2013 academy chemical managemenet - march 13

transcript

Chemical Management UpdateHazard Communicationand Chemical Hygiene

Academy for Lab Safety ExcellenceWebinar on 3/13/2013

ObjectivesObjectives

• Identify the eight pictograms required by OSHA and the GHS

• Describe the proper storage of chemicals

• Discuss the new SDS sections and their use

Polling QuestionPolling Question

• Have you completed your OSHA Mandatory Training on the new GHS chemical labeling?

1. Yes

Chemical Management Chemical Management

• Regulations by:

– OSHA

– CAP

– EPA/DEQ

OSHA OSHA

• 29 CFR 1910.1200 – Haz-Com-1987• Revised in 2012 to include the globally

harmonizing system (GHS) – worldwide uniform classification of chemicals

• 29 CFR 1910.1450 – Chemical Hygiene Standard - 1990

• Supersedes Hazard Communication of 1987 – for laboratories only

CAP CAP

• Written Chemical Hygiene Plan– Updated Annually– SOPs

• Environmental Monitoring• Employee Education• Engineering Controls• Work Practice Controls• PPE

CAP CAP

• Chemical Inventory– Carcinogen List

• Safety Data Sheets (SDS) – for each hazardous chemical

• Proper labeling of chemicals– Transfer Containers

• Medical Exam for Overexposure• Documentation

Engineering Controls Engineering Controls

• Removes the hazard from the workplace– Example: Hoods with proper

ventilation

Work Practice Controls Work Practice Controls

• Provides a procedure to protect the employee from the hazard

– Example: When pouring chemicals, work under a hood and use goggles, a cover gown and gloves

Chemical Storage Chemical Storage

• Do NOT store alphabetically by name

• Incompatibility Chart

Chemical Storage Chemical StorageChemicals should be stored as follows:1. Inorganic acids2. Organic acids3. Oxidizing acids4. Inorganic bases5. Flammable and combustible liquids6. Gases7. Organic peroxides8. Oxidizers9. Reactives (eg: water or exploding materials)10.Toxic and environmentally hazardous

chemicals

Chemical Inventory Chemical Inventory• Performed Annually

– Electronic Form

• Exempt Chemicals– In kit form– Less than 1% of a hazardous chemical

Chemical Waste Chemical Waste

• Pouring chemicals down the drain or evaporating in a fume hood is not always a good idea (even when the provider recommends this action).– Always check local regulations and sewage

treatment plant for capacity before disposing of anything down the drain.

– If your waste water is not treated, check with EPA.

• Removal by outside firm• Neutralizing• Recycling

Polling QuestionPolling Question

• Do you keep paper copies of MSDS or do you use an electronic maintenance system?

1. Paper

2. Electronic

3. Neither

Safety Data Sheets (SDS)Safety Data Sheets (SDS)

Section 1. IdentificationSection 2. Hazard(s) identificationSection 3. Composition/information on ingredientsSection 4. First-Aid measuresSection 5. Fire-fighting measuresSection 6. Accidental release measuresSection 7. Handling and storageSection 8. Exposure controls/personal protectionSection 9. Physical and chemical propertiesSection 10. Stability and reactivitySection 11. Toxicological informationSection 12. Ecological informationSection 13. Disposal considerationsSection 14. Transport informationSection 15. Regulatory informationSection 16. Other information, including date of

preparation or last revision

SDS SDS

• Update Annually– Store old ones for 30 years in

employee or student medical record if injury or accident

– May need catalog number of chemical to obtain

– online– in binders

Health Hazard Pictogram Health Hazard Pictogram• The pictogram is

the upper torso with a starburst center

• Identifies a health hazard such as carcinogens, mutagens, reproductive toxicity and target organ toxicity

Fire Pictogram Fire Pictogram

• The pictogram is a flame and identifies chemicals that can ignite

• Includes flammables, pyrophorics, flammable gases, self-heating, self-reactives and organic peroxides

Irritant PictogramIrritant Pictogram

• The pictogram is an exclamation mark and identifies irritants

• Includes skin sensitizers, narcotic effects and respiratory tract irritants

Gas Pictogram Gas Pictogram

• The pictogram is a gas cylinder

• Represents gases under pressure

Corrosive Pictogram Corrosive Pictogram

• The pictogram is two test tubes pouring chemicals onto an object and skin

• Represents corrosive chemicals

Explosives PictogramExplosives Pictogram

• The pictogram is an exploding bomb

• Represents explosives of all kinds such as self-reactives and organic peroxides

Oxidizer Pictogram Oxidizer Pictogram

• The pictogram is a flame over a circle

• Represents oxidizers

Acute Toxicity PictogramAcute Toxicity Pictogram

• The pictogram is a skull and crossbones

• Represents acute toxicity that is fatal or toxic

Environmental Hazard PictogramEnvironmental Hazard Pictogram

• Pictogram is for environmental hazards and is not covered by OSHA but may be covered by other agencies in the future

Chemical Labeling

• National Fire Protection Association (NFPA)• Hazardous Materials Identification System (HMIS)

Chemical Labeling

•4 Extreme•3 High•2 Moderate•1 Slight•0 Insignificant

•4 Severe•3 Serious•2 Moderate•1 Slight•0 Minimal

Flammable and Combustible Liquids

• Limit Quantities– Up to 1 Gal./100 Sq. Ft. of Lab Space

• No Ignition Sources in the Area

• Large quantities in storage cabinets– Self closing doors– Ventilated vs. Non-ventilated – Comply with NFPA 91– Check with local Fire Marshall

Carcinogens Carcinogens• Formaldehyde – used in

preservation of animals and tissue

– Class A fume hood

– Face velocity of 125 fpm

– Exhausted through charcoal filters

• OSHA-required annual training

• Exposure monitoring

Environmental Sampling Environmental Sampling

• Initial sampling

• Repeat when change in

– Method

– Location

– Air handling

Chemical Spills Chemical Spills• Liquids

– Contain the spill– Use neutralizing agent or

absorbent– Mop up and flush with lots of

water• Solids

– Sweep and place into solid-waste container

– Use vacuum cleaner with HEPA filter

Chemical Spills Chemical Spills

• Spill Team• Housekeeping• Technical Staff

– Use spill kit• Located near chemical storage cabinets

– Wear appropriate PPE• Gown, gloves, goggles

Administrative Requirements

• Chemical Hygiene Officer– Administrative duties

• CHO must be in someone’s job description

– Task Assessment

• Safety Committee– Safety Audit– Discuss Safety Issues

Emergency Eyewash

• Eyewash Station– Must be single hand use or foot

operated– Provides 15 minute flush of tepid water

• American National Standards Institute – ANSI Z358.1 2009 requirement since 2004

– Check weekly• Run for 1 to 3 minutes• Disinfect eyepiece covers with 10% bleach

Emergency Shower

• Safety Showers– Check weekly (ANSI guideline)

Spill CleanupSpill Cleanup• Liquids

– Confine or contain the spill– Small quantities of inorganic acids or bases -

use neutralizing agent – Small quantities of other materials – absorb

with towels or spill pillows– Large quantities of inorganic acids or basis –

flush with large amounts of water– Mop up spill– Vacuum the area– If spill is volatile – let it evaporate

Spill CleanupSpill Cleanup

• Solids– Sweep into dust pan and place in solid waste

container– Use vacuum with HEPA filter

Who Cleans Up The Spill?Who Cleans Up The Spill?• You

• Housekeeping

• Haz-Mat Team

Waste DisposalWaste Disposal• Drain

– Contact Local Sewer District

• Landfill

• Incineration

Chemical EffectivenessChemical Effectiveness

• Reviewed annually– Document the review – Substitutes for hazardous chemicals– Lab Pak for unused or outdated chemicals

Now it is your turn to

Ask the ExpertNow it is your turn to

Ask the ExpertFor more information

go to:

www.safetylady.com

For more information

go to:

www.safetylady.com

2013 academy chemical managemenet - march 13

Documents