Page 1
CHASSISRE-2SERVICE MANUALKP-41S5 RM-862 AEP SCC-N60C-A
KP-41S5B RM-862 French SCC-N63B-A
KP-41S5G RM-862 Greek SCC-N60D-A
KP-41S5K RM-862 OIRT SCC-N62D-A
KP-41S5R RM-862 Russian SCC-N62C-A
KP-41S5U RM-862 UK SCC-N61B-A
MICROFILM
∗ Please file according to model size. .......
41
PROJECTION TV
MODEL COMMANDER DEST. CHASSIS NO. MODEL COMMANDER DEST. CHASSIS NO.................. ........................... ............ .......................... ................. ........................... ............ ..........................
Page 2
– 2 –
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
B/G/H E2..12 21..69 C02 C03 C04..C12 C21..C69
CABLE TV (1) S1..41 S01 S02..S41
CABLE TV (2) S01..S05 M1..M10 U1..U10 S42..S46 S01..S10 S11..S20
ITALY A B C D E F G H H1 H2 21..69 C11..C69
D/K R01..R12 R21..R69 C02..C12 C21..C69
CABLE TV (1) S01 S02..S41
CABLE TV (2) S42 S43..S46
CABLE TV B.. O S21..41 S02.S03..S17.
S21..S41
L F2..F10 F21 F69 C01..C12 C21..C69
I B21..B68 C21..C68
Iudication on the screenReceivable channel
Receivable Channel and Channel Displays
Television system B/G/H,D/K,I,LColour system PAL/SECAM
NTSC 3.58/NTSC4.43(VIDEO IN)Channel coverage See " Receivable channels and channel
displays " on this page.Projected picture size 41 inches
Approx. 103cm measured diagonallyTerminalsRear Center speaker input terminals, 2 terminals
(L, R), audio outputs-phono jackW 1 21-pin Euro connector(CENELEC standard)- inputs for audio and video signals- inputs for RGB- outputs of TV audio and video signals: 2/ q 2 21-pin EURO connector- inputs for audio and video signals- inputs for S Video- outputs for audio and video signals (selectable): 3/ q 3 21-pin Euro connector- inputs for audio and video signals- inputs for S video- outputs for audio and video signals (selectable, the same output source as the: 2/ q 2 connector)
SPECIFICATIONS
Front q 3 S video input-4-pin DIN… 3 video inputs-phono jack– (L.R), Audio inputs-phono jacks" 2 Headphone jack -stereo minijack
Sound output 2 x 30W (music power)2 x 15W (RMS)
Centre SP input 30W (RMS)(using as the centre speaker)Power consumption 155WDimensions(WxHxD) 948x992x 511 mm
(373/8 x 391/8 x 201/8 inches)Mass Approx. 43kg (94 lbs 13 oz)Supplied accessories See page 6.Other features Digital comb filter (High resolution)
FASTEXT
Design and specifications are subject to change without notice.
Page 3
– 19 –
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
3-1. SCREEN VOLTAGE ADJUSTMENT(ROUGH ALIGNMENT)
1. Receive the Monoscope signal.2. Set 50% BRIGHTNESS and minimum PICTURE.3. Turn the red VR on the FOCUS block all the way to the left
and then gradually turn it to the right until the point whereyou can see the retrace line.
4. Next gradually turn it to the left to the position where theretrace line disappears.
3-3. SCREEN (G2) ADJUSTMENT1. Connect jig (A) to 200V. In TP732, CG Board.2. Connect jig (B) to GND. In TP733, CG Board.3. Select with Power ON, VIDEO mode without signals.4. Connect jig (C) to the TP701 (K.CR), TP731 (K:CG), or
TP761 (K.CB) of CR, CG, and CB Board.5. Adjust R, G, and B screen voltage to until retrace line just
appears with screen VR on the Focus block
3-4. FOCUS VR ADJUSTMENT1. Set in service mode.2. Use GH (GSEL) on the service mode menu to shown only
the green color.3. Press the Commander Menu button (convergence) and out-
put the test signal (crosshach).4. Rotate the green VR on the FOCUS block and align to ob-
tain the optimal focus point.5. Use GH (GSEL) from the service mode menu to set to green
and red.6. Output the test signal and rotate the red VR to obtain the
optimum focus at the point where the red and green spotsoverlap.
7. Use BH (BSEL) from the service mode menu to set to redand blue.
8. Output the test signal and rotate the blue VR aligning to ob-tain the optimum focus at the point where the blue and greenspots overlap.
R G B
SCREEN
R G B
FOCUS
FOCUS block
Fig. 3-1
Fig. 3-3
Scanning line visible.
A
B
Minimize both A and B.
Fig. 3-5
Lens
Fig. 3-4
3-2. FOCUS LENS ADJUSTMENT1. Loose the lens screw.2. Set in service mode.3. Use GH (GSEL) on the service mode menu to shown only
the green color.4. Press the Commander Menu button and select TEST MENU
and CONVERGENCE to display the test signal (crosshatch)on the screen.
5. Rotate the green lens and align with the optimal focus pointfrom the test signal.
6. Use GH (GSEL) from the service mode menu to set to greenand red.
7. Output the test signal and rotate the red lens to obtain theoptimum focus at the point where the red and green spotsoverlap.
8. Use BH (BSEL) from the service mode menu to set to redand blue.
9. Output the test signal and rotate the blue lens to obtain theoptimum focus at the point where the blue and red spots over-lap.
10. Tighten the lens screw.
Fig. 3-2
Minimize both A and B.
B
A
Scanning line visible.
Test signal
SECTION 3
SET-UP ADJUSTMENTS
(B) GND
(A)200V
KR-KG-KB (C)
2.2k / 3W x2
5.6k / 3W
2.2k / 3W
Page 4
– 20 –
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
3-5. DEFLECTION YOKE TILT ADJUSTMENT1. Set to receive the Monoscope signal.2. Set in service mode.3. Place the caps on the red and blue lens so that only the green
color.4. Loosen the deflection yoke setscrew and align the tilt of the
Deflection Yoke so that the bars at the center of the monoscopepattern are horizontal.
5. After aligning the deflection yoke, fasten it securely to thefunnel-shaped portion (neck) of the CRT.
6. The tilt of the deflection yoke for red and Blue is aligned thesame as was done for green.
Fig. 3-6
3-6. 2-POLE MAGNET ADJUSTMENT1. Set in service mode.2. Set to receive the Dot signal.3. Place the caps on the red and blue lens so that only the green
color is shown.4. Turn the green VR on the focus block to the right and set to
overfocus to enlarge the spot.5. Now align the 2-Pole Magnet so that the enlarged spot is in
the center of the Just Focus spot.6. Align the green focus VR and set for just (precise) focus.7. Perform the same alignment for red and blue.
Fig. 3-7
3-7. 4-POLE MAGNET ADJUSTMENT1. Set in service mode.2. Set to receive the Dot signal.3. Place the caps on the red and blue lens so that only the green
color is shown.4. Turn the green VR on the focus block to the left and set to
underfocus to enlarge the spot.5. Now align the 4-Pole Magnet so that the enlarged spot be-
comes a perfect circle.6. Perform the same alignment for red and blue.
NG OK NG
Fig. 3-8
3-8. DEFOCUS ADJUSTMENT (Blue)1. Receive the Dot signal.2. Place the caps on the red and green lens so that only the blue
color is shown.3. Rotate the blue focus volume on the focus pack and adjust to
obtain best electrical focus.4. Rotate Blue focus volume of focus pack clocwise, so that
diameter of the Dot see Caution.
[How to Blue defocus.]
÷1
Just Focus: 1.2
Fig. 3-9
[Change Blue Defocus]
Fig. 3-10
5mm Max.
Use the center dot
Use the center dot
Neck Assy
2-pole magnet4-pole magnet
Deflection yoke
Anode cap
Deflection yoke should be as more close to CRT as possible.
Page 5
– 21 –
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862SECTION 4
SAFETY RELATED ADJUSTMENT
When replacing the following components marked with] onthe schematic diagram, always check hold-down voltage and if
necessary re-adjust.
4-1. HV HOLD-DOWN ADJUSTMENT1. Remove CN810. Connect HV meter to HV Block.2. Connect External Power Supply to CN810 2 pin
(+135V) and 1 pin (GND).
Part Replaced (])
E Board C515, C516, C554, D504, D507,L506, Q502, R1, R514, R516,R517, T502, T504 (FBT)
G Board IC6008
Part Replaced ([)
R1
3. Turn on the set.4. Slowly up the supply voltage from 0V to 135V.5. Receive dot picture and set PICTURE/BRIGHTNESS to
minimum.6. Slowly up the voltage until hold-down circuit works (pic-
ture disappear).7. Read the HV meter of peak HV voltage.
Spec: 34.5±0.75KV8. If Hold-down voltage is less than 33.75KV then solder
R1=820K.9. If hold-down voltage is over than 35.25KV then take-off
R514 and solder R1=9.1K.
+
–
2CN810
PowerSupply 1
E BOARD – CONDUCTOR SIDE –
CN810
CN505
CN505
R1
Fig. 4-1
Fig. 4-2
Fig. 4-3
Fig. 4-4
Remove the cap offfrom the unusedterminal and connect astatic voltmeter there.
Page 6
– 22 –
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
5-1. ELECTRICAL ADJUSTMENTS
HOW TO ENTER INTO SERVICE MODE
1. Turn on the main power switch of the set and enter intostandby mode.
2. Press the following sequcnce of buttons on the RemoteCommander.
Service adjustment to this model can performed with the sup-plied remote commander RM-862.
“TT—” will appear in the top right comer of the screen.Other status information wull also be displayed.
3. Press MENU on the commander to obtain the followingmenu on the screen.
5(ON SCREEN
DISPLAY)(DIGIT 5) (VOLUME +) (TV)
PICTURE ADJUSTMENT
AFC mode 2REF position 2SCP BGR 1SCP BGF 1Trap Fo 0Sub contrast AdjSub colour AdjSub brightness AdjGreen drive AdjBlue drive AdjGreen cutoff AdjBlue cutoff AdjGamma 0Pre / overshoot 0Y delay 3
GEOMETRY ADJUSTMENT in 4 : 3 mode
UP Corn Pin AdjV Size AdjV Position AdjS Correction AdjV Linearity AdjH Size AdjH Position AdjPin Amp AdjPin Phase AdjAFC Bow AdjAFC Angle AdjEHT V AdjEHT H AdjCorner Pin AdjLO Corn Pin Adj
WIDE
V Aspect 47V Scroll 31Upper V Lin 0Lower V Lin 0Left Blanking 1Right Blanking 11
TEST MENU
> picture adjustmentGeometryWideMSPIC statusCurrent TV statusConvergence
™
1 2 3
4 5
8
6
7
10
9
Standby
TV POWER ON
VOLUME +
MENU
RM-862
+–
4. Move to the correspondind adjustment using the buttonon the commander.
5. Move the button to the right to enter the selectedadjustment.
6. Before TURN OFF is neccessary:[DATA WRITE], [DATA COPY] in 4 : 3 and 16 : 9 mode.
7. Turn off the power to quit the service mode when adjust-ments are completed.
SECTION 5
CIRCUIT ADJUSTMENTS
*
* : Adjust only if AE board change.For change CRT R-G-B is better CONVERGENCEdon't change in 16 : 9 mode.
Page 7
– 23 –
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
IC STATUS (CXA2076 / CXA2040)CXA2076
H lock 1IKR 1VNG 0X•RAY 0Colour system 3CV1 Sync 0
CXA2040Sync sep 1S1 mode pin 01S2 mode pin 01
TUNERTuner status 01101011
MSP
AGC ON / OFF ONConstant gain CDB 1FM prescale FMP 36Zwei mono-st WHI 36Zwei st-mono WLO 18Zwei mono-bi WMH 36Zwei bi-mono WLO 18Time zwei WML 41Fawct limit 10Fawct soll init FAW 12Fawer tol 2Nicam Err Max CCT 10Nicam Err Min 0Nicam Prescale NIP 97Time Nicam 31Carrier mute CRM OFFAudio clock ACO HIZScart prescale 25Scart volume 64NICAM Prescale I 127NICAM Prescale L 97NICAM Prescale BG 97NICAM Prescale DK 97
CURRENT TV STATUS
Text system C TEXT / TV TEXTDolby NO / YESText language set WEST / EAST / RUSSIANMenu language set WEST / EAST / RUSSIANDestination B / D / U / K / L / E / A / RScart 16 : 9 OFF / ONRGB priority OFF / ONAgeing OFF / ONSize PJColour trap sw SECAM / ALLVelocity mod ON / OFFAFT STATUS WINDOW / HIGH / LOWLumisponder Mode OFF
Page 8
– 24 –
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
5-2. SERVICE LIST
OSD 00 CHSW 0, 1 0 HATCH DISPLAY0 : Disp, Hatch 1 : No Disp, Hatch
01 OSDH 1 ~ 32 10 OSD H Position02 OSDV 1 ~ 32 10 OSD V Position03 VMRK 0, 1 0 V SIZE MARKER
ON / OFF (cannot write to NVM)
Itemnumber
AdjustmentItem
Datarange
Initialdata Name / Description Device
OSD
SFT
SFT 00 SFTE 0, 1 1 SHIFT ENABLE0 : Disable 1 : Enable
01 SFTF 0, 1 0 SHIFT FAST0 : Normal 1 : Quick (cannot write to NVM)
Itemnumber
AdjustmentItem
Datarange
Initialdata Name / Description Device
GH 00 GSEL 0, 1 0 OSD SELECT FOR GH, GV CXP862130 : Green+Red 1 : Green
01 CENT –127 ~ +127 0 GREEN H CENTER02 SKEW –127 ~ +127 0 GREEN H SKEW03 BOW –127 ~ +127 0 GREEN H BOW04 4 BOW –127 ~ +127 0 GREEN H 4th BOW05 SIZE –127 ~ +127 0 GREEN H SIZE06 LIN –127 ~ +127 0 GREEN H LINEARITY07 M SIZ –127 ~ +127 0 GREEN H MID SIZE08 M LIN –127 ~ +127 0 GREEN H MID LINEARITY09 KEY –127 ~ +127 0 GREEN H KEYSTONE10 SSKW –127 ~ +127 0 GREEN H SUB SKEW11 M PIN –127 ~ +127 15 GREEN H MID PINCUSHION12 PIN –127 ~ +127 –12 GREEN H PINCUSHION13 S BOW –127 ~ +127 8 GREEN H SUB BOW14 M BOW –127 ~ +127 0 GREEN H MID BOW15 4PIN –127 ~ +127 0 GREEN H 4th PINCUSHION16 4 SBOW –127 ~ +127 0 GREEN H 4th SUB BOW
GV 00 CENT –127 ~ +127 0 GREEN V CENTER01 SKEW –127 ~ +127 0 GREEN V SKEW02 BOW –127 ~ +127 0 GREEN V BOW03 SIZE –127 ~ +127 0 GREEN V SIZE04 LIN –127 ~ +127 0 GREEN V LINEARITY05 M SIZ –127 ~ +127 0 GREEN V MID SIZE06 M KEY –127 ~ +127 0 GREEN V MID KEYSTONE07 KEY –127 ~ +127 0 GREEN V KEYSTONE08 S SKW –127 ~ +127 0 GREEN V SUB SKEW09 M PIN –127 ~ +127 0 GREEN V MID PINCUSHION10 PIN –127 ~ +127 20 GREEN V PINCUSHION11 S BOW –127 ~ +127 16 GREEN V SUB BOW12 WAVE –127 ~ +127 0 GREEN V WAVE13 4PIN –127 ~ +127 25 GREEN V 4th PINCUSHION
DP
Itemnumber
AdjustmentItem
Datarange
Initialdata Name / Description Device
Page 9
– 25 –
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
RH 00 CENT –95~ +96 0 RED H CENTER CXP8621301 SKEW –95~ +96 0 RED H SKEW02 BOW –127 ~ +127 0 RED H BOW03 4BOW –127 ~ +127 0 RED H 4th BOW04 SIZE –127 ~ +127 25 RED H SIZE05 LIN –127 ~ +127 10 RED H LINEARITY06 MSIZ –127 ~ +127 30 RED H MID SIZE07 MLIN –127 ~ +127 –30 RED H MID LINEARTIY08 KEY –127 ~ +127 0 RED H KEYSTONE09 SSKW –127 ~ +127 0 RED H SUB SKEW10 MPIN –127 ~ +127 0 RED H MID PINCUSHON11 PIN –127 ~ +127 –10 RED H PINCUSHON12 SBOW –127 ~ +127 40 RED H SUB BOW13 MBOW –127 ~ +127 12 RED H MID BOW14 4PIN –127 ~ +127 0 RED H 4th PINCUSHON15 4SBOW –127 ~ +127 0 RED H 4th SUB BOW
RV 00 CENT –95~ +96 –10 RED V CENTER01 SKEW –95~ +96 0 RED V SKEW02 BOW –127 ~ +127 4 RED V BOW03 SIZE –127 ~ +127 0 RED V SIZE04 LIN –127 ~ +127 0 RED V LINEARITY05 MSIZ –127 ~ +127 0 RED V MID SIZE06 MKEY –127 ~ +127 10 RED V MID KEYSTONE07 KEY –127 ~ +127 –10 RED V KEYSTONE08 SSKW –127 ~ +127 10 RED V SUB SKEW09 MPIN –127 ~ +127 0 RED V MID PINCUSHON10 PIN –127 ~ +127 10 RED V PINCUSHON11 SBOW –127 ~ +127 16 RED V SUB BOW12 WAVE –127 ~ +127 30 RED V WAVE13 4PIN –127 ~ +127 10 RED V 4th PINCUSHON14 MWAV –31 ~ +31 0 MID WAVE
BH 00 BSEL 0, 1 0 OSD SELECT FOR BH, BV0 : Blue + Green 1 : Blue + Red
01 CENT –95~ +96 0 BLUE H CENTER02 SKEW –95~ +96 0 BLUE H SKEW03 BOW –127 ~ +127 0 BLUE H BOW04 4BOW –127 ~ +127 0 BLUE H 4th BOW05 SIZE –127 ~ +127 –25 BLUE H SIZE06 LIN –127 ~ +127 –10 BLUE H LINEARITY07 MSIZ –127 ~ +127 30 BLUE H MID SIZE08 MLIN –127 ~ +127 30 BLUE H MID LINEARTIY09 KEY –127 ~ +127 0 BLUE H KEYSTONE10 SSKW –127 ~ +127 0 BLUE H SUB SKEW11 MPIN –127 ~ +127 0 BLUE H MID PINCUSHON12 PIN –127 ~ +127 –10 BLUE H PINCUSHON13 SBOW –127 ~ +127 –40 BLUE H SUB BOW14 MBOW –127 ~ +127 –16 BLUE H MID BOW15 4PIN –127 ~ +127 0 BLUE H 4th PINCUSHON16 4SBOW –127 ~ +127 0 BLUE H 4th SUB BOW
Itemnumber
AdjustmentItem
Datarange
Initialdata Name / Description Device
Page 10
– 26 –
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
ACV
ACV 00 ART0 1~ 8 6 DATA SAMPLE LENGTH(1 step = 1 microsec.)
01 AT1T 0~ 255 18 Data Sampling Start Time02 AT1M 0~ 255 132 from V BLK (50Hz)03 AT1B 0~ 255 240 (1 step = 64 µsec = approx. 1H)04 AH51 0~ 255 18 (1 step = 1 OSD step) OSD H POS 50 (L&R)05 AH52 0~ 255 130 OSD H POS 50 (UP&BOTTOM)06 AV5T 0~ 255 1 (1 step = 2 lines) OSD V POS 50 (UP)07 AV5M 0~ 255 60 OSD V POS 50 (L&R)08 AV5B 0~ 255 130 OSD V POS 50 (BOTTOM)09 AH61 0~ 255 18 (1 step = 1 OSD step) OSD H POS 60 (L&R)10 AH62 0~ 255 130 OSD H POS 60 (BOTTOM)11 AV6T 0~ 255 1 (1 step = 2 lines) OSD V POS 50 (UP)12 AV6M 0~ 255 46 OSD V POS 50 (L&R)13 AV6B 0~ 255 100 OSD V POS 50 (BOTTOM)14 RHCO –127 ~ +127 0 (8 step = 1 step) RH CENT ADJ OFFSET15 BHCO –127 ~ +127 0 BH CENT ADJ OFFSET16 RVCO –127 ~ +127 0 RV CENT ADJ OFFSET17 BVCO –127 ~ +127 0 BV CENT ADJ OFFSET18 RHSO –127 ~ +127 0 RH SKEW ADJ OFFSET19 BHSO –127 ~ +127 0 BH SKEW ADJ OFFSET20 RVSO –127 ~ +127 0 RV SKEW ADJ OFFSET21 BVSO –127 ~ +127 0 BV SKEW ADJ OFFSET22 AERR 0~ 255 0 (see Error Code List)
Itemnumber
AdjustmentItem
Datarange
Initialdata Name / Description Device
MSC
MSC 00 ACTL 0~ 255 0 Lower byte of counter value01 ACTH 0~ 255 0 Higher byte of counter value
Itemnumber
AdjustmentItem
Datarange
Initialdata Name / Description Device
BV 00 CENT –95~ +96 –10 BLUE V CENTER CXP8621301 SKEW –95~ +96 0 BLUE V SKEW02 BOW –127 ~ +127 0 BLUE V BOW03 SIZE –127 ~ +127 0 BLUE V SIZE04 LIN –127 ~ +127 0 BLUE V LINEARITY05 MSIZ –127 ~ +127 0 BLUE V MID SIZE06 MKEY –127 ~ +127 –10 BLUE V MID KEYSTONE07 KEY –127 ~ +127 10 BLUE V KEYSTONE08 SSKW –127 ~ +127 –10 BLUE V SUB SKEW09 MPIN –127 ~ +127 0 BLUE V MID PINCUSHON10 PIN –127 ~ +127 10 BLUE V PINCUSHON11 SBOW –127 ~ +127 32 BLUE V SUB BOW12 WAVE –127 ~ +127 –30 BLUE V WAVE13 4PIN –127 ~ +127 10 BLUE V 4th PINCUSHON14 MWAV –31 ~ +31 0 MID WAVE
Itemnumber
AdjustmentItem
Datarange
Initialdata Name / Description Device
Page 11
– 27 –
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
5-3. REGISTRATION (CONVERGENCE)
ADJUSTMENT METHOD
PAL REGISTRATION ADJUSTMENT1) Receive the PAL SPCB signal.2) Select Service mode and enter adjustment items for Green
signal.With the joystick:>. Items change? / Data change
In internal pattern it appears only RG or G only.ITEM CHSW 01 External pattern
CHSW 00 Internal pattern
CENTER ADJUSTMENT1) Adjust GH and GV CENT.
GV CENT
MAIN DEFLECTION ADJUSTMENT1) Adjust VSP V-Lin.
Correct linearity of the horizontal top and bottom lines.
VSP VLINE
2) Adjust AFC ANGLECorrect the vertical center line to be in parailel with the screenedges and other colors.
AFC ANGLE
UP CORN PIN
6) Adjust UP CORN PINCorrect the screen top section line bow.
PIN PHASE
5) Adjust PIN PHASECorrect the vertical left and right lines to be in parallel witheach other.
4) Adjust PIN AMPCorrect the vertical left and right lines and eliminute pin-cushion-shaped distortion.
PIN AMP
3) Adjust AFC BOWCorrect linearity of the vertical center line.
AFC BOW
GH CENT
SIZE ADJUSTMENT
SPEC : H-SIZE 16.4 +/- 0.15 Sq.V-SIZE 12.3 +/-0.15Sq.
VSP VSIZE
VSP HSIZE
5-4. GEOMETRYBefore adjust GEOMETRY, sure the data inconvergence.• GH SIZE = 0• GV SIZE = 0• Adjust S correction
Page 12
– 28 –
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
SUB DEFLECTION ADJUSTMENT ITEMAdjustment O : Yes – : No
Display Adjustment itemAdjustment type
GH GV RH RV BH BV
BSEL COL SELECT – – – – O –
CENT CENT O O O O O O
SKEW SKEW O O O O O O
BOW BOW O O O O O O
4BOW 4TH BOW O – O – O –
SIZE SIZE O O O O O O
LIN LIN O O O O O O
MSIZ MID SIZE O O O O O O
MLIN MID LIN O O O – O –
MKEY MID KEY – O – O – O
KEY KEY O O O O O O
SSKW SUB SKEW O O O O O O
MPIN MID PIN O O O O O O
PIN PIN O O O O O O
SBOW SUB BOW O O O O O O
WAVE WAVE – O – O – O
MBOW MID BOW O – O – O –
4PIN 4TH PIN O O O O O O
4SBOW 4TH SUB BOW O – O – O –
VERTICAL LINE ADJUSTMENTMENU n Convergence1. Carefully watching out for the GH CENT screen centre sec-
tion, adjust GH CENT, GH BOW, GH SKEW.2. GH 4th Bow adjustment. Correct the corner distortion which
could not be adjusted with GH BOW.
Watch out only for theGH CENT center point.
Watch the vertical center line.
GH CENT
GH BOW
GH SKEW
GH 4BOW
7) Adjust LO CORN PINCorrect the screen bottom section line bow.
LO CORN PIN
Page 13
– 29 –
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
HORIZONTAL LINE ADJUSTMENT1. Finely adjust the centre position of the vertical line at the
centre of the screen with GV CENT.2. Using GV SKEW and GV BOW, correct the tilt and bow of
the horizontal line at the centre of the screen.
Watch the horizontalcenter line.
Watch out only for theGV CENT center point.
Watch out only for the GVCENT center point.
GV CENT
GV BOW
GV SKEW
SIZE AND LINEARITY ADJUSTMENT1. Balance the sizes at both sides of the centre section of the
screen with GH MLIN.2. Balance the sizes on both end sections of the screen with
GH LIN.3. While tracking, adjust with GH MLIN and GH LIN so
that the sizes of the horizontal line at the centre of thescreen are symmetrical left and right.
MLIN
LIN
HORIZONTAL SIZE ADJUSTMENT1. Adjust with GH MSIZE, so that the sizes of both edges and
centre are equal.2. Adjust with GH SIZE, so that the horizontal sizes of both
edges and centre are equal.3. While tracking adjust GH MSIZE and GH SIZE so that the
space intervals for the horizontal section of the screen areequal.
4. Adjust again if M LIN is changed after GH MSIZE and GHSIZE are complete.
GREEN VERTICAL LINEARITY ADJUSTMENT1. Adjust GV LIN so that the vertical lines at the top and bot-
tom of the screen are symmetrical.
MSIZ
SIZE
GH MLIN
GH MSIZ GH LIN
GH SIZE
GH MSIZE
Page 14
– 30 –
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
GREEN VERTICAL SIZE ADJUSTMENT1. Adjust GV MSIZE so that the sizes at the top and bottom and
centre are equal.2. Set the vertical size to correct specification.3. While tracking adjust GV MSIZE and GV SIZE so that the
space intervals for the vertical line of the screen are equal,also the vertical size should be within space.
4. Adjust again if GV L IN has been altered after completingthe above adjustments.
MSIZ
SIZE
GV LIN
GV SIZE GV MSIZGV MSIZE
GREEN HORIZONTAL TRAPEZOIDAL DISTORTIONADJUSTMENT1. Adjust GH SSKW so that the tilt of the vertical lines at both
edges of the screen are symmetrical left and right.2. Adjust GH KEY so that there is no tilt in the vertical lines at
both edges of the screen.3. While tracking adjust GH KEY and GH SSKW.
GREEN HORIZONTAL QUATERNARY ADJUSTMENT1. Adjust GH 4PIN, to correct the 4th order distortion.2. Adjust GH 4SBO to balance and correct the 4th order distor-
tion at both edges of the screen.3. While tracking adjust GH 4PIN and GH 4SBOW.
4 PIN
4SBO4SBOW
GREEN HORIZONTAL ASYMMETRICAL PINDISTORTION ADJUSTMENT1. Adjust GH MBOW, so that the pin asymmetry at both sides
of the centre section are symmetrical left and right.2. Adjust GH SBOW so that the bow at both edges of the screen
is symmetrical left and right.3. While tracking adjust GH MBOW and GH SBOW so that
the bow of vertical lines over the entire screen is symmetri-cal.
SS KW
KEY
SSKW
M BOW
S BOW
Page 15
– 31 –
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
GREEN HORIZONTAL SYMMETRICAL PIN DISTORTIONADJUSTMENT1. Adjust GH MPIN to correct pin distorton at both edges of
the centre section.2. Use GH PIN to correct pin distortion at both edges of the
screen.3. While tracking adjust GH MPIN and GH PIN so that the PIN
of vertical lines on the entire screen have no bowing.4. If there is asymmetrical distortion after adjustments, re-ad-
just GH MBOW and GH SBOW while tracking.
GREEN VERTICAL 4TH ORDER DISTORTIONADJUSTMENT1. By using GV 4 PIN, 4th-Order distortion of the horizontal
lines at the top & bottom can be corrected.Since there is no 4SBO for vertical correction, there will be aslight imbalnace, but adjust the registration to eleiminate anydistortion.
GV 4PIN
GREEN VERTICAL TRAPEZOIDAL DISTORTIONADJUSTMENT1. Adjust GV SSKW so that the tilt of the horizontal lines at the
top and bottom of the screen are symmetrical.2. Adjust GV MKEY so that there is no tilt for the middle sec-
tion.3. Adjust GV KEY so that there is no tilt at the top and bottom
of the screen.4. While tracking adjust GV MKEY and GV KEY, so that there
is no tilt over the entire screen.5. If the tilt is unbalanced after GV MKEY and GV KEY
have been adjusted, readjust GV SSKW.
GV SSKW
GV SSKW
GV KEY GV MKEY
MKEY
KEY
M PIN
PIN
GH MBOW
GH PIN GH SBOW
GH MPIN
GREEN VERTICAL WAVE (3RD-ORDER) DISTORTIONADJUSTMENT1. Check the screen at the top & bottom, and look for any 2nd
or 3rd order waveform distortion of horizontal lines. Correctwith GV WAVE.
2. While tracking adjust GV WAVE and GV KEY, if here areany KEY distortion.
GV KEY
GV WAVE
Page 16
– 32 –
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
GREEN VERTICAL ASYMMETRICAL PIN DISTORTION(2ND-ORDER DISTORTION) ADJUSTMENT1. Correct the asymmetrical pin distortion at the top and bot-
tom of the screen with GV SBOW.
GV SBOW
GREEN VERTICAL ASYMMETRICAL PIN DISTORTIONADJUSTMENT1. Using GV MPIN adjust the pin distortion at both edges of
the screen and at the centre.2. Using GV PIN, adjust, so that the horizontal lines at the top
& bottom of the screen are straight lines.3. Adjust GV MPIN & GV PIN so that there is no curve in the
horizontal lines on the entire screen.4. After adjusting the items above, using tracking with GV
SBOW. GV MPIN, and GV PIN to correct the entire screen.
MPIN
PIN
GV SBOW
GV MPIN GV PIN
GREEN AND RED REGISTRATION ADJUSTMENT1. Receive a PAL cross-hatch signal.2. Adjust so that the red lines lay on the green lines.
Adjust, using the same procedure as the GREEN SUB ad-justment outline above.
Note : Main registration correction should not be while ad-justing Red adjustment.
BEWARE : Not to change Green Sub Items It’ s easily doneby mistake.
GREEN AND BLUE ADJUSTMENT1. Adjust so that the blue and green lines are on top of each
other.
Note : Main registration correction should not be while ad-justing Blue adjustment.
BEWARE : Not to change Green & Red Sub Items.It’ s easily done by mistake.
REGISTRATION DATA WRITE* Points to bear in mind :
There are two independent modes of pictures 4 : 3 MODEand 16 : 9 MODE
1. Once REGISTRATION 4 : 3 has been adjustedPress "Mute" + 0 >"Data Write"
(write data in NVM)Press "On screen disp." + 0 >"WRT 5060" Pal to NTSC
(write data Pal/Secam to NTSC)If 2 + 0 is pressed (Data copy) it is recordingdata from 4 : 3 to 16 : 9 mode.So it should be adjusted in 16 : 9 mode.
2. Adjust REGISTRATION in 16 : 9 mode.Press "Mute" + 0 >"Data Write"
(write data in NVM)Press "On screen disp." + 0 >"WRT 5060"Pal to NTSC
(write Pal/Secam to NTSC)3. Once REGISTRATION has been adjusted in both modes
(4 : 3 and 16 : 9)a) With picture go into service modeb) Press TT and "autoconvergence" button in
control panel and wait for the adjusting
∗ Make sure input signal is PAL. If input signal is NTSCand do this process, NTSC data are copied to PAL data!
5-5. AGC ADJUSTMENT1. Receive an off-air signal.2. Adjust the AGC VR ( IF 1001 ) so that there is no snow noise
and cross-modulation.
Page 17
– 33 –
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
A B
A = B
5-6. WHITE BALANCE ADJUSTMENT1. Receive the monoscope signal and adjust the picture quality
with the menu.2. Adjust service mode S-BRIGHT so that the signal 10 IRE
section barely glows.3. Receive the all-white pattern signal.4. Adjust the white balance with service mode G-CUTOFF and
B-CUTOFF.5. Adjust service mode S-BRIGHT so that the signal 100 IRE
section barely glows.6. Adjust the white balance with service mode G-DRIVE and
B-DRIVE.7. Repeatedly adjust the white balance for the minimum and
maximum picture settings.
5-7. TEXT POSITION ADJUSTMENT1. Receive RF signal with text.2. Press TT74 (Text H position adjustment) of Test commander.3. Adjust H Position of Text.
Page 18
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
– 35 – – 36 – – 37 – – 38 –
SECTION 6
DIAGRAM
6-1. BLOCK DIAGRAM (1)
A1
A2
A3
A4
A5
A6
A7
A8
A9
B1
B2
B3
B4
B5
B6
B7
B8
B9
A10
A11
B10
B11
A12
B12
A14
A15
A16
B13
B14
B15
B16
A13
A18
A19
A20
A21
B18
B19
B20
A17
B17
B21
GND
GND
GND
GND
NC
BLUE IN
MODE
MODE
GND
GND
NC
NC
NC
GREEN IN
NC
NC
GND
GND
GND
GND
SVHS-C IN
RED IN
NC
BLANKING
GND
GND
GND
GND
CVBS OUT
CVBS OUT
CVBS/Y IN
CVBS IN
GND
GND
AUDIO R OUT
AUDIO R IN
AUDIO L OUT
AUDIO L IN
AUDIO L IN
AUDIO R OUT
AUDIO R IN
AUDIO L OUT
CN201
B1
G1
R1
FB1
C2
Y2
V1
V-BUFFER
Q110-112
MONO IN
ANA-IN1
ANA-IN2
L IN AV-1
R IN AV-1
L IN AV-2
R IN AV-2
L IN AV-3
R IN AV-3
XTAL
X201
IC205
RESET
61
1
20
21
34
33
31
32
37
36
L3
R3
L1
L2
R2
R2
RESET
IC202
AUDIO PROCESSOR
L OUT SP
R OUT SP
56
57
28
25
23
BUFFER
Q204
BUFFER
Q203
59
60
47
48
50
51
L1
R1
HP L
HP R
L2
R2
INV
INV
Q206
Q207
5
1
14
12
L OUT HP
R OUT HP
L OUT AV-2
R OUT AV-2
L OUT AV-1
R OUT AV-1
BUFFER
Q217
BUFFER
Q202
15 CVBS OUT
V-2
11
9
Y
C
20
21SCL
SDA
13 BUFFER
Q201
IC201
VIDEO SW
CVBS OUT
SCL
SDA
SYNC C OUT
SYNC Y OUT
CVBS OUT AV-2
23
27
25
29
1
3
4
6
31
5
7
V3
Y3
C3
V2
Y2
C2
S1
S2
V1
INV
Q113,114
TV IN
SYNC IN TV
CVBS
CVBS IN AV-2
Y IN AV-2
C IN AV-2
MODE
MODE
CVBS IN AV-3
Y IN AV-3
C IN AV-3
L102
Q121,130,124
BUFFER
Q120,122
TU101
VIDEO
AGC
AM
QSS
SCL
SDA
SCL
SDA
3
13
IC203
AUDIO SW
SW
Q205
L2
R2
L2
R2
IC4
RESET
BUFFER
Q1,1002
RST SW
Q1001
X1001
20.48MHz
IC1001
TEXT/OSD
10
17
6
7
61
62
63
64
66
67
68
4
5
79
VS
HS
Q20,23
Q21,24
Q22,25
SW
Q4
INV
Q15
INV
Q17
CVBS IN
RST
XOUT
XIN
RED
GREEN
BLUE
ANKING
USART
USART
ENABLE
VS
VS
HS
59
74
15
16
77
55
54
63
16
10
67
FB-2
CVBS IN
XTAL2
X1 11.5MHz
XTAL1
VS
HS/SSCP
RST
P1.1
P2.0
R2
G2
B2
FB2
MUTE
LED
STBY
K1
IR
7
4
61
62
65
80
68
7
P0.6
P0.5
P3.0
P1.4
P2.2
P3.2P2.1
P0.1
P0.0
57
56SCL
SDAIC2
NVM
SCL
SDASDA
SCL
TEST
5
6
A0-A18
D0-D7
IC3
PROGRAM ROM
IC1
MICRO
6
2
9
60
P1.5
P3.1
P1.2
P0.4
4
15
14
SW
Q215
SW
Q216
SCL
SDA
4FSC ADJ
Q101,102
IC102
4FSC PLL
7
1
44FSC
R
FSC
BUFFER
Q103,115,116FL102
BUFFER
Q104
CLAMP
Q105,106
22
11
25
IC103
DIGITAL COMB FILTER
ADIN
OCLK
RAT1
NTPL
BUFF
BUFF
FL104
FL103
Q107,108
Q109,125
31
39
69
70
4
8
1
11
Y
C
IC204
YC SW
3
5
6
9
2
13
12
10
Y BUFFER
Q212
C BUFFER
Q213
INV
Q211
IC206
BUS SW
PAL/NT
SCL
SDA
YC/COMB
MODE S
SP SW
A REGI
6
1
2
7
9
AYO
ACO
55
57
MODE3
15
16
17
18
19
12
13
14
11
53
31
32
49
38
33
37
64
10
SVHS-Y IN
SVHS-C IN
FB2 IN
HB2 IN
R2 IN
G2 IN
B2 IN
R1 IN
G1 IN
B1 IN
FB1 IN
CVBS IN
V- DRIVE
V+ DRIVE
VM
AFC PIN
E-W
H OUT
FISO
SSCP OUT
IC301 SHADING
R OUT
G OUT
B OUT
IK IN
VS HS IN
SYNC OUT
Y OUT
Y IN
SCL
SDA
3.58MHz
3.58MHz
L2 FIL
ABL IN
VTIM
SECAM REF
B-Y IN
R-Y IN
B-Y OUT
R-Y OUT
22
24
26
27
46 47
48
5
6
28
51
50
30
62
61
30
3
4
7
8
1
16
14
11
12
5
19
20
1
12
11
IC303
CHROMA DEC
SSCP
CVBS
IDENT
B-Y OUT
R-Y OUT
+9VMUTE DRIVE
Q208,209,210
INV
Q18,214
BUFFER
Q331
18-35,37
36,38-44
18-35,37
36,38-44
IC302
IH DELAY LINE
R-Y IN
B-Y IN
R-Y OUT
B-Y OUT
SSCP
Y BUFFER
INV
Q330
Q301-303
SCL
SDA
R2
G2
B2
CN6
12V
SCL
SDA
FS
E
PJE YM
PJE YS
PJE B
PJE G
PJE R
SPSW
50-60
VBLK
S300
SW
CN301
RED DRIVE
GRN DRIVE
9V
GND
CUT OFF
GND
BLUE DRIVE
OTO CR BOARD
CN703
ATO D BOARD
CN1702
PROT
E-W
V+
V-
VS
HS AFC PIN
H OUT
STBY
SP L
SP R
V3
Y3
C3
L3
R3
L2
R2
MUTE
K1
IR
LED
MODE3
5
46
48
43
45
7
6
9
38
20
13
15
22
21
37
12
24
26
25
28
23
27
30
29
16
32
39
35
42
3
CN1
BTO D BOARD
CN1801
E/W
V+ OUT
ABL
V SYNC
HFBP
H DRIVE
PROT
P CONT
VM OUT
SPKR L
SPKR R
H/P L
H/P R
VBS OUT
CVBS OUT
V IN
Y IN
C IN
L IN
R IN
L OUT
R OUT
S3/GND
MUTE
KEY2
SIRCS
STBY LED
MODE3
A REGI
B-SS510.<SM.>-B/D-1
Y2/V2
V1
AETUNER,VIDEO SW,AUDIO SW,AUDIO PROCESSOR,
DIGITAL COMB FILTER,CHROMA DECODER
XTAL
SP L
SP R
1
A0-A18
A REGI
HP L
HP R
MUTE
CVBS OUT
Q507,308
1
2
3
4
5
6
7
1
2
3
4
5
6
7
8
9
10
11
12
13
MODE O
RB
D0-D7
18.432M
V OUT
INV
Q309
1
2
3
4
1
2
3
4
5
6
7
8
9
10+5V
NC
SIRCS
GND
KEY1
STBY+5V
GND
R.LED
NC
AC(L)IN
NC
NC
AU(N)IN
CN3003
CN3002
OUT
IC3002
SIRCS
S3006
POWER
1
2
3
4
5
1
2
3
4
LED DRIVE
Q3002
D3002
S3001-3005
CN3004
CN3001
AC(L)OUT
NC
NC
NC
AC(N)OUT
+5V
KEY1
KEY2
GND
M
N
TO G BOARD
CN6007
TO H2 BOARD
CN3201
TO D BOARD
CN1803
TO G BOARD
CN6006
L
C
H1(FUNCTION KEY,SIRCS)1
2
3
4
5
6
7
1
2
3
4
5
6
7
8
CN2703
21P
SCART
CN2701
CN2702
GND
CVBS/Y IN
GND
CVBS OUT
GND
C IN
MODE
L IN
GND
R IN
L OUT
GND
R OUT
GND
F
G
TO D BOARD
CN1808
TO D BOARD
CN1807
1
2
3
4
5
6
7
8
9
10
11
1
2
3
4
5
1
2
3
4
S3205
S3206
CN3204
CN3201
CN3202
FR S3 OUT
GND
FR R OUT
GND
FR L OUT
GND
GND
FR C OUT
GND
FR Y OUT
SP MUTE
HP L IN
GND
GND
HP R IN
GND
KEY1
+5V
AUTO REG1./KEY2
H
N
DTO D BOARD
CN1802
TO D BOARD
CN1601
TO H1 BOARD
CN3001
A/V-INPUT,
FUNCTION KEY
H2
1 2
3 4
V
L
R
J3201
J3202
VIDEO INPUT3
R
L(MONO)
VIDEO
S-VIDEO
HEADPHONE
1
2AC(L)
AC(W) 1
4 AC(L)
CN6007
STBY+7V
P.CONT
PROT
+7V
CN6008
1
3
4
6
+12V
D6003
AC RECT
CN605 CN6006T602LFT
Q6001-6003,6005
IC6004
CONV
DRIVE CONTROL DRIVE
CONV
IC6007Q6015
Q6014
VCC SW
Q6009
IC6001
IC6005
PT6004
Q6010-6012
T6005
AUDIO+
AUDIO-
+15V
-15V
+135V
D6038
AUDIO
RECT
IC6008
+B OCP
Q6013
IC6006
G(POWER SUPPLY)
L
M
B-SS510.<SM.>-B/D-2-P2
AC(N)
AC(L) AC(N)
1
5
TO E BOARD
TO H1 BOARD
CN3003
TO H1 BOARD
CN3004
CN807
1
3
1 2
VCC CONT
VCC OUT
2 4
3
1
D6004
RECT
D6002
RECT
LATCH PROT
VCC SW
4
3
1
2
10
9
10
12
SW
SW
7
5
1
SW SOFT START 1,6
D6017
RECT
4
5
PWM SW
D6007
RECT
D6025
FR V OUT
GNDAUTO REGI./KEY2
UEAV-INPUT/ OUTPUT
Page 19
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
– 42 –– 41 –– 40 –– 39 –
1
2
3
4
5
1
2
3
4
5
6
7
8
9
10
11
1
2
3
4
5
6
7
8
9
10
SW
Q1614
MUTE
Q1801
CN1802
CN1804
CN1803
LED G
LED R
GND(KEY)
STBY 5V
KEY1
GND(KEY)
SIRCS
LUMI
+5V
A.REGI/KEY2
FRINT Y
GND(V3)
FRONT C
GND(V3)
FRONT V
GND(V3)
FRONT L
GND(V3)
FRONT R
GND(V3)
FRONT S
135V
NC
9V
GND
VM
FY
FC
FV
FL
FR
R OUT
L OUT
R3
L3
C3
Y3
V3
V
L
R
L
R
A
A
5
46
48
43
45
7
6
9
38
20
13
15
22
21
37
12
24
26
25
28
23
27
30
29
16
32
39
35
42
3
E/W
V+OUT
ABL
V SYNC
HFBP
H DRIVE
PROT
P CONT
VM OUT
SPKRL
SPKRR
H/P L
H/P R
VBS OUT
CVBS OUT
V IN
Y IN
C IN
L IN
R IN
L OUT
R OUT
S3/GND
MUTE
KEY1
SIRCS
STBY LED
LED
A.REGI/KEY2
CN1801
L3
R3
L/R OUT
V3
Y3
C3
V
FC
FV
FY
BUFFER
Q1803
BUFFER
BUFFER
Q1805
Q1807
MIXING
MIXING
MIXING
Q1802
Q1804
Q1806
1
7
IC1805
MIXING
2
3
6
5
FL
FR
FV/FY/FC
1 2
MUTE
J1601
VAR OUT
3
17
6L
R
IC1603
HP AMP
SW
Q1605
SW
Q604
SW
Q1610,1611
Q1612,1613
+12V
MUTE
Q1602
6
4
8
L
R
3
1
IC1602
AUDIO MAIN AMP
D
E
C
BTO AE BOARD
CN1
TO H1 BOARD
CN3002
TO H2 BOARD
CN3202
TO ZG BOARD
CN1431
1
2
3
4
5
6
7
1
2
3
4
5
6
7
8
9
10
11
12
13
CN1702
CN1708
12V
SCL
SDA
FS
GND
PJE YM
PJE YS
PJE B
PJE G
PJE R
SP SW
50-60
VBLK
GND
SCL
SDA
FS
5V
SCL IN
SDA IN
FOR CHECK
TO AE BOARD
CN6
A
DAUDIO AMP,HP AMP,
SCL
SDA
BUFFER
Q1205
BUFFER
Q1704
Q1701
1703
BUFFER
-
5
3
7
1
IC1503
35
34
32
31
30
25
IC1702
NVM
INV 42
1
10
9
Q1707,1708
47
45
O-YM
O-YS
O-B
O-R
O-G
O-FV
I-SCLN1
O-SDA10
I-FS
I-VP
I-BLK
I-HBLK
IC1701
DJ ENGINE
INV
Q1706
7
4
5
6
49
50
51
52
O-CEB
O-MUTE
O-HSHIFT
O-VSHIFT
O-R WAVE
O-B WAVE
O-DATA
I-SENS3
I-SENS2
I-SENS1
I-SENS0
O-XTAL
I-XTAL
7
1
6
2
IC1703
BUFFER
5
4
10
11
6
9
IC1502
7
1 2
6
IC1704
BUFFER
7
8
19
20
13
12
X1701
8.0M
1
2
3
1
2
3
4
5
6
7
8
9
10
IC1501
V OUT
1
75
1
2
3
1
2
3
4
5
6
7
8
9
10
11
IC1502
1
MUTE
3 4
Q1601,1603
1
1
2
3
4
5
6
7
1
2
3
4
5
1
2
3
4
5
6
7
8
1
2
3
4
L
R
L
R
AUDIO DET
Q1615-1617
RY1601
RY1602
CN1703
CN1704
GND
RV WAVE
BV WAVE
GND
MUTE
DATA
CEB
GND
VP
HC MOVE
GND
VC MOVE
CN1701
CN1501
LOWER
GND
RIGHT
GND
LEFT
GND
UPPER
GND
V DEF
NC
V RET
CN1806
CN1805
HD
GND
HP
GND
PIN
PROT1
ABL
GND
+15V
P.CONT
CN1604
CN1601
L OUT
GND(AU)
R OUT
GND(AU)
HP R
GND
GND
HP L
MUTE
CN1807
CN1808
L IN
GND
R IN
GND
L OUT
GND
R OUT
GND
GND
CVBS/Y IN
GND
CVBS OUT
GND
C IN
MODE
VBLK
CN1606
FTO UE BOARD
CN2701
GTO UE BOARD
CN2702
H
P
TO H2 BOARD
TO G BOARD
CN3204
CN3204
L
R
SPEAKER
TO
PHOTO
SENSOR
CLK
HD
GND
HP
GND
PIN
PROT1
ABL
GND
+15V
GND
RV WAVE
BV WAVE
GND
MUTE
DATA
CEB
GND
VP
GND
VC MOVE
CLK
1
2
3
4
5
6
7
8
9
10
1
2
3
1
2
3
4
5
6
7
8
9
10
1
2
3
4
5
6
7
8
9
10GND
HV.DET
GND
VBLK
GND
GND
GND
GND
GND
GND
CN804
CN813
CN506
CN651
1
4
5
6
7
IC1801
V.WAVE GEN
BUFFER
BUFFER
Q801,804
Q803,806
V.BLK
V.SAW
V.PARA
V.SIN
V.4TH
15
16
19
20
1
2
3
4
38
37
V.SAW
V.PARA
V.SIN
V.4TH
H.SAW
H.PARA
H.SIN
H.4TH
A1 INP
A2 INP
IC804
B CONV GEN
1
IC1802
H.WAVE GEN
4
5
6
7
H.BLK
H.SAW
H.PARA
H.SIN
H.4TH
BV OUT
BH OUT
MPIN 1
M PIN2
CEB
DATA
MUTE
CLKB
41
40
23
22
31
32
33
34
10
11
12
13
31
33
34
32
10
11
12
13
15
16
19
20
1
2
3
4
38
37
IC806
G CONV GEN
V.SAW
V.PARA
V.SIN
V.4TH
H.SAW
H.PARA
H.SIN
H.4TH
A1 INP
A2 INP
V.SAW
V.PARA
V.SIN
V.4TH
H.SAW
H.PARA
H.SIN
H.4TH
A1 INP
A2 INP
CEB
DATA
MUTE
CLKB
CEB
DATA
MUTE
CLKB
CLKB
MUTE
DATA
CEB
CLKB
MUTE
DATA
CEB
GV OUT
GH OUT
RV OUT
RH OUT
41
40
31
32
33
34
41
40
IC808
14
15
6
6
14
15
9
7
11
13
16
18
11
18
8
13
16
7
IC810
TO B BOARD
CN1804
CONV OUT
IC809
CONV OUT
1
2
3
4
1
2
3
4
1
2
3
4
CN803
CN802
CN801
HB OUT
VB OUT
VB RET
HB RET
HG OUT
VG OUT
VG RET
HG RET
HR OUT
VR OUT
VR RET
HR RET
1
2
E(H/V-DEF,HV)
H DRIVE
Q501
H OUT
Q502
2 5
IC501(1/2)
REG COMP
11
1
13 814
9
17
IC501(2/2)
REG COMP
PIN AMP
Q505
BUFFER
Q802,805,808
BUFFER
Q508
13
6
1
14
7
9
108
3
IC805
DF AMP
+7V
DF OUT
Q506,507
Q503,504
1
2
3
4 GND
NC
DF
G2
GND
HV.REG
STDBY 7V
STDBY 7V
CN805
CN507
FOCUS
BLOCK
HV
BLOCK
G2
FV
R
G
B
T502
Q807
BUFFER
5
11
10
6
9
IC803
1
7
3
10
9
4
11
T504
FBT
3
6
1
7
IC811
SHADING AMP
1
2
3
4
5
6
7
8
9
10
1
2
3
4
1
2
3
4
1
2
3
4
KTO CB BOARD
CN766
HV
CN502
CN503
CN504
CN501
B/S
R/S
NC
H(+)
H(-)
NC
NC
200V
NC
GND
R-H(+)
NC
NC
R-H(-)
G-H(+)
NC
NC
G-H(-)
B-H(+)
NC
NC
B-H(-)
I
J
TO ZG BOARD
CN1436
G2
FV
TO ZG BOARD
CN1405
+B
+13V
-13V
-B
D513
1
2
3
4
G2
FV
DY
ZB(DY)
1 2 3 4 5 1 2 3 4 1234
135V
NC
9V
E VH
HB.IN
VB.IN
VB.RET
HB.RET
HB.RET
VB.RET
VB.IN
HB.IN
CN1431
CN1462
CN1464
1
2
3
4
1
2
3
1 2 3 4
I
CN503
CN1434
CN1461
G-H(+)
NC
NC
G-H(-)
V.DEF
V.MID
V.RET
DYVM DRIVE VM CONT
Q1431,1432 Q1433-1436
1
2
3
4
5
6
7
V.IN
NC
V.OUT
NC
VM.OUT
NC
VM.RET
CN1432
1
HG IN
VG IN
VG RET
HG RET
1
2
3
4
5
6
7
V.OUT
NC
V.IN
NC
VM.IN
NC
VM.RET
CN1401
ZG(DY/VM)
1 2 31 2 3 4
DY
2
CN1404
CN1403
HR IN
VR IN
VR RET
HR RET
NC
V.RET
V.DEF
1
2
3
4
NC
NC
R-H(-)
R-H(+)
CN1405
JTO E BOARD
CN504
B-SS510<SM.>-B/D-2-P1
FV
+B
T501
-15V
STBY+7V
P.CONT
PROT 6
+7V 6
3
1
P.CONT 1
15
16
19
20
1
2
3
4
38
37
HC MOVE
TO E BOARD
E
CN1433
(DY/VM)ZR
1
2
3
4
5
6
7
8
-15V
V OUT,PJ ENGINE
6
5
V OUT
G2
G2
NC
200V
NC
E
B
CRR
PICTURE TUBE
PICTURE TUBE
NC
200V
NC
E
B
NC
200V
NC
E
CG
H-
H+
V902
V901
G2
G2
G
(G OUT)
(R OUT)
CN703
OTO AE BOARD
CN301
R
G
B
9V
E
IK
E
1
2
3
4
5
6
7
1
CN704
1
2
3
4
5
6
7
8
1
1
2
2
1
2
3
4
5
6
7
8
9
CN706
CN702
E
9V
G
E
R/S
NC
H(+)
H(-)
NC
E
IK DET
Q701
VIDEO OUT
Q704,703
H(+)
H(-)
200V
Q705,706
BUFFER
1
2
3
4
5
6
7
8
9
1
2
3
4
5
6
7
8
1
VIDEO OUT
Q733,732
NC
R/S
H(+)
H(-)
NC
E
CN736
CN733
CN731
IKG
IKB
E
9V
G
E
1
2
3
4
5
6
7
8
9
1
2
3
4
5
CN737
CN732
R/S
NC
H(-)
H(+)
NC
E
IKB
9V
B
E
IKG
IKB
IK DET
Q731
PICTURE TUBE
NC
200V
NC
G2
V903
E
CB
B
G2
(B OUT)
1
2
3
4
5
6
7
8
9
1
2
3
4
5
1
CN761
IKB
9V
E
B
R/S
NC
H(+)
H(-)
NC
E
CN765
CN762
NC
200V
NC
R/S
NC
H(+)
H(-)
NC E
1 2 3 4 5 6 7 8 9 10
B/S
CN766
VIDEO OUT
Q762,763
H(+)
H(-)G1
TO E BOARD
K
CN501
IK DET
Q761
PROT
Q764
BLOCK DIAGRAM (2)
Page 20
– 43 – – 44 – – 45 – – 46 –
6-2. FRAME SCHEMATIC DIAGRAM
6-3. CIRCUIT BOARDS LOCATION
6-4. PRINTED WIRING BOARDS AND SCHEMATICDIAGRAMS
Note:
• Capacitors without voltage indication are all 50V.
All capacitors are in µF unless otherwise noted.
• All resistors are in ohms.
kΩ=1000Ω, MΩ=1000kΩ• Indication of resistance, which dose not have one for rating electrical power, is
as follows.
Pitch : 5mm
Rating electrical power : 1/ 4 W (CHIP: 1/ 10 W)
• : nonflammable resistor.
• : fusible resistor.
• : internal component.
• : panel designation and adjustment for repair.
• All variable and adjustable resistors have characteristic curve B, unless other-
wise noted.
• As to the voltage volue shown by the semiconductors on the Shematic Dia-
gram, see the another list
• Readings are taken with a color-bar signal input.
no mark : PAL/common
< > : SECAM
( ) : NTSC3.58
• Readings are taken with a 10MΩ digital multimeter.
• Voltages are dc with respect to ground unless otherwise noted.
• Voltage variations may be noted due to normal production tolerances.
• All voltages are in V.
* : Measurement impossibillity.
• v : B+line.
• v : B-line.
(Actual measured value may be different).
• : signal path.
• Circled numbers are waveform references.
Reference information
RESISTOR : RN METAL FILM
: RC SOLID
: FPRD NONFLAMMABLE CARBON
: FUSE NONFLAMMABLE FUSIBLE
: RW NONFLAMMABLE WIREWOUND
: RS NONFLAMMABLE METAL OXIDE
: RB NONFLAMMABLE CEMENT
: ADJUSTMENT RESISTOR
COIL : LF-8L MICRO INDUCTOR
CAPACITOR : TA TANTALUM
: PS STYROL
: PP POLYPROPYLENE
: PT MYLAR
: MPS METALIZED POLYESTER
: MPP METALIZED POLYPROPYLENE
: ALB BIPOLAR
: ALT HIGH TEMPERATURE
: ALR HIGH RIPPLE
G
D
S
2
3
4
5
6
7
8
9
0
!¡
!™
!¢
–
1
G
D
S
G
S S
D
G
D
Ver.1.5
Transistor(FET)
Transistor
Transistor
Discrete semiconductot
(Chip semiconductors that are not actually used are included.)
Diode
Diode
Diode
Diode
Diode
Diode
Diode
Diode
Diode
Diode
Source
Source
Anode Anode
(NC)
(NC)
Cathode
AnodeCathode
Common
Cathode Cathode
Common
Cathode Cathode
Common
Common
Common
Common
Cathode
Anode
Base Emitter
Collector
Base Emitter
Collector
Drain
Gate
Gate
Drain
Device Printed symbol Terminal name Circuit
Terminal name of semiconductors in silk screenprinted circuit ( * )
Anode
Anode
Anode Cathode
Anode Anode
Cathode
!£
Transistor(FET)
Transistor(FET)
!∞
Source
GateDrain
Cathode
AnodeAnode
CathodeAnodeAnode
ZG
ZR
AE
UE
CRD
CGE
CB
G
H2
H1
1
56
7
8
9101112
G4H
H
4
G1
G1G1
K
G2G1NC
1
56
7
8
9101112
G4H
H
4
G1
G1G1
K
G2G1NC
1
56
7
8
9101112
G4H
H
4
G1
G1G1
K
G2G1NC
1 2 3
1
2
3
4
5
6
1 2
1
2
3
4
5
6
7
1
50
25
26
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
9
10
1 2 3 4 5 6 7 8 9 10 1 2 3 41 2 3 4 5 6 7 8 9 10 1 2 3 4 5 6 7 8 9 101 2 3 4 5 6 7 8 9 10
1
2
3
4
1 2 3 4 5 6 7 8 9 101 2 3 4 5 6 7 8 9 10 1 2 3 4 5 6 7 8 9 10
1
2
3
4
1
2
3
4
5
1 2 3 4 5 6 7 8 9 10
1 2 3 41 2 3 4 1 2 3 41 2 3 4 1 2 3 4
1
2
3
4
1 2 3 4 5 6 7
1 2 3 4
1 2 3 4 5 6 7
1 2 3 4
1 2 3 4 5 6 7 1 2 3 4
1
1
2
3
4
5
6
7
8
9
1 2 3 4 5 6 7 8
1 2 3 4 5 6 7 8 9
1
2
3
4
5
6
7
8
9
1 2 3 4 5 6 7 8 9
1 2 3 4
1
2
3
4
5
1
2
3
4
5
1
2
3
4
5
6
7
8
9
10
1
2
3
4
5
6
7
8
1 2 3
12341 2 3 4 5 6 7 8 9 10
11
1 2 3 4 1 2 3 4 1
1 2 3 4 5 6 7 8 9 10
11
12
13
1 2 3 4 5 6 7 8
1
1
2
3
4
1
2
3
1
2
3
4
5
1
2
3
4
5
1
2
3
4
1
2
3
4
5
1
2
3
4
5
6
7
8
9
10
11
1
2
3
1
50
25
26
1
2
3
4
5
6
1
2
3
1
2
3
4
5
6
7
8
9
10
1 2 3 4
12345
1 2 3 4 5 6 7 8
1
1
1 2 3 4 5 6 7 8 9 10
11
1
2
3
4
1
2
3
4
5
1
2
3
4
1
2
3
4
5
6
7
1
2
3
4
5
6
7
1
1
1
2
1
2
1
2
1
2
1
2
3
4
5
1
2
3
4
5
1 2 3
1 2 3 4 5 6 7 8 9 10
11
12
13
1 2
1
2
3
4
5
6
7
1
1 2
CN651 CN506 CN652 CN804
CN803CN802 CN801 CN504
CN807
J1601
CN1432
CN1401
CN1403CN1405CN1404
CN736
CN806
CN1434
CN1433
CN763
CN761
CN762
CN765
CN766
CN734
CN737
CN731CN733
CN732
CN764
CN735
CN704
CN705
CN702
CN706
CN701
TB1601
CN1501
CN1804
CN1604CN1806CN1606 CN1805 CN1703
CN1803
CN1802
CN502CN503
CN6005
CN6012
CN6011
CN6008
CN6013
CN6009
CN6001
CN810
CN3204
CN3201
CN6007
CN6006
CN3202
CN3002
CN703
CN1431
CN1464CN1461CN1436
CN1462
DY1461
CN1702
CN3003
CN3004
CN3001
CN805
CN1601
CN1701
CN1708
CN505
CN808
CN2702
CN2701
CN1808
CN1807
CN1605
CN1502
CN508
CN501
CN507
CN1705
CN1801
CN6002
CN101
CN6
CN301
10P:B-TO-B
10P:B-TO-B
10P:B-TO-B
10P:B-TO-B
4PBLK
:S-MICRO
4PWHT
:S-MICRO
4PRED
:S-MICRO
4P:VH
6PWHT
:S-MICRO
7PWHT
:S-MICRO
7PWHT
:S-MICRO
3PRED
:S-MICRO
4P:VH
4PRED
:S-MICRO
9PWHT
:S-MICRO
3P:MINI
4P:VH
4PWHT
:S-MICRO
1PWHT:MINI
FASTON
5PWHT
:S-MICRO
9PWHT
:S-MICRO
10PWHT
:S-MICRO
1PWHT:MINI
9PWHT
:S-MICRO
FASTON8PWHT
:S-MICRO
5PWHT
:S-MICRO
1PWHT:MINI 8P
WHT:S-MICRO
9PWHT
:S-MICRO
FASTON
3PRED
:S-MICRO
5PWHT
:S-MICRO
4PWHT
:S-MICRO
10PWHT
:B-TO-B-S
10P:B-TO-B-S
10P:B-TO-B-S
10P:B-TO-B-S
10PWHT
:S-MICRO
11PRED
:S-MICRO
4P:VH
4P:VH
2P
4P:MINI
5P:MINI
6PWHT
:S-MICRO
3P:MINI
1P:FASTON
1P:FASTON
3P:MINI
5PRED-L
:S-MICRO
4PWHT-L
:S-MICRO
5B3PS:VH
4B2PS:VH
11PRED-L
:S-MICRO
10PWHT-L
:S-MICRO
7PRED
:S-MICRO
5PWHT
:S-MICRO
4PBLK
:S-MICRO
3PWHT
:S-MICRO1P
:FASTON
4PBLK
:S-MICRO
13P WHT :S-MICRO
4B2PSWHT-L:VH
5B3PSWHT-L:VH
4PWHT-L
:S-MICRO
4P:MINI
5PBLK
:S-MICRO
8PRED
:S-MICRO
7PWHT
:S-MICRO
2P:LARGE
5P:MINI
8PWHT-L
:S-MICRO
7PRED-L
:S-MICRO
7PRED
:S-MICRO
8PWHT
:S-MICRO
4P:MINI
1P:FASTON
1P:FASTON
10PWHT
:S-MICRO
4PWHT
:S-MICRO
2PRED
:S-MICRO
50P:B-TO-B
1P:FASTON
1P:FASTON
13P WHT :S-MICRO
7PRED
:S-MICRO
HV
G2
FV
+
-
+
-
L
R
R
G
B
FOCUSPACK
HV BLOCK
HV
HV
HV
07MXC
07MXC
07MXC
G
BOX
BOX
NC
V.DEF
V.RET
G2(R) G2(G) G2(B)
FV(R) FV(G) FV(B)
DET
G2
FV
DF
E(HV)
E
HV REGHV(B)
HV(G)
HV(R)
NC
NC
NC
NC
NC
AC(W)
AC(L)
GND
POW MONI
NC
GND
ST7V
GND
P.CONT
PORT
GND
+7V
135V
GND
+15V
GND
-15V
AUDIO+
AUDIO-
FV
HV
G SHIELD CHASSIS
CRTCHASSIS
FASTON
+12V
RED DRIVE
BLUE DRIVE
GND
CUT OFF
GND
GRN DRIVE
9V
FRONT Y
FRONT C
GND(V3)
FRONT V
GND(V3)
FRONT L
GND(V3)
FRONT R
GND(V3)
FRONT S
LED G
LED R
STBY 5V
KEY1
SIRCS
+5V
GND(KEY)
135V
NC
9V
GND
VM
GND
GND(V3)
-5V
P.CONT
STBY 7V
5V
12V
NC
135V
RV WAVE
BV WAVE
CLK
MUTE
DATA
CEB
VP
HD
HP
PIN
ABL
-15V
+15V
V DEF
NC
V RET
GND
GND
GND
GND
GND
GND
GND
GND
POWER MONI
AUDIO+
AU GND
AUDIO-GND
GND
GND
GND
VAR OUT
HP L
HP R
MUTE
V OUT
E/W
V+OUT
H DRIVE
V-SYNC
HFBP
EHT
ABL
9V
33V
STBY 5V
SIRCS
SPKRR
STBY LED
KEY 1
VM OUT
MUTE
RIN
LIN
VIN
CIN
YIN
SPKRL
STBY
LUMI/KEY2
GND
GND
GND
GND
GND
GND
GND
5V
GND
GND
GND
GND
GND
GND
GND
H/P R
H/P L
GND
GND
S3/GND
NC/POW LED
NC
NC
NC
NC
5V
VP
MUTE
BV WAVE
RV WAVE
ABL
PIN
HP
HD
135V
+15V
-15V
-5V
HV.REG
NC
+12V
7V
PROT
P.CONT
STBY 7V
+15V
+135V
CEB
DATA
CLK
STDBY 7V
STDBY 7V12V
STBY 7V
P.CONT
HR OUT
HR RET
HG OUT
HG RET
HB OUT
HB RET
VR OUT
VR RET
VG OUT
VG RET
VB OUT
VB RET
R-H(+)
NC
NC
R-H(-)
NC
NC
NC
NC
G-H(+)
G-H(-)
B-H(+)
B-H(-)
H(+)
H(-)
NC
NC
NC
200V
NC
B/S
R/S
G2
DF
135V
NC
9V
VM
GND
GND
R G B 9V
IK
R-H(+)
NC
R-H(-)
HR.RET
NC
NC
VM.RET
NC
NC
VR.IN
VR.RET
HR.IN
VM.IN
V.OUT
V.IN
NC
NC
NC
NC
NC
G-H(+)
G-H(-)
V.IN
V.OUT
VM.RET
VM.OUT
G B 9V
IKG
IKB
NC
H(-)
H(+)
NC
NC
200V
R/S
NC
G B
IKG
IKB
NC
H(-)
H(+)
NC
NC
200V
R/S
NC
H(-)
H(+)
NC
E
NC
200V
R/S
NC
NCNC
H(-)
H(+)
NC
NC
200V
R/S
NC
H(-)
H(+)
NC
NC
200V
R/S
B/S
NC
NC
HG.IN
VG.IN
VG.RET
HG.RET
E
B
E
IKB
9V
E
B
IKB
9V
G2
G2
G2
GND
GND
GND
GND
GND
9V
GND
GND
GND
GND
GND
GNDD
GND
GND
L OUT(+)
GND(AU)(-)
R OUT(+)
GND(AU)(-)
GND
GND
GND
NC
DET(CEZ)
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
-15V
STBY +5V
KEY1
GND
SIRCS
G.LED
R.LED
GND
+5V
KEY LED, AC SW
D
( )
ZR
ZG
CR
CG
CB
NC
NC
NC
NC
NC
H( )
1
E
PROT1
PROT1
PROT1
CN150P
CVBS IN AV-3
AUDIO MUTE
STANDBY LED
LUMISPONDER
V- DRIVE
EAST/WEST DRIVE
V+ DRIVE
H DRIVE
V SYNC
H FLYBACK
ABL
9V
33V
STANDBY 5V
SIRCS
5V
AFC
S-VHS Y IN AV-3
S-VHS C IN AV-3
AUDIO L IN AV-3
AUDIO R IN AV-3
AUDIO R OUT HP
AUDIO L OUT HP
FRONT KEY 1
VERTICAL GND
VERTICAL GND
VIDEO GND
AUDIO GND
AUDIO GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
16:9
VM
EHT
DGC RELAY
PROT1
A.REGI
P.CONT
AUDIO L OUT SP
AUDIO R OUT SP
GND
GND
CVBS OUT
GND
C IN
GND
MODE
L IN
GND
R IN
GND
L OUT
GND
R OUT
CVBS/Y IN
UE
GND
GND
CVBS OUT
GND
C IN
GND
MODE
CVBS/Y IN
L IN
GND
R IN
GND
L OUT
GND
R OUT
GND(ANT)
GND
H2
E
+B OUT
+B IN
FASTON
FASTON
KEY2KEY2
GND
LUMILUMI
GND
GND
GND
GND
UPPER
LEFT
RIGHT
LOWER
(AE)
GND
GND
FR Y OUT
GND
FR C OUT
GND
GND
GND
GND
FR V OUT
FR L OUT
FR R OUT
FR S3 OUT
GND
KEY1
KEY2
STBY +5V
KEY1
KEY2
GND
GND
+5V
HP R IN
SP MUTE
HP L IN
HB.IN
VB.IN
VB.RET
HB.RET
HB.IN
VB.IN
VB.RET
HB.RET
GND
V.DEF
V.MID
V.RET
DY(H)
DY(V)
SUB DY
DY(B)
H(MID)
H+
H-
V.DEF
V(MID)
V.RET
H.IN
V.IN
V.RET
H.RET
12V
SCL
SDA
FS
PJE YS
PJE B
PJE G
PJE R
SPSW
PJE YM
50-60
N.C.
12V
FS
PJE YM
PJE YS
PJE B
PJE G
PJE R
SP SW
SCL
SDA
GND
50-60
N.C.
GND(Z)
GND(Z)
R1
R1
R1
GND
5V
SCL
SDA
FS
SCL N
SDA N
GND
GND
AC(L) IN
AC(N) IN
AC(L) IN
AC(N) IN
AC(L) OUT
AC(N) OUT
AC(L) OUT
AC(N) OUT
GND
GND
GND
GND
GND
GND
GND
HV DET
NC
GND
HV DET
NC
LOWER
GND
RIGHT
GND
LEFT
UPPER
GND
GND
PHOTO
SENSOR
PJRST
NC
AE(µCOM,OSD,YCJ,AUDIO PROCESSER)
(AV3)
(RED AMP)
(RED DY)
(GREEEN AMP)(VM/GREEEN DY)
(BLUE AMP)
(HV.H-DEFRECTION.DF)
(POWER SUPPLY)
(FRONT IN KEY)
AUDIO AMP,V-DEFRECTION, SENSOR AMP,SHADING AMP
R
B-SS510.<SM.>-KESSENZU-05
CN270321PSCART
A1B1A2B2A3B3A4B4A5B5A6B6A7B7A8B8A9B9A10
B10
A11
B11
A12
B12
A13
B13
A14
B14
A15
B15
A16
B16
A17
B17
A18
B18
A19
B19
A20
B20
A21
B21
CN201DUAL SCART
NC
NC
NC
NC
GREEN IN
MODE
GND
MODE
GND
NC
BLUE IN
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
CVBS/Y IN
CVBS OUT
CVBS IN
CVBS OUT
GND
GND
NC
GND
GND
NC
BLANKING
SVHS-C IN
RED IN
AUDIO L OUT
AUDIO R OUT
AUDIO R IN
AUDIO R OUT
AUDIO R IN
AUDIO L OUT
AUDIO L IN
AUDIO L IN
1 2 3 4 5
CN25PWHT
DISABLE
SDA
SCL
GND
AGC
FOR CHECK
Note: The components identified by shading and mark are critical for safet y. Replace only with pa rt numberspecified.
Page 21
– 50 –– 49 –– 48 –– 47 –
G BOARD : IC6004 IR3M02
G BOARD : IC6007 IR2112
Schematic diagram
G board /
REF. VOL.
B 0.8rQ6001 E GND
C 0B 0
rQ6002 E GNDC 13.8B
rQ6003 E 13.8C GNDB 5.1
rQ6005 E 3.0C GNDB 13.8
rQ6009 E 14.5C 14.5B 0.7
Q6010 E GNDC 0.1B 0
Q6011 E GNDC 7.0B 7.0
Q6012 E 7.0C 0B 134.8
Q6013 E 135.1C 0G 6.1
rQ6014 D 147.0S GNDG 150.0
rQ6015 D 292.0S 147.0
G BOARD TRANSISTORVOLTAGE LIST
AII voltages are in V.r : The figurs in the parentheses are the voltage difference from primary side ground.
rIC6001 1 GND2 GND3 GND4 5.95 286.08 GND
rIC6004 1 3.92 4.84 GND5 1.76 3.97 GND8 14.19 5.810 6.411 14.412 14.513 5.314 5.315 5.316 GND
IC6005 1 7.02 5.8r3 13.5r4 13.8
IC6006 1 14.02 13.0r3 GNDr4 3.0
rIC6007 1 6.22 GND3 14.55 147.06 159.07 150.09 14.510 6.411 GND12 5.813 GND
IC6008 1 134.52 12.53 GND
REF. NO. VOL.
•All voltage are in V.•Pin numbers which are not
described are not used.
G BOARDIC VOLTAGE LIST
r : The figurs in the parentheses are the voltage difference from primary side ground.
12V
AUDIO+
15V
12V
7V
7V
135V
ST7V
1
2
1
1
12
34
56
78 9
1011
1213
1415
16
12
34
56
789
1011
1213
14
123
12
345
67
8
1
2
3
4
5
6
S
S
1
2
4
3
1
2
4
3
1
2
3
4
1234
1
2
3
4
6
12
10
11
15
13
14
18
16
17
8
7
9
1
5
6
7
8
9
1
2
3
4
1
2
3
4
5
1
2
3
12345
123 4
C6041
C6049
C6048
C6037
C6019
R6053
C6046
C6045
C6042C6036
C6044 C6055
C6032
R6047
C6021
R6057
C6030
CN6013
CN6012
CN6011
CN6006
CN6005
CN6007
C6051
C6020
C6033
C6053
C6052
R6085
R6075
R6051
R6002
R6022
R6065
FB6009
L6003
L6004
FB6011
CN6008
L6005
C6040
C6012
C6039
C6004
L6011
Q6013C6050
D6048
R6050
R6048R6046
R6052
R6014
R6019
R6063
R6062R6070
R6067
R6068
R6034
R6082
CN6002
CN6001
C6047
Q6015
D6047
D6044D6042
R6064
D6045
D6046
Q6014D6043
FB6010
Q6001
D6018
Q6005
Q6003
R6018
D6007
D6014R6027
D6051
Q6009
IC6005
Q6012
Q6010
D6012
D6050
D6035
D6033
L6009
D6037
D6049
L6008C6035
C6034
D6036
R6066
IC6006
IC6008
C6060C6059
C6061
C6003
C6038L6006
C6006
R6000
Q6002
CN6009
D6013
IC6001
R6060
R6084
R6080
R6079
R6083
D6017
D6025 L6001
F6001
C6062
C6031
D6032
R6045
R6049
R6061
R6069
R6072
R6071
C6026
L6002
R6081
D6038
T6004
C6001
C6007
JW6066 JW6065
R6008
R6009
R6010
C6065
C6064
R6054
R6086
R6056
R6055
R6059
R6058
R6001
R6073
Q6011
PS6001
PS6002
T6005
C6063
R6076
R6077
R6078
D6004
D6002 C6058
PS6003
L6010
T6002
C6002
D6003
JW6059
JW6058
C6018
R6032
R6024 R6026
R6013
JW6005
JW6006
IC6007
IC6004
C6011
D6005
D6008
D6009
220025V
10025V
0.22250V:AC
330p
4725V
10025V
2.2
0.039800V
10
0.001
100p500V
100p500V
220016V
220025V
470025V
1000
1000
1
10025V
220160V
10025V
10025V
330p
1
0.1:MPS
0.47160V
4706.3V
680p1kV
680p1kV
220160V
470p B 470p B
470p B
1P:FASTON
1P:FASTON
2P
4B2P:VH
5B3P:VH
6PWHT
:S-MICRO
1P:FASTON
5P:MINI
4P:MINI
3P:MINI
ERC04-06SRECT
MTZJ-7.5CBIAS
D1NL20URECT
D1NL20U
D2S4M+7V RECT
D2S4M+7V RECT
S2L40F RECT
UF4005PKG23PROTECT
MTZJ-20CPROTECT
UF4005PKG23PROTECT
MTZJ-20CPROTECT
MTZJ-20CPROTECT
MTZJ-20CPROTECT
S2L40F RECT
1.1UH
JW(5)
JW(5)
ON3171-RVCC SW
ON3171-RVCC OUT
SE135NVCC CONTROLER
10µH:LHL08
10µH:LHL08
10µH :LHL08
47µH:LHL08
4.7µH:LHL08 10µH
:LHL08
2SC2412KSW
2SC2412KSOFT START RESET
2SA1037KSOFT START RESET
2SA1037KSOFT START
2SB734-T-2VCC SW
2SA1208+B-COCP
IRFI744G-LFSW
IRFI744G-LFSW
1M :RC
47k:CHIP
47k:CHIP
47k:CHIP
4.7k:CHIP
22k:CHIP
9.1k:RN CHIP
1k:CHIP
JW(5)
5A
470pB
10
1.8k:RN-CP
220k:RN
220k:RN
200k:RN
10µH:LHL08
RBA-406B
10025V
4.7:RF
470k:CHIP
120k:CHIP
0.0047250VF
0.0047250VF
10k:CHIP
1k :CHIP
PIT
470pB
4.7k:CHIP
0.0022250V:E
0.0022250V:E
10MM10MM
3.15A
3.15A
2SC2412KPROTECT
2SC2412KLATCH
2SA1037KLATCH
1k:CHIP
1k:CHIP
4.7k:CHIP
10k:CHIP
10k:CHIP
10k:CHIP
4.7k:CHIP
470:CHIP
10k:CHIP
TOP209PWMSW
SRT
D4SBS4 470p B
5A
4.7µH:LHL08
D10SC6M
470:FPRD
1k:FPRD
22:FPRD
22:FPRD
4.7k:FPRD
4.7k:FPRD
1k:FPRD
# :FPRD
# :FPRD
# :FPRD
0.47 :FPRD
0.47 :FPRD
0.47:FPRD
0.47:FPRD
0.47 :FPRD
0.47 :FPRD
1SS133PROTECT
1SS133TSW
1SS133SOFT START
1SS133PROT
1SS133SOFT START
MTZJ-13B+B-OVP
1SS133PROTECT
1SS133FEED BACK
10µH :LHL08
8.2M1W
270k
270k
22
47k
1k
100k
0.562W:RS
22k:RN
2.21W:RS
LFT
0.22250V:AC
D4SB60LRECT
JW(5)
JW(5)
470450V
0.12W:RF
110W:RB
110W:RB
1.210W:RB JW(5)
JW(5)
IR2112CONV DRIVE
KA7500BCONV DRIVECONTROL
2.2450V
MTZJ-30BSW
ST02D-200TACLAMP
AC(L)
AC(W)
G
AUDIO +
AUDIO -
GND
GND
+135V
+15V
-15V
GND
GND
ST7V
P.CONT
+7V
D
S
C
S
NC
AU GND
GND
+12V
NC
GND(Z)
GND(Z)
TO E BOARD
NC
NC
NC
NC
AC(L)IN
AC(L)OUT
POW MONI
C
HD
VB
VS
NC
VE
COM
L0
NC
VDD
HIN
SD
LIN
VSS
NC
DTC
RT
GND
C1
DPC
VCC
C2
E2
E1
E.AMP1-
FEEDBACK
E.AMP2-
REF OUT
E.AMP1+E.AMP2+
GND
COLLECTOR
VOUTSENSE
PROT
GND(ANT)
AC(N)IN
AC(N)OUT
TO H1 BOARDCN3003 CN3004
TO H1 BOARD
AC IN
220-240V
50/60Hz
TO AE BOARD
CN101
SHIELD CHASSIS
TO G BOARD
(POWER SUPPLY)
TO E BOARDCN806
TO D BOARDCN1605
CN808
CN807TO E BOARD
B-SS510.<AEP>-G..-05
1
A
B
C
D
E
F
G
H
I
K
L
M
N
J
2 12 1311109876543 14 18171615
15.0MM
Page 22
– 55 – – 56 – – 57 – – 58 – – 59 –
IC102 1 2.42 1.9(2.1)3 GND4 2.95 3.06 4.77 3.4
IC103 1 GND2 GND3 GND4 GND5 GND6 GND7 GND8 GND9 GND
10 GND11 2.312 GND13 4.514 2.015 2.016 2.017 4.518 4.5619 GND20 021 1.122 0.623 GND24 GND25 1.226 4.527 2.328 4.529 4.530 GND31 0.6(0.8)32 2.633 1.534 1.535 GND36 0.937 4.538 GND39 0.840 2.641 1.542 1.543 GND52 GND53 4.556 4.567 5.0<4.5>(4.6)68 4.569 0.570 0.571 GND72 GND73 5.074 5.0(4.5)75 GND76 GND77 GND78 GND79 GND80 GND
IC201 1 4.2
REF. NO. VOL.
AE(1/2) BOARD IC VOLTAGE LIST
2 GND3 4.34 0.25 4.26 0.27 4.38 GND9 4.3
10 GND11 4.312 GND13 4.314 GND15 4.316 GND18 GND19 GND20 4.221 4.522 4.623 3.224 GND25 4.326 8.527 4.328 GND29 4.330 GND31 4.332 4.3
IC202 4 2.55 2.6<4.4>(2.4)6 2.47 2.48 4.59 4.7(4.4)
10 GND11 4.812 GND13 4.715 GND16 GND19 GND20 2.321 2.322 GND23 0.5<0.9>24 1.625 1.626 4.827 GND28 3.929 2.730 3.931 3.932 GND33 3.934 3.935 GND36 3.837 3.938 GND39 3.940 3.941 3.942 3.843 GND44 7.2
REF. NO. VOL.
•All voltage are in V.•Pin numbers which are not
described are not used.
45 8.246 7.147 4.6<3.9>(3.9)48 4.5<3.9>(3.9)49 GND50 4.6<3.9>(3.9)51 4.5<3.9>(3.9)52 GND53 4.7<3.9>(3.9)54 4.7<3.9>(3.9)55 GND56 057 058 GND59 0.260 0.261 4.766 GND67 4.8
IC203 1 4.32 GND3 4.4<3.8>(3.8)4 GND5 4.5<4.5>(3.8)6 GND7 GND8 GND9 GND
10 8.911 GND12 4.313 4.4<3.9>(3.8)14 4.4<3.8>(3.8)15 GND16 8.9
IC204 1 4.32 2.6(2.8)3 2.6(2.8)4 2.6(2.8)5 8.96 8.97 GND8 2.39 2.3
10 2.311 4.312 0.413 0.414 9.0
IC205 1 4.72 GND3 4.74 GND
IC206 1 02 0<0.2>(0.2)4 5.06 0.57 0.58 GND9 8.8
10 8.811 GND12 GND13 GND14 4.4<4.1>15 4.7<4.2>16 8.9
REF. NO. VOL. REF. VOL.
B 4.8Q18 E 4.9
C 0B 0.6
Q101 E GNDC 4.6B 4.5
Q102 E 4.7C 4.6B 2.2
Q103 E 2.8C GNDB 2.9
Q104 E 2.3C 4.5B 1.1
Q105 E 1.2C 4.6B 0.5
Q106 E 1.1C GNDB 0.6(0.8)
Q107 E 1.2(1.4)C GNDB 1.5
Q108 E 2.2C GNDB 0.7
Q109 E 1.4C GNDB 2.3
Q110 E 1.7C 4.1B 4.1
Q111 E 4.7C 2.6B 2.6
Q112 E 1.9C 4.7B 1.7
Q113 E 2.3C GNDB 1.8
Q114 E 2.3C GNDB 2.0
Q115 E 1.4C 4.0B 4.0
Q116 E 4.6C 2.1B 5.2
Q120 E 4.5C 9.0B 2.2
Q121 E 1.6C 8.3B 4.1
Q122 E 3.5C 9.0
AE(1/2) BOARD TRANSISTORVOLTAGE LIST
AII voltages are in V.
B 5.4Q124 E 4.7
C 9.0B 1.7
Q125 E 2.3C GNDB 8.3
Q130 E 9.0C 5.4B 4.2
Q201 E 3.6C 8.6B 4.3
Q202 E 3.7C 7.3B 4.5
Q203 E 3.8C 8.9B 4.4
Q204 E 3.8C 8.9B 0
Q205 E GNDC 8.9B 3.7
Q206 E 4.3C GNDB 3.7
Q207 E 4.3C GNDB 8.2
Q208 E 9.0C 9.0B 0.7
Q209 E GNDC 0B 0
Q210 E GNDC 0.7B 0.4
Q211 E GNDC 8.9B 2.6
Q212 E 3.3C GNDB 2.3
Q213 E 2.9C GNDB 0
Q214 E GNDC 2.6B 4.9<4.7>
Q215 E 4.7<4.2>C 4.2<4.4>B 4.9<4.7>
Q216 E 4.4<4.1>C 4.2<4.6>B 4.2OK
Q217 E 3.7C 7.2
REF. VOL.
A B C D
E F G H
• AE(1/2) BOARD WAVEFORMS
• WAVEFORMS AE(1/2) BOARD
CIRCUITWAVEFORMREFERENCE
PAL SECAM NTSC
1 A 1.1Vp-p(H) E 1.2Vp-p(H) F 1.5Vp-p(H)2 A 0.9Vp-p(H) E 1.0Vp-p(H) F 0.9Vp-p(H)3 A 1.0Vp-p(H) E 1.2Vp-p(H) F 1.5Vp-p(H)4 A 1.7Vp-p(H) E 1.8Vp-p(H) F 2.2Vp-p(H)5 B 1.3Vp-p(H) B 1.3Vp-p(H) G 1.6Vp-p(H)6 C 0.5Vp-p(H) C 0.4Vp-p(H) H 1.5Vp-p(H)7 B 1.1Vp-p(H) B 1.1Vp-p(H) G 1.2Vp-p(H)8 C 0.5Vp-p(H) C 0.4Vp-p(H) H 1.2Vp-p(H)9 A 1.1Vp-p(H) E 1.2Vp-p(H) F 1.4Vp-p(H)
10 D 1.6Vp-p(18.4MHz)
AE(1/2) BOARD : IC206 CXA1315M
AE(1/2) BOARD : IC102 NJM2240M(TE2)
AE(1/2) BOARD : IC203 MC14052BDR2
Schematic diagram
AE(2/2) board /
Schematic diagram
? AE(1/2) board
33V 5V
5V
5V
9V
2
1
3
5V
5V
4
5 6
5V
9V
7
8
5V
AUDIO L/R
AUDIO L/R
AUDIO L/R
AUDIO L/R
AUDIO L
AUDIO R
AUDIO RAUDIO L
VIDEO
AUDIO L/R
AUDIO MONO
VIDEO
AUDIO L/R
VIDEO
VIDEO
VIDEO
VIDEO
AUDIO MONO
AUDIO L/R
AUDIO L/R
AUDIO L/R
AUDIO L/R
VIDEO
VIDEO
AUDIO L/R
AUDIO L/R
VIDEO
Y
C
VIDEO
VIDEO
Y Y
C
C
C
Y
C
C
CY
Y
Y
C
C
Y
Y
Y
AUDIO R
AUDIO L
AUDIO MONO
1011121314151617181920212223242526
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60
61
62
63
64
65
66
67
68
1
2
3
4
5
6
7
8
9
A1
B1
A2
B2
A3
B3
A4
B4
A5
B5
A6
B6
A7
B7
A8
B8
A9
B9
A10
B10
A11
B11
A12
B12
A13
B13
A14
B14
A15
B15
A16
B16
A17
B17
A18
B18
A19
B19
A20
B20
A21
B21
EMI
12 3
4
1 2 3 4
5678
12
34
56
7 89
1011
1213
14
12
34
56
78 9
1011
1213
1415
16
1 2 3
46
1 2 3
46
1 2 3
46
1
12
34
56
78
910
1112
1314
1516
1718
1920
2122
2324
25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
4142
4344
4546
4748
4950
5152
5354
5556
5758
5960
6162
6364
65666768697071727374757677787980
1 2 3 4 5 6 7 8
9
10
11
12
13
14
15
16
1718192021222324
25
26
27
28
29
30
31
32
1 2 3 4 5
EMI
EMI
EMI
AGC
AS
SCL
SDA
+33V
GND
+5V
AM
QSS
VIDEO
NC
R101
CN201
C122
CN2
C103
R282
R285
C228
C218
C226
C216
C267
D251C265
C102
R128
L102
FL203
C110
CF120
C209
R107
C113
L111
R123
C101
C124
C202
C217
C219
C227
C229
C230
C263
C268
R103 R104 R106
R110
R121
R124
R125
R126
R209
R214
R216
R218
R220R222
R223R225
R232
R233
R235
R237R238
R240R241R281
R284
C121 C123
R204R205
C204
R200
C203
C205
C264
C282 C281
FL201
FL202
C252C251X201
R265
C258
D220
R156 R158
R159
R160
R161 R162
R169 R170
R173
R176
R177
R178
R186 R187 R188
C125 C127
C128 C129
C130 C131
C132C134 C135
C136
C139
C144
C145
C146
C147
C149 C150
C151
C153
C154
C155
FB101
FB102
Q101
Q104
Q105
R291
C244
FB104
Q211
R296
R295
R298
R297
R184
R251
R252
R254
R253
R256
R255
C279
C280
R102
IC204
IC206
C201
R201
R202
R206
R211
R226
R229
R243
R244
R191
R257
R299
R171
FB103
D218
D216
D221
D217
D223 D226D224 D225
D201
D208
D222
D202
D209
D210
D203
D211
D204
D212
D206
D214
D213
D205
D207
R221
R239
R224
R242
C257C256
L120
C152
R168
JR201
D101 FL101
R130 R136R129
R132
R120 R127 R131
R115
R118R116
C207
C266
R172
C242
C243
R292
R203
R108
C212
C214
C222
C224
C276
C221
R113 R134
R249
R212
R213
R227
R228
R230
R270 R271 R272 R273
R111
R112 R114
R122
R133
R138
R208
R105
R217
R219
R234
R236
C210
L121
Q102
Q107
C254
C104
C120
C253
C115
C269 C270
C112
C271
C272
C213
C215
C223
C225
C261
C262
L122
C126
C148
C133
C138
R182 R183
R175
R179
R180
R174
R181
R157
R207
Q125
R167
C137
R166
R165
R164 R198
R199
Q106
IC103
FL102
FL103
D215
TP1
TP2
R163
R248
R117
C274C273
IC102
C260
R266 R267
R293 C245
D228
R210
R258
R259
C206
D227
D231
R294
JR1
Q108
Q109
R185 R250
R189 R190
FL104
TU101
R264 R268 R269 R274
C275
C277
C278
CN101
R283
R286
Q18
Q214
C211
C220
C208
Q110 Q111 Q112
R119
Q113 Q114 Q120 Q122 Q121 Q130 Q124
Q115 Q116
Q103
Q215 Q216
Q204
Q203
IC202
IC205
Q217
Q202
Q201
IC201
R137
R135
C255
Q212
Q213
C259
R280
0.125V
F:CHIP
22016V
22
100pCH:CHIP
4716V
0.001CH:CHIP
C31633p
CH:CHIP
4716V
330pCH:CHIP
100pCH:CHIP
68pCH:CHIP
680pCH:CHIP
68pCH:CHIP
0.125V
F:CHIP
0.01B:CHIP
10016V
0.01B:CHIP
0.01B:CHIP
6pCH:CHIP
0.01B:CHIP
4716V
0.01B:CHIP
4.7
0.01B:CHIP
0.01B:CHIP
0.01B:CHIP
4716V
10
0.01B:CHIP
0.01B:CHIP
0.01B:CHIP
0.01B:CHIP
0.01B:CHIP
10016V
0.01B:CHIP
0.01B:CHIP
0.01B:CHIP
0.125V
B:CHIP
0.125V
B:CHIP
0.01B:CHIP
0.01B:CHIP
0.125V
B:CHIP
33016V
0.125V
F:CHIP
22
0.001CH:CHIP
10
10
0:CHIP
116V
F:CHIP
470pCH:CHIP
116V
F:CHIP
470pCH:CHIP
4716V
0.01B:CHIP
4716V
0.01B:CHIP
2.216V
F:CHIP
116V
F:CHIP
470pCH:CHIP
116V
F:CHIP
470pCH:CHIP
4716V
0.01B:CHIP
4716V
0.01B:CHIP
0:CHIP
0.01B:CHIP
47
0.01B:CHIP
0.01:CHIP
4pCH:CHIP
4pCH:CHIP
100pCH:CHIP
47pCH:CHIP22
10
0.125V
F:CHIP
470pCH:CHIP
470pCH:CHIP
0.125V
F:CHIP
3.3
1010
220.125V
F:CHIP
390pCH:CHIP
390pCH:CHIP
0.001CH:CHIP
0.001CH:CHIP
0.001CH:CHIP
0.001CH:CHIP
116V
F:CHIP
22
0.1 25V F:CHIP
220.125V
F:CHIP
6.5MHz
5PWHT
DUAL SCART
MA8330
UDZ-9.1B
UDZ-9.1B
UDZ-9.1B
UDZ-9.1B
UDZ-9.1B
UDZ-9.1B
UDZ-9.1B
UDZ-9.1B
UDZ-9.1B
UDZ-9.1B
UDZ-9.1B
UDZ-9.1B
UDZ-9.1B
UDZ-9.1B
UDZ-9.1B
UDZ-5.6B
UDZ-5.6B
UDZ-5.6B
1SS355
1SS355
UDZ-9.1B
UDZ-9.1B UDZ-9.1B UDZ-9.1B UDZ-9.1B
DTZ-6.8B
DTZ-6.8B
UDZ-5.6B
BAS216
HM102:CHIP
HM102:CHIP
HM102:CHIP
HM102:CHIP
FZ103N
FZ103N
FZ103N
FZ103N
NJM2240M(TE2)4FSC-PLL
CXD2044Q-TL
MC14066BFYC-SW
CXA1315MBUS-SW
0:CHIP
0:CHIP
5.6µH :EL0606
0:CHIP
8.2µH:EL0606
1µH:EL0606
8.2µH:EL0606
2SC2412KINV
2SA1037AK4FSC.ADJ
2SC2412KBUFF
2SC2412KCLAMP
2SA1037AKCLAMP
2SA1037AKBUFF
2SA1037AKBUFF
2SA1037AKBUFF 2SA1037AK
BUFF
DTC144EKAINV
3.3k:CHIP
100:CHIP
100:CHIP
10k:CHIP
470k:CHIP
10k:CHIP
0:CHIP #
:CHIP
10k:CHIP
150:CHIP
150:CHIP
10:CHIP
150:CHIP
330:CHIP
4.7k:CHIP
2.2k:CHIP
8.2k:CHIP
6.8k:CHIP
10k:CHIP
470:CHIP
180:CHIP
1k:CHIP
22k:CHIP
100:CHIP
22k:CHIP
270:CHIP
330:CHIP
3.3k:CHIP
10k:CHIP
100:CHIP
470:CHIP
10:CHIP
220:CHIP
470:CHIP
47k:CHIP
47k:CHIP
10k:CHIP
1k:CHIP
3.3k:CHIP
220:CHIP
330k:CHIP
220:CHIP
47k:CHIP
47k:CHIP
220:CHIP
560:CHIP
5.6k:CHIP
1k:CHIP
100:CHIP
100k:CHIP
4.7k:CHIP
100:CHIP
4.3k:RN-CP
1.2k:RN-CP
0:CHIP
1k:CHIP
0:CHIP
1.8k:RN-CP
2.2k:RN-CP
4.7k:RN-CP
220:RN-CP
220:RN-CP
2.2k:CHIP
560:CHIP
5.6k:CHIP
1k:CHIP
2.2k:CHIP
560:CHIP
5.6k:CHIP
2.2k:CHIP
220:CHIP
220:CHIP
1k:CHIP
220:CHIP
220:CHIP
100:CHIP
100:CHIP
39k:CHIP
220:CHIP
47k:CHIP
470:CHIP
1k:CHIP
47:CHIP
220:CHIP
75:CHIP
75:CHIP
100:CHIP
100:CHIP
470k:CHIP
100:CHIP
470k:CHIP
0:CHIP
390:CHIP
47k:CHIP
0:CHIP
390:CHIP
47k:CHIP
220:CHIP
75:CHIP
75:CHIP
220:CHIP
75:CHIP
100:CHIP
100:CHIP
470k:CHIP
100:CHIP
470k:CHIP
0:CHIP
47k:CHIP
390:CHIP
0:CHIP
47k:CHIP
390:CHIP
220:CHIP
220:CHIP
100 :CHIP
10:CHIP
220:CHIP
100 :CHIP
100 :CHIP
100 :CHIP
100 :CHIP
100 :CHIP
100 :CHIP
10k :CHIP
47:CHIP
470:CHIP
4.7k:CHIP
22k:CHIP
4.7k:CHIP
75:CHIP
75:CHIP
75:CHIP
75:CHIP
47k:CHIP
68k:CHIP
47k:CHIP
68k:CHIP
JR2080
:CHIP
JR2090
:CHIP
2.2k:CHIP
2.2k:CHIP
47k:CHIP
100k:CHIP
1k :CHIP
1k :CHIP
220 :CHIP
220 :CHIP
10k :CHIP
#
#
18.432
0.125V
B:CHIP
0.125V
F:CHIP
TVF01-FR
47k:CHIP
47k:CHIP
47k:CHIP
47k:CHIP
116V
F:CHIP
1P:FASTON
2.216V
F:CHIP
2.216V
F:CHIP
4.7k:CHIP
4.7k:CHIP
DTA144EKAINV
DTC144EKAINV
22
22
22
2SC2412KV-BUFF
2SA1037AKV-BUFF
2SC2412KV-BUFF
220:CHIP
2SA1037AKINV
2SA1037AKINV
2SC2412KBUFF
2SC2412KBUFF
2SC2142KBUFF
2SA1037AKBUFF
2SC2142KBUFF
2SC2412KBUFF
2SA1037AKBUFF
2SA1037AKBUFF
2SC2412KSW
2SC2412KSW
2SC2412KBUFF
2SC2412KBUFF
MSP3410D-PS-B4AUDIO PROCESSOR
PST593C-MMP-4PRESET
2SC2412KBUFF
2SC2412KBUFF
2SC2412KBUFF
CXA2040AQ-T4VIDEO SW
1k:CHIP
680:CHIP
100pCH:CHIP
2SA1037AKY BUFF
2SA1037AKC BUFF
0.4725V
F:CHIP
1k:CHIP
D.5V
A.5V
U-PC DISABLE
AGC MONI
SDA
SCL
C AV-3
AUDIO L AV-3
AUDIO R AV-3
SP L
SP R
HP R
HP L
R AV-1
G AV-1
B AV-1
FB AV-1
5V
5V
9V
9V
33V 5V
2
2
2
2
2
22
22
2
2
Y AV-3
CVBS AV-3
2
9V
+9V
+9V
5V +9V
9V
2
2
SPSW
SDA
SCL
C
Y
9V
FSC
9V
9V
CVBS
DISABLE PJE
A.REGI
CVBS OUT
R OUT
L OUT
MODE 3
5V
R3
L3
C2
S1
S2
V1V 2
SDA
SCL
C2
V1
V2
V 2
S1
S2
L 1
L 2
L2
R1
R2
R 1
R 2
MONI
SDA
SCL
V2
R2
L2
R1
L1
L 1
R 1
L1
Y2
Y2
Y3
C3
V3
SCL
SDA
SDA
DIS
MONI
V3
Y3
C3
L3
R3
L 2
PAL/NT
SVHS-Y
SVHS-C
SVHS-C
SCL
SVHS-Y
PAL/NT
R 2
SCL
SDA
DIS
FS
FS
FSC
LPF
E 4FSC
R
5V C
V18
V17
V16
V15
V14
V13
V12
V11
INSL
OCLK
VSS1
VDD1
CLKO
MCK
ADCK
CLP1
VSS4
ICP
CRV
RB
GR
ADCO
XCPON
CVG
ACO
XACO
CVDD
VB
YVSS
YIRF
YVRF
YVG
AYO
XAYO
YVDD
VDD4
RT
ADDVD
ADIN
ADVS
C3
C4
C5
C6
C7
XYOE
CVSS
CIRF
CVRF
C2
C8
TEST
TEST
Y1
Y2
Y3
Y4
Y5
Y6
Y7
Y8
XCOE
APCN
RAT1
NTPL
VSS3
VDD3
INIT
TMD1
TOM3
TOM1
BPF
PMN
DIR
YOT
TEST
TEST
C1
VSS
VSS
VCC
SCL
SDA
SA2
SA1
SA0
SPSW
GND
KILL
PAL/NT
YC/COMB
NC
NC
NC
NC
GREEN IN
MODE
GND
MODE
GND
NC
BLUE IN
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
CVBS/Y IN
CVBS OUT
CVBS IN
CVBS OUT
GND
GND
NC
GND
GND
NC
BLANKING
SVHS-C IN
RED IN
AUDIO L OUT
AUDIO R OUT
AUDIO R IN
AUDIO R OUT
AUDIO R IN
AUDIO L OUT
AUDIO L IN
AUDIO L IN
RIN AV-3
LIN AV-3
VREF(A)
ANA-IN2
ANA-IN
A 5V
A GND
A GND
A GND
A GND
A GND (B)
A GND (C)
A GND (C)
RIN AV-2
LIN AV-2
RIN AV-1
LIN AV-1
STDBY
ADR SEL
D-CTR0
D-CTR1
NC
AUDIO-CLK
XTAL
XTAL
TEST
D GND
D GND
D GND
S-ID
NC
S-DA IN
I2S-DA IN
I2S-DA OUT
I2S-WS
I2S-CLK
S-CL
S-DA OUT
FRAME
N-CL
N-DA
D GND
D 5V
SCL
D GND
SDA
VREF1
AV-CAP
AV-CAP
TEST
LOUT SP
ROUT SP
VREF2
8V
A GND
ROUT AV-2
LOUT AV-1
ROUT AV-1
HP-CAP
LOUT AV-2
LOUT HP
MONO IN(AM)
ANA-IN1
VREF
A GND
SP-CAP
ROUT HP RESET
CVBS OUT
C IN AV-3
SYNC IN TV
CVBS IN AV-1
C IN AV-2
SYNC
ADR
SCL
SDA
GND
GND
9V
TV IN
GND
CVBS IN AV-2
GND
BIAS
GND
MODE
MODE
Y IN AV-3
GND
GND
GND
GND
GND
CVBS OUT
SVHS-Y OUT
CVBS OUT AV-2
SVHS-C OUT
CVBS IN AV-3
Y IN AV-2
DIGITAL COMB FILTER
VDD2
VSS2
DISABLE
SDA
SCL
GND
AGC
CPU
AGC
VIDEO LPF
Y LPF C BPF
GND
MODE-S
MODE-O
A.REGI
FOR CHECK
AEVIDEO SW,AUDIO SW,TUNER,AUDIO PROCESSOR,DIGITAL COMB FILTER
(1/2)
B-SS510.<AEP>-AE.-P1-05
C2830.01B:CHIP
9
10
1
A
B
C
D
E
F
G
H
I
K
L
M
N
O
P
J
2 12 1311109876543 14 2221201918171615
Page 23
– 64 –– 63 –– 62 –– 61 –– 60 –
A B C D E F
G H I J K L
M N
• AE(2/2) BOARD WAVEFORMS• WAVEFORMS AE(2/2) BOARD
CIRCUITWAVEFORMREFERENCE
PAL SECAM NTSC
1 A 1.0Vp-p(H) I 1.2Vp-p(H) J 1.6Vp-p(H)2 C 0.6Vp-p(H) C 1.0Vp-p(H) C 0.4Vp-p(H)3 B 0.6Vp-p(H) B 1.5Vp-p(H) B 0.4Vp-p(H)4 B 1.3Vp-p(H) B 1.1Vp-p(H) B 1.0Vp-p(H)5 C 1.1Vp-p(H) C 1.5Vp-p(H) C 0.6Vp-p(H)67
A 1.0Vp-p(H) I 1.2Vp-p(H) J 1.6Vp-p(H)
8D 1.8Vp-p(H) D 2.2Vp-p(H) K 2.2Vp-p(H)
9E 3.6Vp-p(H) E 3.9Vp-p(H) L 3.9Vp-p(H)
10F 3.6Vp-p(H) F 3.8Vp-p(H) M 3.9Vp-p(H)
11G 3.4Vp-p(H) G 3.7Vp-p(H) N 3.9Vp-p(H)
12
H 3.4Vp-p(11.5MHz)
H 1.7Vp-p(20.48MHz)
IC1 2 03 5.04 5.05 5.06 07 0.88 0.19 0.110 011 1.812 GND13 5.014 2.415 2.316 4.6(5.0)17 1.718 019 3.020 021 2.5(2.9)22 1.023 3.5(3.2)24 3.225 2.2(1.8)26 2.427 2.628 3.529 2.730 2.731 2.632 2.333 2.734 2.635 2.636 3.037 2.538 2.839 2.240 2.841 0.9(2.1)42 5.0(3.0)43 2.5(2.1)44 4.2(1.7)50 GND51 5.052 053 054 1.355 0.856 0(4.5)57 0(4.4)59 0.6(1.3)60 5.0(2.3)61 062 3.963 4.664 0.8(0.1)65 5.066 067 3.9(2.3)68 GND69 070 071 072 5.073 4.974 0(4.7)75 5.0(4.6)76 5.0(4.7)77 5.0(3.0)78 079 0.880 5.0
IC2 1 GND2 GND3 GND
REF. NO. VOL.
AE(2/2) BOARDIC VOLTAGE LIST
4 GND5 4.4<4.6>6 4.2<4.4>7 4.98 5.0
IC3 1 5.02 *
3 *
4 *
5 1.96 *
7 2.88 2.59 2.2
10 2.511 2.512 2.513 2.114 2.015 2.116 GND17 1.9<1.7>(1.9)18 2.819 2.920 2.721 3.022 GND23 *
24 GND25 *
26 *
27 *
28 *
29 0.930 031 5.032 5.0
IC4 1 5.02 GND3 5.04 GND
IC301 1 1.6<4.9>(1.6)2 GND3 5.7<3.0>(5.7)4 5.7<3.0>(5.7)5 3.76 5.07 5.58 5.59 GND
10 0.711 0.112 5.513 5.514 5.515 016 017 5.518 5.519 5.520 8.921 4.422 1.8<2.0>(1.8)23 4.424 1.7<1.9>(1.7)25 4.526 1.6<1.9>(1.8)27 4.9(4.4)28 4.4<28>(3.5)29 8.830 0.631 3.032 3.033 4.134 4.035 4.6
REF. NO. VOL.
36 8.937 3.238 3.439 4.740 4.241 2.442 GND43 1.844 8.945 2.546 4.047 3.248 4.449 6.450 4.551 3.9(4.5)52 4.2(3.9)53 4.0(4.2)54 5.055 4.057 4.259 8.960 5.5<4.7>(5.6)61 2.4(7.4)62 7.4(5.9)63 GND64 5.3
IC302 1 4.93 GND4 GND5 0.68 GND9 4.9
10 GND11 3.112 3.014 1.416 1.4
IC303 1 1.6<4.9>(1.2)5 8.16 GND9 3.5(3.2)
10 4.311 5.7<3.0>(5.7)12 5.7<3.0>(5.7)19 0.720 3.6
IC1001 4 0.95 1.36 1.67 1.89 GND
10 0.9(1.1)11 4.812 4.813 GND16 4.717 0.121 4.823 2.925 4.744 GND49 GND55 GND56 058 GND59 GND60 GND61 062 063 064 066 4.3<4.8>(4.7)67 4.9(4.7)68 3.5<3.0>(3.0)
REF. NO. VOL.
•All voltage are in V.* :Can not mesured.
•Pin numbers which are notdescribed are not used.
REF. VOL.
B 3.6Q1 E 3.0
C 8.2B 0.4
Q4 E 0C 5.0B 0.2
Q15 E 0.8C GNDB 0.7
Q17 E 1.4C GNDB 0.7
Q20 E 0.2C 4.9B 0.7
Q21 E 0.2C 4.7B 0.7
Q22 E 0.2C 4.8B 0
Q23 E 0.7C GNDB 0
Q24 E 0.7C GNDB 0
Q25 E 0.7C GNDB 0
Q300 E GNDC 0B 3.7
Q301 E 3.0C 7.5
AE(2/2) BOARD TRANSISTORVOLTAGE LIST
AII voltages are in V.
B 3.6Q302 E 3.0
C 5.7B 5.7
Q303 E 5.1C 8.9B 0
Q304 E 0C 5.0B 0
Q305 E 0C 5.0B 0
Q306 E GNDC 0.2B 4.2
Q307 E GNDC 0B 0
Q308 E GNDC 3.4B 0(4.9)
Q309 E GNDC 3.6(0)B 4.4(4.7)
Q330 E 5.1(5.3)C GNDB 6.4
Q331 E 5.7C 8.9B 4.6
Q1001 E GNDC 0.1B 8.3
Q1002 E 9.0C 5.3
REF. VOL.
AE(2/2) BOARD : IC302 TDA4665T
5V
STBY5V
23
1
5V
4 5
8 9 10
9V
9V
STBY5V
STBY5V
STBY5V
5V
6 7
12
9V
C
Y
VIDEO
Y
Y
Y
R-Y B-Y
VIDEO
R
G
B
B-Y R-Y
B-YR-Y
R-Y
B-Y
Y
Y
R-Y
B-Y
C Y
VIDEO
R G B
AUDIO L
AUDIO R
AUDIO L
AUDIO R
12345678910
11 12 13 14 15 16 17 18 19 20
5 6 7 8 9 10 11 12 13
14
15
16
17
18
19
20
212223242526272829
30
31
32
1
2
3
4
1
2
3
4
5
6
7
1011
1213
1415
1617
1819
2021
2223
2425
26
27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43
4445
4647
4849
5051
5253
5455
5657
5859
60
6162636465666768123456789
12 3
4
1
2
3
4
5
6
7
8
9
10
11
12
13
1
50
25
26
12
34
56
78
910
1112
1314
1516
1718
1920
2122232425262728293031323334353637383940
4142
4344
4546
4748
4950
5152
5354
5556
5758
5960
61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80
1 2 3 4 5 6 7 8
910111213141516
12
34 5
67
8
12
34
56
78
910
1112
1314
1516
1718
19
20 21 22 23 24 25 26 27 28 29 30 31 32
3334
3536
3738
3940
4142
4344
4546
4748
4950
51
52535455565758596061626364
EMI
C330
C333
R58
R344
C1
C321
C332
R1010
R320 R321 R322
R326
R33
R34
R340
R341
R342 R345
R35
R50 R52
R54
R59
R66
R67
R78
R88
C2
JR1010
C25
R153 R154
R378
R349
R348
R347
R148
R146
R145
R147
C315 C328
R300
R330
C334
C90
R4
CN1
R42
D2
R1
R375
Q305
C372
C373
C370
IC1001
C1013
R40
D370
R1026
R1027
R301
R316
R353
R79
R93 R94
R95
R377
R376
R97
C18
C26 C23
R24
R25
R26
C13
R29
R30
R31
C14
C16
C17
R18
R20
R19
R21
R49
D16
L10
R51 R53
C45
R46
R47
R48 D12
D11
R65
R64
R62
R61
R60
R68
R70
R71
R72
R73
R74
R76
R77
R2
R3
D10
R1024R1028
X1001
D1010
R1017
R1014
C8
R92
R91
Q304
R302 R303L300
R310
R309
C308
C307
C306
R308
C305
C304
R315
R323
D320
R343
R337
R354
C356 R351
X302
X301
C350
R357
R352
C21
R327C320
C359C360
R1020
C337
C19
C343
C301
C10
C11
C354
C358
C309
C310
C311
C325
C342
C1015
C312
C353
R1021
R1022
R1023
R1012
R334
R7
R9
C1020
C22
C43
C302 C303
C313
C371
C300
C3
C15
C348
C357
C331
R192 R193 R194
R195 R196 R197
R374
R373
C377
R325 R332
D303
R379C317
C326C327
C335
C1014
C1010
FL1001
C4 C24
C340
C339
C341
R335
R336
X303
R355 C347
D304
R1002
C1001C1002
C355
C344
C336
R371
L301 C376
R32
C12
R149
R150
R151
CN6
X1
C338
R6
C322 C323 C324
R63
R5
R28
IC1
R356
R304
R339R338
R333
R305
R358
C351
Q20 Q21 Q22
Q23 Q24 Q25
IC3
IC2
IC4
IC303
Q303
Q302Q301
Q300
IC302
IC301
CN301
C20
Q307
R329
R331
Q309Q1001
Q308
Q4
R1001
Q15 Q17
Q331
Q306
Q330
R44
Q1002
Q1
R370
C352
R350
0.1 25V F:CHIP
47 16V
33p CH:CHIP
33pCH:CHIP
0.125V
F:CHIP
47p CH:CHIP
47p CH:CHIP
# :CHIP
# :CHIP
0.1 25V F:CHIP
470p CH:CHIP
# :CHIP
# :CHIP
0.125V
F:CHIP
0.0047 B:CHIP
0.01B:CHIP
100pCH:CHIP
# :CHIP
0.001CH:CHIP
47 16V
4716V
150pCH:CHIP
0.125V
F:CHIP
0.125V
F:CHIP
47pCH:CHIP
0.1 25V F:CHIP
0.001CH:CHIP
0.001CH:CHIP
0.1 25V F:CHIP
0.1 25V F:CHIP
0.01 B:CHIP
0.01 B:CHIP
0.01 B:CHIP
1 16V F:CHIP
1 16V F:CHIP
1 16V F:CHIP
2.216V
F:CHIP
0.001CH:CHIP
0:CHIP
0.125V
F:CHIP
22 0.01B:CHIP
116V
F:CHIP
0.001CH:CHIP
0.047
10
0.163V:PT
0.1100V:MPP
0.01B:CHIP
10016V
0.01B:CHIP
C3800.125V
F:CHIP
0.4725V
F:CHIP
0.001B:CHIP
0.001B:CHIP
0.01 B:CHIP
100 16V
0.47 25V F:CHIP1 16V F:CHIP
0.0047 B:CHIP
100p CH:CHIP
4.7
470pCH:CHIP
10
2.216V
F:CHIP
0.4725V
F:CHIP
22
0.01B:CHIP
470pCH:CHIP
0.4725V
F:CHIP
15pCH:CHIP
15pCH:CHIP0.001
CH:CHIP
0.22
B:CHIP
220pCH:CHIP
10
22pCH:CHIP
22pCH:CHIP
0.125V
F:CHIP
220.125V
F:CHIP
0.2216V
B:CHIP
22pCH:CHIP
50P
13PWHT
:S-MICRO
1SS355
UDZ-5.6B
UDZ-5.6B
UDZ-5.6B
1SS355
1SS355TE
1SS355TE
D1021SS355TE
UDZ-9.1B
BAS216
MA3030H
FZ103N
SDA5273CP TEXD/OSD
0 :CHIP22µH:CHIP
10µH:CHIP
2SC2412K
2SC2412K
100 :CHIP
100 :CHIP
33 :CHIP
470:CHIP
470:CHIP
100 :CHIP
100 :CHIP
100 :CHIP
100 :CHIP
4.7k :CHIP
4.7k :CHIP
# :CHIP
4.7k :CHIP
4.7k :CHIP
4.7k :CHIP 100 :CHIP
100 :CHIP
100 :CHIP
100 :CHIP
5.6k:CHIP
6.8k:CHIP
82k:CHIP
2.2k:CHIP
1:CHIP
100 :CHIP
4.7k:CHIP
2.7k:CHIP
4.7k:CHIP
2.7k:CHIP
100 :CHIP
3.9k :CHIP
100 :CHIP
100 :CHIP
100 :CHIP
100 :CHIP
100 :CHIP
100 :CHIP
2.2k :CHIP
2.2k :CHIP
100 :CHIP
100 :CHIP
100 :CHIP
100 :CHIP
100 :CHIP
100 :CHIP
100 :CHIP
100 :CHIP
100:CHIP
220:CHIP
100 :CHIP
100 :CHIP
100 :CHIP
220:CHIP 220 :CHIP
220:CHIP
100:CHIP
100 :CHIP
100 :CHIP
100 :CHIP
100 :CHIP
100 :CHIP
100 :CHIP
100 :CHIP
100:CHIP
0:CHIP
1k:CHIP
1k:CHIP
1k:CHIP
1k:CHIP
1k:CHIP
1k:CHIP
100:CHIP
220 :CHIP
0:CHIP
0:CHIP
100 :CHIP
220 :CHIP
220 :CHIP
0 :CHIP
220:CHIP
100:CHIP
100:CHIP
100:CHIP
220:CHIP
47k:CHIP
100:CHIP
100:CHIP
100:CHIP
1k:CHIP
470 :CHIP
10k :RN-CP
330k :CHIP
100 :CHIP
100:CHIP
100:CHIP
1k:CHIP
3.3k :CHIP
5.6k:CHIP
100:CHIP
100 :CHIP
100 :CHIP
100 :CHIP
1.5k:CHIP
15k:CHIP
220 :CHIP
0:CHIP
68k:CHIP
1k:CHIP
220:CHIP
1k:CHIP
470:CHIP
1.1k:RN-CP
22k:CHIP
1k:CHIP
16k:RN-CP
470:CHIP
100:CHIP
0:CHIP
470 :CHIP
4.7k:CHIP
0:CHIP
100k:CHIP
150:CHIP1
50:CHIP
150:CHIP
680:CHIP1
00:CHIP
100:CHIP
100:CHIP
4.43MHz
3.58MHz
B500F63500kHz
20.48MHz
0.125V
16V
B:CHIP
3.3
# :CHIP
10k:CHIP
10k :CHIP
SDA30C263-GEG
MICRO
0.125V
F:CHIP
0.125V
F:CHIP
0.125V
F:CHIP
2.216V
F:CHIP
1k:CHIP
4.7k :RN-CP
2.2M:CHIP
3.3M:CHIP
11.5MHz
2.216V
F:CHIP
220:CHIP
5.6k:CHIP
1k :CHIP 1k:CHIP
6.8µH :CHIP
220k :CHIP
2SC2412KR BUFF
2SC2412KG BUFF
2SC2412KB BUFF
2SA1037AKBUFF
2SA1037AKBUFF
2SA1037AKBUFF
M27C2001-12C1RPROGRAM ROM
M24C32-MW6TNVM
PST593C-MMP-4PRESET
TDA8395T/N3CHROMA DEC.
2SC2412KY BUFF
2SC2412KBUFF
2SC2412KBUFF
DTC144EKASW
TDA4665T/V5-118IH DELAY LINE
CXA2076Q-TLSHADING
7PWHT
0.01B:CHIP
DTC144EKAPROT
47k:CHIP
R3590
:CHIP
2.7k:CHIP
DTC144EKAINV
DTC144EKARESET SW
DTC144EKAPROT
2SC2412KSW
100:CHIP
2SA1037AKINV
2SA1037AKINV
2SC2412KBUFF
DTC144EKASW
2SA1037AKINV
6.8k:CHIP
2SA1037AKBUFF
2SC2412KBUFF
0:CHIP
0.4725V
F:CHIP
470:CHIP
C AV-3
HP L
HP R
SP R
SP L
AUDIO L AV-3
AUDIO R AV-3
FB AV-1
G AV-1
B AV-1
R AV-1
AGC MONI
SDA
SCL
U-PC DISABLE
9V
33V
5V
9V
5V
STDBY 5V
STDBY 5V
STDBY 5V
STDBY 5V
STDBY 5V
9V
9V
9V
H 9V
H 9V
9V
1
1STDBY 5V
9V
CVBS AV-3
Y AV-3
9V
STDBY 5V
5V
SPSW
FSC
9V
5V
CVBS
Y
C
DISABLE PJE
A.REGI
CVBS OUT
L OUT
R OUT
MODE 3
A12
A15
A16
D7
D1
D2
D3
D4
D5
D6
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A13
A14
D0
HP L
HP R
SP R
SP L
HFBP
E-W
H OUT
ABL
K1
MUTE
LED
STBY
IR
V3
C3
Y3
R3
L3
V3
C3
Y3
LED
LED
DIS
STBY
K1K1
LS LS
IR
VS
ABL
H OUT
R2
G2
B2
FB2
FB1
VS
HFBP
CVBS
R
EN
RXD RXD
TXDTXD
FB-2
FB-2
COR
MONIMONI
RST
RST
COIL
V-BLK
FB1
EN
RXD
TXD
AFC
HFBP
V SYNC
VS
HS
HS
G
B
IK
RGB-S
WR
E-W
V-
R G B IK
SCL
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
D1
D2
D3
D4
D5
D6
D7
D0
A16
RST2
ALE
RST
STBY
LED
DIS
DIS
V SYNC
RGB-S
4.0
MUTE
EN
CVBS
TEXT
TEXT
TEXT
VM
V+
DGC
VS
HS
V-BLK
FB2
TRAP
R1
G1
B1
TRAP
SDA
A17
HS
CTXTPWR
SCL
SDASDA
SCL
R2
G2
B2
SR
SG
SB
MCOR
MFB2
YM1
YS1
COR
FB2
FSC
FSC
Y
C
C Y
MB2
MG2
MR2
MCOR
MFB2
FB1
R1
G1
B1
V+
HFBP
CVBS
CVBS
SCL
SDA
YM1
YS1
SB
SG
SR
VS
A18
A17
4.1
V-
VM
FB2
SDA
SCL
HP L
HP R
L3
R3
SP L
SP R
MB2
MG2
MR2
HFBP
FS
PROT1 PROT1
PROT1
FS
PROT1
SCL
SDA
RST2
RST
WR
MODE3
CVBS OUT
L OUT
R OUT
MODE3
CVBS OUT
L OUT
R OUT
FV
VBLK
CVBS IN AV-3
AUDIO MUTE
STANDBY LED
LUMISPONDER
V- DRIVE
EAST/WEST DRIVE
V+ DRIVE
H DRIVE
V SYNC
H FLYBACK
ABL
9V
33V
STANDBY 5V
SIRCS
5V
S-VHS Y IN AV-3
S-VHS C IN AV-3
AUDIO L IN AV-3
AUDIO R IN AV-3
AUDIO R OUT HP
AUDIO L OUT HP
FRONT KEY 1
AUDIO R OUT SPEAKER
AUDIO L OUT SPEAKER
VM
SCL
SDA
VERTICAL GND
VERTICAL GND
AUDIO GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
H.SHIFT
VM
EHT
12V
SCL
SDA
FS
PJE YS
PJE B
PJE G
PJE R
SPSW
PJE YM
E
A0
A1
A2
GND
TEST
SCL
SDA
STDBY 5V
GNDOUT
RST 5VSTDBY
A0
A1
A2
A3
A4
A5
A6
A7
A11
OE
A10
CE
D7
D6
D5
D4
D3
GND
D2
D1
D0
P
A12
A15
A16
A14
A13
A8
A9
STDBY 5V
STDBY 5V
A17
CVBS IN
NC
NC
RESET
NC
NC
NC
NC
VREF
NC
A8
A7
A6
A5
A4
A3
A2
A1
A0
A9
A10
A11
RASQ
WEQ
D1
D0
D2
D3
NC
VBB
NC
NC
NC
NC
CASQ
NC
NC
NC
NC
TM
GPO
XIN
XOUT
HS
VS
TCSQ
CLK
INTQ
CORQ
BLANKING
GREEN
D GND
RGB GND
D GND
D GND
D GND
D GND
A GNDA 5V
USART
USART
ENABLE
D 5V
D 5V
D 5V
D 5V
RED
BLUE
A15
A14
A12
A13
D5
D0
D6
A0
D7
A1
A2
A10
A3
A4
A11
A5
A9
A6
A8
A7
D1
D4
D2
D3
RED OUT
GREEN OUT
BLUE OUT
BLANKING
GND
STANDBY 5V
LC IN
LC OUT
HS/SSCP
P0.0
VS
P0.1
P0.4
P0.5
P0.6
P2.3
P2.2
P2.1
P2.0
FIL3SLC
FIL2SLC
FIL1SLC
IREF
CVBS IN
P3.7
P3.6
P3.5
P3.4
P3.3
P3.2
P4.1
A16
P4.0
ALE
RST
XTAL1
XTAL2
STANDBY 5V
GND
P1.0
P1.1
P1.2
P1.3
P1.4
P1.5
P1.6
P1.7
P3.1
A GND
A 5V NC
COR
P0.7
P3.0CTXTPWR
FB-2
RED DRIVE
BLUE DRIVE
GND
CUT OFF
GND
GRN DRIVE
9V
SSCP
NC
NC
5V
NC
GND
NC/GND
NC/5V
AB/NC
NC/GND
NC/GND
VCO/NCOUT
OUT
IN
IN
R-Y
B-Y
B-Y
R-Y
R-Y OUT
B-Y OUT
SSCP IN TEST
GND
NC
NC
NC
NC
NC
NC
8V
NC
NC
NC
NC
CLOCHE
PLL REF
IDENT
CVBS IN
GND
SECAM REF
R-Y OUT
B-Y OUT
Y OUT
Y IN
R-Y IN
B-Y IN
GND
SSCP OUT
FB-1 IN
R-1 IN
R-2 IN
G-1 IN
B-1 IN
FB-2 IN
HB-2 IN
G-2 IN
B-2 IN
RSH
R OUT
GSH
G OUT
BSH
B OUT
IK IN
ABL IN
ABL FIL
VTIM
V- DRIVE
V+ DRIVE
SAW OSC
H OUT
AFC PIN
L2 FIL
AFC FIL
VS FIL
VS IN
HS IN
SYNC OUT
APC FIL
4.43MHZ
3.58MHZ
FSC
BL HOLD
CVBS IN
SYNC IN
DC TRAN
SVHS-Y IN
SVHS-C IN
RGB 9V
Y/C 9V
H 9V
V 9V
GND
NC
GND
CERA
IREF
E-W
V AGC
PROT1
A.REGI
P.CONT
L OUT
R OUT
CVBS OUT
MODE3
50-60
VBLK
CN1702
TO D BOARD
TO CR BOARD
CN703
TO (1/2)
CN1801
TO D BOARD
AE(2/2)(CHROMA DECODER)
B-SS150.<AEP>-AE.-P2-05
R3602.2M:CHIP
R3612.2M:CHIP
12
1
A
B
C
D
E
F
G
H
I
K
L
M
N
O
P
J
2 12 1311109876543 14 201918171615
Page 24
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
12345678910
VCC
OUT
GND
1234
1
2
3
4
1
2
3
4
5
S3006
CN3001 CN3002
R3009
Q3002
R3010
CN3003
CN3004
S3001
S3002
S3003
S3004
D3002
R3006R3002R3001 R3007
S3005
STBY5VC3003
IC3002
4PWHT-L
:S-MICRO
10PWHT-L
:S-MICRO
4B2PSWHT-L:VH
5B3PSWHT-L:VH
2SC2412KLED DRIVE
470:CHIP
680:CHIP
1-571-433-31
POWER
22k:RN-CP
10k:RN-CP
4.7k:RN-CP
2.7k:RN-CP
SLA-580LT3FLED
1016V
SBX1981-51 SIRCS
H1( )
GND
KEY1
STBY +5V
GND
GND
+5V
SIRCS
R.LED
AUTO REGI./KEY2
KEY1
KEY2
AC(N)IN
NC
NC
AC(L)IN
NC
NC
NC
AC(L)OUT
AC(N)OUT
TO G BOARD CN6006
TO G BOARD CN6007
TO D BOARD CN1803TO H2 BOARD CN3201
+5V
NC
NC
RMC, FUNCTION KEY
5V
12345678910
11
1 2 3 4
1
2
3
4
5
1 2
3 4
V
L
R
CN3201
C3203
L3201
L3202
C3204
R3212R3211
R3203
R3202
C3205
R3209 R3210
CN3202
R3207
J3201
CN3204
S3205
S3206
J3202
0.022B:CHIP
0.022B:CHIP
4PWHT-L
:S-MICRO
100µH :EL0606
100µH :EL0606220:CHIP
220:CHIP
220:CHIP
220:CHIP
11PRED-L
:S-MICRO
1.3k:RN-CP
1016V
100:CHIP
100:CHIP
5PBLK-L
:S-MICRO
6
1
2345
789
H2
FR R OUT
GND
FR L OUT
GND
FR V OUT
GND
FR C OUT
GND
FR Y OUT
GND
GND
HP R IN
VIDEO INPUT3
FR S3 OUT
GND
KEY1
AUTO REGI./KEY2
GND
SP MUTE
HP L IN
+5V
PRESET
AUTO
CONVERGENCE
AUTO
HEADPHONE
TO D BOARD CN1601
A/V INPUT,FUNCTION KEY
TO D BOARD CN1802
R
L(MONO)
VIDEO
S-VIDEO
TO H1 BOARD CN3001
B-SS510.<AEP>-H2.
STANDBY
PROG+ PROG- VOL+ VOL-INPUT SELECT
1
A
B
C
D
E
F
G
H
I
J
2 12 1311109876543 14 15
– 65 – – 66 –
H1 [FUNCTION KEY, RMC]
– H1 Board – H2 [A/V INPUT, FUNCTION KEY]
– H2 Board –
H1 BOARDIC VOLTAGE LIST
H1 BOARD TRANSISTORVOLTAGE LIST
• AII voltages are in V.
IC3002 VCC 5.0OUT 5.0GND GND
REF. NO. VOL.
• All voltage are in V.
REF. VOL.
B 0.5Q3002 E 0.1
C 5.0
Page 25
– 69 – – 70 – – 71 – – 72 –
1 2 3 4 5 6
8 9 10 11 12
15 16 17 18 19 20 21
4.5Vp-p (H) 12.7Vp-p (H) 11.4Vp-p (H)2.5Vp-p (H) 89.0Vp-p (H) 11.2Vp-p (H) 1090Vp-p (H)
2.6Vp-p (V) 2.5Vp-p (V) 2.4Vp-p (V) 1.6Vp-p (V) 1.3Vp-p (V)
4.8Vp-p (H) 2.6Vp-p (H) 2.5Vp-p (H) 2.4Vp-p (H) 2.5Vp-p (H) 4.7Vp-p (V)
• E BOARD WAVEFORMS
7
2.6Vp-p (V)
13 14
1.3Vp-p (V) 1.4Vp-p (V)
IC501 1 0.12 0.73 12.24 6.15 1.86 8.37 7.98 1.69 2.5
10 4.511 1.812 GND13 1.614 10.1
IC801 1 0.22 1.13 5.04 05 -0.86 07 -1.19 -5.0
11 0.512 -0.913 0.314 1.215 GND16 -1.717 1.218 -1.5
IC802 1 0.42 1.13 5.04 05 -0.86 07 -1.19 -5.0
11 0.512 -0.913 0.314 1.215 GND16 -1.717 1.218 -1.5
IC803 1 02 03 04 0.15 0.96 08 GND9 0
10 011 013 5.014 -5.0
IC804 1 02 -0.83 04 -1.15 06 -0.47 -4.98 5.09 -4.9
14 -2.015 016 -0.817 018 -0.819 0.120 -0.521 5.022 023 -0.124 0.125 0.126 0.127 0
REF. NO. VOL.
E BOARD IC VOLTAGE LIST
28 0.129 -0.130 -0.531 4.632 0.233 5.034 4.735 0.136 0.137 038 0.139 040 0.241 042 GND
IC805 1 7.42 7.43 7.24 12.35 06 07 08 -0.89 010 011 -12.312 013 014 0.9
IC806 1 02 -0.83 04 -1.15 06 -0.47 GND8 5.09 -4.910 4.711 5.012 0.213 4.614 -2.015 016 0.817 GND18 -0.819 0.120 -0.521 5.022 023 -0.424 0.125 0.226 0.127 028 0.129 030 0.331 4.632 0.233 5.034 4.735 0.136 0.137 038 0.139 040 0.241 042 GND
IC806 1 02 -0.83 04 -1.15 06 -0.47 5.08 5.09 -4.910 4.7
REF. NO. VOL.
•All voltage are in V.•Pin numbers which are not
described are not used.
11 5.012 0.213 4.614 -2.015 016 0.817 018 -0.819 0.120 -0.521 5.022 023 024 0.125 -0.126 0.127 028 0.129 0.230 -0.231 4.632 0.233 5.034 4.735 0.136 0.137 038 0.139 040 0.241 0
IC809 1 GND2 GND3 -13.04 -14.25 14.36 07 08 -14.29 -0.1
10 14.311 012 -14.213 014 015 0.316 0.317 -14.218 0.4
IC810 1 GND2 GND3 -13.04 -14.25 14.36 07 08 -14.29 -0.1
10 14.311 0.212 -14.213 0.214 0.215 016 017 -14.218 -0.1
IC811 1 0.12 0.13 04 -12.35 GND6 07 08 12.3
IC812 I 6.8G GNDO 5.0
IC813 I -11.3G GNDO -4.9
REF. NO. VOL.
E BOARD TRANSISTORVOLTAGE LIST
REF. VOL.
B -0.6Q501 E GND
C 48.1B -0.1
Q502 E GNDC 137.5B 6.9
Q503 E 6.5C 0B 0
Q504 E 0C 450.0B 1.7
Q506 E 1.2C 12.3B 12.3
Q507 E 12.3C 660B 4.1
Q508 E 3.5C 8.3B 0.7
Q701 E GNDC 0B 0.2
Q702 E GNDC 4.8B 2.3
Q801 E 1.8C 5.0B 6.0
Q802 E 7.5C 1.6B 2.3
Q803 E 1.9C 5.0B 2.3
Q804 E 1.9C -5.0B 1.5
Q805 E 0.9C 12.3B 2.3
Q806 E 1.9C -5.0B 2.5
Q807 E 1.9C 4.0B 0.6
Q808 E GNDC 1.5B -14.2
Q809 E -14.2C -13.1B -14.2
Q810 E -14.2C -13.1B 0.1
Q811 E GNDC 0.4B 0.6
Q812 E 0C 0.1G 10.2
Q505 D 20.0S GND
AII voltages are in V.
E BOARD : IC801,802 PA0053BE BOARD : IC804,806,808 PM0002B
5V
1
2
3
4
5
6
7
8
10
9
5V
-5V
-15V
15V
5V
-5V
11
5V
-5V
STBY7V
21
20
19
15
13V
13V
-13V
+B
-13V
13V 13V
-13V
7V
12V
+B
15V
-15V
-15V -5V
5V15V
7V
+B
5V
-5V
13V
13V
14
5V
-5V
7V
-15V
15V
16
17
18
15V
-15V
-15V
13
12
-5V
5V
HV1
11
MV
4
2
6
7
5
3
9
8
10
12
34
56
7 89
1011
1213
14
12
34
56
78
9 1011
1213
1415
1617
18
12
34
56
78
9 1011
1213
1415
1617
18
1
2
3
4
5
6
7
8
9
10
1
2
3
4
5
6
7
8
9
10
1
2
3
4
5
6
7
8
9
10
12
34
56
78
910
1112
1314
1516
1718
12
34
56
78
910
1112
1314
1516
1718
1
2
3
4
1
2
3
4
1
2
3
4
1
2
3
4
1
2
3
4
12345678910
S
1 2 3 4 5 6 7
891011121314
12
34 5
67
8
1
2
3
4
1
2
3
4
5
I OG
12
34
56
7 89
1011
1213
14
I OG
1
2
3
1
2
3
4
1
12
34
56
78
910
1112
1314
1516
1718
1920
21 2223
2425
2627
2829
3031
3233
3435
3637
3839
4041
42
12
34
56
78
910
1112
1314
1516
1718
1920
21 2223
2425
2627
2829
3031
3233
3435
3637
3839
4041
42
12
34
56
78
910
1112
1314
1516
1718
1920
21 2223
2425
2627
2829
3031
3233
3435
3637
3839
4041
42
1
2
3
4
5
6
7
8
9
10
1
2
3
4
1
3
4 7
8
9
10
1
2
3
4
5
6
1
2
3
1
3
4
5
6
1 2
FB501
IC806
IC802
IC804
D829
T502
IC803
R801 R802
R819 R839
R842
T504
D501
R560
D508
D820
C517
R540
T501
R810
R805
R813
D835
D840
D504
L503
C828
C830
C849
C850
C855
C856
C876
C877
C886
C887
C544
C545
C802
C825
C838
C840
C844
C846
C847
C854
C860
C864
C804
C805
C550
C551
C502
C829
C831
C832
C833
C837
C507 C513
C835
C537
C538
C834
C532C511
C821
C515
C826
C836
C866
C809
C813
C839 C841
C842
C851
C852
C853
C861 C863
C539
R903
R910
R944
R517
R858
R859
R860
R861
R862
R863
R913
R914
R915
R916
R917
R918
R967
R968
R969
R970
R971
R824 R826
R847
R850
R541
R550
R555
R565
R814
R816
R843
R844
R851
R852
R856
R857
R597
R873
R887R888
R897
R949
R950
R951R952
R881
R926
R987
R841 R898
R948
R966
R980
R981
R983
R548
R830
R831
R823
R871
R504
R838
R942
R865
R923
R979
R989
R828
R829
R854
R882
R883
R927
R928
R935
R936
R956
R988
R991
R919
R551
R825 R832
R834
R835
R837
R845
R875
R885R890
R896
R940
R941
R943
R947
R853
R579
R568
R536
R539
R545
R546
R566
R567
R525
R554
R939
R556
R537
D506
R521
CN507
D514
D515
D511
R922
R931
R886
C818
D507
R809
R820
C531
R964
R965
R929
R975
R973
R930
R976
C888
C889
C883
C884
C897
R959
R958
R957
R906
R905
R954
C881
C859
R552
CN501
CN502
CN503
C820
R803
JW503 L504
R895
L502
R571
R869
R978
R821
C521
C520
R924IC801
R911
R908
R501
R507 R572
R573
C540
C512
D845
D846
C516
R804
R808R1901
C807
D527
C858
C857
C885
C880R999
R998
R961
D510
R584
R576
C519C524
R912
R933
C822
C533
R535 L508
C872
D524
L803
C514
R589 R588
CN810
CN505
D502
C509
R503
C518
C811
C808
R553
R547
D517
R527
R1904
CN805
IC805
C548
C803
R523Q505
D509
R972
R586
R528
R570
R569
R557 R558 R559 R585
C535NL501
R993
R997
R985
R502
C555C506C556
R583
C823
C870C867C819
C817
R920
R904
R955
C882
D842
R836
R817
R815
R811
R807
C526 R531
R533 R534C530
D520
D521
D513
R990
R513
C523
R902
SG501
R577
D503
D512
R519
C542
C527R524
R591
R538
C827
D519
C868
C801
R963
R962
L801
L802
C815
R909
R580
R530
R982
R995
C816
CN652
CN651
C528
C554
R574
R509R532
C541
L506
R581
C865
IC811
PS603
PS604
PS605
PS606
PS607
PS608
R562
R833
R974
L505
R827
R994
R900
R946
R508
C508
R512
R511
R510
R891
R934
R874
R889
C869
R921
R945
R594
R549
C824
R892
R893
R870
R877
C873
R866
R522
R516R514
R806
R812
R953R937
C536
C810C806
C812
R703
R822C701
PS601
PS602
Q701
D701
Q702R702
D702
R518R575
R542
C529
C845
R846
R529
R848
R563
R894
R878
R872
R868 R884
R867R705
R704
R925
R701
R706
R879
R984
R901
R986
C848
Q811
Q812
Q801 Q803
Q804 Q806
IC810
C862
Q809
R938
Q810
CN508
CN804
CN506
CN808
CN806
CN807 IC812
IC813
Q808
Q802
Q805
Q807
IC501
Q501
Q502
Q503
Q507
Q506
Q504
IC809
CN802
CN803
CN801
CN504
R505
IC808
R544
R5430.47
10016V
22
0.047200V:PT
0.0022:PT
0.001:PP
22
470p2kV:B
0.033630V:PP
0.015 #
0.1:PT
C5051000p:PT
0.0047100V:PT
680p2kVB
680p2kVB
0.0047100V:PT
470p500V:B
100160V
470
470
47250V
0.068200V:PT
100
100
0.00472kVE
0.022
10025V
10025V
220p500VB
47016V
47016V
10.1:PT
10025V
22016V
22016V
22016V
0.047:PT
0.047:PT
0.047:PT
0.001
0.047:PT
4725V
100 16V
4725V
0.01B
0.1:PT
100160V
4725V
10025V
0.1 :MPS
470p
0.47
470p
1
1
1
100
47
0.22 :MPS
4.7
100 25V
0.047:PT
10025V
0.047:PT
0.047:PT
10016V
100 16V
100 16V
100p
100p
0.047:PT
0.047:PT
0.047:PT
100 16V
100p
100p
100 16V
10025V
10025V
10016V
0.047:PT
0.047:PT
10016V
1:MPS
4725V
0.01:F
1
100p
100p
4725V
100p
100p
100p
100 25V
4725V
100p
100p
100p
100 25V
100 25V
10PWHT
:S-MICRO
4P:VH
4P:VH
2P:LARGE
4PWHT
:S-MICRO
4P:MINI
3P:MINI
1SS133
D5231SS133T
1SS133
1SS133
MTZJ-7.5B
JW(5)
EL1Z-V1
ERD29-08J
ERC06-15S
1SS133
RGP10G
RGP10GPKG23200V-RECT
GP08D
GP08D
RGP02-20EL
RGP10GPKG23+12-RECT
RGP10GPKG23-12-RECT
1SS133
MTZJ-5.1B
MTZJ-3.6
MTZJ-5.1
MTZJ-5.6PROTECT
1SS133
1SS133
1SS133
1SS133
1.1UH
PA0053BV.WAVE-GEN
PA0053BH.WAVE-GEN
CA0007AD
PM0002BB-CONV-CORR
NJM2058DDF AMP
PM0002BG-CONV-CORR
5MM
47µH:FLR50
10mH:LM
JW(5)
JW(5)
:LHL10
2SK2251PIN AMP
2.2k
47k1W:RS
3.3k
1.5k
2.7k
3.3k
15k:RN
JW(7.5)
47k
4.7k
68 3W :RS
6801/2W:FPRD
91k1/2W:RN
270k:RN
220k
4.7k1/2W:FPRD 100
10047010047k
100120k
100
1k1/2W
39k3W:RS
39k3W:RS
39k3W:RS
100
1M
1.8 3W :RS
68 3W :RS
2.7k
470k
56k100
270k
8.2k
10k
39k3W:RS
1k2W:RS
22k220k
100 100
12k
4.7k
100
100
10k
4.7k
100
100
22k
100
100
100
100
100
47k
15k
1k
51k:RN
100k
51k:RN
5.6k
5.6k
560
560
100k
100k
100k
100
100k
2.2k
100
220
100
100
100
100k
330k :RN
330k :RN
100
100
220k
10k
100
100
27k62k
:RN :RN
27k :RN
27k :RN
27k :RN
27k :RN
27k :RN
3.9k
4.7k
1k
100
100k
180
10k
10k
100k
8.2k
100100
100k
2.2k
100k
100
220
15k:RN
R596150k:RN
1k :RN
2.2 1/2W :RN
2.2 1/2W :RN
2.2 1/2W :RN
10k:RN
1k:RN
47k :RN
10k :RN
27k :RN
27k :RN
27k :RN
27k :RN
27k :RN
27k :RN
33k
2.2 1/2W :RN
10k :RN
4.7k
10k:RN
180
10k
10k
2.2 1/2W :RN
2.2 1/2W :RN
10k:RN
10k:RN
10k
10k
1.5M
100k
100k
2.2k
100k
1k:RN
100k
220
100
100
100100
3.3k :RN
3.3k :RN
10k
2.2 1/2W :RN
2.2 1/2W :RN
3.3k :RN
4.7k
3.3k :RN
3.3k :RN220
27k :RN
27k :RN
27k :RN
27k :RN
27k :RN
27k :RN
2.2 1/2W :RN
2.2 1/2W :RN
3.3k :RN
8.2k
4.7k
220
220
220
10k
180
10k
4.7k
15k 10k
4.7k
10k:RN
:RN
4.7k
4.7k
68k
4.7k
HDT
PMT
FBT
0.82200V:PP
2.7k
1SS133
1SS133
10k
22016V
3304.7k
4.7k
4.7k
1SS133
0.01:F
10025V
2.2 1/2W :RN
2.2 1/2W :RN
10025V
1k:RN
47k
10k
47k
NJM4560DSHADING AMP
0.0056630V:PP
470p:PP
10
2.2mH:LHL08
220µH
220µH
33k
47k
100k:RN
JW(5)
1250V
0.047:PT
0.0022:PT
10P:B-TO-B
10P:B-TO-B
100k1/2W:RC
2A
2A
2A
2A
2A
2A
821/2W:FPRD
82 3W :RS
82 3W :RS
27k:RN
1k:RN
82 3W :RS
82 3W :RS
33k
6.8k1/2W:FPRD
1.5k3W:RS
1.5k3W:RS
1.5k3W:RS
68k
3.3k
2.7k
0.022:PT
SnS182
100:FPRD
0.47:FPRD
0.47:FPRD
0.68 :FPRD
0.47:FPRD
0.47:FPRD
100:FPRD
0.47:FPRD
0.47:FPRD
0.047:PT
22016V
0.22:MPS
1k
470p500VB
10016V
5.0A
5.0A
100k:RN
8.2k:RN
8.2k
2.2k
10k
#
39k 33k
2SC3311A
RD3.0ES-T1B2 2SC3311A2.2k
10016V
100
15k :RN
27k :RN
100k:RN
4.7k
8.2k:RN
10k:RN
27k:RN
4.7k
15k :RN
10k:RN
10k:RN
15k:RN
R578150k:RN
100 16V
0.68250V:PP
1SS133
39k
15k :RN
1501W:RS
12k :RN
JW(5)
27k :RN
27k :RN27k :RN
15k:RN
2SC3311ASW
2SA1309APROT
2SC3311ABUFF
2SC3311ABUFF
2SA1309ABUFF
2SA1309ABUFF
STK392-150CONV.OUT
0.047:PT
2SC3311AMUTE
1k:RN
2SC3311AMUTE
1P:FASTON
10P:B-TO-B
10P:B-TO-B
5P:MINI
3P:MINI
6PWHT
:S-MICRO
NJM78M05FA+5V REG
NJM79M05-5V REG
DTC144ESAINV
2SA1309ABUFF
2SC3311ABUFF
2SC3311ABUFF
µPC339CREG COMP
2SC2688H DRIVE
2SD2539H OUT
2SA1309AG2-STOP/CONTROL
2SC5022-02DF OUT
2SC3311ADF AMP
2SC4632LSG2-STOP
STK392-150CONV.OUT
4PWHT
:S-MICRO
4PBLK
:S-MICRO
4PRED
:S-MICRO
4P :VH
180kR506150k
PM0002BR-CONV-CORR
150 1W :RS
1 1W :RS
ABL
HP
HD
5V5V
13V 13V 13V
135V
-15V
15V
5V
-5V
H2
H1
H3
H4
V1
V2
H1
H2
H3
H4
H2
BH
BV
GH
GV
RH
RV
V3
H3
H4
H2
H1
V1
V2
V3
V4
SCL
MUTE
SDA
GH
RV
RH
V4
V2
SDA
MUTE
H3
H3
BV
SCL
BH
GV
H1
V1
CEB
H3
H4
V1
V1
V2
V3
CEB
H2
V1
V2
V4
H1
V1
H1
H3
V2
H2
V3
V1
H2
H2
V1
V3
V4
10
10
15k
#
47k
47k
2.7k
4.7k
2.2k
68k
0.047:PP
10k
H.BLK
SAW.C
VCC
H.SAW
H.PARA
H.SIN
H.4TH
H.5TH
VEE H6TH
PEEKDET
PARA.C
BTMDET
REF-R
GND
RETDET
RET.C
SAWDET
V.BLK
SAW.C
VCC
V.SAW
V.PARA
V.SIN
V.4TH
V.5TH
VEE
SWDET
RET.C
RETDET
GND
RET-R
BTMDET
PARA.C
PEEKDET
V.6TH
NC
HR OUT
HR RET
HG OUT
HG RET
HB OUT
HB RET
VR OUT
VR RET
VG OUT
VG RET
VB OUT
VB RET
R-H(+)
NC
NC
R-H(-)
NC
NC
NC
NC
G-H(+)
G-H(-)
B-H(+)
B-H(-)
H(+)
H(-)
NC
NC
NC
200V
NC
B/S
VP
MUTE
BV WAVE
RV WAVE
ABL
PIN
HP
HD
R/S
135V
VG
HB
VB
-Vcc
Ch.3
Ch.2
Ch.1
-Vcc
-Vcc
-Vcc
+Vcc
+Vcc
Pre.Pre.MUTE
SUB.
GND
-Vcc
Ch.3
Ch.2
Ch.1
-Vcc
-Vcc
-Vcc
+Vcc
+Vcc
Pre.Pre.MUTE
SUB.
GND
HR
VR
HG
+15V
-15V
-5V
HV.REG
Y X X YMPY MPY
NC
+12V
7V
PROT
P.CONT
STBY 7V
+15V
+135V
-15V
CEB
DATA
CLK
STDBY 7V
STDBY 7V
12V
STBY 7V
P.CONT
E
-12V
+12V
+B
+200V
C
R-BIAS
B-BIAS
VEE
VCC
H.SAW
H.PARA
H.SIN
H.4TH
V.SAW
V.PARA
ICADDR
HV
INJ
V.SAW
V.PARA
H.SAW
H.PARA
V.SIN
V.4TH
A1INM
A1INP
A2INM
A2INP
PCSEL
CLKB
MUTE
DATA
CEB
HOUT1
HOUT2
HOUT3
VOUT1
VOUT2
VOUT3
MPOUT
MPIN1
GND
CLKB
MUTE
DATA
CEB
MPIN2
GV OUT
GH OUT
V.SAW A1INP
CEB
V.SIN
VCC
V.PARA
H.SAW
H.PARA
INJ
V.4TH
HOUT1
HOUT2
HOUT3
VOUT1
VOUT2
VOUT3
MPOVT
MPIN1
MPIN2
V.PARA
ICADDR
HV
VEE
MUTE
A2INM
A2INP
PCSEL
CLKB
MUTE
DATA
CLKB
DATA CEB
H.4TH
H.SIN
A1INM
GND
H.PARA
H.SAW
BH 0UT
BV OUT
V.SAW
GNDH.SAW
H.PARA
H.SIN
H.4THA1INM
RV OUT
RH OUT
V.SAW A1INP
MUTE
DATAMUTE
CLKB
CLKBVEE
A2INM
A2INP
PCSEL
V.PARA
ICADDR
HV
HOUT1
HOUT2
HOUT3
INJ
V.SAW
CEB
CEBDATA
VOUT2
VOUT3
MPOUT
MPIN1
MPIN2
H.SAW
H.PARA
V.SIN
V.4TH
VCC
VOUT1V.PARA
NC
G2
DF
7V
+B IN
+B OUT
R1
PROT
HV.DET
R1
R1
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
TO HDY(B)
GND
VBLK
TO D BOARDCN1502
CN1805
CN1806TO D BOARD
TO D BOARD
CN6011TO G BOARD
CN6008TO G BOARD
TO G BOARDCN6013
(H/V-DEF,HV)
CN1606
TO D BOARD
R
TO ZG BOARD
CN1462
TO ZG BOARD
CN1433
TO ZR BOARD
CN1404
TO ZR BOARD
CN1405
TO E BOARD T504
FV(G)
FV(R)
(FOCUS BLOCK)
DET G2 DF FV
TO HV BLOCK
TO FOCUS PACK
TO ZG BOARD
CN1434
TO CB BOARD
CN766
TO PICTURE TUBE R
TO PICTURE TUBE G
TO PICTURE TUBE B
<HV.BLOCK>
TO E BOARD T4003
HV
HV(R)
CN1703TO D BOARD
HV(G)
HV(B) 1000M
1000M
FV(B)
3000P
TO CB BOARD
TO CG BOARD
TO CR BOARD
B-SS510.<AEP>-E..-05
1
A
B
C
D
E
F
G
H
I
K
L
J
2 12 1311109876543 14 2221201918171615
R595
D522
1SS133T
62k:RN
Page 26
– 76 –– 75 –– 74 –– 73 –
Schematic diagram
? E board
Schematic diagram
D board /
1 2 3 4 5 6
7 8 9 10
4.9Vp-p (V) 4.6Vp-p (H) 1.5Vp-p (V) 1.5Vp-p (V)
57.5Vp-p (V) 0.7Vp-p (V) 0.7Vp-p (V) 4.6Vp-p (H) 4.8Vp-p (V) 5.0Vp-p (80MHz)
• D BOARD WAVEFORMS
IC1501 1 1.12 14.43 -13.14 -14.35 0.26 14.37 1.1
IC1502 1 GND2 03 04 0.15 0.16 0.18 GND9 0
10 0.111 -0.413 5.014 -4.9
IC1503 1 3.12 3.13 3.14 GND5 3.06 3.07 3.08 5.0
IC1602 1 02 23.03 04 20.55 -23.06 07 GND8 0
IC1603 1 4.12 9.03 4.14 GND5 0.66 07 08 0.6
IC1701 1 0.22 03 04 4.75 5.06 0.27 0.29 0.7
10 0.211 5.012 GND13 2.414 2.117 2.518 0.219 3.920 3.121 022 023 5.024 5.025 030 0.131 0
REF. NO. VOL.
D BOARD IC VOLTAGE LIST
32 034 0.135 0.136 2.837 2.838 5.039 5.040 GND42 4.944 4.845 4.846 4.447 4.748 4.349 2.250 2.351 2.352 2.0
IC1702 1 GND2 GND3 GND4 GND5 4.86 4.87 GND8 5.0
IC1703 1 3.92 03 GND4 -14.45 GND6 07 5.88 14.6
IC1704 1 0.32 03 GND4 -14.45 GND6 07 2.98 14.6
IC1706 2 GND3 GND4 4.95 5.0
IC1801 I 5.0G GNDO 7.0
IC1802 I 13.8G GNDO 9.1
IC1803 I 14.6G GNDO 12.1
IC1804 I 6.7G GNDO 5.0
IC1805 1 4.82 2.43 2.44 GND5 2.46 2.47 4.88 9.0
REF. NO. VOL.
•All voltage are in V.•Pin numbers which are not
described are not used.
REF. VOL.
B 0.7Q1501 E GND
C 0B 14.5
Q1502 E 14.6C 2.0B 0
Q1503 E GNDC 3.0B -0.5
Q1505 E 0.2C 14.4B 0.7
Q1601 E GNDC 0B 1.1
Q1602 E 0.6C 20.7B 0.7
Q1603 E GNDC 0B 0.3
Q1604 E GNDC 1.1B 0.8
Q1605 E GNDC 0.1B 0.3
Q1607 E GNDC 13.9B 0.3
Q1608 E GNDC 13.9B 0
Q1609 E GNDC 0.3B 13.9
Q1610 E 13.7C 0.1B 0
Q1611 E GNDC 0B 0.7
Q1612 E GNDC 0B 0.7
Q1613 E GNDC 0B 0.2
Q1614 E 0.8C 0.7B 0
Q1615 E 0C 0.2B 0
Q1616 E GNDC 0.2B 11.7
Q1617 E 11.8C 0.4
AII voltages are in V.
B 0.1Q1701 E 0.2
C 5.0B 0
Q1702 E 0.2C 5.0B 0
Q1703 E 0.2C 5.0B 0
Q1704 E 0C 5.0B 0
Q1705 E 0C 5.0B 0.2
Q1706 E GNDC 4.7B 0
Q1707 E GNDC 5.0B 4.9
Q1708 E 5.0C 0B 4.6
Q1710 E 4.7C 4.7B 4.6
Q1711 E 4.3C 4.0B 0
Q1801 E GNDC 0B 2.4
Q1802 E 1.8C 5.0B 5.0
Q1803 E 4.3C 9.0B 2.4
Q1804 E 1.7C 5.0B 5.0
Q1805 E 4.4C 9.0B 2.4
Q1806 E 1.8C 5.1B 5.1
Q1807 E 4.4C 9.0B 5.8
Q1808 E 6.4C 0.7B 0.7
Q1809 E GNDC 1.2
REF. VOL.
D BOARD TRANSISTOR VOLTAGE LIST
D BOARD : IC1702 ST24C08FM6TR
5V
9V
12V
-5V
STBY7V
12V
+B
7V
-5V
5V
STBY5V
7V
12V
15V12V
9V
5V
STBY5V
+B
5V
5V
9V
STBY5V
12V
12V
10
9
5V
15V
15V -15V
4
5
1
3
2
15V
-15V
12V
5V
12V
5V
+B
9V
STBY5V
8
7
6
AUDIO R
AUDIO L
AUDIO L/R
HP AUDIO R
HP AUDIO L
HP AUDIO R
HP AUDIO L/R
AUDIO R
AUDIO RAUDIO L
AUDIO L
AUDIO R
AUDIO L
AUDIO L
AUDIO R
AUDIO R
AUDIO L/R
AUDIO L/R(SP)
1 2 3 4 5 6 7
1
2
3
4
5
6
7
8
9
10
1 2 3 4 5 6 7 8
1
2
3
4
1
2
3
4
5
6
7
8
9
10
12
34
56
78
910
1112
1314
1516
1718
1920
2122
2324
2526 27
2829
3031
3233
3435
3637
3839
4041
4243
4445
4647
4849
5051
52
12
3 45
12
34 5
67
8
1
2
3
4
5
6
7
8
9
10
1
2
3
4
5
6
7
8
9
10
IOG
12
34 5
67
8
1 2 3 4 5 6 7 8 9 10
1
2
3
4
IOG
IOG
IOG
+-
+-
12
34 5
67
8
1 2 3 4 5 6 7 8
1 2 3 4
5678
1 2 3 4 5
1 2 3 4 5 6 7 8
1
50
25
26
1 2 3 4 5 6 7
891011121314
1
2
31 2 3 4 51 2 3 4 5 6 7 8 9 10
11
12
34 5
67
8 12
34 5
67
8
LR
1 2 3 4 5 6 7
1 2 3 4 5 6 7 8 9 10
11
12
131 2 3 4 5 6 7
1
D1502C1506
R1532
R1529
IC1602CN1604
C1607C1610 C1611
C1612
R1620
C1617 C1618
R1625 R1626
C1624
R1711R1713R1715
R1718
R1730 R1732
R1735
R1736
R1737
C1803 C1804
C1806 C1807
C1812
R1806
R1807 R1808R1810
R1811R1814
R1817R1818
R1819 R1820
CN1802 CN1803
CN1501
C1524
X1701
D1612
R1745
R1750
R1731
R1727
R1722
R1720
R1765
R1759
R1756
R1753
R1751
R1749
R1744
R1742
R1710
R1716
R1719
R1721
R1733
R1738
C1628
R1617R1611
R1608
R1801
D1801
D1802
D1803
D1804D1805
D1806
D1615
C1802
C1818
L1501
C1805
C1810
C1508
C1603
C1604
CN1605
C1601
C1602
C1509
C1706
C1819
C1820
C1619
R1602R1603
R1637
R1642
R1511
R1641
R1638
R1803
R1609 R1610
R1618
R1521
R1809
R1604
R1605
R1804
R1805
R1508
R1812
R1816R1815
C1816 C1817C1814
C1701 C1702 C1703 C1704R1729R1728
R1648
R1651
C1634 C1635
D1619
R1726
R1645 R1650
R1652
R1512D1501
D1503
R1513R1514
R1515
R1516
C1512R1517
R1534
C1507
R1507
L1702
C1710
C1711
C1709
D1703
D1704
C1707
D1705
C1811
C1808 C1809 C1821
L1801
IC1804
IC1802
R1538R1537
R1539C1526
D1614
TB1601
R1813
R1821
IC1803
C1717
C1721C1716
C1720
C1718
R1743
R1734
R1773
R1766
C1822
C1823
C1824
C1825 C1828
C1829
R1822
R1823 R1824
R1825 R1826
R1827
R1828
R1829
R1830
R1831 R1833
R1836
R1838 R1840
R1841
R1843 R1845
R1846
R1835
R1834
R1839
R1844
C1827
C1826
C1830
IC1805
Q1802
Q1804
Q1806Q1807
Q1805
Q1803
D1618
C1719
C1525
R1701
R1702
R1703
R1704
R1705
R1706 R1717
R1792 R1793 R1794 R1795
C1708
R1847
R1849
IC1801
R1531
C1516
C1501C1503
R1542
R1543
R1520
R1519
C1519
C1517
C1530 C1531C1518
IC1502
R1606R1607
C1613 C1614
R1601
R1631
C1621
R1649
R1629
R1762
R1725
R1755
R1712
R1714
CN1702
R1504
R1510
L1701
R1709 R1708 R1707
C1705
CN1601
IC1603
R1646
R1647
D1601
D1603
D1604
D1606
Q1708
Q1707
R1786
R1787
R1790
R1791
CN1708
R1788
D1504
CN1701
L1602L1601
CN1808CN1807
IC1701
R1764
C1529
R1509
R1502
C1523
R1518R1501
C1520 R1522
R1530
C1813 C1815
CN1606
CN1805
CN1703
CN1806
R1526
R1525
R1544
R1832
R1837
R1842
R1767
R1771R1769
R1636
R1644
R1635
R1639
C1632
R1632
C1633
D1505
D1611
D1613
C1626
R1630 R1634
R1640
R1653R1633
R1655
C1605
D1616
R1654
R1541
R1540
C1527
C1528
J1601
R1533
C1504
C1513 C1514C1521
L1802
C1606
C1715
D1706 D1707
R1768
R1775
R1770
D1708
R1772
L1502
L1503
CN1502
R1848
R1778
R1741
IC1706
C1622 C1627
D1617
D1620
D1621
D1622
R1763
CN1804
R1774
C1510 C1511
C1630
C1631
R1506
R1802
R1614 R1615
R1505
Q1601
Q1603
CN1801
Q1801
IC1703 IC1704
Q1503
Q1502
Q1501
Q1704
Q1705
Q1703 Q1702 Q1701
IC1702
R1754
R1757
R1760
Q1711
Q1710
Q1706
Q1808
Q1614
Q1612
Q1613
Q1610
Q1604 Q1605
Q1611
Q1602
Q1607
Q1609
R1643
Q1608
RY1602
RY1601
Q1616
Q1617
Q1615
IC1503
IC1501
Q1505
Q1809
470pB:CHIP
220
47pCH:CHIP
0.22100V:PT
100pCH:CHIP1
0.1 25V B:CHIP
10
10016V
10016V
1:MPS
10025V
4725V
4716V
0.01B:CHIP
0.001B:CHIP
0.001B:CHIP
0.1:PT
0.1:PT
0.1:PT 1 1
1
47 470.1:PT
0.1:PT
0.125V
B:CHIP
10025V
0.1:PT
10
2.2 22025V
1 1 10 10
100pCH:CHIP
100pCH:CHIP
0.01B:CHIP 470 16V 0.01
B:CHIP47p CH:CHIP
0.01B:CHIP
0.01B:CHIP
100
100
0.01B:CHIP
C17260.125V
B:CHIP
0.01B:CHIP
0.01B:CHIP
47016V
10
0.01B:CHIP
10025V
10
0.01B:CHIP
10025V
0.01B:CHIP
10025V
10
0.125V
B:CHIP
10 10
0.01B:CHIP
10
0.4725V
F:CHIP
100pCH:CHIP
0.4725V
F:CHIP
100pCH:CHIP
10025V
4725V
47 25V
47 25V
10
3PRED
:S-MICRO
5PBLK
:S-MICRO
4PWHT
:S-MICRO
4P:MINI
13PWHT
:S-MICRO
11PRED
:S-MICRO
10PWHT
:S-MICRO
MTZJ-5.6B
GP08D
GP08D
1SS133T
1SS133T
1SS133T
1SS133T
1SS133T
MTZJ-5.6B
MTZJ-5.6B
MTZJ-5.1
D1709RD4.7ES
D1710RD4.7ES
D1712RD4.7ES
D1711RD4.7ES
MTZJ-9.1
MTZJ-9.1
MTZJ-9.1
MTZJ-9.1MTZJ-9.1
MTZJ-9.1
CA0007AM
TDA7264AUDIO MAIN AMP
LM2940CT-5.0STBY 5V REG
PQ09RF29V REG
PQ05RF115V REG
NJM4558MMIXING
8.2µH:LHL08
10µH:EL0606
3.9µH :EL0606
10µH:EL0606
2SC2412KMIXING
2SC2412KBUFF
2SC2412KMIXING
2SC2412KBUFF
2SC2412KMIXING
2SC2412KBUFF
10k:RN-CP
22k:CHIP
10k:RN-CP
2.2k:CHIP
33k:CHIP
1k:CHIP
10k:CHIP
10k:CHIP
10k:CHIP
10k :CHIP
47k :CHIP100k:CHIP
100:CHIP
47k :CHIP
100:CHIP
47k:CHIP
10k:CHIP
27k:CHIP
10k:CHIP
68k:CHIP
68k:CHIP
100:CHIP
470:CHIP
470:CHIP
470k:CHIP
470k:CHIP
22k:CHIP
22k:CHIP
6.8k:CHIP
22k:CHIP
4.7k:CHIP
3.3k:CHIP
3.3k:CHIP
1k:CHIP
1k:CHIP
10k:CHIP
4.7k:CHIP 1k
:CHIP
470:CHIP
47k:CHIP
220:CHIP
120k:CHIP
4.7k:CHIP
4.7k:CHIP
4.7k:CHIP
4.7k:CHIP
4.7k:CHIP
4.7k:CHIP
100:CHIP
100:CHIP
100:CHIP
1k :CHIP47k:CHIP
10k :CHIP
47k:CHIP
10k :CHIP
47k:CHIP
220 :CHIP
47k:CHIP
2.2k:CHIP
220 :CHIP 220 :CHIP
220 :CHIP 220 :CHIP4.7k:CHIP
0 :CHIP 220 :CHIP
100:CHIP
100:CHIP
2.2k:CHIP
220 :CHIP1k
:CHIP
1k :CHIP
1k :CHIP
47k:CHIP
220:CHIP
220:CHIP
100 :CHIP
220 :CHIP 100 :CHIP
220 :CHIP 10k :CHIP
220 :CHIP 10k :CHIP
220 :CHIP
10k :CHIP
100:CHIP
10k :CHIP
10k :CHIP
4.7k:CHIP
10k :CHIP
1k:CHIP
10k:CHIP
47k:CHIP
47k:CHIP
47k:CHIP
47k:CHIP
JW(5)
10k:CHIP
470k:CHIP
470k:CHIP82
:CHIP
2.7k:CHIP
2.7k:CHIP100k
:CHIP82
:CHIP
100:CHIP
100:CHIP
1k:CHIP
82:CHIP
100:CHIP
100:CHIP
100:CHIP2.7k
:CHIP
2.7k:CHIP
2.7k:CHIP 100
:CHIP
47k:CHIP
47k:CHIP
47k:CHIP
47k:CHIP
47k:CHIP
47k:CHIP
47k:CHIP
47k:CHIP
10k:CHIP
3.9k:CHIP
470:CHIP
1k:CHIP
1k :CHIP
1k :CHIP
470:CHIP
1k:CHIP
1k :CHIP
1k :CHIP
470:CHIP
1k:CHIP
1k :CHIP
1k :CHIP
220:CHIP
680:CHIP
CST8.0MTW
0.1100V:PT
1SS133T
1SS133T
1SS133T
1SS133T
DTC144EKA
100:CHIP
100:CHIP
100:CHIP
1SS133T
7PWHT
:S-MICRO
TDA2822MHP/VAR AMP
DTA144EKA
0.1 1/2W :RF
0.1 1/2W :RF
100:CHIP
100:CHIP
8PRED
:S-MICRO
7PRED
:S-MICRO
8PWHT
:S-MICRO
CXP86213-003SPJ ENGINE
4.7k:CHIP
6.8k:RN-CP
6.8k:RN-CP
47p
C15321
CH:CHIP
2.21W:RS
2.21W:RS
10 47k:CHIP
100k :CHIP
27k:CHIP
27k:CHIP
470k:CHIP
470k:CHIP
560k:CHIP
R1748100
:CHIP
R1758100
:CHIP
R1752100
:CHIP
R1747100
:CHIP
2200p CH:CHIP
4725V
4725V
47p CH:CHIP
22k:CHIP
1k :CHIP
12k :CHIP
1k :CHIP 12k :CHIP
10k:CHIP
1k:CHIP
1k:CHIP
1k:CHIP
0.1:PT
1SS133T
22025V
22025V
10P:BTOB-S
10P:BTOB-S
10P:BTOB-S
10PWHT
:BTOB-S
1SS355TE-17
MTZJ-13
MTZJ-13
JW(5)
22k:CHIP
47k:CHIP
47k:CHIP
22k:CHIP
100:CHIP
1k:CHIP
1k :CHIP
R16560
:CHIP
10k:CHIP
22:BP
1500pCH:CHIP
1500pCH:CHIP
56k:CHIP
R15281M
:CHIP
R15271M
:CHIP
56k:CHIP
2200p CH:CHIP
470pCH:CHIP
470pCH:CHIP
0.01B:CHIP
0.01B:CHIP
0.01B:CHIP
0.01B:CHIP
MTZJ-5.1 MTZJ-5.1
1k:CHIP
560k:CHIP
1k:CHIP
MTZJ-5.1
1k:CHIP
0.01B:CHIP
1P:FASTON
1k:CHIP
PST9143NLRESET
JW(5)
JW(5)
JW(5)
220:CHIP
5PWHT
:S-MICRO
2200pCH:CHIP
C1650100p
CH:CHIP
C1651100p
CH:CHIP
2200pCH:CHIP
MA3240-TX
MA3240-TX
MA3240-TX
MA3240-TX
L7812CV12V REG
220:CHIP
3.9k:CHIP
100:CHIP
1000 1000
2200
2200
2202W:RS
22k 3W :RS
4.71W:RS
4.71W:RS
0.47:FPRD
1.5:FPRD
0.47:FPRD
22:FPRD 22
:FPRD
4.7k:FPRD
4.7k:FPRD
4.7:FPRD
1:FPRD
DTC143TKAMUTE
DTC143TKAMUTE
50P:BTOB
2SC2412KMUTE
µPC4558G2 µPC4558G2BUFF BUFF
2SC2412KPROT
2SA1037KPROT
2SC2412KINV
2SC2412KBUFF
2SC2412KBUFF
2SC2412KBUFF
2SC2412KBUFF
2SC2412KBUFF
M24C08-MN6TNVM
10k:CHIP
10k:CHIP
10k:CHIP
2SC2412KSW
2SC2412KSW
2SC2412KINV
2SA1037KBUFF
2SA1037KMUTE SW
DTC143TKAMUTE
DTC143TKAMUTE
2SA1037KMUTE DRIVE
DTC143TKASW
DTC143TKAMUTE
DTC143TKAMUTE
2SC2412KMUTE
2SC2412KRELAY DRIVE
DTC144EKARELAY CONT
10k:CHIP
2SC2412KRELAY DRIVE
2SC2412KDET
2SA1037KSW
2SC2412KDET
LM358DBUFF
STV9379V OUT
2SC2412KBUFF
2SC2412KINV
+15V
-15V
STBY 5V
9V
STBY 7V
+12V
135V
+15V
LUMI/HP MUTE
135V
C17240.125V
B:CHIP
C17250.125V
B:CHIP
HPSW
ABL
VD-
S3
S2
S1
S0
CEB
RMUTE
DATA
CLK
HP
VP
BW
VC
YM
YS
SCL
SDA
FS
YM
YS B G R
SPSW
VD+
VP
HD
HP
PIN
ABL
RW
BW
CLK
RMUTE
VC
DATA
VP
PIN
HD
VP
HP
ABL
L
P.CONT
R
SPSW
MUTE
L
SPSW
R
PROT1
HPL
HPSW
MUTE
HPL
SIRCS
LED G
KEY1
LED R
LED G
LED R
KEY1
HPR
HPR
P.CONT
VD-
VD+
YM1
YS1
S0
S1
S2
S3
PROT1
PROT1
A.REGI/KEY2
A.REGI/KEY2
SL
SR
FL
FR
FV
FY
FC
C3
Y3
V3
FY
FC
FV
FL
FR
M3
V OUT
R OUT
L OUT
R3
L3
V3
C3
Y3
SL
SR
L OUT
R OUT
L3
R3
M3
V OUT
SDA
SCL
FV
FV
RGB
YS1
YM1
SCLN
FS
SDAN
SDAN
SCLN
FS
SDA
SCL
SIRCS
VBLK
VBLK
VCC
FLY
GEN
L OUT
R OUT
-5V
P.CONT
E
STBY 7V
12V
NC
135V
RV WAVE
BV WAVE
CLK
MUTE
DATA
CEB
VP
HD
HP
PIN
ABL
-15V
+15V
V DEF
NC
V RET
I-VP
I-50/100
O-CEB
O-MUTE
O-DATA
O-CLKN
I-HBLK
I-VBLK
I-RESETN
VSS
O-XTAL
I-EXTAL
I-SENS3
I-SENS2
I-SENS1
I-SENS0
I-ADR1
I-ADR0
I-NORM/WIDE
I-60/MULTI
O-HSHIFT
I-SCLN0
IO-SDA0
O-SDA10
I-SDA1I
I-SCLN1
VSS
VDD
I-EOSC
O-OSC
O-YM
O-YS
O-I
O-B
O-G
O-R
XLC
RESETGND
A0
A1
A2
GND
VDD
BCLK
BDAT
12V
FS
PJE YM
PJE YS
PJE B
PJE G
PJE R
SP SW
SCL
SDA
V OUT
E/W
V+OUT
H DRIVE
V-SYNC
HFBP
EHT
ABL
PROT
9V
33V
STBY 5V
SIRCS
SPKRR
STBY LED
KEY 1
VM OUT
MUTE
RIN
LIN
VIN
CIN
YIN
SPKRL
+VCC
MUTE
-VCC
GND
R
L
O-VSHIFT
O-B WAVE
O-R WAVE
I-FS
GND
GND
GND
GND
GND
GND
GND
5V
GND
GND
GND
GND
GND
GND
GND
H/P R
H/P L
S3/GND
NC
VAR OUT
HP L
HP R
FRONT Y
FRONT C
GND(V3)
FRONT V
GND(V3)
FRONT L
GND(V3)
FRONT R
GND(V3)
FRONT S
LED G
LED R
STBY 5V
KEY1
GND(KEY)
SIRCS
+5V
GND(KEY)
135V
NC
9V
GND
VM
GND(AU)
GND(AU)
GND
GND
GND
GND
GND
GND
GND
GND
GND
CENTER SP IN / SURROUND OUT
POWER MONI
AUDIO+
AU GND
AUDIO-
D
GND
GND
GND
GND
GND(V3)
GND
MUTE
UPPER
LEFT
RIGNT
LOWER
GND
GND
GND
GND
7V
PROT1
LUMI
A.REGI/KEY2
P.CONT
GND
5V
CVBS OUT
MODE3/POW LED
A.REGI/KEY2
R OUT
L OUT
L IN
GND
GND
GND
GND
GND
GND
R IN
L OUT
R OUT
CVBS/Y IN
CVBS OUT
MODE
C IN
GND
L
R
O-FV
I-NORM/LINE
50-60
HV DET
GND
GND
GND
SCL
SDA
FS
SCL N
SDA N
GND
LUMI/HP MUTE
GND
VBLK
GND
VBLK
TO UE BOARD CN2702 TO UE BOARD CN2701 TO H2 BOARD CN3204
TO AE(2/2) BOARDCN1
TO H2 BOARD CN3202 TO H1 BOARD CN3002 TO ZG BOARD CN1431 FOR CHECK TO PHOTO SENSER TO AE(2/2) BOARD CN6
AUDIO AMP,HP AMP,V OUT,PJ ENGINE
TO SPEAKER
TO E BOARD CN506
TO ZR BOARD CN1403
TO E BOARD CN508
TO E BOARD CN804
TO E BOARD CN652
TO E BOARD CN651
TO G BOARD CN6012
B-SS510.<AEP>-D..-05
RW
C17270.125V
B:CHIP
CEB
1 2
R1746
CN1705
100:CHIP
2PRED
:S-MICROPJERST
NC
1
A
B
C
D
E
F
G
H
I
K
L
M
N
O
P
J
2 12 1311109876543 14 2221201918171615
Page 27
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
– 82 –– 81 –– 80 –
REF. VOL.
B 1.0Q1431 E 0.5
C 68.6B 134.5
Q1432 E 134.9C 68.6B 5.9
Q1434 E 6.1C GNDB 6.5
Q1435 E 6.1C 9.0B 2.2
Q1435 E 1.6C 5.9B 2.2
Q1436 E 1.6C 9.0
ZG BOARD TRANSISTORVOLTAGE LIST
AII voltages are in V.
ZR [DY/VM]
– ZR Board –
– ZG Board –
ZG [DY/VM]
1
2
3
4
1
2
3
1
2
3
4
5
6
7
1
2
3
4
VM.RET
VM.IN
V.RET
V(MID)V.DEF
H.RETV.RET
V.IN
H.IN
H-
H(MID)
H+
CN1404
CN1403
CN1401
CN1405
R1418R1415
R1402
R1401
DY1401
7PWHT
:S-MICRO
3PRED
:S-MICRO
4PRED
:S-MICRO
4P:VH
560
560
1203W
R14031803W:RS
1203W
R-H(+)
NC
R-H(-)
HR.RET
V.DEF
V.RET
NC
ZR
NC
NC
VM.RET
NC
NC
VR.IN
VR.RET
HR.IN
VM.IN
V.OUT
V.IN
SUB DY
DY(V)
VM
DY(H)
(DY/VM)
TO E BOARD CN504
TO D BOARD CN1501
TO ZG BOARD CN1432
TO E BOARD CN801
B-SS510.<AEP>-ZR.
1
A
B
C
D
E
F
G
H
2 12 1311109876543
9V
135V
1
2
3
4
1
2
3
4
5
6
7
1
2
3
4
1
2
3
4
5
VM.RET
VM.IN
V.RET
V(MID)V.DEF
H.RETV.RET
V.IN
H.IN
H-
H(MID)
H+
1 2 3 41234
1
2
3
R1437
R1440
C1436
C1437
R1455
R1435 R1436
R1432
CN1433
CN1434
CN1432
CN1431
R1443L1431C1439
C1446C1444
C1438
R1433
R1450
R1458
C1445
Q1431
C1434
R1439
R1438
R1457
C1435
D1431
D1432
C1433
R1456
Q1432
R1452
R1453
R1454
R1459
L1432
C1443
D1433R1442C1440
R1445 R1449
R1451
CN1464
SJ1461
R1462
R1461
R1468
R1465
CN1462
CN1461
R1431
R1463
R1448
R1441
DY1431Q1434
Q1433
Q1435
Q1436C1441
0.1200V:PT
0.0047200V:PT
2.2160V
0.001:PT
0.001:PT
C14500.001:PT
0.0047200V:PT
0.0047500V:E
4725V
47016V
47160V
10016V
10016V
5PWHT
:S-MICRO
7PWHT
:S-MICRO
4PWHT
:S-MICRO
4P:VH
3PWHT
:S-MICRO
4PBLK
:S-MICRO
CN14361P
:FASTON
4PBLK
:S-MICRO
MTZJ-T-39DC.BIAS
MTZJ-T-39DC.BIAS
1SS133
47µH:FLR50
JW(5)
2SC4793VM.DRIVE2
2SA1837VM.DRIVE1
560
560
1203W
1203W
560
18k:RN
18k:RN
220
68 68
1k
220
1k
47
391/2W:FPRD
1803W:RS
560
560
1203W:RS
1203W:RS
JW(5)
1k
R1444220
JW(5)
0.47:FPRD560
:FPRD
220
0.47:FPRD
1.8:FPRD
1k:FPRD
1.8:FPRD
39:FPRD
2SC3311AVM CONT
2SA1309AVM CONT
2SC3311ABUFF
2SC3311ABUFF 0.1
100V:PT
NC
NC
NC
NC
NC
G-H(+)
G-H(-)
HG.IN
VG.IN
VG.RET
HG.RET
ZG
VM
E
135V
NC
9V
V.IN
V.OUT
VM.RET
VM.OUT
SUB DY
DY(V)
VM
DY(H)
V.DEF
V.MID
V.RET
T0 V DY(B)
HB.IN
VB.IN
VB.RET
HB.RET
HB.IN
VB.IN
VB.RET
HB.RET
1GND
T0 SUB DY(B)
(DY/VM)
T0 E BOARD CN803
T0 ZR BOARD CN1401
TO D BOARD CN302
T0 E BOARD CN802
T0 E BOARD CN503
B-SS510.<AEP>-ZG.-05
Page 28
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
9V
200V
4
1
2
3
R
R
R
R
R
G
B
B
G
1
2
3
4
5
6
7
8
9
1
1
2
3
4
5
6
7
4
5
6789
10
11
12
1
FGND
G1
G1
H(+)
KNCG2
NC
GND
H(-)
1
2
3
4
5
6
7
8
R704
SG703
SG702R715
SG701
CN701
CN706
R709R701
CN704
R707
TP701
L701
C712D704
C708
D705 D706
C710
C705 C709
R711
CN702D708
CN703
R708
R718
R721
R714
R710
C702
L702
R720
R706
R716
C703
C713R723
R722
R717 D709
R719
Q705
Q706
Q704
Q703
Q701
CN705
100p
330p2kVB
470pB
22250V
:FASTON
8PWHT
:S-MICRO
7PRED
:S-MICRO
1PWHT:MINI
9PWHT
:S-MICRO
1SS133
1SS133 1SS133
1SS133
D7011SS133
470µH:FLR50
1001/2W:RC
560k1/2W
100
330
1k1/2W10k
3W:RS
680k1/2W
47k
4.7k
4725V
4725V
MTZJ-5.1
390pB
100µH:EL0606
10
33k
0.0012kVE
4.7k
1k1/2W:RC
220
1001/2W:RC
33k1/2W:RC
22k
47k
2SA1309ABUFF
2SA1309AIK DET
2SC3311AR OUT
2SC2611-15R OUT
2SA1091IK DET
G
CRTO FOCUS BLOCK
NC
H(-)
H(+)
NC
E
NC
200V
R/S
B
E
9V
E
NC
G2
TO FOCUS BLOCK
IKG
IKB
R
G
B
9V
E
IK
E
E
TO CG BOARD CN736
TO CG BOARD CN733
(R OUT)
HV.BLOCK6
7H
8K
4 10G4G2G1
G3 G5
V901PICTURETUBE
1,2
07MXC(R)
TO AE(2/2)BOARD
CN301
B-SS510.<AEP>-CR.-05
1
A
B
C
D
E
F
G
H
I
J
2 12 1311109876543 14 15
3
200V
9V
1
2
G
G
G
GB
G
B
1
2
3
4
5
6
7
8
9
1
2
3
4
5
6
7
8
9
1
2
3
4
5
1
2
3
4
5
6
7
8
4
5
6789
10
11
12
1
FGND
G1
G1
H(+)
KNCG2
NC
GND
H(-)
1
R732
C733
SG733
SG732SG731
CN737
R737R731
CN736
TP733
TP732
R735
TP731
CN734
L731C737
D731
C738
D735
C739
D732
C734
C740
C735R733
CN733
R739C736
CN732
D733
D736
R738
R745
R740
R746
R736
R741
L732
R742
R744
Q731
Q732
Q733
CN731
CN735
0.0012kVE
470pB
0.0047500VE
330p2kVB
22250V
100p
4725V
470pB
5PWHT
:S-MICRO
8PWHT
:S-MICRO
1PWHT:MINI
9PWHT
:S-MICRO
9PWHT
:S-MICRO
1SS133
1SS133 1SS133
1SS133
1SS133
470µH:EL0606
100µH:EL0606
1001/2W:RC
560k1/2W
10k3W:RS
100
4.7k
1k1/2W
180
680k1/2W
1k1/2W:RC
10
220
330k3.3k
33k1/2W:RC
2SA1091IK DET
2SC2611-15G OUT
2SC3311AG OUT
:FASTON
G
TO FOCUS BLOCK
NC
H(-)
H(+)
NC
E
NC
200V
R/S
B
E
9V
NC
H(-)
H(+)
NC
E
NC
200V
R/S
CG
NC
NC
G2
E
B
E
IKB
9V
IKG
E
IKB
TO FOCUS BLOCK
E
(G OUT)
TO CR BOARD CN702
TO CB BOARD CN762
TO CB BOARD CN765
TO CR BOARD CN706
HV.BLOCK6
7H
8K
4 10G4G2G1
G3 G5
V902PICTURETUBE
1,2
07MXC(G)
B-SS510.<AEP>-CG.-05
– 84 – – 85 –– 83 –
REF. VOL.
B 160.9Q701 E 156.9
C 11.3B 9.0
Q703 E 8.5C 160.9B 1.8
Q704 E 1.2C 8.5B 3.4
Q705 E 3.2C GNDB 5.7
Q706 E 10.9C 3.4
CR BOARD TRANSISTORVOLTAGE LIST
AII voltages are in V.
REF. VOL.
B 150.4Q731 E 144.4
C 11.5B 9.0
Q732 E 8.5C 150.4B 1.8
Q733 E 1.3C 8.5
CG BOARD TRANSISTORVOLTAGE LIST
AII voltages are in V.
1 1 2 2
3 3 4 4
93.0Vp-p (H) 112.0Vp-p (H)
3.7Vp-p (H) 4.3Vp-p (H) 3.6Vp-p (H) 3.7Vp-p (H)
3.5Vp-p (H) 3.7Vp-p (H)
• CR BOARD WAVEFORMS
PAL/SECAM NTSC PAL/SECAM NTSC
PAL/SECAM NTSC PAL/SECAM NTSC
1 1 2 2
3 3
3.4Vp-p (H) 3.7Vp-p ( ) 3.5Vp-p (H) 3.7Vp-p (H)
121.0Vp-p (H) 138.0Vp-p (H)
• CG BOARD WAVEFORMS
PAL/SECAM NTSC PAL/SECAM NTSC
PAL/SECAM NTSC
Schematic diagrams
CB UE boards /
Schematic diagrams
? CG CR boards
CR [R OUT]
– CR Board –
– CG Board –
CG [G OUT]
Page 29
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
200V
2
1
9V
B
B
B
B
1
2
3
4
5
6
7
8
9
4
5
6789
10
11
12
1
FGND
G1
G1
H(+)
KNCG2
NC
GND
H(-)
1
2
3
4
5
6
7
8
9
10
1
1
2
3
4
5
R762
C766 R768
CN766SG763
SG761 SG762C763
R761 C767 L761R766
R765
C768
D761
C769
TP761
CN765
CN763
D762 D763
C770
C765R763
C764
R770
R777
R776
C762
C771
R773
R775
D766
SW
R778
R769
R772
R767
L762
CN762
R779
R771
D765
Q761
Q762
Q763
Q764
CN761
CN764
10
330pB
0.0047500VE
330p2kV:B
22250V
100p
4725V
470pB
1PWHT:MINI
9PWHT
:S-MICRO
10PWHT
:S-MICRO
1SS133
1SS133 1SS133
470µH:EL0606
1001/2W:RC
560k1/2W
10k3W:RS
100
1k1/2W
680k1/2W
270
390
10k 47k
R774470k
6.8k
1SS133T-1710pCH
100µH:EL0606
10
220
0.0012kVE
5PWHT
:S-MICRO
4.7k
1k1/2W:RC
1001/2W:RC
33k1/2W:RC
1SS133
2SA1091IK DET
2SC2611-15B OUT
2SC3311AB OUT
2SA1309APROT
:FASTON
TO FOCUS BLOCK
E
NC
H(-)
H(+)
NC
E
NC
200V
R/S
B
E
NC
H(-)
H(+)
NC
E
NC
200V
R/S
B/S
CB
NC
NC
G2
IKB
9V
TO FOCUS BLOCK
TO E BOARD CN501
TO CG BOARD CN737
(B OUT)
TO CG BOARD CN732
HV.BLOCK6
7H
8K
4 10G4G2G1
G3 G5
V903PICTURETUBE
07MXC(B)
1,2
B-SS510.<AEP>-CB.-05
1
A
B
C
D
E
F
G
2 12 1311109876543 14
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
R2704
R2705
R2709
R2710
R2711
R2712
C2701
C2702
C2703
C2704
C2706
C2707
C2708
C2709
C2710
R2715
R2716
R2717
R2718
D2701
D2702
D2703
D2704
D2705
D2706
D2707
D2708
R2708
R2702
CN2703
R2703
CN2701
CN2702
R2706
R2707
C2705
470pCH:CHIP
0.01B:CHIP
470pCH:CHIP
0.01B:CHIP
10
10
4716V
10
4716V
21PSCART
UDZ-9.1B
UDZ-9.1B
UDZ-9.1B
UDZ-9.1B
UDZ-9.1B
UDZ-9.1B
UDZ-9.1B
UDZ-9.1B
75:CHIP
220:CHIP
390:CHIP
390:CHIP
#:CHIP
470k:CHIP
47k:CHIP
470k:CHIP
47k:CHIP
100:CHIP
0:CHIP
100:CHIP
0:CHIP
91:CHIP
82:CHIP
22016V
7PRED-L
:S-MICRO
8PWHT-L
:S-MICRO
R OUT
R IN
L OUT
MODE
C IN
CVBS OUT
CVBS IN
L IN
GND
GND
CVBS OUT
GND
C IN
GND
MODE
L IN
GND
R IN
GND
L OUT
GND
R OUT
CVBS/Y IN
UE(AV-INPUT/OUTPUT)TO D BOARD CN1808
TO D BOARD CN1807
B-SS510.<AEP>-UE.
– 88 –– 87 –– 86 –
1 1 2 2
3.5Vp-p (H) 3.8Vp-p ( ) 105.0Vp-p (H) 116.0Vp-p (H)
• CB BOARD WAVEFORMS
PAL/SECAM NTSC PAL/SECAM NTSC
REF. VOL.
B 155.2Q761 E 149.4
C 9.4B 9.0
Q762 E 8.5C 155.2B 1.7
Q763 E 1.2C 8.5B 1.1
Q764 E 1.2C GND
CB BOARD TRANSISTORVOLTAGE LIST
AII voltages are in V.
6-5. SEMICONDUCTORS
CA0007ADNJM2058DRC4560DTDA2822MTDA7264
8pin
CA0007AMM24C32-MW6TM24C08-MN6TµPC4558G2
8pin
CXA1315MMC14052BDR2
16pin
CXA2076Q-TL
64pin
CXD2024AQ-T4SDA30C263-GEG
80pin
CXD2044Q-TL
CXP86213-001S
52pin
IR2112µPC339C
14pin
IR3M02ATDA4665T/V5-118
16pin
MC14066BF
14pin
MSP3410D-PS-B4-T-NDSDA5273CP-GEGSDA5273-3CP
68pin
1
TOP VIEW
NJM7805FANJM7905FA
PA0053B
18pin
PQ09RF2TA7812SµPC2405HF
PST593C-MMP-4PPST9143NL
4pin
SBX1981-51
TOP209D
8pin
DTA144EK-T146DTC143TKA-T146DTC144EK-T1462SA1037K-T-146-R2SA1162G2SC1623-L5L62SC2412K-QR
DTC144ESA-TP
2SC4632LS-CB72SD2539 (LBSONY-1)
PM0002B
42pin
PQ05RF11
PC123F2
STV9379
STK392-150
18pin
TDA8395T/N3
32pin
M27C2001-12C1RW402
1
TOP VIEW
20pin
SE135N
2SA1175-HFE2SC2785-HFE
BC
E
2SC5022-02
2SC2611-152SC2688-LK
2SB734-34
2SA12082SC1091-O
CB [B OUT]
– CB Board –
UE [AV-INPUT/OUTPUT]
– UE Board –
Page 30
– 89 –
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
EL1ZGP08DMTZ-T-77-9.1AS2L40FUF4005PKG23
ERC06-15SERD29-08JS2LA20F
DTZ33BDTZ6.8BDTZ9.1RD5.6S-BUDZ-TE-17-6.8B1SS355TE-17
D6SB6OLRBA-406B
MA3030-H(TX)
MA3240-TX
MTZJ-13MTZJ-30BMTZJ-7.5BRD13ES-B2RD20ES-B2RD3.6ES-B1RD39ES-B2RD4.7ESB2RD4.7ES-TIBRD5.1ES-B1RD5.1ES-B2RD5.6ES-B2RD7.5ES-B21SS119-251SS133T-77
SLA-580LT3F
U05G
D2S4MD4SBS4-F
D10SC6M-4012
IRFI744G-LF
BAS216
CATHODE
ANODE
2SK2251-01-F119
Page 31
– 93 –
The componants identified byshading and mark are criti-cal for safety.Replace only with part numberspecified.
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK
C122 1-163-137-00 CERAMIC CHIP 680pF 5% 50V C123 1-163-113-00 CERAMIC CHIP 68pF 5% 50V C124 1-163-038-00 CERAMIC CHIP 0.1µF 25V C125 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C126 1-126-933-11 ELECT 100µF 20% 16V
C127 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C128 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C129 1-163-089-00 CERAMIC CHIP 6pF 0.5pF 50V C130 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C131 1-104-664-11 ELECT 47µF 20% 16V
C132 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C133 1-126-963-11 ELECT 4.7µF 20% 50V C134 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C135 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C136 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V
C137 1-104-664-11 ELECT 47µF 20% 16V C138 1-126-964-11 ELECT 10µF 20% 50V C139 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C143 1-104-664-11 ELECT 47µF 20% 16V C144 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V
C145 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C146 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C147 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C148 1-126-933-11 ELECT 100µF 20% 16V C149 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V
C150 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C151 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C152 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V C153 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V C154 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V
C155 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C201 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V C202 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V C203 1-104-661-91 ELECT 330µF 20% 16V C204 1-163-038-00 CERAMIC CHIP 0.1µF 25V
C205 1-126-965-11 ELECT 22µF 20% 50V C206 1-163-275-11 CERAMIC CHIP 1000pF 5% 50V C207 1-126-964-11 ELECT 10µF 20% 50V C208 1-126-965-11 ELECT 22µF 20% 50V C209 1-126-964-11 ELECT 10µF 20% 50V
C210 1-216-295-00 SHORT 0 C211 1-126-965-11 ELECT 22µF 20% 50V C212 1-164-346-11 CERAMIC CHIP 1µF 16V
AENOTE:
• The components identified by in this manual havebeen carefully factory-selected for each set in order tosatisfy regulations regarding X-ray radiation. Shouldreplacement be required, replace only with the valueoriginally used.
• Items marked " * " are not stocked since they are seldomrequired for routine service. Some delay should beanticipated when ordering these items.
• All variable and adjustable resistors have characteristiccurve B, unless otherwise noted.
RESISTORS• All resistors are in ohms• F : nonflammable
• CAPACITORSPF : µµ F
• There are some cases the reference number onone board overlaps on the other board. Therefore,when ordering parts by the reference number,please include the board name.
SECTION 8
ELECTRICAL PARTS LIST
* A-1298-318-A AE BOARD, COMPLETE*****************************
(KP-41S5/41S5B/41S5U)* A-1298-455-A AE BOARD, COMPLETE (KP-41S5G)
*****************************
* A-1298-456-A AE BOARD, COMPLETE (KP-41S5K)*****************************
* A-1298-457-A AE BOARD, COMPLETE (KP-41S5R)*****************************
1-750-797-11 SOCKET, PLCC
<CAPACITOR>
C1 1-163-038-00 CERAMIC CHIP 0.1µF 25V C2 1-104-664-11 ELECT 47µF 20% 16V C3 1-163-239-11 CERAMIC CHIP 33pF 5% 50V C4 1-163-239-11 CERAMIC CHIP 33pF 5% 50V C8 1-163-038-00 CERAMIC CHIP 0.1µF 25V
C10 1-163-243-11 CERAMIC CHIP 47pF 5% 50V C11 1-163-243-11 CERAMIC CHIP 47pF 5% 50V C14 1-163-038-00 CERAMIC CHIP 0.1µF 25V C15 1-163-133-00 CERAMIC CHIP 470pF 5% 50V C18 1-163-038-00 CERAMIC CHIP 0.1µF 25V
C19 1-163-017-00 CERAMIC CHIP 0.0047µF 10% 50V C20 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C21 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C22 1-163-251-11 CERAMIC CHIP 100pF 5% 50V C24 1-163-275-11 CERAMIC CHIP 1000pF 5% 50V
C25 1-104-664-11 ELECT 47µF 20% 16V C26 1-104-664-11 ELECT 47µF 20% 16V C43 1-163-121-00 CERAMIC CHIP 150pF 5% 50V C45 1-163-038-00 CERAMIC CHIP 0.1µF 25V C90 1-163-038-00 CERAMIC CHIP 0.1µF 25V
C101 1-163-038-00 CERAMIC CHIP 0.1µF 25V C102 1-126-934-11 ELECT 220µF 20% 16V C103 1-126-965-11 ELECT 22µF 20% 50V C104 1-163-251-11 CERAMIC CHIP 100pF 5% 50V C110 1-104-664-11 ELECT 47µF 20% 16V
C112 1-163-275-11 CERAMIC CHIP 1000pF 5% 50V C113 1-104-664-11 ELECT 47µF 20% 16V C115 1-163-263-11 CERAMIC CHIP 330pF 5% 50V C120 1-163-251-11 CERAMIC CHIP 100pF 5% 50V C121 1-163-113-00 CERAMIC CHIP 68pF 5% 50V
REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK
When indicating parts by reference number,please include the board name.The componants identified by
shading and mark are criti-cal for safety.Replace only with part numberspecified.
Page 32
– 94 –
The componants identified byshading and mark are criti-cal for safety.Replace only with part numberspecified.
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK
C302 1-163-275-11 CERAMIC CHIP 1000pF 5% 50V C303 1-163-275-11 CERAMIC CHIP 1000pF 5% 50V C304 1-163-038-00 CERAMIC CHIP 0.1µF 25V C305 1-163-038-00 CERAMIC CHIP 0.1µF 25V C306 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V
C307 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C308 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C309 1-164-346-11 CERAMIC CHIP 1µF 16V C310 1-164-346-11 CERAMIC CHIP 1µF 16V C311 1-164-346-11 CERAMIC CHIP 1µF 16V
C312 1-164-505-11 CERAMIC CHIP 2.2µF 16V C313 1-163-275-11 CERAMIC CHIP 1000pF 5% 50V C315 1-216-295-00 SHORT 0 C316 1-163-239-11 CERAMIC CHIP 33pF 5% 50V C317 1-163-038-00 CERAMIC CHIP 0.1µF 25V
C320 1-126-965-11 ELECT 22µF 20% 50V C321 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C322 1-163-038-00 CERAMIC CHIP 0.1µF 25V C323 1-163-038-00 CERAMIC CHIP 0.1µF 25V C324 1-163-038-00 CERAMIC CHIP 0.1µF 25V
C325 1-164-346-11 CERAMIC CHIP 1µF 16V C326 1-163-275-11 CERAMIC CHIP 1000pF 5% 50V C327 1-137-374-11 FILM 0.047µF 5% 50V C328 1-126-964-11 ELECT 10µF 20% 50V C330 1-130-777-00 FILM 0.1µF 5% 63V
C331 1-137-581-11 FILM 0.1µF 5% 100V C332 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C333 1-126-933-11 ELECT 100µF 20% 16V C334 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C335 1-164-005-11 CERAMIC CHIP 0.47µF 25V
C336 1-163-009-11 CERAMIC CHIP 0.001µF 10% 50V C337 1-163-009-11 CERAMIC CHIP 0.001µF 10% 50V C338 1-126-962-11 ELECT 3.3µF 20% 50V C339 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C340 1-126-933-11 ELECT 100µF 20% 16V
C341 1-164-005-11 CERAMIC CHIP 0.47µF 25V C342 1-164-346-11 CERAMIC CHIP 1µF 16V C343 1-163-017-00 CERAMIC CHIP 0.0047µF 10% 50V C344 1-163-251-11 CERAMIC CHIP 100pF 5% 50V C347 1-126-963-11 ELECT 4.7µF 20% 50V
C348 1-163-133-00 CERAMIC CHIP 470pF 5% 50V C350 1-126-964-11 ELECT 10µF 20% 50V C351 1-164-505-11 CERAMIC CHIP 2.2µF 16V C352 1-164-005-11 CERAMIC CHIP 0.47µF 25V C353 1-164-505-11 CERAMIC CHIP 2.2µF 16V
C354 1-164-005-11 CERAMIC CHIP 0.47µF 25V C355 1-126-965-11 ELECT 22µF 20% 50V C356 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C357 1-163-133-00 CERAMIC CHIP 470pF 5% 50V C358 1-164-005-11 CERAMIC CHIP 0.47µF 25V
C359 1-163-231-11 CERAMIC CHIP 15pF 5% 50V C360 1-163-231-11 CERAMIC CHIP 15pF 5% 50V C370 1-164-505-11 CERAMIC CHIP 2.2µF 16V C371 1-163-275-11 CERAMIC CHIP 1000pF 5% 50V C372 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V
C373 1-164-489-11 CERAMIC CHIP 0.22µF 10% 16V
AE
C213 1-163-133-00 CERAMIC CHIP 470pF 5% 50V C214 1-164-346-11 CERAMIC CHIP 1µF 16V
C215 1-163-133-00 CERAMIC CHIP 470pF 5% 50V C216 1-104-664-11 ELECT 47µF 20% 16V C217 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C218 1-104-664-11 ELECT 47µF 20% 16V C219 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V
C220 1-126-965-11 ELECT 22µF 20% 50V C221 1-164-505-11 CERAMIC CHIP 2.2µF 16V C222 1-164-346-11 CERAMIC CHIP 1µF 16V C223 1-163-133-00 CERAMIC CHIP 470pF 5% 50V C224 1-164-346-11 CERAMIC CHIP 1µF 16V
C225 1-163-133-00 CERAMIC CHIP 470pF 5% 50V C226 1-104-664-11 ELECT 47µF 20% 16V C227 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C228 1-104-664-11 ELECT 47µF 20% 16V C229 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V
C230 1-216-295-00 SHORT 0 C242 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C243 1-126-967-11 ELECT 47µF 20% 50V C244 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C245 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V
C251 1-163-087-00 CERAMIC CHIP 4pF 0.25pF 50V C252 1-163-087-00 CERAMIC CHIP 4pF 0.25pF 50V C253 1-163-251-11 CERAMIC CHIP 100pF 5% 50V C254 1-163-243-11 CERAMIC CHIP 47pF 5% 50V C255 1-163-251-11 CERAMIC CHIP 100pF 5% 50V
C256 1-163-038-00 CERAMIC CHIP 0.1µF 25V C257 1-126-965-11 ELECT 22µF 20% 50V C258 1-126-964-11 ELECT 10µF 20% 50V C259 1-164-005-11 CERAMIC CHIP 0.47µF 25V C260 1-163-038-00 CERAMIC CHIP 0.1µF 25V
C261 1-163-133-00 CERAMIC CHIP 470pF 5% 50V C262 1-163-133-00 CERAMIC CHIP 470pF 5% 50V C263 1-163-038-00 CERAMIC CHIP 0.1µF 25V C264 1-126-962-11 ELECT 3.3µF 20% 50V C265 1-126-964-11 ELECT 10µF 20% 50V
C266 1-126-964-11 ELECT 10µF 20% 50V C267 1-126-965-11 ELECT 22µF 20% 50V C268 1-163-038-00 CERAMIC CHIP 0.1µF 25V C269 1-163-131-00 CERAMIC CHIP 390pF 5% 50V C270 1-163-131-00 CERAMIC CHIP 390pF 5% 50V
C271 1-163-275-11 CERAMIC CHIP 1000pF 5% 50V C272 1-163-275-11 CERAMIC CHIP 1000pF 5% 50V C273 1-163-275-11 CERAMIC CHIP 1000pF 5% 50V C274 1-163-275-11 CERAMIC CHIP 1000pF 5% 50V C275 1-164-346-11 CERAMIC CHIP 1µF 16V
C276 1-164-346-11 CERAMIC CHIP 1µF 16V C277 1-164-505-11 CERAMIC CHIP 2.2µF 16V C278 1-164-505-11 CERAMIC CHIP 2.2µF 16V C279 1-126-965-11 ELECT 22µF 20% 50V C280 1-163-038-00 CERAMIC CHIP 0.1µF 25V
C281 1-126-965-11 ELECT 22µF 20% 50V C282 1-163-038-00 CERAMIC CHIP 0.1µF 25V C283 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C300 1-163-251-11 CERAMIC CHIP 100pF 5% 50V C301 1-163-038-00 CERAMIC CHIP 0.1µF 25V
Page 33
– 95 –
The componants identified byshading and mark are criti-cal for safety.Replace only with part numberspecified.
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK
D225 8-719-977-22 DIODE DTZ9.1 D226 8-719-977-22 DIODE DTZ9.1 D227 8-719-056-83 DIODE UDZ-TE-17-6.8B D228 8-719-977-12 DIODE DTZ6.8B D231 8-719-158-15 DIODE RD5.6SB
D251 8-719-047-16 DIODE BAS216 D303 8-719-988-61 DIODE 1SS355TE-17 D304 8-719-988-61 DIODE 1SS355TE-17 D320 8-719-977-22 DIODE DTZ9.1 D370 8-719-047-16 DIODE BAS216
D1010 8-719-036-58 DIODE MA3030-H(TX)
<FERRITE BEAD>
FB101 1-414-235-11 INDUCTOR CHIP 0µH FB102 1-414-235-11 INDUCTOR CHIP 0µH FB103 1-414-235-11 INDUCTOR CHIP 0µH FB104 1-414-235-11 INDUCTOR CHIP 0µH
<FILTER>
FL101 1-236-071-11 ENCAPSULATED COMPONENT FL102 1-233-765-21 FILTER FL103 1-233-765-21 FILTER FL104 1-233-765-21 FILTER FL201 1-236-071-11 ENCAPSULATED COMPONENT
FL202 1-236-071-11 ENCAPSULATED COMPONENT FL203 1-236-071-11 ENCAPSULATED COMPONENT FL1001 1-236-071-11 ENCAPSULATED COMPONENT
<IC>
IC1 8-759-376-77 IC SDA30C263-GEG IC2 8-759-524-94 IC M24C32-MW6T IC3 8-759-581-32 IC M27C2001-12C1RE402 (KP-41S5K) IC3 8-759-581-33 IC M27C2001-12C1RG402 (KP-41S5G) IC3 8-759-581-34 IC M27C2001-12C1RR402 (KP-41S5R)
IC3 8-759-581-35 IC M27C2001-12C1RW402 (KP-41S5/41S5B/41S5U)
IC4 8-759-394-57 IC PST593C-MMP-4P IC102 8-759-711-62 IC NJM2240M IC103 8-752-379-35 IC CXD2044Q-TL IC201 8-752-081-26 IC CXA2040AQ-T4
IC202 8-759-491-95 IC MSP3410D-PS-B4-T-ND IC204 8-759-008-67 IC MC14066BF IC205 8-759-394-57 IC PST593C-MMP-4P IC206 8-752-058-68 IC CXA1315M IC301 8-752-081-43 IC CXA2076Q-TL
IC302 8-759-565-20 IC TDA4665T/V5-118 IC303 8-759-430-79 IC TDA8395T/N3 IC1001 8-759-584-20 IC SDA5273-3CP
<CHIP, CONDUCTOR>
JR1 1-216-295-00 SHORT 0 JR2 1-216-296-00 SHORT 0 JR3 1-216-296-00 SHORT 0 JR4 1-216-295-00 SHORT 0
AE
C376 1-163-251-11 CERAMIC CHIP 100pF 5% 50V C377 1-126-964-11 ELECT 10µF 20% 50V C380 1-163-038-00 CERAMIC CHIP 0.1µF 25V C1001 1-163-235-11 CERAMIC CHIP 22pF 5% 50V
C1002 1-163-235-11 CERAMIC CHIP 22pF 5% 50V C1010 1-163-038-00 CERAMIC CHIP 0.1µF 25V C1013 1-126-965-11 ELECT 22µF 20% 50V C1014 1-163-038-00 CERAMIC CHIP 0.1µF 25V C1015 1-164-489-11 CERAMIC CHIP 0.22µF 10% 16V
C1020 1-163-235-11 CERAMIC CHIP 22pF 5% 50V
<FILTER>
CF120 1-409-327-00 TRAP, CERAMIC (6.5MHZ)
<CONNECTOR>
CN1 1-695-302-11 CONNECTOR, BOARD TO BOARD 50P CN2 *1-564-508-11 PLUG, CONNECTOR 5P CN6 *1-564-516-11 PLUG, CONNECTOR 13P CN101 1-695-915-11 TAB (CONTACT) CN201 1-766-296-11 CONNECTOR, DUAL SCART
CN301 *1-564-510-11 PLUG, CONNECTOR 7P
<DIODE>
D2 8-719-988-61 DIODE 1SS355TE-17 D10 8-719-158-15 DIODE RD5.6SB D11 8-719-158-15 DIODE RD5.6SB D12 8-719-158-15 DIODE RD5.6SB D16 8-719-988-61 DIODE 1SS355TE-17
D101 8-719-977-81 DIODE DTZ33B D102 8-719-988-61 DIODE 1SS355TE-17 D201 8-719-977-22 DIODE DTZ9.1 D202 8-719-977-22 DIODE DTZ9.1 D203 8-719-977-22 DIODE DTZ9.1
D204 8-719-977-22 DIODE DTZ9.1 D205 8-719-977-22 DIODE DTZ9.1 D206 8-719-977-22 DIODE DTZ9.1 D207 8-719-977-22 DIODE DTZ9.1 D208 8-719-977-22 DIODE DTZ9.1
D209 8-719-977-22 DIODE DTZ9.1 D210 8-719-977-22 DIODE DTZ9.1 D211 8-719-977-22 DIODE DTZ9.1 D212 8-719-977-22 DIODE DTZ9.1 D213 8-719-977-22 DIODE DTZ9.1
D214 8-719-977-22 DIODE DTZ9.1 D215 8-719-977-22 DIODE DTZ9.1 D216 8-719-158-15 DIODE RD5.6SB D217 8-719-158-15 DIODE RD5.6SB D218 8-719-158-15 DIODE RD5.6SB
D220 8-719-988-61 DIODE 1SS355TE-17 D221 8-719-988-61 DIODE 1SS355TE-17 D222 8-719-977-22 DIODE DTZ9.1 D223 8-719-977-22 DIODE DTZ9.1 D224 8-719-977-22 DIODE DTZ9.1
Page 34
– 96 –
The componants identified byshading and mark are criti-cal for safety.Replace only with part numberspecified.
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK
JR201 1-216-295-00 SHORT 0
JR203 1-216-295-00 SHORT 0 JR208 1-216-295-00 SHORT 0 JR209 1-216-295-00 SHORT 0 JR211 1-216-295-00 SHORT 0 JR212 1-216-295-00 SHORT 0
JR303 1-216-296-00 SHORT 0 JR304 1-216-296-00 SHORT 0 JR305 1-216-296-00 SHORT 0 JR360 1-216-295-00 SHORT 0 JR362 1-216-295-00 SHORT 0
JR1010 1-216-295-00 SHORT 0
<COIL>
L10 1-410-379-31 INDUCTOR CHIP 6.8µH L102 1-408-600-31 INDUCTOR 5.6µH L111 1-216-295-00 SHORT 0 L120 1-408-602-31 INDUCTOR 8.2µH L121 1-408-591-11 INDUCTOR 1µH
L122 1-408-602-31 INDUCTOR 8.2µH L300 1-412-006-31 INDUCTOR CHIP 10µH L301 1-410-993-11 INDUCTOR CHIP 1µH
<TRANSISTOR>
Q1 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q4 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q15 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R Q17 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R Q18 8-729-027-38 TRANSISTOR DTA144EKA-T146
Q20 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q21 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q22 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q23 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R Q24 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R
Q25 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R Q101 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q102 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R Q103 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R Q104 8-729-120-28 TRANSISTOR 2SC1623-L5L6
Q105 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q106 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R Q107 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R Q108 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R Q109 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R
Q110 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q111 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R Q112 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q113 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R Q114 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R
Q115 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q116 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R Q120 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q121 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q122 8-729-120-28 TRANSISTOR 2SC1623-L5L6
Q124 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q125 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R Q130 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R Q201 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q202 8-729-120-28 TRANSISTOR 2SC1623-L5L6
Q203 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q204 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q211 1-801-806-11 TRANSISTOR DTC144EKA-T146 Q212 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R Q213 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R
Q214 1-801-806-11 TRANSISTOR DTC144EKA-T146 Q215 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q216 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q217 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q300 1-801-806-11 TRANSISTOR DTC144EKA-T146
Q301 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q302 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q303 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q304 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q305 8-729-120-28 TRANSISTOR 2SC1623-L5L6
Q306 1-801-806-11 TRANSISTOR DTC144EKA-T146 Q307 1-801-806-11 TRANSISTOR DTC144EKA-T146 Q308 1-801-806-11 TRANSISTOR DTC144EKA-T146 Q309 1-801-806-11 TRANSISTOR DTC144EKA-T146 Q330 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R
Q331 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q1001 1-801-806-11 TRANSISTOR DTC144EKA-T146 Q1002 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R
<RESISTOR>
R1 1-216-049-00 RES,CHIP 1K 5% 1/10W R2 1-216-025-00 RES,CHIP 100 5% 1/10W R3 1-216-025-00 RES,CHIP 100 5% 1/10W R4 1-216-013-00 RES,CHIP 33 5% 1/10W R5 1-216-073-00 RES,CHIP 10K 5% 1/10W
R6 1-216-667-11 METAL CHIP 4.7K 0.50%1/10W R7 1-216-041-00 RES,CHIP 470 5% 1/10W R9 1-216-041-00 RES,CHIP 470 5% 1/10W R18 1-216-025-00 RES,CHIP 100 5% 1/10W R19 1-216-025-00 RES,CHIP 100 5% 1/10W
R20 1-216-025-00 RES,CHIP 100 5% 1/10W R21 1-216-025-00 RES,CHIP 100 5% 1/10W R24 1-216-065-00 RES,CHIP 4.7K 5% 1/10W R25 1-216-065-00 RES,CHIP 4.7K 5% 1/10W R28 1-216-073-00 RES,CHIP 10K 5% 1/10W
R29 1-216-065-00 RES,CHIP 4.7K 5% 1/10W R30 1-216-065-00 RES,CHIP 4.7K 5% 1/10W R31 1-216-065-00 RES,CHIP 4.7K 5% 1/10W R32 1-216-025-00 RES,CHIP 100 5% 1/10W R33 1-216-025-00 RES,CHIP 100 5% 1/10W
R34 1-216-025-00 RES,CHIP 100 5% 1/10W R35 1-216-025-00 RES,CHIP 100 5% 1/10W R40 1-216-067-00 RES,CHIP 5.6K 5% 1/10W R42 1-216-069-00 RES,CHIP 6.8K 5% 1/10W R44 1-216-069-00 RES,CHIP 6.8K 5% 1/10W
R46 1-216-095-00 RES,CHIP 82K 5% 1/10W
AE
Page 35
– 97 –
The componants identified byshading and mark are criti-cal for safety.Replace only with part numberspecified.
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK
R126 1-216-025-00 RES,CHIP 100 5% 1/10W R127 1-216-081-00 RES,CHIP 22K 5% 1/10W
R128 1-216-035-00 RES,CHIP 270 5% 1/10W R129 1-216-037-00 RES,CHIP 330 5% 1/10W R130 1-216-061-00 RES,CHIP 3.3K 5% 1/10W R131 1-216-073-00 RES,CHIP 10K 5% 1/10W R132 1-216-025-00 RES,CHIP 100 5% 1/10W
R133 1-216-041-00 RES,CHIP 470 5% 1/10W R134 1-216-001-00 RES,CHIP 10 5% 1/10W R135 1-216-045-00 RES,CHIP 680 5% 1/10W R136 1-216-033-00 RES,CHIP 220 5% 1/10W R137 1-216-049-00 RES,CHIP 1K 5% 1/10W
R138 1-216-041-00 RES,CHIP 470 5% 1/10W R142 1-216-295-00 SHORT 0 R143 1-216-295-00 SHORT 0 R145 1-216-025-00 RES,CHIP 100 5% 1/10W R146 1-216-025-00 RES,CHIP 100 5% 1/10W
R147 1-216-025-00 RES,CHIP 100 5% 1/10W R148 1-216-025-00 RES,CHIP 100 5% 1/10W R149 1-216-025-00 RES,CHIP 100 5% 1/10W R150 1-216-025-00 RES,CHIP 100 5% 1/10W R151 1-216-025-00 RES,CHIP 100 5% 1/10W
R153 1-216-025-00 RES,CHIP 100 5% 1/10W R154 1-216-295-00 SHORT 0 R156 1-216-089-00 RES,CHIP 47K 5% 1/10W R157 1-216-089-00 RES,CHIP 47K 5% 1/10W R158 1-216-073-00 RES,CHIP 10K 5% 1/10W
R159 1-216-049-00 RES,CHIP 1K 5% 1/10W R160 1-216-061-00 RES,CHIP 3.3K 5% 1/10W R161 1-216-033-00 RES,CHIP 220 5% 1/10W R162 1-216-109-00 RES,CHIP 330K 5% 1/10W R163 1-216-033-00 RES,CHIP 220 5% 1/10W
R164 1-216-089-91 RES,CHIP 47K 5% 1/10W R165 1-216-089-91 RES,CHIP 47K 5% 1/10W R166 1-216-033-00 RES,CHIP 220 5% 1/10W R167 1-216-043-91 RES,CHIP 560 5% 1/10W R168 1-216-067-00 RES,CHIP 5.6K 5% 1/10W
R169 1-216-049-00 RES,CHIP 1K 5% 1/10W R170 1-216-025-00 RES,CHIP 100 5% 1/10W R171 1-216-097-00 RES,CHIP 100K 5% 1/10W R172 1-216-065-00 RES,CHIP 4.7K 5% 1/10W R173 1-216-025-00 RES,CHIP 100 5% 1/10W
R174 1-216-666-11 METAL CHIP 4.3K 0.50%1/10W R175 1-216-653-11 METAL CHIP 1.2K 0.50%1/10W R176 1-216-295-00 SHORT 0 R177 1-216-049-00 RES,CHIP 1K 5% 1/10W R178 1-216-295-00 SHORT 0
R179 1-216-657-11 METAL CHIP 1.8K 0.50%1/10W R180 1-216-659-11 METAL CHIP 2.2K 0.50%1/10W R181 1-216-667-11 METAL CHIP 4.7K 0.50%1/10W R182 1-216-635-11 METAL CHIP 220 0.50%1/10W R183 1-216-635-11 METAL CHIP 220 0.50%1/10W
R184 1-216-057-00 RES,CHIP 2.2K 5% 1/10W R185 1-216-043-91 RES,CHIP 560 5% 1/10W R186 1-216-067-00 RES,CHIP 5.6K 5% 1/10W R187 1-216-049-00 RES,CHIP 1K 5% 1/10W R188 1-216-057-00 RES,CHIP 2.2K 5% 1/10W
AE
R47 1-216-057-00 RES,CHIP 2.2K 5% 1/10W R48 1-217-671-11 RES,CHIP 1 5% 1/10W R49 1-216-025-00 RES,CHIP 100 5% 1/10W R50 1-216-065-00 RES,CHIP 4.7K 5% 1/10W
R51 1-216-059-00 RES,CHIP 2.7K 5% 1/10W R52 1-216-065-00 RES,CHIP 4.7K 5% 1/10W R53 1-216-059-00 RES,CHIP 2.7K 5% 1/10W R54 1-216-025-00 RES,CHIP 100 5% 1/10W R58 1-216-063-91 RES,CHIP 3.9K 5% 1/10W
R59 1-216-025-00 RES,CHIP 100 5% 1/10W R60 1-216-025-00 RES,CHIP 100 5% 1/10W R61 1-216-025-00 RES,CHIP 100 5% 1/10W R62 1-216-025-00 RES,CHIP 100 5% 1/10W R64 1-216-025-00 RES,CHIP 100 5% 1/10W
R65 1-216-025-00 RES,CHIP 100 5% 1/10W R66 1-216-057-00 RES,CHIP 2.2K 5% 1/10W R67 1-216-057-00 RES,CHIP 2.2K 5% 1/10W R68 1-216-025-00 RES,CHIP 100 5% 1/10W R70 1-216-025-00 RES,CHIP 100 5% 1/10W
R71 1-216-025-00 RES,CHIP 100 5% 1/10W R72 1-216-025-00 RES,CHIP 100 5% 1/10W R73 1-216-025-00 RES,CHIP 100 5% 1/10W R74 1-216-025-00 RES,CHIP 100 5% 1/10W R76 1-216-025-00 RES,CHIP 100 5% 1/10W
R77 1-216-025-00 RES,CHIP 100 5% 1/10W R78 1-216-025-00 RES,CHIP 100 5% 1/10W R79 1-216-033-00 RES,CHIP 220 5% 1/10W R88 1-216-025-00 RES,CHIP 100 5% 1/10W R91 1-216-025-00 RES,CHIP 100 5% 1/10W
R92 1-216-025-00 RES,CHIP 100 5% 1/10W R93 1-216-033-00 RES,CHIP 220 5% 1/10W R94 1-216-033-00 RES,CHIP 220 5% 1/10W R95 1-216-033-00 RES,CHIP 220 5% 1/10W R97 1-216-025-00 RES,CHIP 100 5% 1/10W
R101 1-216-061-00 RES,CHIP 3.3K 5% 1/10W R102 1-216-025-00 RES,CHIP 100 5% 1/10W R103 1-216-025-00 RES,CHIP 100 5% 1/10W R104 1-216-073-00 RES,CHIP 10K 5% 1/10W R105 1-216-113-00 RES,CHIP 470K 5% 1/10W
R106 1-216-073-00 RES,CHIP 10K 5% 1/10W R107 1-216-295-00 SHORT 0 R110 1-216-073-00 RES,CHIP 10K 5% 1/10W R111 1-216-029-00 RES,CHIP 150 5% 1/10W R112 1-216-029-00 RES,CHIP 150 5% 1/10W
R113 1-216-001-00 RES,CHIP 10 5% 1/10W R114 1-216-029-00 RES,CHIP 150 5% 1/10W R115 1-216-037-00 RES,CHIP 330 5% 1/10W R116 1-216-065-00 RES,CHIP 4.7K 5% 1/10W R117 1-216-057-00 RES,CHIP 2.2K 5% 1/10W
R118 1-216-071-00 RES,CHIP 8.2K 5% 1/10W R119 1-216-033-00 RES,CHIP 220 5% 1/10W R120 1-216-069-00 RES,CHIP 6.8K 5% 1/10W R121 1-216-073-00 RES,CHIP 10K 5% 1/10W R122 1-216-041-00 RES,CHIP 470 5% 1/10W
R123 1-216-031-00 RES,CHIP 180 5% 1/10W R124 1-216-049-00 RES,CHIP 1K 5% 1/10W R125 1-216-081-00 RES,CHIP 22K 5% 1/10W
Page 36
– 98 –
The componants identified byshading and mark are criti-cal for safety.Replace only with part numberspecified.
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK
R250 1-216-033-00 RES,CHIP 220 5% 1/10W R251 1-216-025-00 RES,CHIP 100 5% 1/10W R252 1-216-025-00 RES,CHIP 100 5% 1/10W R253 1-216-025-00 RES,CHIP 100 5% 1/10W
R254 1-216-025-00 RES,CHIP 100 5% 1/10W R255 1-216-025-00 RES,CHIP 100 5% 1/10W R256 1-216-025-00 RES,CHIP 100 5% 1/10W R257 1-216-073-00 RES,CHIP 10K 5% 1/10W R258 1-216-017-00 RES,CHIP 47 5% 1/10W
R259 1-216-041-00 RES,CHIP 470 5% 1/10W R264 1-216-089-91 RES,CHIP 47K 5% 1/10W R265 1-216-065-00 RES,CHIP 4.7K 5% 1/10W R266 1-216-081-00 RES,CHIP 22K 5% 1/10W R267 1-216-065-00 RES,CHIP 4.7K 5% 1/10W
R268 1-216-089-91 RES,CHIP 47K 5% 1/10W R269 1-216-089-91 RES,CHIP 47K 5% 1/10W R270 1-216-022-00 RES,CHIP 75 5% 1/10W R271 1-216-022-00 RES,CHIP 75 5% 1/10W R272 1-216-022-00 RES,CHIP 75 5% 1/10W
R273 1-216-022-00 RES,CHIP 75 5% 1/10W R274 1-216-089-91 RES,CHIP 47K 5% 1/10W R280 1-216-049-00 RES,CHIP 1K 5% 1/10W R281 1-216-089-00 RES,CHIP 47K 5% 1/10W R282 1-216-093-91 RES,CHIP 68K 5% 1/10W
R283 1-216-065-00 RES,CHIP 4.7K 5% 1/10W R284 1-216-089-00 RES,CHIP 47K 5% 1/10W R285 1-216-093-91 RES,CHIP 68K 5% 1/10W R286 1-216-065-00 RES,CHIP 4.7K 5% 1/10W R291 1-216-057-00 RES,CHIP 2.2K 5% 1/10W
R292 1-216-057-00 RES,CHIP 2.2K 5% 1/10W R293 1-216-089-00 RES,CHIP 47K 5% 1/10W R294 1-216-097-00 RES,CHIP 100K 5% 1/10W R295 1-216-049-00 RES,CHIP 1K 5% 1/10W R296 1-216-049-00 RES,CHIP 1K 5% 1/10W
R297 1-216-033-00 RES,CHIP 220 5% 1/10W R298 1-216-033-00 RES,CHIP 220 5% 1/10W R299 1-216-073-00 RES,CHIP 10K 5% 1/10W R300 1-216-025-00 RES,CHIP 100 5% 1/10W R301 1-216-033-00 RES,CHIP 220 5% 1/10W
R302 1-216-295-00 SHORT 0 R303 1-216-295-00 SHORT 0 R304 1-216-129-00 RES,CHIP 2.2M 5% 1/10W R305 1-216-033-00 RES,CHIP 220 5% 1/10W R308 1-216-025-00 RES,CHIP 100 5% 1/10W
R309 1-216-033-00 RES,CHIP 220 5% 1/10W R310 1-216-033-00 RES,CHIP 220 5% 1/10W R315 1-216-295-00 SHORT 0 R316 1-216-033-00 RES,CHIP 220 5% 1/10W R320 1-216-025-00 RES,CHIP 100 5% 1/10W
R321 1-216-025-00 RES,CHIP 100 5% 1/10W R322 1-216-025-00 RES,CHIP 100 5% 1/10W R323 1-216-033-00 RES,CHIP 220 5% 1/10W R325 1-216-089-91 RES,CHIP 47K 5% 1/10W R326 1-216-025-00 RES,CHIP 100 5% 1/10W
R327 1-216-025-00 RES,CHIP 100 5% 1/10W R329 1-216-089-00 RES,CHIP 47K 5% 1/10W R330 1-216-025-00 RES,CHIP 100 5% 1/10W
AE
R189 1-216-043-91 RES,CHIP 560 5% 1/10W R190 1-216-067-00 RES,CHIP 5.6K 5% 1/10W R191 1-216-057-00 RES,CHIP 2.2K 5% 1/10W R192 1-216-049-00 RES,CHIP 1K 5% 1/10W R193 1-216-049-00 RES,CHIP 1K 5% 1/10W
R194 1-216-049-00 RES,CHIP 1K 5% 1/10W R195 1-216-049-00 RES,CHIP 1K 5% 1/10W R196 1-216-049-00 RES,CHIP 1K 5% 1/10W R197 1-216-049-00 RES,CHIP 1K 5% 1/10W R198 1-216-033-00 RES,CHIP 220 5% 1/10W
R199 1-216-033-00 RES,CHIP 220 5% 1/10W R200 1-216-049-00 RES,CHIP 1K 5% 1/10W R201 1-216-033-00 RES,CHIP 220 5% 1/10W R202 1-216-033-00 RES,CHIP 220 5% 1/10W R203 1-216-025-00 RES,CHIP 100 5% 1/10W
R204 1-216-025-00 RES,CHIP 100 5% 1/10W R205 1-216-689-11 RES,CHIP 39K 5% 1/10W R206 1-216-033-00 RES,CHIP 220 5% 1/10W R207 1-216-089-00 RES,CHIP 47K 5% 1/10W R208 1-216-041-00 RES,CHIP 470 5% 1/10W
R209 1-216-049-00 RES,CHIP 1K 5% 1/10W R210 1-216-017-00 RES,CHIP 47 5% 1/10W R211 1-216-033-00 RES,CHIP 220 5% 1/10W R212 1-216-022-00 RES,CHIP 75 5% 1/10W R213 1-216-022-00 RES,CHIP 75 5% 1/10W
R214 1-216-025-00 RES,CHIP 100 5% 1/10W R216 1-216-025-00 RES,CHIP 100 5% 1/10W R217 1-216-113-00 RES,CHIP 470K 5% 1/10W R218 1-216-025-00 RES,CHIP 100 5% 1/10W R219 1-216-113-00 RES,CHIP 470K 5% 1/10W
R220 1-216-295-00 SHORT 0 R221 1-216-039-00 RES,CHIP 390 5% 1/10W R222 1-216-089-00 RES,CHIP 47K 5% 1/10W R223 1-216-295-00 SHORT 0 R224 1-216-039-00 RES,CHIP 390 5% 1/10W
R225 1-216-089-00 RES,CHIP 47K 5% 1/10W R226 1-216-033-00 RES,CHIP 220 5% 1/10W R227 1-216-022-00 RES,CHIP 75 5% 1/10W R228 1-216-022-00 RES,CHIP 75 5% 1/10W R229 1-216-033-00 RES,CHIP 220 5% 1/10W
R230 1-216-022-00 RES,CHIP 75 5% 1/10W R232 1-216-025-00 RES,CHIP 100 5% 1/10W R233 1-216-025-00 RES,CHIP 100 5% 1/10W R234 1-216-113-00 RES,CHIP 470K 5% 1/10W R235 1-216-025-00 RES,CHIP 100 5% 1/10W
R236 1-216-113-00 RES,CHIP 470K 5% 1/10W R237 1-216-295-00 SHORT 0 R238 1-216-089-00 RES,CHIP 47K 5% 1/10W R239 1-216-039-00 RES,CHIP 390 5% 1/10W R240 1-216-295-00 SHORT 0
R241 1-216-089-00 RES,CHIP 47K 5% 1/10W R242 1-216-039-00 RES,CHIP 390 5% 1/10W R243 1-216-033-00 RES,CHIP 220 5% 1/10W R244 1-216-033-00 RES,CHIP 220 5% 1/10W R248 1-216-025-00 RES,CHIP 100 5% 1/10W
R249 1-216-001-00 RES,CHIP 10 5% 1/10W
Page 37
– 99 –
The componants identified byshading and mark are criti-cal for safety.Replace only with part numberspecified.
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK
<TUNER>
TU101 1-693-340-11 TUNER/VIF
<CRYSTAL>
X1 1-767-154-21 VIBRATOR, CERAMIC (11.5MHz) X201 1-760-628-11 VIBRATOR, CRYSTAL (18.432MHz) X301 1-567-504-11 OSCILLATOR, CRYSTAL (4.43MHz) X302 1-567-505-11 OSCILLATOR, CRYSTAL (3.58MHz) X303 1-767-127-11 VIBRATOR, CERAMIC (500kHz)
X1001 1-579-965-21 VIBRATOR, CRYSTAL (20.48MHz)
*****************************************************************************
* A-1316-355-A G BOARD, COMPLETE***************************
4-382-854-11 SCREW (M3X10), P, SW (+)
<CAPACITOR>
C6001 1-119-894-51 CERAMIC 2200pF 20% 250V C6002 ! 1-104-706-51 FILM 0.22µF 20% 250V C6003 1-126-943-11 ELECT 2200µF 20% 25V C6004 1-104-665-11 ELECT 100µF 20% 25V C6006 ! 1-104-706-51 FILM 0.22µF 20% 250V
C6007 1-119-894-51 CERAMIC 2200pF 20% 250V C6011 1-107-676-91 ELECT 2.2µF 20% 450V C6012 1-102-112-00 CERAMIC 330pF 10% 50V C6018 1-117-753-11 ELECT(BLOCK) 470µF 20% 450V C6019 1-104-664-11 ELECT 47µF 20% 25V
C6020 1-104-665-11 ELECT 100µF 20% 25V C6021 1-126-961-11 ELECT 2.2µF 20% 50V C6026 1-104-665-11 ELECT 100µF 20% 25V C6030 1-115-405-11 FILM 0.039µF 3% 1KV C6031 1-126-964-11 ELECT 10µF 20% 50V
C6032 1-126-964-11 ELECT 10µF 20% 50V C6033 1-136-479-11 FILM 0.001µF 2% 50V C6034 1-101-810-00 CERAMIC 100pF 5% 500V C6035 1-101-810-00 CERAMIC 100pF 5% 500V C6036 1-126-768-11 ELECT 2200µF 20% 16V
C6037 1-126-943-11 ELECT 2200µF 20% 25V C6038 1-128-548-11 ELECT 4700µF 20% 25V C6039 1-126-972-11 ELECT 1000µF 20% 50V C6040 1-126-972-11 ELECT 1000µF 20% 50V C6041 1-126-960-11 ELECT 1µF 20% 50V
C6042 1-104-665-11 ELECT 100µF 20% 25V C6044 1-107-641-11 ELECT 220µF 20% 160V C6045 1-104-665-11 ELECT 100µF 20% 25V C6046 1-104-665-11 ELECT 100µF 20% 25V C6047 1-102-112-00 CERAMIC 330pF 10% 50V
C6048 1-126-960-11 ELECT 1µF 20% 50V C6049 1-136-165-00 FILM 0.1µF 5% 50V C6050 1-109-954-11 ELECT 0.47µF 20% 160V C6051 1-126-935-11 ELECT 470µF 20% 6.3V C6052 1-125-969-91 CERAMIC 680pF 10% 1KV
GAE
R331 1-216-059-00 RES,CHIP 2.7K 5% 1/10W R332 1-216-049-00 RES,CHIP 1K 5% 1/10W
R333 1-216-067-00 RES,CHIP 5.6K 5% 1/10W R334 1-216-041-00 RES,CHIP 470 5% 1/10W R335 1-216-675-91 METAL CHIP 10K 0.50%1/10W R336 1-216-109-00 RES,CHIP 330K 5% 1/10W R337 1-216-025-00 RES,CHIP 100 5% 1/10W
R338 1-216-049-00 RES,CHIP 1K 5% 1/10W R339 1-216-049-00 RES,CHIP 1K 5% 1/10W R340 1-216-025-00 RES,CHIP 100 5% 1/10W R341 1-216-025-00 RES,CHIP 100 5% 1/10W R342 1-216-049-00 RES,CHIP 1K 5% 1/10W
R343 1-216-061-00 RES,CHIP 3.3K 5% 1/10W R344 1-216-067-00 RES,CHIP 5.6K 5% 1/10W R345 1-216-025-00 RES,CHIP 100 5% 1/10W R347 1-216-025-00 RES,CHIP 100 5% 1/10W R348 1-216-025-00 RES,CHIP 100 5% 1/10W
R349 1-216-025-00 RES,CHIP 100 5% 1/10W R350 1-216-041-00 RES,CHIP 470 5% 1/10W R351 1-216-053-00 RES,CHIP 1.5K 5% 1/10W R352 1-216-077-91 RES,CHIP 15K 5% 1/10W R353 1-216-033-00 RES,CHIP 220 5% 1/10W
R354 1-216-295-00 SHORT 0 R355 1-216-093-91 RES,CHIP 68K 5% 1/10W R356 1-216-133-00 RES,CHIP 3.3M 5% 1/10W R357 1-216-049-00 RES,CHIP 1K 5% 1/10W R358 1-216-105-00 RES,CHIP 220K 5% 1/10W
R359 1-216-295-00 SHORT 0 R360 1-216-129-00 RES,CHIP 2.2M 5% 1/10W R361 1-216-129-00 RES,CHIP 2.2M 5% 1/10W R370 1-216-295-00 SHORT 0 R371 1-216-033-00 RES,CHIP 220 5% 1/10W
R373 1-216-049-00 RES,CHIP 1K 5% 1/10W R374 1-216-041-00 RES,CHIP 470 5% 1/10W R375 1-216-049-00 RES,CHIP 1K 5% 1/10W R376 1-216-081-00 RES,CHIP 22K 5% 1/10W R377 1-216-049-00 RES,CHIP 1K 5% 1/10W
R378 1-216-680-00 METAL CHIP 16K 0.50%1/10W R379 1-216-041-00 RES,CHIP 470 5% 1/10W R1001 1-216-025-00 RES,CHIP 100 5% 1/10W R1002 1-216-025-00 RES,CHIP 100 5% 1/10W R1010 1-216-295-00 SHORT 0
R1012 1-216-041-00 RES,CHIP 470 5% 1/10W R1014 1-216-065-00 RES,CHIP 4.7K 5% 1/10W R1017 1-216-295-00 SHORT 0 R1020 1-216-097-00 RES,CHIP 100K 5% 1/10W R1021 1-216-029-00 RES,CHIP 150 5% 1/10W
R1022 1-216-029-00 RES,CHIP 150 5% 1/10W R1023 1-216-029-00 RES,CHIP 150 5% 1/10W R1024 1-216-045-00 RES,CHIP 680 5% 1/10W R1026 1-216-025-00 RES,CHIP 100 5% 1/10W R1027 1-216-025-00 RES,CHIP 100 5% 1/10W
R1028 1-216-025-00 RES,CHIP 100 5% 1/10W
Page 38
– 100 –
The componants identified byshading and mark are criti-cal for safety.Replace only with part numberspecified.
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK
<FUSE>
F6001 ! 1-576-232-11 FUSE (H.B.C.) 5A/250V * 1-533-725-11 HOLDER, FUSE ; F6001
<FERRITE BEAD>
FB6009 1-410-397-21 FERRITE 1.1µH
<IC>
IC6001! 8-759-468-89 IC TOP209P IC6004 8-759-537-24 IC KA7500B IC6005 8-749-924-35 PHOTO COUPLER ON3171-R IC6006 8-749-924-35 PHOTO COUPLER ON3171-R IC6007 8-759-185-47 IC IR2112
IC6008 8-749-920-61 IC SE-135N
<COIL>
L6002 1-412-525-31 INDUCTOR 10µH L6003 1-412-525-31 INDUCTOR 10µH L6004 1-412-525-31 INDUCTOR 10µH L6005 1-412-525-31 INDUCTOR 10µH L6006 1-412-525-31 INDUCTOR 10µH
L6008 1-412-533-21 INDUCTOR 47µH L6009 1-412-523-41 INDUCTOR 6.8µH L6010 1-412-523-41 INDUCTOR 6.8µH L6011 1-412-525-31 INDUCTOR 10µH
<IC LINK>
PS6001!1-533-595-31 LINK, IC (3.15A/90V AC, 60V DC) PS6002!1-533-595-31 LINK, IC (3.15A/90V AC, 60V DC) PS6003!1-533-597-31 LINK, IC (5A/90V AC, 60V DC)
<TRANSISTOR>
Q6001 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q6002 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q6003 8-729-920-72 TRANSISTOR 2SA1037K-T-146-QR Q6005 8-729-920-72 TRANSISTOR 2SA1037K-T-146-QR Q6009 8-729-140-97 TRANSISTOR 2SB734-34
Q6010 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q6011 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q6012 8-729-920-72 TRANSISTOR 2SA1037K-T-146-QR Q6013 8-729-820-82 TRANSISTOR 2SA1208-T Q6014 8-729-028-10 TRANSISTOR IRFI744G-LF
Q6015 8-729-028-10 TRANSISTOR IRFI744G-LF
<RESISTOR>
R6000 ! 1-202-885-91 SOLID 1M 20% 1/2W R6001 1-216-049-00 RES,CHIP 1K 5% 1/10W R6002 1-218-265-11 METAL 8.2M 5% 1W R6008 1-216-099-00 RES,CHIP 120K 5% 1/10W R6009 1-215-479-00 METAL 270K 1% 1/4W
G
C6053 1-125-969-91 CERAMIC 680pF 10% 1KV C6055 1-107-641-11 ELECT 220µF 20% 160V C6058 1-102-114-00 CERAMIC 470pF 10% 50V C6059 1-102-114-00 CERAMIC 470pF 10% 50V C6060 1-102-114-00 CERAMIC 470pF 10% 50V
C6061 1-102-114-00 CERAMIC 470pF 10% 50V C6062 1-102-114-00 CERAMIC 470pF 10% 50V C6063 1-102-114-00 CERAMIC 470pF 10% 50V C6064 ! 1-161-964-91 CERAMIC 0.0047µF 250V C6065 ! 1-161-964-91 CERAMIC 0.0047µF 250V
<CONNECTOR>
CN6001 1-695-915-11 TAB (CONTACT) CN6002 1-695-915-11 TAB (CONTACT) CN6005 *1-580-843-11 PIN, CONNECTOR (POWER) CN6006 *1-580-689-11 PIN, CONNECTOR (PC BOARD) 4P CN6007 *1-691-291-11 PIN, CONNECTOR (PC BOARD) 5P
CN6008 *1-564-509-11 PLUG, CONNECTOR 6P CN6009 1-695-915-11 TAB (CONTACT) CN6011 *1-573-986-11 PIN, CONNECTOR (PC BOARD) 5P CN6012 *1-508-766-00 PIN, CONNECTOR (5mm PITCH) 4P CN6013 *1-508-765-00 PIN, CONNECTOR (5mm PITCH) 3P
<DIODE>
D6002 8-719-052-91 DIODE D4SBS4-F D6003 8-719-510-53 DIODE D4SB60L D6004 8-719-057-96 DIODE D10SC6M-4012 D6005 8-719-982-20 DIODE MTZJ-30B D6007 8-719-911-55 DIODE U05G
D6008 8-719-073-23 DIODE ST02D-200TA D6012 8-719-991-33 DIODE 1SS133T-77 D6013 8-719-110-03 DIODE RD7.5ESB2 D6014 8-719-991-33 DIODE 1SS133T-77 D6017 8-719-063-73 DIODE D1NL20U-TR
D6018 8-719-991-33 DIODE 1SS133T-77 D6025 8-719-063-73 DIODE D1NL20U-TR D6032 8-719-991-33 DIODE 1SS133T-77 D6033 8-719-991-33 DIODE 1SS133T-77 D6035 8-719-018-83 DIODE D2S4M
D6036 8-719-018-83 DIODE D2S4M D6037 8-719-031-78 DIODE S2L40F D6038 8-719-312-47 DIODE RBA-406B D6042 8-719-979-64 DIODE UF4005PKG23 D6043 8-719-110-53 DIODE RD20ESB2
D6044 8-719-979-64 DIODE UF4005PKG23 D6045 8-719-110-53 DIODE RD20ESB2 D6046 8-719-110-53 DIODE RD20ESB2 D6047 8-719-110-53 DIODE RD20ESB2 D6048 ! 8-719-921-88 DIODE MTZJ-13B
D6049 8-719-031-78 DIODE S2L40F D6050 8-719-991-33 DIODE 1SS133T-77 D6051 8-719-991-33 DIODE 1SS133T-77
Page 39
– 101 –
The componants identified byshading and mark are criti-cal for safety.Replace only with part numberspecified.
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK
* A-1331-734-A CR BOARD, COMPLETE*****************************
<CAPACITOR>
C702 1-102-113-00 CERAMIC 390pF 10% 50V C703 1-104-664-11 ELECT 47µF 20% 25V C705 1-161-754-00 CERAMIC 0.001µF 10% 2KV C708 1-101-880-00 CERAMIC 47pF 5% 50V C709 1-162-115-00 CERAMIC 330pF 10% 2KV
C710 1-102-114-00 CERAMIC 470pF 10% 50V C712 1-107-662-11 ELECT 22µF 20% 250V C713 1-104-664-11 ELECT 47µF 20% 25V
<CONNECTOR>
CN701 1-695-915-11 TAB (CONTACT) CN702 *1-564-511-11 PLUG, CONNECTOR 8P CN703 *1-564-510-11 PLUG, CONNECTOR 7P CN704 *1-508-784-00 PIN, CONNECTOR (5mm PITCH) 1P CN705! 1-251-182-21 SOCKET, PICTURE TUBE
CN706 *1-564-512-11 PLUG, CONNECTOR 9P
<DIODE>
D701 8-719-991-33 DIODE 1SS133T-77 D704 8-719-991-33 DIODE 1SS133T-77 D705 8-719-991-33 DIODE 1SS133T-77 D706 8-719-991-33 DIODE 1SS133T-77 D708 8-719-991-33 DIODE 1SS133T-77
D709 8-719-109-84 DIODE RD5.1ESB1
<COIL>
L701 1-410-682-31 INDUCTOR 470µH L702 1-408-619-31 INDUCTOR 220µH
<TRANSISTOR>
Q701 8-729-200-17 TRANSISTOR 2SA1091-O Q703 8-729-045-56 TRANSISTOR 2SC2611-15 Q704 8-729-119-78 TRANSISTOR 2SC2785-HFE Q705 8-729-119-76 TRANSISTOR 2SA1175-HFE Q706 8-729-119-76 TRANSISTOR 2SA1175-HFE
<RESISTOR>
R701 1-219-743-11 CARBON 100 5% 1/2W R704 1-260-132-11 CARBON 560K 5% 1/2W R706 1-249-425-11 CARBON 4.7K 5% 1/4W R707 1-247-807-31 CARBON 100 5% 1/4W R708 1-249-411-11 CARBON 330 5% 1/4W
R709 1-260-099-11 CARBON 1K 5% 1/2W R710 1-249-393-11 CARBON 10 5% 1/4W R711 1-215-923-00 METAL OXIDE 10K 5% 3W F R714 1-202-818-00 SOLID 1K 20% 1/2W
CRG
R6010 1-215-479-00 METAL 270K 1% 1/4W R6013 1-202-968-11 CEMENTED 1.2 5% 10W R6014 1-216-089-00 RES,CHIP 47K 5% 1/10W R6018 1-216-089-00 RES,CHIP 47K 5% 1/10W R6019 1-216-089-00 RES,CHIP 47K 5% 1/10W
R6022 1-247-791-91 CARBON 22 5% 1/4W R6024 ! 1-205-998-11 CEMENTED 1 5% 10W R6026 ! 1-205-998-11 CEMENTED 1 5% 10W R6027 1-216-065-00 RES,CHIP 4.7K 5% 1/10W R6032 ! 1-202-933-61 FUSIBLE 0.1 10% 1/2W F
R6034 1-216-113-00 RES,CHIP 470K 5% 1/10W R6045 1-216-657-11 METAL CHIP 1.8K 0.50%1/10W R6046 1-216-081-00 RES,CHIP 22K 5% 1/10W R6047 1-249-437-11 CARBON 47K 5% 1/4W R6048 1-216-065-00 RES,CHIP 4.7K 5% 1/10W
R6049 1-216-073-00 RES,CHIP 10K 5% 1/10W R6050 1-216-049-91 RES,CHIP 1K 5% 1/10W R6051 1-216-674-11 METAL CHIP 9.1K 0.50%1/10W R6052 1-216-049-00 RES,CHIP 1K 5% 1/10W R6053 1-249-417-11 CARBON 1K 5% 1/4W
R6054 1-216-049-00 RES,CHIP 1K 5% 1/10W R6055 1-216-065-00 RES,CHIP 4.7K 5% 1/10W R6056 1-216-073-00 RES,CHIP 10K 5% 1/10W R6057 1-216-073-00 RES,CHIP 10K 5% 1/10W R6058 1-216-073-00 RES,CHIP 10K 5% 1/10W
R6059 1-216-065-00 RES,CHIP 4.7K 5% 1/10W R6060 1-249-413-11 CARBON 470 5% 1/4W F R6061 1-215-477-00 METAL 220K 1% 1/4W R6062 1-249-417-11 CARBON 1K 5% 1/4W F R6063 1-249-397-11 CARBON 22 5% 1/4W F
R6064 1-249-397-11 CARBON 22 5% 1/4W F R6065 1-249-441-11 CARBON 100K 5% 1/4W R6066 1-216-366-00 METAL OXIDE 0.56 5% 2W F R6067 1-249-425-11 CARBON 4.7K 5% 1/4W F R6068 1-249-425-11 CARBON 4.7K 5% 1/4W F
R6069 1-215-477-00 METAL 220K 1% 1/4W R6070 1-249-417-11 CARBON 1K 5% 1/4W F R6071 1-215-453-00 METAL 22K 1% 1/4W R6072 1-215-476-00 METAL 200K 1% 1/4W R6073 1-216-041-00 RES,CHIP 470 5% 1/10W
R6075 1-216-353-00 METAL OXIDE 2.2 5% 1W F R6079 1-249-377-11 CARBON 0.47 5% 1/4W F R6080 1-249-377-11 CARBON 0.47 5% 1/4W F R6081 1-249-377-11 CARBON 0.47 5% 1/4W F R6082 1-249-377-11 CARBON 0.47 5% 1/4W F
R6083 1-249-377-11 CARBON 0.47 5% 1/4W F R6084 1-249-377-11 CARBON 0.47 5% 1/4W F R6085 ! 1-212-849-61 FUSIBLE 4.7 5% 1/4W F R6086 1-216-073-00 RES,CHIP 10K 5% 1/10W
<TRANSFORMER>
T6002 ! 1-424-682-11 TRANSFORMER, LINE FILTER T6004 ! 1-431-732-21 TRANSFORMER, CONVERTER (SRT) T6005 ! 1-429-807-12 TRANSFORMER, CONVERTER (PIT)
******************************************************************************
Page 40
– 102 –
The componants identified byshading and mark are criti-cal for safety.Replace only with part numberspecified.
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK
<TRANSISTOR>
Q731 8-729-200-17 TRANSISTOR 2SA1091-O Q732 8-729-045-56 TRANSISTOR 2SC2611-15 Q733 8-729-119-78 TRANSISTOR 2SC2785-HFE
<RESISTOR>
R731 1-219-743-11 CARBON 100 5% 1/2W R732 1-260-132-11 CARBON 560K 5% 1/2W R733 1-215-923-00 METAL OXIDE 10K 5% 3W F R735 1-247-807-31 CARBON 100 5% 1/4W R736 1-249-425-11 CARBON 4.7K 5% 1/4W
R737 1-260-099-11 CARBON 1K 5% 1/2W R738 1-249-408-11 CARBON 180 5% 1/4W R739 1-260-133-11 CARBON 680K 5% 1/2W R740 1-202-818-00 SOLID 1K 20% 1/2W R741 1-249-393-11 CARBON 10 5% 1/4W
R742 1-247-815-91 CARBON 220 5% 1/4W R744 1-247-891-00 CARBON 330K 5% 1/4W R745 1-247-843-11 CARBON 3.3K 5% 1/4W R746 1-202-814-11 SOLID 33K 20% 1/2W
<SPARK GAP>
SG731 1-519-422-11 GAP, SPARK SG732 1-519-422-11 GAP, SPARK SG733 1-519-422-11 GAP, SPARK
*****************************************************************************
* A-1331-736-ACB BOARD, COMPLETE****************************
<CAPACITOR>
C762 1-126-964-11 ELECT 10µF 20% 50V C763 1-161-754-00 CERAMIC 0.001µF 10% 2KV C764 1-102-112-00 CERAMIC 330pF 10% 50V C765 1-161-830-00 CERAMIC 0.0047µF 500V C766 1-162-115-00 CERAMIC 330pF 10% 2KV
C767 1-107-662-11 ELECT 22µF 20% 250V C768 1-101-880-00 CERAMIC 47pF 5% 50V C769 1-104-664-11 ELECT 47µF 20% 25V C770 1-102-114-00 CERAMIC 470pF 10% 50V
<CONNECTOR>
CN761 1-695-915-11 TAB (CONTACT) CN762 *1-564-508-11 PLUG, CONNECTOR 5P CN763 *1-508-784-00 PIN, CONNECTOR (5mm PITCH) 1P CN764! 1-251-182-21 SOCKET, PICTURE TUBE CN765 *1-564-512-11 PLUG, CONNECTOR 9P
CN766 1-564-513-11 PLUG, CONNECTOR 10P
CR CG CB
R715 1-260-133-11 CARBON 680K 5% 1/2W
R716 1-247-815-91 CARBON 220 5% 1/4W R717 1-249-435-11 CARBON 33K 5% 1/4W R718 1-249-437-11 CARBON 47K 5% 1/4W R719 1-219-743-11 CARBON 100 5% 1/2W R720 1-249-425-11 CARBON 4.7K 5% 1/4W
R721 1-202-814-11 SOLID 33K 20% 1/2W R722 1-247-863-91 CARBON 22K 5% 1/4W R723 1-249-437-11 CARBON 47K 5% 1/4W
<SPARK GAP>
SG701 1-519-422-11 GAP, SPARK SG702 1-519-422-11 GAP, SPARK SG703 1-519-422-11 GAP, SPARK
******************************************************************************
* A-1331-735-ACG BOARD, COMPLETE*****************************
<CAPACITOR>
C733 1-161-754-00 CERAMIC 0.001µF 10% 2KV C734 1-102-114-00 CERAMIC 470pF 10% 50V C735 1-161-830-00 CERAMIC 0.0047µF 500V C736 1-162-115-00 CERAMIC 330pF 10% 2KV C737 1-107-662-11 ELECT 22µF 20% 250V
C738 1-101-880-00 CERAMIC 47pF 5% 50V C739 1-104-664-11 ELECT 47µF 20% 25V C740 1-102-114-00 CERAMIC 470pF 10% 50V
<CONNECTOR>
CN731 1-695-915-11 TAB (CONTACT) CN732 *1-564-508-11 PLUG, CONNECTOR 5P CN733 *1-564-511-11 PLUG, CONNECTOR 8P CN734 *1-508-784-00 PIN, CONNECTOR (5mm PITCH) 1P CN735! 1-251-182-21 SOCKET, PICTURE TUBE
CN736 *1-564-512-11 PLUG, CONNECTOR 9P CN737 *1-564-512-11 PLUG, CONNECTOR 9P
<DIODE>
D731 8-719-991-33 DIODE 1SS133T-77 D732 8-719-991-33 DIODE 1SS133T-77 D733 8-719-991-33 DIODE 1SS133T-77 D735 8-719-991-33 DIODE 1SS133T-77 D736 8-719-991-33 DIODE 1SS133T-77
<COIL>
L731 1-408-623-31 INDUCTOR 470µH L732 1-408-619-31 INDUCTOR 220µH
Page 41
– 103 –
The componants identified byshading and mark are criti-cal for safety.Replace only with part numberspecified.
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK
<CAPACITOR>
C1501 1-163-005-11 CERAMIC CHIP 470pF 10% 50V C1503 1-137-399-11 FILM 0.1µF 5% 100V C1504 1-164-690-91 CERAMIC CHIP 0.0022µF 5% 50V C1506 1-126-969-11 ELECT 220µF 20% 50V C1507 1-163-243-11 CERAMIC CHIP 47pF 5% 50V
C1508 1-137-401-11 FILM 0.22µF 10% 100V C1509 1-163-251-11 CERAMIC CHIP 100pF 5% 50V C1510 1-126-972-11 ELECT 1000µF 20% 50V C1511 1-126-972-11 ELECT 1000µF 20% 50V C1512 1-126-960-11 ELECT 1µF 20% 50V
C1513 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C1514 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C1516 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V C1517 1-126-964-11 ELECT 10µF 20% 50V C1518 1-126-933-11 ELECT 100µF 20% 16V
C1519 1-126-933-11 ELECT 100µF 20% 16V C1520 1-126-964-11 ELECT 10µF 20% 50V C1521 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C1523 1-163-243-11 CERAMIC CHIP 47pF 5% 50V C1524 1-136-177-00 FILM 1µF 5% 50V
C1525 1-104-665-11 ELECT 100µF 20% 25V C1526 1-104-664-11 ELECT 47µF 20% 25V C1527 1-163-145-00 CERAMIC CHIP 0.0015µF 5% 50V C1528 1-163-145-00 CERAMIC CHIP 0.0015µF 5% 50V C1529 1-164-690-91 CERAMIC CHIP 0.0022µF 5% 50V
C1530 1-104-664-11 ELECT 47µF 20% 16V C1531 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C1532 1-126-960-11 ELECT 1µF 20% 50V C1601 1-163-009-11 CERAMIC CHIP 0.001µF 10% 50V C1602 1-163-009-11 CERAMIC CHIP 0.001µF 10% 50V
C1603 1-130-495-00 FILM 0.1µF 5% 50V C1604 1-130-495-00 FILM 0.1µF 5% 50V C1605 1-107-715-11 ELECT 22µF 20% 50V C1606 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C1607 1-137-370-11 FILM 0.01µF 5% 50V
C1610 1-126-960-11 ELECT 1µF 20% 50V C1611 1-126-960-11 ELECT 1µF 20% 50V C1612 1-126-960-11 ELECT 1µF 20% 50V C1613 1-126-967-11 ELECT 47µF 20% 50V C1614 1-126-967-11 ELECT 47µF 20% 50V
C1617 1-130-495-00 FILM 0.1µF 5% 50V C1618 1-130-495-00 FILM 0.1µF 5% 50V C1619 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V C1621 1-104-665-11 ELECT 100µF 20% 25V C1622 1-164-690-91 CERAMIC CHIP 0.0022µF 5% 50V
C1624 1-130-495-00 FILM 0.1µF 5% 50V C1626 1-130-495-00 FILM 0.1µF 5% 50V C1627 1-164-690-91 CERAMIC CHIP 0.0022µF 5% 50V C1628 1-126-964-11 ELECT 10µF 20% 50V C1630 1-128-550-21 ELECT 2200µF 20% 50V
C1631 1-128-550-21 ELECT 2200µF 20% 50V C1632 1-104-664-11 ELECT 47µF 20% 25V C1633 1-104-664-11 ELECT 47µF 20% 25V C1634 1-126-961-11 ELECT 2.2µF 20% 50V C1635 1-104-666-11 ELECT 220µF 20% 25V
<DIODE>
D761 8-719-991-33 DIODE 1SS133T-77 D762 8-719-991-33 DIODE 1SS133T-77 D763 8-719-991-33 DIODE 1SS133T-77 D765 8-719-991-33 DIODE 1SS133T-77 D766 8-719-991-33 DIODE 1SS133T-77
<COIL>
L761 1-408-623-31 INDUCTOR 470µH L762 1-408-619-31 INDUCTOR 220µH
<TRANSISTOR>
Q761 8-729-200-17 TRANSISTOR 2SA1091-O Q762 8-729-045-56 TRANSISTOR 2SC2611-15 Q763 8-729-119-78 TRANSISTOR 2SC2785-HFE Q764 8-729-119-76 TRANSISTOR 2SA1175-HFE
<RESISTOR>
R761 1-219-743-11 CARBON 100 5% 1/2W R762 1-260-132-11 CARBON 560K 5% 1/2W R763 1-215-923-00 METAL OXIDE 10K 5% 3W F R765 1-247-807-31 CARBON 100 5% 1/4W R766 1-260-099-11 CARBON 1K 5% 1/2W
R767 1-249-425-11 CARBON 4.7K 5% 1/4W R768 1-260-133-11 CARBON 680K 5% 1/2W R769 1-202-818-00 SOLID 1K 20% 1/2W R770 1-247-815-91 CARBON 220 5% 1/4W R771 1-219-743-11 CARBON 100 5% 1/2W
R772 1-249-393-11 CARBON 10 5% 1/4W R773 1-249-413-11 CARBON 470 5% 1/4W R774 1-247-895-91 CARBON 470K 5% 1/4W R775 1-249-427-11 CARBON 6.8K 5% 1/4W R776 1-249-437-11 CARBON 47K 5% 1/4W
R777 1-249-427-11 CARBON 6.8K 5% 1/4W R778 1-202-814-11 SOLID 33K 20% 1/2W R779 1-247-815-91 CARBON 220 5% 1/4W
<SPARK GAP>
SG761 1-519-422-11 GAP, SPARK SG762 1-519-422-11 GAP, SPARK SG763 1-519-422-11 GAP, SPARK
*****************************************************************************
* A-1346-678-AD BOARD, COMPLETE***************************
4-201-023-11 SPACER, INSULATING4-202-373-01 SPRING, IC4-382-854-11 SCREW (M3X10), P, SW (+)
DCB
Page 42
– 104 –
The componants identified byshading and mark are criti-cal for safety.Replace only with part numberspecified.
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK
<CONNECTOR>
CN1501 *1-564-506-11 PLUG, CONNECTOR 3P CN1502 1-695-915-11 TAB (CONTACT) CN1601 *1-564-508-11 PLUG, CONNECTOR 5P CN1604 *1-564-507-11 PLUG, CONNECTOR 4P CN1605 *1-508-766-00 PIN, CONNECTOR (5mm PITCH) 4P
CN1606 *1-779-890-11 CONNECTOR, BOARD TO BOARD 10P CN1701 *1-564-511-11 PLUG, CONNECTOR 8P CN1702 *1-564-516-11 PLUG, CONNECTOR 13P CN1703 *1-779-890-11 CONNECTOR, BOARD TO BOARD 10P CN1705 *1-564-505-11 PLUG, CONNECTOR 2P
CN1708 *1-564-510-11 PLUG, CONNECTOR 7P CN1801 1-695-299-11 CONNECTOR, BOARD TO BOARD 50P CN1802 *1-764-334-11 PLUG, CONNECTOR 11P CN1803 1-564-513-11 PLUG, CONNECTOR 10P CN1804 *1-564-508-11 PLUG, CONNECTOR 5P
CN1805 *1-779-890-11 CONNECTOR, BOARD TO BOARD 10P CN1806 *1-779-890-11 CONNECTOR, BOARD TO BOARD 10P CN1807 *1-564-511-11 PLUG, CONNECTOR 8P CN1808 *1-564-510-11 PLUG, CONNECTOR 7P
<DIODE>
D1501 8-719-109-89 DIODE RD5.6ESB2 D1502 8-719-908-03 DIODE GP08D D1503 8-719-908-03 DIODE GP08D D1504 8-719-991-33 DIODE 1SS133T-77 D1505 8-719-988-61 DIODE 1SS355TE-17
D1601 8-719-991-33 DIODE 1SS133T-77 D1603 8-719-991-33 DIODE 1SS133T-77 D1604 8-719-991-33 DIODE 1SS133T-77 D1606 8-719-991-33 DIODE 1SS133T-77 D1611 8-719-921-86 DIODE MTZJ-13
D1612 8-719-991-33 DIODE 1SS133T-77 D1613 8-719-921-86 DIODE MTZJ-13 D1614 8-719-991-33 DIODE 1SS133T-77 D1615 8-719-991-33 DIODE 1SS133T-77 D1616 8-719-991-33 DIODE 1SS133T-77
D1617 8-719-403-00 DIODE MA3240-TX D1618 8-719-991-33 DIODE 1SS133T-77 D1619 8-719-991-33 DIODE 1SS133T-77 D1620 8-719-403-00 DIODE MA3240-TX D1621 8-719-403-00 DIODE MA3240-TX
D1622 8-719-403-00 DIODE MA3240-TX D1703 8-719-109-89 DIODE RD5.6ESB2 D1704 8-719-109-89 DIODE RD5.6ESB2 D1705 8-719-109-84 DIODE RD5.1ESB1 D1706 8-719-109-84 DIODE RD5.1ESB1
D1707 8-719-109-84 DIODE RD5.1ESB1 D1708 8-719-109-84 DIODE RD5.1ESB1 D1709 8-719-109-81 DIODE RD4.7ESB2 D1710 8-719-109-81 DIODE RD4.7ESB2 D1711 8-719-109-81 DIODE RD4.7ESB2
D1712 8-719-109-81 DIODE RD4.7ESB2 D1801 8-719-923-60 DIODE MTZJ-T-77-9.1A D1802 8-719-923-60 DIODE MTZJ-T-77-9.1A D1803 8-719-923-60 DIODE MTZJ-T-77-9.1A
D
C1650 1-163-251-11 CERAMIC CHIP 100pF 5% 50V C1651 1-163-251-11 CERAMIC CHIP 100pF 5% 50V C1701 1-126-960-11 ELECT 1µF 20% 50V C1702 1-126-960-11 ELECT 1µF 20% 50V C1703 1-126-964-11 ELECT 10µF 20% 50V
C1704 1-126-964-11 ELECT 10µF 20% 50V C1705 1-163-251-11 CERAMIC CHIP 100pF 5% 50V C1706 1-163-251-11 CERAMIC CHIP 100pF 5% 50V C1707 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C1708 1-126-935-11 ELECT 470µF 20% 16V
C1709 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C1710 1-163-243-11 CERAMIC CHIP 47pF 5% 50V C1711 1-163-243-11 CERAMIC CHIP 47pF 5% 50V C1715 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C1716 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V
C1717 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C1718 1-126-968-11 ELECT 100µF 20% 50V C1719 1-126-968-11 ELECT 100µF 20% 50V C1720 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C1721 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V
C1723 1-163-235-11 CERAMIC CHIP 22pF 5% 50V C1724 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V C1725 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V C1726 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V C1727 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V
C1802 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C1803 1-126-935-11 ELECT 470µF 20% 16V C1804 1-126-964-11 ELECT 10µF 20% 50V C1805 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C1806 1-104-665-11 ELECT 100µF 20% 25V
C1807 1-126-964-11 ELECT 10µF 20% 50V C1808 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C1809 1-104-665-11 ELECT 100µF 20% 25V C1810 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C1811 1-104-665-11 ELECT 100µF 20% 25V
C1812 1-126-964-11 ELECT 10µF 20% 50V C1813 1-104-666-11 ELECT 220µF 20% 25V C1814 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V C1815 1-104-666-11 ELECT 220µF 20% 25V C1816 1-126-964-11 ELECT 10µF 20% 50V
C1817 1-126-964-11 ELECT 10µF 20% 50V C1818 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C1819 1-163-133-00 CERAMIC CHIP 470pF 5% 50V C1820 1-163-133-00 CERAMIC CHIP 470pF 5% 50V C1821 1-126-964-11 ELECT 10µF 20% 50V
C1822 1-164-005-11 CERAMIC CHIP 0.47µF 25V C1823 1-163-251-11 CERAMIC CHIP 100pF 5% 50V C1824 1-164-005-11 CERAMIC CHIP 0.47µF 25V C1825 1-163-251-11 CERAMIC CHIP 100pF 5% 50V C1826 1-104-665-11 ELECT 100µF 20% 25V
C1827 1-104-664-11 ELECT 47µF 20% 25V C1828 1-104-664-11 ELECT 47µF 20% 25V C1829 1-104-664-11 ELECT 47µF 20% 25V C1830 1-126-964-11 ELECT 10µF 20% 50V
Page 43
– 105 –
The componants identified byshading and mark are criti-cal for safety.Replace only with part numberspecified.
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK
Q1602 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q1603 8-729-027-56 TRANSISTOR DTC143TKA-T146 Q1604 8-729-027-56 TRANSISTOR DTC143TKA-T146 Q1605 8-729-027-56 TRANSISTOR DTC143TKA-T146 Q1607 8-729-120-28 TRANSISTOR 2SC1623-L5L6
Q1608 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q1609 1-801-806-11 TRANSISTOR DTC144EKA-T146 Q1610 8-729-920-72 TRANSISTOR 2SA1037K-T-146-QR Q1611 8-729-027-56 TRANSISTOR DTC143TKA-T146 Q1612 8-729-027-56 TRANSISTOR DTC143TKA-T146
Q1613 8-729-027-56 TRANSISTOR DTC143TKA-T146 Q1614 8-729-920-72 TRANSISTOR 2SA1037K-T-146-QR Q1615 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q1616 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q1617 8-729-920-72 TRANSISTOR 2SA1037K-T-146-QR
Q1701 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q1702 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q1703 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q1704 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q1705 8-729-120-28 TRANSISTOR 2SC1623-L5L6
Q1706 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q1707 1-801-806-11 TRANSISTOR DTC144EKA-T146 Q1708 8-729-027-38 TRANSISTOR DTA144EKA-T146 Q1709 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q1710 8-729-120-28 TRANSISTOR 2SC1623-L5L6
Q1711 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q1801 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q1802 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q1803 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q1804 8-729-120-28 TRANSISTOR 2SC1623-L5L6
Q1805 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q1806 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q1807 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q1808 8-729-920-72 TRANSISTOR 2SA1037K-T-146-QR Q1809 8-729-120-28 TRANSISTOR 2SC1623-L5L6
<RESISTOR>
R1501 1-216-353-00 METAL OXIDE 2.2 5% 1W F R1502 1-216-671-11 METAL CHIP 6.8K 0.50%1/10W R1504 1-216-675-91 METAL CHIP 10K 0.50%1/10W R1505 1-249-377-11 CARBON 0.47 5% 1/4W F R1506 1-215-888-00 METAL OXIDE 220 5% 2W F
R1507 1-216-081-00 RES,CHIP 22K 5% 1/10W R1508 1-249-383-11 CARBON 1.5 5% 1/4W F R1509 1-216-671-11 METAL CHIP 6.8K 0.50%1/10W R1510 1-216-675-91 METAL CHIP 10K 0.50%1/10W R1511 1-216-057-00 RES,CHIP 2.2K 5% 1/10W
R1512 1-216-085-00 RES,CHIP 33K 5% 1/10W R1513 1-216-049-00 RES,CHIP 1K 5% 1/10W R1514 1-216-073-00 RES,CHIP 10K 5% 1/10W R1515 1-216-073-00 RES,CHIP 10K 5% 1/10W R1516 1-216-073-00 RES,CHIP 10K 5% 1/10W
R1517 1-216-081-00 RES,CHIP 22K 5% 1/10W R1518 1-216-353-00 METAL OXIDE 2.2 5% 1W F R1519 1-216-073-00 RES,CHIP 10K 5% 1/10W R1520 1-216-089-00 RES,CHIP 47K 5% 1/10W
D
D1804 8-719-923-60 DIODE MTZJ-T-77-9.1A
D1805 8-719-923-60 DIODE MTZJ-T-77-9.1A D1806 8-719-923-60 DIODE MTZJ-T-77-9.1A
<IC>
IC1501 8-759-192-71 IC STV9379 IC1502 8-759-251-31 IC CA0007AM IC1503 8-759-998-98 IC LM358D IC1602 8-759-250-68 IC TDA7264 IC1603 8-759-502-21 IC TDA2822M
IC1701 8-752-908-27 IC CXP86213-003S IC1702 8-759-527-76 IC M24C08-MN6T IC1703 8-759-100-96 IC µPC4558G2 IC1704 8-759-100-96 IC µPC4558G2 IC1706 8-759-352-91 IC PST9143NL
IC1801 8-759-144-82 IC µPC2405HF IC1802 8-759-095-63 IC PQ09RF2 IC1803 8-759-231-58 IC TA7812S IC1804 8-759-069-28 IC PQ05RF11 IC1805 8-759-100-96 IC µPC4558G2
<JACK>
J1601 1-784-653-11 JACK, PHONO 2P
<CHIP, CONDUCTOR>
JR1502 1-216-295-91 SHORT 0 JR1503 1-216-295-91 SHORT 0 JR1504 1-216-295-91 SHORT 0 JR1505 1-216-295-91 SHORT 0 JR1506 1-216-295-91 SHORT 0
JR1508 1-216-295-91 SHORT 0 JR1510 1-216-295-91 SHORT 0 JR1511 1-216-295-91 SHORT 0 JR1512 1-216-295-91 SHORT 0 JR1513 1-216-295-91 SHORT 0
JR1514 1-216-295-91 SHORT 0 JR1701 1-216-295-91 SHORT 0
<COIL>
L1501 1-412-524-11 INDUCTOR 8.2µH L1601 1-402-711-11 INDUCTOR 0µH L1602 1-402-711-11 INDUCTOR 0µH L1701 1-408-603-31 INDUCTOR 10µH L1702 1-408-598-31 INDUCTOR 3.9µH
L1801 1-408-603-31 INDUCTOR 10µH
<TRANSISTOR>
Q1501 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q1502 8-729-920-72 TRANSISTOR 2SA1037K-T-146-QR Q1503 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q1505 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q1601 8-729-027-56 TRANSISTOR DTC143TKA-T146
Page 44
– 106 –
The componants identified byshading and mark are criti-cal for safety.Replace only with part numberspecified.
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK
R1650 1-216-033-00 RES,CHIP 220 5% 1/10W R1651 1-216-073-00 RES,CHIP 10K 5% 1/10W R1652 1-216-099-00 RES,CHIP 120K 5% 1/10W R1653 1-216-049-91 RES,CHIP 1K 5% 1/10W R1654 1-216-049-91 RES,CHIP 1K 5% 1/10W
R1655 1-216-073-00 RES,CHIP 10K 5% 1/10W R1656 1-216-295-00 SHORT 0 R1701 1-216-065-00 RES,CHIP 4.7K 5% 1/10W R1702 1-216-065-00 RES,CHIP 4.7K 5% 1/10W R1703 1-216-065-00 RES,CHIP 4.7K 5% 1/10W
R1704 1-216-065-00 RES,CHIP 4.7K 5% 1/10W R1705 1-216-065-00 RES,CHIP 4.7K 5% 1/10W R1706 1-216-065-00 RES,CHIP 4.7K 5% 1/10W R1707 1-216-025-00 RES,CHIP 100 5% 1/10W R1708 1-216-025-00 RES,CHIP 100 5% 1/10W
R1709 1-216-025-00 RES,CHIP 100 5% 1/10W R1710 1-216-049-00 RES,CHIP 1K 5% 1/10W R1711 1-216-089-00 RES,CHIP 47K 5% 1/10W R1712 1-216-073-00 RES,CHIP 10K 5% 1/10W R1713 1-216-089-00 RES,CHIP 47K 5% 1/10W
R1714 1-216-073-00 RES,CHIP 10K 5% 1/10W R1715 1-216-089-00 RES,CHIP 47K 5% 1/10W R1716 1-216-033-00 RES,CHIP 220 5% 1/10W R1717 1-216-089-00 RES,CHIP 47K 5% 1/10W R1718 1-216-057-00 RES,CHIP 2.2K 5% 1/10W
R1719 1-216-033-00 RES,CHIP 220 5% 1/10W R1720 1-216-033-00 RES,CHIP 220 5% 1/10W R1721 1-216-033-00 RES,CHIP 220 5% 1/10W R1722 1-216-033-00 RES,CHIP 220 5% 1/10W R1725 1-216-065-00 RES,CHIP 4.7K 5% 1/10W
R1726 1-216-295-00 SHORT 0 R1727 1-216-033-00 RES,CHIP 220 5% 1/10W R1728 1-216-025-00 RES,CHIP 100 5% 1/10W R1729 1-216-025-00 RES,CHIP 100 5% 1/10W R1730 1-216-057-00 RES,CHIP 2.2K 5% 1/10W
R1731 1-216-033-00 RES,CHIP 220 5% 1/10W R1732 1-216-049-00 RES,CHIP 1K 5% 1/10W R1733 1-216-049-00 RES,CHIP 1K 5% 1/10W R1734 1-216-049-00 RES,CHIP 1K 5% 1/10W R1735 1-216-089-00 RES,CHIP 47K 5% 1/10W
R1736 1-216-033-00 RES,CHIP 220 5% 1/10W R1737 1-216-033-00 RES,CHIP 220 5% 1/10W R1738 1-216-025-00 RES,CHIP 100 5% 1/10W R1739 1-216-073-00 RES,CHIP 10K 5% 1/10W R1740 1-216-073-00 RES,CHIP 10K 5% 1/10W
R1741 1-216-033-00 RES,CHIP 220 5% 1/10W R1742 1-216-033-00 RES,CHIP 220 5% 1/10W R1743 1-216-025-00 RES,CHIP 100 5% 1/10W R1744 1-216-033-00 RES,CHIP 220 5% 1/10W R1745 1-216-073-00 RES,CHIP 10K 5% 1/10W
R1746 1-216-025-00 RES,CHIP 100 5% 1/10W R1747 1-216-025-00 RES,CHIP 100 5% 1/10W R1748 1-216-025-00 RES,CHIP 100 5% 1/10W R1749 1-216-033-00 RES,CHIP 220 5% 1/10W R1750 1-216-073-00 RES,CHIP 10K 5% 1/10W
R1751 1-216-033-00 RES,CHIP 220 5% 1/10W R1752 1-216-025-00 RES,CHIP 100 5% 1/10W
D
R1521 1-216-097-00 RES,CHIP 100K 5% 1/10W
R1522 1-216-089-91 RES,CHIP 47K 5% 1/10W R1525 1-216-083-00 RES,CHIP 27K 5% 1/10W R1526 1-216-083-00 RES,CHIP 27K 5% 1/10W R1527 1-216-121-91 RES,CHIP 1M 5% 1/10W R1528 1-216-121-91 RES,CHIP 1M 5% 1/10W
R1529 1-216-025-00 RES,CHIP 100 5% 1/10W R1530 1-216-097-00 RES,CHIP 100K 5% 1/10W R1531 1-216-089-00 RES,CHIP 47K 5% 1/10W R1532 1-216-025-00 RES,CHIP 100 5% 1/10W R1533 1-249-377-11 CARBON 0.47 5% 1/4W F
R1534 1-216-089-91 RES,CHIP 47K 5% 1/10W R1537 1-216-073-00 RES,CHIP 10K 5% 1/10W R1538 1-216-083-00 RES,CHIP 27K 5% 1/10W R1539 1-216-073-00 RES,CHIP 10K 5% 1/10W R1540 1-216-091-00 RES,CHIP 56K 5% 1/10W
R1541 1-216-091-00 RES,CHIP 56K 5% 1/10W R1542 1-216-093-91 RES,CHIP 68K 5% 1/10W R1543 1-216-093-91 RES,CHIP 68K 5% 1/10W R1601 1-216-025-00 RES,CHIP 100 5% 1/10W R1602 1-216-041-00 RES,CHIP 470 5% 1/10W
R1603 1-216-041-00 RES,CHIP 470 5% 1/10W R1604 1-216-113-00 RES,CHIP 470K 5% 1/10W R1605 1-216-113-00 RES,CHIP 470K 5% 1/10W R1606 1-249-397-11 CARBON 22 5% 1/4W F R1607 1-249-397-11 CARBON 22 5% 1/4W F
R1608 1-249-425-11 CARBON 4.7K 5% 1/4W F R1609 1-216-081-00 RES,CHIP 22K 5% 1/10W R1610 1-216-081-00 RES,CHIP 22K 5% 1/10W R1611 1-249-425-11 CARBON 4.7K 5% 1/4W F R1614 1-216-357-00 METAL OXIDE 4.7 5% 1W F
R1615 1-216-357-00 METAL OXIDE 4.7 5% 1W F R1617 1-216-069-00 RES,CHIP 6.8K 5% 1/10W R1618 1-216-081-00 RES,CHIP 22K 5% 1/10W R1620 1-216-065-00 RES,CHIP 4.7K 5% 1/10W R1625 1-216-061-00 RES,CHIP 3.3K 5% 1/10W
R1626 1-216-061-00 RES,CHIP 3.3K 5% 1/10W R1629 1-216-049-00 RES,CHIP 1K 5% 1/10W R1630 1-216-081-00 RES,CHIP 22K 5% 1/10W R1631 1-249-389-11 CARBON 4.7 5% 1/4W F R1632 1-216-089-91 RES,CHIP 47K 5% 1/10W
R1633 1-216-089-91 RES,CHIP 47K 5% 1/10W R1634 1-216-081-00 RES,CHIP 22K 5% 1/10W R1635 1-216-049-91 RES,CHIP 1K 5% 1/10W R1636 1-216-075-00 RES,CHIP 12K 5% 1/10W R1637 1-216-049-00 RES,CHIP 1K 5% 1/10W
R1638 1-216-073-00 RES,CHIP 10K 5% 1/10W R1639 1-216-049-91 RES,CHIP 1K 5% 1/10W R1640 1-216-025-00 RES,CHIP 100 5% 1/10W R1641 1-216-065-00 RES,CHIP 4.7K 5% 1/10W R1642 1-216-049-00 RES,CHIP 1K 5% 1/10W
R1643 1-216-073-00 RES,CHIP 10K 5% 1/10W R1644 1-216-075-00 RES,CHIP 12K 5% 1/10W R1645 1-216-041-00 RES,CHIP 470 5% 1/10W R1648 1-249-381-11 CARBON 1 5% 1/4W F R1649 1-216-089-00 RES,CHIP 47K 5% 1/10W
Page 45
– 107 –
The componants identified byshading and mark are criti-cal for safety.Replace only with part numberspecified.
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK
R1826 1-216-089-00 RES,CHIP 47K 5% 1/10W
R1827 1-216-089-00 RES,CHIP 47K 5% 1/10W R1828 1-216-089-00 RES,CHIP 47K 5% 1/10W R1829 1-216-089-00 RES,CHIP 47K 5% 1/10W R1830 1-216-073-00 RES,CHIP 10K 5% 1/10W R1831 1-216-063-91 RES,CHIP 3.9K 5% 1/10W
R1832 1-216-049-00 RES,CHIP 1K 5% 1/10W R1833 1-216-041-00 RES,CHIP 470 5% 1/10W R1834 1-216-049-00 RES,CHIP 1K 5% 1/10W R1835 1-216-049-00 RES,CHIP 1K 5% 1/10W R1836 1-216-049-00 RES,CHIP 1K 5% 1/10W
R1837 1-216-049-00 RES,CHIP 1K 5% 1/10W R1838 1-216-041-00 RES,CHIP 470 5% 1/10W R1839 1-216-049-00 RES,CHIP 1K 5% 1/10W R1840 1-216-049-00 RES,CHIP 1K 5% 1/10W R1841 1-216-049-00 RES,CHIP 1K 5% 1/10W
R1842 1-216-049-00 RES,CHIP 1K 5% 1/10W R1843 1-216-041-00 RES,CHIP 470 5% 1/10W R1844 1-216-049-00 RES,CHIP 1K 5% 1/10W R1845 1-216-049-00 RES,CHIP 1K 5% 1/10W R1846 1-216-049-00 RES,CHIP 1K 5% 1/10W
R1847 1-216-049-00 RES,CHIP 1K 5% 1/10W R1848 1-216-049-00 RES,CHIP 1K 5% 1/10W R1849 1-216-041-00 RES,CHIP 470 5% 1/10W
<RELAY>
RY1601 1-755-028-11 RELAY RY1602 1-755-028-11 RELAY
<TERMINAL BOARD>
TB1601 1-694-303-11 TERMINAL, PUSH
<CRYSTAL>
X1701 1-579-125-11 VIBRATOR, CERAMIC (8.0MHz)
*****************************************************************************
* A-1346-679-AE BOARD, COMPLETE***************************
4-382-854-11 SCREW (M3X10), P, SW (+)7-682-952-09 SCREW +PSW 3X16
<CAPACITOR>
C502 1-126-959-11 ELECT 0.47µF 20% 50V C505 1-130-471-00 FILM 0.001µF 5% 50V C506 1-126-933-11 ELECT 100µF 20% 16V C507 1-126-965-11 ELECT 22µF 20% 50V C508 1-102-228-00 CERAMIC 470pF 10% 500V
C509 1-106-383-00 MYLAR 0.047µF 10% 200V C511 1-130-475-00 MYLAR 0.0022µF 5% 50V C512 1-136-479-11 FILM 0.001µF 5% 50V
ED
R1753 1-216-073-00 RES,CHIP 10K 5% 1/10W R1754 1-216-073-00 RES,CHIP 10K 5% 1/10W R1755 1-216-025-00 RES,CHIP 100 5% 1/10W
R1756 1-216-073-00 RES,CHIP 10K 5% 1/10W R1757 1-216-073-00 RES,CHIP 10K 5% 1/10W R1758 1-216-025-00 RES,CHIP 100 5% 1/10W R1759 1-216-073-00 RES,CHIP 10K 5% 1/10W R1760 1-216-073-00 RES,CHIP 10K 5% 1/10W
R1762 1-216-065-00 RES,CHIP 4.7K 5% 1/10W R1763 1-216-666-11 METAL CHIP 4.3K 0.50%1/10W R1764 1-216-065-00 RES,CHIP 4.7K 5% 1/10W R1765 1-216-073-00 RES,CHIP 10K 5% 1/10W R1766 1-216-049-91 RES,CHIP 1K 5% 1/10W
R1767 1-216-113-00 RES,CHIP 470K 5% 1/10W R1768 1-216-049-91 RES,CHIP 1K 5% 1/10W R1769 1-216-115-00 RES,CHIP 560K 5% 1/10W R1770 1-216-049-91 RES,CHIP 1K 5% 1/10W R1771 1-216-113-00 RES,CHIP 470K 5% 1/10W
R1772 1-216-049-91 RES,CHIP 1K 5% 1/10W R1773 1-216-073-00 RES,CHIP 10K 5% 1/10W R1774 1-216-025-00 RES,CHIP 100 5% 1/10W R1775 1-216-115-00 RES,CHIP 560K 5% 1/10W R1778 1-216-049-91 RES,CHIP 1K 5% 1/10W
R1786 1-216-025-00 RES,CHIP 100 5% 1/10W R1787 1-216-025-00 RES,CHIP 100 5% 1/10W R1788 1-216-025-00 RES,CHIP 100 5% 1/10W R1789 1-216-049-00 RES,CHIP 1K 5% 1/10W R1790 1-216-025-00 RES,CHIP 100 5% 1/10W
R1791 1-216-025-00 RES,CHIP 100 5% 1/10W R1792 1-216-089-00 RES,CHIP 47K 5% 1/10W R1793 1-216-089-00 RES,CHIP 47K 5% 1/10W R1794 1-216-089-00 RES,CHIP 47K 5% 1/10W R1795 1-216-089-00 RES,CHIP 47K 5% 1/10W
R1802 1-215-925-11 METAL OXIDE 22K 5% 3W F R1803 1-216-073-00 RES,CHIP 10K 5% 1/10W R1804 1-216-113-00 RES,CHIP 470K 5% 1/10W R1805 1-216-113-00 RES,CHIP 470K 5% 1/10W R1806 1-216-023-00 RES,CHIP 82 5% 1/10W
R1807 1-216-059-00 RES,CHIP 2.7K 5% 1/10W R1808 1-216-059-00 RES,CHIP 2.7K 5% 1/10W R1809 1-216-097-00 RES,CHIP 100K 5% 1/10W R1810 1-216-023-00 RES,CHIP 82 5% 1/10W R1811 1-216-025-00 RES,CHIP 100 5% 1/10W
R1812 1-216-025-00 RES,CHIP 100 5% 1/10W R1813 1-216-049-00 RES,CHIP 1K 5% 1/10W R1814 1-216-023-00 RES,CHIP 82 5% 1/10W R1815 1-216-025-00 RES,CHIP 100 5% 1/10W R1816 1-216-025-00 RES,CHIP 100 5% 1/10W
R1817 1-216-025-00 RES,CHIP 100 5% 1/10W R1818 1-216-059-00 RES,CHIP 2.7K 5% 1/10W R1819 1-216-059-00 RES,CHIP 2.7K 5% 1/10W R1820 1-216-059-00 RES,CHIP 2.7K 5% 1/10W R1821 1-216-025-00 RES,CHIP 100 5% 1/10W
R1822 1-216-089-00 RES,CHIP 47K 5% 1/10W R1823 1-216-089-00 RES,CHIP 47K 5% 1/10W R1824 1-216-089-00 RES,CHIP 47K 5% 1/10W R1825 1-216-089-00 RES,CHIP 47K 5% 1/10W
Page 46
– 108 –
The componants identified byshading and mark are criti-cal for safety.Replace only with part numberspecified.
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK
C824 1-126-964-11 ELECT 10µF 20% 50V C825 1-104-665-11 ELECT 100µF 20% 25V C826 1-136-165-00 FILM 0.1µF 5% 50V C827 1-126-964-11 ELECT 0µF 20% 50V C828 1-102-824-00 CERAMIC 470pF 5% 50V
C829 1-126-959-11 ELECT 0.47µF 20% 50V C830 1-102-824-00 CERAMIC 470pF 5% 50V C831 1-126-960-11 ELECT 1µF 20% 50V C832 1-126-960-11 ELECT 1µF 20% 50V C833 1-126-960-11 ELECT 1µF 20% 50V
C834 1-126-968-11 ELECT 100µF 20% 50V C835 1-126-967-11 ELECT 47µF 20% 50V C836 1-136-169-00 FILM 0.22µF 5% 50V C837 1-126-963-11 ELECT 4.7µF 20% 50V C838 1-104-665-11 ELECT 100µF 20% 25V
C839 1-137-374-11 FILM 0.047µF 5% 50V C840 1-104-665-11 ELECT 100µF 20% 25V C841 1-137-374-11 FILM 0.047µF 5% 50V C842 1-137-374-11 FILM 0.047µF 5% 50V C844 1-126-933-11 ELECT 100µF 20% 16V
C845 1-126-933-11 ELECT 100µF 20% 16V C846 1-126-933-11 ELECT 100µF 20% 16V C847 1-126-933-11 ELECT 100µF 20% 16V C848 1-126-933-11 ELECT 100µF 20% 16V C849 1-102-973-00 CERAMIC 100pF 5% 50V
C850 1-102-973-00 CERAMIC 100pF 5% 50V C851 1-137-374-11 FILM 0.047µF 5% 50V C852 1-137-374-11 FILM 0.047µF 5% 50V C853 1-137-374-11 FILM 0.047µF 5% 50V C854 1-126-933-11 ELECT 100µF 20% 16V
C855 1-102-973-00 CERAMIC 100pF 5% 50V C856 1-102-973-00 CERAMIC 100pF 5% 50V C857 1-126-933-11 ELECT 100µF 20% 16V C858 1-104-665-11 ELECT 100µF 20% 25V C859 1-104-665-11 ELECT 100µF 20% 25V
C860 1-126-933-11 ELECT 100µF 20% 16V C861 1-137-374-11 FILM 0.047µF 5% 50V C862 1-137-374-11 FILM 0.047µF 5% 50V C863 1-137-374-11 FILM 0.047µF 5% 50V C864 1-126-933-11 ELECT 100µF 20% 16V
C865 1-137-366-11 FILM 0.0022µF 5% 50V C866 1-136-177-00 FILM 1µF 5% 50V C867 1-104-664-11 ELECT 47µF 20% 25V C868 1-164-096-11 CERAMIC 0.01µF 50V C869 1-130-487-00 MYLAR 0.022µF 5% 50V
C870 1-164-096-11 CERAMIC 0.01µF 50V C872 1-126-960-11 ELECT 1µF 20% 50V C873 1-126-964-11 ELECT 10µF 20% 50V C876 1-102-973-00 CERAMIC 100pF 5% 50V C877 1-102-973-00 CERAMIC 100pF 5% 50V
C880 1-104-664-11 ELECT 47µF 20% 5V C881 1-102-973-00 CERAMIC 100pF 5% 50V C882 1-102-973-00 CERAMIC 100pF 5% 50V C883 1-102-973-00 CERAMIC 100pF 5% 50V C884 1-104-665-11 ELECT 100µF 20% 25V
C885 1-104-664-11 ELECT 47µF 20% 25V
E
C513 1-126-965-11 ELECT 22µF 20% 50V C514 ! 1-162-116-91 CERAMIC 680pF 10% 2KV
C515 ! 1-125-831-91 FILM 0.033µF 3% 630V C516 ! 1-117-648-11 FILM 15000pF 3% 1.2KV C518 1-130-495-00 FILM 0.1µF 5% 50V C519 1-106-359-00 MYLAR 0.0047µF 10% 100V C520 1-162-116-00 CERAMIC 680pF 10% 2KV
C521 1-162-116-00 CERAMIC 680pF 10% 2KV C523 1-115-521-11 FILM 0.82µF 5% 200V C524 1-106-359-00 MYLAR 0.0047µF 10% 100V C526 1-102-228-00 CERAMIC 470pF 10% 500V C527 1-126-970-11 ELECT 330µF 20% 50V
C528 1-107-957-11 ELECT 1µF 20% 250V C529 1-109-844-11 FILM 0.68µF 5% 250V C530 1-107-648-91 ELECT 100µF 20% 160V C531 1-126-971-11 ELECT 470µF 20% 50V C532 1-126-971-11 ELECT 470µF 20% 50V
C533 1-107-655-11 ELECT 47µF 20% 250V C535 1-106-387-00 MYLAR 0.068µF 10% 200V C536 1-137-374-11 FILM 0.047µF 5% 50V C537 1-126-968-11 ELECT 100µF 20% 50V C538 1-126-968-11 ELECT 100µF 20% 50V
C539 1-162-114-00 CERAMIC 0.0047µF 2KV C540 1-137-372-11 FILM 0.022µF 5% 50V C541 1-137-374-11 FILM 0.047µF 5% 50V C542 1-126-934-11 ELECT 220µF 20% 16V C544 1-104-665-11 ELECT 100µF 20% 25V
C545 1-104-665-11 ELECT 100µF 20% 25V C548 1-102-244-00 CERAMIC 220pF 10% 500V C550 1-126-935-11 ELECT 470µF 20% 16V C551 1-126-935-11 ELECT 470µF 20% 16V C554 1-130-062-91 FILM 0.0056µF 5% 630V
C555 1-126-960-11 ELECT 1µF 20% 50V C556 1-130-495-00 MYLAR 0.1µF 5% 50V C701 1-126-933-11 ELECT 100µF 20% 16V C801 1-104-665-11 ELECT 100µF 20% 25V C802 1-104-665-11 ELECT 100µF 20% 25V
C803 1-126-934-11 ELECT 220µF 20% 16V C804 1-126-934-11 ELECT 220µF 20% 16V C805 1-126-934-11 ELECT 220µF 20% 16V C806 1-126-934-11 ELECT 220µF 20% 16V C807 1-137-374-11 FILM 0.047µF 5% 50V
C808 1-137-374-11 FILM 0.047µF 5% 50V C809 1-137-374-11 FILM 0.047µF 5% 50V C810 1-137-374-11 FILM 0.047µF 5% 50V C811 1-102-074-00 CERAMIC 0.001µF 10% 50V C812 1-136-169-00 FILM 0.22µF 5% 50V
C813 1-137-374-11 FILM 0.047µF 5% 50V C815 1-104-665-11 ELECT 100µF 20% 25V C816 1-130-014-00 FILM 470pF 5% 50V C817 1-104-664-11 ELECT 47µF 20% 25V C818 1-126-933-11 ELECT 100µF 20% 16V
C819 1-104-664-11 ELECT 47µF 20% 25V C820 1-102-129-00 CERAMIC 0.01µF 10% 50V C821 1-130-495-00 MYLAR 0.1µF 5% 50V C822 1-107-648-91 ELECT 100µF 20% 160V C823 1-104-664-11 ELECT 47µF 20% 25V
Page 47
– 109 –
The componants identified byshading and mark are criti-cal for safety.Replace only with part numberspecified.
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK
D842 8-719-991-33 DIODE 1SS133T-77 D845 8-719-991-33 DIODE 1SS133T-77 D846 8-719-991-33 DIODE 1SS133T-77
<FERRITE BEAD>
FB501 1-410-397-21 FERRITE BEAD INDUCTOR 1.1µH
<IC>
IC501 8-759-133-90 IC µPC339C IC801 8-759-327-51 IC PA0053B IC802 8-759-327-51 IC PA0053B IC803 8-759-183-37 IC CA0007AD IC804 8-759-464-79 IC PM0011AS
IC805 8-759-711-28 IC NJM2058D IC806 8-759-464-79 IC PM0011AS IC808 8-759-464-79 IC PM0011AS IC809 8-749-014-37 IC STK392-150 IC810 8-749-014-37 IC STK392-150
IC811 8-759-981-96 IC RC4560D IC812 8-759-701-56 IC NJM78M05FA IC813 8-759-701-65 IC NJM79M05FA
<COIL>
L502 1-410-478-11 INDUCTOR 47µH L503 1-459-111-00 INDUCTOR 10mH L505 ! 1-416-637-11 COIL, HORIZONTAL LINEARITY L506 1-412-552-11 INDUCTOR 2.2mH L801 1-406-979-11 INDUCTOR 220µH
L802 1-406-979-11 INDUCTOR 220µH L803 1-406-665-11 INDUCTOR 100µH
<NEON LAMP>
NL501 1-519-108-99 LAMP, NEON
<IC LINK>
PS601! 1-533-597-31 LINK, IC (5A/90V AC,60V DC) PS602! 1-533-597-31 LINK, IC (5A/90V AC,60V DC) PS603! 1-533-593-31 LINK, IC (2A/90V AC,60V DC) PS604! 1-533-593-31 LINK, IC (2A/90V AC,60V DC) PS605! 1-533-593-31 LINK, IC (2A/90V AC,60V DC)
PS606! 1-533-593-31 LINK, IC (2A/90V AC,60V DC) PS607! 1-533-593-31 LINK, IC (2A/90V AC,60V DC) PS608! 1-533-593-31 LINK, IC (2A/90V AC,60V DC)
<TRANSISTOR>
Q501 8-729-119-80 TRANSISTOR 2SC2688-LK Q502 8-729-044-29 TRANSISTOR 2SD2539(LBSONY-1) Q503 8-729-119-76 TRANSISTOR 2SA1175-HFE Q504 8-729-823-81 TRANSISTOR 2SC4632LS-CB7 Q505 8-729-038-83 TRANSISTOR 2SK2251-01-F19
Q506 8-729-119-78 TRANSISTOR 2SC2785-HFE
E
C886 1-102-973-00 CERAMIC 100pF 5% 50V C887 1-102-973-00 CERAMIC 100pF 5% 50V C888 1-102-973-00 CERAMIC 100pF 5% 50V C889 1-104-665-11 ELECT 100µF 20% 25V
C897 1-104-665-11 ELECT 100µF 20% 25V
<CONNECTOR>
CN501 * 1-564-513-11 PLUG, CONNECTOR 10P CN502 * 1-580-689-11 PIN, CONNECTOR (PC BOARD) 4P CN503 * 1-580-689-11 PIN, CONNECTOR (PC BOARD) 4P CN504 * 1-580-689-11 PIN, CONNECTOR (PC BOARD) 4P CN505 * 1-506-371-00 PIN, CONNECTOR 2P
CN506 * 1-779-892-11 CONNECTOR, BOARD TO BOARD 10P CN507 * 1-564-507-11 PLUG, CONNECTOR 4P CN508 1-695-915-11 TAB (CONTACT) CN651 * 1-779-892-11 CONNECTOR, BOARD TO BOARD 10P CN652 * 1-779-892-11 CONNECTOR, BOARD TO BOARD 10P
CN801 * 1-564-507-11 PLUG, CONNECTOR 4P CN802 * 1-564-507-11 PLUG, CONNECTOR 4P CN803 * 1-564-507-11 PLUG, CONNECTOR 4P CN804 * 1-779-892-11 CONNECTOR, BOARD TO BOARD 10P CN805 * 1-508-766-00 PIN, CONNECTOR (5mm PITCH) 4P
CN806 * 1-508-765-00 PIN, CONNECTOR (5mm PITCH) 3P CN807 * 1-564-509-11 PLUG, CONNECTOR 6P CN808 * 1-573-986-11 PIN, CONNECTOR (PC BOARD) 5P CN810 * 1-573-963-11 PIN, CONNECTOR (PC BOARD) 3P
<DIODE>
D501 8-719-991-33 DIODE 1SS133T-77 D502 8-719-991-33 DIODE 1SS133T-77 D503 8-719-991-33 DIODE 1SS133T-77 D504 8-719-921-63 DIODE MTZJ-7.5B D507 8-719-302-43 DIODE EL1Z
D508 8-719-900-26 DIODE ERD29-08J D509 8-719-945-80 DIODE ERC06-15S D510 8-719-991-33 DIODE 1SS133T-77 D511 8-719-302-43 DIODE EL1Z D512 8-719-991-33 DIODE 1SS133T-77
D513 8-719-302-43 DIODE EL1Z D514 8-719-908-03 DIODE GP08D D515 8-719-908-03 DIODE GP08D D517 8-719-018-82 DIODE RGP02-20EL-6394 D519 8-719-991-33 DIODE 1SS133T-77
D520 8-719-302-43 DIODE EL1Z D521 8-719-302-43 DIODE EL1Z D522 8-719-991-33 DIODE 1SS133T-77 D523 8-719-991-33 DIODE 1SS133T-77 D524 8-719-991-33 DIODE 1SS133T-77
D527 8-719-109-85 DIODE RD5.1ESB2 D701 8-719-109-63 DIODE RD3.0ESB2 D702 8-719-991-33 DIODE 1SS133T-77 D820 8-719-109-68 DIODE RD3.6ESB1 D829 8-719-109-84 DIODE RD5.1ESB1
D835 8-719-109-89 DIODE RD5.6ESB2 D840 8-719-991-33 DIODE 1SS133T-77
Page 48
– 110 –
The componants identified byshading and mark are criti-cal for safety.Replace only with part numberspecified.
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK
Q507 8-729-032-61 TRANSISTOR 2SC5022-02 Q701 8-729-119-78 TRANSISTOR 2SC2785-HFE Q702 8-729-119-78 TRANSISTOR 2SC2785-HFE Q801 8-729-119-78 TRANSISTOR 2SC2785-HFE
Q802 8-729-119-76 TRANSISTOR 2SA1175-HFE Q803 8-729-119-78 TRANSISTOR 2SC2785-HFE Q804 8-729-119-76 TRANSISTOR 2SA1175-HFE Q805 8-729-119-78 TRANSISTOR 2SC2785-HFE Q806 8-729-119-76 TRANSISTOR 2SA1175-HFE
Q807 8-729-119-78 TRANSISTOR 2SC2785-HFE Q808 8-729-030-02 TRANSISTOR DTC144ESA Q809 8-729-119-78 TRANSISTOR 2SC2785-HFE Q810 8-729-119-78 TRANSISTOR 2SC2785-HFE Q811 8-729-119-78 TRANSISTOR 2SC2785-HFE
Q812 8-729-119-76 TRANSISTOR 2SA1175-HFE
<RESISTOR>
R1 ! METAL 1/4W R501 1-249-421-11 CARBON 2.2K 5% 1/4W R502 1-216-465-21 METAL OXIDE 27K 5% 2W F R503 1-247-843-11 CARBON 3.3K 5% 1/4W R504 1-249-419-11 CARBON 1.5K 5% 1/4W
R505 1-247-885-00 CARBON 180K 5% 1/4W R506 1-247-883-00 CARBON 150K 5% 1/4W R507 1-249-422-11 CARBON 2.7K 5% 1/4W R508 1-260-338-51 CARBON 6.8K 5% 1/2W R509 1-249-437-11 CARBON 47K 5% 1/4W
R510 1-215-918-00 METAL OXIDE 1.5K 5% 3W F R511 1-215-918-00 METAL OXIDE 1.5K 5% 3W F R512 1-215-918-00 METAL OXIDE 1.5K 5% 3W F R513 1-247-843-11 CARBON 3.3K 5% 1/4W R514 1-215-443-00 METAL 8.2K 1% 1/4W
R516 1-215-473-00 METAL 150K 1% 1/4W R517 1-215-449-00 METAL 15K 1% 1/4W R518 1-249-436-11 CARBON 39K 5% 1/4W R519 1-249-429-11 CARBON 10K 5% 1/4W R522 1-249-428-11 CARBON 8.2K 5% 1/4W
R523 1-249-437-11 CARBON 47K 5% 1/4W R524 1-249-425-11 CARBON 4.7K 5% 1/4W R525 1-249-405-11 CARBON 100 5% 1/4W F R527 1-249-425-11 CARBON 4.7K 5% 1/4W R528 1-215-910-00 METAL OXIDE 68 5% 3W F
R529 1-215-449-00 METAL 15K 1% 1/4W R530 1-249-429-11 CARBON 10K 5% 1/4W R531 1-260-326-11 CARBON 680 5% 1/2W R532 1-260-315-71 CARBON 82 5% 1/2W R533 1-214-912-00 METAL 91K 1% 1/2W
R534 1-215-479-00 METAL 270K 1% 1/4W R535 1-247-887-00 CARBON 220K 5% 1/4W R536 1-249-377-11 CARBON 0.47 5% 1/4W F R537 1-260-336-11 CARBON 4.7K 5% 1/2W R538 1-249-425-11 CARBON 4.7K 5% 1/4W
R539 1-249-377-11 CARBON 0.47 5% 1/4W F R540 1-249-379-11 CARBON 0.68 5% 1/4W F R541 1-247-807-31 CARBON 100 5% 1/4W R542 1-215-864-00 METAL OXIDE 150 5% 1W F
R543 1-216-349-00 METAL OXIDE 1 5% 1W F
R544 1-215-864-00 METAL OXIDE 150 5% 1W F R545 1-249-377-11 CARBON 0.47 5% 1/4W F R546 1-249-377-11 CARBON 0.47 5% 1/4W F R547 1-247-807-31 CARBON 100 5% 1/4W R548 1-249-413-11 CARBON 470 5% 1/4W
R549 1-249-431-11 CARBON 15K 5% 1/4W R550 1-247-807-31 CARBON 100 5% 1/4W R551 1-249-437-11 CARBON 47K 5% 1/4W R552 1-247-807-31 CARBON 100 5% 1/4W R553 1-247-881-00 CARBON 120K 5% 1/4W
R554 1-249-405-11 CARBON 100 5% 1/4W F R555 1-247-807-31 CARBON 100 5% 1/4W R556 1-260-099-11 CARBON 1K 5% 1/2W R557 1-216-490-11 METAL OXIDE 39K 5% 3W F R558 1-216-490-11 METAL OXIDE 39K 5% 3W F
R559 1-216-490-11 METAL OXIDE 39K 5% 3W F R560 8-719-991-33 DIODE 1SS133T-77 R562 1-202-838-00 SOLID 100K 10% 1/2W R563 1-215-447-00 METAL 12K 1% 1/4W R565 1-247-807-31 CARBON 100 5% 1/4W
R566 1-249-377-11 CARBON 0.47 5% 1/4W F R567 1-249-377-11 CARBON 0.47 5% 1/4W F R568 1-247-903-00 CARBON 1M 5% 1/4W R569 1-216-392-11 METAL OXIDE 1.8 5% 3W F R570 1-215-910-00 METAL OXIDE 68 5% 3W F
R571 1-249-422-11 CARBON 2.7K 5% 1/4W R572 1-247-895-91 CARBON 470K 5% 1/4W R573 1-249-438-11 CARBON 56K 5% 1/4W R574 1-249-435-11 CARBON 33K 5% 1/4W R576 1-247-807-31 CARBON 100 5% 1/4W
R577 1-249-422-11 CARBON 2.7K 5% 1/4W R578 1-215-473-00 METAL 150K 1% 1/4W R579 1-247-889-00 CARBON 270K 5% 1/4W R580 1-249-437-11 CARBON 47K 5% 1/4W R581 1-249-437-11 CARBON 47K 5% 1/4W
R583 1-249-428-11 CARBON 8.2K 5% 1/4W R584 1-249-429-11 CARBON 10K 5% 1/4W R585 1-216-490-11 METAL OXIDE 39K 5% 3W F R586 1-215-892-11 METAL OXIDE 1K 5% 2W F R588 1-247-863-91 CARBON 22K 5% 1/4W
R589 1-247-887-00 CARBON 220K 5% 1/4W R591 1-249-425-11 CARBON 4.7K 5% 1/4W R595 1-215-464-00 METAL 62K 1% 1/4W R596 1-215-473-00 METAL 150K 1% 1/4W R597 1-215-464-00 METAL 62K 1% 1/4W
R701 1-215-449-00 METAL 15K 1% 1/4W R702 1-249-421-11 CARBON 2.2K 5% 1/4W R703 1-249-421-11 CARBON 2.2K 5% 1/4W R704 1-215-457-00 METAL 33K 1% 1/4W R705 1-215-457-00 METAL 33K 1% 1/4W
R706 1-215-457-00 METAL 33K 1% 1/4W R801 1-247-807-31 CARBON 100 5% 1/4W R802 1-247-807-31 CARBON 100 5% 1/4W R803 1-249-430-11 CARBON 12K 5% 1/4W R804 1-249-425-11 CARBON 4.7K 5% 1/4W
E• The components identified by in this manual have been
carefully factory-selected for each set in order to satisfyregulations regarding X-ray radiation. Should replacement berequired, replace only with the value originally used.
Page 49
– 111 –
The componants identified byshading and mark are criti-cal for safety.Replace only with part numberspecified.
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK
R867 1-215-455-00 METAL 27K 1% 1/4W R868 1-215-443-00 METAL 8.2K 1% 1/4W R869 1-249-425-11 CARBON 4.7K 5% 1/4W
R870 1-249-437-11 CARBON 47K 5% 1/4W R871 1-249-417-11 CARBON 1K 5% 1/4W R872 1-249-425-11 CARBON 4.7K 5% 1/4W R873 1-247-807-31 CARBON 100 5% 1/4W R874 1-249-435-11 CARBON 33K 5% 1/4W
R875 1-249-441-11 CARBON 100K 5% 1/4W R877 1-249-422-11 CARBON 2.7K 5% 1/4W R878 1-215-469-00 METAL 100K 1% 1/4W R879 1-215-445-00 METAL 10K 1% 1/4W R881 1-249-408-11 CARBON 180 5% 1/4W
R882 1-249-429-11 CARBON 10K 5% 1/4W R883 1-249-429-11 CARBON 10K 5% 1/4W R884 1-215-445-00 METAL 10K 1% 1/4W R885 1-249-441-11 CARBON 100K 5% 1/4W R886 1-249-428-11 CARBON 8.2K 5% 1/4W
R887 1-247-807-31 CARBON 100 5% 1/4W R888 1-247-807-31 CARBON 100 5% 1/4W R889 1-249-439-11 CARBON 68K 5% 1/4W R890 1-249-441-11 CARBON 100K 5% 1/4W R891 1-247-843-11 CARBON 3.3K 5% 1/4W
R892 1-249-425-11 CARBON 4.7K 5% 1/4W R893 1-249-421-11 CARBON 2.2K 5% 1/4W R894 1-215-455-00 METAL 27K 1% 1/4W R895 1-249-421-11 CARBON 2.2K 5% 1/4W R896 1-249-441-11 CARBON 100K 5% 1/4W
R897 1-247-807-31 CARBON 100 5% 1/4W R898 1-247-815-91 CARBON 220 5% 1/4W R900 1-216-474-11 METAL OXIDE 82 5% 3W F R901 1-215-449-00 METAL 15K 1% 1/4W R902 1-215-449-00 METAL 15K 1% 1/4W
R903 1-215-421-00 METAL 1K 1% 1/4W R904 1-214-800-11 METAL 2.2 1% 1/2W R905 1-214-800-11 METAL 2.2 1% 1/2W R906 1-214-800-11 METAL 2.2 1% 1/2W R908 1-215-445-00 METAL 10K 1% 1/4W
R909 1-215-421-00 METAL 1K 1% 1/4W R910 1-215-421-00 METAL 1K 1% 1/4W R911 1-215-461-00 METAL 47K 1% 1/4W R912 1-215-445-00 METAL 10K 1% 1/4W R913 1-215-455-00 METAL 27K 1% 1/4W
R914 1-215-455-00 METAL 27K 1% 1/4W R915 1-215-455-00 METAL 27K 1% 1/4W R916 1-215-455-00 METAL 27K 1% 1/4W R917 1-215-455-00 METAL 27K 1% 1/4W R918 1-215-455-00 METAL 27K 1% 1/4W
R919 1-249-435-11 CARBON 33K 5% 1/4W R920 1-214-800-11 METAL 2.2 1% 1/2W R921 1-249-429-11 CARBON 10K 5% 1/4W R922 1-215-445-00 METAL 10K 1% 1/4W R923 1-249-425-11 CARBON 4.7K 5% 1/4W
R924 1-215-445-00 METAL 10K 1% 1/4W R925 1-249-425-11 CARBON 4.7K 5% 1/4W R926 1-249-408-11 CARBON 180 5% 1/4W R927 1-249-429-11 CARBON 10K 5% 1/4W
E
R805 1-247-807-31 CARBON 100 5% 1/4W R806 1-249-429-11 CARBON 10K 5% 1/4W R807 1-247-807-31 CARBON 100 5% 1/4W R808 1-249-429-11 CARBON 10K 5% 1/4W R809 1-249-425-11 CARBON 4.7K 5% 1/4W
R810 1-247-807-31 CARBON 100 5% 1/4W R811 1-247-807-31 CARBON 100 5% 1/4W R813 1-247-863-91 CARBON 22K 5% 1/4W R814 1-247-807-31 CARBON 100 5% 1/4W R815 1-247-807-31 CARBON 100 5% 1/4W
R816 1-247-807-31 CARBON 100 5% 1/4W R817 1-247-807-31 CARBON 100 5% 1/4W R818 1-249-429-11 CARBON 10K 5% 1/4W R819 1-247-807-31 CARBON 100 5% 1/4W R820 1-249-437-11 CARBON 47K 5% 1/4W
R821 1-249-431-11 CARBON 15K 5% 1/4W R822 1-249-417-11 CARBON 1K 5% 1/4W R823 1-249-417-11 CARBON 1K 5% 1/4W R824 1-215-462-00 METAL 51K 1% 1/4W R825 1-249-441-11 CARBON 100K 5% 1/4W
R826 1-215-462-00 METAL 51K 1% 1/4W R827 1-216-474-11 METAL OXIDE 82 5% 3W F R828 1-249-426-11 CARBON 5.6K 5% 1/4W R829 1-249-426-11 CARBON 5.6K 5% 1/4W R830 1-249-414-11 CARBON 560 5% 1/4W
R831 1-249-414-11 CARBON 560 5% 1/4W R832 1-249-441-11 CARBON 100K 5% 1/4W R833 1-216-474-11 METAL OXIDE 82 5% 3W F R834 1-249-441-11 CARBON 100K 5% 1/4W R835 1-249-441-11 CARBON 100K 5% 1/4W
R836 1-247-807-31 CARBON 100 5% 1/4W R837 1-249-441-11 CARBON 100K 5% 1/4W R838 1-249-421-11 CARBON 2.2K 5% 1/4W R839 1-247-807-31 CARBON 100 5% 1/4W R841 1-247-815-91 CARBON 220 5% 1/4W
R842 1-247-807-31 CARBON 100 5% 1/4W R843 1-247-807-31 CARBON 100 5% 1/4W R844 1-247-807-31 CARBON 100 5% 1/4W R845 1-249-441-11 CARBON 100K 5% 1/4W R846 1-247-807-31 CARBON 100 5% 1/4W
R847 1-215-481-00 METAL 330K 1% 1/4W R848 1-215-449-00 METAL 15K 1% 1/4W R850 1-215-481-00 METAL 330K 1% 1/4W R851 1-247-807-31 CARBON 100 5% 1/4W R852 1-247-807-31 CARBON 100 5% 1/4W
R853 1-247-887-00 CARBON 220K 5% 1/4W R854 1-249-429-11 CARBON 10K 5% 1/4W R856 1-247-807-31 CARBON 100 5% 1/4W R857 1-247-807-31 CARBON 100 5% 1/4W R858 1-215-455-00 METAL 27K 1% 1/4W
R859 1-215-455-00 METAL 27K 1% 1/4W R860 1-215-455-00 METAL 27K 1% 1/4W R861 1-215-455-00 METAL 27K 1% 1/4W R862 1-215-455-00 METAL 27K 1% 1/4W R863 1-215-455-00 METAL 27K 1% 1/4W
R865 1-249-424-11 CARBON 3.9K 5% 1/4W R866 1-249-437-11 CARBON 47K 5% 1/4W
Page 50
– 112 –
The componants identified byshading and mark are criti-cal for safety.Replace only with part numberspecified.
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK
R987 1-249-408-11 CARBON 180 5% 1/4W R988 1-249-429-11 CARBON 10K 5% 1/4W R989 1-249-425-11 CARBON 4.7K 5% 1/4W R990 1-249-431-11 CARBON 15K 5% 1/4W R991 1-249-429-11 CARBON 10K 5% 1/4W
R993 1-249-425-11 CARBON 4.7K 5% 1/4W R994 1-216-474-11 METAL OXIDE 82 5% 3W F R997 1-215-445-00 METAL 10K 1% 1/4W R998 1-249-425-11 CARBON 4.7K 5% 1/4W R999 1-249-425-11 CARBON 4.7K 5% 1/4W
R1901 1-249-439-11 CARBON 68K 5% 1/4W R1904 1-249-425-11 CARBON 4.7K 5% 1/4W
<SPARK GAP>
SG501 1-519-422-11 GAP, SPARK
<TRANSFORMER>
T501 1-437-195-11 TRANSFORMER, HORIZONTAL DRIVE T502 ! 1-431-211-11 TRANSFORMER, FERRITE (PMT) T504 ! 1-453-248-21 FBT ASSY (NX-4007//X4T4)
******************************************************************************
* A-1372-413-A H1 BOARD, COMPLETE*****************************
4-203-258-01 HOLDER, LED
<CAPACITOR>
C3003 1-126-157-11 ELECT 10µF 20% 16V
<CONNECTOR>
CN3001 *1-564-519-11 PLUG, CONNECTOR 4P CN3002 *1-564-525-11 PLUG, CONNECTOR 10P CN3003 *1-580-690-11 PIN, CONNECTOR (PC BOARD) 4P CN3004 *1-691-292-11 PIN, CONNECTOR (PC BOARD) 3P
<DIODE>
D3002 8-719-992-06 DIODE SLA-580LT3F (STANDBY)
<IC>
IC3002 8-742-014-11 HYB IC SBX1981-51
<TRANSISTOR>
Q3002 8-729-120-28 TRANSISTOR 2SC1623-L5L6
<RESISTOR>
R3001 1-216-683-11 METAL CHIP 22K 0.50%1/10W
E H1
R928 1-249-429-11 CARBON 10K 5% 1/4W
R929 1-214-800-11 METAL 2.2 1% 1/2W R930 1-214-800-11 METAL 2.2 1% 1/2W R931 1-215-445-00 METAL 10K 1% 1/4W R933 1-215-445-00 METAL 10K 1% 1/4W R934 1-249-422-11 CARBON 2.7K 5% 1/4W
R935 1-249-429-11 CARBON 10K 5% 1/4W R936 1-249-429-11 CARBON 10K 5% 1/4W R937 1-249-436-11 CARBON 39K 5% 1/4W R938 1-215-421-00 METAL 1K 1% 1/4W R939 1-259-878-11 CARBON 1.5M 5% 1/4W
R940 1-249-441-11 CARBON 100K 5% 1/4W R941 1-249-441-11 CARBON 100K 5% 1/4W R942 1-249-421-11 CARBON 2.2K 5% 1/4W R943 1-249-441-11 CARBON 100K 5% 1/4W R944 1-215-421-00 METAL 1K 1% 1/4W
R945 1-249-439-11 CARBON 68K 5% 1/4W R946 1-215-421-00 METAL 1K 1% 1/4W R947 1-249-441-11 CARBON 100K 5% 1/4W R948 1-247-815-91 CARBON 220 5% 1/4W R949 1-247-807-31 CARBON 100 5% 1/4W
R950 1-247-807-31 CARBON 100 5% 1/4W R951 1-247-807-31 CARBON 100 5% 1/4W R952 1-247-807-31 CARBON 100 5% 1/4W R953 1-249-435-11 CARBON 33K 5% 1/4W R954 1-215-433-00 METAL 3.3K 1% 1/4W
R955 1-215-433-00 METAL 3.3K 1% 1/4W R956 1-249-429-11 CARBON 10K 5% 1/4W R957 1-214-800-11 METAL 2.2 1% 1/2W R958 1-214-800-11 METAL 2.2 1% 1/2W R959 1-215-433-00 METAL 3.3K 1% 1/4W
R961 1-249-425-11 CARBON 4.7K 5% 1/4W R962 1-214-800-11 METAL 2.2 1% 1/2W R963 1-214-800-11 METAL 2.2 1% 1/2W R964 1-215-433-00 METAL 3.3K 1% 1/4W R965 1-215-433-00 METAL 3.3K 1% 1/4W
R966 1-247-815-91 CARBON 220 5% 1/4W R967 1-215-455-00 METAL 27K 1% 1/4W R968 1-215-455-00 METAL 27K 1% 1/4W R969 1-215-455-00 METAL 27K 1% 1/4W R970 1-215-455-00 METAL 27K 1% 1/4W
R971 1-215-455-00 METAL 27K 1% 1/4W R972 1-215-455-00 METAL 27K 1% 1/4W R973 1-214-800-11 METAL 2.2 1% 1/2W R974 1-215-455-00 METAL 27K 1% 1/4W R975 1-214-800-11 METAL 2.2 1% 1/2W
R976 1-215-433-00 METAL 3.3K 1% 1/4W R978 1-215-443-00 METAL 8.2K 1% 1/4W R979 1-249-425-11 CARBON 4.7K 5% 1/4W R980 1-247-815-91 CARBON 220 5% 1/4W R981 1-247-815-91 CARBON 220 5% 1/4W
R982 1-215-469-00 METAL 100K 1% 1/4W R983 1-247-815-91 CARBON 220 5% 1/4W R984 1-215-445-00 METAL 10K 1% 1/4W R985 1-249-429-11 CARBON 10K 5% 1/4W R986 1-215-449-00 METAL 15K 1% 1/4W
Page 51
– 113 –
The componants identified byshading and mark are criti-cal for safety.Replace only with part numberspecified.
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK
R2706 1-216-024-00 RES,CHIP 91 5% 1/10W
R2707 1-216-023-00 RES,CHIP 82 5% 1/10W R2709 1-216-113-00 RES,CHIP 470K 5% 1/10W R2710 1-216-089-00 RES,CHIP 47K 5% 1/10W R2711 1-216-113-00 RES,CHIP 470K 5% 1/10W R2712 1-216-089-00 RES,CHIP 47K 5% 1/10W
R2715 1-216-025-91 RES,CHIP 100 5% 1/10W R2716 1-216-295-91 SHORT 0 R2717 1-216-025-91 RES,CHIP 100 5% 1/10W R2718 1-216-295-91 SHORT 0
*****************************************************************************
* A-1375-171-A H2 BOARD, COMPLETE*****************************
<CAPACITOR>
C3203 1-126-157-11 ELECT 10µF 20% 16V C3204 1-163-037-11 CERAMIC CHIP 0.022µF 10% 50V C3205 1-163-037-11 CERAMIC CHIP 0.022µF 10% 50V
<CONNECTOR>
CN3201 *1-564-519-11 PLUG, CONNECTOR 4P CN3202 *1-564-526-31 PLUG, CONNECTOR 11P CN3204 *1-564-520-11 PLUG, CONNECTOR 5P
<JACK>
J3201 1-784-658-11 TERMINAL BLOCK, S J3202 1-507-806-00 JACK 1P
<COIL>
L3201 1-408-615-31 INDUCTOR 100µH L3202 1-408-615-31 INDUCTOR 100µH
<RESISTOR>
R3202 1-216-025-00 RES,CHIP 100 5% 1/10W R3203 1-216-025-00 RES,CHIP 100 5% 1/10W R3207 1-216-654-11 METAL CHIP 1.3K 0.50%1/10W R3209 1-216-033-00 RES,CHIP 220 5% 1/10W R3210 1-216-033-00 RES,CHIP 220 5% 1/10W
R3211 1-216-033-00 RES,CHIP 220 5% 1/10W R3212 1-216-033-00 RES,CHIP 220 5% 1/10W
<SWITCH>
S3205 1-571-532-21 SWITCH, TACTIL (AUTO CONVERGENCE) S3206 1-571-532-21 SWITCH, TACTIL (AUTO PRESET)
*****************************************************************************
R3002 1-216-675-91 METAL CHIP 10K 0.50%1/10W R3006 1-216-667-11 METAL CHIP 4.7K 0.50%1/10W R3007 1-216-661-11 METAL CHIP 2.7K 0.50%1/10W R3009 1-216-041-00 RES,CHIP 470 5% 1/10W
R3010 1-216-045-00 RES,CHIP 680 5% 1/10W
<SWITCH>
S3001 1-571-532-21 SWITCH, TACTIL (PROG+) S3002 1-571-532-21 SWITCH, TACTIL (PROG-) S3003 1-571-532-21 SWITCH, TACTIL (VOL+) S3004 1-571-532-21 SWITCH, TACTIL (VOL-) S3005 1-571-532-21 SWITCH, TACTIL (INPUT SELECT)
S3006 ! 1-571-433-31 SWITCH, PUSH (MAIN POWER)
*****************************************************************************
* A-1373-658-A UE BOARD, COMPLETE*****************************
<CAPACITOR>
C2701 1-163-133-00 CERAMIC CHIP 470pF 5% 50V C2702 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C2703 1-163-133-00 CERAMIC CHIP 470pF 5% 50V C2704 1-164-232-11 CERAMIC CHIP 0.01µF 10% 50V C2705 1-126-934-11 ELECT 220µF 20% 16V
C2706 1-126-964-11 ELECT 10µF 20% 50V C2707 1-126-964-11 ELECT 10µF 20% 50V C2708 1-104-664-11 ELECT 47µF 20% 16V C2709 1-126-964-11 ELECT 10µF 20% 50V C2710 1-104-664-11 ELECT 47µF 20% 16V
<CONNECTOR>
CN2701 * 1-564-522-11 PLUG, CONNECTOR 7P CN2702 * 1-564-523-11 PLUG, CONNECTOR 8P CN2703 1-695-549-11 SOCKET, PIN 21P
<DIODE>
D2701 8-719-977-22 DIODE DTZ9.1 D2702 8-719-977-22 DIODE DTZ9.1 D2703 8-719-977-22 DIODE DTZ9.1 D2704 8-719-977-22 DIODE DTZ9.1 D2705 8-719-977-22 DIODE DTZ9.1
D2706 8-719-977-22 DIODE DTZ9.1 D2707 8-719-977-22 DIODE DTZ9.1 D2708 8-719-977-22 DIODE DTZ9.1
<RESISTOR>
R2702 1-216-022-00 RES,CHIP 75 5% 1/10W R2703 1-216-033-00 RES,CHIP 220 5% 1/10W R2704 1-216-039-00 RES,CHIP 390 5% 1/10W R2705 1-216-039-00 RES,CHIP 390 5% 1/10W
UEH1 H2
Page 52
– 114 –
The componants identified byshading and mark are criti-cal for safety.Replace only with part numberspecified.
KP-41S5/41S5B/41S5G/41S5K/41S5R/41S5U
RM-862
REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK
<DIODE>
D1431 8-719-110-88 DIODE RD39ESB2 D1432 8-719-110-88 DIODE RD39ESB2 D1433 8-719-991-33 DIODE 1SS133T-77
<CONNECTOR>
DY1431!1-451-454-11 DEFLECTION YOKE
<COIL>
L1431 1-410-478-11 INDUCTOR 47µH
<TRANSISTOR>
Q1431 8-729-017-06 TRANSISTOR 2SC4793 Q1432 8-729-017-05 TRANSISTOR 2SA1837 Q1433 8-729-119-76 TRANSISTOR 2SA1175-HFE Q1434 8-729-119-78 TRANSISTOR 2SC2785-HFE Q1435 8-729-119-78 TRANSISTOR 2SC2785-HFE
Q1436 8-729-119-78 TRANSISTOR 2SC2785-HFE
<RESISTOR>
R1431 1-249-414-11 CARBON 560 5% 1/4W R1432 1-249-414-11 CARBON 560 5% 1/4W R1433 1-249-377-11 CARBON 0.47 5% 1/4W F R1435 1-216-475-11 METAL OXIDE 120 5% 3W F R1436 1-216-475-11 METAL OXIDE 120 5% 3W F
R1437 1-249-414-11 CARBON 560 5% 1/4W R1438 1-215-451-00 METAL 18K 1% 1/4W R1439 1-215-451-00 METAL 18K 1% 1/4W R1440 1-249-414-11 CARBON 560 5% 1/4W F R1441 1-247-815-91 CARBON 220 5% 1/4W
R1442 1-247-815-91 CARBON 220 5% 1/4W R1443 1-249-377-11 CARBON 0.47 5% 1/4W F R1444 1-247-815-91 CARBON 220 5% 1/4W R1445 1-249-403-11 CARBON 68 5% 1/4W R1448 1-249-417-11 CARBON 1K 5% 1/4W
R1449 1-249-403-11 CARBON 68 5% 1/4W R1450 1-249-417-11 CARBON 1K 5% 1/4W R1451 1-247-815-91 CARBON 220 5% 1/4W R1452 1-249-417-11 CARBON 1K 5% 1/4W R1453 1-249-401-11 CARBON 47 5% 1/4W
R1454 1-260-311-11 CARBON 39 5% 1/2W R1455 1-249-384-11 CARBON 1.8 5% 1/4W F R1456 1-216-476-11 METAL OXIDE 180 5% 3W F R1457 1-249-417-11 CARBON 1K 5% 1/4W F R1458 1-249-384-11 CARBON 1.8 5% 1/4W F
R1459 1-249-400-11 CARBON 39 5% 1/4W F R1461 1-249-414-11 CARBON 560 5% 1/4W R1462 1-249-414-11 CARBON 560 5% 1/4W R1465 1-216-475-11 METAL OXIDE 120 5% 3W F R1468 1-216-475-11 METAL OXIDE 120 5% 3W F
******************************************************************************
* A-1390-784-A ZR BOARD, COMPLETE*****************************
<CONNECTOR>
CN1401 *1-564-510-11 PLUG, CONNECTOR 7P CN1403 *1-564-506-11 PLUG, CONNECTOR 3P CN1404 *1-564-507-11 PLUG, CONNECTOR 4P CN1405 *1-580-689-11 PIN, CONNECTOR (PC BOARD) 4P
<CONNECTOR>
DY1401!1-451-454-11 DEFLECTION YOKE
<RESISTOR>
R1401 1-249-414-11 CARBON 560 5% 1/4W R1402 1-249-414-11 CARBON 560 5% 1/4W R1403 1-216-476-11 METAL OXIDE 180 5% 3W F R1415 1-216-475-11 METAL OXIDE 120 5% 3W F R1418 1-216-475-11 METAL OXIDE 120 5% 3W F
*****************************************************************************
* A-1390-785-A ZG BOARD, COMPLETE*****************************
4-382-854-11 SCREW (M3X10), P, SW (+)
<CAPACITOR>
C1433 1-104-999-11 MYLAR 0.1µF 10% 200V C1434 1-107-362-11 FILM 0.0047µF 10% 200V C1435 1-107-667-11 ELECT 2.2µF 20% 160V C1436 1-130-471-00 FILM 0.001µF 5% 50V C1437 1-130-471-00 FILM 0.001µF 5% 50V
C1438 1-107-362-11 FILM 0.0047µF 10% 200V C1439 1-161-830-00 CERAMIC 0.0047µF 99% 500V C1440 1-104-664-11 ELECT 47µF 20% 25V C1441 1-104-999-11 MYLAR 0.1µF 10% 200V C1443 1-126-935-11 ELECT 470µF 20% 16V
C1444 1-107-639-11 ELECT 47µF 20% 160V C1445 1-126-933-11 ELECT 100µF 20% 16V C1446 1-126-933-11 ELECT 100µF 20% 16V C1450 1-130-471-00 FILM 0.001µF 5% 50V
<CONNECTOR>
CN1431 *1-564-508-11 PLUG, CONNECTOR 5P CN1432 *1-564-510-11 PLUG, CONNECTOR 7P CN1433 *1-564-507-11 PLUG, CONNECTOR 4P CN1434 *1-580-689-11 PIN, CONNECTOR (PC BOARD) 4P CN1436 1-695-915-11 TAB (CONTACT)
CN1461 *1-564-506-11 PLUG, CONNECTOR 3P CN1462 *1-564-507-11 PLUG, CONNECTOR 4P CN1464 *1-564-507-11 PLUG, CONNECTOR 4P
ZR ZG
