SEMI FRAMED ADJUSTABLE FRONT ONLY PIVOT DOOR
Disclaimer: Products in this specification manual must by regulation be installed by licensed and registered trade people. The manufacturer/distributor reserves the right to vary specifications or delete models from their range without prior notification. Dimensions are nominal measurements only. Dimensions and set-outs listed are correct at time of publication however the manufacturer/distributor takes no responsibility for printing errors.
Tech Page Version 1
To see the complete CUSTOM GLASS range go to www.reece.com.au/bathrooms
CLEANING RECOMMENDATIONSWe recommend the use of soapy water or approved cleaners.
This product should not be cleaned with abrasive materials.
Damage caused by any improper treatment is not covered by the product warranty - refer to Warranty Conditions.
Please refer to detailed Cleaning Instructions on page 14.
SPECIFICATIONS Recommended use Domestic, Hotel, and Commercial
Material Screen-6mm Clear Toughened Glass. Glass Infill- 5mm Clear Toughened Glass.
Australian Safety Standards Compliant.
Floor Suitability Tiled Floor Installation
Door Opening Option Left or Right
Handle Standard Knob
Frame & Support Rail Colour Polished Silver
Optional Extras 1789912 - Installation Charge
1791295 - Shower Screen Removal
SIZE VARIATIONSCode SIZE ADJ FRONT DOOR SIZE INFILL GLASS HEIGHT
1789864 900 820-900 702 180 1950
1789865 1000 980-1060 702 340 1950
1789866 1200 1140-1220 702 500 1950
1789867 1500 1460-1540 702 840 1950
page 1 of 14
SEMI FRAMED ADJUSTABLE FRONT ONLY PIVOT DOOR
Dimensions are shown in MillimetresDimensions are nominal measurements only.
1950
975
975
73.5
73.5
1803
Min 820 Max 900
820
Min 820 Max 900
180 548
55
702100
page 2 of 14
SEMI FRAMED ADJUSTABLE FRONT ONLY PIVOT DOOR
980
Min 980 Max 1060
340 548
55
702100
1950
975
975
73.5
73.5
1803
Min 980 Max 1060
page 3 of 14
SEMI FRAMED ADJUSTABLE FRONT ONLY PIVOT DOOR
1950
975
975
73.5
73.5
1803
Min 1140 Max 1220
1140
Min 1140 Max 1220
500 548
55
702100
page 4 of 14
SEMI FRAMED ADJUSTABLE FRONT ONLY PIVOT DOOR
1950
975
975
73.5
73.5
1803
Min 1460 Max 1520
1460
Min 1460 Max 1520
840 548
55
702100
page 5 of 14
SEMI FRAMED ADJUSTABLE FRONT ONLY PIVOT DOORImportant NoteINSTALLATION INSTRUCTIONS
-2-
Important Pre-Installation Information
- Please read this entire instruction book before commencing installation.
- A licenced tradesman must be used for the Leave-
care. with handleand moment possible last the until corners glass the on protectors plastic the
installation.
-
* Use the correct type of drill bit for the material being drilled, with 6mm required for anchor fixing and 3mm used for
screwing directly into the wall studs.
** As with all toughened glass, take care while handling and wear safety goggles and gloves for personal protection.
Silicone Sealant Drill Level Rubber Mallet
Pencil Phillips Screwdriver Tape Measure
Utility Knife
Cutting Pliers
8mm 5/16( ") and3mm (1/8") Drill Bits Safety Goggles Gloves
If water alone is not enough to clean the glass, Custom Glass recommends the use of mild
Maintenance
Tools Required
detergent solutions only.
Custom GlassSHOWER SCREENFRONT ONLY
- Branch
Reece Local your Through arranged be Can Installation Required If
8
page 6 of 14
SEMI FRAMED ADJUSTABLE FRONT ONLY PIVOT DOOR
G
X1
X7/X10/X12/X13
Drill's Not Supplied
X1
X7
X1
X2
X2 X1
X1
ST4X35 X7
ST4X35 X7
ST4X10 X7/X9
Componets Front OnlyA Boxfor
Handle
Door
Infill
Wall Plugs
Top Caps
Rail
Door Seal
Fixings
Screens fabricated pre are
wide 1220 to up
10
COMPONENTS
Plumbers, please ensure a copy of the installation instructions is left with the end user for future reference
page 7 of 14
SEMI FRAMED ADJUSTABLE FRONT ONLY PIVOT DOOR
Semi Fra em d Pivot 80mm Adjustment
BoxFront Only
A Type
Custom Glass
6mm Clear ToughenedGlass Door
5mm Clear Toughened Glass Infill Panel
Door
Infill Panel
9
page 8 of 14
SEMI FRAMED ADJUSTABLE FRONT ONLY PIVOT DOOR
12
3
7
4
6
5
8
9
10
Custom
FRONT SCREEN SHOWERONLY
Glass
Item's assembled
pre are 2 and 1
11
INSTALLATION INSTRUCTIONS
page 9 of 14
SEMI FRAMED ADJUSTABLE FRONT ONLY PIVOT DOOR
b
a 3 3
a
7 7
4 4
b 2.2 2.1
Custom
FRONT SCREEN SHOWER ONLY
Glass
Item level be must
Channels Wall G
Close
Channel. wall opposite the into and out Screen the Extend and Channel Wall opposite the with
up Screen the Line Channel. wall the toin screen of side infill push Minimun, theto Screen
Minimum
Maximum
12
Don’t risk it, use a licensed plumber.™
page 10 of 14
SEMI FRAMED ADJUSTABLE FRONT ONLY PIVOT DOOR
c
c
5
6 1
2
d
9
d
CustomFRONT SCREEN SHOWERONLY
Glass
Align
gap even an achieve
to this reverse to need may You
direction. opposite the in Bottom the
and channel the into posible as far as top the pushing
by adjusted be can this even.
is gap the sure making rail, Head
the with door glass the of top the
Only rail head the with level is
door the once 5# off fit
page 11 of 14
SEMI FRAMED ADJUSTABLE FRONT ONLY PIVOT DOOR
e e
B. 4 10
B. 1
B. 2 B. 3
f f
8
CustomFRONT SCREEN SHOWER ONLY
Glass
Top Channels Wall of
top cover to Caps
14Plumbers, please ensure a copy of the installation instructions is left with the end user for future reference
page 12 of 14
SEMI FRAMED ADJUSTABLE FRONT ONLY PIVOT DOOR
48 H
CustomFRONT SCREENSHOWERONLY
Glass
Silicone Supplied Not
Silicone
outside the on rail bottom
the seal Only out. and inside Channels Wall
both Down
15
page 13 of 14
SEMI FRAMED ADJUSTABLE FRONT ONLY PIVOT DOOR
DETAILED CLEANING INSTRUCTIONS
Easy Clean Treated Glass
After showering we strongly recommend you squeegee the glass to remove water from the surface.
A weekly clean using water and 30% vinegar or a mild detergent is all it takes to remove dirt, soap scum and other contaminants.
Spray the vinegar and water on the glass and wipe with a soft cloth, leave this on the sur-face for several minutes before rinsing and drying the glass.
Aluminium Frame and Metal ComponentsThe simplest and most preferred method of cleaning your unit is by washing with clean water and drying with a soft cloth.
Do not use Abrasive powders, steel and Teflon pads or dirty and gritty rags. The anodised coating on the Aluminium is one of the hardest substances known, however, it will be dam-aged by strong acidic or alkaline solutions. These solutions may dull and discolour the finish.
The most reliable preventative measure to preserve your screen is to wipe the surface dry with a soft cloth after each use.
Plumbers, please ensure a copy of the installation instructions is left with the end user for future reference
page 14 of 14