ABCDEFG
UNIVERS ITY OF OULU P.O.B . 7500 F I -90014 UNIVERS ITY OF OULU F INLAND
A C T A U N I V E R S I T A T I S O U L U E N S I S
S E R I E S E D I T O R S
SCIENTIAE RERUM NATURALIUM
HUMANIORA
TECHNICA
MEDICA
SCIENTIAE RERUM SOCIALIUM
SCRIPTA ACADEMICA
OECONOMICA
EDITOR IN CHIEF
PUBLICATIONS EDITOR
Senior Assistant Jorma Arhippainen
Lecturer Santeri Palviainen
Professor Hannu Heusala
Professor Olli Vuolteenaho
Senior Researcher Eila Estola
Director Sinikka Eskelinen
Professor Jari Juga
Professor Olli Vuolteenaho
Publications Editor Kirsti Nurkkala
ISBN 978-951-42-9584-3 (Paperback)ISBN 978-951-42-9585-0 (PDF)ISSN 0355-3213 (Print)ISSN 1796-2226 (Online)
U N I V E R S I TAT I S O U L U E N S I SACTAC
TECHNICA
U N I V E R S I TAT I S O U L U E N S I SACTAC
TECHNICA
OULU 2011
C 393
Narendar Kumar Khatri
OPTIMISATION OF RECOMBINANTPROTEIN PRODUCTIONIN PICHIA PASTORISSINGLE-CHAIN ANTIBODY FRAGMENT MODEL PROTEIN
UNIVERSITY OF OULU,FACULTY OF TECHNOLOGY,DEPARTMENT OF PROCESS AND ENVIRONMENTAL ENGINEERING
C 393
ACTA
Narendar K
umar K
hatri
C393etukansi.kesken.fm Page 1 Tuesday, October 11, 2011 11:19 AM
A C T A U N I V E R S I T A T I S O U L U E N S I SC Te c h n i c a 3 9 3
NARENDAR KUMAR KHATRI
OPTIMISATION OF RECOMBINANT PROTEIN PRODUCTION IN PICHIA PASTORISSingle-chain antibody fragment model protein
Academic dissertation to be presented with the assent ofthe Faculty of Technology of the University of Oulu forpublic defence in Kuusamonsali (Auditorium YB210),Linnanmaa, on 18 November 2011, at 12 noon
UNIVERSITY OF OULU, OULU 2011
Copyright © 2011Acta Univ. Oul. C 393, 2011
Supervised byDoctor Frank HoffmannProfessor Peter NeubauerProfessor Heikki Ojamo
Reviewed byDoctor Ursula RinasDoctor Juha-Pekka Pitkänen
ISBN 978-951-42-9584-3 (Paperback)ISBN 978-951-42-9585-0 (PDF)
ISSN 0355-3213 (Printed)ISSN 1796-2226 (Online)
Cover DesignRaimo Ahonen
JUVENES PRINTTAMPERE 2011
Khatri, Narendar Kumar, Optimisation of recombinant protein production inPichia pastoris. Single-chain antibody fragment model proteinUniversity of Oulu, Faculty of Technology, Department of Process and EnvironmentalEngineering, P.O. Box 4300, FI-90014 University of Oulu, FinlandActa Univ. Oul. C 393, 2011Oulu, Finland
AbstractPotential lethal diarrhoea caused by enterotoxigenic Escherichia coli strains is one of the mostcommon diseases in young pigs. It can be cured by single-chain antibody fragments (scFv), whichcan be produced in recombinant microorganisms. Pichia pastoris, a methylotrophic yeast, isgenerally considered an interesting production system candidate, as it can secrete properly foldedproteins. These proteins accumulate in high concentrations during fermentation, reducing the costfor product recovery.
Strong inducible AOX1 promoter, widely used in P. pastoris for fast, inexpensive production,is typically induced by methanol. The high oxygen demand of methanol metabolism makesoxygen supply a major parameter in cultivations requiring special process design strategies. Instandard fed-batch cultivation, dissolved oxygen concentration inside a bioreactor is kept at acertain level by pumping air and pure oxygen into the reactor. There are safety concerns over thehandling of oxygen, especially at a large scale. Therefore, there is a need to develop a productionprocess under oxygen-limited conditions.
This dissertation studies the development of a cost-efficient production process of scFv in P.pastoris. Both methanol and oxygen parameters influence the production process and the objectivewas to find a robust production process. Fed-batch cultivations were performed in a 10 L scalebioreactor. The effects of lower oxygen level, methanol concentration, glycerol feeding durationand specific substrate-uptake rates on product formation were studied. A P. pastoris GS115 his4strain under an AOX1 promoter system expressing scFv was used in this study. The fed-batchfermentations were carried out in a bioreactor with basal salt media.
In this doctoral dissertation, a process was developed for a single-chain antibody fragment(scFv) production in P. pastoris. The product levels of 3.5 g L-1 scFv in culture supernatant wereachieved and a production process was designed without additional need of pure oxygen, thusrelieving safety requirements and lowering the amount of methanol. The process developed duringthis research may potentially be utilised by both academia and industry having interests inexpressing proteins in P. pastoris. The methanol-uptake control strategy is beneficial for thoseproducts that suffer from degradation or modification during limited feeding of methanol.
Keywords: fed-batch, fermentation, Pichia pastoris, recombinant protein production,scFv
Khatri, Narendar Kumar, Rekombinanttiproteiinin tuoton optimointi Pichiapastoris –hiivalla— scFv-vasta-ainefragmentti malliproteiinina. Oulun yliopisto, Teknillinen tiedekunta, Prosessi- ja ympäristötekniikan osasto, PL 4300, 90014Oulun yliopistoActa Univ. Oul. C 393, 2011Oulu
TiivistelmäEnterotoksigeenisten E.coli kantojen aiheuttama ripuli on porsaiden tavallisimpia tauteja, jokavoi johtaa jopa kuolemaan. Tautia voidaan hoitaa yhdistelmä-DNA-tekniikalla tuotetuilla vasta-ainefragmenteilla (scFv). Metylotrofista Pichia pastoris hiivaa pidetään kiinnostavana vasta-ainefragmenttien tuottoisäntänä, koska se pystyy erittämään oikealla tavalla laskostuneita prote-iineja. Näitä proteiineja kertyy fermentointiprosessissa solujen ulkopuolelle korkeina pitoisuuk-sina, mikä vähentää tuotteiden talteenottokustannuksia.
Vahva metanolilla indusoituva AOX1-promoottori on laajassa käytössä P. pastoris tuottosys-teemissä tuoton nopeuden ja alhaisten kustannusten ansiosta. Metanolin aineenvaihdunta vaatiipaljon happea, joten riittävän tehokas hapen liuottaminen on tärkeimpiä fermentointiparametre-ja ja vaatii erityisiä prosessin toteutusstrategioita. Perinteisessä fed-batch-fermentoinnissa liuen-neen hapen pitoisuus bioreaktorissa pidetään halutulla tasolla lisäämällä ilmaa ja puhdasta hap-pea reaktoriin. Koska hapen käsittelyyn liittyy turvallisuusriskejä erityisesti teollisuusmittakaa-vassa, happirajoitteisissa olosuhteissa toimiva tuotantoprosessi olisi hyödyllinen.
Tässä väitöstutkimuksessa kehitettiin kustannustehokasta prosessia scFv-:n tuottoon P. pasto-ris hiivalla. Metanoliin ja happeen liittyvät parametrit ovat olennaisia prosessiin vaikuttavia teki-jöitä. Tavoite oli kehittää yksinkertainen ja käytännöllinen prosessi. Työssä tutkittiin alhaisenhappitason, metanolin pitoisuuden, glyserolisyötön keston ja substraattien spesifisten kulutusno-peuksien vaikutuksia tuotteen muodostumiseen 10 litran bioreaktorissa. Isäntäkantana oli P. pas-toris GS115 his4, jossa scFv-ekspressiota säädeltiin AOX1 promoottorilla. Fed-batch fermen-tointien kasvatusalustana käytettiin Basal Salt Medium alustaa (BSM).
Väitöstyössä kehitettiin tavoitteiden mukainen vasta-ainefragmenttien tuottoprosessi P.pasto-ris hiivalle. Menetelmällä saavutettiin tuotepitoisuus 3,5 g L-1 kasvatusliemen supernatantissailman puhtaan hapen lisäystarvetta, ja siten metanolin kulutus väheni ja prosessiturvallisuusparani verrattuna perinteisiin prosesseihin. Kehitetty prosessi soveltuu käytettäväksi sekä akatee-misessa tutkimuksessa että teollisuudessa tuotettaessa erilaisia proteiineja P. pastoris hiivalla.Metanolin kulutuksen säätöstrategia on erityisen hyödyllinen tuotteille, joilla ongelmana on pro-teolyysi tai muokkautuminen metanolirajoitteisessa fermentoinnissa.
Asiasanat: fed-batch, fermentointi, Pichia pastoris, rekombinanttiproteiinin tuotto, scFv
To my grandparents, parents and family
8
9
Acknowledgements
This study was initially started at the Institute of Biochemistry and Biotechnology,
Martin Luther University Halle-Wittenberg, Germany and later it continued at the
Bioprocess Engineering Laboratory (BPEL), Department of Process and
Environmental Engineering at the University of Oulu, Finland. Direct and indirect
support for financing the study came from Novoplant GmbH Germany, Centre for
International Mobility (CIMO), Tauno Töningin Foundation, Biocenter Oulu,
Oskar Öflundin Säätiö and Oulun Yliopiston Apuraharahasto (Yliopiston
Apteekin Rahasto). I am grateful to all of them for supporting me during this
study.
I wish to express thanks to my supervisors, Dr Frank Hoffman at Halle, Prof.
Peter Neubauer, and Prof. Heikki Ojamo at Oulu, whose supervision and valuable
comments made this research work possible. I would like to thank the other co-
authors of my publications, Dr Oliver Trentmann and Dr Dörte Gocke for their
valuable contribution and suggestions. Special thanks to Dr Pekka Belt, Dr Janne
Harkonen, Dr Matti Mottonen and Prof. Riitta Keiski for their valuable comments
and support during the dissertation process. I appreciate technicians Uta Best and
Lilja Tuohimaa for their help in laboratory routines.
The reviewers, PD Dr Ursula Rinas and Dr Juha-Pekka Pitkänen are thanked
for their careful review of the thesis and providing many valuable comments. I
thank Edmund Ward, SfEP, for proofreading of the thesis.
I am thankful to all present and former staff of BPEL, Oulu for nice
discussions, translation help and providing good working atmosphere, not to
forget Liisa Myllykoski who took care of all financial and administration tasks,
Antti Vasala who provided generous help in settling us in this cold country. Many
thanks go to my dear friends Swapan Kumar Chatterjee, Naresh Paneru, Shashank
Shekhar, Tiina Ristikari and Martin Kögler for nice discussions and help in
everyday life.
I am grateful to my parents, grandparents, my uncle Dr Ashok Kumar Khatri
and other family members whose blessings and unlimited support through all
stages of my life are unforgettable. This thesis is dedicated to them.
Finally, my deepest gratitude goes to my wife, Neeta, and our children, Nitin
Kumar and Samiksha Rani, who endured my long working days. Their smiles
made me happy and motivated me to work hard.
Oulu, October 2011 Narendar Kumar Khatri
10
11
List of abbreviations
µ specific growth rate (h−1)
µset set specific growth rate (h−1)
AOX Alcohol oxidase enzyme
AOX Alcohol oxidase promoter
BSM Basal salt medium
CDW Cell dry weight (g L−1)
CFW Cell fresh weight (g L−1)
DHAS Dihydroxyacetone synthase promoter
DO Dissolved oxygen concentration (%)
ELISA Enzyme-linked immunosorbent assay
exp exponential
FLD1 Formaldehyde dehydrogenase 1 promoter
GAP Glyceraldehyde 3-phosphate deydrogenase promoter
P. pastoris Pichia pastoris
PI control Proportional-integral control
PID control Proportional-integral-derivative control
qMeOH specific methanol-uptake rate (g g−1 h−1)
qp specific production rate or productivity (mg kg−1h−1)
scFv single-chain antibody fragment
tf time of feeding (h−1)
tind time of induction (h−1)
TLFB temperature limited fed-batch fermentation
YPD Yeast peptone dextrose
12
13
List of original publications
This dissertation is based on the following publications:
I Trentmann O, Khatri NK & Hoffmann F (2004) Reduced oxygen supply increases process stability and product yield with recombinant Pichia pastoris. Biotechnol Prog 20: 1766–1775.
II Khatri NK & Hoffmann F (2006a) Impact of methanol concentration on secreted protein production in oxygen-limited cultures of recombinant Pichia pastoris. Biotechnol Bioeng 93: 871–879.
III Khatri NK, Gocke D, Trentmann O, Neubauer P & Hoffmann F (2011) Single-chain antibody fragment production in Pichia pastoris: Benefits of prolonged pre-induction glycerol feeding. Biotechnol J 6(4): 452–62.
IV Khatri NK & Hoffmann F (2006b) Oxygen-limited control of methanol uptake for improved production of a single-chain antibody fragment with recombinant Pichia pastoris. Appl Microbiol Biotechnol 72: 492–498.
The author of this dissertation has been the primary author in Articles II, III and
IV of the original publications and Number 2 in Article I. The researcher has been
responsible for formulating the research problems, collecting theoretical
background, formulating research questions, coordinating the collection of
empirical material, analysing the material, drawing conclusions, and finally being
either primary or secondary author for the articles. In Article I the author of this
dissertation was responsible for all fermentation-related experiments. In Articles
II, III and IV the role of co-authors has included reviewing and commenting on
the article manuscripts.
14
15
Contents
Abstract
Tiivistelmä
Acknowledgements 9
List of abbreviations 11
List of original publications 13
Contents 15
1 Introduction 17
1.1 Background ............................................................................................. 17
1.2 Objectives and scope ............................................................................... 18
2 Literature review 19
2.1 Pichia pastoris ........................................................................................ 19
2.1.1 Methanol-utilising phenotypes ..................................................... 19
2.1.2 Promoters for Pichia pastoris ....................................................... 20
2.2 Fed-batch fermentations of Pichia pastoris ............................................ 21
2.2.1 Fed-batch control strategies .......................................................... 22
3 Materials and methods 27
3.1 Strain and genetic constructs ................................................................... 27
3.2 Medium ................................................................................................... 27
3.3 Culture conditions ................................................................................... 27
3.4 Purification of the scFv ........................................................................... 29
3.5 Cell density analysis ................................................................................ 29
3.6 scFv analysis ........................................................................................... 29
4 Research contribution 31
4.1 The effects of reduced oxygen supply on production process ................ 31
4.1.1 Cultivation without addition of pure oxygen ................................ 31
4.1.2 Cultivation with addition of pure oxygen ..................................... 33
4.1.3 Discussion relating to Research Question 1 ................................. 34
4.2 The impact of methanol concentration on scFv production under
oxygen-limited conditions ....................................................................... 34
4.2.1 Discussion relating to Research Question 2 ................................. 36
4.3 The effects of long glycerol feeding on scFv production under
oxygen-sufficient conditions ................................................................... 36
4.3.1 Discussion relating to Research Question 3 ................................. 38
4.4 Controlling methanol-uptake for improved production of a scFv ........... 38
4.4.1 Discussion relating to Research Question 4 ................................. 43
16
5 Conclusions 45
References 47
Original publications 55
17
1 Introduction
1.1 Background
Potential lethal diarrhoea caused by enterotoxigenic Escherichia coli strains is
one of the most common diseases in young pigs. Bacterial adhesion to intestinal
surface is mediated by fimbriae and can be inhibited by appropriate monoclonal
antibodies (Sun et al. 2000). Production by hybridoma cells is well established; it
is very expensive for veterinary application as high doses are required. Therefore,
there is a need for a cost-efficient production process of antibodies. Cost-efficient
alternatives are single-chain antibody fragments (scFv), which, because of their
structural simplicity, can be produced in recombinant microorganisms.
The cheapest, easiest and quickest expression system of choice is Escherichia
coli, but it has many drawbacks. Proteins that are produced as inclusion bodies
are often inactive, insoluble, and require refolding (Demain & Vaishnav 2009).
Higher eukaryotic cells can produce functional proteins but the expression
systems are expensive. The yeast-based system P. pastoris is the choice in terms
of price and functionality.
Pichia pastoris, a methylotrophic yeast, is generally an interesting candidate
production system for protein production as it can secrete properly folded proteins,
which accumulate in high concentrations in the culture medium. More than 700
proteins have been expressed in P. pastoris (Zhang et al. 2009). In the controlled
environment of a bioreactor, it is possible to achieve high cell densities of about
400 g L−1 cell fresh weight or 130 g L−1 cell dry weight respectively with
P. pastoris (Jahic et al. 2002). The concentration of the product obtained from this
yeast is reported to be as high as 22 g L−1 for intracellular production (Hasslacher
et al. 1997) and 14.8 g L−1 of clarified broth for secreted proteins (Werten et al.
1999). Product yield of scFv is generally 10–50 mg L−1 (Shi et al. 2003, Panjideh
et al. 2008, Cai et al. 2009, Jafari et al. 2011, Sommaruga et al. 2011) or in some
cases up to 500 mg L−1 (Eldin et al. 1997, Fischer et al. 1999, Chang et al. 2008)
but by using a special sequence, up to 1.2 g L−1 product yield has been reported
(Freyre et al. 2000).
Crucial to the fast, inexpensive production in P. pastoris is the strong
inducible AOX1 promoter to drive recombinant protein expression, which is
induced in the presence of methanol. Other promoter systems are also available
but this promoter system is the most widely used.
18
The high oxygen demand of methanol metabolism makes oxygen supply a
major parameter in P. pastoris cultivations and therefore requires special process-
design strategies. In a standard P. pastoris fed-batch cultivation, dissolved oxygen
concentration inside the bioreactor is kept at a certain level by feeding air and/or
pure oxygen to the reactor. There are safety concerns over handling of oxygen,
especially at a large scale. Therefore, there is a need of a production process
under oxygen-limited (only aeration) conditions.
1.2 Objectives and scope
This dissertation studies the development of a cost-efficient production process of
a single chain antibody fragment in P. pastoris. In high cell density cultivations
during induction on methanol, P. pastoris cells respire fast and need more oxygen
to keep a constant dissolved oxygen concentration in a bioreactor. The main
objective has been to find a robust production process and study the effects of
methanol and oxygen conditions on the process.
This research problem is further divided into the following research questions:
RQ1 What are the effects of reduced oxygen supply on the production of single-
chain antibody fragment (scFv) by recombinant Pichia pastoris?
RQ2 What is the impact of methanol concentration on scFv production under
oxygen-limited conditions?
RQ3 What are the effects of a long glycerol feeding phase on scFv production in
Pichia pastoris under oxygen-sufficient conditions?
RQ4 How can the key process parameter “specific substrate uptake rate” be
controlled under substrate-sufficient conditions?
In this dissertation, each of the four research questions is answered by one
scientific journal article. This study has been carried out at a ten- litre scale. Other
magnitudes have been excluded.
19
2 Literature review
2.1 Pichia pastoris
The methylotrophic yeast Pichia pastoris is currently one of the most effective
and versatile systems for the expression of heterologous proteins (Potvin et al.
2010). This expression system is popular for these reasons: (1) the molecular
biology techniques applied are the same as widely studied yeast Saccharoymyces
cerevisiae (2) its ability to express foreign proteins in high levels, either
intracellular or extracellular (3) the ability performing many posttranslational
modifications, such as glycosylation, disulphide bond formation and proteolytic
processing (4) the availability of the expression system as a commercial kit (5)
the efficient and tightly regulated promoter alcohol oxidase 1 (AOX1) that induces
up to 1000-fold when the carbon source is switched to methanol (6) its ability to
undergo high cell density cultivations in a bioreactor and the preference of a
respiratory rather than fermentative mode of growth (Cereghino & Cregg 2000,
Cereghino et al. 2002).
More than 700 proteins have been expressed in P. pastoris (Zhang et al.
2009). Both high cell density and high product levels are obtained in the
controlled environment of a bioreactor (Hasslacher et al. 1997, Werten et al. 1999,
Jahic et al. 2002, Gurramkonda et al. 2009, Gurramkonda et al. 2010).
Recently, P. pastoris genome sequence has been published (De Schutter et al.
2009, Mattanovich et al. 2009a, Mattanovich et al. 2009b) and a proteomic
analysis of its secretome in methanol induced cultures has been performed
(Huang et al. 2011). These developments open the door to the strain improvement
by systems biology approaches (Bollok et al. 2009).
2.1.1 Methanol-utilising phenotypes
There are three phenotypes of P. pastoris with regard to methanol utilisation
(Macauley-Patrick et al. 2005, Potvin et al. 2010). The Mut+, or methanol
utilisation plus phenotype has both AOX1 and AOX2 genes, grows on methanol at
wild-type rate and therefore requires a high dose of methanol in large-scale
cultivations (Cereghino & Cregg 2000). In the Muts, or methanol utilisation slow
phenotype, AOX1 gene is deleted and therefore the methanol-uptake rate is
slowed down due to weaker AOX2. In some cases, Muts strains have high
20
productivities compared to the wild-type strains (Cregg et al. 1987, Pla et al.
2006). The Mut-, or methanol-utilising minus phenotype, where both AOX genes
are deleted, is unable to grow on methanol and thus has low growth rate
(Macauley-Patrick et al. 2005). Recombinant protein expression is widely
reported with Mut+ phenotype strains (Macauley-Patrick et al. 2005). This study
is also based on this phenotype.
2.1.2 Promoters for Pichia pastoris
The most widely used and popular promoter system in Pichia pastoris for
recombinant protein production is AOX1 (Cereghino & Cregg 2000, Bushell et al.
2003, Lee et al. 2003a, Macauley-Patrick et al. 2005, Jahic et al. 2006, Potvin et
al. 2010). The promoter is repressed when P. pastoris cells are grown on glucose
or glycerol, but is induced strongly up to 1000-fold when the cells are shifted to
methanol medium (Cereghino et al. 2002). The ability of repressing expression of
a foreign protein is beneficial when the protein is toxic to the cells (Cereghino et
al. 2002). The Alcohol oxidase enzyme makes up to 33% of total cell proteins
when cells are grown on methanol (Couderec & Baretti 1980). The AOX1
promoter requires methanol for induction, which is highly combustive, toxic, and
requires special storage and handling issues. Therefore non-methanol-based
systems are desired.
The glyceraldehyde 3-phosphate deydrogenase promoter (GAP) is a strong
constitutive promoter in P. pastoris (Zhang et al. 2009). The common substrates
used are glucose, glycerol, and oleic acid but methanol can also be used (Zhang et
al. 2009). Mostly glycerol and glucose are used as carbon source because least
protein expression is reported when methanol is used (Waterham et al. 1997,
Zhang et al. 2007). The GAP promoter system is suitable for large-scale
production, as the need to change feeding solutions and fire and safety concerns
related to methanol are avoided. The expression levels obtained are comparable
with the AOX1 promoter (Waterham et al. 1997). However, it is not suitable if the
expressed protein is toxic to the cells (Cos et al. 2006a). Some studies report that
heterologous protein expression by GAP system is better than AOX1 (Waterham
et al. 1997, Döring et al. 1998, Delroisse et al. 2005), whereas others report that
AOX1 is better for protein expression (Sears et al. 1998, Boer et al. 2000,
Vassileva et al. 2001, Kim et al. 2009). Protein expression under the control of
both AOX1 and GAP promoters is an effective strategy to increase yields (Potvin
et al. 2010). Human granulocyte macrophage colony-stimulating factor and a
21
thermostable alkaline β-mannanase have been expressed successfully using this
strategy (Wu et al. 2003a, Wu et al. 2003b, He et al. 2008).
The FLD1 promoter based on glutathione-dependent enzyme formaldehyde
dehydrogenase regulates protein expression through induction with either
methanol as a sole carbon source (and ammonium sulphate as nitrogen source) or
methylamine as a sole nitrogen source (and glucose as a carbon source) (Shen et
al. 1998, Cereghino & Cregg 2000). The productivity of a Rhizopus oryzae lipase
in high cell density cultivation under the FLD1 promoter was similar to the AOX1
controlled system (Resina et al. 2005, Cos et al. 2005, Resina et al. 2009).
Some other promoter systems such as ICL1, TEF1, YPT1, DHAS for
recombinant protein expression with P. pastoris are reported but expression levels
are low and therefore AOX1 remains the most popular system (Cereghino &
Cregg 2000, Potvin et al. 2010). In this study, scFv expression is under AOX1
control.
2.2 Fed-batch fermentations of Pichia pastoris
With microbial cells, fed-batch fermentation is carried out to achieve high-density
cultivation. Typically, in a fed-batch process, after the depletion of substrate (such
as glucose) in the batch media, a growth limiting substrate is fed to the reactor
with a rate. The process is easy to control and very widely used to obtain high cell
density cultivations (Chiruvolu et al. 1997, Minning et al. 2001, Cos et al. 2005,
Sirén et al. 2006, Cos et al. 2006b, Yamawaki et al. 2007, Gurramkonda et al.
2009, Potvin et al. 2010, Gurramkonda et al. 2010, Park et al. 2011, Li et al. 2011,
Liu et al. 2011, Sommer et al. 2011, Yuan et al. 2011, Jung & Lee 2011, Abad et
al. 2011, Lopez-Cuellar et al. 2011, Vohra et al. 2011, Zhang et al. 2011, Parawira
& Tekere 2011).
The fed-batch cultivation of P. pastoris expressing a product under the
control of AOX1 consists of three, or in some cases, four phases: glycerol batch
phase, glycerol fed-batch phase, methanol fed-batch, and optional transition phase
(Zhang et al. 2000b, Cos et al. 2006a, Gurramkonda et al. 2009, Potvin et al.
2010). The aim of the first two phases is to produce enough biomass. The
maximum specific growth rate (µmax) of P. pastoris grown on glycerol is 0.18 h−1
(Cos et al. 2005, Potvin et al. 2010) and on methanol is 0.14 h−1 (Brierley et al.
1990, Potvin et al. 2010). Initially, in batch mode, basal salt media contains
40 g L−1 glycerol. When it is consumed, the dissolved oxygen concentration
increases in the bioreactor and at that time limited glycerol feeding is started. The
22
aim of this phase is to derepress the AOX1 promoter and make cells ready for
induction (Zhang et al. 2000b, Cereghino et al. 2002). In a standard protocol, this
intermediate glycerol feeding lasts for 2‒4 hours. After this phase, the methanol
feeding is started to induce the AOX1 promoter. The methanol feeding amount
and control strategy in a bioreactor influence residual methanol concentration,
specific growth rate of the culture, and heterologous protein expression levels
(Potvin et al. 2010).
In some cases, an optional transition phase is included between glycerol-
limited feeding and induction phase, so that cells adapt better for protein
expression. In this phase, a co-feeding of glycerol and methanol over a certain
time is performed whereby the glycerol feeding is decreased slowly and methanol
feeding is increased (Zhang et al. 2000a, Minning et al. 2001). A mixed feed of
glycerol and methanol allowed faster induction of alcohol oxidase and faster
adaptation of cellular metabolism than with a sole methanol feeding (Jungo et al.
2007).
Recently, a two-phase fed-batch protocol composed of a batch with high
glycerol (95 g L−1) and a feeding of methanol at constant rate is reported for the
successful production of Hepatitis B surface antigen (Gurramkonda et al. 2009)
and insulin precursor (Gurramkonda et al. 2010). The process scheme is easy to
implement and requires less instruments and control.
A high cell density fed-batch cultivation of P. pastoris under a GAP promoter
system consists of two phases: a batch phase and a fed-batch phase. The sole
carbon source is either glucose or glycerol. There are contrary reports claiming
which substrate is superior for recombinant protein production. Glucose is seen as
a preferred substrate over glycerol (Döring et al. 1998, Pal et al. 2006). On the
other hand, some authors report glycerol to be better than glucose (Zhang et al.
2007, Tang et al. 2009).
2.2.1 Fed-batch control strategies
Methanol is a carbon source and inducer for recombinant protein production in
AOX1-based Pichia cultivations. Its metabolism requires high amounts of oxygen
(Yurimoto et al. 2002). Methanol feeding rate has been identified as a major
parameter to optimise protein production with recombinant P. pastoris, and small
changes can have profound effects (Sinha et al. 2003). An unlimited methanol
supply can lead to oxygen depletion. Oxygen limitation can negatively affect the
23
protein expression (Cereghino & Cregg 2000). Dissolved oxygen concentration is
a critical parameter for high cell density cultivations (Cunha et al. 2004).
Therefore, fed-batch control strategies are reported with the aim to control
methanol feeding and achieve high product formation. The most common
methanol feeding strategies are 1) constant specific growth-rate feeding (μ-stat), 2)
constant methanol concentration feeding, 3) constant DO-based feeding (DO-stat)
and 4) temperature-limited fed-batch (TLFB).
μ-stat control
In this control method, methanol feeding rate is calculated on mass balance
equations to maintain a constant specific growth rate (µ) (Cos et al. 2006a). This
control method is easy to calculate and does not require any online monitoring of
system parameters, as long as the yield coefficient does not change (Potvin et al.
2010). The parameter µ is a good control strategy for process optimisation, as
many protein production processes are directly or indirectly related with cell
growth (Ren et al. 2003). Maintaining a constant μ enhances process-
reproducibility and facilitates study of growth-rate-related effects on recombinant
protein production (Potvin et al. 2010).
To keep a constant specific growth rate, models are devised using a methanol
feed profile (Potvin et al. 2010). A model based on a relation between the specific
growth rate, methanol concentration, and specific methanol consumption rate is
reported (Zhang et al. 2000a). According to them, the μmax calculated from this
model was 0.08 h−1 and the observed value was 0.0709 h−1. The highest level of
recombinant protein was achieved at about one third of μmax. A macrokinetic
model for P. pastoris expressing recombinant human serum albumin is reported
based on stoichiometric balances describing cell growth and protein production
(Ren et al. 2003). The μset was maintained by a combination of linear and
exponential feeding profiles. Also it was suggested that a μ set-point control
method is more efficient than maintaining a constant feed rate to maximising
production (Ren & Yuan 2005).
Sinha et al. designed a model based on cell growth on methanol with a
substrate-feed equation, and employed the model to control the process (Sinha et
al. 2003). They found that methanol feeding strategy is a very important factor
that controls the recombinant protein induction and protease production in
P. pastoris fermentation. An optimal value of 0.025 h−1 for specific growth rate (µ)
24
was reported, which could be controlled by methanol feeding profile (Sinha et al.
2003).
Trinh et al. reported three methanol feeding strategies for production of
mouse endostatin by P. pastoris (Trinh et al. 2003). First strategy was based on
methanol consumption; the second on dissolved oxygen concentration. In these
two control strategies, methanol supply was unlimited. In the last strategy, limited
methanol feeding was employed using an exponential feeding profile with set
growth rate (µset) of 0.02 h−1. Total recombinant protein produced was the same in
all cases (400 mg in 3L initial culture volume). However, specific product was
twice in limited methanol feeding compared to other strategies (Trinh et al. 2003).
Limited methanol feeding is widely used but not suited for those products
that get degraded or modified under these conditions (Zhou & Zhang 2002, Jahic
et al. 2003). To avoid methanol accumulation in the bioreactor, the specific
growth rate (μ) is maintained at a set value lower than μmax (Zhang et al. 2000a,
Ren et al. 2003).
Constant methanol concentration
Methanol concentration of P. pastoris culture broth is an important parameter to
control. The control strategy requires input from a methanol measurement system.
The most common methods for measuring methanol in offline mode are based on
chromatographic methods (GC and HPLC), and in online mode are based on
liquid gas equilibrium (Potvin et al. 2010). By controlling methanol concentration,
accumulation of methanol to high levels in the bioreactor is avoided.
Formaldehyde, the first product of methanol metabolism, is accumulated to toxic
levels when oxygen and methanol are in excess (Stratton et al. 1998). Stability of
the methanol concentration is important, as higher productivity is achieved at the
constant concentrations than with fluctuating concentrations (Guarna et al. 1997,
Minning et al. 2001).
Typical methanol control strategies are on-off control mode and Proportional-
integral (PI) or proportional-integral-derivative (PID) control. An on-off control
mode is a simple feedback control strategy and is used in P. pastoris cultivations
(Wagner et al. 1997, Guarna et al. 1997, Katakura et al. 1998, Zhang et al. 2000a).
The on-off control strategy is suitable for linear systems, but generally
recombinant protein production in P. pastoris is a more complex and highly non-
linear process, and therefore fluctuations around the set-point are reported (Zhang
et al. 2002, Cos et al. 2006a, Potvin et al. 2010).
25
In a PID control system, the system output depends on the controller gain, KC,
the integral time constant, τI, and derivative time constant, τD (Zhang et al. 2002).
Optimal controller settings are based on the specified desired biomass
concentration and the culture volume. Due to the nonlinearity and complexity of
fermentation process dynamics, the optimal PID controller settings are
determined by trial and error tuning, or by using other empirical methods (Zhang
et al. 2000a, Cos et al. 2006a, Potvin et al. 2010).
Cos et al. used a predictive control algorithm, together with a PI feedback
controller, to optimise the production of a Rhizopus oryzae lipase in P. pastoris
(Cos et al. 2006b). First-time derivative of methanol concentration was used as an
input; proportional gain and integral time constant of the PI controller were fixed
during the fermentation (Cos et al. 2006b).
Minning et al. showed that the methanol-control strategy based on an online
methanol measurement system was a better control strategy than the DO-stat for
the production of R. oryzae lipase in P. pastoris (Minning et al. 2001).
DO-stat control
The dissolved oxygen concentration (DO) in the medium is an important
parameter to control in P. pastoris cultivations. In cyclic fed-batch fermentation,
the specific product concentration depends linearly on the dissolved oxygen
concentration in quasi-steady state, with no product accumulation when DO is
below 15% (Bushell et al. 2003). Because of high demand of oxygen by Pichia
pastoris, generally DO is kept above 20% in the cultivations (Singh et al. 2008).
It is reported that for optimum protein production with P. pastoris, DO control is
very essential (Lim et al. 2003, Woo et al. 2005).
In DO-stat control strategy, the feeding of substrate is controlled to keep a
DO concentration at a constant level in the culture medium (Lee et al. 2003b, Hu
et al. 2008). High density cultures of P. pastoris exhibit oscillatory behaviour
with stirrer speed and aeration when methanol is fed into the bioreactor (Potvin et
al. 2010).
Although DO-stat control is used in several studies as a means to increase
process robustness and performance, the methanol concentration and specific
growth rate have not been held constant, making the influence of these parameters
on production difficult to determine (Inan & Meagher 2001, Lee et al. 2003b,
Oliveira et al. 2005, Cos et al. 2006a).
26
Temperature-limited fed-batch (TLFB)
In this fed-batch strategy, methanol limitation is replaced by temperature
limitation mainly to avoid oxygen deficiency at high cell densities (Jahic et al.
2003, Potvin et al. 2010). By this method, both oxygen and methanol
concentrations can be controlled. The methanol concentration in the broth is
maintained constant by DO-stat, µ-stat, or constant methanol concentration
methods and culture temperature is lowered to maintain DO at a set point (Potvin
et al. 2010). Cell growth is therefore limited by temperature (Jahic et al. 2003,
Potvin et al. 2010).
A recombinant fusion protein composed of a cellulose-binding module (CBM)
from Neocallimastix patriciarum cellulase 6A and lipase B from Candida
antarctica, was produced by P. pastoris fed-batch cultivations (Jahic et al. 2003).
Two fed-batch control strategies (a) methanol-limited fed-batch and (b)
temperature-limited fed-batch (TLFB) were applied and compared. The
production levels were twice in TLFB compared to methanol-limited fed-batch.
Other benefits include a low cell death rate, low protease activity in the culture
supernatant (Jahic et al. 2003) and increase in the activity of alcohol oxidase.
Suribas et al. reported that by using this control strategy, cell death during
cultivation is reduced and 1.3 times more final product was obtained compared to
methanol non-limited conditions (Surribas et al. 2007).
27
3 Materials and methods
3.1 Strain and genetic constructs
A single-chain antibody fragment (scFv) against fimbriae of enterotoxigenic
Escherichia coli F4 was obtained by phage display screening of a library
constructed from spleen cDNA of F4-challenged mice. From the phagemid vector
of a high-affinity binder, the scFv sequence called BA11 was amplified, joined
with sequences encoding the α-mating-factor secretion signal from
Saccharomyces cerevisiae in the plasmid pPic9 (Invitrogen, Carlsbad, CA) and a
His6 tag, and integrated in the genome of P. pastoris GS115 Mut+ strain to give
GS115:BA11. Successful transformants are selected for prototrophy after
complementation of the GS115 his4 strain by the HIS4 gene of pPic9; a high-
producing strain was obtained by screening for scFv secretion (Trentmann et al.
2004).
3.2 Medium
The growth medium was prepared according to the recommendation of the
Invitrogen Manual (EasySelect™ Pichia Expression Kit, Catalogue No. K1740-
01) : YPD (1% w/v yeast extract, 2% w/v peptone, 2% w/v dextrose) and BMGY
(1% w/v yeast extract, 2% w/v peptone, 100 mM KH2PO4 pH 6, 1.34% w/v yeast
nitrogen base with (NH4)2SO4 without amino acids, 4 10−5% biotin, 1% v/v
glycerol). To the basal salt medium BSM (26.7 mL L−1 phosphoric acid, 14.9
g L−1 MgSO4.7H2O, 0.93 g L−1 CaSO4
.2H2O, 18.2 g L−1 K2SO4, 4.13 g L−1 KOH,
40 g L−1 glycerol), 4 mL L−1 sterile-filtered trace element solution PTM1 (6 g L−1
CuSO4.5H2O, 0.08 g L−1 NaI, 3 g L−1 MnSO4
.H2O, 0.2 g L−1 Na2MoO4.2H2O, 0.02
g L−1 H3BO3, 0.5 g L−1 CoCl2, 20 g L−1 ZnCl2, 65 g L−1 FeSO4.7H2O, 0.2 g L−1
Biotin, 5 mL conc. H2SO4) was added after autoclaving (Zhang et al. 2000a). The
pH value was adjusted to pH 6 with 25% ammonium hydroxide solution.
3.3 Culture conditions
For pre-culture, 10 mL YPD were inoculated with a single colony of
GS115:BA11 from an agar plate and incubated 24 h at 30 °C and 160 rpm. Two
times 200 mL BMGY in 1000 mL shake flasks were inoculated with 1% (v/v) of
28
the first pre-culture and incubated for 24 h as above. The reactor was inoculated
with 5% (v/v) of the second pre-culture.
Cultivations were carried out in a Biostat C bioreactor with a working volume
of 10 L connected to a DCU3 digital control unit and the MFCS/win process
supervisory system (B. Braun Biotech International, Melsungen, Germany). The
initial culture volume was 6 L. The pH value was controlled at pH 6 by automatic
addition of 25% ammonium hydroxide solution. Dissolved oxygen (DO)
saturation was determined by a Clark electrode (Ingold, Steinbach, Germany),
and was maintained above 40% by increasing the stirrer speed from 300 to 1200
rpm, subsequently increasing the air flow rate from 2 to 16 L min−1, and—where
indicated—dosage of oxygen up to 10 L min−1, until the maximum oxygen
transfer capacity of the reactor was reached and the culture was harvested or the
DO concentration declined. The cultivation temperature was 30 °C. Antifoam was
added automatically on demand.
When the process control system detected the DO-controlled decrease in
stirrer speed and air flow rate upon depletion of glycerol from the BSM medium,
glycerol feeding was activated with a rate rglycerol given by Equation 1.
The parameter values used were µset = 0.07 h−1 (set growth rate), YX/S =
1 g g−1
setglycerol f setexp[ ( )]f
X S
r X t tY
(1)
(biomass yield coefficient on glycerol (experimental values are from 0.88 to 0.97
g g−1) and Xf = 38.5 g L−1 (expected cell density at the time of feeding start tf).
The initial rate was hence 2.7 g L−1 h−1.
For induction of scFv expression by methanol, the glycerol feeding was
stopped and the methanol concentration was increased in three steps to final
concentrations of 0.1%, 0.3%, and 0.5% (v/v) (for a set point concentration of
0.3%), additional steps of 1% and 2% (for a set point concentration of 1%), 3%
(for a set point concentration of 3%), while waiting for complete consumption of
previously added methanol between the additions. The recorded resistance values
were used to calibrate the methanol sensor (Alkosens electrode and Acetomat
controller, Heinrich Frings GmbH, Bonn, Germany). Afterwards, the methanol
concentration was controlled to the concentration indicated in the results section.
The methanol reservoir was placed on a balance to keep track of methanol
consumption.
29
3.4 Purification of the scFv
After cell removal by centrifugation, the pH value of the supernatant was adjusted
to 7.9 with 3 M K2HPO4. After overnight incubation with Ni-charged “His-Bind
resin” (Novagen, Madison, WI) the His-Bind resin was transferred to plastic
columns, washed with 5 vol. of 500 mM NaCl, 20 mM Tris-HCl pH 7.9, 5 mM
imidazol, and the scFv was eluted with 500 mM NaCl, 20 mM Tris-HCl pH 7.9,
500 mM imidazol. The eluate was extensively dialyzed against solutions of
decreasing NaCl concentrations (finally 1 mM NaCl) and lyophilised.
3.5 Cell density analysis
For cell density determination, 1.5 mL of culture was centrifuged in pre-weighed
Eppendorf tubes. Cell fresh weight (CFW) was determined after removal of
supernatant and cell dry weight (CDW) after drying at 60 °C for 48 hours. The
culture volume V was estimated from the initial volume V0 and mass of added
glycerol mglycerol and methanol mMeOH, neglecting density differences and volume
contraction (eq. 2)
0 glycerol methanolV V m m . (2)
3.6 scFv analysis
The concentration of scFv was quantified by ELISA in 96-well plates coated with
F4 fimbriae using an anti-His6 monoclonal antibody for detection. For ELISA
assay, fimbriae from E. coli F4 were purified following the thermal shock
procedure, re-suspended in PBS buffer (10 mM phosphate buffer, 150 mM NaCl)
and coated to 96-well microtitre plates (Nunc, Wiesbaden, Germany) overnight at
4 °C at 1 µg per well in carbonate buffer (pH 9.6). Wells were washed three times
with PBS buffer, blocked with 3% bovine serum albumin (BSA) in PBS buffer for
one hour, and washed again. Culture samples containing 3% BSA were added to
the wells and incubated for 2 h, followed by washing with PBS containing 0.05%
Tween®20 (Sigma) and washing three times with PBS. After incubation with anti-
polyhistidine the anti-mouse IgG horseradish-peroxidase conjugate (HRP) was
added to the wells. Bound antibody was detected with 1 mg mL−1 APTS (2,2’-
Azino-di-[3-ethylbenzthiazoline sulfonate] diammonium salt; Roche, Mannheim,
Germany) in 10 mM sodium acetate, 5 mM sodium hydrogen phosphate pH 4.2,
30
0.01% H2O2. The substrate turnover was measured at 405 nm in an ELISA-reader
(Tecan Spectra Image, Tecan, Crailsheim, Germany).
31
4 Research contribution
This chapter describes the results to all four research questions. Each research
question is answered through one article in a separate subchapter. The key results
of the original articles are summarised in these subchapters.
4.1 The effects of reduced oxygen supply on production process
Research Question 1 is answered through the results published in Article I
describing the effects of reduced oxygen supply on the production of single-chain
antibody fragment (scFv) by recombinant P. pastoris.
Two process conditions for the production of a scFv with P. pastoris were
compared. In the first experiment, dissolved oxygen (DO) concentration was
maintained by controlling stirrer speed and air flow, whereas additional pure
oxygen was fed in the second experiment.
4.1.1 Cultivation without addition of pure oxygen
A single-chain antibody fragment (scFv) was produced with recombinant Pichia
pastoris in a bioreactor having 6 L basal salt medium (BSM). When glycerol in
the medium is depleted, a limited glycerol feeding phase with a set specific
growth rate (µset) of 0.07 h−1 was started. This feeding lasted for about 2 hours.
The idea of this step was to de-repress the AOX1 promoter and make cells ready
for the induction. The cells were induced by feeding methanol into the reactor.
The concentration of methanol was raised stepwise to 2% (v/v) and afterwards
maintained at 1% with the help of an online methanol probe and control unit. The
dissolved oxygen concentration (DO) is set to 40% and achieved by increasing
first stirrer speed from 300 to 1200 rpm, followed by air flow rate from 2‒16
L min−1 (0.33 to 2.66 vvm). Only normal aeration is used as oxygen source and
additional pure oxygen were not employed. The process parameters of the
cultivation are shown in Fig. 1.
32
Table 1. Fig. 1. Growth and substrate uptake profiles without addition of pure oxygen.
(A) Growth profile monitored by CFW ( ) and CDW (O). (B) Specific growth rate. (C)
Gravimetric (thick line) and specific (thin line) feeding rates of methanol. (D) Dissolved
oxygen saturation (solid line), flow rate of air (dotted line), and oxygen uptake rate
(thick solid line). Time is given relative to induction. (I, published by permission of
John Wiley and Sons).
Fig. 1D shows that DO could not be maintained to 40% throughout the cultivation
as no additional pure oxygen is supplied. The methanol flow rate remained near
constant at about 55–65 g h−1 (Fig. 1C). Cell fresh weight (CFW) of 357 g L−1
corresponding to 116 g L−1 dry weight was reached at the end of cultivation with
a specific growth rate of 0.015 h−1 (Fig. 1A and B). The specific methanol-uptake
rate reached a maximum of 58 g g−1 h−1 at 10 h after induction but started
decreasing afterwards. The scFv was purified from culture supernatant by single
step His affinity chromatography and lyophilised afterwards. In this experiment, a
total of 1065 mg lyophilised scFv was obtained, thus yielding a productivity 27.3
mg h−1.
33
4.1.2 Cultivation with addition of pure oxygen
In this experiment pure oxygen was supplemented with inlet air to maintain the
dissolved oxygen concentration in the bioreactor. By this method, oxygen
limitation could be avoided and methanol-uptake rate reached a maximum of 200
g h−1 as shown in Fig. 2C.
Fig. 2. Growth and substrate uptake profiles with addition of pure oxygen. (A) Growth
profile monitored by CFW ( ) and CDW (O). (B) Specific growth rate. (C) Volumetric
(thick line) and specific (thin line) feeding rates of methanol. (D) Dissolved oxygen
saturation (solid line), flow rate of air (dotted line), and oxygen (dashed line). Time is
given relative to induction. (I, published by permission of John Wiley and Sons).
About 7 h after induction, the specific growth rate of 0.05 h−1 was observed and
maintained within ± 0.02 for 20 hours. The cell density at that time was 425 g L−1
fresh weight or 125 g L−1 dry weight (Fig. 2A and B). The specific methanol-
uptake rate reached maximum of 0.075 g g−1 h−1 at 10–20 h after induction, as the
biomass increased faster than the volumetric methanol consumption rate (Fig. 2C).
When the maximum oxygen transfer capacity was reached 15 h after induction,
the DO dropped to 10% saturation (Fig. 2D). About 22‒24 h after induction, DO
34
concentration increased steadily and ultimately oxygen and methanol
consumption deceased after 30 h induction (Fig. 2C and D). In this experiment, a
total 688 mg lyophilised scFv was obtained, thus yielding productivity of 21.1
mg h−1.
4.1.3 Discussion relating to Research Question 1
Two process conditions for the production of a single-chain antibody fragment
with P. pastoris were compared. In the first experiment, dissolved oxygen (DO)
was maintained by stirrer speed and air flow, whereas additional pure oxygen was
fed in the second experiment.
The product accumulation was fastest in the oxygen supplemented culture. It
is known that higher methanol consumption rates can accelerate production
(Curvers et al. 2001, Jahic et al. 2002). This is the case even with optimum
production with lower specific growth or methanol-uptake rates (Hong et al. 2002,
Cunha et al. 2004). But no impact of methanol-uptake rates on production has
been observed (Trinh et al. 2003). In this study, however, the final product yield
was not primarily determined by the synthesis rates. Rather, fast addition of
methanol compromised the stability of the oxygen-supplemented process, and a
small fluctuation in the feeding rate was followed by complete arrest of
respiration. The metabolic problems during the fast methanol addition prevented
growth and production already 54 h after induction, and the final purified scFv
was only 670 mg. Without oxygen supply, in contrast, production proceeded
smoothly, yielding about 1 g of lyophilised scFv 40 h after induction. Thus,
whereas oxygen limitation did not stop scFv accumulation, similar to the
production of other proteins (Hellwig et al. 2001), the process stability was
negatively affected by fast methanol consumption.
4.2 The impact of methanol concentration on scFv production under oxygen-limited conditions
Research Question 2 is answered through the results published in Article II
describing the impact of methanol concentration on scFv production in oxygen-
limited conditions.
A single-chain antibody fragment (scFv) was produced with recombinant
P. pastoris and secreted to the medium. After the batch phase, glycerol was fed at
35
limiting rate for 2–4 h to de-repress the AOX1 promoter. For induction of the scFv
production, the methanol concentration was increased stepwise to 0.1, 0.3, and
0.5% (v/v) (for a set point concentration of 0.3%), additional steps of 1% and 2%
(for a set point concentration of 1%), 3% (for a set point concentration of 3%),
and complete consumption was allowed between the pulses to adapt the cells to
methanol metabolism as illustrated in Fig. 3C.
Fig. 3. Growth and product formation at different methanol concentrations.
Recombinant gene expression was induced and the methanol concentration was
controlled to 0.3% (v/v) (circles, dotted lines), 1% (triangles, solid lines) or 3%
(squares, dashed lines). Time is given relative to the time of induction tind. (A) CFW
was measured offline (symbols) and estimated from online data (lines). (B) Product
concentration in the culture supernatant was determined by quantitative ELISA
(symbols). For the cultivation with 0.3%, a trendline is given reflecting the production
profiles for several similar cultivations. (C) The methanol concentration was measured
by methanol sensor in the culture broth. (D) Dissolved oxygen saturation was
measured by an Ingold sensor. (II, published by permission of John Wiley and Sons).
The cell densities during the production phase of cultivations with higher
methanol concentrations were low compared to the cultivation at 0.3% methanol
concentration (Fig. 3A). Product accumulation, however, was considerably
accelerated; especially, the production could be maintained at high rates until the
end of the cultivation as shown in Fig. 3B. The final product concentration
36
exceeded 150 mg L−1 with 1% methanol, and with 3% methanol reached 350
mg L−1 already 50 h after induction compared to 60 mg L−1 with 0.3% methanol
cultivations.
4.2.1 Discussion relating to Research Question 2
The impact of methanol concentration on the metabolism of recombinant
P. pastoris and on the production of a single-chain antibody fragment was
examined under oxygen limitation. Three and six times higher product
concentrations were found with methanol concentrations of 1 and 3% (v/v)
respectively, than with a low methanol concentration of 0.3%. Hence, not only the
specific production rate was improved at higher methanol concentrations, as
observed under oxygen-sufficient conditions (Katakura et al. 1998, Zhang et al.
2000a), but also the final product concentrations were enhanced. The biomass
yield, conversely, was lower at high methanol concentrations.
High methanol concentrations increase the selectivity of methanol conversion
to the recombinant protein by avoiding gratuitous biomass formation during the
production phase. Thereby, the specific methanol-uptake rate is maintained well
above the maintenance demand, and the active production phase prolonged. The
negative impact of low oxygen concentration can be compensated by higher
methanol concentration, improving the product quantity and quality. Thus,
efficient production of secreted proteins by recombinant P. pastoris under oxygen
limitation is possible, and as shown in Article II, high methanol concentrations
can mitigate the requirements for additional supply of pure oxygen.
4.3 The effects of long glycerol feeding on scFv production under oxygen-sufficient conditions
Research Question 3 is answered through the results published in Article III
describing the effects of long glycerol feeding on scFv production in Pichia
pastoris under oxygen-sufficient conditions.
Fed-batch cultivations were performed to study the impact of the duration of
the glycerol feeding under oxygen-sufficient conditions on the production process.
In all cultivations, after a batch phase on glycerol, additional glycerol was fed
exponentially at set growth rate of µset = 0.07 h−1. The duration of this feeding
was 2 h, 12 h, or 18 h as shown in Fig. 4C. The cell fresh weight at the end of this
phase reached 130, 216, and 270 g L−1 as shown in Fig. 4A. After induction by
37
switching to methanol, the volumetric methanol addition rate needed to maintain
a constant methanol concentration in the broth (0.3% v/v) was used as shown in
Fig. 4D.
At time point tf 30 hours (since glycerol feeding started), the maximum
methanol-uptake rate (rMeOH) of 235 g h−1 was observed in cultivation with a
shorter glycerol feeding phase whereas the cultivation with the longest glycerol
feeding phase reached only half as much, rMeOH = 115 g h−1. While more than
8000 L (0.5 vvm) pure oxygen was necessary to maintain a constant DO in the
early-induced culture, only 2200 L (0.2 vvm) was consumed with late induction.
Fig. 4. Impact of an extended glycerol feeding phase on the scFv production profiles.
After the batch phase, glycerol was fed for 2 h (triangles, dashed lines), 12 h (squares,
dotted lines), or 18 h (circles, solid lines) before induction of scFv production
(methanol induction points indicated by vertical lines). (A) Cell fresh weight CFW; (B)
scFv concentrations (functional product) as determined by quantitative ELISA;
(C) glycerol flow rates; (D) methanol flow rates. Time is given relative to the start time
of glycerol feeding, tf. The line indicates the trend of the experimental data. (III,
published by permission of John Wiley and Sons).
Quantitative analysis of the functional scFv by ELISA showed that the product
started accumulating 14 hours after induction with the 2 h glycerol feeding
experiment, whereas the product was found already 5 h after induction with 12 h
38
glycerol feeding, and immediately with 18 h glycerol feeding (Fig. 4B). The scFv
concentrations showed similar profiles in all three cultivation runs (Fig. 4B).
4.3.1 Discussion relating to Research Question 3
Limiting feeding of glycerol to de-repress the AOX1 gene prior to the addition of
methanol is known to be beneficial for an efficient uptake of methanol and
induction of the AOX1 promoter (Jahic et al. 2002), and therefore a short glycerol
feeding phase is mostly applied in P. pastoris fed-batch cultivations. Here, we
examined how the production of the scFv fragment under aerobic conditions is
affected by prolonged glycerol feeding followed by methanol feeding to maintain
constant methanol feeding inside the reactor.
In entirely aerobic cultivations, the accumulation of scFv in the culture
supernatant was delayed for 10–20 hours with the standard 2 hours glycerol
feeding procedure, whereas after prolonged glycerol feeding, immediate product
accumulation was achieved. The sum of duration of the glycerol feeding phase
and the product-lag phase after induction was about constant. The same final
product yield and similar high quality, i.e. low degradation, of secreted scFv
fragment were achieved after the same total length of a process. Advantages of
the prolonged glycerol feeding strategy include very significant savings of
methanol and pure oxygen of about 75%, and a 23% lower cell density which
facilitates the downstream purification process.
4.4 Controlling methanol-uptake for improved production of a scFv
Research Question 4 is answered through the results published in Article IV
describing the control of specific methanol-uptake rate for improved production
of a scFv in Pichia pastoris.
In previous cultivation conditions, it is observed that despite full aeration, the
dissolved oxygen saturation (DO) decreased to limiting levels after induction (Fig.
1D). To ensure efficient production under oxygen limitation, a high methanol
concentration was important. With a methanol concentration of 3% (v/v), a final
product concentration of 350 mg L−1 was obtained (Fig. 3B). The volumetric
methanol-uptake rate was constant, as it was determined by the oxygen transfer
capacity of the reactor. Therefore, with increasing cell densities, the specific
methanol-uptake rate qMeOH decreased from more than 0.05 g g−1 h−1 after the
adaptation phase to 0.02 g g−1 h−1 as shown in Fig. 5. The scFv production starts
39
only after a lag phase; the start of scFv accumulation coincided with a qMeOH of
0.02‒0.03 g g−1 h−1. Therefore, the methanol-uptake rate was lowered into the
optimum range from early after induction. Two approaches to control the specific
uptake rate were studied.
Fig. 5. Actual specific methanol-uptake rates. Specific methanol-uptake rates are
compared for cultivations with short glycerol feeding and full aeration throughout the
production phase with 3% methanol feeding (Khatri & Hoffmann 2006a) (thick lines,
Fig. 3), with prolonged glycerol feeding (thin solid lines, Fig. 6) and with restricted air
supply (thin dashed lines, Fig. 8). Time is given relative to the time of induction tind. (IV,
published by permission of Springer Science + Business Media).
Prolonged glycerol feeding
Initially, the specific methanol-uptake rate qMeOH can be controlled by the amount
of biomass present at the time of induction. The glycerol feeding phase before
induction was extended to 16 h (Fig. 6A), during which time glycerol was fed
with exponentially increasing rate, enabling growth with a constant specific
growth rate of 0.07 h−1. The cell density (CFW) reached 245 g L−1 at the time of
induction (Fig. 6C). After induction, the oxygen saturation fell to limiting levels
within 5 h despite full aeration (Fig. 6B). The specific methanol-uptake rate
showed a declining trend due to cell growth, but remained close to 0.02 g g−1 h−1
during the whole production phase (Fig. 5).
40
Fig. 6. Cultivation of Pichia pastoris with extended glycerol feeding phase. After batch
and 16 h fed-batch phase on glycerol, recombinant protein production was induced by
methanol. (A) The glycerol flow rate (thick lines) and methanol concentration (thin
lines). (B) The dissolved oxygen concentration (DO thin line), the airflow rate (thick
line). (C) The cell fresh weight (CFW). Time is given relative to the time of induction tind
(indicated by vertical lines). Solid and dashed lines, open and solid symbols, present
two independent cultivations. (IV, published by permission of Springer Science +
Business Media).
In contrast to cultivations with shorter glycerol feeding, product accumulation
started immediately after addition of methanol (Fig. 7A). The specific production
rate was constantly 80 mg kg−1 h−1 throughout the whole production phase (Fig.
7A). After three days of production, 2500 mg L−1 of scFv per culture supernatant
were obtained (Fig. 7A).
41
Fig. 7. Production of scFv under deliberate oxygen-limited control of the specific
methanol-uptake rate. The concentration of the recombinant single-chain antibody
fragment (scFv) in the culture supernatant was determined by quantitative ELISA
(circles). Specific production rates qP (triangles). (A) Production after extended
glycerol feeding phase in the cultivations of Fig. 6. (B) Production with restricted air
supply in the cultivations of Fig. 8. Lines are drawn to interpret the trend. Time is
given relative to the time of induction tind. Open and solid symbols present two
independent cultivations. (IV, published by permission of Springer Science + Business
Media).
Restricted air supply
In another approach to control the specific methanol-uptake rate during
production at low cell densities, the air flow rate was set to 0.8 vvm upon
induction, and was increased with an exponential profile proportional to exp
(0.03 h−1 * (t – tind)) (Fig. 8B). The DO consequently was below 10% during the
entire production phase (Fig. 8B). The cell density (CFW) increased from 135
g L−1 at induction to 300 g L−1 after three days (70 h) of production (Fig. 8C). The
specific methanol-uptake rate decreased from 0.04 g g−1 h−1 immediately after the
adaptation phase, to 0.02 g g−1 h−1 (Fig. 5).
42
Fig. 8. Cultivation of Pichia pastoris with restricted air supply. After batch and 4 h fed-
batch phase on glycerol, recombinant protein production was induced by methanol.
(A) The glycerol flow rate (thick lines), methanol concentration (thin lines), and (B)
dissolved oxygen saturation (DO thin line). The air flow rate (thick line) was controlled
to a predetermined profile. (C) The cell fresh weight (CFW). Time is given relative to
the time of induction tind (indicated by vertical lines). Solid and dashed lines, open and
solid symbols, present two independent cultivations. (IV, published by permission of
Springer Science + Business Media).
The product scFv accumulated in the culture supernatant only after a lag phase of
20 h after induction (Fig. 7B). The specific production rate was almost constant
during the next 50 h of production, averaging at 250 mg g−1 h−1 (Fig. 5B). This is
5‒8 times faster than in the culture with full aeration, in which the scFv
accumulated with an average specific production rate qP of 30–50 mg kg−1 h−1).
Likewise, qP was 2‒3 times faster as in the cultivations with long glycerol feeding
(Fig. 7A). After 70 h of production under restricted air supply, final product
concentrations of 3500 mg L−1 were reached (Fig. 7B).
43
4.4.1 Discussion relating to Research Question 4
Under oxygen limitation, the scFv accumulated in the culture supernatant only
after a lag phase of one day. During this time span, the specific methanol-uptake
rate declined from 0.06 g g−1 h−1 to 0.02 g g−1 h−1. The latter value optimises
recombinant protein production in methanol-limited fed-batch, chemostat, and
with methanol concentrations controlled to low levels (Zhang et al. 2000a,
d'Anjou & Daugulis 2001, Zhou & Zhang 2002, Trinh et al. 2003, Bushell et al.
2003, Sinha et al. 2003, Cunha et al. 2004). Therefore, the specific methanol-
uptake rate was controlled to lower values immediately after induction. Two
approaches were used, and both resulted in high product yields. Both approaches
differed, however, with respect to the starting time and rate of product
accumulation.
Three advantages stand out from the practical point of view: First, single-
chain antibody fragment titres in the gram-per-litre range were obtained, as in a
few other studies (Freyre et al. 2000, Damasceno et al. 2004), whereas scFv
product levels are usually in range of 50–250 mg L−1 (Fischer et al. 1999). The
specific production rate was increased to 250 mg kg−1 h−1, and final product
concentrations reached 3.5 g L−1. Second, the methanol-uptake can be controlled
even with products that suffer from degradation or modification during limiting
feeding of methanol (Zhou & Zhang 2002, Jahic et al. 2003, Trentmann et al.
2004). Third, problems related to insufficient oxygen transfer capacities in large
scale that cannot meet the high oxygen demand during protein production on
methanol (Curvers et al. 2001) can impede production (Cereghino et al. 2002,
Bushell et al. 2003, Lee et al. 2003a); the drawback of low oxygen transfer rate
can be circumvented by using deliberate oxygen limitation to control the
production process. Oxygen limitation may be superior to methanol limitation
with respect to release of host proteins, even if air is provided with maximum rate
(Charoenrat et al. 2005). Thus, oxygen-limited control of the methanol-uptake is a
versatile tool to optimise secreted protein production with recombinant P. pastoris.
44
45
5 Conclusions
In this doctoral dissertation, a process was developed for a single-chain antibody
fragment (scFv) production in methylotrophic yeast, Pichia pastoris. The product
levels of 3.5 g L−1 scFv in culture supernatant were achieved and production
process was designed without additional need of pure oxygen, thus relieving
safety requirements and lowering the amount of methanol fed into the bioreactor.
Key findings of the thesis were as follows:
1. Reduced oxygen supply by using only air for aeration contributed to the
robustness of the production process and resulted in the highest yield of
purified scFv. This is beneficial, as no additional oxygen is required and
therefore mixing issues and safety concerns regarding oxygen-handling, in
large-scale facilities, are relieved.
2. Efficient recombinant protein production under oxygen limitations requires
high methanol concentration. Both specific production rate and final product
level are enhanced under those process conditions.
3. Long-limiting glycerol feeding before induction under oxygen-sufficient
conditions not only increased volumetric productivity but also reduced the
need of methanol and oxygen by 75%. Additionally, final cell densities are
lower, thus reducing costs during the purification process.
4. Two strategies of (i) long glycerol feeding and (ii) limited aeration have been
demonstrated to control the specific substrate-uptake rate that has been found
optimal in substrate-limited processes. Both strategies resulted in a tenfold
increase in the final product concentration.
The process developed for scFv in this study can potentially be used for other
proteins expressed in P. pastoris. In other words, the process developed during
this doctoral research can prove beneficial for both academia and industry having
interests in expressing proteins in P. pastoris. The methanol-uptake control
strategy is beneficial for those products that suffer from degradation or
modification during limiting feeding of methanol.
46
47
References
Abad S, Nahalka J, Winkler M, Bergler G, Speight R, Glieder A & Nidetzky B (2011) High-level expression of Rhodotorula gracilis D-amino acid oxidase in Pichia pastoris. Biotechnol Lett 33: 557–563.
Boer H, Teeri TT & Koivula A (2000) Characterization of Trichoderma reesei cellobiohydrolase Cel7A secreted from Pichia pastoris using two different promoters. Biotechnol Bioeng 69: 486–494.
Bollok M, Resina D, Valero F & Ferrer P (2009) Recent patents on the Pichia pastoris expression system: expanding the toolbox for recombinant protein production. Recent Pat Biotechnol 3: 192–201.
Brierley RA, Bussineau C, Kosson R, Melton A & Siegel RS (1990) Fermentation development of recombinant Pichia pastoris expressing the heterologous gene: bovine lysozyme. Ann N Y Acad Sci 589: 350–362.
Bushell ME, Rowe M, Avignone-Rossa CA & Wardell JN (2003) Cyclic fed-batch culture for production of human serum albumin in Pichia pastoris. Biotechnol Bioeng 82: 678–683.
Cai H, Chen L, Wan L, Zeng L, Yang H, Li S, Li Y, Cheng J & Lu X (2009) High-level expression of a functional humanized anti-CTLA4 single-chain variable fragment antibody in Pichia pastoris. Appl Microbiol Biotechnol 82: 41–48.
Cereghino GP, Cereghino JL, Ilgen C & Cregg JM (2002) Production of recombinant proteins in fermenter cultures of the yeast Pichia pastoris. Curr Opin Biotechnol 13: 329–332.
Cereghino JL & Cregg JM (2000) Heterologous protein expression in the methylotrophic yeast Pichia pastoris. FEMS Microbiol Rev 24: 45–66.
Chang HJ, Choi SW & Chun HS (2008) Expression of functional single-chain variable domain fragment antibody (scFv) against mycotoxin zearalenone in Pichia pastoris. Biotechnol Lett 30: 1801–1806.
Charoenrat T, Ketudat-Cairns M, Stendahl-Andersen H, Jahic M & Enfors SO (2005) Oxygen-limited fed-batch process: an alternative control for Pichia pastoris recombinant protein processes. Bioprocess Biosyst Eng 27: 399–406.
Chiruvolu V, Cregg JM & Meagher MM (1997) Recombinant protein production in an alcohol oxidase-defective strain of Pichia pastoris in fedbatch fermentations. Enzyme Microb Technol 21: 277–283.
Cos O, Ramon R, Montesinos JL & Valero F (2006a) Operational strategies, monitoring and control of heterologous protein production in the methylotrophic yeast Pichia pastoris under different promoters: a review. Microb Cell Fact 5: 17.
Cos O, Ramon R, Montesinos JL & Valero F (2006b) A simple model-based control for Pichia pastoris allows a more efficient heterologous protein production bioprocess. Biotechnol Bioeng 95: 145–154.
Cos O, Resina D, Ferrer P, Montesinos JL & Valero F (2005) Heterologous production of Rhizopus oryzae lipase in Pichia pastoris using the alcohol oxidase and formaldehyde dehydrogenase promoters in batch and fed-batch cultures. Biochem Eng J 26: 86–94.
48
Couderec R & Baretti J (1980) Oxidation of Methanol by the Yeast, Pichia pastoris. Purification and Properties of the Alcohol Oxidase. Agric Biol Chem 44: 2279–2289.
Cregg JM, Tschopp JF, Stillman C, Siegel R, Akong M, Craig WS, Buckholz RG, Madden KR, Kellaris PA, Davis GR, Smiley BL, Cruze J, Torregrossa R, Velicelebi G & Thill GP (1987) High-Level Expression and Efficient Assembly of Hepatitis B Surface Antigen in the Methylotrophic Yeast, Pichia pastoris. Nat Biotech 5: 479–485.
Cunha AE, Clemente JJ, Gomes R, Pinto F, Thomaz M, Miranda S, Pinto R, Moosmayer D, Donner P & Carrondo MJ (2004) Methanol induction optimization for scFv antibody fragment production in Pichia pastoris. Biotechnol Bioeng 86: 458–467.
Curvers S, Brixius P, Klauser T, Thommes J, Weuster-Botz D, Takors R & Wandrey C (2001) Human chymotrypsinogen B production with Pichia pastoris by integrated development of fermentation and downstream processing. Part 1. Fermentation. Biotechnol Prog 17: 495–502.
d'Anjou MC & Daugulis AJ (2001) A rational approach to improving productivity in recombinant Pichia pastoris fermentation. Biotechnol Bioeng 72: 1–11.
Damasceno LM, Pla I, Chang HJ, Cohen L, Ritter G, Old LJ & Batt CA (2004) An optimized fermentation process for high-level production of a single-chain Fv antibody fragment in Pichia pastoris. Protein Expr Purif 37: 18–26.
De Schutter K, Lin YC, Tiels P, Van Hecke A, Glinka S, Weber-Lehmann J, Rouze P, Van de PY & Callewaert N (2009) Genome sequence of the recombinant protein production host Pichia pastoris. Nat Biotechnol 27: 561–566.
Delroisse JM, Dannau M, Gilsoul JJ, El Mejdoub T, Destain J, Portetelle D, Thonart P, Haubruge E & Vandenbol M (2005) Expression of a synthetic gene encoding a Tribolium castaneum carboxylesterase in Pichia pastoris. Protein Expr Purif 42: 286–294.
Demain AL & Vaishnav P (2009) Production of recombinant proteins by microbes and higher organisms. Biotechnol Adv 27: 297–306.
Döring F, Klapper M, Theis S & Daniel H (1998) Use of the glyceraldehyde-3-phosphate dehydrogenase promoter for production of functional mammalian membrane transport proteins in the yeast Pichia pastoris. Biochem Biophys Res Commun 250: 531–535.
Eldin P, Pauza ME, Hieda Y, Lin G, Murtaugh MP, Pentel PR & Pennell CA (1997) High-level secretion of two antibody single chain Fv fragments by Pichia pastoris. J Immunol Methods 201: 67–75.
Fischer R, Drossard J, Emans N, Commandeur U & Hellwig S (1999) Towards molecular farming in the future: Pichia pastoris-based production of single-chain antibody fragments. Biotechnol Appl Biochem 30(Pt 2): 117–120.
Freyre FM, Vazquez JE, Ayala M, Canaan-Haden L, Bell H, Rodriguez I, Gonzalez A, Cintado A & Gavilondo JV (2000) Very high expression of an anti-carcinoembryonic antigen single chain Fv antibody fragment in the yeast Pichia pastoris. J Biotechnol 76: 157–163.
49
Guarna MM, Lesnicki GJ, Tam BM, Robinson J, Radziminski CZ, Hasenwinkle D, Boraston A, Jervis E, MacGillivray RTA, Turner RFB & Kilburn DG (1997) On-line monitoring and control of methanol concentration in shake-flask cultures of Pichia pastoris. Biotechnol Bioeng 56: 279–286.
Gurramkonda C, Adnan A, Gabel T, Lunsdorf H, Ross A, Nemani SK, Swaminathan S, Khanna N & Rinas U (2009) Simple high-cell density fed-batch technique for high-level recombinant protein production with Pichia pastoris: Application to intracellular production of Hepatitis B surface antigen. Microb Cell Fact 8: 13.
Gurramkonda C, Polez S, Skoko N, Adnan A, Gabel T, Chugh D, Swaminathan S, Khanna N, Tisminetzky S & Rinas U (2010) Application of simple fed-batch technique to high-level secretory production of insulin precursor using Pichia pastoris with subsequent purification and conversion to human insulin. Microb Cell Fact 9: 31.
Hasslacher M, Schall M, Hayn M, Bona R, Rumbold K, Luckl J, Griengl H, Kohlwein SD & Schwab H (1997) High-level intracellular expression of hydroxynitrile lyase from the tropical rubber tree Hevea brasiliensis in microbial hosts. Protein Expr Purif 11: 61–71.
He X, Liu N, Li W, Zhang Z, Zhang B & Ma Y (2008) Inducible and constitutive expression of a novel thermostable alkaline -mannanase from alkaliphilic Bacillus sp. N16–5 in Pichia pastoris and characterization of the recombinant enzyme. Enzyme Microb Technol 43: 13–18.
Hellwig S, Emde F, Raven NP, Henke M, van Der LP & Fischer R (2001) Analysis of single-chain antibody production in Pichia pastoris using on-line methanol control in fed-batch and mixed-feed fermentations. Biotechnol Bioeng 74: 344–352.
Hong F, Meinander NQ & Jonsson LJ (2002) Fermentation strategies for improved heterologous expression of laccase in Pichia pastoris. Biotechnol Bioeng 79: 438–449.
Hu XQ, Chu J, Zhang Z, Zhang SL, Zhuang YP, Wang YH, Guo MJ, Chen HX & Yuan ZY (2008) Effects of different glycerol feeding strategies on S-adenosyl-l-methionine biosynthesis by PGAP-driven Pichia pastoris overexpressing methionine adenosyltransferase. J Biotechnol 137: 44–49.
Huang CJ, Damasceno LM, Anderson KA, Zhang S, Old LJ & Batt CA (2011) A proteomic analysis of the Pichia pastoris secretome in methanol-induced cultures. Appl Microbiol Biotechnol 90: 235–247.
Inan M & Meagher MM (2001) The effect of ethanol and acetate on protein expression in Pichia pastoris. The Society for Biotechnology, Japan 92: 337–341.
Jafari R, Sundstrom BE & Holm P (2011) Optimization of production of the anti-keratin 8 single-chain Fv TS1–218 in Pichia pastoris using design of experiments. Microb Cell Fact 10: 34.
Jahic M, Rotticci-Mulder JC, Martinelle M, Hult K & Enfors SO (2002) Modeling of growth and energy metabolism of Pichia pastoris producing a fusion protein. Bioprocess Biosyst Eng 24: 385–393.
Jahic M, Veide A, Charoenrat T, Teeri T & Enfors SO (2006) Process technology for production and recovery of heterologous proteins with Pichia pastoris. Biotechnol Prog 22: 1465–1473.
50
Jahic M, Wallberg F, Bollok M, Garcia P & Enfors SO (2003) Temperature limited fed-batch technique for control of proteolysis in Pichia pastoris bioreactor cultures. Microb Cell Fact 2: 6.
Jung YK & Lee SY (2011) Efficient production of polylactic acid and its copolymers by metabolically engineered Escherichia coli. J Biotechnol 151: 94–101.
Jungo C, Marison I & von Stockar U (2007) Regulation of alcohol oxidase of a recombinant Pichia pastoris Mut+ strain in transient continuous cultures. J Biotechnol 130: 236–246.
Katakura Y, Zhang W, Zhuang G, Omasa T, Kishimoto M, Goto Y & Suga KI (1998) Effect of methanol concentration on the production of human beta2-glycoprotein I domain V by a recombinant Pichia pastoris: A simple system for the control of methanol concentration using a semiconductor gas sensor. J Ferment Bioeng 86: 482–487.
Khatri NK & Hoffmann F (2006) Impact of methanol concentration on secreted protein production in oxygen-limited cultures of recombinant Pichia pastoris. Biotechnol Bioeng 93: 871–879.
Kim SJ, Lee JA, Kim YH & Song BK (2009) Optimization of the functional expression of Coprinus cinereus peroxidase in Pichia pastoris by varying the host and promoter. J Microbiol Biotechnol 19: 966–971.
Lee CY, Lee SJ, Jung KH, Katoh S & Lee EK (2003a) High dissolved oxygen tension enhances heterologous protein expression by recombinant Pichia pastoris. Process Biochem 38: 1147–1154.
Lee CY, Nakano A, Shiomi N, Lee EK & Katoh S (2003b) Effects of substrate feed rates on heterologous protein expression by Pichia pastoris in DO-stat fed-batch fermentation. Enzyme Microb Technol 33: 358–365.
Li SY, Srivastava R, Suib SL, Li Y & Parnas RS (2011) Performance of batch, fed-batch, and continuous A-B-E fermentation with pH-control. Bioresour Technol 102: 4241–4250.
Lim HK, Choi SJ, Kim KY & Jung KH (2003) Dissolved-oxygen-stat controlling two variables for methanol induction of rGuamerin in Pichia pastoris and its application to repeated fed-batch. Appl Microbiol Biotechnol 62: 342–348.
Liu Y, Koh CM & Ji L (2011) Bioconversion of crude glycerol to glycolipids in Ustilago maydis. Bioresour Technol 102: 3927–3933.
Lopez-Cuellar MR, Alba-Flores J, Rodriguez JN & Perez-Guevara F (2011) Production of polyhydroxyalkanoates (PHAs) with canola oil as carbon source. Int J Biol Macromol 48: 74–80.
Macauley-Patrick S, Fazenda ML, McNeil B & Harvey LM (2005) Heterologous protein production using the Pichia pastoris expression system. Yeast 22: 249–270.
Mattanovich D, Callewaert N, Rouze P, Lin YC, Graf A, Redl A, Tiels P, Gasser B & De Schutter K (2009a) Open access to sequence: browsing the Pichia pastoris genome. Microb Cell Fact 8: 53.
51
Mattanovich D, Graf A, Stadlmann J, Dragosits M, Redl A, Maurer M, Kleinheinz M, Sauer M, Altmann F & Gasser B (2009b) Genome, secretome and glucose transport highlight unique features of the protein production host Pichia pastoris. Microb Cell Fact 8: 29.
Minning S, Serrano A, Ferrer P, Solá C, Schmid RD & Valero F (2001) Optimization of the high-level production of Rhizopus oryzae lipase in Pichia pastoris. J Biotechnol 86: 59–70.
Oliveira R, Clemente JJ, Cunha AE & Carrondo MJT (2005) Adaptive dissolved oxygen control through the glycerol feeding in a recombinant Pichia pastoris cultivation in conditions of oxygen transfer limitation. J Biotechnol 116: 35–50.
Pal Y, Khushoo A & Mukherjee K (2006) Process optimization of constitutive human granulocyte-macrophage colony-stimulating factor (hGM-CSF) expression in Pichia pastoris fed-batch culture. Appl Microbiol Biotechnol 69: 650–657.
Panjideh H, Coelho V, Dernedde J, Fuchs H, Keilholz U, Thiel E & Deckert PM (2008) Production of bifunctional single-chain antibody-based fusion proteins in Pichia pastoris supernatants. Bioprocess Biosyst Eng 31: 559–568.
Parawira W & Tekere M (2011) Biotechnological strategies to overcome inhibitors in lignocellulose hydrolysates for ethanol production: review. Crit Rev Biotechnol 31: 20–31.
Park JH, Kim TY, Lee KH & Lee SY (2011) Fed-batch culture of Escherichia coli for L-valine production based on in silico flux response analysis. Biotechnol Bioeng 108: 934–946.
Pla IA, Damasceno LM, Vannelli T, Ritter G, Batt CA & Shuler ML (2006) Evaluation of Mut+ and MutS Pichia pastoris phenotypes for high level extracellular scFv expression under feedback control of the methanol concentration. Biotechnol Prog 22: 881–888.
Potvin G, Ahmad A & Zhang Z (2010) Bioprocess engineering aspects of heterologous protein production in Pichia pastoris: A review. Biochem Eng J Corrected Proof. In Press.
Ren HT, Yuan JQ & Bellgardt K-H (2003) Macrokinetic model for methylotrophic Pichia pastoris based on stoichiometric balance. J Biotechnol 106: 53–68.
Ren H & Yuan J (2005) Model-based specific growth rate control for Pichia pastoris to improve recombinant protein production. J Chem Technol Biotechnol 80: 1268–1272.
Resina D, Cos O, Ferrer P & Valero F (2005) Developing high cell density fed-batch cultivation strategies for heterologous protein production in Pichia pastoris using the nitrogen source-regulated FLD1 Promoter. Biotechnol Bioeng 91: 760–767.
Resina D, Maurer M, Cos O, Arnau C, Carnicer M, Marx H, Gasser B, Valero F, Mattanovich D & Ferrer P (2009) Engineering of bottlenecks in Rhizopus oryzae lipase production in Pichia pastoris using the nitrogen source-regulated FLD1 promoter. N Biotechnol 25: 396–403.
Sears IB, O'Connor J, Rossanese OW & Glick BS (1998) A versatile set of vectors for constitutive and regulated gene expression in Pichia pastoris. Yeast 14: 783–790.
52
Shen S, Sulter G, Jeffries TW & Cregg JM (1998) A strong nitrogen source-regulated promoter for controlled expression of foreign genes in the yeast Pichia pastoris. Gene 216: 93–102.
Shi X, Karkut T, Chamankhah M, Alting-Mees M, Hemmingsen SM & Hegedus D (2003) Optimal conditions for the expression of a single-chain antibody (scFv) gene in Pichia pastoris. Protein Expr Purif 28: 321–330.
Singh S, Gras A, Fiez-Vandal C, Ruprecht J, Rana R, Martinez M, Strange P, Wagner R & Byrne B (2008) Large-scale functional expression of WT and truncated human adenosine A2A receptor in Pichia pastoris bioreactor cultures. Microb Cell Fact 7: 28.
Sinha J, Plantz BA, Zhang W, Gouthro M, Schlegel V, Liu CP & Meagher MM (2003) Improved production of recombinant Ovine Interferon- by mut+ strain of Pichia pastoris using an optimized methanol feed profile. Biotechnol Prog 19: 794–802.
Sirén N, Weegar J, Dahlbacka J, Kalkkinen N, Fagervik K, Leisola M & Von Weymarn N (2006) Production of recombinant HIV-1 Nef (negative factor) protein using Pichia pastoris and a low-temperature fed-batch strategy. Biotechnol Appl Biochem 44: 151–158.
Sommaruga S, Lombardi A, Salvade A, Mazzucchelli S, Corsi F, Galeffi P, Tortora P & Prosperi D (2011) Highly efficient production of anti-HER2 scFv antibody variant for targeting breast cancer cells. Appl Microbiol Biotechnol 91(3): 613–621.
Sommer C, Volk N & Pietzsch M (2011) Model based optimization of the fed-batch production of a highly active transglutaminase variant in Escherichia coli. Protein Expr Purif 77: 9–19.
Stratton J, Chiruvolu V & Meagher M (1998) High cell-density fermentation. In Higgins DR & Cregg JM (eds) Pichia Protocols. Humana Press, Totowa (New Jersey), p 107–120.
Sun R, Anderson TJ, Erickson AK, Nelson EA & Francis DH (2000) Inhibition of adhesion of Escherichia coli k88ac fimbria to its receptor, intestinal mucin-type glycoproteins, by a monoclonal antibody directed against a variable domain of the fimbria. Infect Immun 68: 3509–3515.
Surribas A, Stahn R, Montesinos JL, Enfors SO, Valero F & Jahic M (2007) Production of a Rhizopus oryzae lipase from Pichia pastoris using alternative operational strategies. J Biotechnol 130: 291–299.
Tang S, Boehme L, Lam H & Zhang Z (2009) Pichia pastoris fermentation for phytase production using crude glycerol from biodiesel production as the sole carbon source. Biochem Eng J 43: 157–162.
Trentmann O, Khatri NK & Hoffmann F (2004) Reduced oxygen supply increases process stability and product yield with recombinant Pichia pastoris. Biotechnol Prog 20: 1766–1775.
Trinh LB, Phue JN & Shiloach J (2003) Effect of methanol feeding strategies on production and yield of recombinant mouse endostatin from Pichia pastoris. Biotechnol Bioeng 82: 438–444.
53
Vassileva A, Chugh DA, Swaminathan S & Khanna N (2001) Expression of hepatitis B surface antigen in the methylotrophic yeast Pichia pastoris using the GAP promoter. J Biotechnol 88: 21–35.
Vohra A, Kaur P & Satyanarayana T (2011) Production, characteristics and applications of the cell-bound phytase of Pichia anomala. Antonie Van Leeuwenhoek 99: 51–55.
Wagner LW, Matheson NH, Heisey RF & Schneider K (1997) Use of a silicone tubing sensor to control methanol concentration during fed batch fermentation of Pichia pastoris. Biotechnol Tech 11: 791–795.
Waterham HR, Digan ME, Koutz PJ, Lair SV & Cregg JM (1997) Isolation of the Pichia pastoris glyceraldehyde-3-phosphate dehydrogenase gene and regulation and use of its promoter. Gene 186: 37–44.
Werten MW, van den Bosch TJ, Wind RD, Mooibroek H & de Wolf FA (1999) High-yield secretion of recombinant gelatins by Pichia pastoris. Yeast 15: 1087–1096.
Woo SH, Park SH, Lim HK & Jung KH (2005) Extended operation of a pressurized 75-L bioreactor for shLkn-1 production by Pichia pastoris using dissolved oxygen profile control. J Ind Microbiol Biotechnol 32: 474–480.
Wu JM, Lin JC, Chieng LL, Lee CK & Hsu TA (2003a) Combined use of GAP and AOX1 promoter to enhance the expression of human granulocyte-macrophage colony-stimulating factor in Pichia pastoris. Enzyme Microb Technol 33: 453–459.
Wu JM, Chieng LL, Hsu TA & Lee CK (2003b) Sequential expression of recombinant proteins and their separate recovery from a Pichia pastoris cultivation. Biochem Eng J 16: 9–16.
Yamawaki S, Matsumoto T, Ohnishi Y, Kumada Y, Shiomi N, Katsuda T, Lee EK & Katoh S (2007) Production of single-chain variable fragment antibody (scFv) in fed-batch and continuous culture of Pichia pastoris by two different methanol feeding methods. J Biosci Bioeng 104: 403–407.
Yuan D, Rao K, Relue P & Varanasi S (2011) Fermentation of biomass sugars to ethanol using native industrial yeast strains. Bioresour Technol 102: 3246–3253.
Yurimoto H, Sakai Y & Kato N (2002) Methanol metabolism. In Gellisen G (ed) Hansenula polymorpha. Biology and applications. Wiley-VCH Verlag, Weinheim, p 61–75.
Zhang A, Zhang T, Luo J, Chen S, Guan W, Fu C, Peng S & Li H (2007) Constitutive expression of human angiostatin in Pichia pastoris by high-density cell culture. J Ind Microbiol Biotechnol 34: 117–122.
Zhang AL, Luo JX, Zhang TY, Pan YW, Tan YH, Fu CY & Tu FZ (2009) Recent advances on the GAP promoter derived expression system of Pichia pastoris. Mol Biol Rep 36: 1611–1619.
Zhang W, Bevins MA, Plantz BA, Smith LA & Meagher MM (2000a) Modeling Pichia pastoris growth on methanol and optimizing the production of a recombinant protein, the heavy-chain fragment C of botulinum neurotoxin, Serotype A. Biotechnol Bioeng 70: 1–8.
54
Zhang W, Inan M & Meagher M (2000b) Fermentation strategies for recombinant protein expression in the methylotrophic yeast Pichia pastoris. Biotechnol Bioprocess Eng 5: 275–287.
Zhang W, Smith LA, Plantz BA, Schlegel VL & Meagher MM (2002) Design of methanol feed control in Pichia pastoris fermentations based upon a growth model. Biotechnol Progress 18: 1392–1399.
Zhang Y, Cong W & Shi SY (2011) Repeated fed-batch lactic acid production in a packed bed-stirred fermentor system using a pH feedback feeding method. Bioprocess Biosyst Eng 34: 67–73.
Zhou XS & Zhang YX (2002) Decrease of proteolytic degradation of recombinant hirudin produced by Pichia pastoris by controlling the specific growth rate. Biotechnol Lett 24: 1449–1453.
55
Original publications
I Trentmann O, Khatri NK & Hoffmann F (2004) Reduced oxygen supply increases process stability and product yield with recombinant Pichia pastoris. Biotechnol Prog 20: 1766–1775.
II Khatri NK & Hoffmann F (2006a) Impact of methanol concentration on secreted protein production in oxygen-limited cultures of recombinant Pichia pastoris. Biotechnol Bioeng 93: 871–879.
III Khatri NK, Gocke D, Trentmann O, Neubauer P & Hoffmann F (2011) Single-chain antibody fragment production in Pichia pastoris: Benefits of prolonged pre-induction glycerol feeding. Biotechnol J 6(4): 452–62.
IV Khatri NK & Hoffmann F (2006b) Oxygen-limited control of methanol uptake for improved production of a single-chain antibody fragment with recombinant Pichia pastoris. Appl Microbiol Biotechnol 72: 492–498.
Reprinted with permission of John Wiley and Sons (I-III) and Springer Science +
Business media (IV).
Original publications are not included in the electronic version of the dissertation.
56
A C T A U N I V E R S I T A T I S O U L U E N S I S
Book orders:Granum: Virtual book storehttp://granum.uta.fi/granum/
S E R I E S C T E C H N I C A
377. Malinen, Ilkka (2010) Improving the robustness with modified boundedhomotopies and problem-tailored solving procedures
378. Yang, Dayou (2011) Optimisation of product change process and demand-supplychain in high tech environment
379. Kalliokoski, Juha (2011) Models of filtration curve as a part of pulp drainageanalyzers
380. Myllylä, Markus (2011) Detection algorithms and architectures for wireless spatialmultiplexing in MIMO-OFDM systems
381. Muhos, Matti (2011) Early stages of technology intensive companies
382. Laitinen, Ossi (2011) Utilisation of tube flow fractionation in fibre and particleanalysis
383. Lasanen, Kimmo (2011) Integrated analogue CMOS circuits and structures forheart rate detectors and other low-voltage, low-power applications
384. Herrala, Maila (2011) Governance of infrastructure networks : developmentavenues for the Finnish water and sewage sector
385. Kortelainen, Jukka (2011) EEG-based depth of anesthesia measurement :separating the effects of propofol and remifentanil
386. Turunen, Helka (2011) CO2-balance in the athmosphere and CO2-utilisation : anengineering approach
387. Juha, Karjalainen (2011) Broadband single carrier multi-antenna communicationswith frequency domain turbo equalization
388. Martin, David Charles (2011) Selected heat conduction problems inthermomechanical treatment of steel
389. Nissinen, Jan (2011) Integrated CMOS circuits for laser radar transceivers
390. Nissinen, Ilkka (2011) CMOS time-to-digital converter structures for theintegrated receiver of a pulsed time-of-flight laser rangefinder
391. Kassinen, Otso (2011) Efficient middleware and resource management in mobilepeer-to-peer systems
392. Avellan, Kari (2011) Limit state design for strengthening foundations of historicbuildings using pretested drilled spiral piles with special reference to St. John’sChurch in Tartu
C393etukansi.kesken.fm Page 2 Tuesday, October 11, 2011 11:19 AM
ABCDEFG
UNIVERS ITY OF OULU P.O.B . 7500 F I -90014 UNIVERS ITY OF OULU F INLAND
A C T A U N I V E R S I T A T I S O U L U E N S I S
S E R I E S E D I T O R S
SCIENTIAE RERUM NATURALIUM
HUMANIORA
TECHNICA
MEDICA
SCIENTIAE RERUM SOCIALIUM
SCRIPTA ACADEMICA
OECONOMICA
EDITOR IN CHIEF
PUBLICATIONS EDITOR
Senior Assistant Jorma Arhippainen
Lecturer Santeri Palviainen
Professor Hannu Heusala
Professor Olli Vuolteenaho
Senior Researcher Eila Estola
Director Sinikka Eskelinen
Professor Jari Juga
Professor Olli Vuolteenaho
Publications Editor Kirsti Nurkkala
ISBN 978-951-42-9584-3 (Paperback)ISBN 978-951-42-9585-0 (PDF)ISSN 0355-3213 (Print)ISSN 1796-2226 (Online)
U N I V E R S I TAT I S O U L U E N S I SACTAC
TECHNICA
U N I V E R S I TAT I S O U L U E N S I SACTAC
TECHNICA
OULU 2011
C 393
Narendar Kumar Khatri
OPTIMISATION OF RECOMBINANTPROTEIN PRODUCTIONIN PICHIA PASTORISSINGLE-CHAIN ANTIBODY FRAGMENT MODEL PROTEIN
UNIVERSITY OF OULU,FACULTY OF TECHNOLOGY,DEPARTMENT OF PROCESS AND ENVIRONMENTAL ENGINEERING
C 393
ACTA
Narendar K
umar K
hatriC393etukansi.kesken.fm Page 1 Tuesday, October 11, 2011 11:19 AM