Post on 13-Feb-2018
transcript
7/23/2019 Manual de Servicio de Toro ST710
1/232
Atlas Copco Scooptram
ST710
Manual de Servicio
PM No. 9852 1543 052004-07
7/23/2019 Manual de Servicio de Toro ST710
2/232
Copyright 2004, Atlas Copco Rock Drills AB, SwedenAny unauthorized use or copying of the contents or any part thereof is prohibited.
This applies in particular to trademarks, model denominations, part numbers and drawings.
Atlas Copco Rock Drills ABSE-70191 rebro, Sweden
REGLAS DE SEGURIDAD
Antes de poner en marcha hay que leerdetenidamente todas las instrucciones.
Se debe prestar atencin especial ala informacin que se encuentra allado de este smbolo.
Slo se pueden usar piezas originales deAtlas Copco.
1250 0071 04
7/23/2019 Manual de Servicio de Toro ST710
3/232
Atlas Copco I
ST710:ndice
Captulo 1: Introduccin sobre el ST710Descripcin del vehculo . . . . . . . . . . . . . . . . . . . . . 1Proteccin contra peligros . . . . . . . . . . . . . . . . . . . . 1
Grficas del vehculo . . . . . . . . . . . . . . . . . . . . . 1Alertas de seguridad de la Gua de servicio . . . . 1Mensajes de ahorro de tiempo . . . . . . . . . . . . . . 1
Transporte del vehculo . . . . . . . . . . . . . . . . . . . . . . 2Amarraduras traseras . . . . . . . . . . . . . . . . . . . . . 2Remolcado del ST710 . . . . . . . . . . . . . . . . . . . . 3
Captulo 2: Mentalizacin en torno a la seguridadProtjase usted y proteja sus compaeros . . . . . . . . 5
Procedimientos de configuracin de servicio. . . 6Estacionar el vehculo en el modo soltado . . 6
Rtulo de advertencia de cabina . . . . . . . . . .6Interruptor principal (aislamiento de la batera)
6
Rtulo de advertencia en el interruptor principal6
Bloqueo de seguridad de la articulacin . . . . 7Soporte de seguridad de brazo. . . . . . . . . . . .7Descargando la presin hidrulica. . . . . . . . . 7
Procedimientos de seguridad general . . . . . . . . . . . . 9Un vehculo bien mantenido es un vehculo ms
seguro . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9Proteccin personal . . . . . . . . . . . . . . . . . . . . . . .9
Elementos sueltos . . . . . . . . . . . . . . . . . . . .10Protecciones y cubiertas . . . . . . . . . . . . . . .10
http://npmtsmi.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://npmtsmi.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/7/23/2019 Manual de Servicio de Toro ST710
4/232
ndiceManual de Servicio
II
ST710
Modificaciones . . . . . . . . . . . . . . . . . . . . . .10Estacionamiento del Scooptram . . . . . . . . . 10Seguridad del brazo. . . . . . . . . . . . . . . . . . . 10
Correcto . . . . . . . . . . . . . . . . . . . . . . . . .10Incorrecto. . . . . . . . . . . . . . . . . . . . . . . . 10
Prevencin de quemaduras, incendios yexplosiones . . . . . . . . . . . . . . . . . . . . . . . . 11
Sistema elctrico . . . . . . . . . . . . . . . . . . 11Bateras . . . . . . . . . . . . . . . . . . . . . . . . . 11Lquidos combustibles. . . . . . . . . . . . . . 11Fluido de arranque. . . . . . . . . . . . . . . . . 11Extintor de incendios. . . . . . . . . . . . . . . 11
Peligros de los dispositivos presurizados . . 11Sistemas hidrulicos . . . . . . . . . . . . . . . 11Acumuladores del sistema hidrulico . . 12
Sistema de refrigeracin del motor . . . . 12ROPS y FOPS . . . . . . . . . . . . . . . . . . . . . . .12Seguridad de neumticos y ruedas . . . . . . . 12Rotulacin del vehculo. . . . . . . . . . . . . . . . 13
Captulo 3: Mantenimiento preventivoOperaciones de servicio . . . . . . . . . . . . . . . . . . . . . 15
Requisitos de empleo en terrenos accidentados 15Para los ajustes elevados de par se requiere el
empleo de herramientas especiales. . . . . . 16Un vehculo bien mantenido es un vehculo ms
seguro . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16Seguridad en la cargadora durante elmantenimiento . . . . . . . . . . . . . . . . . . . . . . . . 16
Soldadura elctrica . . . . . . . . . . . . . . . . . . . . . . 16Limpieza del sistema hidrulico . . . . . . . . . . . . 17Anlisis de aceite independiente . . . . . . . . . . . . 17Mantenimiento efectivo de los procedimientos de
registro . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17Centro de minimensajes y hormetro . . . . . . . . 18Operaciones de inspeccin del vehculo y
comunicacin de informacin . . . . . . . . . . . . 18Lista de control de inspeccin del turno . . . 18
Informe de turno diario . . . . . . . . . . . . . . . . . . . 19Control antes de arrancar el motor . . . .19Comentarios. . . . . . . . . . . . . . . . . . . . . . 19Control despus de arrancar el motor . . 19Comentarios. . . . . . . . . . . . . . . . . . . . . . 19
Diariamente y por turno . . . . . . . . . . . . . . .21Segn las necesidades . . . . . . . . . . . . . . . . . 21
Kits de servicio de Atlas Copco . . . . . . . . . . . . 22Puntos de lubricacin diaria . . . . . . . . . . . . 23Cada 125 horas de funcionamiento . . . . . . . 23Cada 250 horas de funcionamiento . . . . . . . 24
Cada 500 horas de funcionamiento. . . . . . . 24Cada 2.000 horas de funcionamiento . . . . . 25Cada 5.000 horas de funcionamiento . . . . . 25Cada 1.000 horas de funcionamiento . . . . . 25
Procedimientos de mantenimiento por intervalo . . 26Indicador de obstruccin del filtro de aire . 26Radiadores y enfriadores. . . . . . . . . . . . . . . 26Estructuras de la cabina, el cucharn y elbastidor. . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Mangueras de refrigerante, combustible ehidrulicas . . . . . . . . . . . . . . . . . . . . . . . . 27
Interruptores de circuito y fusibles . . . . . . . 27Controle los niveles de lquido . . . . . . . . . . 28
Nivel de combustible . . . . . . . . . . . . . . . . . 28Aceite de motor. . . . . . . . . . . . . . . . . . . . . . 28
Lquido de la Upbox . . . . . . . . . . . . . . . . . . 29Controle el nivel de lquido del transverter. 29Controle el nivel del depsito hidrulico . . 29Filtro y respiradero del depsito hidrulico 29
Neumticos . . . . . . . . . . . . . . . . . . . . . . . . . 30Jaula de inflado de neumticos . . . . . . . . . . 30Extintor de incendios . . . . . . . . . . . . . . . . . 30Correas de accionamiento del motor. . . . . . 30Vlvula de evacuador del filtro de aire. . . . 31Sistema de enfriamiento . . . . . . . . . . . . . . . 31Pasadores de bisagra . . . . . . . . . . . . . . . . . . 31
Indicador de restriccin hidrulica . . . . . . . 32Luces del vehculo . . . . . . . . . . . . . . . . . . . 32Bateras . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Principales puntos de lubricacin. . . . . . . . . . . 32Lubricacin central del bastidor de carga . . 33Lubricacin central del bastidor de
accionamiento . . . . . . . . . . . . . . . . . . . . . 33Rodamiento de apoyo de la lnea de propulsin
33Puntos de lubricacin del pasador del cucharn
33Aceite de motor. . . . . . . . . . . . . . . . . . . . . . 34
Purgar aceite de motor . . . . . . . . . . . . . . . . 34Filtros de aire de motor. . . . . . . . . . . . . . . . 35
Indicador de servicio del filtro . . . . . . . 35Enfriador de motor . . . . . . . . . . . . . . . . . . . 35Bateras . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35Respirador de depsito hidrulico . . . . . . . 36Upbox y respiraderos de eje . . . . . . . . . . . . 36Compruebe el nivel de aceite del diferencial .
36Compruebe el nivel de aceite del planetario 37Examine las ruedas . . . . . . . . . . . . . . . . . . . 37
http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/7/23/2019 Manual de Servicio de Toro ST710
5/232
Atlas Copco III
Juntas deslizantes de lnea de accionamiento.37
Casquillo de cubo de ventilador . . . . . . . . . 37Puntos de lubricacin de pasadores de
articulacin . . . . . . . . . . . . . . . . . . . . . . . 38Tapas de pasadores de articulacin . . . . . . 38Sistema de supresin de incendios . . . . . . . 38Filtros de combustible . . . . . . . . . . . . . . . . 38
Para purgar aire del sistema decombustible:. . . . . . . . . . . . . . . . . . . . 39
Mangueras hidrulicas y montajes de sujecin39
Presin de precarga de acumulador . . . . . . 39Montajes de eje. . . . . . . . . . . . . . . . . . . . . . 40Topes de la direccin, el brazo y el cucharn.
40Llenadoras de depsito de combustible . . . 41Velocidades de marcha en vaco y de pararse
de motor/transverter. . . . . . . . . . . . . . . . . 41Marcha en vaco . . . . . . . . . . . . . . . . . . 41
Depsito de combustible . . . . . . . . . . . . . . 42Filtro de enfriador de motor . . . . . . . . . . . . 42Vlvulas de entrada y escape del motor . . . 42Filtro de aceite del transverter . . . . . . . . . . 42Filtro de aceite hidrulico. . . . . . . . . . . . . . 43Tiempos de ciclo de cucharn y direccin . 43
Correas de transmisin . . . . . . . . . . . . . . . . 43Presin de crter de motor . . . . . . . . . . . . . 43Cilindros hidrulicos . . . . . . . . . . . . . . . . . 43Puntos y montajes de articulacin . . . . . . . 44
Junta de articulacin . . . . . . . . . . . . . . . 44Pernos del soporte del motor y del
transverter . . . . . . . . . . . . . . . . . . . . . 44Todos los pernos de tapas de muoneras .
44Pernos de montaje de ejes. . . . . . . . . . . 44Rodamientos de oscilacin . . . . . . . . . . 44Pernos de montaje de caja de
desplazamiento. . . . . . . . . . . . . . . . . . 44Depsito de combustible . . . . . . . . . . . . . . 45Transverter . . . . . . . . . . . . . . . . . . . . . . . . . 45Ejes, diferenciales y planetarios . . . . . . . . . 45
Diferencial . . . . . . . . . . . . . . . . . . . . . . 45Planetario . . . . . . . . . . . . . . . . . . . . . . . 46
Depsito hidrulico . . . . . . . . . . . . . . . . . . 46
Captulo 4:Unidad de potencia (Detroit Diesel Series40)Sistemas de soporte del motor . . . . . . . . . . . . . . . . 47
Sistema de combustible . . . . . . . . . . . . . . . . . . . . . 47Directrices para la sustitucin de los
componentes del sistema de combustible 48Vlvulas y conductos de combustible . 48Desmontaje de vlvulas y conductos de
combustible . . . . . . . . . . . . . . . . . . . . 48Sustitucin de las vlvulas y conductos de
combustible . . . . . . . . . . . . . . . . . . . . 49Filtro de combustible . . . . . . . . . . . . . . . . . 49
Desmontaje del filtro de combustible. . 49Sustitucin del filtro de combustible . . 49
Bomba manual de cebado de combustible. 49Bomba de suministro de combustible . . . . 50Inyectores de combustible . . . . . . . . . . . . . 50Refrigeradores hidrulico y de combustible 50
Desmontaje de los refrigeradoreshidrulico y de combustible. . . . . . . . 50
Sustitucin de los refrigeradores hidrulicoy de combustible . . . . . . . . . . . . . . . . 50
Depsito de combustible . . . . . . . . . . . . . . 51Desmontaje del depsito de combustible .
51Montaje del depsito de combustible. . 51
Sistema de aceite de motor . . . . . . . . . . . . . . . 52Bomba de aceite de lubricacin . . . . . . . . . 52Filtros de aceite . . . . . . . . . . . . . . . . . . . . . 52
Manmetro de presin de aceite . . . . . . . . 52Sistema elctrico del motor . . . . . . . . . . . . . . . 53Sistema de carga y arranque. . . . . . . . . 53Sistemas de control con microprocesador
53Sistema de control electrnico del motor. . 53
Sistema de refrigeracin del motor . . . . . . . . . 53Recomendaciones de lquido refrigerador . 54Desmontaje del paquete de refrigeracin del
motor . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55Sustitucin del paquete de refrigeracin del
motor . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Sistema de entrada de aire . . . . . . . . . . . . . . . . 56Limpiador de aire . . . . . . . . . . . . . . . . . . . . 56Indicador de obstruccin del filtro de aire . 56
Turbocompresor. . . . . . . . . . . . . . . . . . . . . . . . 57Flujo de aire del turbocompresor . . . . . . . . 57
Sistema de escape . . . . . . . . . . . . . . . . . . . . . . 57Silenciadores . . . . . . . . . . . . . . . . . . . . . . . 58Depuradores . . . . . . . . . . . . . . . . . . . . . . . . 58Escudos trmicos de escape . . . . . . . . . . . . 58Desmontaje de componentes del sistema de
escape . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/7/23/2019 Manual de Servicio de Toro ST710
6/232
ndiceManual de Servicio
IV
ST710
Sustitucin del sistema de escape . . . . . . . . 58Paquete de motor y cuna. . . . . . . . . . . . . . . . . . . . . 59
Desmontaje del motor y la cuna . . . . . . . . . 59Sustitucin del paquete del motor . . . . . . . . 61
Chapter 5: Tren de potenciaIntroduccin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Up box. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63Transverter . . . . . . . . . . . . . . . . . . . . . . . . . . . .64
Convertidor de par. . . . . . . . . . . . . . . . . . . . 64Transmisin. . . . . . . . . . . . . . . . . . . . . . . . . 65Unidad de control del transverter (TCU) . . 65Conmutadores selectores de Control de lgicaprogramable (PLC) y selector de transverter65
Interruptores del selector del transverter. . . 65Sistema hidrulico del transverter . . . . . . . . 66
Vlvula de control . . . . . . . . . . . . . . . . .66Bomba de carga . . . . . . . . . . . . . . . . . . .66Filtro de aceite de transverter . . . . . . . . 66Refrigeradores . . . . . . . . . . . . . . . . . . . .66
Sustitucin del refrigerador. . . . . . . . . . . . . 67Proteja el transverter durante el remolque del
vehculo . . . . . . . . . . . . . . . . . . . . . . . . . .67Comprobacin de la temperatura del aceite
hidrulico . . . . . . . . . . . . . . . . . . . . . . . . . 67
Comprobacin de la presin de control deltransverter. . . . . . . . . . . . . . . . . . . . . . . . . 68Desmontaje del transverter . . . . . . . . . . . . . . . . 69
Sustitucin del transverter. . . . . . . . . . . . . . 70Lneas de accionamiento. . . . . . . . . . . . . . . . . . 71
Cojinetes de junta universal . . . . . . . . . . . . 71Rodamientos de apoyo de la lnea depropulsin . . . . . . . . . . . . . . . . . . . . . . . . .71
Enfasamiento de la lnea de accionamiento 72Instalacin del eje de accionamiento. . . . . . 72Horquillas y montajes de cojinetes . . . . . . . 72Instalacin de protectores de lnea de
accionamiento. . . . . . . . . . . . . . . . . . . . . . 72Upbox a lnea de propulsin de transverter. 73
Desmontar . . . . . . . . . . . . . . . . . . . . . . . 73Sustituir . . . . . . . . . . . . . . . . . . . . . . . . . 73
Lnea de propulsin trasera . . . . . . . . . . . . . 73Desmontar . . . . . . . . . . . . . . . . . . . . . . . 73Sustituir . . . . . . . . . . . . . . . . . . . . . . . . . 74
Lnea de propulsin del medio . . . . . . . . . . 74Desmontar . . . . . . . . . . . . . . . . . . . . . . . 74Sustituir . . . . . . . . . . . . . . . . . . . . . . . . . 74
Lnea de propulsin entre el tren intermedioy el transverter . . . . . . . . . . . . . . . . . . . . . 74
Desmontar . . . . . . . . . . . . . . . . . . . . . . . 74Sustituir . . . . . . . . . . . . . . . . . . . . . . . . . 74
Lnea de propulsin delantera. . . . . . . . . . . 75Desmontar . . . . . . . . . . . . . . . . . . . . . . . 75Sustituir . . . . . . . . . . . . . . . . . . . . . . . . . 75
Ejes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 75Reduccin primaria. . . . . . . . . . . . . . . . . . . 75Reduccin secundaria . . . . . . . . . . . . . . . . . 76Eje delantero . . . . . . . . . . . . . . . . . . . . . . . . 76
Desmontar . . . . . . . . . . . . . . . . . . . . . . . 76Sustituir . . . . . . . . . . . . . . . . . . . . . . . . . 76
Eje trasero . . . . . . . . . . . . . . . . . . . . . . . . . . 77Desmontar . . . . . . . . . . . . . . . . . . . . . . . 77
Sustituir . . . . . . . . . . . . . . . . . . . . . . . . . 77Neumticos y ruedas. . . . . . . . . . . . . . . . . . . . . 78
Mantenimiento en carretera y vida til de losneumticos . . . . . . . . . . . . . . . . . . . . . . . . 78
Examen y mantenimiento de las ruedas yneumticos . . . . . . . . . . . . . . . . . . . . . . . . 78
Presiones de neumtico recomendadas. . . . 79Inflado correcto. . . . . . . . . . . . . . . . . . . . . . 79
El sobreinflar resulta en: . . . . . . . . . . . . 79El inflado insuficiente resulta en: . . . . . 79
Radio de rodadura y dimensionado de los
neumticos . . . . . . . . . . . . . . . . . . . . . . . . 79Ejemplo: . . . . . . . . . . . . . . . . . . . . . . . . . . . 80Prcticas de manejo. . . . . . . . . . . . . . . . . . . 80
Procedimientos de montaje de neumticos. . . . 80Brida de rueda de retencin de llanta de
mquina de movimientos de tierras conrgano motor de servicio pesado . . . . . . . 81
Desmontaje . . . . . . . . . . . . . . . . . . . . . . . . . 81Montaje . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81Examen de las ruedas . . . . . . . . . . . . . . . . . 82Llantas desiguales . . . . . . . . . . . . . . . . . . . . 82Seguridad durante el montaje y el inflado . 83
Procedimientos de montaje e inflado . . . . . 84Par de tuerca de rueda. . . . . . . . . . . . . . . . . 85Precauciones de funcionamiento. . . . . . . . . 85Recauchutado . . . . . . . . . . . . . . . . . . . . . . . 85Almacenamiento de neumticos . . . . . . . . . 86Montaje para almacenamiento . . . . . . . . . . 86
Frenos SAHR . . . . . . . . . . . . . . . . . . . . . . . . . . 87Desmontaje . . . . . . . . . . . . . . . . . . . . . . . . . 87Limpieza e inspeccin. . . . . . . . . . . . . . . . . 90
Caja, cubiertas, etc. . . . . . . . . . . . . . . . . 90Cierres de pistn y caja . . . . . . . . . . . . . 90
http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/7/23/2019 Manual de Servicio de Toro ST710
7/232
Atlas Copco V
Montaje de los frenos SAHR . . . . . . . . . . . 90
Captulo 6: Marco principalIntroduccin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 95Bastidor de carga . . . . . . . . . . . . . . . . . . . . . . . . . . 96
Desmontaje del cucharn . . . . . . . . . . . . . . . . . 96Sustitucin del cucharn. . . . . . . . . . . . . . . 97Desmontaje de la barra en Z. . . . . . . . . . . . 97Sustitucin de la barra en Z . . . . . . . . . . . . 98Desmontaje del brazo . . . . . . . . . . . . . . . . . 98Sustitucin del brazo . . . . . . . . . . . . . . . . . 99
Bastidor de accionamiento. . . . . . . . . . . . . . . . . . 100Cubiertas protectoras . . . . . . . . . . . . . . . . 100Desmontaje de cubierta . . . . . . . . . . . . . . 100Montaje de cubierta . . . . . . . . . . . . . . . . . 100
Desmontaje del depsito de combustible . 100. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 100Sustitucin del depsito de combustible . 101
Separacin del bastidor de carga y el bastidor motor102
Separacin . . . . . . . . . . . . . . . . . . . . . . . . . . . 102Reconexin. . . . . . . . . . . . . . . . . . . . . . . . . . . 103
Pasadores de articulacin. . . . . . . . . . . . . . . . . . . 104Desmontaje del pasador . . . . . . . . . . . . . . 104Montaje del pasador . . . . . . . . . . . . . . . . . 105
Topes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 107
Topes de direccin . . . . . . . . . . . . . . . . . . . . . 107Topes de oscilacin del eje. . . . . . . . . . . . . . . 107Topes de retroceder . . . . . . . . . . . . . . . . . . . . 107Topes de volteo (vaciado) del cucharn. . . . . 108Topes (amortiguadores) de cucharn . . . . . . . 108Topes de brazo . . . . . . . . . . . . . . . . . . . . . . . . 108Examen y mantenimiento de los topes. . . . . . 108Instalacin . . . . . . . . . . . . . . . . . . . . . . . . . . . 108
Ubicacin general . . . . . . . . . . . . . . . . 108Ubicacin final . . . . . . . . . . . . . . . . . . 108
Topes de direccin . . . . . . . . . . . . . . . . . . 108Topes de oscilacin del eje. . . . . . . . . . . . 109
Topes de retroceder . . . . . . . . . . . . . . . . . 109Topes de volteo (vaciado) del cucharn. . 109Topes (amortiguadores) de cucharn . . . . 109Topes de brazo . . . . . . . . . . . . . . . . . . . . . 109
Contacto a pao . . . . . . . . . . . . . . . . . 109
Captulo 7: Sistemas hidrulicosIntroduccin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 111
Sistema standard. . . . . . . . . . . . . . . . . . . . . . . 111Bombas de engranajes hidrulicas . . . . . . . . . 112Cilindros. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 113
Cilindros de direccin . . . . . . . . . . . . . . . 113Cilindro estabilizador (basculacin) . . . . 113Cilindros de levantamiento . . . . . . . . . . . 113
Acumuladores . . . . . . . . . . . . . . . . . . . . . . . . 114Precarga de acumulador. . . . . . . . . . . . . . 114Acumulador para soltar el freno del gancho de
remolque . . . . . . . . . . . . . . . . . . . . . . . . 114Depsito y filtros . . . . . . . . . . . . . . . . . . . . . . 115
Depsito hidrulico (tanque) . . . . . . . . . . 115Inspeccin . . . . . . . . . . . . . . . . . . . . . . . . 115Reparar . . . . . . . . . . . . . . . . . . . . . . . . . . . 115Filtros de aceite . . . . . . . . . . . . . . . . . . . . 115Cartucho de filtro interno con indicador . 116
Mangueras y tubos . . . . . . . . . . . . . . . . . . . . . 116Vlvulas de control . . . . . . . . . . . . . . . . . . . . 117
Vlvula de control principal. . . . . . . . . . . 118Vlvula de prioridad. . . . . . . . . . . . . . . . . 118Vlvula auxiliar . . . . . . . . . . . . . . . . . . . . 119
Vlvula de carga de acumulador . . . . 119Sistema de direccin . . . . . . . . . . . . . . . . . . . 120Sistema de basculacin y levantamiento . . . . 120
Brazo arriba . . . . . . . . . . . . . . . . . . . . . . . 121Cucharn flotante. . . . . . . . . . . . . . . . . . . 121Potencia de brazo abajo . . . . . . . . . . . . . . 121Funcin de carga de vlvula de retencin 121
Componentes de basculacin y levantamiento 121
Sistema de frenos . . . . . . . . . . . . . . . . . . . . . . 121Sistema de freno SAHR . . . . . . . . . . . . . . 122Operacin del sistema de freno SAHR . . . . . 122
Conectador y desconectador de carga deacumulador . . . . . . . . . . . . . . . . . . . . . . 122
Apriete de frenos . . . . . . . . . . . . . . . . . . . . . . 123Funcionamiento de freno de servicio. . . . 123Funcionamiento del freno de estacionamiento
123Funcionamiento del freno de emergencia 123
Componentes de sistema de frenos . . . . . . . . 123Manmetro del acumulador . . . . . . . . . . . 123
Vlvula de control de pedal . . . . . . . . . . . 123Sistema de enfriamiento de frenos. . . . . . . . . 123
Componentes de sistema de enfriamiento defrenos. . . . . . . . . . . . . . . . . . . . . . . . . . . 124
Refrigerador de aceite hidrulico. . . . . . . 124Colector de enfriamiento de freno . . . . . . 124Montaje multidisco de freno enfriado por
lquido . . . . . . . . . . . . . . . . . . . . . . . . . . 124Sistema standard de remolque de emergencia 124
Bomba hidrulica de operacin manual. . 124Botn de supresin de rel . . . . . . . . . . . . 125
http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/7/23/2019 Manual de Servicio de Toro ST710
8/232
ndiceManual de Servicio
VI
ST710
Acumulador hidrulico . . . . . . . . . . . . . . . 125Acumulador cargado . . . . . . . . . . . . . . . . . 125El acumulador no est cargado . . . . . . . . . 125
Gancho de remolque opcional para soltar frenos .125
Funcionamiento del gancho de remolque . 125Componentes de sistema de gancho de
remolque. . . . . . . . . . . . . . . . . . . . . . . . . 126Colector de liberacin de frenos . . . . . . . . 126
Vlvula de retencin de relleno de circuito126
Vlvula de rel de freno. . . . . . . . . . . . 126Vlvula hidrulica de doble efecto . . . 126
Acumulador de gancho de remolque. . . . . 126Cilindro de gancho de remolque . . . . . . . . 126
Palanca de gancho de remolque . . . . . . . . 126Informacin general sobre el mantenimiento . . . .127
Servicio despus de revisin . . . . . . . . . . . 127Nivel de aceite en el depsito . . . . . . . . . . 127Importancia de la limpieza . . . . . . . . . . . . 128Cambios de aceite . . . . . . . . . . . . . . . . . . . 128Almacenamiento y manejo de aceite. . . . . 129Prevencin de espuma. . . . . . . . . . . . . . . . 130Cambio de aceite hidrulico despus de avera
130Filtros y tamices de servicio . . . . . . . . . . . 130
Establecimiento de un programa. . . . . . . . 131Ajuste del pedal de freno SAHR. . . . . . . . 131Inspeccin de cilindro . . . . . . . . . . . . . . . . 131
Localizacin de averas. . . . . . . . . . . . . . . . . . 131Seguridad. . . . . . . . . . . . . . . . . . . . . . . . . . 132Evite los fallos del sistema hidrulico. . . . 132Proteccin de sobrecalentamiento del sistema
132Eliminacin de aire del sistema. . . . . . . . . 133Control de averas de componentes. . . . . . 133Control de fugas en sistemas hidrulicos . 134
Fugas externa. . . . . . . . . . . . . . . . . . . . 134
Fugas internas . . . . . . . . . . . . . . . . . . . 134Causas bsicas de las fugas de lquido 134
Encontrar la localizacin de la fuga . . . . . 135SA 37 Conexin de reborde . . . . . . . . . . 135
Causas . . . . . . . . . . . . . . . . . . . . . . . . . 135Curas . . . . . . . . . . . . . . . . . . . . . . . . . . 135
SAE 45 tuercas . . . . . . . . . . . . . . . . . . . .135Causas . . . . . . . . . . . . . . . . . . . . . . . . . 135Curas . . . . . . . . . . . . . . . . . . . . . . . . . . 136
Otros problemas de fugas . . . . . . . . . . . . . 136Causas:. . . . . . . . . . . . . . . . . . . . . . . . . 136
Curas: . . . . . . . . . . . . . . . . . . . . . . . . . 136Conexin de brida dividida perno SAE 4 . 136Problema 1 . . . . . . . . . . . . . . . . . . . . . . . . 136
Causas . . . . . . . . . . . . . . . . . . . . . . . . . 136Cura. . . . . . . . . . . . . . . . . . . . . . . . . . . 136
Problema 2 . . . . . . . . . . . . . . . . . . . . . . . . 136Causa . . . . . . . . . . . . . . . . . . . . . . . . . . 136Cura. . . . . . . . . . . . . . . . . . . . . . . . . . . 137
Fugas en roscas de tubo . . . . . . . . . . . . . . 137Debe recordar de controlar dos veces . . . . 137Conexin del cierre del lateral de junta trica
137Fundamentos de la junta trica . . . . . . . . . 138
Procedimientos de desmontaje y sustitucin . . . . 139Antes de empezar . . . . . . . . . . . . . . . . . . . 139
Controlar la limpieza. . . . . . . . . . . . . . 139Descargando la presin hidrulica . . . . . . . . . 139
Antes de sacar cualquier manguera. . . . . . 139Controles y ajustes para fijar la presin . . . . . 141
Conectador y desconectador de vlvula dealimentacin . . . . . . . . . . . . . . . . . . . 141
Descarga principal de direccin ybasculacin . . . . . . . . . . . . . . . . . . . . 141
Vlvula de suministro piloto de direccin ybasculacin. . . . . . . . . . . . . . . . . . . . . . . 142
Vlvula secuencial . . . . . . . . . . . . . . . 142
Funcionamiento hidrulico . . . . . . . . . . . . 142Caudales de bomba . . . . . . . . . . . . . . . . . . 142Desmontaje y sustitucin del cilindro de direccin
143Desmontaje del cilindro de direccin . . . . 143Instalacin de cilindro de direccin . . . . . 143
Desmontaje y sustitucin del cilindro debasculacin. . . . . . . . . . . . . . . . . . . . . . . . . . 143
Instalacin de cilindro de basculacin . . . 144Desmontaje y sustitucin del cilindro de
levantamiento. . . . . . . . . . . . . . . . . . . . . . . . 145Desmontaje de cilindro de levantamiento. 145
Instalacin de cilindro de levantamiento . 145Desmontaje y sustitucin de la bomba hidrulica
146Instalacin de bomba . . . . . . . . . . . . . . . . 146
Desmontaje y sustitucin de la vlvula hidrulica146
Desmontaje de vlvula . . . . . . . . . . . . . . . 146Sustitucin de vlvula. . . . . . . . . . . . . . . . 147Desmontaje y servicio del cartucho de vlvula
147Colectores hidrulicos . . . . . . . . . . . . . . . . . . 147
http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/7/23/2019 Manual de Servicio de Toro ST710
9/232
Atlas Copco VII
Sustitucin de colector . . . . . . . . . . . . . . . 148Puesta en marcha de sistema hidrulico. . . . . 148Preparacin para marcha de prueba . . . . . . . . 148Marcha de prueba . . . . . . . . . . . . . . . . . . . . . . 149
Captulo 8: Sistemas elctricosSistema de 24 V, presentacin general . . . . . . . . 151
Exposicin bsica del circuito elctrico. . . . . 151Mantenimiento general de los sistema electrnicos
152Emplee las herramientas adecuadas . . . . . 152Emplee los procedimientos adecuados. . . 152
Sustitucin de componentes electrnicos. . . . 153Principales sistemas de apoyo . . . . . . . . . . . . . . . 154
Mazos de cables . . . . . . . . . . . . . . . . . . . . . . . 154
Interruptor principal . . . . . . . . . . . . . . . . . 154Caja de componentes . . . . . . . . . . . . . . . . 154Caja de conexiones. . . . . . . . . . . . . . . . . . 155Transductores . . . . . . . . . . . . . . . . . . . . . . 155Desmontaje de transductor . . . . . . . . . . . . 155Cambio del transductor. . . . . . . . . . . . . . . 155
Sistema de carga y arranque. . . . . . . . . . . . . . 156Mdulo de control del motor . . . . . . . . . . 156Cuidado de la batera . . . . . . . . . . . . . . . . 156Seleccin e instalacin . . . . . . . . . . . . . . . 156Servicio peridico. . . . . . . . . . . . . . . . . . . 156
Terminales de cable y sujeciones . . . . . . . 157Lquido de batera. . . . . . . . . . . . . . . . . . . 157Climas tropicales . . . . . . . . . . . . . . . . . . . 157Factores que afectan la vida de servicio de labatera . . . . . . . . . . . . . . . . . . . . . . . . . . 157
Sobrecarga . . . . . . . . . . . . . . . . . . . . . 157Carga deficiente . . . . . . . . . . . . . . . . . 158Falta de agua. . . . . . . . . . . . . . . . . . . . 158Congelacin del electrolito. . . . . . . . . 158Envejecimiento . . . . . . . . . . . . . . . . . . 158Capacidad inadecuada. . . . . . . . . . . . . 158Mantenimiento deficiente . . . . . . . . . . 158
Instalacin suelta. . . . . . . . . . . . . . . . . 159Deteccin de averas potenciales . . . . . . . 159
Inspeccin visual. . . . . . . . . . . . . . . . . 159Lectura del contador de horas. . . . . . . 159Pruebas . . . . . . . . . . . . . . . . . . . . . . . . 159
Prueba de carga de elemento . . . . . . . . . . 159Usando un densmetro de lquidos
(hidrmetro) . . . . . . . . . . . . . . . . . . . 159Empleo de un probador de capacidad debatera. . . . . . . . . . . . . . . . . . . . . . . . 159
Cables de recarga de batera. . . . . . . . . . . 160
Almacenamiento de bateras de plomo-cido160
Extraccin de la batera . . . . . . . . . . . . . . 160Cambio de batera . . . . . . . . . . . . . . . . . . 160
Alternador . . . . . . . . . . . . . . . . . . . . . . . . . . . 161Anillos colectores y escobillas del alternador
161Desmontaje del alternador . . . . . . . . . . . . 162Cambio de alternador . . . . . . . . . . . . . . . . 162
Motor de arranque . . . . . . . . . . . . . . . . . . . . . 163Desmontaje del estrter . . . . . . . . . . . . . . 163Cambio de estrter . . . . . . . . . . . . . . . . . . 163
Sistemas de control con microprocesador . . . . . . 164Mdulo de control del motor . . . . . . . . . . . . . 164Diagnstico del ECM del motor . . . . . . . . . . 164
Lector de datos de diagnstico. . . . . . . . . 164Luces de control de motor y parada de motor
165Identificacin de cdigos . . . . . . . . . . 165Generacin de cdigos . . . . . . . . . . . . 165Interpretacin de cdigos . . . . . . . . . . 165
Sensores del sistema ECM. . . . . . . . . . . . 165Sensores del motor . . . . . . . . . . . . . . . 165Sensores del vehculo . . . . . . . . . . . . . 165Sensor de nivel del refrigerante . . . . . 165Sensor de posicin del regulador . . . . 166
Componentes electrnicos montados en la cabina167Unidad de control del transverter (TCU) . 167
Lectores magnticos del transverter. . 168Calibracin del transverter. . . . . . . . . . . . . . . 168
Control lgico programable . . . . . . . . . . . 169Cdigos numricos del PLC mostrados . .
169Seales de entrada y salida del PLC. . 170
Unidad de control de datos. . . . . . . . . . . . 170Protecciones electrnicas . . . . . . . . . . . . . 171
Indicadores y mandos del conductor . . . . . . . . . . 172
Panel de visualizacin de indicadores . . . . . . 172Luz de control de motor, luz de parada de
motor y botn de supresin del motor. .172
Luz de control del transverter. . . . . . . 172Centro de minimensajes (MMC) . . . . 173Temperatura del refrigerante del motor173Esfera indicadora de temperatura de aceite
del transverter . . . . . . . . . . . . . . . . . 173Indicador de presin del transverter . . 174Esfera de combustible . . . . . . . . . . . . 174
http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/7/23/2019 Manual de Servicio de Toro ST710
10/232
ndiceManual de Servicio
VIII
ST710
Manmetro de presin de aceite . . . . . 174Tacmetro . . . . . . . . . . . . . . . . . . . . . . 175Voltmetro . . . . . . . . . . . . . . . . . . . . . . 175Manmetro del acumulador. . . . . . . . . 175Temperatura del aceite hidrulico . . . . 176
Paneles de mando . . . . . . . . . . . . . . . . . . . . . . 176Selector de gama de transmisin. . . . . . . . 176Interruptores de freno de estacionamiento y deprueba de freno. . . . . . . . . . . . . . . . . . . . 176
Conmutador del freno de estacionamiento177
Conmutador de prueba del freno . . . . .177Comprobacin de los frenos . . . . . . . . . . . 177Pruebe el sistema de freno de estacionamiento
en la posicin 1. . . . . . . . . . . . . . . . . . . . 177
Si el vehculo se mueve . . . . . . . . . . . . 178Si los frenos impiden el movimiento del
vehculo. . . . . . . . . . . . . . . . . . . . . . . 178Pruebe el sistema de freno de estacionamiento
en la posicin 2. . . . . . . . . . . . . . . . . . . . 178Si el vehculo se mueve . . . . . . . . . . . . 178Si los frenos impiden el movimiento del
vehculo. . . . . . . . . . . . . . . . . . . . . . . 178Comprobacin de los frenos de servicio . . 178
Si el vehculo se mueve . . . . . . . . . . . . 178Si los frenos impiden el movimiento del
vehculo. . . . . . . . . . . . . . . . . . . . . . . 179Botn de sortear el motor/Peticin dediagnstico . . . . . . . . . . . . . . . . . . . . . . . 179
Botn del claxon . . . . . . . . . . . . . . . . . . . . 179Claxon . . . . . . . . . . . . . . . . . . . . . . . . . 179
Conmutadores de alumbrado de vehculofuncionando . . . . . . . . . . . . . . . . . . . . . . 179
Lmparas de vehculo funcionando. . . 180Interruptor de encendido y ruptores de circuito
180Alarma de marcha atrs. . . . . . . . . . . . . . . 180
Captulo 9: Sistemas opcionalesSistema de supresin de incendios . . . . . . . . . . . . 181
Manejo del sistema . . . . . . . . . . . . . . . . . . . . . 182Secuencia del proceso . . . . . . . . . . . . . . . . . . . 182
Se inicia un incendio . . . . . . . . . . . . . . . . .182El operador activa el actuador. . . . . . . . . . 182Distribucin agente qumico seco . . . . . . . 182Descarga del agente qumico seco. . . . . . . 183
Extintor de mano. . . . . . . . . . . . . . . . . . . . . . . 183En caso de incendio. . . . . . . . . . . . . . . . . . . . . 183Componentes del sistema . . . . . . . . . . . . . . . . 183
Actuador . . . . . . . . . . . . . . . . . . . . . . . . . . 183Receptor del cartucho y cartucho de gas. . 183Depsito de agente qumico seco . . . . . . . 184Boquillas . . . . . . . . . . . . . . . . . . . . . . . . . . 184
Informacin general sobre el mantenimiento . 184Mensualmente. . . . . . . . . . . . . . . . . . . . . . 184Cada seis meses. . . . . . . . . . . . . . . . . . . . . 184
Sistema de supresin de incendios Checkfire . . . 185Sistema automtico Checkfire . . . . . . . . . . . . 185
Mdulo de control de Checkfire . . . . . . . . 185Conmutador de demora/reposicin . . . 185
Lmparas de diagnstico. . . . . . . . . . . . . . 186Sistemas de control del desplazamiento. . . . . . . . 186
Principio de funcionamiento. . . . . . . . . . . . . . 186Componentes del sistema de control del
desplazamiento. . . . . . . . . . . . . . . . . . . . . . . 186Distribuidor de control del desplazamiento . .
186Acumulador. . . . . . . . . . . . . . . . . . . . . . . . 186
Chapter 10: Estrategias para la localizacin deaverasSntomas y soluciones . . . . . . . . . . . . . . . . . . . . . 187
Sntomas del motor. . . . . . . . . . . . . . . . . . . . . 188Sntomas del transverter . . . . . . . . . . . . . . . . . 192Sntomas del eje . . . . . . . . . . . . . . . . . . . . . . . 193
Sntomas de la lnea de propulsin . . . . . . . . . 194Sntomas de las ruedas y neumticos . . . . . . . 195Sntomas de la articulacin. . . . . . . . . . . . . . . 195Sntomas del sistema hidrulico . . . . . . . . . . . 196Sntomas del freno . . . . . . . . . . . . . . . . . . . . . 200Sntomas del freno de estacionamiento . . . . . 202Sntomas del sistema elctrico . . . . . . . . . . . . 202
Captulo 11:Especificaciones del vehculoPrestaciones del ST710. . . . . . . . . . . . . . . . . . 209
Motor. . . . . . . . . . . . . . . . . . . . . . . . . . 209Gama de pesos del vehculo . . . . . . . . 209
Tiempos de los movimientos . . . . . . . 209Direccin/Maniobra y oscilacin . . . . 209Capacidad de cucharn . . . . . . . . . . . . 209Velocidad . . . . . . . . . . . . . . . . . . . . . . 209Presiones hidrulicas. . . . . . . . . . . . . . 209Presin de freno. . . . . . . . . . . . . . . . . . 209
Estabilidad . . . . . . . . . . . . . . . . . . . . . . . . . . . 210Nivel de ruidos . . . . . . . . . . . . . . . . . . . . . . . . 210Sistema elctrico. . . . . . . . . . . . . . . . . . . . . . . 210
Alternador . . . . . . . . . . . . . . . . . . . . . . 210Bateras . . . . . . . . . . . . . . . . . . . . . . . . 210
http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/7/23/2019 Manual de Servicio de Toro ST710
11/232
Atlas Copco IX
Lquidos y lubricacin . . . . . . . . . . . . . . . . . . 210Capacidades de lquidos . . . . . . . . . . . . . . 210
Motor . . . . . . . . . . . . . . . . . . . . . . . . . 210Depsito de combustible . . . . . . . . . . 210Sistema de refrigeracin . . . . . . . . . . 210Transverter . . . . . . . . . . . . . . . . . . . . . 210Up box. . . . . . . . . . . . . . . . . . . . . . . . . 210Ejes . . . . . . . . . . . . . . . . . . . . . . . . . . . 210Depsito hidrulico . . . . . . . . . . . . . . 210Presin de los neumticos. . . . . . . . . . 210
Calidad y seleccin del combustible diesel210Tabla de seleccin del combustible . . . . . 212
Clasificacin general de combustibles 212Especificaciones del refrigerante del motor . .
212
Especificaciones del aceite lubricante . . . 212Upbox . . . . . . . . . . . . . . . . . . . . . . . . . 212Transverter . . . . . . . . . . . . . . . . . . . . . 213Ejes . . . . . . . . . . . . . . . . . . . . . . . . . . . 213
Grasa. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 213Tablas de temperatura ambiente. . . . . . . . 213
Motor . . . . . . . . . . . . . . . . . . . . . . . . . 213Ejes . . . . . . . . . . . . . . . . . . . . . . . . . . . 213
Lquido hidrulico ACW . . . . . . . . . . . . . 213Especificaciones de par . . . . . . . . . . . . . . . . . 214
Emplee la herramienta adecuada para la tarea a
realizar . . . . . . . . . . . . . . . . . . . . . . . . . . 214Valores de par por tamao de perno y rosca .214
Intervalo . . . . . . . . . . . . . . . . . . . . . . . 214Definiciones . . . . . . . . . . . . . . . . . . . . 214Alta resistencia . . . . . . . . . . . . . . . . . . 214Tolerancias . . . . . . . . . . . . . . . . . . . . . 214Rosca gruesa unificada . . . . . . . . . . . . 214Rosca gruesa unificada . . . . . . . . . . . . 214Rosca fina unificada . . . . . . . . . . . . . . 215Rosca fina unificada . . . . . . . . . . . . . . 215Rosca gruesa mtrica . . . . . . . . . . . . . 215
Rosca gruesa mtrica . . . . . . . . . . . . . 215Pares de apriete de los conectores elctricos .
216Conexiones de cableado del bloque debornes. . . . . . . . . . . . . . . . . . . . . . . . 216
Conectores Deutsch con tuerca demampara. . . . . . . . . . . . . . . . . . . . . . 216
Tornillos de apriete y ranurados . . . . . 216Tuerca de interruptor Iso. . . . . . . . . . . 216Conectores con tornillos de clavija
hexagonal . . . . . . . . . . . . . . . . . . . . . 216
Conectores Harting con bornes de tornillo216
http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/http://st710%20spanska.pdf/7/23/2019 Manual de Servicio de Toro ST710
12/232
ndiceManual de Servicio
X
ST710
7/23/2019 Manual de Servicio de Toro ST710
13/232
Atlas Copco 1
Captulo 1: Introduccin sobre el ST710
Descripcin del vehculoEl Atlas Copco Wagner ST710 est equipado con un
bastidor motor y un bastidor de carga conectados poruna junta articulada con una capacidad de rotacin de
42.5 grados, lo cual permite giros muy amplios.Lasdos secciones permanecen niveladas entre s.El ejetrasero oscila de forma que los 4 neumticos siempre
pueden mantenerse en contacto con el suelo, inclusoen terrenos accidentados.
El bastidor motor contiene el motor y el transverterque accionan los sistemas hidrulicos de direccin,frenos, basculacin y transmisin a las 4 ruedas.El
bastidor de carga contiene el eje de accionamientodelantero y sustenta el cucharn.
El vehculo ha sido diseado para un mximadurabilidad y un fcil mantenimiento.
Proteccin contra peligrosLas principales precauciones de seguridad se
especifican en en el captuloMentalizacin en torno a
la seguridaddel manual.Se hacen resaltar
precauciones de seguridad especficas en todos los
captulos.
Grficas del vehculoSe ponen letreros de seguridad en el vehculo para
avisar de una posible exposicin a riesgos que se
pueden incurrir durante el uso o funcionamiento
razonable del vehculo.
Alertas de seguridad de la Gua
de servicioLos mensajes de seguridad que se muestran en este
manual incluyen una palabra de aviso.Esta palabra
muestra el grado o nivel de riesgo.Las palabras de
aviso de seguridad sonPELIGRO, Importante y
Precaucin.
PELIGRO Un peligro extremo que, de no
ser evitado, puede resultar en lesiones
mortales o graves.
Importante Un peligro potencial que, si no seevita, puede conducir a la muerte o a
lesiones graves.
Caution Un riesgo, que si no se evita, puede
causar daos menores o moderados.
Mensajes de ahorro de tiempoPalabras de aviso adicionales destacan informacin
importante que puede facilitar las tareas de servicio.
Importante Informacin que puede evitar daos
al vehculo.
7/23/2019 Manual de Servicio de Toro ST710
14/232
Captulo 1: Introduccin sobre el ST710
Service Guide
2
ST710
N o t a Indica informacin especfica que ahorrartiempo o que ha sido muy til en el pasado.
Transporte del vehculoPELIGRO El vehculo se puede deslizar y
causar daos o la muerte al cargarlo a un
remolque.Primero hay que sacar todo el
aceite, hielo, nieve, agua o residuos de la
rampa y el remolque.
N o t a Se debe empezar el acceso con espaciosuficiente para enderezar el vehculo antes
de entrar en la rampa.Manejar el vehculo
lentamente al remolque, centrndolo a
medida que vaya avanzando.
Amarraduras traseras
Figura 1-1
Argollas de amarraduras traseras
Debe conocer las leyes y regulaciones para cada reapor la que transportar el vehculo.Tambin debe
conocer todo el equipo de seguridad que se requiere en
cada rea.
PASO1 Bloquear cada rueda del remolque.
PASO2 Manejar el vehculo al remolque con
cuidado y lentamente.
PASO3 Posicionar el vehculo en la localizacin
deseada.
PASO4 Cuando se ha parado el vehculo, instalar el
7/23/2019 Manual de Servicio de Toro ST710
15/232
Atlas Copco 3
cierre de articulacin.
PASO5 Apretar el freno de estacionamiento y
parar el motor.
PASO6 Gire el conmutador de activacin a laposicin Off y cierre la cabina.
PASO7 Poner tacos de madera delante y detrs de
cada rueda.
PASO8 Hacer un anclaje transversal de la parte
delantera y trasera con sujeciones
adecuadas.
PASO9 Medir la mquina y el
remolque.Asegurarse que sabe la
anchura y la altura de espacio libre de su
carga.
PASO10 Despus de haber manejado la carga
unos kilmetros debe parar y controlar su
carga.Asegurarse que la carga no se ha
cambiado de sitio.
PASO11 Hay que tener mucho cuidado al sacar el
vehculo del remolque.Asegrese de
desmontar el pasador de bloqueo de la
articulacin.
PASO12 Manejar la mquina lentamente y con
cuidado para sacarla del remolque.
Remolcado del ST710Importante El transverter quedar daado si no
se desacopla la lnea de propulsin.
PELIGRO El remolque de este vehculo
puede causar graves daos o la muerte.Si
este vehculo queda fuera de servicio se
debe bloquear la parte delantera y trasera de
cada rueda y usar el procedimiento
recomendado en este manual.
Las instrucciones siguientes son para mover el
vehculo que ha quedado fuera de servicio una
distancia corta a un sitio de reparacin seguro.Si la
cargadora debe moverse una distancia larga debe
transportarse en un remolque apropiado.
PELIGRO No se debe remolcar el vehculo ms de
un kilmetro.No se deben sobrepasar los 3,3
km/h (2 mph)
PASO1 Bloquee todas las ruedas del vehculo
para evitar su movimiento.
PASO2 Se recomienda que el vehculo que
remolca sea por lo menos igual de grande
que su cargadora.El vehculo que
remolca debe tener suficiente capacidad
de freno, peso y potencia para hacer
funcionar ambos vehculos teniendo en
cuenta el terreno y la distancia implicada.
PASO3 Revisar la barra de remolque o el cable
de remolque para asegurarse que no hay
daos y que la barra o el cable se
encuentra en buenas condiciones.Hay
que asegurarse que la barra o el cable
sea lo suficientemente fuerte para las
condiciones de remolque tomando en
consideracin si el vehculo remolcado
est cargado, descargado, en una
pendiente o inmovilizado en el lodo.
PASO4 Conectar una barra de remolque o uncable de remolque de tamao
suficiente.En caso de utilizar un cable de
remolque, coloque un escudo en ambos
vehculos si hay presente un operario.El
protector debe ser lo suficientemente
fuerte como para proteger a los dos
operadores si se llegara a romper el
cable.
PASO5 Para dar control y freno al bajar el
vehculo fuera de servicio por una
pendiente, se recomienda un vehculo de
remolque ms grande y una barra deremolque slida.El cierre de
articulacin debe estar instalado en la
posicin LOCKED .Se pueden necesitar
vehculos adicionales en la parte trasera
del vehculo que est fuera de servicio.
PASO6 Si el vehculo que est fuera de servicio
ha de ser remolcado cuesta abajo y debe
ser conducido, es necesario tener un
vehculo tractor en la parte delantera y
otro en la parte trasera para controlar el
vehculo que est fuera de servicio.El
cierre de articulacindebe estar en laposicin STORED si se sigue este
procedimiento.
PASO7 Desconecte el tren intermedio y las lneas
de propulsin traseras del transverter.
Importante El transverter quedar daado si no
se desconectan las lneas de propulsin.
PASO8 Soltar el freno de estacionamiento.
N o t a Se debe haber soltado el freno deestacionamiento antes de mover el vehculo,
7/23/2019 Manual de Servicio de Toro ST710
16/232
Captulo 1: Introduccin sobre el ST710
Service Guide
4
ST710
si no pueden ocurrir daos en los neumticos
o el vehculo.
PASO9 Sacar con cuidado los calzos para
ruedas.PASO10 Empezar a mover el vehculo poco a poco
y suavemente para evitar la sobrecarga
de la barra o el cable de remolque.
PASO11 Volver a apretar el freno de
estacionamiento e inmovilizar todas las
ruedas cuando el vehculo est
estacionado.
7/23/2019 Manual de Servicio de Toro ST710
17/232
Atlas Copco 5
Captulo 2: Mentalizacin en torno a la seguridad
Protjase usted y proteja suscompaerosAntes de realizar cualquier mantenimiento en la
cargadora se deben repasar las siguientes precauciones
de seguridad.Estn incluidas para su proteccin.
Siempre hay que observar las siguientes reglasgenerales de seguridad durante el funcionamiento del
vehculo.Tambin hay que observar las reglas de
seguridad que se exponen en el lugar de trabajo y
desarrollar reglas adicionales segn puedan requerir
aplicaciones concretas de minera para un
funcionamiento seguro.
Hay que leer y seguir con cuidado todas las
instrucciones que se resumen en los
Manuales del Operador y de Servicio.
Hay que asegurarse que todos los mandos e
indicadores de funcionamiento estn
actuando de forma correcta.
Nunca se deben usar los mandos con apoyos
de montaje.
Nunca debe permitir acompaantes.
Bloquear las ruedas al estacionar.
Nunca se debe fumar cerca de combustible.
Siempre se debe conocer la localizacin del
extintor de incendios ms cercano.
Controlar la parada de seguridad del sistema
antes de cada turno.
Cuidado con otras personas, puede ser que
ellos no lo estn mirando.
7/23/2019 Manual de Servicio de Toro ST710
18/232
Captulo 2: Mentalizacin en torno a la seguridad
Manual de Servicio
6
ST710
Siempre se deben apretar los frenos antes de
dejar el vehculo.
Procedimientos deconfiguracin de servicioAntes de iniciar el mantenimiento, prepare el vehculo
de acuerdo a los procedimientos siguientes.
Estacionar el vehculo