Wire Rope
Lift with Experience WWW.BLUEJAYINDUSTRIAL.US
Bluejay Industrial Inc.Wire Rope
2
All wire rope is manufactured with three basic components: Wires, Strands and a Core.
The wire is the main component of the wire rope, and is produced by passing a wire rod through a set of drawing dies till the rod gets smaller and reaches its diameter and mechanical properties.Wires are then twisted together around a central wire to form strands.The strands are then helically laid together around a core which can be produced from either synthetic material or inner core strands to form the wire rope.
Diameter and tolerances
Nominal Diameter is always measured from its widest point as per diagram below.
The diameter of wire rope greater than 5/16” is manufactured with a tolerance of 0% to plus 5%. To get an actual diameter of a wire rope it is best to use a wide jaw vernier caliper, take two pairs of measurements, rectangular in two sections and at least 3 feet apart are made. The mean of the four measurements is the actual diameter. Measure-ments can be taken when the wire rope is subject to a load which is 5% of the minimum breaking strength for a more accurate result.
X Incorrect
Î Correct
Construction
������������ ���� �������� ����������������������������������������������� � ��������������������������������� ���������� ���������������� ���������������������������������� ������������������������������������������������ ������������� ������� ��� ����� � �������������� ���-����������������� ��������������������������� ���� � � ������!����������������� ���� ����� ����������!���������������������-��������������� ��������� ����� ����������"-�� !��������� ��������� ��������������������� ��������� ���������������#���$%���� ������������$%���� ��������� �������������%�������%�������$�����������
#���$%� %&%&$!����������������‘SEALE’
#���''� (�����(&(&$!�‘WARRINGTON’
#���)$� $'&#�����#&#&$!�‘WARRINGTON SEALE’
#���'*� $'&#�+�#,-!�.,-//0��1-�02
#���$%��������������������������.$%�1��2
Cross laid wire rope is where the mul-���������� �������� �������� ���������� ����������������������"�����-
��������� ���� ��������� �����������������������-�������������������3���"����������������������������pressures.
4�������������������� 03����/��!�� ���������������������� �������� �����
��������������� ����������������������������� ������������������������������� ���� ��������� ����� �������������� ����������������� �� �
Bluejay Industrial Inc.Wire Rope
3
Core
������������� ������������� ��� �� ��������������������� ���� ����������� ����������"����������������������������������������������������1������ ������� ��������������������������������������
,���5��� ,5��45���65!�� �������������������������������������������� ����� � � ���������� 65!������ ������������ ����� �������������� 45!��,������ ����
���������� ��������� ����������������������������� ��3������������������ ���������������������������������������������������������� �� ���������������������������������������������������,���������� �������� �������������������� �7��������� �-���������� ����� ����� �
8�����5��� 185���-1�5!������������������������������������� -1�5!������� ��������� 185!��-1�5�� ��� ���������-����������������� �����������������-��������� ����� ���� ������185�������� ����� ��������� ����� ����������������������� ������������������� ��8�������� ����� ���������� ��������������������������
� � ��������������� ������������������ ������� ��3�����
Lay
/����������� ������� ���������� ����������������� ���� ��������������� ����������������"� ������������������������������������ �������������5����� ����������������������������������� ����������� ����������������� ������������������������������������� �������2 ���� ���� ��������� ��������������������"���� ��������-��� ����������������� ��������������� ����������������������� ������������������ ������� �����������
���� ���� �������������� ������������ ����� ���� �� �������������������� ���������������-�����������������-89�':;<����������������������������������-� ���� ��������������������������������������������-������� ������������������������� ���� ������������ ���� ���������������������,�� ���������� ������ �� �������������������� ������������������������������������ �������� ���� ������ ������������������������� ������������������������� ���� ������������ =�������6�����������/��� �6�/���69/!>8�/����6�����������/��� /6�/��/69/!>=�������6����/��� �/��� �6//! 8�/����6����/��� �/��� /6//!
sZ zS zZ sS������������ �� �������� ���������������� ������ ������������������������������������ ���������������-������������������ ���� ���?�������������������� � ������������ ������������������������������� ��@���������� ������������������� ����������� ������������������ ��� � �7�������������������� ����������� �������������������������������/���������� ��� ���� ������������������������������������� ����� ���� �������� �����?���������������� �������������������� ����������� ����� � ���������� ����������������������������� ����������� ����� ������������ �� ��������������������������������� �� ������������������� �����������6������������������������ ��� �� � ������������������������ �������-���������� ��������� ����������������� ��������������� ������?��������/��� �6?/��/6?/!�� ������������� ������������������ ���� ���������������������-������/����/��������������/��� )�/����/���A�)��������/��������#� ��������!����� ������ ���������������������� ������������������������� ���� �������7���������������������� ������������������������������-������� ������ �������� ������������ ����ropes.
1������ ���� ��������� ��-�6��6?B@��0�C/?��/?D����� ������� �� ��������
Bluejay Industrial Inc.Wire Rope
4
Preforming
4��������� �������������������� �������������������������� ���� ����������E�������F��������������������� ���������������� ���������������������� ����������� ��� ������������������������������� ��������� ���� ������������������������ �� ���������� �����non-preformed ropes. 4��������������� ������������������������ GH� -���������������������������������H� 1������������� ����������� �����������������������������
������H� 0� ������� �����������������������H� ������� �������������������������������"� ����-
������� ��3������������ ��������� �������������������!
?������ ���� ��������������������������� �������������������������� ������������ ��������������������� �� ��3�����
Grade
1������������� ����������� ������������������� ���������������������������� ����������������"���� �������������������������������� ����������������������������������������������������������������������������"���� ��������5���������� ��������������������������-�������4����8����� -48!��0����-�������4����8����� 0-48!�����0����0����-�������4����8����� 00-48!��-���������������� ��������� ��������� ��������� �$((;�&��I��$%#;�&��I�����'$#;�&��I��0-48�� ������� ������������������������� ��������������������������� ��������� �
Finish
1������� ������� ��������� �J����� ���������>���&����"!���������>�����8������ �8������K� ������������ ���� ���������������� ���������������� �������� �������������� ��� ���������� ���������� ���� � ��������������������������>�������� ����� ��������8������ � �������� �������������� ���������������������� ���� ���������������� �������������� �������������������������� �1������ ������������������������������������������������������ ������������������������� ����� ���� ������������������������������������������� �������-����������������������������� ���� �������������� ��� ��������������������������1������ ������� ���� ���������������� ��������-��� ��4�� ����������� ����������������������������������������� ������� �������������4L5���B��������������4L5����� ������������������������������������� ������������ � ������������� ��2 ��������������� ��-��� ����������� �����������-���������� ������������� �������������� �������� ������������������� ���� ��������� ��B������ �� ��������������������� ������������������ ��� ����� �������������������������� �������� ����� � ������
Rotating or Non-Rotating
Wire rope will tend to spin or rotate under load. Therefore it is impor tant to determine if a rotation resistant wire rope is re-3���������������� � ������������ �����������-
������������������������������3��������������� ���� ���������� ���� ���������������������������������B��M�������������������� � ������������� ��������� �������GH� /��������������������������� ���������H� /��������������������������������������������������
����������?����������� �������!��������� ��������� �������G�H� /������������������������ ���������� ������ �����
������� ����������������!H� 1���������������� ����������M�������������M�����
ropes in pair s
Bluejay Industrial Inc.Wire Rope
5
B��M��������������������� � ������������ ���� �� ������������������� �������������� ������������������ �����������8����������� ��������� ������������ ����������� ����� �������� ��8������������� � ���������� ����� � ������������ ����������������������������������� �����������������������"����������-������������8����������� ����������"�������� �����-������� ������ ����������� �������������� ��� �������������������������8����� � ������������� ����������������� ����� � ������������������ � ������������ ��
Stretch in Ropes
8���������������������������� �7���������� ���-������� ������������� ���������������5�� ���������� �������� ������������������ �����-����������������������� ���������������������� ������������������ �� ���� ��������������� ��������������������� ����������������;�'N�����;�<N����������������������� ����������������������������� �0�� ���������������� ��������������������������������� ���������������������������������������� ����������� ��4��������������������� �������������������� � ����������� ����� ���������������� ������������������������������� ��������
0�������������������������������������� ������� G
0�� ����0���������� ��!�O� /���1!�&� 0���?!
/�O�������������� ��B!1�O������������ ��!0�O���� ���������� � ��B&��I!?�O��������������&��������� ��I!
0�������������������������� ���������� ������������������ ������� ������������� ������������ ���!��-����������������� ����� ��3������������� ��� �������������������������������������������������� �������� ���������� ����������������������� �����������- ��������������������������������������������� �������������������������� ���������� ����������������������������������������������������������������������� ���������������������������������������������� �� ����������� �� ���� ����� ���"������������� �������������� ���������� ���������������������������� ������������ ����������������������������
0�� ����K�����
�����5�� ������� ��B&��I
(���( *�();
(���$% :�(*;
#���$%�A�#���'#�,5 %�*;;
#���$%�A�#���'#�-1�5 $$�;;;
#���)#�A�#���:$�,5 %�;;;
#���)#�A�#���:$�-1�5 $;�;;;
<���$%&)# $'�;;;
4��#P $$�*;;
4��<P4 $$�;;;
����% $'�;;;
4��"�% $:�;;;
4��"�%4 $'�*;;
8����%P $$�;;;
8����%P4 $$�;;;
$%���( $$�*;;
4��$%P $'�*;;
-����� $$�;;;
,������" $)�;;;
$���$% $#�*;;�&�$(�;;;
$���#$ $#�;;;�&�$#�*;;
$���$'( $#�;;;�&�$#�*;;
��"������� ����������J����4����������� ����������Suspension Cables. ?���������������������� �������M����������������������������� ������� G#���$%�8� ,5�M�'#$��I� �������-1�5�M�);)��I�#���':��������������,5�M�'$'��I�#���'#�18� ,5�M�'#:��I� �������-1�5�M�);(��I�#���)#�18� ,5�M�'(;��I� �������-1�5�M�)$)��I�#���:$�18� ,5�M�'()��I� �������-1�5�M�)$#��I�(���(� � � ��������������������185�M�);:��I�(���$%�1� � � ��������185�M�)'#��I�<���$%�8� � � �������-1�5�M�);*��I�$%���(� � � � �������-1�5�M�'%'��I�,��@������ �����������$����������������������������������������� 3���������������������������-�����0������G��#���)#�-1�5�� �)$)��I��@������� 3����� $&'!I��O�$&:F����*����*?���O��'*���)$)��I�O�(<�'*��I� �
Bluejay Industrial Inc.Wire Rope
6
Winch Drums
1�������������� ��� ����������� �>����� ��������������������������������������������������?������������ ��������/�� �����!�� �������������� ���������������������������������������������� �����!���� ������ ��������������� �������� ��������$N�������������������������������������� ��� �� ������� ��������������������
,00K���������������-�������� � ��� ������ ��������������������������@&������ ��������� ������������ ����� ����������� � ����������������������������-��������������������-�������@&��Q�'*�
Sheaves
8����� ������������������������������������������������������������ ����������������������������3����� �>������������ ���������������������������������� ��������������� ������������������������������������ ��� �����������);���������#;�������������������������� � :*��������#;����!������������������� ������������������������� � �!� ��������$�:����$�(����� ���������������������������������������������������������� �������������������� ����������� ����������������������������;N����:N� ��������� ������� GK����������������� R����O�;�*)��K����������������� R����O�;�**��8���� �������������� R����O�;�*:��4�� ���� ��������!� ����� ��3���������������� ���������� ��;�**���� ���� ������ ���� ����� ����� ���������������� ���������������� ������
,������� ����������� ��������������� ������������������� �������� ��������������������������������� @&������!�� ��� ����
Wire Rope ����
������������@&�
K������������@&�
(���( :' '<
(���$% ': $<
#���$%�8 )% '#
#���'#�18 :: );
#���)#�18 )* ')
#���:$�8,1 )' $<
<���$%�8 :$ '(
<���)#�18 :< $<
4��#P )% '#
4��<P4 )$ ';
����% )* ')
����%4 )* ')
K��1P )$ ';
4��"�%4 )* ')
8����%4 )$ ';
8����%P4 )< '*
:���)% )$ ';
$%���( *$ ):
4��$%P )' '$
)*���( )$ ';
-����� )$ ';
,������" )$ ';
Fleet Angle
1������������� ������������������� ������������������������� ������������������������������������������������� ������������������������������������������������������������������������������������������������������������������������������������ ���������������������� �������������
��
�
����������
Bluejay Industrial Inc.Wire Rope
7
?������������������������ ���������������� ��������� �������������� �������� ������������������� � ����������������� ���������� ������������������������������������������������������� �������������������?������������������� ����� ������������� ������������������������������������������� � ������������������� ���� ���"������������������������������������������������������ ������������ �� �$�*��������'������-�� ������ � �������������� ������������� ����������:�����������������4��� ������"����������J���7�������� ������������������������� ������������������������ ���-tion.
Bearing Swivels
-��� ��� �������� ���������� ������������������������������ ��,�� ��������������� ��������������������������������� ������������� ������������� ��������� ����������� ���������5��� !���� ������� �����-��������8������� ������ ����������������������������������������� � ����� ����� �������� �������� ���������� ��������� �������������������������������"���� ������������������������������ � �� ��� �������������������������������� ���������� �������������� � ������ ���������������������������� ����������� ��������������� ���������������������� ���������� ���������� �������������������������������������� �������������E������F������� ����� ��8����� � �������������� ������������������������� � �������������� ���"��)*���(���� !�����869C/@�������used with Semi-rotation resistant ropes and standard ��������������� ��-��� ���������7���������������� ������ ������� ����������� ���� ������ ������������������������������������ ��������������������������������� ���������C����������������"���� �������������� � ������������������
Storage & Handling
1�������� �������� ��������������������������������������������� ���������� ������������ ����������������������������������������������� ��������� � �������� �������������� �����"����1���� ������������������������ ���������������������������"���" �����������" � ����������������� ������������ ��������������������?���� ����������� ��������� ����������������� ������ �
Installation
J������� ����������������������������� ����� �����" �������� � ���������� ������������ ����������������� ����������������� ����� ������������������������������ ��������������-������������ �������- ����� ������ ������������������������3����������������������������������������������������
tion.
������� ���������������
Bluejay Industrial Inc.Wire Rope
8
1������������ � ����������������� ����������������� ���������� ������������������������������������������"����������B0L0�������������������������������� � ����������� ���������������������"��"��������������-�����������������������������������"�� ����������������� ���������������������� ������������������������������������� �������
When the rope is supplied on a reel the use of a turn-��������������7��" �� ��3������B0L0����������-��������������������������� ������������ � �����1���������������� ����������������������������������������� ���������������������������� ��������������������������������������������?��"�� ��������� ������ �������������������������� ������������ ����������� ����to be applied.
-� ������������������������������������������������K����� ������������������ �������������������������������������������������� ���������� ������������������������������������ ��������� ����������������������������������������������������������� � �����It is
very important not to transfer torque from the old rope to the new wire rope. B0L0���������������������������� ������������������������� ������������������� ���� ���� ����� ��� ��������������� �� ������������ ������������������"��������� ��������������� ���!�1���������������� ����������������������������������������� ���������������������������� ������������������������������������������ ��������� !��
���"������������������ ����������������������������� ����������������������������������������� ����������� �� �������������������� �������������-��� ��������������� ������������������� ��������� ����� ��� ������������ ������������� ��������������'N������������-������"�������������������������-��� �������������������������������� � ���������������������� ���� �������������������������9������������� ��� ����������� �������������E��"���F���������������������� �������������������� � ��������������������������������������������������� �������� ����������������������� ������������������� ������������7� �����������"�������������������� ������������� ������������������at the drum.
X √
������6����O�������/�������������������������������@�����������O�/����6����
/����6����O�/����/�����������������������������������@�����������O�������6����
Bluejay Industrial Inc.Wire Rope
9
Cutting
J�����������������������������3����� ��>���� ������������������������ ����������������1��� ��>���� ��������������������� ����� ��?����� ��#������������ ����B���4����������� � 8������ � ����������������!�����'������������ ��������������� ��-� ������-�������������� ��>����� ���������� �������� ��������������������-�� ������������ ������������������������� ���� ������ ���� �������������������������� �������������� ��������������������������
5������� ������������������������� ������� ������ ���������������� ����������������������������� ���-�����3���������?����������� ���������� ������������that the end is welded.
Maintenance
?���������� ��3�������������������������>�������������K������������������������M������������������������������� ��������������� ��������������������1������� ������������������������������������������ ��������������������� ��������������� ���������� ��1�������� ��������� ������������ ��������� � �������7���8����� �������� � �������� ������ �������������� ��� �������� �����������������������?� ������������������� ����������������������������������������� ������� � �������������������� ������"������-������� ���������������� ����� ������������������������� ������������������� �������������0������������������������& ��������������� �������� ������������� �������� ������������6���������� ��������� ����������� ����������������������������
Lubrication
1������ ������������� ������������� ����������������������������������������������������� ����-������������������� ��������"������������������� ������� ��������������������������� ��� ����� ��-���� �������� ���������������� ����� ����@������������"�������������������� ������������������������������������������ ����������������������������� ��M�������������������������� ������ �������������������������������������������������� �������������������������������������������� ���������������������������������� ����� ��6������ �������������������������� ���������������� ���� ����������1������ ������������������������ ��������������������������� ���������� ������������������� ����������������������������� ������������"���� �������������������������������" ����������
Inspection & Rejection Criteria
?������������������������������������������������������� ������� ������� �� ����� ���������������������������� ������"����������������?������������� � ���������� �������� ��������������"�������������7��������������������� �������������� ��-��������"��"���������� ����!���"��������� ���� ��������������������������� �����������3�������������������� ������� � ��������"��������������������������������� ���������������������������� �������-�� ����������!�� ������������������������3��������� ����������������������� ����������������� �������������������� ������������3����������� ������� � ���������?������������������� ������������� ��������"��������-� �������� �����������������������������������������������������������������3���������� ���������� ������ ����������������������"��������������������������� ��� �������������������������� ����������
Bluejay Industrial Inc.Wire Rope
10
���������������������������������" ���������������� �����������������������������1����������� �����������$;������������ ���� ��B��������-��������8������ � ��������� ��������� �������������� ����&������� ����� ������ ������������� ����������������������� �� ���"������ ������ ����-��������������@����������� �������������� ������ ������� ��������������� �������������������� ���� � �������������������� �����J������������ ������ ����������� ������������� ����������" ������������������� ���������������������"����� ������������������������������������������������������Main Check Points. 1 M�5�������� �������������������������������������������� ��������� ������������)���� �������the drum at all times.M�0� ��������������������������� ������������������������� ���������������� ����&�����������M�-� ���������"������ ����� ����������������� ��������� ��0 ��������������������������������������� ��� �������������������������������������� ������2�M�-� ��������������������������������� ��� �����"������ ����� ������������������?� ������������"�������������������������� ����������������������������������� ������M�-� ����������������������������������������������������������������������������������������������� ��������������������� �M�0� ������������������� ��� ���������������3�M�5���������� ������������������� ��������0� ���������������� ���������������� ��������������"�����"������ ����� �����������������?�������� ���-���� ���������� ���� ������ ��������������� � ������������������������� �7������������������� �� � �� ������������������� ��1���������� ���������������������������������� ������4�M�,�������>��� ������������������������ � �7������������������������� ��5���������� ���������"������ ���������� �� � ������� ������������M�-� ����� ����� ������������������������ ������������������������
1
2
4
3
Wire Rope Discard Criteria� ������������1�" ����4���$*�'*!��1��������� �������������������������� ���������!������������������ ����������#����������������� ���������� ��"��������������������)���������� �����"���������� ����������������!���� ���������������� �� ����� �������� ����������)��������"������ ��������������� ������ ���������������������� ������������������"��������������������������������������������!������������������ ������� ������������$&)������������������������������ ������������������ ��!������� �������������"��"�������M�������������������������� ������������ ������������������ ���-�����!������� ���������������������������������!����������������� ��������������������������������� ���������� ����!�;�:��� $&#:F!����������� ���������������������<��� *&$#F!��!�$��� )&#:F!��������������������<�� *&$#F!���������������������$%�� )&:F!���!�'��� *&#:F!��������������������$%�� )&:F!���������������������'%��� $�$&<F!��!�)��� )&)'F!����������� ������������'%��������� $�$&<F!1������������������������ ��������� � ����!����- ���������� ��������������� ���������!������7����������������� �������$*�'*�������� ����!!���������'����������� ��������"������ ����#������������ ����!���������:����������� ��������"������ ����);�rope diameters.
Bluejay Industrial Inc.Wire Rope
11
������������ �B������������������"���1�� ���
Rotation Resistant No. of ����������"���1�� ���
8������������ �B������������������"���1�� ���
Standard 03������� $�����������/��
$�8�����������$����
$�����������/��
$�8�����������$����
$�����������/��
$�8�����������$����
?8K0&J);�'
9�������and
������Cranes
$' : - - - -
?8K0&J);�)
Tower Cranes
# ) : ' - -
?8K0&J);�*
/����������A�K�����
Cranes
# ) : '� ���);�! - -
?8K0&J);�#
@���" # ) - - - -
?8K0&J);�(
J� ��K�������6�� �
# ) - - ) '
?8K0&J);�<
,��������Cranes
# ) - - ) '
?8K0&J);�$#
C��������9�������
6�� �
$' : - - ) -
Wire Rope Discard Criteria� ������������?8K0�8������ !
����������������������� ��������������������� $!����������������"��L��������" ����������������- �������������������������������������� �������������� �������������" �������������������������������� ����������������������������� ���� ��-�����������������������"�������� ��������������������������������same area. 1����������" ���������������������������������������� ����������� ��� ��������� �����-��� ���-���������������� �������������������� ������� ���������� ����������� ������������� ����������1������� �������������� �����������������*N��������������������������������� ���������� ��������1���������������� ��� � ��� ���������� ���������� ���������� ������������������������������������-���� �������������������� G1����6������S�$�)��������������������������������� ������������ �
1����6������S�$�$����������������������������� ������������������������� ����� �������� �?������������������� � ��������������������������� ��������������������������� ������������������������� �����������������������3������� ������������������ ����������������������J);� ������ �?������������ ������������� ��������"����������������������������������� �� �����������3������������-������������� ������������������������������������������������������������� ��������������� �
Bluejay Industrial Inc.Wire Rope
12
@�������-����
1��������������,����4����
Grade Tensile
J���� �������>��
J���7��������Code
K�������8�������Pounds
J���7��������Code
K�������8�������Pounds
$&: ;�$' EIPS 1#$%;<?$ #�<<; 1#$%;<J$ #�$%;
*&$# ;�$< EIPS 1#$%$;?$ $;�*:; 1#$%$;J$ %�:<;
)&< ;�'# EIPS 1#$%$'?$ $*�$;; 1#$%$'J$ $)�*%;
(&$# ;�)* EIPS 1#$#$:?$ ';�:;; 1#$%$:J$ $<�)#;
$&' ;�:# EIPS 1#'#$#?$ '#�#;; 1#$%$#J$ ')�%:;
%&$# ;�*% EIPS 1#'#$<?$ ))�#;; 1#$%$<J$ );�':;
*&< ;�(' EIPS 1#'#';?$ :$�';; 1#$%';J$ )(�;<;
$$&$# ;�<* EIPS 1#'#''?$ *:�<;; 1#$%''J$ :%�)%:
)&: $�;: EIPS 1#'#':?$ *<�<;; 1#$%':J$ *'�%';
$)&$# $�$% EIPS 1#'#'#?$ (#�$;; 1#$%'#J$ #<�**:
(&< $�:' EIPS 1#'#'<?$ (%�#;; 1#$%'<J$ ($�#:;
$*&$# $�*% EIPS 1#'#);?$ %$�*;; 1#$%);J$ <'�)*;
$ $�<* EIPS 1#'#)'?$ $;)�:;; 1#$%)'J$ %)�;#;
$�$&$# '�;' EIPS 1#'#):?$ $')�<;; 1#$%):J$ $$$�*;(
$�$&< '�): EIPS 1#'#)#?$ $);�;;; 1#$%)#J$ $$(�;;;
$�$&: '�<% EIPS 1#'#:;?$ $*%�<;; 1#$%:;J$ $:)�';;
$�)&< )�* EIPS 1#'#::?$ $%'�;;; 1#$%::J$ $('�<;;
$�$&' :�$# EIPS 1#'#:<?$ ''<�;;; 1#$%:<J$ ';*�';;
$�*&< :�<< EIPS 1#'#*'?$ '#:�;;; 1#$%*'J$ ')(�#;;
$�)&: *�#( EIPS 1#'#*#?$ );#�;;; 1#$%*#J$ '(*�:;;
$�(&< #�*; EIPS 1#'##;?$ ):<�;;; 1#$%#;J$ )$)�';;
' (�)% EIPS 1#'##:?$ )%#�;;; 1#$%#:J$ )*#�:;;
'�$&: %�)# EIPS 1#'#('?$ :%:�;;; 1#$%('J$ :::�#;;
'�$&' $$�# EIPS 1#'#<;?$ #;:�;;; 1#$%<;J$ *:)�;;;
6 x 19 IWRC Class Wire Rope6 Outer Strands, Rotation Wire Rope-������ �#�$%8�A�#�'#18���� ������������ ��?����������������� ����������������� ����������� ��� � ������������������������8������������������ ���� � ���"-� !������������ ������������� ��������� ����� �� � ��� �������� ��� ���������������� �������������#�$%8� %+%+$!�-1�5��/����J������9����1�� �$$:�,����,�����;�*(#�'#18� $;+ *+*!+*+$!�-1�5��/����J������9����1�� �$*#��,����,�����;�*(C ����� ������� ���������������
Bluejay Industrial Inc.Wire Rope
13
@�������-����
1��������������,����4����
Grade Tensile
J���� �������>��
J���7���������Code
K�������8�������Pounds
J���7�����������Code
K�������8�������Pounds
$&: ;�$$ EIPS 1#$%;<5$ #�;:; 1#$%;<@$ *�:)#
*&$# ;�$# EIPS 1#$%$;5$ %�)<; 1#$%$;@$ <�::'
)&< ;�': EIPS 1#$%$'5$ $)�:'; 1#$%$'@$ $'�;(<
(&$# ;�)' EIPS 1#$%$:5$ $<�$<; 1#$%$:@$ $#�)#'
$&' ;�:' EIPS 1#$%$#5$ ')�#;; 1#$%$#@$ '$�':;
%&$# ;�*) EIPS 1#'#$<5$ '%�<;; 1#$%$<@$ '#�<';
*&< ;�## EIPS 1#'#';5$ )#�#;; 1#$%';@$ )'�%:;
)&: ;�%* EIPS 1#'#':5$ *'�:;; 1#$%':@$ :(�$#;
(&< $�'% EIPS 1#'#'<5$ (;�<;; 1#$%'<@$ #)�(';
$ $�#< EIPS 1#'#)'5$ %'�;;; 1#$%)'@$ <'�<;;
$�$&< '�$) EIPS 1#'#)#5$ $$*�<;; 1#$%)#@$ $;:�'';
$�$&: '�#) EIPS 1#'#:;5$ $:'�;;; 1#$%:;@$ $'(�<;;
$�)&< )�$< EIPS 1#'#::5$ $(;�<;; 1#$%::@$ $*)�(';
$�$&' )�(< EIPS 1#'#:<5$ ';'�;;; 1#$%:<@$ $<$�<;;
$�*&< :�: EIPS 1#'#*'5$ ')#�;;; 1#$%*'@$ '$'�:;;
$�)&: *�$* EIPS 1#'#*#5$ '('�;;; 1#$%*#@$ '::�<;;
$�(&< *�%$ EIPS 1#'##;5$ )$;�;;; 1#$%#;@$ '(%�;;;
' #�(' EIPS 1#'##:5$ )*'�;;; 1#$%#:@$ )$#�<;;
'�$&: <�*$ EIPS 1#'#('5$ ::;�;;; 1#$%('@$ )%#�;;;
'�$&' $;�*; EIPS 1#'#<;5$ *)<�;;; 1#'#<;@$ :<:�';;
6 x 19 FC Class Wire Rope6 Outer Strands, Rotation Wire Rope-������ �#�$%8�A�#�'#18���� ������������ ��?����������������� ����������������� ������ � ��������� ���������� �������� ��������������� ������� ��������-�������� �������������#�$%8� %+%+$!�,5��/����J������9����1�� �$$:�,����,�����;�:%#�'#18� $;+ *+*!+*+$!�,5��/����J������9����1�� �$*#�,����,�����;�:%C ����� ������� ���������������
Bluejay Industrial Inc.Wire Rope
14
@�������-����
1����������������,����4����
Grade Tensile
J���� �������>��
J���7��������Code
K�������8�������Pounds
J���7��������Code
K�������8�������Pounds
$&: ;�$' EIPS 1#)#;<?$ #�<<; 1#)#;<J$ #�$%;
*&$# ;�$< EIPS 1#)#$;?$ $;�*:; 1#)#$;J$ %�:<;
)&< ;�'# EIPS 1#)#$'?$ $*�$;; 1#)#$'J$ $)�*%;
(&$# ;�)* EIPS 1#)#$:?$ ';�:;; 1#)#$:J$ $<�)#;
$&' ;�:# EIPS 1#)#$#?$ '#�#;; 1#)#$#J$ ')�%:;
%&$# ;�*% EIPS 1#)#$<?$ ))�#;; 1#)#$<J$ );�':;
*&< ;�(' EIPS 1#)#';?$ :$�';; 1#)#';J$ )(�;<;
$$&$# ;�<* EIPS 1#)#''?$ *:�<;; 1#)#''J$ :%�)%:
)&: $�;: EIPS 1#)#':?$ *<�<;; 1#)#':J$ *'�%';
$)&$# $�$% EIPS 1#)#'#?$ (#�$;; 1#)#'#J$ #<�**:
(&< $�:' EIPS 1#)#'<?$ (%�#;; 1#)#'<J$ ($�#:;
$*&$# $�*% EIPS 1#)#);?$ %$�*;; 1#)#);J$ <'�)*;
$ $�<* EIPS 1#)#)'?$ $;)�:;; 1#)#)'J$ %)�;#;
$�$&$# '�;' EIPS 1#)#):?$ $')�<;; 1#)#):J$ $$$�*;(
$�$&< '�): EIPS 1#)#)#?$ $);�;;; 1#)#)#J$ $$(�;;;
$�$&: '�<% EIPS 1#)#:;?$ $*%�<;; 1#)#:;J$ $:)�';;
$�)&< )�* EIPS 1#)#::?$ $%'�;;; 1#)#::J$ $('�<;;
$�$&' :�$# EIPS 1#)#:<?$ ''<�;;; 1#)#:<J$ ';*�';;
$�*&< :�<< EIPS 1#)#*'?$ '#:�;;; 1#)#*'J$ ')(�#;;
$�)&: *�#( EIPS 1#)#*#?$ );#�;;; 1#)#*#J$ '(*�:;;
$�(&< #�*; EIPS 1#)##;?$ ):<�;;; 1#)##;J$ )$)�';;
' (�)% EIPS 1#)##:?$ )%#�;;; 1#)##:J$ )*#�:;;
'�$&: %�)# EIPS 1#)#('?$ :%:�;;; 1#:$('J$ :::�#;;
'�$&' $$�# EIPS 1#)#<;?$ #;:�;;; 1#:$<;J$ *:)�;;;
6 x 36 IWRC Class Wire Rope 6 Outer Strands, Rotation Wire Rope-������ �#�)#18�A�#�:$8,1���� ������������ ��?����������������� ���������������������� ����������������� � ������8������������������ ���� ������������ �����-�������� ������������������ ����������������� �#�)#18� $:+ (+(!+(+$!�-1�5��/����J������9����1�� �'$#��,����,�����;�*%#�:$18� $#+ <+<!+<+$!�-1�5��/����J������9����1�� �':#�,����,������;�*%C ����� ������� ���������������
Bluejay Industrial Inc.Wire Rope
15
@�������-����
1���������������,����4����
Grade Tensile
J���� �������>��
J���7���������Code
K�������8�������Pounds
J���7�����������Code
K�������8�������Pounds
$&: ;�$$ EIPS 1#)#;<5$ #�;:; 1#)#;<@$ *�:)#
*&$# ;�$# EIPS 1#)#$;5$ %�)<; 1#)#$;@$ <�::'
)&< ;�': EIPS 1#)#$'5$ $)�:'; 1#)#$'@$ $'�;(<
(&$# ;�)' EIPS 1#)#$:5$ $<�$<; 1#)#$:@$ $#�)#'
$&' ;�:' EIPS 1#)#$#5$ ')�#;; 1#)#$#@$ '$�':;
%&$# ;�*) EIPS 1#)#$<5$ '%�<;; 1#)#$<@$ '#�<';
*&< ;�## EIPS 1#)#';5$ )#�#;; 1#)#';@$ )'�%:;
)&: ;�%* EIPS 1#)#':5$ *'�:;; 1#)#':@$ :(�$#;
(&< $�'% EIPS 1#)#'<5$ (;�<;; 1#)#'<@$ #)�(';
$ $�#< EIPS 1#)#)'5$ %'�;;; 1#)#)'@$ <'�<;;
$�$&< '�$) EIPS 1#)#)#5$ $$*�<;; 1#)#)#@$ $;:�'';
$�$&: '�#) EIPS 1#)#:;5$ $:'�;;; 1#)#:;@$ $'(�<;;
$�)&< )�$< EIPS 1#)#::5$ $(;�<;; 1#)#::@$ $*)�(';
$�$&' )�(< EIPS 1#)#:<5$ ';'�;;; 1#)#:<@$ $<$�<;;
$�*&< :�: EIPS 1#)#*'5$ ')#�;;; 1#)#*'@$ '$'�:;;
$�)&: *�$* EIPS 1#)#*#5$ '('�;;; 1#)#*#@$ '::�<;;
$�(&< *�%$ EIPS 1#)##;5$ )$;�;;; 1#)##;@$ '(%�;;;
' #�(' EIPS 1#)##:5$ )*'�;;; 1#)##:@$ )$#�<;;
'�$&: <�*$ EIPS 1#)#('5$ ::;�;;; 1#)#('@$ )%#�;;;
'�$&' $;�*; EIPS 1#)#<;5$ *)<�;;; 1#)#<;@$ :<:�';;
6 x 36 FC Class Wire Rope 6 Outer Strands, Rotation Wire Rope -������ �#�)#18��A�#�:$8,1���� ������������ ��?����������������� ���������������������� ����������������� � ������8������������������ ���� ������������ �����-�������� ������������������ ����������������� �#�)#18� $:+ (+(!+(+$!�,5��/����J������9����1�� �'$#�,����,�����;�*;#�:$18� $#+ <+<!+<+$!�,5��/����J������9����1�� �':#�,����,�����;�*;C ����� ������� ���������������
Bluejay Industrial Inc.Wire Rope
16
6 x 24 FC Class Wire Rope 6 Outer Strands, Rotation Wire Rope ?��������� �����������>������������������ ���������������� �����������������-�� ������������� ���������� ���� ���� ������� ����������������� �#�':� $*+%+,5!�,5��/����J������9����1�� �$::�,����,�����;�:$C ����� ������� ���������������
@��������������������-����
1�������������������,����4����
Grade Tensile
J���7������������������Code
K��������������8�������4����
$&: ;�;% EIPS 1#':;<@$5 :�%<;
*&$# ;�$: EIPS 1#':$;@$5 (�#';
)&< ;�'; EIPS 1#':$'@$5 %�*:;
(&$# ;�'( EIPS 1#':$:@$5 $:�$$;
$&' ;�)* EIPS 1#':$#@$5 $%�)';
%&$# ;�:: EIPS 1#':$<@$5 ':�';;
*&< ;�*: EIPS 1#':';@$5 '<�#;;
)&: ;�(< EIPS 1#':':@$5 :;�%;;
(&< $�;# EIPS 1#':'<@$5 **�:;;
$ $�)< EIPS 1#':)'@$5 (*�:;;
$�$&< $�(* EIPS 1#':)#@$5 %;�#:;
$�$&: '�$# EIPS 1#'::;@$5 $$#�#;;
@��������������������-����
1�������������������,����4����
Grade Tensile
J���7������������������Code
K�������������8�������4����
*&$# ;�$: IPS 1((($;J$5 #�%;;
)&< ;�'( IPS 1((($'J$5 $$�:;;
$&' ;�)( IPS 1((($#J$5 $(�:#;
%&$# ;�:: IPS 1((($<J$5 '#�();
7 x 7 x 7 Class Cable Laid Wire Rope 5������������ ���� ������������� �������������� �������������������� ��� � ������ ����� ������������������� �(�(�(� #+$�#+$�#+$!��/����J������9����1�� �'%:C ����� ������� ���������������
:$:$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$
Bluejay Industrial Inc.Wire Rope
17
19 x 7 Class Wire Rope 12 Outer Strands, Rotation Resistant Wire Rope ?������������ ����������� � ����� B9��B�����������!����������8������������������������������� ���� �������������� �����"����� �����"����� �������������� �$%�(� (+#�(+$'�(!��/����J������9����1�� �<:�,����,�����;�**C ����� ������� ���������������
@��������������������������������-����
1���������������������,����
Pounds
Grade Tensile
J���� �������>�� Stainless Steel
J���7������������������Code
K�������8�������Pounds
J���7������������������Code
K�������8�������Pounds
J���7������������������Code
K�������8�������Pounds
)&$# ;�;( EIPS T T U T 1$%(;#8) )�));
$&: ;�$$ EIPS 1$%(;<?) *�*:; T T 1$%(;<8) *�(#;
*&$# ;�$< EIPS 1$%($;?) <�*:; T T 1$%($;8) <�$;;�
)&< ;�'* EIPS 1$%($'?) $'�);; T T T T�
(&$# ;�)* EIPS 1$%($:?) $#�#;; T T T T
$&' ;�:* EIPS 1$%($#?) '$�#;; T T T T
%&$# ;�*< EIPS 1$%($<?) '(�';; 1$%($<J) ':�:;; T T
*&< ;�($ EIPS 1$%(';?) ))�#;; 1$%(';J) );�';; T T
)&: $�;' EIPS 1$%(':?) :<�;;; T T T T
(&< $�)% EIPS 1$%('<?) #*�;;; T T T T
Bluejay Industrial Inc.Wire Rope
18
Galvanized 7 x 7 & 7 x 19 Class Wire Rope 6 Outer Strands, Rotation Wire Rope ?�����������������������������������"� ������������������������ ������������������-��� � �������������������������� �������������������� �� ������������������� ������������ ����� ���������������� �(�(� #+$!�185��/����J������9����1�� �:'�,����,�����;�**(�$%� $'+#+$!�185��/����J������9����1�� �$$:�,����,�����;�*(C ����� ������� ���������������
@�������-����
1��������������,����4����
Grade Tensile
(���(�5�� ������� (���$%�5�� �������
J���7��������Code
K�������8�������Pounds
J���7��������Code
K�������8�������Pounds
)&#: ;�;$ EIPS 1(;(;$J*5 '(; �T T
$&$# ;�;$ EIPS 1(;(;'J*5 :<; �T T
)&)' ;�;) EIPS 1(;(;)J*5 %'; �T T�
$&< ;�;: EIPS 1(;(;:J*5 $�(;; 1($%;:J*5 '�;;;
*&)' ;�;* EIPS T� T 1($%;*J*5 '�<;;
)&$# ;�;( EIPS T T������ 1($%;#J*5 :�';;
(&)' ;�$; EIPS T T� 1($%;(J*5 *�#;;
$&: ;�$$ EIPS T� T� 1($%;<J*5 (�;;;
*&$# ;�$( EIPS T� T� 1($%$;J*5 %�<;;
)&< ;�': EIPS T T 1($%$'J*5 $:�:;;
$&' ;�:$ EIPS T T 1($%$#J*5 ':�;;;
*&< ;�#* EIPS T T� 1($%';J*5 )(�;;;
Galvanized 7 x 19 Class Garage Door Wire Rope 6 Outer Strands, Rotation Wire Rope ?����������������������������������� �������������� ���������������������������� ������� ��� ���������� ��������� ������������������������������������� � ����� ������������������������ ����������������� �(�$%� $'+#+$!�185��/����J������9����1�� �$$:�,����,�����;�*(C ����� ������� ���������������
@������������������-����
1�������������������,����4����
Grade Tensile
J���7�������������������Code
K��������������8�������4����
$&< ;�;: EIPS 1($%;:J*5M@5V '�;;;
*&)' ;�;* EIPS 1($%;*J*5M@5V '�<;;
)&$# ;�;( EIPS 1($%;#J*5M@5V :�';;
Bluejay Industrial Inc.Wire Rope
19
Wire Rope @�������-����
Outside @�������-����
1���������,����4����
4L5�5����� B�����5�����
J���7��������Code
K�������8�������Pounds
J���7��������Code
K�������8�������Pounds
$&$#� (�(! )&)' ;�;' 1(;(;'J4 :<; �1(;(;'JB :<;)&)'� (�(! $&< ;�;) T �T 1(;(;)JB� %';�$&<� (�$%! )&$# ;�;: 1($%;:J4 '�;;; 1($%;:JB '�;;;*&)'� (�$%! )&$# ;�;* T� T� 1($%;*JB '�<;;)&$#� (�$%! $&: ;�;< 1($%;#J4 :�';; 1($%;#JB :�';;$&:� (�$%! *&$# ;�$) 1($%;<J4� (�;;; T T*&$#� (�$%! )&< ;�'; 1($%$;J4 %�<;; T T)&<� (�$%! (&$# ;�': 1($%$'J4� $:�:;; T T
7 x 7 & 7 x 19 Class Black Powder Coated Wire Rope 6 Outer Strands, Rotation Wire Rope ?����������������������������������� ������������� �����������"���������"������������� ����� �������������� �������������� ���� �� ����������������������-��������� ��8������� ����� �������������������������������������������������������������� ��3������5�������� ������������ ���"��� � ������?������������� �������-������ ���������������������������������������������� �(�(� #+$!�185��/����J������9����1�� �:'�,����,�����;�**(�$%� $'+#+$!�185��/����J������9����1�� �$$:�,����,�����;�*(C ����� ������� ���������������
@�������-����
1���������,����4����
Grade Tensile
(���(�5�� ������� (���$%�5�� �������
J���7��������Code
K�������8�������Pounds
J���7��������Code
K�������8�������Pounds
$&$# ;�;$ EIPS 1(;(;'J*5 :<; T T�
)&)' ;�;) EIPS 1(;(;)J*5 %'; T� T�
$&< ;�;: EIPS 1(;(;:J*5 $�(;; 1($%;:J*5 '�;;;
*&)' ;�;* EIPS T �T 1($%;*J*5 '�<;;
)&$# ;�;( EIPS T T������ 1($%;#J*5 :�';;
Galvanized 7 x 7 & 7 x 19 Class Coated Wire Rope 4L5�5������5��� ���������� �����������������B�����������������������������-��������� ������������ ���������-��� �� ����������������������� ��� �� ����� ������ ���������������������� ���������� ����� �������� ��B������ ���������������������������������������� ������������������� ������ ������������� ������� ��� �����?���������� ��������������������� ����� ������������������������ ��5��� �������J���"��D�������1������5����A�����
Bluejay Industrial Inc.Wire Rope
20
Stainless Steel 7 x 7 & 7 x 19 Class Wire Rope 6 Outer Strands, Rotation Wire Rope ?���������������������������� �������������������������� �������������������� �������� ��������� ��� ������������������������� �(�(� #+$!�185��/����J������9����1�� �:'�,����,�����;�**(�$%� $'+#+$!�185��/����J������9����1�� �$$:�,����,�����;�*(C ����� ������� ���������������
@�������-����
1���������,����4����
Grade Tensile
(���(�5�� ������� (���$%�5�� �������
J���7��������Code
K�������8�������Pounds
J���7��������Code
K�������8�������Pounds
$&$# ;�;$ );: 1(;(;'8$ :<; �T T
)&)' ;�;) );: 1(;(;)8$ %'; �T T�
$&< ;�;: );: 1(;(;:8$ $�(;; 1($%;:8$ $�(#;
*&)' ;�;* );: T� T 1($%;*8$ '�:;;
)&$# ;�;( );: T T������ 1($%;#8$ )�(;;
$&: ;�$$ );: T� T� 1($%;<8$ #�:;;
*&$# ;�$( );: T� T� 1($%$;8$ %�;;;
)&< ;�': );: T T 1($%$'8$ $'�;;;
@�����������������-����
1�������������������,����4����
Grade Tensile
J���7��������������������Code
K������������8�������4����
(&$# ;�)# );: 1#$%$:8$ �$#�);;
$&' ;�:# );: 1#$%$#8$ ''�<;;
%&$# ;�*% );: 1#$%$<8$ '<�*;;
*&< ;�(' );: 1#$%';8$ )*�;;;
)&: ;�%' );: 1#$%':8$ :%�#;;
(&< $�:) );: 1#$%'<8$ ##�*;;
$ $�<( );: 1#$%)'8$ <*�:;;�
Stainless Steel 6 x 19 Class Wire Rope 6 Outer Strands, Rotation Wire Rope ?����������������� ����������������� ����������� ��� � �������������������-�����-��� � ���������� � ��� ������������� ���������������� ������������� ������������ ����� ���� �������������������������������������������������������������������������������������#�$%� $'+#+$!�-1�5��/����J������9����1�� �$$:�,����,�����;�*(C ����� ������� ���������������
Bluejay Industrial Inc.Wire Rope
21
Stainless Steel 7 x 7 & 7 x 19 Class Coated Wire Rope 8������ �8�����4L5�5������5��� ����������������������������������� ������������ ������������������������ ��-��� �� ����������������������� ��������� ����� � �������� ����������� ��������������������� ��5��� �������������White and Clear.
Stainless Steel 7 x 7 Class Coated Lifeline Wire Rope 5���������������������� ����� ������������� ������������������ ��������� �������& ������� ������������������������������ ������4L5�5������������� ���������������� ������ ������������������������ ���5������������� ��������������������� ���-�������� ���������������(���(���� �������������� ��� ������ ��������� ������������ ��3���������������� �
Wire Rope @�������-����
Outside @�������-����
1��������������,����4����
GradeJ���7������������
CodeK�������
8�������4����
$&$#� (�(! )&)' ;�;$ );: �1(;(;'84 :<;
)&)'� (�(! $&< ;�;' );: 1(;(;)84 %';
$&<� (�$%! )&$# ;�;* );: 1($%;:84 $�(#;
)&$#� (�$%! $&: ;�;< );: 1($%;#84 )�(;;
Wire Rope @�������-����
Outside @�������-����
1��������������,����4����
GradeJ���7������������
CodeK�������
8�������4����
)&)' $&< ;�;) )$# �1(;(;)84 %;;
$&< $&: ;�;* )$# 1(;(;:84 �$�*;;
)&$# *&$# ;�$; )$# 1(;(;#84 )�$;;
$&: )&< ;�$* )$# 1(;(;<84 *�';;
Bluejay Industrial Inc.Wire Rope
22
Stainless Steel 1 x 19 Strand ?� ����� ����� �������� �������� ���������� ����������������?���������� �������������������&� ��������������������������������������� ������������� �����$�$%��/����J������9����1�� �$'�,����,�����;�(#C ����� ������� ������������������� ��������������������������
@�����������������-����
1�������������������,����4����
Grade Tensile
J���7��������������������Code
K��������������8�������4����
$&$# ;�;$ )$# �1$$%;'8$ :;;
)&)' ;�;' )$# �1$$%;)8$ $�;;;
$&< ;�;: )$# 1$$%;:8$ $�(<;
*&)' ;�;# )$# 1$$%;*8$ '�<;;
)&$# ;�;< )$# 1$$%;#8$ :�;;;
$&: ;�$$ )$# 1$$%;<8$ #�%;;
*&$# ;�'$ )$# 1$$%$;8$ $;�#;;
)&< ;�); )$# 1$$%$'8$ $:�<;;
@�����������������-����
1�������������������,����4����
Grade Tensile
J���7��������������������Code
K�����������8�������4����
)&$# ;�;< 068 1$;(;#�$ �:�;;;
$&: ;�$) 068 1$;(;<�$ #�:;;
*&$# ;�'' 068 1$;($;�$ $$�$;;
)&< ;�'( 068 1$;($'�$ $)�*;;
(&$# ;�)% 068 1$;($:�$ $%�*;;
$&' ;�*' 068 1$;($#�$ '*�*;;
Galvanized 1 x 7 Guy Wire ?� ����� �������� �������� ��������������8��������������,� ��0���� ���B��������,� �����J����������������8�������� ����������������������������������������������������������������������������������������$�(��/����J������9����1�� �#�,����,�����;�(<C ����� ������� ������������������� ��������������������������
Bluejay Industrial Inc.Wire Rope
23
Galvanized Structural Strand 8��������8�������� ������������>���������������������������������������� � �������������� ������ ������������ ������������������������������ ����������� �������� ���������������������������������������� � ����� ���������������������� �����������A� ������ � ��� ��������������������� ������ �� � ������� ������ ����������pendant ropes.
@�������-����
1���������,����4����
Gross K�������������������?��� ��I!
J��"����8����������C8����
Class A 5�� �J Class C �����'��Class A
$&' ;�*' ;�$*; $*�; $:�* $:�' $(�)
*&< ;�<' ;�'): ':�; ')�) ''�< '(�#�
)&: $�$< ;�))< ):�; ))�; )'�) )%�$
(&< $�#$ ;�:*% :#�; ::�# :)�( *'�%
$ '�$; ;�#;; #$�; *%�' *(�% (;�'
$�$&< '�## ;�(*% (<�; <)�: (:�$ <%�(
$�$&: )�'< ;�%)< %#�; %:�$ %'�' $$;�;
$�)&< )�%( $�$); $$#�; $$:�; $$$�; $))�;
$�$&' :�() $�)*; $)<�; $)*�; $)'�; $*%�;
$�*&< *�** $�*%; $#'�; $*%�; $**�; $<#�;
$��)&: #�:) $�<:; $<<�; $<:�; $<;�; '$#�;
$�(&< (�)% '�$$; '$#�; '$'�; ';(�; ':<�;
' <�:; '�:;; ':*�; ':$�; ')<�; '<'�;
'�$&< %�:% '�($; '((�; '()�; '#%�; )$%�;
'�$&: $;�*; )�;:; )$;�; );*�; );$�; )*(�;
'�)&< $$�(; )�)<; )::�; ))%�; )::�; )%#�;
'�$&' $'�<; )�(*; )(#�; )(;�; )#*�; :)'�;
'�*&< $:�*; :�$); :$(�; :$$�; :;:�; :<;�;
'�)&: $*�%; :�*:; :*'�; ::*�; :)<�; *';�;
'�(&< $(�:; :�%#; :%:�; :<#�; :(%�; #$%�;
) $<�%; *�:;; *)<�; *);�; *''�; #('�;
?���������� ����?8�K�?M*<#��J���7���������� �������8��������8������������� ������ �����������?8�K�?M#;)����8��������J�����8���������-89$(<%)�A�0B�$')<*M$;��? ����� ��������������-������������ ��������3�����
Bluejay Industrial Inc.Wire Rope
24
As cranes and machines have increased in ca-pacity and ability, the demands on the wire rope have also increased. Wire Ropes now need to have higher breaking strength, while retaining a greater life expectancy. This can be achieved in many ways including increasing the number of strands, design, compaction and plastic cores.
Compaction
To produce a compacted strand a conventional strand is drawn through a set of compacting dies and rollers. During this process the strand re-duces in diameter and the outer surface becomes smooth. This creates a better surface of contact between the wires in the strand, an increase in the metallic area and a more uniform distribution of the tension on wires. By compacting the outer strands we are able to achieve;� �� ���� ��� �������� ������� ��������������
wire rope due to the higher metallic area.� � �������� ������������� Increase stability of the strand to side forces,
and crushing.� The smoother surface will decrease the in-
dentations on sheaves and drums, and allows easier motion of the elements.
� A reduction in permanent elongation within its working range.
Compacted ropes are preferred over conventional strands for applications where multi layer spool-ing on drums is present. Furthermore, longer service life can be achieved when replacing con-ventional ropes with compacted ropes due to the lower stresses placed on the rope.
Increased Number of Strands
By switching the number of strands from six to eight, nine or ten outer strands we can achieve a better working life for the wire rope. A larger num-ber of strands achieves:� An increase in the metallic area of the rope,
and therefore a higher breaking strength. � The wire rope becomes more round and
therefore increases contact between sheaves and drums, and reduction in tread wear.
� Increase in strands and wires increases the ����������������������
Eight, Nine or Ten strand ropes are preferred over six strands for applications where multi layer spooling on drums is present.
Conventional Strand produces inter strand nicking
Compacted Strand reduces wear between strands
Bluejay Industrial Inc.Wire Rope
25
Plastic Coated Core (Cushion Core)
Is produced by closing the outer strands over a steel core which is coated with plastic. The plas-tic is of a special design to handle the conditions experienced during the life of the rope and to allow continuous operation of the rope in a wide temperature range (-35 deg C to + 90 deg C). The plastic coated core has many advantages including;� Prevents internal wire breaks as the plastic
decreases inner and outer strand contact.� The plastic traps the wire rope lubricant in the
core, and prevents foreign matter entering the rope internally.
� Increases the stability of the rope which eases installation, and also helps prevent incidents of birdcaging as the plastic core is able to absorb some energy.
� A much higher structural stable rope for multi layer spooling.
Rotation Resistant & Non-Rotating
Wire rope will tend to spin or rotate under load. This can be reduced by using ropes made of two or more layers of strands laid in opposite directions, however a true non rotating rope can never be achieved because the alternating lay-ers, although close, are never perfectly equal. !����������������� ������" � #������ �$�����ideal for uses where the stability of suspended, non guided loads especially over longer lifting heights.Rotation Resistant Ropes are manufactured from 2 layers of strands with the outer strands closed in an opposite direction to the inner strands. These type of ropes generally have 11 to 13 outer strands (19 x 7 & 19 x 19 constructions) with an inner core of 6 or 7 inner strands. The torque pro-duced by the outer strands is not equal to that of the inner strands and therefore not considered
non-rotating. Furthermore due to this imbalance, these rotation resistant ropes suffer from the core being over stressed especially where the outer strands crossover the core. When inspecting the visual outer strands may show few signs of fatigue or deterioration, but premature and unexpected failure can occur as a ���'��������������� ���*��!������ �������� ��������should not be used with a swivel as this can reduce the breaking strength of these rope con-structions by up to 40%.A non-rotating rope is made up of three layers where the two inner layers of strands are closed in one direction while the outer strands (14 or more outer strands) are closed in a reverse direc-tion. The torque of the outer strands are designed to be equal to the torque of the inner strands to create a non rotating rope. These types of ropes can be safely used with a swivel, and is highly recommended to allow any build up of twist in the reeving system to escape through the end. These class of ropes should be selected for all types of Tower Cranes and larger Mobile Cranes. For ship deck cranes, marine or offshore use a non rotating rope may be preferred with a plastic coated core between the inner and outer strands, to increase its ability to absorb high dynamic loading environments and to increase structural stability.
Bluejay Industrial Inc.Wire Rope
26
@������������-����
1��������������,����4����
Grade Tensile
J���7��������������Code
K�������8�������4����
K�������8�������"B
(&$# ;�:# IPS 1#'#$:?8 '$�$;; %)�%
$&' ;�#; IPS 1#'#$#?8 '#�:;; $$(�:
%&$# ;�(* IPS 1#'#$<?8 ):�<;; $*:�<
*&< ;�%' IPS 1#'#';?8 :$�$;; $<'�<
$$&$# $�'; IPS 1#'#''?8 *;�';; '')�)
)&: $�)) IPS 1#'#':?8 *%�*;; '#:�(
(&< $�<: IPS 1#'#'<?8 <;�#;; )*<�*
$ '�)* IPS 1#'#)'?8 $;(�;;; :(#�;
PRO6S Swaged Wire Rope 6 Outer Strands, Rotation Wire Rope 4�9#8�8������1��������� ���#�'#���� ���������8�������������������� ��� ��������� ������ ������������� ����� � �������-��� ����������� ���������������������-���� � ����� ����������� �� "����� ���������" �����"� �������������������� �#�'#18� $;+ *+*!+*+$!�-1�5��/����J������9����1�� �$*#�,����,�����;�('C ����� ������� ���������������
@������������-����
1��������������,����4����
Grade Tensile
J���7��������������Code
K�������8�������4����
K�������8�������"B
$&' ;�:< EIPS 1#'#$#?@ );�';; $):�)
%&$# ;�*( EIPS 1#'#$<?@ )#�<;; $#)�(
*&< ;�() EIPS 1#'#';?@ :*�;;; ';;�'
)&: $�;) EIPS 1#)$':?@ #(�';; '%<�%
(&< $�)< EIPS 1#)$'<?@ %;�';; :;$�'
$ $�%; EIPS 1#'#)'?@ $$'�%;; *;'�'
$�$&< '�'# EIPS 1#)$)#?@ $:<�;;; #*<�:
$�$&: '�%' EIPS 1#)$:;?@ $%$�;;; <:%�#
PRO6C Compacted Wire Rope 6 Outer Strands, Rotation Wire Rope 4�9#5�5���������1���������-��� �����������#�'#���� ������������� ���������������#�)$���������������� ��������� ��������������5����������������������� ��� �������������� ��� �������������������������� ���������-��� ����������� ���������� �� �������� ����� ������������ ������� �������"�� ������������������ ������������ ������������� ���������������� �#�'#18� $;+ *+*!+*+$!�-1�5��/����J������9����1�� �$*#�,����,�����;�#:#�)$18� $'+ #+#!+#+$!�-1�5��/����J������9����1�� �$<#�,����,�����;�#:C ����� ������� ��������������
Bluejay Industrial Inc.Wire Rope
27
@������1��������������,����4����
Grade Tensile
J���7��������������Code
K�������8�������4����
K�������8�������"B
(�� ;�$' '$#; K;(;#)#?$'$� <�:*' )(�#
<�� ;�$< '$#; K;<;#)#?$'$� $$�;#; :%�'
%�� ;�'' '$#; K;%;#)#?$'$� $)�(;; #$�)
$;�� ;�'( '$#; K$;;#)#?$'$� $(�'<( (#�%
$$�� ;�)* '$#; K$$;#)#?$'$� ';�%;# %)�;
$:�� ;�*% '$#; K$:;#)#?$'$� ))�%:* $*$�;
$*�� ;�#' '$#; K$*;#)#?$'$� )<�<%; $()�;
$<�� ;�<( '$#; K$<;#)#?$'$� **�$:) ':*�)
';�� $�$; '$#; K';;#)#?$'$� #<�$$: );)�;
''�� $�*; '$#; K'';#)#?$'$� <)�#'* )('�;
6 x 36 Metric Wire Rope 6 Outer Strands, Rotation Wire Rope #�)#18���� ��������� ������������������� ����������������������� ����������������� � ������-��� � �������������������������� ������������� � ������������ ������������ ������������������������� �#�)#18� $:+ (+(!+(+$!�-1�5��/����J������9����1�� �'$#�,����,�����;�*%C ����� ������� ���������������
Bluejay Industrial Inc.Wire Rope
28
@������1��������������,����4����
Grade Tensile
J���7��������������Code
K�������8�������4����
K�������8�������"B
(�*�� ;�$* '$#; K;(*<$%?$'$W %�(): :)�)
%�� ;�$( '$#; K;<;<$%?$'$W $:�;;* #'�)
$$�� ;�)* '$#; K;%;<$%?$'$W ';�%;# %)�;
$)�� ;�*; '$#; K$);<)#?$'$W '%�'': $);�;
$:�� ;�*( '$#; K$:;<)#?$'$/ ))�%:* $*$�;
$*�� ;�#) '$#; K$*;<)#?$'$� )(�*<# $#(�'
$#�� ;�(: '$#; K$#;<)#?$'$� ::�'<* $%(�;
';�� $�'' '$#; K';;<)#?$'$� #%�')< );<�;W�?�����������/��������������6����/����8�����.�2����������6������./2����/����6�������������������
8 Strand Metric Wire Rope 8 Outer Strands, Rotation Wire Rope <�$%8�A�<�)#18���� ����������������������������� ���������������������� ������������������� � ����������������0����������<�8�������� �������������� ������ �������������������� ����������� �������������� ����� �<�$%8� %+%+$!�-1�5��/����J������9����1�� �$*'�,����,�����;�*<<�)#18� $:+ (+(!+(+$!�-1�5��/����J������9����1�� �'<<�,����,�����;�#;C ����� ������� ��������������
@������1��������������,����4����
Grade Tensile
J���7�����������������Code
K�������8�������4����
K�������8�������"B
#�:�� ;�$) '$#; K;#:@4<PJ$'$� %�);# :$�:
<���$%�5���������1���������������>���������6����/��
#�*�� ;�$) '$#; K;#*<$%?@$'$W <�#)' )<�:
<���$%�5���������1��������C��������>���������A�/����6����/��
(�� ;�$: '$#; K;(;$%(?)'$W (�(#' ):�*
$%���(�1��������C��������>���������A�/����6����/��
<�� ;�$% '$#; K;<;$%59K4J$'$W $)�;;; *(�<
<���$%�5���������1���������������>���������A�/����6����/��
%�� ;�') '$#; K;%;#'#59K4@$'$W $*�);; #<�#
#���'#�,5�5����������������>���������A�/����6����/����
Metric Speciality Wire Rope ,������������ ���������������������� ������������������������������������������������������ � �C ����� ������� ��������������
Bluejay Industrial Inc.Wire Rope
29
@������1��������������,����4����
Grade Tensile
J���7��������������Code
K�������8�������4����
K�������8�������"B
<�)�� ;�$* EEIPS K;<)*$%@$'$� �$;�);; �:*�<
*���$%8�,5��������>���������6�����������/��������
$$�*�� ;�)#� EEIPS K$$**'#@$'$� �':�;;; �$;#�<
*���'#18�,5��������>���������6�����������/�������
$#�)�� ;�(: EEIPS K$#):'#@$'$� �:;�:<# $<;�$�
:���'#18�,5��������>���������6�����������/�������
Pulling Hoist Wire Ropes 4 or 5 Outer Strands, Rotation Wire Rope ��� ��������� ������� ���� ��������������������������������������������� ���������� ������������� ��������������������� ������������ � ��������������������������������� ������ ������� � �*�$%8� %+%+$!�,5��/����J������9����1�� �%*�,����,�����;�*'*�'#18� $;+ *+*!+*+$!�,5��/����J������9����1�� �$);�,����,�����;�*':�'#18� $;+ *+*!+*+$!�,5��/����J������9����1�� �$;:�,����,�����;�*#C ����� ������� ��������������
@������1��������������,����4����
Grade Tensile
J���7��������������Code
K�������8�������4����
K�������8�������"B
$$�� ;�)< '$#; K$$;5?�)J$'$� ��':�(;; $$;��W�?� �������������������� ������������(&$#F�#�$%�-1�5�8���������������������������
Redaelli CAT 3 Snowgroomer Ropes 7 Outer Strands, Rotation Wire Rope5���)�� �������� ����� ������������������������������������������ ���������������� ������ ������� �� ������� ������������������ ���� ��-�2 �������������� ������������ ����������������� ��������� ��� ��,�� ���������������4� ����J������4�������P� ��������/��������(�P$%8 %+%+$!41�5�%���������������� ���� �� ���������� ������ ��� �����������������>����/����J������9����1�� �$($�,����,�����;�(#��������������������������C ����� ������� ��������������
����������� �������� ��� ����
Bluejay Industrial Inc.Wire Rope
30
@������1��������������,����4����
Grade Tensile
J���7��������������Code
K�������8�������4����
K�������8�������"B
$$�� ;�)< $%#; K$$;4�9<P4J$$%� ')�#'* $;*�;
$&'F ;�*$ $%#; K$'(4�9<P4J$$%� )$�(;; $:$�;
$)�� ;�*) $%#; K$);4�9<P4J$$%� ))�'(; $:<�;
$:�� ;�#$ $%#; K$:;4�9<P4J$$%� )<�:(* $($�;
$*�� ;�(; $%#; K$*;4�9<P4J$$%� ::�$;; $%#�;
$#�� ;�<; $%#; K$#;4�9<P4J$$%� *;�:;; '':�;
$%�� $�$) $%#; K$%;4�9<P4J$$%� (;�#*; )$:�;
PRO8KP Compacted Wire Rope 8 Outer Strands, Rotation Wire Rope 4�9<P4��� ����<� ��������������������������������� ��������������������5��-����������������� ���� ������ � ����� ����������������������������� ������������ �������������������� ������ ������� ������ ��������������� ��� ������������ �����������������������������#���<� �������� ������������������������� ����������������������<�'#18� $;+ *+*!+*+$!�-1�5��/����J������9����1�� �';<�,����,�����;�#<C ����� ������� ���������������
@������1��������������,����4����
Grade Tensile
J���7��������������Code
K�������8�������4����
K�������8�������"B
$;�� ;�)' '$#; K$;;4�94<PJ$'$� ''�:<; $;;
$'�� ;�*; '$#; K$';4�94<PJ$'$� '%�:;; $::4?�?<P�<���'#�8�����5���������4�������/���5���������6�����������/�������
'#�� $�%# $%#; K'#;4�9<4?)$%W $':�(#: ***
4�9<4�5�<���'*�8������������8�����4�� ����5���������� ��5���������A�/����6�����������/�������
PARA8K & PRO8PRC Wire Rope 8 Outer Strands, Rotation Wire Rope 4?�?<P�A�4�9<4�5��������<� �������� ��������������� ������������������ ����������������� ����#���<� �������� ������������������������� ����������� ���������������� �� ������� ����������������� ����������������� ����������������������������<�'*,-� $'+ #!+#+$!�04-1�5��/����J������9����1�� �';;�,����,�����;�#'<�'#18� $;+ *+*!+*+$!�41�5��/����J������9����1�� �';<�,����,�����;�('C ����� ������� ��������������
Bluejay Industrial Inc.Wire Rope
31
@������1��������������,����4����
Grade Tensile
J���7��������������Code
K�������8�������4����
K�������8�������"B
$;�� �;�); '$#; K$;�0@%?$'$� '$�#:< %#�)
$%�� $�;:� '$#; K$%;�0@%4?$'$W #%�;$) );(�;W�?�����������/��������������6����/����8�����.�2����������6������./2����/����6�������������������
Redaelli RED9 & RED9P Wire Rope 9 Outer Strands, Rotation Wire Rope - ����������������������%������ ���� ��������������������������� 41�5!������%������ ���� ������������������������������������� �������� ����� ������������������������������� � �������"���� ��������������������0@%4� $%��!��� ����� ����������������� ��������������������8����������� ��������-������������� ������������ ��������������� ����������������� �$;���%�(� #+$!�41�5��/����J������9����1�� �#)�,����,�����;�##$%���%�$%� %+%+$!�04-1�5��/����J������9����1�� �$($�,����,�����;�##C ����� ������� ���������������
@������1��������������,����4����
Grade Tensile
J���7��������������Code
K�������8�������4����
K�������8�������"B
%�� ;�'# '$#; K;%;4?5P%4J$'$� $(�%<: <;�;
$;�� ;�)' '$#; K$;;4?5P%4J$'$� ''�;); %<�;
$'�� ;�:# '$#; K$';4?5P%4J$'$� )$�#%# $:$�;
$:�� ;�#< '$#; K$:;4?5P%4J$'$� :)�$#' $%'�;
$#�� ;�<' '$#; K$#;4?5P%4J$'$� *#�:'* '*$�;
$%�� $�$# '$#; K$%;4?5P%4J$'$� (%�*(% )*:�;
';�� $�'< '$#; K';;4?5P%4J$'$W <<�$'$ )%'�;
''�� $�*' '$#; K'';4?5P%4J$'$W $;*�$)% :#(�(
'*�� '�$# '$#; K'*;4?5P%4J$'$� $)<�%'# #$<�;
'<�� '�*$ '$#; K'<;4?5P%4?$'$� $#%�'(: (*)�;��W�?�����������/��������������6����/����8�����.�2����������6������./2����/����6�������������������
Redaelli PACK 9P Compacted Wire Rope 9 Outer Strands, Rotation Wire Rope K������������������%������ ���� ���������� ��������������������%���������������� ���� ������������������������������������� �������� ����� �������� ����������������������������"���������������� �������������� � ������������������8����������� ����������������� ������������ ��������������� ������������ ����� �R$'M'*�%�$%8� %+%+$!�04-1�5��/����J������9����1�� �$($�,����,�����;�#<R'#M'<�%�'*,� $'+ #+#!+$!�04-1�5�/����J������9����1�� �''*�,����,�����;�#<C ����� ������� ��������������
Bluejay Industrial Inc.Wire Rope
32
@������1��������������,����4����
Grade Tensile
J���7��������������Code
K�������8�������4����
K�������8�������"B
$$�� ;�:; '$#; K$$;84-B%P4?''$� '(�#*; $')
$)�� ;�:% '$#; K$);84-B%4?''$W ):�<:: $**
$#�� ;�(: '$#; K$#;84-B%4?''$� *)�;*) ')#
$<�� $�;< '$#; K$<;84-B%P4?''$� ($�:<# )$<��W�?�����������/��������������6����/����8�����.�2����������6������./2����/����6�������������������
Redaelli SPIN9P & SPIN9KP Wire Rope 9 Outer Strands, Spin-Resistant Wire Rope K����������������������%������ ���� ����� �������������������������� ��������������� 04-1�5!��?���������������� ������������������������������� ������ ��� � ������������������������ �������������������������� ������� ������������� ���� ������� �� � ������������������ ��0���������� ���������� ����������&������������� ����������������� �� �����������������"���� ��� ����������-��� ��������������������������������� � �������������������������� ����������������%�$%8� %+%+$!�04-1�5��/����J������9����1�� �$($�,����,�����;�#$� ,����,�����84-B%P4�;�(;!C ����� ������� ���������������
Redaelli METWK Compacted Wire Rope 3/6 Outer Strands, Rotation Wire Rope - ���6�M���������������� ����������������� ���������������������������������"-���� ����������������������������� ������������� ���� ������������ ������ ����������� ���� ������������������������������ ���������� ���������������� ���)� %&%&$!�&�#��� #&$!��/����J������9����1�� �%%�,����,�����;�(;C ����� ������� ��������������
@������1��������������,����4����
Grade Tensile
J���7��������������Code
K�������8�������4����
K�������8�������"B
<�� ;�'' '$#; K;<;K0�1P?$'$W $*�<'# (;�:
$$�� ;�:; '$#; K$$;K0�1P?$'$� '%�<%< $))�;�W�?�����������/��������������6����/����8�����.�2����������6������./2����/����6�������������������
Bluejay Industrial Inc.Wire Rope
33
@������������-����
1��������������,����4����
Grade Tensile
J���7��������������Code
K�������8�������4����
K�������8�������"B
%&$# ;�#: '$#; 1$%$%$<?@ :'�:<( $<%�;
*&< ;�<' '$#; 1$%$%';?@ *'�<;; ':)�%
)&: $�$% '$#; 1$%$%':?@ (#�;;; ))<�;
(&< $�#$ '$#; 1$%$%'<?@ $;)�;;; :*<�'
Redaelli 19 x 19 Compacted Wire Rope 12 Outer Strands, Rotation Resistant Wire Rope���������$%�$%����������� ����������� ���'��������������� � ������������������$'������ ���� ��-��� �������� ������������� ��� � ��������� ���������������������������� ����� ������ ����������B����?����������������������� ���� ���������������ropes. $%�$%8� %+%+$!�-1�5��/����J������9����1�� �)#$�,����,�����;�('C ����� ������� ���������������
4 x 39 Unique Wire Rope 4 Outer Strands, Rotation Resistant Wire Rope ?����3����� ������:� ���������������� ���������� � ��������� ����3������ ������������� ������� ��������� ������������������������������� � �������� ��� � -�������������������� ���������,����������������� �������"������������� ������� ��� �������������������������������������������������� ����� �:�8�8)%� $*+$*+%+,5!�,5�/����J������9����1�� �$*#�����������C ����� ������� ��������������
� ��������������������
@������1��������������,����4����
Grade Tensile
J���7��������������Code
K�������8�������4����
K�������8�������"B
$%�� $�;; EIPS K$%;:)%@'$%� *#�';; '*;�;
';�� $�'; EIPS K';;:)%@'$%� #'�';; '(#�(
)'�� '�** EIPS K)';:)%@'$%W $*%�:;; (;%�;�W�?�����������/��������������6����/����8�����.�2����������6������./2����/����6�������������������
Bluejay Industrial Inc.Wire Rope
34
@������1��������������,����4����
Grade Tensile
J���7��������������Code
K�������8�������4����
K�������8�������"B
<�� ;�$% '$#; K;<;,/0XJ''$� $'�%;) *(�:
%�� ;�'( '$#; K;%;,/0XJ''$� $*�(*< (;�'
$;�� ;�); '$#; K$;;,/0XJ''$� ''�;); %<�;
$$�� ;�:; '$#; K$$;,/0XJ''$� '#�(*$ $$%�;
$'�� ;�:# '$#; K$';,/0XJ''$� )$�#%# $:$�;
$)�� ;�*: '$#; K$);,/0XJ''$� )(�)$# $##�;
$:�� ;�#: '$#; K$:;,/0XJ''$� :)�$#$ $%'�;
$*�� ;�() '$#; K$*;,/0XJ''$� :%�#<; ''$�;
$#�� ;�<* '$#; K$#;,/0XJ''$� *#�:': '*$�;
$(�� ;�%$ '$#; K$(;,/0XJ''$� #)�#$< '<)�;
$<�� $�;# '$#; K$<;,/0XJ''$W ($�:<# )$<�;
$%�� $�$< '$#; K$%;,/0XJ''$� (#�*(% )*:�;
';�� $�); '$#; K';;,/0XJ''$� <<�$'$ )%'�;
'$�� $�:) '$#; K'$;,/0XJ''$� %<�#<( :)%�;
''�� $�*( '$#; K'';,/0XJ''$W $;#�*** :(:�;
')�� $�(; '$#; K');,/0XJ''$� $$<�:#( *'(�;
':�� $�%# '$#; K':;,/0XJ''$� $'#�(<( *#:�;
'*�� '�$* '$#; K'*;,/0XJ''$� $))�%<; *%#�;
'#�� '�'; '$#; K'#;,/0XJ''$� $:*�<%* #:%�;
'<�� '�** '$#; K'<;,/0XJ''$� $#%�'(: (*)�;
)'�� )�)$ '$#; K)';,/0XJ''$� '';�%(< %<)�;
)#�� :�'; '$#; K)#;,/0XJ''$� '(<�(*' $�':;�;�W�?�����������/��������������6����/����8�����.�2����������6������./2����/����6�������������������
Redaelli FLEXPACK Compacted Wire Rope 15 Outer Strands, Non-Rotating Wire Rope ?������������)������������������������������ �)*�(� �������������0B�$')<*M:M';;;!�������$*�������������������� ����� ���� ����� ������� ����������� ���� ������������� �������������� � ��������������������� ��������������������������� � ��������������� ������8������������������������������� ��������������������������� ���� �� ������������ ���������������� ����������� ����� �������� ����������������-����������������������������� ��3�����R�<M$)�'( 1!�(� #+$!�-1�5��/����J������9����1�� �:;*�,����,�����;�(:R�$:M)#�): 1!�(� #+$!�-1�5��/����J������9����1�� �:;*�,����,�����;�(*C ����� ������� �����������
Bluejay Industrial Inc.Wire Rope
35
Index@���������������� �A�5�� �����������������������������������'5���A�/������������������������������������������������������������������)
4���������������,��� ��A�����������������������������������:8������������� �������������������������������������������������������������*
1�����@���A�8������@���� ��� ��,�����?�������������#C �����8����� ��8������A�6�����������������������������(�A�<5��������K������������/����������������������������������������%-� ��������A���7�������5���������������������������%��$;�A�$$#���$%�A�#���'#�1������� �������������������������������$'�A�$)#���)#�A�#���:$�1������� �������������������������������$:�A�$*#���':�1����������������������������������������������������������������$#(���(���(�1������������������������������������������������������������$#$%���(�1����������������������������������������������������������������$(
�������>���?������5���� �?5!�������������������������������$<@���5������5��������������������������������������������������������$<
J���"�4�����5��������������5�����������������������������$%4L5�A�B����� ����5���!�5�������?5�������������������$%8������ �8�����?������5���� 88?5!�������������������������';#���$%�8������ �8�������������������������������������������������������';4L5�5������88?5������������������������������������������������������'$
4L5�5������88?5�/��������1����������������������������������'$$���$%�8������ �8�������������1�������������������������������''$���(�����8��������������������������������������������������������������''
�������>���8��������8�������������������������������������������')5����������A�B�������8���� ������������������������������':5� �����5���A�����������������������������������������������������'*4�9#8� 8����������!�����������������������������������������������'#
4�9#5� #�8�����5��������!������������������������������������'#K�����#���)#���������������������������������������������������������������'(
K�����<�8��������� �������������������������������������������������'<9����K����������5�� ������� ��������������������������������'<4�������6�� ������ � ��������� !�����������������������������'%���������5?��)�8������������� ��������������������������'%4�9<P4� <�8�����5��������!����������������������������������);4�9<4�A�4?�?<P� <�8����!������������������������������������);����������0@�%�A��0@�%4� %�8����!�������������������������)$���������4��"�%4� %�8�����5��������!����������������������)$���������84-B�%4�A�84-B�%P4� %�8����!�������������������)'���������K0�1P�5��������������������������������������������)'���������$%���$%�5������������������������������������������������)):���)%�C��3���1���������������������������������������������������))
���������,������"�B���������������������������������������������):
Lift with Experience
Ratings shown in this catalogue are based upon the items being new or in “as new” condition. Strengths are shown in either working load limit or rated capacity which is the maximum load that should be applied to the product, or breaking strength where the product must be used with an appropriate design factor applied to ����������������������� ������������������������� ���������������� ������� �� ����������� ���� ��������change without notice. It is the customers responsibility to determine the suitability of the product to its intend-ed use, including all industry regulations and guidelines. Careful inspection of any lifting and rigging product is highly recommended for any wear, deformation and misused prior to use.
WWW.BLUEJAYINDUSTRIAL.US© Copyright Bluejay Industrial Inc. 2011
Rigging Center (USA) - Bluejay Industrial Inc.756 W Buckles Ave Hayden ID 83835
Ph: 208 635 5517 Fx: 208 635 5519
Toll Free: 1 877 998 0808Email: [email protected]