35
TICS PUMP ELECTRICAL PART RESISTANCE VALUE LIST FOR HINO
TICS PUMP ELECTRICAL PART RESISTANCE VALUE LIST
FOR HINO
1. OBJECT Pre-stroke actuators and governor actuators on TICS pumps produced after April 1995.REDIII governor part no.: 10595 * - * * * * - applicableREDIV governor part no.: 10596 * - * * * * - not applicable
2. NOTES (1) The resistance values mentioned are the specifi ed values from the drawings (without wire harness resistance).The values listed were measured at an ambient temperature of 25°C.
When measuring the actual values, the measured values may differ from those listed due to the infl uence of the ambient temperature at the time of the measurement, the temperature of the object being measured, differences in the measuring instruments, differences in the measuring methods used, or whether or not wire harnesses are attached.Small differences between actual values and specifi ed values are most probably due to the reasons mentioned above. Those measured resistances alone cannot be used to conclude that there is a fault.
Use together with service manual below (refer to inspection item).
Governor actuator Pub. No. EE13E-11152 GOVERNOR MODEL REDIII
Pre-stroke actuatorPub. No. EE11E-11220 FUEL INJECTION PUMP MODEL TC(S).MD
Pub. No. EE11E-11230 FUEL INJECTION PUMP MODEL TC(S).HD
(2) When measuring insulation resistance, always use the insulation resistance tester.
(3) The pump assembly numbers mentioned are the main assembly numbers. If you cannot fi nd the pump assembly number your are looking for in the TICS pump part number list, search for the actuator part numbers on the governor actuator pages or the pre-stroke actuator pages.
3. OTHERS (1) Wire harness colors
R Red B Black BW Black/whiteW White L Blue BR Black/redY Yellow O Orange BY Black/yellowG Green Br Brown
(2) 'hous.' in the insulation resistance column refers to the housing.
(3) In this list, the resistance in the insulation resistance column described as 'Above 10MΩ' actually means 'not less than 10MΩ'.
(4) Contact Bosch Corporation, JA/MKT1 if there are any mistakes or omissions.
TICS PUMP PART NO. LIST
- 1 -
Pump assemblynumber Company Engine
modelVoltage
(V)Governor actuator Pre-stroke actuator
Part number Ref. no Part number Ref. no
• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
107491-3020 HINO W04C-TM 12 Mechanical 159600-0620 B-1
107491-3021 HINO W04C-TM 12 Mechanical 159600-0620 B-1
107491-3030 HINO W04C-TM 12 Mechanical 159600-0620 B-1
107491-3031 HINO W04C-TM 12 Mechanical 159600-0620 B-1
107491-3040 HINO W04C-TM 12 Mechanical 159600-1120 B-1
107491-3041 HINO W04C-TM 12 Mechanical 159600-1120 B-1
107491-3042 HINO W04C-TM 12 Mechanical 159600-1120 B-1
107491-3043 HINO W04C-TM 12 Mechanical 159600-1120 B-1
107491-3050 HINO W04C-TM 12 Mechanical 159600-1120 B-1
107491-3051 HINO W04C-TM 12 Mechanical 159600-1120 B-1
107491-3052 HINO W04C-TM 12 Mechanical 159600-1120 B-1
107491-3053 HINO W04C-TM 12 Mechanical 159600-1120 B-1
107491-3060 HINO J05C-TB 12 Mechanical 159600-7221 B-2
107491-3061 HINO J05C-TB 12 Mechanical 159600-7221 B-2
107491-3062 HINO J05C-TB 12 Mechanical 159600-7221 B-2
107491-3063 HINO J05C-TB 12 Mechanical 159600-7221 B-2
107491-3064 HINO J05C-TB 12 Mechanical 159600-7221 B-2
107491-3065 HINO J05C-TB 12 Mechanical 159600-7222 B-2
107491-3070 HINO J05C-TB 12 Mechanical 159600-7221 B-2
107491-3071 HINO J05C-TB 12 Mechanical 159600-7221 B-2
107491-3072 HINO J05C-TB 12 Mechanical 159600-7221 B-2
107491-3073 HINO J05C-TB 12 Mechanical 159600-7221 B-2
107491-3074 HINO J05C-TB 12 Mechanical 159600-7221 B-2
107491-3075 HINO J05C-TB 12 Mechanical 159600-7222 B-2
107491-3080 HINO J05C-TD 12 Mechanical 159600-7221 B-2
107491-3081 HINO J05C-TD 12 Mechanical 159600-7221 B-2
107491-3082 HINO J05C-TD 12 Mechanical 159600-7221 B-2
107491-3083 HINO J05C-TD 12 Mechanical 159600-7221 B-2
107491-3084 HINO J05C-TD 12 Mechanical 159600-7222 B-2
107491-3090 HINO J05C-TD 12 Mechanical 159600-7221 B-2
107491-3091 HINO J05C-TD 12 Mechanical 159600-7221 B-2
107491-3092 HINO J05C-TD 12 Mechanical 159600-7221 B-2
107491-3093 HINO J07C-TD 12 Mechanical 159600-7221 B-2
107491-3094 HINO J05C-TD 12 Mechanical 159600-7222 B-2
107491-3110 HINO J05C-TI 24 Mechanical 159601-3820 B-4
107491-3111 HINO J05C-TI 24 Mechanical 159601-3821 B-4
107491-3130 HINO J05C-TI 12 Mechanical 159601-4420 B-2
107491-3131 HINO J05C-TI 12 Mechanical 159601-4421 B-2
107491-3132 HINO J05C-TD 12 Mechanical 159601-4421 B-2
107491-3140 HINO J05C-TI 12 Mechanical 159601-4420 B-2
TICS PUMP PART NO. LIST
- 2 -
Pump assemblynumber Company Engine
modelVoltage
(V)Governor actuator Pre-stroke actuator
Part number Ref. no Part number Ref. no
• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
107491-3141 HINO J05C-TI 12 Mechanical 159601-4421 B-2
107491-3142 HINO J05C-TD 12 Mechanical 159601-4421 B-2
107491-3150 HINO J05C-TI 24 Mechanical 159601-3820 B-4
107491-3151 HINO J05C-TI 24 Mechanical 159601-3820 B-4
107491-3152 HINO J05C-TI 24 Mechanical 159601-3821 B-4
107491-3160 HINO J05C-TD 24 Mechanical 159601-3821 B-4
107491-3161 HINO J05C-TD 24 Mechanical 159601-7420 B-4
107491-3162 HINO J05C-TD 24 Mechanical 159601-7421 B-4
107491-3170 HINO J05C-TF 24 Mechanical 159601-7421 B-4
107491-3180 HINO J05C-TF 24 Mechanical 159645-4120 B-3
107491-3181 HINO J05C-TF 24 Mechanical 159645-4120 B-3
107491-3182 HINO J05C-TF 24 Mechanical 159645-4620 B-3
107491-3190 HINO J05C-TJ 24 Mechanical 159645-4120 B-3
107491-3191 HINO J05C-TJ 24 Mechanical 159645-4120 B-3
107491-3192 HINO J05C-TJ 24 Mechanical 159645-4620 B-3
107491-3200 HINO J05C-TF 24 Mechanical 159645-4120 B-3
107491-3201 HINO J05C-TF 24 Mechanical 159645-4620 B-3
107492-3000 HINO W04C-TT 24 105952-0970 A-1 159590-8720 B-3
107691-3060 HINO H06C-TT 12 Mechanical 159600-1220 B-2
107691-3061 HINO H06C-TT 12 Mechanical 159600-1220 B-2
107691-3062 HINO H06C-TT 12 Mechanical 159600-1220 B-2
107691-3063 HINO H06C-TT 12 Mechanical 159600-1220 B-2
107691-3064 HINO H06C-TT 12 Mechanical 159600-1220 B-2
107691-3065 HINO H06C-TT 12 Mechanical 159600-1220 B-2
107691-3070 HINO H06C-TT 12 Mechanical 159600-1220 B-2
107691-3071 HINO H06C-TT 12 Mechanical 159600-1220 B-2
107691-3072 HINO H06C-TT 12 Mechanical 159600-1220 B-2
107691-3073 HINO H06C-TT 12 Mechanical 159600-1220 B-2
107691-3074 HINO H06C-TT 12 Mechanical 159600-1220 B-2
107691-3075 HINO H06C-TT 12 Mechanical 159600-1220 B-2
107691-3080 HINO H06C-TU 12 Mechanical 159600-1220 B-2
107691-3081 HINO H06C-TU 12 Mechanical 159600-1220 B-2
107691-3082 HINO H06C-TU 12 Mechanical 159600-1220 B-2
107691-3083 HINO H06C-TU 12 Mechanical 159600-1220 B-2
107691-3084 HINO H06C-TU 12 Mechanical 159600-1220 B-2
107691-3085 HINO H06C-TU 12 Mechanical 159600-1220 B-2
107691-3090 HINO H06C-TU 12 Mechanical 159600-1220 B-2
107691-3091 HINO H06C-TU 12 Mechanical 159600-1220 B-2
107691-3092 HINO H06C-TU 12 Mechanical 159600-1220 B-2
107691-3093 HINO H06C-TU 12 Mechanical 159600-1220 B-2
TICS PUMP PART NO. LIST
- 3 -
Pump assemblynumber Company Engine
modelVoltage
(V)Governor actuator Pre-stroke actuator
Part number Ref. no Part number Ref. no
• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
107691-3094 HINO H06C-TU 12 Mechanical 159600-1220 B-2
107691-3095 HINO H06C-TU 12 Mechanical 159600-1220 B-2
107691-3100 HINO H06C-TV 12 Mechanical 159600-1220 B-2
107691-3101 HINO H06C-TV 12 Mechanical 159600-1220 B-2
107691-3102 HINO H06C-TV 12 Mechanical 159600-1220 B-2
107691-3103 HINO H06C-TV 12 Mechanical 159600-1220 B-2
107691-3104 HINO H06C-TV 12 Mechanical 159600-1220 B-2
107691-3105 HINO H06C-TV 12 Mechanical 159600-1220 B-2
107691-3110 HINO H06C-TV 12 Mechanical 159600-1220 B-2
107691-3111 HINO H06C-TV 12 Mechanical 159600-1220 B-2
107691-3112 HINO H06C-TV 12 Mechanical 159600-1220 B-2
107691-3113 HINO H06C-TV 12 Mechanical 159600-1220 B-2
107691-3114 HINO H06C-TV 12 Mechanical 159600-1220 B-2
107691-3115 HINO H06C-TV 12 Mechanical 159600-1220 B-2
107691-3120 HINO J08C-TE 12 Mechanical 159600-7020 B-2
107691-3121 HINO J08C-TE 12 Mechanical 159600-7021 B-2
107691-3122 HINO J08C-TE 12 Mechanical 159600-7021 B-2
107691-3123 HINO J08C-TE 12 Mechanical 159600-7023 B-2
107691-3124 HINO J08C-TE 12 Mechanical 159600-7024 B-2
107691-3130 HINO J08C-TD 12 Mechanical 159600-7020 B-2
107691-3131 HINO J08C-TD 12 Mechanical 159600-7021 B-2
107691-3132 HINO J08C-TD 12 Mechanical 159600-7023 B-2
107691-3133 HINO J08C-TD 12 Mechanical 159600-7024 B-2
107691-3140 HINO J08C-TE 12 Mechanical 159600-7020 B-2
107691-3141 HINO J08C-TE 12 Mechanical 159600-7021 B-2
107691-3142 HINO J08C-TE 12 Mechanical 159600-7021 B-2
107691-3143 HINO J08C-TE 12 Mechanical 159600-7023 B-2
107691-3144 HINO J08C-TE 12 Mechanical 159600-7024 B-2
107691-3150 HINO J08C-TD 12 Mechanical 159600-7020 B-2
107691-3151 HINO J08C-TD 12 Mechanical 159600-7021 B-2
107691-3152 HINO J08C-TD 12 Mechanical 159600-7023 B-2
107691-3153 HINO J08C-TD 12 Mechanical 159600-7024 B-2
107691-3160 HINO J08C-TD 12 Mechanical 159600-7020 B-2
107691-3161 HINO J08C-TD 12 Mechanical 159600-7021 B-2
107691-3162 HINO J08C-TD 12 Mechanical 159600-7021 B-2
107691-3163 HINO J08C-TD 12 Mechanical 159600-7023 B-2
107691-3164 HINO J08C-TD 12 Mechanical 159600-7024 B-2
107691-3170 HINO J08C-TD 12 Mechanical 159600-7020 B-2
107691-3171 HINO J08C-TD 12 Mechanical 159600-7021 B-2
107691-3172 HINO J08C-TD 12 Mechanical 159600-7021 B-2
TICS PUMP PART NO. LIST
- 4 -
Pump assemblynumber Company Engine
modelVoltage
(V)Governor actuator Pre-stroke actuator
Part number Ref. no Part number Ref. no
• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
107691-3173 HINO J08C-TD 12 Mechanical 159600-7023 B-2
107691-3174 HINO J08C-TD 12 Mechanical 159600-7024 B-2
107691-3180 HINO J08C-TP 12 Mechanical 159600-7022 B-2
107691-3181 HINO J08C-TP 12 Mechanical 159600-7022 B-2
107691-3182 HINO J08C-TP 12 Mechanical 159600-7023 B-2
107691-3183 HINO J08C-TP 12 Mechanical 159600-7023 B-2
107691-3184 HINO J08C-TP 12 Mechanical 159600-7023 B-2
107691-3185 HINO J08C-TP 12 Mechanical 159600-7024 B-2
107691-3186 HINO J08C-TP 12 Mechanical 159600-7024 B-2
107691-3190 HINO J08C-TP 12 Mechanical 159600-7022 B-2
107691-3191 HINO J08C-TP 12 Mechanical 159600-7022 B-2
107691-3192 HINO J08C-TP 12 Mechanical 159600-7023 B-2
107691-3193 HINO J08C-TP 12 Mechanical 159600-7023 B-2
107691-3194 HINO J08C-TP 12 Mechanical 159600-7023 B-2
107691-3195 HINO J08C-TP 12 Mechanical 159600-7024 B-2
107691-3200 HINO J08C-TP 12 Mechanical 159600-7022 B-2
107691-3201 HINO J08C-TP 12 Mechanical 159600-7022 B-2
107691-3202 HINO J08C-TP 12 Mechanical 159600-7023 B-2
107691-3203 HINO J08C-TP 12 Mechanical 159600-7023 B-2
107691-3204 HINO J08C-TP 12 Mechanical 159600-7024 B-2
107691-3205 HINO J08C-TP 12 Mechanical 159600-7024 B-2
107691-3210 HINO J08C-TP 12 Mechanical 159600-7022 B-2
107691-3211 HINO J08C-TP 12 Mechanical 159600-7022 B-2
107691-3212 HINO J08C-TP 12 Mechanical 159600-7023 B-2
107691-3213 HINO J08C-TP 12 Mechanical 159600-7023 B-2
107691-3214 HINO J08C-TP 12 Mechanical 159600-7024 B-2
107691-3220 HINO J08C-TR 12 Mechanical 159600-7022 B-2
107691-3221 HINO J08C-TR 12 Mechanical 159600-7022 B-2
107691-3222 HINO J08C-TR 12 Mechanical 159600-7023 B-2
107691-3223 HINO J08C-TR 12 Mechanical 159600-7023 B-2
107691-3224 HINO J08C-TR 12 Mechanical 159600-7023 B-2
107691-3225 HINO J08C-TR 12 Mechanical 159600-7024 B-2
107691-3226 HINO J08C-TR 12 Mechanical 159600-7024 B-2
107691-3230 HINO J08C-TR 12 Mechanical 159600-7022 B-2
107691-3231 HINO J08C-TR 12 Mechanical 159600-7022 B-2
107691-3232 HINO J08C-TR 12 Mechanical 159600-7023 B-2
107691-3233 HINO J08C-TR 12 Mechanical 159600-7023 B-2
107691-3234 HINO J08C-TR 12 Mechanical 159600-7023 B-2
107691-3235 HINO J08C-TR 12 Mechanical 159600-7024 B-2
107691-3240 HINO J08C-TI 24 Mechanical 159601-0020 B-4
TICS PUMP PART NO. LIST
- 5 -
Pump assemblynumber Company Engine
modelVoltage
(V)Governor actuator Pre-stroke actuator
Part number Ref. no Part number Ref. no
• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
107691-3241 HINO J08C-TI 24 Mechanical 159601-0021 B-4
107691-3242 HINO J08C-TI 24 Mechanical 159601-0021 B-4
107691-3243 HINO J08C-TI 24 Mechanical 159601-0021 B-4
107691-3244 HINO J08C-TI 24 Mechanical 159601-0021 B-4
107691-3245 HINO J08C-TI 24 Mechanical 159601-0022 B-4
107691-3250 HINO J08C-TI 24 Mechanical 159601-0020 B-4
107691-3251 HINO J08C-TI 24 Mechanical 159601-0021 B-4
107691-3252 HINO J08C-TI 24 Mechanical 159601-0021 B-4
107691-3253 HINO J08C-TI 24 Mechanical 159601-0021 B-4
107691-3254 HINO J08C-TI 24 Mechanical 159601-0022 B-4
107691-3260 HINO J08C-TT 24 Mechanical 159601-1020 B-4
107691-3261 HINO J08C-TT 24 Mechanical 159601-1020 B-4
107691-3262 HINO J08C-TT 24 Mechanical 159601-1020 B-4
107691-3263 HINO J08C-TT 24 Mechanical 159601-1021 B-4
107691-3270 HINO J08C-TI 24 Mechanical 159601-1020 B-4
107691-3271 HINO J08C-TI 24 Mechanical 159601-1021 B-4
107691-3280 HINO J08C-TI 24 Mechanical 159601-1020 B-4
107691-3281 HINO J08C-TW 24 Mechanical 159601-1020 B-4
107691-3282 HINO J08C-TW 24 Mechanical 159601-1021 B-4
107691-3290 HINO J08C-K 24 Mechanical 159645-0320 B-4
107691-3291 HINO J08C-K 24 Mechanical 159645-1220 B-3
107691-3292 HINO J08C-K 24 Mechanical 159645-1220 B-3
107691-3293 HINO J08C-K 24 Mechanical 159645-1220 B-3
107691-3294 HINO J08C-K 24 Mechanical 159645-1220 B-3
107691-3295 HINO J08C-K 24 Mechanical 159645-1220 B-3
107691-3300 HINO J08C-K 24 Mechanical 159645-0320 B-4
107691-3301 HINO J08C-K 24 Mechanical 159645-1220 B-3
107691-3302 HINO J08C-K 24 Mechanical 159645-1220 B-3
107691-3303 HINO J08C-K 24 Mechanical 159645-1220 B-3
107691-3304 HINO J08C-K 24 Mechanical 159645-1220 B-3
107691-3305 HINO J08C-K 24 Mechanical 159645-1220 B-3
107691-3310 HINO J08C-K 24 105962-0020 - 159645-0820 B-3
107691-3311 HINO J08C-K 24 105962-0020 - 159645-0820 B-3
107691-3312 HINO J08C-K 24 105962-0021 - 159645-0820 B-3
107691-3313 HINO J08C-K 24 105962-0022 - 159645-0820 B-3
107691-3314 HINO J08C-K 24 105962-0022 - 159645-0820 B-3
107691-3320 HINO J08C-J 24 105962-0020 - 159645-0820 B-3
107691-3321 HINO J08C-J 24 105962-0020 - 159645-0820 B-3
107691-3322 HINO J08C-J 24 105962-0021 - 159645-0820 B-3
107691-3323 HINO J08C-J 24 105962-0022 - 159645-0820 B-3
TICS PUMP PART NO. LIST
- 6 -
Pump assemblynumber Company Engine
modelVoltage
(V)Governor actuator Pre-stroke actuator
Part number Ref. no Part number Ref. no
• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
107691-3324 HINO J08C-J 24 105962-0022 - 159645-0820 B-3
107691-3330 HINO J08C-TI 24 Mechanical 159601-4520 B-4
107691-3331 HINO J08C-TI 24 Mechanical 159601-4521 B-4
107691-3332 HINO J08C-TI 24 Mechanical 159601-4521 B-4
107691-3333 HINO J08C-TR 24 Mechanical 159601-4521 B-4
107691-3334 HINO J08C-TR 24 Mechanical 159601-4522 B-4
107691-3340 HINO J08C-TI 24 Mechanical 159601-4520 B-4
107691-3341 HINO J08C-TI 24 Mechanical 159601-4521 B-4
107691-3342 HINO J08C-TI 24 Mechanical 159601-4521 B-4
107691-3343 HINO J08C-TU 24 Mechanical 159601-4521 B-4
107691-3344 HINO J08C-TU 24 Mechanical 159601-4522 B-4
107691-3350 HINO J08C-K 24 105962-0030 - 159645-1020 B-3
107691-3351 HINO J08C-K 24 105962-0031 - 159645-1020 B-3
107691-3352 HINO J08C-K 24 105962-0032 - 159645-1020 B-3
107691-3353 HINO J08C-K 24 105962-0033 - 159645-1020 B-3
107691-3354 HINO J08C-K 24 105962-0033 - 159645-1020 B-3
107691-3360 HINO J08C-K 24 Mechanical 159645-1220 B-3
107691-3361 HINO J08C-K 24 Mechanical 159645-1220 B-3
107691-3362 HINO J08C-K 24 Mechanical 159645-1220 B-3
107691-3363 HINO J08C-K 24 Mechanical 159645-1220 B-3
107691-3364 HINO J08C-K 24 Mechanical 159645-1220 B-3
107691-3370 HINO J08C-TT 24 Mechanical 159601-1020 B-4
107691-3371 HINO J08C-TT 24 Mechanical 159601-1021 B-4
107691-3380 HINO J08C-K 24 105962-0110 - 159645-2320 B-3
107691-3381 HINO J08C-K 24 105962-0111 - 159645-2320 B-3
107691-3382 HINO J08C-K 24 105962-0111 - 159645-2320 B-3
107691-3383 HINO J08C-K 24 105962-0111 - 159645-2320 B-3
107691-3390 HINO J08C-TR 24 Mechanical 159601-6720 B-4
107691-3391 HINO J08C-TR 24 Mechanical 159601-6721 B-4
107691-3400 HINO J08C-TR 24 Mechanical 159601-6720 B-4
107691-3401 HINO J08C-TR 24 Mechanical 159601-6721 B-4
107691-3410 HINO J08C-TP 24 Mechanical 159601-6720 B-4
107691-3411 HINO J08C-TP 24 Mechanical 159601-6721 B-4
107691-3420 HINO J08C-TT 24 Mechanical 159601-6720 B-4
107691-3421 HINO J08C-TT 24 Mechanical 159601-6721 B-4
107691-3430 HINO J08C-K 24 Mechanical 159645-1220 B-3
107691-3431 HINO J08C-K 24 Mechanical 159645-1220 B-3
107691-3440 HINO J08C-TT 24 Mechanical 159601-6720 B-4
107691-3441 HINO J08C-TT 24 Mechanical 159601-6721 B-4
107691-3450 HINO J08C-K 24 105962-0150 - 159645-1020 B-3
TICS PUMP PART NO. LIST
- 7 -
Pump assemblynumber Company Engine
modelVoltage
(V)Governor actuator Pre-stroke actuator
Part number Ref. no Part number Ref. no
• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
107691-3451 HINO J08C-K 24 105962-0150 - 159645-1020 B-3
107691-3460 HINO J08C-K 24 105962-0140 - 159645-3020 B-3
107691-3461 HINO J08C-K 24 105962-0140 - 159645-3020 B-3
107691-3462 HINO J08C-K 24 105962-0141 - 159645-3021 B-3
107691-3470 HINO J08C-TT 24 Mechanical 159601-6721 B-4
107691-3541 HINO J08C 24 105962-0181 - 159645-0820 B-3
107691-3542 HINO J08C-S 24 105962-0181 - 159645-0820 B-3
107691-3550 HINO J08C-T 24 105962-0180 - 159645-0820 B-3
107691-3551 HINO J08C-T 24 105962-0181 - 159645-0820 B-3
107691-3552 HINO J08C-T 24 105962-0181 - 159645-0820 B-3
107691-3560 HINO J08C-UK 24 Mechanical 159645-4120 B-3
107691-3561 HINO J08C-UK 24 Mechanical 159645-4120 B-3
107691-3562 HINO J08C-UK 24 Mechanical 159645-4121 B-3
107691-3570 HINO J08C-UJ 24 Mechanical 159645-4120 B-3
107691-3571 HINO J08C-UJ 24 Mechanical 159645-4121 B-3
107691-3580 HINO J08C-UK 24 105962-0220 - 159645-4220 B-3
107691-3590 HINO J08C-UK 24 Mechanical 159645-4120 B-3
107691-3591 HINO J08C-UK 24 Mechanical 159645-4121 B-3
107691-3600 HINO J08C-TR 24 Mechanical 159645-4120 B-3
107691-3601 HINO J08C-TR 24 Mechanical 159645-4121 B-3
107691-3610 HINO J08C-TI 24 Mechanical 159645-4120 B-3
107691-3611 HINO J08C-TI 24 Mechanical 159645-4121 B-3
107691-3620 HINO J08C-TT 24 Mechanical 159645-4120 B-3
107691-3621 HINO J08C-TT 24 Mechanical 159645-4121 B-3
107691-3630 HINO J08C-UK 24 Mechanical 159645-4120 B-3
107691-3631 HINO J08C-UK 24 Mechanical 159645-4520 B-3
107691-3640 HINO J08C-TW 24 Mechanical 159645-4120 B-3
107691-3641 HINO J08C-TW 24 Mechanical 159645-4121 B-3
107691-3650 HINO J08C-TW 24 Mechanical 159645-4120 B-3
107691-3651 HINO J08C-TW 24 Mechanical 159645-4121 B-3
107691-3660 HINO J08C-TT 24 Mechanical 159645-4120 B-3
107691-3670 HINO J08C-UK 24 Mechanical 159645-4120 B-3
107691-3671 HINO J08C-UK 24 Mechanical 159645-4121 B-3
107691-3680 HINO J08C-UK 24 Mechanical 159645-4120 B-3
107691-3681 HINO J08C-UK 24 Mechanical 159645-4121 B-3
107691-3690 HINO J08C-UK 24 Mechanical 159645-4120 B-3
107691-3691 HINO J08C-UK 24 Mechanical 159645-4121 B-3
107691-3700 HINO J08C-UL 24 Mechanical 159645-4120 B-3
107691-3701 HINO J08C-UL 24 Mechanical 159645-4121 B-3
107691-3710 HINO J08C-UR 24 105962-0230 - 159645-4320 B-3
TICS PUMP PART NO. LIST
- 8 -
Pump assemblynumber Company Engine
modelVoltage
(V)Governor actuator Pre-stroke actuator
Part number Ref. no Part number Ref. no
• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
107691-3711 HINO J08C-UR 24 105962-0230 - 159645-4321 B-3
107691-3720 HINO J08C-US 24 105962-0240 - 159645-4420 B-3
107691-3721 HINO J08C-US 24 105962-0240 - 159645-4421 B-3
107691-3730 HINO J08C-UK 24 105962-0270 - 159645-4820 B-3
107691-3731 HINO J08C-UK 24 105962-0271 - 159645-4821 B-3
107691-3732 HINO J08C-UK 24 105962-0272 - 159645-4821 B-3
107691-3740 HINO J08C-TI 24 Mechanical 159645-4520 B-3
107691-3750 HINO J08C-TR 24 Mechanical 159645-4121 B-3
107691-3751 HINO J08C-TR 24 Mechanical 159645-4121 B-3
107691-3760 HINO J08C-UL 24 Mechanical 159645-4121 B-3
107692-3001 HINO M10U-D 24 Mechanical 159600-2420 B-4
107692-3002 HINO M10U-D 24 Mechanical 159600-2421 B-4
107692-3003 HINO M10U-D 24 Mechanical 159600-2421 B-4
107692-3004 HINO M10U-D 24 Mechanical 159600-2421 B-4
107692-3005 HINO M10U-D 24 Mechanical 159600-2421 B-4
107692-3006 HINO M10U-D 24 Mechanical 159600-2421 B-4
107692-3007 HINO M10U-D 24 Mechanical 159600-2421 B-4
107692-3008 HINO M10U-D 24 Mechanical 159600-2421 B-4
107692-3009 HINO M10U-D 24 Mechanical 159600-2421 B-4
107692-3010 HINO M10U-D 24 105956-0010 A-2 159600-2420 B-4
107692-3011 HINO M10U-D 24 105956-0011 A-2 159600-2420 B-4
107692-3012 HINO M10U-D 24 105956-0011 A-2 159600-4220 B-4
107692-3013 HINO M10U-D 24 105956-0011 A-2 159600-4220 B-4
107692-3014 HINO M10U-D 24 105956-0011 A-2 159600-4221 B-4
107692-3020 HINO JT-3 24 105956-0020 A-2 159600-3120 B-5
107692-3021 HINO JT-3 24 105956-0040 A-2 159600-3120 B-5
107692-3022 HINO JT-3 24 105956-0040 A-2 159600-3120 B-5
107692-3023 HINO JT-3 24 105956-0041 A-2 159600-3121 B-5
107692-3030 HINO M10U-D 24 Mechanical 159600-2421 B-4
107692-3031 HINO M10U-D 24 Mechanical 159600-2421 B-4
107692-3032 HINO M10U-D 24 Mechanical 159600-2421 B-4
107692-3033 HINO M10U-D 24 Mechanical 159600-2421 B-4
107692-3034 HINO M10U-D 24 Mechanical 159600-2422 B-4
107692-3040 HINO M10U-D 24 Mechanical 159600-2422 B-4
108622-3077 HINO K13D-B 24 Mechanical 159590-6721 B-7
108622-3078 HINO K13D-B 24 Mechanical 159590-6721 B-7
108622-3079 HINO K13D-B 24 Mechanical 159590-6721 B-7
108622-3087 HINO P-3 24 Mechanical 159590-6621 B-6
108622-3088 HINO P-3 24 Mechanical 159590-6621 B-6
108622-3089 HINO P-3 24 Mechanical 159590-6621 B-6
TICS PUMP PART NO. LIST
- 9 -
Pump assemblynumber Company Engine
modelVoltage
(V)Governor actuator Pre-stroke actuator
Part number Ref. no Part number Ref. no
• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
108622-3097 HINO P-4 24 Mechanical 159590-6621 B-6
108622-3098 HINO P-4 24 Mechanical 159590-6621 B-6
108622-3099 HINO P-4 24 Mechanical 159590-6621 B-6
108622-3102 HINO P-4 24 105952-0801 A-1 159590-7020 B-6
108622-3103 HINO P-4 24 105952-0802 A-1 159590-7020 B-6
108622-3104 HINO P-4 24 105952-0802 A-1 159590-7020 B-6
108622-3118 HINO K-3 24 Mechanical 159590-6821 B-6
108622-3119 HINO K-3 24 Mechanical 159590-6821 B-6
108622-3127 HINO K-4 24 Mechanical 159590-6821 B-6
108622-3128 HINO K-4 24 Mechanical 159590-6821 B-6
108622-3129 HINO K-4 24 Mechanical 159590-6821 B-6
108622-3340 HINO K13D-D 24 Mechanical 159600-1920 B-5
108622-3341 HINO K13D-D 24 Mechanical 159600-1920 B-5
108622-3342 HINO K13D-D 24 Mechanical 159600-1920 B-5
108622-3343 HINO K13D-D 24 Mechanical 159600-1920 B-5
108622-3344 HINO K13D-D 24 Mechanical 159600-1920 B-5
108622-3345 HINO K13D-D 24 Mechanical 159600-1921 B-5
108622-3350 HINO K13D-D 24 Mechanical 159600-1920 B-5
108622-3351 HINO K13D-D 24 Mechanical 159600-1920 B-5
108622-3352 HINO K13D-D 24 Mechanical 159600-1920 B-5
108622-3353 HINO K13D-D 24 Mechanical 159600-1920 B-5
108622-3354 HINO K13D-D 24 Mechanical 159600-1921 B-5
108622-3360 HINO K13C-TE 24 Mechanical 159600-1420 B-5
108622-3361 HINO K13C-TE 24 Mechanical 159600-1420 B-5
108622-3362 HINO K13C-TE 24 Mechanical 159600-1420 B-5
108622-3363 HINO K13C-TE 24 Mechanical 159600-1420 B-5
108622-3364 HINO K13C-TE 24 Mechanical 159600-1420 B-5
108622-3365 HINO K13C-TE 24 Mechanical 159600-1420 B-5
108622-3366 HINO K13C-TE 24 Mechanical 159600-1420 B-5
108622-3367 HINO K13C-TE 24 Mechanical 159600-1420 B-5
108622-3368 HINO K13C-TE 24 Mechanical 159600-1420 B-5
108622-3369 HINO K13C-TE 24 Mechanical 159600-1421 B-5
108622-3370 HINO K13C-TF 24 Mechanical 159600-1420 B-5
108622-3371 HINO K13C-TF 24 Mechanical 159600-1420 B-5
108622-3372 HINO K13C-TF 24 Mechanical 159600-1420 B-5
108622-3373 HINO K13C-TF 24 Mechanical 159600-1420 B-5
108622-3374 HINO K13C-TF 24 Mechanical 159600-1420 B-5
108622-3375 HINO K13C-TF 24 Mechanical 159600-1420 B-5
108622-3376 HINO K13C-TF 24 Mechanical 159600-1420 B-5
108622-3377 HINO K13C-TF 24 Mechanical 159600-1420 B-5
TICS PUMP PART NO. LIST
- 10 -
Pump assemblynumber Company Engine
modelVoltage
(V)Governor actuator Pre-stroke actuator
Part number Ref. no Part number Ref. no
• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
108622-3378 HINO K13C-TF 24 Mechanical 159600-1420 B-5
108622-3379 HINO K13C-TF 24 Mechanical 159600-1421 B-5
108622-3382 HINO P-4 24 Mechanical 159600-2120 B-4
108622-3383 HINO P-4 24 Mechanical 159600-2120 B-4
108622-3384 HINO P-4 24 Mechanical 159600-2120 B-4
108622-3385 HINO P-4 24 Mechanical 159600-2121 B-4
108622-3386 HINO P-4 24 Mechanical 159600-2121 B-4
108622-3387 HINO P-4 24 Mechanical 159600-2122 B-4
108622-3388 HINO P-4 24 Mechanical 159600-2122 B-4
108622-3389 HINO P-4 24 Mechanical 159600-2122 B-4
108622-3390 HINO P-3 24 Mechanical 159600-2120 B-4
108622-3391 HINO P-3 24 Mechanical 159600-2120 B-4
108622-3392 HINO P-3 24 Mechanical 159600-2120 B-4
108622-3393 HINO P-3 24 Mechanical 159600-2120 B-4
108622-3394 HINO P-3 24 Mechanical 159600-2120 B-4
108622-3395 HINO P-3 24 Mechanical 159600-2121 B-4
108622-3396 HINO P-3 24 Mechanical 159600-2121 B-4
108622-3397 HINO P-3 24 Mechanical 159600-2122 B-4
108622-3398 HINO P-3 24 Mechanical 159600-2122 B-4
108622-3399 HINO P-3 24 Mechanical 159600-2120 B-4
108622-3401 HINO P-4 24 105952-1730 A-2 159600-2020 B-8
108622-3402 HINO P-4 24 105952-1731 A-2 159600-2021 B-8
108622-3403 HINO P-4 24 105952-1731 A-2 159600-2021 B-8
108622-3404 HINO P-4 24 105952-1731 A-2 159600-2021 B-8
108622-3405 HINO P-4 24 105952-2810 A-2 159600-2021 B-8
108622-3406 HINO P-4 24 105952-2810 A-2 159600-2021 B-8
108622-3410 HINO K-4 24 Mechanical 159600-2220 B-4
108622-3411 HINO K-4 24 Mechanical 159600-2220 B-4
108622-3412 HINO K-4 24 Mechanical 159600-2220 B-4
108622-3413 HINO K-4 24 Mechanical 159600-2220 B-4
108622-3414 HINO K-4 24 Mechanical 159600-2221 B-4
108622-3415 HINO K-4 24 Mechanical 159600-2221 B-4
108622-3416 HINO K-4 24 Mechanical 159600-2221 B-4
108622-3417 HINO K-4 24 Mechanical 159600-2221 B-4
108622-3418 HINO K-4 24 Mechanical 159600-2222 B-4
108622-3420 HINO K-3 24 Mechanical 159600-2220 B-4
108622-3421 HINO K-3 24 Mechanical 159600-2220 B-4
108622-3422 HINO K-3 24 Mechanical 159600-2221 B-4
108622-3423 HINO K-3 24 Mechanical 159600-2221 B-4
108622-3424 HINO K-3 24 Mechanical 159600-2221 B-4
TICS PUMP PART NO. LIST
- 11 -
Pump assemblynumber Company Engine
modelVoltage
(V)Governor actuator Pre-stroke actuator
Part number Ref. no Part number Ref. no
• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
108622-3425 HINO K-3 24 Mechanical 159600-2221 B-4
108622-3426 HINO K-3 24 Mechanical 159600-2221 B-4
108622-3427 HINO K-3 24 Mechanical 159600-2222 B-4
108622-3430 HINO K13U-B 24 Mechanical 159600-2320 B-5
108622-3431 HINO K13U-B 24 Mechanical 159600-2320 B-5
108622-3432 HINO K13U-B 24 Mechanical 159600-2321 B-5
108622-3433 HINO K13U-B 24 Mechanical 159600-2321 B-5
108622-3434 HINO K13U-B 24 Mechanical 159600-2321 B-5
108622-3435 HINO K13U-B 24 Mechanical 159600-2321 B-5
108622-3436 HINO K13U-B 24 Mechanical 159600-2321 B-5
108622-3437 HINO K13U-B 24 Mechanical 159600-2321 B-5
108622-3438 HINO K13U-B 24 Mechanical 159600-2321 B-5
108622-3439 HINO K13U-B 24 Mechanical 159600-2321 B-5
108622-3450 HINO K-3 24 Mechanical 159600-2220 B-4
108622-3451 HINO K-3 24 Mechanical 159600-2221 B-4
108622-3452 HINO K-3 24 Mechanical 159600-2221 B-4
108622-3453 HINO K-3 24 Mechanical 159600-2221 B-4
108622-3454 HINO K-3 24 Mechanical 159600-2221 B-4
108622-3455 HINO K-3 24 Mechanical 159600-2221 B-4
108622-3456 HINO K-3 24 Mechanical 159600-2221 B-4
108622-3457 HINO K-3 24 Mechanical 159600-2222 B-4
108622-3460 HINO K13D 24 Mechanical 159600-1920 B-5
108622-3461 HINO K13D 24 Mechanical 159600-1920 B-5
108622-3462 HINO K13D 24 Mechanical 159600-1920 B-5
108622-3463 HINO K13D 24 Mechanical 159600-1920 B-5
108622-3464 HINO K13D 24 Mechanical 159600-1920 B-5
108622-3465 HINO K13D 24 Mechanical 159600-1921 B-5
108622-3470 HINO P11C-TE 24 Mechanical 159600-2120 B-4
108622-3471 HINO P11C-TE 24 Mechanical 159600-2120 B-4
108622-3472 HINO P11C-TE 24 Mechanical 159600-2120 B-4
108622-3473 HINO P11C-TE 24 Mechanical 159600-2120 B-4
108622-3474 HINO P11C-TE 24 Mechanical 159600-2120 B-4
108622-3475 HINO P11C-TE 24 Mechanical 159600-2121 B-4
108622-3476 HINO P11C-TE 24 Mechanical 159600-2121 B-4
108622-3477 HINO P11C-TE 24 Mechanical 159600-2121 B-4
108622-3478 HINO P11C-TE 24 Mechanical 159600-2122 B-4
108622-3479 HINO P11C-TE 24 Mechanical 159600-2122 B-4
108622-3480 HINO YJ35 24 Mechanical 159600-5920 B-5
108622-3481 HINO YJ35 24 Mechanical 159600-5921 B-5
108622-3510 HINO YJ37 24 105962-1730 - 159600-6220 B-4
TICS PUMP PART NO. LIST
- 12 -
Pump assemblynumber Company Engine
modelVoltage
(V)Governor actuator Pre-stroke actuator
Part number Ref. no Part number Ref. no
• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
108622-3511 HINO YJ37 24 105962-1731 - 159600-6221 B-4
108622-3512 HINO YJ37 24 105962-1731 - 159600-6222 B-4
108622-3520 HINO K-4 24 105952-1840 A-2 159600-6520 B-4
108622-3521 HINO K-4 24 105952-1841 A-2 159600-6520 B-4
108622-3522 HINO K-4 24 105952-1841 A-2 159600-6520 B-4
108622-3523 HINO K-4 24 105952-1842 A-2 159600-6520 B-4
108622-3524 HINO K-4 24 105952-1843 A-2 159600-6521 B-4
108622-3525 HINO K-4(K13C-T) 24 105952-1844 A-2 159600-6521 B-4
108622-3526 HINO K-4(K13C-T) 24 105952-1844 A-2 159600-6521 B-4
108622-3527 HINO K-4(K13C-T) 24 105952-1844 A-2 159600-6522 B-4
108622-3540 HINO K13D 24 Mechanical 159600-1920 B-5
108622-3541 HINO K13D 24 Mechanical 159600-1920 B-5
108622-3542 HINO K13D 24 Mechanical 159600-1920 B-5
108622-3543 HINO K13D 24 Mechanical 159600-1920 B-5
108622-3544 HINO K13D 24 Mechanical 159600-1920 B-5
108622-3545 HINO K13D 24 Mechanical 159600-1921 B-5
108622-3550 HINO K-3 24 Mechanical 159590-7421 B-5
108622-3551 HINO K-3 24 Mechanical 159590-7421 B-5
108622-3552 HINO K-3 24 Mechanical 159590-7421 B-5
108622-3553 HINO K-3 24 Mechanical 159590-7421 B-5
108622-3554 HINO K-3 24 Mechanical 159590-7422 B-5
108622-3560 HINO K-3 24 Mechanical 159590-7421 B-5
108622-3561 HINO K-3 24 Mechanical 159590-7421 B-5
108622-3562 HINO K-3 24 Mechanical 159590-7421 B-5
108622-3563 HINO K-3 24 Mechanical 159590-7421 B-5
108622-3564 HINO K-3 24 Mechanical 159590-7422 B-5
108622-3580 HINO K13D 24 Mechanical 159600-1920 B-5
108622-3581 HINO K13D 24 Mechanical 159600-1920 B-5
108622-3582 HINO K13D 24 Mechanical 159600-1920 B-5
108622-3583 HINO K13D 24 Mechanical 159600-1921 B-5
108622-3590 HINO K13C-TM 24 Mechanical 159600-6820 B-4
108622-3591 HINO K13C-TM 24 Mechanical 159600-6820 B-4
108622-3592 HINO K13C-TM 24 Mechanical 159600-6820 B-4
108622-3593 HINO K13C-TM 24 Mechanical 159600-6821 B-4
108622-3594 HINO K13C-TM 24 Mechanical 159600-6822 B-4
108622-3595 HINO K13C-TM 24 Mechanical 159600-6823 B-4
108622-3600 HINO K13C-TN 24 Mechanical 159600-6820 B-4
108622-3601 HINO K13C-TN 24 Mechanical 159600-6820 B-4
108622-3602 HINO K13C-TN 24 Mechanical 159600-6820 B-4
108622-3603 HINO K13C-TN 24 Mechanical 159600-6821 B-4
TICS PUMP PART NO. LIST
- 13 -
Pump assemblynumber Company Engine
modelVoltage
(V)Governor actuator Pre-stroke actuator
Part number Ref. no Part number Ref. no
• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
108622-3604 HINO K13C-TN 24 Mechanical 159600-6822 B-4
108622-3605 HINO K13C-TN 24 Mechanical 159600-6822 B-4
108622-3606 HINO K13C-TN 24 Mechanical 159600-6823 B-4
108622-3620 HINO YJ39 24 105952-1980 A-4 159600-8120 B-4
108622-3621 HINO YJ39 24 105952-2110 A-4 159600-8120 B-4
108622-3622 HINO YJ39 24 105952-2110 A-4 159600-8121 B-4
108622-3623 HINO YJ39 24 105952-2110 A-4 159600-8122 B-4
108622-3630 HINO YJ36 24 Mechanical 159600-8920 B-4
108622-3631 HINO YJ36 24 Mechanical 159600-8920 B-4
108622-3632 HINO YJ36 24 Mechanical 159600-8921 B-4
108622-3633 HINO YJ36 24 Mechanical 159600-8921 B-4
108622-3634 HINO YJ36 24 Mechanical 159600-8922 B-4
108622-3635 HINO YJ36 24 Mechanical 159600-8922 B-4
108622-3640 HINO P-3 24 Mechanical 159600-8920 B-4
108622-3641 HINO YJ37 24 Mechanical 159600-8920 B-4
108622-3642 HINO YJ37 24 Mechanical 159600-8921 B-4
108622-3643 HINO YJ37 24 Mechanical 159600-8921 B-4
108622-3644 HINO YJ37 24 Mechanical 159600-8922 B-4
108622-3645 HINO YJ37 24 Mechanical 159600-8922 B-4
108622-3650 HINO YJ37 24 105952-2080 A-4 159600-8820 B-4
108622-3651 HINO YJ37 24 105952-2081 A-4 159600-8820 B-4
108622-3652 HINO YJ37 24 105952-2082 A-4 159600-8820 B-4
108622-3653 HINO YJ37 24 105952-2082 A-4 159600-8821 B-4
108622-3654 HINO YJ37 24 105952-2083 A-4 159600-8821 B-4
108622-3655 HINO YJ37 24 105952-2280 A-4 159601-2120 B-4
108622-3656 HINO YJ37 24 105952-2281 A-4 159601-3620 B-4
108622-3657 HINO P11C-TD 24 105952-2282 A-4 159601-3620 B-4
108622-3658 HINO P11C-TD 24 105952-2282 A-4 159601-3621 B-4
108622-3659 HINO P11C-TD 24 105952-2282 A-4 159601-3621 B-4
108622-3660 HINO K13C-TE 24 Mechanical 159600-1420 B-5
108622-3661 HINO K13C-TE 24 Mechanical 159600-1420 B-5
108622-3662 HINO K13C-TE 24 Mechanical 159600-1420 B-5
108622-3663 HINO K13C-TE 24 Mechanical 159600-1421 B-5
108622-3664 HINO K13C-TE 24 Mechanical 159601-7820 B-5
108622-3670 HINO K13C-TF 24 Mechanical 159600-1420 B-5
108622-3671 HINO K13C-TF 24 Mechanical 159600-1420 B-5
108622-3672 HINO K13C-TF 24 Mechanical 159600-1420 B-5
108622-3673 HINO K13C-TF 24 Mechanical 159600-1420 B-5
108622-3674 HINO K13C-TF 24 Mechanical 159600-1421 B-5
108622-3675 HINO K13C-TF 24 Mechanical 159601-7820 B-5
TICS PUMP PART NO. LIST
- 14 -
Pump assemblynumber Company Engine
modelVoltage
(V)Governor actuator Pre-stroke actuator
Part number Ref. no Part number Ref. no
• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
108622-3680 HINO K13D 24 Mechanical 159600-9120 B-4
108622-3681 HINO K13D 24 Mechanical 159600-9120 B-4
108622-3682 HINO K13D 24 Mechanical 159600-9120 B-4
108622-3683 HINO K13D 24 Mechanical 159600-9121 B-4
108622-3684 HINO K13D 24 Mechanical 159600-9122 B-4
108622-3685 HINO K13D 24 Mechanical 159600-9122 B-4
108622-3690 HINO YJ35(K13D) 24 Mechanical 159600-9120 B-4
108622-3691 HINO YJ35(K13D) 24 Mechanical 159600-9120 B-4
108622-3692 HINO YJ35(K13D) 24 Mechanical 159600-9120 B-4
108622-3693 HINO YJ35(K13D) 24 Mechanical 159600-9122 B-4
108622-3694 HINO YJ35(K13D) 24 Mechanical 159600-9122 B-4
108622-3700 HINO P11C-TC 24 105952-2081 A-4 159600-8820 B-4
108622-3701 HINO P11C-TC 24 105952-2082 A-4 159600-8820 B-4
108622-3702 HINO P11C-TC 24 105952-2082 A-4 159600-8821 B-4
108622-3703 HINO P11C-TC 24 105952-2083 A-4 159600-8821 B-4
108622-3704 HINO P11C-TC 24 105952-2083 A-4 159600-8821 B-4
108622-3705 HINO P11C-TC 24 105952-2280 A-4 159601-2120 B-4
108622-3706 HINO P11C-TC 24 105952-2281 A-4 159601-3620 B-4
108622-3707 HINO P11C-TC 24 105952-2282 A-4 159601-3620 B-4
108622-3708 HINO P11C-TC 24 105952-2282 A-4 159601-3621 B-4
108622-3709 HINO P11C-TC 24 105952-2282 A-4 159601-3621 B-4
108622-3710 HINO YJ60 24 105952-2170 A-2 159600-9620 B-3
108622-3711 HINO YJ60 24 105952-2171 A-2 159600-9620 B-3
108622-3712 HINO YJ60 24 105952-2172 A-2 159600-9620 B-3
108622-3713 HINO YJ60 24 105952-2172 A-2 159600-9620 B-3
108622-3714 HINO YJ60 24 105952-2310 A-2 159601-3420 B-3
108622-3715 HINO YJ60 24 105952-2310 A-2 159601-3421 B-3
108622-3716 HINO YJ60 24 105952-2310 A-2 159601-3421 B-3
108622-3717 HINO YJ60 24 105952-2310 A-2 159601-3421 B-3
108622-3718 HINO YJ60 24 105952-2310 A-2 159601-6520 B-3
108622-3719 HINO YJ60 24 105952-2310 A-2 159601-6520 B-3
108622-3720 HINO YJ85 24 105952-2250 A-2 159601-1720 B-3
108622-3721 HINO YJ85 24 105952-2320 A-2 159601-3520 B-3
108622-3722 HINO YJ85 24 105952-2320 A-2 159601-3521 B-3
108622-3723 HINO YJ85 24 105952-2320 A-2 159601-3521 B-3
108622-3724 HINO YJ85 24 105952-2320 A-2 159601-3522 B-3
108622-3725 HINO YJ85 24 105952-2320 A-2 159601-3522 B-3
108622-3726 HINO YJ85 24 105952-2321 A-2 159601-3522 B-3
108622-3727 HINO YJ85 24 105952-2321 A-2 159601-3522 B-3
108622-3730 HINO K13C-TU 24 Mechanical 159601-2520 B-4
TICS PUMP PART NO. LIST
- 15 -
Pump assemblynumber Company Engine
modelVoltage
(V)Governor actuator Pre-stroke actuator
Part number Ref. no Part number Ref. no
• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
108622-3731 HINO K13C-TU 24 Mechanical 159601-2520 B-4
108622-3732 HINO K13C-TU 24 Mechanical 159601-2521 B-4
108622-3733 HINO K13C-TU 24 Mechanical 159601-2522 B-4
108622-3740 HINO K13C-TM 24 Mechanical 159601-2520 B-4
108622-3741 HINO K13C-TM 24 Mechanical 159601-2521 B-4
108622-3742 HINO K13C-TM 24 Mechanical 159601-2522 B-4
108622-3750 HINO P11C 24 Mechanical 159601-3020 B-12
108622-3751 HINO P11C 24 Mechanical 159601-3021 B-12
108622-3752 HINO P11C 24 Mechanical 159601-3021 B-12
108622-3753 HINO P11C 24 Mechanical 159601-3021 B-12
108622-3754 HINO P11C 24 Mechanical 159601-3021 B-12
108622-3755 HINO P11C 24 Mechanical 159601-3021 B-12
108622-3760 HINO K13U-B 24 Mechanical 159600-2322 B-5
108622-3770 HINO P11C-TD 24 105952-2340 A-4 159601-3620 B-4
108622-3771 HINO P11C-TD 24 105952-2340 A-4 159601-3621 B-4
108622-3772 HINO P11C-TD 24 105952-2341 A-4 159601-3621 B-4
108622-3773 HINO P11C-TD 24 105952-2341 A-4 159601-3621 B-4
108622-3774 HINO P11C-TD 24 105952-2570 A-4 159601-3621 B-4
108622-3775 HINO P11C-TD 24 105952-2570 A-4 159601-3622 B-4
108622-3776 HINO P11C-TD 24 105952-2570 A-4 159601-3622 B-4
108622-3777 HINO P11C-TD 24 105952-2571 A-4 159601-3622 B-4
108622-3778 HINO P11C-TD 24 105952-2571 A-4 159601-3622 B-4
108622-3780 HINO P11C 24 105952-2360 A-2 159601-3420 B-3
108622-3781 HINO P11C 24 105952-2360 A-2 159601-3421 B-3
108622-3782 HINO P11C 24 105952-2360 A-2 159601-3421 B-3
108622-3783 HINO P11C 24 105952-2490 A-2 159601-3421 B-3
108622-3784 HINO P11C 24 105952-2490 A-2 159601-6520 B-3
108622-3785 HINO P11C 24 105952-2490 A-2 159601-6520 B-3
108622-3786 HINO P11C 24 105952-2490 A-2 159601-6520 B-3
108622-3787 HINO P11C 24 105952-2491 A-2 159601-6520 B-3
108622-3790 HINO P11C 24 Mechanical 159600-2121 B-4
108622-3791 HINO P11C 24 Mechanical 159600-2122 B-4
108622-3792 HINO P11C 24 Mechanical 159600-2122 B-4
108622-3793 HINO P11C 24 Mechanical 159600-2122 B-4
108622-3794 HINO P11C 24 Mechanical 159600-2122 B-4
108622-3800 HINO P11C 24 105952-2420 A-4 159601-5120 B-3
108622-3801 HINO P11C 24 105952-2420 A-4 159601-5120 B-3
108622-3802 HINO P11C 24 105952-2500 A-4 159601-5120 B-3
108622-3803 HINO P11C 24 105952-2500 A-4 159601-5121 B-3
108622-3804 HINO P11C 24 105952-2500 A-4 159601-5121 B-3
TICS PUMP PART NO. LIST
- 16 -
Pump assemblynumber Company Engine
modelVoltage
(V)Governor actuator Pre-stroke actuator
Part number Ref. no Part number Ref. no
• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
108622-3805 HINO P11C 24 105952-2500 A-4 159601-5121 B-3
108622-3806 HINO P11C 24 105952-2501 A-4 159601-5121 B-3
108622-3810 HINO K13U-B 24 Mechanical 159600-2321 B-5
108622-3811 HINO K13U-B 24 Mechanical 159600-2322 B-5
108622-3820 HINO P11C 24 Mechanical 159601-5920 B-3
108622-3821 HINO P11C 24 Mechanical 159601-5920 B-3
108622-3822 HINO P11C 24 Mechanical 159601-5920 B-3
108622-3830 HINO K13D 24 Mechanical 159600-9121 B-4
108622-3831 HINO K13D 24 Mechanical 159600-9122 B-4
108622-3832 HINO K13D 24 Mechanical 159600-9122 B-4
108622-3850 HINO P11C 24 Mechanical 159601-5920 B-3
108622-3851 HINO P11C 24 Mechanical 159601-5920 B-3
108622-3860 HINO P11C 24 Mechanical 159601-5920 B-3
108622-3861 HINO P11C 24 Mechanical 159601-5920 B-3
108622-3862 HINO P11C 24 Mechanical 159601-7120 B-3
108622-3863 HINO P11C 24 Mechanical 159601-7121 B-3
108622-3864 HINO P11C 24 Mechanical 159601-7121 B-3
108622-3865 HINO P11C 24 Mechanical 159601-7121 B-3
108622-3866 HINO P11C 24 Mechanical 159601-7121 B-3
108622-3867 HINO P11C 24 Mechanical 159601-7122 B-3
108622-3870 HINO P11C 24 Mechanical 159601-5920 B-3
108622-3871 HINO P11C 24 Mechanical 159601-5920 B-3
108622-3872 HINO P11C 24 Mechanical 159601-7120 B-3
108622-3873 HINO P11C 24 Mechanical 159601-7121 B-3
108622-3874 HINO P11C 24 Mechanical 159601-7121 B-3
108622-3875 HINO P11C 24 Mechanical 159601-7121 B-3
108622-3876 HINO P11C 24 Mechanical 159601-7122 B-3
108622-3880 HINO K13C-UA 24 105952-2530 A-4 159601-6620 B-13
108622-3881 HINO K13C-UA 24 105952-2530 A-4 159601-6620 B-13
108622-3890 HINO K13C-UB 24 105952-2530 A-4 159601-6620 B-13
108622-3891 HINO K13C-UB 24 105952-2530 A-4 159601-6620 B-13
108622-3900 HINO P11C 24 Mechanical 159601-6920 B-4
108622-3901 HINO P11C 24 Mechanical 159601-6921 B-4
108622-3902 HINO P11C 24 Mechanical 159601-6921 B-4
108622-3903 HINO P11C 24 Mechanical 159601-6921 B-4
108622-3910 HINO P11C 24 Mechanical 159601-6920 B-4
108622-3911 HINO P11C 24 Mechanical 159601-6921 B-4
108622-3912 HINO P11C 24 Mechanical 159601-6921 B-4
108622-3913 HINO P11C 24 Mechanical 159601-6921 B-4
108622-3920 HINO K13C-UK 24 Mechanical 159601-7020 B-3
TICS PUMP PART NO. LIST
- 17 -
Pump assemblynumber Company Engine
modelVoltage
(V)Governor actuator Pre-stroke actuator
Part number Ref. no Part number Ref. no
• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
108622-3921 HINO K13C-UK 24 Mechanical 159601-7021 B-3
108622-3922 HINO K13C-UK 24 Mechanical 159601-7021 B-3
108622-3923 HINO K13C-UK 24 Mechanical 159601-7021 B-3
108622-3930 HINO K13C-UN 24 Mechanical 159601-7020 B-3
108622-3931 HINO K13C-UN 24 Mechanical 159601-7021 B-3
108622-3932 HINO K13C-UN 24 Mechanical 159601-7021 B-3
108622-3940 HINO K13C-UK 24 Mechanical 159601-7020 B-3
108622-3941 HINO K13C-UK 24 Mechanical 159601-7021 B-3
108622-3950 HINO K13C-UN 24 Mechanical 159601-7020 B-3
108622-3951 HINO K13C-UN 24 Mechanical 159601-7021 B-3
108622-3960 HINO P11C-TC 24 105952-2561 A-4 159601-3621 B-4
108622-3961 HINO P11C-TC 24 105952-2561 A-4 159601-3622 B-4
108622-3962 HINO P11C-TC 24 105952-2561 A-4 159601-3622 B-4
108622-3963 HINO P11C-TC 24 105952-2562 A-4 159601-3622 B-4
108622-3964 HINO P11C-TC 24 105952-2562 A-4 159601-3622 B-4
108622-3970 HINO P11C-TD 24 105952-2560 A-4 159601-3621 B-4
108622-3971 HINO P11C-TD 24 105952-2561 A-4 159601-3621 B-4
108622-3972 HINO P11C-TD 24 105952-2561 A-4 159601-3622 B-4
108622-3973 HINO P11C-TD 24 105952-2561 A-4 159601-3622 B-4
108622-3974 HINO P11C-TD 24 105952-2562 A-4 159601-3622 B-4
108622-3975 HINO P11C-TD 24 105952-2562 A-4 159601-3622 B-4
108622-3990 HINO K-3 24 Mechanical 159590-7422 B-5
108622-8000 HINO P11C-TF 24 105952-2311 A-2 159601-6520 B-3
108622-8001 HINO P11C-TF 24 105952-2311 A-2 159601-6520 B-3
108622-8010 HINO P11C-TE 24 Mechanical 159600-2122 B-4
108622-8020 HINO P11C-UB 24 Mechanical 159640-2320 B-3
108622-8021 HINO P11C-UB 24 Mechanical 159640-2321 B-3
108622-8022 HINO P11C-UB 24 Mechanical 159640-2322 B-3
108622-8030 HINO P11C-TE 24 Mechanical 159640-2420 B-3
108622-8031 HINO P11C-TE 24 Mechanical 159640-2421 B-3
108622-8040 HINO P-3 24 Mechanical 159590-6621 B-6
108622-8050 HINO P-4 24 Mechanical 159590-6621 B-6
108622-8060 HINO P-3 24 Mechanical 159600-2122 B-4
108622-8070 HINO P-4 24 Mechanical 159600-2122 B-4
108622-8080 HINO K-3 24 Mechanical 159590-6821 B-6
108822-3007 HINO FT-2 24 Mechanical 159590-7120 B-9
108822-3008 HINO FT-2 24 Mechanical 159590-7121 B-9
108822-3014 HINO F20C-D 24 Mechanical 159590-7621 B-5
108822-3015 HINO F20C-D 24 Mechanical 159590-7622 B-5
108822-3030 HINO F-4 24 Mechanical 159600-1320 B-5
TICS PUMP PART NO. LIST
- 18 -
Pump assemblynumber Company Engine
modelVoltage
(V)Governor actuator Pre-stroke actuator
Part number Ref. no Part number Ref. no
• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
108822-3031 HINO F-4 24 Mechanical 159600-1321 B-5
108822-3032 HINO F-4 24 Mechanical 159600-1321 B-5
108822-3033 HINO F-4 24 Mechanical 159600-1321 B-5
108822-3034 HINO F-4 24 Mechanical 159600-1321 B-5
108822-3042 HINO F-4 24 Mechanical 159600-2820 B-5
108822-3043 HINO F-4 24 Mechanical 159600-2820 B-5
108822-3044 HINO F-4 24 Mechanical 159600-2820 B-5
108822-3045 HINO F-4 24 Mechanical 159600-2820 B-5
108822-3050 HINO FT-2 24 Mechanical 159600-3020 B-10
108822-3051 HINO FT-2 24 Mechanical 159600-3020 B-10
108822-3052 HINO FT-2 24 Mechanical 159600-3020 B-10
108822-3053 HINO FT-2 24 Mechanical 159600-3020 B-10
108822-3054 HINO FT-2 24 Mechanical 159600-3020 B-10
108822-3055 HINO FT-2 24 Mechanical 159600-3020 B-10
108822-3056 HINO FT-2 24 Mechanical 159600-3020 B-10
108822-3057 HINO FT-2 24 Mechanical 159600-3020 B-10
108822-3058 HINO FT-2 24 Mechanical 159600-3021 B-10
108822-3061 HINO F-4 24 Mechanical 159600-1321 B-5
108822-3062 HINO F-4 24 Mechanical 159600-1321 B-5
108822-3070 HINO F17D-TI 24 105952-1500 A-2 159600-3020 B-10
108822-3071 HINO F17D-TI 24 105952-1500 A-2 159600-3020 B-10
108822-3072 HINO F17D-TI 24 105952-1500 A-2 159600-3020 B-10
108822-3073 HINO F17D-TI 24 105952-1500 A-2 159600-3020 B-10
108822-3074 HINO F17D-TI 24 105952-2510 A-2 159600-3020 B-10
108822-3075 HINO F17D-TI 24 105952-2510 A-2 159600-3020 B-10
108822-3076 HINO F17D-TI 24 105952-2510 A-2 159600-3021 B-10
108822-3080 HINO F-4 24 Mechanical 159600-1321 B-5
108822-3081 HINO F-4 24 Mechanical 159600-1321 B-5
108822-3082 HINO F-4 24 Mechanical 159600-1322 B-5
108822-3092 HINO F-4 24 Mechanical 159600-1321 B-5
108822-3093 HINO F-4 24 Mechanical 159600-1321 B-5
108822-3102 HINO FT-1 24 Mechanical 159600-3020 B-10
108822-3103 HINO FT-1 24 Mechanical 159600-3020 B-10
108822-3104 HINO FT-1 24 Mechanical 159600-3020 B-10
108822-3105 HINO FT-1 24 Mechanical 159600-3020 B-10
108822-3114 HINO F-4 24 Mechanical 159600-2820 B-5
108822-3115 HINO F-4 24 Mechanical 159600-2820 B-5
108822-3116 HINO F-4 24 Mechanical 159600-2820 B-5
108822-3117 HINO F-4 24 Mechanical 159600-2820 B-5
108822-3118 HINO F-4 24 Mechanical 159600-2820 B-5
TICS PUMP PART NO. LIST
- 19 -
Pump assemblynumber Company Engine
modelVoltage
(V)Governor actuator Pre-stroke actuator
Part number Ref. no Part number Ref. no
• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
108822-3119 HINO F21C-B 24 Mechanical 159600-2820 B-5
108822-3120 HINO YJ07 24 Mechanical 159600-1321 B-5
108822-3121 HINO YJ07 24 Mechanical 159600-1321 B-5
108822-3122 HINO YJ07 24 Mechanical 159600-1321 B-5
108822-3123 HINO YJ07 24 Mechanical 159600-1321 B-5
108822-3130 HINO FT-1 24 Mechanical 159600-3020 B-10
108822-3131 HINO FT-1 24 Mechanical 159600-3020 B-10
108822-3132 HINO FT-1 24 Mechanical 159600-3020 B-10
108822-3133 HINO FT-1 24 Mechanical 159600-3021 B-10
108822-3140 HINO YJ43 24 Mechanical 159600-6320 B-5
108822-3141 HINO YJ43 24 Mechanical 159600-6320 B-5
108822-3142 HINO YJ43 24 Mechanical 159600-6321 B-5
108822-3150 HINO YJ46 24 Mechanical 159600-6720 B-11
108822-3151 HINO YJ46 24 Mechanical 159600-6720 B-11
108822-3152 HINO YJ46 24 Mechanical 159600-6721 B-11
108822-3160 HINO YJ46 24 105952-1850 A-2 159600-6720 B-11
108822-3161 HINO YJ46 24 105952-1850 A-2 159600-6721 B-11
108822-3170 HINO YJ47 24 Mechanical 159600-6720 B-11
108822-3171 HINO YJ47 24 Mechanical 159600-6720 B-11
108822-3172 HINO YJ47 24 Mechanical 159600-6721 B-11
108822-3180 HINO YJ47 24 105952-1850 A-2 159600-6720 B-11
108822-3181 HINO YJ47 24 105952-1850 A-2 159600-6721 B-11
108822-3190 HINO YJ43 24 105952-1880 A-2 159600-6920 B-5
108822-3191 HINO YJ43 24 105952-1880 A-2 159600-6920 B-5
108822-3192 HINO YJ43 24 105952-1881 A-2 159600-6920 B-5
108822-3193 HINO YJ43 24 105952-1881 A-2 159600-6921 B-5
108822-3206 HINO YJ43 24 Mechanical 159601-3922 B-4
108822-3210 HINO YJ43 24 Mechanical 159600-9020 B-5
108822-3211 HINO YJ43 24 Mechanical 159600-9020 B-5
108822-3212 HINO YJ43 24 Mechanical 159601-3920 B-4
108822-3213 HINO YJ43 24 Mechanical 159601-3921 B-4
108822-3214 HINO F-4 24 Mechanical 159601-3922 B-4
108822-3215 HINO F-4 24 Mechanical 159601-3922 B-4
108822-3220 HINO YJ43 24 105952-2210 A-4 159600-9720 B-12
108822-3221 HINO YJ43 24 105952-2212 A-4 159600-9720 B-12
108822-3222 HINO YJ43 24 105952-2213 A-4 159600-9721 B-12
108822-3223 HINO YJ43 24 105952-2213 A-4 159600-9721 B-12
108822-3224 HINO YJ43 24 105952-2213 A-4 159600-9722 B-12
108822-3225 HINO YJ43 24 105952-2214 A-4 159600-9722 B-12
108822-3226 HINO F21C-B 24 105952-2214 A-4 159600-9722 B-12
TICS PUMP PART NO. LIST
- 20 -
Pump assemblynumber Company Engine
modelVoltage
(V)Governor actuator Pre-stroke actuator
Part number Ref. no Part number Ref. no
• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
108822-3227 HINO F21C-B 24 105952-2214 A-4 159600-9723 B-12
108822-3228 HINO F21C-B 24 105952-2214 A-4 159600-9723 B-12
108822-3240 HINO YJ46 24 105952-2240 A-4 159601-0320 B-10
108822-3241 HINO YJ46 24 105952-2241 A-4 159601-0320 B-10
108822-3242 HINO YJ46 24 105952-2242 A-4 159601-0321 B-10
108822-3243 HINO YJ46 24 105952-2242 A-4 159601-0321 B-10
108822-3244 HINO YJ46 24 105952-2242 A-4 159601-0322 B-10
108822-3245 HINO YJ46 24 105952-2243 A-4 159601-0322 B-10
108822-3246 HINO F17D-TE 24 105952-2243 A-4 159601-0322 B-10
108822-3247 HINO F17D-TE 24 105952-2243 A-4 159601-0323 B-10
108822-3250 HINO YJ47 24 Mechanical 159601-0320 B-10
108822-3251 HINO YJ47 24 Mechanical 159601-0320 B-10
108822-3252 HINO YJ47 24 Mechanical 159601-0321 B-10
108822-3253 HINO YJ47 24 Mechanical 159601-0322 B-10
108822-3254 HINO YJ47 24 Mechanical 159601-0323 B-10
108822-3260 HINO YJ47 24 105952-2240 A-4 159601-0320 B-10
108822-3261 HINO YJ47 24 105952-2241 A-4 159601-0320 B-10
108822-3262 HINO YJ47 24 105952-2242 A-4 159601-0321 B-10
108822-3263 HINO YJ47 24 105952-2242 A-4 159601-0321 B-10
108822-3264 HINO YJ47 24 105952-2242 A-4 159601-0322 B-10
108822-3265 HINO YJ47 24 105952-2243 A-4 159601-0322 B-10
108822-3266 HINO F17D-TD 24 105952-2243 A-4 159601-0322 B-10
108822-3267 HINO F17D-TD 24 105952-2243 A-4 159601-0323 B-10
108822-3270 HINO YJ43 24 Mechanical 159600-2820 B-5
108822-3271 HINO YJ43 24 Mechanical 159601-4020 B-5
108822-3272 HINO YJ43 24 Mechanical 159601-4020 B-5
108822-3273 HINO F21C-B 24 Mechanical 159601-4020 B-5
108822-3274 HINO F21C-B 24 Mechanical 159601-4021 B-5
108822-3275 HINO F21C-B 24 Mechanical 159601-4021 B-5
108822-3280 HINO F21C-C 24 105960-0120 - 159640-0620 B-14
108822-3281 HINO F21C-C 24 105960-0121 - 159640-0620 B-14
108822-3282 HINO F21C-C 24 105960-0121 - 159640-0620 B-14
108822-3283 HINO F21C-C 24 105960-0121 - 159640-0620 B-14
108822-3284 HINO F21C-C 24 105960-0122 - 159640-0620 B-14
108822-3285 HINO F21C-C 24 105960-0123 - 159640-0620 B-14
108822-3286 HINO F21C-C 24 105960-0350 - 159640-0621 B-14
108822-3287 HINO F21C-C 24 105960-0350 - 159640-0621 B-14
108822-3288 HINO F21C-C 24 105960-0350 - 159640-0621 B-14
108822-3290 HINO F21C-D 24 105960-0120 - 159640-0620 B-14
108822-3291 HINO F21C-D 24 105960-0121 - 159640-0620 B-14
TICS PUMP PART NO. LIST
- 21 -
Pump assemblynumber Company Engine
modelVoltage
(V)Governor actuator Pre-stroke actuator
Part number Ref. no Part number Ref. no
• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
108822-3292 HINO F21C-D 24 105960-0121 - 159640-0620 B-14
108822-3293 HINO F21C-D 24 105960-0121 - 159640-0620 B-14
108822-3294 HINO F21C-D 24 105960-0122 - 159640-0620 B-14
108822-3295 HINO F21C-D 24 105960-0123 - 159640-0620 B-14
108822-3296 HINO F21C-D 24 105960-0350 - 159640-0621 B-14
108822-3297 HINO F21C-D 24 105960-0350 - 159640-0621 B-14
108822-3298 HINO F21C-D 24 105960-0350 - 159640-0621 B-14
108822-3300 HINO F21C-E 24 105960-0120 - 159640-0620 B-14
108822-3301 HINO F21C-E 24 105960-0120 - 159640-0620 B-14
108822-3302 HINO F21C-E 24 105960-0121 - 159640-0620 B-14
108822-3303 HINO F21C-E 24 105960-0121 - 159640-0620 B-14
108822-3304 HINO F21C-E 24 105960-0122 - 159640-0620 B-14
108822-3305 HINO F21C-E 24 105960-0123 - 159640-0620 B-14
108822-3306 HINO F21C-E 24 105960-0350 - 159640-0621 B-14
108822-3307 HINO F21C-E 24 105960-0350 - 159640-0621 B-14
108822-3308 HINO F21C-E 24 105960-0350 - 159640-0621 B-14
108822-3310 HINO F21C-C 24 105960-0250 - 159640-1620 B-14
108822-3311 HINO F21C-C 24 105960-0251 - 159640-1620 B-14
108822-3312 HINO F21C-C 24 105960-0252 - 159640-1620 B-14
108822-3313 HINO F21C-C 24 105960-0252 - 159640-1621 B-14
108822-3314 HINO F21C-C 24 105960-0252 - 159640-1622 B-14
108822-3315 HINO F21C-C 24 105960-0252 - 159640-1622 B-14
108822-3320 HINO F21C-F 24 Mechanical 159601-3922 B-4
108822-3321 HINO F12C-F 24 Mechanical 159601-3922 B-4
108822-3322 HINO F12C-F 24 Mechanical 159601-7620 B-12
108822-3323 HINO F12C-F 24 Mechanical 159601-7621 B-12
108922-3001 HINO V-4 24 Mechanical 159600-2720 B-10
108922-3002 HINO V-4 24 Mechanical 159600-2720 B-10
108922-3003 HINO V-4 24 Mechanical 159600-2721 B-10
108922-3004 HINO V-4 24 Mechanical 159600-2721 B-10
108922-3005 HINO V-4 24 Mechanical 159600-2722 B-10
108922-3006 HINO V-4 24 Mechanical 159600-2722 B-10
108922-3010 HINO V-4 24 Mechanical 159600-2720 B-10
108922-3011 HINO V-4 24 Mechanical 159600-2720 B-10
108922-3012 HINO V-4 24 Mechanical 159600-2720 B-10
108922-3013 HINO V-4 24 Mechanical 159600-2721 B-10
108922-3014 HINO V-4 24 Mechanical 159600-2721 B-10
108922-3015 HINO V-4 24 Mechanical 159600-2722 B-10
108922-3016 HINO V-4 24 Mechanical 159600-2722 B-10
108922-3017 HINO V-4 24 Mechanical 159600-2723 B-10
TICS PUMP PART NO. LIST
- 22 -
Pump assemblynumber Company Engine
modelVoltage
(V)Governor actuator Pre-stroke actuator
Part number Ref. no Part number Ref. no
• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
108922-3020 HINO V-4 24 105952-1700 A-3 159600-6020 B-10
108922-3021 HINO V-4 24 105952-1701 A-3 159600-6020 B-10
108922-3022 HINO V-4 24 105952-1702 A-3 159600-6020 B-10
108922-3023 HINO V-4 24 105952-1703 A-3 159600-6020 B-10
108922-3024 HINO V-4 24 105952-1703 A-3 159600-6020 B-10
108922-3025 HINO V-4 24 105952-1704 A-3 159600-6020 B-10
108922-3026 HINO V-4 24 105952-1705 A-3 159600-6020 B-10
108922-3027 HINO V-4 24 105952-1706 A-3 159600-6021 B-10
108922-3028 HINO V-4 24 105952-1706 A-3 159600-6021 B-10
108922-3050 HINO YJ45 24 Mechanical 159601-0120 B-10
108922-3051 HINO YJ45 24 Mechanical 159601-0120 B-10
108922-3052 HINO YJ45 24 Mechanical 159601-0121 B-10
108922-3053 HINO YJ45 24 Mechanical 159601-0122 B-10
108922-3054 HINO YJ45 24 Mechanical 159601-0122 B-10
108922-3060 HINO YJ45 24 105952-2220 A-3 159601-0220 B-10
108922-3061 HINO YJ45 24 105952-2330 A-3 159601-0220 B-10
108922-3062 HINO V26C-B 24 105952-2330 A-3 159601-0220 B-10
108922-3063 HINO V26C-B 24 105952-2330 A-3 159601-0221 B-10
108922-3064 HINO V26C-B 24 105952-2330 A-3 159601-0221 B-10
108922-3065 HINO V26C-B 24 105952-2330 A-3 159601-0222 B-10
108922-3066 HINO V26C-B 24 105952-2330 A-3 159601-0222 B-10
GOVERNOR ACTUATOR
- 23 -• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
Speed sensor
A-1
REDIII P/No.105952-080*105952-097*
11 GND 23 GND 17 SLD 1
12 MDL 2
4 MDL 1
18.0 ~ 21.0 Ω
13.5 ~ 15.5 Ω14 OSC 2
6 OSC 18 SLD 2
10 ACT 1 (-)2 ACT 1 (-)
1 ACT 2 (+)9 ACT 2 (+)
13 SLD 315 GND
16 SIG
9.0 ~ 9.8 Ω
2.1 ~ 2.5 kΩ
1234
678
9101112
14 131516
No. Signal name Color
1 Actuator (+) R
2 Actuator (-) W
3 Rack sensor (GND) G
4 Rack sensor (MDL) B
6 Rack sensor (OSC) Y
7 Shield 1 (MDL) BR
8 Shield 2 (OSC, GND) BW
9 Actuator (+) R
10 Actuator (-) W
11 Rack sensor (GND) G
12 Rack sensor (MDL) B
13 Shield 3 (SIG, GND) BY
14 Rack sensor (OSC) Y
15 Speed sensor (GND) Br
16 Speed sensor (SIG) O
Terminal Resistance (Ω) Actual value
1 - 2 9.0 ~ 9.8 Ω
1 - 10 9.0 ~ 9.8 Ω
2 - 9 9.0 ~ 9.8 Ω
9 - 10 9.0 ~ 9.8 Ω
3 - 6 31.5 ~ 36.5 Ω
3 - 14 31.5 ~ 36.5 Ω
6 - 11 31.5 ~ 36.5 Ω
11 - 14 31.5 ~ 36.5 Ω
3 - 4 18.0 ~ 21.0 Ω
3 - 12 18.0 ~ 21.0 Ω
Terminal Resistance (Ω) Actual value
4 - 11 18.0 ~ 21.0 Ω
11 - 12 18.0 ~ 21.0 Ω
4 - 6 13.5 ~ 15.5 Ω
4 - 14 13.5 ~ 15.5 Ω
6 - 12 13.5 ~ 15.5 Ω
12 - 14 13.5 ~ 15.5 Ω
15 - 16 2.1 ~ 2.5k kΩ
Insulation resistance
Terminal~ hous.
Above 10MΩ(At DC250V)
MΩ
Rack sensor
Actuator
GOVERNOR ACTUATOR
- 24 -• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
A-2
REDIII P/No.105952-150*105952-173*105952-184*105952-185*105952-188*105952-217*105952-225*105952-231*105952-232*105952-236*105952-249*105952-251*105952-281*105956-001*105956-002*105956-004*
7 6
4
5 3
2 1
9101112
14 131516
Speed sensor
11 GND 23 GND 16 SLD 1
12 MDL 2
4 MDL 1
18.0 ~ 21.0 Ω
13.5 ~ 15.5 Ω14 OSC 2
5 OSC 17 SLD 2
10 ACT 1 (-)2 ACT 1 (-)
1 ACT 2 (+)9 ACT 2 (+)
13 SLD 315 GND
16 SIG
9.0 ~ 9.8 Ω
2.1 ~ 2.5 kΩ
No. Signal name Color
1 Actuator (+) R
2 Actuator (-) W
3 Rack sensor (GND) G
4 Rack sensor (MDL) B
5 Rack sensor (OSC) Y
6 Shield 1 (MDL) BR
7 Shield 2 (OSC, GND) BW
9 Actuator (+) R
10 Actuator (-) W
11 Rack sensor (GND) G
12 Rack sensor (MDL) B
13 Shield 3 (SIG, GND) BY
14 Rack sensor (OSC) Y
15 Speed sensor (GND) Br
16 Speed sensor (SIG) O
Terminal Resistance (Ω) Actual value
1 - 2 9.0 ~ 9.8 Ω
1 - 10 9.0 ~ 9.8 Ω
2 - 9 9.0 ~ 9.8 Ω
9 - 10 9.0 ~ 9.8 Ω
3 - 5 31.5 ~ 36.5 Ω
3 - 14 31.5 ~ 36.5 Ω
5 - 11 31.5 ~ 36.5 Ω
11 - 14 31.5 ~ 36.5 Ω
3 - 4 18.0 ~ 21.0 Ω
3 - 12 18.0 ~ 21.0 Ω
Terminal Resistance (Ω) Actual value
4 - 11 18.0 ~ 21.0 Ω
11 - 12 18.0 ~ 21.0 Ω
4 - 5 13.5 ~ 15.5 Ω
4 - 14 13.5 ~ 15.5 Ω
5 - 12 13.5 ~ 15.5 Ω
12 - 14 13.5 ~ 15.5 Ω
15 - 16 2.1 ~ 2.5k kΩ
Insulation resistance
Terminal~ hous.
Above 10MΩ(At DC250V)
MΩ
Rack sensor
Actuator
GOVERNOR ACTUATOR
- 25 -• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
A-3
REDIII P/No.105952-170*105952-222*105952-233*
7 6
4
5 3
2 1
9101112
141516
Speed sensor
11 GND 23 GND 16 SLD 1
12 MDL 2
4 MDL 1
18.0 ~ 21.0 Ω
13.5 ~ 15.5 Ω14 OSC 2
5 OSC 17 SLD 2
10 ACT 1 (-)2 ACT 1 (-)
1 ACT 2 (+)9 ACT 2 (+)
SLD 315 GND
16 SIG
9.0 ~ 9.8 Ω
2.1 ~ 2.5 kΩ
No. Signal name Color
1 Actuator (+) R
2 Actuator (-) W
3 Rack sensor (GND) G
4 Rack sensor (MDL) B
5 Rack sensor (OSC) Y
6 Shield 1 (MDL) BR
7 Shield 2 (OSC, GND) BW
9 Actuator (+) R
10 Actuator (-) W
11 Rack sensor (GND) G
12 Rack sensor (MDL) B
14 Rack sensor (OSC) Y
15 Speed sensor (GND) Br
16 Speed sensor (SIG) O
Terminal Resistance (Ω) Actual value
1 - 2 9.0 ~ 9.8 Ω
1 - 10 9.0 ~ 9.8 Ω
2 - 9 9.0 ~ 9.8 Ω
9 - 10 9.0 ~ 9.8 Ω
3 - 5 31.5 ~ 36.5 Ω
3 - 14 31.5 ~ 36.5 Ω
5 - 11 31.5 ~ 36.5 Ω
11 - 14 31.5 ~ 36.5 Ω
3 - 4 18.0 ~ 21.0 Ω
3 - 12 18.0 ~ 21.0 Ω
Terminal Resistance (Ω) Actual value
4 - 11 18.0 ~ 21.0 Ω
11 - 12 18.0 ~ 21.0 Ω
4 - 5 13.5 ~ 15.5 Ω
4 - 14 13.5 ~ 15.5 Ω
5 - 12 13.5 ~ 15.5 Ω
12 - 14 13.5 ~ 15.5 Ω
15 - 16 2.1 ~ 2.5k kΩ
Insulation resistance
Terminal~ hous.
Above 10MΩ(At DC250V)
MΩ
Rack sensor
Actuator
GOVERNOR ACTUATOR
- 26 -• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
A-4
REDIII P/No.105952-198*105952-208*105952-211*105952-221*105952-224*105952-228*105952-234*105952-242*105952-250*105952-253*105952-256*105952-257* 7 6
4
5 3
2 1
891011
13
17 16
18
Speed sensor
10 GND 23 GND 16 SLD 1
11 MDL 2
4 MDL 1
18.0 ~ 21.0 Ω
13.5 ~ 15.5 Ω13 OSC 2
5 OSC 17 SLD 2
9 ACT 1 (-)2 ACT 1 (-)
1 ACT 2 (+)8 ACT 2 (+)
18 SLD 317 GND
16 SIG
9.0 ~ 9.8 Ω
2.1 ~ 2.5 kΩ
No. Signal name Color
1 Actuator (+) R
2 Actuator (-) W
3 Rack sensor (GND) G
4 Rack sensor (MDL) B
5 Rack sensor (OSC) Y
6 Shield 1 (MDL) BR
7 Shield 2 (OSC, GND) BW
8 Actuator (+) R
9 Actuator (-) W
10 Rack sensor (GND) G
11 Rack sensor (MDL) B
13 Rack sensor (OSC) Y
16 Speed sensor (SIG) O
17 Speed sensor (GND) Br
18 Shield 3 (SIG, GND) BY
Terminal Resistance (Ω) Actual value
1 - 2 9.0 ~ 9.8 Ω
1 - 9 9.0 ~ 9.8 Ω
2 - 8 9.0 ~ 9.8 Ω
8 - 9 9.0 ~ 9.8 Ω
3 - 5 31.5 ~ 36.5 Ω
3 - 13 31.5 ~ 36.5 Ω
5 - 10 31.5 ~ 36.5 Ω
10 - 13 31.5 ~ 36.5 Ω
3 - 4 18.0 ~ 21.0 Ω
3 - 11 18.0 ~ 21.0 Ω
Terminal Resistance (Ω) Actual value
4 - 10 18.0 ~ 21.0 Ω
10 - 11 18.0 ~ 21.0 Ω
4 - 5 13.5 ~ 15.5 Ω
4 - 13 13.5 ~ 15.5 Ω
5 - 11 13.5 ~ 15.5 Ω
11 - 13 13.5 ~ 15.5 Ω
16 - 17 2.1 ~ 2.5k kΩ
Insulation resistance
Terminal~ hous.
Above 10MΩ(At DC250V)
MΩ
Rack sensor
Actuator
PRE-STROKE ACTUATOR
- 27 -• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
B-1
Ps act. P/No.159600-062*159600-112*
B-2
Ps act. P/No.159600-122*159600-702*159600-722*159601-442*
2134
6 5
2134
6 5
No. Signal name Color
1 Actuator (+) G
2 Actuator (-) Y
3 Pre-stroke sensor (GND) B
4 Pre-stroke sensor (MDL) W
5 Shield BW
6 Pre-stroke sensor (OSC) L
Terminal Resistance (Ω) Actual value
1 - 2 0.9 ~ 1.3 Ω
3 - 4 5.5 ~ 6.1 Ω
4 - 6 5.5 ~ 6.1 Ω
Insulation resistance
Terminal~ hous.
Above 10MΩ(At DC500V)
MΩ
0.9 ~ 1.3Ω
5.5 ~ 6.1Ω
5.5 ~ 6.1Ω
2
1
5
3
4
6 OSC
MDLSLD
GNDACT (+)
ACT (-)
No. Signal name Color
1 Actuator (-) G
2 Actuator (+) Y
3 Pre-stroke sensor (GND) B
4 Pre-stroke sensor (MDL) W
5 Shield BW
6 Pre-stroke sensor (OSC) L
Terminal Resistance (Ω) Actual value
1 - 2 0.9 ~ 1.3 Ω
3 - 4 5.5 ~ 6.1 Ω
4 - 6 5.5 ~ 6.1 Ω
Insulation resistance
Terminal~ hous.
Above 10MΩ(At DC500V)
MΩ
0.9 ~ 1.3Ω
5.5 ~ 6.1Ω
5.5 ~ 6.1Ω
1
2
5
3
4
6 OSC
MDLSLD
GNDACT (+)
ACT (-)
PRE-STROKE ACTUATOR
- 28 -• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
B-3
Ps act. P/No.159590-872*159600-962*159601-172*159601-342*159601-352*159601-512*159601-592*159601-652*159601-702*159601-712*159640-232*159640-242*159645-082*159645-102*159645-122*159645-232*159645-302*159645-412*159645-422*159645-432*159645-442*159645-452*159645-462*159645-482*
B-4
Ps act. P/No.159600-212*159600-222*159600-242*159600-422*159600-622*159600-652*159600-682*159600-812*159600-882*159600-892*159600-912*159601-002*159601-102*159601-252*159601-362*159601-382*159601-392*159601-452*159601-672*159601-692*159601-742*159645-032*
5
2
4
1
6
3
2134
6 5
No. Signal name Color
1 Actuator (+) Y
2 Actuator (-) G
3 Pre-stroke sensor (GND) B
4 Pre-stroke sensor (MDL) W
5 Shield BW
6 Pre-stroke sensor (OSC) L
Terminal Resistance (Ω) Actual value
1 - 2 2.45 ~ 2.95 Ω
3 - 4 5.5 ~ 6.1 Ω
4 - 6 5.5 ~ 6.1 Ω
Insulation resistance
Terminal~ hous.
Above 10MΩ(At DC500V)
MΩ
No. Signal name Color
1 Actuator (-) G
2 Actuator (+) Y
3 Pre-stroke sensor (GND) B
4 Pre-stroke sensor (MDL) W
5 Shield BW
6 Pre-stroke sensor (OSC) L
Terminal Resistance (Ω) Actual value
1 - 2 2.45 ~ 2.95 Ω
3 - 4 5.5 ~ 6.1 Ω
4 - 6 5.5 ~ 6.1 Ω
Insulation resistance
Terminal~ hous.
Above 10MΩ(At DC500V)
MΩ
2.45 ~ 2.95Ω
5.5 ~ 6.1Ω
5.5 ~ 6.1Ω
2
1
5
3
4
6 OSC
MDLSLD
GNDACT (+)
ACT (-)
2.45 ~ 2.95Ω
5.5 ~ 6.1Ω
5.5 ~ 6.1Ω
1
2
5
3
4
6 OSC
MDLSLD
GNDACT (+)
ACT (-)
PRE-STROKE ACTUATOR
- 29 -• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
B-5
Ps act. P/No.159590-742*159590-762*159600-132*159600-142*159600-192*159600-232*159600-282*159600-312*159600-592*159600-632*159600-692*159600-902*159601-402*159601-782*
B-6
Ps act. P/No.159590-662*159590-682*159590-702*
2134
6 5
4
2 1 3
6
No. Signal name Color
1 Actuator (+) G
2 Actuator (-) Y
3 Pre-stroke sensor (GND) B
4 Pre-stroke sensor (MDL) W
5 Shield BW
6 Pre-stroke sensor (OSC) L
Terminal Resistance (Ω) Actual value
1 - 2 2.45 ~ 2.95 Ω
3 - 4 5.5 ~ 6.1 Ω
4 - 6 5.5 ~ 6.1 Ω
Insulation resistance
Terminal~ hous.
Above 10MΩ(At DC500V)
MΩ
No. Signal name Color
1 Actuator (+) L
2 Actuator (-) W
3 Pre-stroke sensor (GND) B
4 Pre-stroke sensor (MDL) G
6 Pre-stroke sensor (OSC) Y
Terminal Resistance (Ω) Actual value
1 - 2 2.45 ~ 2.95 Ω
3 - 4 5.5 ~ 6.1 Ω
4 - 6 5.5 ~ 6.1 Ω
Insulation resistance
Terminal~ hous.
Above 10MΩ(At DC500V)
MΩ
2.45 ~ 2.95Ω
5.5 ~ 6.1Ω
5.5 ~ 6.1Ω
2
1
5
3
4
6 OSC
MDLSLD
GNDACT (+)
ACT (-)
2.45 ~ 2.95Ω
5.5 ~ 6.1Ω
5.5 ~ 6.1Ω
2
13
4
6 OSC
MDLSLD
GNDACT (+)
ACT (-)
PRE-STROKE ACTUATOR
- 30 -• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
B-7
Ps act. P/No.159590-672*
B-8
Ps act. P/No.159600-202*
4
2 1 3
6
2134
6 5
No. Signal name Color
1 Actuator (+) Y
2 Actuator (-) G
3 Pre-stroke sensor (GND) B
4 Pre-stroke sensor (MDL) W
6 Pre-stroke sensor (OSC) L
Terminal Resistance (Ω) Actual value
1 - 2 2.45 ~ 2.95 Ω
3 - 4 5.5 ~ 6.1 Ω
4 - 6 5.5 ~ 6.1 Ω
Insulation resistance
Terminal~ hous.
Above 10MΩ(At DC500V)
MΩ
No. Signal name Color
1 Actuator (+) Y
2 Actuator (-) G
3 Pre-stroke sensor (GND) B
4 Pre-stroke sensor (MDL) W
5 Shield BW
6 Pre-stroke sensor (OSC) L
Terminal Resistance (Ω) Actual value
1 - 2 2.45 ~ 2.95 Ω
3 - 4 5.5 ~ 6.1 Ω
4 - 6 5.5 ~ 6.1 Ω
Insulation resistance
Terminal~ hous.
Above 10MΩ(At DC500V)
MΩ
2.45 ~ 2.95Ω
5.5 ~ 6.1Ω
5.5 ~ 6.1Ω
2
13
4
6 OSC
MDLSLD
GNDACT (+)
ACT (-)
2.45 ~ 2.95Ω
5.5 ~ 6.1Ω
5.5 ~ 6.1Ω
2
1
5
3
4
6 OSC
MDLSLD
GNDACT (+)
ACT (-)
PRE-STROKE ACTUATOR
- 31 -• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
B-9
Ps act. P/No.159590-712*
B-10
Ps act. P/No.159600-272*159600-302*159600-602*159601-012*159601-022*159601-032*
1234
6 5
1234
6 5
No. Signal name Color
1 Actuator (+) G
2 Actuator (-) Y
3 Pre-stroke sensor (GND) B
4 Pre-stroke sensor (MDL) W
5 Shield BW
6 Pre-stroke sensor (OSC) L
Terminal Resistance (Ω) Actual value
1 - 2 2.45 ~ 2.95 Ω
3 - 4 5.5 ~ 6.1 Ω
4 - 6 5.5 ~ 6.1 Ω
Insulation resistance
Terminal~ hous.
Above 10MΩ(At DC500V)
MΩ
No. Signal name Color
1 Actuator (-) G
2 Actuator (+) Y
3 Pre-stroke sensor (GND) B
4 Pre-stroke sensor (MDL) W
5 Shield BW
6 Pre-stroke sensor (OSC) L
Terminal Resistance (Ω) Actual value
1 - 2 2.45 ~ 2.95 Ω
3 - 4 5.5 ~ 6.1 Ω
4 - 6 5.5 ~ 6.1 Ω
Insulation resistance
Terminal~ hous.
Above 10MΩ(At DC500V)
MΩ
2.45 ~ 2.95Ω
5.5 ~ 6.1Ω
5.5 ~ 6.1Ω
2
1
5
3
4
6 OSC
MDLSLD
GNDACT (+)
ACT (-)
2.45 ~ 2.95Ω
5.5 ~ 6.1Ω
5.5 ~ 6.1Ω
1
2
5
3
4
6 OSC
MDLSLD
GNDACT (+)
ACT (-)
PRE-STROKE ACTUATOR
- 32 -• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
B-11
Ps act. P/No.159600-672*
B-12
Ps act. P/No.159600-972*159601-302*159601-762*
1234
6 5
2134
6 5
No. Signal name Color
1 Actuator (+) Y
2 Actuator (-) G
3 Pre-stroke sensor (GND) B
4 Pre-stroke sensor (MDL) W
5 Shield BW
6 Pre-stroke sensor (OSC) L
Terminal Resistance (Ω) Actual value
1 - 2 2.45 ~ 2.95 Ω
3 - 4 5.5 ~ 6.1 Ω
4 - 6 5.5 ~ 6.1 Ω
Insulation resistance
Terminal~ hous.
Above 10MΩ(At DC500V)
MΩ
No. Signal name Color
1 Actuator (-) Y
2 Actuator (+) G
3 Pre-stroke sensor (GND) B
4 Pre-stroke sensor (MDL) W
5 Shield BW
6 Pre-stroke sensor (OSC) L
Terminal Resistance (Ω) Actual value
1 - 2 2.45 ~ 2.95 Ω
3 - 4 5.5 ~ 6.1 Ω
4 - 6 5.5 ~ 6.1 Ω
Insulation resistance
Terminal~ hous.
Above 10MΩ(At DC500V)
MΩ
2.45 ~ 2.95Ω
5.5 ~ 6.1Ω
5.5 ~ 6.1Ω
2
1
5
3
4
6 OSC
MDLSLD
GNDACT (+)
ACT (-)
2.45 ~ 2.95Ω
5.5 ~ 6.1Ω
5.5 ~ 6.1Ω
1
2
5
3
4
6 OSC
MDLSLD
GNDACT (+)
ACT (-)
PRE-STROKE ACTUATOR
- 33 -• Confi dential • Bosch Corporation Automotive Aftermarket Division • Date: 30 July 2005
B-13
Ps act. P/No.159601-662*
B-14
Ps act. P/No.159640-062*159640-162*
5
2
4
1
6
3
5
1
4
2
6
3
No. Signal name Color
1 Actuator (-) G
2 Actuator (+) Y
3 Pre-stroke sensor (GND) B
4 Pre-stroke sensor (MDL) W
5 Shield BW
6 Pre-stroke sensor (OSC) L
Terminal Resistance (Ω) Actual value
1 - 2 2.45 ~ 2.95 Ω
3 - 4 5.5 ~ 6.1 Ω
4 - 6 5.5 ~ 6.1 Ω
Insulation resistance
Terminal~ hous.
Above 10MΩ(At DC500V)
MΩ
No. Signal name Color
1 Actuator (-) G
2 Actuator (+) Y
3 Pre-stroke sensor (GND) B
4 Pre-stroke sensor (MDL) W
5 Shield BW
6 Pre-stroke sensor (OSC) L
Terminal Resistance (Ω) Actual value
1 - 2 2.45 ~ 2.95 Ω
3 - 4 5.5 ~ 6.1 Ω
4 - 6 5.5 ~ 6.1 Ω
Insulation resistance
Terminal~ hous.
Above 10MΩ(At DC500V)
MΩ
2.45 ~ 2.95Ω
5.5 ~ 6.1Ω
5.5 ~ 6.1Ω
1
2
5
3
4
6 OSC
MDLSLD
GNDACT (+)
ACT (-)
2.45 ~ 2.95Ω
5.5 ~ 6.1Ω
5.5 ~ 6.1Ω
1
2
5
3
4
6 OSC
MDLSLD
GNDACT (+)
ACT (-)
