU 177RG0432Figure 85. Power Pack Control Valve Assembly

394

177RG Parts Catalog


INDEX CODENO. 1234567

85- 2080029-1- 1 2080011-2- 2 AN815-4D- 3 MS28778-4 PACKING-4 2080011-8

- 7-

-11

-3- 4 2

-

NOTE. REFER TO NOTE % ON FIGURE 83.

A---117RG SERIALF177RG SERIAL

395

MODEL 177RG

Hydraulics (Cont)

4

3

12

27

Detail A177RG0243 & ON

F177RG0043 & ON

Figure 86. Emergency Hand Pump Assembly

396

177RG Parts Catalog

FIGURE

INDEXNO. 1 2 34 6 ASSY CODE

86 - 2080005-1 EMERGENCY HAND PUMP ASSEMBLY-

-2 NAS561P4-22 ROLL PIN

- 3 2080010-4 STOP-HANDLE 2

- 4 NAS561P4-18 ROLL PIN 1

- 5 2080010-2- 6 280007-6

ATTACHING PARTS- 7- MS20392-

ATTACHING PARTS

-14 MS122028 22080006-1

-15-16-17 2080030-1-18 S2394-1-19 MS16625-1031 RETAINING A-19A 2080019-1 SCREW B-20 S2393-3-21 MS28775-008-22 S2059-1-22A 1458-23 S1628-114 BACK-24--27

NOTE. *WHEN INITIALLY ORDERING THIS PART FOR AIRCRAFT

397

MODEL 177RG

Hydraulics (Cont)

Figure 87. Nose Gear Actuator Assembly

FIGURE UNITS USABLEAND

INDEX PART NUMBERNO. 1234567 ASSY CODE

87 - 2043025-12 ACTUATOR ASSEMBLY-NOSE GEAR - 1- I S2049P4FG ROD END - 1- 2 AN316CSR NUT - 1- 3 MS16625-1106 RING-RETAINER - 1- 4 S1628-111 RING --- 1- 5 MS2877-111 PACKING 1- 6 2043025-10 GLAND-NOSE GEAR ACTUATOR 1- T MS28775-02C PACKING ----- 8 2043025-11 PISTCN-NOSE GEAR ACTUATOR - 1-9 S1628-210 RING -- - 2-10 MS28775-210 PACKING 1-11 2043025-9 CYLINDER-NOSE GEAR ACTUATOR 1-12 S2015-4 BEARING 1

398

12

Figure 88. Main Landing Gear Actuator Assembly


88 - 2041007-3 ACTUATOR ASSEMBLY-MAIN LANDING GEAR ------------ -------- 1- 20

- 2 S2426-6 BEARING -- 1

- 3 AN316-7R NUT ------------------ ------------- 4

-5

-6 S1628-133 BACK UP RING -------------------------- 7 MS28775-133 O-RING ------------------------------- 399- 8 S1628- 114 BACK UP RING ----- --------- 9-10 2041009-1 PISTON -------- - ---------------------11 S1628-326 BACK UP RING --------------------------------- -----

399

MODEL 177RG

13

177RG SERIAL 177RG0283 THRU 177RG0787Figure 88A. Main Gear Unlock and Sequence Actuator


88A- 2041057-1 ACTUATOR-MAIN GEAR UNLOCK & SEQUENCE 1 A- 1 1280223-1 . FITTING ASSY 1- 2 MS28778-4 GASKET I- 3 1280222-2 SPRING 1- 4 S272-9 BALL 1- 5 S272-5 BALL 1- 6 MS16625-1093 RING-RETAINER 1- 7 2041055-1 PLUG-ACTUATOR 1- 8 MS28775-115 PACKING 2- 9 S1628-115 RING-BACK UP 2-10 2041054-1 PISTON & ROD 1-11 MS28775-010 PACKING 1-12 S1628-010 RING-BACKUP 2-13 MS28775-110 PACKING 1-14 S1628-110 RING-BACKUP 1-15 2041045-1 VALVE BODY 1

A---177RG SERIAL 177RG0283 THRU 177RG0787F177RG SERIAL F177RG0063 THRU F177R60138

400.

MODEL 177RG

Hydraulics (Cont)

15

28

177RG SERIAL 177RG0433 THRU 177RG0787Figure 88B. Landing Gear Selector Assembly

401 blank/402

177RG Parts Catalog

FIGURE UNITS USABLE

INDE PART NUMBERNO. 1 2 3 4 5 6 7 ASSY CODE

-3- 4 AN515-6R4 2

-6

-ATTACHING PARTS 2

-

AN960-4L 2- A-

-3

-2080041-1

- 208

-2

-28

403

MODEL 177RG

34

177RG SERIAL 177RG0433 THRU 177RG0787Figure 88C. Lock Valve Assembly

FIGURE

NO. 1234567

88C- 1280520-1 VALVE ASSEMBLY-DOOR CLOSE LOCK 1 A- 1 1280518-1 HOUSING 1- 2 S2019-29 NAMEPLATE 1- 3 1280522-1 FITTING -- 4 MS28778-6 PACKING 1- 5 S2059-3 VALVE-CHECK 1- 6 MS28775-012 PACKING 1- 7 AN919-10D FITTING 1- 8 MS28778-8 PACKING 1-9 1280519-1 PISTON 1-10 MS28775-111 PACKING 1-11 S1628-111 RING-BACK UP 2-12 1280521-1 SEAT 1-13 MS28775-012 PACKING - 1-14 S1628-012 RING-BACK UP 1-15 MS28775-011 PACKING 1-16 S1628-011 RING-BACK UP 1-17 S272-5 BALL 1-18 1280515-7 GUIDE 1-19 LC-032B-6MW SPRING LSCI 1


404

Hydraulics (Cont)

17

16

9 5

177RG SERIAL 177RG0788 THRU 177RG1266Figure 88D. Hydraulic Selector Valve Assembly

FIGURE UNITS USABLEANDAND PART NUMBER DESCRIPTION PER ON

INDEX ASSY CODENO. 1234567

88D- 9881000-2 HYDRAULIC SELECTOR VALVE ASSEMBLY -------- ------------- 1 A- 1 9881006-2 COVER-HYDRAULIC SELECTOR VALVE ------ ------

ATTACHING PARTS- 2 AN507-440R4 SCRE ----------------------- -------- 3

- 3 MS16625-1131 RING-RETAINING ------------- ------------- 1- 4 9881004-2 CAP -- -------------------- 5 S2014-5 RACE --- -------------------- --- 6 S2013-5 BEARING ----------------------------------- -- 1- 7 9881002-3 DISC ASSY-HYDRAULIC SELECTOR VALVE ------------- --- I- 8 9881005-2 ROD-HYDRAULIC SELECTOR VALVE ---- -------------------------- 1

ATTACHING PARTS- 9 MS24665-132 COTTER PIN ------- ------ ---------- 1-10 S1450-4-5-032 WASHER ----- --------------- --------- 1-11 MS24585-C144 SPRING ----- -------------- ------------- 1

--- *----12 MS28775-014 PACKING --------------------- - ------- 1-13 0861233-2 KNOB-HYDRAULIC SELECTOR VALVE ---- ----------- ----

ATTACHING PARTS-14 S2239-6 NUT ------------------------------ ------- 1

---*----

-15 9881003-1 PUCK-HYDRAULIC SELECTOR VALVE -------- ------------ 3-16 MS28775-008 PACKING - -------- --------- 3-17 U125-0072 SPRING ------ ---------- 3-18 MS28775-027 PACKING ---- - ------------------------19 9881001-3 BODY ASSY-HYDRAULIC SELECTOR VALVE ------------------ 1

A---117RG SERIAL 177RG0788 THRU 177RG1266F177RG SERIAL F177RG0139 THRU F177RG0177

405

MODEL 177RG

Hydraulics (Cont)

7

177RG SERIAL 177RG1267 & ONFigure 88E. Hydraulic Selector Valve Assembly


88E- 9881020-2 HYDRAULIC SELECTOR VALVE ASSY-GEAR 1 A- 1 9881023-1 COVER-HYDRAULIC SELECTOR VALVE 1

ATTACHING PARTS- 2 AN507-440R4 SCREW 4

- 3 MS16625-1131 RING-RETAINING 1- 4 9881004-2 CAP I- 5 S2014-5 RACE 1- 6 S2013-5 BEARING 1- 7 9881005-2 ROD 1

ATTACHING PARTS- 8 MS24665-132 COTTER PIN 1- 9 S1450-4-5-032 WASHER-10 MS24585C-144 SPRING

-11 0861233-2 KNOB-HYDRAULIC SELECTOR VALVE 1ATTACHING PARTS

-12 S2239-6 NUT 1

-13 9881002-3 DISC ASSY 1-14 MS28775-014 PACKING 1-15 9881003-1 SEAL 3-16 MS28775-008 PACKING 3-17 LC-0380-1 SPRING 3-18 MS28775-027 PACKING 1-19 9881021-1 BODY ASSY-HYDRAULIC SELECTOR VALVE 1

MS2120F1-15 INSERT 3

A-177RG SERIAL l77RG1267 & ON

406

Hydraulics (Cont)

149

177RG SERIAL 177RG0788 & ONFigure 88F. Main Gear Downlock Actuator Assembly

FIGURE UNITS USABLEAND DESCRIPTION PER ON

INDEX PART NUMBER ASSY CODENO. 1234567

88F- 1280504-2 ACTUATOR ASSEMBLY-MAIN GEAR DOWNLOCK ---- - A

- 1 1280611-1 PLUG ---------- 2 1280222-3 SPRING-INNER ------------------ 3 1280222-1 SPRING-OUTER ---------- --------------------------- - 1

- 4 1280504-201 PISTON ROD ASSY --- -------------------5 MS28775-113 PACKING ------ ------

-6 MS28775-010 PACKING ----------------------------------- 1

-7 S1628-010 RING-BACK UP -- 8 1280504-200 BARREL & VALVE BODY ASSY -

- 9 S1628-110 RING-BACK UP -------------------------10 MS28775-110 PACKING --------------------- --

-11 1280223-1 FITTING ASSY -----------12 MS28778-4 PACKING-13 1280222-2 SPRING - --- -----

-14 S272-9 BALL-15 S272-5 BALL ------------------------------------ - . 1

-16 S2019-9 NAMEPLATE - -- 1

A---177RG SERIAL 177RG078 & ONF177RG SERIAL F177RG0139 THRU F177RG0177

407

MODEL 177RG

12 23 Electrical Equipment

Detail

408

408

177RG Parts CatalogFIGUREINDEX PART NUMBER DESCRIPON PER ON

NO. 1 2 3 4 5 67 ASSY CODE

89- ELECTRICAL EQUIPMENT INSTALLATION NP-1 C611501-0102 PARTS 1

PARTS- 2 AN7-42A BOLT 1

- 3-4-5 -5-6

AN3-4A BOLT 2

- 8 0770038-2ATTACHING PARTS

AN515-8R7 2

-9 S1095-9 SHIELD 2

AN520-8R8 SCREW 2

NAS557-14-10 S1917-1

AN4-5A 2AN960-416LAN936A416MS21042L4 2

-11 S1856-1 WARNING E

2LM-E

AN515-2R10 21450020-1AN340-21560218-1 PLATE ASSY 1AAM40 -

PARTS

-14

-15 AN530-6-4 4USE WITH 2070005-22 2

USE WITH


409

177RG Parts Catalog

INDEX PART NUMBER DESCRIPTION PER ONNO. 1234ASSY CODE

89 -22-23

-23A-23B AN516-6R6-23C

-23D

-23G AN340-6-24 S1672-1-24 S1672-2

NAS395-17-3 4-25 2070001-PA6-26 -

AN3-6A ATTACH 2S1807-1 2S2209-2 2

-27 S1095-6 2

-28-29 S1579-2-30 AN3-3A-31 MS21044N3

-32 S1807-2 2-33 S2209-2-34 0770728--35 0511319-

-36-37

-4243:1761

-43

AN3- 3AAN935-10L 2AN341-10 2

-45-46 S1660-1-47 AN3-3A-48 MS25171-1S-49 2070001-PC1


410


AND PART NUMBER DESCRIPTION PERINDEX ASSY CODENO. 1 2 3 4 5 6 7

89 -50

-52

-53-54-55

-56 11- ASSEMBLY-EXTERNAL POWER RECEPTACLE-57-57A-58 ASSEMBLY-59

-61

-63

--65-66-67-68-69 S1831-1

AN515-4-3 SCREW

-70 SEE FIG 90-71-72 SEE FIG 91-73 SEE-74 SEE -1-75

AN515-8R8

-76 OR95-1.5 BEACON 1 D

AN515-8R12 2 D

-77 S1917-1 RELAY 2 C

-78 C622008-0101 POWER SUPPLY-STROBE LIGHT 2ATTACHING PART

-79 AN520-10R7 SCREW 4

-80 1201127-1 BRACKET ASSY 2 DATTACHING

-81

-82

-83 1570166-1

-84 AN515-8R6


411


AND PART NUMBER DESCRIPTION PER ONNO 1 2 3 4 6 7NO. 1234567 ASSY CODE

89 -85 2N3055 TRASISTOR RCA 2ATTACHING PARTS

-86 S1021Z6-3 SCREW 2

-87 S1641-6 HOUSING-SOCKET-88 POST LIGHTS-FLOOD LIGHTS

-90 AN515-8R8 SCREW 2

-91 DELETED NOT USED-92 C596510-0101 SPEAKER L

PARTS-93-94

-95 C593001-0101 SENSOR-OVERVOLTAGE 1-96 TVA1315 CAPACITOR

412

MODEL 177RG

Electrical Equipment (Cont)

46

Detail

Detail E

177RG SERIAL 177RG1267 & ONFigure 89A. Electrical Equipment Ins

413 blank/414

177RG Parts Catalog

FIGUREUNITSAND

INDEX PART NUMBNO. 1234567 ASSY CODE

89A- ELECTRICAL EQUIPMENT INSTALLATION-24 VOLT - A- C611503-0102 ASSY-60 AMP 28 VOLT

ATTACHING PARTS- 2 AN7-44A- 2A- 3

S1450-6-14-080 WASHER

- 4 ADJUST-5- 5A

- 5C- 6

S21 4-2

-7

AN3-6A

- 9

AN515-2R81450020-1AN936A21560218-1AAM40

-10 2070031-PA11

AN3-6A BOLT 2

PARTS-12-15 AN935-10L 2

AN3-3A 2

-16-

-20 0712031-1

AN3-34 2A935-10L 2AN341-10 2

-21


415

-177RG Parts Catalog

FIGURE UNITS USABLEAND PART NUMBER DESCRIPTION PER ONNO. 12 3 4 5 6 7 ASSY

89A-22 S1090-2

43-1761

-25-27 AN3-3A 2

-33-34-35 MS21044N3 2

-36-37

ATTACHING PARTS

AN345-10

-42

-46 1570166-1 DIMMER ASSY-TRANSISTOR 1-47

-48 2N6576 TRANSISTOR RCA 2

-5


416

177RG Parts Catalog

FIGUREAND PART NUMBER

INDEX ASSY CODENO. 1234567 ASSY CODE

89A-52 1706015-2-53-54

AN515-4-3 2

-56 1270733-1 DUAL WARNING UNIT ASSY 1ATTACHING PARTS

-57 AN515-8R8 SCREW 2

-58-59 C596510-0101

-60 AN515-8R10 SCREW 2-61

-62 C594502-0102

AN515-8R8

-63

AN515-8R12 SCREW - 2

-64 C622008-0102

-65 AN520-10R7 SCRE ---- 4

-66 1201127-1 BRACKET ASSY-POWER SUPPLY 2ATTACHING PARTS

-67 AN520-10R7 SCREW - 2

-71 91-n-72-73

417

MODEL 177RG


12

11 1014

3

177RG0001 THRU 177RG0787 177RG0788 & ON

Figure 90. Instrument Panel Lights Installation

418 .

177RG Parts Catalog

FIGURE UNITS

INDEXNO. 1 2 3 4 5 6 7 CODE

90 - I1713243-1

- 1MS20665-132 COTTER PIN 1

-2

--

-8

-9 -

--14

-1

-20

-22 1213319-7

-23171-5064-4

-24-25 NAS448-5-3 NUT 2

-26-27

1570394-1

-28

--3-31 12 -2

NOTE. <THIIS PART MUST HAVE A SECOND NUMBER ADDED

INTERIOR PARTS-PAGE XVII.

419

MODEL 1771RG

4

177RG0283 & ON

Figure 91. Landing Lights Installation

420

177RG Parts Catalog



91 -

- 3-4

5- 6-7

-

-

-

-

2

-22-23-24 AN515-8R8 SCREW ------ 8

A-

F177RG0062

421

MODEL 177RG

Electrical Equipment (Coot)

2

Figure 92. Courtesy Lights Installation

422

177RG Parts Catalog

FIGUREINDEX PART NUMBER DESCRIPTION PER

NO. 2 34567

92-

- 2 S1021Z8-8 SCREW

- 3 MS15584-2 12V 2 AMS15584-15 24V 2 B- 4 0700616-1

- 5 S1021Z6-8 2

- 7 0513208-1

- 8 S

ATTACHING PARTS

AN515-4R4 2

423

MODEL 177RG


3

Figure 93. Flashing Beacon Installation

424

177RG Parts Catalog


NO. 1 2 3 4 5 6 7 ASSY CODE

- A515-8R8 SCREW 2

- 2

-

-8-9-10

-

-

4 A

-18 S

A--

C-

6-

425

MODEL 177RG


13

Figure 94. Control Wheel Map Light & Mike Switch Installation

426

177RG Parts Catalog


94 -- 1 SEE FIG 69-2-

-

--

-

177RG Parts CatalogFICHE FIGURE FICHE FIGURE

PARTNUMBER ANDFRAME

AC

76 -46 AN3-15A 66 -20 AN3-6A 71-25

AN155B325 73 -27 AN3-16A 66 -34 AN3-6A 73-14

71- 8 AN3-3A -13 AN3- 6A -

70-6 AN3-3A -47 AN3-7A 75 -6970 -10 AN3-3A - 4 AN310-3 27 -13

AN123-11 74-71 AN3-3A -83 0-3

AN23-12A 45 -33 AN3-3A -30AN23- 45A-32AN23- 48 -20 AN3-3AAN23- 76-3

24 -3024-35 83-3D 4 -1924A-31 AN3-4A AN315-3R

AN3- 75 -79 AN3-4A 6

AN3- 66-26 AN3-5A 5-28AN3- 66-30A AN3-5A 5A-34AN3-

AN3- 73-62AN3-5A17 -16AN3- 75 -15 AN3-5AAN3-AN3- 75-23 AN3-5A 17-94AN3-AN3- 57-36 AN3-5AAN3-11A 57 -42 AN3-5A

430

177RG Parts CatalogFICHE FIGURE FICHE FIGURE FIGURE

PART NUMBER AND AND PART NUMBER AND PART NUMBER ANDNDEX FRAMENO. NO. NO.

55-14 -12A 27-47 4 70 -18

57 -45A89-1173-55

90 -2149 - 3 14A 12-11 68-25

88B- 6 -17A 83B- A 838-6889 -23G -17A

49 -49 12 -1649 -55 3A49 -58 3A 89 -3849-5949 -6149A-56 -A 73 -1249A-63

49A-67 -31A 50A-22 249A-

49

49 - 76 -25

89A-15

431

-

AN507-632R8 42A-25 AN515-6R22 49C-64 AN515-8R6 89 -12AN515-632R8 49 - 3 AN515-6R26 4-92 AN515-8R6 89 -21

AN507-832R6 38A-53 AN515-6R5 34 -24 AN515-8R7 89A-45

-17- 1A AN515-6R6 82-23 -70

AN515-2R8 35 -39AN515-2R8 57 -45A AN515-8- 73-48 AN515-89A-57

89-6989A-5589 -18

88B- 835 -

78A-10

432

177RG Parts Catalog

FICHE FIGUREAND AND PART NUMBER INDEX

PART NUMBER AND INDEX PART NUMBER ANDFRAME

49 -54 A

49C-55

49C-67 38A-24 AN74208

72-1 81A-

56-1373 - 6879-4479A-7689-6257 -44A

46A-58

49-60

433

177RG Parts Catalog

PART NUMBER FRAME FRAME FRAME83A-16

83A-41 79 -18 57-1983A-44

83B-15 49C-62

83E- 83B-28 83 -29

85 - 2 83C-21 83B-3083 -4283 -51

83

79A- 7 79-2384A-22

A

57-70 83B-

79-50

83 -42 83-3

82 -15

838-79 83A-27 83 -61

79A-2583B-2283 -65

83-1983B-2083D- 383D- 983D-18 AN837 83C-4683E-2183A-71 AN837 83E-27

434

177RG Parts Catalog

PART NUMBER AND PART NUMBERFICHE AND PART NUMBER AND ANDFRAME NO. FRAME FRAME

AN924-4 79A-23 A929-4 83C-53A AN9

83A-10

AN92 83C-1 4 A936A46 6-3 A 46-645

4AN92 -483C-48 AN93644 6 A-33AN961- 57 -42

83B-60 AN936A716 89A-1183C-64 AN936A716 83A-10

85 -10

435

177RG Parts CatalogFICHE FIGURE

PART NUMBER ANDFRAME NO. FRAME NO. FRAME NO.

35A-37-1937 -28 -6L 66-28 6 17 -9237 -3740 -1540 -2145 -28 27 -43A45A-2846 - 546 - 746 -3846 -704646 -98 47 -26 33 -3246A- 3 47A-27 34 - 8

46A-89 88B-1046B- 546B-7

46B- 99C49B-92498-93

56 -1756-22

57 -2057 -2157 -2257-5057-6760-25

64A-1964A-33 48A- 3 74 -8864A-4 1 50A- 3 - 75 -2964A-62 50A-17 75 -3564A-73648-20648-3368-2670 - 470 -1172 -3873 - 4 57 -5073 - 873 -1575 -1675 -24-77 -1179 -22

79A-3979A-4883 - 3D 6 75-9

83B- 683C-683F- 4

83F-4186-9

89-6289-8689A-49

436


PART NUMBER. PART NUMBER AND AND

-796(838- 4A96 79-56

15 -56 79A-5715A-6027 -51 84A- 3

28 -34 57 -5429 -32 57 -5945 -24 57 -61 31A-1045A-2446 -95 64A-53

46B-9249B-42A

89A-4790 -

437

177RG Parts Catalog

ANDPAR NUMBER AND AND PART NUMBER AND PART NUMBERFRAME NO. FRAME NO. FRAME

59-27

59 -2459 -13

59-25 B20060

59-2159 -16 36A-27 31A- 253 -20

AA53 -3353 -17 36A-23 31B- 2

14 36B- 9 53 -23 93 - 715 36A-10 53-18 93 - 215 36B- 7

36A-30 53 -11 93 - 3

A30023 36B-18

A30030 36-30A30040 36A-34A30040 36-32A30047 31A- 9 53 - 7 38A-33A30047 31B-5 -16 - 40 - 4A30048 31A-8 73-12A 31 -1A30048

A30078- 31B- 6A30079- 36A-4A30079- 36- 5 -12- 15A-20 36A-1A30079- 36A- 8A30079-- 36B- 6A30085 36A-33A30085 36B-31A30087 36A-24A30087 36A-28A30087 368-24A30087 36B-28A3124 53 -31A3125 53 -32A3150-1 53 - 4A3150-5 53 -24A3902 53 -25A3906 53-8A4513-1 11-27

4 -77

438

177RG Parts CatalogFIGURE FICHE FIGURE FIGURE

ANDAND FICHEPART NUMBER AND INDEX PART NUMBER AND PART NUMBER AND

AND INDEXFRAME FRAME FRAME

62-62 - 1

57 -7 58- 849 -73

-2549 -7449A-8349B-73

49-7236A-18 93 -36B-1736A-19 93 -31A-3 3 -30

73-36 3 -39 #173 -36 2 -24A73 -43 89 -61 #5 5336A- 7 3-3836A- 631A- 6B 3 -3931A- 6A 3-3831A- 3 89 -78

31B- 736B- 436B-3 49-47

53 -41

53-22 49-4853 -42

3 -50-11 - 49 -4850 -17 49 -4558 -1758-3182-27

53 -82 -23A

49A-668 -47

11-3212 -71

49A-99B 49-43 49B-60

89 -95 49 -5449C-90 49A-61

49C-90 . 3 -62A89A-4293 -14

89A-62

89A-5989- 758- 9 4 49A-56 49 -5558 -2689 - 7 6689 - 7

439

177RG Parts Catalog

PART NUMBER FRAME INDEX FRAME FRAMENO. NO. NO.

49C-58 74

49 -5149A-5849B-46

49A-67

49A-7049B-64 -303 58-23 79 -83

49C-60 59A-19 5749C-62 86 -14 57 -6149C-6450 -3450 -37 34 -43 60 -26788-1 20 -43 60 -2731A-6 - 27-53

36A-

3636B- 3

84-3

84-284- 984 - 784-4 69 -6 57-6084 -14 30 -26 57 -61

89-23A81-681 -11

84A-12 3-63 57 43

81B-84A-1635 -22

440

177RG Parts CatalogFIGURE FIGURE FIGURE

PART NUMBER AND AND PART NUMBER AND PART NUMBER ANDFRAME INDEX IN INEXFRAME NO. FRAME FRAME NO.

73 -3238 -7738A-90

38-3838A-37 46A-14 74

90 - 183 -88 27 -47 77 -1

38-66

38A-42 57 -28 83A-45 -38 82-15

MS

46B-6138 -5766 -11

83F-19

29 -28

441

177RG Parts Catalog

FICHEPARTNUMBER FICHEAND PART NUMBER

29 -34C35A-30 44 46B- 564 -39 48-2364 4764 -5764A-48 49A-6964A-5664A-7764B-5664B-8189 -23C89A-4290 -154 -80 57-688 -52

11 -3427 -53F28 -35

38 -7638A-683845 -2545-4345A-2545A-4646 -9146-9546A-7546A-8346B-84

49B-42A49C-4255 -1763 -3769 -31

78-42489-13 S2 4B73- 7 S24665-32 28 -1689 -8489 -9489A-4589A-4789A-61

.44233 5A-54 S21919 :57 -31NS24665- 3246-84

442

177RG Parts CatalogFIGURE FIGURE FIGURE

PART NUMBER ANDFRAME NO. FRAME NO. NO.

MS24665-132 46 -87 MS24665-134 72 -36MS24665-13246A- 6MS24665-

MS24665-132 74 -79 69 -45MS24665- 32 74 -92

MS24665-132 75 -10MS24665-132 75 -32MS24665-132 75 -38 25041-4 49A-87MS24665-132 75 -44 2504-4 49B-81MS24665-132 75 -71MS24665- 32 75 -82A 71-1S 89 -48MS24665-132 76- 5

MS24665-132 76 -23MS24665-132 76 -33 2571-35 89A-30MS24665-132 76 -45MS24665-132 76 -52MS24665-132 79 -87MS24665-132 79A-53MS24665-132

MS24665-132

MS24665-MS24665- 34 46-23 MS25253-2 35 -MS24665-134 55 -22 25253-2 88B-

MS24665-134 64 -33MS24665-134 64A-35

MS24665-134 64A-39MS24665- 34 64A-42MS24665- 34 64B-52

MS24665-134 70-12MS24665-134 70-29MS24665- 34 71 -14

443

177RG Parts Catalog

PART PARTNUMBER AND PART NUMBERFRAME FRAME

MS28778-4 83C- 2 MS35489-34 37 -19 20 -24MS28778-4 83C- 7 MS35489-4 11 - 8MS28778-4 83C-17MS28778-4 83C-38MS28778-4 83C-42 49A-13

444 3 84-78 64 -25 8-85-3

88B-26MS28778-4 88B-27 MS35489-7 78 - 9 46 -95MS28778-4 88F-12 MS35489-7 79 -2 46A-81MS28778-5 83 -95 MS35489-7 83 -17 46B-91

MS28778-5 83A-99A MS35489-7 83A-25 69 -24MS28778-5 83C-64 MS35489-7 83C-45 38 -74MS28778-5 83C-81 MS35489-7 83C-51 38A-87

83B-74 MS35489-7S 83B-32 27-50

MS29513-10 80 -16

24A- 9

3 -58 11-31

61 -11 3 -63 NAS395-1-3

444

177RG Parts CatalogFICHE FIGUR FICHE FIGURE FICHE FIGURE

PART NUMBER PART NUMBER

NAS395-14-3 9 -12 NAS43000-19 94 - 6 NAS446-1-3 15 -58

NAS395-14-3 19 -39

NAS395-17-3 89 -24NAS395-17-3 89A-41

NAS395-2-3

NAS395-7 18 -43 73 -85

-34

AS39

75-71

3-7 37 -39

24 -6424 -6624A-6824A-70

445

177RG Parts Catalog

NO.PART NUMBER AND

NAS488-1-3 91 -18 NAS561P4-15 46A-29

NAS516-1 30 -67 46A-6520-8NAS5282-10 7-15

NAS557-10A 73 -50NAS557-10A 89A-12 46A-51NAS557-12 89 -27 46B-52

NAS557-14 89 - 9 46B-55NAS557-14 89A- 8 46B-59 14 -27NAS557-16A 7-22NAS557-3A 13 -25 46 -58NASS57-6A 4 - 3 46A-49

NAS557-8A 24 -29 46 -51 5 -45NAS557-8A 24 -34 46A-.40 .5A-53

24 -39 46B-48 25 - 4NAS557-8A 24A-30NAS557-8A 24A-35NAS557-8A 24A-41NAS561-2-3 90-8

NAS561-3-8 77-8NAS561-5-12 68-16

64-40-9H45 -30 -45A-30

45A-51 5A- 3

INAS56' 0 468-39 IAS68OAD8 49 - 6 8 -26

446

177RG Parts CatalogFICHE FIGURE FIGURE FIGURE

PART NUMBER AND INDEX PART NUMBER AND PART NUMBER ANDFRAME O. NO. NO.

5 - 95 - 9E5A- 95A-

7 -38 -128 -105 - 3

5 - 9

16 -1720 -14 -19 30 -66

15-74A 9A-19 30 -3415-79

5A-10

5 -76 NAS697A08K 5A-13S 89A- 5B

49-3249C-20

AS696A3 19 -37 NAS697A3 1 -36 45 -12NAS696A3K 19 -34 NAS697A4 5A-18A 45 -20

NAS696A3K 19 -56 NAS697A4 7 -43NAS696A3K -44F NAS697A4 -20 45A-15

NAS696A4 5 -85 NAS697A4 -29

NAS696A4 -37NAS696A5 -30NAS696A5

NAS696A5

447

177RG Parts Catalog

PART NUMBER AND INDEXPART NUMBER AND NUMBER ANDFRAME D INDEX INDEXFRAME NO. FRAME NO. FRAME NO.

48-17

49C-38

43-2821 -39 8

57 -31

57 -3764A-2664A-75B64B-37 10 -2879-10

42 -20 S

78A-6

42A-24 64A-24 5A-11

78 - 712 43 -16

-12 63 -18

43 -17

448

177RG Parts CatalogFICHE FIGURE

PARFRAME NO. FRAME

S .

449

177RG Parts Catalog

FRAME INDEX FRAMEAND

29-34

23 - 3

63 -21 79 -10

49 -50 65 -19BS1397-6 2-29 65 -198 S1635 -35

S1415-1 1-31

S

S

47-22

-.063 50-21

450

177RG Parts Catalog

FICHEPART NUMBER AND AND PART NUMBER AND PART NUMBER AND AND

FRAME INDEX FRAME INDEX FRAME INDEX

49 -68

49B-76

S1843-1 49C-76 S1898- 49A-44 1-5 49A-98A

S1845-2 49 -63S1845-1-2 49-66 S1899-S1846-1-3 49-68

451

77RG Parts Catalog

PART NUMBER AND PARTNUMBERNO.

30 -28

46-40A

1 -16

80 -19

840 -14

-2

452

177RG Parts Catalog

FICHE FIGURE FICHE FIGURE FICHE FIGUREPART NUMBER AND AND PART NUMBER AND PART NUMBER AND

S227

S22S22

S22

453

177RG Parts Catalog

FICHEPARTNUMBER AND PARTNUMBER

FRAME

-5

1 2-58 2 -391 2-63 2 -64 46B-58

75 -45

1

89A-19

92 -12

49 -10 26A- 6

38- 8

51A-19 90 -13 # 48 -33

72 -31

72 -4775- 7 3292-4 49B-93A # 48-3475-1175 -1175 -62

83C-49

30-68

61A-6515 -33

50 -2250-33

56-112 -23

56 -11

454

177RG Parts Catalog

PART NUMBER AND PART NUMBER AND PART NUMBER ANDFRAME

2 45A-2 46B-1 1 62-1 49B-52 78 -30

49A-50 32 -14

42 -5A42A-26 -5 46A-4842A-29

38A-

3 -353 -353-353-35 38A-35

9 - 19-29-6

11 -2

67 - 367 -2067 -1067 - 967 - 6 68-34

67 - 7

27 -6127 -60

30-72

56-14

54- 854A- 8 #1 46A-1957 -25

94 - 4 46A-19 89 -3494 -4

94-4

94-9

36 -19

455

177RG Parts Catalog

FICHE FIGURE FICHE FIGUREFICHE FIGUREPART NUMBER PART NUMBER AND PART NUMBER AND AND

FRAME NO. FRAME NO.

483F-1 38A-8

82 -26

89A-23

84

50 -38

50 -33

38- 9546 -39 1- -lSA 422- SA-72

46A-60 8-6

40- 2 -142 -14A 8-

2 -21 9-412 -21 9-10 -39

2 - 9

2 -31A89A-382 -15

2-62 7-5

456

177RG Parts Catalog

PART NUMBER PART NUMBER AND PART NUMBER AND

NO. FRAME FRAME

5A- 2

5A-44 -38

457

177RG Parts Catalog

PART NUMBER ANDFRAME

78 -36 62 - 7 84A-45

8 -

5 -5 -76

72 -29

7-24-

458

177RG Parts Catalog

FICHE AND FICHE FICHEPART NUMBER PART NUMBER AND PART NUMBER AND ANDFRAME INDEX INDEX INDEX

FRAME NO. FRAME NO. FRAME

1 39-21

39 -16 50 -43

38 -32

79-3

36 -10

31-4 49F-8 704-1 3-2

36-8

36 -4'5 31-3 7 -1 2-12 16-4 .4-4

.66-1 89A-46

459

177RG Parts Catalog

PART NUMBER AND NUMBER PARTNUMBER ANDFRAME NO. FRAME FRAME

58-1

7 56-

460

177RG Parts Catalog

FICHE FIGURE FICHE AND FICHE FANDPART NUMBER AND

FRAM E NO.

461

177RG Parts Catalog

FICHE FIGURE FICHE FIGURE FIGUREPART NUMBER AND PARTNUMBER AND AND AND

FRAME FRAME NO.FRAME N

7

#1

4002-2 45-7

4000-4000- 46-94 4065- -5

7140

-26 4067-

-96 4067-4001-19 47-28 4068- 45-374001-

462


PART NUMBER AND

FRAME FRAME FRAME INDEX

NO. NO. NO.

463

177RG Parts Catalog

FICHE FIGURE FIGURE FICHE ANDPART NUMBER AND

FRAME FRAME FRAME NO. NO.

4 -71 5 -42 3- 691722002-

4 -65 5 -10

7 -7 - 2 4 -347 - 4 -34

7 -15 4 -79 79A-1

5 - 3 4 -80

#1 5A-285 -2#1

#1 5A-28

5 -79 5A-56

5 -37 7 - 9

5-47 7 -10 -35

464

177RG Parts Catalog

FICHE FIGURE FICHE FIGURE FICHE FIGUREPART NUMBER PART NUMBER AND PART NUMBER AND PART NUMBER

FRAME NO. FRAME INDEX FRAMENO. NO. NO.

-53 75

38-3

465

177RG Parts Catalog

AND ANDPART NUMBER ANDFRAME FRAME FRAME

79A-10 .0-95 79-13

79A-11

79 -55 0-99 79A-66

37 79-51-37 79A-16

79-76

79 -7079 -6279 -6379 -68

53

--

-

-79A-6379A-59

79A-1379A-1479A-16A79A-2079A-21

79A-3057 -35

70 79A-31 5-4 #2 3 -13 -57

79A-3479A-22

466

177RG Parts Catalog

1

222

-

2

467

177RG Parts CatalogFIGURE FICHE

PART NUMBER AND PART AND AND NUMBER ANDFRAME INDEX FRAMENO. NO.

- 7 -36 17 -26 -35

10

3

-19

468468

177RG Parts Catalog

PART NUMBER AND PART NUMBER AND INDEX PART NUMBER AND ANDFRAME INDEX FRAME FRAMENO. NO. NO.

64-13

17-8664 -13

17 -74

64A-27 49D-1

64 -18 - 64B-2364A-27648-3864B-38

64B-4264B-42

15 -52

64A-3115 -5115A-5664-43

469

177RG Parts Catalog

PART NUMBER AND PART NUMBER AND PARTNUMBER ANDFRAME INDEX FRAME FRAME INDEX

2

2

# 48A-14

<

5- <43-27 27 -1

-54 -

470

177RG Parts Catalog

FIGURE FICHE FIGURE FICHE FIGURE

FRAME NO. FRAME FRAME

5

5A- 85 -615A-69

79-7279-7

7

34 -18

471

177RG Parts Catalog

PART NU INDEXFRAME FRAME

54-3054A-31

54-15

54A-1 -3761-6061A-59

54A-2054-21 -22

54 -32

54-2654A-27

54 -27

37 -2154 -43A

54A-4554A-43C54 -4454 -4654A-4754 -3854A-3954- 2060004-1 -1854 -45

54 -36

.

2

54-33

54A-3554 -2454 -3954A-40 17 -4357 -43A57 -4357 -44

-4 57 -44E37 -2256-1291-1291 -1154 -23A

472

177RG Parts Catalog

FIGURE ANDPART NUMBER PART NUMBERQ PARTNUMBER NUMBER AND

FRAME INDEX FRAMENO. NO. NO.

75 -13

767

7

59A-5 84-

6666 - 85-1

83A-91 83A-7428 -11 83A-91 83A-74

17 -49 86 -26 83B-80

473

177RG Parts Catalog

PART NUMBER AND PARTNUMBER ANDPART NUMBER AND ANDFRAME

83- 7

5 83-33

51

83E-15 218547 59A- 4 4509 91 -21-83-38 22FH632 67 - 8 4591 91 -2183B-6683B-63 2646-002449C-64 4600-2 5A-3783C-68 49 -59B 4708 3 -15A

71 83B-5972 83B-52

-73 83E-1883 -3283A-2883B-27 3246-050 59A-35 55083 -15 330 49 -70A 5579654 62-483A-23 330 49A-88 576.. - 583B-31 330 49B-82 579. 1-683C-54 330 51A- 2 6DC- 20 -2583G-13 34002-55 89A-45

83C-35 59A-31 89 -42

83G-11 1-46 602EN683G-12 3690-12 1 -4 6023249B-89

83C-22 37570-001 49 -47 61098 58 -1483C-3383C-53

836-483C-7483C-3083C-7283C-83C-6983C-65 49 -45

474

177RG Parts Catalog

PART NUMBER AND PART NUMBER AND AND PART NUMBER AND ANDFRAME INDEX FRAME INDEX FRAME INDEX

NO. NO. NO.

83A-53

49 -58849A-66 84A 849B-61 83 -4449 -618 84-146246-

49 -59A 88E-1349A-68

62-2

62 - 66622466224 58

6879268972 58 -

7-0170072053 #1 59A-72053 #3 59-72970 58 -1673937 58 - 1073937 58-74151 58-74151 5874904 62 - 975279 58 -1275279 58 -29755288 62-875896 58 - 175897 58- 176211 58 - 776462-1 #5 49 -58876462-1 #7 49A-6676906 89-576906 89A- 576917 58 - 678TA-0 53 -4478292 58-2

-094-37.5 81 -4-6 67 -11

811811542 #6 49A-66

57 -2049 -72

9851

9851 -

-4 4

475/476 blank

Date post:	02-Dec-2014
Category:	Documents
Upload:	wwdean
View:	1,350 times
Download:	249 times

Parts Cat 177RG 1971-1978

Documents