of 12
8/13/2019 PCPL-0532-4-407-04-08-1
1/12
DOCUMENT No
PCPL-0532-4-407-04-08-1
MV SWITCHGEAR
DATA SHEET
SECTION - 4
PAGE: 1 of 12
DATA SHEET-A1
SWITCHGEAR & BUS BAR RATING
1. Rated Voltage, Phases & Frequency 415V, 3Ph, 4Wire, 50 H.
!. "yste# $eutral %arthing %''ecti(ely )
$on e''ecti(ely
%''ecti(ely earthed
3. *a+i#u# "yste# Voltage 45.5 V
4. -ne #inute Poer Frequency Voltagea/ Poer ircuits
/ ontrol ircuitsc/ 2u+. ircuits connected to sec. o' s
!500 V
1500 V!000 V
5. ontinuous urrent Rating o' us ars under "ite re'erence 2#ient
e#erature
"ee us ar details
. Re'erence 2#ient e#erature 45
-
6. *a+i#u# e#erature o' usars, droers & contacts at continuouscurrent rating under site re'erence a#ient e#. 75-
7. "hort circuit ithstand 'or usars & 8roers
a/ "hort i#e 91 sec./ at 415V. :2 9r#s/
/ 8yna#ic Rating :2 9P%2;/
501!5
8/13/2019 PCPL-0532-4-407-04-08-1
2/12
DOCUMENT No
PCPL-0532-4-407-04-08-1
MV SWITCHGEAR
DATA SHEET
SECTION - 4
PAGE: 2 of 12
SWITCHGEAR CONSTRUCTIONAL RE6UIREMENTS
1 hic:ness o' "heet "teel old Rolled Fra#e !## , 8oors 1. ##, o(ers1. ##
Hot Rolled Fra#e, 8oors, o(ers !.5 ##
! 8egree o' rotection as er C" 138/
7 ye o' oerating #anual, sring assisted
#echanis# #anual, sring charged Ees
#otor oerated sring assisted Ees
rea:er -eration ounter Ees
*echanical "ring harged Cndicator Ees
< ;ey interloc:ing required Ees)$o Ees
10 "hunt ri required Ees)$o Ees
11 Protection required
a/ Relays ) "eries releases
*icrorocessor ased o(erload, short
circuit and earth 'ault releases ithadustale current & ti#e delay settingsith sel' diagnostic & ro(ision 'or
addition o' co##unication 'eature
/ Release ye & "ettings oth current & ti#e (ariale
c/ @nder (oltage release required Ees) $o Ees
"etting 60G ith ti#e delay.
1! *ini#u# $o. o' 2u+iliary contacts 9"P2R%/ !$- !$
13 ontrol Voltage
a/ For oerating #otor/ For closing ) triing
110V, 230V 8
DATE: 22-0-200
ISSUE No: P0
8/13/2019 PCPL-0532-4-407-04-08-1
3/12
DOCUMENT No
PCPL-0532-4-407-04-08-1
MV SWITCHGEAR
DATA SHEET
SECTION - 4
PAGE: 3 of 12
c/ For Cndication 30V 8)110V 2
14 %#ergency #anual oeration required in addition to electrical
oerating de(ices
a/ For sring charging & closing Ees)$o
/ For triing Ees)$o
Ees
Ees15 2nnunciator required Ees)$o Ees
1 "tandards alicale 2s er 8ata "heet = 2!
MCC'
1. *oulded case circuit rea:ers to e ro(ided
a/ For *otor ontrol ircuits Ees)$o
/ For other circuits Ees)$o
Ees
Ees9Poer/
!. Voltage 'requency & $o. o' Phases 415V, 50H, 3I
3. Rated -erating duty ontinuous
4. Rated rea:ing caacity :29r#s at 415 V, 0.!5 PF/ 50:2
5. Rated #a:ing current :29P%2;/ 1!5:2
ye o' oerating *anual Ees
#echanis# *otor oerated Ees6. Rated current at site re'. a#ient te#erature "$ %$+ *%&"$#. Re'er ">8
7. -n )-'' -eration *anualRe#ote oered oerated
EesEes
8/13/2019 PCPL-0532-4-407-04-08-1
4/12
DOCUMENT No
PCPL-0532-4-407-04-08-1
MV SWITCHGEAR
DATA SHEET
SECTION - 4
PAGE: 4 of 12
a/ For oerating #otor
/ For closing ) triingc/ For Cndication & ontrol
$2
$2
110V 2
13. -n )-'' -eration *anual ith rotary handle Ees
14. "tandards alicale
M9C9'
1. *iniature circuit rea:ers to e ro(ided
a/ For *otor ontrol ircuits Ees)$o/ For -ther circuits Ees)$o
$-E%" = 'or lighting & control circuits
!. Voltage 'requency & $o. o' Phases 30V 8,110 V 2 and !40V, 50 H,
"ingle Phase
3. Rated oerating duty 2s er C" & C%
4. Rated rea:ing caacity 9r#s at 415 V, 0.!5 PF/ 10:2
5. Rated current at site re'. a#ient te#erature 2s er circuit require#ents
. riing characteristic cur(e 'ora/ For >ighting & s#all oer alication
/ For @P" Poer alicationc/ For 8 alication
ur(e
8 ur(e8 ur(e 98 */
6. Positi(e "itch -erated Cndication Required
7. "itching J- cycles 9#ini#u#/ !0000
8
5. %arth lea:age sensiti(ity 30#2
. "tandards alicale 2s er data sheet J2!
ELC'
1 %> to e ro(ided
a/ For V "econdary Ees)$o $o
!. Voltage 'requency, $o. o' Phases, Poles !40)415V, 50H, 1I) 3I, !)4W
3. Rated oerating duty 2s er C"
4. Rated current at site re'. a#ient te#erature Re'er ">8
5. %arth lea:age sensiti(ity 30#2
DATE: 22-0-200
ISSUE No: P0
8/13/2019 PCPL-0532-4-407-04-08-1
5/12
DOCUMENT No
PCPL-0532-4-407-04-08-1
MV SWITCHGEAR
DATA SHEET
SECTION - 4
PAGE: 5 of 12
. "tandards alicale 2s er 8ata "heet = 2!
ESSENTIAL SPARES
8%"RCPC-$ %""%$C2> "P2R%" - % F@R$C"H%8
a/ o#lete rea:er ith oerating #echanis# and releases
here seci'iedi/ 3!002 2
ii/ 1!502 2iii/ 7002 2
i(/ 302 *
/ losing & triing coils
c/ -erating #otors
d/ 2u+iliary contact loc:s
e/ *o(ing au+iliary contact loc:s
'/ rea:er control sitches
g/ "er(ice selector sitches
h/ Cndicating >a#s ith series Resistors
i/ Redii/ ?reen
iii/ 2#er
i(/ lue(/ White
/ Voltage rans'or#ers
i/ 415 ) 110, > 1
l/ *Bs 'or control circuits
DATE: 22-0-200
ISSUE No: P0
8/13/2019 PCPL-0532-4-407-04-08-1
6/12
DOCUMENT No
PCPL-0532-4-407-04-08-1
MV SWITCHGEAR
DATA SHEET
SECTION - 4
PAGE: of 12
DATA SHEET-A2
APPLICA'LE STANDARDS
01 "itchgear general require#ents, contactors, #otor
starters, 8isconnectors, sitches IS : 13947
0! 2 circuit rea:ers C" 13
8/13/2019 PCPL-0532-4-407-04-08-1
7/12
DOCUMENT No
PCPL-0532-4-407-04-08-1
MV SWITCHGEAR
DATA SHEET
SECTION - 4
PAGE: 7 of 12
DATA SHEET-A3
1.0 8esignation 8? P 3.0 us duct required Ees
!.0 us ar 3.1 ontinuous rating !500 2
!.1 "hort circuit
rating
50:2 3.! %ntry o)otto# o
!.! ontinuous rating 3!002 3.3 >ength JJJ
!.3 *aterial92>)@/ 2> 4.0 "itchgear short
circuit rating
50:2
!.4 P ) PJ$ P$
Feeder
$o. Feeder
designation
ircuit rating
*od
ulety5eurrent ratings in 2#s
0
3ratio ale sie Re#ar:s
:W 2
204
*00
4
*
04
1 8?1Cnco#er
!315 3!00 !500)1 !5002 J$onsegregated us
duct
! FeederJ1 to
$""
!315 3!00 !500)1 i/ < $os. 3
400 "q.## 'orhase
ii/ ! $os. 3400 "q.## 'or
neutral.
3 "are 30 30 00)1 ! $os o' 3400 "q.##
4 us ouler !315 8 3!00
5 8?!
Cnco#er
!315 3!00 !500)1 !5002 J$on
segregated usduct
FeederJ! to
$""
!315 3!00 !500)1 i/ < $os. 3
400 "q.## 'or
haseii/ ! $os. 3
400 "q.## 'or
neutral.
6 Feeder to
8?J *
30 30 00)1 ! $os o' 3
400 "q.##
DATE: 22-0-200
ISSUE No: P0
8/13/2019 PCPL-0532-4-407-04-08-1
8/12
DOCUMENT No
PCPL-0532-4-407-04-08-1
MV SWITCHGEAR
DATA SHEET
SECTION - 4
PAGE: 8 of 12
DATA SHEET A4
1.0 8esignation 8? * 3.0 us duct required $o
!.0 us ar Ees 3.1 ontinuous rating JJJJJJ!.1 "hort circuit
rating
50 :2 3.! %ntry o)otto# JJJJJJJ
!.! ontinuous rating 30 2 3.3 >ength JJJJJJ
!.3 *aterial92>)@/ 2> 4.0 "itchgear short
circuit rating
JJJJJJ
!.4 P ) PJ$ P$
Feeder
$o. Feeder
designation
ircuit
rating
*odulety5e urrent ratings in
2#s
03ratio ale sie Re#a
r:s
:W 2
204
*004
*04
1 Cnco#er 'ro#
8? P
K K 2
K
302
P
K K K K
! Cnco#er 'ro#$"" 415V us
K K 2 K 302P
K K K K
3 Fuel oil trans'eru# L 1
K K 8 K K K K K K
4 Fuel oil trans'eru#J L !
K K 8 K K K K K K
5 ooling toer
'an L1
K K 8 K K K K K K
ooling toer'an L!
K K 8 K K K K K K
6 ooling toer'anJL3
K K 8 K K K K K K
7 ooling toer'anJL4
K K 8 K K K K K K
< "oc:et outlet
'eeder
K K K K K K K K
10 ooling ater
u#JL1
K K 8 K K K K K K
11 ooling ater
u#JL!
K K 8 K K K K K K
1! ooling ateru#JL3
K K 8 K K K K K K
13 ooling ateru#JL4
K K 8 K K K K K K
14 "P2R% K K 8 K K K K K K
15 "P2R% K K 8 K K K K K K
2ll (alues #ar:ed y K shall e 'urnished y idder
DATE: 22-0-200
ISSUE No: P0
8/13/2019 PCPL-0532-4-407-04-08-1
9/12
DOCUMENT No
PCPL-0532-4-407-04-08-1
MV SWITCHGEAR
DATA SHEET
SECTION - 4
PAGE: < of 12
DATA SHEET = '$ote to idders his data sheet shall e 'illed u -*P>%%>E and returned along ith the id.
S+9
No9I& U$"& BIDDER
1.0 "P%CFC P2RC@>2R"
1.1 "itchgear designations
1.! "ingle 'ront or doule 'ront "F)8F
1.3 *odular construction Ees)$o
1.4 Fully dra out)se#i dra out)Fi+ed F8) "8
1.5 otal di#ensions o' each co#lete sitchgear H + W + 8 H
W
8
1. a/ Width o' each (ertical section ith cale alley ##
/ Width o' cale alley only ##
1.6 usar continuous rating under site conditions 2
1.7Ha(e all the 'eeders and co#onents seci'ied in enclosed
draings and 8ata "heet 2J3 een ro(idedMEes)$o
!.0 ?%$%R2> P2RC@>2R"
!.1
"heet "teel
a/ old rolled)Hot rolled
/ hic:ness
i/ Fra#e ##
ii/ 8oor ##
ii/ Rear co(er ##
i(/ "ide and to co(ers ##
(/ Panel artitions ##
!.!Has the sheet #etal een treated in accordance ith theseci'ication
Ees)$o
!.3 "hort ti#e rating 91Jsec./ :29r#s/
!.4 *o#entary rating :29ea:/
!.5
-ne #inute oer 'requency ithstand (oltage
a/ *ain circuit V
/ ontrol circuit V
c/ 2u+. circuits connected to s) Ps V
!.8egree o' rotection ro(ided y the enclosure 9as er
C"!146/
!.6 %arth usar sie ##!
!.7@"2R"
a/ *aterial o' usars
/ "ection ##!
c/ ontinuous current rating under site conditions 2
d/ Whether usars ha(e een insulated Ees) $o
e/ ye o' insulation
'/ e#erature rise o(er the re'erence a#ient hen
carrying rated current0
g/ *aterial o' usar suorts
h/ learance in air
DATE: 22-0-200
ISSUE No: P0
8/13/2019 PCPL-0532-4-407-04-08-1
10/12
DOCUMENT No
PCPL-0532-4-407-04-08-1
MV SWITCHGEAR
DATA SHEET
SECTION - 4
PAGE: 10 of 12
S+9
No9I& U$"& BIDDER
i/ eteen hases ##
ii/ eteen hases and earth ##
i/ "hort ti#e rating 9-ne sec./ :2 / *o#entary rating 9ea:/ :2
3.0 AC'
3.1 *a:erBs na#e
3.! *a:erBs tye designation
3.3 2licale standards
3.4 Rated (oltage V
3.5 Rated oerating duty
3. Rated current 2
3.6 8erating 'actor 'or oeration under site conditions
3.7
Rated sy##etrical rea:ing current at rated (oltage
9Cndicate oer 'actor/:2
P.F.
3.< Rated ea: #a:ing current :2
3.10Rated short ti#e ithstand rating 9'or 1 sec./ 9For *,
C88%R to indicate the ti#e/:2
3.11
*a+i#u# te#erature rise o' the #ain contacts hen thecircuit rea:er is carrying continuous current 9as derated
'or oeration under site conditions and inJanelinstallation/ o(er re'erence a#ient te#erature
8eg. cent.
3.1! -erating #echanis# tye
3.13
>i#its o' (oltage 'or satis'actory oeration o' the 'olloing
de(ices as a G o' nor#al (oltage
i/ -erating #echanis# G
ii/ losing coil G
iii/ ri coil G
3.14
Poer required 'or closing at
i/ $or#al (oltage W
ii/ 70G nor#al (oltage W
3.15
Poer required 'or triing at
i/ $or#al (oltage W
ii/ 60G nor#al (oltage W
3.1
"ring charging #otor details
i/ Rating :W
ii/ Rated (oltage V, 2)8 iii/ "ring charging ti#e "ec.
3.16
$u#er o' oenings the circuit rea:er is caale o'
er'or#ing ithout insection, relace#ent o' contacts orother arts at 100G rated rea:ing current
3.17 -(erload release ro(ided Ees)$o
3.1< "hort circuit release settings and ti#e delay 'eatures
3.!0 @nder (oltage release settings
3.!1Ha(e electrical & #echanical antiJu#ing 'eatures eenro(idedM
Ees)$o
3.!! Ha(e tye test certi'icates een enclosedM Ees) $o
DATE: 22-0-200
ISSUE No: P0
8/13/2019 PCPL-0532-4-407-04-08-1
11/12
DOCUMENT No
PCPL-0532-4-407-04-08-1
MV SWITCHGEAR
DATA SHEET
SECTION - 4
PAGE: 11 of 12
S+9
No9I& U$"& BIDDER
C' $o, 'urnish ye test certi'icate $os. & test dates.
4.0 MCC'
4.1 *a:erBs na#e4.! *a:erBs tye designation
4.3 2licale standards
4.4 Rated (oltage V
4.5 Rated oerating duty
4. Rated current 2
4.6 8erating 'actor 'or oeration under site conditions
4.7
Rated sy##etrical rea:ing current at rated (oltage9Cndicate oer 'actor/
:2
P.F.
4.< Rated ea: #a:ing current :2
4.10
Rated short ti#e ithstand rating 9'or 1 sec./ 9For *,
C88%R to indicate the ti#e/ :2
4.11
*a+i#u# te#erature rise o' the #ain contacts hen the
* is carrying continuous current 9as derated 'oroeration under site conditions and inJanel installation/
o(er re'erence a#ient te#erature8eg. cent.
4.1! -erating #echanis# tye
4.13 "hort circuit release settings and ti#e delay 'eatures
4.14Ha(e electrical & #echanical antiJu#ing 'eatures eenro(idedM
Ees) $o
4.15 Ha(e tye test certi'icates een enclosed Ees) $o
5.0 MC'
5.1 *a:erBs na#e
5.! *a:erBs tye designation
5.3 2licale standards
5.4 Rated (oltage V
5.5 Rated oerating duty
5. Rated current 2
5.6 8erating 'actor 'or oeration under site conditions
5.7
Rated sy##etrical rea:ing current at rated (oltage
9Cndicate oer 'actor/:2
P.F.
5.< Rated ea: #a:ing current :2
5.10Rated short ti#e ithstand rating 9'or 1 sec./ 9For *,
C88%R to indicate the ti#e/
:2
5.11
*a+i#u# te#erature rise o' the #ain contacts hen thecircuit rea:er is carrying continuous current 9as deJrated
'or oeration under site conditions and inJanelinstallation/ o(er re'erence a#ient te#erature
8eg. cent.
90 ELC'
.1 *a:erBs na#e
.! *a:erBs tye designation
.3 2licale standards
.4 Rated (oltage V
DATE: 22-0-200
ISSUE No: P0
8/13/2019 PCPL-0532-4-407-04-08-1
12/12
DOCUMENT No
PCPL-0532-4-407-04-08-1
MV SWITCHGEAR
DATA SHEET
SECTION - 4
PAGE: 12 of 12
S+9
No9I& U$"& BIDDER
.5 Rated oerating duty
. Rated current 2
.6 8eJrating 'actor 'or oeration under site conditions..7 Rated sy##etrical rea:ing current at rated (oltage :2
9Cndicate oer 'actor/ P.F.
.< Rated ea: #a:ing current :2
.10 Rated short ti#e ithstand rating 9'or 1 sec./ 9For *,
C88%R to indicate the ti#e/
:2
.11 *a+i#u# te#erature rise o' the #ain contacts hen thecircuit rea:er is carrying continuous current 9as derated
'or oeration under site conditions/ o(er re'erence a#ientte#erature
deg. cent.
790 RC'O
6.1 *a:erBs na#e
6.! *a:erBs tye designation
6.3 2licale standards
6.4 Rated (oltage V
6.5 Rated oerating duty
6. Rated current 2
6.6 8eJrating 'actor 'or oeration under site conditions.
6.7 Rated sy##etrical rea:ing current at rated (oltage :2
9Cndicate oer 'actor/
P.F.
6.< Rated ea: #a:ing current :2
6.10 Rated short ti#e ithstand rating 9'or 1 sec./ :2
6.11 *a+i#u# te#erature rise o' the #ain contacts hen thecircuit rea:er is carrying continuous current 9as derated'or oeration under site conditions/ o(er re'erence a#ient
te#erature
deg. cent.
DATE: 22-0-200
ISSUE No: P0
