ECO SYSTEMSECO SYSTEMSFuel EnhancerFuel Enhancer
Lowers EmissionsIncreases PerformanceSaves FuelLowers MaintenanceHelps All of Us Breathe Easier
ECO Systems attach between the fuel source and the engine. No maintenance. No consumables.
ARE YOU SERIOUS ABOUT:ARE YOU SERIOUS ABOUT:Lowering Your Operational Cost?Putting Money Back in your Pocket?Becoming Less Dependent on Foreign Oil?Leave money in your account not the Pump?Lowering Harmful Exhaust Emissions?Reducing Particulates/Harmful exhaust gasses?Helping Clean the Air We All Breathe?Helping Reduce Cancer and Asthma? Doing Your Part to Voluntarily Go Green?Not waiting for Government Mandates?
WE WILL DO ALL THIS FOR YOU!
How Does It Work?How Does It Work?ECO Systems Fuel Enhancers work by electro-
statically charging the fuel you are currently using.
Works on Gasoline, Diesel, Propane, Biofuels, Ethanol Blends, and Natural Gas.
On average 10% savings in fuel consumption, with ranges from 3.5% to well into 30%. On average, 10%.
How ECO’s Work ContinuedHow ECO’s Work ContinuedECO-Systems work as a catalyst to enhance the
fuel by increasing it’s ability to Vaporize creating a better Air – Fuel ratio.
This process causes a more complete burn in the combustion chamber.
A more complete burn means increased horsepower.
Lower Harmful emissions emitted from the exhaust system
Less fuel needed to create the same performance as before equals a fuel savings $$$$$.
Fuel SavingsFuel SavingsOn average our units save 10% to 12% fuel on
gasoline and diesel applications.We have seen Higher and Lower numbers and
much depends on the condition of the engine, driving habits, and type of work done.
When you introduce a better quality of fuel to your engine – you will get better fuel economy – better performance – and lower emissions.
When comparing mileage before and after installation of the ECO-Systems just make sure you compare apples to apples.
Lower Maintenance CostLower Maintenance CostA more complete burn means less carbon going
into your oil causing a longer engine life.Less carbon build up on injectors.Less carbon build up on EGR valves and O2
sensors.Less re-gens on engines with Particulate traps due
to less particulate emitted from a more complete burn.
Engine runs smoother and at a cooler thermal temperature.
Which ECO System?ECO #1 - 6 Cylinder or less, Motorcycle, Marine, Light IndustrialMost smaller passenger vehicles, ATV, motorcycles, generators,
and most engines under 5 liters.
ECO #2 - 6 & 8 Cylinder, 5 Liter engine, or lessSmall trucks, most passenger vehicles, ATV, motorcycles, generators,
and most engines under 5 liters.
ECO #4 - 5+ Liter engine, up to 500 hpFull size pickup trucks, school buses, long haul trucks, heavy diesel
engines, and off-road equipment. The Chevy Duramax, Ford 6.4 Liter
require ECO-4 due to fuel line size.
ECO #5 - Big enginesHeavy equipment, including large generators, and earthmoving
equipment.
Fittings and Install Kits available for most applications.
ECO SYSTEMSECO SYSTEMSfor small engines to the very largestfor small engines to the very largest
Installation & WarrantyInstallation & WarrantyInstallation should be done by a certified
technician or by a technician familiar with fuel lines and fuel line repairs.
Fleets with their own maintenance shops may want to do their own installations.
The units carry a 5 year manufacturer’s limited warranty against any defects.
90 Day Money Back Guarantee.
WARRANTYWARRANTYAdding an ECO Fuel Systems Fuel Enhancer will not Adding an ECO Fuel Systems Fuel Enhancer will not
affect your vehicle warranty. It is specifically against the affect your vehicle warranty. It is specifically against the law to prohibit after market devices. law to prohibit after market devices.
Magnuson-Moss Warranty Act
If you are told that installing an ECO System will voidyour warranty, we want to hear from you. Please havethem put it in writing for you.
If they backpedal on putting it in writing, you knowtheir concerns are political and not based on fact.
Maintenance of ECO-SystemsMaintenance of ECO-SystemsMaintenance of these units is as simple as it gets. Install and let it work. There is no maintenance of the unit itself. When you trade off the vehicle simply remove and
install on another vehicle. You may have to change the installation adapters
if different from previous install.5-Year Limited WarrantyExpected Working Life: 40 Years
ECO #2 and ECO #4ECO #2 and ECO #4ECO #2 is for gasoline
engines of less than 5 liter. 4 cylinder, V-6 and small V-8
ECO #4 is for gas or diesel 5L, and up to 500 hp.
Law Enforcement VehiclesLaw Enforcement VehiclesFord Crown Vic-Sheriff
ECO #2 with 007 Kit
Law Enforcement VehiclesLaw Enforcement VehiclesPreferred Installation for 4.6 Crown Vic. InterceptorPreferred Installation for 4.6 Crown Vic. Interceptor
ECO #2 on Jeep ECO #2 on Jeep
2008 Jeep Sahara 006 Kit with ECO #2
School BusesSchool Buses
ECO #4 on Ford F150ECO #4 on Ford F150
Not Heat Dependent.
Hauling Furniture or GrainHauling Furniture or GrainECO #5 & ECO #4ECO #5 & ECO #4
2009 & 2007 Peterbilts 2009 & 2007 Peterbilts w/ ECO #4w/ ECO #4
U.S.I. Test ResultsU.S.I. Test Results
6.5% Fuel Savings8.75mpg to 9.31mpg
Road and Bridge Dept.Road and Bridge Dept.
InstallationsInstallationsThis is an Installation of an ECO
#4 with an 002 kit on a Caterpillar engine.
We disconnect the metal line coming out of the fuel filter going to the engine.
We then connect the male and Female JIC 6 fittings from our unit to the engines’ and tie strap the ECO #4 securely.
Installation must be done by qualified personnel.
Road and Farm EquipmentRoad and Farm Equipment
Construction & Farm
•Less Smoke
•Better Performance
•Less Fuel Used
•Money Saved
Buffalo Marine – Houston TX.Buffalo Marine – Houston TX.Entire Fleet with ECO-Systems – 4 Years Running
Thousands of Gallons of Fuel Saved
Leander ISDLeander ISDThe Particulate Reduction is More Important.The Particulate Reduction is More Important.
Leander ISDLeander ISD8 Buses, 26% Average Savings8 Buses, 26% Average Savings
67 metric tons of carbon67 metric tons of carbon
Leander ISDLeander ISD8 Buses, $13,000/yr Savings in fuel alone.8 Buses, $13,000/yr Savings in fuel alone.
Add in Regen Units and Maintenance.Add in Regen Units and Maintenance.
FundingFundingBuying ECO SystemsBuying ECO Systems
ECO Systems do not require Tax Dollars to be spent.
Funding ECO Systems with grants or external funds islike increasing your budget.
The savings on fuel will fund installation of ECO Systems inyour entire fleet over a reasonable amount of time.
Natural GasNatural GasProven SavingsProven Savings
Natural GasNatural GasSavings using ECO-7 Savings using ECO-7
Cummins Cummins Engine driving a pump driving a pump
Emissions TestsEmissions TestsHundreds have been done.Hundreds have been done.
This is for a ’94 Chevy 1500 in Victoria CountyThis is for a ’94 Chevy 1500 in Victoria County
Emissions TestsEmissions TestsThis is for a ’94 Chevy 1500 in Victoria CountyThis is for a ’94 Chevy 1500 in Victoria County
Test Data and ResultsTest Data and ResultsPlease refer to the White Paper by Richard
Carlson For proof as to why it works.For other test data done by third parties, labs,
real world applications and independent and government fleets please go to:
WWW.TARHEELGREEN.COM
ContactsContacts
Tar Heel Green Performance(919) 400-8733
www.TARHEELGREEN.com
Sales, Installation, Retail, Training, & WarehousingCheck Engine Light – Durham, NC
(919) 620-7963
www.checkenginelightnc.com
10 Reasons Not to Buy ECO Systems
1. You own oil wells.
2. You don’t care about saving fuel.
3. You need to spend your whole fuel budget.
4. You are not worried about air quality.
5. You like buying regen units for your diesels.
6. You have money to burn and don’t need to save.
7. You don’t care about children breathing soot.
8. You want to wait until cleaner air is mandated.
9. Data for 8 years, 8000 buses, in 125 School Districts is not sufficient.
10. Someone told you the ECO doesn’t work.