ML100E17TECHNICAL DESCRIPTION
( EURO 3 - NEW )
The information in this literature is intended to be of a general nature only. Iveco reserve the right to modify or change specification at any time.
1
ML100E17
Gearbox 2855.6
Drive VcbCabWheelbase
LEFT HAND DRIVE DKPAC1D1MLC2700
LEFT HAND DRIVE DKPAC2D1MLC3105
RIGHT HAND DRIVE DKPAC2DAMLC
LEFT HAND DRIVE DKPAC3D1MLC3330
RIGHT HAND DRIVE DKPAC3DAMLC
LEFT HAND DRIVE DKPAC4D1MLC3690
RIGHT HAND DRIVE DKPAC4DAMLC
LEFT HAND DRIVE DKPAC4D2MLL
RIGHT HAND DRIVE DKPAC4DBMLL
LEFT HAND DRIVE DKPAC5D1MLC4185
RIGHT HAND DRIVE DKPAC5DAMLC
LEFT HAND DRIVE DKPAC5D2MLL
RIGHT HAND DRIVE DKPAC5DBMLL
LEFT HAND DRIVE DKPAC6D1MLC4455
RIGHT HAND DRIVE DKPAC6DAMLC
LEFT HAND DRIVE DKPAC6D2MLL
RIGHT HAND DRIVE DKPAC6DBMLL
LEFT HAND DRIVE DKPAC7D1MLC4815
RIGHT HAND DRIVE DKPAC7DAMLC
LEFT HAND DRIVE DKPAC7D2MLL
RIGHT HAND DRIVE DKPAC7DBMLL
Gearbox 2870.9
Drive VcbCabWheelbase
LEFT HAND DRIVE DKPAC1G1MLC2700
LEFT HAND DRIVE DKPAC2G1MLC3105
RIGHT HAND DRIVE DKPAC2GAMLC
LEFT HAND DRIVE DKPAC3G1MLC3330
RIGHT HAND DRIVE DKPAC3GAMLC
LEFT HAND DRIVE DKPAC4G1MLC3690
RIGHT HAND DRIVE DKPAC4GAMLC
LEFT HAND DRIVE DKPAC4G2MLL
RIGHT HAND DRIVE DKPAC4GBMLL
LEFT HAND DRIVE DKPAC5G1MLC4185
RIGHT HAND DRIVE DKPAC5GAMLC
LEFT HAND DRIVE DKPAC5G2MLL
RIGHT HAND DRIVE DKPAC5GBMLL
LEFT HAND DRIVE DKPAC6G1MLC4455
RIGHT HAND DRIVE DKPAC6GAMLC
LEFT HAND DRIVE DKPAC6G2MLL
RIGHT HAND DRIVE DKPAC6GBMLL
2 16/04/2003
ML100E17
LEFT HAND DRIVE DKPAC7G1MLC4815
RIGHT HAND DRIVE DKPAC7GAMLC
LEFT HAND DRIVE DKPAC7G2MLL
RIGHT HAND DRIVE DKPAC7GBMLL
3 16/04/2003
ML100E17
DIMENSIONS (mm) (AB 0856-I MLC)
3330 4185369031052700A Wheelbase
6522 7692688257805375B Total length
1262 1262126212621262C Front overhang
1830 2145183013131313D Rear overhang
2286 2286228622862286E Max width
355 355355355355F Front axle to back of cab
475 475475475475H Front of body to front axle distance
2578 2577257825782580K Overall height to top of cab, unladen
926 920918914921L Height of frame at frame end, unladen
1835 1835183518351835M Front track
1680 1680168016801680N Rear track
172 172172172172P Minimum ground clearance ( Axle2 )
2165 2165216521652165Overall width (rear tyres)
14° 14°14°14°14°Approach angle
4805 5975516540633658Back of cab to end of frame
6500 7800705062005550Steering radius wall to wall
5900 7200645055504950Steering radius kerb to kerb
760 760760760762Frame height at front axle, unladen
867 866866868869Frame height at rear axle, unladen
787570756005Max truck length
48154455A Wheelbase
86208097B Total length
12621262C Front overhang
25052280D Rear overhang
22862286E Max width
355355F Front axle to back of cab
4 16/04/2003
ML100E17
DIMENSIONS (mm) (AB 0856-I MLC)
475475H Front of body to front axle distance
25772577K Overall height to top of cab, unladen
914917L Height of frame at frame end, unladen
18351835M Front track
16801680N Rear track
172172P Minimum ground clearance ( Axle2 )
21652165Overall width (rear tyres)
14°14°Approach angle
69656380Back of cab to end of frame
87508250Steering radius wall to wall
81507600Steering radius kerb to kerb
760760Frame height at front axle, unladen
862864Frame height at rear axle, unladen
88758275Max truck length
5 16/04/2003
ML100E17
DIMENSIONS (mm) (AB 0859-I MLL)
4455 481541853690A Wheelbase
8097 868276926882B Total length
1262 126212621262C Front overhang
2280 250521451830D Rear overhang
2286 228622862286E Max width
935 935935935F Front axle to back of cab
1055 105510551055H Front of body to front axle distance
2571 257125712572K Overall height to top of cab, unladen
918 917920920L Height of frame at frame end, unladen
1835 183518351835M Front track
1680 168016801680N Rear track
172 172172172P Minimum ground clearance ( Axle2 )
2165 216521652165Overall width (rear tyres)
14° 14°14°14°Approach angle
5800 638553954585Back of cab to end of frame
8250 875078007050Steering radius wall to wall
7600 815072006450Steering radius kerb to kerb
754 754754755Frame height at front axle, unladen
863 861864865Frame height at rear axle, unladen
6 16/04/2003
ML100E17
Weights (kg) (BB 0897-I MLC)
3330 4185369031052700Wheelbase
10000 10000100001000010000GVW - Design
13500 13500135001350013500GCW - Design
3600 3600360036003600Plated weight on axle 1 - Design
6800 6800680068006800Plated weight on axle 2 - Design
6675 6605665567006745Body payload - Design
3500 3500350035003500Trailer total weight (inertia brake)
3325 3395334533003255Vehicle kerbweight
2390 2400238523852355Vehicle kerbweight 1
935 995960915900Vehicle kerbweight 2
404539253800Truck kerbweight
249524652460Truck kerbweight on axle 1
155014601340Truck kerbweight on axle 2
48154455Wheelbase
1000010000GVW - Design
1350013500GCW - Design
36003600Plated weight on axle 1 - Design
68006800Plated weight on axle 2 - Design
65506595Body payload - Design
35003500Trailer total weight (inertia brake)
34503405Vehicle kerbweight
23902390Vehicle kerbweight 1
10601015Vehicle kerbweight 2
41804085Truck kerbweight
25002495Truck kerbweight on axle 1
16801590Truck kerbweight on axle 2
Weights (kg) (BB 0900-I MLL)
4455 481541853690Wheelbase
10000 100001000010000GVW - Design
13500 135001350013500GCW - Design
3600 360036003600Plated weight on axle 1 - Design
6800 680068006800Plated weight on axle 2 - Design
6465 642064756525Body payload - Design
3500 350035003500Trailer total weight (inertia brake)
3535 358035253475Vehicle kerbweight
2500 250525102495Vehicle kerbweight 1
1035 10751015980Vehicle kerbweight 2
7 16/04/2003
ML100E17
Engine F4AE0481A*C ( EB 0022-I)
TECTORName
FRONTPosition
DIESELCycle
TC+AFTERCOOLERAspiration type
DIRECTInjection type
IN-LINE4No. of cylinders
DIESEL Fuel type
44 Stroke / 2 Stroke cycle
3900Total displacement cm³
/ 120102Bore / Stroke mm
2700 rpm170 HP125 kWMax power (1)
200 g/kWhSpecific fuel consumption-max power
1200560 Nm57 kgmMax torque (2)
220 g/kWhSpecific fuel consumption-max torque
100 m 1000 m sea levelaboveevery0.2%Power loss
390Dry weight kg
5.3Oil capacity kg
5 BearingsCrankshaft supported by
HIGH PRESSURE / COMMON RAILInjection pump type
ELECTRONIC (AT ALL SPEED BY ECU)Injection pump governor type
WATERCooling system
Hydraulic steering pump
TERMOSTARTER+CHOKE+GRID HEATERCold starting type
EURO3Emissions according regulations
8 16/04/2003
ML100E17
Fuelling (ABB 0022-I)
1No. of tanks
115Total tank capacity l.
RIGHT SIDEPosition on frame
Fuel pump
Prefilter
Filter
Fuel separator
Air intake (AC 0011-I)
DRYFilter type
REAR PART OF THE CAB ON THE LEFTAir filter position
BEHIND THE CAB ON THE LEFTSnorkel position
REAR CHASSISExhaust pipe position
WITH SNORKELAir intake
Cooling (AD 0001-I)
WATERCooling system
VISCOSTATICFan type
Clutch 13'' (FT 0002-I)
SINGLE PLATE DIAPHRAGMType
HYDRAULICRelease control
AUTOMATICAdjustment
GearboxIVECO - 2855.6 (GT 0003-I)
SYNCRONIZEDType
ENGINE FLANGEDInstallation
MANUAL HControl
6+1No. of gears (….+…..reverse)
ALUMINIUMCasing material
97Dry weight kg
8.13Gearbox spacing
Possible P.T.O. installation
Gear ratios
6.341st
3.642nd
2.313rd
1.484th
1.005th
0.786th
5.46Rev. 1st
9 16/04/2003
ML100E17
GearboxIVECO - 2870.9 (GT 0005-I)
SYNCRONIZEDType
ENGINE FLANGEDInstallation
MANUAL HControl
9+1No. of gears (….+…..reverse)
ALUMINIUMCasing material
138Dry weight kg
13.20Gearbox spacing
Possible P.T.O. installation
2Power take off
Gear ratios
13.201st
9.042nd
6.473rd
4.694th
3.555th
2.556th
1.827th
1.328th
1.009th
11.98Rev. 1st
Front steering axle (LB 0015-I )
5833Identification
RIGIDType
STEELAxle material
"I"Beam section
Rear drive axle (MB 0022-I )
450721Identification
RIGIDType
SINGLEAxle
TWINWheel arrangement
SINGLEReduction type
Suspensions (NB 0034-I)
SINGLE ACTING PARABOLIC SPRINGFront steering axle
DOUBLE ACTING PARABOLICRear drive axle
10 16/04/2003
ML100E17
Main features
21Axle no.
7070Leaf width (mm)
1630 Auxiliary leaf spring length (mm)
16701714Master leaf spring length (mm)
1 No. of auxiliary leaf springs
11No. of master leaf springs
Shock absorbers (PT 0001-I)
2Shock absorbers no. (front)
2Shock absorbers no. (rear)
HYDRAULIC TELESCOPICShock absorbers type
Anti-roll bars (OT 0001-I)
FRONT AND REAR AXLEPosition
Wheels (QT 0001-I)
DISCWheel type
17.5" x 6.00"Rim dimensions
Tyres (RB 0013-I)
225/75 R 17.5Tyre dimensions
128/126Load-index
M = 130 Km/hSpeed index
380Rolling radius mm
MountingAxle
SINGLE1
TWIN2
Steering (KT 0001-I)
HYDRAULICType
COLUMN ANGLEAdjustment type
1Degrees of freedom
465Steering wheel diameter (mm)
2No. of parts steering column
Chassis (mm) (JB 100M-I)
PARALLELFrame section
BOLTEDFront crossmember fixing
RIVETEDMiddle crossmember fixing
333031052700Wheelbase
STEELSTEELSTEELSide member material
11 16/04/2003
ML100E17
Chassis (mm) (JB 100M-I)
"C""C""C"Side member section
444Flange thickness
444Web thickness
656565Upper flange width
656565Lower flange width
203203203Side member max. height
848848848Frame width at front
848848848Frame width at rear
445541853690Wheelbase
STEELSTEELSTEELSide member material
"C""C""C"Side member section
554Flange thickness
554Web thickness
656565Upper flange width
656565Lower flange width
203203203Side member max. height
850850848Frame width at front
850850848Frame width at rear
4815Wheelbase
STEELSide member material
"C"Side member section
5Flange thickness
5Web thickness
65Upper flange width
65Lower flange width
203Side member max. height
850Frame width at front
850Frame width at rear
12 16/04/2003
ML100E17
Brakes (SB 0030-I)
Front braking control
Rear braking control
Air dryer
ABSAntiskid system
ON THE EXHAUST PIPE WITH THROTTLE VALVEAuxiliary brake
SERVICE BRAKEEmergency brake
MECHANICAL WITH SPRING CYLINDERParking brake
AIR/HYDRAULICService brake
AXLE 2Parking brake axles
30Total tank capacity l.
225Air compressor displacement cm³
ONE CYLINDREAir compressor
EECBrake standards
EECSemicoupling standards
2No. of circuits
2Number of air tanks
Axle 2Axle 1Axle no.
DISCDISCBrake type
22No. of cylinders
6868Cylinder diameter
322322Disk diameter (mm)
436436Friction area cm²
Electrics (VB 0017-I)
24Voltage V
28/70Alternator power V/A
2No. of batteries
12Battery voltage V
110Battery capacity Ah
4Starter motor power kW
(*) 88 Ah for 2700 and 3105 wheelbases only
Lighting (WB 0029-I)
2No. of headlights
HIGH BEAM AND ANTI-DAZZLE LIGHTS INTEGRATED INTO PARKING LAMPSType of lamps
Front parking lights
Tail lights
Front side marker lights
13 16/04/2003
ML100E17
Lighting (WB 0029-I)
Rear fog lights
Backup lights
Hazard lights
Number plate lights
Rear fog lights
Side lights
Stop lights
Front direction indicators
Side direction indicators
Rear direction indicators
Provision for front fog lights
Additional lights prearrangement
Cab MLC (YB 0044-I)
FORWARD CONTROLCab type
SHORT CABVersion
STEEL PLATEMaterial
1620Internal height in front of the seat (mm)
HYDRAULICTilting device
60°Tilt angle
SIDE HUNG, INTERNALLY COVERED WITH FABRICFront doors type
1424Front doors height (mm)
954Front doors width (mm)
90°Front door(s) opening angle
MANUAL ON RIGHT - MANUAL ON LEFTWind-up-window type (front)
Side spoiler
2Sun visors no.
SYNTHETIC, WASHABLERoof material
Roof light
STRENGTHENED - LAMINATEDWindscreen type
ONE PIECE WOUND UPWindscreen
EECWindscreen post type
2No. of windscreen wipers
2No. of windscreen wiper speeds
2 HELICAL SPRINGS AND SHOCK ABSORBERSFront suspension points
2 HELICAL SPRINGS AND SHOCK ABSORBERSRear suspension points
4Rear view mirrors no.
MANUALMirror control
Kerbside approach mirror
3No. of places
2No. of seats
14 16/04/2003
ML100E17
Cab MLC (YB 0044-I)
3 DEGREES OF FREEDOMDriver seat type
IN HEIGHT, LENGTH AND BACK INCLINATIONDriver seat adjustment
TWO SEATS BENCH WITH DOUBLE BACKPassenger seat(s) type
Passenger seat adjustment
4Fan speed no.
MANUALHeating control
Provision for safety belts
Lighter
CB wiring
Radio wiring
Remarks:
Real wall without windows, doors with fabric carpeting, storage compartments white bottle holder, defroster system for door windows, arm rests. Corrosion protection, underseal and cavety sealing with wax.
Roof panel:Prearrangement for revolving roof lamp.
Floor:Covered with rubber mats, sound proof, engine brake control.
Interior equipment:Storage compartments, shelfs upon overheads console, shelfs on floor level below seats, ceiling lamps, spotlamps, loudspeakers.
Central console:Storage compartments, central panel, adjustable air bleeds, ash-tray, lighter, heating control.
Exterior equipment:Front bumper with steps, mudguard, front grille, pre-arrangement for front towing hook (to be screwed), lateral spoilers as splash protection, mudflaps, external engine starter (when cab is tilted) including safety device.
Cab MLL (YB 5044-I)
FORWARD CONTROLCab type
SLEEPER CABVersion
STEEL PLATEMaterial
2Steps no.
1620Internal width (mm)
HYDRAULICTilting device
60°Tilt angle
MANUALRoof hatch control system
SIDE HUNG, INTERNALLY COVERED WITH FABRICFront doors type
954Front doors height (mm)
1424Front doors width (mm)
90°Front door(s) opening angle
MANUAL ON RIGHT - MANUAL ON LEFTWind-up-window type (front)
15 16/04/2003
ML100E17
Cab MLL (YB 5044-I)
Side spoiler
SYNTHETIC, WASHABLERoof material
Roof light
STRENGTHENED - LAMINATEDWindscreen type
ONE PIECE WOUND UPWindscreen
EECWindscreen post type
2No. of windscreen wipers
2No. of windscreen wiper speeds
2 HELICAL SPRINGS AND SHOCK ABSORBERSFront suspension points
2 HELICAL SPRINGS AND SHOCK ABSORBERSRear suspension points
4Rear view mirrors no.
MANUALMirror control
Kerbside approach mirror
2No. of places
2No. of seats
3 DEGREES OF FREEDOMDriver seat type
IN HEIGHT, LENGTH AND BACK INCLINATIONDriver seat adjustment
4Fan speed no.
MANUALHeating control
1No. of bunks
BOTTOM, FIXEDBunk position
Provision for safety belts
Lighter
CB wiring
Radio wiring
16 16/04/2003
ML100E17
Cab MLL (YB 5044-I)
Remarks:
Rear wall w/o window, doors with fabric carpeting, storage compartments with bottle holder, defroster system for door windows, arm rests; Corrosion protection, underseal and cavety sealing with wax.
Passenger's seat:Fixed, 2 way adjustable (longitudinal +adjustable back)
Roof panel:Prearrangement for revolving roof lamp.
Floor:Covered with rubber mats, sound prouf, engine brake control.
Interior equipment:Storage compartments, shelfs upon overheads console, shelfs on floor level below seats, ceiling lamps, 2 spotlamps, loud-speakers.
Central console:Storage compartments, central panel, adjustable air bleeds, ash-trays, lighter, heating control.
Exterior equipment:External storage box (on side wall) opened from inside, front bumper with steps, mudguard, front grille, pre-arrangement for front towing hook (to be screwed), lateral spoilers as splash protection, mudflaps, external engine starter (when cab is tilted) including safety device.
In cab equipment (TB 0089-I)
17 16/04/2003
ML100E17
In cab equipment (TB 0089-I)
Indicator lamps, on cluster: External lights - High beam headlight - General warning light (STOP) - General alarm - Rear fog light - Direction indicator (left) - Engine brake - Brake failure - Hazard lights - Parking brake - Cluster failure - Direction indicator (right) - Tachograph failure - Engine preheating - ABS failure - Low gear range (9 gears gearbox only) - Speed limiter (programmable).
Indicator lamps, on cluster. Prearrangement: Side PTO - Rear PTO - Longitudinal differential lock - Rear differential lock - Mirrors heating - Fog lights.
Controls on instrument panel:External lights - Headlights adjustment - Rear fog lamp - Hazard lights - Roof light - Speed limiter (programmable) - Engine brake. Controls on instrument panel. Prearrangements:Fog lights - Mirrors heating - Rotating roof lights - Heated windscreen - PTO - Power windows adjustment: full electrical - display menu on - display menu off - Display set on - display set off - contact breaker - Cab internal light: set / display - Cab internal light (MLL-Medium Roof only) - Electrically-powered roof hatch - Tail lift. On central tunnel: electrical / heated mirrors control.
Instruments:Fuel level with reserve indicator and warning light - Water temperature with warning light - Tachometer with trip mileage counter - Rpm counter with coloured sectors - Display - Tachograph 2 drivers - Light dimmer switch - Possibility of connection for external diagnosis (with socket in cab).
Multifunction stalks :Horn - Low beam / high beam - Headlight flasher - Direction indicators - Windscreen wipers with 2 washer jets - Windscreen wipers with interval - Headlight wipers.
Highline version display (option):Display levels of various minimum / maximum fluid levels - extensive diagnostics - functional check of lights - maintenance plan - travel details
Tools kit.
Miscellaneous (XB 0064-I)
EEC NORMSRear underride protection
Jack
Front towing hitch
Tools kit
Final exhaust pipe on the centre (between the side members) Front underrun protection (EC norms)
Drawings (DB 0529-I)
333031052700Wheelbase
504075588504075587504075586Left hand drive vehicle drawing
504075588504075587504075586Right hand drive vehicle drawing
445541853690Wheelbase
504075591504075590504075589Left hand drive vehicle drawing
504075591504075590504075589Right hand drive vehicle drawing
Sleeper cab frame drawing
18 16/04/2003
ML100E17
Drawings (DB 0529-I)
4815Wheelbase
504075592Left hand drive vehicle drawing
504075592Right hand drive vehicle drawing
19 16/04/2003
ML100E17
2855.6225/75 R 17.5
GearboxTyres
Max. gradient %
GVW GCWRear axle ratio Gearbox ratio Max. speed Km/h
10 13.5
3.21
1 - 6.346 - 0.78
19 154.4
25,01,5
18,00,9
3.73
1 - 6.346 - 0.78
16.3 132.9
30,02,2
21,01,4
4.10
1 - 6.346 - 0.78
14.9 120.9
34,02,7
24,01,7
4.56
1 - 6.346 - 0.78
13.4 108.7
38,03,2
27,02,1
4.88
1 - 6.346 - 0.78
12.5 101.6
41,03,6
29,02,4
5.57
1 - 6.346 - 0.78
10.9 89
49,04,4
34,03,0
2855.69.5 R 17.5
GearboxTyres
Max. gradient %
GVW GCWRear axle ratio Gearbox ratio Max. speed Km/h
10 13.5
3.21
1 - 6.346 - 0.78
20.4 166.2
23,01,3
17,00,7
3.73
1 - 6.346 - 0.78
17.6 143
28,02,0
20,01,2
4.10
1 - 6.346 - 0.78
16 130.1
31,02,4
22,01,5
4.56
1 - 6.346 - 0.78
14.4 117
35,02,9
25,01,9
4.88
1 - 6.346 - 0.78
13.4 109.3
38,03,2
27,02,2
5.57
1 - 6.346 - 0.78
11.8 95.8
44,04,0
31,02,7
20 16/04/2003
ML100E17
2870.9225/75 R 17.5
GearboxTyres
Max. gradient %
GVW GCWRear axle ratio Gearbox ratio Max. speed Km/h
10 13.5
3.21
1 - 13.209 - 1
9.1 120.4
62,02,7
42,01,8
3.38
1 - 13.209 - 1
8.7 114.4
67,03,0
45,01,9
3.73
1 - 13.209 - 1
7.9 103.6
78,03,5
51,02,3
4.10
1 - 13.209 - 1
7.1 94.3
93,04,0
58,02,7
4.56
1 - 13.209 - 1
6.4 84.8
100,04,7
67,03,2
4.88
1 - 13.209 - 1
6 79.2
100,05,1
75,03,5
2870.99.5 R 17.5
GearboxTyres
Max. gradient %
GVW GCWRear axle ratio Gearbox ratio Max. speed Km/h
10 13.5
3.21
1 - 13.209 - 1
9.8 129.6
56,02,4
38,01,5
3.38
1 - 13.209 - 1
9.3 123.1
60,02,7
41,01,7
3.73
1 - 13.209 - 1
8.5 111.6
70,03,1
46,02,1
4.10
1 - 13.209 - 1
7.7 101.5
81,03,6
52,02,5
4.56
1 - 13.209 - 1
6.9 91.3
99,04,2
60,02,9
4.88
1 - 13.209 - 1
6.5 85.3
100,04,7
67,03,2
21 16/04/2003