INSTRUMENTATION AND PROCESS CONTROL TRAINING SYSTEM SERIES 3531

(732) 938-2000 / 800-LAB-VOLT, FAX: (732) 774-8573, E-MAIL: [email protected](418) 849-1000 / 800-LAB-VOLT, FAX: (418) 849-1666, E-MAIL: [email protected]

INTERNET: http://www.labvolt.com

System shown with optional equipment.

AInstrumentation and Process Control INSTRUMENTATION AND

PROCESS CONTROL TRAINING SYSTEMSERIES 3531

GENERAL DESCRIPTIONThe Lab-Volt Instrumentation and Process ControlTraining System introduces students to a wide range ofindustrial processes (temperature, pressure, flow, andlevel) as well as with their instruments and control. Theuse of modern equipment coupled with a completetraining program helps students to get the theoretical andpractical knowledge that is mandatory to work in theprocess control industry.

The modularity of this energy-efficient system allowsthe instructor to select specific equipment as a functionof the training objectives without going over budget.Several configurations are available for a singleworkstation. Adding optional equipment can increase thenumber of these configurations.

The Instrumentation and Process Control TrainingSystem features two workstations: the ProcessWorkstation and the Instrumentation Workstation. Thesystem can accomodate a single team of students for thetemperature experiments and up to two teams for thepressure, flow, and level experiments if the second-teamadd-on is used.

One controller from the 3539 Series is required foreach team working on the system. A wide choice ofoptional equipment is available. Refer to the charts belowfor details on the general structure of the Instrumentationand Process Control Training System.

INSTRUMENTATION AND PROCESS CONTROL TRAINING SYSTEMSERIES 3531

2

Structure of the Instrumentation and Process Control Training System

TABLE OF CONTENTSGeneral Description . . . . . . . . . . . . . . . . . . . . . . . . . 1List of Student Manuals . . . . . . . . . . . . . . . . . . . . . . 7List of Equipment Pressure/Flow/Level Basic System 3531-A or -B . . . . . . . . . . . . . . . . . . . . . . 10List of Equipment Temperature Basic System 3531-0 or -1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16List of Equipment Controllers . . . . . . . . . . . . . . . 21Optional Equipment . . . . . . . . . . . . . . . . . . . . . . . . 22Module Description . . . . . . . . . . . . . . . . . . . . . . . . . 27Personal Computer Minimum Requirements . . . . . 56

3Structure of the Instrumentation and Process Control Training System


4

Process Workstation shown with optional equipment.

Instrumentation Workstation shown with optional equipment.

Process WorkstationThe Process Workstation is the hub of the differentprocesses to be investigated by the students. It consistsof a double-sided mobile workstation equipped with two60-liter (16-gal) tanks, up to four centrifugal pumps, aRotameter, a Drip Tray (Front), an InstrumentationMounting Pipe, Ball Valves, and Process Supports.

Up to two groups of students can work at the sametime on Pressure/Flow/Level experiments, one group oneach side of the Process Workstation. This can be doneif the Pressure/Flow/Level option is selected and if theSecond Team Add-on, Model 3530-H or -K (HART) isordered (3530-J or - L for FOUNDATION Fieldbus).

To configure the system for hands-on training, thestudents have to install the appropriate instruments asdescribed in the student manuals. The student manualscover both the theory and practice of measurement,control, and troubleshooting of temperature, pressure,flow, and level processes.

The dimensions of the Process Workstation(excluding any device installed on it) are: 1.73 m x 0.80 mx 1.83 m (5'8'' x 2'8'' x 6'0'').

Instrumentation WorkstationThe Instrumentation Workstation is designed to house theElectrical Unit and the Pneumatic Unit as well as otherelectrical equipment such as the variable speed drives.Devices such as controllers, PLCs, Color PaperlessRecorder, and Touch Screen Graphic Terminals must be

installed on the Instrumentation Workstation. Theworkstation aims to recreate the widespread industrialpractice of separating the process environment from theinstruments and controllers and it limits the risk ofexposing such equipment to contact with water.

The Electrical Unit provides power for the instrumentsused on the Instrumentation and Process Control TrainingSystem. It includes a lockable power switch and a 24 Vdc power supply. The design of the Electrical Unit allowscutoff of both the electric and pneumatic power usingeither an emergency button or the lockable power switch.The teaching material includes a complete lockout/tagoutprocedure explaining how to lock the power switch. Thisprocedure is similar to the procedure used in industry tolock and unlock electrical equipment.

Like the Process Workstation, the InstrumentationWorkstation is a double-sided mobile workstation. Twogroups of students can work at the same time on thesystem, one group on each side.

The Instrumentation Workstation also features aretractable shelf.

The dimensions of the Instrumentation Workstation(excluding any device installed on it) are: 0.68 m x 1.18 mx 1.89 m (2'3'' x 3'10'' x 6'2'').

5Temperature Process SystemThis system is designed to feature the equipmentrequired to complete the measurement, control, andtroubleshooting exercises for temperature processes. Itincludes a Heating/Cooling Unit, a Brazed Plate HeatExchanger, a three-way control valve, a thermocouple,an RTD (Resistance Temperature Detector), and atemperature transmitter. The temperature transmitter cansupport either the HART or the FOUNDATION Fieldbuscommunication protocols.

A variety of optional heat exchangers is available foradvanced training in temperature process control:C a Gasketed Plate Heat ExchangerC a Shell and Tube Heat Exchanger (1 pass)C a Shell and Tube Heat Exchanger (4 pass)

Pressure, Flow, and Level Process SystemThis system includes the equipment required to completethe measurement, control, and troubleshooting exercisesfor the pressure, flow, and level processes.

This system features two differential-pressure trans-mitters supporting the HART communication protocol, adigital pressure gauge, a pneumatic control valve, a colorpaperless recorder, a rotameter, and a Venturi tube.Transmitters supporting other communication protocolssuch as FOUNDATION Fieldbus are available on request.

A wide variety of optional equipment is available foradvanced training in pressure, flow, and level processcontrol:C a Column (Small Diameter)C an Orifice PlateC a Pitot TubeC an Electromagnetic Flow Transmitter (HART)C a Vortex Flow Transmitter (HART)C a Coriolis Flow Transmitter (HART)C a Paddle Wheel Flow TransmitterC an Ultrasonic Level Transmitter (HART)C an Ultrasonic Flow Transmitter (HART)C a Radar Level Transmitter (HART)C a Guided-Radar Level Transmitter (HART)C a Vibrating Fork Level SwitchC a Conductivity Level SwitchC a Capacitive Level Transmitter (HART)C a Float SwitchC a Pressure Switch (with Analog Output)C a Pressure Transmitter (HART)

Most models are also available in a FOUNDATIONFieldbus-compliant version. Consult the descriptions fordetails.

Optional ValvesLab-Volt offers a selection of pneumatic control valves toupgrade your system. The valves come with a current-to-pressure converter (if required). Among the valvesavailable are:C Pneumatic Control Valves with different Digital Posi-

tioners (Three-Way Valve versions also available)C a Pneumatic Control Valve with Positioner (Three-Way

Valve version also available)C Electric Control Valve (Three-Way Valve version also

available)C a Vee-Ball Control ValveC a Solenoid ValveC a Ball Valve

ControllersLab-Volt also offers a wide selection of controllers suchas:C Industrial PID Controllers (Ethernet or Modbus)C Programmable Logic Controllers (with Ethernet

communications, Analog I/O, programming software,and Communication Cable)

SCADA / DCS SoftwareTwo SCADA software programs are available for thesystem: Wonderware Development Studio (includingInTouch) and FactoryTalk View Studio (from RockwellSoftware). Both software programs come with aninterface specially designed for the Instrumentation andProcess Control Training System. An OPC server for theFoxboro controller is also available.

Calibration InstrumentationAn accurate calibration device is an essential addition tothe system. It allows calibration and maintenance of thetransmitters, current to pressure converter, gauges, andcontrol valves. Four different calibration packages areavailable. A basic version makes it possible to performthe required calibration and a second version includesmore advanced equipment.

Three other calibration kits are each designed to actas configurator and sophisticated tools to calibrate thesmart devices over the HART and/or the FOUNDATIONFieldbus communication protocols.

Other devicesOther devices are also available to enhance the system.These devices allow the students to explore moretechnologies and communication protocols used in theindustry. Among the optional devices available are:C a Signal TowerC Touch Screen Graphic Terminal (available in two sizes)C an additional Pumping Unit


6

Simulation of boiling water in the Process Column.

Smart devices: HART and FOUNDATIONFieldbusMany components of the Instrumentation and ProcessControl Training System feature a transmitter which isable to communicate via one of two communicationprotocols: HART or FOUNDATION Fieldbus.

The HART protocol enables communication betweendevices by superimposing digital signals on top of theexisting 4-20 mA outputs. The Fieldbus protocol is like aLocal Area Network (LAN) for smart devices.

Most of these devices can usually be configuredmanually via their alphanumeric display and/or push-buttons, but it is much quicker and more efficient to usea communication link to configure them remotely from acomputer. The HART apparatuses can be connected toa computer using the HART Software Configurator (Model46982-0 or -B). Fieldbus devices can be configured froma computer with the FOUNDATION Fieldbus SoftwareConfigurator (Model 46982-A or -B). Calibration kits areavailable for each of the two communication protocols.

A Software Configurator compatible with the selectedcommunication protocol is strongly suggested and is evenmandatory for some specific transmitters.

TroubleshootingTroubleshooting of industrial process equipment is anintegral part of the learning process. This is why theInstrumentation and Process Control Training Systemfeatures many tools to help instructors devisetroubleshooting exercises for the students. Faults can beinserted in most devices: Controllers, PLCs, Valves,Transmitters, etc.Three different methods to insert faults exist:C Local Fault Insertion is done by accessing the fault

panel on a particular device to activate faults asrequired.

C Remote Calibration Fault is performed by changing thecalibration parameters of a device from the instructor'scomputer over either the HART or the Fieldbus commu-nication protocol (requires the appropriate modules).

C Remote Fault Insertion is done by remotely modifyingthe state of I/O relays on a controller or a PLC from acomputer or from a Touch Screen Terminal.

Pressure and Flow Compressed AirAn instrumentation and process control system forcompressed air is also available as an add-on to the 3531system. Measurement and control experiments relatedto pressure and flow of compressed air can be done withthe following devices:C Air TanksC Air RotameterC Orifice Plate for airC Solenoid Valve for airC Pneumatic Control Valve for air

Boiler Simulation (Water / Air)The Boiler Simulation system is an inherently safe boilersimulator which is not pressurized and works with waterat room temperature. The key features of a boilingprocess are replicated with a controlled flow of air injectedat the base of a process column containing a controllablelevel of water. Up to three elements and three controlloops (2 PID loops and 1 calibrator) are involved in thecontrol of the level of water in the drum of the boiler.

The boiling process is recreated by regulating theflow of air injected in the column while operating a secondpump which drains the column to simulate evaporationof water. The Boiler Simulation system is a synthesis ofmany industrial control notions and involves multiplecontrol loops as well as feedforward and cascade control.

The Boiler Simulation is an add-on to the Instrumen-tation and Process Control Training System and mayinclude a pump and a drive if required. The boiler systemcan only be used by one team at a time. A controller witha minimum of three inputs and two PID loops capable ofboth cascade and feedforward control and a 4-20 mAcalibrator are also necessary.

As both cascade and feedforward control schemesare used, the advanced P/F/L add-on (Model 3530-M0)is required and it is assumed that the students are familiarwith these topics beforehand.

Advanced Process Control - TemperatureThe inclusion of this add-on (Model 3531-2 or -3) to theProcess Control Training system offers the possibility toperform a set of advanced temperature controlexperiments. The main feature resides in the use of

7electromagnetic flowmeters and RTDs coupled to theenergy manager to obtain precise energy balances.

Advanced Process Control - Pressure/Flow/LevelThe inclusion of this add-on (Model 3530-M) to theProcess Control Training system offers the capability toperform a set of advanced process control experiments.The experiments include feedforward control, ratiocontrol, split-range control, and the control ofsecond-order processes. The add-on includes asmall-diameter column, an upper tank, an orifice plate,a pneumatic control valve, and some accessories.

Air requirementsThe Instrumentation and Process Control TrainingSystem requires a reliable source of compressed air fromeither a central air supply or a portable unit. Your centralair supply or your portable unit must be able to deliver airat a minimal flow of 110 l/min (4 CFM) with a pressure of620 kPa (90 PSI).

Compressed air units are available from yourLab-Volt representative. Model 6410-BX is a portable unitwhich is well suited to the system.

Optional system add-onsThe Instrumentation and Process Control TrainingSystem can also be equipped with optional add-ons suchas:C pH and Conductivity add-ons. To obtain information

on the capabilities and models available, please referto the companion datasheet for the 3532 system(88164).

LIST OF STUDENT MANUALSCORE MANUALS - TemperatureThe four core manuals on temperature processes coverthe following topics: Basic use of the system and itsdevices, introduction to temperature measurement andinstruments, RTDs and thermocouples, basics ofthermodynamics and heat transfer mechanisms, heatexchangers, temperature process control, and energybalances.

Familiarization with the Instrumentation and ProcessControl Training System - Temperature (86008-E0)C Process WorkstationC Instrumentation WorkstationC Electrical UnitC AC Drive and PumpsC Emergency Push-ButtonC Pneumatic UnitC Trend RecorderC Heating/Cooling UnitC Temperature Probes and TransmitterC Brazed Plate Heat ExchangerC Three-Way Pneumatic ValveC AccessoriesC Basic SetupC I.S.A. Standard and Instrument Symbols

Temperature Process Measurement (86009)C Introduction to MeasurementC Measuring InstrumentsC Temperature Measurement

Definitions of Temperature, Energy, Scales, andThermodynamics

RTDs and ThermocouplesC Heat Exchanges

Heat Transfer Mechanisms Basic Thermal Energy Transfer Setup

Temperature Process Control (86010)C Dynamic Characteristics of a ProcessC Feedback Control

Tuning and Control of a Temperature Loop Trial and Error Method Ultimate Period Method Ziegler-Nichols Method

C Troubleshooting Guided Process Troubleshooting

Heat Exchangers and Advanced TemperatureMeasurement (86011)C Familiarization with the Energy ManagerC Heat Exchangers


8

Brazed Plate Heat Exchanger Gasketed Plate Heat Exchanger - Optional Shell-and-Tube Heat Exchanger (Single Pass) -

Optional Shell-and-Tube Heat Exchanger (Four Passes) -

Optional

An optional CD-ROM (85980-A0) includes the coretemperature manuals and many other manuals. See thecomplete content of the CD in the list of equipment.

CORE MANUALS - Pressure, Flow, and Level

Familiarization with the Instrumentation and ProcessControl Training System - Pressure, Flow, and Level(86004-E0)C Process WorkstationC Instrumentation WorkstationC Electrical UnitC AC DriveC Emergency Push-ButtonC Pneumatic UnitC Trend RecorderC Process Column, Wet Reference Leg, and BubblerC Digital Pressure GaugeC Differential-Pressure TransmitterC Three-Valve ManifoldC Solenoid ValveC Pneumatic Control ValveC Venturi TubeC RotameterC AccessoriesC Basic SetupC I.S.A. Standard and Instrument Symbols

Measurement - Pressure, Flow, and Level (86005)C Introduction to MeasurementC Measuring InstrumentsC Pressure Measurement

Pressure Measurement Pressure Loss

C Flow Measurement Flowmeters Centrifugal Pumps

C Level Measurement Differential-Pressure Level Meters Bubblers Wet Reference Leg

Process Control - Pressure, Flow, and Level(86006)C Dynamic characteristics of a processC Process control

Tuning and control of a pressure loop (trial and errormethod)

Tuning and control of a flow loop (ultimate periodmethod)

Tuning and control of a level loop (Ziegler-Nicholsmethod)

Cascade control, level-flowC Troubleshooting

Guided Process Troubleshooting (Typical plantstartup after a shutdown)

Non-Guided Process Troubleshooting

Advanced Process Control - Pressure, Flow, andLevel (86007)C Feed forward controlC Ratio controlC Split range controlC 2nd order interacting processesC 2nd order non-interacting processes

An optional CD-ROM (85980-A0) includes the corepressure/flow/level manuals and many other manuals.See the complete content of the CD in the list ofequipment.

CORE MANUALS - AIR - Pressure and Flow

The three core manuals on air processes cover thefollowing topics: Basic use of the system and its devices,introduction to the measurement of air pressure and flow,introduction to the associated instruments, air tanks,control of air pressure and flow.

Familiarization with the Instrumentation and ProcessControl Training System - Air (85987-E0)C Introduction to the Training SystemC Electrical UnitC Emergency Push-ButtonC Pneumatic UnitC Trend RecorderC RotameterC Digital Pressure GaugeC Differential-Pressure TransmittersC Orifice (Air)C Solenoid ValveC Pneumatic Control ValveC Air TanksC Muffler AssemblyC AccessoriesC I.S.A. Standard and Instrument Symbols

9Measurement - Air (85988)C Introduction to MeasurementC Measuring InstrumentsC Pressure Measurement

Introduction to Fluid Mechanics Pressure Sensing devices Pressure Loss

C Flow Measurement Elements of Fluid Dynamics Flowmeters

Process Control - Air (85989)C Dynamic Characteristics of a ProcessC Feedback Control

Tuning and Control of a Pressure Loop and a FlowLoop

Trial and Error Method Ultimate Period Method Ziegler-Nichols Method

C Troubleshooting Guided Process Troubleshooting

An optional CD-ROM (85980-A0) includes the core airmanuals and many other manuals. See the completecontent of the CD in the list of equipment.

CORE MANUALS pH and Conductivity

The three core manuals on pH and conductivityprocesses cover the following topics: Basic use of thesystem and its devices, introduction to pH andconductivity measurement, pH probes, conductivityprobes, ion-exchange resins, basics chemistry, as wellas pH and conductivity process control. The optionalConductivity Process Add-On System is required tocomplete the conductivity exercises of the core manuals.

Familiarization with the Instrumentation and ProcessControl Training System pH and Conductivity(86012-E0)

Measurement pH and Conductivity (86013)

Process Control pH and Conductivity (86014)

OPTIONAL MANUALS

Calibration Package (85984)Human-Machine Interfaces - FactoryTalk View(85985-E0)Human-Machine Interface - InTouch (85986-E0)Electromagnetic Flow Transmitter (85990)Ultrasonic Level Elements (85991)Radar and Guided-Radar Level Transmitters(85992)Boiler Simulation (85993)Vortex Flow Transmitter (85994)Coriolis Flow Transmitter (85995)Primary Flow Elements (85996)Ultrasonic Flow Transmitter (85997)Paddlewheel Flow Transmitter (85998)Capacitive Level Transmitter (85999)Switches (86000)Control Valves (86001-E0)FOUNDATION Fieldbus Device Configuration(86002)ControlLogix and CompactLogix ProgrammableLogic Controllers (86030-E0)PLC MicroLogix 1100 (86032)PID Controller Foxboro (86033)PID Controller Honeywell (86034)HART Device Configuration (86050)FOUNDATION Fieldbus Networking (89454-E0)

An optional CD-ROM (85990-A0) includes many optionalmanuals. See the complete content of the CD in the listof equipment.


1 This model needs a controller Model 3539-XX to be fully functional.2 The ordering numbers showm apply to the English 120-V version. Other versions are available.

10

Content dependency structure of the Lab-Volt manuals for the 3531 system

LIST OF EQUIPMENT PRESSURE/FLOW/LEVEL BASIC SYSTEM 3531-A or -BPRESSURE/FLOW/LEVEL PROCESS HART, MODEL 3531-A1

QTY DESCRIPTION ORDERING NUMBER2

1 Emergency Switch Station . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5926-A01 Digital Pressure Gauge (High Range) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46761-B01 Process Workstation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46801-F01 Instrumentation Workstation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46900-F01 Column (Large Diameter) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46901-001 Rotameter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46910-001 Venturi Tube . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46911-001 Differential-Pressure Transmitter (HART, High Range) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46920-001 Differential-Pressure Transmitter (HART, Low Range) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46921-001 Pneumatic Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46950-B01 Solenoid Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46951-001 Electrical Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46970-B01 Pneumatic Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46971-A01 Color Paperless Recorder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46972-001 AC Drive (Ethernet) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46975-A01 Instrumentation Mounting Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46990-001 Process Supports Pressure/Flow/Level/Temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46991-C01 Drip Tray (Front) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46992-B01 Piping and Accessories - Pressure/Flow/Level Basic System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46993-E01 Familiarization with the Instrumentation and Process Control System -

Pressure/Flow/Level User Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86004-E01 Measurement - Pressure/Flow/Level Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86005-001 Measurement - Pressure/Flow/Level Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86005-101 Process Control - Pressure/Flow/Level Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86006-001 Process Control - Pressure/Flow/Level Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86006-10

3 This model needs a PLC controller Model 3539-XX and the FOUNDATION Fieldbus PLC add-on (3539-9) to be fully functional.

11

LIST OF EQUIPMENT PRESSURE/FLOW/LEVEL BASIC SYSTEM 3531-A or -B (contd)PRESSURE/FLOW/LEVEL PROCESS FOUNDATION FIELDBUS, MODEL 3531-B3


1 Emergency Switch Station . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5926-A01 Digital Pressure Gauge (High Range) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46761-B01 Process Workstation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46801-F01 Instrumentation Workstation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46900-F01 Column (Large Diameter) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46901-001 Rotameter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46910-001 Venturi Tube . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46911-001 Differential-Pressure Transmitter (FOUNDATION Fieldbus, High Range) . . . . . . . . . . . . . . . . . . . 46920-A01 Differential-Pressure Transmitter (FOUNDATION Fieldbus, Low Range) . . . . . . . . . . . . . . . . . . . . 46921-A01 Pneumatic Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46950-B01 Solenoid Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46951-001 Electrical Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46970-B01 Pneumatic Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46971-A01 Color Paperless Recorder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46972-001 AC Drive (Ethernet) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46975-A01 Instrumentation Mounting Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46990-001 Process Supports Pressure/Flow/Level/Temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46991-C01 Drip Tray (Front) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46992-B01 Piping and Accessories - Pressure/Flow/Level Basic System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46993-E01 Familiarization with the Instrumentation and Process Control System -


PRESSURE/FLOW/LEVEL PROCESS SECOND TEAM ADD-ON TO 3531-A HART, MODEL 3530-KQTY DESCRIPTION ORDERING NUMBER2

1 Emergency Switch Station . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5926-A01 Digital Pressure Gauge (High Range) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46761-B01 Column (Large Diameter) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46901-001 Rotameter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46910-001 Venturi Tube . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46911-001 Differential-Pressure Transmitter (HART, High Range) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46920-001 Differential-Pressure Transmitter (HART, Low Range) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46921-001 Pneumatic Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46950-B01 Solenoid Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46951-001 Color Paperless Recorder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46972-001 Instrumentation Mounting Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46990-001 Process Supports Pressure/Flow/Level Add-on, 2nd team . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46991-G01 Drip Tray (Back) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46992-C01 Piping and Accessories (2nd team) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46993-A01 Familiarization with the Instrumentation and Process Control System -



12

LIST OF EQUIPMENT PRESSURE/FLOW/LEVEL BASIC SYSTEM 3531-A or -B (contd)PRESSURE/FLOW/LEVEL PROCESS SECOND TEAM ADD-ON TO 3531-B FOUNDATION FIELDBUS,MODEL 3530-L


1 Emergency Switch Station . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5926-A01 Digital Pressure Gauge (High Range) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46761-B01 Column (Large Diameter) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46901-001 Rotameter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46910-001 Venturi Tube . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46911-001 Differential-Pressure Transmitter (FOUNDATION Fieldbus, High Range) . . . . . . . . . . . . . . . . . . . 46920-A01 Differential-Pressure Transmitter (FOUNDATION Fieldbus, Low Range) . . . . . . . . . . . . . . . . . . . . 46921-A01 Pneumatic Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46950-B01 Solenoid Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46951-001 Color Paperless Recorder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46972-001 Instrumentation Mounting Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46990-001 Process Supports Pressure/Flow/Level Add-on, 2nd team . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46991-G01 Drip Tray (Back) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46992-C01 Piping and Accessories (2nd team) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46993-A01 Familiarization with the Instrumentation and Process Control System -


PRESSURE/FLOW/LEVEL ADVANCED PROCESS CONTROL ADD-ON, MODEL 3530-MQTY DESCRIPTION ORDERING NUMBER2

1 Column (Small Diameter) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46902-001 Upper Tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46903-001 Orifice Plate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46912-001 Pneumatic Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46950-B01 Ball Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46952-001 Piping and Accessories (Advanced) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46993-G01 Advanced Process Control - Pressure/Flow/Level Student Manual . . . . . . . . . . . . . . . . . . . . . . 86007-001 Advanced Process Control - Pressure/Flow/Level Instructor Guide . . . . . . . . . . . . . . . . . . . . . . 86007-10

PRESSURE/FLOW/LEVEL ADVANCED PROCESS CONTROL SECOND TEAM ADD-ON, MODEL 3530-NQTY DESCRIPTION ORDERING NUMBER2

1 Column (Small Diameter) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46902-001 Orifice Plate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46912-001 Pneumatic Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46950-B01 Ball Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46952-001 Piping and Accessories (Advanced) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46993-G01 Advanced Process Control - Pressure/Flow/Level Student Manual . . . . . . . . . . . . . . . . . . . . . . 86007-001 Advanced Process Control - Pressure/Flow/Level Instructor Guide . . . . . . . . . . . . . . . . . . . . . . 86007-10

13

LIST OF EQUIPMENT PRESSURE/FLOW/LEVEL BASIC SYSTEM 3531-A or -B (contd)TEMPERATURE PROCESS ADD-ON HART, MODEL 3531-C


1 Pumps Add-on . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46904-A01 Pumping Unit (Add-on) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46904-B01 Brazed Plate Heat Exchanger . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46905-001 Heating/Cooling Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46908-001 J-Type Thermocouple . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46916-001 Platinum RTD 100 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46917-001 Temperature Transmitter (HART) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46940-001 Three-Way Pneumatic Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46955-B01 AC Drive (Ethernet) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46975-C02 AC Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46975-D01 Drip Tray (Back) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46992-C01 Piping and Accessories Temperature Add-on . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46993-J01 Electrical Distribution Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46997-001 Familiarization with the Instrumentation and Process Control System - Temperature User Guide 86008-E01 Measurement - Temperature Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86009-001 Measurement - Temperature Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86009-101 Process Control - Temperature Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86010-001 Process Control - Temperature Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86010-10

TEMPERATURE PROCESS ADD-ON FOUNDATION FIELDBUS, MODEL 3531-DQTY DESCRIPTION ORDERING NUMBER2

1 Pumps Add-on . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46904-A01 Pumping Unit (Add-on) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46904-B01 Brazed Plate Heat Exchanger . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46905-001 Heating/Cooling Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46908-001 J-Type Thermocouple . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46916-001 Platinum RTD 100 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46917-001 Temperature Transmitter (FOUNDATION Fieldbus) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46940-A01 Three-Way Pneumatic Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46955-B01 AC Drive (Ethernet) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46975-C02 AC Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46975-D01 Drip Tray (Back) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46992-C01 Piping and Accessories Temperature Add-on . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46993-J01 Electrical Distribution Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46997-001 Familiarization with the Instrumentation and Process Control System - Temperature User Guide 86008-E01 Measurement - Temperature Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86009-001 Measurement - Temperature Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86009-101 Process Control - Temperature Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86010-001 Process Control - Temperature Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86010-10

ADVANCED TEMPERATURE PROCESS ADD-ON HART, MODEL 3531-2QTY DESCRIPTION ORDERING NUMBER2

3 Platinum RTD 100 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46917-001 Electromagnetic Flow Transmitter (HART) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46922-001 Electromagnetic Flow Transmitter (HART, 2nd Transmitter for Advanced Temperature) . . . . . . . . . 46922-101 Energy Manager . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46974-001 Accessories (Temperature, Advanced) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46993-D01 Heat Exchangers and Advanced Temperature Measurement - Temperature Student Manual . . 86011-001 Heat Exchangers and Advanced Temperature Measurement - Temperature Instructor Guide . . 86011-10


14

LIST OF EQUIPMENT PRESSURE/FLOW/LEVEL BASIC SYSTEM 3531-A or -B (contd)ADVANCED TEMPERATURE PROCESS ADD-ON FOUNDATION FIELDBUS, MODEL 3531-3


3 Platinum RTD 100 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46917-001 Electromagnetic Flow Transmitter (FOUNDATION Fieldbus) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46922-A01 Electromagnetic Flow Transmitter (FOUNDATION Fieldbus, 2nd Transmitter for

Advanced Temperature) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46922-B01 Energy Manager . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46974-001 Accessories (Temperature, Advanced) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46993-D01 Heat Exchangers and Advanced Temperature Measurement - Temperature Student Manual . . 86011-001 Heat Exchangers and Advanced Temperature Measurement - Temperature Instructor Guide . . 86011-10

BOILER SIMULATION (WATER/AIR) ADD-ON (WITHOUT AIR ADD-ON) HART, MODEL 3531-KQTY DESCRIPTION ORDERING NUMBER2

1 Pumping Unit (Add-on) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46904-B01 Orifice Plate (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46914-001 Rotameter (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46915-001 Differential-Pressure Transmitter (HART, Low Range) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46921-001 Solenoid Valve (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46951-A01 Pneumatic Control Valve (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46953-001 AC Drive (Ethernet) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46975-A01 Boiler Simulation Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-001 Boiler Simulation Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-10

BOILER SIMULATION (WATER/AIR) ADD-ON (WITHOUT AIR ADD-ON) FOUNDATION FIELDBUS, MODEL3531-L


1 Pumping Unit (Add-on) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46904-B01 Orifice Plate (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46914-001 Rotameter (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46915-001 Differential-Pressure Transmitter (FOUNDATION Fieldbus, Low Range) . . . . . . . . . . . . . . . . . . . . 46921-A01 Solenoid Valve (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46951-A01 Pneumatic Control Valve (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46953-001 AC Drive (Ethernet) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46975-A01 Boiler Simulation Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-001 Boiler Simulation Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-10

BOILER SIMULATION (WATER/AIR) ADD-ON (WITHOUT AIR ADD-ON) HART, MODEL 3531-MQTY DESCRIPTION ORDERING NUMBER2

1 Orifice Plate (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46914-001 Rotameter (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46915-001 Differential-Pressure Transmitter (HART, Low Range) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46921-001 Solenoid Valve (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46951-A01 Pneumatic Control Valve (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46953-001 Boiler Simulation Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-001 Boiler Simulation Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-10

15

LIST OF EQUIPMENT PRESSURE/FLOW/LEVEL BASIC SYSTEM 3531-A or -B (contd)BOILER SIMULATION (WATER/AIR) ADD-ON (WITHOUT AIR ADD-ON) FOUNDATION FIELDBUS, MODEL3531-N


1 Orifice Plate (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46914-001 Rotameter (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46915-001 Differential-Pressure Transmitter (FOUNDATION Fieldbus, Low Range) . . . . . . . . . . . . . . . . . . . . 46921-A01 Solenoid Valve (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46951-A01 Pneumatic Control Valve (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46953-001 Boiler Simulation Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-001 Boiler Simulation Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-10

BOILER SIMULATION (WATER/AIR) ADD-ON (WITH AIR ADD-ON) HART, MODEL 3531-PQTY DESCRIPTION ORDERING NUMBER2

1 Differential-Pressure Transmitter (HART, Low Range) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46921-001 Boiler Simulation Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-001 Boiler Simulation Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-10

BOILER SIMULATION (WATER/AIR) ADD-ON (WITH AIR ADD-ON) FOUNDATION FIELDBUS, MODEL 3531-QQTY DESCRIPTION ORDERING NUMBER2

1 Differential-Pressure Transmitter (FOUNDATION Fieldbus, Low Range) . . . . . . . . . . . . . . . . . . . . 46921-A01 Boiler Simulation Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-001 Boiler Simulation Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-10

BOILER SIMULATION (WATER/AIR) ADD-ON (WITH AIR ADD-ON) HART, MODEL 3531-RQTY DESCRIPTION ORDERING NUMBER2

1 Pumping Unit (Add-on) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46904-B01 Differential-Pressure Transmitter (HART, Low Range) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46921-001 AC Drive (Ethernet) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46975-A01 Boiler Simulation Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-001 Boiler Simulation Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-10

BOILER SIMULATION (WATER/AIR) ADD-ON (WITH AIR ADD-ON) FOUNDATION FIELDBUS, MODEL 3531-SQTY DESCRIPTION ORDERING NUMBER2

1 Pumping Unit (Add-on) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46904-B01 Differential-Pressure Transmitter (FOUNDATION Fieldbus, Low Range) . . . . . . . . . . . . . . . . . . . . 46921-A01 AC Drive (Ethernet) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46975-A01 Boiler Simulation Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-001 Boiler Simulation Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-10


4 This model needs a controller Model 3539-XX to be fully functional.

16

LIST OF EQUIPMENT PRESSURE/FLOW/LEVEL BASIC SYSTEM 3531-A or -B (contd)PRESSURE/FLOW AIR PROCESS ADD-ON, MODEL 3533-A


1 Air Tank (Large) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46906-001 Air Tank (Small) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46906-A01 Muffler Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46907-001 Orifice Plate (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46914-001 Rotameter (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46915-001 Solenoid Valve (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46951-A01 Pneumatic Control Valve (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46953-001 Instrumentation Mounting Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46990-001 Piping and Accessories (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46993-B01 Familiarization with the Instrumentation and Process Control System - Air User Guide . . . . . . . 85987-E01 Measurement - Air Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85988-001 Measurement - Air Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85988-101 Process Control - Air Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85989-001 Process Control - Air Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85989-10

LIST OF EQUIPMENT TEMPERATURE BASIC SYSTEM 3531-0 or -1TEMPERATURE PROCESS HART, MODEL 3531-04


1 Emergency Switch Station . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5926-A01 Process Workstation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46801-E01 Instrumentation Workstation with Heating/Cooling Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46900-D01 Brazed Plate Heat Exchanger . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46905-001 J-Type Thermocouple . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46916-001 Platinum RTD 100 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46917-001 Temperature Transmitter (HART) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46940-001 Three-Way Pneumatic Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46955-B01 Electrical Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46970-B01 Pneumatic Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46971-A01 Color Paperless Recorder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46972-002 AC Drive (Ethernet) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46975-C02 AC Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46975-D01 Instrumentation Mounting Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46990-001 Process Supports Temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46991-D01 Drip Tray (Front) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46992-B01 Drip Tray (Back) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46992-C01 Piping and Accessories Temperature Basic System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46993-C01 Electrical Distribution Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46997-001 Familiarization with the Instrumentation and Process Control System - Temperature User Guide 86008-E01 Measurement - Temperature Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86009-001 Measurement - Temperature Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86009-101 Process Control - Temperature Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86010-001 Process Control - Temperature Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86010-10

5 This model needs a PLC controller Model 3539-XX and the FOUNDATION Fieldbus PLC add-on (3539-9) to be fully functional.

17

LIST OF EQUIPMENT TEMPERATURE BASIC SYSTEM 3531-0 or -1 (cont'd)TEMPERATURE PROCESS FOUNDATION FIELDBUS, MODEL 3531-15


1 Emergency Switch Station . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5926-A01 Process Workstation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46801-E01 Instrumentation Workstation with Heating/Cooling Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46900-D01 Brazed Plate Heat Exchanger . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46905-001 J-Type Thermocouple . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46916-001 Platinum RTD 100 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46917-001 Temperature Transmitter (FOUNDATION Fieldbus) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46940-A01 Three-Way Pneumatic Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46955-B01 Electrical Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46970-B01 Pneumatic Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46971-A01 Color Paperless Recorder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46972-002 AC Drive (Ethernet) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46975-C02 AC Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46975-D01 Instrumentation Mounting Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46990-001 Process Supports Temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46991-D01 Drip Tray (Front) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46992-B01 Drip Tray (Back) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46992-C01 Piping and Accessories Temperature Basic System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46993-C01 Electrical Distribution Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46997-001 Familiarization with the Instrumentation and Process Control System - Temperature User Guide 86008-E01 Measurement - Temperature Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86009-001 Measurement - Temperature Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86009-101 Process Control - Temperature Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86010-001 Process Control - Temperature Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86010-10

ADVANCED TEMPERATURE PROCESS ADD-ON HART, MODEL 3531-2QTY DESCRIPTION ORDERING NUMBER2

3 Platinum RTD 100 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46917-001 Electromagnetic Flow Transmitter (HART) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46922-001 Electromagnetic Flow Transmitter (HART, 2nd Transmitter for Advanced Temperature) . . . . . . . . . 46922-101 Energy Manager . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46974-001 Accessories (Temperature, Advanced) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46993-D01 Heat Exchangers and Advanced Temperature Measurement - Temperature Student Manual . . 86011-001 Heat Exchangers and Advanced Temperature Measurement - Temperature Instructor Guide . . 86011-10

ADVANCED TEMPERATURE PROCESS ADD-ON FOUNDATION FIELDBUS, MODEL 3531-3QTY DESCRIPTION ORDERING NUMBER2

3 Platinum RTD 100 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46917-001 Electromagnetic Flow Transmitter (FOUNDATION Fieldbus) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46922-A01 Electromagnetic Flow Transmitter (FOUNDATION Fieldbus, 2nd Transmitter for

Advanced Temperature) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46922-B01 Energy Manager . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46974-001 Accessories (Temperature, Advanced) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46993-D01 Heat Exchangers and Advanced Temperature Measurement - Temperature Student Manual . . 86011-001 Heat Exchangers and Advanced Temperature Measurement - Temperature Instructor Guide . . 86011-10


18

LIST OF EQUIPMENT TEMPERATURE BASIC SYSTEM 3531-0 or -1 (cont'd)PRESSURE/FLOW/LEVEL PROCESS ADD-ON HART, MODEL 3530-F


1 Digital Pressure Gauge (High Range) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46761-B01 Column (Large Diameter) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46901-001 Rotameter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46910-001 Venturi Tube . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46911-001 Differential-Pressure Transmitter (HART, High Range) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46920-001 Differential-Pressure Transmitter (HART, Low Range) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46921-001 Pneumatic Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46950-B01 Solenoid Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46951-001 Process Supports Pressure/Flow/Level Add-on . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46991-E01 Piping and Accessories Pressure/Flow/Level Add-on . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46993-F01 Familiarization with the Instrumentation and Process Control System -


PRESSURE/FLOW/LEVEL PROCESS ADD-ON FOUNDATION FIELDBUS, MODEL 3530-GQTY DESCRIPTION ORDERING NUMBER2

1 Digital Pressure Gauge (High Range) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46761-B01 Column (Large Diameter) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46901-001 Rotameter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46910-001 Venturi Tube . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46911-001 Differential-Pressure Transmitter (FOUNDATION Fieldbus, High Range) . . . . . . . . . . . . . . . . . . . 46920-A01 Differential-Pressure Transmitter (FOUNDATION Fieldbus, Low Range) . . . . . . . . . . . . . . . . . . . . 46921-A01 Pneumatic Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46950-B01 Solenoid Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46951-001 Process Supports Pressure/Flow/Level Add-on . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46991-E01 Piping and Accessories Pressure/Flow/Level Add-on . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46993-F01 Familiarization with the Instrumentation and Process Control System -


PRESSURE/FLOW/LEVEL PROCESS SECOND TEAM ADD-ON TO 3531-0 HART, MODEL 3530-HQTY DESCRIPTION ORDERING NUMBER2

1 Emergency Switch Station . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5926-A01 Digital Pressure Gauge (High Range) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46761-B01 Column (Large Diameter) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46901-001 Rotameter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46910-001 Venturi Tube . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46911-001 Differential-Pressure Transmitter (HART, High Range) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46920-001 Differential-Pressure Transmitter (HART, Low Range) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46921-001 Pneumatic Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46950-B01 Solenoid Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46951-001 Color Paperless Recorder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46972-001 Instrumentation Mounting Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46990-00

19

LIST OF EQUIPMENT TEMPERATURE BASIC SYSTEM 3531-0 or -1 (cont'd)PRESSURE/FLOW/LEVEL PROCESS SECOND TEAM ADD-ON TO 3531-0 HART, MODEL 3530-H (cont'd)


1 Process Supports Pressure/Flow/Level Add-on, 2nd team . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46991-G01 Piping and Accessories (2nd team) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46993-A01 Familiarization with the Instrumentation and Process Control System -


PRESSURE/FLOW/LEVEL PROCESS SECOND TEAM ADD-ON TO 3531-1 FOUNDATION FIELDBUS,MODEL 3530-J


1 Emergency Switch Station . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5926-A01 Digital Pressure Gauge (High Range) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46761-B01 Column (Large Diameter) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46901-001 Rotameter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46910-001 Venturi Tube . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46911-001 Differential-Pressure Transmitter (FOUNDATION Fieldbus, High Range) . . . . . . . . . . . . . . . . . . . 46920-A01 Differential-Pressure Transmitter (FOUNDATION Fieldbus, Low Range) . . . . . . . . . . . . . . . . . . . . 46921-A01 Pneumatic Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46950-B01 Solenoid Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46951-001 Color Paperless Recorder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46972-001 Instrumentation Mounting Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46990-001 Process Supports Pressure/Flow/Level Add-on, 2nd team . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46991-G01 Piping and Accessories (2nd team) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46993-A01 Familiarization with the Instrumentation and Process Control System -


PRESSURE/FLOW/LEVEL ADVANCED PROCESS CONTROL ADD-ON, MODEL 3530-MQTY DESCRIPTION ORDERING NUMBER2

1 Column (Small Diameter) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46902-001 Upper Tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46903-001 Orifice Plate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46912-001 Pneumatic Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46950-B01 Ball Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46952-001 Piping and Accessories (Advanced) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46993-G01 Advanced Process Control - Pressure/Flow/Level Student Manual . . . . . . . . . . . . . . . . . . . . . . . 86007-001 Advanced Process Control - Pressure/Flow/Level Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . 86007-10


20

LIST OF EQUIPMENT TEMPERATURE BASIC SYSTEM 3531-0 or -1 (cont'd)PRESSURE/FLOW/LEVEL ADVANCED PROCESS CONTROL SECOND TEAM ADD-ON, MODEL 3530-N


1 Column (Small Diameter) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46902-001 Orifice Plate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46912-001 Pneumatic Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46950-B01 Ball Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46952-001 Piping and Accessories (Advanced) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46993-G01 Advanced Process Control - Pressure/Flow/Level Student Manual . . . . . . . . . . . . . . . . . . . . . . 86007-001 Advanced Process Control - Pressure/Flow/Level Instructor Guide . . . . . . . . . . . . . . . . . . . . . . 86007-10

BOILER SIMULATION (WATER/AIR) ADD-ON (WITHOUT AIR ADD-ON) HART, MODEL 3531-MQTY DESCRIPTION ORDERING NUMBER2

1 Orifice Plate (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46914-001 Rotameter (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46915-001 Differential-Pressure Transmitter (HART, Low Range) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46921-001 Solenoid Valve (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46951-A01 Pneumatic Control Valve (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46953-001 Boiler Simulation Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-001 Boiler Simulation Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-10

BOILER SIMULATION (WATER/AIR) ADD-ON (WITHOUT AIR ADD-ON) FOUNDATION FIELDBUS, MODEL3531-N


1 Orifice Plate (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46914-001 Rotameter (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46915-001 Differential-Pressure Transmitter (FOUNDATION Fieldbus, Low Range) . . . . . . . . . . . . . . . . . . . . 46921-A01 Solenoid Valve (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46951-A01 Pneumatic Control Valve (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46953-001 Boiler Simulation Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-001 Boiler Simulation Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-10

BOILER SIMULATION (WATER/AIR) ADD-ON (WITH AIR ADD-ON) HART, MODEL 3531-PQTY DESCRIPTION ORDERING NUMBER2

1 Differential-Pressure Transmitter (HART, Low Range) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46921-001 Boiler Simulation Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-001 Boiler Simulation Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-10

BOILER SIMULATION (WATER/AIR) ADD-ON (WITH AIR ADD-ON) FOUNDATION FIELDBUS, MODEL 3531-QQTY DESCRIPTION ORDERING NUMBER2

1 Differential-Pressure Transmitter (FOUNDATION Fieldbus, Low Range) . . . . . . . . . . . . . . . . . . . . 46921-A01 Boiler Simulation Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-001 Boiler Simulation Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85993-10

21

LIST OF EQUIPMENT TEMPERATURE BASIC SYSTEM 3531-0 or -1 (cont'd)PRESSURE/FLOW AIR PROCESS ADD-ON, MODEL 3533-A


1 Air Tank (Large) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46906-001 Air Tank (Small) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46906-A01 Muffler Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46907-001 Orifice Plate (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46914-001 Rotameter (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46915-001 Solenoid Valve (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46951-A01 Pneumatic Control Valve (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46953-001 Instrumentation Mounting Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46990-001 Piping and Accessories (Air) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46993-B01 Familiarization with the Instrumentation and Process Control System - Air User Guide . . . . . . . 85987-E01 Measurement - Air Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85988-001 Measurement - Air Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85988-101 Process Control - Air Student Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85989-001 Process Control - Air Instructor Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85989-10

LIST OF EQUIPMENT CONTROLLERSFOXBORO 762 CONTROLLER BUNDLE, MODEL 3539


1 PID Controller (Foxboro) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46960-001 Foxboro Controller User Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86033-E0

HONEYWELL UDC3500 CONTROLLER BUNDLE, MODEL 3539-1QTY DESCRIPTION ORDERING NUMBER2

1 PID Controller (Honeywell) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46961-001 Honeywell Controller User Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86034-E0

CONTROLLOGIX PLC BUNDLE EDUCATIONAL, MODEL 3539-5QTY DESCRIPTION ORDERING NUMBER1

1 RSLogix 5000 Full Edition . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5935-101 Programmable Logic Controller (ControlLogix) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46965-001 ControlLogix and CompactLogix Programmable Logic Controllers User Guide . . . . . . . . . . . . . . 86030-E0

CONTROLLOGIX PLC BUNDLE COMMERCIAL, MODEL 3539-AQTY DESCRIPTION ORDERING NUMBER2

1 RSLogix 5000 Full Edition (Commercial) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5935-B01 Programmable Logic Controller (ControlLogix) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46965-001 ControlLogix and CompactLogix Programmable Logic Controllers User Guide . . . . . . . . . . . . . . 86030-E0


22

LIST OF EQUIPMENT CONTROLLERS (cont'd)MICROLOGIX PLC BUNDLE EDUCATIONAL, MODEL 3539-7


1 RSLogix Micro . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3245-A01 Communication Cable . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3246-401 Programmable Logic Controller (MicroLogix) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46964-001 MicroLogix1100 Programmable Logic Controller User Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . 86032-E0

MICROLOGIX PLC BUNDLE COMMERCIAL, MODEL 3539-CQTY DESCRIPTION ORDERING NUMBER2

1 RSLogix Micro (Commercial) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3245-B01 Communication Cable . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3246-401 Programmable Logic Controller (MicroLogix) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46964-001 MicroLogix1100 Programmable Logic Controller User Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . 86032-E0

COMPACTLOGIX PLC BUNDLE EDUCATIONAL, MODEL 3539-8QTY DESCRIPTION ORDERING NUMBER2

1 RSLogix 5000 Lite Edition . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5935-001 Programmable Logic Controller (CompactLogix) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46966-001 ControlLogix and CompactLogix Programmable Logic Controllers User Guide . . . . . . . . . . . . . . 86030-E0

COMPACTLOGIX PLC BUNDLE COMMERCIAL, MODEL 3539-DQTY DESCRIPTION ORDERING NUMBER2

1 RSLogix 5000 Lite Edition (Commercial) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5935-A01 Programmable Logic Controller (CompactLogix) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46966-001 ControlLogix and CompactLogix Programmable Logic Controllers User Guide . . . . . . . . . . . . . . 86030-E0

FOUNDATION FIELDBUS PLC ADD-ON, MODEL 3539-9QTY DESCRIPTION ORDERING NUMBER2

1 FOUNDATION Fieldbus Junction Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46978-A01 FOUNDATION Fieldbus Bridge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46979-101 FOUNDATION Fieldbus Networking User Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89454-E0

OPTIONAL EQUIPMENTPROCESS OPTIONS PRESSURE

DESCRIPTION ORDERING NUMBER2

Digital Pressure Gauge (Low Range) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46761-C0Pressure Switch with Analog Output . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46926-00Pressure Transmitter (HART) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46928-00Pressure Transmitter (FOUNDATION Fieldbus) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46928-A0

23

OPTIONAL EQUIPMENT (cont'd)PROCESS OPTIONS FLOW

DESCRIPTION ORDERING NUMBER2

Orifice Plate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46912-00Pitot Tube . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46913-00Electromagnetic Flow Transmitter (HART) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46922-00Electromagnetic Flow Transmitter (HART, 2nd Transmitter for Advanced Temperature) . . . . . . . . . . . . . . . 46922-10Electromagnetic Flow Transmitter (FOUNDATION Fieldbus) . . . . . . . . . . . . . . . . . . . . . . . .

Date post:	25-Nov-2015
Category:	Documents
Upload:	bismark-boateng
View:	223 times
Download:	56 times

INSTRUMENTATION AND PROCESS CONTROL TRAINING SYSTEM SERIES 3531

Documents