Date post: | 02-Jun-2015 |
Category: |
Technology |
Upload: | hanyoung-nux |
View: | 103 times |
Download: | 4 times |
World Leader in Control & Measurement
www.hynux.com
11/12November / December | 2013
HANYOUNG LETTER
New ProductsSlim-Type Thyristor Power Regulator
Small Cam Switch
LED Pilot Lamp & Push Button Switch
Multi-Loop Controller
Hanyoung NewsHanyoung Participated in 2013 Korea Machinery Fair
Website Renewal Opened
76,800 bps communication speed
0.05 sec. sampling period (4 channels)
4-channel relay / voltage / current output
8 Event outputs
Maximum 31 parallel connections
Stop / Monitor / Operation mode
SV / minute rate of change adjustment
Feature
ComingsoonComingsoon
Suffix CodeModel Code Description
ML- ☐ ☐ ☐ Multi loop controller
Channel2 2 Channel
4 4 Channel
Output type
M Relay
S S.S.R (12 V d.c)
C S.C.R (4 - 20 ㎃ d.c)
Model Code Description
ML- ☐ ☐ ☐ Multi loop controller
Type E Event output
Channel 8 8 Channels
SpecificationModel ML-D4M ML-D4S ML-D4C
Input
Number of input 4 Nos. (channel-to-channel isolation)
Input type
•Thermocouple : K, J, E, T, R, B, S, L, N, U, W, PLⅡ •DC Voltage : 1 - 5 V d.c, 0 - 10 V d.c, 0 - 100 ㎷ d.c
•RTD : KPt100 Ω (K.S), Pt100 Ω (IEC / K.S), 3-Wire (wire resistance less than 10 Ω / a line)
•Direct circuit : after input type is set to direct circuit 1-5 V d.c., input terminal is stick at positive terminal to 250Ω resistence
Operation with Burn-out 1) Thermocouple : Up scale 2) RTD : Up scale 3) DC Voltage : Down scale 4) DC Current : Down scale
Influence of signal source resistance 0.2 uV / Ω (thermocouple input)
Influence of source resistance 0.02 % / Ω (RTD) 10 Ω max. per line
Intervals 0.05s / Channel
Input filter 0(off) - 120s
PV bias EUS (-100 ~ +100 %)
Performance
Input degree ±0.3 % of F.S
Effect of ambient temperature ±3 uV / ℃ or ±0.03 % of F.S / ℃ (whichever is greater)
Effect of power fluctuation ±3 uV / 10 V or ±0.03 % of F.S / 10 V (whichever is greater)
Control output
Type Relay output Voltage pulse output Current output
Rating •Relay output 250 V a.c 3 A, 30 V d.c 3 A •Voltage pulse output 0/15 V d.c (at minimum load resistance : 600 Ω) •Current output 4 - 20 ㎃ d.c (at maximum load resistance : 600 Ω)
Communication
Communication method RS-485 (two-wire, half duplex)
Communication speed 9600 bps, 19200 bps, 38400 bps, 76800 bps
Communication protocol PC-Link, PC-Link with SUM, MODBUS-RTU / ASCII
Bit length •Start bit : 1, 2 •Data bit : 7, 8 •Parity bit : none, odd, even •Stop bit : 1, 2
Maximun connection in parallel 31 units
Event output(ML-E)
Number of output 8 Nos.
Output operation ON / OFF
Output type Relay output 250 V a.c 3 A, 30 V d.c 3 A
Event type• Deviation high • Deviation low limit • Deviation high/low • variation in the range • PV high limit • PV low limit
• SV high limit • SV lower • Loop break (LBA) • Operation (RUN) • Stop monitor (Ready) • Fail
Multi-Loop ControllerML series
NE
W P
RO
DU
CT
Slim-TypeThyristor Power Regulator
Ultra Slim type (110 ㎜)
Semi permanent life expectancy due to the best radiant heat design and installation of various protection circuit
Improved reliability by separating controllerpower from load power (apply a wide range of power supply circuit)
Various protection functions (Disconnection of heater, Imbalance of load, Overheated heat sink, Overcurrent etc.)
TPR-3SL series
Suffix CodeModel Code Description
TPR - 3SL ☐ ☐ ☐ Slim type 3 phases thyristor power regulator
Input Control Voltage Contact
040 40 A
055 55 A
070 70 A
Rated load currentL 100 - 240 V a.c. (Low voltage)
H 380 - 440 V a.c. (High voltage)
Option- Inner part of Fuse is installed
N No Fuse
Feature
Specification
ModelLow TPR-3SL040L TPR-3SL055L TPR-3SL070L
High TPR-3SL040H TPR-3SL055H TPR-3SL070H
Power supply voltage100 - 240 V a.c. (Low)
380 - 440 V a.c. (High)
Circuit input power 100 - 240 V a.c.
Power frequency 50 ㎐/60 ㎐ (Dual usage)
Rated current 40 A 55 A 70 A
Applying load Load resistance
Controlinput
Currebt input 4 - 20 ㎃ d.c (Impedence : 100 Ω)
Voltage input 1 - 5 V d.c.
Contact input ON/OFF
External V.R External volume (10 ㏀)
Control method Phase control, Fixed cycle control, Variable cycle control, ON/OFF control
Movement type SOFT START, SOFT UP/DOWN
Output voltage More than 98 % of the power supply voltage ( In case of maximum current input )
Cooling method Natural cooling ( 40 A , 55 A ), Forced cooling ( 70 A )
Display method Display by LED
Insulating resistance Min 100 ㏁ ( Base on 500 V d.c mega )
Output cotrol range 0 ~ 100 %
Dielectric strength 3,000 V a.c 50/60 ㎐ for 1 min
Line noise Noise by noise simulator (2,500 V)
Storage temperature -25 ℃ ~ 70 ℃
Ambient temperature 0 ~ 40 ℃ (with no condenssation)
Ambient humidity 30 ~ 85 % RH
Weight 4044 g 4324 g
※ For circuit input power, please connect 100 - 240 V a.c separately.
ComingsoonComingsoon
NE
W P
RO
DU
CT
Suffix Code
Specification
█ LED Pilot Lamp
█ LED Pilot Lamp
█ Push button switch (Contact Part)
█ Push Button Switch (Actuator Part)
█ Push Button Switch (Contact Part)
█ Push Button Switch
Model Code Description
CR- ☐ ☐ ☐ ☐ CR series LED Pilot lamp
Installing Dimension
252 Ø25 Pilot Lamp
302 Ø30 Pilot Lamp
Power Supply Voltage (Exclusive Unit of LED Light Source)
A 110 V a.c. LED Light Source (Way of dropping of Condenser Voltage)Example) CR-☐☐☐F☐
B 220 V a.c.
C 380 V a.c.
D 24 V d.c. LED Light Source (Way of dropping of resistance voltage)E 12 V d.c.
Light Source FExclusive unit of LED Light Source
※Only power voltage A, B, C, D, E
Lamp Cap Color R Red(R), Green,(G), Yellow,(Y), Blue,(A), White(W)
Model Code Description
CR- ☐ ☐ ☐ ☐ Push Button Switch of CR Series (LED Dimmer)
Installing Dimension
254 25 push button switch (1a1b contact only)
304 30 push button switch (1a1b contact only)
Power Supply Voltage (Exclusive Unit of LED Light Source)
A 110 V a.c. LED Light Source(Way of dropping Condenser Voltage)Example) CR-☐4☐F☐
B 220 V a.c.
C 380 V a.c.
D 24 V d.c. / a.c. LED Light Source (way of dropping resistance voltage)E 12 V d.c. / a.c.
Light Source FExclusive unit of LED Light Source
※Only power voltage A, B, C, D, E
Lamp Cap Color R Red(R), Green,(G), Yellow,(Y), Blue,(A), White(W)
Rated VoltageAlternate Current Direct Current
110 V a.c. 220 V a.c. 380 V a.c. 24 V d.c. 12 V d.c.
Current Consumption 16.6 ㎃ 13 ㎃ 6.55 ㎃ 15 ㎃ 15 ㎃
Life Expectancy of Light Source
100,000 h
Tightening Torque of Locking Ring
1.96 N·m
Tightening Torque of Terminal
0.8 N·m (M3.5 x 7)
Thickness of Installation Panel 1 ~ 6 ㎜ (Without Accessories)
Contact Rating 5 A 250 V a.c.
Contact Resistance Max 50 ㏁
Contact Material AgCdO
Contact Case Material Contact Cover : P.C., Contact Body : ABS
Contact Composition 1a1b
Contact Operation Slow-Action
Frequency of Allowable operation
Mechanical Maximum 30 times per 1 minute
Electrical Maximum 30 times per 1 minute
Insulation Resistence. Min 100 ㏁
Withstand Voltage 1,500 V a.c. / 60 ㎐, 1 min
Vibration Durability 10 ~ 55 ㎐(Double amplitude 3㎜)
ImpactDurability Over 500 ㎨
False Operation Over 100 ㎨
Life Expectancy
Mechanical Over One million Times
Electrical Over 100000 Times
Ambient Temperature -25 ~ 40 ℃
Ambient Humidity 45 ~ 85 % R.H
Storage Temperature -40 ~ +70 ℃
Impact (Durability) 300 ㎨. Pulse Period 11 ㎳
Vibration (Durability) 100 ㎨ 10 ㎐…55 ㎐ Double amplitude 1.5 ㎜ (within 1 ㎳)
Rated VoltageAlternate Current Direct Current
110 V a.c. 220 V a.c. 380 V a.c. 24 V d.c. 12 V d.c.
Current Consumption 16.6 ㎃ 13 ㎃ 6.55 ㎃ 15 ㎃ 15 ㎃
Life Expectancy of Light Source
100,000 h
Tightening Torque of Locking Ring
1.96 N·m
Tightening Torque of Terminal
0.8 N·m (M3.5 x 7)
Contact Materials ABS (Mounting Nut and body)
Feature
LED Pilot Lamp & Push Button Switch
CR series
Ø25 Ø30 Series
Formation of Contact Part: 1a1b one body type.
Long life expecntacy due to effect of LED Light Source
Reduce the weight of the product
NE
W P
RO
DU
CT Comingsoon
Comingsoon
Small Cam SwitchSQ4 series
Suffix CodeModel Code Description
SQ4- ☐ ☐ ☐- ☐ ☐ ☐ ☐ SQ4 Series Cam Switch
Installation F Four holes of panel mounting
Nameplate Frame S Square of Nameplate Frame
HandleH Linear Handle (For General Industry)
R Chrysanthemum type of Handle (Voltmeter and Ammeter Switch)
Positions selection
2 2 Position
3 3 Position
4 4 Position
5 5 Position
6 6 Position
7 7 Position
Number of contact unit
1 1 row
2 2 row
3 3 row
4 4 row
5 5 row
6 6 row
Serial Number 0 1 01 ~ 99
Feature
SpecificationRated Insulation voltage 690 V a.c.
Dielectric strength 2500 V a.c.
Rated Electro Current (Ith) 16 A
Rated Service Voltage (Ie) 16 A
Rated Service Current (Ue) 480 V a.c.
Mechanical Life Expectancy 300,000 Times
Electrical Life Expectancy AC : 200,000 Times, DC : 100,000 Times
Ambient Temperature -25 ~ 55 ℃
Ambient Humidity Max 90 % RH
Altitude Max 2000 m
Protective Structure IP65
Pollution level 3
Component Materials
BodyNY66 GF15 % Level
of Resistence to flame
Cam ACETAL
Contact AgNi
Terminal Brass
Bolt Iron (Galvanizing)
Spring Stainless (STS)
Handle Level of PC Resistence to flame
2 Types of operation handle (H type, R type)
Ammeter Switch (A.S), Voltmeter Switch (V.S.)
Various Circuit of Small Cam Switch
Structure of Contact: Maximum 7 positions and 6 rows
IP65 structure
NE
W P
RO
DU
CT
ComingsoonComingsoon
Hanyoung Nux Participated in 2013 Korea Machinery Fair.
Field Sketch of Korea Machinery Fair Korea Machinery Fair / KINTEX October 16 - 19, 2013We participated in Korea’s largest exhibition, 2013 Korea Machinery Fair, which was held from October 16th to October 19th.
This Korea Machinery Fair was the Korea’s largest exhibition which was combined by five vital capital exhibitions, Tool Tech
Korea, Welding Korea, Korea Metal Week, Korea Automatic Industrial Exhibition Etc. In this Machinery Fair, Hanyoung Nux
introduces new products including Digital Temperature Controller and HMI, Graphic Recorder, Solid State Relay, Multi Loop
Controller, Proximity Sensor, and Photo Sensor Etc.
Especially, HMI (Human Machine Interface) TG Series which was introduced in this exhibition is mostly attracted by audience. HMI, various structure of 5, 7, 10, 12, 15 inch, is expected to be the most issued product.
Moreover, DPS Series which is DIN Rail type of Power Supply (SMPS) is also highly attracted by audience.
TG series
DPS series
HA
NYO
UN
G N
EW
S
Hanyoung Nux’s Website Renewal Opened
www.hynux.comHanyoung Nux’s website is renewal opened for
providing various and convenient information
about products to customers.
Since product’s images are placed in main
page of category, it makes customers to find
out the products easily so that it leads to
optical convenience. Also, mobile website is
opened for convenience of Smartphone users
and it makes them to get information easily
wherever they are.
HA
NYO
UN
G N
EW
S