COSHH RISK ASSESSMENTAssessmentRef No.
TBC
Product Name & Product Code:
Jangro Kitchen Degreaser Heavy Duty, 5LBB015-5
Description of Substance:
Powerful cleaning and degreasing of all kitchen surfaces
Location Used: Kitchen areas: Floors, Hard Surfaces and HobsName & Address of Supplier Hazard
Statements:Yes
Wray Brothers Limited9 – 13 Pleasant Hill StreetLiverpool. L8 5SYT: 0151 709 2271
Precautionary Statements
Yes
MSDSAttached:
Yes
Use of SubstanceDilution How to Use5 litre bucketsDilute 1:50 parts hot water (100ml per 5L / 3 x pelican pumps per 5L). Mop, wipe or spray surface.
Spray bottlesTo re-fill a spray bottle. Dilute 30ml per 600ml (1 x pelican pump per 600ml) cold water.
Kitchen Floors & Hard SurfacesAdd to mop bucket for cleaning kitchen floors from 5 litre bottle or spray onto surface and wipe.
HobsSwitch off appliance and allow to cool. Spray onto surface and wipe clean. Rinse with clean water.
RefillRefill should be undertaken by Supervisor only.Task is to be carried out no higher than waist height.
Substance Properties PPE Requirements
Corrosive ArmProtection
HandProtection
EyeProtection
Skin/Body Protection
Signal Word:DANGER
Oversleeves GlovesBSEN 388:2003,
BSEN 374-2:2003, BSEN 374-3:2003
Over SpectaclesEN166:2001
Tabard
Route(s) of Exposure Group(s) at RiskInhalation No Ingestion Yes Operatives Yes Other (specify
below)Skin Yes Eyes Yes Other
employeesNo e.g. visitors or
the public
First Aid MeasuresInhalationUnlikely route of exposure as the product does not contain volatile substances. If spray/mist has been inhaled, proceed as follows. Move affected person to fresh air and keep warm and at rest in a position comfortable for breathing.
Skin contactWash with plenty of water. Get medical attention promptly if symptoms occur after washing.
IngestionDo not induce vomiting. Give plenty of water to drink. Get medical attention immediately.
Eye contactRinse immediately with plenty of water. Remove any contact lenses and open eyelids wide apart. Get medical attention immediately. Continue to rinse
Control MeasuresFire Precautions
Thermal decomposition or combustion products may include the following substances:Irritating gases or vapours.
Spillage Procedures
Small Spillages: Flush away spillage with plenty of water.Large Spillages: Contain and absorb spillage with sand, earth or other non-combustible material. Collect and place in suitable waste disposal containers and seal securely
Storage Requirements
Keep only in the original container in a cool, well-ventilated place.Store away from the following materials: Oxidising materials.
Disposal Procedures
Discharge used solutions to drain. Small amounts (less than 5 Litres) of unwanted product may be flushed with water to sewer. Larger volumes must be sent for disposal by approved waste contractor. Rinse out empty container with water and consign to normal waste.
Workplace ExposureWorkplace Exposure Limits Yes (refer to MSDS) Health Surveillance
RequirementsNot Applicable
Hazard Statements Precautionary StatementsH314 Causes severe skin burns and eye damage.
P102 Keep out of reach of children.P260 Do not breathe spray.P280 Wear protective gloves/ protective clothing/ eye protection/ face protection.P301+P330+P331 IF SWALLOWED: Rinse mouth. Do NOT induce vomiting.P303+P361+P353 IF ON SKIN (or hair): Take off immediately all contaminated clothing. Rinse skin with water/ shower.P304+P340 IF INHALED: Remove person to fresh air and keep comfortable for breathing.P305+P351+P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing.P315 Get immediate medical advice/ attention.P501 Dispose of contents/ container in accordance with local regulations.
CertificationName of Assessor
Emily Taylor Signed
Date December 2017 Date Review
As and when an accident occurs or a change to this chemical