+ All Categories

Download - pdf_16493 (sram)

Transcript

00spare parts catalog

gear hub systems (comfort)

(english & deutsch)

Achtung: Diese Ersatzteilliste drfen nur qualifizierte FahrradFachhndler und Fahrrad-Hersteller verwenden!

Caution: This Spare Parts Catalog is intended for qualified bicycles dealers and factories only!

SRAM ORIGINALTEILEAchtung: Die SRAM Garantiebedingungen decken Schden nicht ab, die durch andere als SRAM Originalteile entstanden sind. Verwenden Sie fr SRAM Produkte ausschlielich Oiginal-Ersatzteile von SRAM. Die Verwendung von Fremdteilen bzw. nicht vorgesehenen Teilen kann zu Funktions strungen und/oder auch Unfllen fhren. Fr weitere Informationen zu SRAM Produkten besuchen Sie bitte unsere Website www.sram.com oder konktaktieren Sie Ihren Handelspartner. Irrtmer und technische nderungen vorbehalten. Die Abbildungen in diesem Dokument knnen vom Produkt abweichen.

SRAM ORIGINAL PARTSCaution: The SRAM Warranty policy does not cover damages caused by the use of non-SRAM parts. Use only SRAM parts with SRAM components. Installation of parts and accessories not originally intended could result in less than optimal performance and/or injury. For in-depth service information on SRAM products, refer to our website at www.sram.com. Contact your local SRAM distributor or dealer for ordering information. Information contained in this publication is subject to change at any time without prior notice. Your products appearance may vary from the diagrams contained in this catalog.

WARENZEICHENDiese Verffentlichung enthlt Warenzeichen und eingetragene Warenzeichen der SRAM Corporation, die entsprechend mit den Symbolen und gekennzeichnet sind.

TRADEMARKSThis publication includes trademarks and registered trademarks of SRAM Corporation designated by the symbols and , respectively.

Copyright 2008 SRAM Corporation Publ. No. 95.3115.009.000 D/E Rev. A Information may be enhanced without prior notice. Released July 2008

INHALTSVERZEICHNIS GETRIEBENABENSYSTEME TABLE OF CONTENT GEAR HUB SYSTEMS

GETRIEBENABENi-MOTION 9 Rcktrittbremse i-MOTION 3 Ohne Bremse i-MOTION 3 Scheibenbremse i-MOTION 3 i-BRAKE i-MOTION 3 i-MOTION 3 i-MOTION 3 i-MOTION 3 Rcktrittbremse Ohne Bremse Scheibenbremse i-BRAKE 2 4 6 8 10 18 20 22 28 32 36 40 42 46 48 54 58 62 64 70

GEAR HUBSi-MOTION 9 Coaster Brake i-MOTION 3 Without Brake i-MOTION 3 Disc Brake i-MOTION 3 i-BRAKE i-MOTION 3 i-MOTION 3 i-MOTION 3 i-MOTION 3 Coaster Brake Without Brake Scheibenbremse i-BRAKE 2 4 6 8 10 18 20 22 28 32 36 40 42 46 48 54 58 62 64 70 74 78 80 82 84 86

DualDrive / DualDrive II Ohne Bremse DualDrive / DualDrive II Scheibenbremse DualDrive / DualDrive II i-BRAKE Sparc 16V / Sparc 12V SRAM S7 Rcktrittbremse SRAM S7 Trommelbremse SRAM S7 Ohne Bremse SRAM S7 i-BRAKE SRAM P5 SRAM P5 SRAM P5 SRAM P5 Rcktrittbremse Trommelbremse Ohne Bremse i-BRAKE

DualDrive / DualDrive II Without Brake DualDrive / DualDrive II Disc Brake DualDrive / DualDrive II i-BRAKE Sparc 16V / Sparc 12V SRAM S7 Coaster Brake SRAM S7 Drum Brake SRAM S7 Without Brake SRAM S7 i-BRAKE SRAM P5 SRAM P5 SRAM P5 SRAM P5 Coaster Brake Drum Brake Without Brake i-BRAKE

CARGO

SRAM P5 Cargo Rcktrittbremse 74 SRAM P5 Cargo Trommelbremse / Scheibenbremse 78 SRAM T3 SRAM T3 SRAM T3 SRAM T3 Rcktrittbremse Trommelbremse Ohne Bremse i-BRAKE 80 82 84 86

CARGO

SRAM P5 Cargo Coaster Brake SRAM P5 Cargo Drum Brake / Disc Brake SRAM T3 SRAM T3 SRAM T3 SRAM T3 Coaster Brake Drum Brake Without Brake i-BRAKE

SYSTEMKOMPONENTENSRAM Komfy Hydraulisch Scheibenbremse i-BRAKE Vorderradnabe mit Bremse VT5000 VT5000 VT4000 VT3000 VT3000 Trommelbremsnabe, Rillenkugellager Trommelbremsnabe, Konuslager Trommelbremsnabe, Rillenkugellager Trommelbremsnabe, Rillenkugellager Trommelbremsnabe, Konuslager 88 92 93 94 95 96 97 98

GEAR HUB SYSTEM COMPONENTSSRAM Komfy Hydraulic Disc Brake i-BRAKE Front hub with brake VT5000 VT5000 VT4000 VT3000 VT3000 Drum brake hub, Cartridge Bearing Drum brake hub, Cone Bearing Drum brake hub, Cartridge Bearing Drum brake hub, Cartridge Bearing Drum brake hub, Cone Bearing 88 92 93 94 95 96 97 98

i-LIGHT Nabendynamo

i-LIGHT Hub Dynamo

ZUBEHRZahnkrnze und Zubehr Rohrschellen / Schrauben und Muttern / Zge und Seilhllen / Werkzeuge und Spezialfett Kundenspezifische Teile 99 100 102

ACCESSORIESSprockets and accessories Clamps / Screws and Nuts / Cables / Housings / Tools and grease Costumer-specific Parts 99 100 102

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

1

i-MOTION 9 RCKTRITTBREMSE i-MOTION 9 COASTER BRAKE

2 3 1

9 8 7 6 5 4 14 4a 15 6 16

4 17 5 4a 13 11 10 20 12 19 18Achtung: Bei einer Demontage muss jeweils eine Seite der Nabe geschlossen bleiben, um zu verhindern, da das Getriebe auseinanderfllt. Caution: During dismantling, one side of the hub must always remain closed, to prevent the gear unit from coming apart.

32

33 31 34

30

2

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

i-MOTION 9 RCKTRITTBREMSE i-MOTION 9 COASTER BRAKENr. No. 1 2 3 4 4a 5 5 5 5 5 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 19 19 19 19 20 Artikelnummer Part Number 65 0515 005 000 . . 0326 . . . . . . 65 0516 119 004 65 0316 003 000 00 0391 042 000 00 0991 011 000 00 0991 012 000 00 0991 014 000 00 0991 013 000 00 0991 015 000 00 0991 016 000 00 0991 001 000 65 0974 004 000 65 0376 102 000 65 0973 001 000 00 0991 003 000 00 0991 004 000 00 0991 010 000 00 0991 007 000 00 0991 005 000 00 0991 021 000 65 0921 015 000 00 0991 006 000 65 0921 014 000 65 1004 054 000 65 1004 055 000 65 1004 056 000 65 1004 057 000 65 1004 058 000 65 0912 009 000 Bezeichnung Linsenschraube M6x16mm Rohrschellen siehe Seite 100 Sechskantmutter M6 Sechskantmutter Hutmutter, M10x1 Fixierscheiben, i9, 30 Grad, gelb/grn, links/rechts, 1 Set Fixierscheiben, i9, 15 Grad, blau/rot, links/rechts, 1 Set Fixierscheiben, i9, 90 Grad, wei, links/rechts, 1 Set Fixierscheiben, i9, 180 Grad, orange/lila, links/rechts, 1 Set Fixierscheiben, i9, 75 Grad, ockerbraun/hell-lila, links/rechts, 1 Set Fixierscheiben, i9, 67 Grad, dunkelbraun/trkis, links/rechts, 1 Set Set Achsmuttern und Scheiben Zsb. Hebelkonus Zsb. Kugelhalter Zsb. Bremsmantel Sprengring Anlaufscheibe Nadelrollen fr die Bremse Zsb. Walzenfhrungsring Zsb. Kugelhalter Zsb. Festkonus Staubdeckel Zsb. Austauschgetriebe i9 Rcktrittbremse Zahnkranzstaubdeckel Zahnkranz 18 Zhne Zahnkranz 19 Zhne Zahnkranz 20 Zhne Zahnkranz 21 Zhne Zahnkranz 22 Zhne Zahnkranzsprengring Description Pipe Clamp Bolt (fillister head screw) M 6 x 16mm, 8.8 Pipe Clamps see page 100 Hex Nut M6 i9, i3, S7, P5, T3, VT3000, VT4000, VT5000 Hex Nut i3 IGH I-Brake, Coaster Brake, no brake qty 1 Axle Nut Cap Retaining Washers i9 30deg, yellow/green, L/R, Qty 1 Retaining Washers i9 15deg, blue/red, L/R, Qty 1 Retaining Washers i9 90deg, white, L/R, Qty 1 Retaining Washers i9 180deg, purple/orange, L/R, Qty 1 Retaining Washers i9 75deg, ocherbrown/light purple, L/R, Qty 1 Retaining Washers i9 67deg, dark brown/pastel blue, L/R, Qty 1 Set, Nuts/Washers i9, i3 IGH Coaster 32/36h, qty 2 Nuts Coaster Brake Arm Assy i9 IGH 32/36h/Coaster Brake Ball Retainer S7, P5 Brake Ring i9 IGH 23/26h/Coaster Brake Snap Ring i-Motion 9, Qty 5 Washer i-Motion 9, Qty 5 Needle Roller i9 Coaster Brake, Qty 6 Roller Guide Ring i9, Qty 1 Ball Retainer Assy, small, iMotion 9 w/Brakel/Disc/iBrake Fixed Cone assy i9 IGH 32/36h/Coaster Brake Dust Cover i9 Complete Gear Set i9 coaster brake Sprocket Dust Cap i9 IGH w/Brake/Coaster Brake Sprocket 18T i9 IGH w/Brake Sprocket 19T i9 IGH w/Brake Sprocket 20T i9 IGH w/Brake Sprocket 21T i9 IGH w/Brake Sprocket 22T i9 IGH w/Brake Snap Ring i9 IGH/Coaster Brake

30 31 32 33 34

11 2215 000 000 11 2215 001 000 11 2215 002 000 11 2215 003 000 11 5515 000 000

Set Einstellschraube, i-MOTION 9 Schalter, 2 Sets Ganganzeigenabdeckung, 1 Stck Abdeckkappe Schalter, 2 Stck Drehgriffteil, 1 Stck Zsb. Verbindungshlse

Grip Nut/Screw i-Motion 9, Qty 2 Grip Lens i-Motion 9, Qty 1 Cable Change Cover i-Motion 9, Qty 1 Grip i-Motion 9, Qty 1 Connection Sleeve i3/i9 i-Brake

00 0991 002 000 00 0991 008 000

Montagewerkzeug i-MOTION 9 Schaltzug (siehe Seite 101) Gabelschlssel, i-MOTION 9, SW 27 (siehe Seite 101)

Mounting Tool, i9 shift Cable (see Page 101) Spanner SW 27, i9, Qty 1 (see Page 101)

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

3

i-MOTION 9 OHNE BREMSE i-MOTION 9 WITHOUT BRAKE

5 4 3 8 7 1a 10 1 2 1a 6 13 4 9

2 1

12 11Achtung: Bei einer Demontage muss jeweils eine Seite der Nabe geschlossen bleiben, um zu verhindern, da das Getriebe auseinanderfllt. Caution: During dismantling, one side of the hub must always remain closed, to prevent the gear unit from coming apart.

32

33 31 34

30

4

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

i-MOTION 9 OHNE BREMSE i-MOTION 9 WITHOUT BRAKENr. No. 1 1a 2 2 2 2 2 2 3 4 5 6 7 8 9 10 11 12 12 12 12 12 13 Artikelnummer Part Number 65 0316 003 000 00 0391 042 000 00 0991 011 000 00 0991 012 000 00 0991 014 000 00 0991 013 000 00 0991 015 000 00 0991 016 000 00 0991 019 000 00 0991 001 000 00 0991 017 000 00 0991 018 000 00 0991 005 000 00 0991 021 000 65 0921 015 000 00 0991 009 000 65 0921 014 000 65 1004 054 000 65 1004 055 000 65 1004 056 000 65 1004 057 000 65 1004 058 000 65 0912 009 000 Bezeichnung Sechskantmutter Hutmutter, M10x1 Fixierscheiben, i9, 30 Grad, gelb/grn, links/rechts, 1 Set Fixierscheiben, i9, 15 Grad, blau/rot, links/rechts, 1 Set Fixierscheiben, i9, 90 Grad, wei, links/rechts, 1 Set Fixierscheiben, i9, 180 Grad, orange/lila, links/rechts, 1 Set Fixierscheiben, i9, 75 Grad, ockerbraun/hell-lila, links/rechts, 1 Set Fixierscheiben, i9, 67 Grad, dunkelbraun/trkis, links/rechts, 1 Set Kappe, i9, ohne Bremse Set Achsmuttern und Scheiben ET Set Zsb. Stellkonus mit Staubdeckel Zsb. Kugelhalter, gro Zsb. Kugelhalter, klein Zsb. Festkonus Staubdeckel Zsb. Austauschgetriebe ohne Bremse / Scheibenbremse / i-Brake Zahnkranzstaubdeckel Zahnkranz 18 Zhne Zahnkranz 19 Zhne Zahnkranz 20 Zhne Zahnkranz 21 Zhne Zahnkranz 22 Zhne Zahnkranzsprengring Description Hex Nut i3 IGH I-Brake, Coaster Brake, no brake qty 1 Axle Nut Cap Retaining Washers i9 30deg, yellow/green, L/R, Qty 1 Retaining Washers i9 15deg, blue/red, L/R, Qty 1 Retaining Washers i9 90deg, white, L/R, Qty 1 Retaining Washers i9 180deg, purple/orange, L/R, Qty 1 Retaining Washers i9 75deg, ocherbrown/light purple, L/R, Qty 1 Retaining Washers i9 67deg, dark brown/pastel blue, L/R, Qty 1 Cap Set iMotion 9 FreeWheel/Disc Set, Nuts/Washers i9, i3 IGH Coaster 32/36h, qty 2 Nuts Adjustable Cone Assy iMotion 9 FreeWheel/Disc Ball Retainer Assy iMotion 9 FreeWheel/Disc/iBrake Ball Retainer Assy, small, iMotion 9 w/Brakel/Disc/iBrake Fixed Cone assy i9 IGH 32/36h/Coaster Brake Dust Cover i9 Complete Gear Set i9 w/Brake/Disc/i-Brake Sprocket Dust Cap i9 IGH w/Brake/Coaster Brake Sprocket 18T i9 IGH w/Brake Sprocket 19T i9 IGH w/Brake Sprocket 20T i9 IGH w/Brake Sprocket 21T i9 IGH w/Brake Sprocket 22T i9 IGH w/Brake Snap Ring i9 IGH/Coaster Brake

30 31 32 33 34

11 2215 000 000 11 2215 001 000 11 2215 002 000 11 2215 003 000 11 5515 000 000

Set Einstellschraube, i-MOTION 9 Schalter, 2 Sets Ganganzeigenabdeckung, 1 Stck Abdeckkappe Schalter, 2 Stck Drehgriffteil, 1 Stck Zsb. Verbindungshlse

Grip Nut/Screw i-Motion 9, Qty 2 Grip Lens i-Motion 9, Qty 1 Cable Change Cover i-Motion 9, Qty 1 Grip i-Motion 9, Qty 1 Connection Sleeve i3/i9 i-Brake

00 0991 002 000 00 0991 008 000

Montagewerkzeug i-MOTION 9 Schaltzug (siehe Seite 101) Gabelschlssel, i-MOTION 9, SW 27 (siehe Seite 101)

Mounting Tool, i9 shift Cable (see Page 101) Spanner SW 27, i9, Qty 1 (see Page 101)

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

5

i-MOTION 9 SCHEIBENBREMSE i-MOTION 9 DISC BRAKE

4 3 2 1 7 1a 6 3 8

9 1 2 5 12 1a

11 10Achtung: Bei einer Demontage muss jeweils eine Seite der Nabe geschlossen bleiben, um zu verhindern, da das Getriebe auseinanderfllt. Caution: During dismantling, one side of the hub must always remain closed, to prevent the gear unit from coming apart.

32

33 31 34

30

6

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

i-MOTION 9 SCHEIBENBREMSE i-MOTION 9 DISC BRAKENr. No. 1 1a 2 2 2 2 2 2 3 4 5 6 7 8 9 10 11 11 11 11 11 12 Artikelnummer Part Number 65 0316 003 000 00 0391 042 000 00 0991 011 000 00 0991 012 000 00 0991 014 000 00 0991 013 000 00 0991 015 000 00 0991 016 000 00 0991 001 000 00 0991 017 000 00 0991 018 000 00 0991 005 000 00 0991 021 000 65 0921 015 000 00 0991 009 000 65 0921 014 000 65 1004 054 000 65 1004 055 000 65 1004 056 000 65 1004 057 000 65 1004 058 000 65 0912 009 000 Bezeichnung Sechskantmutter Hutmutter, M10x1 Fixierscheiben, i9, 30 Grad, gelb/grn, links/rechts, 1 Set Fixierscheiben, i9, 15 Grad, blau/rot, links/rechts, 1 Set Fixierscheiben, i9, 90 Grad, wei, links/rechts, 1 Set Fixierscheiben, i9, 180 Grad, orange/lila, links/rechts, 1 Set Fixierscheiben, i9, 75 Grad, ockerbraun/hell-lila, links/rechts, 1 Set Fixierscheiben, i9, 67 Grad, dunkelbraun/trkis, links/rechts, 1 Set Set Achsmuttern und Scheiben ET Set Zsb. Stellkonus mit Staubdeckel Zsb. Kugelhalter, gro Zsb. Kugelhalter, klein Zsb. Festkonus Staubdeckel Zsb. Austauschgetriebe ohne Bremse / Scheibenbremse / i-Brake Zahnkranzstaubdeckel Zahnkranz 18 Zhne Zahnkranz 19 Zhne Zahnkranz 20 Zhne Zahnkranz 21 Zhne Zahnkranz 22 Zhne Zahnkranzsprengring Description Hex Nut i3 IGH I-Brake, Coaster Brake, no brake qty 1 Axle Nut Cap Retaining Washers i9 30deg, yellow/green, L/R, Qty 1 Retaining Washers i9 15deg, blue/red, L/R, Qty 1 Retaining Washers i9 90deg, white, L/R, Qty 1 Retaining Washers i9 180deg, purple/orange, L/R, Qty 1 Retaining Washers i9 75deg, ocherbrown/light purple, L/R, Qty 1 Retaining Washers i9 67deg, dark brown/pastel blue, L/R, Qty 1 Set, Nuts/Washers i9, i3 IGH Coaster 32/36h, qty 2 Nuts Adjustable Cone Assy iMotion 9 FreeWheel/Disc Ball Retainer Assy iMotion 9 FreeWheel/Disc/iBrake Ball Retainer Assy, small, iMotion 9 w/Brakel/Disc/iBrake Fixed Cone assy i9 IGH 32/36h/Coaster Brake Dust Cover i9 Complete Gear Set i9 w/Brake/Disc/i-Brake Sprocket Dust Cap i9 IGH w/Brake/Coaster Brake Sprocket 18T i9 IGH w/Brake Sprocket 19T i9 IGH w/Brake Sprocket 20T i9 IGH w/Brake Sprocket 21T i9 IGH w/Brake Sprocket 22T i9 IGH w/Brake Snap Ring i9 IGH/Coaster Brake

30 31 32 33 34

11 2215 000 000 11 2215 001 000 11 2215 002 000 11 2215 003 000 11 5515 000 000

Set Einstellschraube, i-MOTION 9 Schalter, 2 Sets Ganganzeigenabdeckung, 1 Stck Abdeckkappe Schalter, 2 Stck Drehgriffteil, 1 Stck Zsb. Verbindungshlse

Grip Nut/Screw i-Motion 9, Qty 2 Grip Lens i-Motion 9, Qty 1 Cable Change Cover i-Motion 9, Qty 1 Grip i-Motion 9, Qty 1 Connection Sleeve i3/i9 i-Brake

00 0991 002 000 00 0991 008 000

Montagewerkzeug i-MOTION 9 Schaltzug (siehe Seite 101) Gabelschlssel, i-MOTION 9, SW 27 (siehe Seite 101)

Mounting Tool, i9 shift Cable (see Page 101) Spanner SW 27, i9, Qty 1 (see Page 101)

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

7

i-MOTION 9 i-BRAKE i-MOTION 9 i-BRAKE

21

22

1a 20 2 1 3 4

23

24 25 8 7 3 9

10 1 2 5 13 1a

Achtung: Bei einer Demontage muss jeweils eine Seite der Nabe geschlossen bleiben, um zu verhindern, da das Getriebe auseinanderfllt. Caution: During dismantling, one side of the hub must always remain closed, to prevent the gear unit from coming apart.

12 11 32

33 31 34

30 8Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

i-MOTION 9 i-BRAKE i-MOTION 9 i-BRAKENr. No. 1 1a 2 2 2 2 2 2 3 4 5 6 7 8 9 10 11 12 12 12 12 12 13 Artikelnummer Part Number 65 0316 003 000 00 0391 042 000 00 0991 011 000 00 0991 012 000 00 0991 014 000 00 0991 013 000 00 0991 015 000 00 0991 016 000 00 0991 020 000 65 0308 003 000 00 0991 018 000 00 0991 005 000 00 0991 021 000 00 0991 001 000 65 0921 015 000 00 0991 009 000 65 0921 014 000 65 1004 054 000 65 1004 055 000 65 1004 056 000 65 1004 057 000 65 1004 058 000 65 0912 009 000 Bezeichnung Sechskantmutter Hutmutter, M10x1 Fixierscheiben, i9, 30 Grad, gelb/grn, links/rechts, 1 Set Fixierscheiben, i9, 15 Grad, blau/rot, links/rechts, 1 Set Fixierscheiben, i9, 90 Grad, wei, links/rechts, 1 Set Fixierscheiben, i9, 180 Grad, orange/lila, links/rechts, 1 Set Fixierscheiben, i9, 75 Grad, ockerbraun/hell-lila, links/rechts, 1 Set Fixierscheiben, i9, 67 Grad, dunkelbraun/trkis, links/rechts, 1 Set Set Achsmuttern und Scheiben, i9, i-Brake Stellkonus i3, i-Brake Zsb. Kugelhalter, gro Zsb. Kugelhalter, klein Zsb. Festkonus Set Achsmuttern und Scheiben Staubdeckel Zsb. Austauschgetriebe ohne Bremse / Scheibenbremse / i-Brake Zahnkranzstaubdeckel Zahnkranz 18 Zhne Zahnkranz 19 Zhne Zahnkranz 20 Zhne Zahnkranz 21 Zhne Zahnkranz 22 Zhne Zahnkranzsprengring Description Hex Nut i3 IGH I-Brake, Coaster Brake, no brake qty 1 Axle Nut Cap Retaining Washers i9 30deg, yellow/green, L/R, Qty 1 Retaining Washers i9 15deg, blue/red, L/R, Qty 1 Retaining Washers i9 90deg, white, L/R, Qty 1 Retaining Washers i9 180deg, purple/orange, L/R, Qty 1 Retaining Washers i9 75deg, ocherbrown/light purple, L/R, Qty 1 Retaining Washers i9 67deg, dark brown/pastel blue, L/R, Qty 1 Bushing Set iMotion 9/iBrake Adjusting Cone i3 GearHub, i-Brake 32/36h qty 1 Ball Retainer Assy iMotion 9 FreeWheel/Disc/iBrake Ball Retainer Assy, small, iMotion 9 w/Brakel/Disc/iBrake Fixed Cone assy i9 IGH 32/36h/Coaster Brake Set, Nuts/Washers i9, i3 IGH Coaster 32/36h, qty 2 Nuts Dust Cover i9 Complete Gear Set i9 w/Brake/Disc/i-Brake Sprocket Dust Cap i9 IGH w/Brake/Coaster Brake Sprocket 18T i9 IGH w/Brake Sprocket 19T i9 IGH w/Brake Sprocket 20T i9 IGH w/Brake Sprocket 21T i9 IGH w/Brake Sprocket 22T i9 IGH w/Brake Snap Ring i9 IGH/Coaster Brake

20 21 22 23 24 24 25

11 3115 019 000 11 3115 012 000 11 3115 007 000 11 3115 016 000 11 3115 008 000 11 3115 029 000 11 3115 015 000

Zsb. Fixierbuchse Zsb. Bremstrger hinten Torx Senkkopfschraube fr Bremstrommel, i9/DD, 4 Stck Zsb. Gegenhalter Faltenbalg, Set fr i-Brake hinten und vorne Faltenbalg hinten Zsb. Bremszugeinhngung hinten

Fixing Bush Assy, i3 Hub/i-Brake qty 1 Brake Carrier Rear, Dual Drive/P5/S7/T3 iBrake qty 1 Drum Brake Screws, i9 / Dual Drive iBrake, qty 4 Holder Assy, Dual Drive/S7/iBrake/Fr Hub qty 1 Bellows F/R, qty 5, S7/iBrake - F/R Bellow Rear i-Brake, Qty 1 Link/Brake Cable, R, Dual Drive/P5/iBrake, qty 1

30 31 32 33 34

11 2215 000 000 11 2215 001 000 11 2215 002 000 11 2215 003 000 11 5515 000 000

Set Einstellschraube, i-MOTION 9 Schalter, 2 Sets Ganganzeigenabdeckung, 1 Stck Abdeckkappe Schalter, 2 Stck Drehgriffteil, 1 Stck Zsb. Verbindungshlse

Grip Nut/Screw i-Motion 9, Qty 2 Grip Lens i-Motion 9, Qty 1 Cable Change Cover i-Motion 9, Qty 1 Grip i-Motion 9, Qty 1 Connection Sleeve i3/i9 i-Brake

00 0991 002 000 00 0991 008 000

Montagewerkzeug i-MOTION 9 Schaltzug (siehe Seite 101) Gabelschlssel, i-MOTION 9, SW 27 (siehe Seite 101)

Mounting Tool, i9 shift Cable (see Page 101) Spanner SW 27, i9, Qty 1 (see Page 101)

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

9

i-MOTION 3 RCKTRITTBREMSE (bis Juli 07) i-MOTION 3 COASTER BRAKE (till July 07)

2 3 1

9 8 6 7

42

4

5

6

4 41 4a 13 14 15 5 4a

11

12

10

40

10

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

i-MOTION 3 RCKTRITTBREMSE (bis Juli 07) i-MOTION 3 COASTER BRAKE (till July 07)Nr. No. 1 2 3 4 4a 5 6 7 8 9 10 11 12 13 14 15 Artikelnummer Part Number 65 0515 005 000 . . 0326 . . . . . . 65 0516 119 004 65 0316 003 000 00 0391 042 000 00 0391 021 000 65 0316 006 000 00 0391 026 000 65 0576 001 000 00 0391 016 000 00 0389 009 200 65 0321 007 000 65 1004 . . . . . . 65 0512 011 000 00 0391 020 000 65 0378 008 000 Bezeichnung Linsenschraube M6x16mm Rohrschellen siehe Seite 100 Sechskantmutter M6 Sechkantmutter Hutmutter, M10x1 Fixierscheibe i3, i-Brake/Leerlauf/Rcktritt Sechskantmutter i3, Rcktritt Zsb. Hebelkonus i3, Rcktritt Kugelhalter Bremssegmente Set i3 Austauschkit Getriebe i3, Rcktritt, Achslnge 178mm Zahnkranz-Staubdeckel i3, i-Brake/Leerlauf/Rcktritt Zahnkranz siehe Seite 99 Sprengring Gegenhalter i3, i-Brake/Leerlauf/Rcktritt Zsb Fixierbuchse i3, i-Brake/Leerlauf/Rcktritt Description Pipe Clamp Bolt (fillister head screw) M 6 x 16mm, 8.8 Pipe Clamps see page 100 Hex Nut M6 i9, i3, S7, P5, T3, VT3000, VT4000, VT5000 Hex Nut i3 IGH I-Brake, Coaster Brake, no brake qty 1 Axle Nut Cap Retaining washer i3 IGH i-Brake/Coaster Brake, qty 10 Hex Nut i3 IGH CoasterBrake 32/26h, qty 1 Brake Arm Cone Assy i3 IG Coaster Brake Bearing Retainer i3, T3, Sparc, P5 Brake Segment Set, i3 IGH Coaster 32/36h, Qty 1 each Complete gear set, i3, Coaster Brake, Axle 178 mm Sprocket - Dust Cover i3 IGH i-Brake/Coaster Brake, qty 1 Sprocket see page 99 Sprocket Lock Ring i3, Sparc, S7, P5, T3 Counter Support i-Motion 3, Qty 1 Fixing Bush Assy i3 IGH i-Brake/Coaster Brake

40 41 42

11 3115 021 000 11 3115 020 000 11 2215 004 000

Kappe, i3 Schalter Verbindungslasche, i3 Nabe Kunststoffgegenhalter

Cable Change Cap, i3 Shifter, qty 2 Shifter Connector Strap, i3 Hub qty 1 Cable Retainer i-3 Shifter

00 0391 017 000

Montagewerkzeug i-MOTION 3 Schaltzug (siehe Seite 101)

Mounting Tool for i-MOTION 3 shift Cable (see Page 101)

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

11

i-MOTION 3 RCKTRITTBREMSE (ab August 07) i-MOTION 3 COASTER BRAKE (as of August 07)41 3 1

2

27

9 8 17 6 6 7 16

18

42

4

5

16 4a 15 14 13 24 12 25 26 5 4a 4

10 11 21 16 20 19 22 23

40

12

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

i-MOTION 3 RCKTRITTBREMSE (ab August 07) i-MOTION 3 COASTER BRAKE (as of August 07)Nr. No. 1 2 3 4 4a 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 Artikelnummer Part Number 65 0515 005 000 . . 0326 . . . . . . 65 0516 119 004 65 0316 003 000 00 0391 042 000 00 0391 021 000 65 0316 006 000 00 0391 026 000 65 0576 001 000 00 0391 016 000 00 0391 019 000 65 0518 103 100 00 0391 025 000 00 0391 037 000 65 2318 016 000 65 0372 002 000 00 0391 039 000 65 0341 002 000 65 0325 002 000 65 0376 003 000 65 0372 008 000 00 0391 029 000 65 0321 007 000 65 1004 . . . . . . 65 0512 011 000 00 0391 020 000 65 0378 008 000 65 0388 001 000 00 0389 009 200 Bezeichnung Linsenschraube M6x16mm Rohrschellen siehe Seite 100 Sechskantmutter M6 Sechkantmutter Hutmutter, M10x1 Fixierscheibe i3, i-Brake/Leerlauf/Rcktritt Sechskantmutter i3, Rcktritt Zsb. Hebelkonus i3, Rcktritt Kugelhalter Bremssegmente Set i3 Sicherungsscheibe Anlaufscheibe Zsb. Planetenradtrger i3, Rcktritt Zsb. Hohlrad i3, Rcktritt Anlaufscheibe Zsb. Klinkentrger i3, i-Brake/Leerlauf/Rcktritt Zsb. Achse mit Festkonus und Schaltbuchse, i3, Rcktritt, 178 mm Kupplungsstck i3, i-Brake/Leerlauf/Rcktritt Druckfeder i3, i-Brake/Leerlauf/Rcktritt Zsb. Kugelhalter i3, I-Brake/Leerlauf/Rcktritt Zsb. Antreiber i3,Rcktritt Deckel i3, i-Brake/Leerlauf/Rcktritt Zahnkranz-Staubdeckel i3, i-Brake/Leerlauf/Rcktritt Zahnkranz siehe Seite 99 Sprengring Gegenhalter i3, i-Brake/Leerlauf/Rcktritt Zsb Fixierbuchse i3, i-Brake/Leerlauf/Rcktritt Zsb. Schaltseil i3, i-Brake/Leerlauf/Rcktritt Austauschkit Getriebe i3, Rcktritt, Achslnge 178mm (Nr. 10 21 + 27) Description Pipe Clamp Bolt (fillister head screw) M 6 x 16mm, 8.8 Pipe Clamps see page 100 Hex Nut M6 i9, i3, S7, P5, T3, VT3000, VT4000, VT5000 Hex Nut i3 IGH I-Brake, Coaster Brake, no brake qty 1 Axle Nut Cap Retaining washer i3 IGH i-Brake/Coaster Brake, qty 10 Hex Nut i3 IGH CoasterBrake 32/26h, qty 1 Brake Arm Cone Assy i3 IG Coaster Brake Bearing Retainer i3, T3, Sparc, P5 Brake Segment Set, i3 IGH Coaster 32/36h, Qty 1 each Snap Ring i-Motion 3, Qty 10 Thrust washer i3, T3 Planet Pinion Carrier Assy i3 IGH Coaster Brake Gear Ring Assy i3 IGH Coaster Brake Thrust washer i3 Pawl Carrier Assy i3 IGH i-Brake/Coaster Brake/no Brake Axle Assy with Fixed Cone and Shifting Bushing, i3, Coster Brake, 178 mm Coupler i3 IGH i-Brake/Coaster Brake Compression Spring i3 IGH i-Brake/Coaster Brake, qty 1 Ball Retainer Assy i3 IGH i-Brake/Coaster Brake Driver Assy i3 IGH Coaster Brake Cover i3 IGH i-Brake/Coaster Brake, qty 1 Sprocket - Dust Cover i3 IGH i-Brake/Coaster Brake, qty 1 Sprocket see page 99 Sprocket Lock Ring i3, Sparc, S7, P5, T3 Counter Support i-Motion 3, Qty 1 Fixing Bush Assy i3 IGH i-Brake/Coaster Brake Gearshift Cable Assy i3 IGH i-Brake/Coaster Brake/no Brake Complete gear set, i3, Coaster Brake, Axle 178 mm (No. 10 21 + 27)

40 41 42

11 3115 021 000 11 3115 020 000 11 2215 004 000

Kappe, i3 Schalter Verbindungslasche, i3 Nabe Kunststoffgegenhalter

Cable Change Cap, i3 Shifter, qty 2 Shifter Connector Strap, i3 Hub qty 1 Cable Retainer i-3 Shifter

00 0391 017 000

Montagewerkzeug i-MOTION 3 Schaltzug (siehe Seite 101)

Mounting Tool for i-MOTION 3 shift Cable (see Page 101)

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

13

i-MOTION 3 RCKTRITTBREMSE Version ohne Schaltzug-Gegenhalter (bis August 07) i-MOTION 3 COASTER BRAKE Version without cable stop bracket (till August 07)

2 3 1

9 8 6 7

4

5

6

41 4a 5 14 13 12 11 12 13

4

4a

10

40

14

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

i-MOTION 3 RCKTRITTBREMSE Version ohne Schaltzug-Gegenhalter (bis August 07) i-MOTION 3 COASTER BRAKE Version without cable stop bracket (till August 07)Nr. No. 1 2 3 4 4a 2 6 7 8 9 10 11 12 13 14 Artikelnummer Part Number 65 0515 005 000 . . 0326 . . . . . . 65 0516 119 004 65 0316 003 000 00 0391 042 000 00 0991 015 000 65 0316 006 000 00 0391 026 000 65 0576 001 000 00 0391 016 000 00 0389 009 200 65 0321 007 000 65 1004 . . . . . . 65 0512 011 000 00 0391 036 000 Bezeichnung Linsenschraube M6x16mm Rohrschellen siehe Seite 100 Sechskantmutter M6 Sechkantmutter Hutmutter, M10x1 Fixierscheiben, i9, 75 Grad, ockerbraun/hell-lila, links/rechts, 1 Set Sechskantmutter i3, Rcktritt Zsb. Hebelkonus i3, Rcktritt Kugelhalter Bremssegmente Set i3 Austauschkit Getriebe i3, Rcktritt, Achslnge 178mm Version ohne Schaltzug-Gegenhalter Zahnkranz-Staubdeckel i3, i-Brake/Leerlauf/Rcktritt Zahnkranz siehe Seite 99 Sprengring Zsb. Schaltseil i3, Rcktritt, Version ohne Schaltzug-Gegenhalter Description Pipe Clamp Bolt (fillister head screw) M 6 x 16mm, 8.8 Pipe Clamps see page 100 Hex Nut M6 i9, i3, S7, P5, T3, VT3000, VT4000, VT5000 Hex Nut i3 IGH I-Brake, Coaster Brake, no brake qty 1 Axle Nut Cap Retaining Washers i9 75deg, ocherbrown/light purple, L/R, Qty 1 Hex Nut i3 IGH CoasterBrake 32/26h, qty 1 Brake Arm Cone Assy i3 IG Coaster Brake Bearing Retainer i3, T3, Sparc, P5 Brake Segment Set, i3 IGH Coaster 32/36h, Qty 1 each Complete gear set, i3, Coaster Brake, Axle 178 mm, Coaster Brake Version without Cable stop bracket Sprocket - Dust Cover i3 IGH i-Brake/Coaster Brake, qty 1 Sprocket see page 99 Sprocket Lock Ring i3, Sparc, S7, P5, T3 Gearshift Cable Assy i3 Coaster Brake Version without Cable stop bracket

40 41

11 3115 021 000 65 0570 140 100

Kappe, i3 Schalter Klemmhlse T3

Cable Change Cap, i3 Shifter, qty 2 Locating Sleeve T3

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

15

i-MOTION 3 RCKTRITTBREMSE Version ohne Schaltzug-Gegenhalter (ab August 07) i-MOTION 3 COASTER BRAKE Version without cable stop bracket (as of August 07)

2 3 1

41

29

9 8 17 6 6 7 16

18

4

5

16 4a 15 14 13 12 22 21 20 19 23 25 26 27 28 5 4a 4

10 11

24

40

16

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

i-MOTION 3 RCKTRITTBREMSE Version ohne Schaltzug-Gegenhalter (ab August 07) i-MOTION 3 COASTER BRAKE Version without cable stop bracket (as of August 07)Nr. No. 1 2 3 4 4a 2 6 7 8 9 10 11 12 13 14 15 16 16 17 18 19 20 21 22 23 24 25 26 27 28 29 Artikelnummer Part Number 65 0515 005 000 . . 0326 . . . . . . 65 0516 119 004 65 0316 003 000 00 0391 042 000 00 0991 015 000 65 0316 006 000 00 0391 026 000 65 0576 001 000 00 0391 016 000 00 0391 019 000 65 0518 103 100 00 0391 025 000 00 0391 037 000 65 2318 016 000 65 0372 002 000 00 0391 032 000 00 0391 033 000 65 0341 002 000 65 0325 002 000 65 0376 003 000 65 0372 008 000 00 0391 031 000 00 0391 030 000 00 0391 035 000 00 0391 034 000 00 0391 029 000 65 0321 007 000 65 1004 . . . . . . 65 0512 011 000 00 0391 036 000 Bezeichnung Linsenschraube M6x16mm Rohrschellen siehe Seite 100 Sechskantmutter M6 Sechkantmutter Hutmutter, M10x1 Fixierscheiben, i9, 75 Grad, ockerbraun/hell-lila, links/rechts, 1 Set Sechskantmutter i3, Rcktritt Zsb. Hebelkonus i3, Rcktritt Kugelhalter Bremssegmente Set i3 Sicherungsscheibe Anlaufscheibe Zsb. Planetenradtrger i3, Rcktritt Zsb. Hohlrad i3, Rcktritt Anlaufscheibe Zsb. Klinkentrger i3, i-Brake/Leerlauf/Rcktritt Zsb. Achse mit Schaltbuchse i3, Rcktritt, Version ohne SchaltzugGegenhalter 168mm Zsb. Achse mit Schaltbuchse i3, Rcktritt, Version ohne SchaltzugGegenhalter 178mm Kupplungsstck i3, i-Brake/Leerlauf/Rcktritt Druckfeder i3, i-Brake/Leerlauf/Rcktritt Zsb. Kugelhalter i3, I-Brake/Leerlauf/Rcktritt Zsb. Antreiber i3, Rcktritt Festkonus i3, i-Brake/Leerlauf/Rcktritt Distanzbuchse i3, Rcktritt, Version ohne Schaltzug-Gegenhalter Seilfhrungsbuchse i3, Rcktritt, Version ohne Schaltzug-Gegenhalter Gewindebuchse i3, Rcktritt, Version ohne Schaltzug-Gegenhalter Deckel i3, i-Brake/Leerlauf/Rcktritt Zahnkranz-Staubdeckel i3, i-Brake/Leerlauf/Rcktritt Zahnkranz siehe Seite 99 Sprengring Zsb. Schaltseil i3, Rcktritt, Version ohne Schaltzug-Gegenhalter Description Pipe Clamp Bolt (fillister head screw) M 6 x 16mm, 8.8 Pipe Clamps see page 100 Hex Nut M6 i9, i3, S7, P5, T3, VT3000, VT4000, VT5000 Hex Nut i3 IGH I-Brake, Coaster Brake, no brake qty 1 Axle Nut Cap Retaining Washers i9 75deg, ocherbrown/light purple, L/R, Qty 1 Hex Nut i3 IGH CoasterBrake 32/26h, qty 1 Brake Arm Cone Assy i3 IG Coaster Brake Bearing Retainer i3, T3, Sparc, P5 Brake Segment Set, i3 IGH Coaster 32/36h, Qty 1 each Snap Ring i-Motion 3, Qty 10 Thrust washer i3, T3 Planet Pinion Carrier Assy i3 IGH Coaster Brake Gear Ring Assy i3 IGH Coaster Brake Thrust washer i3 Pawl Carrier Assy i3 IGH i-Brake/Coaster Brake/no Brake Axle Assy with Shifting Bushing i3 Coaster Brake Version without Cable stop bracket 168mm Axle Assy with Shifting Bushing i3 Coaster Brake Version without Cable stop bracket 178mm Coupler i3 IGH i-Brake/Coaster Brake Compression Spring i3 IGH i-Brake/Coaster Brake, qty 1 Ball Retainer Assy i3 IGH i-Brake/Coaster Brake Driver Assy i3 IGH Coaster Brake Fixed Cone i3 IGH Coaster Distance Bushing i3 IGH Coaster Brake Version without Cable stop bracket Cable Guide Bushing Assy, i3, Coaster Brake Version without Cable stop bracket Bush i3 IGH Coaster Brake Version without Cable stop bracket Cover i3 IGH i-Brake/Coaster Brake, qty 1 Sprocket - Dust Cover i3 IGH i-Brake/Coaster Brake, qty 1 Sprocket see page 99 Sprocket Lock Ring i3, Sparc, S7, P5, T3 Gearshift Cable Assy i3 Coaster Brake Version without Cable stop bracket Complete gear set, i3, Coaster Brake, Axle 178 mm, Coaster Brake Version without Cable stop bracket (No. 10 25 + 29)

00 0389 011 100

Austauschkit Getriebe i3, Rcktritt Achslnge 178mm, Version ohne Schaltzug-Gegenhalter (Nr. 10 25 + 29)

40 41

11 3115 021 000 65 0570 140 100

Kappe, i3 Schalter Klemmhlse T3

Cable Change Cap, i3 Shifter, qty 2 Locating Sleeve T3

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

17

i-MOTION 3 OHNE BREMSE i-MOTION 3 WITHOUT BRAKE41

24 14 5 4 12 1 2 3 12 1a 11 10 9 21 8 6 7 18 12 17 19 20 22 23 2 1a 1 42 13

16 15

40

18

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

i-MOTION 3 OHNE BREMSE i-MOTION 3 WITHOUT BRAKENr. No. 1 1a 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 Artikelnummer Part Number 65 0316 003 000 00 0391 042 000 00 0391 021 000 65 0321 015 000 00 0991 001 000 65 0308 006 000 00 0391 019 000 65 0318 003 000 65 0372 004 000 65 0381 001 000 65 2318 016 000 65 0372 002 000 00 0391 040 000 65 0341 002 000 65 0325 002 000 65 0376 003 000 65 0318 002 000 65 0372 003 000 00 0391 029 000 65 0321 007 000 65 1004 . . . . . . 65 0512 011 000 00 0391 020 000 65 0378 008 000 65 0388 001 000 00 0389 008 100 Bezeichnung Sechkantmutter i3, i-Brake/Leerlauf/Rcktritt Hutmutter, M10x1 Fixierscheibe i3, i-Brake/Leerlauf/Rcktritt Kappe i3, Leerlauf Set Achsmuttern und Scheiben Stellkonus i3, Leerlauf Sicherungsscheibe Anlaufscheibe i3, I-Brake/Leerlauf Zsb. Planetenradtrger i3, i-Brake/Leerlauf Zsb. Hohlrad i3, i-Brake/Leerlauf Anlaufscheibe Zsb. Klinkentrger i3, i-Brake/Leerlauf/Rcktritt Zsb. Achse mit Festkonus und Schaltbuchse i3, 178mm i-Brake / ohne Bremse / Scheibenbremse Kupplungsstck i3, i-Brake/Leerlauf/Rcktritt Druckfeder i3, i-Brake/Leerlauf/Rcktritt Zsb. Kugelhalter i3, I-Brake/Leerlauf/Rcktritt Scheibe i3, i-Brake/Leerlauf Zsb. Antreiber i3, i-Brake / ohne Bremse Deckel i3, i-Brake/Leerlauf/Rcktritt Zahnkranz-Staubdeckel i3, i-Brake/Leerlauf/Rcktritt Zahnkranz siehe Seite 99 Sprengring Gegenhalter i3, i-Brake/Leerlauf/Rcktritt Zsb Fixierbuchse i3, i-Brake/Leerlauf/Rcktritt Zsb. Schaltseil i3, i-Brake/Leerlauf/Rcktritt Austauschkit Getriebe i3, i-Brake/ohne Bremse/Scheibenbremse 178mm (Nr. 6 18 + 24) Description Hex Nut i3 IGH I-Brake, Coaster Brake, no brake qty 1 Axle Nut Cap Retaining washer i3 IGH i-Brake/Coaster Brake, qty 10 Protective Cap i3 IGH 32/36h no Brake, qty 1 Set, Nuts/Washers i9, i3 IGH Coaster 32/36h, qty 2 Nuts Adjusting Cone i3 IGH no Brake qty 1 Snap Ring i-Motion 3, Qty 10 Thrust Washer i3 IGH/i-Brake/no Brake, qty 1 Planet Pinion Carrier Assy i3 IGH/i-Brake/no Brake Gear Ring Assy i3 IGH/i-Brake/no Brake Thrust washer i3 Pawl Carrier Assy i3 IGH i-Brake/Coaster Brake/no Brake Axle Assy with Fixed Cone and Shifting Bushing i3 IGH/i-Brake/ no Brake Coupler i3 IGH i-Brake/Coaster Brake Compression Spring i3 IGH i-Brake/Coaster Brake, qty 1 Ball Retainer Assy i3 IGH i-Brake/Coaster Brake Washer i3 IGH/i-Brake/no Brake, qty 1 Driver Assy i3 IGH/i-Brake/no Brake Cover i3 IGH i-Brake/Coaster Brake, qty 1 Sprocket - Dust Cover i3 IGH i-Brake/Coaster Brake, qty 1 Sprocket see page 99 Sprocket Lock Ring i3, Sparc, S7, P5, T3 Counter Support i-Motion 3, Qty 1 Fixing Bush Assy i3 IGH i-Brake/Coaster Brake Gearshift Cable Assy i3 IGH i-Brake/Coaster Brake/no Brake Complete gear set i3, i-Brake/no Brake/Disc, Axle 178mm (No. 6 18 + 24)

40 41 42

11 3115 021 000 11 3115 020 000 11 2215 004 000

Kappe, i3 Schalter Verbindungslasche, i3 Nabe Kunststoffgegenhalter

Cable Change Cap, i3 Shifter, qty 2 Shifter Connector Strap, i3 Hub qty 1 Cable Retainer i-3 Shifter

00 0391 017 000

Montagewerkzeug i-MOTION 3 Schaltzug (siehe Seite 101)

Mounting Tool for i-MOTION 3 shift Cable (see Page 101)

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

19

i-MOTION 3 SCHEIBENBREMSE i-MOTION 3 DISC BRAKE41

23 13 4 3 2 11 1a 10 9 8 20 7 5 6 17 11 16 18 19 21 22 2 1a 1 11 42 12

1

15 14

40

20

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

i-MOTION 3 SCHEIBENBREMSE i-MOTION 3 DISC BRAKENr. No. 1 1a 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 Artikelnummer Part Number 65 0316 003 000 00 0391 042 000 00 0391 021 000 00 0991 001 000 00 0391 027 000 00 0391 019 000 65 0318 003 000 65 0372 004 000 65 0381 001 000 65 2318 016 000 65 0372 002 000 00 0391 040 000 65 0341 002 000 65 0325 002 000 65 0376 003 000 65 0318 002 000 65 0372 003 000 00 0391 029 000 65 0321 007 000 65 1004 . . . . . . 65 0512 011 000 00 0391 020 000 00 0391 028 000 65 0388 001 000 00 0389 008 100 Bezeichnung Sechkantmutter i3, i-Brake/Leerlauf/Rcktritt Hutmutter, M10x1 Fixierscheibe i3, i-Brake/Leerlauf/Rcktritt Set Achsmuttern und Scheiben Stellkonus i3, i-Brake Sicherungsscheibe Anlaufscheibe i3, I-Brake/Leerlauf Zsb. Planetenradtrger i3, i-Brake/Leerlauf Zsb. Hohlrad i3, i-Brake/Leerlauf Anlaufscheibe Zsb. Klinkentrger i3, i-Brake/Leerlauf/Rcktritt Zsb. Achse mit Festkonus und Schaltbuchse i3, 178mm i-Brake / ohne Bremse / Scheibenbremse Kupplungsstck i3, i-Brake/Leerlauf/Rcktritt Druckfeder i3, i-Brake/Leerlauf/Rcktritt Zsb. Kugelhalter i3, I-Brake/Leerlauf/Rcktritt Scheibe i3, i-Brake/Leerlauf Zsb. Antreiber i3, i-Brake / ohne Bremse Deckel i3, i-Brake/Leerlauf/Rcktritt Zahnkranz-Staubdeckel i3, i-Brake/Leerlauf/Rcktritt Zahnkranz siehe Seite 99 Sprengring Gegenhalter i3, i-Brake/Leerlauf/Rcktritt Zsb Fixierbuchse i3, i-Brake/Leerlauf/Rcktritt Zsb. Schaltseil i3, i-Brake/Leerlauf/Rcktritt Austauschkit Getriebe i3, i-Brake/ohne Bremse/Scheibenbremse, 178mm (Nr. 5 17 + 23) Description Hex Nut i3 IGH I-Brake, Coaster Brake, no brake qty 1 Axle Nut Cap Retaining washer i3 IGH i-Brake/Coaster Brake, qty 10 Set, Nuts/Washers i9, i3 IGH Coaster 32/36h, qty 2 Nuts Adjusting Cone Assy iMotion 3 Disc Snap Ring i-Motion 3, Qty 10 Thrust Washer i3 IGH/i-Brake/no Brake, qty 1 Planet Pinion Carrier Assy i3 IGH/i-Brake/no Brake Gear Ring Assy i3 IGH/i-Brake/no Brake Thrust washer i3 Pawl Carrier Assy i3 IGH i-Brake/Coaster Brake/no Brake Axle Assy with Fixed Cone and Shifting Bushing i3 IGH/i-Brake/ no Brake Coupler i3 IGH i-Brake/Coaster Brake Compression Spring i3 IGH i-Brake/Coaster Brake, qty 1 Ball Retainer Assy i3 IGH i-Brake/Coaster Brake Washer i3 IGH/i-Brake/no Brake, qty 1 Driver Assy i3 IGH/i-Brake/no Brake Cover i3 IGH i-Brake/Coaster Brake, qty 1 Sprocket - Dust Cover i3 IGH i-Brake/Coaster Brake, qty 1 Sprocket see page 99 Sprocket Lock Ring i3, Sparc, S7, P5, T3 Counter Support i-Motion 3, Qty 1 Fixing Bushing Assy iMotion 3 Disc Gearshift Cable Assy i3 IGH i-Brake/Coaster Brake/no Brake Complete gear set i3, i-Brake/no Brake/Disc, Axle 178mm (No. 5 17 + 23)

40 41 42

11 3115 021 000 11 3115 020 000 11 2215 004 000

Kappe, i3 Schalter Verbindungslasche, i3 Nabe Kunststoffgegenhalter

Cable Change Cap, i3 Shifter, qty 2 Shifter Connector Strap, i3 Hub qty 1 Cable Retainer i-3 Shifter

00 0391 017 000

Montagewerkzeug i-MOTION 3 Schaltzug (siehe Seite 101)

Mounting Tool for i-MOTION 3 shift Cable (see Page 101)

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

21

i-MOTION 3 i-BRAKE i-MOTION 3 i-BRAKE

(bis Juli 07) (till July 07)

29 30

1a 28 2 1 3 4

31

32 33

42

1 41 9 8 11 2 10 1a

6

7

5 40

22

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

i-MOTION 3 i-BRAKE i-MOTION 3 i-BRAKENr. No. 1 1a 2 3 4 5 6 7 8 9 10 11 Artikelnummer Part Number 65 0316 003 000 00 0391 042 000 00 0391 021 000 65 0334 003 000 65 0308 003 000 00 0389 008 100 65 0321 007 000 65 1004 . . . . . . 65 0512 011 000 00 0391 020 000 65 0378 008 000 65 0388 001 000 . . 0326 . . . . . . Bezeichnung

(bis Juli 07) (till July 07)

Description Hex Nut i3 IGH I-Brake, Coaster Brake, no brake qty 1 Axle Nut Cap Retaining washer i3 IGH i-Brake/Coaster Brake, qty 10 Bush i3 GearHub, i-Brake 32/36h Adjusting Cone i3 GearHub, i-Brake 32/36h qty 1 Complete gear set, i3, i-Brake/no Brake Axle, 178mm Sprocket - Dust Cover i3 IGH i-Brake/Coaster Brake, qty 1 Sprocket see page 99 Sprocket Lock Ring i3, Sparc, S7, P5, T3 Counter Support i-Motion 3, Qty 1 Fixing Bush Assy i3 IGH i-Brake/Coaster Brake Gearshift Cable Assy i3 IGH i-Brake/Coaster Brake/no Brake Pipe Clamps see page 100

Sechkantmutter i3, i-Brake/Leerlauf/Rcktritt Hutmutter, M10x1 Fixierscheibe i3, i-Brake/Leerlauf/Rcktritt Buchse i3, i-Brake Stellkonus i3, i-Brake Austauschkit Getriebe i3, i-Brake/ohne Bremse/Scheibenbremse 178mm Zahnkranz-Staubdeckel i3, i-Brake/Leerlauf/Rcktritt Zahnkranz siehe Seite 99 Sprengring Gegenhalter i3, i-Brake/Leerlauf/Rcktritt Zsb Fixierbuchse i3, i-Brake/Leerlauf/Rcktritt Zsb. Schaltseil i3, i-Brake/Leerlauf/Rcktritt Rohrschellen siehe Seite 100

28 29 30 31 32 32 33

11 3115 019 000 11 3115 012 000 11 3115 006 000 11 3115 016 000 11 3115 008 000 11 3115 029 000 11 3115 015 000

Zsb. Fixierbuchse Zsb. Bremstrger hinten Torx Zylinderkopfschraube fr Bremstrommel, 4 Stck Zsb. Gegenhalter Faltenbalg, Set fr i-Brake hinten und vorne Faltenbalg hinten Zsb. Bremszugeinhngung hinten

Fixing Bush Assy, i3 Hub/i-Brake qty 1 Brake Carrier Rear, Dual Drive/P5/S7/T3 iBrake qty 1 Cylinder Screws, Drum Brake, qty 4, T3/iBrake Holder Assy, Dual Drive/S7/iBrake/Fr Hub qty 1 Bellows F/R, qty 5, S7/iBrake - F/R Bellow Rear i-Brake, Qty 1 Link/Brake Cable, R, Dual Drive/P5/iBrake, qty 1

40 41 42

11 3115 021 000 11 3115 020 000 11 2215 004 000

Kappe, i3 Schalter Verbindungslasche, i3 Nabe Kunststoffgegenhalter

Cable Change Cap, i3 Shifter, qty 2 Shifter Connector Strap, i3 Hub qty 1 Cable Retainer i-3 Shifter

00 0391 017 000

Montagewerkzeug i-MOTION 3 Schaltzug (siehe Seite 101)

Mounting Tool for i-MOTION 3 shift Cable (see Page 101)

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

23

i-MOTION 3 i-BRAKE i-MOTION 3 i-BRAKE

(ab August 07) (as of August 07)

41 29 30 23 1a 28 2 1 11 42 11 31 3 12 4

32 9 33 8

10

21 20

5

6

7 17 11 1 15 13 14 40 16 22 2 1a 18 19

24

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

i-MOTION 3 i-BRAKE i-MOTION 3 i-BRAKENr. No. 1 1a 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 Artikelnummer Part Number 65 0316 003 000 00 0391 042 000 00 0391 021 000 65 0334 003 000 65 0308 003 000 00 0391 019 000 65 0318 003 000 65 0372 004 000 65 0381 001 000 65 2318 016 000 65 0372 002 000 00 0391 040 000 65 0341 002 000 65 0325 002 000 65 0376 003 000 65 0318 002 000 65 0372 003 000 00 0391 029 000 65 0321 007 000 65 1004 . . . . . . 65 0512 011 000 00 0391 020 000 65 0378 008 000 65 0388 001 000 . . 0326 . . . . . . 00 0389 008 100 Bezeichnung

(ab August 07) (as of August 07)

Description Hex Nut i3 IGH I-Brake, Coaster Brake, no brake qty 1 Axle Nut Cap Retaining washer i3 IGH i-Brake/Coaster Brake, qty 10 Bush i3 GearHub, i-Brake 32/36h Adjusting Cone i3 GearHub, i-Brake 32/36h qty 1 Snap Ring i-Motion 3, Qty 10 Thrust Washer i3 IGH/i-Brake/no Brake, qty 1 Planet Pinion Carrier Assy i3 IGH/i-Brake/no Brake Gear Ring Assy i3 IGH/i-Brake/no Brake Thrust washer i3 Pawl Carrier Assy i3 IGH i-Brake/Coaster Brake/no Brake Axle Assy with Fixed Cone and Shifting Bushing i3 IGH/i-Brake/ no Brake Coupler i3 IGH i-Brake/Coaster Brake Compression Spring i3 IGH i-Brake/Coaster Brake, qty 1 Ball Retainer Assy i3 IGH i-Brake/Coaster Brake Washer i3 IGH/i-Brake/no Brake, qty 1 Driver Assy i3 IGH/i-Brake/no Brake Cover i3 IGH i-Brake/Coaster Brake, qty 1 Sprocket - Dust Cover i3 IGH i-Brake/Coaster Brake, qty 1 Sprocket see page 99 Sprocket Lock Ring i3, Sparc, S7, P5, T3 Counter Support i-Motion 3, Qty 1 Fixing Bush Assy i3 IGH i-Brake/Coaster Brake Gearshift Cable Assy i3 IGH i-Brake/Coaster Brake/no Brake Pipe Clamps see page 100 Exchange Kit i3, i-Brake/no Brake Axle 178mm (No. 5 17 + 23)

Sechkantmutter i3, i-Brake/Leerlauf/Rcktritt Hutmutter, M10x1 Fixierscheibe i3, i-Brake/Leerlauf/Rcktritt Buchse i3, i-Brake Stellkonus i3, i-Brake Sicherungsscheibe Anlaufscheibe i3, I-Brake/Leerlauf Zsb. Planetenradtrger i3, i-Brake/Leerlauf Zsb. Hohlrad i3, i-Brake/Leerlauf Anlaufscheibe Zsb. Klinkentrger i3, i-Brake/Leerlauf/Rcktritt Zsb. Achse mit Festkonus und Schaltbuchse i3, 178mm i-Brake / ohne Bremse / Scheibenbremse Kupplungsstck i3, i-Brake/Leerlauf/Rcktritt Druckfeder i3, i-Brake/Leerlauf/Rcktritt Zsb. Kugelhalter i3, i-Brake/Leerlauf/Rcktritt Scheibe i3, i-Brake/Leerlauf Zsb. Antreiber i3, i-Brake/ Leerlauf Deckel i3, i-Brake/Leerlauf/Rcktritt Zahnkranz-Staubdeckel i3, i-Brake/Leerlauf/Rcktritt Zahnkranz siehe Seite 99 Sprengring Gegenhalter i3, i-Brake/Leerlauf/Rcktritt Zsb Fixierbuchse i3, i-Brake/Leerlauf/Rcktritt Zsb. Schaltseil i3, i-Brake/Leerlauf/Rcktritt Rohrschellen siehe Seite 100 Austauschkit Getriebe i3, i-Brake/ohne Bremse/Scheibenbremse 178mm (Nr. 5 17 + 23)

28 29 30 31 32 32 33

11 3115 019 000 11 3115 012 000 11 3115 006 000 11 3115 016 000 11 3115 008 000 11 3115 029 000 11 3115 015 000

Zsb. Fixierbuchse Zsb. Bremstrger hinten Torx Zylinderkopfschraube fr Bremstrommel, 4 Stck Zsb. Gegenhalter Faltenbalg, Set fr i-Brake hinten und vorne Faltenbalg hinten Zsb. Bremszugeinhngung hinten

Fixing Bush Assy, i3 Hub/i-Brake qty 1 Brake Carrier Rear, Dual Drive/P5/S7/T3 iBrake qty 1 Cylinder Screws, Drum Brake, qty 4, T3/iBrake Holder Assy, Dual Drive/S7/iBrake/Fr Hub qty 1 Bellows F/R, qty 5, S7/iBrake - F/R Bellow Rear i-Brake, Qty 1 Link/Brake Cable, R, Dual Drive/P5/iBrake, qty 1

40 41 42

11 3115 021 000 11 3115 020 000 11 2215 004 000

Kappe, i3 Schalter Verbindungslasche, i3 Nabe Kunststoffgegenhalter

Cable Change Cap, i3 Shifter, qty 2 Shifter Connector Strap, i3 Hub qty 1 Cable Retainer i-3 Shifter

00 0391 017 000

Montagewerkzeug i-MOTION 3 Schaltzug (siehe Seite 101)

Mounting Tool for i-MOTION 3 shift Cable (see Page 101)

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

25

i-MOTION 3 i-BRAKE i-MOTION 3 i-BRAKE

Version ohne Schaltzug-Gegenhalter (ab August 07) Version without cable stop bracket (as of August 07)

41 29 30 21 1a 28 2 1 11 3 12 4

11 31

32 9 33 8

10

20

5

6

7

17 11 16

18

19

1 2 1a

15 13 14

40

26

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

i-MOTION 3 i-BRAKE i-MOTION 3 i-BRAKENr. No. 1 1a 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 Artikelnummer Part Number 65 0316 003 000 00 0391 042 000 00 0391 021 000 65 0334 003 000 65 0308 003 000 00 0391 019 000 65 0318 003 000 65 0372 004 000 65 0381 001 000 65 2318 016 000 65 0372 002 000 00 0391 040 000 65 0341 002 000 65 0325 002 000 65 0376 003 000 65 0318 002 000 65 0372 003 000 00 0391 029 000 65 0321 007 000 65 1004 . . . . . . 65 0512 011 000 00 0391 036 000 . . 0326 . . . . . . 00 0389 012 000 Bezeichnung

Version ohne Schaltzug-Gegenhalter (ab August 07) Version without cable stop bracket (as of August 07)

Description Hex Nut i3 IGH I-Brake, Coaster Brake, no brake qty 1 Axle Nut Cap Retaining washer i3 IGH i-Brake/Coaster Brake, qty 10 Bush i3 GearHub, i-Brake 32/36h Adjusting Cone i3 GearHub, i-Brake 32/36h qty 1 Snap Ring i-Motion 3, Qty 10 Thrust Washer i3 IGH/i-Brake/no Brake, qty 1 Planet Pinion Carrier Assy i3 IGH/i-Brake/no Brake Gear Ring Assy i3 IGH/i-Brake/no Brake Thrust washer i3 Pawl Carrier Assy i3 IGH i-Brake/Coaster Brake/no Brake Axle Assy with Fixed Cone and Shifting Bushing i3 IGH/i-Brake/ no Brake Coupler i3 IGH i-Brake/Coaster Brake Compression Spring i3 IGH i-Brake/Coaster Brake, qty 1 Ball Retainer Assy i3 IGH i-Brake/Coaster Brake Washer i3 IGH/i-Brake/no Brake, qty 1 Driver Assy i3 IGH/i-Brake/no Brake Cover i3 IGH i-Brake/Coaster Brake, qty 1 Sprocket - Dust Cover i3 IGH i-Brake/Coaster Brake, qty 1 Sprocket see page 99 Sprocket Lock Ring i3, Sparc, S7, P5, T3 Gearshift Cable Assy i3 Coaster Brake Version without Cable stop bracket Pipe Clamps see page 100 Exchange Kit i3, i-Brake/no Brake Axle, Version without Cable stop bracket, 178mm (No. 5 17 + 21)

Sechkantmutter i3, i-Brake/Leerlauf/Rcktritt Hutmutter, M10x1 Fixierscheibe i3, i-Brake/Leerlauf/Rcktritt Buchse i3, i-Brake Stellkonus i3, i-Brake Sicherungsscheibe Anlaufscheibe i3, I-Brake/Leerlauf Zsb. Planetenradtrger i3, i-Brake/Leerlauf Zsb. Hohlrad i3, i-Brake/Leerlauf Anlaufscheibe Zsb. Klinkentrger i3, i-Brake/Leerlauf/Rcktritt Zsb. Achse mit Festkonus und Schaltbuchse i3, 178mm i-Brake / ohne Bremse / Scheibenbremse Kupplungsstck i3, i-Brake/Leerlauf/Rcktritt Druckfeder i3, i-Brake/Leerlauf/Rcktritt Zsb. Kugelhalter i3, i-Brake/Leerlauf/Rcktritt Scheibe i3, i-Brake/Leerlauf Zsb. Antreiber i3, i-Brake/ Leerlauf Deckel i3, i-Brake/Leerlauf/Rcktritt Zahnkranz-Staubdeckel i3, i-Brake/Leerlauf/Rcktritt Zahnkranz siehe Seite 99 Sprengring Zsb. Schaltseil i3, Rcktritt, Version ohne Schaltzug-Gegenhalter Rohrschellen siehe Seite 100 Austauschkit Getriebe i3, i-Brake/Leeflauf, fr Version ohne Schaltzug-Gegenhalter 178mm (Nr. 5 17 + 21)

28 29 30 31 32 32 33

11 3115 019 000 11 3115 012 000 11 3115 006 000 11 3115 016 000 11 3115 008 000 11 3115 029 000 11 3115 015 000

Zsb. Fixierbuchse Zsb. Bremstrger hinten Torx Zylinderkopfschraube fr Bremstrommel, 4 Stck Zsb. Gegenhalter Faltenbalg, Set fr i-Brake hinten und vorne Faltenbalg hinten Zsb. Bremszugeinhngung hinten

Fixing Bush Assy, i3 Hub/i-Brake qty 1 Brake Carrier Rear, Dual Drive/P5/S7/T3 iBrake qty 1 Cylinder Screws, Drum Brake, qty 4, T3/iBrake Holder Assy, Dual Drive/S7/iBrake/Fr Hub qty 1 Bellows F/R, qty 5, S7/iBrake - F/R Bellow Rear i-Brake, Qty 1 Link/Brake Cable, R, Dual Drive/P5/iBrake, qty 1

40

11 3115 021 000

Kappe, i3 Schalter

Cable Change Cap, i3 Shifter, qty 2

41

65 0570 140 100

Klemmhlse T3

Locating Sleeve T3

00 0391 017 000

Montagewerkzeug i-MOTION 3 Schaltzug (siehe Seite 101)

Mounting Tool for i-MOTION 3 shift Cable (see Page 101)

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

27

DUALDRIVE / DUALDRIVE II OHNE BREMSE (bis Februar 08) DUALDRIVE / DUALDRIVE II WITHOUT BRAKE (till February 08)

4 3 11 2 1 2a 1a 10 9 17

9 8 6 5 7 15 16

14 13 1 3 9 2a

18

9

51

40 39 33 31

38

36 37 34

30

35 32Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

28

DUALDRIVE / DUALDRIVE II OHNE BREMSE (bis Februar 08) DUALDRIVE / DUALDRIVE II WITHOUT BRAKE (till February 08)Nr. No. 1 1a 2 2a 3 4 5 6 7 8 9 10 11 13 14 15 16 17 18 Artikelnummer Part Number 65 0516 003 100 65 0516 107 000 65 0517 110 100 65 0517 102 000 65 0516 111 000 00 0391 014 000 65 0325 122 100 65 0517 002 100 65 0318 105 100 65 0372 111 100 00 0391 011 100 65 2318 016 000 00 0391 041 000 65 0325 119 100 65 0376 104 000 00 0391 015 000 00 0391 012 000 65 0308 012 000 65 0328 002 004 00 0389 005 000 00 0389 005 001 Bezeichnung Sechskantmutter FG 10,5 Hutmutter FG 10,5 (alternativ zu Nr. 1) Fixierscheibe mit Haltenase (3,5 mm dick, auf linke Achsseite) Fixierscheibe ohne Haltenase (alternativ zu Nr. 2: 2 Scheiben / beidseitig Sechkantmutter FG 10,5 ET-Set Zsb. Stellkonus mit Staubdeckel Druckfeder Sicherungsscheibe Anlaufscheibe Zsb. Planetenradtrger Zsb. Hohlrad und Zsb. Schaltbuchse Anlaufscheibe Zsb. Achse Druckfeder Kugelhalter Antreiber 24 / 27 Gang (fr 8/9-fach Kassetten) Set Rillenkugellager, Kugelhalter, Staubdeckel fr Antreiber Festkonus Schaltstift Komplettes Getriebe (Nr. 6 - 18 + 3 ) 24 und 27 Gang Komplettes Getriebe (Nr. 6 - 18 + 3 ) 21 Gang Description Axle Nut FG 10,5 Dual Drive, Sparc, S7, P5, T3 Axle Cap Nut FG 10,5 (alternative to No. 1) Dual Drive, Sparc, S7, P5, T3 Retaining Washer with Extention (3,5mm thick, on left Axle end) Dual Drive, Sparc, S7, P5, T3 Retaining Washer without Extention (alternative to No. 2: 2 washers / both sides) Dual Drive Hex Nut FG 10,5 Dual Drive, Sparc, S7, P5, T3 SP Set Assy Adjustable Cone with Dust Cap Dual Drive, Qty 1 Compression Spring Dual Drive, qty 1 Snap Ring i3, Dual Drive, T3 Thrust washer Dual Drive, qty 1 Assy Planet Gear Carrier Dual Drive Assy Gear Ring with Assy shift bushing Dual Drive, Qty 1 Thrust washer i3 Complete Axle, Dual Drive Compression Spring Dual Drive, qty 1 Bearing Retainer Dual Drive SP Set Assy Driver for Dual Drive (Drive 24/27 Speed for 8Speed casSettes), Qty 1 Set, Cartridge bearing, ball Retainer, Dust Cap for Driver Dual Drive, Qty 1 Fixed Cone Dual Drive, qty 1 Shift Rod Dual Drive, qty 1 Complete Gear Set ( No. 6 - 18 + 3 ) 24 and 27 Speed Dual Drive Complete Gear Set ( No. 6 - 18 + 3 ) 21 Speed Dual Drive

30 30 31 32 33 34 35 36 37 38 39 40

65 0303 050 010 65 0303 050 011 00 1199 100 022 00 0000 200 062 11 3115 022 000 11 3115 026 000 65 0315 041 000 11 3115 000 000 65 0318 107 000 11 3115 032 000 11 3115 033 000 11 7915 001 000

Speichenschutzscheibe 36 Loch, transparent (3 Haken) Speichenschutzscheibe 32 Loch, transparent (4 Haken) Kettenfhrungsgabel Zsb. Clickbox, schwarz Seilhlle 2300 mm Kappe Kabelklemmschraube Einstellmutter Klemmblech Abdeckung 7 / 8-Gang Knopf fr Schalter 24 Gang bis Modell 03 / 21 Gang ab Modell 04 Zsb. Drehgriff

Spoke protector 36 holes, transparent (3 snaps) Dual Drive, qty 1 Spoke protector 32 holes, transparent (4 snaps) Dual Drive, qty 1 Chain guide fork Dual Drive, qty 1 Assembly Clickbox Black (AM) Cable Housing S7 IGH shifter, 2300mm Dual Drive, Sparc, P5, qty 5 Cover Dual Drive qty 1 Clamping screw Dual Drive qty 1 Adjuster Nut Indexed, Dual Drive/iBrake, qty 2 Clamping blade Dual Drive, qty 1 Cover 7 / 8 Speed Dual Drive, qty 1 Button 24 Speed till model 03 / 21 Speed as from model 04 Dual Drive, qty 1 DualDrive Grip, Twist, 8/9spd, Qty 1

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

29

DUALDRIVE / DUALDRIVE II OHNE BREMSE (ab Mrz 08) DUALDRIVE / DUALDRIVE II WITHOUT BRAKE (as of March 08)

4 3 10 2 1 2a 1a 8 9 15 8 7 5 6 13 16 12 11 1 3 8 2a 14

9

51

40 39 33 31

38

36 37 34

30

35 32Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

30

DUALDRIVE / DUALDRIVE II OHNE BREMSE (ab Mrz 08) DUALDRIVE / DUALDRIVE II WITHOUT BRAKE (as of March 08)Nr. No. 1 1a 2 2a 3 4 5 6 7 8 9 10 11 12 13 14 15 16 Artikelnummer Part Number 65 0516 003 100 65 0516 107 000 65 0517 110 100 65 0517 102 000 65 0516 111 000 00 0391 014 000 65 0517 002 100 65 0318 105 100 65 0372 111 100 00 0391 011 100 65 2318 016 000 00 0391 041 000 65 0325 119 100 65 0376 104 000 00 0391 015 000 00 0391 012 000 65 0308 012 000 65 0328 002 004 00 0389 005 000 00 0389 005 001 Bezeichnung Sechskantmutter FG 10,5 Hutmutter FG 10,5 (alternativ zu Nr. 1) Fixierscheibe mit Haltenase (3,5 mm dick, auf linke Achsseite) Fixierscheibe ohne Haltenase (alternativ zu Nr. 2: 2 Scheiben / beidseitig Sechkantmutter FG 10,5 ET-Set Zsb. Stellkonus mit Staubdeckel Sicherungsscheibe Anlaufscheibe Zsb. Planetenradtrger Zsb. Hohlrad und Zsb. Schaltbuchse Anlaufscheibe Zsb. Achse Druckfeder Kugelhalter Antreiber 24 / 27 Gang (fr 8/9-fach Kassetten) Set Rillenkugellager, Kugelhalter, Staubdeckel fr Antreiber Festkonus Schaltstift Komplettes Getriebe (Nr. 5 16 + 3) 24 und 27 Gang Komplettes Getriebe (Nr. 5 16 + 3) 21 Gang Description Axle Nut FG 10,5 Dual Drive, Sparc, S7, P5, T3 Axle Cap Nut FG 10,5 (alternative to No. 1) Dual Drive, Sparc, S7, P5, T3 Retaining Washer with Extention (3,5mm thick, on left Axle end) Dual Drive, Sparc, S7, P5, T3 Retaining Washer without Extention (alternative to No. 2: 2 washers / both sides) Dual Drive Hex Nut FG 10,5 Dual Drive, Sparc, S7, P5, T3 SP Set Assy Adjustable Cone with Dust Cap Dual Drive, Qty 1 Snap Ring i3, Dual Drive, T3 Thrust washer Dual Drive, qty 1 Assy Planet Gear Carrier Dual Drive Assy Gear Ring with Assy shift bushing Dual Drive, Qty 1 Thrust washer i3 Complete Axle, Dual Drive Compression Spring Dual Drive, qty 1 Bearing Retainer Dual Drive SP Set Assy Driver for Dual Drive (Drive 24/27 Speed for 8Speed casSettes), Qty 1 Set, Cartridge bearing, ball Retainer, Dust Cap for Driver Dual Drive, Qty 1 Fixed Cone Dual Drive, qty 1 Shift Rod Dual Drive, qty 1 Complete Gear Set (No. 5 16 + 3) 24 and 27 Speed Dual Drive Complete Gear Set (No. 5 16 + 3) 21 Speed Dual Drive

30 30 31 32 33 34 35 36 37 38 39 40

65 0303 050 010 65 0303 050 011 00 1199 100 022 00 0000 200 062 11 3115 022 000 11 3115 026 000 65 0315 041 000 11 3115 000 000 65 0318 107 000 11 3115 032 000 11 3115 033 000 11 7915 001 000

Speichenschutzscheibe 36 Loch, transparent (3 Haken) Speichenschutzscheibe 32 Loch, transparent (4 Haken) Kettenfhrungsgabel Zsb. Clickbox, schwarz Seilhlle 2300 mm Kappe Kabelklemmschraube Einstellmutter Klemmblech Abdeckung 7 / 8-Gang Knopf fr Schalter 24 Gang bis Modell 03 / 21 Gang ab Modell 04 Zsb. Drehgriff

Spoke protector 36 holes, transparent (3 snaps) Dual Drive, qty 1 Spoke protector 32 holes, transparent (4 snaps) Dual Drive, qty 1 Chain guide fork Dual Drive, qty 1 Assembly Clickbox Black (AM) Cable Housing S7 IGH shifter, 2300mm Dual Drive, Sparc, P5, qty 5 Cover Dual Drive qty 1 Clamping screw Dual Drive qty 1 Adjuster Nut Indexed, Dual Drive/iBrake, qty 2 Clamping blade Dual Drive, qty 1 Cover 7 / 8 Speed Dual Drive, qty 1 Button 24 Speed till model 03 / 21 Speed as from model 04 Dual Drive, qty 1 DualDrive Grip, Twist, 8/9spd, Qty 1

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

31

DUALDRIVE / DUALDRIVE II SCHEIBENBREMSE (bis Februar 2008) DUALDRIVE / DUALDRIVE II DISC BRAKE (till February 2008)

4 3 2 1 2a 1a 10 9 8 6 5 7 15 16 9 17 11

14 13 1 3 9 2a

18

9

51

40 39 33 31

38

36 37 34

30

35 32Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

32

DUALDRIVE / DUALDRIVE II SCHEIBENBREMSE (bis Februar 2008) DUALDRIVE / DUALDRIVE II DISC BRAKE (till February 2008)Nr. No. 1 1a 2 2a 3 4 5 6 7 8 9 10 11 13 14 15 16 17 18 Artikelnummer Part Number 65 0516 003 100 65 0516 107 000 65 0517 110 100 65 0517 102 000 65 0516 111 000 00 0391 014 000 65 0325 122 100 65 0517 002 100 65 0318 105 100 65 0372 111 100 00 0391 011 100 65 2318 016 000 00 0391 041 000 65 0325 119 100 65 0376 104 000 00 0391 015 000 00 0391 012 000 65 0308 012 000 65 0328 002 004 00 0389 005 000 00 0389 005 001 Bezeichnung Sechskantmutter FG 10,5 Hutmutter FG 10,5 (alternativ zu Nr. 1) Fixierscheibe mit Haltenase (3,5 mm dick, auf linke Achsseite) Fixierscheibe ohne Haltenase (alternativ zu Nr. 2: 2 Scheiben / beidseitig) Sechkantmutter FG 10,5 ET-Set Zsb. Stellkonus mit Staubdeckel Druckfeder Sicherungsscheibe Anlaufscheibe Zsb. Planetenradtrger Zsb. Hohlrad u. Zsb. Schaltbuchse Anlaufscheibe Zsb. Achse Druckfeder Kugelhalter Antreiber 24 / 27 Gang (fr 8/9-fach Kassetten) Set Rillenkugellager, Kugelhalter, Staubdeckel fr Antreiber Festkonus Schaltstift Komplettes Getriebe (Nr. 6 18 + 3) 24 und 27 Gang Komplettes Getriebe (Nr. 6 18 + 3) 21 Gang Description Axle Nut FG 10,5 Dual Drive, Sparc, S7, P5, T3 Axle Cap Nut FG 10,5 (alternative to No. 1) Dual Drive, Sparc, S7, P5, T3 Retaining Washer with Extention (3,5mm thick, on left Axle end) Dual Drive, Sparc, S7, P5, T3 Retaining Washer without Extention (alternative to No. 2: 2 washers / both sides) Dual Drive Hex Nut FG 10,5 Dual Drive, Sparc, S7, P5, T3 SP Set Assy Adjustable Cone with Dust Cap Dual Drive, Qty 1 Compression Spring Dual Drive, qty 1 Snap Ring i3, Dual Drive, T3 Thrust washer Dual Drive, qty 1 Assy Planet Gear Carrier Dual Drive Assy Gear Ring with Assy shift bushing Dual Drive, Qty 1 Thrust washer i3 Complete Axle, Dual Drive Compression Spring Dual Drive, qty 1 Bearing Retainer Dual Drive SP Set Assy Driver for Dual Drive (Drive 24/27 Speed for 8Speed casSettes), Qty 1 Set, Cartridge bearing, ball Retainer, Dust Cap for Driver Dual Drive, Qty 1 Fixed Cone Dual Drive, qty 1 Shift Rod Dual Drive, qty 1 Complete Gear Set (No. 6 18 + 3) 24 and 27 Speed Dual Drive Complete Gear Set (No. 6 18 + 3) 21 Speed Dual Drive

30 30 31 32 33 34 35 36 37 38 39 40

65 0303 050 010 65 0303 050 011 00 1199 100 022 00 0000 200 062 11 3115 022 000 11 3115 026 000 65 0315 041 000 11 3115 000 000 65 0318 107 000 11 3115 032 000 11 3115 033 000 11 7915 001 000

Speichenschutzscheibe 36 Loch, transparent (3 Haken) Speichenschutzscheibe 32 Loch, transparent (4 Haken) Kettenfhrungsgabel Zsb. Clickbox, schwarz Seilhlle 2300 mm Kappe Kabelklemmschraube Einstellmutter Klemmblech Abdeckung 7 / 8-Gang Knopf fr Schalter 24 Gang bis Modell 03 / 21 Gang ab Modell 04 Zsb. Drehgriff

Spoke protector 36 holes, transparent (3 snaps) Dual Drive, qty 1 Spoke protector 32 holes, transparent (4 snaps) Dual Drive, qty 1 Chain guide fork Dual Drive, qty 1 Assembly Clickbox Black (AM) Cable Housing S7 IGH shifter, 2300mm Dual Drive, Sparc, P5, qty 5 Cover Dual Drive qty 1 Clamping screw Dual Drive qty 1 Adjuster Nut Indexed, Dual Drive/iBrake, qty 2 Clamping blade Dual Drive, qty 1 Cover 7 / 8 Speed Dual Drive, qty 1 Button 24 Speed till model 03 / 21 Speed as from model 04 Dual Drive, qty 1 DualDrive Grip, Twist, 8/9spd, Qty 1

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

33

DUALDRIVE / DUALDRIVE II SCHEIBENBREMSE (ab Mrz 2008) DUALDRIVE / DUALDRIVE II DISC BRAKE (as of March 2008)

4 3 10 2 1 2a 1a 8 9 15 8 7 5 6 13 16 12 11 1 3 8 2a 14

9

51

40 39 33 31

38

36 37 34

30

35 32Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

34

DUALDRIVE / DUALDRIVE II SCHEIBENBREMSE (ab Mrz 2008) DUALDRIVE / DUALDRIVE II DISC BRAKE (as of March 2008)Nr. No. 1 1a 2 2a 3 4 5 6 7 8 9 10 11 12 13 14 15 16 Artikelnummer Part Number 65 0516 003 100 65 0516 107 000 65 0517 110 100 65 0517 102 000 65 0516 111 000 00 0391 014 000 65 0517 002 100 65 0318 105 100 65 0372 111 100 00 0391 011 100 65 2318 016 000 00 0391 041 000 65 0325 119 100 65 0376 104 000 00 0391 015 000 00 0391 012 000 65 0308 012 000 65 0328 002 004 00 0389 005 000 00 0389 005 001 Bezeichnung Sechskantmutter FG 10,5 Hutmutter FG 10,5 (alternativ zu Nr. 1) Fixierscheibe mit Haltenase (3,5 mm dick, auf linke Achsseite) Fixierscheibe ohne Haltenase (alternativ zu Nr. 2: 2 Scheiben / beidseitig) Sechkantmutter FG 10,5 ET-Set Zsb. Stellkonus mit Staubdeckel Sicherungsscheibe Anlaufscheibe Zsb. Planetenradtrger Zsb. Hohlrad u. Zsb. Schaltbuchse Anlaufscheibe Zsb. Achse Druckfeder Kugelhalter Antreiber 24 / 27 Gang (fr 8/9-fach Kassetten) Set Rillenkugellager, Kugelhalter, Staubdeckel fr Antreiber Festkonus Schaltstift Komplettes Getriebe (Nr. 5 16 + 3) 24 und 27 Gang Komplettes Getriebe (Nr. 5 16 + 3) 21 Gang Description Axle Nut FG 10,5 Dual Drive, Sparc, S7, P5, T3 Axle Cap Nut FG 10,5 (alternative to No. 1) Dual Drive, Sparc, S7, P5, T3 Retaining Washer with Extention (3,5mm thick, on left Axle end) Dual Drive, Sparc, S7, P5, T3 Retaining Washer without Extention (alternative to No. 2: 2 washers / both sides) Dual Drive Hex Nut FG 10,5 Dual Drive, Sparc, S7, P5, T3 SP Set Assy Adjustable Cone with Dust Cap Dual Drive, Qty 1 Snap Ring i3, Dual Drive, T3 Thrust washer Dual Drive, qty 1 Assy Planet Gear Carrier Dual Drive Assy Gear Ring with Assy shift bushing Dual Drive, Qty 1 Thrust washer i3 Complete Axle, Dual Drive Compression Spring Dual Drive, qty 1 Bearing Retainer Dual Drive SP Set Assy Driver for Dual Drive (Drive 24/27 Speed for 8Speed casSettes), Qty 1 Set, Cartridge bearing, ball Retainer, Dust Cap for Driver Dual Drive, Qty 1 Fixed Cone Dual Drive, qty 1 Shift Rod Dual Drive, qty 1 Complete Gear Set (No. 5 16 + 3) 24 and 27 Speed Dual Drive Complete Gear Set (No. 5 16 + 3) 21 Speed Dual Drive

30 30 31 32 33 34 35 36 37 38 39 40

65 0303 050 010 65 0303 050 011 00 1199 100 022 00 0000 200 062 11 3115 022 000 11 3115 026 000 65 0315 041 000 11 3115 000 000 65 0318 107 000 11 3115 032 000 11 3115 033 000 11 7915 001 000

Speichenschutzscheibe 36 Loch, transparent (3 Haken) Speichenschutzscheibe 32 Loch, transparent (4 Haken) Kettenfhrungsgabel Zsb. Clickbox, schwarz Seilhlle 2300 mm Kappe Kabelklemmschraube Einstellmutter Klemmblech Abdeckung 7 / 8-Gang Knopf fr Schalter 24 Gang bis Modell 03 / 21 Gang ab Modell 04 Zsb. Drehgriff

Spoke protector 36 holes, transparent (3 snaps) Dual Drive, qty 1 Spoke protector 32 holes, transparent (4 snaps) Dual Drive, qty 1 Chain guide fork Dual Drive, qty 1 Assembly Clickbox Black (AM) Cable Housing S7 IGH shifter, 2300mm Dual Drive, Sparc, P5, qty 5 Cover Dual Drive qty 1 Clamping screw Dual Drive qty 1 Adjuster Nut Indexed, Dual Drive/iBrake, qty 2 Clamping blade Dual Drive, qty 1 Cover 7 / 8 Speed Dual Drive, qty 1 Button 24 Speed till model 03 / 21 Speed as from model 04 Dual Drive, qty 1 DualDrive Grip, Twist, 8/9spd, Qty 1

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

35

DUALDRIVE / DUALDRIVE II i-BRAKE DUALDRIVE / DUALDRIVE II i-BRAKE

(bis Februar 2008) (till February 2008)

2a 1a 2 1 7 6 4 22 24 12 25 23 10 26 8 9 17 27 15 16 21 18 3 11 5

11

11 20 13 18 189

1 19 2a

51

40 39 33 31

38

36 37 34

30

35 32Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

36

DUALDRIVE / DUALDRIVE II i-BRAKE DUALDRIVE / DUALDRIVE II i-BRAKENr. No. 1 1a 2 2a 3 4 5 6 7 8 9 10 11 12 13 15 16 17 18 19 20 21 Artikelnummer Part Number 65 0516 003 100 65 0516 107 000 65 0517 110 100 65 0517 102 000 65 0334 129 000 65 0308 014 000 65 0321 110 000 65 2376 003 000 65 0325 122 100 65 0517 002 100 65 0318 105 100 65 0372 111 100 00 0391 011 100 65 2318 016 000 00 0391 041 000 65 0325 119 100 65 0376 104 000 00 0391 015 000 00 0391 012 000 65 0308 012 000 65 0516 111 000 65 0328 002 004 00 0389 005 000 00 0389 005 001 Bezeichnung Sechskantmutter FG 10,5 Hutmutter FG 10,5 (alternativ zu Nr. 1) Fixierscheibe mit Haltenase (3,5 mm dick, auf linke Achsseite) Fixierscheibe ohne Haltenase (alternativ zu Nr. 2: 2 Scheiben / beidseitig) Buchse Stellkonus Dichtkappe Kugelhalter Druckfeder Sicherungsscheibe Anlaufscheibe Zsb. Planetenradtrger Zsb. Hohlrad u. Zsb. Schaltbuchse Anlaufscheibe Zsb. Achse Druckfeder Kugelhalter Antreiber 24 / 27 Gang (fr 8/9-fach Kassetten) Set Rillenkugellager, Kugelhalter, Staubdeckel fr Antreiber Festkonus Sechskantmutter FG 10,5 Schaltstift Komplettes Getriebe (Nr. 8 21) 24 und 27 Gang Komplettes Getriebe (Nr. 8 21) 21 Gang

(bis Februar 2008) (till February 2008)

Description Axle Nut FG 10,5 Dual Drive, Sparc, S7, P5, T3 Axle Cap Nut FG 10,5 (alternative to No. 1) Dual Drive, Sparc, S7, P5, T3 Retaining Washer with Extention (3,5mm thick, on left Axle end) Dual Drive, Sparc, S7, P5, T3 Retaining Washer without Extention (alternative to No. 2: 2 washers / both sides) Dual Drive Bushing Dual Drive, S7, P5, T3 Adjustable Cone Dual Drive, S7, P5, T3 qty 1 Dust Cap Dual Drive iBrake, S7, P5, T3, qty 1 (note bag 5) Ball Retainer Dual Drive, S7 Compression Spring Dual Drive, qty 1 Snap Ring i3, Dual Drive, T3 Thrust washer Dual Drive, qty 1 Assy Planet Gear Carrier Dual Drive Assy Gear Ring with Assy shift bushing Dual Drive, Qty 1 Thrust washer i3 Complete Axle, Dual Drive Compression Spring Dual Drive, qty 1 Bearing Retainer Dual Drive SP Set Assy Driver for Dual Drive (Drive 24/27 Speed for 8Speed cassettes), Qty 1 Set, Cartridge bearing, ball Retainer, Dust Cap for Driver Dual Drive, Qty 1 Fixed Cone Dual Drive, qty 1 Hex Nut FG 10,5 Dual Drive, Sparc, S7, P5, T3 Shift Rod Dual Drive, qty 1 Complete Gear Set (No. 8 21) 24 and 27 Speed Dual Drive Complete Gear Set (No. 8 21) 21 Speed Dual Drive

22 23 24 25 26 26 27

11 3115 013 000 11 3115 012 000 11 3115 007 000 11 3115 016 000 11 3115 008 000 11 3115 029 000 11 3115 015 000

Fixierbuchse Zsb. Bremstrger hinten Torx Senkkopfschraube fr Bremstrommel, i9/DD, 4 Stck Zsb. Gegenhalter Faltenbalg, Set fr i-Brake hinten und vorne Faltenbalg hinten Zsb. Bremszugeinhngung, hinten

Fixing Bushing, Dual Drive iBrake, qty 10 Brake Carrier Rear, Dual Drive/P5/S7/T3 iBrake qty 1 Drum Brake Screws, i9 / Dual Drive iBrake, qty 4 Holder Assy, Dual Drive/S7/iBrake/Fr Hub qty 1 Bellows F/R, qty 5, S7/iBrake - F/R Bellow Rear i-Brake, Qty 1 Link/Brake Cable, R, Dual Drive/P5/iBrake, qty 1

30 30 31 32 33 34 35 36 37 38 39 40

65 0303 050 010 65 0303 050 011 00 1199 100 022 00 0000 200 062 11 3115 022 000 11 3115 026 000 65 0315 041 000 11 3115 000 000 65 0318 107 000 11 3115 032 000 11 3115 033 000 11 7915 001 000

Speichenschutzscheibe 36 Loch, transparent (3 Haken) Speichenschutzscheibe 32 Loch, transparent (4 Haken) Kettenfhrungsgabel Zsb. Clickbox, schwarz Seilhlle 2300 mm Kappe Kabelklemmschraube Einstellmutter Klemmblech Abdeckung 7 / 8-Gang Knopf fr Schalter 24 Gang bis Modell 03 / 21 Gang ab Modell 04 Zsb. Drehgriff

Spoke protector 36 holes, transparent (3 snaps) Dual Drive, qty 1 Spoke protector 32 holes, transparent (4 snaps) Dual Drive, qty 1 Chain guide fork Dual Drive, qty 1 Assembly Clickbox Black (AM) Cable Housing S7 IGH shifter, 2300mm Dual Drive, Sparc, P5, qty 5 Cover Dual Drive qty 1 Clamping screw Dual Drive qty 1 Adjuster Nut Indexed, Dual Drive/iBrake, qty 2 Clamping blade Dual Drive, qty 1 Cover 7 / 8 Speed Dual Drive, qty 1 Button 24 Speed till model 03 / 21 Speed as from model 04 Dual Drive, qty 1 DualDrive Grip, Twist, 8/9spd, Qty 1

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

37

DUALDRIVE / DUALDRIVE II i-BRAKE DUALDRIVE / DUALDRIVE II i-BRAKE

(ab Mrz 2008) (as of March 2008)

2a 1a 2 1

6 4 20 22 11 23 21 9 24 7 8 15 25 14 19 10 18 12 17 169

5

3 10

10

16

13

1 17 2a

51

40 39 33 31

38

36 37 34

30

35 32Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

38

DUALDRIVE / DUALDRIVE II i-BRAKE DUALDRIVE / DUALDRIVE II i-BRAKENr. No. 1 1a 2 2a 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 Artikelnummer Part Number 65 0516 003 100 65 0516 107 000 65 0517 110 100 65 0517 102 000 65 0334 129 000 65 0308 014 000 65 0321 110 000 65 2376 003 000 65 0517 002 100 65 0318 105 100 65 0372 111 100 00 0391 011 100 65 2318 016 000 00 0391 041 000 65 0325 119 100 65 0376 104 000 00 0391 015 000 00 0391 012 000 65 0308 012 000 65 0516 111 000 65 0328 002 004 00 0389 005 000 00 0389 005 001 Bezeichnung Sechskantmutter FG 10,5 Hutmutter FG 10,5 (alternativ zu Nr. 1) Fixierscheibe mit Haltenase (3,5 mm dick, auf linke Achsseite) Fixierscheibe ohne Haltenase (alternativ zu Nr. 2: 2 Scheiben / beidseitig) Buchse Stellkonus Dichtkappe Kugelhalter Sicherungsscheibe Anlaufscheibe Zsb. Planetenradtrger Zsb. Hohlrad u. Zsb. Schaltbuchse Anlaufscheibe Zsb. Achse Druckfeder Kugelhalter Antreiber 24 / 27 Gang (fr 8/9-fach Kassetten) Set Rillenkugellager, Kugelhalter, Staubdeckel fr Antreiber Festkonus Sechskantmutter FG 10,5 Schaltstift Komplettes Getriebe (Nr. 7 19) 24 und 27 Gang Komplettes Getriebe (Nr. 7 19) 21 Gang

(ab Mrz 2008) (as of March 2008)

Description Axle Nut FG 10,5 Dual Drive, Sparc, S7, P5, T3 Axle Cap Nut FG 10,5 (alternative to No. 1) Dual Drive, Sparc, S7, P5, T3 Retaining Washer with Extention (3,5mm thick, on left Axle end) Dual Drive, Sparc, S7, P5, T3 Retaining Washer without Extention (alternative to No. 2: 2 washers / both sides) Dual Drive Bushing Dual Drive, S7, P5, T3 Adjustable Cone Dual Drive, S7, P5, T3 qty 1 Dust Cap Dual Drive iBrake, S7, P5, T3, qty 1 (note bag 5) Ball Retainer Dual Drive, S7 Snap Ring i3, Dual Drive, T3 Thrust washer Dual Drive, qty 1 Assy Planet Gear Carrier Dual Drive Assy Gear Ring with Assy shift bushing Dual Drive, Qty 1 Thrust washer i3 Complete Axle, Dual Drive Compression Spring Dual Drive, qty 1 Bearing Retainer Dual Drive SP Set Assy Driver for Dual Drive (Drive 24/27 Speed for 8Speed cassettes), Qty 1 Set, Cartridge bearing, ball Retainer, Dust Cap for Driver Dual Drive, Qty 1 Fixed Cone Dual Drive, qty 1 Hex Nut FG 10,5 Dual Drive, Sparc, S7, P5, T3 Shift Rod Dual Drive, qty 1 Complete Gear Set ( No. 7 19) 24 and 27 Speed Dual Drive Complete Gear Set ( No. 7 19) 21 Speed Dual Drive

20 21 22 23 24 24 25

11 3115 013 000 11 3115 012 000 11 3115 007 000 11 3115 016 000 11 3115 008 000 11 3115 029 000 11 3115 015 000

Fixierbuchse Zsb. Bremstrger hinten Torx Senkkopfschraube fr Bremstrommel, i9/DD, 4 Stck Zsb. Gegenhalter Faltenbalg, Set fr i-Brake hinten und vorne Faltenbalg hinten Zsb. Bremszugeinhngung, hinten

Fixing Bushing, Dual Drive iBrake, qty 10 Brake Carrier Rear, Dual Drive/P5/S7/T3 iBrake qty 1 Drum Brake Screws, i9 / Dual Drive iBrake, qty 4 Holder Assy, Dual Drive/S7/iBrake/Fr Hub qty 1 Bellows F/R, qty 5, S7/iBrake - F/R Bellow Rear i-Brake, Qty 1 Link/Brake Cable, R, Dual Drive/P5/iBrake, qty 1

30 30 31 32 33 34 35 36 37 38 39 40

65 0303 050 010 65 0303 050 011 00 1199 100 022 00 0000 200 062 11 3115 022 000 11 3115 026 000 65 0315 041 000 11 3115 000 000 65 0318 107 000 11 3115 032 000 11 3115 033 000 11 7915 001 000

Speichenschutzscheibe 36 Loch, transparent (3 Haken) Speichenschutzscheibe 32 Loch, transparent (4 Haken) Kettenfhrungsgabel Zsb. Clickbox, schwarz Seilhlle 2300 mm Kappe Kabelklemmschraube Einstellmutter Klemmblech Abdeckung 7 / 8-Gang Knopf fr Schalter 24 Gang bis Modell 03 / 21 Gang ab Modell 04 Zsb. Drehgriff

Spoke protector 36 holes, transparent (3 snaps) Dual Drive, qty 1 Spoke protector 32 holes, transparent (4 snaps) Dual Drive, qty 1 Chain guide fork Dual Drive, qty 1 Assembly Clickbox Black (AM) Cable Housing S7 IGH shifter, 2300mm Dual Drive, Sparc, P5, qty 5 Cover Dual Drive qty 1 Clamping screw Dual Drive qty 1 Adjuster Nut Indexed, Dual Drive/iBrake, qty 2 Clamping blade Dual Drive, qty 1 Cover 7 / 8 Speed Dual Drive, qty 1 Button 24 Speed till model 03 / 21 Speed as from model 04 Dual Drive, qty 1 DualDrive Grip, Twist, 8/9spd, Qty 1

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

39

SPARC 16V / SPARC 12V SPARC 16V / SPARC 12V8 7 6 19 6 5 17 16 5 2 1 7 10 1a11 12

18

3

4 13 14

15 24 24/25

1 10 23 22 21

24

7

9

20

43 42 39 44 37 45 34 30 33 32 41 31 35 36 38 40

40

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

SPARC 16V / SPARC 12V SPARC 16V / SPARC 12VNr. No. 1 1a 2 3 4 5 6 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 Artikelnummer Part Number 65 0516 003 100 65 0516 107 000 65 0517 110 100 65 0516 111 000 00 0591 006 000 00 3091 006 100 00 3091 011 100 00 3091 021 100 00 3091 008 000 65 3072 001 000 00 0591 304 034 65 3071 001 000 00 3091 010 000 65 0525 314 000 65 0527 301 000 65 0533 314 000 65 0581 301 101 00 3091 009 000 65 0576 300 000 65 0572 302 100 65 0308 024 000 65 0521 303 000 65 1004 . . . . . . 65 0512 011 000 00 0591 304 030 00 0591 304 016 65 0334 103 000 00 3089 002 000 11 3115 024 000 11 3115 022 000 11 3115 025 000 11 3115 040 000 11 3115 042 000 11 3115 027 000 11 3115 038 000 11 3115 036 000 11 3115 031 000 00 3091 004 001 65 3065 101 000 65 3070 005 101 00 3091 004 100 65 3065 100 000 65 3070 005 200 00 3091 005 002 00 3091 005 003 00 3091 005 004 00 3091 005 000 00 3091 005 001 00 3091 001 000 Bezeichnung Sechskantmutter FG 10,5 Hutmutter FG 10,5 (alternativ zu Nr. 1) Fixierscheibe mit Haltenase (3,5 mm dick, auf linke Achsseite) Sechskantmutter FG 10,5 Sechskantmutter FG 10,5 Set Mutter / Scheiben / Buchse Zsb. Antrieb mit Platine mit Hohlrad (26/28 Europa-Version) Zsb. Antrieb mit Platine mit Hohlrad (26 U.S.A.-Ver. / 20 Europa-Ver.) ET Set mit Scheiben und Federn, SRAM P5 Zsb. Planetenradtrger Et Set Sonnenrder, SRAM P5 Zsb. Achse Schraube Feder Schubklotz Kupplungsrad Zsb. Hohlrad ET Set Deckel / Feder Kugelhalter Zsb. Antreiber Festkonus Staubdeckel fr Zahnkrnze Zahnkranz siehe Seite 99 Sprengring Schutzbgel fr Clickbox (schwarz) Schaltstift, -rhrchen u. Fixierbuchse im Set, P5 Fixierbuchse, P5, S7 Austauschkit Getriebe P5 Sparc (Nr. 7 19) Drehgriffschalter (mit Schaltseil) Seilhlle 2300 mm Stellschraube Klemmnippel Gehusedeckel mit Schraube Rndelschraube fr Clickbox Zsb. Clickbox, schwarz Festgriff, links 126 mm Festgriff, rechts, 71 mm Zsb. Akkubox (inkl. NiMH Akku 16,8V) Akku einzel / 16,8 V NiMH Akku Batteriegehuse ohne Akku fr 16,8 V NiMH Akku Zsb. Akkubox (inkl. Blei-Gel Akku 12 V) Akku einzel / 12 V Blei-Gel Akku Batteriegehuse ohne Akku fr 12 V Blei-Gel Akku Ladegert 16 V fr Euro (220 V / 16,8 V, 2,0 A) Ladegert 16 V fr USA/Taiwan (110 V / 16,8 V, 2.0 A) Ladegert 16 V fr UK (220 V / 16,8 V, 2,0 A) Ladegert 12 V fr Euro (220 V / 12 V, 1,5 A) Ladegert 12 V fr USA/Taiwan (110 V / 12 V, 2.0 A) Steuereinheit Akkukabel: 00 3091 002 000 650 mm 00 3091 002 010 1400 mm 00 3091 002 002 750 mm 00 3091 002 012 1650 mm 00 3091 002 003 850 mm 00 3091 002 015 1950 mm Steuerkabel: 00 3091 003 000 1500 mm 00 3091 003 003 1800 mm 00 3091 003 001 1600 mm 00 3091 003 005 2000 mm 00 3091 003 002 1700 mm 00 3091 003 007 2200 mm Description Axle Nut FG 10,5 Dual Drive, Sparc, S7, P5, T3 Axle Cap Nut FG 10,5 (alternative to No. 1) Dual Drive, Sparc, S7, P5, T3 Retaining Washer with Extention (3,5mm thick, on left Axle end) Hex Nut FG 10,5 Dual Drive, Sparc, S7, P5, T3 Lock Nut FG 10,5 Sparc, S7, P5, T3 SP Set resin Nut / washers / bushing Sparc qty 1 SP Set electric drive unit with Ring Gear (26/28 Europe version) Sparc qty 1 SP Set electric drive unit with Ring Gear (26 U.S.A. ver. / 20 Europe ver.) Sparc qty 1 SP Set w/spacers and Springs, SRAM P5, Sparc qty 1 Assy Planet Gear Carrier Sparc SP Set sun Gears, SRAM P5, Sparc (24T, 30T) qty 1 each Complete Axle Sparc Screw Sparc qty 1 Sping P5 Sliding Key T3, Sparc, P5 Clutch Wheel Sparc, S7, P5 Gear Ring Sparc, P5 SP Set w/spacer and Springs Sparc qty 1 Bearing Retainer i3, T3, Sparc, P5 Driver Sparc, P5 Fixed Cone Sparc, S7, P5 qty 1 (note bag 5) Sprocket Dust Cap Sparc Sprocket see page 99 Sprocket Lock Ring i3, Sparc, S7, P5, T3 Clickbox protection arm (black) Sparc, S7, P5, qty 1 SP Set shifting Rod / tube / Retainer Sparc, qty 1 Locating Sleeve, S7, P5 Complete Gear Set P5 Sparc (no. 7 19 ) qty 1 P5 Twist Shifter with shift cable qty 1 Cable Housing S7 IGH shifter, 2300mm Dual Drive, Sparc, P5, qty 5 Barrel adjuster Sparc, S7, P5 qty 1 Clamping Bolt IGH Shifter Sparc, S7, PR, qty 1 Cover/Screw, S7 IGH shifter, Sparc, P5 qty 1 Fixing Bolt for Clickbox Sparc, S7, P5, qty 1 Clickbox, P5 w/accessories (from MY03) qty 1 Fixed Grip, Left, 126mm (P5/S7) qty 1 Fixed Grip, Right, 71mm (P5/S7), qty 1 Battery box for SPARC with battery 16,8V qty 1 Battery separate / NiMH battery 16,8 V Sparc Battery Box for NiMH battery 16,8 V (without Battery) Sparc Battery Box Assy (incl. lead-acid battery 12 V) Sparc qty 1 Battery separate / lead-acid battery 12 V Sparc Battery Box for lead-acid battery 12 V (without Battery) Sparc Charger 16 V for Europe (220 V / 16,8 V, 2,0 A) Sparc qty 1 Charger 16 V for USA / Taiwan (110 V / 16,8 V, 2.0 A) Sparc qty 1 Charger 16 V for UK (220 V / 16,8 V, 2,0 A) Sparc qty 1 Charger 12 V for Europe (220 V / 12 V, 1,5 A) Sparc qty 1 Charger 12 V for USA / Taiwan (110 V / 12 V, 2.0 A) Sparc qty 1 Remote Control Unit Sparc qty 1 Battery cable: 00 3091 002 000 650 mm 00 3091 002 010 1400 mm 00 3091 002 002 750 mm 00 3091 002 012 1650 mm 00 3091 002 003 850 mm 00 3091 002 015 1950 mm Remote Control Cable: 00 3091 003 000 1500 mm 00 3091 003 003 1800 mm 00 3091 003 001 1600 mm 00 3091 003 005 2000 mm 00 3091 003 002 1700 mm 00 3091 003 007 2200 mm

30 31 32 33 34 35 36 37 38 39 39 40 40 44 44 44 45 45 42 41 41 41 43 43 43

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

41

SRAM S7 RCKTRITTBREMSE (bis August 05) SRAM S7 COASTER BRAKE (till August 05)

11 10 2 1 16 9 8 6 4 5 13a 13b 13c 23 13 11 20 12 19 8/27 21 22 24 28 7 14 14 25 14 4 11 15 3 17

11

18

25/26

25

5 1

7

4 3 2 6

8 42

9

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

SRAM S7 RCKTRITTBREMSE (bis August 05) SRAM S7 COASTER BRAKE (till August 05)Nr. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 13a 13b 13c 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 Artikelnummer Part Number 65 0515 005 000 . . 0326 . . . . . . 65 0516 119 004 65 0516 003 100 65 0516 107 000 65 0517 110 100 00 0591 304 032 00 0391 004 104 65 0573 300 200 65 0574 106 100 00 0391 004 003 65 0372 108 000 00 0391 004 002 65 0333 122 000 65 0333 124 000 65 0333 126 000 65 0371 111 001 65 0327 103 000 65 0327 101 000 65 0533 314 000 65 0381 101 001 65 0372 104 100 65 0308 024 000 65 0321 101 000 65 1004 . . . . . . 65 0512 011 000 00 0591 304 030 00 0391 004 001 65 0334 103 000 65 0376 102 000 65 0516 111 000 00 0389 001 101 Bezeichnung Linsenschraube M 6x16 mm Rohrschellen siehe Seite 100 Sechskantmutter M6 Sechskantmutter FG 10,5 Hutmutter FG 10,5 (alternativ zu Nr. 4) Fixierscheibe mit Haltenase (3,5 mm dick, auf linke Achsseite) Zsb. Hebelkonus mit Staubdeckel und Bremshebel, sowie 1 Mutter, P5 / S7 (bis August 2005) ET-Set Kugelhalter S7 Zsb. Bremsmantel P5 / S7 (bis August 05) Zsb. Bremskonus P5 / S7 (bis August 05) ET-Set Scheiben und Federn S7 Zsb. Planetenradtrger S7 (bis August 05) ET-Set Sonnenrder S7 Sonnenrad-S7 einzeln, Gang 1 Sonnenrad S7 einzeln, Gang 2 Sonnenrad S7 einzeln, Gang 3 Zsb. Achse Schubklotz, S7 Schubklotz, S7 Kupplungsrad Zsb. Hohlrad Zsb. Antreiber, S7 Festkonus Staubdeckel fr Zahnkranz Zahnkranz siehe Seite 99 Sprengring Schutzbgel fr Clickbox (schwarz) Schaltstift, -rhrchen u. Fixierbuchse im Set, S7 Fixierbuchse, P5, S7 Kugelhalter Sechskantmutter FG 10,5 Austauschkit Getriebe S7 (Nr. 11 20) (bis August 05) Description Pipe Clamp Bolt M6 x 16mm i9, i3, S7, P5, T3, VT3000, VT4000, VT5000 Pipe Clamps see page 100 Hex Nut M6 i9, i3, S7, P5, T3, VT3000, VT4000, VT5000 Axle Nut FG 10,5 Dual Drive, Sparc, S7, P5, T3 Axle Cap Nut FG 10,5 (alternative to No. 1) Dual Drive, Sparc, S7, P5, T3 Retaining Washer with Extention (3,5mm thick, on left Axle end) Dual Drive, Sparc, S7, P5, T3 SP Set Cone w/ Dust Cap and brake lever, 1 Nut, P5 / S7 (till August 2005) qty 1 SP Set Ball Retainer S7, Qty 1 P5 / S7 brake cylinder (till August 05) Brake Cone P5 / S7 (till August 05) SP Set spacers and Springs S7, Qty 1 each S7 planet gear carrier (till August 05) SP Set sun Gears S7 (21T, 3oT, 33T) Qty 1 each Sun Gear S7 separate, Gear 1, 33T, qty 1 Sun Gear S7 separate, Gear 2, 30T, qty 1 Sun Gear S7 separate, Gear 3, 21T, qty 1 Complete Axle S7, Dual Drive S7 sliding Key, qty 1 S7 sliding Key, qty 1 Clutch Wheel Sparc, S7, P5 Gear Ring S7 S7 Driver Fixed Cone Sparc, S7, P5 qty 1 (note bag 5) Sprocket Dust Cap S7, qty 1 Sprocket see page 99 Sprocket Lock Ring i3, Sparc, S7, P5, T3 Clickbox protection arm (black) Sparc, S7, P5, qty 1 Shift Rod, shift tube, and locating Sleeve kit, S7 Locating Sleeve, S7, P5 Ball Retainer S7, P5 Hex Nut FG 10,5 Dual Drive, Sparc, S7, P5, T3 Complete Gear Set S7 (No. 11 20) (till August 05)

1 2 3 4 5 6 7 8 9

11 3115 023 000 11 3115 022 000 11 3115 025 000 11 3115 040 000 11 3115 042 000 11 3115 027 000 11 3115 037 000 11 3115 036 000 11 3115 031 000

Drehgriffschalter (mit Schaltseil) Seilhlle 2300 mm Stellschraube Klemmnippel Gehusedeckel mit Schraube Rndelschraube fr Clickbox Zsb. Clickbox, schwarz Festgriff, links 126 mm Festgriff, rechts, 71 mm

S7 Twist Shifter with shift cable qty 1 Cable Housing S7 IGH shifter, 2300mm Dual Drive, Sparc, P5, qty 5 Barrel adjuster Sparc, S7, P5 qty 1 Clamping Bolt IGH Shifter Sparc, S7, PR, qty 1 Cover/Screw, S7 IGH shifter, Sparc, P5 qty 1 Fixing Bolt for Clickbox Sparc, S7, P5, qty 1 Clickbox, S7 w/accessories (from MY03) qty 1 Fixed Grip, Left, 126mm (P5/S7) qty 1 Fixed Grip, Right, 71mm (P5/S7), qty 1

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

43

SRAM S7 RCKTRITTBREMSE (ab September 05) SRAM S7 COASTER BRAKE (as of September 05)

10 11 10 2 1 9 8 7 6 4 5 13a 13b 13c 23 13 10 20 12 19 8/27 21 22 24 28 7 14 14 25 14 25 4 25/26 15 16 10 3 17 18

5 1

7

4 3 2 6

8 44

9

Ersatzteilliste 2009 Getriebenabensysteme / Spare Parts Catalog 2009 Gear Hub Systems Rel. A

SRAM S7 RCKTRITTBREMSE (ab September 05) SRAM S7 COASTER BRAKE (as of September 05)Nr. No. 1 2 3 4 5 6 7 7 8 9 10 11 12 13 13a 13b 13c 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 Artikelnummer Part Number 65 0515 005 000 . . 0326 . . . . . . 65 0516 119 004 65 0516 003 100 65 0516 107 000 65 0517 110 100 00 0591 002 000 00 0591 003 000 00 0391 004 104 00 0591 005 000 00 0391 004 003 00 0591 001 000 65 0372 001 001 00 0391 004 002 65 0333 122 000 65 0333 124 000 65 0333 126 000 65 0371 111 001 65 0327 103 000 65 0327 101 000 65 0533 314 000 65 0381 101 001 65 0372 104 100 65 0308 024 000 65 0321 101 000 65 1004 . . . . . . 65 0512 011 000 00 0591 304 030 00 0391 004 001 65 0334 103 000 65 0376 102 000 65 0516 111 000 00 0789 001 001 Bezeichnung Linsenschraube M 6x16 mm Rohrschellen siehe Seite 100 Sechskantmutter M6 Sechskantmutter FG 10,5 Hutmutter FG 10,5 (alternativ zu Nr. 4) Fixierscheibe mit Haltenase (3,5 mm dick, auf linke Achsseite) Zsb. Hebelkonus mit Staubdeckel und Bremshebel, sowie 1 Mutter, P5 / S7 (ab September 2005) Zsb. Hebelkonus mit Staubdeckel und Bremshebel, sowie 1 Mutter, P5 / S7, Schwarz (ab September 05) ET-Set Kugelhalter S7 Zsb. Bremsmantel P5 / S7 (ab September 05) ET-Set Scheiben und Federn S7 Zsb. Bremskonus P5 / S7 (ab September 05) Zsb. Planetenradtrger S7 (ab September 05) ET-Set Sonnenrder S7 Sonnenrad-S7 einzeln, Gang 1 Sonnenrad S7 einzeln, Gang 2 Sonnenrad S7 einzeln, Gang 3 Zsb. Achse Schubklotz, S7 Schubklotz, S7 Kupplungsrad Zsb. Hohlrad Zsb. Antreiber, S7 Festkonus Staubdeckel fr Zahnkranz Zahnkranz siehe Seite 99 Sprengring Schutzbgel fr Clickbox (schwarz) Schaltstift, -rhrchen u. Fixierbuchse im Set, S7 Fixierbuchse, S7, P5 Kugelhalter Sechskantmutter FG 10,5 Austauschkit Getriebe S7 (Nr. 11 20) (ab September 05) Description Pipe Clamp Bolt M6 x 16mm i9, i3, S7, P5, T3, VT3000, VT4000, VT5000 Pipe Clamps see page 100 Hex Nut M6 i9, i3, S7, P5, T3, VT3000, VT4000, VT5000 Axle Nut FG 10,5 Dual Drive, Sparc, S7, P5, T3 Axle Cap Nut FG 10,5 (alternative to No. 1) Dual Drive, Sparc, S7, P5, T3 Retaining Washer with Extention (3,5mm thick, on left Axle end) Dual Drive, Sparc, S7, P5, T3 SP Set Cone w/ Dust Cap and brake lever, 1 Nut, P5 / S7 (as of September 05) Coaster Brake qty 1 SP Set Cone w/ Dust Cap and brake lever, 1 Nut, P5 / S7, black (as of September 05) Coaster Brake qty 1 SP Set Ball Retainer S7, Qty 1 SP Set Brake segment P5+S7 Coaster Brake (as of September 05) qty 1 SP Set spacers and Springs S7, Qty 1 each Brake Cone P5 / S7 (as of September 05) Coaster Brake qty 1 S7 Planet Gear Carrier (as of September 05) SP Set sun Gears S7 (21T, 3oT, 33T) Qty 1 each Sun Gear S7 separate, Gear 1, 33T, qty 1 Sun Gear S7 separate, Gear 2, 30T, qty 1 Sun Gear S7 separate, Gear 3, 21T, qty 1 Complete Axle S7, Dual Drive S7 sliding Key, qty 1 S7 sliding Key, qty 1 Clutch Wheel Sparc, S7, P5 Gear Ring S7 S7 Driver Fixed Cone Sparc, S7, P5 qty 1 (note bag 5) Sprocket Dust Cap S7, qty 1 Sprocket see page 99 Sprocket Lock Ring i3, Sparc, S7, P5, T3 Clickbox protection arm (black) Sparc, S7, P5, qty 1 Shift Rod, shift tube, and locating Sleeve kit, S7 Locating Sleeve, S7, P5 Ball Retainer S7, P5 Hex Nut FG 10,5 Dual Drive, Sparc, S7, P5, T Complete Gear Set S7 (No. 11 20) (as of September 05) qty 1

1 2 3 4 5 6 7 8 9

11 3115 023 000 11 3115 022 000 11 3115 025 000 11 3115 040 000 11 3115 042 000 11 3115 027 000 11 3115 037 000 11 3115 036 000 11 3115 031 000

Drehgriffschalter (mit Schaltseil) Seilhlle 2300 mm Stellschraube Klemmnippel Gehusedeckel mit Schraube Rndelschraube fr Clickbox Zsb. Clickbox, schwarz Festgriff, links 126 mm Festgriff, rechts, 71 mm

S7 Twist Shifter with shift cable qty 1 Cable Housing S7 IGH shifter, 2300mm Dual Drive, Sparc, P5, qty 5 Barrel adjuster Sparc, S7, P5 qty 1 Clamping Bolt IGH Shifter Sparc, S7, PR, qty 1 Cover/Screw, S7 IGH shift


Top Related