Vivaro and Movano specification and technical · PDF filebody-lock front seatbelt pretensioner...

Every effort has been made toensure that the contents of thispublication were accurate and up-to-date at the time of going to press (March 2005).

Vauxhall vehicles are equipped with components manufactured by various General Motors operating units and outside suppliers. The Company reserves the right to change specifications and make modifications to thevehicles described and illustrated at any time.

Any such modifications will benotified to Vauxhall retailers atthe earliest opportunity; pleaseconsult your local retailer for thelatest information.

The specifications detailed within this brochure are not necessarilyapplicable to alternative models such as Special Editions. Details of any such models will be contained in specific literature or found on the Vauxhall website.

Please note that Vauxhall retailersare not the agents of Vauxhall Motors Limited and are notauthorised to bind the Company by any specific or impliedundertaking or representation.

It is advisable to ensure that yourmotor insurance policy providesadequate cover for additional fitted options and accessories.

As part of Vauxhall’s policy ofenvironmental care, this brochure is printed on papermanufactured using ElementalChlorine Free pulps from specially farmed, sustainable timber resources.

All rights reserved. No partof this publication may bereproduced in any form or by any means, without the priorwritten permission of VauxhallMotors Limited.

Published March 2005 (Graymatter)

Vauxhall Motors Limited, Luton LU1 3YTwww.vauxhall.co.uk

VM0505464

Vauxhall 2005 ModelsEdition number 2

Vivaro and Movano specification and technical data

S.2

Safety

Standard features ● Driver’s airbag ● Anti-lock Braking System (ABS) with Electronic Brakeforce Distribution (EBD) ● Height-adjustable

padded head restraints ● Three inertia-reel lap and diagonal seatbelts (doublecab – six) ● Height-adjustable outer front seatbelts ● Pyrotechnic

body-lock front seatbelt pretensioner system ● Front seatbelt force limiters ● Anti-submarining ramps in front seats ● Side-impact protection

beams ● Laminated windscreen

Additional feature Panel van Sportive Doublecab

Front passengers’ twin airbag ●● ●● ●●

vivaro

specification

Standard features ● Gateway cloth seat trim ● Driver’s seat height adjuster ● Driver’s seat adjustable for reach and rake● Dual front passengers’ bench seat

Seating

Interior features

Standard features ● Vinyl floor covering ● Twin sunvisors ● Air blend heater with four-speed fan ● Four adjustable face-level heating and

ventilation outlets ● Windscreen and front side-window demist vents ● Air recirculation system ● Overhead storage shelf (high roof only)● Door armrests ● Front door pockets with bottle holder ● Front ashtray ● Dipping rear-view mirror3

Additional features Panel van Sportive Doublecab

CDR 2005 RDS EON stereo radio/compact disc player/remote multi-function display1 ●● ● ●●

NCDR 2011 RDS EON stereo radio/compact disc player/CD-ROM-driven satellite navigation system/●● ●● ●●

remote monochromatic display/steering wheel mounted audio controls

Steering wheel mounted audio controls available when the CDR 2005 audio unit is specified ●●2 ●● ●●

Factory-fit telephone pre-wiring available when the CDR 2005 or NCDR 2011 audio units are specified ●● ●● ●●


Air-conditioning4 ●● ● ●●


Vinyl seat trim N/C N/C

Single front passenger’s seat N/C N/C

Driver’s seat and single front passenger’s seat with lumbar adjustment and armrest●● ●● ●●

(available to order Summer 2005)

Driver’s seat with lumbar adjustment and armrest (available to order Summer 2005) ●● ●● ●●

Three-passenger rear bench seat ●

Security

Standard features ● Remote control central deadlocking (doors, tailgate – when specified, and fuel flap) with internal switch ● Security code

protection for audio equipment ● Electronic engine deadlock immobiliser ● ‘Key left in ignition’ audible warning ● Visible Vehicle Identification

Number (VIN) ● Steering column lock ● Freewheeling door and steering lock cylinders


Remote control ultrasonic security alarm system ●● ● ●●

Audio, communication and navigation (see page S.5 for details)

Standard features ● CAR 2002 stereo radio/cassette player ● Four speakers ● Traffic Programme ● Flexible roof-mounted aerial

Load area

Standard features ● Nearside sliding side-access door ● Illuminated load area ● Load restraint lashing eyes

S.3

vivaro


Full-height steel load restraint guard behind driver ● ●

Full-height ABS plastic bulkhead with window ●

Full-height steel bulkhead5 ●● ●●

Full-height steel bulkhead with window ●● ●●

Resin-coated wooden load floor covering ●● ●●

FlexxCargo anchorage ●● ●●

Delete standard nearside sliding side-access door N/C

Offside sliding side-access door ●● ●●

Fixed window on nearside sliding side-access door ●●6

Sliding window on nearside sliding side-access door ●●6

Offside sliding side-access door with fixed windows to both nearside and offside doors ●●6

Offside sliding side-access door with sliding windows to both nearside and offside doors ●●6 ●

Glazed rear doors (90˚/165˚opening)3 N/C ●

Unglazed rear doors (90˚/165˚opening) ● ● N/C

Glazed rear doors with heated windows and wash/wipe facility (not with 250˚opening glazed rear●● ●● ●●

door option)3

250˚opening unglazed rear doors (LWB standard roof only) ●●

250˚opening glazed rear doors3 (LWB standard roof only) ●● ●●

Tailgate with heated window and wash/wipe facility3 (standard roof only) ●● ●●

Standard features ● Tinted glass ● Two-speed windscreen wipers with variable intermittent wipe and electric screenwash ● Lights-on audible

warning ● Electric headlight beam levelling ● Twin adjustable and foldable door mirrors (wide-angle on driver’s side) ● High-level tail lights ● High-level brake light ● Twin reversing lights ● Rear fog light ● Body side-protection mouldings ● Side repeat indicators (white on Sportive)

Mechanical

Standard features ● Five-speed manual gearbox – 1.9CDTI (82PS) ● Six-speed manual gearbox – 2.0i 16v/1.9CDTI (100PS)/2.5CDTI 16v ● Power-assisted steering

Exterior features

● = Standard equipment.

●● = Optional at extra cost.

N/C = No-cost option.■■ = Only available as part of an extra-cost option pack.

1 = Multi-function display shows time, date, audio

information and outside air temperature (with ice

warning function).

2 = Standard on high roof models when the CDR 2005

audio unit is specified.

3 = Dipping rear-view mirror standard when glazed rear

doors/tailgate options are specified.

4 = Air-conditioning not available in conjunction

with engine-driven power take-off option.

5 = Full-height steel bulkhead without window

not available when the tailgate option is specified.

6 = Fixed or sliding window options for sliding

side-access door(s) also include glazed rear doors.

7 = Star Silver two-coat metallic paint is standard.

Midnight Black two-coat pearlescent paint, Flame Red

and Glacier White solid paint are available as no-cost

options.

Panel van Sportive Doublecab

Electric pack ● Electrically operated front windows ● Electrically adjustable/heated door mirrors ●● ● ●●

Option pack

Features Panel van Sportive Doublecab

6J x 16 steel wheels with wheel centre covers ● ●

6J x 16 steel wheels with full-diameter flush wheel covers ●

195/65 R 16 tyres – 2700, 2.0i 16v/1.9CDTI (82PS/100PS) models ● ●

205/65 R 16 tyres – 2900, 2.0i 16v/1.9CDTI (82PS/100PS) standard roof and 2.5CDTI 16v high ● ● ●

roof models

215/65 R 16 tyres – 2700/2900 2.5CDTI 16v standard roof models ● ● ●

Wheels and tyres


Tecshift six-speed transmission with sequential manual gearshift and automatic mode ●● ●●

(2.5CDTI 16v only) (available to order Summer 2005)

Engine-driven power take-off (1.9CDTI (100PS)/2.5CDTI 16v only)4 ●● ●●


Solar Reflect® windscreen ●● ● ●●

Front fog lights ●● ● ●●

Electrically operated front windows with safety autoreverse and one-touch facility ■■ ● ■■

Electrically adjustable/heated door mirrors ■■ ● ■■

Body-colour side-protection mouldings ●

Body-colour front bumper and rear quarter bumpers ●

Front and rear mudflaps ●

Two-coat metallic or pearlescent paint ●● ●7 ●●

Special paint (restrictions apply – please consult your retailer for availability) ●● ●●

Facia, instruments and controls

Standard features ● Facia-mounted gear lever ● Steering column adjustable for reach ● Trip odometer ● Rev counter ● Coolant temperature gauge● Fuel gauge with low fuel level warning light ● Engine oil level indicator ● Service-due indicator ● Cigar lighter/accessory socket ● Digital clock and

outside air temperature display ● Illuminated glovebox ● Facia-mounted drinks holders ● Facia-mounted bag-carrying hook


Leather-covered steering wheel ●

S.4

vivaro technical dataEngines

2.0i 16v 1.9CDTI (82PS) 1.9CDTI (100PS) 2.5CDTI 16v

Fuel type Petrol Diesel Diesel Diesel

Capacity 1998cc 1870cc 1870cc 2463cc

Maximum power 120PS (88kW) @ 4750rpm 82PS (60kW) @ 3500rpm 100PS (74kW) @ 3500rpm 135PS (99kW) @ 3500rpm

Maximum torque 190Nm (140 lb.ft.) @ 3750rpm 190Nm (140 lb.ft.) @ 2000rpm 240Nm (177 lb.ft.) @ 2000rpm 310Nm (229 lb.ft.) @ 2000rpm

Compression ratio 9.8:1 18.3:1 17.8:1

Emission compliance Euro 3

Layout 4 cylinders / 4 cylinders / 2 valves per cylinder / 4 cylinders /

4 valves per cylinder / single overhead camshaft 4 valves per cylinder /

double overhead camshafts double overhead camshafts

Induction system Multi-point sequential Turbocharger and intercooler.

electronic fuel injection Common rail fuel injection

Service interval 18,000 miles or two years, whichever occurs sooner

Transmission ratios

Vauxhall Assistance andwarranties**Every Vivaro base vehicle comes with:● A one-year unlimited mileage

manufacturer’s warranty● Second and third year no-fee customer

option warranty up to 100,000 miles

from date of first registration● Vauxhall Assistance for 12 months from

first registration● Six-year body panel anti-perforation

warranty

** = Warranty is only available on vehicles sourced

from Vauxhall Motors Ltd. Terms and conditions

apply – please see your Vauxhall Commercial

Vehicle retailer for details.

Transmissions● Front-wheel drive● Five-speed manual gearbox – 1.9CDTI (82PS)● Six-speed manual gearbox – 2.0i 16v/

1.9CDTI (100PS)/2.5CDTI 16v● Six-speed Tecshift transmission –

available at extra cost on

2.5CDTI 16v models* (excluding Sportive)

Tecshift hydraulic transmission offers

all the main features and flexibility of a

regular automatic, plus the performance

and control of a ‘one touch’ manual gearbox.

Drivers may switch between modes on

the move using the gearshift selector.● Hydraulic, asbestos-free single-plate clutch

* = Available to order Summer 2005.

ElectricsMaintenance-free battery: 70Ah.

Alternator: 125A.

Brakes● Anti-lock Braking System (ABS) with

Electronic Brakeforce Distribution (EBD)● Vacuum servo-assisted system● Dual circuit hydraulic system● Asbestos-free brake linings● Floor-mounted parking brake lever

Front ventilated disc brakes:

305mm diameter.

Rear disc brakes: 280mm diameter.

Body● Six-year body panel anti-perforation

warranty● Galvanised body panels● Anti stone-chip mastic coating on sills● Anti-corrosion wax pumped into sills

and other underbody cavities● Flush-fitted windscreen and rear door

glass (when specified)● Detachable front towing eye● Rear towing eye

Fuel economy1.9CDTI (100PS) 2700 SWB – 39.1mpg

(laden) and 43.7mpg (unladen) long-term test

by Commercial Motor magazine. June 2003.

1.9CDTI (100PS) 2700 SWB – 45.75mpg

(half-laden) 1.9CDTI (100PS) 2900 LWB –

42.94mpg (half-laden) obtained during

the RAC/Fleet World MPG Marathon in

September 2002.

Important: Figures quoted relate to the particular

vehicle tested by an independent organisation. They

do not necessarily follow any government-approved

vehicle testing procedures. Variations in equipment,

payload, driving style, road and traffic conditions,

vehicle mileage and standard of maintenance may

also affect fuel consumption; therefore the test

results do not express or imply any guarantee of

fuel consumption attainable.

Fuel tank capacity90 litres (19.8 gallons).

SuspensionFront: Independent wishbones with

MacPherson spring struts, control arms

and separate galvanised, double isolated,

vibration reducing subframe.

Rear: Semi-independent with trailing links,

progressive-rate mini-block coil springs

with rubber bump-stops and telescopic,

load-adaptable gas-pressure dampers.

Steering● Power-assisted rack and pinion system● Turning circles (kerb-to-kerb/wall-to-wall):

SWB – 11.84m (38.8ft.)/12.40m (40.7ft.)

LWB – 13.17m (43.2ft.)/13.73m (45.1ft.)● Turns lock-to-lock: 3.3

Insurance groupsAll models (exc. 2900 2.5CDTI 16v LWB/

doublecab) – 4E.

2900 2.5CDTI 16v LWB and all doublecab

models – 5E.

As recommended by the Association of

British Insurers.

SWB Laden Unladen

2700 std. roof 162 (6.4) 185 (7.3)

2900 std. roof 164 (6.5) 192 (7.5)

2900 high roof 159 (6.3) 193 (7.6)

LWB

2900 std. roof 158 (6.2) 188 (7.4)

2900 high roof 149 (5.9) 187 (7.4)

Ground clearances mm (inches).

S.5

audio, communication and navigationAudio standard features

General (all models) ● Four-figure security code ‘burnt in’ to memory chip ● Balance control ● Four speakers

Tuner (all models) ● FM and MW reception ● Microprocessor-controlled quartz tuning ● Traffic Programme ● Up and down manual

tuning functions ● Autostore function ● Automatic search tuning

Cassette player (CAR 2002) ● Fast forward wind ● Radio reception during fast cassette wind

CD player (CDR 2005/NCDR 2011) ● Single-disc CD player† ● Track up/down facility ● Random and continuous play facilities

Additional features CAR 2002 CDR 2005 NCDR 2011

Maximum output (watts per channel) 7 20 20

Full RDS EON ● ●

Programmable speed-dependent volume control ● ●

Separate bass and treble control ● ●

Fader control ● ●

Dimmable illumination ● ●

Number of station preset buttons 4 6 10

Steering wheel mounted audio controls ●●†† ●

CAR 2002 stereo radio/cassette player (standard). CDR 2005 stereo radio/CD player

(optional at extra cost).

NCDR 2011 stereo radio/CD player/CD-ROM-driven

satellite navigation system (optional at extra cost).

Standard features (NCDR 2011) ● Automatic re-routing on request ● Display of estimated time remaining and distance to destination ● Exact location of vehicle using the GPS (Global Positioning System) and speed sensor ● Choice of four different route types – Using motorways, avoiding motorways, shortest distance, shortest journey time ● Store up to 100 personal destinations● ‘Points of Interest’ menu offers a wide choice of popular destinations ● Last 10 destinations stored automatically● CD-ROMs available for all major European countries

Satellite navigation

● = Standard features.


† = Please note: on NCDR 2011 units an audio CD cannot be played whilst the navigation CD is loading.

†† = Standard on high roof models.

NavigationThe NCDR 2011 stereo radio/CD player/

navigation unit uses the international network

of GPS (Global Positioning System) satellites

linked to a comprehensive CD-ROM mapping

system to determine your precise location

and guide you to your chosen destination

virtually anywhere in mainland Britain.

Despite its technical sophistication, the

system is very simple to operate, using a

range of menu-driven options which are

easily accessed via the steering wheel

mounted audio controls.

Clearly spoken instructions indicate the road

you need to take or the lane you need to be

in, both well in advance and again when the

manoeuvre is due. Directional pictograms,

clearly shown on the special monochromatic

display screen, back up the spoken

commands.

The CD-ROM supplied with the system

covers all major link roads and streets in

towns and cities across mainland Britain.

Discs are updated twice a year and are

available at extra cost by subscription.

Telephone pre-wiringHelping to keep drivers in touch at all

times, telephone pre-wiring is available

as a factory-fitted option, at extra cost,

when either the CDR 2005 or NCDR 2011

audio units are specified. Pre-wiring when

fitted in conjunction with the Vauxhall

accessory hands-free phone installation kit

allows drivers to listen to incoming calls

hands-free via the audio speakers.

Telephone pre-wiring is fitted in the

factory to ensure full compatibility with the

original wiring, eliminating the problems

often associated with aftermarket systems.

It comprises a microphone and modified

roof aerial together with an integrated

harness complete with power and

aerial connections for the phone. It is

compatible with both the GSM 900

and 1800 frequencies.

Gear ratios (mph/1000rpm) Final drive

Manual 5/6-speed 1 2 3 4 5 6 Reverse ratio

2700 2.0i 16v 3.91:1 (4.1) 2.11:1 (7.7) 1.39:1 (11.6) 0.98:1 (16.5) 0.76:1 (21.3) 0.64:1 (25.3) 3.66:1 4.87:1

2700 1.9CDTI (82PS) 4.64:1 (4.0) 2.24:1 (8.4) 1.39:1 (13.5) 0.98:1 (19.2) 0.76:1 (24.8) – 3.89:1 4.19:1

2700 1.9CDTI (100PS) 4.64:1 (4.0) 2.24:1 (8.4) 1.39:1 (13.5) 0.98:1 (19.2) 0.76:1 (24.8) 0.64:1 (29.4) 3.89:1 4.19:1

2700 2.5CDTI 16v 3.91:1 (5.0) 2.11:1 (9.3) 1.39:1 (14.1) 0.98:1 (20.0) 0.76:1 (25.8) 0.60:1 (32.7) 3.66:1 4.19:1

2900 2.0i 16v 3.91:1 (4.3) 2.11:1 (8.0) 1.39:1 (12.1) 0.98:1 (17.2) 0.76:1 (22.2) 0.64:1 (26.3) 3.66:1 4.87:1

2900 1.9CDTI (82PS) 4.64:1 (4.2) 2.24:1 (8.7) 1.39:1 (14.1) 0.98:1 (20.0) 0.76:1 (25.8) – 3.89:1 4.19:1

2900 1.9CDTI (100PS) 4.64:1 (4.2) 2.24:1 (8.7) 1.39:1 (14.1) 0.98:1 (20.0) 0.76:1 (25.8) 0.64:1 (30.6) 3.89:1 4.19:1

2900 2.5CDTI 16v 3.91:1 (5.0) 2.11:1 (9.3) 1.39:1 (14.1) 0.98:1 (20.0) 0.76:1 (25.8) 0.60:1 (32.7) 3.66:1 4.19:1

Tecshift 6-speed*

2700/2900

2.5CDTI 16v3.91:1 (5.0) 2.11:1 (9.3) 1.39:1 (14.1) 0.98:1 (20.0) 0.76:1 (25.8) 0.60:1 (32.7) 3.66:1 4.19:1

* = Available to order Summer 2005.

S.7

LWB panel van

1904 (75.0)excluding door mirrors

2206 (86.8)including door mirrors

Std. roof1960 (77.2)

High roof2492 (98.1)

833(32.8)

3498 (137.7) 851(33.5)

5182 (204.0)

SWB panel van

S.6



Std. roof1960 (77.2)


833(32.8)

3098 (122.0) 851(33.5)

4782 (188.3)

Measurements are shown in millimetres (inches). All heights are shown unladen. Measurements are shown in millimetres (inches). All heights are shown unladen.

vivaro dimensions and weights

Weights and towing data

A

E

D

C

B

UK plated weights and kerbweights kg Plated Gross

Front axle Rear axle Total Payload Combination

Model Plated Kerb Plated Kerb GVW Kerb kg Weights (GCW) kg

2900 2.0i 16v std. roof 1550 1063 1650 647 2925 1710 1215 4925

2900 1.9CDTI std. roof* 1550 1078 1650 648 2940 1726 1214 4940

2900 1.9CDTI (100PS) Sportive std. roof 1550 1104 1650 659 2940 1763 1177 4940

2900 1.9CDTI doublecab std. roof* 1550 1138 1650 711 2940 1849 1091 4940

2900 2.5CDTI 16v std. roof 1580 1153 1650 645 3030 1798 1232 5030

2900 2.5DTI 16v std. roof Tecshift** 1580 1161 1650 644 3060 1805 1255 5060

2900 2.5CDTI 16v Sportive std. roof 1580 1179 1650 656 3030 1835 1195 5030

2900 2.5CDTI 16v doublecab std. roof 1580 1213 1650 708 3030 1921 1109 5030

2900 2.5CDTI 16v doublecab std. roof Tecshift** 1580 1221 1650 707 3060 1928 1132 5060

2900 2.0i 16v high roof 1550 1088 1650 709 2975 1797 1178 4975

2900 1.9CDTI high roof* 1550 1103 1650 710 2990 1813 1177 4990

2900 2.5CDTI 16v high roof 1580 1179 1650 707 3015 1886 1129 5015

2900 2.5DTI 16v high roof Tecshift** 1580 1187 1650 706 3070 1893 1177 5070


Loadspace mm (inches)

A Maximum length 2415 (95.1)

A1 Maximum length1920 (75.6)

at load floor – doublecab


behind rear seats – doublecab

B Maximum width 1663 (65.5)

C Maximum height – std. roof 1387 (54.6)

D Maximum height – high roof 1913 (75.3)

E Width between wheel arches 1268 (49.9)

Interior dimensions

SAE method cu.m (cu.ft.)

Std. roof 5.3 (187)

High roof 7.4 (261)

VDA method cu.m (cu.ft.)

Std. roof 5.0 (177)

Std. roof doublecab 3.3 (116)

High roof 7.1 (251)

Loadspace volume

SWB panel van SWB doublecab LWB panel van LWB doublecab

* = Weights for 1.9CDTI (82PS/100PS) models. ** = Available to order Summer 2005.

Note: Kerbweights for standard vehicles include coolant, oil, 90% full fuel tank and spare wheel. They will vary according to the vehicle specification (including options and accessories) with

a corresponding variation in payload. Payload figures do not allow for the weight of the driver, or any passengers, which should therefore be deducted from the figures shown. Gross platedweights (including axle weights) quoted on the vehicle plate must never be exceeded. Roof load should not exceed 200kg including the weight of the roof rack/carrier. Towing weightsshould not exceed 750kg (unbraked trailer) or 2000kg (braked trailer).

* = Weights for 1.9CDTI (82PS/100PS) models. ** = Available to order Summer 2005.


a corresponding variation in payload. Payload figures do not allow for the weight of the driver, or any passengers, which should therefore be deducted from the figures shown. Gross platedweights (including axle weights) quoted on the vehicle plate must never be exceeded. Roof load should not exceed 200kg including the weight of the roof rack/carrier. Towing weightsshould not exceed 750kg (unbraked trailer) or 2000kg (braked trailer).




2700 2.0i 16v std. roof 1450 1022 1550 633 2685 1655 1030 4685

2700 1.9CDTI std. roof* 1450 1036 1550 635 2700 1671 1029 4700

2700 1.9CDTI (100PS) Sportive std. roof 1450 1062 1550 646 2700 1708 992 4700

2700 2.5CDTI 16v std. roof 1450 1115 1550 635 2760 1750 1010 4760

2700 2.5CDTI 16v std. roof Tecshift** 1550 1123 1650 634 2790 1757 1033 4790

2700 2.5CDTI 16v Sportive std. roof 1450 1141 1550 646 2760 1787 973 4760

2900 2.0i 16v std. roof 1550 1025 1650 637 2885 1662 1223 4885

2900 1.9CDTI std. roof* 1550 1039 1650 639 2900 1678 1222 4900

2900 1.9CDTI doublecab std. roof* 1550 1099 1650 702 2900 1801 1099 4900

2900 2.5CDTI 16v std. roof 1550 1115 1650 635 2965 1750 1215 4965

2900 2.5CDTI 16v std. roof Tecshift** 1550 1123 1650 634 2960 1757 1203 4960

2900 2.5CDTI 16v doublecab std. roof 1550 1175 1650 698 2965 1873 1092 4965

2900 2.5CDTI 16v doublecab std. roof Tecshift** 1550 1183 1650 697 2960 1880 1080 4960

2900 2.0i 16v high roof 1550 1044 1650 699 2885 1743 1142 4885

2900 1.9CDTI high roof* 1550 1058 1650 701 2900 1759 1141 4900

2900 2.5CDTI 16v high roof 1550 1134 1650 697 2975 1831 1144 4975

2900 2.5CDTI 16v high roof Tecshift** 1550 1142 1650 696 2970 1838 1132 4970

E

C

A1

B

A2

A

E

B

D

C

B

E

A1

A2C

Side door(s) mm (inches)

Aperture height 1285 (50.6)

Aperture width 1000 (39.4)

Rear doors mm (inches)

Aperture height – std. roof 1320 (52.0)

Aperture height – high roof 1818 (71.6)

Aperture width (at floor) 1390 (54.7)

Loading height – std./high roof 549 (21.6)

Loadspace mm (inches)

A Maximum length 2815 (110.8)


at load floor – doublecab


behind rear seats – doublecab

B Maximum width 1663 (65.5)

C Maximum height – std. roof 1387 (54.6)

D Maximum height – high roof 1913 (75.3)


Interior dimensions


Std. roof 6.2 (219)

High roof 8.7 (307)

VDA method cu.m (cu.ft.)

Std. roof 5.9 (208)

Std. roof doublecab 4.2 (148)

High roof 8.4 (297)

Loadspace volume

Side door(s) mm (inches)

Aperture height 1285 (50.6)

Aperture width 1000 (39.4)

Rear doors mm (inches)

Aperture height – std. roof 1320 (52.0)

Aperture height – high roof 1818 (71.6)

Aperture width (at floor) 1390 (54.7)

Loading height – std. roof 542 (21.3)

Loading height – high roof 547 (21.5)

S.8

Safety

Standard features ● Driver's airbag and pyrotechnic body-lock seatbelt pretensioner ● Anti-lock Braking System (ABS) and Electronic Brakeforce

Distribution (EBD) ● Emergency Brake Assist (EBA) ● Height-adjustable padded head restraints ● Three inertia-reel lap and diagonal front seatbelts ● Height-adjustable outer seatbelts (front only – crew cab) ● Anti-submarining ramps in seats ● Laminated windscreen ● Crash protection box

behind front bumper

Interior features

Standard features ● Vinyl floor covering in cabin area ● Twin sunvisors ● Twin passenger assist handles (one only with single passenger seat) ● Air blend heater with four-speed fan ● Four adjustable face-level heating and ventilation outlets ● Windscreen and side-window demist vents ● Overhead storage shelf (high roof/maxi roof only) ● Fade down cabin area courtesy light ● Adjustable map reading light ● Driver’s and passenger’s

door armrests ● Driver’s and front passenger’s door pockets with bottle holder

Audio, communication and navigation (see page S.11 for details)

Standard features ● CD 413 RDS EON stereo radio/compact disc player ● Traffic Programme ● Two door-mounted speakers ● Flexible roof-mounted aerial

Additional features Panel van Chassis cab Crew cab

Air-conditioning4 and full-height steel bulkhead ●●

Air-conditioning4 and full-height steel bulkhead with window ●●

Air-conditioning4 ●● ●●


CR 213 RDS EON stereo radio/cassette player N/C N/C N/C

MS 4150 RDS EON stereo radio/compact disc player/CD-ROM-driven satellite navigation system/●● ●● ●●

monochromatic display

Standard features ● New Orleans cloth seat trim ● Driver’s seat adjustable for height, cushion angle, reach and rake ● Driver’s seat armrest● Dual front passengers’ bench seat ● Dual front passengers’ bench seat underseat storage tray

Seating


Vinyl seat trim2 N/C N/C N/C

Multi-function front passengers’ bench seat with underseat storage facility2 ●● ●● ●●

Single passenger seat and full-height steel load restraint mesh behind passenger1 N/C N/C3

Single fully adjustable ‘comfort’ passenger seat with armrest and ●● ●●

3full-height steel load restraint mesh behind passenger2

Four-passenger rear bench seat with underseat storage facility ●

movano

specification

Standard features ● Facia-mounted gear lever ● Trip odometer ● Rev counter ● Coolant temperature gauge ● Fuel gauge with low fuel level

warning light ● Engine oil level indicator ● Warning lights for low brake fluid, engine temperature and fuel filter ● Cigar lighter/accessory socket● Digital clock ● Lidded glovebox ● Facia-mounted document clip ● Document storage pocket ● Facia-mounted drinks holders

Facia, instruments and controls


Tachograph ●● ●● ●●

Trip computer ●● ●● ●●

Cruise control ■■ ■■ ■■

Load area (panel van)

Standard features ● Nearside sliding side-access door ● Full-height steel load restraint mesh behind driver ● Illuminated load area ● Load restraint

lashing eyes (SWB – six. MWB/LWB – eight) ● Internal lockable rear and sliding side-access doors ● Unglazed rear doors (90˚/180˚opening)

Security

Standard features ● Remote control central locking with internal switch ● Automatic door locking ● Electronic engine deadlock immobiliser● Steering column lock ● Freewheeling door and steering lock cylinders ● Locking fuel filler cap

Exterior features


Rear parking distance sensor10 ●●

Electrically operated front windows ■■ ■■ ■■

Electrically adjustable/heated door mirrors ■■ ■■ ■■

Two-coat metallic paint ●● ●● ●●

Special paint (restrictions apply – please consult your retailer for availability) ●● ●● ●●

Standard features ● Two-speed windscreen wipers with variable intermittent wipe and electric screenwash ● Lights-on audible warning ● Electric

headlight beam levelling ● Twin adjustable and foldable door mirrors (wide-angle on driver’s side) ● Extended mirror arms (chassis cab/crew cab) ● High-level brake light (panel van) ● Twin reversing lights ● Rear fog light ● Body side-protection mouldings (doors only – chassis cab/crew cab)

S.9

Standard features ● Five-speed manual gearbox – 1.9CDTI (82PS)/2.5CDTI 16v (100PS) ● Six-speed manual gearbox – 2.5CDTI 16v (115PS)/

3.0CDTI 16v (136PS) ● Power-assisted steering

Mechanical


Engine-driven power take-off4 ●● ●● ●●

Pneumatic rear suspension adjustable for height (not available on 1.9CDTI) ●● ●● ●●

Reinforced rear suspension (standard on 1.9CDTI) ●● ● ●

Tow bar in conjunction with reinforced rear suspension10 ●●

Tecshift six-speed transmission with sequential manual gearshift and automatic mode (2.5CDTI 16v only) ●● ●● ●●

Wheels and tyres

Standard feature ● 6J x 16 steel wheels with wheel centre covers

Panel van Chassis cab Crew cab

Electric pack ● Electrically operated front windows ● Electrically adjustable/heated door mirrors ●● ●● ●●

Technical pack ● Cruise control with speed limiter ● Trip computer ●● ●● ●●

Option packs

movano

Additional feature Panel van Chassis cab Crew cab

Remote control ultrasonic security alarm system ●● ●● ●●


Full-height steel bulkhead ●●

Full-height steel bulkhead with window ●●

Fixed window on nearside sliding side-access door and opposite panel ●●

Fixed windows on nearside and optional offside sliding side-access doors ●●

Offside sliding side-access door5 ●●

Delete standard nearside sliding side-access door5,6 N/C

Glazed rear doors (90˚/180˚opening) with dipping rear-view mirror ●●

Glazed rear doors (90˚/180˚opening) with dipping rear-view mirror and heated windows ●●

270˚opening unglazed rear doors (not available on SWB models) ●●

270˚opening glazed rear doors with dipping rear-view mirror (not available on SWB models) ●●

Resin-coated wooden load floor covering7 ●●

Half-height protection panelling ●●

Full-height load area plywood lining with anti-slip flooring and wheel arch protection7 ●●

Glazed van pack (includes glazed upper side panels and rear doors)8 ●●

Tilting glass sunroof for load area9 ●●


195/65 R 16 tyres – 2800 models ● ●

215/65 R 16 tyres – 3300 models ●

225/65 R 16 tyres – 3500 models ● ● ●

Delete spare wheel N/C N/C N/C

● = Standard equipment.


N/C = No-cost option.■■ = Only available as part of an extra-cost option pack.

1 = Front passengers’ twin airbag is not available when

the single passenger’s seat option is specified.

2 = Vinyl seat trim is not available in conjunction with

multi-function front passengers’ bench seat or single fully

adjustable ‘comfort’ passenger seat option.

3 = Full-height steel load restraint mesh behind

passenger seat is not available on chassis cab models.

4 = Air-conditioning not available in conjunction with

engine-driven power take-off.

5 = Offside sliding side-access door not available when

the delete standard nearside sliding side-access door or

glazed van pack options are specified.

6 = Deletion of standard nearside sliding side-access door

is not available when the glazed van pack or glazed rear

door options are specified.

7 = Resin-coated wooden load floor covering is not

available when the full-height load area plywood lining

with anti-slip flooring and wheel arch protection option

is specified.

8 = Glazed van pack not available when delete standard

nearside sliding side-access door, offside sliding

side-access door, half-height protection panelling or

full-height plywood lining options are specified.

9 = Tilting glass sunroof not available on maxi roof models.

10 = Tow bar with reinforced rear suspension is not

available when the rear parking distance sensor is

specified.


Front passengers’ twin airbag and pyrotechnic body-lock seatbelt pretensioners1 ●● ●● ●●

Lap and diagonal inertia-reel outer rear seatbelts and two centre rear lap belts ●

movano technical data

S.10

Transmission ratios

Engines

1.9CDTI 2.5CDTI 16v (100PS) 2.5CDTI 16v (115PS) 3.0CDTI 16v

Fuel type Diesel Diesel Diesel Diesel

Capacity 1870cc 2463cc 2463cc 2953cc

Maximum power 82PS (60kW) @ 3500rpm 100PS (73kW) @ 3500rpm 115PS (84kW) @ 3500rpm 136PS (100kW) @ 3600rpm

Maximum torque 200Nm (147 lb.ft.) @ 2000rpm 260Nm (192 lb.ft.) @ 1500rpm 290Nm (214 lb.ft.) @ 1600rpm 320Nm (236 lb.ft.) @ 1800rpm

Compression ratio 18.3:1 17.7:1 16.9:1

Emission compliance Euro 3

Layout 4 cylinders / 4 cylinders /

2 valves per cylinder / 4 valves per cylinder /

single overhead camshaft double overhead camshafts

Induction system Turbocharger and intercooler. Common rail fuel injection

Service interval 18,000 miles or two years* 24,000 miles or two years*

* = Whichever occurs sooner.

Vauxhall Assistance andwarranties†

Every Movano base vehicle comes with:● A one-year unlimited mileage

manufacturer’s warranty● Second and third year no-fee customer

option warranty up to 100,000 miles from

date of first registration● Vauxhall Assistance for 36 months from

date of first registration● Six-year body panel anti-perforation

warranty

† = Warranty is only available on vehicles sourced

from Vauxhall Motors Ltd. Terms and conditions

apply – please see your Vauxhall Commercial

Vehicle retailer for details.

Insurance groupsSWB panel van:

2800 1.9CDTI/2.5CDTI 16v (100PS) models

– 13A.

2800 2.5CDTI 16v (115PS)/3300 2.5CDTI

16v (100PS) models – 14A.

3300/3500 all models (exc. 3300 2.5CDTI

16v (100PS)) – 15A.

MWB panel van:

3300/3500 all models

(exc. 3500 3.0CDTI 16v) – 15A.

3500 3.0CDTI 16v models – 16A.

LWB panel van:

3500 2.5CDTI 16v (100PS) high roof – 15A.

3500 all models (exc. 2.5CDTI 16v (100PS)

high roof) – 16A.

Chassis cab:

All models – 15A.

Crew cab:

2.5CDTI 16v (100PS/115PS) models – 15A.

3.0CDTI 16v models – 16A.

As recommended by the Association of

British Insurers.

Fuel tank capacity100 litres (22 gallons).

Fuel economy2.5CDTI (115PS) 3500 MWB high roof –

29.5mpg (fully laden) – Commercial

Fleet World magazine, January 2004.

Important: Figures quoted relate to the particular

vehicle tested by an independent organisation. They

do not necessarily follow any government-approved

vehicle testing procedures. Variations in equipment,

payload, driving style, road and traffic conditions,

vehicle mileage and standard of maintenance may

also affect fuel consumption; therefore the test

results do not express or imply any guarantee of fuel

consumption attainable.

Transmissions● Front-wheel drive● Five-speed manual gearbox

– 1.9CDTI, 2.5CDTI 16v (100PS)● Six-speed manual gearbox

– 2.5CDTI 16v (115PS), 3.0CDTI 16v● Six-speed Tecshift transmission – available

at extra cost on 2.5CDTI 16v

(100PS/115PS) models

Tecshift hydraulic transmission offers

all the main features and flexibility of a

regular automatic, plus the performance

and control of a ‘one touch’ manual gearbox.

In manual mode the driver changes gear

sequentially by pushing the lever forward

(higher gear) or pulling it backwards (lower

gear), with automatic-style ‘kickdown’

through two or more gears also possible

in manual mode. In addition, the Tecshift

transmission offers variable settings to

adjust for vehicle loading. Automatic clutch

control means there is no need for a clutch

pedal. Drivers may switch between modes

on the move using the gearshift selector.● Hydraulic, asbestos-free single-plate clutch

Steering● Power-assisted rack and pinion system● Turning circles (kerb-to-kerb/wall-to-wall):

SWB – 12.07m (39.6ft.)/12.48m (40.9ft.)

MWB – 13.75m (45.1ft.)/14.11m (46.3ft.)

LWB – 15.20m (49.9ft.)/15.68m (51.4ft.)● Turns lock-to-lock: 3.6

SuspensionFront: Independent double wishbones

with coil springs and telescopic dampers.

Anti-roll bar on 3300/3500 models.

Rear: Tubular axle with variable-rate single

leaf springs (steel on 2800 panel vans,

chassis and crew cabs, composite on

3300/3500 panel vans) and telescopic

dampers. Anti-roll bar on 3500 LWB vans

and all chassis cab models. Reinforced rear

suspension (does not increase axle load

rating) standard on 1.9CDTI panel van,

chassis and crew cab models, optional

at extra cost on 2.5CDTI 16v (100PS),

2.5CDTI 16v (115PS) and 3.0CDTI 16v panel

vans. Pneumatic suspension adjustable for

height optional at extra cost (not 1.9CDTI).

Minimum ground clearance:

All base models (laden) – 150mm (5.9 inches).

Brakes● Four-channel Anti-lock Braking System

(ABS) with Electronic Brakeforce

Distribution (EBD)● Emergency Brake Assist (EBA)● Vacuum servo-assisted system● Dual circuit with secondary system acting

on front brakes only● Low brake fluid level warning light● Asbestos-free brake linings● Floor-mounted parking brake lever

Front ventilated disc brakes:

305mm diameter.

Rear disc brakes:

305mm diameter.

Body● Six-year body panel anti-perforation

warranty● Galvanised body panels● Anti stone-chip mastic coating on sills● Individually removable lower body panels● Flush-fitted windscreen and rear door glass

(when specified)● Flat-topped box section, chassis rails and

crossmembers (chassis cab/crew cab)● Detachable front towing eye● Rear towing eye

ElectricsMaintenance-free battery: 85Ah.

Alternator:

1.9CDTI (82PS) – 125A.

2.5CDTI 16v (100PS/115PS) – 150A.

3.0CDTI 16v (136PS) – 130A.

S.11

audio, communication and navigationAudio standard features

General (all models) ● Four-figure security code ‘burnt in’ to memory chip ● Seven sound presets ● Separate bass and treble adjustment● Balance control ● Two speakers

Tuner (all models) ● Full RDS EON ● FM, MW and LW reception ● Microprocessor-controlled quartz tuning ● Six station preset buttons● Traffic Programme ● Up and down manual tuning functions ● Autostore function ● Automatic search tuning

Cassette player (CR 213) ● Fast forward/rewind ● Radio reception during fast cassette wind ● Autoreverse function

CD player (CD 413/MS 4150) ● Single-disc CD player†† ● Track up/down facility ● Random and continuous play facilities

Additional features CR 213 CD 413 MS 4150

Maximum output (watts per channel) 20 35 40

Programmable speed-dependent volume control ●

CR 213 stereo radio/cassette player

(optional at no extra cost).

CD 413 stereo radio/CD player (standard). MS 4150 stereo radio/CD player/CD-ROM-driven

satellite navigation system (optional at extra cost).

Standard features (MS 4150) ● Automatic re-routing on request ● Display of estimated time remaining and distance to destination ● Exact location of vehicle using the GPS (Global Positioning System) and speed sensor ● Choice of four different route types – Using motorways, avoiding motorways, shortest distance, shortest journey time ● Store up to 200 personal destinations● ‘Points of Interest’ menu offers a wide choice of popular destinations ● Last 20 destinations stored automatically● CD-ROM containing road map software and travel guide information

Satellite navigation

NavigationThe MS 4150 stereo radio/CD player/

navigation unit uses the international network

of GPS (Global Positioning System) satellites

linked to a comprehensive CD-ROM mapping

system to determine your precise location

and guide you to your chosen destination

virtually anywhere in mainland Britain.

Despite its technical sophistication, the

system is very simple to operate, using

a range of menu-driven options.

Clearly spoken instructions indicate the road

you need to take or the lane you need to be

in, both well in advance and again when the

manoeuvre is due. Directional pictograms,

clearly shown on the monochromatic display

screen, back up the spoken commands.

The CD-ROM supplied with the system is

encrypted and can be partially or completely

activated for a defined period with the aid of

an access code. The benefits of this are that

only information or time used is charged,

automatic CD updates are received and the

latest information is always available.

● = Standard feature.

†† = Please note: on MS 4150 units an audio CD cannot be played whilst the navigation CD is loading.

Gear ratios (mph/1000rpm) Final driveManual 5/6-speed 1 2 3 4 5 6 Reverse ratio

2800 1.9CDTI (82PS) 4.18:1 (4.2) 2.24:1 (7.9) 1.39:1 (12.7) 0.90:1 (19.6) 0.71:1 (25.0) – 3.89:1 4.44:1

2800 2.5CDTI 16v (100PS) 4.18:1 (4.5) 2.24:1 (8.4) 1.39:1 (13.5) 0.90:1 (20.8) 0.71:1 (26.5) – 3.89:1 4.19:1

2800 2.5CDTI 16v (115PS) 4.18:1 (4.5) 2.24:1 (8.4) 1.39:1 (13.5) 0.98:1 (19.2) 0.76:1 (24.8) 0.64:1 (29.4) 3.89:1 4.19:1

3300 2.5CDTI 16v (100PS) 4.18:1 (4.4) 2.24:1 (8.2) 1.39:1 (13.3) 0.90:1 (20.4) 0.71:1 (26.0) – 3.89:1 4.44:1

3300 2.5CDTI 16v (115PS) 4.18:1 (4.4) 2.24:1 (8.2) 1.39:1 (13.3) 0.98:1 (18.9) 0.76:1 (24.3) 0.64:1 (28.8) 3.89:1 4.44:1

3300 3.0CDTI 16v (136PS) 3.91:1 (4.3) 2.11:1 (8.0) 1.29:1 (13.0) 0.89:1 (18.9) 0.69:1 (24.4) 0.55:1 (30.6) 3.89:1 4.87:1

3500 2.5CDTI 16v (100PS) 4.18:1 (4.3) 2.24:1 (8.0) 1.39:1 (12.8) 0.90:1 (19.7) 0.71:1 (25.2) – 3.89:1 4.44:1

3500 2.5CDTI 16v (115PS) 4.18:1 (4.3) 2.24:1 (8.0) 1.39:1 (12.8) 0.98:1 (18.2) 0.76:1 (23.5) 0.64:1 (27.9) 3.89:1 4.44:1

3500 3.0CDTI 16v (136PS) 3.91:1 (4.2) 2.11:1 (7.7) 1.29:1 (12.6) 0.89:1 (18.3) 0.69:1 (23.6) 0.55:1 (29.6) 3.89:1 4.87:1

Tecshift 6-speed

2800 2.5CDTI 16v** 4.18:1 (4.5) 2.24:1 (8.4) 1.39:1 (13.5) 0.98:1 (19.2) 0.76:1 (24.8) 0.64:1 (29.4) 3.89:1 4.19:1

3300 2.5CDTI 16v** 4.18:1 (4.4) 2.24:1 (8.2) 1.39:1 (13.3) 0.98:1 (18.9) 0.76:1 (24.3) 0.64:1 (28.8) 3.89:1 4.44:1

3500 2.5CDTI 16v** 4.18:1 (4.3) 2.24:1 (8.0) 1.39:1 (12.8) 0.98:1 (18.2) 0.76:1 (23.5) 0.64:1 (27.9) 3.89:1 4.44:1

** = Ratios for 2.5CDTI 16v (100PS/115PS models).

S.13

Measurements are shown in millimetres (inches). All heights are shown unladen.

Maxi roof2721 (107.0)

High roof 2493 (98.1)

959 (37.8)3578 (140.9)

5399 (212.6)

862 (33.9) 1990 (78.3)excluding door mirrors


959 (37.8)862 (33.9) 3078 (121.2)

4899 (192.9)




Std. roof 2253 (88.7)


Std. roof 8.0 (282)

High roof 9.1 (321)

Interior dimensions

Loadspace mm (inches) Side door mm (inches) Rear doors mm (inches)

A Maximum length 2714 (106.9) Aperture height – std. roof 1555 (61.2) Aperture height – std. roof 1632 (64.3)

B Maximum width 1764 (69.4) Aperture height – high roof 1800 (70.9) Aperture height – high roof 1874 (73.8)

C Maximum height – std. roof 1670 (65.7) Aperture width 1099 (43.3) Aperture width (at floor) 1515 (59.6)

D Maximum height – high roof 1912 (75.3) Loading height – std./high roof 545 (21.4)


Loadspace volume



High roof 10.8 (381)

Maxi roof 12.0 (424)

Loadspace volume

Interior dimensions


A Maximum length 3214 (126.5) Aperture height - high/maxi roof 1800 (70.9) Aperture height 1874 (73.8)

B Maximum width 1764 (69.4) Aperture width 1099 (43.3) Aperture width (at floor) 1515 (59.6)

C Maximum height – high roof 1912 (75.3) Loading height – high/maxi roof 541 (21.3)

D Maximum height – maxi roof 2147 (84.5)



S.12


AB

C

E

D

A B

C

E

D

movano dimensions and weights

* = Weights for 2.5CDTI 16v (100PS/115PS) models.

Note: Kerbweights for standard vehicles include coolant, oil, 90% full fuel tank and spare wheel. They will vary according to the vehicle specification (including options and accessories) with a

corresponding variation in payload. Payload figures do not allow for the weight of the driver, or any passengers, which should therefore be deducted from the figures shown. Gross platedweights (including axle weights) quoted on the vehicle plate must never be exceeded. Roof load should not exceed 200kg including the weight of the roof rack/carrier. Towing weightsshould not exceed 750kg (unbraked trailer) or 2000kg (braked trailer).




SWB panel van MWB panel van




2800 1.9CDTI std. roof 1550 1120 1600 637 2800 1757 1043 4800

2800 2.5CDTI 16v std. roof* 1550 1163 1600 636 2800 1799 1001 4800

2800 2.5CDTI 16v Tecshift std. roof* 1550 1171 1600 635 2800 1806 994 4800

3300 2.5CDTI 16v high roof* 1750 1183 1900 647 3300 1830 1470 5300

3300 2.5CDTI 16v Tecshift high roof* 1750 1192 1900 646 3300 1838 1462 5300

3300 3.0CDTI 16v high roof 1750 1236 1900 634 3300 1870 1430 5300

3500 2.5CDTI 16v high roof* 1850 1187 2060 650 3500 1837 1663 5500


3500 3.0CDTI 16v high roof 1850 1239 2060 637 3500 1876 1624 5500




3300 2.5CDTI 16v high roof* 1750 1213 1900 658 3300 1871 1429 5300


3300 3.0CDTI 16v high roof 1750 1264 1900 647 3300 1911 1389 5300

3500 2.5CDTI 16v high roof* 1850 1218 2060 661 3500 1879 1621 5500


3500 3.0CDTI 16v high roof 1850 1267 2060 650 3500 1917 1583 5500

3500 2.5CDTI 16v maxi roof* 1850 1233 2060 669 3500 1902 1598 5500

3500 2.5CDTI 16v Tecshift maxi roof* 1850 1241 2060 669 3500 1910 1590 5500

3500 3.0CDTI 16v maxi roof 1850 1283 2060 658 3500 1941 1559 5500

AB

C

E

D


High roof 12.6 (445)

Maxi roof 13.9 (491)

S.15S.14

Loadspace volume

Maxi roof2720 (107.1)

High roof 2490 (98.0)

959 (37.8)4078 (160.6)

5899 (232.3)

862 (33.9) 1990 (78.3)excluding door mirrors



Interior dimensions


A Maximum length 3714 (146.2) Aperture height - high/maxi roof 1800 (70.9) Aperture height 1874 (73.8)

B Maximum width 1764 (69.4) Aperture width 1099 (43.3) Aperture width (at floor) 1515 (59.6)

C Maximum height – high roof 1912 (75.3) Loading height – high roof 538 (21.2)

D Maximum height – maxi roof 2147 (84.5) Loading height – maxi roof 537 (21.1)



A

E

712(28.0)

G

D

C



B

2200(86.6)

4869 (191.7)

3078 (121.2) 929 (36.6)862 (33.9)

F


Recommended conversion dimensions

mm (inches) mm (inches)

A Maximum allowable overall length – chassis cab/body 5519 (217.3) E Maximum allowable body height above chassis 2788 (109.8)

B Maximum allowable overall width of body 2230 (87.8) F Front axle to back of cab 1342 (52.8)

C Maximum allowable rear overhang from rear axle 1579 (62.2) G Minimum allowable body length 2654 (104.5)

D Maximum allowable body length 3304 (130.0)

movano dimensions and weights










* = Weights for 2.5CDTI 16v (100PS/115PS) models. ** = Availability to be confirmed. Please consult your retailer. † = The weight of any fitted conversion body will have to be deducted

from these figures to establish actual payload.

Note: Kerbweights for standard vehicles include coolant, oil, 90% full fuel tank and spare wheel. They will vary according to the vehicle specification (including options and accessories)

with a corresponding variation in payload. Payload figures do not allow for the weight of the driver, or any passengers, which should therefore be deducted from the figures shown. Grossplated weights (including axle weights) quoted on the vehicle plate must never be exceeded. Towing weights should not exceed 750kg (unbraked trailer) or 2000kg (braked trailer).

5369 (211.4)

A

3578 (140.9) 929 (36.6)862 (33.9)

E

669(26.3)

G

D

F

C



B

2200(86.6)



MWB chassis cab


LWB panel van SWB chassis cab**




3500 2.5CDTI 16v high roof* 1850 1248 2060 673 3500 1921 1579 5500


3500 3.0CDTI 16v high roof 1870 1296 2060 664 3500 1960 1540 5500

3500 2.5CDTI 16v maxi roof* 1850 1266 2060 683 3500 1949 1551 5500

3500 2.5CDTI 16v Tecshift maxi roof* 1850 1266 2060 683 3500 1949 1551 5500

3500 3.0CDTI 16v maxi roof 1870 1314 2060 673 3500 1987 1513 5500




2800 2.5CDTI 16v* 1550 1222 1600 429 2800 1651 1149† 4800

2800 2.5CDTI 16v Tecshift* 1550 1231 1600 429 2800 1660 1140† 4800




3500 2.5CDTI 16v* 1850 1219 2060 398 3500 1617 1883† 5500

3500 2.5CDTI 16v Tecshift* 1850 1227 2060 397 3500 1624 1876† 5500

3500 3.0CDTI 16v 1850 1269 2060 386 3500 1655 1845† 5500








E

666(26.2)

A

G

D

C

F

5869 (231.1)

4078 (160.6) 929 (36.6)862 (33.9)



B

2195(86.4)


E

662(26.1)

A

G

D

C

F

5869 (231.1)

4078 (160.6) 929 (36.6)862 (33.9)



B

2203(86.7)




A Maximum allowable overall length – crew cab/body 6519 (256.6) E Maximum allowable body height above chassis 2838 (111.7)





Plated weightThe maximum weight to which a vehicle

or an axle may be loaded, determined

either by the design of the components or

by legislation. All commercial vehicles must

carry a manufacturer’s ‘plate’ showing the

vehicle and axle gross ‘plated weights’. It is

an offence to drive a vehicle in a condition

where any of these weights are exceeded.

KerbweightThe weight of the complete vehicle in

standard form, excluding payload and

driver but including coolant, oil, 90% full fuel

tank and spare wheel where appropriate.

Kerbweights quoted in Vauxhall brochures

are subject to manufacturing tolerances and

to the fitment of optional equipment and

accessories. Where load capacity is critical

the actual kerbweight should be obtained

by weighing the vehicle on a calibrated

public weighbridge.

Gross Vehicle Weight (GVW)The total permissible weight of a vehicle

including payload and passengers, as shown

on the manufacturer’s plate.

Gross Combination Weight (GCW)The maximum permissible weight of a

vehicle, including payload and passengers,

combined with the total weight of any trailer

it is towing. The maximum GCW weight limit

is quoted on the vehicle plate and must not

be exceeded.

PayloadThe total permissible weight that can be

carried without exceeding the vehicle’s plated

weight. This can be obtained by deducting the

kerbweight from the plated Gross Vehicle

Weight (GVW). Please note: the payload

figure does not allow for the weight of the

driver or any passengers.

Maximum towing weightThe maximum weight of any trailer and its

load which may be towed within the limit

of the vehicle’s plated Gross Combination

Weight (GCW). It is based on the ability of

the vehicle – at full GCW – to restart on a

12% gradient, which is approximately 1 in 8.3,

at sea level. At altitudes above 1500 metres,

the engine output may drop with a

corresponding reduction in towing capability.

It is the operator’s responsibility to ensure

that the trailer noseweight does not cause

the rear axle plated weight of the towing

vehicle to be exceeded.

Always fit Vauxhall towing attachments

and accessories available from your

Vauxhall Commercial Vehicle retailer.

They are designed specifically for Vauxhall

models and carry a 12-month warranty.

glossary of terms

* = Weights for 2.5CDTI 16v (100PS/115PS) models. ** = Availability to be confirmed. Please consult your retailer. † = The weight of any fitted conversion body will have to be deducted

from these figures to establish actual payload.


a corresponding variation in payload. Payload figures do not allow for the weight of the driver, or any passengers, which should therefore be deducted from the figures shown. Gross platedweights (including axle weights) quoted on the vehicle plate must never be exceeded. Towing weights should not exceed 750kg (unbraked trailer) or 2000kg (braked trailer).




B

2209(87.0)

5369 (211.4)

A

3578 (140.9) 929 (36.6)862 (33.9)

E

676(26.6)

G

D

F

C



A Maximum allowable overall length – crew cab/body 6019 (237.0) E Maximum allowable body height above chassis 2824 (111.2)





S.17S.16

movano dimensions and weightsLWB chassis cab LWB crew cab

MWB crew cab**




3500 2.5CDTI 16v* 1850 1234 2060 398 3500 1632 1868† 5500

3500 2.5CDTI 16v Tecshift* 1850 1243 2060 398 3500 1641 1859† 5500

3500 3.0CDTI 16v 1850 1282 2060 389 3500 1671 1829† 5500




3500 2.5CDTI 16v* 1850 1325 2060 476 3500 1801 1699† 5500

3500 2.5CDTI 16v Tecshift* 1850 1333 2060 475 3500 1808 1692† 5500

3500 3.0CDTI 16v 1850 1375 2060 464 3500 1839 1661† 5500




3500 2.5CDTI 16v* 1850 1338 2060 476 3500 1814 1686† 5500

3500 2.5CDTI 16v Tecshift* 1850 1347 2060 476 3500 1823 1677† 5500

3500 3.0CDTI 16v 1850 1369 2060 460 3500 1829 1671† 5500

customer care

There are more important things to life than worrying about how to finance and serviceyour commercial vehicle, where to go in the event of an accident and how we go aboutmeeting the transport challenges of the future. So when you choose Vauxhall, you can rely on us to safeguard both you and the environment around you, leaving you free toconcentrate on the more important business of enjoying your commercial vehicle!

Customer Care CommitmentFor added peace of mind, Vauxhall has aninnovative Customer Care Commitment*package that offers the following:

• A one-year unlimited mileage manufacturer’s warranty

• Second and third year no-fee customeroption warranty up to 60,000 miles onCorsavan, Astravan and Combo and 100,000 miles on Vivaro base and Movano base vehicles from date of first registration

• Vauxhall Assistance for 12 months (36 months for Movano) from firstregistration (conditions may apply tominibus models)

• Six years body panel anti-perforationwarranty

* = Warranty is only on vehicles sourced from

Vauxhall Motors Ltd. Terms and conditions apply

– please see your Vauxhall Commercial Vehicle

retailer for details.

Vauxhall Assistance**Vauxhall Assistance is operated by the AAand is provided automatically with every new Vauxhall Commercial Vehicle for 12months (36 months on Movano) from firstregistration and covers everything fromaccidents, mechanical breakdown and flattyres to illness while driving. With VauxhallAssistance help is literally just a free†

phone call away, 24 hours a day, 365 days a year!

Benefits include:• Full rescue service including roadside

assistance• Recovery – if a problem cannot be

solved at the roadside, or if someone istaken ill while driving, the driver, vehicleand all passengers will be transported to the nearest Vauxhall retailer or to anysingle UK destination

• ‘At home’ service – help will be sentif there is a vehicle problem at the driver’s home

• Accident assistance – if your vehicle is immobilised by an accident, both the vehicle and occupants will berecovered to your choice of destination(Vauxhall recommends a VauxhallApproved Accident Repair Centre, where appropriate)

• Vehicle theft – Vauxhall Assistance willhelp to keep you mobile in the unlikelyevent of your vehicle being stolen

** = Conditions may apply to minibus models.

Please consult your Vauxhall Commercial Vehicle

retailer for details.

† = Mobile phone users will be charged at their

standard tariff.

Protecting the environmentOur products are increasingly winningenvironmental awards, both through theuse of more recycled materials and bybecoming cleaner and more efficient. For information on Vauxhall's efforts toachieve an environmentally sustainablefuture, including information on Design for Recycling, take-back of End-of-LifeVehicles (ELVs), and the recycling of ELVs,see www.vauxhall.co.uk/recycling. Vauxhallwas also the first manufacturer to offer arange of dualfuel LPG/petrol vehicles,supported by a full factory warranty.

Specialist Mobility adviceMotability accredited Vauxhallretailers can provide specialmobility help and advice. Blue

badge holders are entitled to veryfavourable discounts when purchasing new vehicles. For full details contact yourlocal Motability accredited Vauxhall retaileror Freefone 0800 731 5267.

Fleet Customer ServicesOur dedicated support services for fleetmanagers includes factory demonstrators and information on whole life costs,company vehicle taxation and finance. For further information please call0870 010 0651.

Business LeaseBusiness Lease from GMAC is a leasefinancing programme offering highlycompetitive terms on all VauxhallCommercial Vehicles up to 12 months old. It offers all the versatility of a purchase-based finance plan but makes the most efficient use of current tax andcash-flow benefits to VAT-registeredbusiness users. Business Lease is alsohighly flexible, offering terms of between 12 and 48 months with a variable deposit(subject to a minimum of three months’rental) and a choice of payment profiles. Ask your retailer for full details, or for awritten quotation on the VauxhallCommercial Vehicle of your choice, pleasecontact GMAC, Wesley House, 19 ChapelStreet, Luton LU1 2SY. Security may berequired, subject to status. Applicants mustbe aged 18 or over.

Servicing and maintenanceThe best way to maximise the performanceand reliability of your Vauxhall CommercialVehicle is to have all routine servicing andmaintenance carried out at a VauxhallCommercial Vehicle retailer. There arearound 200 light commercial vehicle and150 heavy commercial vehicle retailersnationwide.

Sureguard protectionParticularly suitable for drivers covering higher mileages, Sureguard providesadditional cover against mechanical and electrical failures above and beyond Vauxhall’s Customer Care Commitment. • Extends Vauxhall Assistance for the

full duration of your Sureguard cover

• Can be purchased when you buy yournew vehicle, building the cost into the overall finance agreement

Speak to your retailer or call 0870 752 7020 for more information.

vivaro | movano

S.18 S.19

• Vauxhall Rental 0870 442 1567• Fleet support 0870 010 0651• Military and Diplomatic Sales 0870 442 1580• Vauxhall Accident Support 0800 010 304• Sureguard extended warranty 0870 752 7020• Vauxhall Leasing 0870 737 2557• Vauxhall Mobility 0800 731 5267• Dualfuel information 01582 874 388

Useful Contacts:

Vauxhall LeasingAs Vauxhall's own contract hire and fleetmanagement operation, Vauxhall Leasingprovides a one-stop-shop for competitivecar and commercial vehicle leasingsolutions – for business users and private individuals. Working with theVauxhall retailer network, we combine the support of a national contract with the convenience of a local contact. Forfurther information, please see your localVauxhall Commercial Vehicle retailer orcall us on 0870 737 2557.

Alternatively, you can visit our websiteat www.vauxhall-leasing.co.uk

In the event of an accident...Free to all Vauxhall drivers, VauxhallAccident Support can help keep you mobile following an accident, with promptrecovery to a Vauxhall Approved AccidentRepair Centre. For details, Freefone0800 010 304.

For a copy of thisbrochure in large print, Braille, or onaudio tape, please call 0845 600 1500. We can also becontacted using ourtextphone service on18001 08456 785 785.

For more information...For a brochure (up to a maximum of threeper caller) on any model in our commercialvehicle range: Corsavan, Astravan, Combo,Vivaro and Movano, or any model in ourcar range: Agila, Corsa, Meriva, New Tigra, New Astra, Astra Convertible, Zafira, Vectra,Signum, VX220 and Monaro, or details of your nearest Vauxhall retailer please Lo-call 0845 600 1500. Alternatively,details can be found on our website:www.vauxhall.co.uk

Lo-call 0845 600 1500www.vauxhall.co.uk

Get The GM Platinum Card and enjoy:

• 100 free Rebate Points when you first use yourGM Card – worth £100 off a new Vauxhall Commercial Vehicle

• Redeem up to 500 Rebate Points as high streetvouchers when you choose a new Vauxhall as yourcompany commercial vehicle

• 0% per annum on purchases and balance transfers forthe first five months from account opening,

Typical 14.9% APR variable.

Call 0845 746 2777 (quoting ref: BB55)to apply for your GM Platinum Card.

Or apply online at www.gmcard.co.uk/brochure

A N E W V A U X H A L L

H a v e fu n g e tt i n g t h e r e

Clean up on a shiny newVauxhall Commercial Vehicle

The GM Platinum Card is issued by HFC Bank Limited and is available to persons aged 18 years or over and resident in the UK (or 21 and over in the Channel Islands) and is subject to status and conditions. Written quotations available upon request from TheGM Platinum Card, PO Box 3615, Birmingham B3 2RJ. Typical 14.9% APR variable. For Balance Transfers and Purchases the rate is 0% per annum fixed for five months from account opening. The rate for Balance Transfers and Purchases made after theintroductory period is 1.167% per month variable. The rate for Cash Advances is 1.307% per month variable. Cash Advances also incur a 1.75% handling charge (minimum £2.50). An administration charge of 2.75% of the transaction value is payable fornon sterling transactions. No interest on Transactions if the balance is paid in full by the due date, otherwise interest payable from the date of Transaction. Interest payable on Cash Advances and Balance Transfers from date of advance. Monthly minimumpayment required is 2% of the outstanding balance with a minimum of £5 or the balance if less. The minimum credit limit is £250 and the maximum is £15,000. The typical APR quoted is the rate for new customers. Payments will be applied first to repaymentof any introductory or promotional rate balances. Rebate Points are earned on purchases using The GM Platinum Card. Rebate Points are not earned on Balance Transfers or Cash Advances. You earn money off a new Vauxhall by accumulating Rebate Pointsunder the Rebate Points Programme. Vauxhall Motors Ltd is solely responsible for the operation of the Rebate Points Programme, which is subject to the Rebate Points Programme Rules. You can redeem up to 2000 Rebate Points and unlimited Partner Pointssubject to the Model Line Maximum, which will vary in amount in relation to different Vauxhall vehicle model lines. Rebate Points and unlimited Partner Points are redeemable as discounts on a new Vauxhall vehicle and must be redeemed within four years ofyour account opening. Rebate Points may not be redeemed by Motability Contract Hire customers. ‘The GM Card’ is a trading name and style of both HFC Bank Limited and Vauxhall Motors Ltd. HFC Bank Limited is authorised and regulated by the FinancialServices Authority. Registered Office: North Street, Winkfield, Windsor, Berkshire SL4 4TD. Registered in England number 1117305. . Vauxhall Motors Ltd, Registered office: Griffin House, Osborne Road, Luton, Bedfordshire LU1 3YT.Registered in England number 135767. Details are correct at time of going to press.

trust vauxhall

Date post:	06-Mar-2018
Category:	Documents
Upload:	vuongkhuong
View:	222 times
Download:	2 times

Vivaro and Movano specification and technical · PDF filebody-lock front seatbelt pretensioner...

Documents