18
ST in Aerospace Thibault BRUNET Marketing Manager 1 Thibault Brunet – Aerospace & High Reliability Products 10/19/2012
ST in Aerospace
Thibault BRUNET
Marketing Manager
1 Thibault Brunet – Aerospace & High Reliability Products 10/19/2012
Tours (F)
Catania (I)
Ang Mo Kio
(Sp)
RENNES (F)
Agrate (I)
Crolles (F)
Wafer Fab
IMS Group
Wafer
Fab
Wafer
Fab
Wafer Fab
IMS Group
Assy/Test
Selection
Wafer Fab
IMS Group
IMS
Group
Grenoble (F)
Aerospace Industrial Operations Over the World
MOSFETs
Bipolar
transistors
Schottky
diodes
Bipolar
diodes
ST portfolio for Aerospace
Thibault Brunet – Aerospace & High Reliability Products
Discrete
devices
Logic and
interfaces
Analog and
sensors
Power
management
Bus drivers
Level shifters
ADC
Op-amps
ACMOS logic
HCMOS logic
CMOS4000
New PWM
Controllers
Linear
regulator
Current
limiters
Gate Drivers
Comparators
Voltage
reference
Legend:
Hirel
50/100 krad
300 krad
DLA
ESCC
Development
New
New New
New
New
Part
Number Type
Vceo
V
Ic
A
Hfe
Min
ESCC
Spec Package Hirel
Rad
Resist
2N2219A NPN 40 0.8 100 5201-003 TO-39 Y -
2N2222A NPN 40 0.8 100 5201-002 TO-18, LCC-3, LCC-3UB Y 100k
2N2905A PNP -60 0.8 100 5202-002 TO-39 Y -
2N2907A PNP -60 0.8 100 5202-001 TO18, LCC3, LCC-3UB Y 100k**
2N2920A * NPN 60 0.03 300 5207-002 TO-77, LCC-6 Y 100k**
2N3019 NPN 80 1.0 100 5201-011 TO-39 Y 4Q11**
2N3700 NPN 80 1.0 100 5201-004 TO-18, LCC-3, LCC-3UB Y 100k
2N3810HR * PNP -60 0.05 150 5207-005 TO-78, LCC-6 Y -
2N5153 PNP -80 5.0 70 5204-002 TO-39, TO257, SMD.5 Y 100k**
2N5154HR NPN 80 5 70 5203-010 TO-257, TO-39, SMD.5 Y 100k
2N5401 PNP -150 0.6 60 5202-014 TO-18, LCC-3, LCC-3UB Y 100k
2N5551 NPN 150 0.6 60 5201-019 TO-18, LCC-3, LCC-3UB Y 100k
Space Grade Bipolar Transistors
(*) Dual matched transistors
(**) : Post Radiation spec tbd 4 Thibault Brunet – Aerospace & High Reliability Products 10/19/2012
ESCC
Variant
Rad Resistant : Low Dose Rate TID
TO-18/39/77/78 : Not Recommended for New Designs
Logic ICs for Aerospace Widest Offering
Gates - Flip-Flops - Latches…
Decoders - Multiplexers - Buffers – Transceivers …
Counters - Adders - PLLs – Monostables…
54AC - 54ACT 62 products
Rad-Hard part numbering = RHFACxx, RHFACTxx
54VCXHxxx : 3Volt 5 products
Rad-Hard part numbering = RHFXH162xx
CMOS4000 75 products
Rad-Hard part numbering = HCC4xx
M54HC / HCT : No Switching Time Degradation 89 products
Rad-Hard part numbering = M54HCxx
300krad
300krad
100krad
50krad
Cold
Spares
QML-V
QML-V
5 Thibault Brunet – Aerospace & High Reliability Products 18-Aug-10
NOW
16bit Interfaces Series - 3 Volt 300krad
54VCXH162xxx series - QML-V - 300 krad :
No SEE detected under 72MeV/cm²/mg LET ions.
Cold Spare
Family Overview :
54VCXH162244: 16bit Bus interface
54VCXH162245: 16bit Bus Transceiver
54VCXHR162245: Same with 26 Ω sets
54VCXH162373: 16bit D-type Latch
54VCXH162374: 16bit D-type Flip Flop
54VCXH163245 3.6v 1.4volt 16 bit Level Shifter
Bi Voltage Version of the 54VCXHR162245
Ideal to interface FPGA’s and MCU’s
54AC164245 5v2.3volt 16 bit Level Shifter – 100 krad
6 Thibault Brunet – Aerospace & High Reliability Products 10/19/2012
NOW
NOW
NOW
NOW
NOW
NOW
QML-V
Qualified
100 MHz
500 MHz
1 GHz
GBP
Icc mA
Rad-Hard BiCMOS Opamps 300 Krad - SEL free
RHF310
RHF330
RHF350
Low Power
LEGEND :
Precision - Rail to Rail Output
High Speed
5.0 10.0 15.0
10 MHz
RHF43
0
Stability Gain : 1
Noise : 1.5nV/√Hz
Supply : 5 Volt
Output Capable : 100Ω
Stability Gain : 1
Noise : 7.5nV/√Hz
Supply : 5 Volt
Output Capable : 1KΩ
Stability Gain : 5
Noise : 8nV/√Hz
Supply : 18 Volt
Output Capabilty : 1KΩ - 100pF
Stability Gain : 2
Noise : 1.3nV/√Hz
Supply : 5 Volt
Output Capable : 100Ω
QML-V
Qualified
RHF484
QML-V
Qualified
QML-V
Qualified
7 Thibault Brunet – Aerospace & High Reliability Products 10/19/2012
EM : Now
Flight : Now
8
Tools for evaluation - Opamp
Order Now :
EVAL-RHF43BV1
EVAL-RHF310V1
EVAL-RHR330V1
EVAL-RHF350V1
Thibault Brunet – Aerospace & High Reliability Products 10/19/2012 8
Now
9
RHF1201 Pipeline ADC 12-bit - 50 Msps - 300 krad
Key Features :
Wide sampling Range : 0.5 to 50Msps
Input range : 2 Vpp differential
2.5V / 3.3V Compatible Digital I/O
Differential Non Linearity : +/-0.5 LSB
Low Consumption :
44mW @ 0.5Msps - 100mW @ 50Msps
75dB SFDR @ Fs = 50Msps
Internal / External V-ref
Rad Hard : 300 krad (Si) TID
SEFI & SEL Immune @ 125°C for LET ≤110 MeV.cm2/mg
SEU : Saturated Cross Section : 3.10-4 cm2 @ 55.9 MeV.cm2/mg
SET : Saturated Cross Section : 3.5.10-5 cm2 @ 55.9 MeV.cm2/mg
QML-V : SMD 5962-05217 SFDR : Spurious Free Dynamic Range
Thibault Brunet – Aerospace & High Reliability Products 10/19/2012
Demo
Board Now
SO-48
10
RHF1401 Pipeline ADC 14-bit - 30 Msps - 300 krad
Key Features :
Wide sampling range : 1.5 to 20Msps
Input Range : 2 Vpp Differential
2.5V / 3.3V Compatible Digital I/O
Tri-state output available
Differential Non Linearity : +/-0.3 LSB
Sample & Hold :
Effective Bandwidth 130 MHz
Low Consumption : 85mW @ 20Msps
90dB SFDR @ Fs = 20Msps, Fin = 5MHz
Internal / External V-ref
Rad-Hard: 300 krad (Si) TID
SEFI & SEL Free up to 120 MeV.cm2/mg @ 2.7V & 125°C
No ELDRS Effects
QML-V : SMD 5962-06260
Thibault Brunet – Aerospace & High Reliability Products 10/19/2012
Demo
Board Now
SO-48
Tools for evaluation - ADC
VREFP
14-bit +DR
Clock
SMA
AVCC
50W
DIP
connections
DVCC VCCBE
GND
VREFM
INCM 50W
50W
Diff. Input
SMA
Vin
Vinb
VCCBI
11 Thibault Brunet – Aerospace & High Reliability Products 10/19/2012
Order Now :
EVAL-RHF1201V2
EVAL-RHF1401V2
Space Grade Voltage Regulator 300 krad - SEL & SEU Immune
RHFL4913xxy RHFL7913
Vin 3.0 to 12.0 Volt (1) -3.0 to -12 Volt
Iout 3.0 A -3.0 A
Vout 2.5 - 3.3 - 5.0 Volt
Adj : 1.23 to 9.0 Volt Adj : -1.23 to -9.0 Volt
Vdrop 0.4 V @ 0.4 A - 0.75 V @ 2 A
Iq On / Off 20 mA / 1 mA max tbd / 1 mA max
Package Flat16 - SMD5-C - Die Flat16 - SMD5-C SMD # 5962F0253x 5962F02532
Thermal Shutdown
If Tj ≥ 165 to 175 °C
OverCurrent Protection
Adjustable up to 4A
Remote Current Sensing
ELDRS
Free
QML-V
Qualified
In pre-rad Spec after 300krad ELDRS MIL 1019
SEL & SEU free @ 68MeV.cm²/mg LET
Sustains 2x10(14) protons/cm2
Sustains 2x10(14) neutron/cm2)
(1) : Down to 2.5 A with Light load
12 Thibault Brunet – Aerospace & High Reliability Products 10/19/2012
ST1843 – ST1845 : Key Features Pre Irradiation : Standard Specification
Ii op : 17 mA max – Istart up : 0.5 mA max
Total Dose : 50 / 100 krad (UC2843 / UC2845)
Test @ 30 rad/hour – Biased and Unbiased
Specified Drifts for Levels & Consumption (ESCC Spec)
Vref : Very good Post Irradiation Accuracy
SEL Free @ 120 MeV.cm2/mg@ 125°C
SET @ 60 MeV.cm2/mg
Threshold : 1.5 MeV.cm2/mg – Cross Section : 1.10-2 cm2
« According To » ESCC : Now
13 Thibault Brunet – Aerospace & High Reliability Products 10/19/2012
Ceramic Flat-8
New
EM : Now
Flight : Now
Developments & Roadmap
14 Thibault Brunet – Aerospace & High Reliability Products 10/19/2012
Very High Speed Comparator RHF801 Target Spec
Key Features :
Response time : 4ns
100mV step + 50mV overdrive
Rise Time : 1.3 ns on 10 pF
Fall Time : 1.6 ns on 10 pF
Low consumption : 2.0 mA
Input Offset Voltage : 200µV
Equivalent Input Frequency : 120 MHz
Specified on Capacitive Load
Macro Models : 4Q12
BiCMOS 0.25µm (HF7CMOS, Crolles)
Rad-Hard Targets
300 krad (Si) – ELDRS Free
SEL : Immune at 110 MeV.cm²/mg
SET : Report Available
+2.5V to 5.5V
ref
+
-
1kW
in
out
Capacitive load
10pF
15 Thibault Brunet – Aerospace & High Reliability Products 10/19/2012
EM 2 : Oct12
Flight : 2Q13
Flat-8S
Integrated Current Limiter Schematics
3rd June, 2010
Integrated Current Limiter Block Diagram
16 Thibault Brunet – Aerospace & High Reliability Products 10/19/2012
Integrated Current Limiter Key Features
3rd June, 2010
PROCESS: BCD6s – option 100V
Wide Supply Voltage range : 7.5 V to 52V DC
Very Low DC consumption : Total SSP system < 3mA
Inhibit Pin
High External Configurability
Current Limit : 50 mA min
Trip-Off & Linear
TON time & TOFF (Trip-Off Mode) Around 1 to 100 ms
3 modes Latched – ReTriggerable - Foldback
Under Voltage detection & Hysteresis
2 pins for Telemetry : analog current - digital & protection status
Short Circuit Protection
Floating Ground Compatibility
17 Thibault Brunet – Aerospace & High Reliability Products 10/19/2012
Flat-20
DemoBoard Now
Flight : 3Q13
18
DSM Status
Technology and rad-hard Library provided by ST
Partnership with Atmel for
Sales & Marketing
Design
Layout
Assembly
Logistic
Program details : see CNES presentation
Thibault Brunet – Aerospace & High Reliability Products 10/19/2012
