Date post: | 09-May-2023 |
Category: |
Documents |
Upload: | khangminh22 |
View: | 0 times |
Download: | 0 times |
Innovative water-proof and tamper-proof Smart DIN
meter solutions Guo Tao(Captain)
Marketing Director
Shenzhen Inhemeter co., Ltd.
China
Table of Content
1. Target of Metering Solution
2. Challenges for Utilities
3. Water/Tamper Proof Smart DIN Meter Solution
4. Smart DIN Meter Solution Using Cases
5. Conclusion
Improving Revenue and Cash Flow
Fair Distribution of Electricity
Speeding Up Billing & Customer Service
Effective Asset Management
Cost Saving for Customer & Utility
Positive ROI
Access to Electricity & Improve Quality of Supply
Saving Natural Resource & Decreasing CO2
Powering People for Better Life
Target of Metering Solution
High line
loss rate
(technical
and Non-
technical)
Bad debt,
overdue
payments
and Cash
flow
Load
Shedding
and
Shortage of
Electricity
Failure
Rate and
maintenanc
e cost
Challenges for Utilities In General
Johannesburg/South Africa(Jan 2016) Water Ingress Damage Assets/Tamper Loss
Challenges for Utilities on Site
Support STS (Prepayment) & DLMS (AMR/AMI)
Two Way Communication to Support all AMI Functions & Remote
Firmware upgrade
Multi Communication: PLC (G3, Prime, SFSK, BPSK) , RF/RF Mesh,
Zigbee, GPRS, etc
Multi Channel Vending: POS, Cellphone, E-Banking, Scratch card, CDU,
AVM, etc;
Demand Side Management/Load Control/TOU
Tamper Proof Solution
High Secure and Extendable
High Performance
Smart DIN Meter Solution Highlight
Dual Measurement Sensor/Contact
MC171 Port (VTC)
Prepayment /Post Payment
Anti-Tamper/Theft
Water-Proof Design (IP54)
STS (Prepayment) & DLMS (AMR/AMI)
Two Way Communication
Remote Firm Wave
Multi Communication: PLC/PLC Mesh,
RF/RF Mesh, Zigbee.
DIN-III
Water & Tamper Proof Smart DIN-III Meter Solution
No ingress of dust
Protection against effects of continuous immersion in water
IP68
IEC60529(Water/Dust):IP51,IP54 VS IP68
MALAWI ESCOM &
KENYA KPLC &
SUDAN SEDC &
ZIMBABWE ZETDC’ s headache:
Meter burnt / failed because of water in meter
IP51 Is NOT Enough
Dual sensor and contactor
Cancellation of Tampers
Fully disconnect Customer from Power Network
Safety and Security
Current Bypass
Phase & neutral interchanged
I/C & O/G interchanged
Neutral disconnected
I/C & O/G (phase or neutral)
disconnected
Load connected to ground ……
Phase & neutral disconnected,
load connected to ground;
Why Dual Sensor & Contactor
Not only calculate, but also control.
Nout Lout
Nin Lin
Nout Lout
Nin Lin
BYPASS
Dual Sensor & Contactor ?
Not only calculate, but also control.
Nou
t
Lout
Nin Lin
Nout Lout
Nin Lin
Dual Sensor & Contactor ?
Direct Installation on Self-
Supporting ABC Cable
with IPC Connector.
Water & Tamper Proof Smart DIN-ABC Meter
Prepayment /Post Payment
Anti-Tamper/Theft
Water-Proof Design (IP68)
STS (Prepayment) & DLMS
(AMR/AMI)
Two Way Communication
Remote Firm Wave
Multi Communication: PLC/PLC
Mesh, RF/RF Mesh, Zigbee.
DIN-ABC
Water & Tamper Proof Smart DIN-ABC Meter
Enterprise Bus (CIM)
AMI System
SFDM System
SCADA
Vending System
Payment Platform
Billing System
Integration Platform Based on CIM
HES System integrates multiple Meter Data Collection Systems,
billing data, distribution management data, and makes sophisticated process on meter data.
HES System Function Architecture
• Communication Media: GSM/GPRS, Fiber Optic, RF,
PLC, etc.
• Communication Protocol: DLMS/COSEM, ANSI, DLT
• High performance (Using Clustering Method)
• Automatic Detection of Meter to Simplified Installation
• Open Interface for Integration & Compatibility
• Support >500,000 Metering Points/Instant
• 24/7 Real Time Online Service Support….
HES System Highlight
Data Exchange platform (open interface to other System)
Interface to Different Smart Metering System
Data Warehouse AMM function
Unified Event and alarm management
Report and Analysis
Data and line loss analysis
Audit Trail and Data versioning
VEE (Validation, Estimation and editing)
Calculation engine (aggregation)
Load control
Work flow and task management
Customer Portal and Customer Management
New Function
MDM system as multi-vendor platform gathers metering information from different brand of
Smart metering system or Smart Meter, make processing on received information and after
categorizing send it related utilities applications.
MDM System Function Architecture
Service Point Concept Meter & Customer Modeling
Rich Set of Configurable Data Validation
Configurable & Automated Data Delivery Rules
Asset Management
Strong Aggregation & Calculation Method
Highly Secure, Extremely Available, Highly Scalable
Modular Design, Easily Extensible, Fully Flexible
Support of Open Interfaces to Other System
Support Different AMI System from Different Suppliers
MDM System Highlight
Disconnection Done in
Customer Level Instead of
Feeder Level
Make limitation on Customer Consumption
Disconnection of Customer
Appliance Instead of Fully Disconnection
Two Way Measurement
Provide Infrastructure for Integration of New Energy
Cu
sto
mer
Sat
isfa
ctio
n
Reduce Load Shedding Effect
0101010
Over Load Signal
Smart Terminal 0101010
0101010
SCADA System
0101010
Load Control
0101010
AMI System
Demand Side Management
To activate demand limiting function, Utility will relay a command to the specific meter to turn on the demand limiting module.
Demand Limiting Module will cut off when the consumption exceeds a certain predetermined level
Utility
DONE DC
Request AMI System
PLC
or R
F
Demand Limiting
Concentrator will collect meter data from meters within its domain and transmit it back to the Utility at a regular frequency
DC
Request
Response
Utility
AMI system
PLC
or R
F
Scheduled Meter Reading
An Alarm sent out identifying the meter when that specific meter is tampered
ALARM NOTIFICATION
Tamper Alarm
Utility
DC
AMI System GIS system
PLC
or R
F
Tamper Detect
Request Special Read of a specific Meter from utility
DISCONNECT
DONE
Utility
DC
AMI system
PLC
or R
F
Remote Control: Connect/Disconnect
If the meter need to increase some new functions
Upgrade firmware
Utility
DC
DONE
Request
AMI System
PLC
or R
F
Remote Firmware Upgrading
AMI can gather real time data to provide to customer to proof the
quality of the energy supplied to their vicinity
DC
Utility
Request
Response
AMI System
PLC
or R
F
Quality of Power Supply
ALARM NOTIFICATION
Outage Alarm
Utility
AMI System
Outage Management system
PLC
or R
F
Outage Detection
AMI Server can establish two way communication with Customer for Billing, Credit, advertising
Two Way Communication with Customer
DC
Utility
SMARTview
Customer Communication
• Increase Visibility of Power Network
• Reduce Line Losses (Technical/Non-Technical)
• Reduce Asset Loss and Improve Revenue
• Improve Demand/Load Management
• Realize AMR/AMI Management of Metering & Meter Assets
• Improve customer satisfaction through offering better services
Smart DIN Meter Solution
Conclusion
Powering People of Better Life