LTI’s 2012 SummaryLTI NO. DATE Company INJURY DIR LTI NO. DATE Company INJURY DIRLTI # 01 0 7/01/2012 Dalma Energy Broken Arm UWD LTI # 18 02/07/2012 Dalma Energy Broken Finger UWD
LTI # 02 07/01/2012 Abraj Energy Broken Thigh OSD LTI # 19 05/07/2012 Weatherford 2nd Degree Burns UWD
LTI # 03 20/01/2012 Dalma Energy Finger Injury UWD LTI # 20 05/07/2012 KCA Deutag Broken Finger UWD
LTI # 04 0 8/02/2012 Dalma Energy Broken Finger UWD LTI # 21 06/07/2012 Baker Hughes Broken Foot UWD
LTI # 05 02/02/2012 MBPS Finger Injury UWD LTI # 22 17/07/2012 Al Katheery Broken Leg OND
LTI # 06 13/02/2012 OTO Back Injuries UWD LTI # 23 02/08/2012 GPS Metal Penetrated Abdomen OSD
LTI # 07 14/02/2012 MBPS Broken Wrist UWD LTI # 24 13/08/2012 Al Turki Knee Injury OSD
LTI # 08 16/03/2012 MBPS Broken Arm UWD LTI # 25 16/08/2012 KCA Deutag Finger and Thumb UWD
LTI # 09 20/03/2012 Al-Hassan Fatal GD LTI# 26 02/09/2012 Sanna Desert Broken Jaw UWD
LTI # 10 29/03/2012 ATE Broken Leg OSD LTI# 27 05/09/2012 Sea & Land Finger Amputation UWD
LTI # 11 02/04/2012 Dalma Energy Broken Jaw UWD LTI# 28 09/09/2012 PDO Broken Wrist GD
LTI # 12 0 3/04/2012 Sea and Land Broken Skull UWD LTI# 29 17/09/2012 PDO Finger Injury OND
LTI # 13 11/04/2012 Hamoud Al Rashdi LLC Broken Leg OSD LTI# 30 20/09/2012 ATE Fatal OSD
LTI # 14 04/05/2012 Fahud Oil Field Services Broken Thumb UWD LTI# 31 20/09/2012 STST Broken Arm OND
LTI # 15 13/05/2012 KCA Deutag Broken Thumb UWD LTI# 32 04/08/2012 AlKatheery Broken Leg OND
LTI # 16 09/05/2012 Abraj Energy Srvs LLC Finger Injury OSD
LTI # 17 25/06/2012 Shaleem Petroleum Broken Foot UWD
RTA
RTA
RTA
RTA
For enquiries and or comments on these slides, please Contact; Adel al Musalmy on 24673380
RTA
LTI Notification 7th January
LTI No 01
2012
WHAT HAPPENED:Dalma Energy Assistant Driller broke his upper arm while climbing up the cellar pit. His right foot slipped causing his hand to get trapped on the rung.
RESULTS:• Broken upper arm.• 42 Work Days Lost.
Accident Location: Rig 1 at Nimr
IP slipped while climbing up the cellar pit. He was wearing safety boots. Lighting was adequate
Back to Main Page
LTI Notification 7th January
LTI No 02
2012
WHAT HAPPENED:Abraj Energy, Ofsat contractor, working for Petrogas Rima driver with Operator was travelling to Nimr from Rima (Abraj Rig 101) when their vehicle hit a camel at about 2200 hours. The operator broke his thigh bone. The driver escaped with only first aid injuries.
RESULTS:• Broken upper leg.• 42 Work Days Lost.
Accident Location: 3KM towards Nimr R/A
RTA
Back to Main Page
LTI Notification 20th January
LTI No 03
2012
WHAT HAPPENED:Dalma Enargy Junior Mechanic was raising a mud boat using hydraulic jacks. While he was pushing the mechanical support into position his finger got trapped between the two surfaces causing crash finger tip injuries, which was later amputated at Salalah Hospital.
RESULTS:• Finger Injury.• 28 Work Days Lost.
Accident Location: Rig-46 - Nimr 873
Back to Main Page
LTI Notification 8th February
LTI No 04
2012
WHAT HAPPENED:Dalma Energy Floorman was guiding the Cavins air operated slips using a winch towards the rotary table on the rig floor in preparing for commencement of POOH (Pool Out Of Hole). He broke his finger when it got trapped between the Farr tong beam and the Calvin slips.
RESULTS:• Broken Finger.• 21 Work Days Lost.
Accident Location: Rig-1 - Nimr 878
Farr Tong Beam
Calvin Slips
Back to Main Page
LTI Notification 2th February
LTI No 05
2012
WHAT HAPPENED:MBPS Derrick man was helping the installation of the escape line pole in the monkey board of the hoist. His finger got caught between the pin and the steel floor edge causing crush injury.
RESULTS:• Finger Injury.• 14 Work Days Lost.
Accident Location: Hoist 31 - Lekhwair
Back to Main Page
LTI Notification 13th February
LTI No 06
2012
WHAT HAPPENED:OTO driver, working under the Bahwan DHL contract was transporting pipes from Muscat to Haima. Injured his back At the Nizwa – Imty junction (23:30) when his vehicle left the road and travelled approximately 40 meters where it struck the compound wall of a residence.
RESULTS:• Back Injury.• 42 Work Days Lost.
Accident Location: Hoist 31 – Nizwa Imty Junction
RTA
Back to Main Page
LTI Notification 14th March
LTI No 07
2012
WHAT HAPPENED:MB Petroleum Wire-line Assistant was alighting from the Wire-line unit via a set of steps when he lost his footing on the second step from the top and fell forward onto the ground and broke his wrist.
RESULTS:• Broken Wrist.• 28 Work Days Lost.
Accident Location: Wireline Unit (L662) - Lekhwair
Back to Main Page
LTI Notification 16th March
LTI No 08
2012
WHAT HAPPENED:MB Petroleum Floorman was bleeding down pressure from the well through a back pressure manifold when a piece of tubing used as a bleed down line swung and struck his arm due to incorrectly secured. He suffered a double fractures, abrasions and puncture wounds to his arm.
RESULTS:• Broken and wound punctured Arm.• 28 Work Days Lost.
Accident Location: Hoist 4 – Well Ufuq 13 Lekhwair
Back to Main Page
Fatal LTI Notification 20th March
LTI No 09
2012
WHAT HAPPENED:On Tuesday the 20th March at approximately 17:20 hrs, a lorry belonging to Al-Hassan Engineering Company working as a Subcontractor of Petrofac E&C Oman LLC on the PDO Kauther Depletion Compression Project was parked close to the Kauther Gas Plant fence whilst it was being loaded with scaffolding which required removal from site. After loading was complete the driver began to reverse the lorry when seconds later he felt an impact. He stopped the vehicle to investigate and realized that he had struck and severely injured a pedestrian who was declared dead on arrival at Adam Hospital.
To Allah We belong, and to Him is our return: - : راجعون إليه وإنا لله إنا RESULT: Fatality.
Accident Location: PDO Kauther Depletion Compression Project.
RTA
Back to Main Page
LTI Notification 29th March
LTI No 10
2012
WHAT HAPPENED:ATE civil helper broke his leg while aligning a new welded flow line on sleepers. It unexpectedly rolled back from the sleeper and hit his leg.
RESULTS:• Broken Leg.• 42 Work Days Lost.
Accident Location: Sadad 1 Well in Bahja.
Back to Main Page
LTI Notification 2nd April
LTI No 11
2012
WHAT HAPPENED:Dalma Energy Floorman was standing on the rig floor cover plate slipping drilling lines. The plate moved causing him to fall into the bottom box beam. He broke his jaw bone.
RESULTS:• Broken Jaw.• 42 Work Days Lost.
Accident Location: Rig 58 Hazar 13, Bahja
Back to Main Page
LTI Notification 3rd April
LTI No 12
2012
WHAT HAPPENED:Sea and Land Chief Mechanic was checking and recharging the Mud Pump pulsation dampener when he lost his balance and fell. He stroke his head on the pumps discharge line and broke his skull.
RESULTS:• Broken Skull and internal bleeding.• 28 Work Days Lost.
Accident Location: Rig 79 Fahud
Back to Main Page
LTI Notification 11th April
LTI No 13
2012
WHAT HAPPENED:Hamood Al Rashidi LLC helper, subcontractor of Amran Est subcontracted to ATE was in the process of loading the casing pipes using the hiab crane. He was standing between the bundles of pipes waiting to hoop up the lifting belts when the pipe bundle slipped and hit and broke his leg.
RESULTS:• Broken Leg.• 42 Work Days Lost.
Accident Location: ATE Marmul Material Yard
Back to Main Page
LTI Notification 4th May
LTI No 14
2012
WHAT HAPPENED:Trainee Operator working for Fahud Oilfield Services (Well Test Unit-8) was walking near brine/water tanks at shift change when he tripped over a flexible hose and fell to the ground. He broke his thumb.
RESULTS:• Broken Thumb.• 42 Work Days Lost.
Accident Location: Saih Nihaida WT-8
Back to Main Page
LTI Notification 13th May
LTI No 15
2012
WHAT HAPPENED:
KCA Deutag Floorman was rigging down the substructure beams. His broke his thumb when it got trapped between the beam and the edge of the cement pad ditch.
RESULTS:• Broken Thumb.• 14 Work Days Lost.
Accident Location: Rig 77 - Burhan
Back to Main Page
Pinch point
LTI Notification 9th May
LTI No 16
2012
WHAT HAPPENED:Floorman working for Abraj Energy Services LLC, a subcontractor of Petrogas was running in drill collars when he pushed the tongs towards the drill collar without holding them by the handles. The jaw made contact with the drill collars and bounced backwards pinching his finger.
RESULTS:• Broken Finger.• 14 Work Days Lost.
Accident Location: Rig 101 -Rima for Abraj Energy Srvs LLC
Back to Main Page
Pinch point which crushed finger
Handle which should have been used
LTI Notification 25th June
LTI No 17
2012
WHAT HAPPENED:A Shaleem Petroleum Trainee Roustabout was lifting the pump barrel from the catwalk to pump shop using a forklift. While trying to pull the pump barrel inside the container, the load rolled and dropped on his foot.
RESULTS:• Broken Foot.• 56 Work Days Lost.
Accident Location: Al Burj in Nimr
Back to Main Page
LTI Notification 2nd July
LTI No 18
2012
WHAT HAPPENED:Dalma Energy Mechanic and Derricman were adjusting the vertical position of the stabbing board in the derrick when the cable connecting the stabbing board and counter weight came off the pulley. The air winch was used to put back the pulley. The counterweight dropped and hit the derricman’s hand breaking his finger.
RESULTS:• Broken Finger.• 42 Work Days Lost.
Accident Location: Rig59 - Haban
Back to Main Page
LTI Notification 5th July
LTI No 19
2012
WHAT HAPPENED:A Weatherford Crane Operator was working on a crane when he heard a strange sound coming from the engine. On investigating, he opened the radiator cap. He got 2nd degree burns when hot water splashed on his hand, forearm and neck.
RESULTS:• 2nd Degree Burns.• Several Weeks Lost.
Accident Location: Rig 4 – Anzouz – In Bahja Area
Back to Main Page
LTI Notification 5th July
LTI No 20
2012
WHAT HAPPENED:A KCA Deutag Roustabout was helping the floorman to raise an extension ladder. He broke his finger when it got trapped between the stopper on the ladder and the rung.
RESULTS:• Broken Finger• 10 Work Days Lost.
Accident Location: Rig 92 – Fakhr Area
Back to Main Page
Pinch point caused by stopper on the upper section of the ladder
LTI Notification 6th July
LTI No 21
2012
WHAT HAPPENED:A Baker Hughes Artificial Lift Technician was checking the motor serial numbers and moving them from an old storage rack to a new steel support rack. He broke his foot when the motor slid off the rack and fell onto his foot.
RESULTS:• Broken Foot• 42 Work Days Lost.
Accident Location: Baker Hughes – Qarn Alam Yard
Back to Main Page
Motor rolled and slid off the side of the rackOld rack the motors were resting on
LTI Notification 17th July
LTI No 22
2012
WHAT HAPPENED:A Driver’s Helper working for Al Katheery broke his leg when the sewage vacuum tanker he was travelling in was involved in a rollover incident. The tanker was travelling to Kholoud transporting sewage from Rig-78.
RESULTS:• Broken Leg• 42 Work Days Lost.
Accident Location: Kholoud - Fahud
Back to Main Page
RTA
LTI Notification 2nd August
LTI No 23
2012
WHAT HAPPENED:Two Gulf Petroleum Services (GPS), plant mechanics were replacing the old teeth of an excavator bucket with a new one. During replacement, one worker was hammering on the old teeth for removal while his co-worker (IP) was standing approximately 1.5 meter away. A piece of small metal from the old teeth flew off and penetrated into the IP’s abdomen, resulting in a bleeding wound.
RESULTS:• Metal Penetration into
abdomen• 14 Work Days Lost.
Accident Location: Polymer Projects Site - Nimr
Back to Main Page
LTI Notification 13th August
LTI No 24
2012
WHAT HAPPENED:Al Turki Pipeline Technician twisted his knee when he fell on the pipeline as the crew were doing pigging job. The pig got stuck. They started banging the pig to get it released. As it was released it jerked and produced a loud noise causing the IP to tip over.
RESULTS:• Twisted Knee• 28 Work Days Lost.
Accident Location: Pipeline Pigging- Marmul
Back to Main Page
Knee injured when falling over piping
LTI Notification 16th August
LTI No 25
2012
WHAT HAPPENED:KCA Deutag Floor man crushed his thumb and finger when his hand was trapped between the chain and block while the rig crew were laying down the top drive.
RESULTS:• Finger and Thumb• 28 Work Days Lost.
Accident Location: Rig 78 KCA Deutag - Rabiha Fahud
Back to Main Page
Pinch point causing the injury
LTI Notification 2nd September
LTI No 26
2012
WHAT HAPPENED:
Sanna Desert in Fahud. crew were in the casing yard re-arranging casing pipes on a storage rack to prepare them for a forklift to transfer them over to an inspection rack. There were two pipes remaining on the second level of casings which were resting on wooden dunnage (wooden beams) to separate them from the level below. As the team manually rolled the pipes along the dunnage and the second pipe approached one end, the other end flipped into the air and struck the IP, fracturing his jaw.
RESULTS:• Broken Jaw• 14 Work Days Lost.
Accident Location: Casing Yard - Fahud
Back to Main Page
LTI Notification 5th September
LTI No 27
2012
WHAT HAPPENED:Sea and Land Assistant Driller placed the air operated slip assembly in the bowl of the spider for inspection. The latching device holding the slips was not latched in position. He was closing the door of the spider with his left hand, when the latching device dropped down on to the bowl of the spider and trapped his right hand fingers between the latching device and top of the bowl crushing the ring finger tip.
RESULTS:• Finger Tip Amputation• 5 Work Days Lost.
Accident Location: Rig 7 - Marmul
Back to Main Page
LTI Notification 9th September
LTI No 28
2012
WHAT HAPPENED:PDO Rotating Equipment Engineer broke his wrist when he fell back off a platform whilst on a visit to the Saih Nihayda project for Pre-Start Up Audit.
RESULTS:• Broken Wrist• 21 Work Days Lost.
Accident Location: Saih Nihayda
Back to Main Page
30cm
LTI Notification 17th September
LTI No 29
2012
WHAT HAPPENED:PDO Electrical Technician (IP) was carrying out repair works for an HV Circuit Breaker (CB) in the workshop. He injured his finger when it was trapped between the rotating shaft and the CB body causing.
RESULTS:• Finger Injuries• 28 Work Days Lost.
Accident Location: PDO Electrical Workshop - Fahud
Back to Main Page
LTI Notification 20th September
LTI No 30
2012
WHAT HAPPENED:ATE (Al Turki) mechanical crew were using a 25 ton crane to lift pipe sleeves. During the lifting operation, the deceased went to fetch slings from the crane’s tool box located above the cranes battery. The contents of the box could not be accessed from ground level so he stood on the outrigger to reached over. He placed himself in the arc path taken by the cranes counter weight which rotated and crushed him against the toolbox. He immediately fell unconscious and was taken to STS camp clinic in Amal where he was given CPR but could not revived, thus pronounced dead.
To Allah We belong, and to Him is our return: - : راجعون إليه وإنا لله إنا
RESULTS: Fatality
Accident Location: Fatality at Amin Steam Pilot Project – Nimr Area
Back to Main Page
LTI Notification 20th September
LTI No 31
2012
WHAT HAPPENED:STST employee broke his arm while working near to the main line pumping station when he felt dizziness. He lost his balance and fell into a trench landing on his hand.
RESULTS:• Broken Arm• 28 Work Days Lost.
Accident Location: Main Pumping Station - Fahud
Back to Main Page
0.7m trench
LTI Notification 20th August
LTI No 32
2012
WHAT HAPPENED:
Al Katheery skip Truck driver broke his leg when his truck collided with a military light vehicle. Three army personnel were killed and two of their personnel had Lost Time Injuries in this incident.
RESULTS: PDO• Broken Leg• 14 Work Days Lost.
Accident Location: Dhulaima – Malan Road - Lekhwair
Back to Main Page
RTA
RESULTS: Non PDO Work Related:
• 03 Non Work Related Fatalities
• 02 None Work Related Injuries