+ All Categories
Home > Documents > Renault Clio 2003 Manual

Renault Clio 2003 Manual

Date post: 01-Jun-2018
Category:
Upload: ivan-salarz
View: 297 times
Download: 3 times
Share this document with a friend
210
8/9/2019 Renault Clio 2003 Manual http://slidepdf.com/reader/full/renault-clio-2003-manual 1/210 nu654-6 - CLIO II C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:44 - page 1 loaded from www.Manualslib.com manuals search engine 
Transcript
Page 1: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 1/210

nu654-6 - CLIO II   C :\Documentum\Checkout\nu65 4-6_eng_T1.WIN 4/11/2002 13:44   - page 1

loaded from www.Manualslib.com manuals search engine 

Page 2: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 2/210

nu654-6 - CLIO II   C :\Documentum\Checkout\nu65 4-6_eng_T1.WIN 4/11/2002 13:44   - page 2

RENAULTrecommends

loaded from www.Manualslib.com manuals search engine 

Page 3: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 3/210

nu654-6 - CLIO II   C :\Documentum\Checkout\nu6 54-6_eng_T1.WIN 4/11/2002 13:44   - page 3

0.0

Welcome to your new RENAULT 

This driver’s handbook  contains all the information you will need:

• to get to know your Renault, to use it to the best advantage and to benefit from all the latest technical developmentwhich are incorporated in it.

• to ensure that it is always running well by following the simple, but strict, advice concerning regular maintenance

• to enable you to deal quickly with minor faults which do not require specialist attention.

The few minutes you spend reading this handbook will be amply rewarded by the information which it provides and thetechnical innovations it will bring to your attention. If certain points are still unclear, the technicians in our Network wil be happy to provide you with any additional information you may require.

The following symbols are used in this handbook to help you while you are reading it:

To indicate a risk, danger or safety advice.

The description of the models given in this handbook is based on the technical specifications known at the date thisdocument was produced.  The handbook covers all equipment   (standard or optional)  which is available for thesemodels, but their presence on the vehicle depends on the version, options selected and country of marketing.Certain equipment which is due to be made available during the year may also be included in this handbook.

Enjoy driving your new Renault.

Copying or translation, in part or in full, is forbidden without written permission from Renault, 92100 Billancourt 2002.

loaded from www.Manualslib.com manuals search engine 

Page 4: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 4/210

nu654-6 - CLIO II   C :\Documentum\Checkout\nu65 4-6_eng_T1.WIN 4/11/2002 13:44   - page 4

0.02

 Brief overview 

• Tyre pressures .............................................................................................. 0.04 - 0.05

• Adjusting the seats and driving position ............................................... 1.11  1.14

• Child restraints ........................................................................................... 1.24    1.36

• Warning lights ............................................................................................ 1.42    1.52

• Horn and headlamp flash ............................................................. 1.55    1.57 - 1.62

• De-icing .................................................................................................................... 1.61

• Running in, driving ................................................................................... 2.02    2.30

• Heating/air conditioning ........................................................................... 3.04    3.22

• Opening the bonnet ............................................................................................... 4.02

• Levels (engine oil, windscreen washer, etc.) .......................................... 4.03  4.11

• Emergency spare wheel ............................................................................ 5.02    5.05

• Practical advice (changing the bulbs, fuses, repairs, operatingincidents) .................................................................................................... 5.02  5.34

loaded from www.Manualslib.com manuals search engine 

Page 5: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 5/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:44   - page 5

0.0

C O N T E N T S

Sectio

1

2

3

4

5

6

7

Getting to know your car   .....................................................................

Driving   ...............................................................................................................

Your comfort   .................................................................................................

Maintenance   ..................................................................................................

Practical advice   ...........................................................................................

Technical specifications   ........................................................................

Alphabetical index   ....................................................................................

loaded from www.Manualslib.com manuals search engine 

Page 6: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 6/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:44   - page 6

0.04

Tyre inflation pressures when cold   (in bar)

Versions   1.21.2 16V

1.4 16V1.6 16V

  2.0 16V  1.5 dCi

1.9 dCi

Tyre sizes 175/65 R14 T185/55 R15 H

175/65 R14 T185/55 R15 H

195/45 R16 195/50 R15 175/65 R14 T185/55 R15 H

Normal use   (2)• Front 1.9 2.2 (1) 2.3 2.3 2.2• Rear 1.8 2 2.1 2.1 2

Motorway use   (2)• Front 2 2.3 (1) 2.7 2.5 2.3• Rear 2 2.1 (1) 2.2 2.2 2.1

Wheel sizes  5.5 J 14

6.0 J 157 J 16 7 J 16 5.5 J 14

6.0 J 15

Tyre safety and use of chains

Refer to the information on tyres in Section 5 for information on maintenance and, depending on the version, thconditions under which snow chains may be fitted to the vehicle.

Special features of the 2.0 16V version

The tyres on this vehicle cannot be fitted with chains. If you wish to fit snow chains, you must use  special equipmentConsult your Renault Dealer.

(1)  Vehicle with automatic transmission:  add  0.1 bar.(2) Special note concerning vehicles used under full load  (maximum permissible all-up weight)  and towing a trailer

Maximum speed must be limited to 60 mph (100 km/h) and the tyre pressure increased by  0.2 bar  (or  3 PSI).Refer to the information on weights in Section 6 for more details.

loaded from www.Manualslib.com manuals search engine 

Page 7: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 7/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:44   - page 7

0.0

Tyre pressures when cold   (in PSI) (continued)

Versions   1.21.2 16V

1.4 16V1.6 16V

  2.0 16V  1.5 dCi

1.9 dCi

Tyre sizes 175/65 R14 T185/55 R15 H

175/65 R14 T185/55 R15 H

195/45 R16 195/50 R15 175/65 R14 T185/55 R15 H

Normal use•  Front 28 32 (1) 33 33 32• Rear 26 29 30 30 29

Motorway use   (2)• Front 29 33 (1) 39 36 33• Rear 28 30 (1) 32 32 30

Wheel sizes  5.5 J 14

6.0 J 157 J 16 7 J 16 5.5 J 14

6.0 J 15

Tyre safety and use of chains

Refer to the information on tyres in Section 5 for information on maintenance and, depending on the version, thconditions under which snow chains may be fitted to the vehicle.

Special features of the 2.0 16V version

The tyres on this vehicle cannot be fitted with chains. If you wish to fit snow chains, you must use  special equipmentConsult your Renault Dealer.

(1)  Vehicle with automatic transmission:  add  3 PSI.(2) Special note concerning vehicles used under full load  (maximum permissible all-up weight)  and towing a trailer

Maximum speed must be limited to 60 mph (100 km/h) and the tyre pressure increased by  0.2 bar  (or  3 PSI).Refer to the information on weights in Section 6 for more details.

loaded from www.Manualslib.com manuals search engine 

Page 8: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 8/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:44   - page 8

0.06

loaded from www.Manualslib.com manuals search engine 

Page 9: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 9/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:44   - page 9

1.0

Section 1: Getting to know your car 

Keys - plip remote control unit ............................................................................................................ 1.02 - 1.03

Doors .......................................................................................................................... ............................. 1.04 - 1.05

Automatic locking of doors when driving ..................................................................................................... 1.0

Engine immobiliser system ................................................................................................................... 1.07 - 1.0

Head restraints - Seats ......................................................................................................................... 1.09    1.12

Seat belts/Methods of restraint in addition to the front seat belts ................................................. 1.13    1.23

Child safety ........................................................................................................................................... 1.24    1.36

Clock and external temperature ...................................................................................................................... 1.3

Driving position ................................................................................................................ ................... 1.38    1.41

Instruments ........................................................................................................................................... 1.42    1.49

On-board computer .......................................................................................................................... 1.50    1.52Rear-view mirrors .................................................................................................................................. 1.53 - 1.54

Steering wheel .................................................................................................................. ................................ 1.54

Lighting and external signals ............................................................................................................... 1.55 - 1.5

Headlight beam adjustment ........................................................................................................ ..................... 1.57

Wipers ................................................................................................................................................... 1.58    1.60

De-icing .............................................................................................................................................................. 1.61

Visible and audible warning signals ................................................................................................ ............... 1.6

Fuel tank (filling with fuel) .................................................................................................................. 1.63 - 1.64

loaded from www.Manualslib.com manuals search engine 

Page 10: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 10/210

1

2

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:44  - page 10

1.02

KEYS / RADIO FREQUENCY REMOTE CONTROL

1   Remote control coded ignitionkey, key for doors and fuel fillercap.

The plip remote control 1 locks andunlocks the doors.

It is supplied with power by a battery which has to be replacedwhen the battery tell-tale light  2  nolonger comes on. (Refer to theinformation on the radio frequencyremote control batteries.)

If there is a child (oranimal) in the car, neverleave it unattended withthe key in the ignition.

With the key in the ignition itwould be possible to operateelectrical equipment such as thewindow risers and there is a riskthat the child may be seriouslyinjured (by trapping his or herneck, arm, hand, etc.).

Locking/unlocking the doorsPress the remote control foapproximately one second to lock ounlock the doors. (Tell-tale light   2will switch on.)

- The hazard warning lights flashtwice   to indicate that the doorhave been  locked.

Note: Depending on the vehicle, i

either a door or tailgate is open onot properly closed or if a reainterior light remains in th“continuous lighting” position(see information on interior lightin section 3), the hazard warninglights will not flash.

- The hazard warning lights flashonce   to indicate that the doorhave been  unlocked.

loaded from www.Manualslib.com manuals search engine 

Page 11: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 11/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:44  - page 11

1.0

RADIO FREQUENCY REMOTE CONTROL   (continued)The range within which the remotecontrol will operate

This varies according to theenvironment: therefore take carewhen handling the remote controlthat you do not inadvertently lockor unlock the doors.

Note: On certain vehicles, if a dooris not opened within approximately30 seconds of unlocking the doorusing the remote control, the doorswill lock again automatically.

InterferenceInterference may be caused to theoperation of the remote control byfactors in the immediate vicinity(external installations or the use of equipment operating on the samefrequency as the remote control).

If you lose your keys or needanother set of keys (or a remotecontrol),   contact your RENAULTDealer.

• If a remote control unit isreplaced, it will be necessary totake the vehicle to yourRENAULT Dealer because boththe vehicle and all the remote

control units are needed toinitialise the system.

• No more than two remote controlscan be used on one vehicle.

• Make sure that the batteries arealways in good condition - theylast for approximately two years.

loaded from www.Manualslib.com manuals search engine 

Page 12: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 12/210

1

2

5

4

3

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:44  - page 12

1.04

OPENING THE DOORS

Opening the doors from theoutsideFront:   Use the key to unlock thefront door lock   2. Slip your handunder the handle   1   and pull ittowards you.

Rear: When the front door is open,lift the unlocking knob   3   frominside and pull the door handle.

Opening the doors from insidethe vehicleMove handle  4.

Lights on warning buzzerIf you have left the lights switchedon after turning off the ignition, awarning buzzer will sound when adoor is opened (risk of batterydischarge).

Childproof locksTo prevent the rear doors beinopened from inside the vehiclemove lever   5   on each door andcheck from inside the car that bothdoors are securely locked.

loaded from www.Manualslib.com manuals search engine 

Page 13: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 13/210

2

1

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:44  - page 13

1.0

LOCKING THE DOORS

Manual locking

Front: Use the key from the outside.

Rear: Press down knob   1   in eachdoor.

Electric central lockingThis enables the doors andthe luggage compartment to belocked or unlocked simultaneously.

Lock by pressing the indicator lighton switch  2.

The front door mechanism cannot be locked if the door is open.

Opening status warning lightThe warning light on switch   2informs you of the closure status othe doors and tailgate:

- the light comes on when the doorare locked;

- when a door is opened (oincorrectly closed) the indicatolight goes out.

When you lock the doors using theplip remote control, the indicatolight remains lit for approximatelyone minute then goes out.

If you decide to keep thedoors locked when youare driving, rememberthat it may be more

difficult for those assisting youto gain access to your vehicle inthe event of an emergency.

loaded from www.Manualslib.com manuals search engine 

Page 14: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 14/210

1

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:44  - page 14

1.06

AUTOMATIC LOCKING OF DOORS, ETC. WHEN DRIVINGYou must first decide if you want toactivate this function.

To activate

With the ignition on, press thecentral door locking button   1   forapproximately 5 seconds, until youhear the beep.

To deactivate

With the ignition on, press thecentral door locking button   1   forapproximately 5 seconds, until youhear the beep.

If you decide to keep thedoors locked when youare driving, rememberthat it may be more

difficult for those assisting youto gain access to your vehicle inthe event of an emergency.

Operating principleWhen the vehicle moves off, thesystem automatically locks thedoors, etc. as soon as a speed of 4mph (6 km/h) is attained. Theindicator light on button 1 light ups.

Unlocking occurs automatically:

- if a front door is opened.

Note: If a rear door is opened, thiswill be locked again automaticallywhen the vehicle attains a speed of approximately 4 mph (6 km/h).

- by pressing the door unlocking button 1.

Operating incidentIf you note that the system is nooperating correctly (automatilocking does not take place, thindicator light on button  1  does nolight up when the doors, etc. arlocked), first of all check that all thdoors, etc. are properly closedHowever, if they are closed

correctly, consult your RenaulDealer.

Also make sure that locking has no been deactivated inadvertently. Ithis occurs, switch the ignition ofand on again and reactivate it adescribed above.

loaded from www.Manualslib.com manuals search engine 

Page 15: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 15/210

1

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:44  - page 15

1.0

ENGINE IMMOBILISERThis prevents the engine beingstarted by anyone who does nothave the coded key for the vehicle.

Any operation on ormodification to theimmobiliser system(computers, wiring, etc.)

may be dangerous. It must becarried out by qualifiedRENAULT personnel.

Operating principleThe vehicle is automaticallyprotected a few seconds after thekey has been removed from theignition.

When the ignition is switched on,warning light  1  comes on for a fewseconds then goes out.

The vehicle has recognised the codeand the engine may be started.

If the code of the ignition key is notrecognised by the vehicle, warninglight 1  will flash continuously andthe engine cannot be started.

Indicator lightSystem operational indicator light

When the ignition is switched onindicator light   1   lights upcontinuously for approximatelthree seconds and then goes outYou can then start the engine.

Vehicle protection indicator light

A few seconds after the ignition ha been switched off, indicator light  1will flash continuously.

The vehicle will not be protecteduntil the key has been taken out othe ignition.

loaded from www.Manualslib.com manuals search engine 

Page 16: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 16/210

1

2

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:44  - page 16

1.08

ENGINE IMMOBILISER   (continued)

Warning light to indicate that thesystem is not operating correctly

When the ignition has beenswitched on,   if warning light   1continues to flash or remains on, itindicates that the system is notoperating correctly.

In all instances, you must contact aRENAULT Dealer, who are the onlypeople authorised to repair theengine immobiliser system.

If the coded ignition key is faulty,use the second key (supplied withthe vehicle).

loaded from www.Manualslib.com manuals search engine 

Page 17: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 17/210

A   1

1

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:44  - page 17

1.0

HEAD RESTRAINTS

To raise or lower the headrest

Pull the headrest towards you (i.e.towards the front of the vehicle) andslide it up or down at the same time.

To adjust the angle of the headrestOn certain vehicles the angle of the

headrest can be adjusted. To do this,move the front section   A   of theheadrest forwards or backwardsuntil it feels comfortable.

To remove the headrest

First incline the seatback towardsthe rear.

Raise the headrest until it is at thehighest possible setting. Lift uptab   1   and then pull the headrestupwards until it is released.

To refit the headrest

Insert the rods into the sleeves, withthe notches facing the front.

Lower the headrest until it locks inposition.

The head restraint isimportant for safety: ensurethat it is positionedcorrectly. The distance

 between your head and the headrestraint should be as small aspossible, and the top of the headrestraint should be as close aspossible to the top of your head.

loaded from www.Manualslib.com manuals search engine 

Page 18: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 18/210

11

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:44  - page 18

1.10

REAR HEAD RESTRAINTS

To adjust the height

Simply slide it up.

To remove it

Press tab  1.

To refit the headrest

Insert the rods into the sleeves, withthe notches to the front, and lowerthe headrest to the desired height.

Storage positionWhen the headrest is fully lowered,it is in the storage position;  do notuse this position when someone issitting in the rear seats.

The head restraint isimportant for safety: ensurethat it is positionedcorrectly. The distance

 between your head and the headrestraint should be as small aspossible, and the top of the headrestraint should be as close aspossible to the top of your head.

loaded from www.Manualslib.com manuals search engine 

Page 19: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 19/210

2

3

4

1

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:44  - page 19

1.1

FRONT SEATS

To move forwards or backwards:

Lift lever   2   to unlock the seat.Release the lever when the seat is inthe required position and ensure itis locked in place.

To raise or lower the driver’s seat:

Lift lever  1.

To tilt the seatback:

Move handle   4   and tilt the seat tothe required position.

To adjust the lumbar support on thedriver’s seat:

Turn wheel  3.

So that the effectiveness of the seat belts is notreduced, we would adviseyou not to recline the

seatbacks excessively.

Make sure the seatback is locked inplace correctly.

No objects should be placed on the

floor (area in front of driver) assuch objects may slide under thepedal during braking manoeuvres,thus obstructing its use.

For safety reasons, adjustthe seats only when thevehicle is stationary.

loaded from www.Manualslib.com manuals search engine 

Page 20: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 20/210

Page 21: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 21/210

1

2

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:44  - page 21

1.1

SEAT BELTSAlways wear your seat belt whentravelling in your car. You must alsocomply with the local legislation inthe particular country you are in.

Before driving off:

- First ensure that your drivingposition is correct.

- Then, to provide maximum

safety, adjust your seat beltcorrectly.

Incorrectly adjusted seat belts may cause injuriesin the event of anaccident.

Even pregnant women shouldwear a seat belt. In this case,ensure that the pressure of thelap belt on the abdomen is notexcessive.

Adjusting your driving position• Sit with your back firmly against

the seatback.

This is essential to ensure yourlumbar vertebrae are in thecorrect position.

•  Adjust the distance between theseat and the pedals.

Your seat should be as far back aspossible to allow you to press theclutch pedal fully down. Theseatback should be adjusted sothat your arms remain slightly

 bent.

•   Adjust the position of the headrestraint.

For maximum safety, your headshould be as close as possible tothe head restraint.

•  Adjust the height of the seat.

This adjustment allows you toselect the seat position whichoffers you the best possiblevision.

•  Adjust the position of the steeringwheel

Adjusting the seat beltsSit with your back firmly against thseatback.

The shoulder strap  1   should be aclose to the base of the neck apossible but not on it.

The lap strap   2   should be helfirmly over the thighs and againsthe pelvis.

The belt should be worn so that it ias close to the body as possible, i.eavoid wearing heavy clothing ohaving bulky objects under th

 belts.

loaded from www.Manualslib.com manuals search engine 

Page 22: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 22/210

3

45

66

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:44  - page 22

1.14

SEAT BELTS   (continued)

Adjusting the height of the frontseat shoulder strapMove button  3  to adjust the belt sothat the shoulder strap 1 is positionedas described above.

After making the adjustment, ensure

the belt is correctly locked.

LockingUnwind the belt slowly and smoothlyensuring the buckle 4  clips correctlyinto housing 6 (check it is locked bypulling on buckle 4). If the belt jams,allow it to return slightly beforeunwinding it again

Locking  (continued)

If the belt is jammed completely:

- pull slowly but firmly, to unwindjust over an inch (approximately3 cm);

- allow the belt to rewind by itself

- unwind the belt once more;

- if the problem persists, consult youRENAULT Dealer.

Driver's seat belt nofastened warning lightIf the driver's seat belt i

unfastened this lights up, andwhen the vehicle reaches a speed oapproximately 6 mph (10 km/h), iwill flash and a beep will sounfor approximately 90 second

 before the light returns to beinpermanently lit.

UnlockingPress button 5 on housing 6. The belwill rewind by itself.

Hold the buckle to help the action

loaded from www.Manualslib.com manuals search engine 

Page 23: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 23/210

1

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:44  - page 23

1.1

METHODS OF RESTRAINT IN ADDITION TO THE FRONT SEAT BELTSThese are:

  Front seat belt pretensioners.

  Force limiters.

 Driver's and passenger airbags.These airbags are adaptable inthat they offer a small or largevolume depending on theseverity of the frontal impact.

These systems are provided to actindependently or together when thevehicle is subjected to a frontalimpact.

Depending on the force of theimpact the system may engage:

- seat belt locking;

- the buckle pretensioner (whichtriggers to take up the slack in theseat belt);

- the lap belt pretensioner to keepthe occupant in their seat, the low

volume front airbag and the loadlimiters;

- the large volume front airbag.

  Side airbags   are provided toactivate in the event of severeside impacts.

Front seat belt pretensionersWith the ignition switched on, if there is a severe frontal impact anddepending on the force of theimpact, the system may engage:

- the piston   1   which immediatelyretracts the seat belt.

The pretensioners pull the seat belt against the body, holding theoccupant more securely against theseat, thus increasing the seat belt'sefficiency.

• Have the entire restraintsystem checked followingan accident.

• No operation whatsoeveris permitted on any part of thesystem (pretensioners, airbags,computers, wiring) and thesystem components must not be

re-used on any other vehicle,even if identical.

• To avoid premature triggering of the system which may causeinjury, only qualified RENAULTNetwork personnel may work onthe pretensioner and airbagsystem.

• Testing of the electric triggersystem may only be carried out

 by a specially trained technicianusing special equipment.

• When the vehicle is scrapped,contact your RENAULT Dealerfor disposal of the pretensionerand airbag gas generators.

loaded from www.Manualslib.com manuals search engine 

Page 24: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 24/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:44  - page 24

1.16

METHODS OF RESTRAINT IN ADDITION TO THE FRONT SEAT BELT   (continued)Force limiterAbove a certain severity of impact,this mechanism is used to limit theforce of the belt against the body sothat it is at an acceptable level.

Warning relating to theservice life of airbagsand pretensioners

Pyrotechnic systems forairbags and pretensioners have alimited service life: refer to theservicing booklet for yourvehicle for the replacementfrequency.

Driver and passenger airbagsThese are fitted to both the driverand the front passenger seats.

An “Airbag” marking on thesteering wheel and dashboard and alabel in the lower section of thewindscreen inform you of thepresence of additional means of restraint (airbags, pretensioners,

etc.) in the passenger compartment.Each airbag system consists of:

- an airbag and its two gasgenerators (for the small orlarge-volume bag depending onthe severity of the frontal impact)mounted on the steering wheel forthe driver and in the dashboard forthe passenger;

- a computer for both systems,which includes the impactdetector and the monitorcontrolling the electrical triggersystem for each of the gas

generators;- A single warning light on

the instrument panel.

The air bag system uses theprinciples of pyrotechnics. Thisexplains why, when the air baginflates, it will generate heat,produce smoke (this does not meanthat a fire is about to start) andmake a noise upon detonation. In asituation where an air bag isrequired, it must inflate immediatelyand this may cause some minor,superficial grazing to the skin.

loaded from www.Manualslib.com manuals search engine 

Page 25: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 25/210

1

2

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:44  - page 25

1.1

METHODS OF RESTRAINT IN ADDITION TO THE FRONT SEAT BELT   (continued)OperationThe system waits a few secondsafter the ignition has been switchedon before being operational.

If a severe   frontal   impact occurs,the airbag(s) inflate(s) rapidly,cushioning the impact of thedriver's head and chest against thesteering wheel and the front

passenger's head against thedashboard. The airbag(s) thendeflate(s) immediately so that thepassengers are not impeded in anyway when they get out of thevehicle.

The passenger airbag system islinked to a front passenger airbagdeactivation warning light  2  on theinstrument panel. This warninglight is linked to the passengerairbag deactivation system throughthe ignition key.

It lights up to indicate that the

passenger airbag will not be inflatedin the event of an impact (refer tothe section on Deactivating the frontpassenger airbag).

Operational incidentsWarning light   1   lights up on theinstrument panel when the ignitionis turned on and then goes out aftera few seconds.

If it does not light up when theignition is turned on, there is a faultin the system.

If it lights up while you are driving,stop at once and switch off theignition.

If it is still lit up after the ignitionhas been switched on again, there ia fault in the system. In this case, rear-facing child seat MUST NOT bfitted to the front passenger seat.

We do not recommend fitting anyother kind of passenger seat device

In both cases, consult youRENAULT Dealer as soon a

possible.

loaded from www.Manualslib.com manuals search engine 

Page 26: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 26/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:44  - page 26

1.18

METHODS OF RESTRAINT IN ADDITION TO THE FRONT SEAT BELT   (continued)All the warnings below are given so that the airbag is not obstructed in any way when it is inflated and also to prevent thrisk of serious injuries caused by items which may be dislodged when the airbag inflates.

The airbag is designed to complement the action of the seat belt. Both the airbags and seat belts are integral partsof the same protection system. It is therefore essential to wear the seat belt at all times. If the seat belt is not worn,it exposes the occupants to the risk of serious injury in the event of an accident. It may also increase the risk of minor, superficial injuries occurring when the airbag is deployed, although such minor injuries are alwayspossible with airbags.

The airbag does not offer protection against minor and moderately serious frontal impacts, side or rear impacts or if thevehicle turns over.

Airbags for driver and passenger

• No work or modification whatsoever  may be performed on the entire airbag system for the driver and passenger(computer, wiring, etc.) except by qualified RENAULT network personnel.

• To ensure that the system is in good working order and to avoid incorrect triggering of the system which may causeinjury, only qualified RENAULT network personnel may work on the airbag system.

• As a safety precaution, have the airbag system checked if your vehicle has been involved in an accident, is stolen or broken into.

• When selling or lending the vehicle, inform the user of these points and hand over this handbook with the vehicle.

• When scrapping your vehicle, contact your RENAULT Dealer for disposal of the gas generator(s).

loaded from www.Manualslib.com manuals search engine 

Page 27: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 27/210

1

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 27

1.1

METHODS OF RESTRAINT IN ADDITION TO THE FRONT SEAT BELT   (continued)

All the warnings given below aredesigned to ensure that the airbagcan inflate correctly and to preventserious injuries caused by itemswhich may be dislodged when theairbag inflates.

Warnings concerning the driver’s airbag

• Do not adjust either the steering wheel or the airbag cushion.

• Do not cover the airbag cushion.

• Do not attach any objects (badge, logo, clock, telephone holder, etc.) to theairbag cushion.

• The steering wheel must not be removed (except by qualified personnelfrom the RENAULT network).

• Do not sit too close to the steering wheel. If you sit with your arms slightly bent (see the information on Adjusting your driving position in Section 1),you will ensure that there is sufficient space for the airbag to inflateproperly and to be fully effective.

Warnings concerning the passenger airbag: location  1

• Do not attach or glue any objects (badges, logo, clock, telephone holder,etc.) onto the front passenger side of the dashboard.

• Nothing should be placed between the dashboard and the passenger (pet,umbrella, walking stick, parcels, etc.).

• The passenger must not put his or her feet on the dashboard or seat as thereis a risk that serious injuries may be sustained. As a general rule, keep allparts of the body (knees, hands, head, etc.) well away from the dashboard.

• You should reactivate the airbag as soon as you remove the child seat fromthe front passenger seat to ensure the protection of the front passenger inthe event of an impact.

IT IS FORBIDDEN TO FIT A REAR-FACING CHILD SEAT ON THE FRONTPASSENGER SEAT WHILE THE RESTRAINING METHODS ADDITIONAL

TO THE PASSENGER SEAT BELT ARE NOT DEACTIVATED.(Refer to the information on Deactivationof front passenger airbags in Section 1).

loaded from www.Manualslib.com manuals search engine 

Page 28: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 28/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 28

1.20

METHODS OF RESTRAINT IN ADDITION TO THE FRONT SEAT BELT   (continued)Side airbagsThese airbags may be fitted to thefront seats and are deployed at thesides of the seats (door side) toprotect the occupants in the event of a severe side impact.

The slits on the frontseatbacks (door side) andthe gap between the rear

 bench seatback and theinterior fittings form the triggerarea for the airbag, so it isforbidden to place any objectsthere.

Warnings concerning theside airbag• Fitting seat covers:  Seats

equipped with an airbagrequire special coversspecifically designed for yourvehicle. Consult your RENAULTDealer to see if appropriatecovers are available fromRENAULT outlets. The use of anycovers other than those designedfor your vehicle (and includingthose designed for anothervehicle) may affect the operationof these airbags and reduce yourprotection.

• Do not place any accessories,objects or pets between theseatback and the door. This mayprevent the airbag from operatingcorrectly or cause injury if theairbag is deployed.

• No work or modificationwhatsoever may be carried outon the seat, except by qualifiedRENAULT Network personnel.

loaded from www.Manualslib.com manuals search engine 

Page 29: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 29/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 29

1.2

METHODS OF RESTRAINT IN ADDITION TO THE REAR SEAT BELTSForce limiterIn the event of a frontal impactabove a certain severity, thismechanism is used to limit the forceof the belt against the body so that itis at an acceptable level.

Rear side seat belt pretensioners

This system is only operationalwhen the ignition is switched on.

If the vehicle is subjected to a severeimpact, a device retracts the seat

 belt, pulling the seat belt tightagainst the body and therebyimproving its efficiency.

Warning relating to theservice life of airbags andpretensioners

Pyrotechnic systems forairbags and pretensioners have alimited service life: refer to theservicing booklet for your vehiclefor the replacement frequency.

loaded from www.Manualslib.com manuals search engine 

Page 30: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 30/210

1

53

2

4

6

A

B

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 30

1.22

REAR SEAT BELTS

Rear side seat belts  1The belts are locked, unlocked andadjusted in the same way as for thefront seat belts.

The rear bench seat must be correctly secured forthe seat belts to beefficient.

Refer to the information on rear bench seats in section 3.

Rear central beltUnwind the belt slowly fromposition  2.

Fasten the black buckle   4   into the black housing 6.

Fasten the last sliding buckle 2  into

the red housing  5.

Special point concerning vehiclewith a two-part rear bench seat

If you have to fold down the part othe rear bench seat behind the fronleft-hand seat:

- lift the cushion B  against the fronseat;

- insert the black buckle  4   into th black housing 6;

- lower the seatback   A   (afteremoving the head restraint).

Then fasten the last sliding buckle 3into the red housing  5.

loaded from www.Manualslib.com manuals search engine 

Page 31: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 31/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 31

1.2

SEAT BELTSThe following information applies to both the vehicle’s front and rear seat belts:

• No modifications may be made to the component parts of the original restraint systems: seat belts andtheir mountings.

Consult your Renault Dealer for special applications (e.g. fitting a child seat).

• Do not use any devices which give any play in the belts (clothes pegs, clips for example).

• Never wear the shoulder strap under your arm or behind your back.

• Never use the same belt for more than one person and never hold a baby or child on your knees with the seat belt around them.

• The seat belt should never be twisted.

• Following a serious accident, replace all the belts which were in use at the time. Likewise, have the beltsreplaced if they show any signs of wear.

• When refitting the rear bench seat, check that the seat belts are repositioned correctly, to enable them to be usedproperly.

• If necessary, re-adjust the position and tension of the belt.

loaded from www.Manualslib.com manuals search engine 

Page 32: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 32/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 32

1.24

CHILD SAFETY   (continued)

In all countries there are regulationsgoverning the use of restraintsystems for children and babies.

In Europe, children under 12 yearsof age, less than 1.50 m tall andweighing less than 36 kg(1) must berestrained with an approvedrestraint adapted to the child'sweight and height.

The driver is responsible forensuring that this equipment isused correctly.

Child restraints for which typeapproval was obtained after January1992 offer a level of safety muchgreater than for restraints with typeapproval before that date.

We therefore advise you to select anapproved child restraint thatcomplies with European regulationECE 44.

Restraints that comply with thislegislation must be marked with anorange label bearing the letter   Efollowed by a number (whichstands for the country where it is anapproved type) and the year inwhich the type approval wasgranted.

(1) Always comply with the laws of thecountry in which you are travelling.They may be different to theguidelines in this handbook.

Remember that a collision at30 mph (50 km/h) is the same asfalling a distance of 10 metres.Expressed in other terms,transporting a child without arestraint is the equivalent of allowing him or her to play on athird-floor balcony which does not

have any railings.

Under no circumstancesshould babies or children

 be allowed to travel sittingon the knees of another

passenger in the vehicle.

If a head-on collision occurs at30 mph (50 km/h) a child weighing30 kg (66 lbs) will be transformedinto a missile equivalent to onetonne: you will find it impossibleto hold the child, even if youyourself are wearing a belt.

It is particularly dangerous to putthe belt round your child when heor she is sitting on your knee.Never use the same belt for morethan one person at the same time.

The tables on the following pageinform you of the types of seat thacan be fitted in each of the vehiclseat positions on the vehicle inaccordance with the Europeandirective.

Before installing a child seat in thefront seat  (if fitting is permitted)

If the passenger seat is fitted withone, carry out the followinadjustments:

- pull back the seat as far apossible,

- straighten the seatback as much apossible,

- raise the seat squab as far apossible,

- pull the headrest up to itmaximum position,

- move the seat belt height controto the low position.

Refer to the Child safety equipmen booklet available from thRENAULT Network to choose thseat suited to your child anrecommended for your vehicle.

loaded from www.Manualslib.com manuals search engine 

Page 33: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 33/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 33

1.2

CHILD SAFETY   (continued)

Age of child(weight of child)

All versions (except utility version)

Front passenger seat(2)

Rear sideseats

Rear centreseat

Birth to approximately 9 months(weight below 13 kg)

  I (4) U - I X

From 9 months to approximately3 years (weight from 9 to 18 kg)   I (4) U - I (3) X

From 3 years to approximately12 years (1) (weight from 15 to 36 kg)

  X U (3) X

X : seat not suitable for fitting a child seat for this age range.U : seat suitable for fitting a belt-fitted child seat classed as universal for this age range, check that it can be fitted.I : seat equipped with anchoring points for mounting a seat for this age range using Isofix locks, only RENAULT seats ar

approved.

(1) A child taller than 1.50 m or weighing more than 36 kg can be strapped in the same way as an adult, without a speciaseat.

(2) Only a rear-facing child seat may be installed in this seat.

(3) Place the back of the child seat against the vehicle seatback, adjust the headrest height or remove it if necessary.

(4) DANGER RISK OF DEATH OR SERIOUS INJURY: CHECK THAT THE FRONT PASSENGER AIRBAG HASBEEN DEACTIVATED BEFORE INSTALLING A REAR-FACING CHILD SEAT IN THIS SEAT.(Refer to the Deactivating the front passenger Airbag information in Section 1 of the basic manual).

loaded from www.Manualslib.com manuals search engine 

Page 34: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 34/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 34

1.26

CHILD SAFETY   (continued)

Age of child(weight of child)

Utility version

Front passenger seat

Birth to approximately 9 months(weight below 13 kg)

  I (2)

From 9 months to approximately

3 years (weight from 9 to 18 kg)

  I (2)

From 3 years to approximately12 years (1) (weight from 15 to 36 kg)

  X

X : seat not suitable for fitting a child seat for this age range.I : seat equipped with anchoring points for mounting a seat for this age range using Isofix locks, only RENAULT seats ar

approved.

(1) A child taller than 1.50 m or weighing more than 36 kg can be strapped in the same way as an adult, without a speciaseat.

(2) DANGER RISK OF DEATH OR SERIOUS INJURY: CHECK THAT THE FRONT PASSENGER AIRBAG HASBEEN DEACTIVATED BEFORE INSTALLING A REAR-FACING CHILD SEAT IN THIS SEAT.(Refer to the Deactivating the front passenger Airbag information in Section 1 of the basic manual).

loaded from www.Manualslib.com manuals search engine 

Page 35: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 35/210

1 2

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 35

1.2

CHILD SAFETY   (continued)The right choiceThe safety of your children is alsoyour responsibility.

To give your children maximumprotection, we recommend that youuse seats obtained from a RenaultDealer.

If your vehicle is equipped with anIsofix system, it is preferable to usean Isofix seat. (Refer to theinformation in section 1 on theIsofix system of child seats.)

Restraint systems for all categoriesare available. These systems have

 been developed in consultationwith the manufacturers and have

 been tested in Renault vehicles.

Take the advice of your RenaultDealer and ask him to help you toinstall it.

Category 0 and 0+A child’s neck is very susceptible toinjury up to the age of two. In afront-facing seat there is a risk that achild will sustain neck injuries inthe event of a frontal collision.Renault therefore recommends a

rear-facing seat with a harness thatgives all-round protection (figure 1).

Category 1Between the ages of 2 and 4, child’s pelvis is not fully developedRestraints using three-point beltare not adequate and there is a riskthat the child will sustainabdominal injuries in the event of

frontal collision. It is thereforadvisable to use rear-facing seat(figure 1), bucket type seats (figur2) or seats with harnesses.

To avoid any risk to your safety, we recommend that you useRENAULT approved accessories because they are suitable for yourcar and are the only accessories for which RENAULT will provide awarranty.

loaded from www.Manualslib.com manuals search engine 

Page 36: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 36/210

3

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 36

1.28

CHILD SAFETY   (continued)

Category 2 (15 to 25 kg) andcategory 3 (22 to 36 kg)To correctly secure the pelvis of achild of up to 12 years old, smallerthan 1.50 m and weighing less than36 kg, it is preferable to use childseats that can be combined with

three-point seat belts. This is a booster seat (figure 3) with beltguides to ensure that the belt will beworn flat over the thighs of thechild.

A booster seat with aheight-adjustable seatback and a

 belt guide are recommended as thiswill allow the belt to be worn asclose to the base of the neck aspossible but not on it.

Place the head rest in the topposition to allow you to press theseat back of the child seat firmly

against the vehicle seatback.If a booster seat without a seatbackis used, the vehicle's headrest willhave to be adjusted to suit thechild's stature; the upper edge of theheadrest must be at the same heightas the top of the child's head andshould never be lower than in linewith the child's eyes.   The standard classifies the

restraints in five categories:

Category 0 : from 0 to 10 kg (0 to 22 lbs)Category 0+: from 0 to 13 kg (0 to 28 lbs)Category 1 : from 9 to 18 kg (20 to 40 lbs)Category 2 : from 15 to 25 kg (33 to 55 lbs)

Category 3 : from 22 to 36 kg (48 to 80 lbs)

We recommend that you removethe headrest and put it in theluggage compartment, to facilitatefitting certain types of child seat.

loaded from www.Manualslib.com manuals search engine 

Page 37: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 37/210

4 5

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 37

1.2

CHILD SAFETY   (continued)

DANGERSince front passenger airbag triggering and the position of arear-facing child seat are incompatible, it is not permitted to installsuch a seat in this position unless the vehicle is fitted with an airbag

deactivation device. Refer to the information on deactivating the frontpassenger airbag. The child may suffer very serious injuries if the airbaginflates.

Label 4 (on the dashboard) and markings 5 (on the sun visors) remind you of these instructions.

loaded from www.Manualslib.com manuals search engine 

Page 38: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 38/210

1

2

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 38

1.30

CHILD SAFETY   (continued)

Deactivation of the frontpassenger airbagYou   must   deactivate the frontleft-hand airbag before fitting arear-facing child seat on the frontpassenger seat.

To deactivate the airbag:  switch off the ignition, insert the ignition keyin the lock 1, push and turn the lockto the OFF  position and remove thekey while holding it in the   OFFposition. The airbag is deactivated.

With the ignition switched on,check that the warning light   2,AIRBAG OFF, is lit up on thedashboard.

This indicator light remains lit toconfirm that you can fit a child seat,as the left-hand airbag has beendeactivated.

loaded from www.Manualslib.com manuals search engine 

Page 39: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 39/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 39

1.3

CHILD SAFETY   (continued)Activation of the frontpassenger airbagYou should reactivate the airbag assoon as you remove the child seatfrom the front passenger seat toensure the protection of your frontpassenger in the event of an impact.

To reactivate the airbag: switch off 

the ignition and insert the ignitionkey into lock 1. The key then turnsautomatically to the  ON   position.

Switch the ignition back on, andthen check that   AIRBAG OFFindicator light   2   goes out. Theairbag is activated.

Activation or deactivationof the passenger airbagmust be done with theignition off .

Six seconds after the ignition has been switched on, operatinglock   1   will deactivate thesupplementary methods of restraint in addition to the seat

 belt in the front passenger seat

and the indicator light

will come on to warn you.

Operational faultsIt is FORBIDDEN to fit a rear-facingchild seat to the front passenger seatif the air bag activation/deactivationsystem is faulty.

We do not recommend fitting anyother kind of passenger seat device.

Consult your RENAULT Dealer assoon as possible.

loaded from www.Manualslib.com manuals search engine 

Page 40: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 40/210

1

3

2

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 40

1.32

CHILD SAFETY   (continued)Isofix - mounting system forchild seatsThis is a new procedure forinstalling a child seat. This systemequips the front passenger seat andthe rear side seats of the vehicle.

It consists of the followingcomponents:

• Two anchoring rings   1   located between the seat and theseatback.

• A special RENAULT child seatfitted with two catches   3   whichhook onto the two rings;

• Make sure that there isnothing obstructing theseat mounting mechanismat the anchorage points

(gravel, rags, toys, etc.).

• Always remember to fasten theseat belt on child seats for alljourneys.

Only RENAULT child seats areapproved for this vehicle.

To purchase these seats, pleasecontact your RENAULT Dealer.

They are fitted with locks whichcan be secured to the Isofix

attachments in your vehicle.They can also be secured in othervehicles using a three-point seat

 belt.

Use of this device on thefront passenger seat is onlyauthorized if the passengerairbags have been

deactivated.

Refer to the information in thesection on deactivating the frontpassenger airbag.

loaded from www.Manualslib.com manuals search engine 

Page 41: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 41/210

1

3

2

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 41

1.3

CHILD SAFETY   (continued)

Fitting a child seat•  Before fitting and using the seat,

read the instructions providedcarefully;

• Fix the fitting guides   2   on therings 1  fitted to the rear seats andfront passenger seat of thevehicle;

Fitting a child seat  (continued)

•   Slide the seat catches   3   in theguides 2 and push the seat hard tolock it on the rings;

• Check that the seat is correctlylocked by moving it from leftto right and forwards and

 backwards.

loaded from www.Manualslib.com manuals search engine 

Page 42: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 42/210

7

5

4

4

56

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 42

1.34

CHILD SAFETY   (continued)

A front-facing Isofix seat fittedon the front passenger seatUse the belt   4   delivered with theseat:

- pass the belt between the two headrestraint rods;

- fix the hook 5 on the ring 6 locatedunder the front passenger seat;

- tighten the belt.

Note:   only fit the seat here if allother places are occupied.

A rear-facing Isofix seat fitted onthe front passenger seat

The front passenger seat must beadjusted so that the back of the childseat is touching the dashboard.

Use the belt   4   delivered with theseat:

- remove the cover to access thering  7 ;

- attach the belt catch   5   to thering 7 ;

- tighten the belt.

loaded from www.Manualslib.com manuals search engine 

Page 43: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 43/210

Page 44: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 44/210

Page 45: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 45/210

2

3H   M

1

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 45

1.3

CLOCK / EXTERNAL TEMPERATURE

Clock  1  - setting the clockWith the ignition on, press button:

 H   For hours, M   For minutes.

Clock  3, setting the timeWith the engine switched on,display   3   set to total mileagerecorder and clock function, pressand hold button   2, to access timesetting mode, then release the

 button.

There are two ways to set the time:

- one long press on button  2  allowsyou to scroll through the hoursand minutes quickly;

- short presses on button   2   allowyou to set the time minute byminute.

If the electrical supply is cut(battery disconnected, feed wire

 broken, etc.), the clock must bereset.

For your safety, we recommend

that you do not reset or alter thetime while driving.

External temperaturedisplay 1The formation of ice isrelated to exposure, local

hygrometry and temperature.The external temperature alone isnot sufficient to detect ice.

loaded from www.Manualslib.com manuals search engine 

Page 46: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 46/210

Page 47: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 47/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45   - page 47

1.3

DRIVER’S LAYOUT, LEFT HAND DRIVE   (continued)The equipment fitted, described below, depends on the version, option and country.

1   Demister outlet for left-handside window

2   Left-hand side vent

3   Stalk for:• direction indicators,• exterior lights,• front fog lights,• rear fog lights,• horn.

4   Instruments.

5   • Driver's airbag location.• Horn

6   Radio satellite controls.

7    • Stalk for windscreen and rearscreen wash/wipe.

• Trip computer informationscrolling control.

8   Centre air vents.

9   Display:• Clock and temperature,• Radio, clock and temperature• Radio, clock, external

temperature and navigationsystem

10   Storage compartment.

11   Passenger airbag location.

12   Right-hand side air vent.

13   Demister outlet for right-handside vent

14   Glove box.

15   Heated rear screen switch

16   Hazard warning lights switch.

17    Radio location or storagecompartment

18   Air conditioning controls.

19   Ashtray and cigarette lighter

20   Handbrake

21   Gear lever

22   Cup holder

23   Electric door locking switch

24   Ignition switch

25   Cruise control/speed limitecontrols

26   Steering wheel height adjuste

27    Controls for:• Electric headlight beam

adjustment• Dimmer for control lighting• Cruise control• Electronic Stability Program

(ESP)

28   Storage compartment

29   Bonnet release

30   Fuse box

loaded from www.Manualslib.com manuals search engine 

Page 48: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 48/210

1 2 3 4 5 6 7 8 9 10 11 12 13

30 29 28 27 26 25 24 21 20 19 18 17 16 15 14

2223

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 48

1.40

DRIVER’S LAYOUT, RIGHT-HAND DRIVE

loaded from www.Manualslib.com manuals search engine 

Page 49: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 49/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45   - page 49

1.4

DRIVER’S LAYOUT, RIGHT-HAND DRIVE   (continued)The equipment fitted, described below, depends on the version, option and country.

1   Demister outlet for left-handside window

2   Left-hand side vent

3   Passenger airbag location.

4   Storage compartment.

5   Display:• Clock and temperature,• Radio, clock and temperature,• Radio, clock, external

temperature and navigationsystem

6   Centre air vents.

7    Stalk for:• direction indicators,• exterior lights,• front fog lights,• rear fog lights,• horn.

8   Instruments.

9   • Driver's airbag location.• Horn

10   Radio satellite controls

11   • Stalk for windscreen and rearscreen wash/wipe

• On-board computerinformation readout control

12   Right-hand side vents

13   Demister outlet for right-handside vent

14   Controls for:• Electric headlight beam

adjustment• Instrument panel lighting

dimmer• Cruise control and speed

limiter

• Electronic Stability Program(ESP)

15   Storage compartment

16   Ignition switch

17    Cruise control/speed limitercontrols

18   Steering wheel height adjuster

19   Heated rear screen switch

20   Hazard warning lights switch

21   Cup holder

22   Handbrake

23   Gear lever

24   Ashtray and cigarette lighter

25   Heating and ventilationcontrols

26   Radio location or storagcompartment

27    Electric door locking switch

28   Glove box

29   Bonnet release

30   Fuse box

loaded from www.Manualslib.com manuals search engine 

Page 50: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 50/210

2 3 4a 4 5

11 10 9 8 7

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 50

1.42

INSTRUMENT PANEL   (continued)The presence and operation of the warning lights described below depend on the vehicle equipment andcountry.

If the warning light comes on, you must stop as soon as traffic conditions allow.

If the warning light comes on, you should visit a Renault Dealer in the near future.

loaded from www.Manualslib.com manuals search engine 

Page 51: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 51/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 51

1.4

INSTRUMENT PANEL   (continued)The presence and operation of the warning lights described below depend on the vehicle equipment andcountry.

1   Headlight dipped beamwarning light

Main beam headlightindicator light

Rear fog light indicatorlight

Front fog lightindicator light

Anti-lock brakingsystem warning lightThis light comes on

when the ignition is switchedon and goes out within 3seconds. If it comes on whenyou are driving, it indicates afault in the anti-lock brakingsystem. Braking will then occurnormally but without theanti-lock braking system.Consult your RENAULT Dealeras soon as possible.

Rear screen demistingindicator light

2   Rev counter (scale × 100)

3   Fuel level gauge

4   Coolant temperature indicatorIn normal use, the needleshould be below zone   4a.Under severe use the needlemay enter this zone. This is notserious unless warning light

lights up.

5   Speedometer   (km or miles perhour)

6   Airbag warning light

This lights up when theignition is switched onand goes out after a fewseconds.If it does not light up when theignition is switched on, orlights up when the engine isrunning, there is a fault in thesystem. Refer to theinformation in Section 1 on therestraint device additional tothe front seat belt, and consultyour RENAULT Dealer as soonas possible.

6   Front passenger airbadeactivated warninlight

Refer to the information onChild safety in Section 1.

Driver's seat belt nofastened warning lightIt remains lit when th

vehicle is started, then whenthe car reaches a speedof approximately 6 mph(10 km/h), it flashes and a beepsounds for approximately90 seconds.

Door(s) open warninlight

loaded from www.Manualslib.com manuals search engine 

Page 52: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 52/210

2 3 4a 4 5

11 10 9 8 7

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 52

1.44

INSTRUMENT PANEL   (continued)The presence and operation of the warning lights described below depend on the vehicle equipment andcountry.

If the warning light comes on, you must stop as soon as traffic conditions allow.

If the warning light comes on, you should visit a Renault Dealer in the near future.

loaded from www.Manualslib.com manuals search engine 

Page 53: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 53/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 53

1.4

INSTRUMENT PANEL   (continued)

or

The presence and operation of the warning lights, described below, depend on the vehicle equipment andcountry.

6   Speed limiter andcruise control indicatorlight

To understand how thisoperates, refer to theinformation on the cruisecontrol and speed limiter

functions in Section 2.

Toxic fume monitoringwarning lightFor vehicles equipped

with this option, the lightcomes on when the ignition isswitched on then goes out.• If it lights up permanently,

consult your Renault Dealeras soon as possible;

• If it flashes, reduce theengine speed until the lightstops flashing.Consult your Renault Dealeras soon as possible.

Refer to the information onanti-pollution, fuel economyand driving in Section 2.

6   Over-revving warning lightIndicates that you needto change gear.

LPG mode operatingindicator

Refer to theLPG-poweredvehicles supplement.

7    Multifunction display

Oil level display functionThe vehicle must be parked onlevel ground and the engineshould have been switched off for some time beforehand toobtain an accurate levelreading.When the ignition has beenswitched on for approximately

30 seconds:-   if the level is correct, thedisplay will show “oil OK”

- when the minimum oil levelis reached:   the word “OK”will no longer be displayed,the dashes and the word“Oil” will flash and the SERVwarning light will light upuntil the engine is switchedoff.It is vital to top up as soon aspossible.

7    Total mileage recorder, tripmileage and clockCan be read approximately30 seconds after the ignition iswitched on.

8   Multifunction keyPress the key repeatedly tselect information on thdisplay, to reset the trip mileagrecorder or to set the clock.

loaded from www.Manualslib.com manuals search engine 

Page 54: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 54/210

2 3 4a 4 5

11 10 9 8 7

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 54

1.46

INSTRUMENT PANEL   (continued)The presence and operation of the warning lights described below depend on the vehicle equipment andcountry.

If the warning light comes on, you must stop as soon as traffic conditions allow.

If the warning light comes on, you should visit a Renault Dealer in the near future.

loaded from www.Manualslib.com manuals search engine 

Page 55: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 55/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 55

1.4

INSTRUMENT PANEL   (continued)The presence and operation of the warning lights, described below, depend on the vehicle equipment andcountry.

9   STOP lightIt goes out as soon asthe engine starts.

This lights up together withone of the warning lights:

Engine immobilisersystem indicator lightThis light performs

several functions.Refer to the information on theengine immobiliser in Section 1.

SERVICE warning lightThis lights up when theignition is switched on

and goes out after a fewseconds. If it lights up when thevehicle is being driven, it isadvisable to stop at a RenaultDealer soon.It lights up together with one of the warning lights:

9   Left turn signalindicator light

Low fuel level warninglightIt goes out as soon as

the engine starts.If it lights up or remains lit, fillup with fuel as soon aspossible.

Right turn signalindicator light

Electronic StabilityProgram (ESP) andtraction control

indicator lightThere are several reasons forthis warning light coming on:see Section 2 for informationon the Electronic StabilityProgram: ESP and the Tractioncontrol system.

9   Preheating/electronicfault or waterin the dieselwarning light.

• Preheating indicator lightThis light should come on

when the ignition key is inposition   M; it indicates thathe heater plugs arfunctioning. It goes out aftepreheating is sufficient anthe engine can be started.

•  Electronic fault/or watepresent in the diesel warninlightIf it comes on while drivingit indicates an electronifault or that water is presenin the fuel. Consult youRENAULT Dealer as soon a

possible.

loaded from www.Manualslib.com manuals search engine 

Page 56: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 56/210

2 3 4a 4 5

11 10 9 8 7

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 56

1.48

INSTRUMENT PANEL   (continued)The presence and operation of the warning lights described below depend on the vehicle equipment andcountry.

If the warning light comes on, you must stop as soon as traffic conditions allow.

If the warning light comes on, you should visit a Renault Dealer in the near future.

loaded from www.Manualslib.com manuals search engine 

Page 57: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 57/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 57

1.4

INSTRUMENT PANEL   (continued)The presence and operation of the warning lights described below depend on the vehicle equipment andcountry.

9   Coolant temperaturewarning lightIf this lights up when

the vehicle is being driven, itindicates that the engine isoverheating. Stop and allow theengine to run at idle speed for a

minute or two. Thetemperature should drop. If itdoes not, stop the engine andcheck the coolant level (havinglet the engine cool down).  Callfor the assistance of a RenaultDealer if necessary.

Oil pressure warninglightIt should go out as soon

as the engine starts; if it lightsup when you are driving, stopat once, switch off the ignitionand check the oil level. If this isnormal, call for the assistanceof a Renault Dealer.

9   Battery charge warninglightIt should go out as soon

as the engine starts.If it lights up when you aredriving, it indicates that thecircuit is overcharging or

discharged. Stop and have thecircuit checked.

Handbrake “on” and brake circuit incidentwarning light.

If it lights up when the brakesare applied, it indicates that thefluid level in the circuit is low.It may be dangerous tocontinue driving. Call for theassistance of a Renault Dealer.

10   Warning lights relating to thoperation of and/or faults inthe automatic gearbox oQuickshift 5.Refer to the information onautomatic gearbox in section 2

11   Variablepower-assisted steerinwarning light

It goes out as soon as the enginstarts. If it lights up when youare driving, this indicates fault in the system. Consulyour Renault Dealer as soon apossible.

loaded from www.Manualslib.com manuals search engine 

Page 58: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 58/210

Page 59: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 59/210

Page 60: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 60/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 60

1.52

ON-BOARD COMPUTER   (continued)

Examples of display selections bypressing button  3

Interpreting the display

e) Current consumption  (in mpg or litres/100 km)The value is displayed after reaching a speed of 15 mph (25 km/h).

f) Estimated range with remaining fuel (in miles or km)This function uses the average consumption since the last general reset.The value is displayed after covering 400 metres.

g) Distance covered  (in miles or km) since the last reset.

h) Average speed  (in mph or km/h) since the last reset.The value is displayed after covering 400 metres.

i) Cruise control or speed limiter recommended speed   (depending onvehicle).See the information on speed limiter and cruise control in section 2.

loaded from www.Manualslib.com manuals search engine 

Page 61: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 61/210

1BA   2

C

D

E

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 61

1.5

REAR VIEW MIRRORS

External rear view mirrors withmanual adjustmentTo adjust the mirror, move lever  1.

External rear view mirrors withelectrical adjustmentIgnition on, move knob  2:

- position  C  to adjust the left handmirror;

- position E  to adjust the right hand

mirror; D   is the central neutral position.

Heated rear view mirrorsThe mirrors are de-iced at the sametime as the rear screen demisting /de-icing is used.

The driver’s side externalrear view mirror has twoclearly marked areas. Zone

 B  corresponds to what cannormally be seen in a conventionalrear view mirror. Zone  A   increasesthe area visible to the rear and tothe side of your vehicle, for yoursafety.

Objects in zone   A   appear to bemuch further away than theyreally are.

loaded from www.Manualslib.com manuals search engine 

Page 62: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 62/210

1

2

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:45  - page 62

1.54

REAR VIEW MIRRORS   (continued)   STEERING WHEEL

Interior rear view mirrorThis is adjustable. When driving atnight, to avoid being blinded by theheadlights of a following vehicle,lower the small lever   1   located

 behind the rear view mirror.

Adjusting the steering wheelOn certain vehicles, the position of the steering wheel can be adjusted.

Lift lever   2   and set the steeringwheel in the required position.Lower the lever to lock the steeringwheel.

For safety reasons, onlyadjust the steeringwheel when the vehicleis stationary.

loaded from www.Manualslib.com manuals search engine 

Page 63: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 63/210

Page 64: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 64/210

4 5

4

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:46  - page 64

1.56

EXTERNAL LIGHTING AND SIGNALS   (continued)

Front fog lightsTurn the central ring   4   of the stalk to align the symbol withmark  5.

Operation of the fog lights dependson the external lighting selected anda warning light will light up on theinstrument panel.

Rear fog lightTurn the central ring   4of the stalk to align the symbol withmark  5.

Operation of the rear fog lightdepends on the external lightingselected and a warning light willlight up on the instrument panel.

Remember to turn this light off when it is no longer needed to avoidinconveniencing other road users.

The front and rear fog lights switchoff when the exterior lights arswitched off.

Special case

The front and rear fog lights do nooperate in automatic mode.

They only come on if the end o

ring   1   is in position o.

Lights on warning buzzerA warning buzzer will sound whena front door is opened and the lightare left on after the ignition has beenswitched off (to prevent dischargof the battery).

loaded from www.Manualslib.com manuals search engine 

Page 65: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 65/210

A

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:46  - page 65

1.5

ELECTRIC HEADLIGHT BEAM ADJUSTMENT

On vehicles fitted with thisfunction, the tumblewheel A allowsyou to adjust the height of the beamsaccording to load.

Turn the tumblewheel   A   down tolower the headlights and up to raisethem.

Versions

All versions except utility

Utility version

Tumblewheel adjustment positions A

Position 0 or 1: basic setting, luggagecompartment empty with driveralone or with a front passenger.

Position 2 or 3: vehicle with 5 personson board, luggage compartment empty.

Position 3: Vehicle luggage compartmentfully laden and driver only.

Position 4:  intermediate position.

Position0: Basic setting, vehicle unladen

Position 3:  Vehicle fully laden

Positions 1, 2, 4: Intermediate positions

loaded from www.Manualslib.com manuals search engine 

Page 66: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 66/210

1

A

B

C

D

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:46  - page 66

1.58

WINDSCREEN WIPER/WASHER

Vehicle fitted withintermittent wipingwindscreen wipersWith the ignition switched on, turnstalk  1

• A  off 

•  B   intermittent wipingThe wipers may stop for a fewseconds between wipesdepending on the version. It ispossible to vary the time

 between sweeps by turning thecentral ring on the stalk  1:

•  C   continuous slow wiping

•  D   continuous fast wiping

Vehicle fitted with windscreenwiper and rain sensorWith the ignition switched on, turnstalk  1

• A  off 

•  B   rain sensor positionWhen this position is selected,

the system detects the presenceof water on the windscreen andtriggers wiping at a suitablewiping speed.The central ring on stalk   1enables you to vary thesensitivity of the rain sensor–to  :

– represents minimumsensitivity

represents maximumsensitivity.

•  C   continuous slow wiping.

•  D   continuous fast wiping.

The rain sensor is deactivatedevery time the ignition isswitched off.To reactivate the sensor, return tostop position   A, then move torain sensor position   B. Thiscauses the wipers to sweep once.

Vehicles with automatiselection of wiping speedIf a wiping speed is selected whendriving, the wiping speed ireduced to a lower speed when thvehicle stops:

• from fast wiping speed the speedwill change to normal wipinspeed;

• from normal wiping speed thspeed will change to intermittenwiping.

As soon as the vehicle moves offwiping will return to the speedoriginally selected.

When the vehicle is stationarypressing stalk   1   overrides ancancels automatic operation.

Note:

If for any reason the wipers cannomove (e.g. stuck to windscreen by

ice), the system will automaticallycut off the power supply to thwipers.

loaded from www.Manualslib.com manuals search engine 

Page 67: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 67/210

1

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:46  - page 67

1.5

WINDSCREEN WASHER/WIPER   (continued)

Windscreen washer,headlight washersWith the ignition on, pull stalk   1towards you.

A short press triggers one sweepcycle of the wiper, while a longer

press triggers three cycles.•  Car lights off 

You activate the windscreenwasher and wiper.

This will make another sweepafter a few seconds.

•  Car headlights on

Press for longer than one secondto activate the windscreen washerand headlight washer devicessimultaneously.

In frosty weather, make sure thatthe wiper blades are not stuck byice (risk of motor overheating).

Keep an eye on the condition of the blades. Change the wiper

 blades as soon as they becomeless efficient (approximatelyonce a year).

If you switch off the ignition before switching off thewindscreen wiper (position   A)the blades will stop at random onthe windscreen.

loaded from www.Manualslib.com manuals search engine 

Page 68: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 68/210

1

2

1

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:46  - page 68

1.60

REAR SCREEN WASH/WIPE

Intermittent rear wiperIgnition on, turn the end of stalk   1   to align reference mark   2opposite the symbol.

Rear washerIgnition on, turn the end of stalk   1   to align reference mark   2opposite the symbol.

When the stalk is released, it returnsto the rear wiper position.

Special noteForcertain vehicles,if thewindscreenwipers are operating when reversegear is selected, the rear wiper willoperate intermittently.

In freezing conditions, make sure thathe wiper blades are not stuck to thewindscreen (risk of overheating thmotor).

Keep an eye on the condition of th blades. Change them as soon as the become less efficient: approximatelonce a year.

loaded from www.Manualslib.com manuals search engine 

Page 69: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 69/210

1

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:46  - page 69

1.6

DE-ICING

Heated rear screen

With the engine running,press button   1   (the warning lightlights up on the instrument panel).

This function ensures the de-icingand demisting of the rear screen and

the heated external rear-viewmirrors (if the vehicle is fitted withthem).

The function is stopped:

- automatically after 15 minutesoperation,

- by pressing button   1   again (thewarning light goes out).

loaded from www.Manualslib.com manuals search engine 

Page 70: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 70/210

1

3   1

0

2

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:46  - page 70

1.62

AUDIBLE AND VISIBLE SIGNALS

HornPress on the central cushion of steering wheel  2.

Headlight flasherTo flash your headlights, even if thelights are not in use, pull the stalk  1towards you.

Special caseIf automatic operation for dippedheadlights is activated, first pullstalk 1 towards you to light the main

 beam headlight then again to turnthem off.

Hazard warning lightsPress switch  3.

This switch lights up all fourindicators at the same time.

It is to be used in cases of danger towarn other road users that you:

• are obliged to stop in a normallyprohibited location,

• are obliged to drive underparticular conditions.

Direction indicatorsMove stalk 1  parallel to the steerinwheel and in the direction in whichyou are going to turn.

When driving on the motorway, thsteering wheel is not often turned

far enough to return the stalkautomatically to position 0. There ian intermediate position in whichthe stalk can be held when changinlanes.

When the stalk is released, iautomatically returns to  0.

loaded from www.Manualslib.com manuals search engine 

Page 71: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 71/210

1

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:46  - page 71

1.6

FUEL TANK

Useful capacity of the fuel tank:

Approximately  11 gallons(50 litres).

There is a cap holder  1  on the fuelfiller flap for holding the cap whenfilling the tank.   Fuel filler cap: this is of a

special type. If you have tochange it, make sure thenew cap is of the sametype.

Never handle the cap near a sourceof heat or a flame.

Fuel grade

Petrol version

Use fuel which corresponds to thappropriate grade defined by thstandards in force in the particulacountry you are in.

Refer to the Engine specificationsection.

Diesel versions

Use diesel fuel only. When fillinthe tank, ensure that no water enterthe tank accidentally. The filler capand the neck must be clean anddust-free. The fuel must be of highquality.

Rapeseed oil must not be used under anycircumstances. Also, donot mix even small

amounts of petrol with diesel.

loaded from www.Manualslib.com manuals search engine 

Page 72: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 72/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T1.WIN 4/11/2002 13:46  - page 72

1.64

FUEL TANK   (continued)Filling with fuel

Petrol version

Use  unleaded fuel only.

Using leaded fuel will damage thedepollution equipment and maylead to a loss of warranty.

To avoid the tank being filled withleaded fuel, the filler neck has a

restrictor with a valve   which onlyallows an unleaded petrol nozzle to be used  (at the petrol pump).

- Insert the nozzle to open the valve,as far as it will go.

- Hold the nozzle in this positionwhile the tank is filled and thenrelease it.

Filling with fuel  (continued)

Petrol and diesel versions

To allow room for expansion in thefuel tank, do not top up more thantwice after the pump nozzle has cutout automatically.

Any operation ormodification on the fuelsupply system (computers,wiring, fuel circuit, in-

jector, protective covers...) isstrictly forbidden due to thesafety risks it may cause (exceptfor qualified staff from theRenault network.

Persistent fuel odourYour vehicle has a pressurised fuesupply system. If a persistent fueodour should occur, please:

• stop the vehicle if trafficonditions allow and switch thignition off;

• switch on the hazard warninlights and ask all passengers t

leave the vehicle to keep themaway from the traffic;

• do not intervene or restart beforthe vehicle has been checked byqualified Renault network staff.

loaded from www.Manualslib.com manuals search engine 

Page 73: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 73/210

Page 74: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 74/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 2

2.02

RUNNING IN IGNITION SWITCHPetrol versionFor the first 625 miles (1,000 km), donot exceed 80 mph (130 km/h) in thehighest gear or 3,000 to 3,500 rpm.

After 625 miles (1,000 km), you maydrive your car normally, but it isonly after 1,500 miles (3,000 km)have been covered that you mayreasonably expect full performance.

Service intervals: refer to thevehicle’sWarranty and Servicing booklet.

Diesel versionFor the first 750 miles (1,500 km), donot exceed 2,500 rpm. On completionof this mileage you may drive faster,

 but the vehicle will only provide topperformance after approximately4,000 miles (6,000 km).

During the running in period, donot accelerate hard while the engine

is still cold and do not let the enginerev too high.

Service intervals: refer to thevehicle’sWarranty and Servicing booklet.

“Stop” position and anti-theft lockapplied St

To lock, remove the key and turn thesteering wheel until the latch clicksas it engages in the steering column.

To unlock, turn the key and steeringwheel slightly.

“Accessories” position A

The ignition is switched off. Anyaccessories (radio...) will continueto function.

“Ignition on” position M

The ignition is on:

• petrol version: the engine may bstarted

• diesel version:   the heater plugare on.

“Start” position D

If the engine does not start, turn thkey back before activating thstarter motor again. Release the keyas soon as the engine starts.

loaded from www.Manualslib.com manuals search engine 

Page 75: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 75/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 3

2.0

STARTING AND STOPPING THE ENGINEStarting the engine   Petrol injection

Engine hot or cold

- Turn the key to the Startposition   without depressingthe accelerator.

- Release the key as soon as theengine starts.

  Diesel injection

Cold or warm engine

Turn the ignition key to theignition on position M, and holdthis position until the preheatingwarning light goes out.

Turn the key to the starterposition  D, without accelerating.

Release the key as soon as theengine starts.

Stopping the engineWith the engine idling, return thekey to the “Stop” position.

If there is a child (or pet) inthe car, never leave itunattended with the key inthe ignition. With the key

in the ignition it would be possibleto operate the electrical equipmentsuch as the windows and there is arisk that the child may be seriouslyinjured (by trapping his or herneck, arm, hand, etc.).

Never switch off the ignition before the vehicle has stoppedcompletely.   Once the engine hasstopped, the power steering, brakeservo and passive safety devicessuch as airbags and pretensionerswill no longer operate.

When the key has been removed,the steering will lock.

loaded from www.Manualslib.com manuals search engine 

Page 76: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 76/210

Page 77: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 77/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 5

2.0

SPECIAL POINTS - DIESEL VERSIONSDiesel engine speedDiesel engines have an injectionsystem with a mechanical governorwhich prevents overrevving of theengine regardless of the gear engaged.

Running out of fuelAfter filling the tank, if you have run

completely out of fuel,  on conditionthat the battery is fully charged, theengine may be started normally.

If, after a few seconds, after severalattempts, the engine will not start,call for the assistance of a RenaultDealer.

Winter precautionsTo avoid any problems in icyconditions:

• ensure your battery is always wellcharged.

• ensure the fuel level in the tanknever drops too low to avoidcondensation forming at the

 bottom of the tank.

Vehicles fitted with a diesel fuelheaterThis allows diesel fuel to be usedwith no additives down to   –18°C,or, in the case of a vehicle usedregularly over short distances(engine cold)  down to  –5°C.

loaded from www.Manualslib.com manuals search engine 

Page 78: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 78/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 6

2.06

ADVICE ON ANTIPOLLUTION AND HOW TO ECONOMISE ON FUEL WHEN DRIVINGRENAULT actively participates inthe reduction of pollutant exhaustgas emissions and in saving energy.

By virtue of its design, its originalsettings and moderate fuelconsumption, your RENAULTconforms to the current antipollutionstandards. Technical design cannotachieve everything, however. The

level of exhaust gas pollutantemissions and the fuelconsumption of your vehicle iswithin your control. Ensure thatyour vehicle is maintainedcorrectly, and that you drive and useit carefully.

MaintenanceNot observing the antipollutionlegislation may lead to the owner of the vehicle being prosecuted.Replacing parts of the engine, thefuel supply system and the exhaustwith parts which are not originalparts recommended by themanufacturer may mean that your

vehicle no longer conforms to theantipollution regulations.

Have your vehicle checked andadjusted by your Renault Dealer inaccordance with the instructions inyour Warranty and Servicing booklet.

Your Renault Dealer has all theequipment necessary to ensure thatyour vehicle is maintained to itsoriginal standard.

Always remember that the emissionof pollutant fumes is directly linkedto fuel consumption.

Engine adjustments• ignition: this requires no adjustmen

• spark plugs:  optimum conditionof use, performance and outpurequire that the specificationlaid down by our DesignDepartment be rigorouslyadhered to.

If the spark plugs have to breplaced, use the make, type andgap specified for your engineConsult your Renault Dealer fothis information.

• idle speed:   this requires nadjustment.

• air filter, diesel fuel filter:   blocked cartridge reduces outpuand must be replaced.

• injection pump setting:  this mus be set to the recommended values

loaded from www.Manualslib.com manuals search engine 

Page 79: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 79/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 7

2.0

ADVICE ON ANTIPOLLUTION AND HOW TO ECONOMISE ON FUEL WHEN DRIVING (continuedMonitoring exhaust gasThe exhaust gas monitoring systemwill detect any malfunctioning of the vehicle's exhaust gasdepollution system.

If this system malfunctions, toxicsubstances may be released into theatmosphere or mechanical damagemay occur.

This warning light on theinstrument panel willindicate if there are anyproblems with the system:

This lights up when the ignition isswitched on and then goes out.

- If it lights up continuously,consult your Renault Dealer assoon as possible.

- If it flashes, reduce the enginespeed until the light stopsflashing. Consult your RenaultDealer as soon as possible.

Driving•   Drive carefully for the first few

miles until the engine reaches itsnormal operating temperaturerather than letting it warm upwhile stationary.

• Speed is expensive.

• “Snappy” driving uses a lot of fuel: drive with a “light rightfoot”.

• Brake as little as possible bsuitably anticipating an obstaclor bend and then simply releasinthe accelerator pedal.

• Avoid sudden acceleration.

• Do not overrev the engine inintermediate gears.Use the highest gear possiblwithout labouring the engine.

(On versions with an automatigearbox, try to always usposition  D.)

• Try not to maintain the samspeed up a hill as you would onthe level; keep your foot in thsame position on the acceleratopedal.

• Double declutching andaccelerating before switching ofthe engine are superfluouactions in modern cars.

• Bad weather, flooded roadsDo not drive on floodedroads if the depth owater is above the loweedge of the wheel rims

loaded from www.Manualslib.com manuals search engine 

Page 80: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 80/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 8

2.08

ADVICE ON ANTIPOLLUTION AND HOW TO ECONOMISE ON FUEL WHEN DRIVING  (continued)

General hints•  Electricity is “fuel”; switch off all

the electrical units which are notreally needed.

However,   (with safety always inmind), keep your lights on whenthe visibility is bad (see and beseen).

• Try to use the air vents. Driving ata speed of 60 mph (100 km/h)with the windows open willincrease the use of fuel by 4%.

•  For vehicles fitted with airconditioning, more fuel may beused during urban driving; switchoff the system when it is not reallyneeded.

• Never fill the fuel tank up to the brim to avoid it overflowing.

• Do not leave an empty roof rack inposition.

• Use a trailer for carrying bulkyobjects.

• When towing a caravan, fit a winddeflector and adjust it properly.

• Avoid using the car for door todoor calls (short journeys withlong stops in between), as theengine never reaches its idealtemperature. Try to group yourcalls.

Tyres•  Inflation pressures which are too

low may increase fueconsumption.

• The use of non-recommendedtyres may also increase fueconsumption.

loaded from www.Manualslib.com manuals search engine 

Page 81: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 81/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 9

2.0

ENVIRONMENTYour vehicle has been designed withthe aim of caring for the environment.

• Most versions are fitted with adepollution system incorporatingthe   catalytic converter, oxygensensor and active carbon filter(which prevents fuel vapourevaporating from the fuel tankinto the open air).

•  These vehicles run on unleadedfuel only.

•  your vehicle comprises 87%recyclable parts   and alreadycontains parts which are madefrom recycled materials (as markedon the diagram above).

• 95% of the plastic parts in yourvehicle are marked by a symbolwhich allows the principalcomponentmaterial to be identified.This marking means that the partsremoved can be sorted moreeasily, making recycling of each of 

them easier.

In addition, your vehicle meets therequirements of European legislationconcerning the protection of theenvironment.

Make your contribution toenvironmental protection too !

Do not dispose of parts replaced inthe course of routine vehiclemaintenance (battery, oil filter, airfilter...) and oil cans (empty or filledwith old oil...) with householdwaste.

Dispose of them through specialistorganisations. In all cases complywith local legislation.

loaded from www.Manualslib.com manuals search engine 

Page 82: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 82/210

A

B

C

1

FG

H

I

E

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 10

2.10

PROACTIVE AUTOMATIC GEARBOX

Selector lever  1P   : ParkR : ReverseN : NeutralD : Drive in automatic

(gears authorised: 1, 2, 3 and 4)2   : 2nd gear hold  H 

(gears authorised: 1, 2)1   : 1st gear hold  H .

The display E and indicator lights F ,G,   H ,   I , on the instrument panelindicate the position of the gearlever 1 and/or the operating mode of the automatic gearbox.

Position D3 or 3rd gear hold(Gears authorised: 1, 2, 3).

With the selector lever in positionD, press button  B. Indicator light  Gwill light up on the instrumentpanel. Press button   B   again todeselect this position. (indicatorlight will go out.)

Note: When indicator light is lit, thesystem will prevent 4th gear beingselected.

For safety reasons, certain positionmay not be selected until thmechanismis released: press button A

The lever may only be moved to Dor R when the vehicle is stationarywith your foot on the brake and theaccelerator pedal released.

Moving off forwardsWith the lever in position P   or   Nswitch on the ignition.

With your foot on the brake pedalmove the lever out of position P or N

For safety reasons, to take the leveout of position P, the brake pedamust be pressed before pressing thereleasing button  A.

loaded from www.Manualslib.com manuals search engine 

Page 83: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 83/210

C

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 11

2.1

PROACTIVE AUTOMATIC GEARBOX   (continued)Forward gearsMove the lever to position D. In themajority of traffic conditions, youwill not have to move the leveragain: the gears will changeautomatically at the right time andat the appropriate engine speed,since the automatic system takesinto account the vehicle load, the

road contour and the particulardriving style you have chosen.

Acceleration and overtakingFully depress the accelerator pedalquickly (or take your foot off theaccelerator and press it in again asfar as it will go).

When the pedal is depressedquickly, it activates the“kickdown” switch to obtainmaximum performance.

Special circumstances• Snow position:  if you are driving

on a surface with low adhesion(snow, mud etc.), press switch C ,warning light  F  will come on.

When these driving conditions no

longer apply, turn the system off  by pressing button   C   again andthe warning light will go out.

• In hilly or mountainous countryif the road conditions and thnumber of bends do not allow youto remain in 4th, we recommendyou select position   D3   (bypressing button  B, with the gealever in position   D), or even  (2nd gear hold), to avoid thtransmission changing to a highegear than the one selected

Position 1, which enforces the usof 1st gear, gives good engin

 braking.

When travelling downhill for long way, select position  D3  or  2(or even  1) to give more efficienengine braking, and to relieve th

 brakes.

•   In cold weather, to prevent thengine from stalling, wait for few moments before moving thlever from position   P   or   N   tposition  D  or  R.

loaded from www.Manualslib.com manuals search engine 

Page 84: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 84/210

A

J

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 12

2.12

PROACTIVE AUTOMATIC GEARBOX   (continued)

Economical drivingOn the open road, always leave thelever in position   D. Press theaccelerator pedal lightly to ensurethat the gears change automaticallyat a low engine speed.

Never use positions D3, 2, 1 and thesnow position unless specialcircumstances apply.

Parking the vehicleWhen the vehicle is stationary,place the lever in position  P  whilekeeping your foot on the brakepedal: the automatic gearbox is inneutral and the drive wheels aremechanically locked by thegearbox.

Apply the handbrake.

Operating faults• If the lever becomes jammed in P,

even though you are depressingthe brake pedal, it can be releasedmanually.

To do this, unclip the cover J  thensimultaneously press the button(located under the cover   J ) andthe unlocking button  A   to movethe lever from  P.

Consult your RENAULT Dealer.

• If warning light   I   comeon when the vehicle i

 being driven, it iindicating that there is a failureConsult a RENAULT Dealer asoon as possible.

• and : If thes

warning lights come on

simultaneously when thvehicle is being driven, avoidleaving the gear lever in   Dposition (or  R) when stopping intraffic: always return to   Nposition when stopped. Consult RENAULT Dealer as soon apossible.

•  If a vehicle with an automatigearbox breaks down, refer to thinformation on towing in section 5

loaded from www.Manualslib.com manuals search engine 

Page 85: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 85/210

1

4

3

5

2

6

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 13

2.1

QUICKSHIFT 5 GEARBOX

Selector lever

1  Mode selection button: enablesyou to move from manual mode toautomatic mode or fromautomatic to manual mode at anytime with the engine running.

Note:   The selector leverautomatically returns to the middleposition after use.

Display

2  automatic mode

3  brake pedal depressed warninglight

4  gear display

5  not used

6  gearbox fault warning light.

The gear used (1,   2..,   5,   N ,   R) isindicated in the instrument paneldisplay. In automatic mode,   (A)   isalso displayed.

DrivingSwitch on the ignition.

The display lights up on thinstrument panel.

As long as neutral is displayed ( N )start the engine but do not depresthe accelerator.

If a gear other than neutral   (N)   i

displayed this will flash; it will onl be possible to start the engine if youpress down the brake pedal (thwarning light 3  will come on if youforget) when holding the key instarting position.

The vehicle will then change tneutral ( N ) automatically and thengine will start.

Note: do not attempt to start thengine by pushing the vehicle if th

 battery is flat (the display remainoff when the ignition is switche

on).

loaded from www.Manualslib.com manuals search engine 

Page 86: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 86/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 14

2.14

QUICKSHIFT 5 GEARBOX   (continued)Starting upMoving forwards   (starting inneutral)

The gear display shows  N  and  A.

•  With your foot on the brakepedal, push the selector levertoward the front and then releaseit again.

• Release the brake pedal:

- it is possible to carry out parkingmanoeuvres when the engine isidling.

- accelerate gently to move off.

Note: you can pull away in secondgear if you are driving on slipperysurfaces (snow, mud, etc.).

To do this, move the gear selectorlever twice with your foot on the

 brake pedal.

The figure   2   appears on thedashboard display. The system is

then running in semi-automaticmode.

To return to automatic mode, pressthe mode change button.

Reverse

• Foot on the brake pedal. Push thelever as far as it will go to theright, hold and pull backaccording to the marking on theknob, then release it. Reverse gearis engaged and the letter   Rappears on the display.

• Release the brake pedal:- it is possible to carry out parking

manoeuvres when the engine isidling.

- accelerate gently to reverse.

Note:  You should put your foot onthe brake to engage or disengage agear when stopping. Otherwise, thegear selected will flash and thewarning light  3  will come on.

Gear selection gate+  To move up through the gears

– To move down through the gear

 N   Neutral

 R   Reverse

•Only stable lever position

loaded from www.Manualslib.com manuals search engine 

Page 87: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 87/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 15

2.1

QUICKSHIFT 5 GEARBOX   (continued)Semi-automatic mode (manual)When in automatic mode, movingthe selector lever up or downthrough the gears or pushing theautomatic mode switch will switchthe system into semi-automaticmode. If you push the switch, youdo not need to shift up or downthrough the gears.

You can initiate gear changes usingthe selector lever.

To move up through the gearssimply push the selector leverforwards without necessarilyreleasing the accelerator.

To move down through the gearssimply push the selector lever

 backwards without necessarilyreleasing the accelerator.

The system will not tolerate a seriesof up or down changes that causethe engine to underrev or overrev.

Pushing forwards twice insuccession enables a shift up of twogears at once (except in the case of underrev). Pulling backwards twicein succession enables a shift down

of two gears at once (except in thecase of overrev).

When decelerating with the foot off the pedal, the gears willautomatically drop to the low speedlimit to avoid stalling. First gearautomatically passes below acertain speed limit. You can stop thevehicle at red lights or junctions etc.

 by pressing the brake pedal; there isno need to change to neutral ( N ).

The vehicle will move off again:

- slowly, if you release the brakwithout accelerating (e.g. when ina traffic jam)

- quickly, if you release the brakand accelerate.

Note:   neutral is only accessibl

when you are driving or stationarywith  your foot on the brake (if youforget, the warning light   3   wilcome on and the  N  sign will flash)

Push the gear lever to the right toengage neutral.

Moving from one mode to anothecan be performed with the enginrunning, at any time and in alratios.

loaded from www.Manualslib.com manuals search engine 

Page 88: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 88/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 16

2.16

QUICKSHIFT 5 GEARBOX   (continued)Automatic modeAutomatic mode is selected bydefault every time the ignition isswitched on.

You can change it at any time whendriving by pressing the modechange button. The letter A appearson the display.The vehicle is controlled using the

accelerator and the brake. Gears willchange automatically at the correctmoment to a speed suitable for theengine because the automaticfunction takes into considerationthe weight of the car, the roadsurface and the chosen drivingstyle.

Note:

Automatic mode takes account of:

- the position and speed of  depression of the acceleratorpedal to assess driving style andselect the optimum gear,

- action on the brake pedal to alertthe engine brake by anticipatingthe down-change

You can stop the vehicle at redlights, with the gear engaged, bypressing the brake pedal; there is noneed to change to neutral.

The vehicle will move off again:

- slowly, if you release just the brakewithout accelerating (e.g. when ina traffic jam)

- quickly, if you release the brakeand accelerate.

The level of oil in theautomatic gearbox systemreservoir is variabledepending on use. Adding

oil is  strictly forbidden   (except byqualified Renault networkpersonnel).

loaded from www.Manualslib.com manuals search engine 

Page 89: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 89/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 17

2.1

QUICKSHIFT 5 GEARBOX   (continued)Accelerating and overtakingYou have two options:

1) slowly depress the acceleratorpedal to speed up gradually.

2) depress the accelerator pedal asfar as it will go (or: take your footoff the pedal and depress thepedal again until you reach thepoint of resistance.

ParkingIt is possible to park in gear (forexample, on a slope). To do this:

- with the ignition on, select a gearwith your foot on the brake.

- check that a gear other than   N   isdisplayed on the instrumentpanel, then remove the ignitionkey.

To disengage the gear, repeat thisoperation by switching on theignition without starting the engineand shift the selector lever toneutral with your foot on the brake.

Check that   N   is displayed on theinstrument panel.

loaded from www.Manualslib.com manuals search engine 

Page 90: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 90/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 18

2.18

QUICKSHIFT 5 GEARBOX   (continued)Horn•  If you keep the vehicle on a slope

for too long without applying the brakes or handbrake, there is arisk that the clutch will overheat.

In this event, an intermittent beepwill remind you that you shouldput your foot on the brake orapply the handbrake.

• Never leave the vehicle with theengine running when in gear.For safety reasons you will hearan intermittent beep when youopen the door if you have notshifted into neutral or you havenot switched off the ignition orpressed the brake pedal.

• Your vehicle will not start:

you can start the engine when thevehicle is moving if the battery isnot discharged (display lit up).

Proceed as before:

- switch on the ignition- select neutral- push or tow the car or run it

down a slope until you reach thespeed at which the warning

 buzzer is activated. This willindicate that moving theselector lever forwards willengage the gear most suited tostarting the engine.

Note: never attempt this in reverse.

Operating faultsWhen driving, if thiwarning light comes on, iindicates a fault in th

system.In most cases, you may still drivthe vehicle, although it will nofunction perfectly. However, youshould consult a Renault Dealer a

soon as possible.

Towing a vehicle with asequential gearboxIf the gearbox is stuck in a gear:

- switch on the ignition

- select neutral with your   foot onthe brake

- check that the gearbox is in neutra(by pushing the vehicle, foexample).

If you cannot find neutral you mustow the vehicle with the fronwheels raised.

Towing should always take placwith the ignition switched off.

loaded from www.Manualslib.com manuals search engine 

Page 91: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 91/210

Page 92: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 92/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 20

2.20

ANTI-LOCK BRAKING SYSTEM (ABS)When braking sharply, the two mainaims are to reduce the stoppingdistance and to keep the vehicleunder control. However, dependingon the nature of the ground, theatmospheric conditions and yourreactions, dangers due to loss of adherence may exist: the wheelsmay lock and directional controlmay be lost. To avoid these risks,

your vehicle has been fitted withthe anti-lock braking system (ABS).

The safety enhancement is that the brake control system prevents thewheels from locking, even if the

 brakes are applied too sharply,allowing the vehicle to be steeredand thus itsdirection to be controlled.Under these circumstances, it is quitepossible for the driver to steer thevehicle and avoid an obstacle whilstat the same time applying the brake.This system also allows stoppingdistances to be improved, especially

when adhesion is limited (wet roads,slippery or uneven road surface).

Although this system allows thisoptimisation, the ABS system in noway increases performance which isphysically related to the localadherence conditions between thetyres and the ground. You must stillfollow the rules of good drivingpractice (driving at a safe distancefrom the vehicle in front etc.).  Thefact that the vehicle’s safety has been

increased should not encourage youto take risks.

Each time the system is activated,you will feel a certain degree of pulsation at the brake pedal. Thesetangible signs will warn you that theadhesion between the tyres and theground has reached its limit andenable you to adapt your drivingstyle to suit the road conditions.

Operating incidentsTwo situations must be considered

1 - The warning light i

illuminated on the instrumenpanel.

Braking is still assured, buwithout the action of the ABSsystem. Consult a Renault Dealeas soon as possible.

2 - The warning lights

are illuminated on the instrumenpanel.

This indicates a fault in one othe ABS braking componentsBraking may be partially assuredIt is however dangerous to braksharply, so you must stopimmediately as soon as trafficonditions allow. Call for thassistance of a Renault Dealer a

soon as possible.

The braking modulation provided by the ABS system is independent of the force applied at the pedal. In anemergency, apply   firm, continuous pressure  at the brake pedal - there is no need to pump it repeatedly.

loaded from www.Manualslib.com manuals search engine 

Page 93: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 93/210

1

2

  6

5

3

4

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 21

2.2

CRUISE CONTROL - SPEED LIMITER: limiter function

The speed limiter function allowsyou to decide on a maximumdriving speed.

This may be useful, for example, intown driving or in areas with speedrestriction (roadworks), etc.

The system operates above a drivingspeed of approximately 20 mph(30 km/h).

Controls1  Main On/Off switch

2  Limited speed storage switch andadjustment of limited speed(increasing).

3  Return to stored limited speed.

4  Switching the function off (withstored limited speed)

5  Limited speed storage switch andadjustment of limited speed(decreasing).

Indicator light

This orange indicator light lights upon the instrument panel to indicatthat the limiter function is inoperation.

Stored speed information appear

on instrument panel display  permanently or for approximately30 seconds, depending on vehicltype.

loaded from www.Manualslib.com manuals search engine 

Page 94: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 94/210

1

2

5

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 22

2.22

CRUISE CONTROL - SPEED LIMITER: limiter function   (continued)

Switching onPress the side switch  1

The indicator light lights up in theinstrument panel and the on-boardcomputer enters speed limitermode.

Limiting the speedAt a stable speed (approximately20 mph or 30 km/h) and in thecorrect gear (for vehicles withmanual gearboxes), press switch  2:the speed is stored.

DrivingWhen a limited speed is stored,press on the accelerator pedal untilyou reach the limited speed.

From this point, no effort on theaccelerator pedal will allow you toexceed the programmed speedexcept in an emergency (seeinformation on exceeding the

limited speed).

Changing the limited speedThe limited speed may be changed

 by acting (pressing frequently ocontinuously) on:

- button  2   to increase speed,

- button  5   to reduce speed.

If the car has the temporary displayfunction, the limited speed idisplayed for approximately 3seconds.

loaded from www.Manualslib.com manuals search engine 

Page 95: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 95/210

1

3

4

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 23

2.2

CRUISE CONTROL - SPEED LIMITER: limiter function   (continued)Exceeding the limited speedIn the event of an emergency

It is possible to exceed the limitedspeed at any moment. To do this:depress the accelerator pedal firmlyand fully   (beyond the point of resistance).

The speed flashes on the instrumentpanel (on-board computer) to

inform you that the cruise controlspeed is being exceeded.

When the emergency has passed,release the accelerator pedal: thespeed limiter function will return assoon as you reach a speed lowerthan the limited speed before theemergency.

Impossible to operate at the limitedspeed

If the limited speed cannot bemaintained by the system (forexample in the event of a steepincline), the speed will flash on theinstrument panel (on-boardcomputer).

Switching the function off The speed limiter function isinterrupted when you press:

- button  4, in this case the limitedspeed remains stored

- button  1, in this case the limitedspeed is no longer stored.

Confirmation that the function has been switched off is given when theindicator light on the instrumentpanel goes out.

Return to limited speedIt is possible to return to a storedspeed by pressing button  3.

If the car has the temporary displayfunction, the limited speed idisplayed for approximately 3seconds.

loaded from www.Manualslib.com manuals search engine 

Page 96: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 96/210

1

2

  6

5

3

4

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 24

2.24

CRUISE CONTROL - SPEED LIMITER: cruising function

When road conditions permit (fluidor motorway traffic), the cruisecontrol allows you to take your footoff the accelerator while your carcontinues to cruise at the speed youhave selected. This is called the“cruising speed”.

This cruising speed may be set atany speed at speeds of 20 mph(30 km/h) and above.

Controls1  Main On/Off switch

2  Cruising speed storage switch andadjustment of limited speed(increasing)

3  Return to stored cruising speed

4  Switching the function off (withstored cruising speed)

5  Cruising speed storage switch andadjustment of limited speed(decreasing)

Indicator light

This green indicator light lights upon the instrument panel to indicatthat the cruising function is inoperation.

Stored speed information appear

on instrument panel display  permanently or for approximately30 seconds, depending on vehicltype.

loaded from www.Manualslib.com manuals search engine 

Page 97: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 97/210

1

2

5

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 25

2.2

CRUISE CONTROL - SPEED LIMITER: cruising function   (continued)

Switching onPress side switch  1

The indicator light lights up in theinstrument panel and the on-boardcomputer enters cruise controlmode.

Activating cruise controlAt a stable speed (approximately20 mph or 30 km/h) and in thecorrect gear (for vehicles withmanual gearboxes), press switch  2:the speed is stored.

DrivingWhen a cruise control speed isstored you can lift your foot off theaccelerator pedal.

Changing the cruise control

speedThe cruise control speed may bechanged by acting (pressingrepeatedly or continuously) on:

- button  2   to increase speed,

- button  5   to reduce speed.

If the car has the temporary displayfunction, the limited speed isdisplayed for approximately30 seconds.

Exceeding the cruise controspeedIn the event of an emergency

The cruising speed may bexceeded at any time by pressinthe accelerator pedal.The speed flashes on the instrumenpanel (on-board computer) tinform you that the cruise contro

speed is being exceeded.When the emergency has passedrelease the accelerator pedal: youvehicle will automatically return tothe speed previously selected andthe indicator light will go out.

Impossible to operate at the speedselected

If the adjusted speed cannot bmaintained by the system (foexample in the event of a steepincline), the speed will flash on thinstrument panel (on-board

computer).

loaded from www.Manualslib.com manuals search engine 

Page 98: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 98/210

1

3

4

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 26

2.26

CRUISE CONTROL - SPEED LIMITER: cruising function   (continued)

Switching the function off The function is switched off whenyou:

- press the brake pedal,

- press the clutch pedal to shift toneutral for vehicles withautomatic gearbox,

- press button   4; in this case theselected speed remains stored,

- press button   1; in this case theselected speed is no longer stored.

Confirmation that the function has been switched off is given when theindicator light on the instrumentpanel goes out.

Return to cruising speedA stored speed can be recalled bypressing button 3  if you are drivingat a speed of approximately 20 mph(30 km/h).

If the car has the temporary displayfunction, the limited speed isdisplayed for approximately 30seconds.

This function is anadditional aid to driving.

However, the function doesnot take the place of the

driver. Under no circumstancesshould it replace observation of speed limits nor vigilance andresponsibility on the part of thedriver.

loaded from www.Manualslib.com manuals search engine 

Page 99: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 99/210

1

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 27

2.2

ELECTRONIC STABILITY PROGRAM: ESPThis system helps you to keepcontrol of the vehicle in “critical”driving conditions (avoiding anobstacle, loss of grip in a bend...).

This function is anadditional aid in theevent of critical drivingconditions to allow the

 behaviour of the vehicle to beadapted to the drivingconditions.

However, the function does nottake the place of the driver.   Itdoes not increase the vehicle'slimitations and should notencourage you to drive morequickly.

It can, thus, under nocircumstances replace thevigilance or responsibility of thedriver when manoeuvring thevehicle (the driver must always

 be aware of sudden incidentswhich may occur when driving).

Operating principleA sensor in the steering wheeldetects the path selected by thedriver.

Other sensors throughout thevehicle measure the actual path.

The system compares the pathselected by the driver and the actualvehicle path and corrects this asnecessary by applying the brakesselectively and/or acting on theengine power.

When the function is in operationmessage 1  lights up to confirm this

loaded from www.Manualslib.com manuals search engine 

Page 100: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 100/210

2

1

3

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 28

2.28

ELECTRONIC STABILITY PROGRAM: ESP   (continued)

Disabling the functionThe function is deactivated bypressing switch   2, warning light   1will light up to confirm this.

This action also deactivates tractioncontrol: see the information on thetraction control system in section 2.

As the ESP offers additional safety,it is recommended that you do notdrive when the function is disabled.Correct this as soon as possible bypressing button  2   again.

Note:   ESP is automaticallyreactivated when the ignition isswitched on.

FaultsWhen the system detects anoperating fault, warning lights  and  3   light up.

Consult your Renault Dealer.

loaded from www.Manualslib.com manuals search engine 

Page 101: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 101/210

1

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 29

2.2

TRACTION CONTROL SYSTEMThis system helps to limit skiddingon drive wheels and to control thevehicle when pulling away oraccelerating.

This function is anadditional aid in theevent of critical drivingconditions to allow the

 behaviour of the vehicle to beadapted to the drivingconditions.

However, the function does nottake the place of the driver.   Itdoes not increase the vehicle'slimitations and should notencourage you to drive morequickly.

It can, thus, under nocircumstances replace thevigilance or responsibility of thedriver when manoeuvring thevehicle (the driver must always

 be aware of sudden incidentswhich may occur when driving).

Operating principleThe system uses sensors in thewheels to constantly measure andcompare the speed of the drivewheels and prevents them spinning.

If a wheel is tending to skid, thesystem brakes automatically untilthe drive delivered becomescompatible with the level of grip.

The system also adjusts the enginspeed to the grip available under thwheels, independently of the actionexerted on the accelerator pedal.

When the function is in operationmessage 1  lights up to confirm this

loaded from www.Manualslib.com manuals search engine 

Page 102: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 102/210

2

1

3

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T2.WIN 30/10/2002 12:06   - page 30

2.30

TRACTION CONTROL SYSTEM   (continued)

Disabling the functionIn some situations (driving on verywet ground: snow, mud,... ordriving with chained wheels), thesystem may reduce the enginepower to limit skidding. It ispossible to deactivate the function

 by pressing switch   2   if this is notdesirable.

Warning light  1   lights up.

Disabling the traction controlfunction also deactivates the ESPfunction: refer to the information onthe ESP in section 2.

Correct this as soon as possible bypressing switch  2   again.

Note:   traction control isautomatically reactivated when theignition is switched on.

Operating faultsWhen the system detects anoperating fault, warning lights  and  3   light up.

Consult your Renault Dealer.

loaded from www.Manualslib.com manuals search engine 

Page 103: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 103/210

nu654-6 - CLIO II   C :\Documentum\Checkout\nu654-6_eng_T 3.WIN 30/10/2002 12:12   - page 1

3.0

Section 3: Your comfort 

Air vents ....................................................................................................................... .......................... 3.02 - 3.03

Heating and air conditioning .............................................................................................................. 3.04    3.22

Interior lights .......................................................................................................................................... 3.23 - 3.24

Electric windows .............................................................................................................................................. 3.25Sun visor/Vanity mirrors/Windscreen .............................................................................................. .............. 3.26

Sunroof ................................................................................................................................................. 3.27    3.29

Storage compartments ........................................................................................................................... 3.30 - 3.31

Ashtrays - Cigarette lighters ............................................................................................................................ 3.3

Rear bench seat ................................................................................................................................................. 3.3

Luggage compartment ............................................................................................................................ 3.34 - 3.35

Rear window shelf - separating grille ......................................................................................................... 3.3

Transporting items in the luggage compartment ....................................................................................... 3.3

loaded from www.Manualslib.com manuals search engine 

Page 104: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 104/210

1 2 3 4 5 6 7

8 8

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 2

3.02

AIR VENTS (air outlets)

1  - left hand side window demister

2  - left hand side air vent

3   - windscreen demisting vents

4  - centre air vents

5   - control panel

6  - right hand side air vent

7   - right hand side window demiste

8   - heater outlets for front and reafootwells

loaded from www.Manualslib.com manuals search engine 

Page 105: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 105/210

1  2

4

3 3

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 3

3.0

AIR VENTS   (continued)

Side air ventsFlow:

Move wheel   2   (beyond the pointwhere a certain resistance is felt).

: fully open.

: closed.

Direction:

Right / left: move tab  1.

Up / down: press on the top or bottom of the air vent

Centre air ventFlow:

Move wheel   4   (beyond the pointwhere a certain resistance is felt).

: fully open.

: closed.

Direction:

Right / left: move tabs  3.

Up / down: press on the top or bottom of the air vent

loaded from www.Manualslib.com manuals search engine 

Page 106: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 106/210

A B C

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 4

3.04

HEATING - VENTILATION

Controls A  Air temperature adjustment.

 B  Distribution of air.

C  Adjusting air volume output.

Adjusting the air temperatureMove control  A.

The further the control is positionedto the right, the higher thetemperature.

Distribution of air in thpassenger compartmentMove control  B.

•  Position

The air flow is directed to thdashboard air vents only.

This selection is not appropriate i

all the air vents are closed.

•  Position

The air flow is directed to thdashboard air vents and thfootwells.

•  Position

The air flow is directed to thfootwells.

•  Position

The air flow is distributed betweenall the air vents, the side windowdemisters, the windscreendemisters and the footwells.

loaded from www.Manualslib.com manuals search engine 

Page 107: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 107/210

B C

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 5

3.0

HEATING - VENTILATION   (continued)

• Position

For improved efficiency, close thedashboard air vents.

All the air flow is directed to thewindscreen demisters and the sidewindow demisters.

•  Position (Isolationposition)

This position prevents any air fromentering (regardless of the positionof control   C ). This allows the

passenger compartment to beisolated from the externalenvironment (driving throughpolluted areas, etc.).

Prolonged use of the ISOLATIONposition may cause the windows tomist up.

We recommend that anotherposition is selected as soon as thepolluted area is left behind.

Adjusting the amount of aisupplied to the passengecompartmentMove control  C   from  0   to  4.

Passenger compartment ventilationis by blown air. The blowe

determines how much air enters bucar speed has some effect on this.

The further the control is positionedto the right, the greater the volumof air blown into the passengecompartment.

loaded from www.Manualslib.com manuals search engine 

Page 108: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 108/210

A B C D E

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 6

3.06

HEATING - VENTILATION AND ISOLATING THE PASSENGER COMPARTMENT

Controls A  Air temperature adjustment.

 B  Distribution of air.

C   Isolation of the passengercompartment (air recirculation).

 D  Air recirculation operationindicator light.

 E  Adjusting air volume output.

Distribution of air in thepassenger compartmentMove control  B.

•  Position

The air flow is directed to the

dashboard air vents only.This selection is not appropriate if all the air vents are closed.

•  Position

The air flow is directed to thdashboard air vents and thfootwells.

•  Position

The air flow is directed to th

footwells.

•  Position

The air flow is distributed betweenall the air vents, the side windowdemisters, the windscreendemisters and the footwells.

•  Position

For improved efficiency, close thdashboard air vents.

All the air flow is directed to th

windscreen demisters and the sidwindow demisters.

loaded from www.Manualslib.com manuals search engine 

Page 109: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 109/210

A E

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 7

3.0

HEATING - VENTILATION AND ISOLATING THE PASSENGER COMPARTMENT  (continued

Adjusting the air temperatureMove control  A.

The further the control is positionedto theright, thehigherthetemperature.

Adjusting the amount of airsupplied to the passengercompartmentMove control  E   from  0   to  4.

Passenger compartment ventilationis by “blown air”. The ventilation

fan determines how much air enters but vehicle speed has a slight effecton this.

The further the control is positionedto the right, the more air is blowninto the passenger compartment.

loaded from www.Manualslib.com manuals search engine 

Page 110: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 110/210

C D

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 8

3.08

HEATING - VENTILATION AND ISOLATING THE PASSENGER COMPARTMENT  (continued

Isolating the passengercompartmentButton C 

Normal operation of the system isobtained using external air.

The air recirculation position allows

the passenger compartment to beisolated from the external atmosphere(driving in polluted areas...).

To enter the isolation mode, press

 button C .

This function allows the desiredwarmth of the passengercompartment to be achieved asquickly as possible.

This button switches the airrecirculation system on or off.Warning light D  comes on when thefunction is operational. In thisposition, air is taken from within thepassenger compartment and isrecycled without outside air entering.

Prolonged use of the isolation modmay cause odours due to the air no

 being renewed and may cause thwindows to mist up.

Return to normal operation (externaair) by pressing button  C  as soon athe polluted area is left behind.

loaded from www.Manualslib.com manuals search engine 

Page 111: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 111/210

A D E F GB C

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 9

3.0

AIR CONDITIONING

Controls A  Air temperature adjustment.

 B  Operating the air conditioning.

C  Air conditioning operationindicator light.

 D  Air distribution control.

 E   Isolation of the passengercompartment (air recirculation).

 F   Air recirculation operationindicator light.

G  Adjusting air volume output.

Adjusting the air temperatureMove control  A.

To the right: maximum temperaturpossible

To the left:  minimum temperaturpossible.

Adjusting the amount of aisupplied to the passengecompartmentMove control  G   from  0  to  4.

Passenger compartment ventilationis by “blown air”. The ventilationfan determines how much air enter

 but vehicle speed has a slight effecon this.

The further the control is positioneto the right, the more air is blowninto the passenger compartment.

loaded from www.Manualslib.com manuals search engine 

Page 112: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 112/210

D

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 10

3.10

AIR CONDITIONING   (continued)

Distribution of air in thepassenger compartmentMove control  D.

• Position

The air flow is directed to thedashboard air vents only.

This selection is not appropriate if all the air vents are closed.

• Position

The air flow is directed to thedashboard air vents and the footwells.

• Position

The air flow is directed to thefootwells.

• Position

The air flow is distributed betweenall the air vents, the side windowdemisters, the windscreen demisterand the footwells.

• Position

For improved efficiency, close thdashboard air vents.

All the air flow is directed to thwindscreen demisters and the sidwindow demisters.

In this position, simultaneouoperation of the air conditioninsystem could make demisting morefficient.

loaded from www.Manualslib.com manuals search engine 

Page 113: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 113/210

E F

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 11

3.1

AIR CONDITIONING   (continued)

Isolating the passengercompartment

Button E 

Normal operation of the system isobtained using external air.

The air recirculation position

allows the passenger compartmentto be isolated from the externalatmosphere (driving in pollutedareas, etc.).

To enter the isolation mode, press

 button E .

This function allows the desiredwarmth of the passengercompartment to be achieved asquickly as possible.

This button switches the airrecirculation system on or off.Warning light F  comes on when the

function is operational. In thisposition, air is taken from withinthe passenger compartment and isrecycled without outside airentering.

Prolonged use of the isolation modemay cause odours due to the air not

 being renewed and may cause thewindows to mist up.

Return to normal operation(external air) by pressing button  Das soon as the polluted area is left

 behind.

loaded from www.Manualslib.com manuals search engine 

Page 114: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 114/210

GB C

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 12

3.12

AIR CONDITIONING   (continued)

Air conditioning controlsControl  B  operates or stopsthe air conditioning system.

The air conditioning will not operateif control  G  is positioned on  0.

Using the air conditioning system:

• lowers the internal passengercompartment temperature,especially in hot weather, whendriving in traffic or when thevehicle has been parked in thesun;

• reduces the humidity of the air blown inside the passengercompartment (prevents misting).

Fuel consumption increases whenthe air conditioning system is beingused. (Switch it off when it is notrequired.)

Note:   the air conditioning may bused in all conditions, but does nooperate when the externatemperature is low.

•  Button  B  not activated (warninlight  C  off)

The air conditioning is nooperational.

Heating and ventilation artherefore identical to that of vehicle without air conditioning

•  Button B activated (warning lighC  on)

The air conditioning is operating

Air is taken from outside thvehicle and is constantlyrenewed.

loaded from www.Manualslib.com manuals search engine 

Page 115: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 115/210

GB C

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 13

3.1

AIR CONDITIONING   (continued)

In very hot weather, or when thevehicle has been parked in the sun,open the doors for a few moments toallow the hot air to escape beforestarting off.

To lower the temperature of thepassenger compartment as quickly

as possible to the required level, usethe “Isolation of the passengercompartment” function. Once therequired comfort level has beenreached, turn the recirculationfunction off.

When the air conditioning isoperating, all the windows must beclosed to give the best efficiency.

If there is an operating fault, contactyour Renault Dealer.

No cool airCheck that the controls are correctlpositioned and that the fuses are ingood condition. If not, stop the aiconditioning system (warninlight  C   goes out) and call for thassistance of a Renault Dealer.

Do not open the refrigerantcircuit. The fluid isdangerous to the eyes andskin.

loaded from www.Manualslib.com manuals search engine 

Page 116: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 116/210

1 2 3 4 5

13 12 11 10 9 8 7 6

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 14

3.14

AUTOMATIC AIR CONDITIONING

Controls

1  - automatic mode button

2 and 12   - air temperatureadjustment buttons

3 - display

4  and 7  - ventilation speedadjustment buttons

5  - automatic windscreendemister-de-icer button

6  - air recirculation button

8 to  10  - air distribution buttons

11 - air conditioning button

13 - unit off button

All buttons except 2, 4, 7 , and 12have associated indicator lightswhich light up when the functionis being used and go out when thefunction is not in use.

loaded from www.Manualslib.com manuals search engine 

Page 117: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 117/210

1 2

12

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 15

3.1

AUTOMATIC AIR CONDITIONING  (continued)

  Air conditioning (automaticmode)Automatic air conditioning is asystem which will ensure thatthe temperature in the passengercompartment is maintained at acomfortable level   (except in

extreme conditions of use).This system is equipped with acomfort level selector to providein-car comfort whatever theweather.

Operation of the automatic mode

•   Press button 1; the indicator lightcomes on.

• Choose a comfort level between

16 and 26°C by pressing buttons2  and  12.

MAXI position:   maximum aitemperature,

MINI position:   minimum aitemperature.

loaded from www.Manualslib.com manuals search engine 

Page 118: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 118/210

3

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 16

3.16

AUTOMATIC AIR CONDITIONING  (continued)

Operation of the automatic mode(continued)

To reach and maintain the selectedcomfort level, the system acts upon:

- blower speed,- air distribution,

- air recirculation management,- air conditioning (on or off).

The indicator lights let you knowwhat the system has selected.

The value on the display 3 indicatesthe comfort level.

When the vehicle is started in cold

or hot weather, increasing ordecreasing the values displayeddoes not mean that the comfort levelis reached more quickly (the systemoptimises the temperature increaseor decrease whatever the airtemperature indicated).

For optimum operation, wrecommend that you leave the aivents open in all weathers.

loaded from www.Manualslib.com manuals search engine 

Page 119: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 119/210

51

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 17

3.1

AUTOMATIC AIR CONDITIONING  (continued)

 Visibility (automatic de-icing- demisting)

Press button 5   to operate

windscreen de-icing/demisting by ventilation.

The indicator light comes on.The AUTO indicator light goesout.

This system quickly demists andde-ices the windscreen and thefront side windows. To improveefficiency, the air conditioning isautomatically switched on at thesame time (indicator light comeson).

The best possible flow of air is thendirected towards the windscreenand front window air outlets.

Press button 1 to return to automatimode. Press button   5   again tswitch off automatic windscreendemisting/de-icing mode.

You may wish to switch on theair conditioning once more if there are high levels of humidity.

In this case, the air conditioningwill operate permanently,whatever mode is selectedafterwards.

loaded from www.Manualslib.com manuals search engine 

Page 120: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 120/210

1

10 9 8

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 18

3.18

AUTOMATIC AIR CONDITIONING  (continued)

Personalised operation

 Selecting air distributionThe system normally operates inautomatic mode but you canalter the standard settings used

 by the system (quantity of air,

etc.).

Automatic mode is switched off bypressing one of the following

 buttons.

The indicator light on button  1  willgo out.

Button  8

The air flow is directed to thedemisting vents (for the windscreenand the side windows).

Button  9

The air is only directed to the feet othe front and rear passengers.

Button  10

The air flows mainly to thdashboard air vents.

In personalised operation mode,you may choose no more thantwo air distribution selections atonce (N.B.: buttons   8   and   10cannot be selected together).

If you alter the automaticselection, the   AUTO   key 1indicator light goes out, but onlythe function changed is nolonger controlled by theautomatic system.

To return to automatic mode,press the  AUTO  button.

loaded from www.Manualslib.com manuals search engine 

Page 121: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 121/210

1 4 5

11 7 6

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 19

3.1

AUTOMATIC AIR CONDITIONING  (continued)

  Switching the airconditioning on and off In automatic mode, the systemswitches the air conditioningsystem on or off, depending onexternal weather conditions.

The automatic mode is switchedoff by pressing button   11; theindicator light in button 1 will goout.

Button  11  allows you to switch theair conditioning system on or off.

N.B.:   switching on thedemisting/de-icing function

(buttons   5   and   6) automaticallyswitches on the air conditioning.

 Altering blower speedIn automatic mode, the systemuses the most suitable amount oair to reach and maintain thdesired temperature.

Press button  4  or  7  to switch ofautomatic mode.

The indicator light on button  will go out.

These buttons increase odecrease the amount of air blowninto the passenger compartment

In cold weather, the automaticair conditioning system will notstart immediately at maximumpower but will increasegradually until the enginetemperature is warm enough toheat the passenger compartmentair. This may take between 30seconds and several minutes.

loaded from www.Manualslib.com manuals search engine 

Page 122: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 122/210

6

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 20

3.20

AUTOMATIC AIR CONDITIONING  (continued)

 Using recirculated airPress button   6; theindicator light will come on.

In this position the air is takenfrom inside the passengercompartment and is recirculatedwithout admitting external air.

Recirculation of air allows theexternal atmosphere to beisolated (driving in pollutedareas).

Prolonged use of the airrecirculation mode may cause thewindows to mist up or lead toodours, as the air is not renewed.

We therefore advise you to return tonormal mode (external air) bypressing button   6   as soon as airrecirculation is no longer required.

Special instructionsSwitching on air recirculationautomatically switches on the aiconditioning.

The function operates periodicallyif the external temperature is lowethan approximately 10°C; thindicator light on button  6  will goout after a few minutes.

The function operates permanentlyif the external temperature is abovapproximately 10°C; press button  6to switch off.

loaded from www.Manualslib.com manuals search engine 

Page 123: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 123/210

1 3 5

13

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 21

3.2

AUTOMATIC AIR CONDITIONING  (continued)

  Switching the system off 

Press button  13

The indicator light comes on. Nomore information appears on thedisplay   3. The system isswitched off.

The button isolates the

passenger compartment from theoutside atmosphere.

Press buttons   1   or   5   to return to

automatic mode.

loaded from www.Manualslib.com manuals search engine 

Page 124: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 124/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 22

3.22

AIR CONDITIONING

If no cool air is produced

Check that the controls are set correctly and that the fuses are in good condition. Otherwise switch off the airconditioning and contact a RENAULT Dealer.

Do not open the refrigerant fluid circuit.

Fuel consumption

When the air conditioning is operating, it is normal to notice an increase in fuel consumption (especially when drivingin town).

In winter, use the air conditioning occasionally in order to keep the system in correct working order.

Do not worry about any water which may appear from underneath the vehicle as this results from condensation.

Operating faults

Generally, if you notice a decrease in the efficiency of de-icing, demisting or air conditioning, it may be caused byclogging up of the particle filter cartridge, if one is fitted to the vehicle: consult your RENAULT Dealer.

loaded from www.Manualslib.com manuals search engine 

Page 125: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 125/210

13

2

A

B

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 23

3.2

INTERIOR LIGHTING

Light  ATilt light  1   to give:

- continuous lighting,

- lighting controlled, depending onversion, by the opening of one of the front doors, or by one of thefour doors. It only extinguisheswhen the doors concerned arecorrectly closed.

Light BTilt switch  2  to give:

- Continuous lighting.

- Lighting controlled, depending onversion, by opening one of thefront doors, or by one of the fourdoors. It only extinguishes whenthe doors concerned are correctlyclosed.

- Lighting off.

- Lighting up of map reading light  3.

Adjust map reading light   3   to therequired position.

Automatic operation of interiorlighting (depending on the vehicle)

•   If the doors are unlocked usingthe plip remote control, theinterior lights are switched on forapproximately 15 seconds.

• If the doors are locked using theplip remote control, the lights areswitched off immediately.

• If the door is open (or notproperly closed), the lights areswitched on for a period of approximately 15 minutes.

• If all the doors are closed, theinterior lights start to dim whenthe ignition is switched on.

loaded from www.Manualslib.com manuals search engine 

Page 126: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 126/210

4

5

6

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 24

3.24

INTERIOR LIGHTING   (continued)

Front door lights  4They operate in a similar way to theother lights.

Rear lights  6Tilt switch  5   to give:

- Continuous lighting.

- Lighting controlled by the openingof one of the four doors. It onlygoes out when the doorsconcerned are correctly closed.

- No lighting.

loaded from www.Manualslib.com manuals search engine 

Page 127: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 127/210

Page 128: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 128/210

1

2

3

1

2

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 26

3.26

SUN VISOR WINDSCREEN

Front sun visorLower the sun visor  1.

Vanity mirrors  2

Special feature on driver's side:

A vanity mirror in the sun visor hasa cover.

Windscreen with reflectivlayersThis windscreen reflects the suand, in particular, limits thinfrared rays entering the passengecompartment.

An area   3   is suitable for affixinpasses to the windscreen (e.gmotorway permits, car park seasontickets, etc.).

loaded from www.Manualslib.com manuals search engine 

Page 129: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 129/210

2

1

43

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 27

3.2

MANUAL SUNROOF

OpeningTo the first stage

Tilt handle 1 forwards until it locks.

To the second stage

Press lever 2 and simultaneously tilthandle 1 until the mechanism locksagain.

ClosingKeep lever  2   depressed and returnhandle 1   to its original position.

• Check that the sunroof iscorrectly closed before leavingthe vehicle.

• Cleantheseal every three monthsusing products provided byour Technical Department

RemovalOpen the sunroof to the first stage

Press button 4  (if necessary, using tool such as a flat screwdriver) torelease the pin 3  from handle 1: thpin should be freed.

Lift the sunroof glass almost verticallyand release it from its hinges.

RefittingRefitting is the reverse of removal

Ensure pin  3   is correctly locked inposition.

loaded from www.Manualslib.com manuals search engine 

Page 130: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 130/210

1

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 28

3.28

ELECTRIC SUNROOF

To tilt the sunroof 

With the ignition on:

- Opening: tilt the switch 1  towardsthe rear and keep it depresseduntil the required tilt angle isobtained.

- Closing: tilt the switch  1   towardsthe front.

To slide the sunroof 

Tilted sunroof,

- Opening: tilt the switch 1  towardsthe rear and keep it depresseduntil the required tilt angle isobtained.

- Closing: tilt the switch  1   towardsthe front.

Child safetyNever leave the key in theignition when there is achild in the car   (or an

animal). It would be possible tooperate the sunroof and there is arisk that the child could trap a partof his/her body in the sunroof (neck, arm, hand, etc.), causingserious injury.

loaded from www.Manualslib.com manuals search engine 

Page 131: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 131/210

2

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 29

3.2

ELECTRIC SUNROOF   (continued)

Sunroof screenSlide it using handle  2.

To keep the screen closed, the hookmust be secured into the sunroof frame.

• Check that the sunroof iscorrectly closed before leavingthe vehicle.

• Clean the seal every three monthsusing products provided by ourTechnical Department.

• Do not open the sunroof  immediately after a rain shower orafter washing your vehicle.

loaded from www.Manualslib.com manuals search engine 

Page 132: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 132/210

2

3

1 4

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 30

3.30

STORAGE COMPARTMENTS

Passenger side glove box  1To open, lift handle   2. The boxcontains a sunglasses holder, a penholder and space for credit cards.

Centre console storagecompartment  3

Driver's storage compartment 4

No objects should beplaced on the floor (areain front of driver) as suchobjects may slide under

the pedal during brakingmanoeuvres, thus obstructing itsuse.

loaded from www.Manualslib.com manuals search engine 

Page 133: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 133/210

1

3

3

4

2

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 31

3.3

STORAGE COMPARTMENTS   (continued)

Door storage compartments  1   Rear compartments 2   Front seat document pouches 3

Storage compartment undepassenger seat  4

loaded from www.Manualslib.com manuals search engine 

Page 134: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 134/210

2

1

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 32

3.32

ASHTRAYS - CIGAR LIGHTER

AshtrayTo open, lift cover  1.

To empty the ashtray, pull theassembly towards you and it will bereleased from its housing.

Cigar lighterIgnition on, press in the cigarlighter  2.

It will click out by itself as soon as itis ready. Pull it out to use it. Afteruse, replace it without pushing it allthe way in.

loaded from www.Manualslib.com manuals search engine 

Page 135: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 135/210

1

A

3

4

3

42

B

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 33

3.3

REAR BENCH SEAT   (operation)

The seat base and the seatback may be folded down (in one or twosections) to allow bulky objects to

 be carried

To fold down the seat base

Lift seat base   A, against the frontseats.

To fold down the seatbackRemove the rear head restraints (if they are fitted to the vehicle). Press

 button 2  and lower the seatback  B.

Removing the seat baseLift the seat base to remove bracketsfrom their housing  4.

To refit the seat base,  carry out thoperations in reverse order tremoval.   Ensure the seat base i

correctly secured.

• When refitting the seatback, ensure it is correctly locked at the top. If seat covers are being used,check that they are not preventing the seatback locking mechanism from operating correctly.

• When moving the bench seat, check that the seat belt housings  1  are correctly positioned beforefolding down the seat base.

Once the bench seat is in place again, ensure the seat belts are correctly repositioned.

loaded from www.Manualslib.com manuals search engine 

Page 136: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 136/210

1

2

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 34

3.34

LUGGAGE COMPARTMENT

To openPress button  1  and lift the tailgate.

To close:Lower the tailgate using handle   2inside the tailgate to help you.

When the tailgate has been loweredto shoulder height, release handle  2and finish closing the tailgate bypressing down on the tailgate fromthe outside.

loaded from www.Manualslib.com manuals search engine 

Page 137: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 137/210

1 1

2

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 35

3.3

LUGGAGE COMPARTMENT   (continued)

Rear shelf To remove, release the two returncords  1.

Do not place any objects,in particular heavy orhard objects, on the rearparcel shelf. These may

pose a risk to the vehicleoccupants if the driver has to

 brake suddenly or if the vehicleis involved in an accident.

Gently lift the shelf and pull ittowards you.

Refitting is the reverse of removal.

Built-in garment case  2This is located under the rear parceshelf and is closed by a zip fastener

It can be used to store clothes.

The total weight of luggageplaced in the built-ingarment case must notexceed 5 kg (11 lbs).

loaded from www.Manualslib.com manuals search engine 

Page 138: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 138/210

Page 139: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 139/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 37

3.3

TRANSPORTING OBJECTS IN THE LUGGAGE COMPARTMENTAlways place objects carried in theluggage compartment so that theirlargest dimension is against:

- the back of the rear bench seat, fornormal loading.

- the folded down seat, formaximum loading.

Always put the heaviestitems directly onto thefloor. When the vehicle is

fitted with them, use thelashing points located on the floorat the rear to secure transporteditems. Luggage should be loaded insuch a way that no item will bethrown forward and strike theoccupants if the driver has to brakesuddenly. Fasten the rear seat belts,even if the seats are not occupied.

loaded from www.Manualslib.com manuals search engine 

Page 140: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 140/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T3.WIN 30/10/2002 12:12   - page 38

3.38

loaded from www.Manualslib.com manuals search engine 

Page 141: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 141/210

nu654-6 - CLIO II   C :\Documentum\Checkout\nu654-6_eng_T 4.WIN 28/10/2002 11:44   - page 1

4.0

Section 4: Maintenance

Bonnet ................................................................................................................................................................ 4.02

Engine oil level .................................................................................................................................... 4.03    4.0

Oil changes: Engine .......................................................................................................................................... 4.0Levels: Brake fluid ............................................................................................................................................ 4.08

Coolant .................................................................................................................................................. 4.09

Power steering pump .......................................................................................................................... 4.10

Battery ................................................................................................................................................... 4.10

Screen washer reservoir ...................................................................................................................... 4.11

Filters ........................................................................................................................ ......................................... 4.11

Bodywork maintenance ......................................................................................................................... 4.12 - 4.13

Interior trim maintenance ................................................................................................................................ 4.14

loaded from www.Manualslib.com manuals search engine 

Page 142: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 142/210

1

4

3

2

5

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T4.WIN 28/10/2002 11:44   - page 2

4.02

BONNET

Opening the bonnetTo open, pull handle  1.

Bonnet safety lockTo unlock, lift lever  2.

Lift the bonnet, release the strut   4from its mounting 3. For your safety,this  must  be placed in location  5.

Closing the bonnetTo close the bonnet, replace strut  4in its mounting  3,  hold the bonnein the middle and lower it to 20 cmabove the closed position. Nowrelease it and it will lock under itown weight.

Check that the bonnet is correctlylocked.

Check that nothing has been left inthe engine compartment beforclosing the bonnet.

Ensure it is correctlylocked.

Take care when workingunder the bonnet as theengine cooling fan maycut in at any moment.

loaded from www.Manualslib.com manuals search engine 

Page 143: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 143/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T4.WIN 28/10/2002 11:44   - page 3

4.0

ENGINE OIL LEVELAn engine uses oil for lubricationand to coolmoving parts and it issometimes necessary to top up thelevel between oil changes.

However, consult your RenaultDealer if more than 0.5 litre is

 being consumed every 625 miles(1000 km) after the running-inperiod.

Oil change frequency: Check the oillevel from time to time and always

 before long journeys, to avoid therisk of damaging your engine.

Reading the oil levelThe car must be parked on levelground and the engine should have

 been switched off for some time beforehand to obtain an accuratereading.

The oil level can be read:

- on the instrument panel;- using the dipstick.

Reading the level on the instrumentpanel

When ignition has been switchedon for approximately 30 seconds:-  if the level is correct, the display

will show “oil OK”: displaymessage  1

Special note:   To gain a moreprecise indication of the level,press the trip mileage counterreset button or the informationscroll button on the on-boardcomputer.

The squares which appear on thdisplay indicate the level. Thnumber of squares displayeddecreases as the oil level drops andthey are replaced by a dash: displaymessage  2.

To move to on-board computereading, press the button again.

-   When the minimum oil level i

reached,  the dashes and the word“Oil” flash, and the word “OKdisappears (display message  3)

and some versions

lights up on the instrument panel

It is vital to top up the oil as soonas possible.

Message 1Levelsatisfactory

Message 2Leveldisplayfunction

Message 3Minimumlevel(flashing)

loaded from www.Manualslib.com manuals search engine 

Page 144: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 144/210

B

A

B

A

C

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T4.WIN 28/10/2002 11:44   - page 4

4.04

ENGINE OIL LEVEL   (continued)

Reading the level using the dipstick

- Take out the dipstick.

- Wipe the dipstick using a clean,lint-free cloth.

- Push the dipstick in as far as it willgo. (For vehicles equipped with acap-type dipstick C , screw the capin as far as it will go.)

- Take out the dipstick again.

- Read the level. It should never fall below the minimum mark   B   orexceed the maximum mark  A.

Take care when workingunder the bonnet as theengine cooling fan may cutin at any moment.

Consult your Renault Dealer atonce if you notice an abnormal orrepeated drop in any of the fluidlevels.

loaded from www.Manualslib.com manuals search engine 

Page 145: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 145/210

1

2

2

1   1

2

1.2 1.2 16V 1.4 16V - 1.6 16V

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T4.WIN 28/10/2002 11:44   - page 5

4.0

ENGINE OIL LEVEL   (continued)

Topping up/fillingThe vehicle must be parked on levelground and the engine should becold (for instance, before the engineis started up for the first time in theday).

- Unscrew filler cap  1.

- Top up the level. (For information,the capacity between theminimum and maximum readingon dipstick 2  is between 1.5 and 2litres depending on the engine.)

- Wait for approx. two minutes toallow the oil to flow into theengine.

- Check the level using dipstick   2(as explained above).

Do not exceed the max. level and donot forget to refit cap  1.

loaded from www.Manualslib.com manuals search engine 

Page 146: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 146/210

1  2

1

2C

2.0 16V 1.5 dCi 1.9 dTi

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T4.WIN 28/10/2002 11:44   - page 6

4.06

ENGINE OIL LEVEL   (continued)

Special features on engine 2.0 16VCap   1   is located underneath a fillerflap.

loaded from www.Manualslib.com manuals search engine 

Page 147: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 147/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T4.WIN 28/10/2002 11:44   - page 7

4.0

ENGINE OIL LEVEL   (continued)  / OIL CHANGEOil changeOil change frequency:  Refer to theServicing booklet for your vehicle.

Change the oil more often if thevehicle is subject to severe use.

Average capacities of oil change(for information)

1.2 l - 1.2 l 16V engines : 4.0 litres

1.4 litre 16 V engines: 4.9 litres1.6 litre 16V engines: 4.9 litres2.0 16V engines : 4.75 litres1.5 litre dCi engine: 5.0 litres1.9 l dTi engine: 5.5 litres

Oil filter included.

The oil filter should be replacedperiodically: consult the Servicing

 booklet for your vehicle.

Engine oil gradeTo find out which grade of oil to use,see the Servicing booklet for yourvehicle.

Filling: Take care whentopping up the oil that nooil drips onto enginecomponents: there is a risk

of fire. Do not forget to refit the capsecurely as there is a risk of fire if oil splashes onto hot enginecomponents.

Engine oil change: If youchange the oil when theengine is hot, be careful toavoid scalding yourself asthe oil flows out.

Take care when workingunder the bonnet as theengine cooling fan may cutin at any moment.

Never run the engine in anenclosed space as exhaustfumes are poisonous.

Consult your Renault Dealer atonce if you notice an abnormal orrepeated drop in any of the fluidlevels.

loaded from www.Manualslib.com manuals search engine 

Page 148: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 148/210

1

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T4.WIN 28/10/2002 11:44   - page 8

4.08

LEVELS

Brake fluidThis must be checked frequently,especially if you notice even theslightest loss in braking efficiency.

Level  1

The level falls naturally as the brakepads wear, but it should never beallowed to fall below theMINIMUM warning mark.

Topping up

After any operation on thehydraulic circuit, a specialist mustreplace the brake fluid.

Only use fluids approved byRENAULT’s Technical Departmentand which have been taken from asealed container.

Fluid change frequency:   Refer tothe servicing booklet for yourvehicle.

Take care when workingunder the bonnet as theengine cooling fan may cutin at any moment.

loaded from www.Manualslib.com manuals search engine 

Page 149: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 149/210

1

1

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T4.WIN 28/10/2002 11:44   - page 9

4.0

LEVELS   (continued)

CoolantThe level   when cold   should be

 between the MINIMUM andMAXIMUM marks on theexpansion bottle  1.

Top up the level when cold before itreaches the MINIMUM mark.

No operations may becarried out on thecooling circuit when theengine is hot.

Danger of burns.If there is an abnormal drop in thecoolant level or if coolant loss isrepeated, consult your RENAULTDealer.

Frequency for checking coolanlevel

Check the coolant level regularl(very severe damage is likely to bcaused to the engine if it runs out ocoolant).

If topping up is required, only usproducts approved by RENAULT'Technical Department:

- Anti-freeze protection;- Anti-corrosion protection of th

cooling system.

Coolant replacement intervals

Refer to your vehicle's Servicin booklet.

loaded from www.Manualslib.com manuals search engine 

Page 150: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 150/210

1  2

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T4.WIN 28/10/2002 11:44   - page 10

4.10

LEVELS   (continued)

Power assisted steering pumpFrequency of changing:  refer to theServicing booklet for your vehicle.

Level:  The correct level when coldshould be:

- visible between the  Min  and  Maxmarks on reservoir  1.

For topping up or refilling with oil,use products approved byRENAULT's Technical Department.

BatteryThe battery does not require anymaintenance. Never open cover  2.

Take care when workingin the enginecompartment as theengine cooling fan maycut in at any momentwithout warning.

Handle the battery withcare as it containssulphuric acid which mustnot come into contact with

the eyes or skin.If it does, rinse with plenty of water.Keep all sources of flame, heat andsparks away from the battery asthere is a risk of explosion.

loaded from www.Manualslib.com manuals search engine 

Page 151: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 151/210

1

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T4.WIN 28/10/2002 11:44   - page 11

4.1

LEVELS   (continued)   FILTERS

Windscreen washer reservoirFilling:  via plug  1.

This reservoir also supplies theheadlight washers (if fitted to thevehicle).

Liquid:   water + washer product(antifreeze product in winter).

Jets:   tilt each small sphere with apin to alter the angle of the spray.

The replacement of filter elements(air filter, passenger compartmentfilter, diesel filter, etc.) isanticipated in the maintenanceoperations for your vehicle.

Frequency for replacing filtercomponents:   see the Servicing

 booklet for your vehicle.

If there is an abnormal drop inany of the fluid levels, consultyour Renault Dealer at once.

Take care when workingunder the bonnet as theengine cooling fan maycut in at any moment.

loaded from www.Manualslib.com manuals search engine 

Page 152: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 152/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T4.WIN 28/10/2002 11:44   - page 12

4.12

BODYWORK MAINTENANCEProtection against the action of corrosive agentsAlthough your vehicle has beentreated with very effectiveanti-corrosion products, it is stillsubject to the action of:

• corrosives in the atmosphere

- atmospheric pollution (urban

and industrial areas),- saline atmosphere (near the sea,

particularly in hot weather),

- seasonal and humid climaticconditions, especially road saltin winter.

• abrasives- wind-carried dust and sand, mud,

road grit thrown up by othervehicles.

• minor impacts

To avoid losing the benefits of thisprotection, a minimum number of precautions should be taken toensure against this risk.

What you must not do• Wash the vehicle in bright sunlight

or in freezing temperatures.

• Scrape off mud or dirt withoutpre-wetting.

• Allow external dirt to accumulate.

• Allow rust to form after minorimpacts.

• Use solvents not recommended by Renault's Technical Departmentto remove spots as they maydamage the paintwork.

• Drive frequently in snow or muddyconditions without periodicallywashing the car, particularlyunder the wheel arches and underthe body.

• Degrease or clean mechanicacomponents (e.g. engincompartment), underneath th

 bodywork, parts with hinges (e.ginside the fuel tank flap, sunroofand painted plastic externafittings (e.g. bumpers) using highpressure cleaning apparatus ospraying on products which arnot approved by our TechnicaDepartment as this could give risto corrosion or incorrect operation

loaded from www.Manualslib.com manuals search engine 

Page 153: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 153/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T4.WIN 28/10/2002 11:44   - page 13

4.1

BODYWORK MAINTENANCE   (continued)What you should do• Wash your car frequently, using our

recommended cleaning productsand use a high pressure jet to rinseoff the wheel arches and under the

 body to get rid of:- spots of tree resin and industrial

grime;

-  bird droppings, which contain

chemicals which   rapidlydiscolour paintwork and mayeven cause the paint to peel off;The vehicle   must   be washedimmediately to remove thesemarks since they cannot beremoved by polishing;

- salt from the wheel arches andunder the body, after the vehiclehas been driven in areas wherethe roads are chemically treated;

- mud forming damp patches inthe wheel arches and under the

 body.

• Keep well away from the vehiclein front when driving on a freshlylaid surface to avoid damage toyour paintwork.

• Have patches where the paint has been damaged repaired quickly toavoid corrosion spreading.

• If your vehicle is covered by theRenault anti-corrosion warranty,remember to visit the bodyshopperiodically. Refer to your vehicle’sWarranty and Servicing booklet.

• Respect local regulations relatingto washing your vehicle (e.g. donot wash your vehicle on a publichighway).

• Before using a revolving brushtype car wash, check the mountingof exterior equipment, additionaheadlights and rear view mirrorsSecure the wiper blades and radioaerial with adhesive tape.

Remove the car phone aerial if thvehicle has one.

• If mechanical components suchas hinges have to be cleaned, theiprotection must be reapplied byspraying on products approve

 by Renault's Technical Department

We have selected special productsto care for your vehicle whichmay be obtained from RenaultAccessory Outlets.

loaded from www.Manualslib.com manuals search engine 

Page 154: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 154/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T4.WIN 28/10/2002 11:44   - page 14

4.14

MAINTAINING INTERIOR TRIMDoWhatever type of stain is on thetrim, use soapy water (if necessary,with warm water) based on:• natural soap,• washing up liquid (with one part

washing up liquid to 200 partswater).

Rinse off with a soft, damp cloth.

Special instructions

• Glass instrument panel   (e.g.:instrument panel, clock, exteriortemperature display, radiodisplay, etc...).

Use a soft cloth (or cotton wool).

If this does not clean themproperly, use a soft cloth or cottonwool slightly moistened withsoapy water and then wipe cleanwith a soft damp cloth.

Finally, dry off   carefully   with a

soft dry cloth.Cleaning products containingalcohol may not be used underany circumstances.

• Seat belts

These must be kept clean.

Use products selected by ourTechnical Department or warmsoapy water using a sponge anddry off with a dry cloth.

Do not use cleaning agents ordyes.

We have selected specialproducts to care for your vehicleand you can obtain these fromRenault accessory outlets.

Do not

You are strongly recommendednot to use high pressure oratomising cleaning equipmentinside the passengercompartment: unless carefullyused, such equipment couldinterfere with correct operationof the electrical or electroniccomponents in the vehicle,amongst other effects.

loaded from www.Manualslib.com manuals search engine 

Page 155: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 155/210

nu654-6 - CLIO II   C :\Documentum\Checkout\nu654-6_eng_T 5.WIN 30/10/2002 12:27   - page 1

5.0

Section 5: Practical advice

Emergency spare wheel .................................................................................................................................... 5.02

Toolkit (Jack - Wheelbrace - Tyre levers etc.) ................................................................................................ 5.0

Hubcaps - Wheels ............................................................................................................................................. 5.04

Changing a wheel ............................................................................................................................................. 5.05

Tyres (tyre safety, wheels, winter use) ............................................................................................... 5.06    5.08

Wiper blades ..................................................................................................................................................... 5.09

Changing the bulbs ............................................................................................................... ............... 5.10    5.18

Headlights ................................................................................................................................... 5.10    5.12

Front fog lights ................................................................................................................. ....................... 5.13

Rear lights ..................................................................................................................................... 5.14 - 5.15Side-mounted repeaters .......................................................................................................................... 5.16

Interior lights ................................................................................................................. ............... 5.17 - 5.18

Battery ..................................................................................................................................................... 5.19 - 5.20

Remote control door locking (changing the batteries) .................................................................................. 5.2

Fuses ....................................................................................................................................................... 5.22 - 5.23

Towing (breakdown - attachments) .................................................................................................. .. 5.24    5.26

Fitting a radio/accessories .................................................................................................................... 5.27 - 5.28

Operating incidents ............................................................................................................................. 5.29    5.34

loaded from www.Manualslib.com manuals search engine 

Page 156: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 156/210

1

3

2

4

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:27   - page 2

5.02

EMERGENCY SPARE WHEEL

Emergency spare wheel  2This is located in the luggagecompartment.

To reach the emergency sparewheel:

• Open the tailgate.

• Lift the luggage compartmentcarpet using circular cut-out  1.

• Slacken central fastener  3.

• Remove the tool kit  4.

• Release the emergency sparewheel 2.

If the spare wheel has beenstored for several years,have it checked by yourDealer to ensure that it issafe to use.

loaded from www.Manualslib.com manuals search engine 

Page 157: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 157/210

1

4

5

36

2

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:27   - page 3

5.0

TOOL KIT

The tool kit   1   is located on theemergency spare wheel. It consistsof a set of tools for variousoperations on the vehicle: jack,wheelbrace, towing hitch, etc. and aspace for a bulb unit.

Wheelbrace  5

Jack  4When replacing the jack, fold itdown completely before putting it

 back into position.

The jack is designed forchanging a wheel. Underno circumstances shouldit be used for carrying out

repairs or to gain access underthe vehicle.

Hubcap spanner  2This is used to unclip the hubcaps

Wheel spanner  6This is used to lock or release thewheel bolts.

Towing ring  3Refer to the Towing section insection 5 for information on usinthe towing ring.

loaded from www.Manualslib.com manuals search engine 

Page 158: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 158/210

1

A

2

3

5 4

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:27   - page 4

5.04

WHEEL HUBCAPS - WHEELS

Hubcap with concealed wheel bolts(example: Hubcap  1)

Remove the Hubcap using theHubcap spanner   A   (from the toolkit) or the end of the wheelbrace, byengaging the hook into one of the

openings around the edge of theHubcap.

To refit the Hubcap, clip it intoposition, ensuring it is aligned withthe valve  2.

Wheel or Hubcap with exposedwheel bolts

Remove the bolts and remove thewheel.

Central embellisher(example: Hubcap  3)

Remove the Hubcap using theHubcap spanner (stored in the glove

 box). Insert the spanner   4   in therecess  5.

To refit, align recess 5 with rim, clipthe Hubcap back into position andrefit the nut using spanner  4.

We would advise you to note thenumber engraved on the spanner sothat you can replace it if it is lost.

loaded from www.Manualslib.com manuals search engine 

Page 159: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 159/210

1

3

2

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:27   - page 5

5.0

CHANGING A WHEEL

•  Remove the wheel embellisher(see section on embellishers).

• Use the wheelbrace   1   to loosenthe wheel bolts slightly. Fit it sothat you press downwards andnot upwards.

• Offer up the jack horizontally, thejack head must be slidunderneath the jacking pointunder the body, nearest the wheelconcerned.

• Screw up the jack by hand at firstto align the base plate (whichshould be inclined furtherinwards than the jack head). Use apiece of wood under the baseplate if on soft ground.

• Insert the end of the wheelbrace 2into the jack   3   and turn a fewtimes to lift the wheel off theground:

• Remove the bolts.

• Take off the wheel.

• Position the emergency sparewheel on the central hub and turnit to locate the mounting holes inthe wheel and the hub.

• Tighten the bolts and lower thejack.

• Tighten the bolts fully when thewheel is on the ground.

Park your vehicle on firm,flat ground (if necessary,placing a plank under the

 base of the jack).Switch on the hazard warninglights.Apply the handbrake and engage agear (first or reverse, or   P   on anautomatic gearbox).

Ask all the passengers to get out of the vehicle and keep them awayfrom moving traffic.

If you have a puncture,replace the wheel as soonas possible.A tyre which has been

punctured should always beinspected (and repaired if possible)

 by a specialist.

loaded from www.Manualslib.com manuals search engine 

Page 160: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 160/210

2

1

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:27   - page 6

5.06

TYRESTyre safety - road wheelsThe tyres are the only contact

 between the vehicle and the road, soit is essential to keep them in goodcondition.

You must make sure that your tyresconform to local road regulations.

When they need to be

replaced, only tyres of the same make,dimension, type and

profile should be used.

When fitting tyres to the car,they should either be identical tothose fitted originally orconform to those recommended

 by your Renault Dealer.

Maintaining the tyresThe tyres must be in good conditionand the tread form must havesufficient depth: tyres approved byour Technical Department havewear warning strips   1   which arerisers moulded into the tread at

several points.

When the tread has worn down tothe level of these risers,   they

 become visible   2:   the tyreconcerned must be replaced now aonly   1.6 mm maximum of treadremains and this is not sufficient tomaintain good grip on wet roads.

Incidents which occur whedriving such as striking the kerb

may damage the tyres and coullead to the misalignment of the fronaxle geometry.

An overloaded car, long journeys bymotorway, especially in very howeather, or continual driving onpoor road surfaces will lead to morrapid tyre wear and affect safety.

loaded from www.Manualslib.com manuals search engine 

Page 161: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 161/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:27   - page 7

5.0

TYRES   (continued)Tyre inflation pressuresTyre inflation pressures must beadhered to. (Remember to check theemergency spare wheel at the sametime.) Inflation pressures must bechecked at least once a month andalways before a long journey. (Referto the section on Tyre inflationpressures).

Incorrect tyre pressureslead to abnormal tyrewear and unusually hot

running. Factors which mayseriously affect safety and leadto:

- poor roadholding

- possibility of blow-outs or of throwing a tread at high speed.

Inflation pressures depend onthe load and the driving speed.Adjust the pressures accordingto the conditions of use. (Refer tothe section on tyre inflationpressures).

Pressures should be checked whenthe tyres are cold; ignore higherpressures which may be reached inhot weather or after driving at highspeeds.

If tyre pressures cannot be checkedwhen the tyres are  cold,  assume anincrease of  0.2   to  0.3  bar (3  PSI).

Never deflate a hot tyre.Note: a label (depending on countryor version) affixed to the edge orframe of the driver's door gives therecommended tyre pressures.

Replacing tyres

For safety reasons, thisoperation must only becarried out by aspecialist.

Fitting different tyres maychange your vehicle as follows:

- It may mean that your vehicleno longer conforms to currentregulations.

- It may change the way ithandles when cornering.

- It may cause the steering to beheavy.

- It may cause tyre noise.

- It may affect the use of chains.

Changing wheels aroundThis practice is not recommended

Emergency spare wheelRefer to the information on themergency spare wheel andinstructions on how to change wheel in section 5.

loaded from www.Manualslib.com manuals search engine 

Page 162: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 162/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:27   - page 8

5.08

TYRES   (continued)Use in winter

• Chains

For safety reasons, chains mustnever be fitted to the wheels onthe rear axle.

Chains must not be fitted  to tyreswhich are larger than thoseoriginally fitted to the vehicle.

Chains may only be fittedto tyres of the same sizeas those originally fittedto  your vehicle.

•  “Snow” or winter tyres

We recommend that these arefitted to all four wheels to ensurethat your vehicle retainsmaximum road holding.

Note:   These tyres sometimeshave:

- a specific direction of rotation

- a maximum speed which may be lower than the maximumspeed of your vehicle.

•  Studded tyres

This type of equipment may only be used for a limited period andas laid down by local legislation.

It is necessary to keep to the speedspecified by current legislation.

As a minimum, these tyres may befitted to the two front wheels.

In all cases, we recommend thatyou consult your Renault Dealer,who will be able to advise you onthe choice of equipment which ismost suitable for your vehicle.

loaded from www.Manualslib.com manuals search engine 

Page 163: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 163/210

21

4

A

B

C

5

3

6

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:27   - page 9

5.0

WIPERS

Replacing the windscreenwiper blades  1• Lift the wiper arm  3.

• Move the blade into a horizontalposition.

• Press tab   2   and slide the wiper

 blade downwards until the hook4  of the wiper arm is released.

• Remove blade in direction of arrow ( A) and fit new blade indirection of arrow ( B).

Replacing the rear screen wiper blade 5• Lift the wiper arm  6.

• Pivot the blade until a resistanceis felt.

• Release the blade by pulling it (C ).

Refitting a windscreen or reascreen wiper bladeRefitting is the reverse of removalEnsure the blade is correctly lockedin position.

• In freezing conditions, makesure that the wiper blades arenot stuck to the windscreen(risk of overheating the motor).

• Keep an eye on the condition of the blades. Change them as soonas they become less efficient:approximately once a year.

loaded from www.Manualslib.com manuals search engine 

Page 164: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 164/210

A   B   1

5

4

3

2

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:27   - page 10

5.10

HEADLIGHTS WITH HALOGEN BULBS: replacing bulbs

Headlight main beamRemove the cover  A.

Unclip bulb connector  1.

Disengage the springs 2 and removethe bulb.

Dipped beam headlightsRemove cover  B.

Turn the connector a quarter of aturn and remove bulb  3.

Type of bulb:  1     H13     H7

anti-UV (see box).

Do not touch the Halogen bulbglass. Hold it by its base.

Front side lightsRemove the bulb holder 5  to accessthe bulb.

Bulb type: W5W.

Direction indicator lightsTurn the bulb holder 4 a quarter of aturn and remove the bulb.

Bulb type: PY21W.

When the bulb has been changed,please refit the cover.

Cleaning the headlightsAs the headlights have plastilenses, use a soft cloth or cottonwool.

If this is not sufficient, use a sofcloth (or cotton wool) dampenewith soapy water then rinse using soft cloth or cotton wool.

Carefully   dry off using a soft, drycloth.

Alcohol based cleaning productmust not be used under anycircumstances.

As the headlights arefitted with plastic“lenses”, it is essential touse anti-UV bulbs.

(If other bulbs are used, this maydamage the headlight).

It is advisable to carry a set of spare bulbs for emergencies.

loaded from www.Manualslib.com manuals search engine 

Page 165: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 165/210

B

A

2

31

4

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:27   - page 11

5.1

HEADLIGHTS WITH XENON BULBS: replacing bulbs

Dipped beam headlights withxenon bulbsThey are marked on the label   3under the cover  B.

This type of headlight bulb must bechanged by a RENAULT Dealer.

Bulb type: D2S.

A special mounting isrequired to fit this type of headlight.   It is notpermitted to fit a headlight

fitted with xenon bulbs to a vehiclewhich was not designed to acceptit.

Main beam headlightsRemove cover  A.

Turn the connector  1  a quarter of turn and remove the bulb.

Type of bulb: anti U.V. (see box).

Do not touch the Halogen bulglass. Hold it by its base.

When the bulb has been changedrefit cover  A  correctly.

As headlights are fittedwith plastic lenses, youmust use anti-UV 55 W

 bulbs.   (Using any othertype of H1 bulb may damage theheadlight).

It is advisable to carry a set of spare bulbs for emergencies.

loaded from www.Manualslib.com manuals search engine 

Page 166: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 166/210

2

4

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:27   - page 12

5.12

HEADLIGHTS WITH XENON BULBS: replacing bulbs   (continued)

Direction indicatorsTurn the bulb holder 2 a quarter of aturn and take out the bulb.

Bulb type: orange PY21 W bayonet bulb.

Front side lightsRemove the cover  A.

Remove the bulb holder 4  to accessthe bulb.

Bulb type: W5W.

Cleaning headlightsAs the headlights are made withplastic lenses, use a soft cloth ocotton wool to clean them.

If this does not clean them properlyuse a soft cloth or cotton wooslightly moistened with soapy wateand then wipe clean with a sofdamp cloth.

Finally,  carefully dry off with a sofdry cloth.

Cleaning products containinalcohol must not be used under anycircumstances.

loaded from www.Manualslib.com manuals search engine 

Page 167: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 167/210

1

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:27   - page 13

5.1

FOG LIGHTS: replacing the bulbs

Front fog lights  1

Changing a bulb and adjusting theheadlight beam:

Consult your Renault Dealer.

Additional lightsIf you wish to fit fog lights or longrange headlights to your vehicle,consult your Renault Dealer.

Any operation on (ormodification to) theelectrical system must beperformed by a Renault

Dealer since an incorrectconnection might damage theelectrical installation (harness,components and in particular,the alternator). In addition, yourDealer has available all the partsrequired for fitting these units.

loaded from www.Manualslib.com manuals search engine 

Page 168: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 168/210

Page 169: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 169/210

1

2   3

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:27   - page 15

5.1

REAR LIGHTS: replacing the bulbs  (continued)

Third centre stop light  1The third stop light is a special striplight. Consult your Renault Dealer if any work needs to be carried out onthis.

Number plate lightsRelease bulb holder  2   (using a flat

 blade screwdriver for example).Unclip lens  3   from the bulb holdeto reach the bulb.

Bulb type: double ended tubula bulb 5 W.

loaded from www.Manualslib.com manuals search engine 

Page 170: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 170/210

1

2

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:27   - page 16

5.16

SIDE REPEATERS: replacing the bulbs

Unclip the repeater   1   (using a flat blade screwdriver for example).

Turn the bulb holder 2 a quarter turnand remove the bulb.

Bulb type: W 5 W.

loaded from www.Manualslib.com manuals search engine 

Page 171: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 171/210

1   4

2

3

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:27   - page 17

5.1

INTERIOR LIGHTS: replacing the bulbs

Courtesy lightUnclip cover 1 (using a tool such asa flat screwdriver).

Turn bulb holder 2 or 3 a quarter of aturn.

Bulb type: W 5 W  or:   festoon type bulb 7W for a single courtesy light.

Rear lights  4Unclip the light (using a tool such aa flat-bladed screwdriver).

Remove the bulb by turning it quarter of a turn.

Type of bulb: Bayonet type 5 W.

loaded from www.Manualslib.com manuals search engine 

Page 172: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 172/210

6

7

8

5

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:27   - page 18

5.18

INTERIOR LIGHTS: replacing the bulbs  (continued)

Door lights 5Unclip the light 5 (using a tool suchas a flat blade screwdriver).

Release the bulb.

Type of bulb: W 5 W.

Luggage compartment light  6Unclip light   6   by pressing on thetabs on each side of the light (usinga tool such as a flat screwdriver).

Disconnect the light.

Press tab   7   to release the lens andreach the bulb  8.

Type of bulb: double-ended tubula bulb 7 W.

loaded from www.Manualslib.com manuals search engine 

Page 173: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 173/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:27   - page 19

5.1

BATTERY breakdownTo avoid all risk of sparks:- Ensure that the consumers are

disconnected before disconnectingor reconnecting the battery.

- When charging, switch off thecharger before connecting ordisconnecting the battery.

- Do not place metal objects on the battery to avoid creating a short

circuit between the terminals.

Connecting a battery chargerBoth battery leads must bedisconnected (with the engineswitched off).

Do not disconnect the battery whenthe engine is running.   Follow theinstructions for use given by themanufacturer of the battery chargeryou are using.

Only a well-charged andwell-maintained battery will have along and useful life and enable youto start the vehicle’s enginenormally.

The battery must be kept clean anddry.

Have the battery's charge statuschecked regularly:

• especially if you use your vehiclefor short journeys or for frequentdriving in town;

• When the external temperaturedrops (in winter),   the chargedecreases. In winter, only usethose electrical comsumers whichare really necessary.

• Finally, you should understandthat the charge decreasesnaturally as a result of certainpermanent consumers such as:the clock, aftermarketaccessories...

When a large number of accessorieare fitted to the vehicle, have themconnected to + after ignition. In thicase, it is advisable to have youvehicle fitted with a battery whichhas an increased nominal capacityConsult your Renault Dealer.

If the vehicle is to be left stationaryfor a long time, disconnect th

 battery and recharge it regularlyespecially in cold weather. Thmemories, radio etc. will then havto be reprogrammed. The batterymust be stored in a dry andventilated area protected from frost

Specific procedures may be required to chargesome batteries. Consultyour Renault Dealer.

Avoid all risk of sparks whichmay cause an immediateexplosion and charge the batteryin a well-ventilated area.Risk of serious injury.

loaded from www.Manualslib.com manuals search engine 

Page 174: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 174/210

1

4A

2B

3

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:28   - page 20

5.20

BATTERY: breakdown   (continued)Starting the vehicle using the

 battery from another vehicleProceed as follows when startingyour vehicle from another vehicle's

 battery:

Obtain suitable jump leads (with alarge cross section) from a RenaultDealer or, if you already have jumpleads, ensure that they are in perfect

condition.Both batteries must have anidentical nominal voltage: 12 volts.The battery supplying the currentshould have a capacity (amp-hours,Ah) which is at least the same asthat of the discharged battery.

A frozen battery must be thawed out before current is supplied to it.

Ensure that there is no risk of contact between the two vehicles(risk of short circuiting when thepositive terminals are connected)

and that the discharged battery isproperly connected. Switch off yourvehicle ignition.

Start the engine of the vehiclesupplying the current and run it ataverage speed.

Secure the positive cable (+)   A   tothe (+) terminal 1  of the discharged

 battery then to (+) terminal 2  of the battery supplying the current.

Secure the negative cable (–)   B   tothe (–) terminal   3   of the batterysupplying the current then to the (–)

terminal 4 of the discharged battery.

Check that there is no contac between cables   A   and   B   and thacable   A   is not touching any metaparts on the vehicle supplying thcurrent.

Start the engine as you wouldnormally. As soon as it startsdisconnect cables   A   and   B   in threverse order (4-3-2-1).

Handle the battery withcare since it containssulphuric acid whichmust never come into

contact with eyes or skin. If itdoes, wash with plenty of water.Keep all flames, light sourcesand sparks away from the

 battery: risk of explosion.Take care when working in theengine compartment as theengine cooling fan may cut in atany moment without warning.

loaded from www.Manualslib.com manuals search engine 

Page 175: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 175/210

1

2

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:28   - page 21

5.2

REMOTE CONTROL LOCKING DEVICE   (batteries)

Replacing the batterySlide off the remote control cover 1.

The batteries can be obtainedfrom your Renault Dealer.

These batteries should last abouttwo years. There is a delay of 1second between locking andunlocking actions.

Replace the battery   2   according tothe direction marked on the cover.

Note: When replacing the battery, itis advisable not to touch theelectronic circuit in the key cover.

loaded from www.Manualslib.com manuals search engine 

Page 176: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 176/210

1

A

32

4

3

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:28   - page 22

5.22

FUSES

CORRECT INCORRECT

Fuse box  2If electrical equipment does notwork, check the condition of thefuses.

Lift cover  A  using handle  1.

To identify the fuses, refer to the

fuse allocation label   4   (shown onthe page opposite).

It is not advisable to use the freefuse locations.

Check the fuse in questionand replace it, if necessary,with a fuse which must beof the same rating as the

original fuse.

If a fuse is fitted where the rating istoo high, it may cause the electricalcircuit to overheat (risk of fire) inthe event of an item of equipmentusing an excessive amount of current.

Remove the fuse using tweezers  3

Slide the fuse sideways to remove ifrom the tweezers.

A sensible precaution:Obtain an emergency kitcontaining spare bulbs and fusesfrom your RENAULT Dealer.

loaded from www.Manualslib.com manuals search engine 

Page 177: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 177/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:28   - page 23

5.2

FUSES   (continued)Allocation of fuses  (the presence of fuses depends on the vehicle equipment level)

Symbol Allocation

Air bag/Central timer

Stop lights

Heated rear screen

Windscreen wipers

Anti-lock braking (ABS)

Fan

Radio/Cigar lighter/Clock

Horn

Left handdipped headlight

Right handdipped headlight

Symbol Allocation

Right hand main beamheadlight

Left hand main beamheadlight

Dual headlights(dipped beam headlightsand main beamheadlights)

Heated rear view mirrors

Front fog lights

Not used

Not used

Central timer

Directionindicators/Hazard warninglights

Rear fog light

Symbol Allocation

Left hand side light

Right hand side light

Engine immobiliser

Interior and luggagecompartment lights/Radio

Central door locking

Electric windows

Headlight washers

Heated seats

Electric sunroof 

loaded from www.Manualslib.com manuals search engine 

Page 178: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 178/210

1

2

2

34

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:28   - page 24

5.24

TOWING breakdown

The steering lock must not beapplied; the ignition key must be inposition “M” (ignition) allowinglights and signals to be used (stoplights and direction indicators).The vehicle lights must be used atnight.

It is also important to observe thetowing conditions defined by thelegislation for the particular countryyou are in. Do not exceed the towingweight for your vehicle. Consultyour Renault Dealer.

Only use the towing ring  2  (in thetool kit 1) and the towing points atthe front   3. (Never use the driveshafts.) These towing points mayonly be used for pulling the car,never for lifting it either directly orindirectly.

Front towing point  3

Rear towing point 4

First screw in the towingring 2  by hand as far as itwill go. Then use thewheelbrace from the toolkit to finish tightening it.

loaded from www.Manualslib.com manuals search engine 

Page 179: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 179/210

Page 180: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 180/210

A

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:28   - page 26

5.26

TOWING trailer

 A = 662 mm.

Permissible nose weight whentowing a trailer, max. towingweight, braked and unbraked:Refer to the information on“WEIGHTS” in section 6:Refer to the manufacturer’sinstructions for information onhow to fit and operate the towingattachment.It is advisable to keep theseinstructions with your othervehicle documentation.

loaded from www.Manualslib.com manuals search engine 

Page 181: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 181/210

1

2

3

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:28   - page 27

5.2

FITTING A RADIO

Radio installation 1Unclip and remove the cover. Theaerial, + and – supply connectorsand left and right speaker wires arefixed to the rear face of the cover.

Front speakersUnclip cover   2   using a flat bladescrewdriver type tool at the arrows.

Remove the two screws  3  and thentake off the protective card to reachthe speaker wires.

• In all cases, follow the manufacturer’s fitting instructions carefully.

• The specifications of the supports and wires (available as a Renault parts accessory) vary depending on equipmentlevel of your vehicle and the type of radio.To find out their reference, consult your Renault Dealer.

• Any operation on (or modification to) the electrical system must be performed by a Renault Dealer since incorrectconnections might damage the electrical installations or any components connected to it.

loaded from www.Manualslib.com manuals search engine 

Page 182: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 182/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:28   - page 28

5.28

ACCESSORIES

Using mobile phones andCB equipment.Mobile phone equipmentwith integrated aerials may

cause interference to the originalelectronic systems fitted to thevehicle: we recommend that youonly use equipment with anexterior aerial.

Furthermore, we remind you of the need to conform to thelegislation in force concerning theuse of such equipment.

After-sales installation of non-electrical accessories(roof bars, towingattachments, etc.)

Accessories approved by Renaultare based on a strict specificationand are regularly tested. We wouldrecommend that you use approvedaccessories (particularly wherethese affect safety) because they areparticularly reliable andappropriate for your vehicle.

After-sales installation of electricor electronic accessories

•  Any work on the electric circuitof the vehicle must be carried out

 by Renault network engineers: if the system is connectedincorrectly, it may result indamage being caused to theelectrical installation and/or the

units connected to it.• If the vehicle is retrofitted with

any electrical equipment, makesure that the unit is correctlyprotected by a fuse. Ask forinformation on the rating andposition of this fuse.

loaded from www.Manualslib.com manuals search engine 

Page 183: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 183/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:28   - page 29

5.2

OPERATING FAULTSYour vehicle should not be affected by faults likely to keep it off the road for long periods if you have followed the RenaulServicing Programme regularly.

The following advice will allow you to get going again quickly, albeit temporarily: for reasons of safety, you shouldalways consult a Renault Dealer as soon as possible.

When starter is activated CAUSES REMEDIAL ACTION

• There is no response. The warninglights fail to illuminate and the starterdoes not turn.

Battery lead disconnected or terminalsoxidised. Check battery terminals: scrape cleanif oxidised and re-tighten.

Battery discharged. Connect another battery to the faulty battery.

Battery unserviceable. Replace the battery.

• Warning lights go dim and starterturns very slowly.

Battery terminals not tight.Battery terminals oxidised.

Check battery terminals: scrape cleanif oxidised and re-tighten.

Battery discharged. Connect another battery to the faulty battery.

• The engine is difficult to start indamp conditions or after washing.

Poor ignition, ignition system damp. Dry the plug leads and ignition coil

• The engine is difficult to start whenhot.

Poor carburation (bubbles of vaporisedfuel in the circuit).

Let the engine cool down.

Lack of compression. Consult a Renault Dealer.

loaded from www.Manualslib.com manuals search engine 

Page 184: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 184/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:28   - page 30

5.30

OPERATING FAULTS   (continued)When starter is activated CAUSES REMEDIAL ACTION

• The engine fires once or twice thendies and is difficult to start when cold.

Immobiliser active. Refer to the “Engine immobilisersection.

Starting procedure incorrect Refer to the “starting the enginesection.

orPoor fuel supply or ignition fault. If the vehicle will not start, do nokeep trying to start it.Consult a Renault Dealer.

System for cutting off fuel supplyactivated if vehicle has been subject tosevere impact.

See a Renault Dealer. (Refer tinformation on fuel cut-off system insection 5.)

• Vibrations. Tyres incorrectly inflated, incorrectly balanced or damaged.

Check the tyre pressures and, if theyare correct, have a Renault Dealer checkthe condition of the tyres.

• Coolant boiling in expansion bottle. Mechanical fault: cylinder head gasket blown, water pump faulty.

Stop the engine.Consult a Renault Dealer.

Engine cooling fan not working. Check the appropriate fuse, otherwisconsult a Renault Dealer.

loaded from www.Manualslib.com manuals search engine 

Page 185: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 185/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:28   - page 31

5.3

OPERATING FAULTS   (continued)On the open road CAUSES REMEDIAL ACTION

• Abnormal white smoke from theexhaust.

Mechanical fault: cylinder head gasket blown.

Stop the engine.Consult a Renault Dealer.

• Smoke under the bonnet. Short circuit. Stop the vehicle, switch off thignition, disconnect the battery.

Cooling circuit fault. Consult a Renault Dealer.

• The oil pressure warning lightilluminates- when cornering or braking. The level is too low. Top up the oil.- at idle speed. The oil pressure is too low. Consult the nearest Renault Dealer.- is slow to extinguish or remainsilluminated on acceleration.

Loss of oil pressure. Stop and call for the assistance of Renault Dealer.

• The engine lacks power. Dirty air filter. Replace the cartridge.

Fuel supply fault. Check the fuel level.

Spark plugs faulty, incorrect gap. Consult a Renault Dealer.

• Idle speed unsteady or engine stalls. Lack of compression (spark plugs,ignition, air leak)

Consult a Renault Dealer.

loaded from www.Manualslib.com manuals search engine 

Page 186: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 186/210

Page 187: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 187/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:28   - page 33

5.3

OPERATING FAULTS   (continued)Electrical equipment CAUSES REMEDIAL ACTION

• The wipers do not work. Wiper blades stuck. Release the blades before use.

Fuse blown (intermittent, park). Replace the fuse.

Motor faulty. Consult a Renault Dealer.

• Indicators flash more rapidly. - Bulb blown. Replace the bulb.

• Direction indicatorsnot flashing.

On one side: - bulb blown. Replace the bulb.

- feed wire disconnected or connector

out of position.

Reconnect the wire.

- faulty earth. Find the earth wire which is securedto a metal component, scrape the endof the earth wire and refit it carefully

On both sides: - fuse blown. Replace the fuse.

- flasher unit faulty. Replace: consult a Renault Dealer.

loaded from www.Manualslib.com manuals search engine 

Page 188: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 188/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T5.WIN 30/10/2002 12:28   - page 34

5.34

OPERATING FAULTS   (continued)Electrical equipment CAUSES REMEDIAL ACTION

• Headlightsdo not work.

On one side: - bulb blown. Replace the bulb.

- feed wire disconnected or connectorout of position.

Check and reconnect the wire or thconnector.

- faulty earth. See above.

On both sides: - if the circuit is protected by a fuse. Check and replace the fuse if necessary

• Traces of condensation in the lights. This is not a fault. The presence of traces of condensation in the lights isa natural phenomenon concernedwith variations in temperature.These traces will disappear quicklyonce the lights are in use.

loaded from www.Manualslib.com manuals search engine 

Page 189: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 189/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654- 6_eng_T6.WIN 28/10/2002 12:31   - page 1

6.0

Section 6: Technical specifications

Identification plates ........................................................................................................... .................. 6.02    6.04

Engine specifications ........................................................................................................................................ 6.05

Weights .................................................................................................................................................. 6.06    6.14

Towing weights .................................................................................................................................... 6.06    6.14

Dimensions ........................................................................................................................................................ 6.15

Replacement parts ............................................................................................................... ............................. 6.16

loaded from www.Manualslib.com manuals search engine 

Page 190: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 190/210

A

1

2

3

4

5

678

9

10

11

12

13

A

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T6.WIN 28/10/2002 12:31   - page 2

6.02

IDENTIFICATION PLATES

The information on the vehicleidentification plate   A   (right handside) must be quoted when writingor ordering parts

 A  - Vehicle identification plate

1  Vehicle type and chassis number.(Number repeated on a platemounted on the dashboard at the

 base of the windscreen)

2   Maximum permissible all upweight.

3  Maximum permissible total trainweight (= vehicle loaded andtowing a trailer).

4  Maximum permissible front axleloading.

5   Maximum permissible rear axleloading.

6   Technical specifications of thvehicle.

7   Paint code.

8   Equipment level.

9   Vehicle type.

10   Trim code.

11   Additional equipment definitioncode.

12  Fabrication number.

13   Interior matching trim code.

loaded from www.Manualslib.com manuals search engine 

Page 191: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 191/210

1

3

B

B

B

B

2

B

1.2 1.2 16V

1.4 16V - 1.6 16V 2.0 16V

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T6.WIN 28/10/2002 12:31   - page 3

6.0

IDENTIFICATION PLATES   (continued)

The information on the vehicleidentification plate and the engineplate   B   must be quoted whenwriting or ordering parts.

 B  - Engine plate or engine label(location differs depending on engine)

1   Engine type2   Engine suffix

3   Engine number

loaded from www.Manualslib.com manuals search engine 

Page 192: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 192/210

1

3

B

2

B

B

1.5 dCi 1.9 dTi

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T6.WIN 28/10/2002 12:31   - page 4

6.04

IDENTIFICATION PLATES   (continued)

The information on the vehicleidentification plate and the engineplate   B   must be quoted whenwriting or ordering parts.

 B  - Engine plate or engine label(location differs depending on

engine)1  Engine type

2  Engine suffix

3  Engine number

loaded from www.Manualslib.com manuals search engine 

Page 193: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 193/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T6.WIN 28/10/2002 12:31   - page 5

6.0

ENGINE SPECIFICATIONS

Versions 1.2 1.2   16V   1.4   16V   1.6  16V   2.0   16V   1.5 dCi 1.9 dTi

Vehicle type(see vehicleidentification plate)

B/C/SB0FB/C/SB10B/C/SB1K

B/CB2D

B/C/SB05B/C/SB11

B/C/SB0W

B/CB1LB/CB0PB/CB13

B/CB14B/CB1D

CB15CB1CCB1GCB1NCB1SCB1T

B/C/SB07B/C/SB08

SB09BB1W

B/CB2C

Engine type(see engineplate)   D7F D4F K4J K4M F4R K9K F9Q turbo

Capacity  (cm³) 1 149 1 149 1 390 1 598 1 998 1 461 1 870

Fuel grade   Unleaded fuel Diesel

Octane rating   95 or 98 (1) 98 – –

Spark plugs   Only use the type specified

for your vehicle’s engine.Their type is shown on a label inthe engine compartment,

otherwise consult your RENAULT Dealer.Fitting spark plugs which

are not to specificationmay damage the engine.

– –

(1) If unavailable, unleaded fuel with an octane rating of 91 may be used.

loaded from www.Manualslib.com manuals search engine 

Page 194: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 194/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T6.WIN 28/10/2002 12:31   - page 6

6.06

WEIGHTS   (in kg)  - Basic vehicle without options, likely to change in the course of the model year:Consult your RENAULT Dealer.

5-door petrol versions(versions sold vary according to country)

  1.2 1.2   16V  1.2   16V

Quickshift 5  1.4   16V

  1.4   16V

Automatic  1.6   16V

  1.6   16V

Automatic

Vehicle type(see vehicle identification plate)

BB0FBB10BB1KBB2D

BB05BB0WBB11

BB05BB0W

BB0PBB13BB1L

BB13BB1L

BB14BB1D

BB14BB1D

KerbweightWithout driver

TotalFront

Rear

900 930 940 1 000 1 030 1 040 1 065545 565 575 645 670 675 700355 365 365 355 360 365 365

Maximum permittedaxle load

FrontRear

780 780 780 850 860 850 860785 785 785 785 785 785 785

Maximum permissible all up weight   1 440 1 470 1 480 1 545 1 570 1 535 1 560

Maximum permissible towed weight, unbraked   485 500 505 535 550 545 555

Maximum permissible towed weight,

 braked (1) driver only 1 100 1 100 1 100 1 200 1 200 1 200 1 200

other cases 800 800 800 900 900 900 900

Maximum permissible total train weight(= maximum permissible all up weight+ trailer)

2 200 2 200 2 250 2 400 2 400 2 400 2 400

Maximum permissible nose weight   75

Max. permissible load on roof rack   70 (including the carrying device)

loaded from www.Manualslib.com manuals search engine 

Page 195: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 195/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T6.WIN 28/10/2002 12:31   - page 7

6.0

WEIGHTS   (continued)(1) Towed weight  (Towing a caravan, boat, etc.)

- It is important that the towing weights in each country governed by local legislation are respected. Consult your RenaulDealer for all towing attachments.  In all cases, never exceed the maximum permissible total train weight (vehicle +trailer).

- If your vehicle is already being used fully laden (maximum permitted all up weight); your maximum speed must belimited to 60 mph (100 km/h) and the tyre inflation pressures should be increased by 0.2 bar.

- Engine output and performance on hills are reduced with altitude. We recommend that you reduce the maximum load b10% at an altitude of 1000 metres, then by an additional 10% for each 1000 metres thereafter.

loaded from www.Manualslib.com manuals search engine 

Page 196: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 196/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T6.WIN 28/10/2002 12:31   - page 8

6.08

WEIGHTS   (in kg)  - Basic vehicle without options, likely to change in the course of the model year:Consult your RENAULT Dealer.

3-door petrol versions(versions sold vary according to country)

  1.2 1.2   16V  1.2   16V

Quickshift 5  1.2   16V

  1.2   16V

Quickshift 5  1.4   16V   1.4   16V

Vehicle type(see vehicle identification plate)

CB0FCB10CB1KCB2D

CB05CB11

CB05 CB0W CB0W CB0PCB13CB1L

CB13CB1L

KerbweightWithout driver

TotalFront

Rear

880 910 920 910 920 980 1 010540 560 570 560 570 640 665340 350 350 350 350 340 345

Maximum permittedaxle load

FrontRear

780 780 780 780 780 850 860785 785 785 785 785 785 785

Maximum permissible all up weight   1 420 1 450 1 460 1 450 1 460 1 525 1 550

Maximum permissible towed weight, unbraked   475 490 495 490 495 525 540

Maximum permissible towed weight,

 braked (1) driver only 1 100 1 150 1 150 1 150 1 150 1 200 1 200

other cases 850 800 800 850 850 950 900

Maximum permissible total train weight(= maximum permissible all up weight+ trailer)

2 200 2 250 2 250 2 250 2 250 2 400 2 400

Maximum permissible nose weight   75

Max. permissible load on roof rack   60 (including the carrying device)

loaded from www.Manualslib.com manuals search engine 

Page 197: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 197/210

Page 198: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 198/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T6.WIN 28/10/2002 12:31   - page 10

6.10

WEIGHTS   (in kg)  - Basic vehicle without options, likely to change in the course of the model year:Consult your RENAULT Dealer.

3-door petrol versions (continued)(versions sold vary according to country)

  1.6   16V  1.6   16V

Automatic  1.6   16V

  1.6   16V

Automatic  2.0   16V

Vehicle type(see vehicle identification plate)

CB14 CB14 CB1D CB1D CB15 - CB1CCB1G - CB1NCB1S - CB1T

KerbweightWithout driver

TotalFront

Rear

1 020 1 045 1 030 1 060 1 035670 695 680 705 660350 350 350 355 375

Maximum permittedaxle load

FrontRear

850 860 850 860 850785 785 785 785 700

Maximum permissible all up weight   1 515 1 540 1 515 1 540 1 490

Maximum permissible towed weight,unbraked   535 545 535 545 (2)

Maximum permissible towed weight, braked (1) driver only 1 200 1 200 1 200 1 200 (2)

other cases 900 900 950 900 (2)

Maximum permissible total train weight(= maximum permissible all up weight+ trailer)

2 350 2 400 2 400 2 400 1 490

Maximum permissible nose weight   75 (2)

Max. permissible load on roof rack   60 (including the carrying device)

loaded from www.Manualslib.com manuals search engine 

Page 199: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 199/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T6.WIN 28/10/2002 12:31   - page 11

6.1

WEIGHTS   (continued)(1) Towed weight  (Towing a caravan, boat, etc.)-   It is important that the towing weights in each country governed by local legislation are respected. Consult your Renaul

Dealer for all towing attachments.  In all cases, never exceed the maximum permissible total train weight (vehicle +trailer).

- If your vehicle is already being used fully laden (maximum permitted all up weight); your maximum speed must belimited to 60 mph (100 km/h) and the tyre inflation pressures should be increased by 0.2 bar.

- Engine output and performance on hills are reduced with altitude. We recommend that you reduce the maximum load b10% at an altitude of 1000 metres, then by an additional 10% for each 1000 metres thereafter.

(2) No towing option

loaded from www.Manualslib.com manuals search engine 

Page 200: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 200/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T6.WIN 28/10/2002 12:31   - page 12

6.12

WEIGHTS   (in kg)  - Basic vehicle without options, likely to change in the course of the model year:Consult your RENAULT Dealer.

Diesel versions(versions marketed depend on country)

1.5 dCi5 doors

1.9 dTi5 doors

1.5 dCi3 doors

1.9 dTi3 doors

Vehicle type(see vehicle identification plate)

BB07 BB08 BB1W BB2C CB07 CB08 CB2C

KerbweightWithout driver

TotalFront

Rear

980 980 990 1 020 960 960 1 000610 610 620 655 605 605 650370 370 370 365 355 355 350

Maximum permittedaxle load

FrontRear

860 860 840 860 860 860 860785 785 785 785 785 785 785

Maximum permissible all up weight   1 535 1 540 1 510 1 510 1 515 1 520 1 490

Maximum permissible towed weight,unbraked   535 535 530 545 525 525 535

Maximum permissible towed weight,

 braked (1) driver only 1 200 1 200 1 100 1 200 1 200 1 200 1 200

other cases 900 900 800 950 950 950 950

Maximum permissible total train weight(= maximum permissible all up weight+ trailer)

2 400 2 400 2 250 2 400 2 400 2 400 2 400

Maximum permissible nose weight   75

Max. permissible loadon roof rack

70(including the carrying device)

60 (includingthe carrying device)

loaded from www.Manualslib.com manuals search engine 

Page 201: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 201/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T6.WIN 28/10/2002 12:31   - page 13

6.1

WEIGHTS   (continued)(1) Towing weight  (towing a caravan, boat, etc.)

- It is important to comply with the towing weights, governed by local legislation in each country and, in particular laiddown in the Road Traffic Regulations. Consult your Renault Dealer about any attachments.  Under no circumstances maythe total train weight (= max. permissible all-up weight and weight towed) be exceeded.

- If your vehicle is already used at full load (max. permissible all-up weight), the maximum speed must be limited to60 mph (100 km/h) and the tyre inflation pressure increased by 0.2 bar.

- The engine output and climbing capability are reduced with altitude. We recommend that the maximum load be reduce by 10% at an altitude of 1000 metres and by an additional 10% for each 1000 metres thereafter.

loaded from www.Manualslib.com manuals search engine 

Page 202: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 202/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T6.WIN 28/10/2002 12:31   - page 14

6.14

WEIGHTS   (in kg) -  Basic vehicle without option, likely to change in the course of the model year.Consult your RENAULT Dealer.

Utility versions(versions marketed depend on country)   1.2 1.2   16V   1.5 dCi 1.5 dCi

Vehicle type(see vehicle identification plate)

SB0FSB10SB1K

SB05SB11

SB0W

SB07 SB08SB09

KerbweightWithout driver

TotalFront

Rear

880 910 980 980540 560 630 630340 350 350 350

Maximum permittedaxle load

FrontRear

780 780 860 860785 785 785 785

Maximum permissible all up weight   1 420 1 450 1 515 1 520

Maximum permissible towed weight, unbraked   475 505 525 525

Maximum permissible towed weight,

 braked (1) driver only 1 100 1 100 1 150 1 150

other cases 850 800 900 900

Maximum permissible total train weight(= maximum permissible all up weight+ trailer)

2 200 2 200 2 400 2 400

Permissible nose weight   75 50

Max. permissible load on roof rack  60

(including the carrying device)

(1) Towed weight(Towing a caravan, boat, etc.)

-   It is important that the towinweights in each country governed

 by local legislation are respectedConsult your RENAULT Dealer foall towing attachments.   In alcases, never exceed the maximum

permissible total train weigh(vehicle + trailer).

- If your vehicle is already beinused fully laden (maximumpermitted all up weight); youmaximum speed must be limitedto 60 mph (100 km/h) and the tyrinflation pressures should bincreased by 0.2 bar.

- Engine output and performancon hills are reduced with altitudeWe recommend that you reducthe maximum load by 10% at analtitude of 1000 metres, then b

an additional 10% for each1000 metres thereafter.

loaded from www.Manualslib.com manuals search engine 

Page 203: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 203/210

0,736 2,473 (2) - 2,472 0,600 1,418 (2) - 1,406

3,811 1,940

1,392 (2) - 1,385

1,409 (2)

1,417

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T6.WIN 28/10/2002 12:31   - page 15

6.1

DIMENSIONS (in metres)

(1) According to equipment(2) Version 2.0 16V

loaded from www.Manualslib.com manuals search engine 

Page 204: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 204/210

Page 205: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 205/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T6.WIN 28/10/2002 12:31   - page 17

ALPHABETICAL INDEXA   ABS ........................................................................... 2.20

Accessories ............................................................... 5.28Accessories installation ........................................... 5.28Additional headlights .............................................. 5.13Adjusting beam height ............................................ 1.57Adjusting the driver's position .................... 1.13 - 1.14Air conditioning .......................................... 3.09    3.22Air vents ........................................................ 3.02 - 3.03Airbag ........................................................... 1.15    1.20Anti-lock braking system ........................................ 2.20

Anti-pollution (advice) ............................... 2.06    2.08Anti-theft system (switch) ....................................... 2.02Ashtrays .................................................................... 3.32Automatic gearbox (use) ............................. 2.10    2.12Automatic gearbox selector lever .............. 2.10    2.12

B   Battery ................................................. 4.10 - 5.19 - 5.20Bodywork (maintenance) ............................. 4.12 - 4.13Bonnet ...................................................................... 4.02Brake fluid ................................................................ 4.08Bulbs (changing) ......................................... 5.10    5.18Buzzer (lights on) ......................................... 1.04 - 1.56

C   Capacity of mechanical components .......... 4.07 - 4.09Catalytic converter (special points) ........................ 2.04Catalytic converter ................................................... 2.04Central door locking .......................... 1.02 - 1.03 - 1.05Changing a wheel .................................................... 5.05Changing the bulbs ..................................... 5.10    5.18Child booster seat ....................................... 1.23    1.32Child safety ................. 1.04 - 1.24    1.36 - 3.25 - 3.28Children ........... 1.04 - 1.19 - 1.24    1.36 - 3.25 - 3.28Cigarette lighter ........................................................ 3.32

C   Clock ......................................................................... 1.37Control instruments .................................... 1.42    1.52Controls ........................................................ 1.38    1.41Coolant ..................................................................... 4.09Courtesy lights .............................................. 3.23 - 3.24Courtesy mirrors ...................................................... 3.26Cruise control - speedlimiherer ................. 2.21    2.26

D   Dashboard ............................ 0.04    0.06 - 1.38    1.41Deactivating front passenger airbags ........... 1.34 - 1.35De-icing: windscreen .............. 3.05 - 3.06 - 3.10 - 3.1

rear screen ................................................ 1.61Demisting: windscreen ........... 3.05 - 3.06 - 3.10 - 3.1

rear screen ............................................. 1.61Dimensions ............................................................... 6.15Dipstick ........................................................ 4.03    4.06Direction indicators ..... 1.62 - 5.10 - 5.12 - 5.14 - 5.16Door locking ................................................ 1.03    1.06Doors .............................................................. 1.04 - 1.05Driver's layout ............................................. 1.50    1.52Driving ......................................................... 2.02    2.30

Driving position .......................................... 1.38 

 1.41

E   Electronic stability program: ESP ................ 2.27 - 2.28Emergency spare wheel ........................................... 5.02Engine (technical specifications) ............................ 6.05Engine immobiliser ....................................... 1.07 - 1.08Engine oil .................................................... 4.03    4.07Engine specifications ............................................... 6.05Environment ............................................................. 2.09ESP: Electronic stability program ................ 2.27 - 2.28Exterior temperature ................................................ 1.37

loaded from www.Manualslib.com manuals search engine 

Page 206: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 206/210

Page 207: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 207/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T6.WIN 28/10/2002 12:31   - page 19

ALPHABETICAL INDEXP   Paintwork (maintenance) ............................. 4.12 - 4.13

Paintwork (part number) ......................................... 6.02Petrol and diesel special features ................ 2.04 - 2.05Power assisted steering ................................ 2.19 - 4.10Power assisted steering pump ................................ 4.10Practical advice ........................................... 2.06    2.08Puncture ....................................................... 5.02    5.05

Q   Quickshift 5 gearbox (use) ......................... 2.13    2.18Quickshift 5 gearbox lever ...................................... 2.13

R   Radio (fitting) ........................................................... 5.27Radio (installation) .................................................. 5.27Reading lights ............................................... 3.23 - 3.24Rear bench seat ........................................................ 3.33Rear parcel shelf ........................................... 3.35 - 3.36Rear screen (demisting) ........................................... 1.61Rear seats .................................................................. 3.33Rear view mirrors ......................................... 1.53 - 1.54Remote control: electric door locking ......... 1.02 - 1.03

door locking - batteries ............... 5.21

Replacement parts ................................................... 6.16Reverse gear ............................................................. 2.19Running in ............................................................... 2.02

S   Seat belts ..................................................... 1.13    1.23Side repeaters ........................................................... 5.16Speakers (locktion) .................................................. 5.27Starting the engine ....................................... 2.02 - 2.03Steering wheel (adjusting) ...................................... 1.54Storage compartments .................................. 3.30 - 3.31Sun visor .................................................................. 3.26Sunroof ........................................................ 3.27    3.29

T   Tank: brake fluid ...................................................... 4.08engine coolant ............................................... 4.09fuel ....................................................... 1.58 - 1.64windscreen washer ....................................... 4.11

Technical specifications ............................. 6.02    6.15Towing (attachments) .............................................. 5.26Towing (breakdown) ..................................... 5.24 - 5.25Towing (caravan) ......................................... 6.06    6.14Towing weights ........................................... 6.06    6.14Traction control ............................................. 2.28 - 2.29

Traction control system ................................ 2.29 - 2.30Transporting items in the luggage compartment .. 3.37Turning circle ........................................................... 6.15Tyre pressures .................................... 0.04 - 0.05 - 5.07Tyre pressures ............................................. 0.04    0.06Tyres ............................................................. 5.06    5.08

V   Vehicle identification plates ...................... 6.02    6.04Ventilation and heating .............................. 3.04    3.22

W  Washing ....................................................... 4.12    4.14Weights ........................................................ 6.06    6.14Wheelbrace ............................................................... 5.03Wheels (safety) ............................................ 5.06    5.08Window winder ....................................................... 3.25Windscreen ............................................................... 3.26Windscreen washer ............................ 1.58 - 1.59 - 4.11Wiper blades ............................................................ 5.09Wipers ............................................... 1.58    1.60 - 5.09

loaded from www.Manualslib.com manuals search engine 

Page 208: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 208/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T6.WIN 28/10/2002 12:31   - page 20

loaded from www.Manualslib.com manuals search engine 

Page 209: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 209/210

nu654-6 - CLIO II   C:\Documentum\Checkout\nu654-6_eng_T6.WIN 28/10/2002 12:31   - page 21

loaded from www.Manualslib.com manuals search engine 

Page 210: Renault Clio 2003 Manual

8/9/2019 Renault Clio 2003 Manual

http://slidepdf.com/reader/full/renault-clio-2003-manual 210/210


Recommended