Prepared For: Presented By:MWF - # 8637-02 MODEL 4400 SERIESSTOCKScott Schneekloth901 Commerce Rd.Luverne, MN 56156-2265(507)283 - 9141
NORTH CENTRAL INTLRobin Kunz
4511 NORTH CLIFFSIOUX FALLS SD 57104
605-336-3820
Thank you for the opportunity to provide you with the following quotation on a new International truck. I am sure the following detailed specification will meet your operational requirements, and I look forward to serving your business needs.
Model Profile2013 4400 SBA 4X2 (MA035)
APPLICATION: Tank (Emergency)MISSION: Requested GVWR: 40000. Calc. GVWR: 40000
Calc. Start / Grade Ability: 27.90% / 2.75% @ 55 MPHCalc. Geared Speed: 65.0 MPH
FUEL ECONOMY: 6.81 MPG @ 55 MPHDIMENSION: Wheelbase: 217.00, CA: 149.90, Axle to Frame: 75.00ENGINE, DIESEL: {MaxxForce DT} EPA 10, 300 HP @ 2200 RPM, 860 lb-ft Torque @ 1300 RPM,
2400 RPM Governed SpeedTRANSMISSION,AUTOMATIC:
{Allison 3000EVS_P} 4th Generation Controls; Close Ratio, 5-Speed; WithOverdrive, Includes Oil Level Sensor, With Provision for PTO, Less Retarder,Max. GVW N/A
CLUTCH: Omit Item (Clutch & Control)AXLE, FRONT NON-DRIVING: {Meritor MFS-14-143A} Wide Track, I-Beam Type, 14,000-lb CapacityAXLE, REAR, SINGLE: {Dana Spicer S26-190} Single Reduction, 26,000-lb Capacity, R Wheel Ends
Gear Ratio: 6.14CAB: ConventionalTIRE, FRONT: (2) 12R22.5 G661 HSA (GOODYEAR) 484 rev/mile, load range H, 16 plyTIRE, REAR: (4) 12R22.5 G282 MSD (GOODYEAR) 481 rev/mile, load range H, 16 plySUSPENSION, RR, SPRING,SINGLE:
Vari-Rate; 31,000-lb Capacity, With 4500 lb Auxiliary Rubber Spring
PAINT: Cab schematic 100GALocation 1: 2304, Red (Prem)
Chassis schematic N/A
May 07, 2012
1 Proposal: 8637-02
Code DescriptionMA03500 Base Chassis, Model 4400 SBA 4X2 with 217.00 Wheelbase, 149.90 CA, and 75.00 Axle
to Frame.
1570 TOW HOOK, FRONT (2) Frame Mounted
1CAG FRAME RAILS Heat Treated Alloy Steel (120,000 PSI Yield); 10.250" x 3.610" x0.375" (260.4mm x 91.7mm x 9.5mm); 456.0" (11582mm) Maximum OAL
1LNN BUMPER, FRONT Full Width, Aerodynamic, Chrome Plated Steel; 0.142" MaterialThickness
1WEJ WHEELBASE RANGE 199" (505cm) Through and Including 254" (645cm)
2ARV AXLE, FRONT NON-DRIVING {Meritor MFS-14-143A} Wide Track, I-Beam Type, 14,000-lb Capacity
Notes: The following features should be considered when calculating Front GAWR: Front Axles;Front Suspension; Brake System; Brakes, Front Air Cam; Wheels; Tires.
3ADD SUSPENSION, FRONT, SPRING Parabolic, Taper Leaf; 14,000-lb Capacity; With ShockAbsorbers
Includes: SPRING PINS Rubber Bushings, Maintenance-Free
Notes: The following features should be considered when calculating Front GAWR: Front Axles;Front Suspension; Brake System; Brakes, Front Air Cam; Wheels; Tires.
4091 BRAKE SYSTEM, AIR Dual System for Straight Truck Applications
Includes: BRAKE LINES Color and Size Coded Nylon: DRAIN VALVE Twist-Type: GAUGE, AIR PRESSURE (2) Air 1 and Air 2 Gauges; Located in Instrument Cluster: PARKING BRAKE CONTROL Yellow Knob, Located on Instrument Panel: PARKING BRAKE VALVE For Truck: QUICK RELEASE VALVE Bendix On Rear Axle for Spring Brake Release: 1 for 4x2, 2for 6x4: SLACK ADJUSTERS, FRONT Automatic: SLACK ADJUSTERS, REAR Automatic: SPRING BRAKE MODULATOR VALVE R-7 for 4x2, SR-7 with relay valve for 6x4
Notes: Front and Rear Dust Shields not Included: Rear Axle is Limited to 19,000-lb GAWR with Code 04091 BRAKE SYSTEM, AIR andCode 04NCL BRAKES, REAR, AIR CAM Regardless of Axle/Suspension Ordered.: Rear Axle is Limited to 20,000-lb GAWR with Code 04091 BRAKE SYSTEM, AIR andCode 04NCG BRAKES, REAR, AIR CAM Regardless of Axle/Suspension Ordered.: Rear Axle is Limited to 23,000-lb GAWR with Code 04091 BRAKE SYSTEM, AIR andStandard Rear Air Cam Brakes Regardless of Axle/Suspension Ordered.
Vehicle Specifications May 07, 20122013 4400 SBA 4X2 (MA035)
2 Proposal: 8637-02
Code Description4722 DRAIN VALVE {Bendix DV-2} Automatic; With Heater; for Air Tank
Includes: DRAIN VALVE Mounted in Wet Tank
4773 BRAKE SHOES, REAR Cast
Notes: Provides Rear Axle GAWR Up to 26,000-Lb.: The following features should be considered when calculating Rear GAWR: Rear Axles;Rear Suspension; Brake System; Brakes, Rear Air Cam; Brake Shoes, Rear; SpecialRating, GAWR; Wheels; Tires.
4AZA AIR BRAKE ABS {Bendix AntiLock Brake System} Full Vehicle Wheel Control System (4-Channel)
4EBT AIR DRYER {Bendix AD-IP} With Heater
Includes: AIR DRYER LOCATION Inside Left Rail, Back of Cab
4ESX BRAKE CHAMBERS, FRONT AXLE {Haldex} 20 SqIn
4EVL BRAKE CHAMBERS, REAR AXLE {Haldex GC3030LHDHO} 30/30 Spring Brake
Includes: BRAKE CHAMBERS, SPRING (2) Rear Parking; WITH TRUCK BRAKES: All 4x2, 4x4;WITH TRACTOR BRAKES: All 4x2, 4x4; 6x4 & 6x6 with Rear Tandem Axles Less Than46,000-lb. or GVWR Less Than 54,000-lb.
4JCJ BRAKES, FRONT, AIR CAM S-Cam; 16.5" x 5.0"; Includes 20 Sq. In. Long Stroke BrakeChambers
Notes: Front Axle with 14,000-lb GAWR is Limited to 13,200-lb GAWR when used in Conjunctionwith 15" BRAKES, FRONT, AIR CAM.: The following features should be considered when calculating Front GAWR: Front Axles;Front Suspension; Brake System; Brakes, Front Air Cam; Wheels; Tires.
4NDB BRAKES, REAR, AIR CAM S-Cam; 16.5" x 7.0"; Includes 30/30 Sq.In. Long Stroke BrakeChamber and Spring Actuated Parking Brake
Notes: The following features should be considered when calculating Front GAWR: Front Axles;Front Suspension; Brake System; Brakes, Front Air Cam; Wheels; Tires.
4SBC AIR COMPRESSOR {Bendix Tu-Flo 550} 13.2 CFM Capacity
4VBC AIR DRYER LOCATION Mounted To Battery Box, Left side, Under Cab
5710 STEERING COLUMN Tilting and Telescoping
5CAL STEERING WHEEL 2-Spoke, 18" Diam., Black
5PSM STEERING GEAR {Sheppard HD94} Power
Vehicle Specifications May 07, 20122013 4400 SBA 4X2 (MA035)
3 Proposal: 8637-02
Code Description7BDB EXHAUST SYSTEM Single Horizontal, Aftertreatment Device, Frame Mounted Right Side,
Under Cab, Includes Horizontal Tail Pipe
Includes: NOTE: The Horizontal Tailpipe Includes a Temperature Control Device
7SCZ ENGINE EXHAUST BRAKE for MaxxForce I6 Engines, Electronically Activated
7WZX SWITCH, FOR EXHAUST 3 Position, Momentary, Lighted Momentary, ON/CANCEL,Center Stable, INHIBIT REGEN, Mounted in IP Inhibits Diesel Particulate FilterRegeneration When Switch is Moved to ON While Engine is Running, Resets When Ignitionis Turned OFF
8000 ELECTRICAL SYSTEM 12-Volt, Standard Equipment
Includes: BATTERY BOX Steel: DATA LINK CONNECTOR For Vehicle Programming and Diagnostics In Cab: FUSES, ELECTRICAL SAE Blade-Type: HAZARD SWITCH Push On/Push Off, Located on Top of Steering Column Cover: HEADLIGHT DIMMER SWITCH Integral with Turn Signal Lever: HORN, ELECTRIC Single: JUMP START STUD Located on Positive Terminal of Outermost Battery: PARKING LIGHT Integral with Front Turn Signal and Rear Tail Light: STARTER SWITCH Electric, Key Operated: STOP, TURN, TAIL & B/U LIGHTS Dual, Rear, Combination with Reflector: TURN SIGNAL SWITCH Self-Cancelling for Trucks, Manual Cancelling for Tractors, withLane Change Feature: TURN SIGNALS, FRONT Includes Reflectors and Auxiliary Side Turn Signals, Solid StateFlashers; Flush Mounted: WINDSHIELD WIPER SWITCH 2-Speed with Wash and Intermittent Feature (5 Pre-SetDelays), Integral with Turn Signal Lever: WINDSHIELD WIPERS Single Motor, Electric, Cowl Mounted: WIRING, CHASSIS Color Coded and Continuously Numbered
8518 CIGAR LIGHTER Includes Ash Cup
8540 HORN, ELECTRIC (2)
8630 IGNITION SWITCH Keyless
8GWY ALTERNATOR {Leece-Neville 14931PAH} Brush Type, 12 Volt 320 Amp. Capacity, PadMount
8HAB BODY BUILDER WIRING Back of Standard Cab at Left Frame or Under Extended or CrewCab at Left Frame; Includes Sealed Connectors for Tail/Amber Turn/Marker/ Backup/Accessory Power/Ground and Sealed Connector for Stop/Turn
8MKL BATTERY SYSTEM {International} Maintenance-Free, (3) 12-Volt 1950CCA Total
8RJV RADIO {International} AM/FM Stereo With Weatherband, Clock, Auxiliary Input, IncludesMultiple Speakers
Vehicle Specifications May 07, 20122013 4400 SBA 4X2 (MA035)
4 Proposal: 8637-02
Code DescriptionIncludes: SPEAKERS IN CAB (2) Dual-Cone with Deluxe Interior: SPEAKERS IN CAB (4) Coaxial with Premium Interior
8THB BACK-UP ALARM Electric, 102 dBA
8WEE SWITCH, AIR HORN, PASSENGER Fire Truck Application; Momentary Switch Located inInstrument Panel Close to Passenger, Driver Also To Activate Switch at Steering Wheel
8WHE HORN, AIR ACCOMMODATION PACKAGE; less Horn
8WJV BATTERY DISCONNECT SWITCH {Joseph Pollak} for Cab Power Disconnect Switch;Lever Operated, Disconnects Power to PDC, Does Not Disconnect Charging Circuits, CabMounted
8WPB HEADLIGHTS Halogen; Composite Aero Design for Two Light System; Includes DaytimeRunning Lights
8WPH CLEARANCE/MARKER LIGHTS (5) {Truck Lite} Amber LED Lights, Flush Mounted onCab or Sunshade
8WTK STARTING MOTOR {Delco Remy 38MT Type 300} 12 Volt; less Thermal Over-CrankProtection
8WWJ INDICATOR, LOW COOLANT LEVEL With Audible Alarm
8WZP INDICATOR, BATTERY WARNING Green BATTERY ON Indicator, Mounted on Left Sideof Instrument Panel, To be Used with Factory Installed or Customer Mounted BatteryDisconnect Switch
8XAH CIRCUIT BREAKERS Manual-Reset (Main Panel) SAE Type III With Trip Indicators,Replaces All Fuses Except For 5-Amp Fuses
9HAD GRILLE Chrome
9WAY FRONT END Tilting, Fiberglass, With Three Piece Construction
9WBB GRILLE EMBER SCREEN Mounted to Grille to Keep Hot Embers out of Engine Air IntakeSystem
10060 PAINT SCHEMATIC, PT-1 Single Color, Design 100
Includes: PAINT SCHEMATIC ID LETTERS "GA"
10761 PAINT TYPE Base Coat/Clear Coat, 1-2 Tone
10769 PAINT CLASS Premium Color
10WBE KEYS - ALL ALIKE, ID Z-001
11001 CLUTCH Omit Item (Clutch & Control)
12NUT ENGINE, DIESEL {MaxxForce DT} EPA 10, 300 HP @ 2200 RPM, 860 lb-ft Torque @1300 RPM, 2400 RPM Governed Speed
Includes
Vehicle Specifications May 07, 20122013 4400 SBA 4X2 (MA035)
5 Proposal: 8637-02
Code Description: AIR COMPRESSOR AIR SUPPLY LINE Naturally-Aspirated (Air Brake Chassis Only): ANTI-FREEZE Red Shell Rotella Extended Life Coolant; -40 Degrees F/ -40 Degrees C;for MaxxForce Engines: COLD STARTING EQUIPMENT Intake Manifold Electric Grid Heater with Engine ECMControl: CRUISE CONTROL Electronic; Controls Integral to Steering Wheel: ENGINE OIL DRAIN PLUG Magnetic: ENGINE SHUTDOWN Electric, Key Operated: FUEL FILTER Included with Fuel/Water Separator: FUEL/WATER SEPARATOR Fuel/Water Separator and Fuel Filter in a Single Assembly;With Water-in-Fuel Sensor; Engine Mounted: GOVERNOR Electronic: OIL FILTER, ENGINE Spin-On Type: WET TYPE CYLINDER SLEEVES
Notes: Recommend Code 12THT when using front mount obstructions (winches, cones, reels,etc.) that restrict air flow through the radiator.
12THT FAN DRIVE {Horton Drivemaster} Direct Drive Type, Two Speed With Residual TorqueDevice for Disengaged Fan Speed
Includes: FAN Nylon
Notes: Recommend Code 12THT when using front mount obstructions (winches, cones, reels,etc.) that restrict air flow through the radiator.
12UAU RADIATOR Aluminum; 2-Row, Cross Flow, Over Under System, 1045 SqIn Louvered, with373 SqIn CAC, with 369 SqIn LTR, with In-Tank Transmission Oil Cooler
Includes: DEAERATION SYSTEM with Surge Tank: HOSE CLAMPS, RADIATOR HOSES Gates Shrink Band Type; Thermoplastic CoolantHose Clamps: RADIATOR HOSES Premium, Rubber
12UXG FEDERAL EMISSIONS for 2010; MaxxForce DT Engines
12VBR AIR CLEANER With Service Protection Element
Includes: GAUGE, AIR CLEANER RESTRICTION Air Cleaner Mounted
12VXU THROTTLE, HAND CONTROL Engine Speed Control for PTO; Electronic, Stationary Pre-Set, Two Speed Settings; Mounted on Steering Wheel
12VZA ENGINE CONTROL, REMOTE MOUNTED Provision for; Includes Wiring for Body BuilderInstallation of PTO Controls; With Ignition Switch Control for MaxxForce post 2007Emissions Electronic Engines
Vehicle Specifications May 07, 20122013 4400 SBA 4X2 (MA035)
6 Proposal: 8637-02
Code Description12WTA FAN DRIVE SPECIAL EFFECTS Fan Cooling Ring with Fan Shroud Effects, Engine
Mounted
12WYK ENGINE WATER COOLER {Sen-Dure} Auxiliary, For Use With Fire Trucks
12WZD EMISSION COMPLIANCE Engine Shutdown System Exempt Vehicles, Complies WithCalifornia Clean Air Regulations
13AJV TRANSMISSION, AUTOMATIC {Allison 3000EVS_P} 4th Generation Controls; CloseRatio, 5-Speed; With Overdrive, Includes Oil Level Sensor, With Provision for PTO, LessRetarder, Max. GVW N/A
Includes: OIL FILTER, TRANSMISSION Mounted on Transmission: TRANSMISSION OIL PAN Magnet in Oil Pan
13WBL TRANSMISSION SHIFT CONTROL {Allison} Push-Button Type; for Allison 3000 & 4000Series Transmission
13WLP TRANSMISSION OIL Synthetic; 29 thru 42 Pints
13WUZ ALLISON SPARE INPUT/OUTPUT for Emergency Vehicle Series (EVS), 127/198 IncludesJ1939 Based Auto Neutral; Fire/Pumper, Tank, Aerial/Ladder
13WYL SHIFT CONTROL PARAMETERS Allison Performance Programming in Primary andAllison Economy Programming in Secondary
14AHK AXLE, REAR, SINGLE {Dana Spicer S26-190} Single Reduction, 26,000-lb Capacity, RWheel Ends . Gear Ratio: 6.14
Includes: REAR AXLE DRAIN PLUG (1) Magnetic, For Single Rear Axle
Notes: The following features should be considered when calculating Rear GAWR: Rear Axles;Rear Suspension; Brake System; Brakes, Rear Air Cam; Brake Shoes, Rear; SpecialRating, GAWR; Wheels; Tires.: When Specifying Axle Ratio, Check Performance Guidelines and TCAPE for Startabilityand Performance
14VAJ SUSPENSION, RR, SPRING, SINGLE Vari-Rate; 31,000-lb Capacity, With 4500 lbAuxiliary Rubber Spring
Notes: The following features should be considered when calculating Rear GAWR: Rear Axles;Rear Suspension; Brake System; Brakes, Rear Air Cam; Brake Shoes, Rear; SpecialRating, GAWR; Wheels; Tires.
15SNY FUEL TANK Top Draw; D Style, Non Polished Aluminum, 19" Deep, 50 U.S. Gal., 190 LCapacity, Beveled Back of Tank, With Quick Connect Outlet, Mounted Right Side, UnderCab
Notes: N/A with 19.5" Tires
Vehicle Specifications May 07, 20122013 4400 SBA 4X2 (MA035)
7 Proposal: 8637-02
Code Description16030 CAB Conventional
Includes: ARM REST (2) Molded Plastic; One Each Door: CLEARANCE/MARKER LIGHTS (5) Flush Mounted: COAT HOOK, CAB Located on Rear Wall, Centered Above Rear Window: CUP HOLDERS Two Cup Holders, Located in Lower Center of Instrument Panel: DOME LIGHT, CAB Rectangular, Door Activated and Push On-Off at Light Lens, TimedTheater Dimming, Integral to Console, Center Mounted: GLASS, ALL WINDOWS Tinted: GRAB HANDLE, CAB INTERIOR (1) "A" Pillar Mounted, Passenger Side: GRAB HANDLE, CAB INTERIOR (2) Front of "B" Pillar Mounted, One Each Side: INTERIOR SHEET METAL Upper Door (Above Window Ledge) Painted Exterior Color: STEP (4) Two Steps Per Door
16HBA GAUGE CLUSTER English With English Electronic Speedometer
Includes: GAUGE CLUSTER (5) Engine Oil Pressure (Electronic), Water Temperature (Electronic),Fuel (Electronic), Tachometer (Electronic), Voltmeter: ODOMETER DISPLAY, Miles, Trip Miles, Engine Hours, Trip Hours, Fault Code Readout: WARNING SYSTEM Low Fuel, Low Oil Pressure, High Engine Coolant Temp, and LowBattery Voltage (Visual and Audible)
16HCK SEATBELT WARNING PREWIRE Includes Seat Belt Switches and Seat Sensors for allBelted Positions in the Cab and a Harness Routed to the Center of the Dash for theAftermarket Installation of the Data Recorder and Seatbelt Indicator Systems, for 1 to 3Seat Belts
16HGH GAUGE, OIL TEMP, ALLISON TRAN
16HHE GAUGE, AIR CLEANER RESTRICTION {Filter-Minder} With Black Bezel Mounted inInstrument Panel
16HKT IP CLUSTER DISPLAY On Board Diagnostics Display of Fault Codes in Gauge Cluster
16JJE SEAT, DRIVER {National 2000} NFPA Compliant, Air Suspension, High Back With IntegralHeadrest, Vinyl, Isolator, 1 Chamber Lumbar, 2 Position Front Cushion Adjust, -3 to +14Degree Back Angle Adjust
Includes: SEAT BELT 3-Point, Lap and Shoulder Belt Type
16LPE SEAT, PASSENGER {Gra-Mag} Non Suspension, High Back With Integral Headrest, Vinyl,With Fixed Back, With Under Seat Storage
Includes: SEAT BELT 3-Point, Lap and Shoulder Belt Type
16SDC GRAB HANDLE (2) Chrome Towel Bar Type With Anti-Slip Rubber Inserts; for Cab Entry,Mounted Left and Right, Each Side at "B" Pillar
Vehicle Specifications May 07, 20122013 4400 SBA 4X2 (MA035)
8 Proposal: 8637-02
Code Description16SDU MIRRORS (2) {Lang Mekra} Styled; Rectangular, 7.09" x 15.75" & Integral Convex Both
Sides, 102" Inside Spacing, Breakaway Type, Heated Heads Thermostatically Controlled,Power Both Sides, Clearance Lights LED, Bright Finish Heads & Brackets
16VBW CAB MOUNTING HEIGHT EFFECTS Mid Cab in Lieu of Low Cab Mounting Height(Approx. 4") for Increased Cooling System Requirements
16VBZ SEAT BELT All Red; 1 to 3
16WCT AIR CONDITIONER {Blend-Air} With Integral Heater & Defroster
Includes: HEATER HOSES Premium: HOSE CLAMPS, HEATER HOSE Mubea Constant Tension Clamps: REFRIGERANT Hydrofluorocarbon HFC-134A
16WJS INSTRUMENT PANEL Center Section, Flat Panel
16WLS FRESH AIR FILTER Attached to Air Intake Cover on Cowl Tray in Front of WindshieldUnder Hood
16WRX CAB INTERIOR TRIM Deluxe
Includes: "A" PILLAR COVER Molded Plastic: CAB INTERIOR TRIM PANELS Cloth Covered Molded Plastic, Full Height; All ExposedInterior Sheet Metal is Covered Except for the Following: with a Two-Man Passenger Seator with a Full Bench Seat the Back Panel is Completely Void of Covering: CONSOLE, OVERHEAD Molded Plastic; With Dual Storage Pockets with Retainer Netsand CB Radio Pocket: DOOR TRIM PANELS Molded Plastic; Driver and Passenger Doors: FLOOR COVERING Rubber, Black: HEADLINER Soft Padded Cloth: INSTRUMENT PANEL TRIM Molded Plastic with Black Center Section: STORAGE POCKET, DOOR (1) Molded Plastic, Full-Length; Driver Door: SUN VISOR (2) Padded Vinyl with Driver Side Toll Ticket Strap, Integral to Console
16WSK CAB REAR SUSPENSION Air Bag Type
27DMC WHEELS, FRONT DISC; 22.5" Polished Aluminum, 10-Stud (285.75MM BC) Hub Piloted,Flanged Nut, Metric Mount, 8.25 DC Rims; With Steel Hubs
Notes: Aluminum Wheels not Painted or Coated: Compatible Tire Sizes: 11R22.5, 12R22.5, 255/70R22.5, 255/80R22.5, 265/75R22.5,275/70R22.5, 275/80R22.5, 295/75R22.5, 295/80R22,5
28DRA WHEELS, REAR DUAL DISC; 22.5" Polished Aluminum Outer Wheel, With Steel InnerWheel; 10-Stud (285.75MM BC) Hub Piloted, Flanged Nut, Metric Mount, 8.25 DC Rims,With Steel Hubs
Notes: Aluminum Wheels not Painted or Coated
Vehicle Specifications May 07, 20122013 4400 SBA 4X2 (MA035)
9 Proposal: 8637-02
Code Description: Compatible Tire Sizes: 11R22.5, 12R22.5, 255/70R22.5, 255/80R22.5, 265/75R22.5,275/70R22.5, 275/80R22.5, 295/75R22.5, 295/80R22,5
29563 WHEEL SEALS, FRONT {Dana Spicer Outrunner} for Oil Lubricated Wheel Bearings
7382158105 (4) TIRE, REAR 12R22.5 G282 MSD (GOODYEAR) 481 rev/mile, load range H, 16 ply
7382158107 (2) TIRE, FRONT 12R22.5 G661 HSA (GOODYEAR) 484 rev/mile, load range H, 16 ply
Cab schematic 100GA
Location 1: 2304, Red (Prem)
Chassis schematic N/A
Commodity Surcharge
Vehicle Specifications May 07, 20122013 4400 SBA 4X2 (MA035)
10 Proposal: 8637-02
Graphics are provided as visual aids only and are not intended to represent the actual scale, shape, or color of the truck or its components.All weights are represented in lbs.
Truck Body/Trailer Chassis/Empty WeightsBumper to Axle (BA) 39.9Wheelbase (WB) 217.00Axle to Frame (AF) 75.00Axle to Back Cab (ABC) 67.1Cab to Axle (CA) 149.9Usable CA 149.9CA Reduction Adjustment 0Fuel (Gals) 0
Body Length (BL) 229 Tractor Front Axle: 7,708Tractor Rear Axle: 4,543
PayloadsBefore the Cab Cab Chassis Body After the Body# Weight CG # Weight CG # Weight CG # Weight CG # Weight CG
1 0 0
Loads Weight DistributionPayload Weight: 0Driver: 0Fuel(lbs): 0
Total Front Axle: 7,708Total Rear Axle: 4,544Total Weight: 12,252
Weights and clearances in this proposal are estimates only. Navistar, Inc. is not liable for any consequences resultingfrom any differences between the estimated weights and clearances and the actual manufactured weights and clearances.
Weight Summary May 07, 20122013 4400 SBA 4X2 (MA035)
11 Proposal: 8637-02
Weight Distribution
All weights are represented in lbs.
Truck
Front Rear Total
Chassis Weight
Chassis Weight: 7,708 4,543 12,251Fuel: 0 0 0Empty Body: 0 1 1
(Curb Weight): 7,708 4,544 12,252
Loads
Payloads: 0 0 0Driver: 0 0 0
Axle Totals (Gross Weight): 7,708 4,544 12,252
Weight Ratings
Truck
Front Rear
Axle(axle capacity) 14,000 26,000Tire(tire capacity) 14,780 29,560Suspension(suspension capacity) 14,000 31,000Spring: 0
Fed Bridge Law (axle spread): 20,000 20,000
Wheel Combination Load Limit
1 - 2 12,252 48,000
Federal Total Vehicle Weight Limit: 80,000
Maximum Gross Vehicle Weight Rating (GVWR) 40,000 - Gross Vehicle Weight(GVW) 12,252 = 27,748 Reserves
Weight Summary
* Distributed weights are within capacity limits
Weight Summary May 07, 20122013 4400 SBA 4X2 (MA035)
12 Proposal: 8637-02
Series: 4000Model: MA035Description: 4400 SBA 4X2Model Year: 2013
Calculation Factors
Wheelbase: 217
Front Axle: 0002ARVDescription: AXLE, FRONT NON-DRIVING, {Meritor
MFS-14-143A} Wide Track, I-Beam Type,14,000-lb Capacity
Front Wheel: 0027DMCDescription: WHEELS, FRONT, DISC; 22.5" Polished
Aluminum, 10-Stud (285.75MM BC) Hub Piloted,Flanged Nut, Metric Mount, 8.25 DC Rims; WithSteel Hubs
Front Tire: 07382158107Description: TIRES, 12R22.5 G661 HSA (GOODYEAR) 484
rev/mile, load range H, 16 ply
Steering Gear:0005PSMDescription: STEERING GEAR, {Sheppard HD94} Power
Turning Radius Statistics
General InformationInside Turn Angle: 42 DegreesRadial Overhang: 19
Axle InformationKingPin Inclination: 6.25 DegreesKingPin Center: 71.5
Turning Radius - Curb View
C - Curb Contact Length: 16.23CI - Curb Clearance Increment: 6.12CR - Curb Clearance Radius: 34'1''CH - Curb Height: 6''TR - Turning Radius: 33'7"TW - Tire Width: 11.60
* All Measurements are in inches, unless otherwise specified.
Turning Radius Summary May 07, 20122013 4400 SBA 4X2 (MA035)
13 Proposal: 8637-02
This information is based on engineering information available at this time. Actual figures may vary.Navistar, Inc. cannot accept liability for consequences due to this variance.
Turning Radius Summary May 07, 20122013 4400 SBA 4X2 (MA035)
14 Proposal: 8637-02
ENGINE, DIESEL (0012NUT)ATTACHMENTS: NONE
Parameter Value UOM
Max Vehicle Speed:7902 65 MPHMax Eng Speed w/Speed Fault:7901 2400 N/AIDLE Shutdown Timer Mode:7400 OFF N/AIDLE Shutdown Time:7401 15 MINISD - Max Intake Air Temp:7402 44 CCruise Control - MIN Veh SP:7603 35 MPHCruise Control - MAX Speed:7604 65 MPHRetarder Mode:7000 EXH-LTCH N/AService Interval - Enable:9500 OFF N/AService Interval - Distance:9503 12000 MILESService Interval - Run Time:9502 450.0 HOURSService Interval - Fuel Used:9501 1500 GALLONSPTO - Max Vehicle Speed:7501 5 MPHPTO - Vehicle Speed Override:7518 AFFCTRPS N/APTO - Max Engine Speed:7508 2200 RPMPTO - Ramp Rate:7507 100 RPM/SECPTO - Preset 1:7505 1000 RPMPTO - Preset 2:7506 1500 RPMPTO - Enable Overrides:7526 ENABLE N/APTO - Park Brake Override:7515 NOEFFRPS N/APTO - Brake Override:7514 AFFCTRPS N/APTO - Driveline Override:7516 AFFCTRPS N/APTO - Driveline Mode:9301 NEUTRLOP N/ARemote Pedal - Enable:7504 NO N/ARemote Pedal - Return To 0 Req:7513 RTZ-NOT N/ARemote Pedal - Enable Override:7525 ENABLE N/ARemote Pedal - Brake Override:7520 AFFCTRPS N/ARemote Pedal - VS Kickout En:9102 AFFCTRPS N/ARemote Pedal - IN-CAB override:7523 AFFCTRPS N/ARemote Pedal - Park Brake Ovrd:7521 NOEFFRPS N/ARemote Pedal - Driveline OVRD:7522 AFFCTRPS N/ACustomer Password:8700 0000 N/A
These Electronic Parameters have been successfully finalized
Electronic Parameters Summary May 07, 20122013 4400 SBA 4X2 (MA035)
15 Proposal: 8637-02
ENGINE/TRANSMISSION MATCHING
Sawtooth Details
Gear TransRatio
Upshift Power Avail Govern Power Avail Peak Power Comparison Warn MsgVeh Spd Eng Spd Veh Spd Eng Spd Gear Step 85% Range 90% Range
(MPH) (RPM) (MPH) (RPM) (%) (%) (%)1C 3.49 0.0 2212.5 9.4 2318.7 N/A 71 582C 1.86 9.4 2218.1 16.8 2299.3 N/A 71 582L 1.86 16.8 1538.2 23.7 2170.6 N/A 71 583L 1.41 23.7 1645.5 31.7 2201.0 N/A 71 584L 1.00 31.7 1561.0 45.2 2225.0 N/A 71 585L 0.75 45.2 1668.8 65.0 2400.0 N/A 71 58
@ - WHEELSLIP CAN OCCUR AT THE GRADE SHOWN. THE VEHICLE IS CAPABLE OF INCREASED GRADEABILITY IF MOREWEIGHT IS PLACED ON THE DRIVE AXLES.
Perfomance TCAPE Summary May 07, 20122013 4400 SBA 4X2 (MA035)
16 Proposal: 8637-02
STEADY STATE PERFORMANCE
Performance Results Gear Veh Spd Eng Spd Fuel Econ Grade Notes(mph) (rpm) (mpg) (%)
LEVEL ROAD MAXIMUMSPEED
5L 66.6 2459 5.18 0.00
HI GEAR SPEED @ RATEDRPM
5L 65.0 2400 5.36 1.21
55.0 MPH STEADY-STATE 5L 55.0 2030 6.81 2.75 - Calculated GradeAbility/FuelEconomy
VEHICLE ORDER CODING ERRORS MAY RESULT IF THE "LEVEL ROAD MAX SPEED" VALUE EXCEEDSTHE "HI GEAR SPEED @ RATED RPM" AND IS USED AS THE ENGINE PROGRAMMABLE VEHICLE SPEEDLIMIT.
IF THE RESULTS CONTAIN " -----" , VEHICLE CANNOT ATTAIN THAT SPEED.
IF THE RESULTS CONTAIN "*****", THE ENGINE USED DOES NOT HAVE A FUEL MAP. FUEL ECONOMYCANNOT BE PREDICTED.
Recommendations / General Information
IDLE FUEL RATE : 0.91 GALS/HR @ 800 RPMTORQUE CONVERTER: TC-413 STALL RATIO: 2.44
Fuel Economy Route: Normal Route - City, Suburban, and Highway
Key Fuel EconomyInformation
City Suburban Highway Notes
MILES PER GALLON 6.11 7.75 6.51AVERAGE MPH 18.97 39.84 54.61MISSION MINUTES 29.8 52.0 173.3
IF THE RESULTS CONTAIN "*****", THE ENGINE USED DOES NOT HAVE A FUEL MAP. FUEL ECONOMYCANNOT BE PREDICTED.
Perfomance TCAPE Summary May 07, 20122013 4400 SBA 4X2 (MA035)
17 Proposal: 8637-02
GRADEABILITY PERFORMANCE
Enroute - Full Throttle Upshift Performance
Gear TransRatio
Veh Spd Eng Spd Whl Pwr Grade WarnMsg
Notes(mph) (rpm) (hp) (%)
1C 3.49 0.0 2212.5 0.0 45.50 @ STALL5.4 2221.4 185.9 33.60 70% EFF7.1 2250.9 209.1 27.90 80% EFF9.4 2318.7 219.0 21.50
2C 1.86 9.4 2218.1 180.6 17.5016.8 2299.3 220.2 11.60
2L 1.86 16.8 1538.2 226.8 12.0023.7 2170.6 267.1 9.80
3L 1.41 23.7 1645.5 242.6 8.8031.7 2201.0 265.9 6.90
4L 1.00 31.7 1561.0 230.2 5.8045.2 2225.0 262.6 4.10
5L 0.75 45.2 1668.8 241.8 3.6065.0 2400.0 233.2 1.20 RATED RPM65.3 2410.2 220.8 1.0066.0 2435.2 189.6 0.5066.6 2459.4 158.8 0.00 LEVEL ROAD
STARTING / TOP GEAR PERFORMANCE
Gear TransRatio
Veh Spd Eng Spd Whl Pwr Grade WarnMsg
Notes(mph) (rpm) (hp) (%)
1C 3.49 0.0 0.0 45.50 @ STALL7.1 209.1 27.90 80% EFF - Calculated Start Ability
@ - WHEELSLIP CAN OCCUR AT THE GRADE SHOWN. THE VEHICLE IS CAPABLE OF INCREASEDGRADEABILITY IF MORE WEIGHT IS PLACED ON THE DRIVE AXLES.
THE TRANSMISSION WAS SIMULATED IN PERFORMANCE OPERATING MODE.
Perfomance TCAPE Summary May 07, 20122013 4400 SBA 4X2 (MA035)
18 Proposal: 8637-02
ACCELERATION PERFORMANCE RESULTS
Acceleration Performance Grid
Acceleration Performance: TIME TO ACCELERATE ON A 0.00% GRADE TO 55.0 (MPH) IS 39.81 (SECS)
Acceleration Performance Details
Gear Time Distance Speed Notes(secs) (feet) (mph)
1 0.16 0.1 1.00.34 0.5 2.00.49 1.1 3.00.62 1.7 4.00.76 2.7 5.00.92 4.0 6.01.10 5.7 7.01.30 7.8 8.01.52 10.6 9.0
2 1.64 12.2 9.41.96 16.9 10.42.28 22.0 11.42.60 27.6 12.42.93 33.9 13.43.28 41.2 14.43.66 49.4 15.44.06 58.7 16.4
3 4.21 62.4 16.84.66 73.9 17.85.12 86.1 18.85.58 99.1 19.86.05 113.1 20.86.54 128.5 21.87.06 145.4 22.8
4 7.55 162.3 23.7
Perfomance TCAPE Summary May 07, 20122013 4400 SBA 4X2 (MA035)
19 Proposal: 8637-02
Gear Time Distance Speed Notes(secs) (feet) (mph)8.14 183.0 24.78.72 204.7 25.79.31 227.5 26.79.93 252.0 27.7
10.57 278.4 28.711.23 307.0 29.711.93 337.8 30.712.66 371.0 31.7
5 12.66 371.2 31.713.50 411.1 32.714.35 452.3 33.715.20 495.0 34.716.05 539.1 35.716.91 584.8 36.717.79 632.6 37.718.70 683.4 38.719.64 737.4 39.720.61 794.7 40.721.62 855.7 41.722.66 920.5 42.723.75 989.7 43.724.89 1063.4 44.7
6 25.48 1102.1 45.226.80 1190.7 46.228.13 1282.1 47.229.48 1376.3 48.230.85 1473.9 49.232.25 1576.4 50.233.71 1684.9 51.235.23 1799.8 52.236.81 1921.7 53.238.45 2051.2 54.239.81 2160.4 55.0
Perfomance TCAPE Summary May 07, 20122013 4400 SBA 4X2 (MA035)
20 Proposal: 8637-02
REQUIRED TCAPE INFORMATION
TCAPE Factors For Vehicle
Selected Rear Axle Gear Ratio(s): 6.14Vehicle Vocation: GENERAL ON HIGHWAYRoad Surface Type: TYPICALEnroute PTO: NOTransmission Mode: PerformanceFuel Economy Route: Normal Route - City, Suburban, and HighwayID Wheel Slip Conditions: YesEngine Fan Type: VISCOUSParked PTO: NORoad Governor/Cruise Ctrl: NoAcceleration Grade (%): 0.0Weight on Drive Axle (LBF): 26000Alternator (A): 40Frontal Area (FT2): 96Air Compressor (HP): 2.20Vehicle Width (IN): 96Vehicle Height (IN): 144Steering Gear (HP): 2.60Air Conditioner (HP): 3.20Acceleration Vehicle Spd (MPH): 55.0Speed Limit on Route (MPH): 61.0Relative Drag Coefficient: 85TIRE, FRONT 2 - RADIAL NORMALTIRE, REAR 4 - RADIAL NORMAL
Components
0002ARV AXLE, FRONT NON-DRIVING {Meritor MFS-14-143A} Wide Track, I-Beam Type, 14,000-lbCapacity
0004SBC AIR COMPRESSOR {Bendix Tu-Flo 550} 13.2 CFM Capacity0005PSM STEERING GEAR {Sheppard HD94} Power0008GWY ALTERNATOR {Leece-Neville 14931PAH} Brush Type, 12 Volt 320 Amp. Capacity, Pad Mount0012NUT ENGINE, DIESEL {MaxxForce DT} EPA 10, 300 HP @ 2200 RPM, 860 lb-ft Torque @ 1300 RPM,
2400 RPM Governed Speed0012THT FAN DRIVE {Horton Drivemaster} Direct Drive Type, Two Speed With Residual Torque Device for
Disengaged Fan Speed0013AJV TRANSMISSION, AUTOMATIC {Allison 3000EVS_P} 4th Generation Controls; Close Ratio, 5-
Speed; With Overdrive, Includes Oil Level Sensor, With Provision for PTO, Less Retarder, Max.GVW N/A
0014AHK AXLE, REAR, SINGLE {Dana Spicer S26-190} Single Reduction, 26,000-lb Capacity, R WheelEnds
0016030 CAB Conventional0016WCT AIR CONDITIONER {Blend-Air} With Integral Heater & Defroster07382158105 TIRE, REAR 12R22.5 G282 MSD (GOODYEAR) 481 rev/mile, load range H, 16 ply 12R22.5 G282
MSD (GOODYEAR) 481 rev/mile, load range H, 16 ply
Perfomance TCAPE Summary May 07, 20122013 4400 SBA 4X2 (MA035)
21 Proposal: 8637-02
07382158107 TIRE, FRONT 12R22.5 G661 HSA (GOODYEAR) 484 rev/mile, load range H, 16 ply 12R22.5G661 HSA (GOODYEAR) 484 rev/mile, load range H, 16 ply
TCAPE HAS BEEN DESIGNED TO GIVE ECONOMY AND PERFORMANCE PREDICTIONS WHICH HAVEBEEN SHOWN TO BE TYPICAL FOR MOST OPERATIONS. HOWEVER, DUE TO OPERATINGCONDITIONS, DRIVER INFLUENCES, AND OTHER FACTORS, YOUR RESULTS MAY VARY FROM THOSEPREDICTED. ALSO, BECAUSE OF FUEL MAPPING PROCEDURES USED BY VARIOUS ENGINEMANUFACTURERS, COMPARISONS OF FUEL ECONOMY RESULTS FOR DIFFERENT BRANDS OFENGINES MAY VARY FROM THOSE SHOWN.
NAVISTAR, INC. SHALL NOT BE LIABLE FOR ANY LOSS OF PROFITS, LOSS OF USE, INTERRUPTIONOF BUSINESS OR INDIRECT, SPECIAL, INCIDENTAL OR CONSEQUENTIAL DAMAGES OF ANY KINDTHAT ARE INCURRED BY DEALER OR BY DEALER'S CUSTOMERS AS A RESULT OF RELIANCE ONTCAPE, WHETHER THE CLAIM IS IN CONTRACT,TORT (INCLUDING NEGLIGENCE), STRICT LIABILITYOR OTHERWISE.
Perfomance TCAPE Summary May 07, 20122013 4400 SBA 4X2 (MA035)
22 Proposal: 8637-02