VIKING PUMP
Duplex Fuel Oil Packages
Field Start-Up Guide
Bulletin: UDF400
Version: 5
Issued: 1-Jan-15
VIKING PUMP, INC. • A Unit of IDEX Corporation •
Before arriving on job site, make sure you have:
When you arrive at the site confirm the following:
Observations to be made on site:General Installation
Suction Piping
Discharge Piping
VIKING PUMP, INC. • A Unit of IDEX Corporation •
Priming the Duplex Fuel Oil Package:1.
2.
3.
4.
5.
6.
7.
8.
VIKING PUMP, INC. • A Unit of IDEX Corporation •
9.
10.
11.
12.
13.
14.
15.
16.
17.
18.
19.
20.
NOTE
NOTE
NOTE
VIKING PUMP, INC. • A Unit of IDEX Corporation •
CONTROL PANEL
RELIEF VALVES
Checking Relief Valves Current Setting1.2.3.4.5.
6.7.
VIKING PUMP, INC. • A Unit of IDEX Corporation •
Setting the Pressure Relief Valves1.2.
3.4.
5.6.
7.
8.
9.
FLOAT CONTROLS
VIKING PUMP, INC. • A Unit of IDEX Corporation •
TROUBLESHOOTING
NOTE:
1)
2)
3)
install a vacuum gauge inthe suction port and a pressure gauge in the discharge port
Vacuum Gauge - Suction Port
1.
a).b).c).d).
2.
a).b).c).d).
VIKING PUMP, INC. • A Unit of IDEX Corporation •
3.
a).b).
c).
Pressure Gauge - Discharge Port
1.
2.
1.
3.a).b).c).d).
A).
li
B).
VIKING PUMP, INC. • A Unit of IDEX Corporation •
WARRANTY
Viking warrants all products manufactured by it to be freefrom defects in workmanship or material for a period of one (1)year from date of startup, provided that in no event shall thiswarranty extend more than eighteen (18) months from the date ofshipment from Viking. If, during said warranty period, anyproducts sold by Viking prove to be defective in workmanship ormaterial under normal use and service, and if such products arereturned to Viking’s factory at Windsor, Ontario, transportationcharges prepaid, and if the products are found by Viking to bedefective in workmanship or material, they will be replaced orrepaired free of charge, FOB. Windsor, Ontario.
Viking assumes no liability for consequential damages of anykind and the purchaser by acceptance of delivery assumes allliability for the consequences of the use or misuse of Vikingproducts by the purchaser, his employees or others. Viking willassume no field expense for service or parts unless authorized byit in advance.
Equipment and accessories purchased by Viking from outsidesources which are incorporated into any Viking product arewarranted only to the extent of and by the originalmanufacturer’s warranty or guarantee, if any.
THIS IS VIKING’S SOLE WARRANTY AND IS INLIEU OF ALL OTHER WARRANTIES,EXPRESSED OR IMPLIED, WHICH ARE HEREBYEXCLUDED, INCLUDING IN PARTICULAR ALLWARRANTIES OF MERCHANTABILITY ORFITNESS FOR A PARTICULAR PURPOSE. No
officer or employee of IDEX Corporation or Viking PumpCanada is authorized to alter this warranty.