Date post: | 15-Dec-2015 |
Category: |
Documents |
Upload: | jana-mangan |
View: | 216 times |
Download: | 1 times |
Rider Education Division Trailering Seminar
The Trailering Seminar should provide:• Education and Information• A better understanding of potential problems• A reduction in risk associated with trailers• An increase in riding safety
We will cover the following topics associated with trailering:
• Types of Trailers, Suspensions and Hitches• Set-up of the Bike and Trailer• Weights and Packing• Braking Practice • Backing Up• Curves, Turns and Obstacle Avoidance• On The Road
Types of Trailers
• Cargo or Camper• New or Used• Factory or Homemade• Shape• Cooler Rack• Spare Tire
Different Suspensions• Leaf or Coil Springs• Shock Absorbers/Torsion Bar/Air• Wheels – Small or Large Diameter
Tire Width and Height
Smaller wheels turn at higher RPM• Bearings – Bearing Buddies vs Dexter Axle
Bushtec Cycle-Mate
Hitches
• Pin, Ball and Heim Joint• Swivel Connection• Ball – 47 Degree lean• Swivel – 360 Degrees
Standard Ball with Swivel
Bushtec Heim Joint
Setting up the Bike and Trailer
• A straight line should pass through center of front & rear axles, center of ball and center of mass of loaded trailer
Setting up the Bike and Trailer
• If the ball is too high:Decreased rear wheel traction when brakingRear wheel skid/High-side
• If the ball is too low:Decreased front wheel traction when brakingFront wheel skid
Safety Chains
• Required by Law
Most states require two• Strong enough to hold the trailer if the hitch fails• Long enough to reach in a tight turn• Short enough to prevent separation if pin comes
out
Tire Pressure
• Manufacturer SpecificationAt what load?
• Needs to be adjusted for your load• Put white shoe polish on the tread, go for a ride,
check wear pattern and adjust pressure
Maintenance
• Ball lubricationGrease, Vaseline, waxpaper
• Wheel bearings• Clamp shoe• Tires• Lights
Tongue Weight• Recommendations vary
7-12% or 10-15% is most common• 20 to 70 Lbs. is the usual range• What feels right and keeps trailer stable• The rider needs to determine this• Use fish scale or bathroom scale with coupler at
towing height
Packing• What is empty weight of the trailer?• What is the Gross Vehicle Weight Rating?• GVWR minus Trailer Wt.= Load Capacity• Heavy stuff on the bottom over axle• Even weight side to side• Heavier load = longer stopping distance, more
push in corners, increased risk of rear wheel slide-out
Braking Practice
• 200’ long - 10 to 15 MPH• Bike and trailer in a straight line• Handlebars square to the bike• Compare distance with & without trailer• Weight transfer should be the same if
mounted and loaded properly
Backing Up• To back into a parking space:
Pull beyond the spot, turn away from the spot and straighten out before backing
Start moving with a sharp turn of the handlebars pushing forward on the side that you want the trailer to turn toward
As trailer begins to move, begin moving handlebars back toward center gently following the change in the trailer angle with the angle of the bars. Leave the bars turned too long and trailer turns too sharp – “jackknife”
YEAH, RIGHT!
Backing Up
• The trailer can be steered by directing the “BACK” of the front wheel in the direction you want the trailer to go
This didn’t work for me either!
Backing Up
• The more people watching, the worse you will do
• When alone – you’ll look like an expert• Practice, practice, practice
Curves and Turns• Low speed – Trailer tracks inside• High speed – Trailer tracks outside• Driving, braking and side forces are
different with a trailer• The trailer creates a side force trying to
push the rear tire to the outside• Slow, Look, Press, Roll - GENTLY
Curves and Turns
• Trailer pushes in
the direction of
the arrow
Obstacle Avoidance• Quick swerves place great side loads on
the bike• Trailers create additional side forces• Swerves with a trailer should only be
practiced with a trained professional• NEVER MIX BRAKING AND
SWERVING IN THE SAME ACTION
Hills
• The effect the trailer has on the bike is greater than on flat surfaces
• Up hill – Less weight on front wheel• Down hill – Less weight on rear wheel
Up hill
• Trailer pulls• Less weight on the front wheel
Down hill
• Trailer pushes• Braking distance increases• Less weight on rear wheel
On The Road• Remember the added length & width
At gas stations & toll booths• More space needed
Pulling out in traffic and passingSlower acceleration
• Team RidingTrailer should be at front of groupLonger stopping distance
During the Seminar we have discussed the following topics associated with pulling a trailer with a motorcycle:
• Types and styles of trailers• How to set up the bike and trailer• Loading and weights• Handling: braking, backing up• Turning and Obstacle Avoidance
The rider is ultimately responsible for the bike and trailer.
Pulling a trailer can be done safely by taking the proper precautions.
Above all, be safe, take your time and have fun!
AmazingDart
Honky Escapade
Grimreaper
Cyclops
? Questions ?