Screw compressor units - with OHU 04123 oil separator
SAB 120, SAB 151, SAB 193 A-frame and SAB�ex
Spare parts manual en
Contents
1. Spare parts list SAB 120, SAB 151, SAB
193 A-frame and SABflex 4
1.1.1 How to use the spare parts list 4
1.1.2 Recommended spare parts 6
1.1.3 General arrangement 8
1.1.4 Screw compressor, typical - SAB 120 - SAB 151 12
1.1.5 Oil separator, typical 18
1.1.6 Oil filter, single, typical - SAB 120, SAB151 and SABflex 22
1.1.7 Oil filter - single, typical - SAB 193 24
1.1.8 Oil filter, dual, typical - SAB 120, SAB 151, SAB 193 andSABflex 26
1.1.9 Oil cooler piping, typical - SAB 120, SAB 151, SAB 193and SABflex 28
1.1.10 Compressor overflow valve 30
1.1.11 Liquid injection - SAB 120, SAB 151 and SAB 193 32
1.1.12 Valve set, by-pass at start-up 34
1.1.13 Suction/discharge/stop valve, typical - SAB 120, SAB151, SAB 193 and SABflex 36
1.1.14 Spare parts list for all suction/discharge/service/stopvalves 37
1.1.15 Discharge stop/check valve - SAB 120, SAB 151 and SAB193 38
1.1.16 Spare parts list for check valve 38
1.1.17 Economizer SAB 120 and SAB 151 40
1.1.18 Economizer SAB 193 and SABflex 42
1.1.19 Oil pump - SAB 120, SAB 151 and SAB 193 43
1.1.20 Coupling assembly - SAB 120 and SAB 151 44
1.1.21 Coupling assembly - SAB 193 45
1.1.22 Coupling assembly - SABflex 46
1.1.23 Piping and instrumentation, typical 47
Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator009252 en 2016.06 3/50
1. Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
1.1.1 How to use the spare parts listSAB Rotary screw compressor unit
This spare parts list applies to standard Sabroe rotary screw compressor units, models SAB120, SAB 151, SAB 193 A-frame and SABflex.
Units built with special options, modifications or conversions are not considered.
Item numbers only apply to units with PED (Pressure Equipment Directive 97/23/EC) approvalwhen this is relevant.
Concerning rotary screw compressors (models XJF) and Unisab control systems, please referto specific spare parts lists.
The spare parts list provides identification for detail parts by Figure and Index number (Fig-Index column), Item number and Description.
To find the correct replacement item, locate the item in Figure 1, 2, etc. Note the Index num-ber and refer to the corresponding Fig-Index in the spare parts list to see Item number andDescription.
Consider that some parts depend on voltage, set pressure etc. and that your unit may have aspecial modification.
Quantity per assembly or item is stated in the Qty. column and always applies to each unitunless otherwise specified. If the quantity is 0 (zero) this either means that the Item numberis included as information only or it may be that the actual quantity is stated elsewhere egunder Description or in a footnote.
Some of the Item Numbers are included for information purposes only and are not usuallyconsidered spare parts.
If the word “Assembly” (not the abbreviation “Ass.”) is included in Description, the Item num-ber may be included for information purposes only and is not necessarily a spare part. Pleasecontact Refrigeration Parts Centre for more information.
The P&I Ref. column contains the connection designation of the item as shown in a typical P&Idiagram (see Fig. 21, Fig. 22 and Fig. 23: ) as well as the P&I diagram of your particular unitwhen this is relevant. A reference like P128 means item no. 128 and can only be seen in yourspecific P&I diagram.
Note: The 3-digit numbers do not refer to the spare parts list. They refer to the legend in theOperating manual and the Engineering, Service and Maintenance manual.
Unit of measure in the Description column etc. is always stated in SI-units unless otherwisespecified, eg subfixed “ if in inches.
American drawing standards, third angle projection method, are used in all figures.
Abbreviations for more than one item or model eg:
SAB 120S + SAB120M + SAB 120L + SAB 120E + SAB 151S + SAB151M + SAB 151L + SAB151E + SAB 193L + SAB 193L + SABflex
LG-1/2/3 means LG-1 + LG-2 + LG-3
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
4/50Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator
009252 en 2016.06
Abbreviations in this manual include:
Ang. angle OD= outside diameter equal to
Ass. assembly Rc. cooling medium refrigerant
Cp. compressor Reg regulating
DN (+space) nominal diameter Sc. seal cap
f. for Ser. service
g gauge Str. straight
Hex. hexagon Wc. cooling medium water
ID= inside diameter equal to ø diameter (ISO-standard)
L= length equal to
N/A not applicable ornot available
The unit pipe system name plate (example below) listing unit pipe system type, year andidentification number etc., is attached to the frame below the electric motor.
Note: Please provide Sabroe unit pipe system type, year and identification numberwhen requesting a quotation or placing an order. Failure to include this informationmay delay the processing of your request.
BY JOHNSONCONTROLS
Scope
Design code
Approval No
Refrigerant
Supply voltage
Refrigerant charge
Pressure systemCategoryAllowable pressure
Test pressure
Allowable temp.
Refrigeration unit
Fluid
Type
No
Group
Control
Year
Max.
LP side HP side
V/Hz
kg
bar g
°Cbar g
2516-342
Min/Max.
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator009252 en 2016.06 5/50
1.1.2 Recommended spare partsNote: There is no specific drawing for this figure. This list is based on one typical unit. Con-sider that your unit may have some special modifications. When stocking for more than oneunit, the quantity should be adjusted to meet your individual requirements.
List 00 - SAB 120, SAB 151, SAB 193 and SABflex
Fig-In-dex
P&IRef.
Item num-ber
Description
Qty
.
SA
B1
20
S
SA
B1
20
M
SA
B1
20
L
SA
B1
20
E
SA
B1
51
S
SA
B1
51
M
SA
B1
51
L
SA
B1
51
E
SA
B1
93
S
SA
B1
93
L
SA
Bfl
ex
00-01 1517.061 Filter, coalescing 1 x x x x x x x x x x x00-01 1331.604 O-ring ø329,57 x 5,33 , Manway 1 x x x x x x x x x x x
00-02 531A0224H02 Element, super filter II (K)
1 x x x x x x x x x x x
00-02 720M0366G01EU Spare parts kit f. each oil filter
1 x x x x x x x x x x x
00-02 720M0174G01EU Spare parts kit f. each oil filter
1 x x
00-02 531A0218H02 Element, super filter II (K)
2 x x
00-02 531B0100H02 Element, super filter II (K) (AJ)
1 x x
00-02 959A0053H01 Gasket ø7-13/16" x 1/8"
1 x x
00-02 959A0082H01EU Gasket ø251/222 x 2
1 x x
00-03 TE-1 1373.346Temperature sensorincluding pocket,L= 130
1 x x x x x x x x x x
00-03TE-1/-2
1373.343Temperature sensorincluding pocket,L= 80
1 x
00-03 TE-2 1373.345Temperature sensorincluding pocket,L= 95
1 x x x x x x x x x x
00-03 TE-3 1373.343Temperature sensorincluding pocket,L= 80
1 x x x x x x x x x x x
00-03 TE-4 1373.346Temperature sensorincluding pocket,L= 130
1 x x x x x x x x x x x
00-03 TE-1 1377.441 Temperature sensor,L= 130 (l) 1 x x x x x x x x x x
00-03TE-1/-2
1377.438Temperature sensor,L= 80 (l)
1 x
00-03 TE-2 1377.442 Temperature sensor,L= 95 (l) 1 x x x x x x x x x x 00-03 TE-3 1377.438 Temperature sensor,L= 80 (l) 1 x x x x x x x x x x x00-03 TE-4 1377.441 Temperature sensor,L= 130 (l) 1 x x x x x x x x x x x
00-03TE-1/2/3/4
1349.135 Seal ring, bonded, for G 1/4 A (H)(for pocket sealing purpose)
1 x x x x x x x x x x x
00-04PE-1/2/3
1373.338Pressure transducer,
1 x x x x x x x x x x x
-1/25 bar 4-20 mA / 24 VDC 00-04 PE-4 1373.337 Pressure transducer, 1 x x x x x x x x x x x
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
6/50Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator
009252 en 2016.06
Fig-In-dex
P&IRef.
Item num-ber
Description
Qty
.
SA
B1
20
S
SA
B1
20
M
SA
B1
20
L
SA
B1
20
E
SA
B1
51
S
SA
B1
51
M
SA
B1
51
L
SA
B1
51
E
SA
B1
93
S
SA
B1
93
L
SA
Bfl
ex
-1/9 bar 4-20 mA / 24 VDC 00-04 PE5 1373.338 Pressure transducer, 1 x -1/25 bar 4-20 mA / 24 VDC 00-05 HTR-1 3181.039 Oil heater, 115 V 1 x x x x x x x x x x x00-05 HTR-1 3181.040 Oil heater, 230 V 1 x x x x x x x x x x x
00-06 YY-1/2 1372.409Ass., four-way solenoid valve110/120V 50/60Hz
1 x x x x x x x x
00-06 YY-1/2 1372.404Ass., four-way solenoid valve220/240V 50/60Hz
1 x x x x x x x x
00-06 YY-1/2 1372.489Ass., four-way solenoid valve110/120V 50/60Hz
2 x x
00-06 YY-1/2 1372.487Ass., four-way solenoid valve220/240V 50/60Hz
2 x x
00-06 951A0113H20 Seal kit f. four-way solenoid valve
1 x x x x x x x x
00-07 1372.538 Coil 10W 110V 50/60Hz (n) 1 x x x x x x x x x x 00-07 1372.537 Coil 10W 230V 50/60Hz (n) 1 x x x x x x x x x x
00-08 951A0095H01 Coil 11W 120V 50/60Hz (u)
1 x x x x x x x x x x
00-08 951A0095H02 Coil 11W 120V 50/60Hz (u)
1 x x x x x x x x x x
00-09 YY-3/4951A0095H01 Coil 11W 120V 50/60Hz (AA)
1 x x x x x x x x
00-09 YY-3/4951A0095H02 Coil 11W 120V 50/60Hz (AA)
1 x x x x x x x x
00-09 YY-3/4950A0293H02 Coil 110/120V 50/60Hz (AB)
1 x x x x x x x x
00-09 YY-3/4950A0293H01 Coil 208/240V 50/60Hz (AB)
1 x x x x x x x x
00-10 LSL-1 1553.423 Switch, oil level sensing, 24V (AC) 1 x x x x x x x x x x x00-10 LSL-1 1553.422 Switch, oil level sensing, 24V (AD) 1 x x x x x x x x x x x00-10 1349.248 Seal ring, steel, ø26/21,1 x 4,5 1 x x x x x x x x x x xH) Quantity is for each sealing purposeK) Quantity is for each oil purposel) Repair kit complete (sensor insert with connector) excluding pocketn) Only for solenoid valve in liquid injection coolingu) If liquid injection, dual flowAA) If replacing product supplied by PE valveAB) If replacing product supplied by DanfossAC) For package with Unisab II control onlyAD) For package with Unisab III control only.(AJ) After January 2015
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator009252 en 2016.06 7/50
1.1.3 General arrangement
118 109
23 1 6
5 2
14
15
9 7
17
16
Fig. 1: SAB 151 shown
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
8/50Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator
009252 en 2016.06
List 01 - SAB 120, SAB 151, SAB 193 and SABflex
Fig-Index
P&IRef.
Itemnumber
Description
Qty
.
SA
B1
20
S
SA
B1
20
M
SA
B1
20
L
SA
B1
20
E
SA
B1
51
S
SA
B1
51
M
SA
B1
51
L
SA
B1
51
E
SA
B1
93
S
SA
B1
93
L
SA
Bfl
ex
01-01 INF
CompressorSee further information for compressorin chapter 1.1.4. or Service parts list forXJF/SGC compressor and SABflex
1 X X X X X X X X X X X
01-02 INFCouplingSee further information inchapter 1.1.20. and chapter 1.1.21.
1 X X X X X X X X X X X
01-03 INFMotorSee further information for motorspecifications in the Operating Manual
1 X X X X X X X X X X X
01-04 UI Unused Index 0 X X X X X X X X X X X
01-05 INFUnisabSee further information in the Unisabmanual
1 X X X X X X X X X X X
01-06 SUC
Suction stop and check valvesSee chapter 1.1.13. andchapter 1.1.16. (J)(See further information for check valvein chapter 1.1.15.) (k)
0 X X X X X X X X X X
01-06 P101 1361.195 Stop valve, Ang., Sc., SVA-ST 80 (J) 1 X 01-06 P101 1361.074 Stop valve, Ang., Sc., SVA-ST 100 (J) 1 X X X X 01-06 P101 1361.196 Stop valve, Ang., Sc., SVA-ST 100 (J) 1 X X 01-06 P101 1361.197 Stop valve, Ang., Sc., SVA-ST 125 (J) 1 X X X X X X X X X X01-06 P101 1361.198 Stop valve, Ang., Sc., SVA-ST 150 (J) 1 X X X X 01-06 P101 1361.199 Stop valve, Ang., Sc., SVA-ST 200 (J) X
01-06 PE-4 1373.337Pressure transducer, -1/9 bar4-20 mA / 24 VDC (Z) (AD)
1 X X X X X X X X X X X
01-07 DISCheck valveSee chapter 1.1.15. (J) (Q)
0 X X X X X X X X X X X
01-07 P102 1361.196 Stop valve, Ang., Sc., SVA-ST 100 (J) 1 X X X X X X X X X X X01-07 P126 1372.602 Check valve, Ang., GVD 100 (T) 1 X X X X X X X X X X 01-07 P126 1372.607 Check valve, Ang., GVD 100 (U) 1 X X X X
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator009252 en 2016.06 9/50
Fig-Index
P&IRef.
Itemnumber
Description
Qty
.
SA
B1
20
S
SA
B1
20
M
SA
B1
20
L
SA
B1
20
E
SA
B1
51
S
SA
B1
51
M
SA
B1
51
L
SA
B1
51
E
SA
B1
93
S
SA
B1
93
L
SA
Bfl
ex
01-08 INFOil filterSee chapter 1.1.6., 1.1.7. and 1.1.8.
0 X X X X X X X X X X X
01-09 INFOil separatorSee further information in chapter 1.1.5.
0 X X X X X X X X X X X
01-10 INFOil pumpSee further informationin chapter1.1.19.
0 X X X X X X X X X X
01-11 INFOil coolerSee further information in chapter 1.1.9.
0 X X X X X X X X X X X
01-12 INFLiquid injectionSee further information inchapter 1.1.11.
0 X X X X X X X X X X
01-13 INFEconomizerSee further information inchapter 1.1.17. and chapter 1.1.18.
0 X X X X X X X X X X X
01-14 INFSee further information forunit safety valve in chapter 1.1.5.
0 X X X X X X X X X X X
01-15 INFSee further information for compressorsafety valve system in chapter 1.1.9.
0 X X X X X X X X X X
01-16 200 3447.649 Oil return valve 1 X X X X X X X X X X X01-16 1377.246 Repair kit for oil return valve 1 X X X X X X X X X X X01-17 159 1373.132 High pressure unit 1 X X X X X X X X X X X01-17 2336.537 Bend pipe OHU 4123 1 X X X X X X X X X X X01-17 2336.539 Bend pipe OHU 4136 1 X X X X X X X X X X X01-17 1349.077 Pipe nippel 1/2 x 1/4 1 X X X X X X X X X X X01-17 1349.124 Straight screw joint ø6-G1/4A 1 X X X X X X X X X X X01-17 1349.311 T-piece 1 X X X X X X X X X X X01-17 2332.924 Bend pipe ø6 x 1U pipe for KP7 ABS 1 X X X X X X X X X X X01-17 1373.132 High pressure cut-out KP7 ABS 1 X X X X X X X X X X X01-17 1437.060 Star washer 1 X X X X X X X X X X X01-17 1413.320 Cylinder screw M4x16 (AJ) 1 X X X X X X X X X X X01-17 1523.1001 KP-4ABS dæmperpakning (AJ) 1 X X X X X X X X X X XJ) Spare parts kits and sets for stop valve in Fig. 12.k) See service parts list for SABflex screw compressor and suction throttling valve.Q) Spare parts kits and sets for check valve in Fig. 13.T) Only at high stage operating mode.U) Only at booster operating mode.AD) For package with Unisab III control only.AJ) After january 2015
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
10/50Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator
009252 en 2016.06
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator009252 en 2016.06 11/50
1.1.4 Screw compressor, typical - SAB 120 - SAB 151
Fig. 2: Drawing for list 02 - SAB 151
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
12/50Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator
009252 en 2016.06
List 02 - SAB 120, SAB 151
Fig-Index
P&I Ref. Item number Description
Qty
.
SA
B1
20
S
SA
B1
20
M
SA
B1
20
L
SA
B1
20
E
SA
B1
51
S
SA
B1
51
M
SA
B1
51
L
SA
B1
51
E
02- C-1 534E0305G01 Screw compressor XJF 120S (w) 1 X 02- C-1 534E0305G02 Screw compressor XJF 120M (y) 1 X 02- C-1 534E0305G03 Screw compressor XJF 120L (y) 1 X 02- C-1 534E0305G04 Screw compressor XJF 120S (y) 1 X 02- C-1 534E1205G01 Screw compressor XJF 151A (y) 1 X 02- C-1 534E1205G02 Screw compressor XJF 151M (y) 1 X 02- C-1 534E1205G03 Screw compressor XJF 151L (y) 1 X 02- C-1 534E1205G04 Screw compressor XJF 151N (y) 1 X02-01 CV-1 1364.410 Check valve, 4" 1 X X X X 02-01 CV-1 1364.409 Check valve, 5" 1 X X X X X X X X02-02 959A0054H10 Gasket for 4" check valve 2 X X X X 02-02 2354.180 Gasket for 5" check valve 2 X X X X X X X X 1427.061 Stud bolts 4 X X X X X X X X02-03 YY-3/4 951A0095H01 Coil, 11W 120 50/60_Hz (AA) 2 X X X X X X X X02-03 YY-3/4 951A0095H02 Coil, 11W 2400 50/60_Hz (AA) 2 X X X X X X X X02-03 YY-3/4 950A0293H02 Coil, 110/120 50/60_Hz (AB) 2 X X X X X X X X02-03 YY-3/4 950A0293H01 Coil, 220/240 50/60_Hz (AB) 2 X X X X X X X X02-03 YY-3/4 111Q0993344 Valve, solenoid 2 X X X X X X X X02-03 YY-3/4 534A0565H01 Gasket, solenoid valve 2 X X X X X X X X02-03 YY-3/4 901A0085H19 Cap screw, socket head, M8 x 30 2 X X X X X X X X02-03 1372.545 DIN cable connector f. coil 2 X X X X X X X X02-03 1554.159 Gasket f. DIN cable connector 2 X X X X X X X X02-04 UI Unused Index 0 X X X X X X X X02-05 534B1088H01 Block, manifold f. solenoid valve 1 X X X X X X X X02-06 534C2342H01 Gasket, manifold to compressor 1 X X X X X X X X
02-08 YY-1/2 1372.409Ass., four-way solenoid valve110/120V 50/60Hz (Y)
1 X X X X X X X X
02-08 YY-1/2 1372.404Ass., four-way solenoid valve220/240V 50/60Hz (Y)
1 X X X X X X X X
02-08 980A0012K58 O-ring, manifold to valve 4 X X X X X X X X02-09 951A0113H20 Seal kit f. four-way solenoid valve 1 X X X X X X X X02-10 P159 1373.132 High pressure cut-off 1 X X X X X X X X02-11 PE-3 1373.269 Pressure transducer, -1/25 bar 1 X X X X X X X X02-12 959A0057H18 Gasket f. flange, Cp. discharge 1 X X X X 02-12 2356.106 Gasket f. flange, Cp. discharge 1 X X X X X X X X02-13 NV-2 1361.117 Stop valve, Ang., Sc., SNV-ST CD10 (J) 1 X X X X X X X X 181/182 1364.438 Regulation valve for capacity slide 2 X X X X X X X X02-14 534B1023H01 Rod, indicator 1 X X X X X X X X02-15 980A0012K62 O-ring 1 X X X X X X X X02-16 534A0883H01 Spring, compression 1 X X X X X X X X
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator009252 en 2016.06 13/50
Fig-Index
P&I Ref. Item number Description
Qty
.
SA
B1
20
S
SA
B1
20
M
SA
B1
20
L
SA
B1
20
E
SA
B1
51
S
SA
B1
51
M
SA
B1
51
L
SA
B1
51
E
02-17 534C1552H01Linear transmitter, short stroke(slide valve indicator)
1 X X X X X X X X
02-18 534A1072G01 Kit, shaft seal 1 X X X X X X X X 181/182 1364.438 Regulation valve capacity slide 2 X X X X X X X X J) Spare parts kits and sets for stop valve in Fig. 12.Y) Including all mounting hardware (coils, cable connectors and gaskets, seal kit).w) For electric motor with 4 polesy) For electric motor with 2 polesAA) If replacing product supplied by PE valveAB) If replacing product supplied by DanfossAC) For package with Unisab II control onlyAD) For package with Unisab III control only.
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
14/50Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator
009252 en 2016.06
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator009252 en 2016.06 15/50
Screw compressor, typical - SAB 193
Fig. 3: Drawing for list 02 - SAB 193
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
16/50Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator
009252 en 2016.06
List 02 - SAB 193
Fig-Index
P&IRef.
Item number Description
Qty
.
SA
B1
93
S
SA
B1
93
L
02- 534E0672G01 Screw compressor SGC 1913 1 X 02- 534E0672G02 Screw compressor SGC 1918 1 X
02-01 534C1478H01Assembly, Transmitter, Linear(Slide stop)
1 X X
534C1478H02 Transmitter, Linear (less well) 1 X X 534C1314H01 Rod, Indicator 1 X X 534A0032H02 Spring (not part of assembly) 1 X X 980A0012K62 O-ring (not part of assembly) 1 X X02-02 534D1251H01 Assembly, Slide valve linear transmitter 1 X X 534D1251H03 Transmitter, Linear (less well) 1 X X 980A0012K60 O-ring 1 X X02-03 INF See further information (P) 0 X X02-04 INF See further information (P) 0 X X02-05 535E0122H01 Block, manifold f. two solenoid valves 1 X X
02-05SC-1/2SC-3/4BP
535E0122H11 Valve, needle, flow regulator in block5 X X
02-06 980A0012A61 O-ring, manifold to compressor 4 X X02-07 1413.307 Screw, hex. socket cap M6 x 80 4 X X
02-08 1, 2 1372.489Ass., four-way solenoid valve110/120V 50/60Hz (Y)
2 X X
02-08 1, 2 1372.487Ass., four-way solenoid valve220/240V 50/60Hz (Y)
2 X X
02-08 1372.545 DIN cable connector f. coil 4 X X02-08 1554.159 Gasket f. DIN cable connector 4 X X02-10 INF See further information (P) 0 X X02-11 PE-3 1373.269 Pressure transducer, -1/25 bar 1 X X02-12 959A0054H30 Gasket Cp discharge flange 1 X X02-13 CH 956A0050H04 Check valve 6” 1 X X02-14 1336.076 Gasket 2 X X 1427.058 Stud bolts 12 X XP) See service parts list for SGC compressor.Y) Including all mounting hardware (coils, cable connectors and gaskets, seal kit).
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator009252 en 2016.06 17/50
1.1.5 Oil separator, typical
121310811
6
16 2 3 7
1
564
Fig. 4: Drawing for list 03 - SAB 151 shown
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
18/50Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator
009252 en 2016.06
List 03 - SAB 120, SAB 151, SAB 193 and SABflex
Fig-Index
P&IRef.
Itemnumber
Description
Qty
.
SA
B1
20
S
SA
B1
20
M
SA
B1
20
L
SA
B1
20
E
SA
B1
51
S
SA
B1
51
M
SA
B1
51
L
SA
B1
51
E
SA
B1
93
S
SA
B1
93
L
SA
Bfl
ex
03- PV-14241.405.PED
Assembly, oil separator OHU 041231 X X X X X X X X X X X
03-01 1331.604 O-ring ø329,57 x 5,33 , Manway 1 X X X X X X X X X X X03-02 LG-1/2 1226.017 Sight glass ø90 (16+34) 2 X X X X X X X X X X X03-02 1331.543 O-ring ø52,07 x 2,62 2 X X X X X X X X X X X03-03 HTR-1 3181.039 Ass., oil heater, 500W/120V 460/115 1 X X X X X X X X X X X03-03 HTR-1 3181.040 Ass., oil heater, 500W/240V 460/230 1 X X X X X X X X X X X03-03 1331.403 Dowty ring 1 X X X X X X X X X X X03-04 HSL-1 1553.423 Switch, oil level sensing, 24V (AC) 1 X X X X X X X X X X X03-05 LSL-1 1553.423 Switch, oil level sensing, 24V (AC) 1 X X X X X X X X X X 03-05 LSL-1 1553.422 Switch, oil level sensing, 24V (AD) 1 X X X X X X X X X X 03-05 1349.248 Seal ring, steel, ø26/21,1 x 4,5 1 X X X X X X X X X X
03-06 TE-2 1373.345Temperature sensor including pocket,L=95
1 X X X X X X X X X X X
03-06 TE-4 1373.346Temperature sensor including pocket,L=130
1 X X X X X X X X X X X
03-06 1349.135Seal ring, bonded, for G 1/4 A (H)(for pocket sealing purpose)
1 X X X X X X X X X X X
03-07 Dual safety valve DSV 1/SFA 15Assembly, (E) (F)
1 X X X X X X X X X X X
03-07 P103 1364.349 Double stop valve DSV 1 1 X X X X X X X X X X X
03-07P104/105
1364.361 Safety valve SFA 15, 22 bar g2 X X X X X X X X X X X
03-07P104/105
1364.363 Safety valve SFA 15, 24 bar g2 X X X X X X X X X X X
03-07P104/105
1364.371 Safety valve SFA 15, 26 bar g2 X X X X X X X X X X X
03-07 1377.257 Repair kit, gaskets for DSV 1 1 X X X X X X X X X X 03-07 1377.255 Kit, gaskets f. two SFA 15 on DSV 1 1 X X X X X X X X X X 03-07 1377.259 Repair kit f. SFA 15 (gaskets+cone) 1 X X X X X X X X X X 03-08 1517.061 Filter, coalescing 1 X X X X X X X X X X X03-10 3254.658 Retainer, filter end plate 1 X X X X X X X X X X X03-11 2111.125 Stud bolt, M12 1 X X X X X X X X X X X
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator009252 en 2016.06 19/50
Fig-Index
P&IRef.
Itemnumber
Description
Qty
.
SA
B1
20
S
SA
B1
20
M
SA
B1
20
L
SA
B1
20
E
SA
B1
51
S
SA
B1
51
M
SA
B1
51
L
SA
B1
51
E
SA
B1
93
S
SA
B1
93
L
SA
Bfl
ex
03-12 1433.075 Nut, hexagon 1/2-13 UNC (B) 2 X X X X X X X X X X X03-16 P108 1361.118 Stop valve, Ang., Sc., SNV-ST G1/2” 1 X X X X X X X X X X X03-16/17
2313.027 Blind nut 1 X X X X X X X X X X X
03-16/17
2356.123 Allu gasket ø18/10 1 X X X X X X X X X X X
03-16/17
2356.283 Allu gasket ø19/14 1 X X X X X X X X X X X
03-17 P106 1361.118 Stop valve, Ang., Sc., SNV-ST G1/2” 1 X X X X X X X X X X X A) Quantity depends on operating conditions of the unit.B) Quantity is for each coalescer element.C) Quantity is for each unused filter opening.E) Only safety valves can be replaced.F) Set pressure depends on operating conditions.H) Quantity is for each sealing purpose.J) Spare parts kits and sets for stop valve in Fig. 12.AC) For package without Unisab control only.AD) For package with Unisab III control only.AF) See service parts list for SABflex screw compressor and suction throttling valve.
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
20/50Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator
009252 en 2016.06
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator009252 en 2016.06 21/50
1.1.6 Oil filter, single, typical - SAB 120, SAB151 and SABflex
4 2
3
1
7
Not or partly shown : 5, 8, 16
8
Fig. 5: Drawing for list 04
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
22/50Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator
009252 en 2016.06
List 04 - SAB151 and SABflex
Fig-Index
P&I Ref. Item number Description
Qty
.
SA
B1
20
S
SA
B1
20
M
SA
B1
20
L
SA
B1
20
E
SA
B1
51
S
SA
B1
51
M
SA
B1
51
L
SA
B1
51
E
SA
Bfl
ex
04- Assembly, single oil filter 1 X X X X X X X X X04-01 OF-1 535C0513EU Ass., oil filter 1 X X X X X X X X X04-02 531A0224H02 Element, super filter II (K) 1 X X X X X X X X X04-03 959A0082H02 Gasket for oil filter (K) 1 X X X X X X X X X04-04 535A0378H01 Spring for oil filter (K) 1 X X X X X X X X X04-05 P123 1361.192 Stop valve, Ang., Sc., SVA-S 40 (J) 1 X X X X X X X X X04-7 P124 1364.531 Reg. valve, Ang., Sc., REG-SB 40 (J) 1 X X X X X X X X X04-8 P121 1361.117 Stop valve, Ang., Sc., SNV-ST CD10 (J) 1 X X X X X X X X X04-16/17
2313.027 Blind nut 1 X X X X X X X X X
04-16/17
2356.123 Allu gasket ø18/10 1 X X X X X X X X X
04-16/17
2356.283 Allu gasket ø19/14 1 X X X X X X X X X
J) Spare parts kits and sets for stop valve in Fig. 12.K) Quantity is for each oil filter.
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator009252 en 2016.06 23/50
1.1.7 Oil filter - single, typical - SAB 193
12
832
76
54 10
141
17
18
9 13 15
10
832
54
Prior to January 2015
After January 2015
11
Fig. 6: Drawing for list 04 - SAB 193
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
24/50Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator
009252 en 2016.06
List 04 - SAB 193
Fig-Index
P&IRef.
Item number Description
Qty
.
SA
B1
93
S
SA
B1
93
L
04-01 OF-1 553E0013EU Ass., Oil filter OF 2111/DN 40 (D) 1 X X04-02 959A0082H01EU Gasket ø251/222 x 2 1 X X04-02 2355.253 Gasket ø250/225 x 3, grooved steel w.
graphite for PED/AD 2000 oil filter1 X X
04-03 553A0001EU Cover, end 1 X X04-04 1424.109 Screw, hexagon M16 x 80 10 X X04-05 1432.072 Nut, hexagon M16 10 X X04-06 535A0144H01 Plate, clamping 1 X X04-07 959A0053H01 Gasket ø7-13/16" x 1/8" 1 X X04-08 1413.356 Screw, hex. socket cap M8 x 21 6 X X04-08 1436.034 Washer, plain ID=8,4 6 X X04-09 333Q0001268 Rod, threaded
1/2-13 UNC x 31-1/2"1 X X
04-10 531A0218H02 Element, SuperFilter II 1 X X04-10 531B0100H02 Element, super filter II (AJ) 1 X X04-11 900A0007H01 Seal center 1 X X04-12 900A0008H01 Yoke, bottom 1 X X04-13 1436.005 Washer, plain ID=13 1 X X04-14 1361.117 Stop valve, Ang., Sc., SNV-ST CD10 (J) 1 X X04-14 2313.027 Blind nut 1 X X04-14 2356.123 Allu gasket ø 18/10 1 X X04-14 2356.283 Allu gasket ø 19/14 1 X X04-15 902A0021H01 Nut, hexagon 1/2-13 UNC 2 X X04-17 1361.056 Stop valve, Ang., Sc., SVA-ST 40 (J) 1 X X04-18 1364.325 Reg. valve, Ang., Sc., REG 40 #10 (J) 1 X X D) See cross-sectional view in Fig. 6.J) Spare parts kits and sets for stop valve in Fig. 12.AJ) After January 2015
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator009252 en 2016.06 25/50
1.1.8 Oil filter, dual, typical - SAB 120, SAB 151, SAB 193 and SABflex
1 4
3
2
Fig. 7: Drawing for list 05 - SAB 151 shown
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
26/50Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator
009252 en 2016.06
List 05 - SAB 120, SAB 151 and SABflex
Fig-Index
P&I Ref.Item num-ber
Description
Qty
.
SA
B1
20
S
SA
B1
20
M
SA
B1
20
L
SA
B1
20
E
SA
B1
51
S
SA
B1
51
M
SA
B1
51
L
SA
B1
51
E
SA
Bfl
ex
05- Assembly, dual oil filter 1 X X X X 05-01 OF-1/2 535C0513EU Ass., oil filter (D) 2 X X X X X X X X X05-02 P121/137 1361.117 Stop valve, Ang., Sc.,
SNV-ST CD10 (J) (K)1 X X X X X X X X X
05-03 P123/135/136/138
1361.192 Stop valve, Ang., Sc., SVA-S 40 (J) 4 X X X X X X X X X
05-04 P124 1364.531 Reg. valve, Ang., Sc., REG-SB 40 (J) 1 X X X X X X X X D) See cross-sectional view in fig.4.J) Spare parts kits and sets for stop valve in fig.9.K) Quantity is for each oil filter.
List 05 - SAB 193
Fig-Index
P&I Ref. Item number Description
Qty
.
SA
B1
93
S
SA
B1
93
L
05-01 OF-1/2 535C0513EU Ass., oil filter OF2111/DN 40 (D) 2 X X05-03 1361.056 Stop valve, Ang., Sc., SVA-ST 40 (J) 4 X X05-04 1361.117 Stop. valve, Ang., Sc., SNV-ST CD10 (K) (J) 1 X X05-04 1364.325 Reg. valve, Ang., Sc., REG 40 #10 (J) 1 X X D) See cross-sectional view in Fig. 6.J) Spare parts kits and sets for stop valve in Fig. 12.K) Quantity is for each oil filter.
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator009252 en 2016.06 27/50
1.1.9 Oil cooler piping, typical - SAB 120, SAB 151, SAB 193 and SABflex
06-W
Fig. 8: Drawing for list 06 - Alfanova oil cooler
Fig. 9: Drawing for list 06 - Vahterus oil cooler
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
28/50Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator
009252 en 2016.06
List 06 - SAB 120, SAB 151, SAB 193 and SABflex
Fig-Index
P& IRef.
Item number Description
Qty
.
SA
B1
20
S
SA
B1
20
M
SA
B1
20
L
SA
B1
20
E
SA
B1
51
S
SA
B1
51
M
SA
B1
51
L
SA
B1
51
E
SA
B1
93
S
SA
B1
93
L
SA
Bfl
ex
06-R/W WCOC/TSOC
1952.119 Oil cooler PSHE 34, Rc./Wc. 1 X X X X X X X X X X X
06-R/W WCOC/TSOC
1952.120 Oil cooler PSHE 66, Rc./Wc. 1 X X X X X X X X X X X
06-R/W WCOC/TSOC
1952.1121 Oil cooler PSHE 116, Rc./Wc. 1 X X X X X X X
06-W WCOC 990A0090H01EU Oil cooler ANHP52-20H 1 X X X X X X X X X X X06-W WCOC 990A0090H02EU Oil cooler ANHP52-30H 1 X X X X X X X X X X X06-W WCOC 990A0090H03EU Oil cooler ANHP52-40H 1 X X X X X X X X X X X06-W WCOC 990A0090H04EU Oil cooler ANHP52-50H 1 X X X X X X X X X X X06-W WCOC 990A0090H05EU Oil cooler ANHP52-60H 1 X X X X X X X X X X X06-W WCOC 990A0090H06EU Oil cooler ANHP52-70H 1 X X X X X X X X X X X06-W WCOC 990A0090H07EU Oil cooler ANHP52-80H 1 X X X X X X X X X X X06-W WCOC 990A0090H08EU Oil cooler ANHP52-100H 1 X X X X X X X X X X X06-01 P119 1361.206 Stop valve, Ang., Straight.,
SVA-S 40 (J)1 X X X X X X X X X X X
06-02 STR-2 950A0001H08EU Strainer 2", flange size 1-1/2"(L)
1 X X X X X X X X X X
06-02 950A0001H27 Kit for 2" strainer (L) (V) 1 X X X X X X X X X X 06-02 950A0001H40 Screen gasket for 2" strainer
(L)1 X X X X X X X X X X
06-02 950A0001H34 Flange gasket for 2" strainer(L)
2 X X X X X X X X X X
06-03 CV-2 956A0012G03EU Check valve, Str., 1-1/2" (L) 1 X X X X X X X X X X 06-03 959A0057H04 Gasket OD=2-5/16" (L) 2 X X X X X X X X X X 06-04 1344.369 Flange DN 40 (L) 2 X X X X X X X X X X 06-05 959A0054H25 Gasket OD=3-3/4" (L) 2 X X X X X X X X X X 06-06 901A0172H03EU Kit, screws f. flange DN 40 (L) 2 X X X X X X X X X X 06-07 TCV-1 2418.001 Complet valve, ORV 40 H1,
49°C1 X X X X X X X X X X
06-07 1375.138 Housing, ORV 40, includinggasket
1 X X X X X X X X X X
06-07 1375.157 Thermostatic element, H1,49°C
1 X X X X X X X X X X
06-07 148 H 3246 Kit, gasket and guide ring, H1 1 X X X X X X X X X X 06-08 P145 1361.113 Stop valve, Ang., Sc.,
SNV-ST CD6 (J)(L)1 X X X X X X X X X X
J) Spare parts kits and sets for stop valve in Fig. 12.L) Only if with oil pump.V) Consists of screen, spring and screen gasket.z) Consists of screen and screen gasket.A) See service parts list for SABflex screw compressor and suction throttling valve.
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator009252 en 2016.06 29/50
1.1.10 Compressor overflow valve
Fig. 10: Drawing for list 07 - Compressor overflow valve
List 07
Fig-Index
P& IRef.
Itemnumber
Description
Qty
.
SA
B1
20
S
SA
B1
20
M
SA
B1
20
L
SA
B1
20
E
SA
B1
51
S
SA
B1
51
M
SA
B1
51
L
SA
B1
51
E
SA
B1
93
S
SA
B1
93
L
SA
Bfl
ex
07-22 P127 2417.232 Safety valve POV 40 1 X X X X 07-22 P127 1364.348 Safety valve POV 1050 1 X X X X A07-23 P128 2416.203 Safety valve BSV 8, 20 bar g 1 X X X X X X X X X X A07-23 P128 2416.224 Safety valve BSV 8, 22 bar g 1 X X X X X X X X X X A07-23 P128 2416.315 Safety valve BSV 8, 24 bar g 1 X X X X X X X X X X A07-23 2356.127 Gasket, Aluminium ø24/13 x
1,51 X X X X X X X X X X A
07-23 2356.137 Gasket, Aluminium ø30/16 x1,5
1 X X X X X X X X X X A
07-24 1331.481 O-ring ø171,04x3,53 1 X X X X X X X X 07-24 1336.075 Gasket ø141/ø216x1.5 X 07-24 1336.076 Gasket ø168/ø251x1.5 X 07-25 2356.222 Gasket ø109/95x2 1 X X X X X X X X X X A) See service parts list for SABflex screw compressor and suction throttling valve.
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
30/50Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator
009252 en 2016.06
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator009252 en 2016.06 31/50
1.1.11 Liquid injection - SAB 120, SAB 151 and SAB 193
Fig. 11: Drawing for list 08
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
32/50Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator
009252 en 2016.06
List 08
Fig-Index
P&IRef.
Itemnumber
Description
Qty
.
SA
B1
20
S
SA
B1
20
M
SA
B1
20
L
SA
B1
20
E
SA
B1
51
S
SA
B1
51
M
SA
B1
51
L
SA
B1
51
E
SA
B1
93
S
SA
B1
93
L
08- 3449.K08 Assembly, liquid injection cooling 1 X X X X 08- 3449.M49 Assembly, liquid injection cooling 1 X X X X X X
08-01 P170 1361.189Stop valve, Ang., Sc., SVA-S 20 (J)(q)(t)
1 X X X X X X X X X X
08-01 P170 1361.190Stop valve, Ang., Sc., SVA-ST 25 (J)(r)(t)
1 X X X X X X X X X X
08-01 P170 1361.191Stop valve, Ang., Sc., SVA-ST 32 (J)(s)(t)
1 X X X X X X X X X X
08-01 P170 1361.203Stop valve, Str., Sc., SVA-S 20 (J)(q)(o)(p)(u)
1 X X X X X X X X X X
08-01 P170 1361.204 Stop valve, Str., Sc., SVA-S 25 (J)(r)(u) 1 X X X X X X X X X X
08-01 P170 1361.205Stop valve, Str., Sc., SVA-S 32 (J)(s)(u)
1 X X X X X X X X X X
08-02 P165 1361.202Stop valve, Str., Sc., SVA-S 15 (J)(p)(o)
1 X X X X X X X X X X
08-02 P165 1361.203 Stop valve, Str., Sc., SVA-S 20 (J) (q) 1 X X X X X X X X X X08-02 P165 1361.204 Stop valve, Str., Sc., SVA-S 25 (J) (r) 1 X X X X X X X X X X08-02 P165 1361.206 Stop valve, Str., Sc., SVA-ST 40 (J) (s) 1 X X X X X X X X X X
08-03 1377.262Gasket (set of 2), ring ø32/22 x 1,0 (p)(o)
2 X X X X X X X X X X
08-03 1336.029 Gasket (set of 2), ring ø39/29 x 1,5 (r) 2 X X X X X X X X X X08-03 P167 1372.395 Solenoid valve EVRAT 10 (excl. coil) (o) 1 X X X X X X X X X X08-03 P167 1372.347 Solenoid valve EVRA 15 (excl. coil) (p) 1 X X X X X X X X X X08-03 P167 1372.348 Solenoid valve EVRA 20 (excl. coil) (q) 1 X X X X X X X X X X08-03 P167 1372.349 Solenoid valve EVRA 25 (excl. coil) (r) 1 X X X X X X X X X X08-03 P167 1372.039 Solenoid valve EVRA 32 (excl. coil) (s) 1 X X X X X X X X X X08-03 P167 1372.538 Coil 10W 110V 50/60Hz 1 X X X X X X X X X X08-03 P167 1372.537 Coil 10W 220/230V 50/60Hz 1 X X X X X X X X X X08-03 P166 1375.174 Strainer, Str., FA 15 (p) 1 X X X X X X X X X X08-03 1377.250 Repair kit (strainer and gasket), FA 15 1 X X X X X X X X X X08-03 1377.078 Seal kit (f. cover and flange), FA 15 1 X X X X X X X X X X08-03 P166 1375.173 Strainer, Str., FA 20 (q) 1 X X X X X X X X X X08-03 1377.251 Repair kit (strainer and gasket), FA 20 1 X X X X X X X X X X08-03 1377.079 Seal kit (f. cover and flange), FA 20 1 X X X X X X X X X X08-03 P166 1375.186 Strainer (body), Str., FIA 25 D (r) 1 X X X X X X X X X X08-03 P166 1375.190 Strainer (body), Str., FIA 40 D (s) 1 X X X X X X X X X X08-03 P166 1375.082 Element 100 my for FIA 25-40 (r)(s) 1 X X X X X X X X X X08-03 P168 1377.263 Sight glass SGT 15 TG (p)(o) 1 X X X X X X X X X X08-03 P168 1377.268 Sight glass SGT 24 TG (r)(q) 1 X X X X X X X X X X08-03 P168 2511.022 Sight glass MLI 40 D (s) 1 X X X X X X X X X X08-04 P169 1379.064 Actuator ICAD 600 for motor valve 1 X X X X X X X X X X
08-04 P169954A0070H01EU Motorvalve ICM 20-A (excl. actuator)
1 X X X X X X X X X X
08-04 P169954A0070H02EU Motorvalve ICM 20-B (excl. actuator)
1 X X X X X X X X X X
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator009252 en 2016.06 33/50
Fig-Index
P&IRef.
Itemnumber
Description
Qty
.
SA
B1
20
S
SA
B1
20
M
SA
B1
20
L
SA
B1
20
E
SA
B1
51
S
SA
B1
51
M
SA
B1
51
L
SA
B1
51
E
SA
B1
93
S
SA
B1
93
L
08-04 P169954A0070H03EU Motorvalve ICM 20-C (excl. actuator)
1 X X X X X X X X X X
08-04 P169954A0071H01EU Motorvalve ICM 25-A (excl. actuator)
1 X X X X X X X X X X
08-04 P169954A0072H01EU Motorvalve ICM 32-A (excl. actuator)
1 X X X X X X X X X X
08-04 1377.447 Service kit, gaskets/O-rings f. ICM 20 1 X X X X X X X X X X08-04 1377.448 Service kit, gaskets/O-rings f. ICM 25 1 X X X X X X X X X X08-04 1377.449 Service kit, gaskets/O-rings f. ICM 32 1 X X X X X X X X X X08-04 1377.453 Manual magnet tool f. ICM 20-32 1 X X X X X X X X X X08-05 P172/
175SPEC Application-specific or customized (j) 3 X X X X X X X X X X
08-06 PI SPEC Application-specific or customized (j) 1 X X X X X X X X X X
08-07 YY-9951A0053H01 Solenoid 3-way valve PE (excl. coil)
1 X X X X X X X X X X
08-07951A0095H01 Coil 11W 120V 50/60Hz
1 X X X X X X X X X X
08-07951A0095H02 Coil 11W 240V 50/60Hz
1 X X X X X X X X X X
08-08 SPEC Application-specific or customized (j) 1 X X X X X X X X X X08-09 SPEC Application-specific or customized (j) 1 X X X X X X X X X X J) Spare parts kits and sets for stop valve in Fig. 12.j) Contact Refrigeration Parts Centre for more information.o) If liquid injection flow max. 8.6 kg/min.p) If liquid injection flow max. 15.6 kg/min.q) If liquid injection flow max. 25.9 kg/min.r) If liquid injection flow max. 57.6 kg/min.s) If liquid injection flow max. 227 kg/min.t) If liquid injection, single flow.u) If liquid injection, dual flow.
1.1.12 Valve set, by-pass at start-up
Pos. P&I Designation Quantity Part no.Kit
code no.
230 Regulating valve REG 20 1 1364.317 231 Solenoid valve EVRA20 1 1372.348 Flange kit for PM20 1 1344.125 Coil 10W 220V EVM 1 1372.330 232 Non-return valve NRVA 20 1 1372.246 233 Stop valve SVA-ST 20 1 1361.053
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
34/50Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator
009252 en 2016.06
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator009252 en 2016.06 35/50
1.1.13 Suction/discharge/stop valve, typical -SAB 120, SAB 151, SAB 193 and SABflex
Fig. 12: Drawing for list 09
List 09
Fig-Index
P&I Ref.Itemnumber
Description
Qty
.
SA
B1
20
S
SA
B1
20
M
SA
B1
20
L
SA
B1
20
E
SA
B1
51
S
SA
B1
51
M
SA
B1
51
L
SA
B1
51
E
SA
B1
93
S
SA
B1
93
L
SA
Bfl
ex
09- -Suction/discharge/service stopvalve(See chart below)
1 X X X X X X X X X X X
09-01 - Cone and cone seal (k) X X X X X X X X X X X09-02 - Packing gland (k) X X X X X X X X X X X09-03 - Packing washer (k) X X X X X X X X X X X09-04 - O-ring (k) X X X X X X X X X X X09-05 - O-ring (k) X X X X X X X X X X X09-06 - Gasket (k) X X X X X X X X X X X09-07 UI Unused index 09-08 - Washer (k) X X X X X X X X X X X09-09 UI Unused index 09-10 - Cap (k) X X X X X X X X X X X09-11 - Gasket for cap (k) X X X X X X X X X X X09-12 - Soft backseat (k) X X X X X X X X X X X09-13 - Wear ring (k) X X X X X X X X X X X k) Quantity as required for one valve in the actual kit.
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
36/50Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator
009252 en 2016.06
1.1.14 Spare parts list for all suction/discharge/service/stop valves
ItemNumber
DescriptionRepair kit
(a)
Kit,Packing gland
(b)
Kit,Cap incl.
gasket (c)
1364.325 Reg. valve, Ang., Sc., REG 40 #10 2453.044 1377.249 1365.0981361.117 Stop valve, Ang., Sc., SNV-ST CD10 (d) (d) (d)1361.052 Stop valve, Ang., Sc., SVA-ST 15 1377.417 1377.273 1365.0961361.078 Stop valve, Str., Sc., SVA-ST 15 1377.417 1377.273 1365.0961361.053 Stop valve, Ang., Sc., SVA-ST 20 1377.417 1377.273 1365.0971361.079 Stop valve, Str., Sc., SVA-ST 20 1377.417 1377.273 1365.0971361.054 Stop valve, Ang., Sc., SVA-ST 25 1377.418 1377.249 1365.0981361.067 Stop valve, Str., Sc., SVA-ST 25 1377.418 1377.249 1365.0981361.055 Stop valve, Ang., Sc., SVA-ST 32 1377.418 1377.249 1365.0981361.064 Stop valve, Str., Sc., SVA-ST 32 1377.418 1377.249 1365.0981361.056 Stop valve, Ang., Sc., SVA-ST 40 1377.418 1377.249 1365.0981361.065 Stop valve, Str., Sc., SVA-ST 40 1377.418 1377.249 1365.0981361.057 Stop valve, Ang., Sc., SVA-ST 50 1377.419 1377.274 1365.0981361.066 Stop valve, Str., Sc., SVA-ST 50 1377.419 1377.274 1365.0981361.063 Stop valve, Ang., Sc., SVA-ST 65 1377.420 1377.274 1365.0981361.068 Stop valve, Str., Sc., SVA-ST 65 1377.420 1377.274 1365.0981361.073 Stop valve, Ang., Sc., SVA-ST 80 1377.421 1377.279 1365.0991361.074 Stop valve, Ang., Sc., SVA-ST 100 1377.422 1377.279 1365.0991361.075 Stop valve, Ang., Sc., SVA-ST 125 1377.423 1377.282 1365.1001361.076 Stop valve, Ang., Sc., SVA-ST 150 1377.424 1377.282 1365.1001361.077 Stop valve, Ang., Sc., SVA-ST 200 1377.425 1377.283 1365.1011361.108 Stop valve, Ang., Sc., SVA-DH 250 1377.285 1377.284 1365.1151361.135 Stop valve, Ang., Sc., SVA-DH 300 1377.286 1377.284 1365.115 a) SVA-ST consists of: Cone complete including screw and steel balls, packing gland including gasketsand all other necessary gaskets (Index 1-6/11-12).SVA-DH consists of: Cone wear ring including gaskets, packing gland including gasketsand all other necessary gaskets (Index 1-6/11-12).b) Consists of packing gland including gaskets (Index 2-5).c) Consists of cap with gasket (Index 10/11).d) No spare parts available (tighten packing gland or replace all with a new valve).
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator009252 en 2016.06 37/50
1.1.15 Discharge stop/check valve - SAB 120, SAB 151 and SAB 193
Fig. 13: Drawing for list 10
1.1.16 Spare parts list for check valve
Item number DescriptionBonnetgasket
(fig. 10-17)Seal kit (e)
Spring kit0.5 bar (f)
Spring kit2 bar (f)
1372.589 Check valve, Ang., GVD 100 (T) 956A0045H11 956A0045H12 N/A 956A0045H14956A0045H02 Check valve, Ang., GVD 100 (U) 956A0045H11 956A0045H12 956A0045H13 N/A
T) At high stage operating mode only.U) At Booster operating mode only.e) Consists of gasket and various rings (Index 16-22).f) Consists of plate, rivet and spring (Index 14/28-29).
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
38/50Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator
009252 en 2016.06
List 10
Fig-Index
P&I Ref.Item num-ber
Description
Qty
.
SA
B1
20
S
SA
B1
20
M
SA
B1
20
L
SA
B1
20
E
SA
B1
51
S
SA
B1
51
M
SA
B1
51
L
SA
B1
51
E
SA
B1
93
S
SA
B1
93
L
10- - Assembly, discharge stop/checkvalve (Item no. see Fig-Index01-07) Spare parts for: stopvalve, see fig.9 - check valve,see chart previous page
1 X X X X X X X X X X
10-01 - Housing 1 X X X X X X X X X X10-02 - Bonnet 1 X X X X X X X X X X10-03 - Piston cylinder 1 X X X X X X X X X X10-04 - Piston rod 1 X X X X X X X X X X10-05 - Piston 1 X X X X X X X X X X10-06 - Cone 1 X X X X X X X X X X10-07 - Spring screw 1 X X X X X X X X X X10-08 - Spring bushing 1 X X X X X X X X X X10-09 - Cone plate 1 X X X X X X X X X X10-10 - Cone rod 1 X X X X X X X X X X10-11 - Rear bushing 1 X X X X X X X X X X10-12 - Front bushing 1 X X X X X X X X X X10-13 - Spring 1 X X X X X X X X X X10-14 - Spring (f) 1 X X X X X X X X X X10-15 - Plug (not shown) 1 X X X X X X X X X X10-16 - Teflon ring (e) 1 X X X X X X X X X X10-17 - Bonnet gasket (e) 1 X X X X X X X X X X10-18 - Nylon washer (e) 1 X X X X X X X X X X10-19 - Glyde ring (e) 1 X X X X X X X X X X10-20 - O-ring (e) 1 X X X X X X X X X X10-21 - O-ring (e) 1 X X X X X X X X X X10-22 - O-ring (e) 1 X X X X X X X X X X10-23 - Spring ring 1 X X X X X X X X X X10-24 - Spring ring 1 X X X X X X X X X X10-25 - Spring ring 1 X X X X X X X X X X10-26 - Nut 1 X X X X X X X X X X10-27 - Set screw (O) 0 X X X X X X X X X X10-28 - Marking plate (f) 1 X X X X X X X X X X10-29 - Rivet (f) 1 X X X X X X X X X X10-30 - Washer 1 X X X X X X X X X X10-31 - Nut 1 X X X X X X X X X X10-32 - Screw 1 X X X X X X X X X X10-33 P107 1361.117 Stop valve, Ang., Sc., SNV-ST
CD10 (J)1 X X X X X X X X X X
J) Spare parts kits and sets for stop valve in Fig. 12.O) Quantity as required (may be suggested).e) Consists of gasket and various rings (Index 16-22).f) Consists of plate, rivet and spring (Index 14/28-29).
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator009252 en 2016.06 39/50
1.1.17 Economizer SAB 120 and SAB 151
Fig. 14: Drawing for list 11 - SAB 151
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
40/50Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator
009252 en 2016.06
List 11 - SAB 120 and SAB 151
Fig-Index
P&I Ref. Item number Description
Qty
.
SA
B1
20
S
SA
B1
20
M
SA
B1
20
L
SA
B1
20
E
SA
B1
51
S
SA
B1
51
M
SA
B1
51
L
SA
B1
51
E
11- 535B0056G02EU Kit, Economizer connection system 1 X X X X 11- 535B0056G03EU Kit, Economizer connection system 1 X X 11- 535B0056G04EU Kit, Economizer connection system 1 X X 11-01 CV-3 956A0025H28EU Check valve, Str., 1-1/4", modified 1 X X X X X X 11-01 CV-3 956A0025H23EU Check valve, Str., 1-1/2", modified 1 X X11-01 959A0057H04 Gasket OD=2-5/16" 2 X X X X X X 11-01 959A0057H05 Gasket OD=2-3/4" 2 X X11-02 STR-5 950A0001H05EU Strainer 1-1/4", flange size 1-1/4" 1 X X X X X X 11-02 STR-5 950A0001H08EU Strainer 2", flange size 1-1/2" 1 X X11-02 950A0001H24 Kit for 1-1/4" strainer (V) 1 X X X X X X 11-02 950A0001H27 Kit for 2" strainer (V) 1 X X11-02 950A0001H39 Screen gasket f. 1-1/4" strainer 1 X X X X X X 11-02 950A0001H40 Screen gasket f. 2" strainer 1 X X11-02 950A0001H33 Flange gasket f. 1-1/4" strainer 2 X X X X X X 11-02 950A0001H34 Flange gasket f. 1-1/2" and 2" strainer 2 X X11-03 P141 1361.146 Stop valve, Ang., Sc., SVA-ST 32 (J) 1 X X X X X X 11-03 P141 1361.147 Stop valve, Ang., Sc., SVA-ST 40 (J) 1 X X11-04 1349.296 Connector, but weld ø46 - tube end ø42 1 X X X X 11-04 2334.031 Pipe reducer, DN 32 - ø42 1 X X 11-04 1356.028 Pipe reducer, DN 40 - DN 32 1 X X11-05 1349.391 Swivel reducer, ø42 - ø35 1 X X X X 11-05 2334.031 Pipe reducer, DN 32 - ø42 1 X X11-06 1349.390 Connector, tube end ø35 - 1 7/8-12 UN 1 X X X X 11-06 1349.384 Connector, tube end ø42 - 1 7/8-12 UN 1 X X X X J) Spare parts kits and sets for stop valve in Fig. 12.V) Consists of screen, spring and screen gasket.
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator009252 en 2016.06 41/50
1.1.18 Economizer SAB 193 and SABflex
Fig. 15: Drawing for list 11 - SAB 193 and SABflex
List 11 - SAB 193 and SABflex
Fig-Index
P&IRef.
Item number Description
Qty
.
SA
B1
93
S
SA
B1
93
L
SA
Bfl
ex
11- 535M0001G03EU Kit, Economizer connection system 1 X X 11- 535M0001G04EU Kit, Economizer connection system 1 11-01 STR-5 950A0001H08EU Strainer 2", flange size 1-1/2" 1 X X 11-01 STR-5 950A0001H06EU Strainer 2", flange size 2" 1 X11-01 950A0001H27 Kit for 2" strainer (V) 1 X X X11-01 950A0001H40 Screen gasket f. 1-1/2" & 2" strainer 1 X X X11-01 950A0001H34 Flange gasket f. 1-1/2" & 2" strainer 2 X X 11-02 CV-3 956A0025H23EU Check valve, Str., 1-1/2", modified 1 X X 11-02 CV-3 956A0025H24EU Check valve, Str., 2", modified 1 X11-03 1361.147 Stop valve, Ang., Sc., SVA-ST 40 (J) 1 X X 11-03 1361.148 Stop valve, Ang., Sc., SVA-ST 50 (J) 1 11-04 944A0358H02EU Flange, Square, 1-1/2" 1 X X 11-04 959A0057H05 Gasket OD=2-3/4" 1 X X 11-04 1356.031 Reducer DN 80/DN 65 1 11-04 3013.539 Flange, Square DN50 1 X J) Spare parts kits and sets for stop valve in Fig. 12V) Consists of screen, spring and screen gasket
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
42/50Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator
009252 en 2016.06
1.1.19 Oil pump - SAB 120, SAB 151 and SAB 193
Fig. 16: Drawing for list 12 - SAB 151 shown
List 12
Fig-Index
P&I Ref. Item number DescriptionQ
ty.
SA
B1
20
S
SA
B1
20
M
SA
B1
20
L
SA
B1
20
E
SA
B1
51
S
SA
B1
51
M
SA
B1
51
L
SA
B1
51
E
SA
B1
93
L
12-01 P/PM-1 960A0090G01Ass., oil pump, 1 hp3x400/460V 50/60Hz
1 X X X X
12-01 P/PM-1960A0082G01960A0082G03
Ass., oil pump, 1 hp3x400/460V 50/60Hz
1 X X X X X
12-01 960A0090H01 Pump only (f. 1 hp) 1 X X X X 12-01 960A0082H01 Pump only (f. 1&1-1/2 hp) 1 X X X X X12-01 914A0015H01 Motor only (f. 1 hp) 1 X X X X 12-01 914A0015H02 Motor only (f. 1&1-1/2 hp) 1 X X X X X12-01 960A0068H11 Coupling only (f. 1 hp) 1 X X X X 12-01 960A0066H11 Coupling only (f. 1&1-1/2 hp) 1 X X X X X
12-01 P7PM-1 960A0082G01Ass, oil pump, 1 hp3x400/460V 50/60Hz
1 X X X X
12-01 960A0075H41 Kit, shaft seal f. pump, 1 hp (N) 1 X X X X 12-01 960A0076H41 Kit, shaft seal f. pump, 1-3 hp (N) 1 X X X X X12-02 CV-3 956A0014H01 Check valve, Str., 3/4" 1 X X X X X X X X X N) Consists of shaft seal, O-ring, bearings and locknut.
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator009252 en 2016.06 43/50
1.1.20 Coupling assembly - SAB 120 and SAB 151
COMPRESSOR FLANGE MOTOR FLANGE
CENTRE
Fig. 17: Drawing for list 13 - Coupling SAB 120 and SAB 151
List 13 - SAB 120 and SAB 151
Fig-Index
P&I Ref. Item number Description
Qty
.
SA
B1
20
S
SA
B1
20
M
SA
B1
20
L
SA
B1
20
E
SA
B1
51
S
SA
B1
51
M
SA
B1
51
L
SA
B1
51
E
13- 1524.L02 Ass., Coupling 8C, ø55 & 1.575" (g) 1 X X X X 13- 1524.L03 Ass., Coupling 9C, ø60 & 1.575" (g) 1 X X X X 13- 1524.L04 Ass., Coupling 9C, ø65 & 1.575" (g) 1 X X X X 13- 1524.L34 Ass., Coupling 10C, ø65 & 1.575" (g) 1 X X X X 13- 1524.L08 Ass., Coupling 10C, ø70 & 1.575" (g) 1 X X X X 13- 1524.L05 Ass., Coupling 9C, ø60 & 2.000" (g) 1 X X X X13- 1524.L06 Ass., Coupling 9C, ø65 & 2.000" (g) 1 X X X X13- 1524.L33 Ass., Coupling 10C, ø65 & 2.000" (g) 1 X X X X13- 1524.L07 Ass., Coupling 10C, ø70 & 2.000" (g) 1 X X X X13-01 930A0093H05 Center for coupling size 9C 1 X X X X13-01 930A0093H11 Center for coupling size 10C 1 X X X X g) Motor and compressor bore respectively.
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
44/50Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator
009252 en 2016.06
1.1.21 Coupling assembly - SAB 193
Fig. 18: Drawing for list 13 - Coupling SAB 193
List 13 - SAB 193
Fig-Index
P&IRef.
Item number DescriptionQ
ty.
SA
B1
93
S
SA
B1
93
L
13- 1524.275 Ass., Coupling ø65 & ø2,251" (g) (h) 1 X X13- 1524.276 Ass., Coupling ø70 & ø2,251" (g) (h) 1 X X13- 1524.283 Ass., Coupling ø80 & ø2,251" (g) (i) 1 X X13-01 720C0078H11 Kit, Disc pack including all fasteners 2 X X13-02 720C0079H11 Kit, Disc pack including all fasteners 2 1524.311 Ass., Coupling ø80 & ø2,251" (g) (i) (j) 1 X X g) Motor and compressor bore respectively.h) As spare parts kit use 14-01.i) As spare parts kit use 14-02.j) Coupling spacer short L=148.
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator009252 en 2016.06 45/50
1.1.22 Coupling assembly - SABflex
Fig. 19: Drawing for list 13 - Coupling SABflex
List 13 - SABflex
Fig-Index
P&IRef.
Item number
Description
Qty
.
SA
Bfl
ex
Feder
Single Double
13- 1526.002 Locking bushing 1 X13- 2125.483 2125.491 Ass., Coupling ø45 & L = 122 (g) (L) 1 X13- 2125.484 2125.492 Ass., Coupling ø55 & L = 142 (g) (L) 1 X13- 2125.481 2125.490 Ass., Coupling ø65 & L = 112 (g) (L) 1 X13- 2125.479 2125.489 Ass., Coupling ø65 & L = 155 (g) (L) 1 X13- 2125.486 2125.494 Ass., Coupling ø65 & L = 185 (g) (L) 1 X13- 2125.485 2125.493 Ass., Coupling ø70 & L = 155 (g) (L) 1 X13- 2125.487 2125.495 Ass., Coupling ø70 & L = 185 (g) (L) 1 X g) Motor and compressor bore respectively.L) Spacer length.
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
46/50Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator
009252 en 2016.06
1.1.23 Piping and instrumentation, typical
Typical piping diagram for SAB 120
200
158
191
113
126
147
104
103
117116
154
160161
120
200
155
156
153
135
121
195
150
104
119
159
194
GAS TOTHE COMPR.
SUCTION
DIS
CH
AR
GE
GA
S FR
OM
UN
IT
106
163
108
PV-1
115114
TSOC/WCOC
105
102107
152
193
133132131
130
143141
142
101
151
103
105
192
129
Fig. 20
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator009252 en 2016.06 47/50
Typical piping diagram for SAB 151
DIS
CH
AR
GE
GA
S
FRO
M U
NIT
DISCHARGE STOP/CHECK VALVE ASSEMBLY PURGE VALVE
SUCTION VALVE SHIPPED LOOSE
SUCTION GAS TO COMPR
SEE TABLE FOR SAFETY VALVE
REF OUT WATER IN
REF IN WATER OUT
TSOC / WCOC CUSTOMER IS RESPONSIBLE FOR PROVIDING AND INSTALLING RELIEF PROTECTION IF COOLER IS ISOLATED SAFETY VALVE
ECONOMIZER KIT
1 1/2 HAND EXPANSION VALVE
OILCHARGE
OPTIONAL
181182
108
105104
103107
126102
192 191
152
114
129
101
151
115
158
128
127
157
159
140
193
154
160
119
144145
146
139
133132
130
131
106
161
120
200
156
136
135
123
124153
195
196
138
137
121
194
117
116
163
143 142 141
155
Fig. 21
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
48/50Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator
009252 en 2016.06
Typical piping diagram for SAB 193
200
151
158
129
101
128
127
192
191
126
157
152
193
104
103
117116
154
160161
120
200136
124
138
196
156
137
135121
195
123
155
119 139
144 145
146
194
GAS TOTHE COMPR.
SUCTION
GA
S TO
THE
CO
MPR
.
SUC
TIO
N
DIS
CH
AR
GE
GA
S FR
OM
UN
IT
106
163
108
PE3
TE2
PV-1
115114
TSOC/WCOC
REF INWATER OUT
TCV1
PE2
OF-2
105
102 107 159
140
OF-1
153
133132131
130
REF OUTWATER IN
143
141
142
S S
A B
NC
SAFETY VALVE
COMPRESSOR END VIEW
ECONOMIZER KIT
1PE
TE4
4PE
1TE
F
C
F
C
KP7
1LG LG
2
1LSL
P-1PM-1
1HSL3
TE
PS
J
Z1
Z1Z1 4809-052-5
M-1C-1
Fig. 22
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator009252 en 2016.06 49/50
Typical piping diagram for SABflex
136
138
135195
123196
137
121
156
120
200161 106
194
160
154119
117
116
163
193
108103
159
152157 155153
191192
105104
102
204
143
142
141
190
151
205
128
158
203
206127
133132131
130
4809-060
190
202
102
230
231
232
233
Non-return valve, delivered by JCI as loose part. Placed on uppermost side of discharge line.
By-pass non-return valve, optional
Fig. 23
Note: The 3-digit numbers do not refer to the spare parts list. They refer to the legend in theOperating manual and the Engineering, Service and Maintenance manual.
Spare parts list SAB 120, SAB 151, SAB 193 A-frame and SABflex
50/50Spare parts manual - SAB 120, SAB 151, SAB 193 A-frame and SABflex with OHU 04123 oil separator
009252 en 2016.06