S5ES series 29CZ5DE 29CZ5T 29CZ6SIskematv.files.wordpress.com/2011/08/toshiba...[TV/VIDEO] button,...

SERVICE MANUAL

Color Television

FILE NO. 060-200565GR

Published in Singapore, October 2005 GREEN

Color TelevisionS5ES series

29CZ5DE29CZ5T 29CZ6SI

SUPPLEMENT

© TOSHIBA SINGAPORE PTE LTD

The above models are classified as green products (*1), as indicated by the underlined serial numbers. This Service

Manual describes replacement parts for the green products. When repairing these green product (s), use the part (s)

described in this manual and lead-free solder (*2).

For (*1) and (*2), see the next page.

– 2 –

(*2)

LEAD-FREE SOLDERThis product is manufactured using lead-free solder as a part of a movement within the consumer products industry at largeto be environmentally responsible. Lead-free solder must be used in the servicing and repair of this product.

WARNINGThis product is manufactured using lead free solder.

DO NOT USE LEAD BASED SOLDER TO REPAIR THIS PRODUCT!

The melting temperature of lead-free solder is higher than that of leaded solder by 86˚F to 104˚F (30˚C to 40˚C). Use of asoldering iron designed for lead-based solders to repair product made with lead-free solder may result in damage to thecomponent and or PCB being soldered. Great care should be made to ensure high-quality soldering when servicing thisproduct -especially when soldering large components, through-hole pins, and on PCBs - as the level of heat required tomelt lead-free solder is high.

(*1)GREEN PRODUCT PROCUREMENTThe EC is actively promoting the WEEE & RoHS Directives that define standards for recycling and reuse of Waste Electri-cal and Electronic Equipment and for the Restriction of the use of certain Hazardous Substances. From July 1, 2006, theRoHS Directive will prohibit any marketing of new products containing the restricted substances.Increasing attention is given to issues related to the global environmental. Toshiba Corporation recognizes environmentalprotection as a key management tasks, and is doing its utmost to enhance and improve the quality and scope of itsenvironmental activities. In line with this, Toshiba proactively promotes Green Procurement, and seeks to purchase anduse products, parts and materials that have low environmental impacts.Green procurement of parts is not only confined to manufacture. The same green parts used in manufacture must also beused as replacement parts.

TABLE OF CONTENTS

CHAPTER 1 GENERAL ADJUSTMENTS

SAFETY INSTRUCTIONS ............................................................................................................................................. 3

SET-UP ADJUSTMENT ................................................................................................................................................. 4

SERVICE MODE ........................................................................................................................................................... 8

DESIGN MODE ........................................................................................................................................................... 11

ELECTRICAL ADJUSTMENTS ................................................................................................................................... 12

CIRCUIT CHECK......................................................................................................................................................... 13

CHAPTER 2 SPECIFIC INFORMATIONS

SETTING & ADJUSTING DATA ................................................................................................................................... 14

NAMES AND FUNCTIONS OF CONTROLS .............................................................................................................. 15

PROGRAMMING CHANNEL MEMORY ...................................................................................................................... 16

PROCEDURES TO SET HOTEL MODE ..................................................................................................................... 18

CHASSIS AND CABINET REPLACEMENT PARTS LIST ........................................................................................... 19

PC BOARDS BOTTOM VIEW...................................................................................................................................... 26

TERMINAL VIEW OF TRANSISTORS ........................................................................................................................ 30

CIRCUIT BLOCK DIAGRAM ....................................................................................................................................... 32

SPECIFICATIONS .................................................................................................................................................... END

APPENDIX:

CIRCUIT DIAGRAM

GE

NE

RA

L A

DJU

ST

ME

NT

SS

PE

CIF

IC IN

FO

RM

AT

ION

S

– 3 –

2. The only source of X-RAY RADIATION in this TV receiveris the picture tube. For continued X-RAY RADIATIONprotection, the replacement tube must be exactly the sametype tube as specified in the parts list.

3. Some part in this receiver have special safety-relatedcharacteristics for X-RAY RADIATION protection. Forcontinued safety, parts replacement should be undertakenonly after referring to the PRODUCT SAFETY NOTICEbelow.

SAFETY PRECAUTION

WARNING : Service should not be attempted by anyone unfamiliar with the necessary precautions on this receiver. The followingare the necessary precautions to be observed before servicing this chassis.1. An isolation transformer should be connected in the power line between the receiver and the AC line before any service is

performed on the receiver.2. Always discharge the picture tube anode to the CRT conductive coating before handling the picture tube. The picture tube

is highly evacuated and if broken, glass fragments will be violently expelled. Use shatter proof goggles and keep picturetube away from the unprotected body while handling.

3. When replacing a chassis in the cabinet, always be certain that all the protective devices are put back in place, such as;nonmetallic control knobs, insulating covers, shields, isolation resistor-capacitor network etc.

CHAPTER 1 GENERAL ADJUSTMENTS

SAFETY INSTRUCTIONS

WARNING: BEFORE SERVICING THIS CHASSIS, READ THE “X-RAY RADIATION PRECAUTION”, “SAFETY PRECAU-TION” AND “PRODUCT SAFETY NOTICE” INSTRUCTIONS BELOW.

X-RAY RADIATION PRECAUTION

1. Excessive high voltage can produce potentially hazardousX-RAY RADIATION. To avoid such hazards, the highvoltage must not be above the specified limit. The nominalvalue of the high voltage of this receiver is (A) kV at zerobeam current (minimum brightness) under a (C) V ACpower source. The high voltage must not, under anycircumstances, exceed (B) kV.

Refer to table-1 for high voltage (A), (B) & AC voltage (C).(See SETTING & ADJUSTING DATA on page 14)

Each time a receiver requires servicing, the high voltageshould be checked following the HIGH VOLTAGE CHECKprocedure in this manual. It is recommended that thereading of the high voltage be recorded as a part of theservice record. It is important to use an accurate andreliable high voltage meter.

PRODUCT SAFETY NOTICE

Many electrical and mechanical parts in this chassis have special safety-related characteristics. These characteristics areoften passed unnoticed by a visual inspection and the protection afforded by them cannot necessarily be obtained by usingreplacement components rated for higher voltage, wattage, etc. Replacement parts which have these special safety char-acteristics are identified in this manual and its supplements; electrical components having such features are identified by theinternational hazard symbols on the schematic diagram and the parts list.Before replacing any of these components, read the parts list in this manual carefully. The use of substitute replacementparts which do not have the same safety characteristics as specified in the parts list may create shock, fire, X-ray radiationor other hazards.

GE

NE

RA

L A

DJU

ST

ME

NT

SS

PE

CIF

IC IN

FO

RM

AT

ION

S

– 4 –

SET-UP ADJUSTMENT

R The following adjustments should be made when a complete realignment is required or a new picture tube is installed.Perform the adjustments in order as follows :1. Color Purity2. Convergence3. White BalanceNote: The PURITY/CONVERGENCE MAGNET assembly and rubber wedges need mechanical positioning.

Refer to figure 1.Mounting position of the purity magnet assembly should fit to same position as old one because slightly difference tothe position depend on a kind of tube.

* There are no adjustment of purity and convergence in some picture tube (Unified with purity magnet)

5. Remove the Rubber Wedges.6. Rotate and spread the tabs of the purity magnet (See fig-

ure 2.) around the neck of the picture tube until the greenbelt is in the center of the screen. At the same time, enterthe raster vertically.

7. Slowly move the yoke forward or backward until a uniformgreen screen is obtained. Tighten the clamp screw of theyoke temporarily.

8. Check the purity of the red and blue raster.

GLASS CLOTHTAPES

DEFLECTIONYOKE

TEMPORARYMOUNTING

RUBBER WEDGE

ADHESIVE

DEFLECTIONYOKE

PURITY/CONVERGENCEMAGNET ASS'Y

29.1mm(28", 29")25mm(25")19mm(19", 20", 21")14mm(13", 14")

Figure 1.

WARNING: BEFORE SERVICING THIS CHASSIS, READ THE “X-RAY RADIATION PRECAUTION”, “SAFETY PRECAU-TION” AND “PRODUCT SAFETY NOTICE” ON PAGE 3 OF THIS MANUAL.

COLOR PURITY ADJUSTMENTNOTE : Before attempting any purity adjustments, the

receiver should be operated for at least fifteen min-utes.

1. Demagnetize the picture tube and cabinet using a degauss-ing coil.

2. Set the brightness and contrast to maximum.3. Use a green raster from a signal generator.4. Loosen the clamp screw holding the yoke and slide the

yoke backward or forward to provide vertical green belt(zone) in the picture screen.

GE

NE

RA

L A

DJU

ST

ME

NT

SS

PE

CIF

IC IN

FO

RM

AT

ION

S

– 5 –

Figure 2.BLU RED

BLU

RED

RED/BLU GRN

RED/BLU

GRN

BGR

RGB

BGR

RGB

BGR

RGB

RGB

BGR

4-POLE MAGNETS MOVEMENT

INCLINE THE YOKE UP (OR DOWN)

6-POLE MAGNETS MOVEMENT

Center Convergence by Convergence Magnets

Circumference Convergence by DEF Yoke

INCLINE THE YOKE RIGHT (OR LEFT)

Figure 3. Dot Movement Pattern

4-POLEMAGNETS

PURITYMAGNETS

6-POLEMAGNETS

ADJUST THE ANGLE(VERTICAL LINES) FIXED

ROTATE TWO TABSAT THE SAME TIME(HORIZONTAL LINES)

CONVERGENCE MAGNET ASSEMBLY ADJUSTMENT OF MAGNETS

R CIRCUMFERENCE CONVERGENCE ADJUSTMENT1. Loosen the clamping screw of deflection yoke slightly to

allow the yoke to tilt.2. Temporarily put a wedge as shown in figure 1. (Do not

remove cover paper on adhesive part of the wedge.)3. Tilt front of the deflection yoke up or down to obtain better

convergence in circumference. (See figure 3.) Push themounted wedge into the space between picture tube andthe yoke to fix the yoke temporarily.

4. Put other wedge into bottom space and remove the coverpaper to stick.

5. Tilt front of the yoke right or left to obtain better convergencein circumference. (See figure 3.)

6. Keep the yoke position and put another wedge in eitherupper space. Remove cover paper and stick the wedge onpicture tube to fix the yoke.

7. Detach the temporarily mounted wedge and put it in an-other upper space. Stick it on picture tube to fix the yoke.

8. After fixing three wedges, recheck overall convergence.Tighten the screw firmly to fix the yoke and check the yokeis firm.

9. Stick three adhesive tapes on wedges as shown in figure1.

CONVERGENCE ADJUSTMENTSNOTE: Before attempting any convergence adjustments, the

receiver should be operated for at least fifteenminutes.

R CENTER CONVERGENCE ADJUSTMENT1. Use the cross-dot pattern from a signal generator.2. Set the brightness and contrast for well defined pattern.3. Adjust two tabs of the 4-Pole Magnets to change the angle

between them (See figure 2.) and superimpose redand blue vertical lines in the center area of the picturescreen.

4. Turn the both tabs at the same time keeping the angleconstant to superimpose red and blue horizontal lines atthe center of the screen.

5. Adjust two tabs of 6-Pole Magnets to superimpose red/blue line and green one. Adjusting the angle affects thevertical lines and rotating both magnets affects thehorizontal lines.

6. Repeat adjustments 3, 4, 5 keeping in mind red, greenand blue movement, because 4-Pole Magnets and 6-PoleMagnets have mutual interaction and make dot movementcomplex.

WARNING: BEFORE SERVICING THIS CHASSIS, READ THE “X-RAY RADIATION PRECAUTION”, “SAFETY PRECAU-TION” AND “PRODUCT SAFETY NOTICE” ON PAGE 3 OF SERVICE MANUAL.

SET-UP ADJUSTMENT (FOR FLAT TUBE)� The following adjustments should be made when a complete realignment is required or a new picture tube is installed.

Perform the adjustments in order as follows :1. Color Purity2. Convergence3. White BalanceNote:The PURITY/CONVERGENCE MAGNET assembly and rubber wedges need mechanical positioning.

Refer to figure 1.

COLOR PURITY ADUSTMENT

(1)Let the screen face in the installing direction or toward the east (when it is to be moved), bring up the service modescreen after demagnetizing (front, left, right, and top) with the degaussing coil, receive white signals by pressing the[TV/VIDEO] button, and then the receiver should be operated for more than 40 minutes.

(2)Perform rough adjustment of the central convergence with the P/C magnet according to the adjustment item.

(3)Receive built-in green signals, loosen set screws on the deflection yoke, remove rubber wedges, and shift the deflectionyoke to toward front.

(4)Move alternately the two 2-pole magnets of the P/C magnets so that the green raster can come to the center of thescreen.

Figure 1.

(5)Receive built-in red and blue signals, check that there is no inclination of the single color raster toward one side, and ifeach color tilts to a great extent, make adjustment with the 2-pole magnet so that the 3 colors will come to the centerevenly.

(6)Receive the green raster, shift the deflection yoke from aforemost position (hitting against the picture tube) to abackward position horizontally, stop the deflection yokeat a position where it begins to become a green raster,and perform accurate marking on the picture tube.

(7)Shift the deflection yoke further backward, and performaccurate marking at a position where the green rasterbegins to being luck.

(8)Fix the deflection yoke at a position 60% forward withinthe range marked in items (6) and (7) above.

CONVERGENCE ADJUSTMENTS

* Adjust the convergence magnet to get vest convergence in the the order to (1) ~ (5).

� CENTER CONVERGENCE:

(1)Receive the white crosshatch or dot pattern from the service signal generator.

(2)Use the 2 pieces of main 4-pole magnets of P/C magnets, change the open angle, and align the red and blue verticallines on the screen center.

(3)Freeze the open angle of the main 4-pole magnets, turn them simultaneously, and align the horizontal lines.

(4)Take the same steps for items (2) and (3) above and align red/blue with green on the screen center using two 6-polemagnets.

A

P/C magnet installing position A• 30"=26.5 mm• 32"=30.5 mm or 32.5 mm• 34"=37 mm• 34"=39 mm

Green Belt

2-pole purity magnet(27": Magnet is fixed with deflection yoke.)

Main 4-pole convergence magnet (30" : 32")6-pole convergence magnet (34")

Sub-4-pole convergence magnet (32" : 34")Sub-4-pole convergence magnet (to be installed on deflection yoke for 30", 32")

6-pole convergence magnet (30" : 32")Main 4-pole convergence magnet (34")

Fix the deflection yoke at a position 60% forward from apoint between (6) and (7)

Picture tube

Shift deflection yoke(6)

(8)(7) Perform marking of each point

on the tape of picture tube

CRT-D board

P/C Mag100 60 0%

GE

NE

RA

L A

DJU

ST

ME

NT

S

– 6 –

(5)Adjust the sub-4-pole magnets only in case there is any deviation of Xv bow-shaped convergence. (To be usually set atthe initial position)

Align both sides with the sub-4-pole magnets and minimize the deviation of blue and red with the main 4-pole magnets.

blue

bluered

red

Main 4-pole magnet

red/blue

red/blue

green

green

6-pole magnet

Xv bow-shaped deviation of convergence

blue

red

Sub-4-pole magnet

� CIRCUMFERENCE CONVERGENCE:

* Perform correction in the following manner.

A

D

E

F

A

B

C

B

C

SN

D

E

F

A

B

C

D

E

F

NS

VR3

YV YHC

G HG H

VR2 VR1

bluegreenred

• Adjust coils and minimize deviation(The 27” unit has coils underneath it)

bluegreen

red

(Parts code:23 948 274) TC-S

Blue color or blue mark

*Insert the correction piece between thepicture tube and the deflection yoke.

(Insertion position of correctionpiece)

Bonded surface

bluegreen

red

(Parts code:23 948 464)

TransparentBonded surface

Adjust VR 1 and minimize the deviation of YH. *Only 27", 30" and 32".

Redgreen

blue

Redgreen

blue

Redgreen

blue

Redgreen

blue

Adjust VR 2 (YHC) and minimize the deviation of YH.

Redgreen

blue

Redgreen

blue

Redgreen

blue

Redgreen

blue

Adjust VR 3 (YV) and minimize the deviation of YV.

Red

bluegreen

Red

bluegreen

Red

bluegreen

Red

bluegreen

Red

blue

gree

n

blue red

green

Red

blue

gree

n

blue red

green

� 30", 27", 32"

� 34"

27" (Part No. 23 947 371)32", 30" (Part No. 23 947 121)34" (Part No. 23 993 080)

Perform correction by inserting thecorrection piece into the clear-ance of terminal board coils ofthe deflection yoke.

Note:Perform insertion by turning the

metal side to the terminal boardside of the deflection yoke.

GE

NE

RA

L A

DJU

ST

ME

NT

S

– 7 –

GE

NE

RA

L A

DJU

ST

ME

NT

S

– 8 –

SERVICE MODE

1. ENTERING TO SERVICE MODE1) Press o button once on

Remote Control.

2. DISPLAYING THE ADJUSTMENT MENU1) Press MENU button on TV.

3. KEY FUNCTION IN THE SERVICE MODEThe following key entry during display of adjustment menu provides special functions.

A single horizontal line ON/OFF: - / - - button (on remote control)Test signal ON/OFF : a button (on TV or remote control)Selection of the adjustment items : Channel s/t (on TV or remote control)Change of the data value : Volume ; +/– (on TV or remote control)Adjustment menu mode ON/OFF : MENU button (on TV)Initialization of the memory (QA10) : CALL + Channel button on TV (s)Reset the count of operating protect

circuit to “00”: CALL + Channel button on TV (t)“VG2” alignment : 0 button

“BCUT” selection : 1 button“GCUT”selection : 2 button“SCNT” selection : 4 button“COLC” selection : 5 button“TNTC” selection : 6 button“SBY” selection : 7 buttonSelf diagnostic display ON/OFF : 9 button

CAUTION : Never try to perform initialization unless you have changed the memory IC.

2) Press o button again tokeep pressing.

3) While pressing the o button,press MENU button on TV.

Color thickness correctionnote: Displayed differently as shown below, depending

on the setting of the receiving color system.COLP (PAL)COLC (NTSC)COLS (SECAM)

S

(Service mode display)

Item

Data

Adjustment mode

Press

Press

Service mode

Item

DataS

GE

NE

RA

L A

DJU

ST

ME

NT

S

– 9 –

4. SELECTING THE ADJUSTING ITEMS1) Every pressing of CH s button in the service mode changes the adjustment items in the order of table-2.

(t button for reverse order)

Refer to table-2 for preset data of adjustment mode.(See SETTING & ADJUSTING DATA on page 14)

5. ADJUSTING THE DATA1) Pressing of ; +/– button will change the value of data in the range from 00H to FFH. The variable range depends on

the adjusting item.

6. EXIT FROM SERVICE MODE1) Pressing POWER button to turn off the TV once.

R INITIALIZATION OF MEMORY DATA OF QA10After replacing QA10, the following initialization is required.

1. Enter the service mode, then select any register item.2. Press and hold the CALL button on the remote control, then press the CH s button on the TV. The initialization of QA10

has been completed.3. Check the picture carefully. If necessary, adjust any adjustment item above.

Perform “ASM function” on the owner’s manual.CAUTION: Never attempt to initialize the data unless QA10 has been replaced.

GE

NE

RA

L A

DJU

ST

ME

NT

S

– 10 –

7. SELF DIAGNOSTIC FUNCTION1) Press “9” button on the remote control during display of adjustment menu in the service mode.

The diagnosis will begin to check if interface among IC’s are executed properly.2) During diagnosis, the following displays are shown.

Indicated color of mode now selected : Green and RedIndicated color of other modes : White

Green : NormalRed : The microprocessor operates to provide judgement

of no video signal.

OTHERS : (1) In case that power indicator is blinking withinterval of 0.5 seconds; it means protectingcircuit (Current limiter) is operating, and circuitcomponents may possibly be damaged.Check related components.

(2) In case that power indicator is blinking withinterval of 1 second; Protecting circuit doesnot operate, but a part of Bus line does notoperate normally. Check Bus line.

1 Part number of microprocessor (QA51)2 Software type:

“ ECMVT A01” --------- Software for Asian models.“ ERFAP R01” --------- Software for Russian models.“ ERFAP P01” --------- Software for Middle East models.

3 Software version4 Memory IC data version5 Protection circuit operation count6 BLOCK

UV : TV reception mode

V1 : VIDEO 1 input mode (a1)



MICON : 23* * * * * *S/W : E* * * * * 01

V 1.00EEP : V00POWER : 000BLOCK : UV V1 V2 V3

<SELF CHECK>

123456

GE

NE

RA

L A

DJU

ST

ME

NT

S

– 11 –

DESIGN MODE

2) While pressing CALL button again and press MENU button on the TV.

3) Press MENU button on TV.

ITEM

DATAS D Press

(Design mode) (Adjustment mode)

Press

1. ENTERING TO DESIGN MODE1) When in Service mode (see page 8), press CALL button on the remote control once.

When QA10 is initialized, items “OPT” ,“OPT1” and “OPT2” of DESIGN MODE are set to the data of the representative modelof this chassis family.Therefore, because ON-SCREEN specification remains in the state of the representative of model. This model is required toreset the data of items “OPT” ,“OPT1” and “OPT2” according to current on-serviced model .

2. SELECTING THE ADJUSTING ITEMSEvery pressing of CH t button in the design mode changes the adjustment items in the order of table-3.(s button for reverse order)

Refer to table-3 for data of design mode.(See SETTING & ADJUSTING DATA on page 14)

3. ADJUSTING THE DATAPressing of ; -/+ buttons will change the value of data.

GE

NE

RA

L A

DJU

ST

ME

NT

S

– 12 –

ELECTRICAL ADJUSTMENTS

FOCUS VR ADJ

SUB-BRIGHTNESS(BRTC)

HORIZONTAL POSITIONADJUSTMENT (HPOS)

VERTICAL POSITIONADJUSTMENT (VPOS)

VERTICAL AMPLITUDE ADJUSTMENT (HIT)

1. Enter the service mode, then input AV1 black cross-bar pattern with signal generator.2. Adjust the FOCUS control (on T461) for well defined scanning lines on the picture

screen.

1. Input AV1 “5 steps pattern” with video signalgenerator.

2. Set CONTRAST to minimum andBRIGHTNESS to center by adjusting usercontrols.

3. Enter Service mode and press CH s/t toselect BRTC.

4. Press ; –/+ buttons to adjust BRTC untilstep 0 and step 1 has the same blackness.

5. Exit service mode and press h button to

set picture mode to DYNAMIC.

1. Enter the service mode, input AV1 blackor white cross-bar signal with signalgenerator.

2. Select either HPOS (Horizontal picturephase) or VPOS (Vertical picturephase) with CH s /t buttons, andadjust horizontal or vertical pictureposition in the center of screen with; –/+ buttons.

1. Enter the service mode, input AV1 blackor white cross-hatch signal with signalgenerator.

2. Select HIT (Vertical amplitude) withCH s/t buttons, and adjust verticalamplitude with ; –/+ buttons so thatvertical amplitude lacks a little.

3. Adjust vertical amplitude with ; –/+buttons so that the first bar on cross-hatch signal touches edge of screen.

The first

ITEM ADJUSTMENT PROCEDURE

GE

NE

RA

L A

DJU

ST

ME

NT

S

– 13 –

WHITE BALANCEADJUSTMENT

SCREEN VOLTAGE ADJUST-MENT (SCREEN VR) of FBT

• DRIVE ADJUSTMENT(GDRV)(BDRV)(RDRV)

• CUTOFF ADJUSTMENT(GCUT)(BCUT)

ITEM ADJUSTMENT PROCEDURE

1. Select AV1 (with no input).2. Enter Service mode and press “0” button.3. Adjust Screen VR until OSD “HBC” toggle

between 1 & 0.4. Press “0” button again to exit.5. Input AV1 “5 steps pattern” with video signal

generator.6. Press h button to set picture mode to

DYNAMIC.X To correct white balance in high light area

(steps 3 and 4) select GDRV, BDRV andRDRV with ; – /+buttons.

X To correct white balance in low light area(steps 1 and 2), select GCUT and BCUT.

CIRCUIT CHECK

HIGH VOLTAGE CHECKCAUTION: There is no HIGH VOLTAGE ADJUSTMENT on this chassis. Checking should be done following the steps below.1. Connect an accurate high voltage meter to the second anode of the picture tube.2. Turn on the receiver. Set the BRIGHTNESS and CONTRAST controls to minimum (zero beam current).3. High voltage must be measured below (B) kV.

Refer to table-1 for high voltage (B).(See SETTING & ADJUSTING DATA on page 14)

4. Vary the BRIGHTNESS control to both extremes to be sure the high voltage does not exceed the limit under any conditions.

SP

EC

IFIC

INF

OR

MA

TIO

NS

– 14 –

CHAPTER 2 SPECIFIC INFORMATIONSSETTING & ADJUSTING DATA

SAFETY INSTRUCTIONS

SERVICE MODE

ADJUSTING ITEMS AND DATAS IN THE SERVICE MODE:

Table-1

Table-2

29"

HIGH VOLTAGE AT MAX BEAM CURRENT: (A) 30.0 kV

MAX HIGH VOLTAGE: (B) 32.0 kV

AC VOLTAGE (C) 110-240 V

BCUT B CUTOFF (B/W) 20H ←GCUT G CUTOFF (B/W) 20H ←RDRV R DRIVE 20H ←GDRV G DRIVE 20H ←BDRV B DRIVE 20H ←BRTC SUB BRIGHT CENTER 24H ←COLC SUB COLOR CENTER NTSC 1EH ←TNTC SUB TINT CENTER 1EH ←COLP SUB COLOR CENTER PAL 1DH ←COLS SUB COLOR CENTER SECAM 1DH ←SCNT SUB CONTRAST TV 00H ←SBY SECAM B-Y BLACK OFFSET 01H ←VPOS 50Hz V-POSITION 1CH ←HIT HEIGHT 25H ←VLIN V-LINEARITY 24H ←HPOS H-POSITION 2BH ←WID EW WIDTH 31H ←PARA EW PARABOLA 17H ←TRAP EW TRAPEZIUM 26H ←TCNR EW UPPER PARABOLA 15H ←BCNR EW LOWER PARABOLA 15H ←HPLL HORIZONTAL PARALLELOGRAM 22H ←HBOW HORIZONTAL BOW 20H ←XCAL CRYSTAL CALIBRATION 30H ←RAGC AGC TAKE-OVER 12H ←CTR1 CONTROL 1 07H ←

Item Adjustment Reference Data Adjust Data

SP

EC

IFIC

INF

OR

MA

TIO

NS

– 15 –

NAMES AND FUNCTIONS OF CONTROLSModel 29CZ5DE is used in this manual for illustration purpose.

TV Front and Remote control

TV Remote Control1 f Power on/standby

2 o Sound Mute, pressagain or ; -/+ torestore the sound.

3 0~9 Number buttons

4 a Input source selection,Timer-ON positionsettingSwitch the activeteletext page of thedouble window mode

5 MENU Turn on menu display

6 CH s/t Channel up/down,Menu item selection

7 8 Sound menu

8 CALL/i On-screen on/off,Turn off the menu,Teletext initial/index

9 Teletext colored buttonsRed/Green/Yellow/Blue

! mI/II Stereo/bilingualselection

" Double-window on/off

# -/-- Digit selection

$ ; -/+ Volume down/up,Menu selection oritem adjust

% Picture menu

& TXT/TV Teletext/TV selection

( Teletext functions

y/X – Time display, To selecta page while viewing anormal picture

^ – To enlarge teletextdisplay size

? – To reveal concealedtext

v – To hold a wanted page

12

3

456

78

9

!"

#

$

%&(

ae fh cbgij d

Open the lid

a q Main power on/off

b Remote sensor

c q Power indicator (red)

r Timer-ON indicator(green)

d MENU Turn on menu display

e a Input source selection

f - ; + Volume down/up,Menu selection or itemadjust

g tcs Channel down/up,Menu item selection

h L Stereo headphones jack(Ø3.5mm) for privatelistening. The soundfrom the speakers willbe cut off automatically.

i AUDIO Audio input terminals

j VIDEO Video input terminal

SP

EC

IFIC

INF

OR

MA

TIO

NS

– 16 –

PROGRAMMING CHANNEL MEMORYModel 29CZ5DE is used in this manual for illustration purpose.

To use the SEARCH function

1 Press MENU and then ; -/+ to highlight

the “ TUNING” icon.

TUNINGMFTAFTASMSEARCHPOSITIONMEMORY

P001

ON

MENUSELECT / MENU –/+ BACK

2 Press CH s/t to select “SEARCH”. Press ; -/+ tostart searching. Pressing “–” searches for channels atlower frequencies while pressing “+” searches forchannels at higher frequencies. While searching,pressing the opposite direction button, + and -respectively, will cancel SEARCH function.

SEARCH VHF H P001

STOP


P001

ON

MENUSELECT / ADJUST –/+ BACK

Repeat this process until you can get the desiredchannel.

3 When the desired channel is shown, press CH t toselect “POSITION”. Press the ; -/+ buttonsrepeatedly until the position number to be preset isshown.


P002

OFF


4 Press CH s/t to select “MEMORY”, then press ; +to memorize the channel at the current position.

MFTAFTASMSEARCHPOSITIONMEMORY

P002

OFF


TUNING

5 When you program other channels, repeat steps 2 to4.

Preset the channels automatically(ASM function)Use remote control for this operation. The buttons on the TVwith similar name may also be use.

1 Select the starting position for channel to be preset.Press the Number buttons (-/--, 0~9) or CH s/t.

1

2 Set the correct broadcast system for your region. PressMENU and then ; -/+ to highlight the “ SET UP”icon.

SETUPLANGUAGECOLOR MODESOUND MODESKIPBLUE SCREENTEXT

ONFAST

AUTO

OFFB/G

ENGLISH


Confirm “COLOR MODE” is set to “AUTO” and“SOUND MODE” is set to proper system. If not, pressCH s/t to select “COLOR MODE” or “SOUND MODE”and press ; -/+ to set each proper system.

3 Press MENU and then ; -/+ to highlightthe “ TUNING” icon. Select “ASM”, then press ; +to start the search. When the TV screen returns to thestart position, the procedure is complete.

CH

CHTUNINGMFTAFTASMSEARCHPOSITIONMEMORY

P001

OFF


Presetting channel

• First, use the ASM (Automatic Search Memory) functionto preset all active channels in your area automatically.Then, arrange the preset channels with the SEARCH,SKIP and MFT (Manual Fine Tuning) functions so thatyou can tune into only desired channels.

• Use the SEARCH function if desired channels cannot bepreset with the ASM or if you would like to preset channelsto specific position numbers one by one.

SP

EC

IFIC

INF

OR

MA

TIO

NS

– 17 –

Auto fine tuning (AFT)

If the signal frequency is unstable due to environmentalconditions, use auto fine tuning.

1 Select the position number where the channel youwant to fine-tune with CH s/t or the digit selectionand number buttons (-/--, 0~9).

NoteWhen the position is set to “AFT OFF” status, the “R”mark appears to the left of the position number.

When the channel is set to “AFT ON” status,theposition number is displayed without the “R” mark.

2 Press MENU then ; -/+ to highlight the “ TUNING”icon.

3 Press CH s/t to select “AFT”. Press ; -/+ to selectthe “ON” indication.


P002

OFF


Notes• When you operate MFT, AFT is switched “OFF”

automatically. If you switch on AFT after fine tuning withMFT, MFT may be canceled.

• AFT may be set independently for each position.

Manual fine tuning (MFT)

The adjustments below are not necessary under normalconditions. However, under some reception conditions, finetuning may be necessary to improve the picture quality. Insuch cases, adjust the manual fine tuning (MFT).

1 Select the position number where the channel youwant to fine-tune with CH s/t or digit selection andnumber buttons (-/--, 0~9).

2 Press MENU and then ; -/+ to highlight the “TUNING” icon.

3 Press CH s/t to select “MFT”. Press ; -/+ to startfine tuning. Press ; -/+ repeatedly until the bestpossible picture and sound are obtained.

To skip a position number

After presetting the channels, you may skip unnecessaryposition numbers so that only the channels you want to watchare selected using CH s/t.

1 First, select the position number to be skipped withCH s/t or digit selection and number buttons (-/--,0~9).

2 Highlight the “ SET UP” icon and press CH s/t toselect “SKIP”.

SETUPLANGUAGECOLOR MODESOUND MODESKIPBLUE SCREENTEXT

ONFAST

AUTO

ONB/G

ENGLISH


3 Press the ; -/+ to set “SKIP” to “ON”. This completesthe setting for skipping the selected position number.

Notes• When “SKIP” is set to “ON” for the selected position number,

a “ * ” mark appears to the left of the position number.

The position number will then be skipped when you selectthe position with the CH s/t buttons.

• If you want to restore a skipped position number, select itusing the -/-- and 0~9 buttons then switch the “SKIP” settingto “OFF”.


P002

ON


SP

EC

IFIC

INF

OR

MA

TIO

NS

– 18 –

PROCEDURES TO SET HOTEL MODE

1. Set the Channel Programs which you want the Customer to watch.

1) Use ASM (see page 16) or SEARCH (see page 16) to select the programs.

2) Choose the position you want the programs to be stored in TUNING menu.

3) Save the programs by MEMORY operation in TUNING menu (see page 16).

2. Set the Channels which you don’t want the Customer to access

1) Select the channel by pressing the number buttons or CH s/t buttons.

2) Set the SKIP from OFF to ON (see page 17).

3) Repeat above 1) & 2) for all the channels which need to be blocked.

3. Activate the HOTEL Mode:

1) Select startup channel (TV, video input 1, 2/DVD, or 3) first, then enter into design mode (see page 11).

2) In Design Mode (see page 11), press CH t button on the remote controller to show the Design Item “OPT1”.

3) Add “0x80” to the data of “OPT1” to activate the HOTEL Mode with panel buttons unlocked, or add “0xC0” to thedata of “OPT1” to activate the HOTEL Mode with panel buttons locked.

4) Turn off the TV once and turn it on again, the TV will be in HOTEL Mode with all the customer settings taking effect.

4. Set the maximum volume:

1) Enter Service Mode (see page 8).

2) Enter Design Mode (see page 11).

3) Use the CH t button on the remote controller to show the Design Item “VOLX”.

4) Adjust the “VOLX” data by pressing ;+/- buttons (Default 0x1E is equal to Volume 30 in Decimal).

5. Set the following items in HOTEL Mode:

1) Picture modePress h button to select the desired picture quality. “DYNAMIC”, “STANDARD”, “MILD” and “MEMORY” will appear

cyclically.

2) Sound mode

Press 8 button to select the desired sound quality. “THEATER”, “NEWS” and “MEMORY” will appear cyclically.

(Every time turning on the TV will call back the above customer setting.)

– 19 –

SP

EC

IFIC

INF

OR

MA

TIO

NS

CHASSIS AND CABINET REPLACEMENT PARTS LISTWARNING: BEFORE SERVICING THIS CHASSIS, READ THE “X-RAY RADIATION PRECAUTION”, “SAFETY PRE-CAUTION” AND “PRODUCT SAFETY NOTICE” ON PAGE 3 OF THIS MANUAL.

CAUTION: The international hazard symbols “ ” in the schematic diagram and the parts list designate componentswhich have special characteristics important for safety and should be replaced only with types identical to those in theoriginal circuit or specified in the parts list. The mounting position of replacements is to be identical with originals.Before replacing any of these components, read carefully the PRODUCT SAFETY NOTICE. Do not degrade the safetyof the receiver through improper servicing.

NOTICE:• The part number must be used when ordering parts, in order to assist in processing, be sure to include the Model number and Description.• The PC board assembly with * mark is no longer available after the end of the production.

Model: 29CZ5DE/29CZ5T/29CZ6SI

Capacitors .......... CD : Ceramic Disk PF : Plastic Film EL : ElectrolyticResistors ............ CF : Carbon Film CC : Carbon Composition MF : Metal Film OMF : Oxide Metal Film VR : Variable Resistor FR : Fusible Resistor(All CD and PF capacitors are ±5%, 50V and all resistors, ±5%, 1/6W unless otherwise noted.)

Location Parts No. DescriptionNo.


[#1: 29CZ5DE][#2: 29CZ5T][#3: 29CZ6SI]

CAPACITORSC101 76797479 ELECTROLYTIC 50V 4.7UF MC102 76109103 CERAMIC CHIP 50V B 0.01UF KC103 76109103 CERAMIC CHIP 50V B 0.01UF KC104 #1 76109103 CERAMIC CHIP 50V B 0.01UF K

#3 76109103 CERAMIC CHIP 50V B 0.01UF KC105 76109103 CERAMIC CHIP 50V B 0.01UF KC106 76109103 CERAMIC CHIP 50V B 0.01UF KC107 76109102 CERAMIC CHIP 50V B 1000PF KC108 76797100 ELECTROLYTIC 50V 10UF MC109 76797221 ELECTROLYTIC 50V 220UF MC110 76797221 ELECTROLYTIC 50V 220UF MC114 76109103 CERAMIC CHIP 50V B 0.01UF KC116 76109103 CERAMIC CHIP 50V B 0.01UF KC121 76797100 ELECTROLYTIC 50V 10UF MC122 76100104 CERAMIC CHIP 25V F 0.1UF ZC123 76109332 CERAMIC CHIP 50V B 3300PF KC124 76100104 CERAMIC CHIP 25V F 0.1UF ZC125 76797229 ELECTROLYTIC 50V 2.2UF MC127 76797229 ELECTROLYTIC 50V 2.2UF MC128 76100104 CERAMIC CHIP 25V F 0.1UF ZC129 76793471 ELECTROLYTIC 10V 470UF MC131 76109103 CERAMIC CHIP 50V B 0.01UF KC140 #2 76000445 CHIP JUMPER 1608TYPEC141 #2 76109103 CERAMIC CHIP 50V B 0.01UF KC142 #2 76109103 CERAMIC CHIP 50V B 0.01UF KC144 #2 76797100 ELECTROLYTIC 50V 10UF MC145 #2 76100104 CERAMIC CHIP 25V F 0.1UF ZC156 76105120 CERAMIC CHIP 50V CH 12PF JC157 76105510 CERAMIC CHIP 50V CH 51PF JC158 76797100 ELECTROLYTIC 50V 10UF MC159 76100104 CERAMIC CHIP 25V F 0.1UF ZC201 76109682 CERAMIC CHIP 50V B 6800PF KC202 76125006 E. CAP 25V 1.5UF REA1R5K1EFC-0511C203 76503045 PLASTIC FILM 63V 0.22UF JC204 76795100 ELECTROLYTIC 25V 10UF MC205 76109223 CERAMIC CHIP 25V B 0.022UF KC206 76100104 CERAMIC CHIP 25V F 0.1UF ZC211 76100104 CERAMIC CHIP 25V F 0.1UF ZC212 76206010 ELECTROLYTIC 50V 1.0UF M 7L 3AC219 76092729 CERAMIC CHIP 16V B 0.068UF KC220 76503047 PLASTIC FILM 63V 0.33UF JC303 76214471 CERAMIC DISC 500V B 470PF KC308 76669221 ELECTROLYTIC 50V 220UF M

C309 76667102 ELECTROLYTIC 25V 1000UF MC310 76667222 ELECTROLYTIC 25V 2200UF M 3AC313 76082061 PLASTIC FILM 100V 0.47UF JC315 76109102 CERAMIC CHIP 50V B 1000PF KC321 76109272 CERAMIC CHIP 50V B 2700PF KC322 76214471 CERAMIC DISC 500V B 470PF KC327 76100102 CERAMIC CHIP 50V F 1000PF ZC328 76693104 PLASTIC FILM 100V 0.1UF JC329 76100102 CERAMIC CHIP 50V F 1000PF ZC331 76109472 CERAMIC CHIP 50V B 4700PF KC333 76667222 ELECTROLYTIC 25V 2200UF M 3AC335 76667221 ELECTROLYTIC 25V 220UF MC336 76109272 CERAMIC CHIP 50V B 2700PF KC350 76503043 PLA CAP PCMT36676154C363 76693104 PLASTIC FILM 100V 0.1UF JC401 76105151 CERAMIC CHIP 50V CH 150PF JC402 76693472 PLASTIC FILM 100V 4700PF JC413 76214821 CERAMIC DISC 500V B 820PF KC416 76678479 ELECTROLYTIC 200V 4.7UF MC417 76214391 CERAMIC DISC 500V B 390PF KC430 76092731 CERAMIC CHIP 16V B 1UF KC432 76100102 CERAMIC CHIP 50V F 1000PF ZC435 76794220 ELECTROLYTIC 16V 22UF MC439 76503125 PLASTIC FILM 400V 0.075UF JC442 76503298 PLASTIC FILM 315V 0.3UF JC443 76503194 PLASTIC FILM 1500VH 0.01UF HC444 76503228 PLASTIC FILM 1500VH 6800PF HC447 76679220 ELECTROLYTIC 250V 22UF M 3AC448 76640908 ELECTROLYTIC 160V 33UF M 3A LIC449 76667102 ELECTROLYTIC 25V 1000UF MC463 76212222 CERAMIC DISC 50V B 2200PF KC464 76073124 ELECTROLYTIC 100V 10UF MC467 76503159 PLASTIC FILM 630V 0.039UF JC470 76766101 ELECTROLYTIC 50V 100UF MC4700 76109332 CERAMIC CHIP 50V B 3300PF KC4703 76764221 ELECTROLYTIC 25V 220UF MC4712 76109332 CERAMIC CHIP 50V B 3300PF KC4717 76000445 CHIP JUMPER 1608TYPEC472 76503049 PLASTIC FILM 63V 0.47UF JC475 76100103 CERAMIC CHIP 50V F 0.01UF ZC501 76793471 ELECTROLYTIC 10V 470UF MC502 76092730 CERAMIC CHIP 16V B 0.1UF KC503 76203100 ELECTORLYTIC 16V 10UF M 7L 3AC504 76100104 CERAMIC CHIP 25V F 0.1UF ZC505 76793471 ELECTROLYTIC 10V 470UF MC506 76100104 CERAMIC CHIP 25V F 0.1UF ZC507 76793471 ELECTROLYTIC 10V 470UF MC508 76100104 CERAMIC CHIP 25V F 0.1UF Z

– 20 –

SP

EC

IFIC

INF

OR

MA

TIO

NS



C509 76109561 CERAMIC CHIP 50V B 560PF KC510 76105220 CERAMIC CHIP 50V CH 22PF JC511 76105220 CERAMIC CHIP 50V CH 22PF JC512 76105220 CERAMIC CHIP 50V CH 22PF JC660 76206010 ELECTROLYTIC 50V 1.0UF M 7L 3AC662 76109102 CERAMIC CHIP 50V B 1000PF KC663 76797229 ELECTROLYTIC 50V 2.2UF MC664 76206010 ELECTROLYTIC 50V 1.0UF M 7L 3AC666 76109102 CERAMIC CHIP 50V B 1000PF KC667 76797229 ELECTROLYTIC 50V 2.2UF MC671 76763471 ELECTROLYTIC 16V 470UF MC672 76203470 ELECTROLYTIC 16V 47UF M 7L 3AC681 76765102 ELECTROLYTIC 35V 1000UF MC682 76765102 ELECTROLYTIC 35V 1000UF MC683 76765102 ELECTROLYTIC 35V 1000UF MC684 76203470 ELECTROLYTIC 16V 47UF M 7L 3AC686 76092883 CERAMIC CHIP 50V B 0.1UF KC687 76092883 CERAMIC CHIP 50V B 0.1UF KC690 76766101 ELECTROLYTIC 50V 100UF MC704 76591822 PLASTIC FILM 50V 8200PF JC705 76232103 CERAMIC DISC 50V F 0.01UF ZC707 76795470 ELECTROLYTIC 25V 47UF MC712 76795470 ELECTROLYTIC 25V 47UF MC713 76709100 ELECTROLYTIC 200V 10UF MC714 76436101 CERAMIC DISC 50V SL 100PF JC715 76214472 CERAMIC DISC 500V B 4700PF KC716 76436101 CERAMIC DISC 50V SL 100PF JC717 76214472 CERAMIC DISC 500V B 4700PF KC718 76794470 ELECTROLYTIC 16V 47UF MC719 76435560 CERAMIC DISC 500V SL 56PF JC720 76709100 ELECTROLYTIC 200V 10UF MC721 76794470 ELECTROLYTIC 16V 47UF MC722 76436561 CERAMIC DISC 50V SL 560PF JC726 76212102 CERAMIC DISC 50V B 1000PF K

z C801 76503507 PLASTIC FILM AC275V 0.22UF Kz C802 76503507 PLASTIC FILM AC275V 0.22UF K

C805 76092281 CERAMIC DISC AC250V E 4700PFC806 76092281 CERAMIC DISC AC250V E 4700PFC808 76794222 ELECTROLYTIC 16V 2200UF MC809 76797479 ELECTROLYTIC 50V 4.7UF MC810 76086857 ELECTROLYTIC 400V 560UF

z C811 76166021 CERA CAP E 250V 102 DE1E3KX102MB4BL01z C812 76166021 CERA CAP E 250V 102 DE1E3KX102MB4BL01z C813 76166021 CERA CAP E 250V 102 DE1E3KX102MB4BL01z C814 76166021 CERA CAP E 250V 102 DE1E3KX102MB4BL01z C815 76166021 CERA CAP E 250V 102 DE1E3KX102MB4BL01

C817 76092347 CERAMIC DISC 2KV R 1500PF KC818 76105471 CERAMIC CHIP 50V CH 470PF JC820 76591473 PLASTIC FILM 50V 0.047UF JC821 76797470 ELECTROLYTIC 50V 47UF MC823 76105221 CERAMIC CHIP 50V CH 220PF JC824 76109182 CERAMIC CHIP 50V B 1800PF KC830 76212103 CERAMIC DISC 50V B 0.01UF KC831 76794101 ELECTROLYTIC 16V 100UF MC832 76794101 ELECTROLYTIC 16V 100UF MC833 76212103 CERAMIC DISC 50V B 0.01UF KC834 76794101 ELECTROLYTIC 16V 100UF MC836 76794102 ELECTROLYTIC 16V 1000UF MC837 76794101 ELECTROLYTIC 16V 100UF MC838 76503047 PLASTIC FILM 63V 0.33UF JC839 76503047 PLASTIC FILM 63V 0.33UF JC841 76503047 PLASTIC FILM 63V 0.33UF JC842 76503047 PLASTIC FILM 63V 0.33UF JC843 76794101 ELECTROLYTIC 16V 100UF MC848 76212103 CERAMIC DISC 50V B 0.01UF KC849 76794101 ELECTROLYTIC 16V 100UF MC884 76086052 ELECTROLYTIC 200V 220UF M 22AC885 76214471 CERAMIC DISC 500V B 470PF KC888 76105471 CERAMIC CHIP 50V CH 470PF JC889 76796222 ELECTROLYTIC 35V 2200UF MC890 76796222 ELECTROLYTIC 35V 2200UF MC891 76763471 ELECTROLYTIC 16V 470UF MC892 76214471 CERAMIC DISC 500V B 470PF KC893 76092337 CERAMIC DISC 2KV 220PF KC894 76214471 CERAMIC DISC 500V B 470PF KC895 76796332 ELECTROLYTIC 35V 3300UF MC896 76668331 ELECTROLYTIC 35V 330UF M 3AC897 76214471 CERAMIC DISC 500V B 470PF KC898 76503045 PLASTIC FILM 63V 0.22UF J

C899 76214471 CERAMIC DISC 500V B 470PF KC901 76214103 CERAMIC DISC 500V B 0.01UF KC902 76092353 CERAMIC DISC 2KV 4700PF KC903 76168053 PLASTIC FILM 540)400V 134J 4-20C904 76679100 ELECTROLYTIC 250V 10UF M 3AC909 76679100 ELECTROLYTIC 250V 10UF M 3AC910 76206478 ELECTROLYTIC 50V 0.47UF M 7L 3AC911 76206478 ELECTROLYTIC 50V 0.47UF M 7L 3AC912 76763471 ELECTROLYTIC 16V 470UF MC931 76214101 CERAMIC DISC 500V B 100PF KCA01 76203100 ELECTORLYTIC 16V 10UF M 7L 3ACA03 76092734 CERAMIC CHIP 16V F 0.22UF ZCA04 76092734 CERAMIC CHIP 16V F 0.22UF ZCA05 76092730 CERAMIC CHIP 16V B 0.1UF KCA06 76793101 ELECTROLYTIC 10V 100UF MCA101 76092734 CERAMIC CHIP 16V F 0.22UF ZCA108 76105680 CERAMIC CHIP 50V CH 68PF JCA109 76105680 CERAMIC CHIP 50V CH 68PF JCA110 76092734 CERAMIC CHIP 16V F 0.22UF ZCA112 76795100 ELECTROLYTIC 25V 10UF MCA116 76092734 CERAMIC CHIP 16V F 0.22UF ZCA117 76797221 ELECTROLYTIC 50V 220UF MCA118 76092730 CERAMIC CHIP 16V B 0.1UF KCA119 76797229 ELECTROLYTIC 50V 2.2UF MCA120 76100103 CERAMIC CHIP 50V F 0.01UF ZCA124 76092734 CERAMIC CHIP 16V F 0.22UF ZCA14 76795100 ELECTROLYTIC 25V 10UF MCA30 76100104 CERAMIC CHIP 25V F 0.1UF ZCA31 76100104 CERAMIC CHIP 25V F 0.1UF ZCA88 76092734 CERAMIC CHIP 16V F 0.22UF ZCA89 76793101 ELECTROLYTIC 10V 100UF MCA90 76092734 CERAMIC CHIP 16V F 0.22UF ZCA91 76092730 CERAMIC CHIP 16V B 0.1UF KCA92 76793101 ELECTROLYTIC 10V 100UF MCA93 76092734 CERAMIC CHIP 16V F 0.22UF ZCA94 76793101 ELECTROLYTIC 10V 100UF MCA95 76092730 CERAMIC CHIP 16V B 0.1UF KCA96 76092734 CERAMIC CHIP 16V F 0.22UF ZCA97 76100103 CERAMIC CHIP 50V F 0.01UF ZCA98 76105680 CERAMIC CHIP 50V CH 68PF JCA99 76105680 CERAMIC CHIP 50V CH 68PF JCB07 76203100 ELECTORLYTIC 16V 10UF M 7L 3ACB21 76794470 ELECTROLYTIC 16V 47UF MCC01 76109103 CERAMIC CHIP 50V B 0.01UF KCC02 76109102 CERAMIC CHIP 50V B 1000PF KCC03 76109102 CERAMIC CHIP 50V B 1000PF KCC04 76109102 CERAMIC CHIP 50V B 1000PF KCC05 76109102 CERAMIC CHIP 50V B 1000PF KCC06 76109102 CERAMIC CHIP 50V B 1000PF KCC14 76109103 CERAMIC CHIP 50V B 0.01UF KCC17 76212102 CERAMIC DISC 50V B 1000PF KCC18 76212102 CERAMIC DISC 50V B 1000PF KCC20 #1 76105150 CERAMIC CHIP 50V CH 15PF JCS01 76203100 ELECTORLYTIC 16V 10UF M 7L 3ACS02 76203100 ELECTORLYTIC 16V 10UF M 7L 3ACS03 76794220 ELECTROLYTIC 16V 22UF MCS04 76100103 CERAMIC CHIP 50V F 0.01UF ZCS05 76206478 ELECTROLYTIC 50V 0.47UF M 7L 3ACS06 76206478 ELECTROLYTIC 50V 0.47UF M 7L 3ACS07 76206478 ELECTROLYTIC 50V 0.47UF M 7L 3ACS08 76206478 ELECTROLYTIC 50V 0.47UF M 7L 3ACS09 76206478 ELECTROLYTIC 50V 0.47UF M 7L 3ACS10 76206478 ELECTROLYTIC 50V 0.47UF M 7L 3ACS11 76206478 ELECTROLYTIC 50V 0.47UF M 7L 3ACS12 76105470 CERAMIC CHIP 50V CH 47PF JCS13 76105470 CERAMIC CHIP 50V CH 47PF JCS14 76105470 CERAMIC CHIP 50V CH 47PF JCS15 76105470 CERAMIC CHIP 50V CH 47PF JCS16 76105470 CERAMIC CHIP 50V CH 47PF JCS17 76105470 CERAMIC CHIP 50V CH 47PF JCS18 76105470 CERAMIC CHIP 50V CH 47PF JCS19 76105470 CERAMIC CHIP 50V CH 47PF JCS20 76105470 CERAMIC CHIP 50V CH 47PF JCS21 76105470 CERAMIC CHIP 50V CH 47PF JCS22 76105470 CERAMIC CHIP 50V CH 47PF JCS23 76105470 CERAMIC CHIP 50V CH 47PF JCV06 76762471 ELECTROLYTIC 10V 470UF MCV08 76795470 ELECTROLYTIC 25V 47UF MCV09 76100104 CERAMIC CHIP 25V F 0.1UF Z

– 21 –

SP

EC

IFIC

INF

OR

MA

TIO

NS



CV10 76100104 CERAMIC CHIP 25V F 0.1UF ZCV11 76100104 CERAMIC CHIP 25V F 0.1UF ZCV12 76100103 CERAMIC CHIP 50V F 0.01UF ZCV13 76100104 CERAMIC CHIP 25V F 0.1UF ZCV14 76100104 CERAMIC CHIP 25V F 0.1UF ZCV15 76100104 CERAMIC CHIP 25V F 0.1UF ZCV16 76105101 CERAMIC CHIP 50V CH 100PF JCV17 76105101 CERAMIC CHIP 50V CH 100PF JCV18 76105101 CERAMIC CHIP 50V CH 100PF JCV19 76105101 CERAMIC CHIP 50V CH 100PF JCV20 76105101 CERAMIC CHIP 50V CH 100PF JCV21 76109102 CERAMIC CHIP 50V B 1000PF KCV22 76109102 CERAMIC CHIP 50V B 1000PF KCV25 76212101 CERAMIC DISC 50V B 100PF KZ154 23303166 CERAMIC TRAP 39.5MHZ TCF1107Z155 23303224 CERAMIC TRAP TCF1120AM

RESISTORSG714 76545220 FUSIBLE 1/4W 22 OHM JGJ01 76011472 CHIP 1/20W 4.7K OHM JGJ02 76011472 CHIP 1/20W 4.7K OHM JGJ03 76000445 CHIP JUMPER 1608TYPEGJ05 76000445 CHIP JUMPER 1608TYPEGJ401 76000445 CHIP JUMPER 1608TYPEGJ808 76000445 CHIP JUMPER 1608TYPEGJ811 76000445 CHIP JUMPER 1608TYPEGR001 76000445 CHIP JUMPER 1608TYPEGR828 76366221 CARBON FILM 1/6W 220 OHM JJR001 76000445 CHIP JUMPER 1608TYPEJR002 76000445 CHIP JUMPER 1608TYPEJR003 76000445 CHIP JUMPER 1608TYPEJR004 76000445 CHIP JUMPER 1608TYPEJR005 76000445 CHIP JUMPER 1608TYPEJR006 76000445 CHIP JUMPER 1608TYPEJR007 76000445 CHIP JUMPER 1608TYPEJR008 76000445 CHIP JUMPER 1608TYPEJR009 76000445 CHIP JUMPER 1608TYPEJR010 76000445 CHIP JUMPER 1608TYPEJR011 76000445 CHIP JUMPER 1608TYPEJR013 76000445 CHIP JUMPER 1608TYPEJR014 76000445 CHIP JUMPER 1608TYPEJR016 76000445 CHIP JUMPER 1608TYPEJR017 76000445 CHIP JUMPER 1608TYPEJR018 76000445 CHIP JUMPER 1608TYPEJR019 76000445 CHIP JUMPER 1608TYPELC04 76366101 CARBON FILM 1/6W 100 OHM JLC05 76366101 CARBON FILM 1/6W 100 OHM JLC06 76000445 CHIP JUMPER 1608TYPELC07 76000445 CHIP JUMPER 1608TYPELC08 76000445 CHIP JUMPER 1608TYPELC09 76000445 CHIP JUMPER 1608TYPELC10 76000445 CHIP JUMPER 1608TYPELC11 76000445 CHIP JUMPER 1608TYPELC12 76000445 CHIP JUMPER 1608TYPELC13 76000445 CHIP JUMPER 1608TYPELC14 76000445 CHIP JUMPER 1608TYPELC15 76000445 CHIP JUMPER 1608TYPELC16 76000445 CHIP JUMPER 1608TYPELC17 76000445 CHIP JUMPER 1608TYPER101 76011330 CHIP 1/20W 33 OHM JR102 76011682 CHIP 1/20W 6.8K OHM JR103 76011272 CHIP 1/20W 2.7K OHM JR104 76011330 CHIP 1/20W 33 OHM JR105 76011751 CHIP 1/20W 750 OHM JR106 76011330 CHIP 1/20W 33 OHM JR107 76366390 CARBON FILM 1/6W 39 OHM JR108 76011821 CHIP 1/20W 820 OHM JR109 76011102 CHIP 1/20W 1K OHM JR110 #1 76366103 CARBON FILM 1/6W 10K OHM J

#3 76366103 CARBON FILM 1/6W 10K OHM JR111 #1 76011302 CHIP 1/20W 3K OHM J

#3 76011302 CHIP 1/20W 3K OHM JR112 #1 76011103 CHIP 1/20W 10K OHM J

#3 76011103 CHIP 1/20W 10K OHM JR113 #1 76011332 CHIP 1/20W 3.3K OHM J

#3 76011332 CHIP 1/20W 3.3K OHM JR115 76011102 CHIP 1/20W 1K OHM JR116 76011101 CHIP 1/20W 100 OHM JR117 #1 76366153 CARBON FILM 1/6W 15K OHM J

R117 #3 76366153 CARBON FILM 1/6W 15K OHM JR118 #1 76011101 CHIP 1/20W 100 OHM J

#3 76011101 CHIP 1/20W 100 OHM JR119 76000445 CHIP JUMPER 1608TYPER121 76011471 CHIP 1/20W 470 OHM JR122 76011391 CHIP 1/20W 390 OHM JR124 76011123 CHIP 1/20W 12K OHM JR125 76011563 CHIP 1/20W 56K OHM JR126 76011681 CHIP 1/20W 680 OHM JR140 #2 76011101 CHIP 1/20W 100 OHM JR141 #2 76011222 CHIP 1/20W 2.2K OHM JR142 #2 76011221 CHIP 1/20W 220 OHM JR152 76011331 CHIP 1/20W 330 OHM JR156 76553153 OXIDE METAL FILM 1W 15K OHM JR201 76011123 CHIP 1/20W 12K OHM JR215 76366203 CARBON FILM 1/6W 20K OHM JR216 76366103 CARBON FILM 1/6W 10K OHM JR217 76366203 CARBON FILM 1/6W 20K OHM JR218 76366332 CARBON FILM 1/6W 3.3K OHM JR219 76011224 CHIP 1/20W 220K OHM JR227 76366272 CARBON FILM 1/6W 2.7K OHM JR228 76011103 CHIP 1/20W 10K OHM JR303 76170001 0XIDE R 109J RS1BSJHD109R305 76322159 OXIDE METAL FILM 1W 1.5 OHM JR314 76011473 CHIP 1/20W 47K OHM JR318 76011102 CHIP 1/20W 1K OHM JR320 76011101 CHIP 1/20W 100 OHM JR321 76011103 CHIP 1/20W 10K OHM JR322 76182030 METAL R ERX1FJ4R7HR324 76011472 CHIP 1/20W 4.7K OHM JR325 76011101 CHIP 1/20W 100 OHM JR327 76182030 METAL R ERX1FJ4R7HR328 76011682 CHIP 1/20W 6.8K OHM JR329 76011682 CHIP 1/20W 6.8K OHM JR331 76366562 CARBON FILM 1/6W 5.6K OHM JR336 76383221 OXIDE METAL FILM 2W 220 OHM JR346 76000445 CHIP JUMPER 1608TYPER347 76011103 CHIP 1/20W 10K OHM JR348 76011562 CHIP 1/20W 5.6K OHM JR350 76367393 CARBON FILM 1/6W 39K OHM JR354 76011223 CHIP 1/20W 22K OHM JR363 76552181 OXIDE METAL FILM 1/2W 180 OHM JR401 76011105 CHIP 1/20W 1M OHM JR403 76382472 OXIDE METAL FILM 1W 4.7K OHM JR409 76011123 CHIP 1/20W 12K OHM JR412 76011472 CHIP 1/20W 4.7K OHM JR413 76000445 CHIP JUMPER 1608TYPER415 76553272 OXIDE METAL FILM 1W 2.7K OHM JR416 76019332 OXIDE METAL FILM 5W 4.3K OHM JR419 76011183 CHIP 1/20W 18K OHM JR420 76011102 CHIP 1/20W 1K OHM JR4200 76011101 CHIP 1/20W 100 OHM JR424 76011103 CHIP 1/20W 10K OHM JR425 76011103 CHIP 1/20W 10K OHM JR426 76011101 CHIP 1/20W 100 OHM JR429 76552560 OXIDE METAL FILM 1/2W 56 OHM JR431 76011101 CHIP 1/20W 100 OHM JR435 76011562 CHIP 1/20W 5.6K OHM JR437 76000445 CHIP JUMPER 1608TYPER438 76366823 CARBON FILM 1/6W 82K OHM JR439 76366222 CARBON FILM 1/6W 2.2K OHM JR440 76011471 CHIP 1/20W 470 OHM JR441 76532102 FUSIBLE 1W 1K OHM JR448 76182049 METAL OXIDE 9.1 OHM ERX1FJ9R1HR462 76322229 OXIDE METAL FILM 1W 2.2 OHM JR470 76182018 METAL R ERX1FJR47HR4704 76011104 CHIP 1/20W 100K OHM JR471 76381131 OXIDE METAL FILM 1/2W 130 OHM JR4716 76011393 CHIP 1/20W 39K OHM JR4717 76011824 CHIP 1/20W 820K OHM JR4718 76011273 CHIP 1/20W 27K OHM JR473 76000247 METAL FILM 1/4W 39K OHM FR4760 76000242 METAL FILM 1/4W 18K OHM FR4770 76011102 CHIP 1/20W 1K OHM JR479 76381271 OXIDE METAL FILM 1/2W 270 OHM JR501 76011103 CHIP 1/20W 10K OHM JR502 76011102 CHIP 1/20W 1K OHM JR503 76011101 CHIP 1/20W 100 OHM JR504 76011101 CHIP 1/20W 100 OHM J

– 22 –

SP

EC

IFIC

INF

OR

MA

TIO

NS



R505 76011101 CHIP 1/20W 100 OHM JR620 76011103 CHIP 1/20W 10K OHM JR621 76366103 CARBON FILM 1/6W 10K OHM JR660 76011223 CHIP 1/20W 22K OHM JR662 76011222 CHIP 1/20W 2.2K OHM JR664 76011223 CHIP 1/20W 22K OHM JR666 76011222 CHIP 1/20W 2.2K OHM JR671 76011103 CHIP 1/20W 10K OHM JR672 76011103 CHIP 1/20W 10K OHM JR673 76011103 CHIP 1/20W 10K OHM JR674 76011103 CHIP 1/20W 10K OHM JR675 76011104 CHIP 1/20W 100K OHM JR686 76011229 CHIP 1/16W 2.2 OHM JR687 76011229 CHIP 1/16W 2.2 OHM JR701 76011101 CHIP 1/20W 100 OHM JR702 76366821 CARBON FILM 1/6W 820 OHM J (U901)

76011102 CHIP 1/20W 1K OHM J (U902)R704 76011470 CHIP 1/20W 47 OHM JR705 76011221 CHIP 1/20W 220 OHM JR709 76366563 CARBON FILM 1/6W 56K OHM JR713 76366393 CARBON FILM 1/6W 39K OHM JR715 76366223 CARBON FILM 1/6W 22K OHM JR716 76366273 CARBON FILM 1/6W 27K OHM JR717 76366333 CARBON FILM 1/6W 33K OHM JR719 76366392 CARBON FILM 1/6W 3.9K OHM JR720 76366392 CARBON FILM 1/6W 3.9K OHM JR721 76366102 CARBON FILM 1/6W 1K OHM JR722 76552471 OXIDE METAL FILM 1/2W 470 OHM JR723 76366471 CARBON FILM 1/6W 470 OHM JR724 76366470 CARBON FILM 1/6W 47 OHM JR725 76366182 CARBON FILM 1/6W 1.8K OHM JR730 76552100 OXIDE METAL FILM 1/2W 10 OHM JR731 76552331 OXIDE METAL FILM 1/2W 330 OHM JR732 76366820 CARBON FILM 1/6W 82 OHM JR733 76366683 CARBON FILM 1/6W 68K OHM JR734 76366820 CARBON FILM 1/6W 82 OHM JR735 76366683 CARBON FILM 1/6W 68K OHM JR736 76366620 CARBON FILM 1/6W 62 OHM JR737 76366152 CARBON FILM 1/6W 1.5K OHM JR738 76366102 CARBON FILM 1/6W 1K OHM JR739 76366152 CARBON FILM 1/6W 1.5K OHM JR740 76366620 CARBON FILM 1/6W 62 OHM JR741 76366279 CARBON FILM 1/6W 2.7 OHM JR742 76366279 CARBON FILM 1/6W 2.7 OHM JR743 76554221 OXIDE METAL FILM 2W 220 OHM JR744 76366122 CARBON FILM 1/6W 1.2K OHM JR745 76366122 CARBON FILM 1/6W 1.2K OHM JR760 76366101 CARBON FILM 1/6W 100 OHM JR775 76366182 CARBON FILM 1/6W 1.8K OHM J

z R801 76017010 METAL GLAZE 1/2W PRC92M02M20JR805 76366221 CARBON FILM 1/6W 220 OHM J

z R808 76079005 THERMISTOR PTC DGC3D4R5M27R811 76366225 CARBON FILM 1/6W 2.2M OHM JR812 76510479 CERAMIC COVERED 5W 4.7 OHM JR813 76120004 CEMENT RES FUSIBLE SQMT-3W-1R8KR817 76366124 CARBON FILM 1/6W 120K OHM JR818 76366229 CARBON FILM 1/6W 2.2 OHM JR820 76366224 CARBON FILM 1/6W 220K OHM JR825 76366474 CARBON FILM 1/6W 470K OHM JR826 76366564 CARBON FILM 1/6W 560K OHM JR829 76182014 METAL R ERX1FJR22HR830 76019459 METAL PLATE 2W 0.12 OHM JR831 76366152 CARBON FILM 1/6W 1.5K OHM JR832 76366183 CARBON FILM 1/6W 18K OHM JR833 76011223 CHIP 1/20W 22K OHM JR834 76366222 CARBON FILM 1/6W 2.2K OHM JR837 76011102 CHIP 1/20W 1K OHM JR838 76366392 CARBON FILM 1/6W 3.9K OHM JR839 76366222 CARBON FILM 1/6W 2.2K OHM JR840 76011472 CHIP 1/20W 4.7K OHM JR841 76011152 CHIP 1/20W 1.5K OHM JR842 76011472 CHIP 1/20W 4.7K OHM JR843 76000445 CHIP JUMPER 1608TYPER846 76011154 CHIP 1/20W 150K OHM JR847 76000445 CHIP JUMPER 1608TYPER848 76011101 CHIP 1/20W 100 OHM JR898 76321228 OXIDE METAL FILM 1/2W 0.22 OHM J

z R899 76017012 METAL GLAZE 1/2W PRC92M08M20JR901 76376222 CARBON FILM 1/2W 2R2K J

R902 76376222 CARBON FILM 1/2W 2R2K JR903 76376222 CARBON FILM 1/2W 2R2K JR904 76376101 CARBON FILM RD50JJHBA101R905 76376101 CARBON FILM RD50JJHBA101R906 76376101 CARBON FILM RD50JJHBA101R907 76383101 OXIDE METAL FILM 2W 100 OHM JR911 76366101 CARBON FILM 1/6W 100 OHM JR912 76366101 CARBON FILM 1/6W 100 OHM JR913 76366101 CARBON FILM 1/6W 100 OHM JR920 76000568 FUSIBLE 1W 4.7 OHM JR936 76545150 FUSIBLE 1/4W 15 OHM JR937 76366181 CARBON FILM 1/6W 180 OHM JR938 76366563 CARBON FILM 1/6W 56K OHM JR939 76366102 CARBON FILM 1/6W 1K OHM JR992 76366150 CARBON FILM 1/6W 15 OHM JRA105 76011101 CHIP 1/20W 100 OHM JRA106 76011101 CHIP 1/20W 100 OHM JRA108 76011332 CHIP 1/20W 3.3K OHM JRA109 76011332 CHIP 1/20W 3.3K OHM JRA14 76366100 CARBON FILM 1/6W 10 OHM JRA15 76366100 CARBON FILM 1/6W 10 OHM JRA16 76366473 CARBON FILM 1/6W 47K OHM JRA17 76366472 CARBON FILM 1/6W 4.7K OHM JRA18 76366473 CARBON FILM 1/6W 47K OHM JRA19 76366100 CARBON FILM 1/6W 10 OHM JRA20 76366100 CARBON FILM 1/6W 10 OHM JRA21 76366472 CARBON FILM 1/6W 4.7K OHM JRA30 76011153 CHIP 1/2OW 15K OHM JRA31 76011101 CHIP 1/20W 100 OHM JRA32 76366153 CARBON FILM 1/6W 15K OHM JRA33 76011153 CHIP 1/2OW 15K OHM JRA34 76011153 CHIP 1/2OW 15K OHM JRA35 76011101 CHIP 1/20W 100 OHM JRA36 76011101 CHIP 1/20W 100 OHM JRA98 76011472 CHIP 1/20W 4.7K OHM JRA99 76011472 CHIP 1/20W 4.7K OHM JRB08 76011102 CHIP 1/20W 1K OHM JRB09 76011332 CHIP 1/20W 3.3K OHM JRB21 76366122 CARBON FILM 1/6W 1.2K OHM JRB22 76366151 CARBON FILM 1/6W 150 OHM JRB23 76366181 CARBON FILM 1/6W 180 OHM JRB24 76366241 CARBON FILM 1/6W 240 OHM JRB25 76366331 CARBON FILM 1/6W 330 OHM JRB26 76366471 CARBON FILM 1/6W 470 OHM JRB30 76366470 CARBON FILM 1/6W 47 OHM JRB31 76366103 CARBON FILM 1/6W 10K OHM JRB32 76366560 CARBON FILM 1/6W 56 OHM JRB33 76366221 CARBON FILM 1/6W 220 OHM JRB34 76366223 CARBON FILM 1/6W 22K OHM JRB35 76366102 CARBON FILM 1/6W 1K OHM JRB49 76366102 CARBON FILM 1/6W 1K OHM JRC01 76000445 CHIP JUMPER 1608TYPERC02 76000445 CHIP JUMPER 1608TYPERC03 76000445 CHIP JUMPER 1608TYPERC04 76000445 CHIP JUMPER 1608TYPERC05 76000445 CHIP JUMPER 1608TYPERC06 76000445 CHIP JUMPER 1608TYPERS01 76011473 CHIP 1/20W 47K OHM JRS02 76011473 CHIP 1/20W 47K OHM JRS03 76011473 CHIP 1/20W 47K OHM JRS04 76011473 CHIP 1/20W 47K OHM JRS05 76011102 CHIP 1/20W 1K OHM JRS06 76011102 CHIP 1/20W 1K OHM JRS09 76011561 CHIP 1/20W 560 OHM JRS10 76011101 CHIP 1/20W 100 OHM JRS11 76011101 CHIP 1/20W 100 OHM JRS12 76011222 CHIP 1/20W 2.2K OHM JRS13 76011222 CHIP 1/20W 2.2K OHM JRS14 76011104 CHIP 1/20W 100K OHM JRS15 76011104 CHIP 1/20W 100K OHM JRS16 76011103 CHIP 1/20W 10K OHM JRS17 76011103 CHIP 1/20W 10K OHM JRS18 76011104 CHIP 1/20W 100K OHM JRS19 76011103 CHIP 1/20W 10K OHM JRS20 76011103 CHIP 1/20W 10K OHM JRS21 76011103 CHIP 1/20W 10K OHM JRS23 76011103 CHIP 1/20W 10K OHM JRS24 76011103 CHIP 1/20W 10K OHM JRS25 76011103 CHIP 1/20W 10K OHM J

– 23 –

SP

EC

IFIC

INF

OR

MA

TIO

NS



RS26 76011103 CHIP 1/20W 10K OHM JRS27 76011103 CHIP 1/20W 10K OHM JRS28 76011103 CHIP 1/20W 10K OHM JRS29 76011103 CHIP 1/20W 10K OHM JRS30 76011103 CHIP 1/20W 10K OHM JRS31 76011103 CHIP 1/20W 10K OHM JRS32 76011103 CHIP 1/20W 10K OHM JRS33 76011101 CHIP 1/20W 100 OHM JRS34 76011101 CHIP 1/20W 100 OHM JRS35 76011101 CHIP 1/20W 100 OHM JRS36 76011101 CHIP 1/20W 100 OHM JRS40 76366473 CARBON FILM 1/6W 47K OHM JRS41 76366473 CARBON FILM 1/6W 47K OHM JRS63 76552271 OXIDE METAL FILM 1/2W 270 OHM JRS64 76552271 OXIDE METAL FILM 1/2W 270 OHM JRV01 76011750 CHIP 1/20W 75 OHM JRV02 76011101 CHIP 1/20W 100 OHM JRV03 76011750 CHIP 1/20W 75 OHM JRV04 76000445 CHIP JUMPER 1608TYPERV05 76011750 CHIP 1/20W 75 OHM JRV06 76000445 CHIP JUMPER 1608TYPERV07 76011750 CHIP 1/20W 75 OHM JRV08 76000445 CHIP JUMPER 1608TYPERV09 76011750 CHIP 1/20W 75 OHM JRV10 76000445 CHIP JUMPER 1608TYPERV11 76011750 CHIP 1/20W 75 OHM JRV15 76366101 CARBON FILM 1/6W 100 OHM JRV16 76011101 CHIP 1/20W 100 OHM JRV19 76011101 CHIP 1/20W 100 OHM JRV21 76011102 CHIP 1/20W 1K OHM JRV22 76011102 CHIP 1/20W 1K OHM JRV25 76366101 CARBON FILM 1/6W 100 OHM JRV26 76366750 CARBON FILM 1/6W 75 OHM J

COILS & TRANSFORMERSG404 23103308 FERRITE CORE TEM2011AO 3.5X4.5G405 23103308 FERRITE CORE TEM2011AO 3.5X4.5G461 23103308 FERRITE CORE TEM2011AO 3.5X4.5GL601 23103308 FERRITE CORE TEM2011AO 3.5X4.5GL889 23103311 FERRITR CHOKE TEM2014AO 3.5X5X2L101 23289187 COIL PEAKING 0.22MMHK COLTRF4R22AVL102 23289043 COIL PEAKING TRF4100AUL103 23289197 COIL PEAKING 1.2MMHK CNSS (NP)-1R2JL104 23248461 COIL CHOKE TLN3278ACL110 #2 23289043 COIL PEAKING TRF4100AUL156 23289196 COIL PEAKING 1.0MMHK COLTRF41R0AVL157 23289196 COIL PEAKING 1.0MMHK COLTRF41R0AVL301 23103308 FERRITE CORE TEM2011AO 3.5X4.5L441 23233132 COIL LINEARITY TLN2083AHL442 23248404 COIL CHOKE TLN3383DL461 23248375 COIL CHOKE 19X29H 470MMHK 1.5A TLN3335AAL462 23231491 DEFLECTION YOKE 29'’ PF DY TDY-829HPL462A 23993696 BOARD CORRECTIONL462B 23949616 CONVER COMPENSATOR TC-R (YV)L462C 23993081 METAL SHEET CONV. CORRECTION TCRMXH01HL462D 23948535 SHEET MAGNETIC FERRITEL462E 23948536 SHEET MAGNETIC FERRITEL501 23289043 COIL PEAKING TRF4100AUL502 23289043 COIL PEAKING TRF4100AUL503 23289043 COIL PEAKING TRF4100AUL504 23289043 COIL PEAKING TRF4100AUL702 23103323 FERRITE CORE HC5-035L704 23103308 FERRITE CORE TEM2011AO 3.5X4.5L705 23103308 FERRITE CORE TEM2011AO 3.5X4.5L805 23248423 COIL CHOKE TLN3481ACL806 23248423 COIL CHOKE TLN3481ACL811 23103308 FERRITE CORE TEM2011AO 3.5X4.5L815 23103308 FERRITE CORE TEM2011AO 3.5X4.5L882 23103308 FERRITE CORE TEM2011AO 3.5X4.5L883 23221142 COIL CHOKE TRF9253DL885 23248400 COIL CHOKE TLN3299DL886 23103308 FERRITE CORE TEM2011AO 3.5X4.5L888 23289174 COIL PEAKING 10MMHK TWE5NP-100K-5L889 23289174 COIL PEAKING 10MMHK TWE5NP-100K-5L891 23103308 FERRITE CORE TEM2011AO 3.5X4.5L892 23103308 FERRITE CORE TEM2011AO 3.5X4.5L894 23103308 FERRITE CORE TEM2011AO 3.5X4.5

z L901 23204003 COIL DG 0.5ALU 48T 8TYPE TSB-2389EALLA01 23289049 COIL PEAKING TRF4330AU

LA03 23289043 COIL PEAKING TRF4100AULA04 23289043 COIL PEAKING TRF4100AULA05 23289043 COIL PEAKING TRF4100AULA101 23289043 COIL PEAKING TRF4100AULA110 23289043 COIL PEAKING TRF4100AULA117 23289043 COIL PEAKING TRF4100AULA124 23289043 COIL PEAKING TRF4100AULA14 23289043 COIL PEAKING TRF4100AULA88 23289043 COIL PEAKING TRF4100AULA90 23289043 COIL PEAKING TRF4100AULA93 23289043 COIL PEAKING TRF4100AULA94 23289043 COIL PEAKING TRF4100AULA96 23289043 COIL PEAKING TRF4100AUT401 23224395 TRANSFORMER HORIZ DRIVER TLN1098AH

z T461 23236962 TRANSFORMER FBT TFB4228ATz T801 23211793 COIL LINE FILTER TRF3247AWz T802 23211838 COIL LINE FILTER TRF3202ARz T862 23217777 TRANSFORMER TPW3573AM

V901M 23102565 COIL CMG29.1VM6TLEAD3P MAG-1124Z101 #1 23303363 FILTER SAW BSF6284K

#2 23303176 SAW FILTER 38MHZ PIF SIF INTER OFWK2964M#3 23303363 SAW FILTER BSF6284K

Z102 #1 23303356 FILTER SAW BSF9351K#3 23303356 SAW FILTER BSF9351K BSF9351K

Z104 #2 23303353 FILTER FIL CFILT 5.74MHZ EFCS5R74YS5A

SEMICONDUCTORSD101 23362104 DIODE ZENER DZ33 BS CD103 #1 23362138 DIODE KDS114-RTK

#3 23362138 DIODE KDS114-RTKD202 23357697 DIODE 1SS133D203 23357697 DIODE 1SS133D301 23362228 DIODE VRM=200V 1N4003FD302 23357372 DIODE EU2JGF-41U2D303 23357917 DIODE SC570AD311 23362140 DIODE KDS160-RTKD312 23362069 DIODE ZENER DZ5.6 BS AD313 23357372 DIODE EU2JGF-41U2D406 23357372 DIODE EU2JGF-41U2D408 23357471 DIODE RU4DG-3AM2D441 23362071 DIODE ZENER DZ5.6 BS CD444 23357705 DIODE ERC06-15D445 23362081 DIODE ZENER DZ9.1 BS CD461 23357364 DIODE RU4JGF- M2D467 23357372 DIODE EU2JGF-41U2D470 23362107 DIODE ZENER DZ36 BS BD4703 23362140 DIODE KDS160-RTKD475 23357697 DIODE 1SS133D476 23357697 DIODE 1SS133D501 23362140 DIODE KDS160-RTKD502 23362140 DIODE KDS160-RTKD670 23362140 DIODE KDS160-RTKD671 23362140 DIODE KDS160-RTKD672 23362140 DIODE KDS160-RTKD673 23362140 DIODE KDS160-RTKD674 23362140 DIODE KDS160-RTKD680 23362140 DIODE KDS160-RTKD681 23362140 DIODE KDS160-RTKD682 23362140 DIODE KDS160-RTKD683 23362140 DIODE KDS160-RTKD704 23357697 DIODE 1SS133D705 23357697 DIODE 1SS133D715 23357697 DIODE 1SS133D720 23357697 DIODE 1SS133D721 23357697 DIODE 1SS133D801 23362217 DIODE BRG. VRM600V IO6A GBU6J-T1D805 23362235 DIODE VRM=200V IO=1.0A FTRR 1EDG-41AD807 23357372 DIODE EU2JGF-41U2D808 23357372 DIODE EU2JGF-41U2D809 23362094 DIODE ZENER DZ15 BS BD812 23362070 DIODE ZENER DZ5.6 BS BD813 23362070 DIODE ZENER DZ5.6 BS BD814 23362094 DIODE ZENER DZ15 BS BD815 23362103 DIODE ZENER DZ33 BS BD816 23362235 DIODE VRM=200V IO=1.0A FTRR 1EDG-41AD817 23362235 DIODE VRM=200V IO=1.0A FTRR 1EDG-41AD818 23357372 DIODE EU2JGF-41U2D841 23362067 DIODE ZENER DZ5.1 BS BD845 23357697 DIODE 1SS133

– 24 –

SP

EC

IFIC

INF

OR

MA

TIO

NS



D883 23357364 DIODE RU4JGF- M2D885 23357471 DIODE RU4DG-3AM2D891 23362235 DIODE VRM=200V IO=1.0A FTRR 1EDG-41AD892 23357372 DIODE EU2JGF-41U2D893 23362235 DIODE VRM=200V IO=1.0A FTRR 1EDG-41AD894 23357492 DIODE VRM=200IO=2A UG2D-41A-U4D901 23357104 DIODE 1SS244D902 23357104 DIODE 1SS244D903 23357104 DIODE 1SS244D904 23357104 DIODE 1SS244D905 23357104 DIODE 1SS244D906 23357104 DIODE 1SS244D907 76019471 VARISTOR TNR10V271KD911 23357372 DIODE EU2JGF-41U2D913 23357697 DIODE 1SS133D914 23357697 DIODE 1SS133D915 23357697 DIODE 1SS133D916 23357697 DIODE 1SS133D918 23362151 DIODE ZV=3.92-4.14 DZ3.9 BS BD919 23362151 DIODE ZV=3.92-4.14 DZ3.9 BS BD920 23362151 DIODE ZV=3.92-4.14 DZ3.9 BS BDA110 23362069 DIODE ZENER DZ5.6 BS ADA111 23362069 DIODE ZENER DZ5.6 BS ADA118 23362144 DIODE ZV=1.88-2.10 DZ2.0 BS ADA119 23357406 DIODE ZENER UDZS5.6BDA120 23357697 DIODE 1SS133DA121 23362140 DIODE KDS160-RTKDB21 23358577 DIODE LED RED/GREEN BT-H684WKB21 23085842 IC REMOCON RECEIVER ROM-N338TBQ101 23205509 TRANSISTOR 2SC4988FRTL-EQ102 #2 23205277 TRANSISTOR 2SC4116-Y (TE85LF)Q107 #1 23205214 TRANSISTOR NPN R1=R2=10KOHM SRC1202U (SOT-323)

#3 23205214 TRANSISTOR NPN R1=R2=10KOHM SRC1202U (SOT-323)Q108 #1 23205214 TRANSISTOR NPN R1=R2=10KOHM SRC1202U (SOT-323)

#3 23205214 TRANSISTOR NPN R1=R2=10KOHM SRC1202U (SOT-323)Q301 23085439 IC AN5523Q320 23205358 TRANSISTOR KTC3875S Y/PQ401 23205277 TRANSISTOR 2SC4116-Y (TE85LF)Q402 23205479 TRANSISTOR FET 2SK941 (F)Q404 23205502 TRANSISTOR 2SD2539(FAF)Q460 23205535 TRANSISTOR NMOS FET VDSS=200V STK630FQ471 23205433 TRANSISTOR KTA1024-Y/PQ472 23205277 TRANSISTOR 2SC4116-Y (TE85LF)Q473 23205357 TRANSISTOR KTA1504S Y/PQ610 23085693 IC AN5277Q670 23205276 TRANSISTOR 2SA1586Y (TE85LF)Q671 23205424 TRANSISTOR KTC2875B/PQ672 23205424 TRANSISTOR KTC2875B/PQ701 23205358 TRANSISTOR KTC3875S Y/PQ706 23205376 TRANSISTOR 2SC5343-Y (BULK)Q707 23205314 TRANSISTOR 2SC752 (G) TM-Y (F)Q709 23205376 TRANSISTOR 2SC5343-Y (BULK)Q710 23205372 TRANSISTOR 2SA1980-Y (BULK)Q711 23205435 TRANSISTOR KTA1837/PQ712 23205434 TRANSISTOR KTC4793/PQ719 23205376 TRANSISTOR 2SC5343-Y (BULK)Q720 23205376 TRANSISTOR 2SC5343-Y (BULK)Q773 23205376 TRANSISTOR 2SC5343-Y (BULK)Q801 23135069 IC STRF6268SQ802 23205543 TRANSISTOR FN155Q803 23205376 TRANSISTOR 2SC5343-Y (BULK)Q805 23205229 TRANSISTOR SRC1205M

z Q826 23085841 PHOTO COUPLER VCEO=80V IF=50M K1010HB CTRQ831 23085812 IC KIA78D05F-RTF/PQ835 23085730 IC AN34040AQ841 23205277 TRANSISTOR 2SC4116-Y (TE85LF)Q842 23205277 TRANSISTOR 2SC4116-Y (TE85LF)Q844 23085792 IC KIA 78D33 PIQ883 23009991 IC SE133N LF4Q901 23085754 IC TDA6107AJFQ908 23205202 TRANSISTOR 2SC5344YQ909 23205376 TRANSISTOR 2SC5343-Y (BULK)QA10 #1 23085765 IC AT24C16A-10PU2.7

#2 23085764 IC AT24C08A-10PU2.7#3 23085764 IC AT24C08A-10PU2.7

QA14 23205358 TRANSISTOR KTC3875S Y/PQA15 23205586 TRANSISTOR PNP 2SA1013-R(F)QA16 23205358 TRANSISTOR KTC3875S Y/PQA17 23205586 TRANSISTOR PNP 2SA1013-R(F)

QA51 #1 23085647 IC TDA12021H/N1F01#2 23085798 IC PHILIPS UOC3-AVST (NO-TXT) TDA12063H/N1F00#3 23085796 IC TDA12011H/N1F00

QB04 23205358 TRANSISTOR KTC3875S Y/PQB21 23205376 TRANSISTOR 2SC5343-Y (BULK)QB22 23205372 TRANSISTOR 2SA1980-Y (BULK)QS01 23205277 TRANSISTOR 2SC4116-Y (TE85LF)QS02 23205277 TRANSISTOR 2SC4116-Y (TE85LF)QS03 23205424 TRANSISTOR KTC2875B/PQS04 23205424 TRANSISTOR KTC2875B/PQS05 23205222 TRANSISTOR PNP R1=R2=47KOHM SRA2204S (SOT-23)QV02 23205357 TRANSISTOR KTA1504S Y/P

MISCELLANEOUSC903A 23965241 TAPE CC #12 10MM L30M

z F470 23144297 FUSE CARTRIDGE 250V 1A 5.2X20F470A 23165469 FUSE HOLDER 5.2 DFH-001F470B 23165469 FUSE HOLDER 5.2 DFH-001

z F801 23144302 FUSE CARTRIDGE 250V 4A 5.2X20F801A 23165469 FUSE HOLDER 5.2 DFH-001F801B 23165469 FUSE HOLDER 5.2 DFH-001

z F802 23144200 FUSE CARTRIDGE 5.2X20 250V 3AF802A 23165469 FUSE HOLDER 5.2 DFH-001F802B 23165469 FUSE HOLDER 5.2 DFH-001J602D 23171400 WIRE PVC SOLDER-PLATED 300V 7/16 BRN UL CSAJ602E 23171400 WIRE PVC SOLDER-PLATED 300V 7/16 BRN UL CSAM461A 23192251 CABLE ANODE CAP ASSY TCC5606CTM461B 23507638 CABLE FOCUSM461C 23507543 CABLE ASSY CABLE SCREENN724 23965900 TAPE GLASS-CLOTH W/ADHESIVE W=18 T=0.18N728 23960101 SILICONE RUBBER TSE-382 RTVP107 23713756 PLUG 5P 2.5MM G B5B-EH-F1-TV4P401 23757267 CONNECTOR B06B-DVS-L JST B06B-DVS-L (LF)P501 23713756 PLUG 5P 2.5MM G B5B-EH-F1-TV4P601A 23713755 PLUG 4P 2.5MM G B4B-EH-F1-TV4P601B 23713755 PLUG 4P 2.5MM G B4B-EH-F1-TV4P602 23713755 PLUG 4P 2.5MM G B4B-EH-F1-TV4P662 23023116 PLUG HEAD PHONE JACK 3.5MM PJ3-14-7P704A 23713755 PLUG 4P 2.5MM G B4B-EH-F1-TV4P704B 23713755 PLUG 4P 2.5MM G B4B-EH-F1-TV4

z P801 #1 23372323 POWER CORD AC CORD CEE M4206-2.5Mz #2 23372333 POWER CORD THAI KP-10KW -2.5Mz #3 23372323 POWER CORD AC CORD CEE M4206-2.5M

P902A 23713759 PLUG 8P 2.5MM G B8B-EH-F1-TV4P902B 23713759 PLUG 8P 2.5MM G B8B-EH-F1-TV4P903A 23713757 PLUG 6P 2.5MM G B6B-EH-F1-TV4P903B 23713757 PLUG 6P 2.5MM G B6B-EH-F1-TV4P910 23164725 PLUG 2PPA21A 23713757 PLUG 6P 2.5MM G B6B-EH-F1-TV4PA21B 23713757 PLUG 6P 2.5MM G B6B-EH-F1-TV4PB01 23713755 PLUG 4P 2.5MM G B4B-EH-F1-TV4PV01 23023429 JACK 11P+1SV JACK (4SW)-852V2-01 NI FE LFPV03 23023258 JACK 3P MTJ-032-39BBA-432Q301B 23717241 SCREW BITTB3X8 ECOQ301G 23960136 ADHESIVE SILICONE TSE3843-WQ404B 23738136 SCREW 3X10MMQ404G 23960136 ADHESIVE SILICONE TSE3843-WQ460B 23717241 SCREW BITTB3X8 ECOQ610B 23717241 SCREW BITTB3X8 ECOQ801B 23738136 SCREW 3X10MMQ801G 23960136 ADHESIVE SILICONE TSE3843-WQ835B 23717241 SCREW BITTB3X8 ECOQ844B 23717241 SCREW BITTB3X8 ECO

z S801 23344545 SWITCH POWER KDC-A20-1-8ASA11 23344516 SWITCH TACTING TSV TYP TSVB-1SA12 23344516 SWITCH TACTING TSV TYP TSVB-1SA13 23344516 SWITCH TACTING TSV TYP TSVB-1SA14 23344516 SWITCH TACTING TSV TYP TSVB-1SA15 23344516 SWITCH TACTING TSV TYP TSVB-1SA16 23344516 SWITCH TACTING TSV TYP TSVB-1

z SR81 23146587 RELAY DC12V 0.53W G5PA-1-Mz SR83 23146585 RELAY DC12V 2M G5PA-2 DC12z V901A 23903174 SOCKET CRT ISH46S-EN ING

V901B 23102456 MAGNET MAG4006W661 23351339 SPEAKER SPK 8-OHM 10W SPK-1410ALW662 23351339 SPEAKER SPK 8-OHM 10W SPK-1410ALXA03 23153618 CRYSTAL RESONATOR 24.576 CRYSTAL 24.5MHZZ891 23144415 FUSE PROTECTOR 125V 4A SMP125M04A00Z892 23144415 FUSE PROTECTOR 125V 4A SMP125M04A00

– 25 –

SP

EC

IFIC

INF

OR

MA

TIO

NS



Z894 23144415 FUSE PROTECTOR 125V 4A SMP125M04A00

PC BOARD ASSEMBLIES

* U901 23764818 PC BOARD ASSY PD2078A CRT/D

* U902 #1 23764737 PC BOARD ASSY PD2249C SIGNAL

* #2 23764846 PC BOARD ASSY PD2249R SIGNAL

* #3 23764768 PC BOARD ASSY PD2249H SIGNAL

* U903 23764738 PC BOARD ASSY PD2276 FRONT

PICTURE TUBEz V901 23324229 PICTURE TUBE 29 PF ORION A68QFD290X

TUNERH001 23321549 TUNER ASIA HYPER FS5V B8A86ST

ACCESSORIESA701 23015306 CARTON BOXK902 #1 23306623 REMOCON HAND UNIT IR CT-90229

#2 23306624 REMOCON HAND UNIT IR CT-90230#3 23306624 REMOCON HAND UNIT IR CT-90230

Y101A #1 23566823 OWNERS MANUAL ENGLISH#2 23566855 OWNERS MANUAL ENGLISH/THAI#3 23566836 OWNERS MANUAL ENGLISH

Y101B #1 23566824 OWNERS MANUAL INDONESIAN#3 23566837 OWNERS MANUAL INDONESIAN

Y120 23943846 BAG POLYY121 #1 23943846 BAG POLY

#3 23943846 BAG POLY

CABINET PARTSA201 #1 23533666 COVER FRONT ASSY

#2 23533666 COVER FRONT ASSY#3 23571086 COVER FRONT ASSY

A401 23532083 COVER BACK COVER PROPERA423 23929522 WASHER T=1.0A504 23738086 SCREW BTB4X16 ECOA508 23738086 SCREW BTB4X16 ECOA522 23738086 SCREW BTB4X16 ECOA702A 23946119 PACKING TOPA702B 23946120 PACKING BOTTOMA902 23428371 DOOR FRONTA905 23445914 BUTTON POWERA911 23436893 HANDLEA914 23738088 SCREW BTBW3X12 ECOA915 23738085 SCREW BTB4X12 ECOB202 23738088 SCREW BTBW3X12 ECOB212 23738086 SCREW BTB4X16 ECOB232 23738088 SCREW BTBW3X12ECOE912 23848729 WEDGE YOKE HOLDING 3 REQUIRED

– 26 – – 27 –

SIGNAL BOARD PD2249BOTTOM (FOIL) SIDE

23547884

51

SD

A

SC

L

IFNC32

V

NC

+5VNC

AD

RV

t

AG

C

1

B

10 6

1

85

4

12

21

3

CAUTION LIVE AREA

C15

8

P107M804A

C110

C10

8

LC04

L157 L103

L156

PB01

L158

D10

1

L112

C350

Z101

P499

SL1

PV01

LC05

C109

R107

C101

L101

H001

R11

0

C20

4

G103

L104TP15 + +

415

412

3

+

+

+

C202

LA124

R117

RA17

LA117

LA03

L501

D47

3

C203

LA05

RA32

LA04

C50

1

CA117

C450

DA

120

LA110

C47

03

CA06

LA14

CA119

DA118

RA

16

QA

15

D450

XA03

RA21

LA10

1

CA14

++

++

+

+

+

125

+ +115

105

5

15

25

++

C833

Q83

5

C69

0

C83

0

RA15

C67

2

C660RA14

C83

4

C671

C664

C84

8

C83

6

RA

19

C67

0

C84

9

C66

3

C66

5

C83

1

Q835A

Q844A

QA17

C832

RA

20R

A18

C661

+

++

+

++

+

+

M501A

P496

+

1

2

34

5

C328

C310

C144

Z102

GL896

RV15

CS08

RV13

R33

1

R305

D30

1

C309

L110

R322

CS07

C503

CS

03

R35

0

CS

05

Q30

1

CS

06

L109

M50

2A

C335

R217C311

Z10

4

R21

5

P704A

L102

C12

1

C333

C308

Z15

4

Z15

5

C31

2

C44

9

CV06D

313

CS

02

C125

CS

01

CV08

SL06

C323

D312L5

02

R310

1

+

+

+

+

+

+

+

+

431

65432

+

1

4321

+

++

+

+ ++ +

+

C36

3

R471

Q471

R83

9

Q883 D882 T862+

C89

3

C884

Q82

6

LA01

C50

5

R33

6

L504

CS09

CA

01

R36

3

C50

7

GR

828

D202

C212

C464Z

R473

C129

C47

0

M501B

CS

10

LA94

C439Z

R43

2

CA89

C435

D20

3

LA90

L503

LA88

DA111

M502B

LA96

R156

DA110

RB49

P90

2A

C439

C127

CA

112

D47

0

CS11

CA94QA10

R4760

C464

CA92

L461

D4700

D47

5

+

++

3

78

+

+

+

+

+

+

+

33

32

8

1

1

2

+

97

+

+

432

5432

+

1

+

+

4

5

6

+96

85

90

80

75

64

55

50

45

40

35

+

21"

GL601

T0.8A L/250V

A

C89

5

R470

R479

C47

2

C89

8

L888

C889

D883

L885

D893

L882

L886

C84

1

L894

C66

7

C885

R68

3

C68

1

R898

C891

LA93

C839 P601A

PA21B

L891

L815

L883

C68

4

LC02

D894

D841

Z892R838

Q61

0A

L892

C89

7

Q84

4

D891

C890

C84

2

C894

D892

C843

C838

C837

C682

D885

L889

C68

3

C896C892

GL8

93

R621

D68

4

LC01

C89

9

F470

Q61

0

Z891

+

B +

+

+ +

T1A L/250V25"/29"

+

+

123

4

+

+

+

OUT

IN

+

+

+

GL8

95

RB

04

LC03

SA

04

RS

61G

L808

RS62

RB

06R

681

P661

Z894 SA

05S

A06

PV02

CB

07

RB

05

+

12

P498

R227

C322

D302

C445Z

C40

2

Q404

R439

T46

1

D408

G40

4

C30

3R

438

C448

R46

2R

460

R403

R327

D40

6

C498

D44

1

D303

C445

G40

3

C220

D46

7R

475

C460

C44

7

C473

R21

6

L301

R218

R46

2Z

R303

R448

Q46

0

C313

P903A

+6

7

D

S

+

1

2

3

45

8

9

10

+

G

R830R830Z

G405

R429

G402

C467ZC467

Q80

1

L811

Q803

C413

R83

4

C46

3

R82

6

C442

L442

D81

4

R41

6D

445

C417

C442Z

G46

1

C44

0

D81

3

D818

C442Y

C443R

817

R441

D816

T401Z

C815

Q802

C41

6

R899

R831

D809

D444

R805

D81

2

D476

C817

T401

C820

R41

5G

L888

D44

3

R474

R825

C80

9D805

L441Z Q40

2

D461

P40

1

R832

R818

R82

9

GL828

C82

1

D81

5D

817

D442R

820

C811

Q801A

R42

8

L441

C444

+

+

B

A

+

T80

1

G10

9 G10

6

R801

C801Z

C801

T802

D80

8

L806

D801

P801

G105F801

C81

0Z

G10

8

C802Z

R80

8

C81

0

C805

D80

7

C802

P91

0

F80

2

R81

0

C80

6

R81

4

C81

4 D845

G107

SR83

R81

2

P802

S80

1

SR

81

M80

4B

L805

C812

G104

R81

1

R81

3

+T4A L/250V

T3.

15A

L/2

50V

P497

KB01

DB01

SA

03

CB

01

RB

03C808

Q80

5

C813

DB02

SA

01R

B01

DB

02A

RB

02S

A02

R106C103C111

GJ14

D104

GJ04

R329

C471

7

C105

C106

C102

R482

C104

C157

R484

R113

C159

GJ03

GJ401

C156

R115

R101

GJ07

R102

C327R328

C497

D103

C432

R124

Q101

C499

R108

CC01

R103

Q108

C114

C107

R498 Q461

R4717R4720

GJ17

GJ02

R112

R104

Q107

GJ05

R426R105

R109

R119

R126

R125

R118

R111

R152GJ

01

JR00

5

JR013

JR01

6

C205

CA108

RA34

CA124

R412

R320

C401

RA30

C329

RA35

R325

R413

CA03

QA14

R453

RA105

CA04

CA116

C471

2

C475

RA109

R4200C120

R425

CA31

R201

R451

R116

CA120

RA106 RA108

R450

CA05

CA109

R452

C116

R4716

C201

CC20

Q451

CA11

8CA30

R401

Q472

R481

Q450

RA31

R471

8

D4703

CA110

Q473

R424

QA16

R461

C502

R318

JR00

7

JR004

JR003

JR001

RJ03

D672

R673

Q671

Q614

DA121 C666

C662

R671

Q670

D670

R672

R674

R660

Q672

R666

R675

R661D673

R618D674

R662

R617

GJ808

Q613

D671

CC09

RV18LC20

CV07

RV17

R665R664

C141

CC04

RV01 LC07

R324

GJ06

LC09

CV01

C331

R141

RC05 RJ02

RJ01

R346RS

36

RC02

QS03

C131

C145

C142

R347

RS04

CC03

RS13

RV04

RV08

Q320

QS04

QS02

LC06

RV02

RC03

RS09

CC06

R348

CC07

LC13

LC11

D501

RS27

D311

CC05

C130

RV10

CV02

CS14

D310

RS19

RV05

C504

RS01

CV22

CS13RV07

R501

RV09

RS10

RS12

LC10

RS16

LC08

CV09

RV22

Q102

RS18

RS14

GJ811

QS01

CV03

RS24

CV21

C336

RS05

R121

LC17

RS20

QV02

R140

LC12

R142

RS15

RV21

RV06

R354

LC16

RS11

RS35

R314

LC15

R123

RV11

RS06

CV05

R323

RS02

RS17

RC04

RS03

CS15

C321

QS05

RC01

CV04

RV16

RS23

D502

RV03

RC06

C140

CV12

RS21

RS25

LC14

CC02

CS04

RS26

R321

CS12

C315

JR014

JR00

2

C888

R836

R437

R214

R702

RB09

CA97

RA36

C506

C122

RS29

R701

R122

CS22

CA88

QB04

C126

C128

R4703

R4712

R703CV

18

RS28

RV19

R503

CA98

DA119

R504

R705

R505

R440

CV14

RB08

RS30

RA33

CV20

CV15

RA98

C124

R219

CA99

CS19

C211

CS23CS18

QA51

R435

C511

C512

CA95

CV11

Q210

CV13

C219

R4770

R431

RS32

C508

CA91

RS31

RS33

CV19

Q701

CS16

RA99

R212

Q401

R409

CS20

C123

CV16

CS17

R502

CA90

D470

1

CA101

CA96

C510

C430

CA93

R837

CV10

C206

R848

C509

CV17

CS21

RS34

R704

JR00

9

JR018

JR01

9

JR011

JR00

6

JR008

Q831

R843

D683

Q842R840Q8

41

D682

R620 R687

R842

D681

CC14

Q615

JR017

JR01

0

RC08

CC30

CC31

R686

LC19

CC32

C687 CC08

D680

RS08

CC33

C686

RS07

LC18RC07

R228

R463

C4702

C824

C823

R470

2

R833

R4701

C818C4701

R420

D420

R847

R470

4

R419

C470

0

R846

R841

QB02

RB10

RB15

RB12

RB11

RB13

QB01 RB14

– 28 – – 29 –

2354

7775

IBL B G R

6 2 145 378

H

B E

EB

BE

+

+

+

+

MCL-437F

32

KG

1

123456

KB

KR

H

+

B

BE

B

E

3

2

1

E

B+

EB

+

+

+

+

E

2 3 41

R910

R906

R911

R908C931

D919

D918

R912

R913

R909 R904

P902B

D920

R905

D90

2

D90

3

A

BOUT

GOUT

ROUT

+200V

I BLACK

BIN

RINGIN

GND

R992

R70

2

Q707

Q773

R760

Q720

R716

R725

R71

3

R775

Q706

R723

C71

2

C70

4

R722

R721

R71

7

C72

2

C705

R72

4R715

D914

R93

8

C90

2

R90

7

R93

9

D91

2

C910

Q90

1

P903B

D917

C903

P900

C91

2

D915

C930

V901B

Q90

1A

Q908

Q909

R902

D913

D91

6

D911

R901

C911

C90

1

C904

R936

D901

R937

V901

A

R90

3

P905

A

L705

Q711

R73

1

C71

9

R732

R730

R745 L702

C717

Q71

9

D715

Q71

1A

P70

3

R709

R744

R735

C72

6

P704B

R733

C71

5

R920

R720

C718

C72

1

D721

R740

R74

2

R738C714

Q712

R920Z

G714

R74

3

R719

Q71

2A

L704

C716

D705

R73

4

C707

D720

R736

Q710

Q709

C713

D704

R739

C72

0

R74

1

R73

7

CRT-D BOARD PD2078BOTTOM (FOIL) SIDE

FRONT BOARD PD2276BOTTOM (FOIL) SIDE

2354

7893

B

C

E

E C B

CH UP

3 421

5 64321

MENU VIDEO VOL DN VOL UP CH DN

MCL-437F1 2 3 4 5

1234

RB

31

QB21

QB22

RB

32

RB

33

SA11

RB

35

RB30

RB34

DB21

RB22

CB

21

KB21

+CC

34

P602

CC

35

RS

63CC36

CC

37

RB24

PA21A

RB21

SA13SA16 SA12

RB25

SA15

RB26 RB23

SA14

LC04

LC06

LC05

LC25

RC

18

RS

40

RC

17

RS

41R

V26

PV03

P501

CC17CC18

LC26

RV25

CV25

LC27

P601B

RS64

P66

2

SP

EC

IFIC

INF

OR

MA

TIO

NS

– 30 –

EC

B

BCE

BCE

BCE

EC B

EC

B

BCE

BC

E

TERMINAL VIEW OF TRANSISTORS

1 2SD2253 (old)2SC52432SC5859

2 2SA1186A2SA13062SA17882SA18372SA19302SC15692SC38522SC45442SC47932SC51712SD1763A2SD2396

3 2SA10202SC24822SC26552SC4721P2SC53432SC53442SC752GTM

4 2SA10152SA1320(F)2SA29802SA562TM2SA93352SC1740S2SC18152SC21202SC28782SC752KTA1266KTC3198

6 2SA1788

6 KRC105MRN1201RN1202RN1203RN1204RN1205RN2201RN2203RN2204

7 2SD15542SD15562SD22532SD23962SD25532SD5143

8 ON4409

SP

EC

IFIC

INF

OR

MA

TIO

NS

– 31 –

SPECIFIC INFORMATIONS

SCHEMATIC DIAGRAM

MODEL : 29CZ5DE/29CZ5T/29CZ6SI

WARNING: BEFORE SERVICING THIS CHASSIS, READ THE “X-RAY radiation precaution”, “SAFETY PRECAUSTION”and “PRODUCT SAFETY NOTICE” ON THE MANUAL FOR THIS MODEL.

CAUTION: The international hazard symbols “ ” in the schematic diagram and the parts list designate componentswhich have special characteristics important for safety and should be replaced only with types identical to those in theoriginal circuit or specified in the parts list. The mounting position of replacements is to be identical with originals.

Before replacing any of these components, read carefully the PRODUCT SAFETY NOTICE on the MANUAL for this

model. Do not degrade the safety of the receiver through improper servicing.

NOTE:1. RESISTOR Resistance is shown in ohm [K = 1.000, M = 1.000.000]. All resistors are 1/6W and 5% tolerance carbon

resistor, unless otherwise noted as the following marks.1/2R = Metal or Metal oxide of 1/2 watt 1/2S = Carbon compsistion of 1/2 watt1RF = Fuse resistor of 1 watt 10W = Cement of 10 wattK = ±10% G = ±2% F = ±1%

2. CAPACITOR Unless otherwise noted in schematic, all capacitor values less than 1 are expressed in µF, and the valuesmore than 1 in pF.All capacitors are ceramic 50V, unless otherwise noted as the following marks.

+

Electolytic capacitor M Mylar capacitor

3. The parts indicated with “ ” have special characteristics, and should be replaced with identical parts only.4. Voltages read with DIGITAL MULTI-METER from point indicated to chassing ground, using a color bar signal with all

controls at normal, line voltage at 220 volts.5. Waveforms are taken receiving color bar signal with enough sensitivity.6. Voltage reading shown are nominal values and may vary ±20% except H.V.

L SCHEMATIC DIAGRAM STRUCTURE:

– MAIN Circuit – SIGNAL/MICON [SHEET-1/6] ......................................... 1/8

– VERT [SHEET-2/6] .................................................2/8

– HORIZONTAL [SHEET-3/6] .................................................3/8

– PROTECTER [SHEET-4/6] .................................................4/8

– LOW B REG [SHEET-5/6] .................................................5/8

– POWER [SHEET-6/6] .................................................6/8

– CRT DRIVE Circuit ..................................................................................................................................................7/8

– FRONT Circuit ..................................................................................................................................................8/8


– 32 –

CIRCUIT BLOCK DIAGRAM

+-

L

R

W661

W662

JACKHEADPHONE

Q610

AUDIO OUT

SIFSAW FILTER

Z101,Z102H001

TUNERVIF

Q801

QA10

MEMORY

HYBRID

D801Q404

H. OUT

Vdrb

Vguard

Vdra

Q301

Q901

BLACK

V. OUT

RGB OUT

D.Y.

Q835

REGULATOR

V

CRT

H

H.V.

F.B.T

Q883

ERROR AMP.

UOC3

QA51

TV ONE CHIP IC

Q826

CONVERTER TRANS.

+B VOLTAGE

Q844, Q831

REGULATOR

T862

L

CR

R

C

V

R

L

B

R

L

V

V

R

V

L

(

(2)

(1)

(3)

AV IN

AV IN

OUTPUTMONITOR

AV IN

Y

C

DPC

Q460

– 33 –– END –

MODEL

Rated voltage

Power consumption(at g 220 V, 50 Hz)

Dimensions(Width × Depth × Height)

Mass

Picture tube

Channelcoverage

Special RFsignal

Television system(Aerial input)

Color system Sound system

NTSC4.43 5.5/6.0/6.5 MHzPAL 60Hz 5.5/6.0/6.5 MHz

UHF21 – 6921 – 6913 – 5721 – 6921 – 6914 – 6913 – 62

CATV (Channels)X ~ Z+2, S1 ~ S41 —Z–1 ~ Z–38X ~ Z+2, S1 ~ S41X1 ~ X19A–6 ~ A–1, A ~ W, AA ~ ZZ, AAA, BBBM1 ~ M10, S1 ~ S41

CCIRUKCHINACCIROIRTUSJAPAN

PAL50 / PAL60 / SECAM / NTSC4.43 / NTSC3.58

10 W + 10 W (10 % THD)

6 × 12 cm (2)

Input [a(1)] : S-Video/Video, Audio L/MONO, Audio RInput [a(2)/DVD] : Video/Y, PB/CB, PR/CR, Audio L/MONO, Audio RInput [a(3)] : Video, Audio L/MONO, Audio ROutput [>(MONITOR)] : Video, Audio L/MONO, Audio RHeadphone output : ø 3.5mm (mini jack stereo type)

VHF2 – 12

—1 – 122 – 121 – 122 – 131 – 12

SystemPAL B/GPAL IPAL D/KSECAM B/GSECAM D/KNTSC MNTSC M

29CZ5DE/29CZ5T/29CZ6SI

g 110 V – 240 V, 50/60 Hz

123 W

782.1 (W) × 492.5 (D) × 585.1 (H) mm

44 kg

Type 29 Flat square picture tube(727.4 mm) Overall picture tube measured diagonally(676.0 mm) Viewable picture tube measured diagonally104° deflection

Channel

Color system (Video input)

Sound output

Speaker

Terminals

SPECIFICATIONS

* The shaded areas are not available for 29CZ5T.Please refer to owner’s manual in details.

– 34 –

SP

EC

IFIC

INF

OR

MA

TIO

NS

– 31 –


SCHEMATIC DIAGRAM

MODEL : 29CZ5DE/29CZ5T/29CZ6SI

WARNING: BEFORE SERVICING THIS CHASSIS, READ THE “X-RAY radiation precaution”, “SAFETY PRECAUSTION”and “PRODUCT SAFETY NOTICE” ON THE MANUAL FOR THIS MODEL.

CAUTION: The international hazard symbols “ ” in the schematic diagram and the parts list designate componentswhich have special characteristics important for safety and should be replaced only with types identical to those in theoriginal circuit or specified in the parts list. The mounting position of replacements is to be identical with originals.

Before replacing any of these components, read carefully the PRODUCT SAFETY NOTICE on the MANUAL for this

model. Do not degrade the safety of the receiver through improper servicing.

NOTE:1. RESISTOR Resistance is shown in ohm [K = 1.000, M = 1.000.000]. All resistors are 1/6W and 5% tolerance carbon

resistor, unless otherwise noted as the following marks.1/2R = Metal or Metal oxide of 1/2 watt 1/2S = Carbon compsistion of 1/2 watt1RF = Fuse resistor of 1 watt 10W = Cement of 10 wattK = ±10% G = ±2% F = ±1%

2. CAPACITOR Unless otherwise noted in schematic, all capacitor values less than 1 are expressed in µF, and the valuesmore than 1 in pF.All capacitors are ceramic 50V, unless otherwise noted as the following marks.

+

Electolytic capacitor M Mylar capacitor

3. The parts indicated with “ ” have special characteristics, and should be replaced with identical parts only.4. Voltages read with DIGITAL MULTI-METER from point indicated to chassing ground, using a color bar signal with all

controls at normal, line voltage at 220 volts.5. Waveforms are taken receiving color bar signal with enough sensitivity.6. Voltage reading shown are nominal values and may vary ±20% except H.V.

L SCHEMATIC DIAGRAM STRUCTURE:

– MAIN Circuit – SIGNAL/MICON [SHEET-1/6] ......................................... 1/8

– VERT [SHEET-2/6] .................................................2/8

– HORIZONTAL [SHEET-3/6] .................................................3/8

– PROTECTER [SHEET-4/6] .................................................4/8

– LOW B REG [SHEET-5/6] .................................................5/8

– POWER [SHEET-6/6] .................................................6/8

– CRT DRIVE Circuit ..................................................................................................................................................7/8

– FRONT Circuit ..................................................................................................................................................8/8


– 32 –

CIRCUIT BLOCK DIAGRAM

+-

L

R

W661

W662

JACKHEADPHONE

Q610

AUDIO OUT

SIFSAW FILTER

Z101,Z102H001

TUNERVIF

Q801

QA10

MEMORY

HYBRID

D801Q404

H. OUT

Vdrb

Vguard

Vdra

Q301

Q901

BLACK

V. OUT

RGB OUT

D.Y.

Q835

REGULATOR

V

CRT

H

H.V.

F.B.T

Q883

ERROR AMP.

UOC3

QA51

TV ONE CHIP IC

Q826

CONVERTER TRANS.

+B VOLTAGE

Q844, Q831

REGULATOR

T862

L

CR

R

C

V

R

L

B

R

L

V

V

R

V

L

(

(2)

(1)

(3)

AV IN

AV IN

OUTPUTMONITOR

AV IN

Y

C

DPC

Q460

A

B

C

D

E

F

G

H

I

J

L

K

L

K

J

I

H

G

F

E

D

C

B

A

1 1615141312111098765432

16151 2 3 4 5 6 7 8 9 10 11 12 13 14

PIC-TB19

5V1

5V-1

9V

3.3V-2

SAW_SW

DEG

1.8V-2

1.8V-2

3.3V

-1

1.8V-1

1.8V-1

1.8V-1

IF

AGC

SC

L

SD

A

KETSU

SHORT

SHORT

23221141

23221139

(RA)

(RB)

TRF9240AC

TRF9240AH

RC17 ~ RC18 (FRONT)

(MAIN)

10nF

LC04 ~ LC06

CC36 ~ CC37

RC01 ~ RC06

RUSSIA MODEL

1k

OTHER MODEL

NOT USED

USED

PRE AMP

SHORT

KETSU

GJ17

47pF

KETSU

10nFKETSU

(RC)

(RA)

(RB)

KETSU

Q107 ~ Q108

C140

DTC114EUA

SRC1202U

KRC402

C141

1k

2.2k

100R

R141 KETSU

R123

R142

KETSU

KETSU

KETSU KETSU

KETSU 100R

C130

R140

KETSU (RA)

KETSU

(RC)

(RB)

Q102

Z104

KETSU

KETSU

10uH

12uHL109

L110

2SC4116Y

2SC4081T

EFCS5R74Y5ST

KTC4075Y

C142 10nFKETSU

C145

C144 10uF

100nF

KETSU

KETSU

KETSU

KETSU

(RB)

3KR111

(RA)D103

MA77

KDS114

THAIMULTI

BILINGUALLOCATION

10K

15K

10K

3.3K

100R

R117

R112

R110

R113

R118

KETSU

KETSU

KETSU

KETSU

KETSU

KETSUKETSU(R1)AV STEREO TSF6380Y

K6284K K9351K(RB)(RB)

KETSU SHORT KETSU KETSU SHORT

KETSUKETSU SHORT KETSUSHORT

*M*, *R*

MODEL

MONO BILINGUAL

15p

KETSU

CC20

K2964M

OTHER MODELS KETSU

KETSU SHORTKETSU SHORT KETSU

KETSUKETSU SHORT KETSUKETSU

(R2) K6269K

F816K(R3) KETSU

KETSU

KETSU

KETSU

SHORT

(RA)NICAM SHORT10nF

GJ03C104

SHORTKETSU

GJ05GJ04

(RA)

Z101

BSF6284 BSF9351

Z102 GJ06

KETSU KETSU

GJ07

23103302(RB)

(RA) 23103308G106 ~ G109 KETSUTEM2011AO

TEM2011AH

KETSU

23248386(RB)

RUSSIA MODEL

(RA) 23248423

TLN3481AA

OTHER MODEL

KETSUTLN3481AC

23248417(RB) TLN3481AH

LOCATION

G104 ~ G105

[21CZ6~8 MODELS]POWER (MAIN BOARD)

SHORTGJ32 ~ GJ43

[29CZ5 MODELS]

[21CZ6~8 MODELS]

LOCATION

ENV59DA7G3

OTHER MODELLOCATION RUSSIA MODEL VIETNAM MODEL

ENV59DA7G3 23321549(R1)H001 23321514 23321514115B8A86ST

100R

SHORT

(RA)

(RB)

LC01 ~ LC03

(RB)

(RA)

(RA)

(RB)

1k

G103

LC04

LC05

RC01 ~ RC08

LOCATION

CC32 ~ CC33 KETSU

SHORT

10nF

TRF9240AC23221141

23221139 TRF9240AH

RUSSIA MODEL

23103279

23103249

23103894

23103248

(R1)

SHORT

(R3)

(R2)

(R2)

(R3)

TEM2011AA

TEM2014AO

TEM2011AO

TEM2014AA

SHORT

OTHER MODEL

23321534

23321545

100R

100R

SHORT

TAEM-G107D

ENV59K11G3F

12V_FBT

*

Connected To pin9 Audio GND

*

*

*

(This Ground is connected to UOCIII Pin 81)

29CZ5/6

21CZ6/7/8

21CZ7 ONLY

21CZ6/8

1

2

3

4

6 5 4 3 12

KE

Y

GN

D

3.3V-1LE

D

RE

MO

TE

5V-1

21CZ8 (4 SPKS - 4ohms)

21CZ6/7 (2 SPKS - 8ohms)

+

-

BO

TT

OM

LEF

T

+

M604

+

-

M602

TO

P LE

FT

-

M603

BO

TT

OM

RIG

HT

TO

P R

IGH

T

M601

+

-

RIG

HT

LEF

T

-

M602

++

-

M601

(ABL)

EHT

2

4

3

1

*

4

3

2

1

KE

Y

CH UP MENUVOL DNCH DN VOL UP VIDEO

NC

4

SD

A

5

SC

L

13

5V1

2

GN

D

9V

*

*

*

*

*

*

*

*

*

4 3 2 1

Speaker Mute

Line Out Mute

9V

27V

Audio GND

E3

E1 S-VIDEO

MONITOR OUT

E1

E2 DVD

E2

*

*

*

*

*

*

*

2

5V-2

15 34

*

5V-2

E2-CVBS 0V

E2-DVD

DVD IN Detect

5V

5V-2

E2-

DV

D IN

5V-2

Video Monitor OUT

E1 IN

Audio

Monitor OUT

E3 INE2 IN

8V

L Monitor-OUT

R Monitor-OUT

*

RFAGC

SCL1

3.3V-1

SDA1 SDA1

SCL1

5V2

1.8V-2

3.3V-1

5V2

32V

SD

A1

3.3Vstb

4

GN

D

SC

L1

5V

32V

*FROM FRONT BOARD

*

*

2 31

1.8V-2

GREENRED

5V-2

24.576MHzIF

M: H

IGH 3.3V-1

9V

*

Speaker Mute

S-Video IN Detect

1.8V-2

0V

5V

E1=S-Video

E1=CVBS

SA

W_S

W /

HM

LBG/I/DK

RA

GC

Rea

d In

/

Line Out Mute

System Select

* L

R

*

V-Out*

R-Out

CR

CB

V / Y

L-Out

**

*

* R

Y

C

* V

L

GN

D

23477609 HEAT SINK

ST

D B

Y

R O

UT

Connected To pin4 GND

VC

C

*

* *

*

L IN

GN

D

RIGHT3

4 VIDEO GND

R IN

SSIF

4VIDEO GND

VIDEO 5

9V

THAI BILINGUAL

1 LEFT

2 AUDIO GND

LEFT

AUDIO GND

RIGHT

1

3

2

5V25V-2

9V

MU

TE

L O

UT

RF

VIDEO5 NC

L Monitor-OUTL Monitor-OUT

R Monitor-OUTR Monitor-OUT

NC

**

*

*

R

V

L

2

5

3

4

8

6

7

BOUT

ROUT

GOUT

I-BLACK

GND

SVM

L/R P

HO

NO

JAC

K

GND1

29CZ5/6 21CZ6/7/8

21CZ6/7/8

*

*

270RS61~ RS62

HEAD PHONE JACKP661

LOCATION

GJ21 ~ GJ22 SHORT

KETSU

KETSU

21CZ6/7/8

KETSU

29CZ5/6

*

*

*

A

A

A

AA

23205354L

23205005L

23205204L

NE

W

W

2

1

NE

W

W

2

1

NE

W

W

2

1

NE

W

W

2

1

NE

W

W662

2

1

NE

W

W661

2

1

1Q610B

6-C8

2-A1,4-A2,6-C8

3-D3,5-A2

2-A1

5-B2

5-A2

4-B1

2-A1

3-A3

3-B3,6-B8

3-C3

2-A1

4-A1

3-A3

2-A1,3-A3,5-A2

2-A1,3-D3,6-C8

6-A8

6-E8

5-B2

12V_FBT

12V_FBT

6V

EW

GND_AUDIO

27V

9V

VGUARD

3.3V-1

3.3V-2

32V

VDR_A

FBP

6V

HDRIVE

VDR_B

PROTECT

EHT_INFO

5V2

GND

DEG

POWER

5V1

+

+

+

+

+

++

+

+

+

+

+

+

M

+

+

+

+

+

+

+

+

+

+

+

++

+ +++

+

+ +

+

+ +

+

+

M

+

+

++

+

+

+

M

+

+

+ +

+

+

M

+

+

+

+

47pF

KETSU

SHORT

1/6P1k

6.3V

470

PIN

KDS160-RTK/P

25V

220

1k

SHORT

KETSU

10V470

10V470

10V470

TEM2011AW

RM73B1HR00OD

1/6P2.2k

1/6P2.2k

35V1000

35V1000

16V47

16V10u

33u

16V10u

0.01

10u 1k

50V 1uF

1/8W1k

MTZJ5.1C

82K

1KKTC4075Y-RTK

KTC4075Y-RTK

50V 1uF

27K

1P

1/6P39

KTC4075Y-RTK

5.6K

470

SHORT

16V

22U

F

4.7k

KE

TS

U

4.7k

RMT SENSER

HOLDER

TLSG116

1M

B1000p

1k

B 6B-EH-A

100

KETSU

100K

KD

S16

0-R

TK

/P

KE

TS

U

10k

SHORT

KTC2875B-RTK

0.01

RN2404

1SS3551SS355

1/6P

4.7k

10u

50V0.22u

SHORT

25V10

25V0.022

25V10

0.01

0.1u

F

B1000p

KETSU

0.01uF

1.8K330K

0.001uF

KE

TS

U

KETSU

1SS

133

UD

ZS

TE

-17

5.6B

470

KETSU

0.01u

100100p 75

SHORT

100

100p 75SHORT

KTC4075Y-RTK

75

1000p

7547

K

1000p

1M

RM

73B

1H47

0JD

KETSU

1SS133

2SA1162-Y

KE

TS

U

100

B25V0.01

KETSU

KE

TS

U

KETSU

B1000p

B1000p

SHORT

1/6P180

1/6P1501/6P1.2k 1/6P4701/6P240

1/6P330

5B-EH-A

B 4B-EH-A

0.01

10K

75

1/6P15k

1/6P10k

1/6P4.7k

DTC114EUA

100

KETSU

25V0.1

1/6W-100ohm

2SA1037AKT

KETSU

25V47

100

6.8K

6.8K

100

50V0.001

100

50V0.001

12k

47pF

50V

4.7

2SC4116-Y

16V470

35V1000

0.22uF

10u

10u

10V100

10u

0.22uF

10V100

1K

2SC2712Y

100

12K

M50

1

100

15K

10u

25V0.1

25V0.1

25V0.1

0.22

uF

10u

25V0.1

10V100

0.1uF

0.22

uF

10u

1K

1SS355-TE17

10k

560p

100k

KTA2014Y

10u

0.22

uF

10u

100

10u

UO

C3

WIT

H S

OK

ET

B25V0.01

6.8k

2SA

1013

-R

1k

0.22

uF

10u

3.3k

B25V0.01B25V0.01

3k

0.22uH

10k

33750

10u 2SC

2712

Y

0.22

uF

0.22

uF

1/6P

15k0.

22uF

15k

10u

100

15k

25V

0.01

MT

ZJ2

.0A

SHORT 1/6P

10

1/6P

10

1/6P

47k

50V10u25V0.1

68p

KETSUSHORT

68p

100

56k

680

MT

ZJ5

.6A

MT

ZJ5

.6A

0.1u

F

50V

2.2

25V

0.1

50V

220 25

V10

1.2

25V0.1

10u

25V0.1

50V

0.47

u

25V

0.01

50V

0.47

u

25V

0.1

50V

0.47

u

25V

0.1

50V

0.47

u

16V10u

KETSU 10K

10u

100

100

50V

0.47

u

25V

0.1

50V

0.47

u

220

100

10K

10K

10K10K

10K

10K

10K

10K

10K

10K

10K

10K

25V0.1

0.01u

16V10u25V0.1

10u

5.74M 2.2k

390

100

50V

2.2u

50V

2.2u

47pF

100

100p

47pF

100p

47pF

100p

47pF

B33

00p

25V

0.1

25V

0.1

50V

10u

100

KE

TS

U

OP

EN

100p

47pF

47pF

47pF

47pF

100p

25V

1.5u

6800

p

12k

50V0.15u

27K

1M

220K

47K

47pF

47pF

100

25V0.001

39K 2%

25V0.1

2SA1162-Y

16V1uF

KTC4075Y-RTK

4.7k

25V0.1

10u

10.000M

0.1u

F

10V

100

12p

51p

DTC114EUA

1/6P

10

1/6P

10

1/6P

47k

2SA

1013

-R

2SC3357

TC

F11

20A

M

2SC

2712

Y

0.22

uF

1.0 330

1.0

3333

10u

B25V0.01

TC

F11

07

2.7k

MA77

100

100

KETSU820

100

4722

0

0.1uF

2SA

1162

-Y

16V

47

220 10

k

270

22K 2SC

2712

Y

68p

68p

4.7k

4.7k

2SC2712Y

1k3.

3k

B1000p

RD

33

50V

10B25

V0.

01

50V

220

PLUG 4P

50V

220

TLN3278GH

3.3k

3.3k

1000p

4P JACK

SHORTSHORT

SHORT

75

SHORT

100

2SC3326B

1000p

47K

SHORT

100p

1000p

47K

SHORT

RN2404

KETSU

KETSU

OP

EN

OP

EN

KE

TS

U

KE

TS

U

SHORT

1/2R270

1/2R270

2SC3326B

MTJ-032-39BBA-432 NILF

2.2K

KTC4075Y-RTK

16V10

KTC2875B-RTK

KTC2875B-RTK

50V1.0

KETSUKETSU

2.2k

10k

100k 16V47

Open

10k

1SS355

1SS355

1SS355

1SS355

KETSU

2.7k

50V

2.2

AN5277

OPEN

10K

M50

1

10K

50V

100

50V1.0

100K

10K

50V0.47

KETSU

2.7k

KETSU

2.2k

1SS355

1/6P10k

1SS355

1SS355

SHORT

50V

2.2

1SS355

25V

0.01

50V0.1

2.2 2.2

50V0.1

1K

KTC2875B-RTK

SHORT

100K

100K

PLUG 8P

2.2K

560

OPEN

16V22

16V10

100

22p

1000p100pSHORT

100SHORT

SHORT

SHORT

SHORT

SHORT

47K

1000pSHORT

1000p1k

100100p

22p22p

SHORT10V470

SHORT

47K

1k

75100

SHORT

1000p

SHORT

47K

100p

SHORT

1000p

100

1KSHORT

SHORT

CS14

L109

C140

RB49

C50

1

TP15

TLA0119

TLA0118

TLA0117

D4703

C47

03

R413

GJ47

GJ48TLC0193

C129

C505

C507

CC20

GL601

GJ811

R683

R681

C681

C683

C684

CB07

TLC0278

LA01

CA01

CA

97

GJ17

C105

Z10

1

LA14

R318

C212

R452

D450

R451

R453Q451

Q450

C450

R450

M804A

TLA0115TLA0114TLA0112

TLA0111 TLA0110 TLA0109 TLA0108

R107

Q401

R435

R440

R437

C43

5

GJ02

C11

1

GJ01

KB01

Q610A

DB02ADB02

DB01

R4720

C4717

RB

15

PA21B

GJ22

GJ21

R4200

C120

R42

4

DA

121

C49

7

R425

GJ401

QS03

CS04

QS05

D502D501

RA

21

L501

C203

R119

C204

C205

CA14

C475

C50

2

C401

R461 C4712

R212R214

C219

R48

1

C499

DA

120

DA

119

R121

C130

C142

M502A

RV08CV04

RV

07

LC13

RV10

CV05 RV09

LC14TLC0233

QS01

RV11

CC05RV

05

RS

03CC04

M502B

R40

1

RB

10

D203

D202

Q210

R48

2

R426

C131

Q461

R48

4

R498

C666C662

D684

SA03

RB03

SA01 SA02

RB02RB01

TLC09 TLC10

SA04

RB06RB04 RB05

TLC11

SA06SA05

P107

P601A

CA

120

TLC0348TLC0347

TLC0346

TLC0345

TLC0343

TLC0340

TLC0339

TLC0338

TLC0337

TLC0336

TLC0335

TLC0334

TLC0333

TLC0332

TLC0349

TLC0330

TLC0329

TLC0328

TLC0326

TLC0325

TLC0324

TLC0323

TLC0322

TLC0321

TLC0320

TLC0319

TLC0318

TLC0312

TLC0314

TLC0311

TLC0302

TLC0301

TLC0300

TLC0299

TLC0298

TLC0297

TLC0295

TLC0294

TLC0293TLC0291

TLC0290

TLC0289

TLC0313

TLC0286

TLC0285

TLC0283 TLC0282TLC0281TLC0280

TLC0279

TLC0275

TLC0274

TLC0273

TLC0272

TLC0271

TLC0185TLC0184

TLC0183TLC0182TLC0181TLC0189TLC0188

TLC0187TLC0186

R62

0

TLC0270

TLC0269

TLC0268

TLC0267

TLC0266

TLC0265

TLC0264

TLC0262

TLC0261TLC0260

TLC0259

TLC0258

TLC0257TLC0256

TLC0255 TLC0254

TLC0250

TLC0249

RV

03

TLC0248

TLC0246

TLC0245

TLC0244 TLC0243 TLC0242

TLC0241

TLC0238

TLC0237

TLC0236

TLC0235

TLC0234

TLC0232

TLC0231

TLC0230

TLC0228

TLC0226

TLC0225

TLC0223

TLC0222

R117

R110

RA17

Q108

R118

GJ14

CA30

RV15

QV02

RV13CV08

RV16

G103

C10

4

L112

R329

R328

R325

C327

R320

C329Z10

2

GJ05

GJ06

GJ03

GJ07

GJ04

R124

CS15

C10

1

TLA0054

Q102

C671

C682

CA96

LA96

L504

CA92

LA93

CA88

CA89

R702

Q701

R431

R409

M501B

RA36

RA33

L503

C506

C206

C508

CA

90

LA88

C211

CA94

CA95

CA

93

LA90

R502

D674

R674

C509

R675

Q670

LA94

CA

110

LA11

0

RA

35

LA10

1

QA

51

C103

R10

2 QA

15

R10

9

CA

124

LA124

R11

3

C102

C114

R11

1L101

R112R10

6

R10

5

LA03

QA

14

CA

03

CA

101

RA

32

CA

116

RA34

RA

106

LA11

7

RA

105

RA

31

RA30

C11

6

DA

118

L158 RA

15

RA

14

RA

16

C158 C159

CA

108

D104R115

CA

109

R116

R125

R126

DA

111

DA

110

CA

118

CA

119 CA

31

CA

117

CA

112

L103

CV14

L102

C128

CS

07

CV

12 CS

09

CV

10

CS

08

CV

09

CS

06

C503

R123 R501

L502

RS

33

RS

34CS

10

CV

11CS

11

R142

R140

RS21

RS23

RS24RS20

RS27

RS26

RS25

RS32

RS29

RS31

RS28

RS30

C504

C141

C144

C145L110

Z104 R141

R12

2

R70

1C12

5

C12

7

CS

16

RV

19

CV

16

CS

18

CV

18

CS

19

CV

17

CS

17

C12

3

C12

4

C12

2

C12

1

RS36

C12

6

R70

3

CV

20

CS

23

CS

22

CS

20

CS

21

CV

19

C20

2 C20

1

R20

1

C350

R4718

R4717

R219

R4716

CS

13

CS

12

RS35

C432

R350

TLC0213

TLC0216

TLC0214

CV13

Q473

C430

Q472

R412

CV15

LA05

XA03

CA

05

CA

06C15

6

C15

7

Q107

RA

20

RA

19

RA

18

QA

17

Q101

Z15

5

QA

16

CA

04

L157 R15

2

L156

R104R101

LA04

C106

Z15

4

R10

3

D103

R504

R505

D473R108

R503

R70

4

TLC0215

R70

5

CA91

QB

02

CB

01

RB

13

RB

11

RB

12

RB14

QB

01

QA

10

TLC0218

TLC0217

CA

99

CA

98

RA

99

RA

98

TLC0219

QB04

RB

08

TLA0099

RB

09

H001

LC05

TLA0053

C107

SL1D10

1

C10

8

CC

01

C11

0

LC04

PB01

TLA0004

TLA0006


C10

9

L104

RA

108

RA

109

CC07

PV01

LC17RC06

RC08

RV

17

RC07

RV18

Q614

CC09

RS

08LC19

CV07

CC08

RS

07LC18

Q613 R618

R617

CC

31

CC

30

P661

TLA0069

TLA0068

LC01

CC

33

CC

32

LC02

LC03

RS62

RS61

Q615

PV02

TLC0179

TLA0104

TLA0105

TLA0107

TLC0221

RS

13

QS02

CS02

Q671

Q672

C664

C665R665

R664

R672

R673 C672RJ03

R671

D672

D671

D673

D670

C670

R66

6

TLC0033

C66

3

Q610

RJ02

RS16

M501A

RS17

TLC0024 TLC0028

C69

0

TLC0209

TLC0208

TLC0211

TLC0212

TLC0210

C660

RS

18

RS19

CS05

R661

R66

2

C661

R660TLC0020

D681

R621

D683

D680

GJ13

C66

7

D682

CC

14

C686

R686 R687

C687

RS06

QS04

LC20

RS

14

RS

15

P902A

TLC0195

TLA0098

RS

12

RS09

RJ01

CS03

CS01

RS10

C512

CC03

CV02LC09

RV04LC08

LC12

LC10

RC01

LC07

RS

01

CC02LC06

CV22

RV22 RV06CV03

C511C510

LC15CV06

RC04

RS

04

RV21

RV

01RV02

TLC0168

TLC0166

TLC0171

TLC0161

TLC0160

TLC0159

TLC0162

TLC0163

TLC0164

TLC0175

TLC0176

RC03

CV21

RC02

RS

02

CV01

LC11

CC06

RS11

RS05LC16

RC05

TLC0180

10876

5 4 3 2 1

5 4

3 2 1

Vcc

GN

D

VO

UT

P2.

1/P

WM

0

P2.

0/P

MW

VD

DP

(3.3

V)

P1.

7/S

DA

P1.

6/S

CL

P1.

3/T

1

P0.

0/2S

DI1

P0.

1/12

SD

01

P0.

2/12

SD

02

P0.

3/12

SC

LK

P0.

4/12

SW

S

VS

SC

2

VSSadc

VD

DC

2

P1.

1/T

O

P1.

0/IN

T1

INT

O/P

0.5

GNDA

VDDA

(1.8V)

(3.3V)

VDDA2

VD

Dad

c(1.

8)

VREFAD

VREFAD_POS

VREFAD_NEG

VDDA1(3.3V)

BO

GO

RO

BLKIN

BCLIN

VP3

GND3

R

BB/P IN3

R/P IN3

G/YIN3

INSSW3

VOUT(SW01)

UOUT(INSW-2)

YOUT

YSYNC

R

B

YIN(G/Y-2/CVBS/Y-X)

UIN(B/P -2)

VIN(R/P -2/C-X)

VDDcomb

/CSY

combVSS

AU

DO

UT

HP

L

AU

DO

UT

HP

R

CV

BS

O/P

IP

SVM

HOUT

FBISO

AU

DO

UT

LSR

AU

DO

UT

LSL

C2/

C3

CV

BS

3/Y

3

AU

DIO

IN3R

AU

DIO

IN3L

CV

BS

2/Y

2

AU

DIO

IN2R

/SS

IF

AU

DIO

IN2L

C4

CV

BS

4/Y

4

AU

DIO

IN4R

AU

DIO

IN4L

SV

O/IF

OU

T/C

VB

SI

VP

2

DV

BO

/FM

RO

AG

C2S

IF

VC

C8V

DV

BO

//IF

VO

/FM

RO

SIF

AG

C/D

VB

AG

C

AM

OU

T/Q

SS

O

GN

D2

PLL

IF

/AU

DE

EM

DE

CS

DE

M

AU

DIO

UT

SR

AU

DIO

IN5R

AU

DIO

UT

SL

AU

DIO

IN5L

AV

L/S

WO

/SS

IF

RE

FIN

/RE

FO

UT

EHTO

AGCOUT

/SIFIN2

DVBIN2

GNDIF

/SIFIN1

DVBIN1

IREF

VSC

VIFIN2

VIFIN1

VDRA

VREF_POS_HPR

VREF_NEG_HPL+HPR

VREF_POS_LSR+HPL

VREF_NEG_LSL+LSR

VREF_POS_LSL

VDDA3(3.3V)

VGUARD/SWIO

AVL/EWD

SECPLL

DECIDG

DECBG

GND1

VDRB

VP1

VSSA1

PH1LF

PH2LF

XTALOUT

XTALIN

VSSC4

VSSP2 P1.

4/R

X/TX

P1.

5

VDDC4

P2.

2/P

WM

1

P2.

3/P

WM

2

P3.

0/A

DC

0

P3.

1/A

DC

1

VD

DC

1(1.

8)

DE

CV

1V8

P3.

2/A

DC

2

P3.

3/A

DC

3

VS

SC

1/P

P2.

4/P

WM

3

P2.

5/P

WM

4

VD

DC

3

VS

SC

3

P1.

2/IN

T2

109

11

126

128

127

125

41

23

56

87

8687

92

117

115

112

98 9799107

106

102

100

101

103

104

105

108

109

110

111

96

113

114

95

116

9394

119

118

8890

9189

123

124

120

122

121

3433 35 36

1315

1819

2024

2829

3132

3027

2625

2322

2116

1714

12

7978

51

77

55 60 61 63 64

7572

7167

6566

6869

7073

7476

6256 57 59585453525048 4943 44 4745 46

8180

4137 38 4039 42

8582

8483

M

A2

GN

D

VD

D

WP

SD

A

SC

L

85 76

24 3 1

A1

AG

C

1 3 5 7 10 1198642

SD

A

NC

AD

R

SC

L

32V

NC

1F5V NC

Vt

2 4 76 109 12118531

1

2

3

4

B 4B-EH-A

TLA0119

TLA0118

TLA0117

P601A

29CZ5DE/29CZ5T/29CZ6SIMAIN (SIGNAL/MICON) [SHEET-1/6]

SCHEMATIC DIAGRAM MODEL : 29CZ5DE/29CZ5T/29CZ6SI (1/8)

A

B

C

D

E

F

1 432

IFSC

L

SD

A

KETSU

SHORT

SHORT

23221141

23221139

(RA)

(RB)

TRF9240AC

TRF9240AH

RC17 ~ RC18 (FRONT)

(MAIN)

10nF

LC04 ~ LC06

CC36 ~ CC37

RC01 ~ RC06

RUSSIA MODEL

1k

OTHER MODEL

NOT USED

USED

PRE AMP

SHORT

KETSU

GJ17

KETSU

(RC)

(RA)

(RB)

Q107 ~ Q108

DTC114EUA

SRC1202U

KRC402

KETSU

KETSU

(RB)

3KR111

(RA)D103

MA77

KDS114

THAIMULTI

BILINGUALLOCATION

10K

15K

10K

3.3K

100R

R117

R112

R110

R113

R118

KETSU

KETSU

KETSU

KETSU

KETSU

KETSUKETSU(R1)AV STEREO TSF6380Y

K6284K K9351K(RB)(RB)

KETSU SHORT KETSU KETSU SHORT

KETSUKETSU SHORT KETSUSHORT

*M*, *R*

MODEL

MONO BILINGUAL

15p

KETSU

CC20

K2964M

OTHER MODELS KETSU

KETSU SHORTKETSU SHORT KETSU

KETSUKETSU SHORT KETSUKETSU

(R2) K6269K

F816K(R3) KETSU

KETSU

KETSU

KETSU

SHORT

(RA)NICAM SHORT10nF

GJ03C104

SHORTKETSU

GJ05GJ04

(RA)

Z101

BSF6284 BSF9351

Z102 GJ06

KETSU KETSU

GJ07

[29CZ5 MODELS]

[21CZ6~8 MODELS]

LOCATION

ENV59DA7G3

OTHER MODELLOCATION RUSSIA MODEL VIETNAM MODEL

ENV59DA7G3 23321549(R1)H001 23321514 23321514115B8A86ST

100R

SHORT

(RA)

(RB)

LC01 ~ LC03

(RB)

(RA)

(RA)

(RB)

1k

G103

LC04

LC05

RC01 ~ RC08

LOCATION

CC32 ~ CC33 KETSU

SHORT

10nF

TRF9240AC23221141

23221139 TRF9240AH

RUSSIA MODEL

23103279

23103249

23103894

23103248

(R1)

SHORT

(R3)

(R2)

(R2)

(R3)

TEM2011AA

TEM2014AO

TEM2011AO

TEM2014AA

SHORT

OTHER MODEL

23321534

23321545

100R

100R

SHORT

TAEM-G107D

ENV59K11G3F

32V

*

*

*

A

5-A2

2-A1,3-D3,6-C8

3.3V-2

GND

+

++

+

PIN

TEM2011AW

RM73B1HR00OD

4.7k

KE

TS

U

4.7k

12k

50V

4.7

KETSUSHORT

56k

68012

1.0

B1000p

RD

33

50V

10B25

V0.

01

50V

220

50V

220

TLN3278GH

TP15

GL601

GJ811

GJ02

C11

1

GJ01

TLC0285

TLC0222

R124

C10

1

TLA0054

D104R115

R125

R126

H001

LC05

TLA0053

C107

SL1D10

1

C10

8

CC

01

C11

0

LC04

TLA0004

TLA0006


C10

9

L104

AG

C

1 3 5 7 10 1198642

SD

A

NC

AD

R

SC

L

32V

NC

1F5V NC

Vt

8765

3.3V-2

SAW_SW

1.8V-2

1.8V-1

1.8V-1

IF

AGC

*

*

*

*

29CZ5/6

6 5 4 3 12

KE

Y

GN

D

3.3V-1LE

D

RE

MO

TE

5V-1

9V

*

* *

*

*

*

4 3 2 1

RFAGC

SCL1

3.3V-1

SDA1 SDA1

SCL1

5V2

1.8V-2

3.3V-1

5V2

GN

D

SC

L1

32V

FROM FRONT BOARD

21

5V-2

24.576MHzIF

M: H

IGH 3.3V-1

9V

Speaker Mute

S-Video IN Detect

0V

5V

E1=S-Video

E1=CVBS

SA

W_S

W /

HM

LBG/I/DK

RA

GC

Rea

d In

/

Line Out Mute

System Select

A

A

A

AA

+

M

+

+

+

+

++

+

+

6.3V

470

10u 1k

1P

1/6P39

B 6B-EH-A

KETSU

1/6P

4.7k

10u

50V0.22u

25V10

25V10

0.01

0.1u

F

0.011/6P15k

1/6P10k

1/6P4.7k

DTC114EUA

100

KETSU

25V0.1

0.22

uF

10u

100

UO

C3

WIT

H S

OK

ET

B25V0.01

6.8k

2SA

1013

-R

1k

0.22

uF

10u

3.3k

B25V0.01B25V0.01

3k

0.22uH

10k

33750

10u 2SC

2712

Y

0.22

uF

1/6P

15k0.

22uF

15k

10u

100

15k

25V

0.01

MT

ZJ2

.0A

SHORT 1/6P

10

1/6P

10

1/6P

47k

50V10u25V0.1

68p

68p

100

MT

ZJ5

.6A

0.1u

F

50V

2.2

25V

0.1

50V

220 25

V10

1.2

25V

1.5u

6800

p

12k

10u

10.000M

0.1u

F

10V

100

12p

51p

DTC114EUA

1/6P

10

1/6P

10

1/6P

47k

2SA

1013

-R

2SC3357

TC

F11

20A

M

2SC

2712

Y

0.22

uF

1.0 330

1.0

3333

10u

B25V0.01

TC

F11

07

2.7k

MA77

KETSU820

B1000p

RD

33

PLUG 4P

50V

220

3.3k

3.3k

C50

1

CC20

GJ17

C105

Z10

1

LA14

R318

M804A

TLA0111 TLA0110

R107

PA21B

C120

RA

21

L501

C203

C204

C205

CA14

C475

C50

2

CA

120

TLC0329

TLC0328

TLC0326

TLC0325

TLC0324

TLC0323

TLC0322

TLC0321

TLC0320

TLC0319

TLC0318

TLC0299

TLC0298

TLC0297

TLC0295

TLC0294

TLC0293TLC0291

TLC0290

TLC0289

TLC0313

TLC0286

TLC0285

TLC0283 TLC0282TLC0281TLC0280

R117

R110

RA17

Q108

R118

GJ14

CA30

G103

L112GJ05

GJ03

GJ07

GJ04

CA

110

LA11

0

RA

35

QA

51

C103

R10

2 QA

15

R10

9

CA

124

LA124

R11

3

C102

C114

R11

1L101

R112R10

6

R10

5

LA03

QA

14

CA

03

RA

32

CA

116

RA34

RA

106

LA11

7

RA

105

RA

31

RA30

C11

6

DA

118

L158 RA

15

RA

14

RA

16

C158 C159

CA

108

CA

109

R116

DA

110

CA

118

CA

119 CA

31

CA

117

CA

112

L103

C20

2 C20

1

R20

1

LA05

XA03

CA

05

CA

06C15

6

C15

7

Q107

RA

20

RA

19

RA

18

QA

17

Q101

Z15

5

QA

16

CA

04

L157 R15

2

L156

R104R101

LA04

C106

Z15

4

R10

3

D103

D473R108

C107

SL1D10

1

PB01

TLA0013

RA

108

RA

109

10876

5 4 3 2 1

P2.

1/P

WM

0

P2.

0/P

MW

VD

DP

(3.3

V)

P1.

7/S

DA

P1.

6/S

CL

P1.

3/T

1

P0.

0/2S

DI1

VREF_POS_HPR

VREF_NEG_HPL+HPR

VREF_POS_LSR+HPL

VREF_NEG_LSL+LSR

VREF_POS_LSL

VDDA3(3.3V)

VGUARD/SWIO

SECPLL

DECIDG

DECBG

GND1

VP1

VSSA1

PH1LF

PH2LF

XTALOUT

XTALIN

VSSC4

VSSP2 P1.

4/R

X/TX

P1.

5

VDDC4

P2.

2/P

WM

1

P2.

3/P

WM

2

P3.

0/A

DC

0

P3.

1/A

DC

1

VD

DC

1(1.

8)

DE

CV

1V8

P3.

2/A

DC

2

P3.

3/A

DC

3

VS

SC

1/P

P2.

4/P

WM

3

P2.

5/P

WM

4

VD

DC

3

VS

SC

3

P1.

2/IN

T2

109

11

126

128

127

125

41

23

56

87

117

115

112

107

106

108

109

110

111

113

114

116

119

118

123

124

120

122

121

1315

1819

2016

1714

12

11

1F

SCHEMATIC DIAGRAM MODEL :

1211109

PIC-TB19

5V1

5V-1

1.8V-2

3.3V

-1

1.8V-1

21CZ6/7/8

21CZ7 ONLY

21CZ6/8

4

3

2

1

KE

Y

CH UP MENUVOL DNCH DN VOL UP VIDEO

NC

4

SD

A

5

SC

L

13

5V1

2

GN

D

*

**

E2-

DV

D IN

*

SD

A1

3.3Vstb

4

GN

D

SC

L1

5V

2 31

1.8V-2

GREENRED

*

1.8V-2

*

+

+

+

+

+

+

+

1/6P1k

10V470

16V10u

33u

16V10u

0.01

RMT SENSER

HOLDER

TLSG116

1k

1SS

133

UD

ZS

TE

-17

5.6B

RM

73B

1H47

0JD

1/6P180

1/6P1501/6P1.2k 1/6P4701/6P240

1/6P330

5B-EH-A

75

0.22uF

10u

10u

10V100

10u

0.22uF

10V100

25V0.1

0.22

uF

10u

25V0.1

10V100

0.1uF

0.22

uF

10u

1K

560p

10u

10u

0.22

uF

68p

MT

ZJ5

.6A

MT

ZJ5

.6A

25V0.1

25V0.1

25V0.1

100

100

100

0.1uF

2SA

1162

-Y

16V

47

220 10

k

270

22K 2SC

2712

Y

68p

68p

4.7k

4.7k

2SC2712Y

1k3.

3k

G 4P

3.3k

22p

1000p100pSHORT

100SHORT

SHORT

SHORT

47K

1000pSHORT

22p22p

1k

100

1000p

SHORT

47K

100p

RB49

C507

CB07

TLC0278

LA01

CA01

CA

97


TLA0111 TLA0110 TLA0109 TLA0108

KB01

DB02ADB02

DB01

RB

15

DA

120

DA

119

M502B

RB

10

SA03

RB03

SA01 SA02

RB02RB01

TLC09 TLC10

SA04

RB06RB04 RB05

TLC11

SA06SA05

P107

TLC0346

TLC0345

TLC0343

TLC0279

TLC0250

TLC0249

RV

03

TLC0223

CA96

LA96

L504

CA92

LA93

CA88

CA89

C508

CA

90

LA88

C211

CA94

CA95

CA

93

LA90

R502

C509

LA94

LA10

1

CA

101

RA

106

RA

105

CA

108

DA

111

DA

110

CA

112

CV14

CV13

CV15

R504

R505

R503

CA91

QB

02

CB

01

RB

13

RB

11

RB

12

RB14

QB

01

QA

10

TLC0218

TLC0217

CA

99

CA

98

RA

99

RA

98

TLC0219

QB04

RB

08

TLA0099

RB

09

PB01

RA

108

C512

CC03

CV02LC09

RV04LC08

RC01

LC07

RS

01

CC02LC06

C511C510

RV2

RV02

CV21

RC02

RS

02

CV01

5 4

3 2 1

Vcc

GN

D

VO

UT

P1.

6/S

CL

P1.

3/T

1

P0.

0/2S

DI1

P0.

1/12

SD

01

P0.

2/12

SD

02

P0.

3/12

SC

LK

P0.

4/12

SW

S

VS

SC

2

VSSadc

VD

DC

2

P1.

1/T

O

P1.

0/IN

T1

INT

O/P

0.5

GNDA

VDDA

(1.8V)

(3.3V)

VDDA2

VD

Dad

c(1.

8)

VREFAD

VREFAD_POS

VREFAD_NEG

VDDA1(3.3V)

BO

GO

RO

BLKIN

BCLIN

VP3

GND3

R

BB/P IN3

R/P IN3

G/YIN3

INSSW3

8687

92

98 9799107

106

102

100

101

103

104

105

108

9695

9394

8890

9189

7978

7781

8085

8284

83

M

A2

GN

D

VD

D

WP

SD

A

SC

L

85 76

24 3 1

A1

EL : 29CZ5DE/29CZ5T/29CZ6SI (1/8)

F

E

D

C

B

A

16151413

DEG

12V_FBT

E1 S-VIDEO

* R

Y

C

2

5

3

4

8

6

7

BOUT

ROUT

GOUT

I-BLACK

GND

SVM

GND1

6-A8

6-E8

5-B2

12V_FBT

DEG

POWER

5V1

SHORT

KETSU

4P JACK

PLUG 8P

1k

75100

1000p

SHORT

47K

100p

GJ47

GJ48TLC0193

TLC0223

PV01

P902A

TLC0195

TLA0098

RV21

RV

01RV02TLC0161

TLC0160

TLC0159

TLC0162

TLC0163

TLC0164

CV21

RC02

RS

02

CV01

G

H

I

J

L

K

1 2 3 4

47pF

KETSU

10nFKETSU

(RC)

(RA)

(RB)

KETSU

Q107 ~ Q108

C140

DTC114EUA

SRC1202U

KRC402

C141

1k

2.2k

100R

R141 KETSU

R123

R142

KETSU

KETSU

KETSU KETSU

KETSU 100R

C130

R140

KETSU (RA)

KETSU

(RC)

(RB)

Q102

Z104

KETSU

KETSU

10uH

12uHL109

L110

2SC4116Y

2SC4081T

EFCS5R74Y5ST

KTC4075Y

C142 10nFKETSU

C145

C144 10uF

100nF

KETSU

KETSU

15K

100R

R117

R118 KETSU

KETSU

23103302(RB)

(RA) 23103308G106 ~ G109 KETSUTEM2011AO

TEM2011AH

KETSU

23248386(RB)

RUSSIA MODEL

(RA) 23248423

TLN3481AA

OTHER MODEL

KETSUTLN3481AC

23248417(RB) TLN3481AH

LOCATION

G104 ~ G105

[21CZ6~8 MODELS]POWER (MAIN BOARD)

SHORTGJ32 ~ GJ43

(This Ground is c

(ABL)

EHT

3-D3,5-A2

2-A1

5-B2

5-A2

4-B1

2-A1

3-A3

3-B3,6-B8

3-C3

2-A1

4-A1

3-A3

2-A1,3-A3,5-A2

12V_FBT

6V

EW

9V

VGUARD

3.3V-1

3.3V-2

32V

VDR_A

FBP

6V

HDRIVE

VDR_B

PROTECT

EHT_INFO

5V2

+

82K

KTC

K

50V 1uF

27K

4

100K

KD

S16

0-R

TK

/P

10k

KETSU

KE

TS

U

KETSU

KE

TS

U

16V1uF

KTC407

4.7k

R451

Q

C450

R450

R4

R42

4

DA

121

R425

R461

R48

1

R48

2

Q461

R48

4

C430

Q472

R412

5 6 7 8

9V

*

(This Ground is connected to UOCIII Pin 81)

*

*

*

*

*

*

2

5V-2

15 34

Video Monitor OUT

E1 IN

Audio

Monitor OUT

E2 IN

8V

SSIF

9V

THAI BILINGUAL5V25V-2

9V

L Monitor-OUT

R Monitor-OUT

A

+

+

+

+

M

+

+ +++

++

+ +

+

+

M

47pF

KETSU

SHORT

KDS160-RTK/P

25V

220

1k

10V470

50V 1uF

1/8W1k

MTZJ5.1C

82K

1KKTC4075Y-RTK

KTC4075Y-RTK

KTC4075Y-RTK

5.6K

470

SHORT

16V

22U

F

1M

B1000p

100

KETSU

100K

KD

S16

0-R

TK

/P

KE

TS

U

SHORT

1SS3551SS355

50V0.22u

SHORT

25V10

25V0.022

B1000p

KETSU

0.01uF

1.8K330K

0.001uF

KE

TS

U

KETSU

470

KETSU

0.01u

1M

KETSU

1SS133

2SA1162-Y

KE

TS

U

100

B25V0.01

TSU

KE

TS

U

KETSU

6.8K

6.8K

100

50V0.001

100

50V0.001

47pF

2SC4116-Y 10u

25V0.1

50V

0.47

u

25V

0.01

50V

0.47

u

25V

0.1

50V

0.47

u

25V

0.1

50V

0.47

u

16V10u

KETSU 10K

10u

220

100

10K

10K

10K10K

10K

10K

10K

10K

10K

25V0.1

0.01u

16V10u25V0.1

10u

5.74M 2.2k

390

50V

2.2u

50V

2.2u

47pF

100

100p

47pF

100p

47pF

100p

47pF

B33

00p

25V

0.1

25V

0.1

50V

10u

100

KE

TS

U

47pF

25V

1.5u

6800

p

12k

50V0.15u

27K

1M

220K

47K

47pF

47pF

100

25V0.001

39K 2%

2SA1162-Y

F

KTC4075Y-RTK

4.7k

CS14

L109

C140

D4703

C47

03

R413

C129

C212

R452

D450

R451

R453Q451

Q450

Q401

R435

R440

R437

C43

5

R4720

C4717

R4200

C120

DA

121

C49

7

GJ401

D502D501

C203

R119

C204

C205

C401

R461 C4712

R212R214

C219

R48

1

C499

R121

C130

C142

R40

1

D203

D202

Q210

R48

2

R426

C131

R48

4

R498

TLC0340

TLC0339

TLC0338

TLC0337

TLC0336

TLC0335

TLC0334

TLC0333

TLC0332

TLC0349

TLC0330

TLC0329

TLC0328

TLC0312

TLC0314

TLC0311

TLC0302

TLC0301

TLC0300

TLC0299

C10

4

L112

R329

R328

R325

C327

R320

C329Z10

2

GJ05

GJ06

GJ03

CS15

Q102

L102

C128

CS

07

CV

12 CS

09

CV

10

CS

08

CV

09

CS

06

C503

R123 R501

L502

R142

R140

RS21

RS23

RS24RS20

RS27

RS26

RS25

RS28

RS30

C504

C141

C144

C145L110

Z104 R141

R12

2

C12

5

C12

7

CS

16

RV

19

CV

16

CS

18

CV

18

CS

19

CV

17

CS

17

C12

3

C12

4

C12

2

C12

1

RS36

C12

6

CS

C20

2 C20

1

R20

1

C350

R4718

R4717

R219

R4716

CS

13

CS

12

RS35

C432

R350

Q473

0

Q472

R412

CV

BS

2/Y

2

AU

DIO

IN2R

/SS

IF

AU

DIO

IN2L

C4

CV

BS

4/Y

4

AU

DIO

IN4R

AU

DIO

IN4L

SV

O/IF

OU

T/C

VB

SI

VP

2

DV

BO

/FM

RO

AG

C2S

IF

VC

C8V

DV

BO

//IF

VO

/FM

RO

SIF

AG

C/D

VB

AG

C

AM

OU

T/Q

SS

O

GN

D2

PLL

IF

/AU

DE

EM

DE

CS

DE

M

AU

DIO

UT

SR

AU

DIO

IN5R

AU

DIO

UT

SL

AU

DIO

IN5L

AV

L/S

WO

/SS

IF

RE

FIN

/RE

FO

UT

EHTO

AGCOUT

/SIFIN2

DVBIN2

GNDIF

/SIFIN1

DVBIN1

IREF

VSC

VIFIN2

VIFIN1

VDRA

AVL/EWD

SECPLL

DECBG

GND1

VDRB

PH1LF

3433 35 36

1819

2024

2829

3132

3027

2625

2322

211

51 555453525048 4943 44 4745 464137 38 4039 42

9 10 11 12

Connected To pin9 Aud

2

4

3

1

*

Speaker Mute

Line Out Mute

9V

27V

Audio GND

*

*

*

*

*

*

5V-2

E2-CVBS 0V

E2-DVD

DVD IN Detect

5V

5V-2

E2-

DV

D IN

5V-2

E3 INE2 IN

L Monitor-OUT

R Monitor-OUT

*

*

*

*

GN

D

23477609 HEAT SINK

ST

D B

Y

R O

UT


VC

C

*

*

L IN

GN

D

RIGHT3

4 VIDEO GND

R IN

4VIDEO GND

VIDEO 5

1 LEFT

2 AUDIO GND

LEFT

AUDIO GND

RIGHT

1

3

2

MU

TE

L O

UT

RF

VIDEO5 NC

L Monitor-OUT

R Monitor-OUT

NC

23205354L

23205005L

23205204L

1Q610B

+

++

+

+

+

+

++ + +

+

+

M

+

+

+ +

+

+

M

+

+

+

+

10V470

1/6P2.2k

1/6P2.2k

35V1000

35V1000

16V47

KTC2875B-RTK

0.01

RN2404

100100p

SHORT

100

100p 75SHORT

KTC4075Y-RTK

75

1000p

7547

K

1000p

B1000p

B1000p

SHORT

10K

75

1/6W-100ohm

2SA1037AKT

KETSU

25V47

100

16V470

35V1000

1K

2SC2712Y

100

12K

M50

1

100

15K

10u

25V0.1

25V0.1

1SS355-TE17

10k

100k

KTA2014Y

25V0.150

V0.

47u

25V

0.1

50V

0.47

u

100

100

50V

0.47

u

25V

0.1

50V

0.47

u

10K

10K

10K

10K

10K

10K

10K

100

47F

100p

47pF

OP

EN

100p

47pF

47pF

47pF

47pF

100p

25V0.1

25V0.1

4722

0

1000pS

10

1000pSHORT

100p

1000pSHORT

RN2404

KETSU

KETSU

2.2K

KTC4075Y-RTK

16V10

KTC2875B-RTK

KTC2875B-RTK

50V1.0

KETSUKETSU

2.2k

10k

100k 16V47

Open

10k

1SS355

1SS355

1SS355

1SS355

KETSU

2.7k

50V

2.2

AN5277

OPEN

10K

M50

1

10K

50V

100

50V1.0

100K

10K

50V0.47

KETSU

2.7k

KETSU

2.2k

1SS355

1/6P10k

1SS355

1SS355

SHORT

50V

2.2

1SS355

25V

0.01

50V0.1

2.2 2.2

50V0.1

1K

KTC2875B-RTK

SHORT

100K

100K

2.2K

560

OPEN

16V22

16V10

100

1000p100pSHORT

100SHORT

SHORT

SHORT

1000p1k

100100p

10V470

SHORT

SHORT

47K

SHORT

1000p

100

1K S

C505

R683

R681

C681

C683

C684

Q610A

QS03

CS04

QS05

M502A

RV08CV04

LC13

RV10

CV05 RV09

LC14TLC0233

QS01

RV11

CC05RV

05

RS

03CC04

C666C662

D684

TLC0348TLC0347

TLC0343

TLC0275

TLC0274

TLC0273

TLC0272

TLC0271

TLC0185TLC0184

TLC0183TLC0182TLC0181TLC0189TLC0188

TLC0187TLC0186

R62

0

TLC0270

TLC0269

TLC0268

TLC0267

TLC0266

TLC0265

TLC0264

TLC

TLC0261TLC0260

TLC0259

TLC0258

TLC0257TLC0256

TLC0255 TLC0254

TLC0250

RV

03

TLC0248

TLC0246

TLC0245

TLC0244 TLC0243 TLC0242

TLC0241

TLC0238

TLC0237

TLC0236

TLC0235

TLC0232

TLC0231

TLC0230

TLC0226

TLC0225

RV15

QV02

RV13CV08

RV16

C671

C682

R702

Q701

R431

R409

M501B

RA36

RA33

L503

C506

C206

D674

R674

R675

Q670

CV14C

S09

CV

10

CS

08

RS

33

RS

34CS

10

CV

11CS

11

RS27

RS25

RS32

RS29

RS31

RS28

RS30

R70

1

CS

18

CV

18

CS

19

R70

3

CV

20

CS

23

CS

22

CS

20

CS

21

CV

19

TLC0213

TLC0216

TLC0214

CV13

CV15

R70

4

TLC0215

R70

5

CC07 R

RV

CC09LC19

CV07

CC08LC18

Q613 R618

R617

RS

13

QS02

CS02

Q671

Q672

C664

C665R665

R664

R672

R673 C672RJ03

R671

D672

D671

D673

D670

C670

R66

6

TLC0033

C66

3

Q610

RJ02

RS16

M501A

RS17

TLC0024 TLC0028

C69

0

TLC0209

TLC0208

TLC0211

TLC0212

TLC0210

C660

RS

18

RS19

CS05

R661

R66

2

C661

R660TLC0020

D681

R621

D683

D680

GJ13

C66

7

D682

CC

14

C686

R686 R687

C687

RS06

QS04

LC20

RS

14

RS

15

RS

12

RS09

RJ01

CS03

CS01

RS10

CC03

CV02LC09

RV04LC08

LC12

LC10

CV22

RV22 RV06CV03

CV06

RC03

RC02

RS

02

LC11

CC06

RS11

RS05 RC

R

BB/P IN3

R/P IN3

G/YIN3

INSSW3

VOUT(SW01)

UOUT(INSW-2)

YOUT

YSYNC

R

B

YIN(G/Y-2/CVBS/Y-X)

UIN(B/P -2)

VIN(R/P -2/C-X)

VDDcomb

/CSY

combVSS

AU

DO

UT

HP

L

AU

DO

UT

HP

R

CV

BS

O/P

IP

SVM

HOUT

FBISO

AU

DO

UT

LSR

AU

DO

UT

LSL

C2/

C3

CV

BS

3/Y

3

AU

DIO

IN3R

AU

DIO

IN3L

CV

BS

2/Y

2

AU

DIO

IN2R

/SS

IF

AU

DIO

IN2L

7978

77

55 60 61 63 64

7572

7167

6566

6869

7073

7476

6256 57 59585453

8

2 4 76 109 12118531

L

K

J

I

H

G

161513 14

Connected To pin9 Audio GND

1

2

3

4

21CZ8 (4 SPKS - 4ohms)

21CZ6/7 (2 SPKS - 8ohms)

+

-

BO

TT

OM

LEF

T

+

M604

+

-

M602

TO

P LE

FT

-

M603

BO

TT

OM

RIG

HT

TO

P R

IGH

T

M601

+

-

RIG

HT

LEF

T

-

M602

++

-

M601

E3

MONITOR OUT

E1

E2 DVD

E2

*

* L

R

*

V-Out*

R-Out

CR

CB

V / Y

L-Out

**

*

* R

C

* V

L


*

*

**

*

*

R

V

L

L/R P

HO

NO

JAC

K

29CZ5/6 21CZ6/7/8

21CZ6/7/8

*

*

270RS61~ RS62

HEAD PHONE JACKP661

LOCATION

GJ21 ~ GJ22 SHORT

KETSU

KETSU

21CZ6/7/8

KETSU

29CZ5/6

*

*

*

NE

W

W

2

1

NE

W

W

2

1

NE

W

W

2

1

NE

W

W

2

1

NE

W

W662

2

1

NE

W

W661

2

1

0B

6-C8

2-A1,4-A2,6-C8

GND_AUDIO

27V

+

P2.2k

35V1000

35V1000

16V47

100100p 75

75

1000p

7547

K

B 4B-EH-A

1000p SHORTSHORT

SHORT

75

SHORT

100

2SC3326B

1000p

47K

SHORT

100p

1000p

47K

HORT

04

KETSU

KETSU

OP

EN

OP

EN

KE

TS

U

KE

TS

U

SHORT

1/2R270

1/2R270

2SC3326B


SHORT10V470

SHORT

47K

SHORT

SHORT

47K

RT

1000p SHORTSHORT

TLA0119

TLA0118

TLA0117

81

C681

C683

A

GJ22

GJ21

RV08CV04

RV

07

RV09

CC05RV

05

RS

03

P601A

TLC0264

TLC0262

TLC0248

TLC0238

TLC0237

TLC0234

TLC0230

TLC0228

CC07 LC17RC06

RC08

RV

17

RC07

RV18

Q614

CC09

RS

08LC19

CV07

CC08

RS

07C18

R618

R617

CC

31

CC

30

P661

TLA0069

TLA0068

LC01

CC

33

CC

32

LC02

LC03

RS62

RS61

Q615

PV02

TLC0179

TLA0104

TLA0105

TLA0107

TLC0221

LC15CV06

RC04

RS

04

TLC0168

TLC0166

TLC0171

TLC0162

TLC0163

TLC0164

TLC0175

TLC0176

RC03

RC02

RS

02

1

CC06LC16

RC05

TLC0180

1

2

3

4

B 4B-EH-A

TLA0119

TLA0118

TLA0117

P601A

29CZ5DE/29CZ5T/29CZ6SIMAIN (SIGNAL/MICON) [SHEET-1/6]

A

B B

A

21

21

23477932

21CZ6/7/829CZ5

to link to R305 gndUse a chip jumper

**

*

**

*

*

*

2R100R336

R363 1/2R180

2R1K

M100V0.1uF

23478144

AN5523

1W1R

1/4P33K

1/4P10K

Q301

C363*

R329

R330

Q301A

R305

R345

1/4P15KR331

(C311 close to IC Pin)

(C313 ground close to IC Gnd pin 4)

Q301A1

1Q301B

1Q301C

1-(690.25,71.5),4-A2,6-C8

1-(161.5,192)

1-(162,289.5),3-D3,6-C8

1-(161.5,188)

1-(161.5,232),3-A3,5-A2

3-C8

3-B8

1-(161.5,248)

+13V

-13V

VDR–B

GND

VDR–A

5V2

V–DY–G

V–DY–Y

VGUARD

+

+

+

M

M

+

25V1000

1K

5.6K

10k

1/6P5.6k

B27

00p

KETSU

B4700p

50V220

25V220

10k

KETSUB2700p

100V0.1uF

AN5523

2R2201/2R180

100V0.1u

KETSU

KETSU

1R0.75

100V0.22

ERB12-02

OPEN

4.7K

2SC2712-Y

SC570ALFE2

1nF

MA111-TX

KETSU

1/2W2.2

TEM2011

MTZJ5.6A

22K

47K

C309

R346

R348

R347

R331

C33

6

C311

C331

C308

C335

R321

R323C321

C328

Q301

R336R363

TLC0058

C363

D310

R310

TLC0070

TLC0060

TLC0062

TLC0064

SL06

R305

TLA0049TLA0050

C313

D301

C312

TLA0048TLA0051

R324

Q320

D303

C315

D311

C323

TLC0049

TLC0055

TLC0052

R303

TLA0046TLA0047

L301

TLC0046

D312TLC0016

TLC0025

R354

TLC0040

R314

TLC0043

TLA00452 4 6 7531


29CZ5DE/29CZ5T/29CZ6SIMAIN (VERT) [SHEET-2/6]

F

E

D

C

B

A

F

E

D

C

B

A

87654321

7 81 2 3 4 5 6

12V_FBT

KETSU

76503274B 1.5KV/782

KETSU

21CZ 6/7/8

76503213B 1.5KV/152

76693472D 100V/472

76082995B 250V/364

76640872E 100V/10uF

KETSU

C402

C439

29CZ5

76693472D 100V/472

76503125B CAP 400V/753J

76503298B 315V/304J

76503194B 1.5KV 103H

76503225B 1.5KV 622H

C442

C464

C444

C440

C443

7621222A(RA)76640872E(RB)

R474 (R1)

R474 (R2)

R474 (R3)

KETSU

76383271S

76383221S

KETSU

23248460 TLN3337AC

23248376 TLN3337AA

23233147 TLN2210AC

23233145 TLN2210AY

76503157B 630V/333

23233113 TLN2210AA

23248410 TLN3337AD

23224404 TLN1039

KETSU

KETSU

KETSU

23236957 TFB4228AS

23224391 TLN1104AH

23236962 TFB4228AT

76679100S 250V/10UF

76182011L ERX1SJS4R7P

(RA)76019329 (RB)76510332 5W 332J

76366332Y 1/6W/63.3K

76366472Y 1/6W/64.7K

76366472Y 1/6W/64.7K

76182011L ERX1SJS4R7P

76553272L 1W272

76019323 5W 182J

L441(RC)

L441(RB)

L442

C467

L441(RA)

R327

C416

C440

R416

R415

C447

C413

R227

R218

R322

R216

L461(RA)

L461(RC)

L461(RB)

T461(RB)

T401(RB)

T401(RA)

T461(RA)

76678479S 200V 4.7UF

TLN1098AH

KETSU

KETSU

23248459TLN3335AC

76366103Y 1/6W/10K

KETSU

23233124 TLN2083AT

23233132 TLN2083AH

23248404 TLN3383D

23211848 TLN2083G

23248409 TLN3335AD

23248375 TLN3335AA

76366392Y 1/6W/3.9K

23236963 TFB4229AG

23224395 TLN1098GH

76679220S 250V/22UF

76503160B 630V 433J

76182030L ERX1FJ4R7H

23183918 WIRE JUMPER

76182030L ERX1FJ4R7H

76214821A CERA 500V/821K

*

*

*

*

*

TO FOCUS

TO ANODE

*

*

*

*

*

*

**

*

***

***

FOR 29"ONLY

C

WIRE J601C(23513300)

C

*

ALL KETSU FOR 21"

*

*

*

*

CRT/D BOARDTO P903B

23

1

56

4

34

TO P704B

TO VSM CIRCUIT

21

4 4

6 65 5

SCREEN

FOCUS

HV

FWPF114

2 21 1

33

*

1Q460B1Q460A

1Q460C

1Q404C

1Q404B

Q404A23477926

1

65

43

12

21

21

2-B2

1-(161.25,39),6-B84-A1

4-B2

1-(161.5,115)

1-(162,289.5),2-A1,6-C8

1-(161.5,101)

1-(161.5,232),2-A1,5-A2

1-(161.5,225)

2-A2

9V

EW

V–DY–G

-13V

12V–FBT+13V

125V–1

HDRIVE

GND

FBP

5V2

EHT–INFO

V–DY–Y

+

+

+

+ +

M

M

+

+

+

M

M

25V1000

25V2200

25V2200

1/16W 360K

1/6P

20k

1/6P

20k

1/6P4.7k

TLN1098AH

IRF630FP

1R6.8

KE

TS

U

MTZJ9.1C

1W 472

SHORT

KETSU

EU2A

100V

10uF

68K

SHORTKETSU

KETSUKE

TS

U

2R6.8

CHIP 50V/222K

1SS355-TE17

270k

392pFKETSU

270k

SHORT

KETSU

1RF1k

KETSU

1R9.1

DC50VM0.22

TEM2011

B22

00p

SHORT

KETSU

SH

OR

T

SHORT

KETSU

250V10

KETSU

SH

OR

T

SHORT

TEM2011

TLN1039

470

EU2A

EU2A

470

3JHJGR-M2

B 6B-EH-A

KETSU

390

18K 1SS133

2SK941

RU-4AM

KETSU

1K

ER

C06

-15L

KETSU

B 4B-EH-A

10k

EU2A

160V33uF

OPEN

KETSU

1SS133

1/6P2.2k

1SS133

6P_5mm_5A

HV

C449

C310

C333

R4704

R416

C413

R415

TLA0017

TLA0015

TLA0016

TLA0052

R21

5

R21

7

D420

R216

T401

Q460TLC0075

R462Z

R43

2

R322

C442Z

L441

C46

7

C44

4

C44

0

D441

R403

GJ405

C442

C439

L442

C439Z

D442

TLC0084 TLC0086

R474

D467

TLC0113

C46

4

C46

4Z

C442Y

L461

R438

TLC0077

R475

TLC0353

R463

R460

C46

0

R462

TLC0082

TLC0088

C4700

D4701

R4702

C4701C4702

TLC0071

R4701

R4703

D4700

TLC0068

TLC0059

R441

R4712

L441Z

TLC0063

R327

R448

C220

G405

C46

3

D443

R428

GJ4

45

R218R227

TLA0018

TLA0014

G403

TLC0053 TLC0050

C445Z C445

TLC0056

T461

C447

GJ446

G46

1

G402

C44

3

C46

7Z

G404

T401Z

TLC0351

TLC0350

C322

D313

D302

C303

TLC0094

D408TLC0098

P903A

TLA0003

TLC0092

TLC0090

Q404

G407

C417

TLC0013

R419 D445

Q402

TLC0009

D461

R429

TLC0017

R420

D44

4

C416

GJ70

P704A

TLA0005

TLA0012

R228

TLC0038

TLC0105TLC0035

D406

C448

TLC0103

C402

C473

TLC0101

C498

D476

R439

D475

TLC0111

TLC0109

TLC0115

TLA0001

TLA0061

TLA0020

P401

TLA0025

TLA0024

TLA0027

TLA0026

TLA0021

TLA0023

TLA0028

6

43

2

1

SV

26

25

FV

5

2

3

9

10

1

86

7

4

1

3

6

5

4

E

B

C


29CZ5DE/29CZ5T/29CZ6SIMAIN (HORIZONTAL) [SHEET-3/6]

76381131L 1/2 W 130

*

76182018L ERX1FJR47H

76000247Y RN14C2E393F

76000242Y 1/4W 18K

76182021L ERX1FJR75H

* 21CZ6/7/829CZ5

R470

(RA)23144297(RB)23144210 250V 1A

R471

R4760 76366183Y 1/6W 183

C470

R473

76011102R 1/16W 102

(RA)76766470S (RB)76797470S 50V/47UF

R4770

(RA)76766101S(RB)76797101S 50V/100UF

76011102R RM73M1J102JD

76366183Y 1/6W 183

76382121S 1W121

76552301L 1/2W 301R479 76381271L RS14B2H271J

F470 (RA)23144296 (RB)23144211 250V/0.8A

**

*

*

*

*

*

3-B3

1-(161.5,242.5)

1-(161.5,262)

6-C8 125V–1

PROTECT

32V

125V

+

M

1/4R39K

1k

1/4R18K

RD36ESAB2

1R15k

250V_1A

50V47u

1/2R

F27

0

1/2R

130

0.47

2SA949-Y

R470

R4760

TLC

0048

TLC

0054

R4770

R473

D470

TLC

0036

TLC

0045

TLC

0042

F470B

R156

F470A

TLC

0027

F470

TLC

0051

C470

TLC

0023

R47

9

TLC

0039

R47

1 C472

Q471


29CZ5DE/29CZ5T/29CZ6SIMAIN (PROTECTER)

[SHEET-4/6]

*

Q844C1

1Q844B

6-C8

6-C8

6-C8

1-(161.5,268.5)

1-(161.5,232),2-A1,3-A3

1-(161.5,253.5),3-D3

1-(161.75,277)

27V-2

12V

6V

3.3V-1

5V2

9V

3.3V-2

5V1

++

++ +

+M M

M+

M+

16V

1000

KIA78D33PI

KIA78D05F

16V

100

16V

100

SHORT

B10

000p

16V

100

16V

100

16V10063V0.33 63V0.33

63V0.33

AN34040A

B10

000p

B10

000p

16V10063V0.3335V2200

C83

6

Q844

Q831

C83

1

C83

2

GJ808

C83

3

C83

4 C84

9

TLC0032

C843C841 C842

TLC0015

Q844A

TLC0019

C839

Q835

C84

8

C83

0

TLA0056TLA0057

C837

TLA0055

TLC0007TLC0003

TLA0059 TLA0058TLA0060

Q835A

C838C890

TLC0011

31 2

IN GN

D

OU

T

3

2

1

2 4 6 7531


29CZ5DE/29CZ5T/29CZ6SIMAIN (LOW B REG) [SHEET-5/6]

GND

**

HEATSINK(65mm)HEATSINKQ801ASTR-F6268SSTR-F6267SQ801

OPEN

OPEN

OPEN

SE125

SHORT

TPW3577AW

15W2.2

SHORT

SHORT

SHORT

OPEN

OPEN

OPEN

OPEN

SHORT

SHORT

7W270

OPEN

RZ92P2E180M3or5

29CZ521CZ6/7/8

OPEN

OPEN

OPEN

OPEN

OPEN

SHORT

5W4.7

SE133

SHORT

2W1.8

1SS133RN1205

RELAY DC 12V

250V 1000pF

1/6W2.2M

RZ92P2E4R5MorM1

RELAY DC 12V 2M

SHORT

TPW3573AM

*

R813

D882

T862

Q883

GJ805

GJ806

GJ809

GJ810

GJ807

R812

R810

D845

SR81

Q805

R811SR83

R808

R814

C812

*

M804B

or TLP621(GR-LF2)

250V 7.5A/10A

250V13A/10A

250V13A/10A

250V 2.5A

SASO

SASONON

MIDDLE EAST

125V 7A

250V 6ATHAILAND

TAIWAN

AUSTRALIA

HONG KONG

EAST EUROPE

ASIA/250V 2.5A

*

**

* **1

*

2

**

GJ38

G106

GJ36

G105

GJ37

GJ39

GJ40

G107

GJ43

G108

GJ42

GJ41

G107

GJ34

GJ35

GJ33

G104

*

Russia Model OnlyGJ32

*

POWER CORD

GND

*

* *

**

*

*

2

1

TO Choke Transformer

TO DEG COIL

*

*

**

**

TO TUNER GND

*

*

1

2

*

**

***

Power Cord in

GND–AUDIO

AUDIO Vcc

*

**

**

*

4

12

3

23478146

R899Z

21

MA28

DEF

MA02

MA08

MA07

DEF

Q801C11

Q801B11

1-(161.25,39),3-B3

1-(680,434)

1-(677,422.5)

1-(162,289.5),2-A1,3-D3

4-B1

5-A1

5-A1

5-B1

1-(690.5,60.75)

1-(690.25,71.5),2-A1,4-A2

12V–FBT

DEG

GND

POWER

GND

125V

6V

12V

27V-2

GND–AUDIO

27V

+

+

+

+

+

+

+

+

M

+

M

+

TEM2014

SHORT

SHORT

SHORT

SHORT

KETSU

250V1000

PK14A2H825J

250V1000

TLP421F(GR)

AL0

1Z

KDC-A11(E221)

SHORT

5W4.7

1/6P

3.9k

OP

EN

SHORT

SHORT

7W 271J

2P

RZ92P2E180M5

PINPIN GT-PINPIN

15W2.2

1W 0

.22o

hm

KE

TS

U

470p

4.7k

KTC4075Y-RTK

000

KETSU

KETSU

OPEN

SHORT

TEM2011

AC

275V

0.22

TRF3247AW

AC

275V

0.22

uF

OPEN

SHORT

OPEN

SHORT

SHORT

*

1/2W

2.2M

SHORT

OPEN

SHORT

SHORT

SHORT

OPEN

OPEN

SHORT

SHORTT4AL/250V

2W 0

.12o

hmn

TLN3299GH/D

TRF4100AZ

TRF4100AZ

470p

1/6P2.2k

DZ5.6 BS B

1/6P

18k

50V

47

200V220u

RU-4AM LF-L1

SHORT

SHORT

OPEN

SHORT

SHORT

OPEN

RM73B1HR00OD

SE125N

OPEN

OPEN

35V470

16V2200u

1/6P

220

1/6P

2.2

2SC5343-Y

1k

400V560u

TLN3481AC/AH/AD

AC250V4700

AC250V4700

TLN3481AC/AH/AD

220p

1/6P220k

EU2JGF

EU2JGF

1/6P470k

1/6P560k

1/6P120k

D5SB60/LN6SB60-F05

1/6P1.5k

DZ

5.6

BS

B

FN

155

DZ

15 B

S B

TRF3202BQ

AC250V1000

OPEN

OPEN

AC250V1000

TE

M20

11

1EDG

SH

OR

T

1/6P220

100

1.5k

150k

35V2200

500VB470

RU4Z LF-L1TEM2011

1/2W R22J

1EDG

35V330

500V470

TEM2011

SHORT

TEM2011500V470

500V470 EU2JGF PRF40005491

2KV(R1)220

RL2ZTEM2011

TRF9253D

PRF40005491

PRF400054911EDG

500V470

TEM2011

OPEN35V3300

63V0.22

EU

2JG

F

1800p

1/6P2.2k

DZ

5.1

BS

B

50V4.7

KTC4075Y-RTK4.7k

DC

50V

M0.

047

KETSU

1EDG

RD

33E

SA

B2

DZ15 BS B

22k

2kV1500pF

HEAT SINK

250V–3.15A

GL889

Q801

T862

GL808

GL895

GL893

GL896

SR83

SR81

C811

R899

C815

Q826

D81

7

S801

GL828

R812

R83

8

GL8

88

C812

R811

TLA0063

TLA0062

R814

P910

R808

GJ8

07G

J810

GJ8

09G

J806

P499P496 P498P497

R810

R813

R82

9

R83

0

C88

8

R84

2

Q842

R843

TLC0074

TLC0072

D845

Q805

GJ804

GJ803

L815C80

1

T801MA09

C80

2Z

C80

2

DEF

P802

GJ805

G106

GJ37

GJ36

C80

1Z

R80

1

GJ38

G109

GJ39

F801BTLC17

P801GJ33

GJ32

G105

G104

GJ35

GJ34

TLA0007

TLA0008

F801A

F801

R83

0Z

L885

L889

L888

SL02

SL01

SL04

SL05

C81

8

SL03

R839

TLC0152

D813

R83

2

C82

1

C884

D883

GJ43

GJ42

G108

GJ41

GJ40

G107

DEF

R847

DEF

Q883

GJ08

GJ09

C891

C808

R80

5

R81

8

Q803

R837

C810

L805

C805

C806

L806

TLC0119

C823

TLA0044

R820

D807

D808

TLC0097 R825

R826

R817

D801

TLC0095

TLC0093

R831

D81

2

TLC0102

TLC0106

Q80

2

TLC0100

D80

9

TLC0108

TLC0080

T802

C813TLC0083

TLC0089TLC0087

TLC0081

GJ10

GJ11

TLC0096

TLC0085

C814

L811

TLC0120

TLC0117

D816 D88

2

GR828

R848

TLC0129

R841

R846

C889

C885

D885L886

TLA0032 R898

D893

C896

C897

TLC0138

L882

TLC0137

GJ802

TLC0142 TLC0143 TLC0157

TLC0141

L892

C894

C892D892

Z892

TLA0039

C893

D894TLA0036

L894

TLA0038

TLA0070

TLC0130

L883

Z894

Z891

D891

TLA0033

C899

TLA0034

TLC0140

L891

TLC0133

TLC0132

TLC0139

TLC0158

TLC0131

GJ801C895

C898TLC0136

TLC0156

TLC0155TLC0144

TLC0135

TLC0154TLC0146

TLC0153TLC0145

D81

8

TLA0029

TLA0030

C824

R834

D84

1

TLC0125

C809

Q841R840

TLC0127 TLC0150

TLC0151

C82

0

R836

TLC0149

D805

TLC0110

D815

D814

R833

TLA0043

C810Z

C817

TLC0121

TLA0040 TLA0041 TLA0042

TLC0112

TLC0114

Q801A

F802

F802B

TLC0122

F802A

FB

GN

D

OC

P

Vin

D

54321

13

12

15

14

11

17

18

16

7

8

5

2

4

5

4

3 6

12

23

4 1

BC

G

+-

P

P

P


29CZ5DE/29CZ5T/29CZ6SIMAIN (POWER)

[SHEET-6/6]


29CZ5DE/29CZ5T/29CZ6SICRT DRIVE

+12V

+132V

1

TLA002

500V

2W

500V

1/6W

2KV

1/2W

1/2W

1/2W

500V

500V

2

1

+

+

+

+

+

+

M

+

+

+

+

B

CE

B

CE

1

B

CE

B

CE

B

EC

B

CE

B

CE

B

CE

B

CE

B

CE

GND

B

EC

10nF

100ohm

1SS244

1SS244

1SS244

0.47

uF

2SC5343-Y

100

KE

TS

U

KE

TS

U

KE

TS

U

1SS

133

1SS

133

1SS

133

3.3V3.3V

3.3V

100

100

10nF

250V10uF

SH

OR

TK

ET

SU

0.47

uF

KE

TS

U

KETSU

1/6P1K

PLUG 4P

1/6P100

1/6P100k

1SS

133

150J

16V4702SC2120-Y

PLUG 3P

16V47

15ohm

1000p

1W5.1

1P

CRT Socket

PLUG 6P

TDA6108AJF

Double Focus Socket 23903145

HEAT SINK 23474116

PLUG 8P

3P_5mm

100ohm

100ohm

100ohm

SHORT

1/2W 1K

100pEU2A

1/2W 1K

1/2W 1K

100p

OPEN

1/6P100

1/6P56k

1/6P39kKTC3198Y 25V47

1SS133

KTC3198Y

KTA1266Y1/6P820

1SS133

1/6P82

1/6P82

1/2R10

1/2R330

2SC752GTM

1/6P47560

1/6P33k

1/6P

3.9k

OPEN

1/6P3.9k

1SS133

1/2R470

KTC3198Y

1/6P27k

1/6P1.8k

KTC3198Y

1/6P470

0.01

KTC3198Y

1/6P1.8k

1/4W22

50V8200p

25V47 1/6P1k

1/6P22k

B1000p

16V47

2R220

1/6P2.7

HC5-035

200V10

1/6P1.2k

1/6P68k

2SC4793

1/6P1k

1/6P1.5k

1SS133

1SS133

100

1/6P

1.5k

1/6P68k

4700

100

4700

200V10

1/6P1.2k

TEM2011

2SA1837

56

1/6P62

1/6P

62

TEM2011

1/6P2.7

2 4 76 98531

C901

R907

D903 D902 D901

C91

1 Q909

R91

1

R91

0

R90

9

R90

8

D91

4

D91

6

D91

5

D918

D91

9

D920

R91

2

R91

3

C903C904

GJ0

5G

J06

TLA003

C91

0

D91

2

D917

R939

P704B

R937

R938

D91

3

R936

C912Q908

P703

TLC007

TLA065

TLA064

TLA063

TLA062

TLA061

TLA067

TLA057

TLC011

TLC009

TLC005

TLC004

TLA052 TLA051

TLA050TLA049

TLA048TLA047

TLA046

TLC001TLC002

TLC003

TLA042

TLC006

TLC010TLC008

TLA038

TLA037

TLA036

TLA035

TLA034

TLA033

C721

TLA031

TLA005

TLA032

TLA030

TLA029

TLA028

TLA027

TLA026

TLA025

TLA024

TLA023

TLA022

TLA021

TLA020TLA019TLA018TLA017TLA016TLA015TLA014TLA013TLA012

TLA011

TLA010

TLA009

TLA008

TLA007

TLA006

TLA004

TLA001

R992

C902

R920Z

R920

P905

V901A

V901

P903B

Q901

V901B

Q901A

P902B

P900

R906

R905

R904

G901

R903

C931

D911

R901

R902

C930

G920

R760

R709

R713

Q719 C712

D715

Q709

Q710R702

D721

R734

R732

R730

R731

Q707

R724C722

R717

R72

0

GJ01

R719

D720

R722

Q706

R716

R725

Q720

R723

C705

Q773

R775

G714

C704

C707 R721

R715

C726

C718

R743

R741

L702

C720

R744

R733

Q712

R738

R737

D704

D705

C716

R73

9

R735

C715

C714

C717

C713

R745

L704

Q711

C719

R736

R74

0

L705

R742

Q712A

Q711A

B

GR

12V

9V

Small signal GND

Spot Killer and CRT discharge Circuit

<=

SV

M

CRT-Drive BOARD

9V

13

TO

P70

4A

Spark Gap GND

For G3 (Pin1)

Small signal GND

+132V

Aquadag

(SV)1

11

Single Focus Socket View from Copper Side

23903147

V901A

6G

14

5G1

13

G3

H

Spark Gap GNDB

12

98

7G2

HGR 10

Signal Focus

Large signal GND

+200V

HEATER

NC

NC

NC

HEATER GND

1

2

3

4

5

6

Spark Gap

23474116

10 147511689

1312

Foc

us V

olta

ge (

FV

)

(FV)

Scr

een

Vol

tage

(S

V)

FBT

EHT

EHT

(SV)

1

2

3

+200V

B IN

G IN

R IN

I Bla

ck o

ut

GN

D

B O

UT

G O

UT

R O

UT

+20

0V

+200V<= I black

SVM

GND

GND

5

7

6

2 R

1

4 B

3

TO

P90

2AS

IGN

AL

BO

AR

D

G

8

G3G2G1

H

HG

R

B

G

G1 G2 G3

PO

W/D

EF

BO

AR

D

3

4

1

2

V901M

MAG-1116

2


29CZ5DE/29CZ5T/29CZ6SIFRONT

A

B B

A

21

21

2336

7065

23351255 SPK1401AN

W662

21

23351255 SPK1401AN

W661

21

PIC-TB19

2SA

1980

-Y

2SC

5343

-Y

1/6P

1k1/6P22k

1/6P

220

1/6P270

1/6P

10k

1/6P

47

1/6P75

1/6P1001/6P47k1/6P47k

B100pB1000p

SHORT

SHORT

SHORT

B1000p

SHORTSHORT

KETSU

KETSU

KETSU

KETSU

B5B

-EH

-A


1/2R

270

1/2R

270

B 4B-EH-A

SH

OR

T

SH

OR

T

SH

OR

T

B4B-EH-A

B 6B-EH-A

1/6P240 1/6P470

1/6P3301/6P1.2k

1/6P150

1/6P180

RMT SENSOR

16V

47 QB

22

QB

21

RB

35

RB34

RB

33

RB

32

RB

31

RB

30

RV26

RV25RS41RS40

CV25CC17

LC27

LC26

LC25

CC18

RC18RC17

CC36

CC37

CC34

CC35

P501

DB21

PV03

RS

63

RS

64

P662

TLA32

P602

TLA33TLA30 TLA31

TLC

26

TLC

29

TLC

25

TLC

28LC

06

LC04

LC05

P601B

TLA06TLA05

TLC15

TLC09

TLA03 TLA04TLA01 TLA02

PA21A

TLC12 TLC13TLC11

RB24

SA14

TLC14

RB26

SA16SA15

RB25RB21

SA11

TLC10

RB22

SA13SA12

RB23

KB21

CB

21

+

5 4

3 2 1

Vcc

GN

D

VO

UT

4 1LE

FT

RIG

HT

3 25V

IDE

O

E3

R L V

*

***

AU

DIO

GN

D

VID

EO

GN

D

M602

- +

*

LEFT

-

124 3

*

+

L/R PHONO JACK

*

M601

RIGHT

*

4 3 12

AU

DIO

GN

D

AU

DIO

GN

D

RIG

HT

LEF

T

5V-1

3.3V

-1

RE

MO

TE

LED

2

KE

Y

431

GN

D

65

VOL UPCH DN MENUVOL DN VIDEOCH UP

RED GREEN

Date post:	28-Oct-2020
Category:	Documents
Upload:	others
View:	2 times
Download:	0 times

S5ES series 29CZ5DE 29CZ5T 29CZ6SIskematv.files.wordpress.com/2011/08/toshiba...[TV/VIDEO] button,...

Documents