+ All Categories
Home > Documents > Pemasangan Sistem Pemipaan Air Bersih

Pemasangan Sistem Pemipaan Air Bersih

Date post: 26-Mar-2015
Category:
Upload: gus-andrian
View: 210 times
Download: 4 times
Share this document with a friend
32
ENGINEERING PLUMBING AND SANITATION Application of Plumbing System Of Clean Water
Transcript
Page 1: Pemasangan Sistem Pemipaan Air Bersih

ENGINEERING PLUMBING AND SANITATION

Application of Plumbing System Of Clean Water

Page 2: Pemasangan Sistem Pemipaan Air Bersih

System of Clean Water

Purpose Of Common Instructional :

1. After this Lesson solvent and understands in explaining system division of clean water .

Teknologi dan Rekayasa

Page 3: Pemasangan Sistem Pemipaan Air Bersih

Purpose Of Special Instructional Student can mention :

1. Direct joint system 2. Indirect joint system 3. Advantage and disadvantage of

one of system

Teknologi dan Rekayasa

Page 4: Pemasangan Sistem Pemipaan Air Bersih

Teknologi dan Rekayasa

Installation of Clean Water Pipe

To get safe installation there are some thing that need to be paid attention :

1. Material is not corrosion easy to

2. Pipe through wall must be given canopy

3. Applycation of pipe must be diametrical

Page 5: Pemasangan Sistem Pemipaan Air Bersih

Teknologi dan Rekayasa

4.Utilizes fitting for transformation of direction and transformation of diameter

5.Exactly in determination of pipe diameter

6.For vertical pipe labored straight to the above of from basis

7.Every floor gives one crane stops8.After meter water is attached [by]

crane which can prevent reverse flow

Page 6: Pemasangan Sistem Pemipaan Air Bersih

Teknologi dan Rekayasa

Example : Installation Scheme of Pipe in building

1. Principal pipe2. Housing joint3. Meter water4. Distributor pipe5. Supply pipe of clean water6. Vertical pipe7. Branch pipe for equipments sanitary

Page 7: Pemasangan Sistem Pemipaan Air Bersih

Correct installation :

Teknologi dan Rekayasa

In important installation again was all valves or crane attached at one particular installation didn't cause or can generate reverse flow and exploitation to return if there are

transformation of water pressure in installation.

Page 8: Pemasangan Sistem Pemipaan Air Bersih

1. Direct joint system

This system especially applied for low and small housing

And Example :

a. Shut off valve in plot of land

b. Shut off valve below(under road street)

physical plant.

Teknologi dan Rekayasa

Page 9: Pemasangan Sistem Pemipaan Air Bersih

Teknologi dan Rekayasa

a. Shut off valve in plot of land

Page 10: Pemasangan Sistem Pemipaan Air Bersih

Teknologi dan Rekayasa

b. Shut off valve below(under road street) physical plant.

Page 11: Pemasangan Sistem Pemipaan Air Bersih

2. Indirect joint system :

In this system, distribution pipe within doors indirectly is attributed to principal pipe of supply of cleanness water.

Water is accomodated in advance in the tank then is flown / pumped to be distributed in building for requirement of cleanness water would.

Teknologi dan Rekayasa

Page 12: Pemasangan Sistem Pemipaan Air Bersih

2.1. Roof tank system :

At this system, water is accomodated in advance in the tank under (attached to low floor of building or below(under ground face), then is pumped to an usual upper tank is attached above roof or above highest floor of building.

Teknologi dan Rekayasa

Page 13: Pemasangan Sistem Pemipaan Air Bersih

Teknologi dan Rekayasa

Drawing :System with roof tank

Page 14: Pemasangan Sistem Pemipaan Air Bersih

Compress tank system drawing

Teknologi dan Rekayasa

Page 15: Pemasangan Sistem Pemipaan Air Bersih

Application of Subterranean Pipe

Purpose Of Common Instructional :

1. After this Lesson solvent student and understands way of applications of pipe in ground.

Teknologi dan Rekayasa

Page 16: Pemasangan Sistem Pemipaan Air Bersih

Purpose Of Special Instructional Student can mention :

1. Dig aperture height 2. Way of putting down pipe in dig 3. Detention of pipe from at

dividing valve ( for big diameter ) 4. Pipe test

Teknologi dan Rekayasa

Page 17: Pemasangan Sistem Pemipaan Air Bersih

Applications of subterranean pipe

Teknologi dan Rekayasa

4 important factor of Applications subterranean pipe :

1.Dig aperture height

Page 18: Pemasangan Sistem Pemipaan Air Bersih

Teknologi dan Rekayasa

Page 19: Pemasangan Sistem Pemipaan Air Bersih

2. Situation of Pipe

Teknologi dan Rekayasa

Page 20: Pemasangan Sistem Pemipaan Air Bersih

Explanation

A. Situation of Correct pipe because :

Pipe exactly ground anvil.

Easy to checking of joint before landfill with ground

Teknologi dan Rekayasa

Page 21: Pemasangan Sistem Pemipaan Air Bersih

B. situation of Not accurate pipe because.

Ground anvil pipe only in each joint

Cannot guarantee lineation of pipe

If there are dividing valve from the top (of), very possibly pipe earns break

Teknologi dan Rekayasa

Page 22: Pemasangan Sistem Pemipaan Air Bersih

C. Situation of Pipe that is not true because : Equiamplitude surface of ground scraggly Pipe support above land not

regular Possibility to change / peripatetic

when landfill [by] ground or receives payload from the top monstrous.

Teknologi dan Rekayasa

Page 23: Pemasangan Sistem Pemipaan Air Bersih

A.Turns pipe

Teknologi dan Rekayasa

Joint that need to be given retainer :

Page 24: Pemasangan Sistem Pemipaan Air Bersih

B. Joint Knie 90

Teknologi dan Rekayasa

Page 25: Pemasangan Sistem Pemipaan Air Bersih

C. Tee Joint

Teknologi dan Rekayasa

Page 26: Pemasangan Sistem Pemipaan Air Bersih

D.Pipe connection final_

Teknologi dan Rekayasa

Page 27: Pemasangan Sistem Pemipaan Air Bersih

4 . Test pipe :

Step of putting down pipe :

a. Ground dug and in dig basis has plane equiamplitude surface.

b. Equiamplitude surface of dig has certain dip

Teknologi dan Rekayasa

Page 28: Pemasangan Sistem Pemipaan Air Bersih

c. Given sand as thick 10 cm

d. Pipe is put down, tied on correctness

e. Put down as according to above mentioned drawing.

Teknologi dan Rekayasa

Page 29: Pemasangan Sistem Pemipaan Air Bersih

Step of pipe test :

a. In check before hand every joint

b. By the end of pipe network is closed

Teknologi dan Rekayasa

Page 30: Pemasangan Sistem Pemipaan Air Bersih

c. At the end of pipe network attributed to pump

d. Depressed until pipe dividing valve permitted

e. Emphasis within 15 second/ 100 m. Pipe length.

Teknologi dan Rekayasa

Page 31: Pemasangan Sistem Pemipaan Air Bersih

Pipe test scheme

Teknologi dan Rekayasa

Page 32: Pemasangan Sistem Pemipaan Air Bersih

THE END

Teknologi dan Rekayasa


Recommended