I
I
FEATURES
62 SAE net hp, diesel or gasoline (65.9 DIN-PS)
Choice of 3 masts to 28 ft. (8.53 m) liftingheight
Lifting capacity to 5000 lb. (2268 kg)or 6000 lb. (2722 kg)
Bolt-on counterweights; total weight dependson mast
Mast tilts forward 19 degrees and rearward9 degrees
Overhead guard
Hydrostatic power steering
Differential lock
Hydraulically actuated reversing transmission;8 speeds forward, 8 reverse
Vandal protection
ADD VERSATILITY WITH*:Swingboom Hydraulic bucketDozer blade Log clampsRotator Concrete block tinesHose reel
"Available from Harlo Products Corporation, Grandville,Mich. (rotator and hose reel available from Cascade Cor-poration, Portland, Ore.)
ENGINE PERFORMANCE
I-U.ciJ...JW::>0a:0l-I-WZ
160
150
140
130
TORQUE+-t--I @"WJ:3:>-...J'=-a:w3:0D..Wena:0J:I-WZ
~ HORSEPOWER
70
60
50
40
30
a:J:cLJ:enen
l'...JW::>u.
.45
.40
.35FUEL CON'SUMPTION+-
1500 19001100 2300
ENGINE SPEED-RPM
FORKLIFT SPECIFICATIONS
Hydraulic System: Open-centerControl 3-leverPump. . . . . . Gear, 23 gpm (87 I/min) @ 2500engine rpmPressure. .2000 psi (137.9 bar) (140.6 kg/ cm2)Oil lines . . . . . .Seamless steel tubing; double-wire-braid hoseFilter. . . . .33-micron paper cartridge in return
JD480-BFORKLIFT i I
I
\~19°1\\ \1\\ \
r7
90 -.{:'I"I JI,I JJ I, ,, ,, I
I,"""J I: I, I", I, ,
I J
/Q"I ,I J!CJ
I II IJ JI II 'I JI !II,. I
-r~E~
E~ECO) '1'LO~C\IcO ...f~c~
;:::(0;:::co"':"<tC\I-""
Nf\\ II I
\ I
IC)\ \I II I\ I\ I1\I \\ I\I\
\ IIII\
E~ELOE....CO) ..... C\I .~CO)~
.r--: .c~c
co;:::m"':"<t"':
;C\I~CO) ....
~EEEI'LO(O~~(OC\IC\I
~~:;::::mcoC\I . .
::::::::mm
~
49
JD480-B FORKLIFT SPECIFICATIONS
(Specifications and design subject to change without notice. Wherever applicable, specifications are in accordance with ICED and SAE Standards. Except whereotherwise noted, these specifications are based on a unit equipped with 16.9-24 drive tires, 11L-15 steering tires, pallet fork, diesel engine and standard equip-ment)
Power (@ 2500 engine rpm): Gasoline and DieselSAE DIN
Gross 66hp(49.2kW*)Net 62 hp (46.2 kW) 65.9 PS
Net engine flywheel power is for an engine equipped with fan, air cleaner,water pump, lubricating oil pump, fuel pump, alternator, and muffler. Grossengine power is without fan. Flywheelpower ratings are under SAEstandardconditions of 500-11.altitude and 85° F. temperature and DIN 70020 standardconditions of 760 mm Hg barometer (sea level) and 20° C. temperature.*In the International System of Units (SI), power is expressed in kilowatts(kW).
Engine: John Deere 4-cylinder valve-in-head, 4-stroke cycle
Gasoline Diesel
Bore and stroke. . . . . . . . . . . . 4.02x4.33 in.(102x110 mm)
.. 219 cu. in.(3588 cm3)
Compression ratio 7.5 to 1 16.2 to 1Maximum torque @ 1,300 rpm 160 Ib-ft (217 Nm) (22.1 kg-m)NACC or AMA (U.S. Tax)horsepower """"""'" 25.65
Mainbearings 3 5Lubrication. . . . . . . . . . . . . . Pressure system wi full-flow filterCooling. . . . . . . . Pressurized w/thermostat and fixed bypassFan SuctionAir cleaner " DryElectrical system .12-volt wi alternatorBattery (12 volt) .Reserve capacity: 110 minutes
Engine Disconnect Clutch. . . . . . Hand-operated, single 10-in.(254mm) plate
Transmission. .8-speed transmission w/hydraulically-actuatedno-clutch direction reverser. "Inching" pedal is provided.
Gear: Travel Speeds:mph
Rev.1.42.03.04.15.47.8
11.616.1
Piston displacement........
12345678
Fwd.1.62.33.54.86.39.0
13.518.7
Fwd.2.63.75.67.7
10.114.521.730.1
km/hRev.
2.33.24.86.68.7
12.618.725.9
Final Drives Inboard, planetary
Brakes. . . . . .Hydraulically actuated, wet-disk. Foot-operatedindividually or simultaneously.
Steering Power (hydrostatic)Turning radius (brake applied wlo fork) . .10 fl. 10 in. (3.30 m)Turning clearance (brake applied wi 0 fork) .22 fl. 6 in. (6.86 m)Wheel rotation, max. left to max. right. . . . . . . . . . . . . .3 turns
Steering7.50/8.00-16, 10-ply-rating, F3
11L-15, 8-ply-rating, F3
Tires: Drive21L-24, 8-ply-rating, R416.9-24, 8-ply-rating, R419.5L-24, 8-ply-rating, R4
low profile, tubeless
Wheel Tread (front and rear) 62 in. (1.58 m)Dimensions:Overall width 6fl. 7in.(2.01 m)Ground clearance, min. 1 fl. 2 in. (356 mm)Reach from center line of drive wheels to front
or fork carriage 2fI.10in.(864mm)
Capacities: U.S. LitersCooling system 3 gal. 11.4Fueltank 19.5gal. 73.8Engine lubrication,includingfilter. . . . . . . . .. 1.5gal. 5.7Hydraulic system 12.5gal. 47.3
Additional Standard Equipment:Electric hourmeterVertical muffler wi rain capEther starting aid (diesel)Overhead guardHand throttleFoot throttleDifferential lockFendersFuel filterKey switch safety startAntifreezeFuel gaugeOil pressure indicator lightAlternator charge indicator lightWater temperature gaugeAppropriate counterweightLightsTransistorized voltage regulatorHornAir cleaner restriction indicator
SAE Operating Weight (w/required counterweights):Gasoline Diesel
14 fl., 6000-lb.capacity. . . . . . .10,870 lb. (4931 kg)
21 ft. 6 in. 5000-lb.capacity. . . . . . . 10,735 lb. (4869 kg)
28 fl., 5000-lb.capacity 11,580Ib.(5252kg)
Shipping Weight:Two 4-fl. (1.22 m) 5000-lb.
(2268 kg) pallet tines 350Ib.(159kg)Two 4-fl. (1.22 m), 6000-lb.
(2722 kg) pallet tines 425Ib.(193kg)
10,980 lb. (4980 kg)
10,845 lb. (4919 kg)
11,690 lb. (5303 kg)
*Measured at 24 in. (610 mm) from heel of fork with load centered
Special Equipment:Engine coolant heaterMuffler extension
50
Vandal protection
1
Operating Maximum Lifting HeightInformation 14 ft. (4.27 m) 21 ft. 6 in. (6.55 m) 28 ft. (8.53 m)
Max. lift capacity*6000 lb. 5000 lb. 5000 lb.
(2722 kg) (2268 kg) (2268 kg)
Lift capacity at full height*6000 lb. 2500 lb. 1000 lb.
(2722 kg) (1134 kg) (454 kg)
Side-shift. . . .3 in. (76 mm)to right and left of center No Yes No
Rate of lift @ 2500 57 fpm 83 fpm 83 fpmengine rpm (max. load) (17.4 m/min) (25.3 m/min) (25.3 m/min)
Rate of lift @ 2500 61 fpm 95 fpm 95 fpmengine rpm (empty) (18.6 m/min) (29.0 m/min) (29.0 m/min)
Rate of drop (max. load) 29 fpm 54 fpm 54 fpm(8.8 m/min) (16.5 m/min) (16.5 m/min)
Rate of drop (empty) 33 fpm 68 fpm 68 fpm(10.1 m/min) (20.7 m/min) (20.7 m/min)