1
Wyndham Case Study
Installation Details Water conditioner model HydroFLOW Custom 12”i
Pipe Outer Diameter 10.8 inches
Pipe Material Iron
Installation location Cooling Tower
Overview
Limescale has accumulated on the cooling tower honeycombs, louvers and infratructure even though
the water throughout the building is treated by a traditional salt softening system. And, at the tower,
treated by chemicals under the supervision of an outside chemical company.
Trial method:
1. Monitor the effect of Hydropath Technology to remove limescale accumulated on the cooling tower
honeycombs, louvers and infrastructure.
2. Monitor the effect of Hydropath Technology on preventing the growth of new limescale.
Expected results:
1. Limescale will be dissolved on the honeycombs, louvers and portions of the infrastucture where the
treated water has consistent contact.
2. Limescale will not rematerialize on the above mentioned areas of the cooling tower.
3. Chemicals can be reduced or discontinued without any detrimental effects.
Location: Wyndham Office Building
Whippany, NJ - USA
Date of First Inspection:
April 6, 2012
Application: Install Custom 12”i Date of Second Inspection:
April 26, 2012
Purpose of Installation:
Removing and preventing limescale and kill bacteria and algae.
Installation Date: March 14, 2012
2
Picture of the 12”i
Installed Custom 12”i
3
Pre HydroFLOW
4
5
6
Post HydroFLOW
Pre-Clean
Cleaned
7
Pre-Clean
Cleaned
8
Pre-Clean
Cleaned
9
Pre-Clean
Cleaned
10
10 Weeks Post HydroFLOW
Cleaned
After 10 Weeks
Cleaned
11
After 10 Weeks
Cleaned
12
After 10 Weeks
Pre HydroFLOW
13
After 10 Weeks
14
Definitive results after 10 weeks
* Existing Limescale was dissolved and eradicated. New limescale did not reappear or accumulate on the
tower.
Conclusion
* Hydropath Technology can be recommended as a chemical-free method to remove
and prevent scaling on cooling towers.