Type 1J Type description Golf MY 2002 Engine ID ALH Gearbox EGR Kilometer reading Radio/Navigation System (RNS) with multi-function display (MFD) and TV Warning! Before working on the electrical system disconnect the battery earth strap. Notes: u When faced with complaints it is absolutely necessary to know the functions and how to operate the radio/navigation system. u Additional information => Operating instructions => Self-study programme No. 199 u The anti-theft coding is a fixed code. => Operating instructions u When retrofitting, repairing or fault finding => Self-diagnosis => Current flow diagrams, Electrical fault finding and Fitting locations => Installation instructions u When the battery is reconnected, check operation of electrical equipment (radio, clock and convenience electrics etc.) according to Workshop Manual or Owner's Manual. Job number 900018 Chassis number Registration number User M Date 15/03/2002 Workshop Manual - 1 -
Transcript
Type1J
Type descriptionGolf
MY2002
Engine IDALH
GearboxEGR
Kilometer reading
Radio/Navigation System (RNS) with multi-function display (MFD) and TV
Warning!Before working on the electrical system disconnect the battery earth strap.
Notes: u When faced with complaints it is absolutely necessary to know the functions and how to operate the radio/navigation system. u Additional information => Operating instructions => Self-study programme No. 199 u The anti-theft coding is a fixed code. => Operating instructions u When retrofitting, repairing or fault finding => Self-diagnosis => Current flow diagrams, Electrical fault finding and Fitting locations => Installation instructions u When the battery is reconnected, check operation of electrical equipment (radio, clock and convenience electrics etc.) according to Workshop Manual or Owner's Manual.
Job number900018
Chassis number Registration number UserM
Date15/03/2002
Workshop Manual - 1 -
Type1J
Type descriptionGolf
MY2002
Engine IDALH
GearboxEGR
Kilometer reading
General description The radio/navigation system (RNS) combines the functions of a navigation system with that of a high quality RDS car radio. Vehicles 05.00 >, a radio/navigation system is installed which includes a traffic information control unit. Apart from this the RNS unit 05.00 > differs from the RNS unit > 04.00 in the following ways: u On the top left of the unit front is the designation "Radio Navigation System", on an RNS unit 05.00 > "MFD" is additionally included. u There is also an additional aerial connection on the back of the unit. The units > 04.00 and 05.00 > are not interchangeable with one another. Installed in the systems double DIN housing are u a RDS radio receiver u a 5-inch liquid crystal colour display u a navigation system with GPS satellite receiver u a CD-ROM drive for the navigation system.
u A TV tuner is available as optional equipment for vehicles 01.01> with a radio/navigation system. The television function is an extended function of the navigation device. The device can receive all terrestrial programmes, that is, all programmes which can be received using a normal aerial, not via satellite.
Job number900018
Chassis number Registration number UserM
Date15/03/2002
Workshop Manual - 1 -
Type1J
Type descriptionGolf
MY2002
Engine IDALH
GearboxEGR
Kilometer reading
The device recognises all current broadcasting standards such as PAL, NTSC or Secam. The television picture is blacked out when the vehicle is in motion but the sound remains. A connector on the housing connects the radio, telephone and navigation operation aerial with the navigation system. Connections are provided to extend the radio functions for a 6 disc magazine CD changer and for a DSP sound system. Fault finding The radio/navigation system is equipped with self-diagnosis. To find faults, perform self-diagnosis with the vehicle diagnosis, testing and information system VAS 5051. => "Guided fault finding" on Vehicle Diagnosis, Testing and Information System VAS 5051.
Job number900018
Chassis number Registration number UserM
Date15/03/2002
Workshop Manual - 2 -
Type1J
Type descriptionGolf
MY2002
Engine IDALH
GearboxEGR
Kilometer reading
Connections on radio/navigation system
Job number900018
Chassis number Registration number UserM
Date15/03/2002
Workshop Manual - 1 -
Type1J
Type descriptionGolf
MY2002
Engine IDALH
GearboxEGR
Kilometer reading
1 - Navigation system aerial connection 2 - 26-pin connection for navigation sensors Contact assignment =>Page 91-98. 3 - RGB connection Contact assignment => from Page 91-98. 4 - Multi-pin connections I, II, III Contact assignment => from Page 91-100. 5 - Diversity aerial connection Only fitted on RNS unit 06.00 > This connection is not wired up. 6 - Radio aerial connection
Contact assignment of 26-pin connector for navigation sensors
Job number900018
Chassis number Registration number UserM
Date15/03/2002
Workshop Manual - 2 -
Type1J
Type descriptionGolf
MY2002
Engine IDALH
GearboxEGR
Kilometer reading
ï 26-pin connector 4 -Terminal 15 (ignition) 5 -Speed sensor output, left 6 -Navigation instructions Nf + 13 -CAN bus High 17 -Reversing light switch 18 -Speed sensor output, right 19 -Navigation instructions Nf - 20 -Navigation instructions Nf screen 26 -CAN bus LOW
Chamber assignment of 11-pin connector for RGB connection 1 -NF Earth 2 -NF left 3 -NF right 4 -C synch 5 -Video earth
Job number900018
Chassis number Registration number UserM
Date15/03/2002
Workshop Manual - 3 -
Type1J
Type descriptionGolf
MY2002
Engine IDALH
GearboxEGR
Kilometer reading
6 -PAL/NTSC 7 -Video on 8 -B in 9 -G in 10 -R in 11 -Shield earthMulti-pin connectors I, II, III contact assignment on rear of radio/navigation system Multi-pin connector I, -T20- consists of 3 parts that are marked with different colours:
ïMulti-pin connector I, part 1, yellow 1 -Line Out rear left, LR 2 -Line Out rear right, RR 3 -Line Out, earth 4 -Line Out front left, LF 5 -Line Out front right, RF 6 -Switched positive for sound amplifier Multi-pin connector I, part 2, green 7 -Telephone input signal, TEL+ 8 -Second display, CLOCK
Job number900018
Chassis number Registration number UserM
Date15/03/2002
Workshop Manual - 4 -
Type1J
Type descriptionGolf
MY2002
Engine IDALH
GearboxEGR
Kilometer reading
9 -Second display, DATA 10 -Second display, ENA 11 -Remote control, REM 12 -Telephone input signal, TEL-
ïMulti-pin connector I, part 3, blue 13 -CD changer, DATA IN 14 -CD changer, DATA OUT 15 -CD changer, CLOCK 16 -CD changer, terminal 30 voltage supply (+) 17 -CD changer, control signal 18 -CD changer, left and right channel, earth 19 -CD changer, left channel, CD/L 20 -CD changer, right channel, CD/R
Job number900018
Chassis number Registration number UserM
Date15/03/2002
Workshop Manual - 5 -
Type1J
Type descriptionGolf
MY2002
Engine IDALH
GearboxEGR
Kilometer reading
ïMulti-pin connector II, -T8a-, 8-pin, brown 1 -Loudspeaker + rear right 2 -Loudspeaker - rear right 3 -Loudspeaker + front right 4 -Loudspeaker - front right 5 -Loudspeaker + front left 6 -Loudspeaker - front left 7 -Loudspeaker + rear left 8 -Loudspeaker - rear left
ïMulti-pin connector III, -T8-, 8-pin, black 1 -Gala (volume adaption) 2 -Telephone mute circuit 3 -Self-diagnosis/K wire 4 -Connection for ignition key controlled switching on and off (S contact) 5 -Anti-theft system control signal, SAFE 6 -Illumination (terminal 58b) 7 -Battery + (terminal 30) 8 -Battery - (terminal 31)
Job number900018
Chassis number Registration number UserM
Date15/03/2002
Workshop Manual - 6 -
Type1J
Type descriptionGolf
MY2002
Engine IDALH
GearboxEGR
Kilometer reading
Removing and installing radio/navigation unit
Notes: u The part number for the complete Radio navigation system is printed on a sticker on the radio/ navigation system housing! u If an RNS unit from a vehicle is fitted into a different vehicle, it is essential that the part number of the replacement unit is the same as the unit previously installed. Otherwise faults will occur with the navigation as the turn angle sensor adjustment in the RNS unit will not be compatible for the vehicle.
Special tools, testers, measuring instruments and auxiliary items required u T10057 Release tool
To remove the radio/navigation system, 2 sets of release tool T10057 are required.
Removing: Note:
Job number900018
Chassis number Registration number UserM
Date15/03/2002
Workshop Manual - 1 -
Type1J
Type descriptionGolf
MY2002
Engine IDALH
GearboxEGR
Kilometer reading
u Before removing radio/navigation system, secure code number from the customer. If the radio/ navigation system is renewed, it is essential to activate the anti-theft coding (see operating instructions). The new code number must be given to the customer. u If the radio/navigation system has a TV function, carefully pull out the device to avoid damaging the RGB connection. If the RGB connection is damaged, the wiring connection must be renewed all the way to the TV tuner. Repair of the RGB connector is not possible. Carry out work sequence as follows:
- ï Slide radio release tool T10057 into the release slots -arrows- as shown until they locate.
Top L - top and bottom on left Top R - top and bottom on right
- Pull radio/navigation system out of the dash panel using the grip rings of the release tools. - Release connections and pull off
Job number900018
Chassis number Registration number UserM
Date15/03/2002
Workshop Manual - 2 -
Type1J
Type descriptionGolf
MY2002
Engine IDALH
GearboxEGR
Kilometer reading
Pulling out release tools: - ï Press locking tabs -arrow- and pull release tool out forwards. Installing: - Connect plug to radio/navigation system. - Slide radio/navigation system straight into the dash panel, until it engages in the assembly frame. Note: u When pushing in the RNS device, do not, under any circumstances, press on the display or operating buttons, as this could damage the RNS device. u If the radio/navigation system is renewed, the proper broadcasting standard must be set for television reception. => Operating instructions, radio/navigation system/TV tuner
Job number900018
Chassis number Registration number UserM
Date15/03/2002
Workshop Manual - 3 -
Type1J
Type descriptionGolf
MY2002
Engine IDALH
GearboxEGR
Kilometer reading
Removing and installing traffic information control unit The traffic information control unit -J559- is located on a retainer plate on dash panel mounting to the right, under the passenger's airbag. Removing: - Remove glove box.
- ï Remove left bolt from retainer -arrow-.
Job number900018
Chassis number Registration number UserM
Date15/03/2002
Workshop Manual - 1 -
Type1J
Type descriptionGolf
MY2002
Engine IDALH
GearboxEGR
Kilometer reading
- ï Remove right bolt from retainer -arrow-.
- Release connections for voltage supply and pull off aerial cables -arrows-. - Remove control unit with retainer. - To remove control unit from retainer, push the control unit forward out of the plastic retainer box.Installing: Installation is carried out in the reverse sequence!
Job number900018
Chassis number Registration number UserM
Date15/03/2002
Workshop Manual - 2 -
Type1J
Type descriptionGolf
MY2002
Engine IDALH
GearboxEGR
Kilometer reading
Removing and installing TV tuner The TV tuner (J415) is located on the left in the luggage compartment. Removing:
- Open left-hand flap in luggage compartment. - ï Remove bolts on left-hand side of bracket -arrows-.
Job number900018
Chassis number Registration number UserM
Date15/03/2002
Workshop Manual - 1 -
Type1J
Type descriptionGolf
MY2002
Engine IDALH
GearboxEGR
Kilometer reading
- ï Remove bolts on right-hand side of bracket -arrows- - Release connections for aerials and voltage supply and pull off -arrows-.Installing: Installation is carried out in the reverse sequence! Chamber assignment of 54-pin connector for TV tuner
1 -CAN bus earth 2 -CAN bus low 3 -CAN bus high 4 -Audio earth front 5 -NF right front 6 -Audio earth 7 -NF left front 8 -Audio earth 9 -A/V total screen front 10 -Video screen front
Job number900018
Chassis number Registration number UserM
Date15/03/2002
Workshop Manual - 2 -
Type1J
Type descriptionGolf
MY2002
Engine IDALH
GearboxEGR
Kilometer reading
11 -C synch. front 12 -Video earth 13 -Video B front 14 -Video earth 15 -Video G front 16 -Video earth 17 -Video R front 18 -Video earth
37 -vacant 38 -vacant 39 -vacant 40 -AUX: NF left rear 41 -AUX: NF right rear 42 -AUX: A/V earth rear 43 -AUX: S VHS (Y) rear 44 -AUX: S VHS (C) rear 45 -AUX: CVBS rear 46 -AUX: A/V total screen rear 47 -AUX: NF left front 48 -AUX: NF right front 49 -AUX: A/V earth Front 50 -AUX: S VHS (Y) front 51 -AUX: S VHS (C) front 52 -AUX: CVBS front
Job number900018
Chassis number Registration number UserM
Date15/03/2002
Workshop Manual - 4 -
Type1J
Type descriptionGolf
MY2002
Engine IDALH
GearboxEGR
Kilometer reading
53 -AUX: A/V total screen front 54 -vacant
Job number900018
Chassis number Registration number UserM
Date15/03/2002
Workshop Manual - 5 -
Type1J
Type descriptionGolf
MY2002
Engine IDALH
GearboxEGR
Kilometer reading
Removing and installing TV aerial amplifier
The four aerials (R55, R56, R57 and R58) for TV reception are integrated in the rear window of the Golf. Each aerial has its own amplifier. The amplifiers (R82, R83, R84 and R85) are built into the tailgate/boot lid of the Golf. Removing: Remove tailgate trim.
- Pull off aerial amplifier connectors. - Separate connector in wire between aerial amplifier and rear window, being especially careful, as the wire and the connector are very sensitive to mechanical stress.In the event of damage to the wiring connection between aerial amplifier and rear window, the rear window must be renewed. It is not possible to repair the wiring connection. - Remove aerial amplifier. If several aerial amplifiers must be removed, be sure to mark the fitting position of individual amplifiers. Installing: When installing, ensure that the amplifiers are fitted in the same positions from which they were removed. Installation is carried out in the reverse sequence!
Job number900018
Chassis number Registration number UserM
Date15/03/2002
Workshop Manual - 1 -
Type1J
Type descriptionGolf
MY2002
Engine IDALH
GearboxEGR
Kilometer reading
Checking function of individual TV aerial amplifiers
Note: The test possibilities below describe only a simple test of the television system and are no substitute for testing with the vehicle diagnosis, testing and information system VAS 5051. You can have the performance of the individual TV aerials displayed on the television screen. Starting this function checks the basic functionality of the television system at the same time. The test screen is enabled in the following manner: - Switch on television mode and find a broadcaster with a strong signal. => Operating instructions - The test screen is activated by the simultaneous pressing of the "AS" button and the button with a clef symbol.
Job number900018
Chassis number Registration number UserM
Date15/03/2002
Workshop Manual - 1 -
Type1J
Type descriptionGolf
MY2002
Engine IDALH
GearboxEGR
Kilometer reading
Screen display: ANT 1 = TV aerial 1 -R55- with ON and OFF function ANT 2 = TV aerial 2 TV -R56- with ON and OFF function ANT 3 = TV aerial 3 TV -R57- with ON and OFF function ANT 4 = TV aerial 4 TV -R58- with ON and OFF function Note:
- The voltage supply of the respective TV aerial amplifier can be switched on or off using the right rotary control. When the voltage supply is switched off, the picture quality must become significantly worse. - Leave the menu by pressing the "Return" button. Possible tests: u The ability to switch the voltage supply of each aerial amplifier on and off makes it possible to draw a conclusion about the function of the respective aerial amplifier. u The operation of the TV tuner via the RNS partially tests the hardware and software of the CAN bus. u By readying the television system for operation, selecting a programme and selecting videotext, the most important functions of the television receiver have been used and the audio-video connection has been ensured. u Whether the cause of a fault is an interruption of the aerial cable or a defective TV aerial amplifier can be determined by more extensive fault finding. For extensive fault finding:
Job number900018
Chassis number Registration number UserM
Date15/03/2002
Workshop Manual - 2 -
Type1J
Type descriptionGolf
MY2002
Engine IDALH
GearboxEGR
Kilometer reading
=> "Guided fault finding" on Vehicle Diagnosis, Testing and Information System VAS 5051.
Job number900018
Chassis number Registration number UserM
Date15/03/2002
Workshop Manual - 3 -
Type1J
Type descriptionGolf
MY2002
Engine IDALH
GearboxEGR
Kilometer reading
Suppression measures The majority of the electrical consumers in the vehicle are suppressed for radio/navigation system as standard. On vehicles with radio or prepared for radio the following components are additionally suppressed: u Radiator fan -V7- u Windscreen wiper motor -V- u Rear window wiper motor -V12- Additional earth connections on vehicle with radio or prepared for radio: u Earth strap from left wheel housing to bonnet
