Russia Intellectual and other property rights to the information contained in this document are held by PlasmaVenture Ltd. with all rights reserved © 2003 -2006

Valeriy KolesnikTel. +7 903 6361072 CFD-consultant

The purpose researches

Purpose – QUENCH TANK & Tangential Breaking the Jet about inside wall

The purpose researches

HELICOID TRAY in the form of SHNEK's

The purpose researches

HELICOID TRAY in the form of SHNEK's

The purpose researches

HELICOID TRAY in the form of SHNEK's

The purpose researches

SHNEK & Tank

The purpose researches

SHNEK & Tank , Free Surface Lithium

The purpose researches

Result tangential braking the jet about inside a wall of a tank . t=0.4 sec

The purpose researches

Result tangential braking the jet about inside a wall of a tank . t=0.5 sec

The purpose researches

Result tangential braking the jet about inside a wall of a tank . t=0.5 sec

The purpose researches

Result tangential braking the jet about inside a wall of a tank . t=1.2 sec

The purpose researches

Result tangential braking the jet about inside a wall of a tank . t=1.2 sec

The purpose researches

Author offers original design TANGENTIAL BRAKING the JET Lithium about inside a wall of a tank by twistings by means of the HELICOID TRAY in the form of SHNEK's.

The design is realized in project ISTC-2036:

http://tech-db.istc.ru/ISTC/sc.nsf/html/projects.htm?open&id=2036

http://www.fluent.com/about/news/newsletters/05v14i3/a13.htm

http://www.fluent.com/about/news/newsletters/05v14i3/pdfs/nl13.pdf

Originality of the decision of sharp clearing of kinetic energy flat turbulent jet of liquid lithium after an output from a target and hits in Quench Tank consists in use HELICOID TRAY in the form tray in width of 300 mm and a lateral wall 100мм.

Very much an important point having buried current of a jet of lithium after a tray targets. That is about 150 mm the jet in a tank flies by freely and then rather softly (under a corner of 6 degrees) meets with a surface SHNEK's. After that there is a crushing a jet on separate fragments which in the further twist on an internal wall tank in a tangential direction also I form a new jet in width 300 mm. Thus kinetic energy decreases very sharply (approximately on exponential law) and the jet meets free surface of a level with a speed approximately 2-3 meters (instead of 20 meters). It allows to avoid capture Gas on FS and to eliminate cavitation the pump....

CONCLUSION:

The purpose researches

1. FLUENT 6.2. Theory Manual . 2005. Fluent Inc. Central Source Park,10 Cavendish Court, Lebanon, NH 03766,USA . http://www.fluent.com

2. GAMBIT 2.2. User’s Guide. 2005. Fluent Inc. Central Source Park, 10 Cavendish Court, Lebanon, NH 03766,USA. http://www.fluent.com

REFERENCES:

The purpose researches

http://www.fluent.com/worldwide/europe/contact/dist.htm