Service Manual - Audio-Circuit.dk

Service Manual

www.altoproaudio.comVersion: 1.1

Model: L-8 (8-CHANNEL MIXING CONSOLE

WITH DIGITEL EFFECTS)

CONTENTS

1. Specification

2. Block Diagram

3. Schematic Diagram

4. Printed Circuit Board

5. Wiring Diagram

6. Test Procedure

7. Electrical Parts List

8. Exploded Views & Mechanical Parts List

9. Notes

8. TECHNICAL SPECIFICATION

Mono input channels

Microphone input electronically balanced, discrete input configuration

Frequency response 10Hz to 55kHz, + 3dB

Distortion (THD & N) 0.005% at + 4dBu, 1kHz

Gain range 0dB to 60dB (MIC)

SNR (Signal to Noise Ratio) 115dB

Line input electronically balanced

Frequency response 10Hz to 55kHz, + 3dB

Distortion (THD & N) 0.005% at + 4dBu, 1kHz

Sensitivity range +15dBu to 45dBu

Stereo input channels

Line input unbalanced

Frequency response 10Hz to 55kHz, 3dB +

Distortion (THD & N) 0.005% at +4dBu, 1kHz

Impedances

Microphone input 1.4kOhm

Channel Insert return 2.5kOhmAll other inputs 10kOhm or greater

Tape out 1kOhm

All other output 120Ohm

Equalization

Hi shelving + 15dB @12kHz

Mid bell + 12dB @2.5kHz

Low shelving + 15dB @80Hz

Low Cut filter 75Hz, 18dB/oct.

Main Mix Section

Noise (Bus noise) Fader 0 dB, channels muted: 100dBr (ref.:+4dBu)

Fader 0dB, all input channels assigned

and set to UNITY gain: 90dBr (ref.:+4dBu)

Max output +22dBu balanced XLR,+22dBu unbalanced, 1/4" jacks

AUX Return gain range OFF to +20dB

AUX Sends max out +22dBu

DSP SECTION

A/D and D/A converters 24 bit

DSP resolution 24 bit

Type of effects Hall, Room, Vocal & Plate REVERBS

Mono & Stereo DELAY (max DELAY TIME 500ms)

Chorus, Flanger & Vibrato MODULATIONS

REV+DELAY, REV+CHORUS, REV+FLANGER, REV+VIBRATO combinations

Presets 256

Controls 16-position PRESET BANK Selector

16-position VARIATION selector

CLIP LED

MUTE SWITCH with LED indicator

Power supply

Main voltage USA/Canada 100 120V~, 60Hz

Europe 210 230V~, 50Hz

U.K./Australia 240V~, 50Hz

Power Consumption 25watts

Fuse 100 120V~ : T500mAL

210 240V~ : T250mAL

Main connection Standard IEC receptacle

Physical

Net weight 2.4Kg (5.29lb)

Shipping weight 3.5Kg (7.72lb)

Dimension (W D H) 245mm 268mm 24/73mm (9.64" 10.54" 0.94"/2.87")

12

34

56

78

ABCD

87

65

43

21

D C B A

L8MA

PSc

h

Ttel

Size

Fle

Date

Draw

n By

Shee

t

Revis

ionMo

del N

o

5-Oct-

2003

KE

VIN

LIN

ALTO

MIX

ING

CONS

OLE

11

of

L-8 B

LOCK

DIA

GRAM

VER0

3011

8A2

(C)

MONO

INPU

T CH

ANNE

LS (

1-4 )

2 13MI

C IN

+48V

3-BA

ND E

Q12K

2.5K

80

HI P

ASS

213

LO C

UT

SG/O

L

LEFT-BUSRIGHT-BUSAUX-1AUX-2

RIGH

T-BU

S

LEFT

-BUS

AUX-

1

AUX-

2

STER

EO IN

PUT

CHAN

NELS

(5-8

)

EQ12

K2.5

K80

LEFT

-BUS

RIGH

T-BU

S

AUX-

1

AUX-

2

LEFT

-BUS

RIGH

T-BU

S

STER

EO A

UX R

ETUR

N 2

RIGH

T-BU

S

LEFT

-BUS

AUX-

1

AUX

SEND

AUX-

2

MAIN

OUT

LEFT

-BUS

RIGH

T-BU

S

21 3

2TK

TO M

IX 21 3

RIGH

T-BU

S

LEFT

-BUS

TAPE

IN

RIGH

T

2-TR

ACK

21 3

2TK

TO C

TRL

RO

OM

21 3

PHON

ES O

UTPU

T

LEFT

MET

ER

RIGH

T MET

ER

75Hz

+/-15

db

3-BA

ND E

Q12K

2.5K

80

+/-15

db

3c 5e1a4d 2b

LEFT

3c 5e1a4d 2b

RIGH

T

MAIN

MIX

AU

X S

EN

D1

TR S

AU

X S

EN

D2

TR S

MA

IN M

IX L

EFT

TR S

MA

IN M

IX R

IGH

T

TR S

CONT

ROL

ROOM

OUT

PUT

LEFT

TR S

RIG

HT

TR S

PH

ON

ES

TR S

& PH

ONES

CONT

ROL R

OOM

LEFT

TAPE

OUT

2 13 2 13

LEVE

L

AUX

RETU

RN2

STER

EO A

UX R

ETUR

N 1

3c 5e1a4d 2b

LEFT

(MON

O) 3c 5e1a4d 2b

RIGH

T

AUX

RETU

RN1

-TR SRN TN TR SRN TNTR SRN TN TR SRN TN

PA

N

PHAN

TOM

LINE

N

GA

IN

-+

POW

ER

- --

LOM

IDH

I

12

12

AU

X1

AU

X2

LEV

EL

POST

PRE

BALA

NCE

AUX1

AUX2

LEVE

L

LOM

IDH

I

SG/O

L

3c 5e1a4d 2b

LEFT

(MON

O) 3c 5e1a4d 2b

RIGH

T

TR SRN TN TR SRN TN

- -

2 13MI

C5 IN

+48V

PHAN

TOM

GA

IN

-+

POW

ER

CHAN

NEL 5

6 ONL

Y

3c 5e1a4d 2b

INSE

RT

TR SRN TN

MIC

GAIN

:0~60

dBLIN

E IN

TRIM

:15d

B~-4

5dB

EFX

SEND

DSP

BOAR

D

PRES

ETS

VARI

ATIO

NS

MUTE

DSP

FOOT

SWIT

CH

EFX SEND

LEFT-BUSRIGHT-BUSAUX-1AUX-2EFX SEND

AUX-

1

AUX1

1 2 3 4 5 6 7 8

A

B

C

D

87654321

D

C

B

A

L8MN1.Sch

Titel

Size

File:Date:

Drawn By:Sheet

RevisionModel No:

5-Oct-2003 KEVIN LIN.

INPUT STAGE

41 of

ALTO L-8 VER030113A2

EQ HI12KHZ

C13118n(M)

VR2B50K

R1516K8

VR4B50K

R1506K8

LO

R4710K

C8747u/25V

5

67

U3B4580M

R2201M

C17922P

R2121K1

VR3B50K

R1371K3

MID

R196910R

C15512n(M)

R197910R

C13933n(M)

C14033n(M)

C17112n(M)

C16318n(M)

C8847u/25V

R2855K1

VR6W50K

AUX-1

R22868K

R2484K7

C1952.2u/50V

R1526K8

TR2BR

TR1BR

R2641K5 +VCC

LD1RED

R23630K

3

21

U3A4580M

VR8W50K

PEAK

C8947u/25V R256

3K9

R27036K

C18022P

VR5W50K

C9047u/25V

R2845K1

AUX-2

LEVEL

AUX-POST

VR7AJQ10K

VR7BJQ10K

R2875K1

R2865K1

LEFT-BUS

RIGHT-BUS

PAN

PGND

AUX-PRE80HZ

2.5K

EQ HI12KHZ

C13218n(M)

VR10B50K

R1556K8

VR12B50K

R1546K8

LO

R5510K

C9447u/25V

5

67

U6B4580M

R2211M

C18122P

R2131K1

VR11B50K

R1391K3

MID

R198910R

C15612n(M)

R199910R

C14133n(M)

C14233n(M)

C17212n(M)

C16418n(M)

C9547u/25V

R2895K1

VR14W50K

AUX-1

R22968K

R2494K7

C1962.2u/50V

R1566K8

TR4BR

TR3BR

R2651K5 +VCC

LD2RED

R23730K

3

21

U6A4580M

VR16W50K

PEAK

C9647u/25V R257

3K9

R27136K

C18322P

VR13W50K

C9847u/25V

R2885K1

AUX-2

LEVEL

AUX-POST

VR15AJQ10K

VR15BJQ10K

R2915K1

R2905K1

LEFT-BUS

RIGHT-BUS

PAN

PGND

AUX-PRE80HZ

2.5K

EQ HI12KHZ

C13318n(M)

VR18B50K

R1596K8

VR20B50K

R1586K8

LO

R6310K

C10147u/25V

5

67

U9B4580M

R2221M

C18222P

R2141K1

VR19B50K

R1411K3

MID

R200910R

C15712n(M)

R201910R

C14333n(M)

C14433n(M)

C17312n(M)

C16518n(M)

C10347u/25V

R2935K1

VR22W50K

AUX-1

R23068K

R2504K7

C1972.2u/50V

R1606K8

TR6BR

TR5BR

R2661K5 +VCC

LD3RED

R23830K

3

21

U9A4580M

VR24W50K

PEAK

C9747u/25V R258

3K9

R27236K

C18422P

VR21W50K

C10647u/25V

R2925K1

AUX-2

LEVEL

AUX-POST

VR23AJQ10K

VR23BJQ10K

R2955K1

R2945K1

LEFT-BUS

RIGHT-BUS

PAN

PGND

AUX-PRE80HZ

2.5K

EQ HI12KHZ

C13418n(M)

VR26B50K

R1636K8

VR28B50K

R1626K8

LO

R7110K

C10247u/25V

5

67

U12B4580M

R2231M

C18522P

R2151K1

VR27B50K

R1431K3

MID

R202910R

C15812n(M)

R203910R

C14533n(M)

C14633n(M)

C17412n(M)

C16618n(M)

C10447u/25V

R2985K1

VR30W50K

AUX-1

R23168K

R2514K7

C1982.2u/50V

R1646K8

TR8BR

TR7BR

R2671K5 +VCC

LD4RED

R23930K

3

21

U12A4580M

VR32W50K

PEAK

C10547u/25V R259

3K9

R27336K

C18622P

VR29W50K

C10747u/25V

R2975K1

AUX-2

LEVEL

AUX-POST

VR31AJQ10K

VR31BJQ10K

R2965K1

R2995K1

LEFT-BUS

RIGHT-BUS

PAN

PGND

AUX-PRE80HZ

2.5K

84

U3C4580M

84

U6C4580M

C205100n

C206100n

+VCC

-VCC

C289100n

C290100n

84

U12C4580M

84

U9C4580M

J2

POST

(PRE)

J1

POST

(PRE)

J3

POST

(PRE)

J4

POST

(PRE)

C295100n

C296100n

C297100n

C298100n

(SOLTON 1K2)用

C31947u/25V

C31847u/25V

C32047u/25V

C32147u/25V

EQ HI

C13518n(M)

VR34AB50K

R1676K8

VR36AB50K

R1666K8

LO

R9610K

C11147u/25V

3

21

U16A4580M

R2241M

C18722P

R2161K1

VR35AB50K

R1451K3

MID

R204910R

C15912n(M)

R205910R

C14733n(M)

C14833n(M)

C17512n(M)

C16718n(M)

C11247u/25V

R3125K1

VR38W50K

AUX-1

R23247K

R2544K7

C1992.2u/50V

R1706K8

TR10BR

TR9BR

R2681K5 +VCC

LD5RED

R24422K 3

21

U17A4580M

VR40AW50K

PEAK

C11347u/25V R260

3K9R28136K

C18822P

VR37W50K

C11647u/25V

R3135K1

AUX-2

LEVEL

AUX-POST

VR39AJQ10K

VR39BJQ10K

R3115K1

R3105K1

LEFT-BUS

RIGHT-BUS

BAL

PGND

AUX-PRE

80HZ

2.5K

EQ HI

C13618n(M)

VR34BB50K

R1696K8

VR36BB50K

R1686K8

LO

R11110K

C11947u/25V

5

67

U16B4580M

R2251M

C19022P

R2171K1

VR35BB50K

R1461K3

MID

R206910R

C16012n(M)

R207910R

C14933n(M)

C15033n(M)

C17612n(M)

C16818n(M)

C12047u/25V

80HZ

2.5K

R9710K

R9810K

R23347K

R24522K 5

67

U17B4580M

VR40BW50K

C11447u/25V R261

3K9

R28036K

C18922P

C11547u/25V

LEVEL

R10010K

R9910K

J5

POST

(PRE)

EQ HI12KHZ

C13718n(M)

VR41AB50K

R1726K8

VR43AB50K

R1716K8

LO

R12010K

C12447u/25V

3

21

U19A4580M

R2261M

C19122P

R2181K1

VR42AB50K

R1471K3

MID

R208910R

C16112n(M)

R209910R

C15133n(M)

C15233n(M)

C17712n(M)

C16918n(M)

C12747u/25V

R3175K1

VR45W50K

AUX-1

R23547K

R2554K7

C2002.2u/50V

R1736K8

TR12BR

TR11BR

R2691K5 +VCC

LD6RED

R24622K 3

21

U20A4580M

VR47AW50K

PEAK

C12147u/25V R262

3K9R28336K

C19222P

VR44W50K

C13047u/25V

R3145K1

AUX-2

LEVEL

AUX-POST

VR46AJQ10K

VR46BJQ10K

R3165K1

R3155K1

LEFT-BUS

RIGHT-BUS

BAL

PGND

AUX-PRE

80HZ

2.5K

EQ HI12KHZ

C13818n(M)

VR41BB50K

R1756K8

VR43BB50K

R1746K8

LO

R12510K

C12547u/25V

5

67

U19B4580M

R2271M

C19322P

R2191K1

VR42BB50K

R1481K3

MID

R210910R

C16212n(M)

R211910R

C15333n(M)

C15433n(M)

C17812n(M)

C17018n(M)

C12647u/25V

80HZ

2.5K

R12110K

R12210K

R23447K

R24722K 5

67

U20B4580M

VR47BW50K

C12847u/25V R263

3K9

R28236K

C19422P

C12947u/25V

LEVEL

R12410K

R12310K

J6

POST

(PRE)

PCB# L8MN1.PCB

RTN-CH1

RTN-CH2

RTN-CH3

RTN-CH4

PRE-CH5

PRE-CH6

PRE-CH7

PRE-CH8

84

U16C4580M

84

U17C4580M

C217100n

C218100n

C219100n

C220100n

84

U20C4580M

84

U19C4580M

C207100n

C208100n

C201100n

C202100n

MAIN IN-OUTPUTL8MN1.S01

LED DISPLAYL8MN1.S02

L8MN1 (1/3)

UDASP IN-OUT SECTIONL8MN1.S03

1 2 3 4 5 6 7 8

A

B

C

D

87654321

D

C

B

A

L8MN1.S01

Titel

Size

File:Date:

Drawn By:Sheet

RevisionModel No:


STEREO AUX & SENDS & MAIN OUT & 2TK & CTRL R & PHONES

32 of

ALTO L-8 VER030120A2(C)

C265100P

C24147u/25V R77

8K2

R24122K

C266100P

C23947u/25V R78

8K2

R24022K

VR48BW50K

VR48AW50K

3

21

U21A4580M

5

67

U21B4580M

84

U23C4580M

R31856K

C22322P

C24347u/25V

R3025K1

R32056K

C26922P

C24547u/25V

R3045K1

5

67

U25B4580M

3

21

U25A4580M

84

U26C4580M

R155K1

C1322P

LEFT-BUS

RIGHT-BUS

C26022P

R3065K1

R3055K1

84

U21C4580M

R3015K1

C23447u/25V

C23347u/25V

5

67

U26B4580M

3

21

U26A4580M

84

U27C4580M

R27736K

C26422P

R163K9

C847u/25V

VR51BW50K

MAIN MIX

VR51AW50K

R27636K

C26322P

R3393K9

C23647u/25V

C23747u/25V

C23847u/25V

R7610K

R7510K

84

U24C4580M

C203100n

C204100n

+VCC

-VCC

C211100n

C212100n

C25147u/25V

R18820K

3

21

U23A4580M

R18920K

C28222P

C25247u/25V

R8510K

R3095K1

C24647u/25V

R18620K

5

67

U23B4580M

R18720K

C28122P

C24847u/25V

R8110K

R3085K1

LEFT-BUS

RIGHT-BUS

2TK TO MIX

R34827K

2TK TO

R34927K

3

21

U27A4580M

5

67

U27B4580M

VR50BW50K

VR50AW50K

C24947u/25V

C25547u/25V

R3443K9

R3453K9

R27836K

R27936K

C22522P

C22622P

C25047u/25V

C25647u/25V

R8210K

R8610K

84

U25C4580M

AUX RETURN 1

R-METER

EFX TO AUX1

R18420K

C23147u/25V

3

21

U24A4580M

R27536K

C22222P

L-METER

AUX-1

R18520K

C23247u/25V

5

67

U24B4580M

R27436K

C22122P

AUX-2

C271100P

C272100P

MAIN MIX

ROOM

LEFT-BUS

RIGHT-BUS

LEFT

RIGHT

R7339K

R7439K

CONTROLPHONES/

CTRL ROOM

C14100P

C1947u/25V R7

10K

C20100P

C547u/25V R8

10K

VR49BW50K

VR49AW50K

3

21

U1A4580M

5

67

U1B4580M

R31936K

C22422P

C24447u/25V

R2710K

R32136K

C27022P

C24747u/25V

AUX RETURN 2

C2222P

C4547u/25V

R395K1

R7210K

R385K1

5

67

U31B4580M

C2422P

C28647u/25V

R3755K1

R4151K

R935K1

12345678

CN02.5-8P

PGND

+VCC-VCCPH PWR

C305100n

C306100n

C307100n

C308100n

C309100n

C310100n

C311100n

C312100n

MAIN-L-2

MAIN-R-2

LEFT-BUS

RIGHT-BUS

AUX-1AUX-2AUX-SEND1

AUX-SEND2

AUX-RTN1-L

AUX-RTN1-R

AUX-RTN2-L

AUX-RTN2-R

2TK- N-L

2TK- N-R

2TK TO CR-R

2TK TO CR-L

SW9APS-22E85L

SW9BPS-22E85L

RIGHT-BUS

LEFT-BUS

MAIN-L-3

MAIN-R-3

SW10BPS-22E85L

MAIN-R-2

2TK TO CR-R

2TK TO CR-L

MAIN-L-2

SW10APS-22E85L CTRL-R-L

CTRL-R-R

CTRL-R-L

CTRL-R-R

123456789101112

CN32.5-12P-B24(TO L8MN1)

RTN-CH1RTN-CH2RTN-CH3RTN-CH4

PRE-CH5PRE-CH6PRE-CH7PRE-CH8

123456789101112

CN42.5-12P-B24(TO L8MN1)

MAIN-R-2MAIN-R-3MAIN-L-2MAIN-L-3

+VCC-VCC

12345678

CN52.5-8P-B24A(TO L8MN1)

AUX-RTN1-LAUX-SEND1

AUX-RTN1-RAUX-SEND2

AUX-RTN2-L

CTRL-R-L

AUX-RTN2-R

CTRL-R-R2TK-IN-L2TK-IN-R

PH PWR

FOOTSW

+VCC-VCC

EFXRTN-L

EFXRTN-R

AUX-SEND2AUX-SEND1

MAIN-L-2

MAIN-L-3

MAIN-R-2

MAIN-R-3

2TK-IN-L

2TK-IN-R

+5VD

L8MN1 (2/4)

DGND

3

21

U31A4580M

3

21

U2A4580M

C6

47u/25V

C7

47u/25V5

67

U2B4580M

R1010K

C1222P

R910K

C1122P

R1110K R12

5K1

R1327K

R14

27K

R263K9

C1047u/25V

R253K9

C947u/25V

AUX-1

84

U1C4580M

84

U2C4580M

C15100n

C16100n

C17100n

C18100n

VR9W50K (AUX RETURN2)

84

U31C4580M

C340100n

C341100n

12

34

ABCD

43

21

D C B A

L8MN

1.S02

Titel

Size

File:

Date:

Draw

n By:

Shee

t

Revis

ionMo

del N

o:

5-Oc

t-200

3 KE

VN

LN.

DISP

LAY

STAG

E

43

of

ALTO

L-8

VER0

3012

0A4

8

914

U35

CLM

339

16

7

U35

BLM

339

16

7

U38

BLM

339

8

914

U38

CLM

339

8

914

U36

CLM

339

16

7

U36

BLM

339

16

7

U39

BLM

339

8

914

U39

CLM

339

LD10

GR

LD11

GR

LD12

GR

LD13

GR

LD14

GR

LD15

GR

LD16

GR

LD17

GR

R35

012

0R

R35

512

0RR

356

470R

R35

933

0RR

357

470R

R36

033

0RR

358

470R

R36

151

0RR

362

620R

+VCC

R35

456

R

-VCC

PGN

D

10

1113

U35

DLM

339

5

42

U35

ALM

339

5

42

U38

ALM

339

10

1113

U38

DLM

339

10

1113

U36

DLM

339

5

42

U36

ALM

339

5

42

U39

ALM

339

10

1113

U39

DLM

339

LD22

GR

LD23

GR

LD24

GR

LD25

GR

LD26

GR

LD27

GR

LD28

GR

LD29

GR

-VCC

LEFT

MET

ER(-3

0)(-2

0)(-1

0)(-7

)(-4

)(-2

)(0

)(+

2)

321

U30

A45

80M

R36

710

0K

R37

10R

0

R36

910

0KC

283

47u/

25V PG

ND

10

1113

U37

DLM

339

5

42

U37

ALM

339

5

42

U40

ALM

339

10

1113

U40

DLM

339

LD30

GR

LD31

GR

LD32

YEL

LD33

RED

8

914

U37

CLM

339

16

7

U37

BLM

339

16

7

U40

BLM

339

8

914

U40

CLM

339

LD18

GR

LD19

GR

LD20

YEL

LD21

RED

R36

31K

3R

364

2KR

365

5K6

R36

627

K

TR13

HR

+VCC

D1A D

A20

4KD1B

DA

204K

TR14

HR

R35

312

0R

R35

147

0R

R35

247

0RR

8710

K

PGN

D

567

U30

B45

80M

R36

810

0K

R37

20R

0

R37

010

0KC

284

47u/

25V PG

ND

L-M

ETER

R-M

ETER

3 12

U36E

LM33

9

3 12

U37E

LM33

9

3 12

U35E

LM33

9

3 12

U38E

LM33

9

3 12

U39E

LM33

9

8 4

U30C

4580

M

C213

100n

C214

100n

R373

47R

R374

47R

C257

47u/2

5V

C258

47u/2

5V

+VCC

-VCC

PGN

D

LD8

REDLD

7G

R R253

4K7

R252 2K

PGN

D

PGN

D

PH P

WR

31

D3A

DA20

4K

D3B

DA20

4K

31

D2A

DA20

4K

D2B

DA20

4K

(+4)

(+7)

(+10

)(+

18)

PWR

ON

PHAN

TOM

+VCC

3 12

U40E

LM33

9

R42

810

KR

427

10K

PGN

DPG

ND

L8M

N1

(3/4

)

C342

47P

C343

47P

1 2 3 4 5 6 7 8

A

B

C

D

87654321

D

C

B

A

L8MN1.S03

Titel

Size

File:Date:

Drawn By:Sheet

RevisionModel No:


UDASP IN/OUT SECTION

44 of


C3922P

C611.5nF 2.5%

C504.7uF

5

67

U44B4580M

R2410K

R6868R

R173K3 R19

10K

R2210K

3

21

U44A4580M

R110K

C4022P

C621.5nF 2.5%

C524.7uF

5

67

U45B4580M

R4610K

R668R

R183K3 R20

10K

R2310K

3

21

U45A4580M

R4810K

357

RL1BRY-5W-K

468

RL1CRY-5W-K

EFXRTN-L

EFXRTN-R

C594.7uF

5

67

U46B4580M

3

21

U46A4580M

C601.5nF 2.5%

R2110K

R210K

C4922P

R5610K

C3822P

R542K2

R5310K

EFXRTN-L

EFXRTN-R

AUX-SEND2

(MUTE)

(MUTE)

12345678910

111213141516

CN6HEADER 8X2 1

234

COM

EN2SDB161PVB15FS

1234

COM

EN1SDB161PVB15FS1

23

45

67

8

AR1680R*4

12

34

56

78

AR2680R*4

DGND DGND

+5VD

DGND

+5VD

CLK 4

J 2

S5

R1

Q6

Q7 K 3

U48A74HC109

+5VDR5010K

D7BAS316

12

U49A74HC14

C31uF

DGND

+5VD

R5210K

D15BAS316

C41uF

DGND

R80220R

R79220R SW1

PS-22E85NL

DGND

(MUTE)

R6710K

R6610K

TR16BR

DGNDDGND1

2

RL1ARY-5W-K

+5VD

C51100N

D9RLS4148

R65220R

R497K5

LD54RED

FOOTSW

84

U44C4580M

84

U46C4580M

84

U45C4580M

C29100N

C30100N

C31100N

C32100N

+VCC

-VCC

3 4

U49B

74HC14

5 6

U49C

74HC14

8 9

U49D74HC14

12 13

U49F74HC14

147

U49G74HC14

DGND

CLK 12

J 14

S11

R15

Q10

Q9 K 13

U48B74HC109

DGND

168

U48C74HC109 C36

100NC35

100N+5VD

DGND

C8610uF

UDASP IN/OUT SECTIONJP1

PGND

1248

1248

DGND

3

21

U47ALM393

5

67

U47BLM393

R904K7

+VCC

R1141K

C37100N

R1121M

R1132M2

R5820K

D10ARB400D

PEAK(FLICKER)MUTE(GLOW)

PRESETVARIATION

84

U47CLM393

TR17BR

DGND

R11810K

R310K

DGND

OUT3 RS 4

TG 2

TH 6

CTR

5

DS

7

U43ANE555

C1100N

DGND

+5VD

R447K

C11810uF

DGND

81

U43BNE555

C11733P

C233P

10K CHANGE TO 3K3

L8MN1 (4/4)

EFX-SEED

D16DA202K

1 2 3 4 5 6 7 8

A

B

C

D

87654321

D

C

B

A

L8PU2.Sch

Titel

Size

FileDate

Drawn BySheet

RevisionModel No


INPUT/OUTPUT STAGE

11 of


R134R7

R144R7

C61n

C51n

C511000u/10V

R114R7

VR12C10K

R121K50

R502K49

3

21

U2A4580M

R465K11

C4922P

C8547u/25V

5

67

U2B4580MR131

62K

R1361K3

R17720K

R17620K

C8647u/25V

C700.22u/50V

C710.22u/50V

C720.22u/50V

R1496K8

LO CUT2

13

4

X5JY-5042-030G

3c

5e

1a

4d2b

X6JY-6351G-02-250

T

R

S

RNTN

C1330P

C1510n

R388470R

R452K49

C2947u/63V

C3047u/63V

R296K34

R306K34

C2022u/35V

C1922u/35V

R26K81

R16K81

3

21

U5A4580M

R545K11

C5422P

C9147u/25V

5

67

U5B4580M

R13262K

R1381K3

R17920K

R17820K

C9347u/25V

C730.22u/50V

C740.22u/50V

C750.22u/50V

R1536K8

2

13

4

X7JY-5042-030G

3c

5e

1a

4d2b

X8JY-6351G-02-250

T

R

S

RNTN

3

21

U8A4580M

R625K11

C5822P

C9247u/25V

5

67

U8B4580M

R13362K

R1401K3

R18220K

R18020K

C10047u/25V

C760.22u/50V

C770.22u/50V

C780.22u/50V

R1576K8

2

13

4

X9JY-5042-030G

3c

5e

1a

4d2b

X10JY-6351G-02-250

T

R

S

RNTN

3

21

U11A4580M

R675K11

C5922P

C9947u/25V

5

67

U11B4580M

R13462K

R1421K3

R18320K

R18120K

C10847u/25V

C790.22u/50V

C800.22u/50V

C810.22u/50V

R1616K8

2

13

4

X11JY-5042-030G

3c

5e

1a

4d2b

X12JY-6351G-02-250

T

R

S

RNTN

LINE IN1

LINE IN2

LINE IN3

LINE IN4

MIC 1

MIC 2

MIC 3

MIC 4

84

U2C4580M

C203100n

C201100n

C204100n

C202100n

VCC

-VCC

C205100n

C206100n

84

U5C4580M

84

U8C4580M

84

U11C4580M

PH PWR

C287100n

C288100n

C289100n

C290100n

C291100n

C292100n

C293100n

C294100n

C295100n

C296100n

C297100n

C298100n

C299100n

C300100n

C301100n

C302100n

C43100n

C45100n

TR15HR

TR16A1316

R151K50

-VCC

VCC

R522K49

R512K49

C1610n

R389470R

TR25HR

TR26A1316

-VCC

VCC

3

21

U1A4580M

5

67

U1B4580M

C4822P

C5022P

R4035K11

R4025K11

R582K49

-VCC

R572K49

TR35HR

VCCR532K49

D4BAS316

VCC

R2820K

-VCC

R41710K0

R41810K0

R4045K11

C5722P

84

U1C4580M

84

U4C4580M

84

U7C4580M

84

U10C4580M

R484R7

R494R7

C81n

C71n

C521000u/10V

R3984R7

VR92C10K

R161K50

R602K49

C2330P

C1710n

R390470R

R592K49

C3247u/63V

C3347u/63V

R316K34

R326K34

C2322u/35V

C2122u/35V

R46K81

R36K81

PH PWR

TR17HR

TR18A1316

R171K50

-VCC

VCC

R652K49

R642K49

C3510n

R391470R

TR27HR

TR28A1316

-VCC

VCC

3

21

U4A4580M

5

67

U4B4580M

C6022P

C6122P

R4065K11

R4055K11

R942K49

-VCC

R912K49

TR36HR

VCCR562K49

D5BAS316

VCC

R4020K

-VCC

R41910K0

R42010K0

R4075K11

C6222P

R194R7

R204R7

C101n

C91n

C531000u/10V

R3994R7

VR172C10K

R181K50

R612K49

C3330P

C3110n

R392470R

R1272K49

C3447u/63V

C3647u/63V

R336K34

R346K34

C2622u/35V

C2522u/35V

R66K81

R56K81

PH PWR

TR19HR

TR20A1316

R211K50

-VCC

VCC

R662K49

R1292K49

C3810n

R393470R

TR29HR

TR30A1316

-VCC

VCC

3

21

U7A4580M

5

67

U7B4580M

C6422P

C8222P

R4095K11

R4085K11

R1442K49

-VCC

R1262K49

TR37HR

VCCR902K49

D6BAS316

VCC

R4220K

-VCC

R42110K0

R42210K0

R4105K11

C6322P

R244R7

R254R7

C121n

C111n

C551000u/10V

R4004R7

VR252C10K

R221K50

R1282K49

C4330P

C4010n

R394470R

R1912K49

C3747u/63V

C3947u/63V

R356K34

R366K34

C2822u/35V

C2722u/35V

R86K81

R76K81

PH PWR

TR21HR

TR22A1316

R231K50

-VCC

VCC

R1302K49

R3792K49

C4410n

R395470R

TR31HR

TR32A1316

-VCC

VCC

3

21

U10A4580M

5

67

U10B4580M

C8422P

C11022P

R4135K11

R4125K11

R3802K49

-VCC

R1652K49

TR38HR

VCCR1352K49

D7BAS316

VCC

R4320K

-VCC

R42310K0

R42410K0

R4115K11

C8322P

MIC GAIN=0~-60dBLINE IN GAIN=+15~-45dB

INS-CH1

2

13

4

X13JY-5042-030G

3c

5e

1a

4d2b

X14JY-6351G-02-250

T

R

S

RNTNLINE IN 5/6

MIC 5

3c

5e

1a

4d2b

X15JY-6351G-02-250

T

R

S

RNTN

LEFT(MONO)

RIGHT

3

21

U15A4580M

R10810K

C6622P

C11747u/25V

R10510K

C22722P

R10110K

C275100P

R10210K

C273100P

5

67

U15B4580M

R10910K

C6722P

C11847u/25V

R10610K

C22822P

R10310K

C276100P

R10410K

C274100P

R10710K

R11010K

R884R7

R894R7

C141n

C131n

C561000u/10V

R4014R7

VR332C10K

R261K50

R3822K49

3

21

U14A4580M

R955K11

C6522P

C10947u/25V

R19020K

C18330P

C4610n

R396470R

R3812K49

C4147u/63V

C4247u/63V

R106K81

R96K81

PH PWR

TR23HR

TR24A1316

R271K50

-VCC

VCC

R3842K49

R3832K49

C4710n

R397470R

TR33HR

TR34A1316

-VCC

VCC

3

21

U13A4580M

5

67

U13B4580M

C31522P

C31622P

R4155K11

R4145K11

R3872K49

-VCC

R3862K49

TR39HR

VCCR3852K49

D8BAS316

VCC

R4420K

-VCC

R42510K0

R42610K0

R4165K11

C31722P

R19220K

R19320K

TP7

TP8

3

21

U16A4580M

5

67

U16B4580M

R3810K

R3710K

C2247u/25V

C2447u/25V

PRE-CH5

PRE-CH6

3c

5e

1a

4d2b

X16JY-6351G-02-250

T

S

RNTNLINE IN 7/8

3c

5e

1a

4d2b

X17JY-6351G-02-250

T

R

S

RNTN

LEFT(MONO)

RIGHT

3

21

U18A4580M

R11810K

C6822P

C12247u/25V

R11610K

C22922P

R11210K

C279100P

R11310K

C277100P

5

67

U18B4580M

R11910K

C6922P

C12347u/25V

R11710K

C23022P

R11410K

C280100P

R11510K

C278100P

R19420K

R19520K

84

U15C4580M

84

U16C4580M

84

U14C4580M

84

U13C4580M

VCC

-VCC

3c

5e

1a

4d2b

X18JY-6351G-02-250

STEREO AUX

LEFT 1

3c

5e

1a

4d2b

X19JY-6351G-02-250

RIGHT 1

RETURN2STEREO AUX

RETURN1

3c

5e

1a

4d2b

X20JY-6351G-02-250

3c

5e

1a

4d2b

X21JY-6351G-02-250

RIGHT 2

LEFT 2

(MONO / MASTER)

EFXRTN-L

EFXRTN-R

AUX-RTN2-L

AUX-RTN2-R

AUX-RTN1-R

AUX-RTN1-L

3c

5e

1a

4d2b

X22JY-6351G-02-250

AUX SEND1

R324120R

R323120R

3c

5e

1a

4d2b

X23JY-6351G-02-250

AUX SEND2

R322120R

R325120R

T

R

S

RNTN

T

R

S

RNTN

AUX-SEND1

AUX-SEND2

R3421K

R3431K

L(WHITE)

R(RED)

TAPE IN TAPE OUT

1 4

2 5

3 6

X31SCP6873NS3232

MAIN-L-2

MAIN-R-2

2TK-IN-L

2TK-IN-R

3

21

U29ABA15218N

5

67

U29BBA15218N

C26222PR8310K

R332120R

3c

5e

1a

4d2b

X28JY-6351G-02-250

R334120R

PHONES

R331120R

R330120R

3

21

U28ABA15218N

5

67

U28BBA15218N

R8410K

C26122P

CTRL-R-R

CTRL-R-L

84

U28CBA15218N

84

U29CBA15218N

R34747R

R34647R

C25347u/25V

C25447u/25V

C313100n

C314100n

VCC

-VCC

1234567

CN27P-2.0

(TO L8PU1)

MAIN-R-2

MAIN-L-2MAIN-R-3

MAIN-L-3

123456789101112

CN32.5-12P-B24(TO L8MN1)



123456789101112

CN42.5-12P-B24(TO L8MN1)


+VCC-VCC

12345678

CN52.5-8P-B24A(TO L8MN1)

AUX-RTN1-LAUX-SEND1

AUX-RTN1-RAUX-SEND2

AUX-RTN2-L

CTRL-R-L

AUX-RTN2-R


PH PWR

CTRL-R-LCTRL-R-R

FOOTSW

VCC-VCC

EFXRTN-L

EFXRTN-R

3c

5e

1a

4d2b

X25JY-6351G-02-250

FOOTSWITCH

FOOTSW

123456789

CN19P-2.0

(TO L8PU1)

INS-CH1

INS-CH2

INS-CH3

INS-CH4RTN-CH4

RTN-CH3

RTN-CH2

RTN-CH1

L8PU2

PCB# L8PU2.PCB

SW1APS-22E85L

SW1BPS-22E85L

LO CUT

INS-CH2

SW2APS-22E85L

SW2BPS-22E85L

LO CUT

INS-CH4

SW4APS-22E85L

SW4BPS-22E85L

LO CUT

INS-CH3

SW3APS-22E85L

SW3BPS-22E85L

PRE-CH7

PRE-CH8

C303100n

C304100n

84

U18C4580M

12

34

ABCD

43

21

D C B A

3c 5e1a4d 2b

X1

JY-6

351G

-02-

250

TR SRN

TN

GN

D-IN

S

INSE

RT1

L8P

U1.

Sch

Tite

l

Size

File

:D

ate:

Dra

wn

By:

She

et

Rev

isio

nM

odel

No:

5-O

ct-2

003

KEVI

N L

IN.

OU

TPU

T S

TAG

E (I

NS

ER

T &

MAI

N O

UTP

UT)

11

of

ALT

O L

-8V

ER

0211

03A4

NS1

RTN

1

3c 5e1a4d 2b

X2

JY-6

351G

-02-

250

TR SRN

TN

GN

D-IN

S

INSE

RT2

NS2

RTN

2

3c 5e1a4d 2b

X3

JY-6

351G

-02-

250

TR SRN

TN

GN

D-IN

S

INSE

RT3

NS3

RTN

3

3c 5e1a4d 2b

X4

JY-6

351G

-02-

250

TR SRN

TN

GN

D-IN

S

INSE

RT4

NS4

RTN

4

3c 5e1a4d 2b

X8

JY-6

351G

-02-

250

TR SRN

TNM

AIN

R (U

NB

AL)

3c 5e1a4d 2b

X7

JY-6

351G

-02-

250

TR SRN

TNM

AIN

L (U

NB

AL)

R7

120R

R6

120R

R11

120RR5

120R

3c 5e1a4d 2b

X5

JY-6

351G

-02-

250

TR SRN

TN

CTR

L R

OO

M R

3c 5e1a4d 2b

X6

JY-6

351G

-02-

250

TR SRN

TN

CTR

L R

OO

M L

R4

120R

R3

120R

R10

120R

R2

120R

(BAL

ANCE

D)2 13

X10

JY-5

030-

030G

2 13

X9

JY-5

030-

030G

R14

120R

MAIN

OUT

RIGH

T

R21

5K1

LEFT

R13

120R

R23

5K1

R16

120R

R22

5K1

R15

120R

R24

5K1

MAI

N-R

-2M

AIN

-R-3

MAI

N-L

-2M

AIN

-L-3

1 2 3 4 5 6 7 8 9

CN

19P

-2.0

GN

D-IN

S

1 2 3 4 5 6 7

CN

27P

-2.0

PCB#

L8P

U1

PCB

R1

120R

R8

120R

R9

120R R12

120R

L8PU

1

4. PRINTED CIRCUIT DIAGRAM

PCB : L8MN1 Top Overlay

PCB : L8MN1 Top Layer

PCB : L8MN1 Bottom Layer

PCB : L8PU1 Top Overlay

PCB : L8PU1 Bottom Layer

PCB : L8PU2 Top Overlay

PCB : L8PU2 Top Layer

PCB : L8PU2 Bottom Layer

PCB : RD82PWR Top Overlay

PCB : RD82PWR Bottom Layer

PCB : 313123/2 Top Layer

PCB : 313123/2 Bottom Layer

PCB : 313123/2 Top Overlay

12

34

56

78

ABCD

87

65

43

21

D C B A

L8PI

NSc

h

Ttel

Size

Fle

Date

Draw

n By

Shee

t

Revis

ionMo

del N

o

5-Oct-

2003

SA

MBOW

ALTO

MIX

ING

CONS

OLE

11

of

L-8 W

IRE

CONF

IGAT

ION

VER0

3040

3A3

123456789

CN

19P

-2.0

1234567

CN

27P

-2.0

1234567

CN2

7P-2.

0(T

O L8

PU1)

MAIN-R-2

MAIN-L-2MAIN-R-3

MAIN-L-3

123456789101112

CN

32.5

-12P-

B24

(TO

L8MN

1)

123456789101112

CN

42.5

-12P-

B24

(TO

L8MN

1)

12345678

CN

52.5

-8P-B

24A

(TO

L8MN

1)

CTRL-R-LCTRL-R-R

123456789

CN1

9P-2.

0(T

O L8

PU1)

INS-CH1

INS-CH2

INS-CH3

INS-CH4RTN-CH4

RTN-CH3

RTN-CH2

RTN-CH1

(TO

L8PU

2)(T

O L8

PU2)

GND

GND

INS-CH1

INS-CH2

INS-CH3

INS-CH4RTN-CH4

RTN-CH3

RTN-CH2

RTN-CH1

GND

MAIN-R-2

MAIN-L-2MAIN-R-3

MAIN-L-3

CTRL-R-LCTRL-R-R

GND

12345678

CN

02.

5-8P

123456789

101112 C

N3

2.5-12

P-B2

4(T

O L8

PU2)



123456789

101112 C

N4

2.5-12

P-B2

4(T

O L8

PU2)


+VCC-VCC

12345678 C

N5

2.5-8P

-B24

A(T

O L8

PU2)

AUX-RTN1-L

AUX-SEND1

AUX-RTN1-R

AUX-SEND2

AUX-RTN2-L

CTRL-R-L

AUX-RTN2-R


FOOTSW

EFXRTN-L

EFXRTN-R

PH PWR

GND

GND

GND

GND

1 2 3 4 5 6 7 8 CN

32.

5-8P

123

CN

13P

-39

12CN

22P

-2.5

RD82

PWR

(TO

RD82

PWR)

L8MN

1

L8PU

2

L8PU

1

+48V

GND

GND

-15V

GND

+15V

+5V

GND

+48VGNDGND-15VGND+15V+5VGND

(TO

L8MN

1)

POW

ERPH

ANTO

M

PT-S

12_2

30V

(PT-

S12_

115V

)

Multi-Level BOM Structure Listing

Report No.:Prepared by JG970003[蔡忠憲]

2003/10/05DatePage No.: 1 / 19

IEBO_P02

SEKAKU ELECTRON INDUSTRY CO.,LTD

Version UNIT:PF01225L-8L-8 ALTO 230V

PCS

2003/04/29Date:DESCRIPTION:Item No.

Version Item NoItem Descri

Ver. UnitLoss % Cardinal@:Phantom LayerEffective Date

Component RemarkUsage RateAttrition Rate

1.00001panel

L-8 ALTO

MA04065├0001---------------------------------││

0.00 %N

││PCS

2003/04/29

1.00001panel

L-8

MA04066│└0001-------------------------------│ │

0.00 %N

│ │PCS

2003/04/24

1.00001panel

L-8

MA04067│ └0001------------------------------│ │

0.00 %N

│ │PCS

2003/04/24

1.000015hot gradual zinc

1.0t*2135*1220mm 20.45kg

MJ01186│ ├0001-----------------------------│ │

0.00 %N

│ │PCSKG

2003/04/24

1.00001screw

M3*10*0.5PH

ME00097│ └0002-----------------------------│

0.00 %N

│PCS

2003/07/11

1.00001rear board

L8

MB02799├0002---------------------------------││

0.00 %N

││PCS

2003/04/29

1.00001rear board

L-8

MB02800│└0001-------------------------------│ │

0.00 %N

│ │PCS

2003/04/24

1.000020iron board

1*2135*1220 20.45kg

MJ00058│ ├0001------------------------------│ │

0.00 %N

│ │PCSKG

2003/04/24

2.00001iron pillar

hexagon6.35*M3*5.2

ME00032│ ├0002------------------------------│ │

0.00 %N

│ │PCS

2003/08/24

2.00001screw

M3*10*0.5PH

ME00004│ └0003------------------------------│

0.00 %N

│PCS

2003/08/24

1.00001partitions

L-8

MJ01189├0003---------------------------------││

0.00 %N

││PCS

2003/04/29

1.0000221Zn-plated board

1*2135*1220 20.45kg

MJ00061│├0001-------------------------------││

0.00 %N

││PCSKG

2003/04/24

3.00001iron pillar

M3*7

ME00066│└0002-------------------------------│

0.00 %N

│PCS

2003/04/24

1.00001power switch

RA12KKATOF 2P

HI00026├0004---------------------------------│

0.00 %N

│PCS

2003/04/29

1.00001power switch

R612KKAT0F1

HI00171├0005---------------------------------│

0.00 %N

│PCS

2003/04/29

1.00001AC outlet

3515 A TYPE(RF-2004-C-4.8)

HC00008├0006---------------------------------│

0.00 %N

│PCS

2003/04/29

1.00001fuse

250mA 250V φ5.2*20mm CSA/S/UL/VDE

HD00054├0007---------------------------------│

0.00 %N

│PCS

2003/04/29

8.00001copper pole

M3*14*0.5PH

MG00304├0008---------------------------------│

0.00 %N

│PCS

2003/04/29

3.00001bare

M3*14*0.5PH

MG00363├0009---------------------------------│

0.00 %N

│PCS

2003/04/29

1.00001copper pole

M3*24*0.5PH

MG00305├0010---------------------------------│

0.00 %N

│PCS

2003/04/29

4.00001key

5.5*5.5*14.5

NI01862├0011---------------------------------│

0.00 %N

│PCS

2003/04/29

7.00001key

φ5.5*W10*7.5

NI01863├0012---------------------------------│

0.00 %N

│PCS

2003/04/29



2003/10/05DatePage No.: 2 / 19

IEBO_P02



PCS





18.00001knob

φ10.5*18

NI02083├0013---------------------------------│

0.00 %N

│PCS

2003/04/29

12.00001knob

φ10.5*18

NI02081├0014---------------------------------│

0.00 %N

│PCS

2003/04/29

6.00001knob

φ10.5*18

NI02082├0015---------------------------------│

0.00 %N

│PCS

2003/04/29

5.00001knob

φ10.5*18

NI02084├0016---------------------------------│

0.00 %N

│PCS

2003/04/29

2.00001konb

φ14*13mm

NI02386├0017---------------------------------│

0.00 %N

│PCS

2003/04/29

37.00001screw

M3*6

MG00041├0018---------------------------------│

0.00 %N

│PCS

2003/06/24

2.00001screw

M3*10

MG00042├0019---------------------------------│

0.00 %N

│PCS

2003/04/29

15.00001screw

M3*10

MG00061├0020---------------------------------│

0.00 %N

│PCS

2003/04/29

2.00001screw

M4*8

MG00102├0021---------------------------------│

0.00 %N

│PCS

2003/04/29

1.00001washer

φ4*φ7*1t

MF00038├0022---------------------------------│

0.00 %N

│PCS

2003/04/29

1.00001washer

φ4*φ8*0.5t

MF00048├0023---------------------------------│

0.00 %N

│PCS

2003/04/29

24.00001socket nut

JY-6351G-02-250

ME00060├0024---------------------------------│

0.00 %N

│PCS

2003/04/29

24.00001washer

JY-6351G-02-250

MF00061├0025---------------------------------│

0.00 %N

│PCS

2003/04/29

1.00001signle terminal wiring CF:W146

80 green/yellow

HA01174├0026---------------------------------│

0.00 %N

│PCS

2003/04/29

1.00001P.V.C single wave wired UL1617

80 brown

HA01835├0027---------------------------------│

0.00 %N

│PCS

2003/04/29

1.00001row-wire connector wiring

2P 150

HA01392├0028---------------------------------│

0.00 %N

│PCS

2003/04/29

1.00001wire

8P-8P 200mm UL1007 22AWG

HA02355├0029---------------------------------│

0.00 %N

│PCS

2003/04/29

1.00001power cord Europe 3P

LT-312+LT-501

HA00861├0030---------------------------------│

0.00 %N

│PCS

2003/04/29

2.00001cable tie-black

ALT-102SB

NI00218├0031---------------------------------│

0.00 %N

│PCS

2003/04/29

7.00001sleeve

φ4*20mm

NI00252├0032---------------------------------││

0.00 %N

││PCS

@ 2003/04/29

20.00001000sleeve

φ4*1000mm

NI00248│└0001-------------------------------│

0.00 %N

│M

2002/06/04

4.00001foot cushion

12.7*9*3t(SF-004)

NI00501├0033---------------------------------│

0.00 %N

│PCS

2003/04/29



2003/10/05DatePage No.: 3 / 19

IEBO_P02



PCS





1.00001PE bag

0.04t*580*300mm

NA00123├0034---------------------------------│

0.00 %N

│PCSKG

2003/04/29

1.00001desiccant

30g

HJ00006├0035---------------------------------│

0.00 %N

│PCS

2003/04/29

1.00001transformer

PT-DJM3_230V

TC00160├0036---------------------------------│

0.00 %N

│PCS

2003/04/29

1.00001separating shade

S-12

MI01629├0037---------------------------------││

0.00 %N

││PCS

2003/04/29

1.0000119iron board

0.3*200*3000 1.431kg

MJ00090│└0001-------------------------------│

0.00 %N

│PCSKG

2003/02/08

1.00001heat sink

RD82

MJ01145├0038---------------------------------││

0.00 %N

││PCS

2003/04/29

1.00001radiator

RD82

MJ01142│└0001-------------------------------│ │

0.00 %N

│ │PCS

2002/11/25

1.0000880AL board

4*2440*1220 32.40kg

MJ00070│ └0001------------------------------│

0.00 %N

│PCSKG

2003/02/22

4.00001caushion

TW-1(TO-220)

NI02249├0039---------------------------------│

0.00 %N

│PCS

2003/04/29

1.00001insulation

0.3t*18*45mm S-8

NC00022├0040---------------------------------│

0.00 %N

│PCS

2003/04/29

1.00001silicone insulator

TO-220 square type

NC00005├0041---------------------------------│

0.00 %N

│PCS

2003/04/29

4.00001screw

M3*8

MG00162├0042---------------------------------│

0.00 %N

│PCS

2003/04/29

3.00001colour nut

3m/m

ME00015├0043---------------------------------│

0.00 %N

│PCS

2003/07/28

6.00001washer

φ3*φ5*1t

MF00037├0044---------------------------------│

0.00 %N

│PCS

2003/04/29

2.00001washer

φ3*φ8*0.8t

MF00030├0045---------------------------------│

0.00 %N

│PCS

2003/04/29

1.00001assurance card

ALTO

NF00061├0046---------------------------------│

0.00 %N

│PCS

2003/04/29

4.00001label

ALTO

NE05004├0047---------------------------------│

0.00 %N

│PCS

2003/04/29

1.00001insulation board

1*86.5*53 L-8

NI02620├0048---------------------------------│

0.00 %N

│PCS

2003/04/29

3.00001knob

φ10.5*18

NI02633├0049---------------------------------│

0.00 %N

│PCS

2003/04/29

8.00001knob

φ12*18 double color

NI00826├0050---------------------------------│

0.00 %N

│PCS

2003/04/29

1.00001instruction

L-8 ALTO

NF01355├0051---------------------------------││

0.00 %N

││PCS

2003/04/29

2.00001paper

889*640mm

NH00149│└0001-------------------------------│

0.00 %N

│張令

2003/09/09



2003/10/05DatePage No.: 4 / 19

IEBO_P02



PCS





1.00001colour box

L-8 ALTO

NB02249├0052---------------------------------│

0.00 %N

│PCS

2003/04/29

4.00001label

L-8 ALTO

NE11348├0053---------------------------------││

0.00 %N

││PCS

2003/04/29

1.000080bond paper

0.04*1M

NH00012│├0001-------------------------------││

0.00 %N

││M

2003/05/31

1.000080membrane

0.035*1M

NI00014│└0002-------------------------------│

0.00 %N

│M

2003/05/31

1.00001handle

for wireless coloful box

NI01272├0054---------------------------------│

0.00 %N

│PCS

2003/04/29

1.00001barrier

S8

NB01568├0055---------------------------------│

0.00 %N

│PCS

2003/04/29

1.00001barrier

S8

NB01625├0056---------------------------------│

0.00 %N

│PCS

2003/04/29

1.00004box

L-8

NB02354├0057---------------------------------│

0.00 %N

│PCS

2003/05/30

1.00001K-PC board

P-L8MN1-DIP

HK03835├0058---------------------------------││

0.00 %N

││PCS

2003/04/29

2.00001fixed resistor 1/4W

120Ω M type

RA00185│├0001-------------------------------││

0.00 %N

││PCS

2003/04/29

││ R350,R353││

2.00001electrolytic capacitor

1uF/50V φ4*7mm

CB00009│├0002-------------------------------││

0.00 %N

││PCS

2003/04/29

││ C3,C4││


2.2uF/50V φ5*11mm

CB00011│├0003-------------------------------││

0.00 %N

││PCS

2003/04/29

││ C195,C196,C197,C198,C199,C200││


4.7uF/25V φ4*7mm

CB00018│├0004-------------------------------││

0.00 %N

││PCS

2003/04/29

││ C50,C52,C59││


10uF/16V φ4*7mm

CB00024│├0005-------------------------------││

0.00 %N

││PCS

2003/04/29

││ C86,C118││


47uF/25V SLL φ5*11mm

CB00175│├0006-------------------------------││

0.00 %N

││PCS

2003/06/13

││ C5,C6,C7,C8,C9,C10,C19,C45,C87,C88,C89,C90,C94,C95,││ C96,C97,C98,C101,C102,C103,C104,C105,C106,C107,C111,││ C112,C113,C114,C115,C116,C119,C120,C121,C124,C125,││ C126,C127,C128,C129,C130,C231,C232,C233,C234,C236,││ C237,C238,C239,C241,C243,C244,C245,C246,C247,C248,││ C249,C250,C251,C252,C255,C256,C257,C258,C283,C284,││ C286,C318,C319,C320,C321││

16.00001metal-film capacitor MSC

0.012uF/63V ±5% CASE01

CF00054│├0007-------------------------------││

0.00 %N

││PCS

2003/04/29

││ C155,C156,C157,C158,C159,C160,C161,C162,C171,C172,



2003/10/05DatePage No.: 5 / 19

IEBO_P02



PCS





││ C173,C174,C175,C176,C177,C178││


0.018uF/63V 5% CASE01

CF00021│├0008-------------------------------││

0.00 %N

││PCS

2003/04/29

││ C131,C132,C133,C134,C135,C136,C137,C138,C163,C164,││ C165,C166,C167,C168,C169,C170││


0.033uF/63V 5% CASE01

CF00023│├0009-------------------------------││

0.00 %N

││PCS

2003/04/29

││ C139,C140,C141,C142,C143,C144,C145,C146,C147,C148,││ C149,C150,C151,C152,C153,C154││

3.00001metal-film capacitor FKP

0.0015uF/63V 2.5% (PFR5 152H63J11L4)

CF00070│├0010-------------------------------││

0.00 %N

││PCS

2003/04/29

││ C60,C61,C62││

2.00001row-wire header

12P 2.0mm 180°

HC00261│├0011-------------------------------││

0.00 %N

││PCS

2003/06/24

││ CN3,CN4││


8P 2.0mm 180°

HC00259│├0012-------------------------------││

0.00 %N

││PCS

2003/06/24

││ CN5││


8P 2.5mm 90°

HC00072│├0013-------------------------------││

0.00 %N

││PCS

2003/04/29

││ CN0││

1.00001row-pin header(single)#2804

2.54 180° 2*8P(gold-plated) 5.7mm

HC00511│├0014-------------------------------││

0.00 %N

││PCS

2003/04/29

││ CN6││

2.00001push-button switch

2 paragraphs 6p PS-22E8552L

HI00162│├0015-------------------------------││

0.00 %N

││PCS

2003/04/29

││ SW9,SW10││


2段 6P PS-22E8552N(3.3*3.3)NO LOCK

HI00177│├0016-------------------------------││

0.00 %N

││PCS

2003/04/29

││ SW1││

21.00001L.E.D high intensity

3m/m round(green)long foot 26

SA00052│├0017-------------------------------││

0.00 %N

││PCS

2003/04/29

││ LD7,LD10,LD11,LD12,LD13,LD14,LD15,LD16,LD17,LD18,LD19,││ LD22,LD23,LD24,LD25,LD26,LD27,LD28,LD29,LD30,LD31││


3m/m round(red)long foot 26mm

SA00053│├0018-------------------------------││

0.00 %N

││PCS

2003/04/29

││ LD1,LD2,LD3,LD4,LD5,LD6,LD8,LD21,LD33,LD54││


3m/m round(yellow)long foot 26

SA00054│├0019-------------------------------││

0.00 %N

││PCS

2003/04/29

││ LD20,LD32││



2003/10/05DatePage No.: 6 / 19

IEBO_P02



PCS





33.00001LED spacer support

LEDS-11 11mm

NI01782│├0020-------------------------------││

0.00 %N

││PCS

2003/04/29

6.00001potentiometer

J/Q10K RV112BC-40-30A-J/Q10K-0C

RC00259│├0021-------------------------------││

0.00 %N

││PCS

2003/04/29

││ VR7,VR15,VR23,VR31,VR39,VR46││


W50K RV09BC-40-30F-W50K-0C

RC00235│├0022-------------------------------││

0.00 %N

││PCS

2003/04/29

││ VR5,VR6,VR8,VR9,VR13,VR14,VR16,VR21,VR22,VR24,VR29,││ VR30,VR32,VR37,VR38,VR44,VR45││


W50K RV112BC-40-30A-W50K-0C

RC00237│├0023-------------------------------││

0.00 %N

││PCS

2003/04/29

││ VR40,VR47,VR48,VR49,VR50,VR51││


B50K RV09BC-40-30F-B50K-0C

RC00233│├0024-------------------------------││

0.00 %N

││PCS

2003/04/29

││ VR2,VR3,VR4,VR10,VR11,VR12,VR18,VR19,VR20,VR26,VR27,││ VR28││


B50K RV112BC-40-30A-B50K-0C

RC00236│├0025-------------------------------││

0.00 %N

││PCS

2003/04/29

││ VR34,VR35,VR36,VR41,VR42,VR43││

1.00001relay

RY-5W-K,5V

HI00161│├0026-------------------------------││

0.00 %N

││PCS

2003/04/29

││ RL1││

2.00001switch

SDB161PVB15.5F-1-4-16-16PC

HI00195│├0027-------------------------------││

0.00 %N

││PCS

2003/04/29

││ EN1,EN2││

1.00001K-PC board

P-L8MN1-SMD

HK03834│└0028-------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

1.00001pc board

L8MN1_VER030714

HB00917│ ├0001------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

2.00001SMD fixed resistor 1/10W

0.0Ω ±5% 0603

RD00059│ ├0002------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R371,R372│ │


47Ω ±5% 0603

RD00065│ ├0003------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R373,R374│ │


56Ω ±5% 0603

RD00346│ ├0004------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R354│ │


68Ω ±5% 0603

RD00066│ ├0005------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R6,R68│ │



2003/10/05DatePage No.: 7 / 19

IEBO_P02



PCS






120Ω ±5% 0603

RD00069│ ├0006------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R355│ │


220Ω ±5% 0603

RD00073│ ├0007------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R65,R79,R80│ │


330Ω ±5% 0603

RD00076│ ├0008------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R359,R360│ │


470Ω ±5% 0603

RD00078│ ├0009------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R351,R352,R356,R357,R358│ │


510Ω ±5% 0603

RD00347│ ├0010------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R361│ │


620Ω ±5% 0603

RD00348│ ├0011------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R362│ │


910Ω ±5% 0603

RD00349│ ├0012------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R196,R197,R198,R199,R200,R201,R202,R203,R204,R205,│ │ R206,R207,R208,R209,R210,R211│ │


1.0KΩ ±5% 0603

RD00083│ ├0013------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R114│ │


1.1KΩ ±5% 0603

RD00350│ ├0014------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R212,R213,R214,R215,R216,R217,R218,R219│ │


1.3KΩ ±5% 0603

RD00351│ ├0015------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R137,R139,R141,R143,R145,R363,R146,R147,R148│ │


1.5KΩ ±5% 0603

RD00085│ ├0016------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R264,R265,R266,R267,R268,R269│ │


2.0KΩ ±5% 0603

RD00087│ ├0017------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R252,R364│ │


2.2KΩ ±5% 0603

RD00088│ ├0018------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R54│ │



2003/10/05DatePage No.: 8 / 19

IEBO_P02



PCS






3.9KΩ ±5% 0603

RD00092│ ├0019------------------------------│ │

0.00 %N

│ │PCS

2003/08/26

│ │ R16,R339,R344,R345,R256,R257,R258,R259,R260,R261,R262,│ │ R263│ │


4.7KΩ ±5% 0603

RD00093│ ├0020------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R90,R248,R249,R250,R251,R253,R254,R255│ │


5.1KΩ ±5% 0603

RD00094│ ├0021------------------------------│ │

0.00 %N

│ │PCS

2003/06/07

│ │ R375,R287,R288,R289,R290,R291,R292,R293,R294,R295,│ │ R296,R297,R298,R299,R301,R302,R304,R305,R306,R308,│ │ R309,R310,R311,R312,R313,R314,R315,R316,R317,R12,R15,│ │ R38,R39,R284,R285,R286,R93│ │


5.6KΩ ±5% 0603

RD00095│ ├0022------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R365│ │


6.8KΩ ±5% 0603

RD00097│ ├0023------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R150,R151,R152,R154,R155,R156,R158,R159,R160,R162,│ │ R163,R164,R166,R167,R168,R169,R170,R171,R172,R173,│ │ R174,R175│ │


7.5KΩ ±5% 0603

RD00098│ ├0024------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R49│ │


8.2KΩ ±5% 0603

RD00099│ ├0025------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R77,R78│ │


10KΩ ±5% 0603

RD00101│ ├0026------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R1,R2,R3,R7,R8,R9,R10,R11,R19,R20,R21,R22,R23,R24,R27,│ │ R46,R47,R48,R50,R52,R53,R55,R56,R63,R66,R67,R71,R72,│ │ R75,R76,R81,R82,R85,R86,R87,R96,R97,R98,R99,R100,R111,│ │ R118,R120,R121,R122,R123,R124,R125,R427,R428│ │


20KΩ ±5% 0603

RD00306│ ├0027------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R184,R185,R186,R187,R188,R189│ │


22KΩ ±5% 0603

RD00105│ ├0028------------------------------│ │

0.00 %N

│ │PCS

2003/08/26

│ │ R240,R241,R244,R245,R246,R247,R319,R321│ │


27KΩ ±5% 0603

RD00106│ ├0029------------------------------│ │

0.00 %N

│ │PCS

2003/08/26

│ │ R348,R349,R366│ │


30KΩ ±5% 0603

RD00107│ ├0030------------------------------│ │

0.00 %N

│ │PCS

2003/04/29



2003/10/05DatePage No.: 9 / 19

IEBO_P02



PCS





│ │ R236,R237,R238,R239│ │


36KΩ ±5% 0603

RD00353│ ├0031------------------------------│ │

0.00 %N

│ │PCS

2003/08/26

│ │ R270,R271,R272,R273,R274,R275,R276,R277,R278,R279,│ │ R280,R281,R282,R283│ │


39KΩ ±5% 0603

RD00109│ ├0032------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R73,R74│ │


47KΩ ±5% 0603

RD00111│ ├0033------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R4,R232,R233,R234,R235│ │


51KΩ ±5% 0603

RD00354│ ├0034------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R41│ │


56KΩ ±5% 0603

RD00112│ ├0035------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R318,R320│ │


68KΩ ±5% 0603

RD00114│ ├0036------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R228,R229,R230,R231│ │


100KΩ ±5% 0603

RD00116│ ├0037------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R367,R368,R369,R370│ │


820KΩ ±5% 0603

RD00124│ ├0038------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R5│ │


1.0MΩ ±5% 0603

RD00125│ ├0039------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R112,R220,R221,R222,R223,R224,R225,R226,R227│ │


2.2MΩ ±5% 0603

RD00126│ ├0040------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R113│ │

38.00001SMD ceramic capacitor 0603

22PF/50V NPO ±5%

CI00051│ ├0041------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ C11,C12,C13,C22,C24,C38,C39,C40,C49,C179,C180,C181,│ │ C182,C183,C184,C185,C186,C187,C188,C189,C190,C191,│ │ C192,C193,C194,C221,C222,C223,C224,C225,C226,C260,│ │ C263,C264,C269,C270,C281,C282│ │


33PF/50V NPO ±5%

CI00053│ ├0042------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ C2,C117│ │



2003/10/05DatePage No.: 10 / 19

IEBO_P02



PCS






47PF/50V NPO ±5%

CI00055│ ├0043------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ C342,C343│ │


100PF/50V NPO ±5%

CI00059│ ├0044------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ C14,C20,C265,C266,C271,C272│ │


0.1uF/50V Y5V +80,-20%

CI00075│ ├0045------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ C1,C29,C30,C31,C32,C35,C36,C51,C15,C16,C17,C18,C37,│ │ C201,C202,C203,C204,C205,C206,C207,C208,C211,C212,│ │ C213,C214,C217,C218,C219,C220,C289,C290,C295,C296,│ │ C297,C298,C305,C306,C307,C308,C309,C310,C311,C312,│ │ C340,C341│ │

2.00001resistor

680Ω*4 ±5% 8P 0603

RE00011│ ├0046------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ AR1,AR2│ │

2.00001diode

BAS316,115

SE00028│ ├0047------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ D7,D15│ │

3.00001SMD rectifier diode

DA204K/T-146

SE00008│ ├0048------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ D1,D2,D3│ │


DAN202K/T-146

SE00009│ ├0049------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ D16│ │


RB400D(D3A)

SE00007│ ├0050------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ D10│ │


RLS4148 0.5A (LL-34)

SE00011│ ├0051------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ D9│ │

2.00001SMD transistor

2SA1036K(R)(MMBT3906LT1)

SF00004│ ├0052------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ TR13,TR14│ │


2SC2412K(R)(MMBT3904LT1)

SF00010│ ├0053------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ TR1,TR2,TR3,TR4,TR5,TR6,TR7,TR8,TR9,TR10,TR11,TR12,│ │ TR16,TR17│ │

6.00001SMD integraded circuit

LM339DR/(TI)

SG00032│ ├0054------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ U35,U36,U37,U38,U39,U40│ │



2003/10/05DatePage No.: 11 / 19

IEBO_P02



PCS





21.00001SMD integrated circuit

NJM4580M-TE3

SG00122│ ├0055------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ U1,U2,U3,U6,U9,U12,U16,U17,U19,U20,U21,U23,U24,U25,│ │ U26,U27,U30,U31,U44,U45,U46│ │


74HC14DT

SG00068│ ├0056------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ U49│ │

1.00001integrated circut

74HC109D

SG00164│ ├0057------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ U48│ │


BA10393F

SG00005│ ├0058------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ U47│ │


NE555DT

SG00094│ ├0059------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ U43│ │


3.3KΩ ±5% 0603

RD00091│ ├0060------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R17,R18│ │


6.2KΩ ±5% 0603

RD00096│ ├0061------------------------------│ │

0.00 %│ │PCS

2003/08/27

│ │ R25,R26│ │


12KΩ ±5% 0603

RD00102│ └0062------------------------------│

0.00 %│PCS

2003/08/27

│ R13,R14│

1.00001K-PC board

P-L8PU2-DIP

HK03838├0059---------------------------------││

0.00 %N

││PCS

2003/04/29

10.00001precise resistor 1/4W

6.81KΩ M type

RA00505│├0001-------------------------------││

0.00 %N

││PCS

2003/04/29

││ R1,R2,R3,R4,R5,R6,R7,R8,R9,R10││


1000uF/10V φ8*11mm

CB00074│├0002-------------------------------││

0.00 %N

││PCS

2003/04/29

││ C51,C52,C53,C55,C56││


0.22uF/50V φ5*11mm

CB00003│├0003-------------------------------││

0.00 %N

││PCS

2003/04/29

││ C70,C71,C72,C73,C74,C75,C76,C77,C78,C79,C80,C81││


22uF/35V φ5*11mm

CB00029│├0004-------------------------------││

0.00 %N

││PCS

2003/04/29

││ C19,C20,C21,C23,C25,C26,C27,C28││


47uF/25V SLL φ5*11mm

CB00175│├0005-------------------------------││

0.00 %N

││PCS

2003/06/13



2003/10/05DatePage No.: 12 / 19

IEBO_P02



PCS





││ C22,C24,C85,C86,C91,C92,C93,C99,C100,C108,C109,C117,││ C118,C122,C123,C253,C254││


47uF/63V 105℃ LZ φ8*11mm

CB00042│├0006-------------------------------││

0.00 %N

││PCS

2003/04/29

││ C29,C30,C32,C33,C34,C36,C37,C39,C41,C42││

10.00001transistor

2SA1316-GR

SB00050│├0007-------------------------------││

0.00 %N

││PCS

2003/04/29

││ TR16,TR18,TR20,TR22,TR24,TR26,TR28,TR30,TR32,TR34││

2.00001integrated circuit

BA15218N (M5218L substitute)

SD00007│├0008-------------------------------││

0.00 %N

││PCS

2003/04/29

││ U28,U29││

16.00001MIC jack

JY-6351G-02-250

HC00125│├0009-------------------------------││

0.00 %N

││PCS

2003/04/29

││ X6,X8,X10,X12,X14,X15,X16,X17,X18,X19,X20,X21,X22,X23,││ X25,X28││


2 paragraphs 6p PS-22E8552L

HI00162│├0010-------------------------------││

0.00 %N

││PCS

2003/04/29

││ SW1,SW2,SW3,SW4││


O10KΩ RV09BC-40-30F-02C10K

RC00296│├0011-------------------------------││

0.00 %N

││PCS

2003/04/29

││ VR1,VR9,VR17,VR25,VR33││

5.00001MIC jack for balance

JY-5042-030G female plug 180°

HC00126│├0012-------------------------------││

0.00 %N

││PCS

2003/04/29

││ X5,X7,X9,X11,X13││

1.00001rca

SCP6873NS3232T2 4P

HC00403│├0013-------------------------------││

0.00 %N

││PCS

2003/04/29

││ X31││

2.00001header wiring

12P-12P 40

HA01583│├0014-------------------------------││

0.00 %N

││PCS

2003/06/24

││ CN3,CN4││


8P(male)-8P(female) 40mm UL1007 28AWG

HA01580│├0015-------------------------------││

0.00 %N

││PCS

2003/06/24

││ CN5││


7P(male)-7P(parent) 140

HA01507│├0016-------------------------------││

0.00 %N

││PCS

2003/04/29

││ CN2││

1.00001header wiring AF:W267

9P(male)-9P(parent) 140

HA01506│├0017-------------------------------││

0.00 %N

││PCS

2003/04/29

││ CN1││

1.00001K-PC board

P-L8PU2-SMD

HK03837│└0018-------------------------------│ │

0.00 %N

│ │PCS

2003/04/29



2003/10/05DatePage No.: 13 / 19

IEBO_P02



PCS





1.00001pc board

L8PU2_VER030714

HB00916│ ├0001------------------------------│ │

0.00 %N

│ │PCS

2003/04/29


4.7Ω ±5% 0603

RD00355│ ├0002------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R11,R13,R14,R19,R20,R24,R25,R48,R49,R88,R89,R398,R399,│ │ R400,R401│ │


120Ω ±5% 0603

RD00069│ ├0003------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R322,R323,R324,R325│ │


470Ω ±5% 0603

RD00078│ ├0004------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R388,R389,R390,R391,R392,R393,R394,R395,R396,R397│ │


1.0KΩ ±5% 0603

RD00083│ ├0005------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R342,R343│ │


1.3KΩ ±5% 0603

RD00351│ ├0006------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R136,R138,R140,R142│ │


6.8KΩ ±5% 0603

RD00097│ ├0007------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R149,R153,R157,R161│ │


10KΩ ±5% 0603

RD00101│ ├0008------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R37,R38,R83,R84,R101,R102,R103,R104,R105,R106,R107,│ │ R95,R110,R112,R113,R114,R115,R116,R117,R118,R119│ │


20KΩ ±5% 0603

RD00306│ ├0009------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R28,R40,R42,R43,R44,R176,R177,R178,R179,R180,R181,│ │ R182,R183,R190,R192,R193,R194,R195│ │


62KΩ ±5% 0603

RD00113│ ├0010------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R131,R132,R133,R134│ │

10.00001SMD precise resistor 1/10W

1.50KΩ ±1% 0603

RD00201│ ├0011------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R12,R15,R16,R17,R18,R21,R22,R23,R26,R27│ │


2.49KΩ ±1% 0603

RD00204│ ├0012------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R45,R50,R51,R52,R53,R56,R57,R58,R59,R60,R61,R64,R65,│ │ R66,R90,R91,R94,R126,R127,R128,R129,R130,R135,R144,│ │ R165,R191,R379,R380,R381,R382,R383,R384,R385,R386,R387│ │


5.11KΩ ±1% 0603

RD00210│ ├0013------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R46,R54,R62,R67,R402,R403,R404,R405,R406,R407,R408,



2003/10/05DatePage No.: 14 / 19

IEBO_P02



PCS





│ │ R409,R410,R411,R412,R413,R414,R415,R416│ │


6.34KΩ ±1% 0603

RD00287│ ├0014------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R29,R30,R31,R32,R33,R34,R35,R36│ │


10.0KΩ ±1% 0603

RD00214│ ├0015------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R417,R418,R419,R420,R421,R422,R423,R424,R425,R426│ │


22PF/50V NPO ±5%

CI00051│ ├0016------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ C48,C49,C50,C54,C57,C58,C59,C60,C61,C62,C63,C64,C65,│ │ C66,C67,C68,C69,C82,C83,C84,C110,C227,C228,C229,C230,│ │ C261,C262,C315,C316,C317│ │


100PF/50V NPO ±5%

CI00059│ ├0017------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ C273,C274,C275,C276,C277,C278,C279,C280│ │


330PF/50V NPO ±5﹪

CI00062│ ├0018------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ C1,C2,C3,C4,C18│ │


0.001uF/50V X7R ±10%

CI00065│ ├0019------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ C5,C6,C7,C8,C9,C10,C11,C12,C13,C14│ │


0.01uF/50V X7R ±10%

CI00071│ ├0020------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ C15,C16,C17,C31,C35,C38,C40,C44,C46,C47│ │


0.1uF/50V Y5V +80,-20%

CI00075│ ├0021------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ C43,C45,C201,C202,C203,C204,C205,C206,C287,C288,C289,│ │ C290,C291,C292,C293,C294,C295,C296,C297,C298,C299,│ │ C300,C301,C302,C303,C304,C313,C314│ │


47Ω ±5% 0805

RD00004│ ├0022------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R346,R347│ │


120Ω ±5% 0805

RD00007│ ├0023------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ R330,R331,R332,R334│ │


NJM4580M-TE3

SG00122│ ├0024------------------------------│ │

0.00 %N

│ │PCS

2003/05/26

│ │ U1,U2,U4,U5,U7,U8,U10,U11,U13,U14,U15,U16,U18│ │


2SA1036K(R)(MMBT3906LT1)

SF00004│ ├0025------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ TR15,TR17,TR19,TR21,TR23,TR25,TR27,TR29,TR31,TR33,│ │ TR35,TR37,TR38,TR39,TR36│ │



2003/10/05DatePage No.: 15 / 19

IEBO_P02



PCS





5.00001diode

BAS316,115

SE00028│ ├0026------------------------------│ │

0.00 %N

│ │PCS

2003/04/29

│ │ D4,D5,D6,D7,D8│ │


30KΩ ±5% 0603

RD00107│ └0027------------------------------│

0.00 %N

│PCS

2003/04/29

│ R108,R109│

1.00001K-PC board

P-L8PU1

HK03836├0060---------------------------------││

0.00 %N

││PCS

2003/04/29

1.00001pc board

L8PU1(1*4)_VER030214

HB00915│├0001-------------------------------││

0.00 %N

││PCS

2003/04/29


120Ω M type

RA00185│├0002-------------------------------││

0.00 %N

││PCS

2003/04/29


5.1KΩ M type

RA00232│├0003-------------------------------││

0.00 %N

││PCS

2003/04/29

││ R21,R22,R23,R24││

2.00001shape male

JY-5030-030G 180°

HC00392│├0004-------------------------------││

0.00 %N

││PCS

2003/04/29

││ X9,X10││

3.00001jumper wire

10mm

HA01925│├0005-------------------------------│││

0.00 %N

│││PCS

2003/04/29

│││ JP1,JP2,JP3│││

0.02001wire

φ0.6

HA02249││└0001-----------------------------││

0.00 %N

││MKG

2002/09/19

8.00001MIC jack

JY-6351G-02-250

HC00125│├0006-------------------------------││

0.00 %N

││PCS

2003/04/29

││ X1,X2,X3,X4,X5,X6,X7,X8││


7P 2.0mm 180°

HC00258│├0007-------------------------------││

0.00 %N

││PCS

2003/04/29

││ CN2││

1.00001row wire header

9P 2.0mm 180°

HC00260│└0008-------------------------------│

0.00 %N

│PCS

2003/04/29

│ CN1│

1.00001K-PCb

P-RD82PWR(RD82FX)

HK03648├0061---------------------------------││

0.00 %N

││PCS

2003/04/29

1.00001pc board

RD82PWR_VER030110

HB00879│├0001-------------------------------││

0.00 %N

││PCS

2003/03/12


10KΩ M type

RA00242│├0002-------------------------------││

0.00 %N

││PCS

2003/03/12

││ R2││


10Ω Mr type

RA00159│├0003-------------------------------││

0.00 %N

││PCS

2003/03/12

││ R3



2003/10/05DatePage No.: 16 / 19

IEBO_P02



PCS





││14.0000

1rectifier diode1N4002/100V

SA00094│├0004-------------------------------││

0.00 %N

││PCS

2003/03/12

││ D1,D2,D3,D4,D5,D6,D7,D9,D10,D11,D12,D13,D14,D8││

1.00001zener diode

1/2W 47V 1N5261

SA00127│├0005-------------------------------││

0.00 %N

││PCS

2003/03/12

││ ZD1││


20KΩ M type

RA00250│├0006-------------------------------││

0.00 %N

││PCS

2003/03/12

││ R4││


390KΩ M type

RA00301│├0007-------------------------------││

0.00 %N

││PCS

2003/03/12

││ R1││


47uF/25V φ5*11mm

CB00039│├0008-------------------------------││

0.00 %N

││PCS

2003/03/12

││ C3,C4││


47uF/100V φ10*12mm

CB00043│├0009-------------------------------││

0.00 %N

││PCS

2003/03/12

││ C8,C9││


100uF/100V φ13*20mm

CB00052│├0010-------------------------------││

0.00 %N

││PCS

2003/03/12

││ C5,C6││


220uF/100V φ12*25mm

CB00061│├0011-------------------------------││

0.00 %N

││PCS

2003/03/12

││ C7││


2200uF/25V φ16*20mm

CB00082│├0012-------------------------------││

0.00 %N

││PCS

2003/03/12

││ C1,C2││


7815(TO-220)

SD00077│├0013-------------------------------││

0.00 %N

││PCS

2003/03/12

││ TR1││


7915(TO-220)

SD00079│├0014-------------------------------││

0.00 %N

││PCS

2003/03/12

││ TR2││

1.00001transistor

TIP122(ST)

SB00043│├0015-------------------------------││

0.00 %N

││PCS

2003/03/12

││ TR3││


2P 2.5mm 180°

HC00076│├0016-------------------------------││

0.00 %N

││PCS

2003/03/12

││ CN2││



2003/10/05DatePage No.: 17 / 19

IEBO_P02



PCS






8P 2.5mm 180°

HC00082│├0017-------------------------------││

0.00 %N

││PCS

2003/03/12

││ CN3││


3P 3.9mm 180°

HC00089│├0018-------------------------------││

0.00 %N

││PCS

2003/03/12

││ CN1││

4.00001jumper wire

8mm

HA01922│├0019-------------------------------│││

0.00 %N

│││PCS

2003/03/12

│││ JP1,JP6,JP7,JP10│││

0.01801wire

φ0.6

HA02249││└0001-----------------------------││

0.00 %N

││MKG

2002/09/19

5.00001jumper wire

10mm

HA01925│├0020-------------------------------│││

0.00 %N

│││PCS

2003/03/12

│││ JP2,JP3,JP4,JP8,JP9│││

0.02001wire

φ0.6

HA02249││└0001-----------------------------││

0.00 %N

││MKG

2002/09/19


7805(TO-220)

SD00074│├0021-------------------------------││

0.00 %N

││PCS

2003/03/12

││ TR4││


1000uF/16V φ10*16mm

CB00070│└0022-------------------------------│

0.00 %N

│PCS

2003/03/12

│ C10│

1.00001PC board

P-313123-DIP(L-8)

HK03893├0062---------------------------------││

0.00 %N

││PCS

2003/04/29

1.00001quartz crystalloid

16.00MHZ LP-3.5S(HC-49US)

SC00004│├0001-------------------------------││

0.00 %N

││PCS

2003/04/29

││ XT1││

1.00001row pin

2.54mm 180°2*8P

HC00499│├0002-------------------------------││

0.00 %N

││PCS

2003/06/24

││ CN2││

1.00001integrated ciucire

AT27LV010A-90JC/L-8

SG00193│├0003-------------------------------│││

0.00 %│││PCS

2003/05/31

│││ IC4│││

1.00001integrated ciucire

AT27LV010A-90JC

SG00139││└0001-----------------------------││

0.00 %N

││PCS

2003/05/30

1.00001PC board

P-313123-AI(L-8)

HK04041│├0004-------------------------------│││

0.00 %│││PCS

2003/06/19


10uF/16V φ4*5mm

CB00165││├0001-----------------------------│││

0.00 %N

│││PCS

2003/06/18

│││ C7│││



2003/10/05DatePage No.: 18 / 19

IEBO_P02



PCS






100uF/16V φ6*5mm

CB00166││├0002-----------------------------│││

0.00 %N

│││PCS

2003/06/18

│││ C19,C12,C5,C24,C21,C25,C26,C28,C2,C16│││

1.00001PC board

P-313123-SMD(L-8)

HK03894││└0003-----------------------------││ │

0.00 %N

││ │PCS

2003/06/18

1.00001pc board

313123/2(1*6)

HB00895││ ├0001----------------------------││ │

0.00 %N

││ │PCS

2003/04/29


15PF/50V NPO ±5%

CI00049││ ├0002----------------------------││ │

0.00 %N

││ │PCS

2003/04/29

││ │ C8,C9││ │


0.1uF/50V Y5V +80,-20%

CI00075││ ├0003----------------------------││ │

0.00 %N

││ │PCS

2003/04/29

││ │ C17,C15,C18,C6,C10,C22,C20,C13,C14,C1,C3,C4,C11││ │


10Ω ±5% 0603

RD00061││ ├0004----------------------------││ │

0.00 %N

││ │PCS

2003/04/29

││ │ R22││ │


100Ω ±5% 0603

RD00068││ ├0005----------------------------││ │

0.00 %N

││ │PCS

2003/04/29

││ │ R12,R14,R7,R8,R34,R17,R13,R33││ │


220Ω ±5% 0603

RD00073││ ├0006----------------------------││ │

0.00 %N

││ │PCS

2003/04/29

││ │ R3││ │


1.5KΩ ±5% 0603

RD00085││ ├0007----------------------------││ │

0.00 %N

││ │PCS

2003/04/29

││ │ R16,R15,R21,R20,R4,R19,R10,R18,R9,R5││ │


2.2KΩ ±5% 0603

RD00088││ ├0008----------------------------││ │

0.00 %N

││ │PCS

2003/04/29

││ │ R28,R27,R23,R24,R29,R30,R25,R26││ │


10KΩ ±5% 0603

RD00101││ ├0009----------------------------││ │

0.00 %N

││ │PCS

2003/04/29

││ │ R32,R31,R1││ │


1.0MΩ ±5% 0603

RD00125││ ├0010----------------------------││ │

0.00 %N

││ │PCS

2003/04/29

││ │ R2││ │

2.00001SMDrow resistor1/16W

100Ω*4 ±5% 8P 0603

RE00006││ ├0011----------------------------││ │

0.00 %N

││ │PCS

2003/04/29

││ │ AR1,AR2││ │


RLS4148 0.5A (LL-34)

SE00011││ ├0012----------------------------││ │

0.00 %N

││ │PCS

2003/04/29

││ │ D1││ │



2003/10/05DatePage No.: 19 / 19

IEBO_P02



PCS






74HC14DT

SG00068││ ├0013----------------------------││ │

0.00 %N

││ │PCS

2003/04/29

││ │ IC1││ │

1.00001integrated ciucrt

AS4LC256K16EO-60JC

SG00138││ ├0014----------------------------││ │

0.00 %N

││ │PCS

2003/04/29

││ │ IC6││ │


TY-2 ALTO(GMCODE:105022)

SG00166││ ├0015----------------------------││ ││

0.00 %N

││ ││PCS

2003/04/29

││ ││ IC3││ ││

1.00001integrated circut

CHEF DSP(GMCODE:105022)

SG00147││ │└0001--------------------------││ │

0.00 %N

││ │PCS

2003/05/10


LD1117DT33C

SG00037││ ├0016----------------------------││ │

0.00 %N

││ │PCS

2003/04/29

││ │ IC2││ │

1.00001IC jack (SMD)

PLCC32 (D03-32T.A.4)

HC00233││ ├0017----------------------------││ │

0.00 %N

││ │PCS

2003/04/29

││ │ IC4││ │


UDA1345TS (Philips)

SG00016││ └0018----------------------------││

0.00 %N

││PCS

2003/04/29

││ IC5││

1.00001label

L-8

NE11475│└0005-------------------------------│ │

0.00 %│ │PCS

2003/06/23

1.0000410bond paper

0.06*1M

NH00035│ ├0001------------------------------│ │

0.00 %N

│ │M

2003/06/26

1.0000410membrane

0.055*1M

NI00017│ └0002------------------------------│

0.00 %N

│M

2003/06/26

4.00001wood washer

φ3.17*φ8.2*1

NC00080├0063---------------------------------││

0.00 %││PCS

2003/05/16

1.00001insulation

φ8.2*1

NC00079│└0001-------------------------------│ │

0.00 %N

│ │KG

2003/02/25

68.000039000000insulator

0.65M*60M*1t

NC00014│ └0001------------------------------│

0.00 %N

│KG

2002/04/04

4.00001insulate bean

TO220B

NI00863├0064---------------------------------│

0.00 %│PCS

2003/06/24

4.00001screw

M3*8

MG00020└0065---------------------------------

0.00 %PCS

2003/06/24

Mechanical Parts List

ALTO L-8NO Item No Item Description pcs1 MA04065 panel L-8 ALTO 12 HK03838 K-PC board P-L8PU2-DIP 13 MG00305 copper pole M3*24*0.5PH 14 MG00061 screw M3*10 155 MG00041 screw M3*6 376 MF00061 washer JY-6351G-02-250 247 ME00060 socket nut JY-6351G-02-250 248 NI02084 knob φ10.5*18 59 NI01862 key 5.5*5.5*14.5 4

10 NI01863 key φ5.5*W10*7.5 711 HK03835 K-PC board P-L8MN1-DIP 112 MG00304 copper pole M3*14*0.5PH 813 MG00363 bare M3*14*0.5PH 314 NI02083 knob φ10.5*18 1815 NI02081 knob φ10.5*18 1216 NI02082 knob φ10.5*18 617 NI00826 knob φ12*18 double color 818 NI02386 konb φ14*13mm 219 NI02633 knob φ10.5*18 320 MI01629 separating shade S-12 121 TC00160 transformer PT-S12_230V 122 MG00102 screw M4*8 223 MJ01189 partitions L-8 124 NI02620 insulation board 1*86.5*53 L-8 125 HK03893 PC board P-313123-DIP(L-8) 126 HK03836 K-PC board P-L8PU1 127 HC00008 AC outlet 3515 A TYPE(RF-2004-C-4.8) 128 MG00042 screw M3*10 229 HI00171 power switch R612KKAT0F1 130 HI00026 power switch RA12KKATOF 2P 131 ME00016 colour nut 4m/m 132 MF00038 washer φ4*φ7*1t 133 HA01174 signle terminal wiring CF:W146 80 green/yellow 134 MF00048 washer φ4*φ8*0.5t 135 MB02799 rear board L8 136 HK03648 K-PCb P-RD82PWR(RD82FX) 137 MJ01145 heat sink RD82 138 MF00037 washer φ3*φ5*1t 239 MF00030 washer φ3*φ8*0.8t 240 ME00015 colour nut 3m/m 241 MG00162 screw M3*8 442 NI02249 caushion TW-1(TO-220) 443 NI00501 foot cushion 12.7*9*3t(SF-004) 444 NC00022 insulation 0.3t*18*45mm S-8 145 NC00005 silicone insulator TO-220 square type 1

Model No.

Date post:	16-Mar-2023
Category:	Documents
Upload:	khangminh22
View:	0 times
Download:	0 times

Service Manual - Audio-Circuit.dk

Documents