Note: Energy usage estimates based on industry recognized energy
analysis software. Water usage estimates based on typical operating
parameters, cost varies by municipality. See system detail on
following page.
$100,000
$80,000
$60,000
$40,000
$20,000
Recold Evaporative Condenser INSIGHT
Hasta 50% menos de consumo de energa
Informacin General
Detalle - Bajo costo de operacin
Porque... La refrigeracin por evaporacin proporciona
temperaturas de condensacin significativamente ms bajas que las
logradas con dispositivos de disipacin de calor en seco
El consumo de energa del compresor y condensador se puede
reducir hasta un 51%, que se traduce en hasta $35,000 en ahorro de
costo anual de operacin
Beneficios del sistema como menor carga de refrigerante,
reduccin de costos de mantenimiento y vida extendida del
compresor
El ahorro anual puede ser mayor que el precio del
condensador
Los condensadores evaporativos Recold pueden mejorar su sistema
de condensacin refrigerado por aire al tener:
Los dispositivos evaporativos transfieren calor de manera ms
eficientemente usando menor energa elctrica
Costo anual estimado de la energa del compresor y
condensador
$0Air-Cooled Evaporative
Total Low and Medium Temperature Air-Cooled Evaporative
Delta
InstalledCompressorandCondenserPower(hp) 175.1 132.4 -24%
AnnualEnergyUse(kWh) 1,030,687 502,752 -51%
AnnualEnergyCost $92,762 $45,246 -$47,516
AnnualWaterUsage,Serwer,MaintenanceCosts $11,844
AnnualOperatingCost -$35,672
Detail System Benefits
Lowercondensingtemperaturescanlowercompressionratioasmuchas23%,extendingcompressorlife
Upto24%lesstotalinstalledcondenserandcompressorpower,reducingrackandelectricalservicecosts
Evaporativeheattransfercanlowerrefrigerantchargebyasmuchas100lbs
Calculation Detail
Estimatesbasedonsimulatedannualoperationofa40,000ft2supermarketrefrigerationsysteminMiami,FL.ContactRecoldforinformationspecifictoyoursite.
Evaporative Condenser INSIGHT
7401 WEST 129 STREET | OVERLAND PARK, KANSAS 66213 UNITED STATES
| 913 664 7400 | [email protected] | spxcooling.com
Contact your Marley Sales Representative at
spxcooling.com/en/sales/In the interest of technological progress,
all products are subject to design and/or material change without
notice.
2011 SPX Cooling Technologies, Inc. | Printed in USA
IN-COND-11
*Evaporative condenser rated power includes a 10 hp fan motor
and 2 hp pump motor. One unit is used for both low and medium
temperature systems; multiple loads are easily separated in a
Recold Evaporative Condenser.
Key Contacts
SoutheastRefrigerationSales:
[email protected]
RefrigerationApplications: [email protected]
HVACApplications: [email protected]
Recold Evaporative Condensers
Low-profileforced-draftorinduced-draft
294to7644MBHCapacity
Corrosion-resistantcoppercoils
Provenredundancyoptions
Timesavingmaintenanceaccessfeatures
Easytoinstall,factorywiredandtested
MadeintheUSA
RecoldhasmanufacturedheatexchangeequipmentservingRefrigeration,HVAC,andIndustrialapplicationsforover75years.Forthebestvalueinheatrejection,insistonaRecoldEvaporativeCondenser.
Evaluation Parameter Low-Temperature Summary Medium-Temperature
Summary
Condenser Air-Cooled Evaporative Delta Air-Cooled Evaporative
Delta
Refrigerant R-404A R-404A R-404A R-404A
Capacity(Btu/hr) 303,500 306,000 555,000 551,000
SuctionTemperature(F) -20 -20 +20 +20
CondensingTemperature(F) 110 95 -15 115 95 -20
DryBulb/WetBulbTemperature(F) 100 80 -20 100 80 -20
RateCompressorPower(hp) 73.6 60.6 -18% 83.5 59.8 -28%
CompressionRatio 8.98 7.33 -18% 4.33 3.32 -23%
Rated Condenser Power (hp)* 9 6 -33% 9 6 -33%
Annual Energy Use (kWh) 525,376 272,223 -48% 505,311 230,519
-55%
Annual Energy Cost ($) $47,284 $24,501 -$22,783 $45,478 $20,745
-$24,733
