Scanning system : CCIR standard (625 TV lines, 25 frames/sec.)Interlace : 2:1 interlaceImage device : 1/3 inch solid state image device CCDPicture elements : 542 (Horizontal) x 584 (Vertical)Effective picture elements : 512 (Horizontal) x 582 (Vertical)Synchronizing system : Internal sync (INT), Line lock (LL) : manually switchableResolution : 400 TV lines horizontally, 400 TV lines verticallyVideo output level : 1.0 Vp-p/75 Ω, compositeVideo S/N ratio : More than 50 dBMinimum required illumination : Approx. 0.05 lux with a F 1.2 lens,(incandescent lighting) approx. 0.07 lux with a F 1.4 lensBacklight compensation : Manual ON/OFF switching, zone light measuring system (Active when using an auto-iris lens)Iris function : Manual ON (EI)/OFF (AI) switchingHigh speed electronic shutter : 8 speeds, selectable by switch:

(1/50, 1/120, 1/250, 1/500, 1/1000, 1/2000, 1/4000, 1/10000 sec.)Electronic iris range : 0.07 lux to 42,000 lux (F1.4, lens) 0.05 lux to 30,000 lux (F1.2, lens)Flange-back : 12.5 mm ± 0.8 mmAGC : Manual ON/OFF switchingGamma correction : γ = 0.45Lens mount : CS mountEnvironmental conditions : Temperature: -10 °C ~ + 50 °C Humidity: less than 90 % (no condensation)Power supply : 220 - 230 V AC ± 10%, 50HzPower consumption : 4.0W (with auto iris lens)

3.0W (without auto iris lens)Weight : Approx. 800 g (without lens)

SERVICE MANUAL

B/W CCD Camera VCB-3440P(Product Code : 117 074 24)(South East Asia)(Europe)

FILE NO.

REFERENCE No. SM5310377L73Q5/XE

NOTE : 1. Parts order must contain model number, part number, and description. 2. Substitute parts may be supplied as the service parts. 3. N. S. P. : Not available as service parts.

Design and specification are subject to change without notice.

The components designated by a symbol ( ) in this schematic diagram designates components whose value are of

special significance to product safety. Should any component designated by a symbol need to be replaced, use only the

part designated in the Parts List. Do not deviate from the resistance, wattage, and voltage ratings shown.

PRODUCT SAFETY NOTICE

CONTENTS1. DISASSEMBLY ....................................22. BOARD LOCATION .............................33. ADJUSTMENT .....................................44. PARTS LIST .........................................6CIRCUIT DIAGRAMS & PRINTEDWIRING BOARDS ..................................C1

SPECIFICATIONS

− 2 −

1. DISASSEMBLY

and unlock the lens adapter

rear board

and 3 pin cableboard then pull out 5 pin wire harness

7. Remove the six screws and the power

board then pull out 4 pin wire harness6. Remove the two screws and the iris

power board

iris board

control board

FPC

sensor board

9. Remove FPC and the four screwsand remove the sensor board kit

10. Remove the two set screws

3. Remove the four screwsand pull out the rear cover

8. Remove the four screws

5. Remove the six screws and the timingboard and pull all wire harness(4 pcs)

and remove the rear board

and pull out the bottom cover2. Remove the four screws

and FPC on sensor boardand pull out the front cover

4. Remove the four screws

and pull out the top cover1. Remove the four screws

Anti-dusty Film

11. Remove the two screws and pull out the Tripod

12. Remove the lens cap

− 3 −

CE6310-2 BOARD

CE6310-3 BOARD

CE6310-4 BOARD

CE6310-1 BOARD

CE6310-5 BOARD(REAR)

(POWER)

(CONTROL)

(IRIS)

(SENSOR)

2. BOARD LOCATION

SW401

CN201

VR500VAGC

CE6310-2 BOARD

SW200

VR502VRG

CN502

CN

501

& TIMING UNIT

CN

503

SIGNAL PROCESS

VR501VSUB

CN

504

CN

500

CE6310-4 BOARD

LED400

SW400 J400

CN

200

VR200

IRIS UNIT

CN

400

SHUTTER SPEED

PHASE

CN

401

VIDEO OUT

T3

CE6310-5 BOARD

C587

PLLN

VR400

POWER ON LED

− 4 −

3. ADJUSTMENT

3-1. ADJUSTMENT PREPARATION1. Use the 5,100K viewer for the subject.2. Set the ITE gray scale chart II (γ =0.45) to the viewer.3. Set the angle of adjustment control (VR) before starting

adjustment at the center or temporary adjustment (nearlyadjusted) unless specified.

4. Set the trigger signal of oscilloscope to VIDEO OUT, andapply H sync unless specified.

5. If no switch position is specified, the auto-iris lens switchposition should be above (SW200). The other switchesshould be default (LL,AI, BLC OFF, AGC, SHUTTER → “0” ).

6. The VIDEO OUT connector (J400) connect to a video monitor terminated in 75 Ω input impedance.

3-2. VCO VOLTAGE ADJUSTMENTAdjustment location: C587 (6310-5)Measuring location: PLLN (6310-5) J400 (VIDEO OUT, 6310-4)Measuring equipment: OscilloscopeSubject: No designationAdjusting method:1. Adjust the C587 so that the waveform width of PLLN is min.&

stable (negative pulse) (pulse width < 250us).

L: Distance from CS mount to pattern (mm)

H: Pattern height (mm)

f : Lens focal length (standard 12.5 mm)

h: Height (4.8 mm) of CCD imaging surface

Note : The video monitor should be an under-scan TV.

L = X f − 12.5 mm(H + h)2

H X h

LCS mount surface

CCD camera

5,100 K viewer

H

T3

3-3. VSUB & VRG VOLTAGE ADJUSTMENTAdjustment location: VR501 (VSUB, 6310-5) VR502 (VRG, 6310-5)Measuring location: T3 (6310-5) J400 (VIDEO OUT, 6310-4)Measuring equipment: OscilloscopeSubject: Gray scale chart (γ =0.45)Adjusting method:1. Display the gray scale chart on full screen.2. Adjust the lens aperture so that the gray scal level is 4

levels.3. Adjust the VR501(VSUB) so that the waveform of T3 is clear

picture (uniformity).4. Adjust the VR502(VRG) so that the waveform of T3 is max

amplitude (uniformity).5. Adjust the lens aperture to have full white clear picture.6. Repeat item 2 ~ 5 until camera has clear picture (uniformity).

3-4. AGC LEVEL ADJUSTMENT (BLC OFF)Adjustment location: VR500 (VAGC, 6310-5)Measuring location: J400 (VIDEO OUT, 6310-4) T3 (6310-5)Measuring equipment: OscilloscopeSubject: Gray scale chart (γ =0.45)Adjusting method:1. Display the gray scale chart on full screen.2. Adjust the lens aperture so that the waveform level of T3 is

450 ± 20 mVp-p.

3. Adjust with VR500 so that the waveform level is 770 ± 20mVp-p during video output (J400).

− 5 −

T3

400 mVp-p

3-5. AUTO IRIS LEVEL ADJUSTMENT (BLC OFF)Adjustment location: VR200 (6310-2)Measuring location: T3 (6310-5)Measuring equipment: OscilloscopeSubject: Gray scale chart (γ =0.45)Adjusting method:1. Attach the automatic iris lens, and then display the gray

scale chart on full screen.2. Adjust with VR200 so that the waveform level of T3 is 400

mVp-p.3. Set the BLC switch (SW401) to the “BLC” position.4. Check video level saturation status (max. 2 steps saturation).5. Return the BLC switch (SW401) to the “OFF” position.

+10−20

+10−20

VIDEO OUTPUT (J400)

770 ± 20 mVp-p

3-6. LINE LOCK PHASE ADJUSTMENTAdjustment location: VR400 (6310-4)Measuring location: J400 (VIDEO OUT, 6310-4) 230V AC/GND terminalsMeasuring equipment: OscilloscopeSubject: No designationAdjusting method:1. Connect the camera to a 230V AC/50 Hz power source.2. The HOT (signal) side and COLD (GND) side of the oscilloscope probe connect to the 230V AC terminals respectively.3. Turn VR400 (LINE LOCK PHASE) to adjust the leading edge

of the vertical sync signal and zero-cross shift of the 230VAC power supply to 0 ± 0.2 ms.

T3

450 ± 20 mVp-p

24 V AC

TP123

zero crosspoint

0 0.2 msec.J400

230 V AC / 50Hz

6

4. PARTS LISTLOCATION PARTS NO. DESCRIPTION LOCATION PARTS NO. DESCRIPTION

ACCESSORIES & PACKING MATERIALS645 051 5224 LENS CAP645 055 0492 3440P INSTRUCTION MANUAL645 050 9728 IRIS PLUG,4P645 051 0496 AC TYPE PE CUSHION645 055 0508 3440P UNIT BOX645 051 0526 PE CAMERA BAG

CABINET & CHASSIS PARTS1 645 050 9193 FRONT COVER2 645 050 9209 REAR COVER3 645 050 9216 TOP COVER4 645 050 9186 BOTTOM COVER5 645 055 0348 REAR PANEL6 645 050 9162 ANTI DUSTY FILM7 645 050 9223 SUPPORTER8 645 050 9230 TRIPOD9 645 050 9179 CS MOUNT RING10 645 050 9254 TRIPOD SCREW M3X611 645 050 9322 SUPPORTER SCREW M2X4

12 645 050 9292 PCB SCREW M2X413 645 050 9285 CABINET SCREW M2X414 645 050 9278 SET SCREW M3X415 645 051 0373 BNC SB-124B16 645 055 0416 POWER CORD

(Included in the POWER PCB ASSY POWER BOARD17 645 051 0281 WIRE (N.S.P.)18 645 051 0304 WIRE (N.S.P.)19 645 051 0311 WIRE (N.S.P.)20 645 051 0328 WIRE (N.S.P.)21 645 051 0298 FLEXILE CABLE22 645 050 9308 GND WIRE SCREW M3X423 645 052 0099 SENSOR PCB ASSY SENSOR BOARD24 645 050 9117 IRIS PCB ASSY IRIS BOARD25 645 055 0294 POWER PCB ASSY POWER BOARD26 645 059 4670 REAR PCB ASSY REAR BOARD27 645 052 0143 CONTROL PCB ASSY CONTROL BOARD28 645 051 0380 BNC SB-124B GND29 645 051 0397 BNC SB-124B NUT30 645 055 0447 CORD BUSHING31 645 055 0324 MYLAR32 645 055 0355 M3 SPRING WASHER

2

1712

15

16

12

23

31

26

28

30

5

12

1212

21

27

12

18

20

11

25

19

10

8

4

13

7

2213

7

14

61

24

3

13

9

29

32

7

Note:1. Materials of Capacitors and Resistors are abbreviated as follows ;

Resistors Capacitors MT-FILM Metallized Film Resistor MT-POLYEST Metallized Polyester Capacitor MT-GLAZE Metallized Glaze Resistor MT-COMPO Metallized Composite Capacitor OXIDE-MT Oxide Metallized Film Resistor TA-SOLID Tantalum Solid Capacitor

AL-SOLID Aluminum Solid Capacitor NP-ELECT Non-Polarized Electrolytic Capacitor OS-SOLID Aluminum Solid Capacitors with Organic

Semiconductive Electrolytic Capacitor DL-ELECT Double Layered Electrolytic Capacitor

2. Tolerance of Capacitor (10pF over) and Resistor are noted with follow symboles. F ............1% G ............2% J ............5% K ............10% M ..........20% N ..........30% Z ..........+80% ~ -20%

3. CapacitorsU : µF P : pF

4. InductorsUH : µH MH : mH

5. N.S.P. : Not available as service parts.

ELECTRICAL PARTS

LOCATION PARTS NO. DESCRIPTION LOCATION PARTS NO. DESCRIPTIONSENSOR PCB ASSY SENSOR BOARD

645 052 0099

(CONNECTOR)CN100 645 050 9735 SMD CONNECTOR 16P,P1.0,180DEG. (N.S.P.)

(CAPACITORS)C100 645 051 0090 CERAMIC 0.1U Z 25VC101 645 051 0182 CERAMIC 0.047U Z 25VC102 645 051 0182 CERAMIC 0.047U Z 25VC103 645 051 0090 CERAMIC 0.1U Z 25VC116 645 051 0199 CERAMIC 4.7U Z 16VC117 645 051 0090 CERAMIC 0.1U Z 25VC118 645 051 0199 CERAMIC 4.7U Z 16VC119 645 051 0090 CERAMIC 0.1U Z 25VC122 645 051 0243 DIP ELECT 100U M 16V

(INDUCTORS)L101 645 050 9575 INDUCTOR 47UH JL102 645 050 9575 INDUCTOR 47UH J

(SEMICONDUCTOR)Q100 645 050 9711 TR KTC3882

(RESISTORS)R100 645 050 9766 CHIP RESISTOR 0 JR101 645 050 9773 CHIP RESISTOR 1M JR102 645 050 9988 CHIP RESISTOR 4.7K JR103 645 050 9797 CHIP RESISTOR 100 JR104 645 050 9766 CHIP RESISTOR 0 JR105 645 050 9766 CHIP RESISTOR 0 JR106 645 050 9773 CHIP RESISTOR 1M JR119 645 050 9780 CHIP RESISTOR 10 JR121 645 050 9766 CHIP RESISTOR 0 J

(MISCELLANEOUS)U100 645 059 4687 CCD MN39210AT

IRIS PCB ASSY IRIS BOARD645 050 9117

(CONNECTOR)CN200 645 050 9490 DIP CONNECTOR 4PINS (N.S.P.)CN201 645 050 9728 SOCKET 4P,IRIS JACK (N.S.P.)

(CAPACITORS)C200 645 051 0199 CERAMIC 4.7U Z 16VC202 645 051 0090 CERAMIC 0.1U Z 25VC203 645 050 9476 CERAMIC 1U Z 25VC204 645 051 0229 TA-SOLID 1U M 35VC206 645 051 0199 CERAMIC 4.7U Z 16VC207 645 050 9476 CERAMIC 1U Z 25VC208 645 051 0212 TA-SOLID 10U M 10VC209 645 051 0090 CERAMIC 0.1U Z 25VC211 645 051 0090 CERAMIC 0.1U Z 25VC212 645 051 0175 CERAMIC 47P J 50VC213 645 051 0175 CERAMIC 47P J 50VC214 645 051 0175 CERAMIC 47P J 50VC215 645 050 9476 CERAMIC 1U Z 25V

C216 645 051 0090 CERAMIC 0.1U Z 25VC218 645 050 9476 CERAMIC 1U Z 25V

(DIODES)D200 645 050 9544 DIODE 1SS355D203 645 050 9544 DIODE 1SS355

(INDUCTOR)L200 645 050 9582 INDUCTOR 22UH J

(SEMICONDUCTORS)Q201 645 050 9667 TR MMST2222AQ203 645 050 9667 TR MMST2222A

(RESISTORS)R200 645 050 9766 CHIP RESISTOR 0 JR201 645 050 9766 CHIP RESISTOR 0 JR207 645 050 9988 CHIP RESISTOR 4.7K JR208 645 050 9926 CHIP RESISTOR 3.3K JR209 645 050 9865 CHIP RESISTOR 2K JR211 645 050 9933 CHIP RESISTOR 33K JR212 645 050 9544 DIODE 1SS355R213 645 050 9759 CHIP RESISTOR 100 JR214 645 050 9834 CHIP RESISTOR 1M JR215 645 050 9742 CHIP RESISTOR 0 JR216 645 050 9759 CHIP RESISTOR 100 JR217 645 050 9742 CHIP RESISTOR 0 JR218 645 050 9742 CHIP RESISTOR 0 JR219 645 050 9742 CHIP RESISTOR 0 JR220 645 050 9742 CHIP RESISTOR 0 JR221 645 050 9742 CHIP RESISTOR 0 JR222 645 050 9803 CHIP RESISTOR 1K JR235 645 050 9988 CHIP RESISTOR 4.7K J

(SWITCH)SW200 645 051 0359 SLIDE SW 12P,00420693

(INTEGRATED CIRCUITS)U200 645 050 9353 IC NJM3414AMU201 645 050 9612 REGULATOR 78L05

(VARIABLE RESISTOR)VR200 645 050 9445 DIP VR 10K

(JUMP)JUMP 645 051 0052 CHIP RESISTOR 0 J

POWER PCB ASSY POWER BOARD645 055 0294

(CONNECTORS)CN300 645 055 0416 POWER CORD AC230V (N.S.P.)CN301 645 050 9537 DIP CONNECTOR 4PINS (N.S.P.)

(CAPACITORS)C300 645 052 0303 X2 CAP. 0.01U Z 275VC301 645 051 0236 DIP ELECT 1000U/25VC303 645 051 0274 DIP ELECT 470U/25VC304 645 051 0250 SMD ELECT 47U M 16VC305 645 051 0090 CERAMIC 0.1U Z 25VC309 645 051 0199 CERAMIC 4.7U Z 16VC310 645 051 0090 CERAMIC 0.1U Z 25VC311 645 051 0250 SMD ELECT 47U M 16V

8

LOCATION PARTS NO. DESCRIPTION LOCATION PARTS NO. DESCRIPTIONC312 645 051 0090 CERAMIC 0.1U Z 25VC313 645 051 0090 CERAMIC 0.1U Z 25VC316 645 050 9476 CERAMIC 1U Z 25VC317 645 051 0106 CERAMIC 0.01U Z 50VC318 645 052 0297 TA-SOLID 0.22U K 35VC319 645 052 0297 TA-SOLID 0.22U K 35V

(DIODES)D300 645 052 0181 DIODE BD104GD304 645 050 9636 ZENER DIODE UDZ16B

(FUSE)F301 645 055 0423 FUSE 250MA/250V

(INDUCTOR)L301 645 050 9605 INDUCTOR 22UH M

(SEMICONDUCTORS)Q300 645 050 9704 TR 2SD1733RQ302 645 050 9667 TR MMST2222AQ303 645 052 0235 TR MMST2907AQ304 645 050 9667 TR MMST2222AQ307 645 050 9667 TR MMST2222A

(RESISTORS)R301 645 050 9803 CHIP RESISTORS 1K JR302 645 050 9810 CHIP RESISTORS 10K JR303 645 050 9766 CHIP RESISTORS 0 JR304 645 052 0259 CHIP RESISTORS 510 JR307 645 050 9803 CHIP RESISTORS 1K JR308 645 050 9810 CHIP RESISTORS 10K JR309 645 050 9995 CHIP RESISTORS 47K JR311 645 052 0266 CHIP RESISTORS 68K JR312 645 050 9452 CHIP RESISTORS 3.3 JR314 645 050 9766 CHIP RESISTORS 0 JR315 645 052 0242 CHIP RESISTORS 12K JR318 645 050 9827 CHIP RESISTORS 100K JR320 645 051 0014 CHIP RESISTORS 6.8K JR321 645 050 9797 CHIP RESISTORS 100 J

(TRANSFORMER)T300 645 055 0430 TRANSFORMER EI-41 AC230V

(REGULATOR)U300 645 050 9612 REGULATOR 78L05

(VARIABLE RESISTOR)VA300 645 052 0334 VARISTER DNR-07D471K

REAR PCB ASSY REAR BOARD

(CONNECTORS)CN400 645 050 9520 DIP CONNECTOR 12P,P1.25 (N.S.P.)CN401 645 050 9506 DIP CONNECTOR 2P,P1.25 (N.S.P.)

(LED)LED400 645 050 9155 LED P3.0,RED

(RESISTORS)R400 645 051 0205 DIP RESISTOR 1.2K J 1/4WR401 645 052 0259 CHIP RESISTOR 510 JR402 645 050 9810 CHIP RESISTOR 10K J

(SWITCHES)SW400 645 051 0366 DIP ROTARY SW ERD210RSSW401 645 052 0358 DIP SW 206004ES,4POLES

CONTROL PCB ASSY CONTROL BOARD645 052 0143

(CONNECTORS)CN500 645 050 9537 DIP CONNECTOR 4P,P2.0 (N.S.P.)CN501 645 050 9490 DIP CONNECTOR 4P,P1.25 (N.S.P.)CN502 645 050 9735 SMD CONNECTOR 16P,P1.0,180DEG. (N.S.P.)CN503 645 050 9520 DIP CONNECTOR 12P,P1.25 (N.S.P.)CN504 645 050 9506 DIP CONNECTOR 2P,P1.25 (N.S.P.)

(CAPACITORS)C500 645 051 0199 CERAMIC 4.7U Z 16VC501 645 051 0090 CERAMIC 0.1U Z 25VC503 645 051 0199 CERAMIC 4.7U Z 16VC504 645 051 0199 CERAMIC 4.7U Z 16VC506 645 051 0199 CERAMIC 4.7U Z 16VC507 645 051 0199 CERAMIC 4.7U Z 16VC508 645 051 0151 CERAMIC 330P J 50VC509 645 051 0243 DIP ELECT 100U M 16V

C510 645 051 0090 CERAMIC 0.1U Z 25VC511 645 051 0199 CERAMIC 4.7U Z 16VC512 645 051 0199 CERAMIC 4.7U Z 16VC513 645 051 0090 CERAMIC 0.1U Z 25VC515 645 050 9483 CERAMIC 2.2U Z 16VC516 645 051 0199 CERAMIC 4.7U Z 16VC517 645 051 0199 CERAMIC 4.7U Z 16VC518 645 051 0090 CERAMIC 0.1U Z 25VC520 645 051 0090 CERAMIC 0.1U Z 25VC521 645 051 0090 CERAMIC 0.1U Z 25VC522 645 051 0090 CERAMIC 0.1U Z 25VC523 645 051 0137 CERAMIC 0.22U Z 16VC524 645 051 0212 TA-SOLID 10U M 10VC525 645 051 0090 CERAMIC 0.1U Z 25VC526 645 051 0090 CERAMIC 0.1U Z 25VC527 645 051 0090 CERAMIC 0.1U Z 25VC529 645 050 9483 CERAMIC 2.2U Z 16VC530 645 051 0090 CERAMIC 0.1U Z 25VC531 645 051 0090 CERAMIC 0.1U Z 25VC532 645 051 0120 CERAMIC 22P J 50VC533 645 051 0212 TA-SOLID 10U M 10VC534 645 052 0310 DIP ELECT 220U M 10VC535 645 051 0168 CERAMIC 33P J 50VC536 645 051 0168 CERAMIC 33P J 50VC537 645 050 9476 CERAMIC 1U Z 25VC538 645 051 0090 CERAMIC 0.1U Z 25VC539 645 051 0090 CERAMIC 0.1U Z 25VC540 645 051 0090 CERAMIC 0.1U Z 25VC541 645 051 0212 TA-SOLID 10U M 10VC542 645 051 0090 CERAMIC 0.1U Z 25VC543 645 050 9483 CERAMIC 2.2U Z 16VC547 645 051 0151 CERAMIC 330P J 50VC548 645 051 0151 CERAMIC 330P J 50VC549 645 050 9483 CERAMIC 2.2U Z 16VC550 645 050 9476 CERAMIC 1U Z 25VC551 645 050 9483 CERAMIC 2.2U Z 16VC555 645 050 9483 CERAMIC 2.2U Z 16VC557 645 051 0090 CERAMIC 0.1U Z 25VC559 645 051 0090 CERAMIC 0.1U Z 25VC561 645 051 0113 CERAMIC 100P J 50VC562 645 051 0090 CERAMIC 0.1U Z 25VC563 645 051 0144 CERAMIC 27P J 50VC564 645 051 0168 CERAMIC 33P J 50VC565 645 051 0090 CERAMIC 0.1U Z 25VC567 645 050 9476 CERAMIC 1U Z 25VC568 645 050 9469 CHIP RESISTOR 0 JC569 645 051 0199 CERAMIC 4.7U Z 16VC570 645 051 0199 CERAMIC 4.7U Z 16VC571 645 051 0090 CERAMIC 0.1U Z 25VC572 645 050 9476 CERAMIC 1U Z 25VC573 645 051 0090 CERAMIC 0.1U Z 25VC574 645 051 0090 CERAMIC 0.1U Z 25VC575 645 051 0090 CERAMIC 0.1U Z 25VC576 645 051 0090 CERAMIC 0.1U Z 25VC577 645 051 0090 CERAMIC 0.1U Z 25VC578 645 051 0090 CERAMIC 0.1U Z 25VC579 645 051 0090 CERAMIC 0.1U Z 25VC580 645 051 0090 CERAMIC 0.1U Z 25VC581 645 051 0090 CERAMIC 0.1U Z 25VC582 645 051 0090 CERAMIC 0.1U Z 25VC583 645 051 0090 CERAMIC 0.1U Z 25VC586 645 050 9469 CHIP RESISTOR 0 JC587 645 052 0280 CERAMIC TRIM CAP. TZC3P200A110C589 645 050 9476 CERAMIC 1U Z 25VC590 645 051 0090 CERAMIC 0.1U Z 25VC591 645 051 0199 CERAMIC 4.7U Z 16VC593 645 052 0310 DIP ELECT 220U M 10VC594 645 051 0090 CERAMIC 0.1U Z 25VC598 645 050 9483 CERAMIC 2.2U Z 16VC599 645 050 9483 CERAMIC 2.2U Z 16VC600 645 051 0106 CERAMIC 0.01U Z 50VC602 645 051 0199 CERAMIC 4.7U Z 16VC603 645 051 0199 CERAMIC 4.7U Z 16VC605 645 051 0199 CERAMIC 4.7U Z 16VC606 645 051 0199 CERAMIC 4.7U Z 16VC607 645 051 0199 CERAMIC 4.7U Z 16VC611 645 050 9476 CERAMIC 1U Z 25VC613 645 051 0151 CERAMIC 330P J 50V

9

LOCATION PARTS NO. DESCRIPTION LOCATION PARTS NO. DESCRIPTIONC614 645 051 0199 CERAMIC 4.7U Z 16VC615 645 050 9483 CERAMIC 2.2U Z 16VC616 645 051 0199 CERAMIC 4.7U Z 16VC618 645 051 0090 CERAMIC 0.1U Z 25VC620 645 051 0090 CERAMIC 0.1U Z 25V

(DIODES)D503 645 050 9544 DIODE 1SS355D504 645 050 9636 ZENER DIODE UDZ16BD505 645 050 9643 ZENER DIODE UDZ5.6BD506 645 052 0198 VER IABLE CAP. DIODE 1SV215D507 645 052 0198 VER IABLE CAP. DIODE 1SV215D508 645 052 0204 LED SML-310VTD509 645 050 9544 DIODE 1SS355D510 645 050 9568 DIODE RB706F-40D511 645 050 9544 DIODE 1SS355D512 645 050 9544 DIODE 1SS355D513 645 050 9650 ZENER DIODE UDZ8.2BD515 645 050 9568 DIODE RB706F-40

(INDUCTORS)L501 645 050 9575 INDUCTOR 47UH JL502 645 050 9575 INDUCTOR 47UH JL503 645 050 9575 INDUCTOR 47UH JL504 645 050 9599 INDUCTOR 10UH JL505 645 052 0228 INDUCTOR 8.2UH JL506 645 050 9575 INDUCTOR 47UH JL507 645 050 9599 INDUCTOR 10UH JL508 645 050 9575 INDUCTOR 47UH JL509 645 050 9575 INDUCTOR 47UH JL510 645 050 9575 INDUCTOR 47UH JL511 645 050 9582 INDUCTOR 22UH JL512 645 050 9599 INDUCTOR 10UH J

(SEMICONDUCTORS)Q500 645 050 9681 TR 2SD1664RQ502 645 050 9766 CHIP RESISTOR 0 JQ504 645 050 9698 TR 2SC4617RQ506 645 050 9667 TR MMST2222AQ507 645 050 9674 TR IMZ1AQ508 645 050 9667 TR MMST2222AQ509 645 050 9667 TR MMST2222A

(RESISTORS)R501 645 051 0069 CHIP RESISTOR 10 JR502 645 051 0076 CHIP RESISTOR 12 JR503 645 050 9971 CHIP RESISTOR 470 JR506 645 050 9810 CHIP RESISTOR 10K JR507 645 050 9810 CHIP RESISTOR 10K JR508 645 050 9889 CHIP RESISTOR 2.2K JR509 645 050 9902 CHIP RESISTOR 300 JR510 645 050 9766 CHIP RESISTOR 0 JR512 645 051 0083 CHIP RESISTOR 3.16K FR513 645 059 4694 CHIP RESISTOR 1.8K JR514 645 051 0083 CHIP RESISTOR 3.16K FR515 645 054 8611 CHIP RESISTOR 56K JR516 645 050 9766 CHIP RESISTOR 0 JR517 645 050 9810 CHIP RESISTOR 10K JR518 645 050 9841 CHIP RESISTOR 1.2K JR520 645 050 9766 CHIP RESISTOR 0 JR521 645 050 9810 CHIP RESISTOR 10K JR522 645 050 9957 CHIP RESISTOR 39K JR523 645 050 9940 CHIP RESISTOR 36K JR524 645 050 9858 CHIP RESISTOR 15K JR525 645 051 0045 CHIP RESISTOR 9.1K JR526 645 050 9889 CHIP RESISTOR 2.2K JR527 645 050 9797 CHIP RESISTOR 100 JR528 645 051 0083 CHIP RESISTOR 3.16K FR529 645 050 9766 CHIP RESISTOR 0 JR530 645 050 9803 CHIP RESISTOR 1K JR531 645 051 0083 CHIP RESISTOR 3.16K FR532 645 050 9896 CHIP RESISTOR 24K JR533 645 050 9933 CHIP RESISTOR 33K JR534 645 051 0014 CHIP RESISTOR 6.8K JR535 645 051 0007 CHIP RESISTOR 5.6K JR537 645 050 9964 CHIP RESISTOR 4.7 JR538 645 050 9919 CHIP RESISTOR 330 JR539 645 050 9773 CHIP RESISTOR 1M JR540 645 050 9797 CHIP RESISTOR 100 JR541 645 050 9810 CHIP RESISTOR 10K JR542 645 050 9810 CHIP RESISTOR 10K JR543 645 050 9810 CHIP RESISTOR 10K J

R544 645 050 9803 CHIP RESISTOR 1K JR545 645 050 9773 CHIP RESISTOR 1M JR550 645 050 9995 CHIP RESISTOR 47K JR551 645 050 9810 CHIP RESISTOR 10K JR554 645 050 9766 CHIP RESISTOR 0 JR555 645 050 9810 CHIP RESISTOR 10K JR557 645 050 9803 CHIP RESISTOR 1K JR558 645 050 9810 CHIP RESISTOR 10K JR559 645 050 9773 CHIP RESISTOR 1M JR560 645 050 9797 CHIP RESISTOR 100 JR561 645 050 9766 CHIP RESISTOR 0 JR562 645 050 9964 CHIP RESISTOR 4.7 JR564 645 050 9995 CHIP RESISTOR 47K JR565 645 050 9773 CHIP RESISTOR 1M JR566 645 051 0038 CHIP RESISTOR 820 JR569 645 050 9827 CHIP RESISTOR 100K JR570 645 050 9827 CHIP RESISTOR 100K JR571 645 050 9827 CHIP RESISTOR 100K JR572 645 050 9827 CHIP RESISTOR 100K JR573 645 050 9827 CHIP RESISTOR 100K JR574 645 050 9827 CHIP RESISTOR 100K JR575 645 050 9827 CHIP RESISTOR 100K JR577 645 050 9810 CHIP RESISTOR 10K JR587 645 050 9803 CHIP RESISTOR 1K JR588 645 050 9766 CHIP RESISTOR 0 JR589 645 050 9810 CHIP RESISTOR 10K JR591 645 051 0007 CHIP RESISTOR 5.6K JR592 645 050 9827 CHIP RESISTOR 100K JR594 645 050 9766 CHIP RESISTOR 0 JR596 645 050 9766 CHIP RESISTOR 0 JR597 645 050 9964 CHIP RESISTOR 4.7 JR598 645 050 9766 CHIP RESISTOR 0 JR607 645 050 9988 CHIP RESISTOR 4.7K JR610 645 051 0021 CHIP RESISTOR 75 JR611 645 050 9766 CHIP RESISTOR 0 JR612 645 050 9766 CHIP RESISTOR 0 JR613 645 050 9964 CHIP RESISTOR 4.7 JR614 645 050 9964 CHIP RESISTOR 4.7 JR615 645 050 9766 CHIP RESISTOR 0 JR620 645 051 0021 CHIP RESISTOR 75 JR621 645 050 9919 CHIP RESISTOR 330 JR625 645 050 9919 CHIP RESISTOR 330 JR626 645 050 9872 CHIP RESISTOR 220 JR628 645 050 9810 CHIP RESISTOR 10K JR629 645 050 9827 CHIP RESISTOR 100K JR631 645 050 9766 CHIP RESISTOR 0 J

(INTEGRATED CIRCUITS)U501 645 050 9414 IC SN104280PTU502 645 050 9407 IC UPD65630GA-Y38U503 645 050 9339 IC MN3112SAU505 645 050 9612 REGULATOR 78L05U507 645 052 0327 COMPARATOR TA75S393FU509 645 050 9360 IC 7S04FU510 645 050 9360 IC 7S04FU511 645 050 9391 IC BU4S81U512 645 050 9391 IC BU4S81U513 645 050 9391 IC BU4S81U514 645 050 9391 IC BU4S81U515 645 050 9346 IC 74HC4053DU516 645 050 9346 IC 74HC4053DU517 645 050 9346 IC 74HC4053DU518 645 050 9384 IC BU4S66

(INTEGRATED CIRCUITS)VR500 645 050 9421 VR 20KVR501 645 050 9421 VR 20K

(CRYSTAL DEVICE)X500 645 050 9629 CRYSTAL 18.9375MHZ

C1

CIRCUIT DIAGRAMS & PRINTED WIRING BOARDS

TABLE OF CONTENTS

1. CIRCUIT DIAGRAMS Page

OVERALL WIRING ........................................................................................................................................... C3

POWER BOARD ............................................................................................................................................... C3

SENSOR BOARD ............................................................................................................................................. C4

REAR BOARD .................................................................................................................................................. C4

CONTROL BOARD ........................................................................................................................................... C5

IRIS BOARD ..................................................................................................................................................... C6

CIRCUIT WAVEFORMS ................................................................................................................................... C6

2. PRINTED WIRING BOARDS (P.W.B.)POWER P.W.B. ................................................................................................................................................ C7

SENSOR P.W.B. ............................................................................................................................................... C7

IRIS P.W.B. ....................................................................................................................................................... C7

CONTROL P.W.B. ............................................................................................................................................ C8

REAR P.W.B. .................................................................................................................................................... C8

C2

PRODUCT SAFETY NOTICETHE COMPONENTS DESIGNATED BY A SYMBOL ( ) IN THISSCHEMATIC DIAGRAM DESIGNATES COMPONENTS WHOSEVALUE ARE OF SPECIAL SIGNIFICANCE TO PRODUCT SAFETY.SHOULD ANY COMPONENT DESIGNATED BY A SYMBOL NEED TOBE REPLACED, USE ONLY THE PART DESIGNATED IN THE PARTSLIST.DO NOT DEVIATE FROM THE RESISTANCE, WATTAGE AND VOLT-AGE RATINGS SHOWN.

A

B

C

D

E

F

G

H

I

J

K

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19

A

B

C

D

E

F

G

H

I

J

K

C3

CIRCUIT DIAGRAMSOVERALL WIRING

V4 1V3 2V2 3V1 4

GND 5OS 6

GND 7+15V 8-7V 9

GND 10SUB 11RG 12H1 13H2 14

GND 15+10V 16

V41V32V23V14

GND5OS6

GND7+15V8-7V9

GND10SUB11RG12H113H214

GND15+10V16

SENSOR BOARD

CN100 CN502

CCD SENSOR

+10V1GND2IRISV3

CSYNC4

CN501+10V 1GND 2IRISV 3

CSYNC 4

CN201

IRIS BOARD

+10VA/C-1NC/C+2

IROS/D+3GND4

CN200

IRIS

OU

T

+5VD 1VR#1 2LL/INT 3GND 4

AEX/MEX 5BLC 6AGC 7GND 8

R-SW1(S4) 9R-SW2(S3) 10R-SW4(S2) 11R-SW5(S1) 12

CN503

+10V1GND2ACP3GND4

CN301+10V 1GND 2ACP 3GND 4

CN500

CONTROL BOARD

POWERCORD

POWER BOARDCN300

+5VD1VR#12LL/INT3GND4

AEX/MEX5BLC6AGC7GND8

R-SW1(S4)9R-SW2(S3)10R-SW4(S2)11R-SW5(S1)12

CN400

VIDEO O/P 1GND 2

CN504VIDEO O/P1

GND2

CN401 J400

REAR BOARD

TO CONTROLBOARD CN500

12

3

4

- +

ACP

+10V

GND

GND

ACP

+5V

+5V

12

1 2 12

GN

D2

VI3 VO 1

12

12

2

1

3

121

2

12

1 2

12

12

12

12

1

4

7

6

1 2

12

1

2

3

4

12

12

12

1 2

121 2

3

2

1

13

2

12

3

2

1

3

2

1

12

12

12

12

12

12

12

1 2

1

3

DC1

R30210K

R3030

C3050.1u

U300REG.

78L05

C3100.1u

C3094.7u/16V

Q3002SD1733R

C3120.1u

C3000.01u/275V

D300BD104G

C3130.1u

R3071K

R30810K R318

100K

R3140

R321100

T300EI-41

GND

+5V

+10V

VA300CNR-07D471K

L30122uH C311

47u/16V CN3014PINS

C3011000u/25V

C30447u/16V

R3011K

R31512K

R31168K

C3170.01u

Q302MMST2222A

Q303MMST2907A

R3206.8K

Q304MMST2222A

Q307

MMST2222ASOT-23

D304UDZ16B

C3190.22u/35V

R30947K

C3180.22u/35V

C316

1u/25V

C304470u/25V

R304510

R3123.3

F301

FUSE250mA/250V

CN300Power Cord

!

!

! !

!

POWER BOARD

A

B

C

D

E

F

G

H

I

J

K

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19

A

B

C

D

E

F

G

H

I

J

K

C4

V4

V3

V2

V1

GND

OS

GND

+15V

-7V

GND

SUB

RG

H1

H2

GND

CCD:

+10V

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

12

12

12

1 2

1 2

12

1 2

1 2

12

3

2

1

1 2

12

12

1 2

12

12

12

1 2

OD

1O

R2

RD

3V

/O4

LG5

V1

12

V2

13

V3

14

OV

415

PW

16

OG

6H

27

H1

8H

IS9

SU

B10

PT

11

1 2

12

1 2

CN100TO CONTROL BOARD CN502

C1190.1u

C1184.7u/16V

C1170.1u

C1030.1u

R11910

R1061M

R1000

C1164.7u/16V

R103100

Q100KTC3882

R1050

R1024.7K

R1011M

R1040

C1020.047u

C1010.047u

C1000.1u

T6

T5

R1210

U100MN3726AT

L10147uH

C122100u/16V

L10247uH

+5VD

VR#1

LL/INT

GND

AEX/MEX

BLC

AGC

GND

S4

S3

S2

S1

S4

S2

S1

S3

ON

MEX

OFF

OFF

TOCONTROL BOARD CN503

LL V-PHASE ADJ.

POLE SW OFF SW ON

1

2

3

4

BLC

AGC

OFF

OFF

AE

XB

LCA

GC

INT LL

LL

INT AI EI

TOCONTROL BOARD CN504

2

8

431

5

1

2

3

4

5

6

7

8

9

10

11

12

1 2

1 2 3 4

8 7 6 5

1

2

1

2

3 1 2

12

SW400

ERD210RSREAL CODES

CN-400

R4001.2K1/4W

LED400RED

SW401206004ES4-POLE

CN401 J400SB-124BNC

VR40020K R401

5101/4W(R0805)

R402

12K(EIA)/10K(CCIR)

1/4W(R0805)

REAR BOARD

SENSOR BOARD

A

B

C

D

E

F

G

H

I

J

K

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19

A

B

C

D

E

F

G

H

I

J

K

C5

GND

IRISV

GND

GND

X

Y

Z

X

Y

Z

X

Y

Z

GND

H2

H1

RG

SUB

GND

-7V

+15V

GND

OS

GND

V1

V2

V3

V4

+5VD

VR#1

LL/INT

GND

AEX/MEX

BLC

AGC

GND

R-SW1(S4)

R-SW2(S3)

R-SW4(S2)

OPEN:H(EIA)

CLOSE:L(CCIR)

(ASP)

+5VD

+5VD

+5VD

(TG.)

VIDEO O/P

GND

TO IRIS BD. CN200

TO POWER BD. CN301

TO REAR BD. CN401

S1"

S2"

S3"S4"

S4’

BLC/OFF

AGC/OFF

LO

HI

LO

HI

LO

HI

HD

R-SW5(S1)

HIB

AEX/MEX

WIND

S1S2S3S4

BLC/OFF

PAL

RGH1

H2

+15V +15V

-7V

-7V

V2V1

+18V+18V

VIDEO O/P-7V

TO SENSOR BD. CN100

IRIS

AGC

X500

EIA :19.0699MHzCCIR :18.9375MHz

ACP

VR#1

LL/INT

+5VA

S1’

S2’

S3’

+10V

ACP

+10V

+10V

+ +

LOB

LOBHIB

HD

HD

CSYNC

CSYNC

ACP

R525EIA=8.2KCCIR=9.1K

1 2

1

2

3

4

12

1 2

1 2

12

1 2

12

12

43 12

5 6 12

1 2

12

12

12

12

12

12

12

12

12

12

12

12

1 2

1 2

12

12

12

12

12

12

12

12

12

12

12

1

2

3

1 2

1 2

1 2

1 2

1

2

12

12

12

12

12

12

12

12

12

1 2

12

12

1 2

12

1 2

1 2 1 2

12

GN

D2

VI3 VO 1

12

12

12

12

12

121 2

2

1

3

1 2

1

2

3

4

1

3

5

42

1

3

5

42

1

3

5

42

1

3

5

42

1

3

5

42

1 2

12

12

12

12

12

12

12

1411

1510

49

678

3

51

213

1216

12

12

12

12

1411

1510

49

678

3

51

213

1216

12

12

12

1411

1510

49

678

3

51

213

1216

1 2

1 2

12

1234 5

12

1 2

1 2

12

12

12

1 2

1 2

1

2

3

12

12

12

12

OS

LI2

V1

35V

236

GN

D3

PLLP

4P

LLN5

GN

D6

DE

TO

7E

XIN

8E

SO

29V

DD

30R

31H

132

H2

33G

ND

34

OS

LO1

VR

ST

9C

TR

L10

SP

SW

11T

ES

T12

OS

CO

25O

SC

I26

GN

D27

PA

L28

VDD24MODE23S422S321S220S119GND18AREA17VD16CBLK15CHD14SYNC13 VDD 48

CL 47DS2 46DS1 45CP2 44

CPOB 43PBLK 42VSUB 41CH2 40CH1 39V4 38V3 37

1 2

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

12

12

1 2

12

1 2

12

12

12

12

12

12

12

12

12

12

12

12

12

1 2

1 2

1

2

3

3

2

1

12

1 2

12

12

12

12

1 2 1 2

12

1 21 21 2

1 2

1 21 2

12

1

3

5

42

1 2

12

1 2

12

12

12

121 2

12

12

1 2

1

2

3

4

5

6

7

8

9

10

11

12

1 2

12

1 2

12

12

12

1 2

12

12

12

HIB35 LOB36

SYNP29 BLKP30 GND331 SAG32 V OUT33 VCC334

SYNL25 SET26 CL P27 VCC228

HC

PL

24C

LP IN

23

VC

C1

48A

GC

MA

X47

AG

CLV

46B

AC

K L

45A

GC

DE

T44

VC

C4

43IR

IS42

GN

D4

41W

IND

P40

CE

NT

39W

ID38

IR F

T37

DIN1 1DIN2 2GND 3

CLK1 4CLK2 5

6/12SET 6D-AMPO 7AGCIN 8

AGCGAIN 9LPFC 10LPFO 11R IN 12

HO

P13

R_C

14C

HD

15G

ND

216

R O

UT

17V

RE

F18

DL C

19A

P G

20A

P F

T21

AP

AM

PO

0

12

12

12

12

12

12

1 2

12

3

2

1

1 2

1 2

3

2

1

1 2

1 2

12

1 2

OS

UB

1V

L2

OV

23

VM

134

OV

15

VD

C6

IV1

7C

H1

8IV

29

VS

UB

10N

C11

IV4

12C

H2

13IV

314

GN

D15

VH

16O

V3

17O

V4

18V

M24

19V

HH

20

1 2

1 2

12

12

12

1 2

1 2

12

12

2

3

1

1 2

2

3

1 3

2

1

12

12

1 2

12

1 2

1 21 2

1 2

12

12

1 2

3

2

1

12

1234 5

12

12

1 2

12

1 2

1 21 2

1 2

T2

CCIR

VD

VRST

T1

PLLN

LL

HDMCK

T3

CN500

C5010.1u

R5082.2K

R50610K

R50710K

C6000.01u

R503470

D5121SS355

Q507IMZ1A C602

4.7u/16V

C5044.7u/16V

R621330

D504

UDZ16B

D513

UDZ8.2B C6054.7u/16V

C6064.7u/16V

R5100

R62075

C506

4.7u/16V

C5074.7u/16V

D5111SS355

C6034.7u/16V

R61075

C5420.1u

C543

2.2u/16V

C54110u/10V

C6200.1u

R625330

R5290

R5283.16K

R5313.16K

R626220

C5371u/25V

R5301K

C5400.1u

R5355.6K

VR50020K

C6180.1u

C5390.1u

C5200.1u

C5220.1u

CN504

C5260.1u

C5270.1u

R51710K

C5292.2u/16V

C5310.1u

R5200

R52110K

R52336K

R52415K

R589 10K

R527100

R5980

R615

0C5300.1u

R50110

R50212

R509300

C5100.1u

U50578L05

C5114.7u/16V

C5124.7u/16V

C5130.1u

C5180.1u

C517

4.7u/16V

C5164.7u/16V

C515

2.2u/16V

Q5002SD1664R

C53222P

CN501

U510

7S04F

U511

BU4S81

U512

BU4S81

U513

BU4S81

U514

BU4S81

C5750.1u

C5780.1u

C5770.1u

C5760.1u

C579

0.1u

R571100K

R570100K

R569100K

U51574HC4053D

R572100K

R573100K

R574100K

R575100K

U51674HC4053D

C5810.1u

C5830.1u

C5800.1u

U51774HC4053D

C582

0.1u

R5571K

R55810K

U518BU4S66

C613330P R628

10K

R559

1MR560

100

C56327P C564

33P

X50018.9375MHz

C5940.1u

VR50220K

C5660.1u

D5011SS355

C5650.1u

R5624.7

U502

C.P.U.

UPD65630GA-Y38QFP48

R5674.7

CN502

R6144.7

R6134.7

T6

L508

47uH

C5704.7u/16V

D5091SS355

D5031SS355

C5671u/25V

R5651MC569

4.7u/16VC5710.1u

C5891u/25V

C6152.2u/16V

C5620.1u

C572

1u/25V

R566820

C5730.1u

R564 47KC5740.1u

R6074.7K

C590

0.1u

VR50120K

Q5042SC4617R

C5914.7u/16V

L50947uH

T5

R5960

R5940

C547330P

C58720P

C548330P

R54210K

R54110K

D5071SV215D506

1SV215

C5501u/25V

R6310

C5512.2u/16VR550

47K

R545

1M

R5540

R55110K

R55510K

D508SML-310VT/RED

U5097S04F

R544

1K

C508330P

R5880

R5871K

C5590.1u

C5570.1u

R540100

R539

1M

C53633P

C53533P

C521

0.1u

CN503

L51122uH

T4

R5143.16KR525

9.1K/8.2K

R5153.16K

R5181.2K

R52239K

R5262.2K

R5346.8K

R5374.7

R538330

U501

SN104280PT

CDS AGC

R6110

C5380.1u

D505UDZ5.6B

R54310K

C561100P

C5492.2u/16V

R5915.6K

C5004.7u/16V

Q509

MMST2222A

C5982.2u/16V

C5992.2u/16V

Q508MMST2222A

L50347uH

L504

10uH

R5610

L5058.2uH

U503V-DRIVE

MN3112SA

L50647uH

L51047uH

C509100u/16V

C6144.7u/16V

C503

4.7u/16V

C616

4.7u/16V

L50147uH

C6074.7u/16V

C534220u/10V

D515RB706F-40

L507

10uH

D510RB706F-40

Q506MMST2222A

L51210uH

R5162.2K

C53310u/10V

C5230.22u/16V

C593220u/10V

C52410u/10VR629

100K

R592100K

R53333K

R53224K

C5860

Q502short (B&E)

C5552.2u/16V

U507TA75S393F

R6120 R577

10K

C568

0R0805

C6111u/25V

L50247uH

R5132.2K

R5123.16K

C525

0.1u/25V

+5VD

TO REAR BD. CN400

CONTROL BOARD

A

B

C

D

E

F

G

H

I

J

K

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19

A

B

C

D

E

F

G

H

I

J

K

C6

123

456 7

89

101112

IRISV

GND

IRIS

C-

C+

D+

NC/C+

IRIS/D+

GND

A

B

+10V

+10VA/C-

CSYNC

+10V

A

1 2

12

VI1

VO3

GN

D2 1

2

1 2

1 2

12

12

12

12

1 2

12

12

12

1 2

1 2

12

12

1

2

3

4

1

2

3

4

12

12

12

12

1 2 1 2

12

5

6

7

1 2

1 2

3

2

1

1 2

12

3

2

1

3

21

84

1 2

1 2

1 2

1 2

12

1 2

1 2

12

12

12

1

2

3

R2000

C2020.1u

U20178L05

C2181u/25V

R2180

C2031u/25V

C21247P

R2200

R2190

C21447PR221

0C21347PC209

0.1u

C20810u/10V

R2221K

D2031SS355

C2004.7u/16V

C2160.1u

CN201

IRIS JACK

CN200TO COMTROL BOARD CN501

C2064.7u/16V

C2151u/25V

D2001SS355

R2354.7K

R2074.7K

R2083.3K

C2110.1u

U200

NJM3414AM

+

-

R2170

R2150

Q201MMST2222A

R213100

L20022uH

Q203MMST2222A

U200NJM3414AM

+

-

SW20000420693

R216100

R2010

R2141M

C2071u/25V

C2041u/35V

R224NC

JUMP

0

R21133K

R2092K

R2121SS355

VR20010K

+10VA

+5V

+10VA

+5V

WAVEFORMTEST POINT

LOCATION

TEST POINT

LOCATION

WAVEFORM

Test point T5

Shutter

=1/50sec

1V/div

5ms/div

Test point T5

Shutter

=1/120sec

1V/div

5ms/div

Test point T5

Shutter

=1/250sec

1V/div

5ms/div

Test point T5

Shutter

=1/500sec

1V/div

5ms/div

Test point T5

Shutter

=1/1000sec

1V/div

5ms/div

Test point T5

Shutter

=1/2000sec

1V/div

5ms/div

Test point T5

Shutter

=1/4000sec

1V/div

5ms/div

Test point T5

Shutter

=1/10000sec

1V/div

5ms/div

IRIS BOARD CIRCUIT WAVEFORMS

WF-VCB3440P

A

B

C

D

E

F

G

H

I

J

K

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19

A

B

C

D

E

F

G

H

I

J

K

C7

PRINTED WIRING BOARDS (P.W.B.)

POWER P.W.B. (SIDE A) POWER P.W.B. (SIDE B)

SENSOR P.W.B. (SIDE A) SENSOR P.W.B. (SIDE B)

IRIS P.W.B. (SIDE A)

IRIS P.W.B. (SIDE B)

A

B

C

D

E

F

G

H

I

J

K

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19

A

B

C

D

E

F

G

H

I

J

K

C8

CONTROL P.W.B. (SIDE A)CONTROL P.W.B. (SIDE B)

REAR P.W.B. (SIDE B)REAR P.W.B. (SIDE A)

Dec./’02

SANYO Electric Co., Ltd.Osaka, Japan