-
ITEM PART NO.Default -
Top Level/QTY.
DESCRIPTION
1 000-6207 2 END CAP2 000-6244 1 ISIS TRUVATIV 118MM X 160MM BB3
000-6264 1 SEAT, MED WIDTH4 000-6324 1 CRANK ARM LEFT HAND5
001-0391 1 CRANK ARM RIGHT HAND6 001-0424 1 WATER BOTTLE HOLDER7
001-0458 1 DECAL, WARNING, U/R9168 001-6347 1 KEYPANEL, OVERLAY,
RIGHT9 001-6365 2 DISC, CRANK10 01-4034 2 BOLT BH , 8-32 x 1''
ZINC11 01-4036 2 BOLT BH , 3/8 -16 x '' ZINC12 01-4048 1 BOLT BH ,
3/8 -16 x ''13 01-4064 2 BOLT BH 3/8-16 X 2" ZINC14 01-4094 1 BOLT
BH, 5/16 -18 UNC x 2'' - ZINC15 01-4113 2 Button HD Joint
Connector, 3/8-16 X 1.0616 01-4126 2 BOLT BH , -20 x '' SS BLACK17
02-3021 2 SCREW SHCS , 10-32 UNC x 18 02-3058 4 SCREW #8-32 X 1
PHIL PAN HEAD ZINC19 02-3062 8 #6 -32 UNC THREAD x 1" OVAL HEAD
PHILLIPS M/S _SS-BLACK OXIDE20 02-4130 2 SCREW, SET, -20 UNC x 21
02-4174 4 SCREW SHCS , -20 UNC x Zinc22 02-4177 4 SCREW SHCS , 3/8
-16 UNC x 1 Zinc23 02-9305 3 M5 X 0.8 X 16M Philipps Pan Head
Screw24 02-9306 3 M5 X 0.8 X 80M Philipps Pan Head Screw25 02-9307
4 SCREW, M6-1.0 X 20mm L, SHCS, STAINLESS26 03-1035 2 3/8" Lock
Nut27 03-3043 1 5/16" Lock Nut28 03-4031 6 8-32 INSERT HEX29
03-4034 10 10-32 INSERT HEX30 03-4036 8 RIVNUT 10-32 NF,
.125-.22531 03-9080 1 M8-1.0 Hex Fin Jam Nut32 04-2021 1 WASHER,
FLAT, 3/8" USS33 05-5130 2 IGUS FLANGE .5 ID x .5938 OD x .25L 34
05-5146 3 EB-TENSIONER BRACKET MOUNT BUSHING35 07-1156 2 6204-2z
Ball Bearing Double Sealed36 08-5186 1 SPACER NYLON 5/8 DIA X 1/2
L37 09-8080 1 TYRAP, .14 X 11.038 10-4040 1 LeeSpring-LHL750A 0739
12-1151 2 DECAL SEAT ADJUSTMENT 1-13 R1040 12-1380 1 Made In USA41
12-1822 1 Honix Console Decal42 12-5621 2 NLS ONE 3 Dome Decal
(000-6491)43 12-6180 1 Decal, Parts Diagram Schematic U1044 12-6304
1 DECAL, U10 "E-BRAKE TECHNOLOGY" LEFT45 12-6305 1 DECAL, U10
"E-BRAKE TECHNOLOGY" RIGHT46 12-6308 1 Membrane Switch Overlay for
Honix Display47 12-7500 1 MPale Antimicrobial Label48 12-7501 1
Caution 15V and 4A49 12-8005 1 DECAL SEAT ADJUSTMENT 1-4 U1050
19-1013 1 TAPE DBL SIDED 2 3/4" WIDE51 19-1043 1 U10 Quick Assembly
Instructions (Hardcopy Printed)52 19-6000 1 DVD Technical
Documentation53 27592 3 WASHER, M8, SPLIT LOCK54 40654 28 SCREW,
#10-32 X .75, PAN HEAD, W/LOCK WASHER55 56-0584 2 Wheel (56-0580
Drilled Out to .641 ID)56 56-0585 2 Wheel Sleeve (for 56-0584)57
56-0587 1 SPRING GAS LOCKING IN COMPRESSION 100N58 57-0350 1 Power
Adaptor, 15VDC, 4A59 57-0355 1 BATTERY 12V 1.3 Ah60 57-0373 1
PULLEY 8 GROOVE 11 3/4" DIA61 57-0376 1 DC BLOWER FAN ASSEMBLY62
57-0388 1 Seat Slide Cap 1 x 3 Rect63 57-0389 1 Seat Slide guide 1
x 3 Rect64 57-0391 2 BUSHING SEAT SHOCK MOUNT65 57-0465 1 H10
Console ATSC DOM TV KIT 10"66 57-0469 1 CABLE POWER INPUT E10,
U1067 57-0478 1 Assembly Cable Contact Heart Rate68 57-0479 1 BELT
J Groove 8 Rib 63" / Drive belt U1069 57-0482 1 Eddy Brake/Gen with
clutch (FB62HA21)
ITEM PART NO.Default -
Top Level/QTY.
DESCRIPTION
70 57-0485 1 Lower Control Board, BLCB01171 57-0487 1 BRACKET
POWER INLET72 57-0497 4 SPACER, #10 SCREW, 5/16"73 57-0507 1 Board
Interface to Lower Control74 57-0511 1 EB-COMPRESSION SPRING
RETAINING BRACKET75 57-0536 1 TV Cable Assembly, E/U/R 10 Series76
57-0537 1 CABLE ASSY, T-BAR GRIP TO CONSOLE, RoHS77 57-0538 1
ASSEMBLY FAN INPUT POWER CABLE R10, U1078 57-0541 1 U10 MAIN
SHROUD, LEFT79 57-0542 1 U10 MAIN SHROUD, RIGHT80 57-0545 2 GRIP
CHR /ROC TOP ASSEMBLY81 57-0546 2 GRIP CHR TOP ASSEMBLY82 57-0547 4
GRIP CHR BOTTOM ASSEMBLY83 57-0554 1 CABLE, Console to LCB, R10,
U1084 57-0555 1 INLET COVER U10 BLACK85 57-0557 1 Mast Shield Right
Side86 57-0562 1 CABLE, Intermediate Board to BCLB002, E10, U10,
R1087 57-0563 1 CABLE, Intermediate Board to BCLB00288 57-0566 1
SEAT LOCKING HEX NUT89 57-0567 1 SEAT LOCKING STOP PLATE90 57-0568
1 NYLON SEAT LOCK91 57-0574 1 Handle with 3/8"-16 Threaded Stud92
57-0608 1 I-POD MOUNT93 57-0611 1 Pocket, Peel & Stick, Cardio
Schematic94 70-1208 1 ASSEMBLY, FRAME U10 BIKE95 71-1203 1 Weldment
Front Display Mast U10 Bike96 72-1213 1 Weldment Seat Handle97
73-1206 1 EB BELT COMPRESSION SPRING TENSIONER98 75-1205 1 Weldment
Seat Adjustment Vertical99 75-1207 1 SEAT MOUNT SLIDE ASSEMBLY
100 75-1208 1 Seat Slide Housing Bracket101 899-0004 1 DECAL
SERIAL/COMPLIANCE U9/U10102 901-5496 2 SCW-PHP #10-32x1.25 SS103
902-4707 4 SCREW SHCS, M6-1.0 X 10, SHCS, BLACK, EPOXY104 902-5681
7 SCW-SHCS M8-1.25x25 SS105 91-999 1 Paint (1.5 lbs)106 95-0614 L 1
PEDAL EXERCISER JD-48-A 9-16 LEFT107 95-0614 R 1 PEDAL EXERCISER
JD48-A 9/16 RIGHT108 95-9004 1 Packaging Kit Estimate U10109
SM000-6218 1 ASSEMBLY, HANDLEBAR110 SM001-6348 1 KEYPANEL, OVERLAY,
LEFT111 SM002-0540 2 PCB, CHR INTER-CONNECT112 SM13180 4 CAP,
LEVELING SUPPORT113 SM17686 4 PAD, LEVELING114 SM17787 2 CONNECTOR,
RF, 3MM, F115 SM21607 2 TAPE, DOUBLE SIDED, FOAM116 SM22214 1
WASHER, FLAT, 5/16" SAE ROHS117 SM27579 4 WASHER, M6, FLAT, ZINC
PLATED118 SM40235 1 FASTENER, HOOK119 SM40236 1 FASTENER, HOOK120
SM41269 2 Grommet, 2879, 7/8" ID
U10U10 Upright Bike
All labeled components are to be assembled 1. before shipment
unless otherwise noted. 2. All bearings are to be pressed in with
force applied to outer ring only.3. All hardware to be torqued to
specs listed in chart below.4. Special notes if any are shown
below.
Customer Service & Parts 800/ 235-2233General Parts
Requests: [email protected] Service Requests:
[email protected] Parts Requests:
[email protected] Systems, Inc. 800/ 831-7665
www.medfitsystems.com
REV F
-
70-1208
71-1203
73-1206BLACK
75-1205Zinc Plated
72-1213Teflon Paint
(Shadow Bronze)
75-1207Zinc Plated
75-1208Teflon Paint
(Shadow Bronze)
001-0391Silver Paint
000-6324Silver Paint
57-0566Zinc Plated
57-0511BLACK
57-0608
U10U10 Upright Bike
Red: PAINTED ITEMS
All labeled components are to be assembled 1. before shipment
unless otherwise noted. 2. All bearings are to be pressed in with
force applied to outer ring only.3. All hardware to be torqued to
specs listed in chart below.4. Special notes if any are shown
below.
Blue: KITS
Customer Service & Parts 800/ 235-2233General Parts
Requests: [email protected] Field Service Requests:
[email protected] Systems, Inc. 800/ 831-7665
www.medfitsystems.com REV F
-
57-0391 x 201-4094
SM22214
03-3043
40654 x 3
03-4036 x 3
57-056857-056708-5186
57-0566Zinc Plated
57-0574
01-4113 x 2
01-4036 x 2
12-8005
75-1208Teflon Paint
(Shadow Bronze)
75-1205Zinc Plated
72-1213Teflon Paint
(Shadow Bronze)
75-1207Zinc Plated
12-1151
57-0389
05-5130 x 2
03-9080
000-6264
902-5681 x 3
27592 x 3
03-4036 x 2
02-3021 x 2
56-0587
01-4094SM22214
57-0391 x 2
03-3043
02-4130 X 2(see detail)
57-0388
12-1151
Note 02-4130: 1. Add(Blue)Loctite 242 to threads.2. Thread set
screws in place leaving 1/8" threads exposed to stop travel of
seat.
U10U10 Upright Bike
Red: PAINTED ITEMS
All labeled components are to be assembled 1. before shipment
unless otherwise noted. 2. All bearings are to be pressed in with
force applied to outer ring only.3. All hardware to be torqued to
specs listed in chart below.4. Special notes if any are shown
below.
Blue: KITS
Customer Service & Parts 800/ 235-2233General Parts
Requests: [email protected] Field Service Requests:
[email protected] Systems, Inc. 800/ 831-7665
www.medfitsystems.com REV F
-
02-4177 X 4
71-1203
57-0465
40654 X 3
03-4034 X 3
12-1380
12-7500
001-0458
902-5681 X 4
001-0424
57-0465
57-0465
57-0465
57-0465
57-0465
01-4126
01-4126
57-0608
57-0381
12-6308
57-0465 (Shown) H10 Console ATSC DOM TV KIT 10"57-0470
(Optional) H10 Console DVB-T TV KIT 10"57-0393 (Optional) H10
Console Kit 7"
U10U10 Upright Bike
Red: PAINTED ITEMS
All labeled components are to be assembled 1. before shipment
unless otherwise noted. 2. All bearings are to be pressed in with
force applied to outer ring only.3. All hardware to be torqued to
specs listed in chart below.4. Special notes if any are shown
below.
Blue: KITS
Customer Service & Parts 800/ 235-2233General Parts
Requests: [email protected] Field Service Requests:
[email protected] Systems, Inc. 800/ 831-7665
www.medfitsystems.com
REV F
-
57-0547
57-0546
02-3062 x 4
57-0545
57-0547
02-3062 x 2
02-3062 x 2
57-054757-0545
001-6347
SM001-6348
SM000-6218
000-6207
RH- "LEVEL UP/DOWN
SM21607
SM002-0540
SM21607
SM002-0540
LH- "LOCK/QUICK START
U10U10 Upright Bike
Red: PAINTED ITEMS
All labeled components are to be assembled 1. before shipment
unless otherwise noted. 2. All bearings are to be pressed in with
force applied to outer ring only.3. All hardware to be torqued to
specs listed in chart below.4. Special notes if any are shown
below.
Blue: KITSCustomer Service & Parts 800/ 235-2233General
Parts Requests: [email protected] Field Service Requests:
[email protected] Systems, Inc. 800/ 831-7665
www.medfitsystems.com
REV F
-
001-0391Silver Paint
000-6324Silver Paint
95-0614 R
000-6244001-6365
57-0373
02-9307 x 4
000-6244
001-6365
902-4707 x 4
95-0614 L
000-6244
000-6244
SM27579 x 4
To Install: 1) Install and Tighten clockwise using "AM BB ISIS
DRIVE Tool"with "LOCTITE 243 BLUE" until bearing cup is secure.2)
Add outer Jam Nut ring secure with Flat faced screw driver.
To Remove: 1) Loosen jam ring (turning counter clockwise) with
screw driver in one of the slots.2) Use "AM BB ISIS DRIVE Tool" and
turn counter clockwise to loosen threads. Note: This may take some
pressure to loosen due to working loose the current thread lock
solution.
Use Pedal Wrench such as "Park Tool PW-3" available at your
local Bike Shop for Loosening Pedals
To Install Bolt: Tighten Bolt securely by applying approximately
40ft/lbs of torque.
To Remove: loosen bolt using "Crank Puller" for bolt
001-6244 - ISIS 118 L EXERCISE BOTTOMBRACKET INSTALL/ REMOVAL
DETAILS
To Install: This side has Left Hand Threads. Tighten using a
purchased "AM BB ISIS DRIVE Tool" turning Hub Counter clockwise
until flange Face is completely flush with bike frame hub. Use
"LOCTITE 243 BLUE" while installing for thread locking.
To Remove: use "AM BB ISIS DRIVE Tool" and turn clockwise to
loosen threads. Note: This may take some pressuredue to thread
locking material used previously.
Jam Nut
Locate Molded Plastic Lip outward towards 001-0391
Locate Molded Plastic Lip outward towards 000-6324
000-6244
U10U10 Upright Bike
Red: PAINTED ITEMS
All labeled components are to be assembled 1. before shipment
unless otherwise noted. 2. All bearings are to be pressed in with
force applied to outer ring only.3. All hardware to be torqued to
specs listed in chart below.4. Special notes if any are shown
below.
Blue: KITSCustomer Service & Parts 800/ 235-2233General
Parts Requests: [email protected] Field Service Requests:
[email protected] Systems, Inc. 800/ 831-7665
www.medfitsystems.com
REV F
-
57-0479
57-0373
02-4174 X 4
Pre-tension Spring here with screwdriver to install belt.
57-0482
10-4040
INSTALL BELT UNDERNEATH PULLEY ASSEMBLY FOR PROPER
TENSIONING
Note: Belt Tension 110-120 lbs.
57-0482
01-404804-2021
07-1156
02-9305 X 305-5146 X 3
73-1206BLACK
02-9306 X 3
57-0482 X 3
10-4040
57-0511BLACK
U10U10 Upright Bike
Red: PAINTED ITEMS
All labeled components are to be assembled 1. before shipment
unless otherwise noted. 2. All bearings are to be pressed in with
force applied to outer ring only.3. All hardware to be torqued to
specs listed in chart below.4. Special notes if any are shown
below.
Blue: KITS
Customer Service & Parts 800/ 235-2233General Parts
Requests: [email protected] Field Service Requests:
[email protected] Systems, Inc. 800/ 831-7665
www.medfitsystems.com
REV F
-
12-5621
12-6305
40654 x 2
12-6304
12-5621
57-0556 - Black000-6259 - Dk Grey
40654 x 13
901-5496 x 2
40654 x 3
57-0555 - Black000-6257 - Dk Gray
SM17787 57-048703-4036 x 3
12-7501
SM13180 x 4
SM17686 x 4
01-4064x 256-0585
x 256-0584
x 2
03-1035 x 2
899-0004
57-0557 - Black000-6260 - Dk Gray
57-0542- Black000-6252 - Gray
57-0541 - Black000-6251 - Gray
57-0611
12-6180
U10U10 Upright Bike
Red: PAINTED ITEMS
All labeled components are to be assembled 1. before shipment
unless otherwise noted. 2. All bearings are to be pressed in with
force applied to outer ring only.3. All hardware to be torqued to
specs listed in chart below.4. Special notes if any are shown
below.
Blue: KITSCustomer Service & Parts 800/ 235-2233General
Parts Requests: [email protected] Field Service Requests:
[email protected] Systems, Inc. 800/ 831-7665
www.medfitsystems.com
REV F
-
40654 x 3
57-0485
03-4034 x 3
03-4031 x 2
01-4034 x 257-0376
19-1013
SM41269
SM41269
02-3058 x 4
57-0507
57-0497 x 403-4031 x 4
SM40235SM40236 57-0355
09-8080
57-0538
57-0469
57-0478 x 2
57-0536
57-0554 19-1043
19-6000
57-0350
57-0537
SM17787
57-056257-0563
57-0350-01 (North America)57-0350-02 (Europe) 57-0350-03
(Switzerland)57-0350-04 (United Kingdom)57-0350-05 (Australian)
12-6180
U10U10 Upright Bike
Red: PAINTED ITEMS
All labeled components are to be assembled 1. before shipment
unless otherwise noted. 2. All bearings are to be pressed in with
force applied to outer ring only.3. All hardware to be torqued to
specs listed in chart below.4. Special notes if any are shown
below.
Blue: KITS
Customer Service & Parts 800/ 235-2233General Parts
Requests: [email protected] Field Service Requests:
[email protected] Systems, Inc. 800/ 831-7665
www.medfitsystems.com
REV F
-
57-0391 x 2
01-4094SM22214
03-3043
40654 x 303-4036 x 3
57-056857-056708-5186
57-0566Zinc Plated
57-057401-4113 x 2
01-4036 x 2
12-8005
75-1208
75-1205Zinc Plated
72-1213
75-1207Zinc Plated
12-1151
57-0389
05-5130 x 2
03-9080
000-6264
902-5681 x 327592 x 3
03-4036 x 2
02-3021 x 2
56-0587
01-4094
SM22214
57-0391 x 203-3043
02-4130 X 2
57-0388
12-1151
40654 X 303-4034 X 3
12-138012-7500902-5681 X 4
001-0424
57-0465
57-0465
57-0465
57-046557-0465
01-412601-4126
57-0608
57-0381
02-417771-1203
57-0465
57-0547
57-0546
02-3062 x 4
57-054557-0547
02-3062 x 2
02-3062 x 2
57-054757-0545
001-6347
SM001-6348SM000-6218
000-6207SM21607 x 2SM002-0540 x 2
001-0391Silver Paint
000-6324Silver Paint
95-0614 R
000-6244001-6365
57-0373
02-9307 x 4
001-6365
902-4707 x 4
95-0614 L000-6244
000-6244
SM27579 x 4
57-047957-0373
02-4174 X 4
57-0482
10-4040
57-0482
01-404804-2021
07-1156
02-9305 X 305-5146 X 3
73-1206BLACK
02-9306 X 3
57-0482 X 3
10-4040
57-0511BLACK
12-5621
12-6305
40654 x 2
12-6304
12-5621
57-0556 Black000-6259 - Dk Gray
40654 x 13
901-5496 x 2
40654 x 3
57-0555 - Black000-6257 - Dk Gray
SM17787
57-048703-4036 x 3
12-7501
SM13180 x 4
SM17686 x 4
01-4064x 2
56-0585x 256-0584
x 2
03-1035 x 2
899-0004
57-0557 - Black000-6260 - Dk Gray
57-0542 - Black000-6252 - Gray 57-0541 - Black
000-6251 - Gray
57-061112-6180
40654 x 357-0485
03-4034 x 3
03-4031 x 2
01-4034 x 2
57-0376
19-1013SM41269
SM4126902-3058 x 457-0507
57-0497 x 403-4031 x 4
57-0355
09-8080
SM40235SM40236
57-053857-0469
57-0478 x 2
57-053657-0554 19-1043
19-6000
57-0350
57-0537
SM17787
57-0562
57-0563
57-0350-01 (North America)57-0350-02 (Europe)
57-0350-03 (Switzerland)57-0350-04 (United Kingdom)
57-0350-05 (Australian)
12-6180
000-6244
PART NO. Default - Top Level/QTY. DESCRIPTION
000-6207 2 END CAP000-6244 1 ISIS TRUVATIV 118MM X 160MM
BB000-6264 1 SEAT, MED WIDTH000-6324 1 CRANK ARM LEFT HAND001-0391
1 CRANK ARM RIGHT HAND001-0424 1 WATER BOTTLE HOLDER001-0458 1
DECAL, WARNING, U/R916001-6347 1 KEYPANEL, OVERLAY, RIGHT001-6365 2
DISC, CRANK01-4113 2 Button HD Joint Connector, 3/8-16 X
1.0601-4126 10 BOLT BH , -20 x '' SS BLACK02-3058 4 SCREW #8-32 X 1
PHIL PAN HEAD ZINC02-3062 8 #6 -32 UNC THREAD x 1" OVAL HEAD
PHILLIPS M/S _SS-BLACK OXIDE02-4130 2 SCREW, SET, -20 UNC x 02-4174
10 SCREW SHCS , -20 UNC x Zinc02-9306 6 M5 X 0.8 X 80M Philipps Pan
Head Screw02-9307 4 SCREW, M6-1.0 X 20mm L, SHCS, STAINLESS03-3043
4 5/16" Lock Nut03-4031 6 8-32 INSERT HEX03-4034 10 10-32 INSERT
HEX03-4036 8 RIVNUT 10-32 NF, .125-.22504-2021 2 WASHER, FLAT, 3/8"
USS05-5130 2 IGUS FLANGE .5 ID x .5938 OD x .25L 05-5146 3
EB-TENSIONER BRACKET MOUNT BUSHING07-1156 2 6204-2z Ball Bearing
Double Sealed08-5186 1 SPACER NYLON 5/8 DIA X 1/2 L09-8080 1 TYRAP,
.14 X 11.010-4040 1 LeeSpring-LHL750A 0712-1151 2 DECAL SEAT
ADJUSTMENT 1-13 R1012-1380 1 Made In USA12-1822 1 Honix Console
Decal12-5621 2 NLS ONE 3 Dome Decal (000-6491)12-6180 1 Decal,
Parts Diagram Schematic U1012-6304 1 DECAL, U10 "E-BRAKE
TECHNOLOGY" LEFT12-6305 1 DECAL, U10 "E-BRAKE TECHNOLOGY"
RIGHT12-6308 1 Membrane Switch Overlay for Honix Display12-7500 1
MPale Antimicrobial Label12-7501 1 Caution 15V and 4A12-8005 1
DECAL SEAT ADJUSTMENT 1-4 U1019-1013 1 TAPE DBL SIDED 2 3/4"
WIDE19-1043 1 U10 Quick Assembly Instructions (Hardcopy
Printed)19-6000 1 DVD Technical Documentation27592 3 WASHER, M8,
SPLIT LOCK40654 28 SCREW, #10-32 X .75, PAN HEAD, W/LOCK
WASHER56-0584 2 Wheel (56-0580 Drilled Out to .641 ID)56-0585 2
Wheel Sleeve (for 56-0584)56-0587 1 SPRING GAS LOCKING IN
COMPRESSION 100N57-0350 1 Power Adaptor, 15VDC, 4A57-0355 1 BATTERY
12V 1.3 Ah57-0373 1 PULLEY 8 GROOVE 11 3/4" DIA57-0376 1 DC BLOWER
FAN ASSEMBLY57-0388 1 Seat Slide Cap 1 x 3 Rect57-0389 1 Seat Slide
guide 1 x 3 Rect57-0391 2 BUSHING SEAT SHOCK MOUNT57-0465 1 H10
Console ATSC DOM TV KIT 10"57-0469 1 CABLE POWER INPUT E10,
U1057-0478 1 Assembly Cable Contact Heart Rate57-0479 1 BELT J
Groove 8 Rib 63" / Drive belt U1057-0482 1 Eddy Brake/Gen with
clutch (FB62HA21)57-0485 1 Lower Control Board, BLCB01157-0487 1
BRACKET POWER INLET57-0497 4 SPACER, #10 SCREW, 5/16"57-0507 1
Board Interface to Lower Control57-0511 1 EB-COMPRESSION SPRING
RETAINING BRACKET57-0536 1 TV Cable Assembly, E/U/R 10
Series57-0537 1 CABLE ASSY, T-BAR GRIP TO CONSOLE, RoHS57-0538 1
ASSEMBLY FAN INPUT POWER CABLE R10, U1057-0541 1 U10 MAIN SHROUD,
LEFT57-0542 1 U10 MAIN SHROUD, RIGHT57-0545 2 GRIP CHR /ROC TOP
ASSEMBLY57-0546 2 GRIP CHR TOP ASSEMBLY57-0547 4 GRIP CHR BOTTOM
ASSEMBLY57-0554 1 CABLE, Console to LCB, R10, U1057-0555 1 INLET
COVER U10 BLACK57-0557 1 Mast Shield Right Side
57-0562 1 CABLE, Intermediate Board to BCLB002, E10, U10,
R1057-0563 1 CABLE, Intermediate Board to BCLB00257-0566 1 SEAT
LOCKING HEX NUT57-0567 1 SEAT LOCKING STOP PLATE57-0568 1 NYLON
SEAT LOCK57-0574 1 Handle with 3/8"-16 Threaded Stud57-0608 1 I-POD
MOUNT57-0611 1 Pocket, Peel & Stick, Cardio Schematic70-1208 1
ASSEMBLY, FRAME U10 BIKE71-1203 1 Weldment Front Display Mast U10
Bike72-1213 1 Weldment Seat Handle73-1206 1 EB BELT COMPRESSION
SPRING TENSIONER75-1205 1 Weldment Seat Adjustment Vertical75-1207
1 SEAT MOUNT SLIDE ASSEMBLY75-1208 1 Seat Slide Housing
Bracket899-0004 1 DECAL SERIAL/COMPLIANCE U9/U10901-5496 2 SCW-PHP
#10-32x1.25 SS902-4707 4 SCREW SHCS, M6-1.0 X 10, SHCS, BLACK,
EPOXY902-5681 7 SCW-SHCS M8-1.25x25 SS91-999 1 Paint (1.5
lbs)95-0614 L 1 PEDAL EXERCISER JD-48-A 9-16 LEFT95-0614 R 1 PEDAL
EXERCISER JD48-A 9/16 RIGHT95-9004 1 Packaging Kit Estimate
U10SM000-6218 1 ASSEMBLY, HANDLEBARSM001-6348 1 KEYPANEL, OVERLAY,
LEFTSM002-0540 2 PCB, CHR INTER-CONNECTSM13180 4 CAP, LEVELING
SUPPORTSM17686 4 PAD, LEVELINGSM17787 2 CONNECTOR, RF, 3MM,
FSM21607 2 TAPE, DOUBLE SIDED, FOAMSM27579 4 WASHER, M6, FLAT, ZINC
PLATEDSM40235 1 FASTENER, HOOKSM40236 1 FASTENER, HOOKSM41269 2
Grommet, 2879, 7/8" ID
U10U10 Upright Bike
Customer Service & Parts 800/ 235-2233General Parts
Requests: [email protected] Service Requests:
[email protected] Parts Requests:
[email protected] Systems, Inc. 800/ 831-7665
www.medfitsystems.com12-6180 REV F
-
57-0465 H10 Console ATSC DOM TV KIT 10"57-0470 H10 Console DVB-T
TV KIT 10"57-0393 H10 Console Kit 7"
GENERATOR CABLE,3 PIN SUPPLIED WITH 57-0482.
BRAKE CABLE, 2 PINSUPPLIED WITH 57-0482
57-20008HR SENSOR
(57-0509)
(57-20016) (57-0563)
(57-0562)
(57-0469) POWER
(57-0538)
(57-0536)TV CABLENOT AVAILABLEON 57-0393
FAN(57-0376)
INTERMEDIATE CONTROL BOARD (57-0507)
BRAKE(57-0482)
LOWER CONTROL BOARD (57-0485)
GREEN
(57-0554)
-+
BATTERY(57-0355)
CONTACTHEART RATE GRIPS
(CONSOLE)
WHITE
RED
BLACK
Left Right
(57-0537)
(57-0478)
R L
(57-0469)
FAN (J4)(J1) TO
CONSOLEPOWERIN (J5)
POWER TO BCLB002 (J3)
(J2) TOBCLB002
TO 57-0507(CN6)
TO 57-0507(JP2) TO BRAKE
(CN2)
TO GENERATOR(CN1)
FANPLUG
15V dc
12V dc
Customer Service & Parts 800/ 235-2233General Parts
Requests: [email protected] Service Requests:
[email protected] Parts Requests:
[email protected] Systems, Inc. 800/ 831-7665
www.medfitsystems.com12-6180 REV
-
68cm27in
152cm60in
123cm48in
U10U10 Upright Bike
Customer Service & Parts 800/ 235-2233General Parts
Requests: [email protected] Field Service Requests:
[email protected] Systems, Inc. 800/ 831-7665
www.medfitsystems.comREV F
U10Drawing View1
Assembly DiagramDrawing View2
Seat DiagramDrawing View3Drawing View4Drawing View20
Display MountDrawing View5Drawing View6
Handle BarDrawing View8
Pedal Crank Drawing View9Drawing View10
BRAKEDrawing View11Drawing View12Drawing View13
ShieldingDrawing View14
ElectricalDrawing View15Drawing View16
SCHEMATICDrawing View21Drawing View22Drawing View23Drawing
View24Drawing View25Drawing View26Drawing View27Drawing
View28Drawing View29Drawing View30Drawing View31Drawing
View32Drawing View33
Wiring DiagramDimensionsDrawing View34Drawing View35Drawing
View36
