SECTION 2 - Tistory

SECTION 2RECEIVER/DRIERS & TX VALVES

Receiver Filter-Driers

Drier Brackets

Thermostatic Expansion Valves

40

Notes

41

SEC

TION

2

Receiver/Driers & TX Valves Introduction IndexDESICCANT TYPESXH 5 Suitable for R12 only.XH 7 Suitable for R12 and R134a.XH 9 Suitable for R12, R134a and Blends.CODE OF PRACTICEPressure Relief Valves and Fusible PlugsThe Code of Practice Items 17 and 18 quoted below,govern the use of Pressure Relief Valves and Fusible Plugsin Receiver-Driers.17. PRESSURE RELIEFIt is not acceptable to use pressure relief devices as the onlymeans of protection against over-pressurisation.Whenever practicable any vehicle requiring servicing that isonly fitted with a pressure relief valve shall be fitted with ahigh/low pressure cut-out switch.18. FILTER-DRIERWhenever the refrigerant system is opened, the filter-drieror accumulator, when fitted, shall be replaced inaccordance with the manufacturer’s instructions. Where themanufacturer has not issued instructions the units shall bereplaced whenever the system is opened. The filter/driershall not incorporate a fusible plug, unless an alternativetype is not manufactured.It is acceptable therefore in certain circumstances for FusePlugs and Pressure Relief Valves to be used.Some Ford Motor Company, Japanese and Europeanoriginal equipment will continue to retain these features.

FUSE PLUG FUNCTIONThe primary function of the fuse plug is to offer the airconditioning system protection against excess heat.The temperature at which the fuse plug is designed to ventvaries, but it is usually between 107°C and 118°C.A secondary function of the fuse plug is to offer the airconditioning system protection against excessively highpressure. The pressure at which the fuse plug will vent isalways considerably higher than that which will activate thehigh pressure cut-out switch.In general, a leaking fuse plug is evidence of a hightemperature having occurred, and a blown fuse plug isevidence of excessively high pressure. When a fuse plugvents, it is performing as designed to protect expensivesystem componentry.Though fusible plugs vent to atmosphere, the use of thesedevices is still completely legal in all States of Australiawhen used in conjunction with a low/high pressure cut-outswitch, and some Australian manufacturers still specify fuseplugs as the last line of defence against high temperaturesand high pressures.Regulations and specifications may change from time totime and State to State. Clients should check with localauthorities for latest regulations.

MALE FLARE MALE O-RING FEMALE O-RING FEMALE O-RINGTO TO TO TO

MALE FLARE MALE O-RING FEMALE O-RING BARB

MALE O-RING MALE O-RING MALE O-RINGTO TO TO PAD TYPE

FEMALE O-RING FEMALE FLARE QUICK DISCONNECT

PageUNIVERSAL

‘O’-Ring ....................................................42-43Pad ................................................................44Flare...............................................................45

ALFA ..................................................................46AUDI ..................................................................46BMW.............................................................46-47CHRYSLER...........................................................47CITROEN ............................................................47DAIHATSU ..........................................................47FORD ............................................................48-50HOLDEN........................................................51-52HONDA ........................................................52-53HYUNDAI ......................................................53-54JAGUAR .............................................................54MAZDA.........................................................54-55MERCEDES-BENZ...........................................55-56

PageMITSUBISHI .........................................................57NISSAN ........................................................58-59PEUGEOT ......................................................59-60PORSCHE ...........................................................60PROTON ............................................................60RENAULT ............................................................60ROVER ...............................................................60SAAB .................................................................61SUBARU ........................................................61-62SUZUKI...............................................................62NIPPONDENSO..................................................62TOYOTA.............................................................63VOLVO...............................................................63TRUCK & TRACTOR & MISC. PARTS................64-67ADDITIONAL DRIER RANGE...........................68-69TRANSPORT REFRIGERATION.........................70-71

DIMENSIONS AND CONNECTIONS

INDEX

42

Driers Universal O-Ring

OLD NEW OLD NEW OLD NEWNUMBER NUMBER NUMBER NUMBER NUMBER NUMBER

NF00805 047-6000SMS NF00160 047-0128M NF00750 047-2001

XH9 Desiccant XH9 Desiccant

Connections: Inlet: 3/8" MO Connections: Inlet: 3/8" MO Connections: Inlet: 5/16" MOOutlet: 3/8" MO Outlet: 3/8" MO Outlet: 5/16" MO

Diameter: 2.5" (63.5 mm) Diameter: 2.36" (60 mm) Diameter: 2.68" (68 mm)Height: 7.6" (193 mm) Height: 7.6" (193 mm) Height: 7.5" (190.5 mm)Fittings: 2 Male switch plugs Fittings: 2 Male switch plugs Fittings: 2 Male switch plugsDesiccant: 2 cu. ins Desiccant: 2 cu. ins Construction: Aluminium

SUITABLE FOR: SUITABLE FOR: SUITABLE FOR:Ford Corsair Ford Corsair Ford Telstar AR/AS 83-87Holden Astra Holden Astra Honda Prelude 94Holden Commodore VB/VC/VH/VK/VL/VR/VS Holden Camira Mitsubishi Magna TM/TN 87-90Honda Integra/Accord 85-87 Holden Commodore VL 6 cyl & V8 NippondensoMazda MX6 Mitsubishi Lancer CA/CB/CC Toyota Camry 87-89Mitsubishi Galant HG/HH Mitsubishi Nimbus UF Toyota Corolla AE82Mitsubishi Lancer CA/CB/CC Nissan Bluebird 5/83 on Toyota CressidaMitsubishi Nimbus UF Nissan Exa Toyota Landcruiser 60Nissan Bluebird 5/83 on Nissan Nomad 1/84 on Toyota Hiace/TaragoNissan Datsun 200B Nissan Patrol 1/84 onNissan Gazelle Nissan PintaraNissan Navara Nissan Pulsar 87-91Nissan Patrol Pre 1/84 Nissan SkylineNissan Patrol 1/88 onNissan PintaraNissan Pulsar 87-91Rolls-Royce

OLD NEW OLD NEWNUMBER NUMBER NUMBER NUMBER

NF00740 047-2034 NF00530 RD2428

Also BMW 318/323, Honda,Suzuki, ToyotaXH9 Desiccant

Connections: Inlet: 5/16" MO Connections: Inlet: 3/8" MOOutlet: 5/16" MO Outlet: 3/8" MODiameter: 2.5" (63.5 mm) Diameter: 2.36" (60 mm)Height: 8.0" (203 mm) Height: 8.1" (206 mm)Fittings: Integral bottom fuse plug Fittings: Binary switch left handDesiccant: 2.2 cu. ins side of inlet

Desiccant: 2.2 cu. ins

43

SEC

TION

2

Driers Universal O-Ring (cont’d)


NF00125 047-2563M NF00950 047-2036 047-5002 047-5002

Also Caterpillar, ARA Rooftop Porsche With Dye CapsuleXH9 Desiccant

Connections: Inlet: 3/8" MO Connections: Inlet: 3/8" MO Connections: Inlet: #5 MOOutlet: 3/8" MO Outlet: 3/8" MO Outlet: #5 MO

Diameter: 3.0" (76 mm) Diameter: 2.64" 67 mm Diameter: 2.36" (60.0mm)Height: 6.33" (161 mm) Height: 7.72" 196 mm Height: 7.6" (193mm)Fittings: 2 Switch plugs Fittings: 2 Male switch ports Fittings: 2 Male Switch PlugsDesiccant: 4 cu. ins. SUITABLE FOR:

Commodore VR, VSNippondenso

OLD NEWNUMBER NUMBER

047-2034 047-2034

With Dye Capsule

Connections: Inlet: #6 MOOutlet: #6 MO

Diameter: 2.36" (60.0mm) Height: 7.6" (193mm)Fittings: 2 Male Switch PlugsDesiccant: 2 cu. ins

SUITABLE FOR:Ford CorsairHolden AstraHolden Commodore VB/VC/VH/VK/VL/VR/VSHonda Integra/Accord 85-87Mazda MX6Mitsubishi Galant HG/HHMitsubishi Lancer CA/CB/CCMitsubishi Nimbus UFNissan Bluebird 5/83 onNissan Datsun 200BNissan GazelleNissan NavaraNissan Patrol Pre 1/84Nissan Patrol 1/88 onNissan PintaraNissan Pulsar 87-91Rolls-Royce

44

Driers Universal pad


NF00755 ARD-1001 NF01055 ARD-0805 NF01000 ARD-1005

XH9 Desiccant

Connections: Pad typeDiameter: 2.38" (60.5 mm)Height: 6.75" (171.5 mm)Desiccant: 2.2 cu. ins.

NIPPONDENSO PAD TYPESuits all new systems 1989 on:Daihatsu Charade G100 w/3 cyl.

6/87-1/93Daihatsu Feroza 12/92Daihatsu Applause A101 10/89-2/94Ford Capri SA/SC 10/89-7/93 (R12)Holden Apollo JK 8/89-5/91Holden Apollo JL 8/91-2/93Holden Barina MF/MH 2/89-5/94Holden Nova LE 8/89-8/91 (R12)Holden Nova LF 90-93Honda Accord 90-93 (R12)Honda Prelude 90-93Mazda MX5 9/89-91 (R12)Mitsubishi Magna TR 4/93-3/94Mitsubishi Magna TS 94Nissan Pintara 92-93Nissan Pulsar 92-93Subaru Liberty 92-93 (R12)Suzuki Swift 1.3L. 90-94 (R12)Toyota Camry SV20, 21, 22, 5/87-2/93Toyota Celica 91-2/94 (R12)Toyota Corolla AE92, 93, 94,

89-8/93 (R12)Toyota Cressida MX83 89-90 (R12)Toyota Dyna 150 91-11/93 (R12)Toyota Hilux 90-3/94 (R12)Toyota Landcruiser HZJ80, HZJ75,

HDJ80, 90-6/93 (R12)Toyota Landcruiser FJ80, FJ70, 90-6/93Toyota MR2 91-3/94 (R12)Toyota Paseo 91-8/93 (R12)Toyota 4Runner 89-9/93 (R12)

Connections: Pad TypeDiameter: 60 mmHeight: 174 mm

SUITABLE FOR:Mitsubishi L300 Express SJ 10/94- (R134a)Nissan Maxima J30 10/92-10/93 (R134a)Subaru Impreza 94-95Subaru Liberty 95- (R134a)

Connections: Pad typeDiameter: 60 mmHeight: 185 mm

SUITABLE FOR:Daihatsu Charade G200 w/3 cyl.

3/92-4/96Holden Apollo JM 4/93-8/95Mitsubishi Magna TS 3/94-3/96 (R134a)Mitsubishi Pajero NJ 11/93-9/96 (R134a)Proton Satria 1.5L, 2/97-98Subaru Liberty 94-95 (R134a)Suzuki Baleno 1.3/1.6L. 92-95 (R134a)Suzuki Sierra 1.3L. 3/94-95 (R134a)Suzuki Swift 1.3L. 2/94-95 (R134a)Suzuki Vitara 1.6L. 10/94-95 (R134a)Toyota Camry SDV10, VDV10, 2/92-4/95Toyota Celica 2/94-95 (R134a)Toyota Corolla AE102 8/93-97 (R134a)Toyota Hilux LN85/106/111,

3/94-95 (R134a)Toyota Hilux RN85/105/110,

3/94-95 (R134a)Toyota MR2 3/94-95 (R134a)Toyota RAV4 10/94-95 (R134a)Volkswagen Transporter T4

(ND System) 94-95


NF01005 ARD-1006


SUITABLE FOR:Holden Nova LF 9/91-10/94 (R134a)Rover Discovery 4/94-95 (R134a)Toyota Corolla AE102 8/93-95Toyota Landcruiser FZ J80, FZJ75,

7/94-95Toyota Paseo 8/93-94 (R134a)Toyota 4Runner 9/93-94 (R134a)

45

SEC

TION

2

Driers Universal flare


NF00515 RD2407 NF00800 047-6000SMF NF00090 047-2104M

Connections: Inlet: 3/8" MF Connections: Inlet: 3/8" MF Connections: Inlet: 3/8" MFOutlet: 3/8" MF Outlet: 3/8" MF Outlet: 3/8" MF

Diameter: 2.36" (60 mm) Diameter: 2.36" (60 mm) Diameter: 3.0" (76 mm)Height: 8.1" (206 mm) Height: 7.6" (193 mm) Height: 6.31" (160 mm)Fittings: Binary switch left hand Fittings: 2 Male switch plugs Fittings: 2 Male switch plugs

side of inlet Desiccant: 2 cu. ins


047-6001 –

With Dye Capsule

Connections: Inlet: #6 MFOutlet: #6 MF

Diameter: 2.36" (60.0mm)Height: 7.6" (193mm)Fittings: 2 Male Switch Plugs

Also Massey Ferguson 305Cane TractorXH9 Desiccant

46

Driers Alfa, Audi, BMW


NF00158 047-4320 NF00945 RD4164 NF00860 RD4433

ALFA, AUDI, Peugeot & SAAB ALFA 164 (Also Saab 9000) BMW 525/528 ’82-’86XH9 Desiccant XH9 Desiccant

Connections: Inlet: 3/8" MO Connections: Inlet: 3/8" FO Connections: Inlet: 16mm MOOutlet: 3/8" FO Outlet: 3/8" MO Outlet: 16mm MO

Diameter: 2.36" (60 mm) Diameter: 2.99" (76 mm) Diameter: 3.0" (76 mm)Height: 7.5" (191 mm) Height: 6.0" (152 mm) Height: 6.5" (165 mm)Fittings: Male switch plug Fittings: Male switch plug Fittings: Fuse plug, Schrader

1/4" Schrader Valve charge port valve, Male switch plug


NF00849 NF00849 NF00850 RD4434 NF00865 RD4430

BMW 320 ’81-’83 BMW 318/323 ’85-’87 BMW 318/323733/735 (Bosch)

Connections: Inlet: 1/2" MF Connections: Inlet: 3/8" MO Connections: Inlet: 16mm MOOutlet: 1/2" MF Outlet: 3/8" MO Outlet: 20mm MO

Diameter: 76 mm Diameter: 3.0" (76 mm) Diameter: 3.0" (76 mm)Height: 168 mm Height: 6.625" (168 mm) Height: 6.625" (168 mm)Fittings: Fuse plug,Schrader Fittings: Fuse plug, Schrader Fittings: Fuse plug, Male switch

valve valve, Switch plug plug, Schrader valve


NF00740 047-2034 NF00847 RD9152 NF00848 RD9151

Universal Type Drier for: BMW 3 SERIES E36 BMW 5 SERIES E34 2/’89 OnBMW 318/323 (Nippondenso Type)Also Honda, Suzuki, ToyotaXH9 Desiccant

Connections: Inlet: 5/16" MO Connections: Pad Type Connections: Pad TypeOutlet: 5/16" MO Height: 99 mm Height: 186 mmDiameter: 2.5" (63.5 mm) Fittings: Fuse plug, Two maleHeight: 8.0" (203 mm) switch plugs, Aux.Fittings: Integral bottom fuse plug switch portDesiccant: 2.2 cu. ins

47

SEC

TION

2

Driers Chrysler, Citroen, Daihatsu


NF00026 NF00026 NF00935 RD4200 NF00755 ARD-1001

CHRYSLER VOYAGER CITROEN Universal Pad Type Drier for:XH9 Desiccant DAIHATSU CHARADE G100 w/3 Cyl.

6/’87-1/’93DAIHATSU FEROZA 12/’92DAIHATSU APPLAUSE A10110/’89-2/’94XH9 Desiccant

Connections: Pad Type Connections: Inlet: 3/8" MO Connections: Pad TypeDiameter: 60 mm Outlet: 3/8" MO Diameter: 2.38" (60.5 mm)Height: 172 mm Diameter: 1.95" (50 mm) Height: 6.75" (171.5 mm)

Height: 9.45" (240 mm) Desiccant: 2.2 cu. ins.Fittings: Schrader valve


NF01000 ARD-1001

Universal Pad Type Drier for:DAIHATSU CHARADE G200 w/3 Cyl.

3/’92-4/’96Refer Universal Section for fulllisting of applicable vehicles


48

Driers Ford


NF00984 047-2222M NF00985 047-2807M NF00986 047-2909M

FALCON/FAIRLANE EA/EB/NA FALCON EB3, ED, EF FALCON ELXH9 Desiccant XH7 Desiccant (R134a)


Diameter: 2.75" (70 mm) Diameter: 2.5" (63.5 mm) Diameter: 60 mmHeight: 10.08" (256 mm) Height: 7.98" (203 mm) Height: 200 mmFittings: Switch Plug Fittings: Fuse plug Fittings: Fuse plug RH of Inlet

Mounting Studs Switch Plug Mounting studs

OLD NEW OLD NEW OLD NEWNUMBER NUMBER NUMBER NUMBERR NUMBER NUMBER

NF00987 047-1905 NF00760 ARD-0800 NF01115 ARD-0603

FALCON AU Accumulator LASER KF, KH 6/’90-10/’93 (R12) LASER KH 11/’93-5/’94 (R134a)(Also Mazda) TELSTAR AV – 1/’90-1/’92 (R12)XH9 Desiccant

Diameter: 89 mm Connections: Pad Type Connections: Pad TypeHeight: 276 mm Diameter: 2.5" (63.5 mm) Diameter: 80 mm

Height: 7.6" (193 mm) Height: 174 mmFittings: Male switch plug Fittings: 2 Switch Ports

Schrader valve


NF00981 047-2138M NF00982 047-2163MS NF00983 047-4016M

FALCON XD Post 4/’81 FALCON XE Post 10/’83 FALCON XF, UTILITY XGFALCON XE Pre 10/’83 (Sanden Compressor) XH9 Desiccant(XE York Compressor) XH9 DesiccantXH9 Desiccant


Diameter: 2.75" (70 mm) Diameter: 2.75" (70 mm) Diameter: 2.5" (63.5 mm)Height: 9.86" (250 mm) Height: 10.17" (258 mm) Height: 12.3" (312 mm)Fittings: Switch plug Fittings: HP/LPCO Switch Desiccant: 4 cu. ins.Desiccant: 4 cu. ins Schrader valve

49

SEC

TION

2

Driers Ford (cont’d)


NF01123 ARD0605 NF00750 047-2021 NF00980 047-10030M

LASER KL LIATA 12/’96-98 (R134a) Universal Type Drier for: TELSTAR 1989(Also Mazda) TELSTAR AR/AS (Also Hyundai

Refer Universal Section for full & Subaru)listing of applicable vehiclesXH9 Desiccant

ALUMINIUM CONSTRUCTION Connections: No. 5 TubeConnections: Pad Type Connections: Inlet: 5/16" MO Inlet: 16 mm MODiameter: 60 mm Outlet: 5/16" MO Outlet: 16 mm MOHeight: 148 mm Diameter: 2.68" (68 mm) Diameter: 2.75" (70 mm)Fittings: Switch Port Height: 7.5" (190.5 mm) Height: 7.25" (184 mm)

Fittings: Fuse plug Fittings: Male switch plugDesiccant: 4.4 cu. ins.



TELSTAR AX 5/’93-8/’94 (R134a) TELSTAR AX 1/’92-5/’93 (R12) FORD FESTIVA WB 4/’94-12/’96LASER KJ 10/’94-12/’96 (R134a) LASER KJ 5/’94-12/’94 (R134a) (R134a)

Connections: Pad Type Connections: Pad Type Connections: Pad TypeDiameter: 60 mm Diameter: 60 mm Diameter: 60 mmHeight: 160 mm Height: 151 mm Height: 150 mm

Fittings: 2 Switch Ports



Universal Pad Type Drier for: FORD CAPRI SE 7/’93-7/’94 FORD CAPRI 6/’93-’95 (R134a)FORD CAPRI (R12)Suits most new systems 1989 on –Refer Universal Section for fulllisting of applicable vehiclesXH9 Desiccant

Connections: Pad Type Connections: Pad Type Connections: Pad TypeDiameter: 2.38" (60.5 mm) Diameter: 60 mm Diameter: 60 mmHeight: 6.75" (171.5 mm) Height: 174 mm Height: 145 mmDesiccant: 2.2 cu. ins. Fittings: Switch port

50

Driers Ford (cont’d)


NG00255 422-004 NF00160 047-0128M

FORD XF SIGHT GLASS Universal Type Drier for:Without Switch & Fuse Plug FORD CORSAIR

Refer Universal Section for fulllisting of applicable vehiclesXH9 Desiccant

Connections: Inlet: 3/8" MOOutlet: 3/8" MO

Diameter: 3.5" (89 mm)Height: 7.6" (193 mm)Fittings: 2 Male switch plugsDesiccant: 2 cu. ins.

Notes

51

SEC

TION

2

Driers Holden


NF00402 07-5000 NF00015 RD6012 NF00160 047-0128M

NQ01035 1452 COMMODORE VB, VC Universal Type Drier for:XH9 Desiccant COMMODORE VL 6 & 8 CYL & ASTRA

WB HOLDEN ACCUMULATOR Refer Universal Section for full(NQ01035 for WB Statesman) listing of applicable vehicles

XH9 Desiccant

Connections: Inlet: 3/4" FO Connections: Inlet: 3/4" FO Connections: Inlet: 3/8" MOOutlet: 3/4" FO Outlet: 3/4" MO Outlet: 3/8" MO

Diameter: 3.5" (89 mm) Diameter: 3.5" (89 mm) Diameter: 2.36" (60 mm)Height: 10.0" (254 mm) Height: 9.0" (229 mm) Height: 7.6" (193 mm)Fittings: 2 Schrader valves, Tube Fittings: Schrader valve inlet end Fittings: 2 Male switch plugsAssembly (NQ01035) Desiccant: 6 cu. ins. Desiccant: 2 cu. ins.


NF00805 047-6000SMS NF00404 RD6023 NF00635 RD6108

Universal Type Drier for: COMMODORE VN, VP 8/’88-9/’91 Universal Type Drier for:COMMODORE VB, VC, VH, VK, VL COMMODORE VR, VSRefer Universal Section for full XH9 Desiccantlisting of applicable vehiclesXH9 Desiccant

Connections: Inlet: 3/8" MO Connections: Inlet: 3/4" FO Connections: Inlet: 5/16" MOOutlet: 3/8" MO Outlet: 3/4" MO Outlet: 5/16" MO

Diameter: 2.36" (60 mm) Diameter: 3.5" (89 mm) Diameter: 2.36" (60 mm)Height: 8.02" (204 mm) Height: 9.0" (229 mm) Height: 8.1" (206 mm)Fittings: 2 Male switch plugs Fittings: 2 Schrader valves Fittings: 2 Male switch plugs


NF00810 047-5000SMS NF00532 047-H516

Universal Type Drier for: COMMODORE VTCOMMODORE VR, VS HYUNDAI LANTRA -94XH9 Desiccant

Connections: Inlet: 5/16" MO Connections: No. 6 TubeOutlet: 5/16" MO Inlet: No. 5 MO

Diameter: 2.36" (60 mm) Outlet: No. 5 MOHeight: 8.1" (206 mm) Diameter: 2.36" (60 mm)Fittings: 2 Male switch plugs Height: 8.10" (206 mm)

Fittings: 2 Male Switch Plugs

52

Driers Holden, Honda


NF00160 047-0128M NF00430 RD8517 NF00755 ARD-1001

CAMIRA GM V.I.R. DESICCANT BAG Universal Type Drier for:XH9 Desiccant APOLLO JK 8/’89-7/’91

APOLLO JL 8/’91-3/’93BARINA MF-MH ’90-’94NOVA LE 7/’89-7/’91XH9 Desiccant

Connections: Inlet: 3/8" MOOutlet: 3/8" MO

Diameter: 2.36" (60 mm) Connections: Pad TypeHeight: 7.6" (193 mm) Diameter: 2.38" (60.5 mm)Fittings: 2 Male switch plugs Height: 6.75" (171.5 mm)Desiccant: 2 cu. ins. Desiccant: 2.2 cu. ins.



Universal Type Drier for: BARINA ML 4/’87-1/’89 Universal Type Drier for:APOLLO JM 4/’93-8/’95 NOVA LF 9/’91-10/’94 (R134a)Refer Universal Section for full Refer Universal Section for fulllisting of applicable vehicles listing of applicable vehicles



NF00720 NF00720 NF00715 07-1158 NF01110 047-2009

HONDA PRELUDE ’83-’86 HONDA CIVIC ’84-’87 HONDA CIVIC 1988-’92 (R12)

Connections: Inlet: 3/8" MO Connections: Inlet: 3/8" MO Connections: Pad TypeOutlet: 3/8" MO Outlet: 3/8" MO Diameter: 70 mm

Diameter: 2.5" (63.5 mm) Diameter: 2.5" (63.5 mm) Height: 165 mmHeight: 10.5" (267 mm) Height: 10.5" (267 mm)Fittings: Integral bottom fuse plug Desiccant: 3.5 cu. ins.Desiccant: 3.5 cu. ins.

53

SEC

TION

2

Driers Honda, Hyundai



HONDA CIVIC 1992-’93 (R12) HONDA CIVIC 1994-’95 (R134a) HONDA CIVIC ’95-’98 (R134a)HONDA INTEGRA DA HONDA INTEGRA 7/’93-’95 (R134a)9/’91-7/’93 (R12)

Connections: Pad Type Connections: Pad Type Connections: Pad TypeDiameter: 60 mm Diameter: 60 mm Diameter: 60 mmHeight: 165 mm Height: 165 mm Height: 159.5 mm

Fittings: Switch port


NF00740 047-2034 NF00755 ARD-1001 NF00750 047-2021

Universal Type Drier for: Universal Pad Type Drier for: Universal Pad Type Drier for:HONDA HONDA PRELUDE ’90-’93 HONDA PRELUDE ’94(Also BMW, Suzuki, Toyota) HONDA ACCORD ’90-’93 (R12) Refer Universal Section for fullXH9 Desiccant XH9 Desiccant listing of applicable vehicles

XH9 Desiccant

Connections: Inlet: 5/16" MO Connections: Pad Type Connections: Inlet: 5/16" MOOutlet: 5/16" MO Diameter: 2.38" (60.5 mm) Outlet: 5/16" MO

Diameter: 2.5" (63.5 mm) Height: 6.75" (171.5 mm) Diameter: 2.68" (68 mm)Height: 8.0" (203 mm) Desiccant: 2.2 cu. ins. Height: 7.5" (190.5 mm)Fittings: Integral bottom fuse plug Fittings: 2 Male switch plugsDesiccant: 2.2 cu. ins. Construction: Aluminium


NF00532 047-H516 NF00980 047-10030M

HYUNDAI LANTRA -94 HYUNDAI EXCEL 1992 On(Also Telstar & Subaru)

Connections: No. 6 Tube Connections: No. 5 TubeInlet: No. 5 MO Inlet: 16 mm MOOutlet: No. 5 MO Outlet: 16 mm MO

Diameter: 2.36" (60 mm) Diameter: 2.75" (70 mm)Height: 8.10" (206 mm) Height: 7.25" (184 mm)Fittings: 2 Male Switch Plugs Fittings: Male switch plug

Desiccant: 4.4 cu. ins.

54

Driers Hyundai, Jaguar, Mazda


NF00979 RD6026 NF01120 ARD-0501 NF01121 ARD-0502

HYUNDAI EXCEL GLS ’90-4/’93 HYUNDAI EXCEL ’94-’97 (R134a) HYUNDAI LANTRA 11/’94 On (R134a)(Also Mazda 323 Astina)

Connections: Inlet: Male SL Connections: Pad type Connections: Pad typeOutlet: Male SL Diameter: 60 mm Diameter: 60 mm

Diameter: 88 mm Height: 150 mm Height: 150 mmHeight: 215 mmFittings: 2 Schrader Valves


NF00470 07-1137 NF00495 RD9100 NF00496 RD9050

JAGUAR V12 6 Cyl. JAGUAR XJ6 6 Cyl. JAGUAR XJ40Long Type

Connections: Inlet: 3/8" MO Connections: Inlet: 3/8" MO Connections: Inlet: 3/8" MOOutlet: 3/8" MO Outlet: 3/8" FO Outlet: 3/8" MO

Diameter: 1.75" (44.5 mm) Diameter: 3.0" (76.2 mm) Diameter: 2.95" (75 mm)Height: 16.75" (425 mm) Height: 6.1" (155 mm) Height: 7.28" (185 mm)Fittings: Male switch plug Fittings: Male switch plug Fittings: Male switch plug



Universal Pad Type Drier for: MAZDA 323 ’90-’93 (Also Laser) MAZDA 121 1/’94-12/’96 (R134a)MAZDA MX5 XH9 Desiccant (R12) MAZDA 323 7/’94-3/’96 (R134a)Suits most new systems 1989 on – MAZDA 626 9/’94-6/’97 (R134a)Refer Universal Section for full MAZDA 929 ’94-’95 (R134a)listing of applicable vehicles XH7 DesiccantXH9 Desiccant

Connections: Pad type Connections: Pad type Connections: Pad typeDiameter: 2.38" (60.5 mm) Diameter: 2.5" (63.5 mm) Diameter: 60 mmHeight: 6.75" (171.5 mm) Height: 7.6" (193 mm) Height: 160 mmDesiccant: 2.2 cu. ins. Fittings: Male switch plug,

Schrader valve

55

SEC

TION

2

Driers Mazda, Mercedes-Benz



MAZDA MX5 ’91-’94 (R12) MAZDA 323 11/’93-5/’94 (R12) MAZDA 626 GF 7/’97 OnMAZDA 121 ’90-’94 MAZDA 626 ’90-’91MAZDA 626 9/’91-’94 (R12) MAZDA 929 ’89-’91 (R12)MAZDA 626 V6 1/’92-8/’94 (R12)MAZDA 929 ’91-’93 (R12)

Connections: Pad type Connections: Pad type Connections: Pad typeDiameter: 60 mm Diameter: 80 mm Diameter: 60 mmHeight: 151 mm Height: 174 mm Height: 163 mmFittings: 2 Switch Ports Fittings: 2 Switch Ports Fittings: Switch port



MAZDA EUNOS 500 6/’96 On MAZDA 323 ASTINA ’97 (R134a) MAZDA 323 ASTINA 1/’97 On(Also Hyundai Excel) (R134a)

(Also Laser KL Liata)

Connections: Pad type Connections: Pad type Connections: Pad typeDiameter: 60 mm) Diameter: 60 mm Diameter: 60 mmHeight: 150 mm Height: 150 mm Height: 148 mm

Fittings: Switch port


NF01122 ARD-0601 NF00595 RD1114

MAZDA 121 11/’90-1/’94 (R12) MERCEDES-BENZ SERIES 220, 240, 250MAZDA EUNOS 30X-V6 SERIES W114, W115, W1166/’96-12/’96

Connections: Pad type Connections: Inlet: 1/2" MFDiameter: 60 mm Outlet: 1/2" MFHeight: 159 mm Diameter: 3.0" (76.2 mm)Fittings: 2 Switch Ports Height: 6.625" (168 mm)

Fittings: Male switch port,Temp. switch port

56

Driers Mercedes-Benz (cont’d)


NF00600 RD1116 NF00605 RD1123 NF00610 RD1126

MERCEDES-BENZ 280, 350, 450 MERCEDES-BENZ 230, 280, 300 MERCEDES-BENZ EARLY SERIES W126SERIES W116 SERIES W123 With provision for Temperature

Pressure Switch

Connections: Inlet: 3/8" MF Connections: Inlet: 3/8" MO Connections: Inlet: 3/8" MOOutlet: 3/8" MF Outlet: 3/8" MO Outlet: 3/8" MO

Diameter: 3.0" (76.2 mm) Diameter: 3.0" (76.2 mm) Diameter: 3" (76.2 mm)Height: 6.625" (168 mm) Height: 6.625" (168 mm) Height: 6.625" (168 mm)Fittings: Male switch port, Fittings: Male switch port, Fittings: Male switch plug

Temp. switch port Temp. switch port


NF00615 RD4400 NF00620 RD1124 NF00621 RD1128

MERCEDES-BENZ 190 MERCEDES-BENZ 300E, 300D MERCEDES-BENZ LATE SERIES W126SERIES W201 SERIES W124 With provision for Fan Pressure

Switch


Diameter: 3" (76.2 mm) Diameter: 3" (76.2 mm) Diameter: 76 mmHeight: 6.33" (161 mm) Height: 6.625" (168 mm) Height: 168 mmFittings: 2 Male switch plugs, Fittings: Male switch plug, Fittings: 2 Male switch plugs

Fuse plug Fuse plug


NF00622 047-4222 NF00623 RD4398M NF00624 NF00624

MERCEDES-BENZ SERIES W107 MERCEDES-BENZ SERIES W107 MERCEDES-BENZ SERIES W108380SL, 450SLC 560 SL

Connections: Inlet: 3/8" MF Connections: Inlet: 3/8" FO Connections: Inlet: 1/2" MFOutlet: 1/2" MF Outlet: 3/8" FO Outlet: 1/2" MF

Diameter: 76 mm Diameter: 76 mm Diameter: 76 mmHeight: 162 mm Height: 168 mm Height: 168 mmFittings: High Press. Relief Valve Fittings: Male switch plug, Fittings: Temp. switch plug

Male switch plug Fuse plug Fuse plug

57

SEC

TION

2

Driers Mitsubishi


NF00055 047-9007 NF00160 047-0128M NF00750 047-2021

CHRYSLER VALIANT, KENWORTH Universal Type Drier for: Universal Type Drier for:(Also Massey Ferguson Tractor) Mitsubishi vehicles MAGNA TM, TNXH9 Desiccant Refer Universal Section for full Refer Universal Section for full

listing of applicable vehicles listing of applicable vehiclesXH9 Desiccant XH9 Desiccant

Connections: Inlet: 3/8" MO Connections: Inlet: 3/8" MO ALUMINIUM CONSTRUCTIONOutlet: 3/8" MO Outlet: 3/8" MO Connections: Inlet: 5/16" MO

Diameter: 2.75" (70 mm) Diameter: 2.36" (60 mm) Outlet: 5/16" MOHeight: 10.12" (257 mm) Height: 7.6" (193 mm) Diameter: 2.68" (68 mm)Fittings: Male switch plug, Fittings: 2 Male switch plugs Height: 7.5" (190.5 mm)

HP Relief valve Desiccant: 2 cu. ins. Fittings: Fuse plugDesiccant: 7 cu. ins.



Universal Pad Type Drier for: Universal Type Drier for: MAGNA TE 4/’96-5/’97 (R134a)MAGNA TR MAGNA TS 1994-’95 R134a LANCER CC – Sedan/Wagon ’92-’95Suits most new systems 1989 on – PAJERO 1994-’95 R134aRefer Universal Section for full XH7 Desiccantlisting of applicable vehiclesXH9 Desiccant

Connections: Pad type Connections: Pad Type Connections: Pad TypeDiameter: 2.38" (60.5 mm) Diameter: 60 mm Diameter: 60 mmHeight: 6.75" (171.5 mm) Height: 185 mm Height: 174 mmDesiccant: 2.2 cu. ins. Fittings: 2 Switch Ports


NF00800 047-6000SMF NF01125 ARD-0703 NF01055 ARD-0805

PAJERO LANCER CC 9/’92-7/’96/CK ’98 Universal Pad Type Drier for:XH9 Desiccant MAGNA TF 6/’97 On (R134a) L300 EXPRESS SJ 10/’94 (R134a)

TRITON MK 10/’96 On (R134a)

Connections: Inlet: 3/8" MF Connections: Pad Type Connections: Pad TypeOutlet: 3/8" MF Diameter: 60 mm Diameter: 60 mm

Diameter: 2.5" (63.5 mm) Height: 192.5 mm Height: 174 mmHeight: 8.02" (203.7 mm) Fittings: Switch portFittings: 2 Male switch plugDesiccant: 2 cu. ins.

58

Driers Nissan


NF00160 047-0128M NF00160 047-0128M NF00690 07-1133

Universal Type Drier for: PATROL 1/’88 On, PINTARA, DATSUNNISSAN Vehicles SKYLINE PATROLRefer Universal Section for full XH9 Desiccantlisting of applicable vehiclesXH9 Desiccant

Connections: Inlet: 3/8" MO Connections: Inlet: 3/8" MO Connections: Inlet: 20 mm MOOutlet: 3/8" MO Outlet: 3/8" MO Outlet: 16 mm MO

Diameter: 2.36" (60 mm) Diameter: 2.36" (60 mm) Diameter: 2.5" (63.5 mm)Height: 7.6" (193 mm) Height: 7.6" (193 mm) Height: 8.0" (203 mm)Fittings: 2 Male switch plugs Fittings: 2 Male switch plugs Fittings: Fuse plug, Switch portDesiccant: 2 cu. ins. Desiccant: 2 cu. ins. Desiccant: 4.4 cu. ins.


NF00636 RD9300 NF00696 07-1155 NF00697 07-1156

NISSAN PATROL GQ ’88 On NISSAN NISSAN 280ZX ’81-’83

Connections: Inlet: 20 mm MO Connections: Inlet: 16 mm MO Connections: Inlet: 16 mm MOOutlet: 16 mm MO Outlet: 16 mm MO Outlet: 16 mm MO

Diameter: 60 mm Diameter: 2.75" (70 mm) Diameter: 2.75" (70 mm)Height: 275 mm Height: 7.5" (190.5 mm) Height: 7.5" (190.5 mm)Fittings: 2 Male switch plugs Fittings: Fuse plug, Switch port Fittings: Fuse plug, Switch port

Desiccant: 3.5 cu. ins. Desiccant: 3.5 cu. ins.


NF00695 07-1160 NF01045 ARD-0802 NF01055 ARD-0805

NISSAN 200ZX ’84-’86 NISSAN MAXIMA J30 Universal Pad Type Drier for:NISSAN PULSAR ’82-’87 Imported 2/’90-10/’92 (R12) NISSAN MAXIMA J30STANZA, MAXIMA (Some) 10/’92-10/’93 (R134a)

Connections: Inlet: 20 mm MO Connections: Pad Type Connections: Pad TypeOutlet: 16 mm MO Diameter: 60 mm Diameter: 60 mm

Diameter: 2.5" (63.5 mm) Height: 174 mm Height: 174 mmHeight: 8.0" (203 mm)Fittings: Fuse plug, Switch portDesiccant: 4.4 cu. ins.

59

SEC

TION

2

Driers Nissan, Peugeot



NISSAN PULSAR N14 11/’91-’94 (R12) NISSAN BLUEBIRD 7/’93-10/’94 NISSAN BLUEBIRD ’97 (R134a)NISSAN SERENA 3/’92-9/’94 (R12) NISSAN MAXIMA A32 10/’93-10/’95 NISSAN NAVARA D22 3/’97 On (R134a)

NISSAN PULSAR N14 ’94-’95 NISSAN PULSAR N15 2/’97-’98 (R134a)NISSAN PULSAR N15 ’95 On NISSAN 200SX ’97 (R134a)(All R134a)


Fittings: 2 Switch Ports Fittings: Switch port



NISSAN PULSAR N15 ’95-4/’96 NISSAN PULSAR N15 4/’96 On NISSAN PULSAR N15 ’98-’99(R134a) (R134a) PATHFINDER V6 ’99

Connections: Pad Type Connections: Pad Type Connections: Pad TypeDiameter: 60 mm Diameter: 60 mm Diameter: 60 mmHeight: 150 mm Height: 148 mm Height: 148 mmFittings: Switch Port Fittings: Switch Port Fittings: Switch Port


NF01127 ARD-0801 NF01129 ARD-0809 NF00158 047-4320

NISSAN MICRA 5/’95 On (R134a) NISSAN PATHFINDER VG33E PEUGEOT (Also Alfa, Audi)11/’95 On (R134a) XH9 Desiccant

Connections: Pad Type Connections: Pad Type Connections: Inlet: 3/8" MODiameter: 60 mm Diameter: 60 mm Outlet: 3/8" FOHeight: 150 mm Height: 165 mm Diameter: 2.36" (60 mm)Fittings: Switch Port Fittings: Switch Port Height: 7.5" (191 mm)

Fittings: Male switch plug1/4" Schrader Valvecharge port

60

Driers Peugeot, Porsche, Proton, Renault, Rover


NF00920 RD4005 NF00950 NF00950 NF00955 RD4911

PEUGEOT 405 PORSCHE PORSCHE 911

Connections: Inlet: 3/8" MO Connections: Inlet: 3/8" MO Connections: Inlet: 3/8" MFOutlet: 3/8" MO Outlet: 3/8" MO Outlet: 3/8" MF

Diameter: 2.0" (51 mm) Diameter: 67 mm Diameter: 1.95" (50 mm)Height: 9.45" (240 mm) Height: 196 mm Height: 11.57" (294 mm)Fittings: Moisture indicator, Fittings: 2 Male switch plugs Fittings: Male switch plug,

Schrader valve Temp. switch port

OLD NEW OLD NEW OLD NEW NUMBER NUMBER NUMBER NUMBER NUMBER NUMBER

NF00960 RD4922 NF00965 RD4928 NF01000 ARD-1005

PORSCHE 911 PORSCHE 928 Universal Pad Type Drier for:PROTON SATRIA 1.5L 2/’97-’98Refer Universal Section for fulllisting of applicable vehicles

Connections: Inlet: 3/8" MO Connections: Inlet: 1/2" FO Connections: Pad TypeOutlet: 3/8" MO Outlet: 3/8" MO Diameter: 60 mm

Diameter: 1.96" (50 mm) Diameter: 2.95" (75 mm) Height: 185 mmHeight: 11.57" (294 mm) Height: 6.1" (155 mm)Fittings: Male switch plug, Fittings: Male switch plug,

Temp. switch port Temp. switch port,Schrader valve


NF00158 047-4320 NF01050 ARD-0803 NF01005 ARD-1006

RENAULT ROVER DISCOVERY ’93-4/’94 (R12) Universal Pad Type Drier for:XH9 Desiccant ROVER DISCOVERY 4/’94-’95

(R134a)

Connections: Inlet: 3/8" MO Connections: Pad Type Connections: Pad TypeOutlet: 3/8" FO Diameter: 60 mm Diameter: 60 mm

Diameter: 2.36" (60 mm) Height: 145 mm Height: 205 mmHeight: 7.5" (191 mm)Fittings: Male switch plug

1/4" Schrader Valvecharge port

61

SEC

TION

2

Driers SAAB, Subaru


NF00158 047-4320 NF00945 RD4164 NF00946 RD4165

SAAB (Also Alfa) SAAB 9000 (Also Alfa) SAAB 9000 1992-XH9 Desiccant XH9 Desiccant

Connections: Inlet: 3/8" MO Connections: Inlet: 3/8" FO Connections: Inlet: 3/8" MOOutlet: 3/8" FO Outlet: 3/8" MO Outlet: 3/8" MO

Diameter: 2.36" (60 mm) Diameter: 2.99" (76 mm) Diameter: 76 mmHeight: 7.5" (191 mm) Height: 6.0" (152 mm) Height: 155 mmFittings: Male switch plug Fittings: Male switch plug Fittings: 2 Male Switch Plugs

1/4" Schrader Valvecharge port


NF00770 07-1174 NF00980 047-10030M NF00780 07-1176

SUBARU ‘82-‘83 SUBARU ’83-’84 SUBARU(Also Hyundai & Telstar)

Connections: Inlet: 16 mm MO Connections: No. 5 Tube Connections: Inlet: 16 mm MOOutlet: 16 mm MO Inlet: 16 mm MO Outlet: 16 mm MO

Diameter: 2.5" (63.5 mm) Outlet: 16 mm MO Diameter: 2.75" (70 mm)Height: 7.63" (194 mm) Diameter: 2.75" (70 mm) Height: 7.25" (184 mm)Fittings: 3 Switch ports Height: 7.25" (184 mm) Fittings: Male switch plugDesiccant: 3.5 cu. ins. Fittings: Male switch plug Desiccant: 4.4 cu. ins.

Desiccant: 4.4 cu. ins.


NF00785 07-1177 NF00790 07-1178 NF00755 ARD-1001

SUBARU ’85-’87 SUBARU ’85-’87 Universal Pad Type Drier for:XH9 Desiccant SUBARU LIBERTY ’92

Suits most new systems 1989 on –Refer Universal Section for fulllisting of applicable vehiclesXH9 Desiccant

Connections: Inlet: 16 mm MO Connections: Inlet: 16 mm MO Connections: Pad typeOutlet: 16 mm MO Outlet: 16 mm MO Diameter: 2.38" (60.5 mm)

Diameter: 2.75" (70 mm) Diameter: 2.75" (70 mm) Height: 6.75" (171.5 mm)Height: 7.25" (184 mm) Height: 7.25" (184 mm) Desiccant: 2.2 cu. ins.Desiccant: 4.4 cu. ins. Desiccant: 4.4 cu. ins.

62

Driers Subaru, Suzuki, Nippondenso


NF01000 ARD-1005 NF01055 ARD-0805 NF00740 047-2034

Universal Pad Type Drier for: Universal Pad Type Drier for: Universal Type Drier for:SUBARU LIBERTY ’94-’95 (R134a) SUBARU LIBERTY ’95 On (R134a) SUZUKI (Also BMW, Honda, Toyota)

SUBARU IMPREZA ’94-’95 XH9 Desiccant

Connections: Pad Type Connections: Pad Type Connections: Inlet: 5/16" MODiameter: 60 mm Diameter: 60 mm Outlet: 5/16" MOHeight: 185 mm Height: 174 mm Diameter: 2.5" (63.5 mm)

Height: 8.0" (203 mm)Fittings: Integral bottom fuse plugDesiccant: 2.2 cu. ins.


NF01000 ARD-1005 NF00755 ARD-1001 NF00635 NF00635

Universal Pad Type Drier for: Universal Pad Type Drier for: NF00810 047-5000SMSSUZUKI – NIPPONDENSO SYSTEMSBALENO 1.3 & 1.6L 2/’95 Suits most new systems 1989 on – NIPPONDENSO (Also Universal)SIERRA 1.3L 3/’94-’95 Refer Universal Section for full NF00635 = XH9 DesiccantSWIFT 1.3L 2/’94-’95 listing of applicable vehicles NF00810 = XH7 DesiccantVITARA 1.6L 10/’94-’95 XH9 Desiccant

Connections: Pad Type Connections: Pad type Connections: Inlet: 5/16" MODiameter: 60 mm Outlet: 5/16" MOHeight: 185 mm Diameter: 2.38" (60.5 mm) Diameter: 2.36" (60 mm)

Height: 6.75" (171.5 mm) Height: 8.1" (206 mm)Desiccant: 2.2 cu. ins. Fittings: 2 Male switch plugs

63

SEC

TION

2

Driers Toyota, Volvo


NF00740 047-2034 NF00750 047-2021 NF01000 ARD-1005

Universal Type Drier for: Universal Type Drier for: TOYOTA – Replacement forTOYOTA TOYOTA Vehicles R134a Systems(Also BMW, Honda, Suzuki) Refer Universal Section for full Camry – SVD10, VDV10, 8/’93-’95XH9 Desiccant listing of applicable vehicles Celica 2/’94-’95

XH9 Desiccant MR2 3/’94-’95Hilux 3/’94-’95RAV4 10/’94-’95XH7 Desiccant

Connections: Inlet: 5/16" MO ALUMINIUM CONSTRUCTION Connections: Pad typeOutlet: 5/16" MO Connections: Inlet: 5/16" MO Diameter: 60 mm

Diameter: 2.5" (63.5 mm) Outlet: 5/16" MO Height: 185 mmHeight: 8.0" (203 mm) Diameter: 2.68" (68 mm)Fittings: Integral bottom fuse plus Height: 7.5" (190.5 mm)Desiccant: 2.2 cu. ins. Fittings: Fuse plug


NF01005 ARD-1006 NF01130 ARD-1008 NF00644 RD7020

TOYOTA – Replacement for TOYOTA HIACE Petrol ’91-11/’93 VOLVO 740, 760 ACCUMULATORR134a Systems (R134a)

Landcruiser 80, 75 7/’94-’95 TOYOTA TARAGO ’96 On Corolla – After 8/’93 (Twin System)Paseo 8/’93-’94 (R134a)4Runner 9/’93-’94 (R134a)XH7 Desiccant

Connections: Pad type Connections: Pad type Connections: Inlet: 3/4" FODiameter: 60 mm Diameter: 60 mm Outlet: 3/4" MOHeight: 205 mm Height: 245 mm Diameter: 89 mm

Height: 241 mmFittings: Schrader Valve

64

Driers Truck & Tractor


NF00400 07-9107 NF00125 047-2563M NF00680 07-9168

ALLIS CHALMERS CATERPILLAR ARA ROOFTOP CATERPILLAR – Late ModelVERSATILE TRACTOR (Also Universal)

XH9 Desiccant

Connections: Inlet: 3/8" MF Connections: Inlet: 3/8" MO Connections: Inlet: 3/8" MOOutlet: 3/8" MF Outlet: 3/8" MO Outlet: 3/8" MO

Diameter: 4.0" (102 mm) Diameter: 3.0" (76 mm) Diameter: 4.0" (102 mm)Height: 6.88" (175 mm) Height: 6.33" (161 mm) Height: 8.0" (203 mm)Desiccant: 9 cu. ins. Fittings: 2 Switch plugs Fittings: HP relief valve, Male

Desiccant: 4 cu. ins. pressure switch plug


NF00681 834032 NF00345 07-9119 NF00010 047-4700

CATERPILLAR ’65-’75 CATERPILLAR JOHN DEERE

XH9 Desiccant

Connections: Inlet: 3/8" MF Connections: Inlet: 3/8" MF Connections: Inlet: 3/8" FOOutlet: 3/8" MF Outlet: 3/8" MF Outlet: 3/8" MO

Diameter: 1.75" (44.5 mm) Diameter: 100 mm Diameter: 4.0" (102 mm)Height: 19.75" (502 mm) Height: 194 mm Height: 7.88" (200 mm)Fittings: Fuse plug Fittings: Fuse plug left of Inlet Fittings: 2 Sight Glasses on sideDesiccant: 3.5 cu. ins. Desiccant: 10 cu. ins.


NF00011 07-088252-01 NF00660 07-9167 NF00685 RD7030

JOHN DEERE JOHN DEERE FORD TRACTOR

XH9 Desiccant 5610, 6610, 6710, 7710

Connections: Inlet: 3/8" FO Connections: Inlet: 3/8" FO Connections: Inlet: 3/8" FOOutlet: 3/8" MO Outlet: 3/8" MO Outlet: 3/8" FO

Diameter: 4.0" (102 mm) Diameter: 4.0" (102 mm) Diameter: 4.0" (102 mm)Height: 7.88" (200 mm) Height: 9.0" (229 mm) Height: 11.0" o/aFittings: 2 Sight Glasses on side Fittings: Fuse plug (280 mm)Desiccant: 10 cu. ins.

65

SEC

TION

2

Driers Truck & Tractor (cont’d)


NF00686 07-9117 NF00684 RD6112 NF00001 047-4702MF

FORD TRACTOR ’76-’79 Universal – e.g. Ford Tractor NF00002 NF00002

INTERNATIONAL HARVESTERXH9 Desiccant

Connections: Inlet: 7/8" Quick Connections: Inlet: 3/8" MO Connections: Inlet: 3/8" MFInlet: Disconnect Outlet: 3/8" MO Outlet: 3/8" MFOutlet: 3/8" MO Diameter: 100 mm Diameter: 4.0" (102 mm)

Diameter: 4.0" (102 mm) Height: 184 mm Height: 6.18" (157 mm)Height: 8.0" (203 mm) Desiccant: 9 cu. ins.Fittings: Fuse plugDesiccant: 12.5 cu. ins.


NF00005 047-4702 NF00670 07-9131 NF00650 07-7130

NF00003 07-0880022-00 INTERNATIONAL HARVESTER INTERNATIONAL TRUCK ’73-’84

INTERNATIONAL HARVESTERXH9 Desiccant

XH9 Desiccant

Connections: Inlet: 3/8" FO Connections: Inlet: 3/8" MO Connections: Inlet: 7/16" FOOutlet: 3/8" MO Outlet: 3/8" FO Outlet: 3/8" FO

Diameter: 4.0" (102 mm) Diameter: 4.0" (102 mm) Diameter: 3.0" (76 mm)Height: 6.18" (157 mm) Height: 8.0" (204 mm) Height: 10.63" (270 mm)Desiccant: 9 cu. ins. Fittings: Fuse plug


NF00055 047-9007 NF00080 047-9006 NF00655 088324

KENWORTH KENWORTH KENWORTHXH9 Desiccant XH9 Desiccant ’94 & Up. Class 8

OEM P/N K251-571

Connections: Inlet: 3/8" MO Connections: Inlet: 3/8" MO Connections: Inlet: 3/8" FOOutlet: 3/8" MO Outlet: 3/8" MO Outlet: 3/8" MO

Diameter: 2.75" (70 mm) Diameter: 2.75" (70 mm) Diameter: 3.0" (76 mm)Height: 10.12" (257 mm) Height: 10.3" (262 mm) Height: 10.12" (257 mm)Fittings: Male switch plug, Fittings: HPRV left of inlet, Fittings: Moisture Indicator

HP relief valve Switch plug on top Side Sight GlassDesiccant: 3.5 cu. ins. Desiccant: 2.8 cu. ins. Desiccant: 12 cu. ins.

66



NF00055 047-9007 NF00090 047-2104M NF00626 RD9010

MASSEY FERGUSON MASSEY FERGUSON MERCEDES-BENZ TRUCK2000 SERIES TRACTOR SERIES 305 CANE TRACTOR(Also Chrysler Valiant) (Also Universal)XH9 Desiccant XH9 Desiccant

Connections: Inlet: 3/8" MO Connections: Inlet: 3/8" MF Connections: Inlet: 1/2" MOOutlet: 3/8" MO Outlet: 3/8" MF Outlet: 1/2" MO

Diameter: 2.75" (70 mm) Diameter: 3.0" (76 mm) Diameter: 71 mmHeight: 10.12" (257 mm) Height: 6.31" (160 mm) Height: 200 mmFittings: Male Switch plug, Fittings: 2 Male switch plugs Fittings: 2 Male switch plugs

HP Relief Valve Desiccant: 2 cu. ins.Desiccant: 3.5 cu. ins.


NF00125 047-2563M NF00640 RD3900 NF00641 RD3915

SPERRY NEW HOLLAND VOLVO TRUCK F10 VOLVOVOLVO CLASSHEADER 690SL


Diameter: 3.0" (76 mm) Diameter: 2.75" (70 mm) Diameter: 2.75" (70 mm)Height: 6.3" (161 mm) Height: 8.66" (220 mm) Height: 9.45" (240 mm)Fittings: 2 Male switch plugs Fittings: Male switch plug, Fuse Fittings: Male switch plugDesiccant: 4 cu. ins. plug, Schrader valve Schrader valve


NF00642 RD3910 NF00643 RD3925 NF00647 RD6115

VOLVO TRACTOR VOLVO TRACTOR120b, 150BVERSITILE

Connections: Inlet: 3/8" MO Connections: Inlet: 3/8" MO Connections: Inlet: 3/8" MOOutlet: 3/8" MO Outlet: 3/8" MO Outlet: 3/8" FO

Diameter: 2.75" (70 mm) Diameter: 76 mm Diameter: 76 mmHeight: 8.66" (220 mm) Height: 156 mm Height: 220 mmFittings: Male switch plug, Fuse Fittings: Schrader valve LH Fittings: R134a Charge Port

plug, Schrader valve of Inlet, Fuse plug

67

SEC

TION

2



NZ00140 CB6024 NQ00793 AF2602 NQ01070 TO4010

ADAPTORCan be screwed into a DrierSwitch plug port and used as acharging port or to fit a femalepressure switch

UNIVERSAL DRIER BRACKET CONVERTER Standard 3/8" – 24 UNF MaleConverts No. 6 Male O-Ring Switch plug to7/16” – 20 UNFTo No. 6 Female O-Ring (1/4" Flare)

Schrader valve with Brass Cap


NQ01071 AF4000

ADAPTORR134a High SideCan be screwed into Drier Switch plug port and used as a charging port.

Supplied with Cap,Valve Core and O-Ring

68

Driers Additional Range

OLD NEW MNFRSVEHICLE MODELSNUMBER NUMBER PART No.

NF0004 NF0004 Drier C/Temp Sys W/O P/Switch RD0004NF0010 NF0010 Drier Mercedes Bus '97 RD0010NF0050 RD0050 Drier Ford Taurus Accum 97 On RD0050

NF0069M NF0069M Drier Sigma W/2 Charge Ports RD0069MNF0080 NF0080 Drier Audi 80 2.0 2.6 2.8 All RD0080NF0081 NF0081 Drier Audi 100 2.8 4dr & Quattro RD0081NF0082 RD0082 Drier Audi 84-93 Accumulator RD0082NF0108 RD0108 Drier Saab 900 3/8 MO-3/8 FO RD0108NF0110 NF0110 Drier Renault Fuego O-Ring RD0110NF0111 NF0111 Drier Renault Laguna 95 RD0111NF0112 NF0112 Drier Commodore VL V8 RD0112NF0123 NF0123 Drier Mercedes 123 (Gen Kmp) RD0123NF0124 NF0124 Drier Mercedes W124 (Gen Kmp) RD0124NF0126 NF0126 Drier Univ Flare #6 X #6 W S/P RD0126NF0128 NF0128 Drier Camira JB-JE RD0128NF0150 NF0150 Drier Spacia Yr22 11/93-6/97 RD0150NF0161 NF0161 Drier Univ Flare #6 X #6 2 S/P RD0161NF0170 NF0170 Drier Sanden Rooftop RD0170NF0202 NF0202 Drier Univ O Ring #5 X #5 2 S/P RD0202NF0205 NF0205 Drier Peugeot 205/309 RD0205NF0306 RD0306 Drier Peugeot 306 RD0306NF0501 NF0501 Drier Univ Flare #6 X #6 RD0501NF0505 NF0505 Drier Peugeot 505 Male Switch Port RD0505NF0546 NF0546 Drier Mark IV Rooftop Truck Unit RD0546NF2013 RD2013 Drier Falcon XA-XB Flare RD2013NF2014 RD2014 Drier Kingswood HG-HZ O/R-Barb RD2014NF2054 NF2054 Drier Univ Flare #6 X #6 2 S/P RD2054NF2082 NF2082 Drier Falcon XC RD2082NF2100 NF2100 Drier Ford TS100 Tractor RD2100NF2106 NF2106 Drier Falcon XD TO 4/81 RD2106NF2116 NF2116 Drier New Holland Sperry 618491 RD2116NF2138 NF2138 Drier Falcon XD-XE RD2138NF2163 RD2163 Drier Falcon XE 10/83- RD2163NF2197 NF2197 Drier Univ Flare #6 X #6 H/Duty RD2197NF2224 NF2224 Drier Kenworth W/Schraeder RD2224NF2229 NF2229 Drier Univ 3/8 FO 2 X ML SW/Plugs RD2229NF2234 NF2234 Drier Univ 3/8 FO 2 X ML SW/Plugs RD2234NF2410 NF2410 Drier Univ Sw #6 Flare R/Hand RD2410NF2426 NF2426 Drier Univ Sw #6 O Ring R/Hand RD2426NF2563 NF2563 Drier Caterpillar (O Ring) RD2563NF2564 NF2564 Drier Caterpillar (Flare) RD2564NF3010 RD3010 Drier Mondeo 95 - 8/96 RD3010NF3020 NF3020 Drier Mondeo 8/96 ON RD3020NF3021 NF3021 Drier Ford Transit Accumulator RD3021NF3040 NF3040 Drier Mondeo OE # XS7H19E647DC RD3040NF3521 NF3521 Drier Ford Tractor Springlock RD3521NF4016 NF4016 Drier Falcon XF (Non Genuine) RD4016NF4020 NF4020 Drier Denso Subcool Assy Large RD4020NF4040 NF4040 Drier Denso Subcool Assy Small RD4040NF4399 NF4399 Drier Mercedes W107 380/450SL RD4399NF4401 NF4401 Drier Mercedes W115 222/240/250 RD4401NF4402 NF4402 Drier Mercedes W140 1408300183 RD4402NF4403 NF4403 Drier Mercedes W202 C180, C220 RD4403NF4404 NF4404 Drier Mercedes Benz W140 S320 RD4404NF4413 NF4413 Drier Nippondenso Mf Fit R/Angle RD4413NF4432 NF4432 Drier BMW 5 Series/318 75-76 RD4432NF4435 NF4435 Drier BMW 318 All 82/91 RD4435


NF4436 NF4436 Drier BMW 5 & 6 Series 76-82 RD4436NF4501 RD4501 Drier Golf 3 / Polo RD4501NF5010 RD5010 Drier Patrol CQ O/R 20mm X 16mm RD5010NF5015 NF5015 Drier Telstar AT Metric #5 Pipe RD5015NF5160 NF5160 Drier Denso #5 90 Degree 67mm RD5160NF5402 NF5402 Drier VW Caravelle / T4 RD5402NF5560 RD5560 Drier Range Rover W/2 X R12 S/P RD5560NF5561 RD5561 Drier Discovery (Rover) 97- RD5561NF6027 NF6027 Drier Accum Excel 4/93-94 RD6027NF6107 NF6107 Drier W/Bin Sw #6 Flare L/Hand RD6107NF6110 NF6110 Drier W/Bin Sw #6 Flare R/Hand RD6110NF6113 RD6113 Drier Freightliner FL 112 RD6113NF6114 RD6114 Drier Univ O Ring #6 In #5 Out RD6114NF6118 RD6118 Drier Commodore VT RD6118NF6119 NF6119 Drier Univ O Ring #5 X #5 RD6119NF6121 NF6121 Drier Massey Ferguson Tractor RD6121NF6122 RD6122 Drier Lantra 91-93 W/Pr Sw #6 RD6122NF6126 NF6126 Drier Univ Sw #6 O Ring R/Hand RD6126NF6128 NF6128 Drier Univ Sw #6 O Ring L/Hand RD6128NF6156 NF6156 Drier Univ O Ring #6 X #6 RD6156NF6181 NF6181 Drier Univ O Ring #5 X #5 3 S/P RD6181NF6182 NF6182 Drier Univ O Ring #6 X #6 3 S/P RD6182NF6226 NF6226 Drier Univ Sw #5 O Ring R/Hand RD6226NF6228 NF6228 Drier Univ Sw O Ring #5 L/Hand RD6228NF6255 NF6255 Drier Commodore VL 6cyl RD6255NF6260 NF6260 Drier 200B MQ Patrol Flare RD6260NF6309 RD6309 Drier Univ O Ring #5 2 S/P 63.5 RD6309

NF6310M RD6310M Drier Univ O Ring #5 X #5 2 S/P RD6310MNF6311 NF6311 Drier Hyundai Accent 6/2000- RD6311NF6312 NF6312 Drier Odyssey Accord RD6312NF6316 NF6316 Drier Vectra RD6316NF6317 RD6317 Drier Astra TR 9/96 - 9/98 RD6317NF6359 NF6359 Drier Univ O Ring #6 2 S/P 63.5 RD6359NF6709 NF6709 Drier Univ O Ring #5 2 S/P 70mm RD6709NF6759 NF6759 Drier Univ O Ring #6 2 S/P 70mm RD6759NF7003 NF7003 Drier Cressida/Capri/Charade RD7003NF7004 NF7004 Drier Univ 3/8” MF 172 x 76 RD7004NF7008 NF7008 Drier Sonata 4 Cyl 1990 RD7008NF7014 RD7014 Drier Barina ML Discovery 93-94 RD7014NF7015 NF7015 Drier Mazda 929 V6 89-91 RD7015NF7018 RD7018 Drier Caterpillar 5V5698 RD7018NF7028 ARD-1401 Drier Swift R134a/Baleno/Sierra RD7028NF7031 NF7031 Drier Toyota Camry SV20,21,22 RD7031NF7032 RD7032 Drier Volvo 940/960 RD7032NF7037 NF7037 Drier L300 Dual Sys 96- RD7037NF7042 NF7042 Drier Univ 3/8” MF 132 x 63.5 RD7042NF7043 NF7043 Drier Univ 3/8” MF 140 x 53 RD7043NF7044 NF7044 Drier Mazda 626 96 - 6/97 RD7044NF7046 NF7046 Drier Lanos 97- RD7046NF7047 NF7047 Drier Nubira 97- Leganza 97- RD7047NF7048 NF7048 Drier Laser KJ RD7048NF7049 NF7049 Drier Barina SB 5-94 On RD7049NF7050 NF7050 Drier Volvo Accumulator Metric RD7050NF7051 NF705 Drier Subaru Impreza 7/97- RD7051NF7054 RD7054 Drier Tarago TCR20/TR39 & Hiace RD7054NF7055 NF7055 Volvo Accum 850 W/134 92-97 RD7055NF7083 NF7083 Drier Cressida MX83 89-90 RD7083

69

SEC

TION

2

Driers Additional Range (cont’d)


NF7110 NF7110 Drier Hupp-Aire Rooftop 63148-G1 RD7110NF7113 NF7113 Drier Skyline 92- RD7113NF7119 RD7119 Drier Caterpillar 6P1309 RD7119NF7128 RD7128 Drier International Truck RD7128NF7131 RD7131 Drier Niss 300ZX Subaru Leone'L' RD7131NF7133 RD7133 Drier Nissan (Var) #6 FO X #6 FO RD7133NF7145 NF7145 Drier Nissan 27640-H7206 RD7145NF7149 NF7149 Drier Mazda RX7 79-88 RD7149NF7156 NF7156 Drier Nissan OE 92130-W2400 RD7156NF7157 NF7157 Drier Civic 81-83 RD7157NF7161 NF7161 Drier Accord W/Keihin Compressor RD7161NF7163 NF7163 Drier Accord 79-82 RD7163NF7164 NF7164 Drier Accord 79-81 RD7164NF7165 NF7165 Drier Accord 86- RD7165NF7166 NF7166 Drier Prelude 79-82 RD7166NF7167 NF7167 Drier Honda Accord Mini Style RD7167NF7169 NF7169 Drier 280ZX 81-83 RD7169NF7174 NF7174 Drier Subaru 82-83 Fitt In Body RD7174NF7175 NF7175 Drier Subaru 83-84 Fitt 180 Deg RD7175NF7177 NF7177 Drier Subaru 85-87 Fitt 110 Deg RD7177NF7178 NF7178 Drier Subaru 85-87 Fitt 130 Deg RD7178NF7184 RD7184 Drier Sonata 2.0L Doh 94- R134a RD7184NF7187 NF7187 Drier Sonata 3.0 V6 90/91 RD7187NF7188 NF7188 Drier Sonata 3.0 V6 92/93 RD7188NF7189 RD7189 Drier Sonata 98-99 RD7189NF7190 RD7190 Drier Komatsu D375a-3 & D475a-3 RD7190NF8115 RD8115 Drier Jeep Cherokee RD8115NF8133 NF8133 Drier Kenworth With Moisture Ind RD8133NF8211 RD8211 Drier Caterpillar 106-5533 RD8211NF8239 NF8239 Drier John Deere/Hitachi 91-93 RD8239


NF8261 RD8261 Drier Caterpillar 3E3535 RD8261NF9000 NF9000 Drier Universal Accumulator Imp. RD9000NF9001 NF9001 Drier Universal Accumulator Met. RD9001NF9011 NF9011 Drier Mercedes Benz Truck RD9011NF9012 RD9012 Drier Caterpillar 325 Pad FTG RD9012NF9055 NF9055 Drier Saab 900 (Single Stud Mt) RD9055NF9062 NF9062 Drier International S/T Line RD9062

NF9151PS NF9151PS Drier BMW E34 5series RD9151PSNF9153 NF9153 Drier Saab 900 (Late) RD9153NF9154 NF9154 Drier BMW 740 750 840 E38 RD9154NF9157 NF9157 Drier BMW 5 Series E39 1998 RD9157NF9158 NF9158 Drier BMW 5 Series E39 1998 RD9158NF9159 NF9159 Drier BMW 5 Series E39 1997 RD9159NF9160 NF9160 Drier Massey Ferguson 3383321M3 RD9160NF9161 NF9161 Drier Massey Ferguson 3763351M1 RD9161NF9201 NF9201 Drier Jaguar 93-97 M16 x M16 RD9201NF9248 RD9248 Drier Ford Aeromax L Series RD9248NF9580 NF9580 Drier Neon (Chrysler) RD9580NF9655 NF9655 Drier Daewoo Cielo 1.5 1/95- RD9655NF9696 NF9696 Drier Daewoo Various RD9696NF9748 NF9748 Drier Universal Accumulator GM RD9748NF9775 NF9775 Drier Calibra 16V / SB Barina RD9775NF9776 NF9776 Drier Daewoo 1.5i (Not Cielo) RD9776NF9777 NF9777 Drier Jetta RD9777NF9778 NF9778 Drier VW Passat (Early) RD9778NF9779 NF9779 Drier Peugeot 605 RD9779NF9780 NF9780 Drier MGF 1.8 Roadster 96- RD9780NF9803 RD9803 Drier Sportage 12/96- RD9803NF9804 NF9804 Drier VW Passat 95- RD9804

Transport Refrigeration - Driers - Oil Separators

70

PART NUMBERPART NUMBER

OIL SEPARATOR ONLYCOMPLETE KIT (INCLUDING

VALVE, CAPILLARY & BRACKET)

3215-4808 3215-4808-KIT

Suitable for small truck & van refrigerationsystems

Connections: 3/4"-16 UNF Refrigerant In/Out,7/16"-20 UNF Oil Outlet

Body Length: 129mmBody Diameter: 75.7mm

Refrigerated transport driers designed as exact replacements for OEM driers.

Features:■ Desiccant used ensures the same or better performance, as original part■ Supplied with "O" Rings, where required■ Built to UL207 standards■ Safe working pressure 3,400 kPa (400 P.S.I.)

PART NUMBER REPLACES

3030-5788 66-5788

THERMOKING

Connections: 3/8"OR-FS# x 3/8"OR-FS## = O Ring Face Seal

Body Length: 120mmBody Diameter: 88mm


3030-5750 66-5750

THERMOKING

Connections: 5/8"OR-FS# x 1/2"OR-FS## = O Ring Face Seal



3030-4900 66-4900

THERMOKING

Connections: 5/8"MF x 1/2"MF



3030-00209-00 14-00209-00104302

TRANSICOLD

Connections: 5/8"MF* x 5/8"MF** = Has groove for O Ring



3030-106316 106316

SUTRACK

Connections: 5/8"MF x 5/8"MF


71

SEC

TION

2

Transport Refrigeration Refrigerant, Oil, Copper Tube Fittings & Insulation

Kembla copper tubing is manufactured to AS/NZS1571 and is designed to withstand the higher operating pressures ofR410A refrigerants. It can be clearly identified by the markings on the tube and the pink end caps. Use Pink, no need to think!

PART NUMBER TYPE CONTAINER CONTENTS CONTAINER TYPE CYLINDER BAND (kg) COLOUR

0220012L R22 12 CYLINDER Light Green0220022L R22 22 CYLINDER Light Green0220065L R22 65 CYLINDER Light GreenU134012L R134a 12 CYLINDER Light BlueU134022L R134a 22 CYLINDER Light BlueU134065L R134a 65 CYLINDER Light Blue0404010 R404A 10 CYLINDER Rose Pink0404016 R404A 16 CYLINDER Rose Pink0404050 R404A 50 CYLINDER Rose Pink

REFRIGERANT

NOTE: Other refrigerant grades available.

PART NUMBER BRAND TYPE / GRADE APPLICATION CONTAINER SIZE (ltr)

L318 SUNISO MINERAL - 3GS R22 3.8L319 SUNISO MINERAL - 4GS R22 3.8L320 SUNISO MINERAL - 5GS R22 3.8

S31-HE-3.8 SOLEST POLYOLESTER - 31HE R134a / R410A 3.8S32-5 SOLEST POLYOLESTER - 32 R134a / R410A 5.0

S68-38 SOLEST POLYOLESTER - 46 R134a / R410A / R404A 3.8

REFRIGERATION OIL

NOTE: Other container sizes are also available.

PART NUMBER TUBING OUTSIDE DIAMETER WALL THICKNESS (mm) LENGTH (mts) METRES/CARTION

9B090061 1/4" 9.0 2.0 2109B090101 3/8" 9.0 2.0 1769B090121 1/2" 9.0 2.0 1409B090151 5/8" 9.0 2.0 1109B090201 3/4" 9.0 2.0 889B090221 7/8" 9.0 2.0 809B090281 1-1/8" 9.0 2.0 56

PIPE INSULATION

NOTE: Other sizes and wall thicknesses available.

PART NUMBER SIZE WALL THICKNESS (mm)LENGTH (mtrs)

SOFT DRAWN HARD DRAWN

T59422 1/4" 0.91 30 –T55745 3/8" 0.91 18 –T54136 1/2" 0.91 18 –T54079 5/8" 0.91 18 –T24937 5/8" 1.02 – 6T88072 3/4" 1.14 – 6T64173 7/8" 1.63 – 6T91961 1-1/8" 1.83 – 6

COPPER TUBING

Kembla copper fittings are manufactured with a greater wall thickness for use with R410A refrigerant.

NOTE: A comprehensive range of copper fittings are available from all branches

COPPER FITTINGS

PART NUMBER SIZE

ELBOWS (Female to Female)LP00002 1/4"W02009 3/8"J00017 1/2"J00026 5/8"J00042 3/4"J00051 7/8"J00066 1-1/8"

PART NUMBER SIZE

UNIONS (Female to Female)J00677 1/4"J00692 3/8"J00702 1/2"J00716 5/8"J00736 3/4"J00756 7/8"J00811 1-1/8"

72

MODEL NUMBER DESCRIPTION

Medium Temperature ControllerXR20C-AUTO Temperature Range: -40 to 110C

Setpoint: 3°CDifferential: 2°CPower Supply: 12/24 Vac/dcProbe Inputs: NTC/PTCDigital Inputs: Alarm, Start Defrost, AUX, door switch and pressure switch.Relay Outputs: CompressorSpecial Feature: Hot Key programming device

Low Temperature ControllerXR60C-AUTO Temperature Range: -40 to 110C

Setpoint: -5°CDifferential: 2°CDefrost Termination Temperature: 8°CPower Supply: 12/24 Vac/dcProbe Inputs: NTC/PTCDigital Inputs: Alarm, Start Defrost, AUX, door switch and pressure switch.Relay Outputs: 1st and 2nd Compressor, Defrost, Fans, Alarm or Auxiliary.Special Feature: Hot Key programming device

Medium Temperature ControllerXW20L-7/40V Temperature Range: -40 to 110C

Setpoint: -5°CDifferential: 2°CDefrost Termination Temperature: 8°CPower Supply: 7/40 VdcProbe Inputs: NTC/PTCDigital Inputs: Alarm, Start Defrost, AUX, door switch and pressure switch.Relay Outputs: Compressor, Defrost, Fans, Alarm or Auxiliary.Special Feature: Hot Key programming device

Medium/Low Temperature ControllerXW40L-7/40V Temperature Range: -40 to 110C

Setpoint: -5°CDifferential: 2°CDefrost Termination Temperature: 8°CPower Supply: 7/40 VdcProbe Inputs: NTC/PTCDigital Inputs: Alarm, Start Defrost, AUX, door switch and pressure switch.Relay Outputs: Compressor, Defrost, Fans, Alarm or Auxiliary.Special Feature: Hot Key programming device

Medium/Low Temperature ControllerT630-XW370K Temperature Range: -50°C to 150°C

Features:■ Controls two zones at the same time (one normal and one low temp. area)■ Three operating modes: Cooling, Heating and Neutral zone■ Four NTC Probes: room 1, room 2 (Opt.), evaporator and "ON Demand" defrost (Opt.)■ "On Demand" defrost for optimum defrost cycle management■ Service Hour counting for system maintenance cycles■ Power Supply 7/40 VdcSpecial Feature: Hot Key programming device

Transport Refrigeration Electronic Controls

18 6

18 6

18 6 set

18 6 set

18 6 set

aux

73

SEC

TION

2

Thermostatic Expansion Valves

BLOCK VALVES

LIQUID VALVE VALVE OUTLETSUPEROLD NEW INLET OUTLET INLET TO SPECIALTONS HEATNUMBER NUMBER FROM TO FROM COMP FEATURES°F COND. EVAP. EVAP. SUCTION

329 SERIESNG00001 329-439 1-1/2 5 3/8" FO 1/2" FO 1/2" FO 5/8" FONG00002 329-404 1-1/2 8 3/8" FO 1/2" FO 1/2" FO 5/8" FO 2 Mtg HolesNG00003 329-448 1-1/2 8 3/8" FO 1/2" FO 5/8" FO 5/8" FO 2 Mtg HolesNG00008 NG9015 1-1/2 5 3/8" FO 1/2" FO 1/2" FO 5/8" FONG00015 329-433 1-1/2 8 3/8" FO 1/2" FO 1/2" FO 5/8" FONG00005 NG9041 2 8 3/8" FO 1/2" FO 1/2" FO 5/8" FONG00010 NG8719 2 6.3 3/8" FO 1/2" FO 5/8" FO 5/8" FONG00011* 329-413 2 5 3/8" FO 1/2" FO 5/8" FO 5/8" FO

2 *Mtg Holes

NG00009 329-435A 2 5 3/8" FO 1/2" FO 1/2" FO 5/8" FONG00012 03-329-443 2.5 5 3/8" FO 1/2" FO 1/2" FO 5/8" FO

529 SERIESNG00018 NG00018 1-1/2 8.5 10mm TO 13.9mm TO 20.3mm TO 20.3mm TO 2 Mtg. Holes

829 SERIESNG00071 NG1006 1-1/2 – 10mm TO 18mm TO 18mm TO 18mm TO 2 Mtg. HolesNG00072 NG1007 1-1/2 – 10mm TO 18mm TO 18mm TO 18mm TO 2 Mtg. HolesNG00074 NG00074 2 6.5 14mm TO 14mm TO 20mm TO 20mm TO Mtg. Stud

929 SERIESNG00091 929-405 1-1/2 8 3/8" TO 1/2" TO 1/2" TO 5/8" TONG00076 929-401 1.7 8 3/8" TO 1/2" TO 5/8" TO 3/4" TONG00077 929-421 2 10.8 3/8" TO 1/2" TO 5/8" TO 3/4" TONG00078 NG9422 2 5.4 3/8" TO 1/2" TO 5/8" TO 3/4" TONG00079 NG9457 2 5.4 3/8" TO 1/2" TO 5/8" TO 3/4" TO 2 Mtg. HolesNG00080 929-452 2 3/8" TO 1/2" TO 5/8" TO 5/8" TO Cross ChargeNG00092 929-433 2 6.3 3/8" TO 1/2" TO 5/8" TO 3/4" TONG00086 929-432L 2-1/2 5 3/8" TO 1/2" TO 5/8" TO 5/8" TO W/Out SwitchNG00087 929-432SL 2-1/2 5 3/8" TO 1/2" TO 5/8" TO 5/8" TO With SwitchNG00090 NG9815 2-1/2 5 3/8" TO 1/2" TO 5/8" TO 5/8" TONG00094 NG9819 2-1/2 5 3/8" TO 1/2" TO 5/8" TO 5/8" TO W/Out SwitchNG00093 929-407L 2-1/2 5 3/8" TO 1/2" TO 5/8" TO 5/8" TO With Switch

*NG00011 (329-413) – 2 x 0.25" mounting holes through valve body.

74

Thermostatic Expansion Valves (cont’d)

APPLICATIONS – BLOCK VALVES

OLD NEWNUMBER NUMBER VEHICLE MODELS

NG00078 NG9422 BMW – All from 1991

CHRYSLERNG00018 NG00018 NeonNG00074 NG00074 Voyager

DAEWOONG00080 929-452 Nubira J-100NG00080 929-452 Leganza V-100

FORDNG00005 NG9041 Falcon XA, XB, XC, XD, XENG00090 NG9815 Falcon XF, XG Without SwitchNG00094 NG9819 Falcon EA, EB to Feb ’92

Without SwitchNG00093 929-407SL Falcon EA, EB to Feb ’92

With SwitchNG00086 929-432L Falcon EB, ED, EF 3/’92 on

Without SwitchNG00087 929-432SL Falcon EB, ED, EF 3/’92 on

With SwitchTX2621 TX2621 Falcon AU Orifice TubeTX2621 TX2621 Falcon BA Orifice Tube

HOLDENNG00072 NG1007 Apollo JM-JPNG00015 329-433 AstraNG01033 NG01033 Commodore VB – VC ‘81NG00005 NG9041 Commodore VC, VHNG00070 34-118 Commodore VKNG00078 NG9422 Commodore VR, VSNG00079 NG9457 Commodore VTTX9457 TX9457 Commodore VXTX9457 TX9457 Commodore VY

JEEPNG00003 329-448 Cherokee 89 on

MERCEDES-BENZNG00001 329-439 240, 280, 300, 380NG00010 NG8719 280, 300, 380, 450, 500NG00092 929-433 190NG00077 929-421 All 1991 on

NISSANNG00015 329-433 Pulsar, Bluebird prior May ’83NG00091 929-405 Pintara, Skyline, Bluebird

May ’83 on

PEUGEOTNG00009 329-435A – 505

PORSCHENG00001 329-439 – All late models

OLD NEWNUMBER NUMBER VEHICLE MODELS

RENAULTNG00015 NG9041 Renault 18, Fuego, Le Car

SAABNG00005 NG9041NG00076 929-401

TOYOTA-NIPPONDENSONG00071 NG1006 Most to 1994, R12 SystemsNG00072 NG1007 Most from 1994, R134a Systems

UNIVERSAL

NG00001 329-439 1-1/2 Ton CapacityNG00008 NG9015NG00015 329-433NG00091 929-405

NG00005 NG9041 2 Ton CapacityNG00010 NG8719NG00011 329-413NG00092 929-433

NG00090 NG9815 2-1/2 Ton CapacityNG00093 929-407SLNG00094 NG9819NG00012 03-329-443

TRUCK & TRACTOR

NG00015 329-433 ALLIS CHALMERS

NG00015 329-433 ARA ROOFTOP

CATERPILLARNG00012 03-329-443 Large Earth Moving Machinery

FORD LOUISVILLENG00002 329-404 – All

FREIGHTLINERNG00008 NG9015 (Red Dot Air)NG00005 NG9041F (Factory Air)

KENWORTHNG00008 NG9015 K100, C500

NG00008 NG9015 KYSOR

NG00008 NG9815 MACKNG00011 329-413NG00008 NG9015 RED DOTNG00011 329-413

NG00020 NG00025

NG00030 NG00035NG00040

NG00050 NG00055NG00060

NG00085

NQ01031

75

SEC

TION

2


MISCELLANEOUS VALVES & COMPONENTS

OLD NEWNUMBER NUMBER DESCRIPTION

NQ01031 04-MC-552 GM CCOT Expansion Tube Insert – Blue Orifice 0.067"NQ01032 04-MC-605 GM CCOT Expansion Tube Insert – Red Orifice 0.062"`NQ01034 NQ01034 Ford AU Expansion Tube Insert - Orange OrificeNG00097 38309 Eaton TEV Inlet Filter ScreenNG00096 46359-1 Eaton TEV Bulb Clamp 3/8"NG00099 TX8133 Eaton TEV Bulb Clamp 5/8"

RIGHT ANGLE VALVES

SUPER EXT. EXT.OLD NEW INLET OUTLET CAP SENSOR SWIVELTONS HEAT EQUAL. EQUAL.NUMBER NUMBER CONN. CONN. LENGTH TYPE NUTSETT. °F LENGTH CONN.

INTERNALLY EQUALISEDNG00112 TX1001 1 3/8" MF 1/2" MF 3/8" Coil — — —NG00115 TX1003 1 5/16" MO 1/2" MO 8" 3/8" Coil — — —

M16 x M20 xNG00300 9811027 1 8" 3/8" Coil — — —

1.5 MO 1.5 MONG00210 NG00210 1 — #5 #5 10" — — — —NG00125 TX1534A 1 3 #6 #8 8" 3/8" Coil — — —NG00045 34-32 1-1/2 5 3/8" MO 1/2" MO 8" 3/8" Coil — — —NG00120 TX1005 1-1/2 5/16" MO 1/2" MO 8" 3/8" Coil — — —NG00020 626-130-826-012 1-1/2 8 3/8" MF 1/2" MF 12" 3/8" Coil — — —NG00025 626-210-826-021 2 5 3/8" MF 1/2" MF 12" 3/8" Coil — — —NG00046 626-610-826-053 2 5 3/8" MO 1/2" MO 12" 3/8" Coil — — —NG00335 827-008 2 8 3/8" MO 1/2" MO 12" — — — —

EXTERNALLY EQUALISEDNG00030 626-333-826-028 1-1/2 8 3/8" MF 1/2" MF 8" 3/8" Coil 13" 1/4" F.F. FemaleNG00035 34-309 1-1/2 8 3/8" MF 1/2" MF 19" 3/8" Coil 16-1/2" 1/4" F.F. FemaleNG00040 031134-305 2 8 3/8" MF 1/2" MF 12" 3/8" Coil 16-1/2" 1/4" F.F. FemaleNG00031 626-710-826-059 1-1/2 5 3/8" MO 1/2" MO 19" 3/8" Coil 16-1/2" 1/4" MO FemaleNG00050 34-138 1-1/2 8 3/8" MO 1/2" MO 12" 3/8" Coil 13" 1/4" MO Female

M14 xNG00325 827-010 1-1/2 8 1/2" MO 12" 3/8" Tube 33" 1/4" MO Female

1.5 MOM16 x

NG00330 827-011 1-1/2 8 1/2" MO 12" — 33" 1/4" MO Female1.5 MO

NG00310 9811025 1-1/2 3/8" MO 1/2" MO 12" Bulb 13" 1/4" MO FemaleNG00055 34-156 2 5 3/8" MO 1/2" MO 8" 3/8" Tube 9-3/4" 1/4" MO FemaleNG00060 34-137 2 5 3/8" MO 1/2" MO 8" 3/8" Coil 9-3/4" 1/4" MO FemaleNG00065 626-832-826-077 2 8 3/8" MO 1/2" MO 12" Bulb 16-1/2" 1/4" MO FemaleNG00070 34-118 2 8 3/8" MO 1/2" MO 12" 3/8" Coil 9-3/4" 1/4" MO FemaleNG00085 31-19 2 10.5 3/8" MO 1/2" MO 33" Flat Tube 31" 1/4" MO Male

EXTERNALLY EQUALISED (Reverse Flow)NG1024 NG1024 — — #5 #8 8" — 12" — FemaleNG1026 NG1026 1-1/2 — #6 #8 12" — 12-3/4 1/4" MO Female

NG00340 NG00340 1-1/2 — #6 #8 — — — — —NG1032 NG1032 — — M16 M20 — — — — —

76


NG00020 NG00025

NG00030 NG00035NG00040

NG00050 NG00055NG00060

NG00075

NG00085

APPLICATIONS – RIGHT ANGLE VALVES

OLD NEW EQUAL. CONN.MAKE/MODEL TONSNUMBER NUMBER CONN. TYPE

NG00020 626-130-826-012 UNIVERSAL Int. Flare 1-1/2NG00025 626-210-826-021 Int. Flare 2NG00300 9811027 Metric Int. O-R 1NG00045 34-32 Int. O-R 1-1/2NG00046 626-610-826-053 Int. O-R 2NG00335 827-008 Int. O-R 2NG00030 626-333-826-028 Ext. Flare 1-1/2NG00035 34-309 Ext. Flare 1-1/2NG00040 031134-305 Ext. Flare 2NG00031 626-710-826-059 Ext. O-R 1-1/2NG00050 34-138 Ext. O-R 1-1/2NG00325 827-010 Metric Ext. O-R 1-1/2NG00330 827-011 Metric Ext. O-R 1-1/2NG00310 9811025 Ext. O-R 1-1/2NG00055 34-156 Ext. O-R 2NG00060 34-137 Ext. O-R 2NG00070 34-118 Ext. O-R 2NG00085 31-19 Ext. O-R 2NG00065 626-832-826-077 Ext. O-R 2

NG00035 34-309 AUDI Ext. Flare 1-1/2100LS, Fox

BMWAll Models pre ’73,

NG00035 34-309 320i Ext. Flare 1-1/2

HOLDENNG00085 31-19 Kingswood HG-HZ Ext. O-R 2NG00085 31-19 Commodore VB, VC Ext. O-R 2NG00070 34-118 Commodore VK Ext. O-R 2NG00050 34-138 Commodore VL Ext. O-R 1-1/2

HONDAAccord, Civic,

NG00335 827-008 Prelude Int. O-R 2

NG00060 34-137 JAGUAR Ext. O-R 2XJS, XJ6

JEEPNG00050 34-138 Grand Cherokee Ext. O-R 1-1/2

MERCEDES-BENZ230, 250, 280,

NG00030 626-333-826-028 300, 380, 450 Ext. Flare 1-1/2

MITSUBISHING00335 827-008 Magna RX7 Int. O-R 2NG00025 626-210-826-021 Sigma Int. Flare 2

NIPPONDENSONG00120 TX1005 (Some) Int. O-R 1-1/2

OLD NEW EQUAL. CONN.MAKE/MODEL TONSNUMBER NUMBER CONN. TYPE

NISSANNG00030 626-333-826-028 Datsun 200B Ext. Flare 1-1/2NG00330 827-011 Skyline (Imported) Ext. O-R 1-1/2

PORSCHE924, 911, 912,

NG00020 626-130-826-012 914 Int. Flare 1-1/2

NG00060 34-137 ROLLS-ROYCE Ext. O-R 2

TOYOTANG00115 TX1003 Nippondenso Int. O-R 1

Celica, Corona,NG00325 827-010 Cressida, Supra Ext. O-R 1-1/2

VOLVONG00050 34-138 240 Ext. O-R 1-1/2NG00070 34-118 Ext. O-R 2

TRUCK & TRACTOR

CABIN COMFORTNG00035 34-309 Series 5 Ext. Flare 1-1/2NG00040 031134-305 Series 6 Ext. Flare 2

NG00050 34-138 CATERPILLAR Ext. O-R 1-1/2

NG00020 626-130-826-012 JOHN DEERE Int. Flare 1-1/2NG00055 34-156 Ext. O-R 2

NG00020 626-130-826-012 FLEETSTAR Int. Flare 1-1/2

NG00020 626-130-826-012 INTERNATIONAL Int. Flare 1-1/2NG00040 031134-305 Ext. Flare 2

NG00050 34-138 KENWORTH Ext. O-R 1-1/2K100

NG00020 626-130-826-012 KYSOR Int. Flare 1-1/2NG00035 34-309 Ext. Flare 1-1/2NG00050 34-138 Ext. O-R 1-1/2NG00085 31-19 Ext. O-R 2

NG00050 34-138 MACK Ext. O-R 1-1/2

NG00040 031134-305 PAYSTAR Ext. Flare 2

NG00035 34-309 RED DOT Ext. Flare 1-1/2

NG00020 626-130-826-012 TRANSTAR Int. Flare 1-1/2NG00040 031134-305 Ext. Flare 2

Date post:	16-Oct-2021
Category:	Documents
Upload:	others
View:	7 times
Download:	0 times

SECTION 2 - Tistory

Documents